Bettis EHO Electro-Hydraulic Operator

Transcription

1 ettis Electro-Hydraulic Operator The ettis is a self-contained, quarter-turn, valve actuator that combines proven technologies from Emerson s Valve utomation. The actuator has been designed for critical shutdown applications where reliability is crucial. The utilizes a dependable spring-return actuator for the fail-safe stroke combined with an integral hydraulic power pack and electronic control module. The accepts a wide range of single-phase, three-phase or power sources, also solar panels are available for areas without electrical power. hydraulic hand pump can be used to stroke the actuator during commissioning or in the event of an emergency power loss. Electronic modules are contained within an explosion proof, IP68 enclosure and all electronic components are isolated from the customer connection terminals. oth spring-return and double-acting configurations are available with torque outputs up to 68, Nm. The provides a compact design with actuator and control components that have been field proven for decades in critical service applications. Product ata Sheet March 0 O.S.-M Rev. The comes in two versions: the Standard and the Smart. The Standard is designed for on/off ES applications, while the Smart is designed for modulating ES applications and comes with alert, alarm, diagnostic, and self-calibration features. Standard Smart

2 March 0 Product ata Sheet Table Of ontents Table of ontents Section : Product ttributes... Section : General Specifications... Section : Torque Output ata Spring-Return... 6 ouble-cting... Section : Model Information Standard Spring-Return... 9 Standard ouble-cting... Smart Spring Return... Smart ouble-cting... Section : imension Spring-Return... ouble-cting... 8 Section 6: iagrams Standard Electrical onnection iagram... 0 Smart Electrical onnection iagram...

3 Product ata Sheet -M.0.0.EN, Page of, Rev. March 0 Product ttributes Easy Installation ettis actuator is a totally self-contained system and designed for compactness and adaptable to new or existing valves ettis TM G-Series hydraulic double-acting or spring-return, fail-safe actuator Shafer TM hydraulic control technology EIM TM electronics and communication technology Multiple input power options with Local lockable Remote/Local/Offline selector switch Local Open/lose selector knob Partial-stroke test Fast speed of operation to fail-safe position if required Emergency shutdown independent safety circuits and solenoid valve ual sealed Separate Terminal hamber, allows installation wiring to be performed or fuses to be replaced without exposing control components to hostile environmental conditions ontrol enclosure is made of low-copper aluminum alloy, powder-coated, salt-resistant also rated for IP68 ingress protection Hydraulic hand pump manual override ccumulators (optional) Operating pressures up to 0 bar with standard components Easy control over actuator stroking speeds The stroking speed is controlled through adjustable hydraulic flow control valves. This enables field personnel to easily adjust actuator stroking speed to comply with field requirements (Smart) ommunication support through Modbus, HRT and Foundation Fieldbus (FF) (Smart) Modulating through -0m analog input (Smart) Over alerts and alarms (Smart) iagnostics and self-calibration features

4 March 0 Product ata Sheet -M.0.0.EN, Page of, Rev. General Specifications Input Power () Three-phase 0 Hz 0, 0, 0, 80, 00, 0, 60, 80, 00, 0,, 600 volts Three-phase 60 Hz 08, 0, 0, 80, 0, 60, 80,, 600 volts Single-phase 0 Hz 0,, 0, 0, 0 volts Single-phase 60 Hz, 0, 08, 0, 0 volts () volts Note: The nominal operating voltage must be specified at time of order. Published actuator performance data is for power supply variations of a ± 0% voltage and a ± Hz frequency. If power supply variations are outside these limits, please consult Valve utomation to ensure that actuator performance meets your requirements. onduit Entry Sizes Two NPT, One. NPT bottom entry One NPT top entry Local Operation and isplay (Standard) Open/lose/Stop push buttons (Smart) Open/lose selector knob Local/Off/Remote lockable selector switch (Smart) -digit LE display (Smart) LE alarm and alerts display Local/Off/Remote position indicator LEs Hydraulic hand pump manual override Remote Operation (Inputs) iscrete Open/lose/Stop/ES signals (Smart) iscrete PST signal (Smart) -0m positioning (% accuracy) (Outputs) iscrete open/close limits -0m hydraulic pressure feedback (Smart) configurable relays (Smart) ES monitor relay (Smart) -0m position feedback

5 Product ata Sheet -M.0.0.EN, Page of, Rev. March 0 General Specifications (continuation) Operating Temperature -0 F to +0 F (-9 to +60 ) -0 F to +0 F (-0 to +60 ) optional Hydraulic Fluid ONOO Megaflow W HVI For temperatures down to -0 F (-9 ) EXXON Univis J For temperatures down to -0 F (-0 ) Ingress Protection ontrol enclosure: IP68 Hydraulic actuator: IP6M Motor: IP68 Hazardous rea lassification and SIL ertification S, anadian Standard ssociation ertification lass I, ivision I, Groups, and Group configuration upon request FM, Factory Mutual ertification lass I, II, and III, Groups,, E, F, G, ivision I, T Group configuration upon request TEX irective EExd II T IEEx ertificate of onformity Ex d II T SIL- ertification(standard Spring Return) SIL- ertification(smart Spring Return) Reservoir: IP (IP66 optional)

6 March 0 Torque Output ata (Spring-Return, Fail-Safe ctuator) Product ata Sheet -M.0.0.EN, Page of, Rev. Spring- Return Model ctuator MOP (bar) ctuator ISPL (cm ) Spring ET (Nm) Spring ycle (Nm) Spring RUN (Nm) Spring T (Nm) Pressure bar Unless indicated (Nm) Pressure bar (Nm) or designated pressure bar RUN (Nm) Pressure bar (Nm) Pressure 0 bar (Nm) Pressure 0 bar (Nm) or designated pressure 0 bar RUN (Nm) Pressure 0 bar (Nm) Stroke Time Power ycle (seconds) -Phase Stroke Time Pressure ycle (seconds) ½ HP Motor E SRH @ bar 86@ bar 0@ 69 bar 8@ 69 bar 0@ 69 bar *** E0 SRH ,0.86 9@ bar 9@ bar 6@ bar,@ 69 bar 6@ 69 bar 89@ 69 bar ***6.0.0 E60 SRH ,06..6,8.6,8@ bar 9@ 69 bar,86@ 8 8 bar,088@ 8 bar ***..0 G000.0-SR.9 8.,06 600,00, 699,6,8 90,6 6 ***8..0 G000.0-SR.9 8.,6 80,6, ,0 6, 6 ***8..0 G00.-SR ,6,098,8,,06,6,0,6,9 0 ***..0 G00.-SR ,0,98,960,69 9,0,,,88 0 ***..0 G00.-SR..9,0,86,00,60,6,6,86,98,9 ***0..0 *G00.0-SR * ,96,6,,9,8,9 *6,60 *,0 *,6 ***.8.0 G00.0-SR..,,8,,660,96,6 6,8,09, 6 ***..0 G00.-SR 0.9,09.66,,8 0,8,6,,98 0,0,8, 8 *** 6..0 G00.-SR 6.9,9.9 0,6,6 6,9,6 9,80,0 8,,9, ** ***08. *G00.0-SR *0.,966.06,8 0,99,,, 6,98 *,9 *,9 *,9 **0 ***0. G00.0-SR.0,.6 0,6,69,66,9,09,,80 9,0 9, **8 ***6 0. G00.0-SR.0,.6,8 6,96 0,9 9,99 0,9,96,996,,68 **8 ***6 0. G006.0-SR.8,.96,,9 6,9,0 6,0 0,99 8,9,88 6,0 **6 *** 0. G800.0-SR 0.0 8,.66 9,9,0 6,06 8, 9, 66,0 0,9,69 90, **90 ***00 8. G800.0-SR 0.0 8,.66,06 9, 66,98,,9, 00,0, 80, **90 ***00 8. *G SR *9.8 9,0. 6, 6,,968 09,@ 8 bar 9,86@ 8 bar 6,@ 8 bar 6,989@ bar,@ bar 99,6@ bar **00 *** *G SR *9.8 9,0. 8, 6,0,9 96,6@ 8 bar 86,90@8 bar,89@ 8 bar,00@ bar 06,608@ bar,@ bar **00 *** *G00.0-SR MOP = 9 bar, torques are calculated at MOP *G00.0-SR MOP = 0 bar, torques are calculated at MOP *G SR & SR MOP = 96 bar, torque calculated at 8 bar & bar ** If motors are single phase, the stroke time of the G and larger will be ½ x the strokes shown: example 00 seconds with ½ HP would be 00 x. = 600 seconds *** If a /6 HP motor is utilized, the stroke time of the actuators shall be approximately. X the stroke times listed for the ½ HP motor as shown: example 0 seconds with ½ HP motor would be 0 x. = 90 seconds SR Stroke Time to Fail Position (sec) Motor HP Req. 6

7 Product ata Sheet -M.0.0.EN, Page of, Rev. Torque Output ata (ouble-cting ctuator) March 0 ounterclockwise to Open G-Series ouble- cting Model MOP (bar) Outboard ISPL (cm ) Outboard TO & ETO Torque Expression (Nm/bar) Torque Outboard TO & 0 bar (Nm) Torque Outboard 0 bar (Nm) Torque Outboard TO & 8 bar or MOP (Nm) Torque Outboard 8 bar or MOP (Nm) Torque Outboard TO & 0 bar or MOP (Nm) Torque Outboard RUN@ 0 bar or MOP (Nm) **Estimated Stroke Time Open (seconds) G ,08,,80,0,,6.8 G ,,,9,80 *, *,.8 G ,9,8 9,,066 *,66 *,99. G ,609,89, 6,8, 9,. G ,. 0.86, 8, 0,8,0 *,60 *,0.6 G ,6..9 9,988 0,66 6,,9 0,09,.8 G ,9.6.96,9 6,,0, *,098 *,6.8 G , ,6 0,,8,0,6, G , ,,00 *0,0 *, N/ N/. G , ,08 6, 8,9 8,6 *6, *86, G , ,9 8,88 08, 09,86,99 6,69 6. *Torques are calculated at MOP **Estimated Stroking speeds will vary with temperature and hydraulic fluid viscosity changes. For stroking speed requirements less than the illustrated, consult factory for additional hydraulic accumulator to decrease open and closing speeds.

8 March 0 Torque Output ata (ouble-cting ctuator) Product ata Sheet -M.0.0.EN, Page of, Rev. lockwise to lose G-Series ouble- cting Model MOP (bar) Inboard ISPL (cm ) Inboard T & ET Torque Expression (Nm/bar) Torque Inboard T & 0 bar (Nm) Torque Inboard 0 bar (Nm) Torque Inboard T & 8 bar or MOP (Nm) Torque Inboard RUN@ 8 bar or MOP (Nm) Torque Inboard T & ET@ 0 bar or MOP (Nm) Torque Inboard 0 bar or MOP(Nm) **Estimated Stroke Time lose (seconds) G ,0 86,00,09,09,60.8 G ,80 999,8, *,6 *,0 9. G ,89,0,808,60 *9, *,90. G ,,99 8,0,,8 6,8. G ,0. 9.,00,06,80 9,9 *9, *0,. G ,0. 0.,6,88 9,8 0, 9,88, G , ,68,98, 8,66 *,9 *,0 6. G ,.6.0 0,6 6, 0,90, 6,6,8.0 G , ,0 8, *9,09 *9,9 N/ N/ 6. G ,68.. 0,69, 9,6,6 *,60 *6,9. G , ,8 68,8,6 9,6 9,,0 0. *Torques are calculated at MOP **Estimated Stroking speeds will vary with temperature and hydraulic fluid viscosity changes. For stroking speed requirements less than the illustrated, consult factory for additional hydraulic accumulator to decrease open and closing speeds. 8

9 Product ata Sheet -M.0.0.EN, Page of 8, Rev. March 0 Model Information Standard Spring-Return -SRH00 G0x0.-SR9 0-SRH00 G0x0.0-SR 60-SRH00 G000.0-SR G000.0-SR G00.-SR G00.-SR G00.-SR G00.0-SR G00.0-SR G00.-SR G00.-SR G00.0-SR G00.0-SR G00.0-SR G006.0-SR G800.0-SR G800.0-SR G SR G SR Product escription Standard Self-ontained Electro-Hydraulic ctuator ctuator Size Spring-Return ctuator Model Temperature Rating -0 F (-9 ) -0 F (-0 ) Valve Rotation irection 0 lockwise to close ounterclockwise to close ctuator Function On/Off Fail Function Loss of Power Loss of ES Signal 0 Stay put (No ES) N/ Stay put lose lose lose Stay put Open Open Open lose (No ES) N/ 6 Open (No ES) N/ ES Solenoid Valve N No ES Solenoid Valve S Internal Standard Solenoid Valve R Internal Standard Solenoid Valve with External Manual Reset Push utton ox L External Low Wattage Solenoid Valve(down to -) ual ES Solenoid Valves Remote ontrol 0 iscrete Limit Switches SPT SPT Output 0 None Internal pressure transmitter with -0 m output for hydraulic pressure monitoring Internal pressure switch for low pressure alarm Internal pressure switch for low pressure alarm (accumulator) 9

10 Product ata Sheet March 0 -M.0.0.EN, Page of 8, Rev. Model Information Standard Spring-Return (continuation) Power Supply Volts Phase Hz T N K 0 0 P 0 0 L 0 R 0 0 S V W F - - Orientation (Operator to Pipeline) Pipeline Orientation Valve Stem Orientation ctuator ylinder Orientation Horizontal Vertical Parallel to pipeline Horizontal Vertical Perpendicular to pipeline Horizontal Horizontal Parallel to pipeline Horizontal Horizontal Perpendicular to pipeline Vertical Horizontal Perpendicular to pipeline 6 Vertical Horizontal Parallel to pipeline Valve Mounting MN No Valve Mounting daptor M Valve mounting daptor Options (Multiple hoices) X ccumulator for X strokes, for example, means accumulator for stroke lose coupled circuit breaker P ustomer specified paint PS ettis standard paint R Remote mounted circuit breaker R Remote display module SP Solar panel and battery (only V model) SW Level Switch ertificates (Multiple hoices) X TEX Eexd II T S S lass I iv. I Group, S lass I iv. I Group,, FM FM lass I iv. I Group, F FM lass I iv. I Group,, IE IE S SIL Special onfiguration S Special onfiguration 0

11 Product ata Sheet -M.0.0.EN, Page of 8, Rev. March 0 Model Information Standard ouble-cting G000.0 G00.0 G00.0 G00.0 G00.0 G00.0 G00.0 G00.0 G008.0 G G Product escription Smart Self-ontained Electro-Hydraulic ctuator ctuator Size ouble-cting ctuator Model Temperature Rating -0 F (-9 ) -0 F (-0 ) Valve Rotation irection 0 lockwise to close ounterclockwise to close ctuator Function On/Off Fail Function Loss of Power 0 Stay put (No ES) N/ Stay put lose lose lose Stay put Open Open Open lose (No ES) N/ 6 Open (No ES) N/ Loss of ES Signal ES Solenoid Valve N No ES Solenoid Valve S Internal Standard Solenoid Valve R Internal Standard Solenoid Valve with External Manual Reset Push utton ox L External Low Wattage Solenoid Valve(down to -) ual ES Solenoid Valves Remote ontrol 0 iscrete Limit Switches SPT SPT Output 0 None Internal pressure transmitter with -0 m output for hydraulic pressure monitoring Internal pressure switch for low pressure alarm Internal pressure switch for low pressure alarm (accumulator)

12 Product ata Sheet March 0 -M.0.0.EN, Page of 8, Rev. Model Information Standard ouble-cting (continuation) Power Supply Volts Phase Hz T N K 0 0 P 0 0 L 0 R 0 0 S V W F - - Pipeline Orientation Valve Stem Orientation ctuator ylinder Orientation Horizontal Vertical Parallel to pipeline Horizontal Vertical Perpendicular to pipeline Horizontal Horizontal Parallel to pipeline Horizontal Horizontal Perpendicular to pipeline Vertical Horizontal Perpendicular to pipeline 6 Vertical Horizontal Parallel to pipeline Valve Mounting MN No Valve Mounting daptor M Valve mounting daptor Options (Multiple hoices) X ccumulator for X strokes, for example, means accumulator for stroke lose coupled circuit breaker P ustomer specified paint PS ettis standard paint R Remote mounted circuit breaker R Remote display module SP Solar panel and battery (only V model) SW Level Switch ertificates (Multiple hoices) X TEX Eexd II T S S lass I iv. I Group, S lass I iv. I Group,, FM FM lass I iv. I Group, F FM lass I iv. I Group,, IE IE Special onfiguration S Special onfiguration

13 Product ata Sheet -M.0.0.EN, Page of 8, Rev. March 0 Model Information Smart Spring-Return S -SRH00 G0x0.-SR9 0-SRH00 G0x0.0-SR 60-SRH00 G000.0-SR G000.0-SR G00.-SR G00.-SR G00.-SR G00.0-SR G00.0-SR G00.-SR G00.-SR G00.0-SR G00.0-SR G00.0-SR G006.0-SR G800.0-SR G800.0-SR G SR G SR Product escription Smart Self-ontained Electro-Hydraulic ctuator ctuator Size Spring-Return ctuator Model Temperature Rating -0 F (-9 ) -0 F (-0 ) Valve Rotation irection 0 lockwise to close ounterclockwise to close ctuator Function On/Off or Intermittent Positioning Modulating Fail Function Loss of Power Loss of ES Signal 0 Stay put (No ES) N/ Stay put lose lose lose Stay put Open Open Open lose (No ES) N/ 6 Open (No ES) N/ N S R L Modbus(M0)(efault) HRT(M6) Foundation Fieldbus(M8) N ES Solenoid Valve No ES Solenoid Valve Internal Standard Solenoid Valve Internal Standard Solenoid Valve with External Manual Reset Push utton ox External Low Wattage Solenoid Valve(down to -) ual ES Solenoid Valves ommunication Protocols Limit Switches No Limit Switches SPT SPT

14 Product ata Sheet March 0 -M.0.0.EN, Page 6 of 8, Rev. Model Information Smart Spring-Return (continuation) Power Supply Volts Phase Hz T N K 0 0 P 0 0 L 0 R 0 0 S V W F - - Orientation (Operator to Pipeline) Pipeline Orientation Valve Stem Orientation ctuator ylinder Orientation Horizontal Vertical Parallel to pipeline Horizontal Vertical Perpendicular to pipeline Horizontal Horizontal Parallel to pipeline Horizontal Horizontal Perpendicular to pipeline Vertical Horizontal Perpendicular to pipeline 6 Vertical Horizontal Parallel to pipeline Valve Mounting MN No Valve Mounting daptor M Valve mounting daptor Options (Multiple hoices) X ccumulator for X strokes, for example, means accumulator for stroke lose coupled circuit breaker P ustomer specified paint PS ettis standard paint R Remote mounted circuit breaker R Remote display module SP Solar panel and battery (only V model) SW Level Switch ertificates (Multiple hoices) X TEX Eexd II T S S lass I iv. I Group, S lass I iv. I Group,, FM FM lass I iv. I Group, F FM lass I iv. I Group,, IE IE S SIL Special onfiguration S Special onfiguration

15 Product ata Sheet -M.0.0.EN, Page of 8, Rev. March 0 Model Information Smart ouble-cting S G000.0 G00.0 G00.0 G00.0 G00.0 G00.0 G00.0 G00.0 G008.0 G G Product escription Smart Self-ontained Electro-Hydraulic ctuator ctuator ouble-cting ctuator Model Temperature Rating -0 F (-9 ) -0 F (-0 ) Valve Rotation irection 0 lockwise to close ounterclockwise to close ctuator Function On/Off or Intermittent Positioning Modulating Fail Function Loss of Power 0 Stay put (No ES) N/ Stay put lose lose lose Stay put Open Open Open lose (No ES) N/ 6 Open (No ES) N/ Loss of ES Signal ES Solenoid Valve N No ES Solenoid Valve S Internal Standard Solenoid Valve L External Low Wattage Solenoid Valve ual ES Solenoid Valves ommunication Protocols Modbus(M0)(efault) HRT(M6) Foundation Fieldbus(M8) Limit Switches N No Limit Switches SPT SPT Output 0 None Internal pressure transmitter with -0 m output for hydraulic pressure monitoring Internal pressure switch for low pressure alarm

16 Product ata Sheet March 0 -M.0.0.EN, Page 8 of 8, Rev. Model Information Smart ouble-cting (continuation) Power Supply Volts Phase Hz T N K 0 0 P 0 0 L 0 R 0 0 S V W F - - Orientation (Operator to Pipeline) Pipeline Orientation Valve Stem Orientation ctuator ylinder Orientation Horizontal Vertical Parallel to pipeline Horizontal Vertical Perpendicular to pipeline Horizontal Horizontal Parallel to pipeline Horizontal Horizontal Perpendicular to pipeline Vertical Horizontal Perpendicular to pipeline 6 Vertical Horizontal Parallel to pipeline Valve Mounting MN No Valve Mounting daptor M Valve mounting daptor Options (Multiple hoices) X ccumulator for X strokes, for example, means accumulator for stroke lose coupled circuit breaker P ustomer specified paint PS ettis standard paint R Remote mounted circuit breaker R Remote display module SP Solar panel and battery (only V model) SW Level Switch ertificates (Multiple hoices) X TEX Eexd II T S S lass I iv. I Group, S lass I iv. I Group,, FM FM lass I iv. I Group, F FM lass I iv. I Group,, IE IE Special onfiguration S Special onfiguration 6

17 Weight INH MM INH MM INH MM INH MM INH MM Lbs KG Product ata Sheet M.0.0.EN, Page of, Rev ER L imension Spring-Return, Fail-Safe ctuator H G -VE- POWER MOULE F H G F opyright 0 Emerson Process Management Valve utomation, Inc. opyright 0 Emerson Process Management Valve utomation, Inc. H G F -VE- POWER MOULE E YLINER L POWER MOULE SPRING MOULE OUTLINE IMENSION N ETILS OUTL ctuator ctuator INH MM INH MM INH INH MM MM INH INH G000.0-SR-W.0.6G000.0-SR-W G000.0-SR-W.0.6G000.0-SR-W G00.-SR-W.8 68.G00.-SR-W G00.-SR-W.8 68.G00.-SR-W G00.-SR-W G00.-SR-W G00.0-SR-W G00.0-SR-W G00.0-SR-W 6. 9.G00.0-SR-W G00.-SR-W 6. 9.G00.-SR-W G00.-SR-W G00.-SR-W G00.0-SR-W G00.0-SR-W G00.0-SR-W YLINER G00.0-SR-W. L YLINER LG00.0-SR-W G00.0-SR-W G006.0-SR-W G006.0-SR-W G800.0-SR-W 9. 8.G800.0-SR-W G800.0-SR-W 9. 8.G800.0-SR-W G SR-W G SR-W SPRING MOULE March 0 SPRING MOULE E MNUL OVERRIE E MNUL OVERRIE HYRULI MNIFOL SSEMLY LOL ISPLY MOULE (Local/Remote Operation) MNUL OVERRIE IRUIT REKER MOULE HYRULI MNIFOL SSEMLY PRESSURE GUGE LOL ISPLY MOULE (Local/Remote Operation) IRUIT REKER MOULE HYRULI MNIFOL PRESSURE GUGE SSEMLY LOL ISPLY MOULE (Local/Remote Operation) IRUIT REKER MOULE PR VLVE MOUNTING SURFE YLINER L YLINER L X STOP JUSTMENT VLVE MOUNTING SURFE VLVE MOUNTING SURFE X STOP JUSTMENT VLVE L SREW VLVE L SREW VLVE L YLINER L X STOP JUSTMENT VLVE L SREW YLINER L VLVE L E E OUTLINE IMENSION N ETILS pproximate E ctuator Weight inch cm inch cm inch cm inch cm inch cm lbs kg G000.0-SR-W G000.0-SR-W G00.-SR-W G00.-SR-W G00.-SR-W G00.0-SR-W G00.0-SR-W ,9.6 G00.-SR-W , 9. G00.-SR-W , G00.0-SR-W , G00.0-SR-W ,8,68. G00.0-SR-W ,,08.9 G006.0-SR-W ,,0.0 G800.0-SR-W ,,0. G800.0-SR-W ,,6.6 G SR-W ,9,00.8 VLVE L 6

18 Product ata Sheet March 0 -M.0.0.EN, Page of, Rev. imension Spring-Return ctuator OUTLINE IMENSION N ETILS pproximate E ctuator Weight inch cm inch cm inch cm inch cm inch cm lbs kg E SRH E0-SRH E60-SRH

19 OUTLINE IMENSION N ETILS E pproximate Weight MM INH MM INH MM INH MM INH MM Lbs KG Product ata Sheet M.0.0.EN, Page..6 of, 8Rev imension ouble-cting ctuator March 0 OUTLINE IMENSION N OUTLINE ETILS IMENS ctuator ctuator INH MM INH INH MM MM INH INH MM MM INH INM G G G G G G G G G G G G G G G G G G G G G G OUTLINE IMENSION N ETILS pproximate E ctuator Weight inch cm inch cm inch cm inch cm inch cm lbs kg G G G G G G ,. G , G , G , G ,6,6.9 G ,,0.8 9

20 March 0 Standard Electrical onnection iagram Product ata Sheet -M.0.06.EN, Page of, Rev. Two-Wire control Maintain ontact to Open Three-Wire control Maintain ontacts Four-Wire control Maintain ontacts ES Input Internal Power Supply LOSE LOSE STOP NOT PPLILE 9 + V 9 + V 9 + V USTOMER MIN POWER ONNETION 60 V 60 HZ PH L L L F OL T T T T T T HETER W MOTOR External Power Supply V 9 + V 0 V 9 LOSE + V 0 V 9 LOSE STOP + V 0 V 9 NOTE: O NOT USE INTERNL V POWER SOURE (EX. FROM 9, 0) ES + V 0 V F H USTOMER MIN POWER ONNETION LS- LOSE LS- 60 V 60 HZ PH 0 FOR REMOTE STOP P OR RELY: REMOVE JUMPER J L L L F P - 88 J H F H X6 V X X V X X V X T T T T P P6 P P P H P J 6 P H LS- LOSE LS- FOR REMOTE STOP P OR RELY: REMOVE JUMPER J T T T S 6 8 OL T T T LOSING SOL GRN P - 88 J HETER W MOTOR H X6 V X X V X X V X T T T T P P6 P P LOSE S PS- PM P H R J 6 P STOP ONTTOR O R P H S 6 8 OFF LOL (HN) S S S6 S LOSING SOL. REMOTE (UTO) 96 Internal Power Supply External Power Supply V ST USTOMER ONNETIONS Four-Wire control Maintain ontacts 0 0 V LS- N/ RELY OUTPUT RY ONTT LS- OMMON RELY OUTPUT 9 + RY VONTT LS- N/O RELY OUTPUT RY ONTT LOSE LS- N/ RELY OUTPUT RY ONTT LOSE LS- OMMON RELY OUTPUT RY ONTT LOSE LS- N/O RELY OUTPUT RY ONTT JUMPER INSTLLE Y FTORY REMOVE IF REMOTE STOP PUSHUTTON IS INSTLLE SELETOR IN LOL RY ONTT LOSE LOSE 9 SELETOR IN LOL RY ONTT 0 STOP LOSE SELETOR IN REMOTE RY ONTT R SELETOR IN REMOTE RY ONTT + V 9 + V + V MOTOR OVERLO RY ONTT MOTOR OVERLO RY ONTT 98 0 V 0 V 0 V R ST USTOMER 9 ONNETIONS 0 LIMIT SWITH NO ONTT LIMIT SWITH N ONTT LOSE LOSE LS- LIMIT SWITH OMMON JUMPER INSTLLE Y FTORY LOSE LIMIT SWITH NO ONTT REMOVE IF REMOTE STOP PUSHUTTON IS INSTLLE LOSE LIMIT SWITH N ONTT LOSE LS- O- R- LOSE LIMIT SWITH OMMON ES SOLENOI POWER (+ V) ES 0V V V P() LS- N/ RELY OUTPUT RY ONTT P() LS- OMMON RELY OUTPUT RY ONTT P() LS- N/O RELY OUTPUT RY ONTT P() LOSE LS- N/ RELY OUTPUT RY ONTT P() LOSE LS- OMMON RELY OUTPUT RY ONTT P() LOSE LS- N/O RELY OUTPUT RY ONTT SELETOR IN LOL RY ONTT 9 SELETOR IN LOL RY ONTT 0 SELETOR IN REMOTE RY ONTT SELETOR IN REMOTE RY ONTT 9 MOTOR OVERLO RY ONTT MOTOR OVERLO RY ONTT GRN RE PS- Two-Wire control Maintain ontact to Open ONTTOR O R 9 + V Three-Wire control Maintain ontacts 9 + V R- LOSE P() P() P() P() P() P() LOSE ES SOLENOI POWER (+ V) ES 0V 9 + V LOSE STOP ES Input NOT PPLILE NOTE: O NOT USE INTERNL V POWER SOURE (EX. FROM 9, 0) ES + V 0 V REVISIONS REV EN TE -- LIMIT SWITH ONTT EVELOPMENT VLVE POSITION FULLY MI FULLY POSITION LOSE LIMIT SWITH LS- & LS- & ONTT N.. N.O. N.. N.O. SS TLE HN OFF UTO X O O S S O O X S6 O O X S X O O

21 (NO) STOP LOL (YES) REMOTE SETUP (K) LRM TQ S T OP (NEXT) (NO) LOL REMOTE SETUP 60 STOP 0 (YES) (K) 0 LRM TQ ST OP (NEXT) Product ata Sheet -M.0.06.EN, Page of, Rev. March 0 Smart Electrical onnection iagram MOTOR Thermal Protector Motor ontrol Module L L L - Phase Power Supply GN F F I (Open) I (lose) entral ontrol Module Field oard V Power Supply Input-Output Module IOM oard igital Inputs 6 I (Stop / PST) ommon 0V (I - I) I (Open Inhibit) I (lose Inhibit) I6 (ES +Ve) 8 ES 0V 9 + V 0 0 V Open lose Local Remote Open lose Local Remote R0# RL ommon Local isplay Module Remote isplay Module ( or May be fitted) ontact Outputs R0# R0# R0# Monitor Relay R0# 6 8 RL RL ommon RL N.O. ontact ommon Two-Wire ontrol Maintain ontact to Open Open Three-Wire ontrol Maintained ontacts Open lose Four-Wire ontrol Momentary ontacts Open lose ES Input ES PST Input PST Separate Terminal hamber 9 0 } N.. ontact Emergency Stop RS8 Notes: Internal Power Supply External Power Supply 8-00 V or 0-0 V V + V Open + - ommon OV V + V Open lose + - ommon OV V Stop + V Open lose Stop + ommon OV -. ll digital inputs have an input voltage range of 8-00 V or 0-0 V. NOTES: ) ll digital inputs have an input voltage range of 8-00 V or 0-0 V.. ll digital relay ) outputs ll digital are relay rated outputs for are 0 for or 0 or V 0 Resistive, V Resistive, Inductive load. ) RL - RL are dual latching type realys.. RL - RL are ) dual Emergency latching stop type requires relays. jumper or normally closed contact (actuator stops when contact open). ) Remote display communication port is RS-8. 6). Emergency stop If requires bare wires jumper (without or terminals) normally are connected, closed contact remove (actuator a maximum stops of. when inch insulation. contact open). ) User replaceable primary fuses (F and F) are located in the Terminal hamber Enclosure. 8) For single phase supply option, terminal L should be used as Live connection and L. Remote display communication port is RS-8. should be used as Neutral connection. 9) The Shield connections of RS8, nalog input and nalog output lines should be 6. If bare wires (without terminated terminals) on therminal are # connected,. remove a maximum of. inch insulation V + V ES + ommon OV V + V PST ommon OV - RM Interface us nlog Inputs nlog Outputs Mechaniacl Limit Switch Outputs Other Options Shield ommand Signal (+) 6 ommand Signal (-) Position Feedback (+) 8 Position Feedback (-) 9 Torque Feedback (+) 0 Torque Feedback (-) LS N.O. LS N.. LS ommon LS N.O. LS N } LS ommon Reserved for Future Use 9 0 uxiliary relay Module OR Network M. User replaceable primary fuses (F and F) are located in the Terminal hamber Enclosure. 8. For single phase supply option, terminal L should be used as Live connection and L should be used as Neutral connection. 9. The Shield connections of RS8, nalog input and nalog output lines should be terminated on terminal #. + - Pushbutton N.O. Type Pushbutton N.. Type Extermal voltage Source Emergency Switch- N.. Type

22 World rea onfiguration enters (W) offer sales support, service, inventory and commissioning to our global customers. hoose the W or sales office nearest you: NORTH & SOUTH MERI 900 Northwest Freeway Houston TX 06 US T F MILE EST & FRI P. O. ox 0 ubai United rab Emirates T F v. Hollingsworth Iporanga Sorocaba SP razil T F SI PIFI No. 9 Gul Road #0-0 Singapore 696 T F No. Lai Yuan Road Wuqing evelopment rea Tianjin 000 P. R. hina T F P. O. ox 00 Jubail 96 Saudi rabia T F ngus rescent Longmeadow usiness Estate East P.O. ox 6908 Greenstone 66 Modderfontein Extension South frica T + 00 F EUROPE erenyi u Videoton Industry Park uilding #0 Székesfehérvár 8000 Hungary T F For complete list of sales and manufacturing sites, please visit or contact us at info.actuationtechnologies@emerson.com 0 Emerson. ll rights reserved. The Emerson logo is a trademark and service mark of Emerson Electric o. ettis is a mark of one of the Emerson family of companies. ll other marks are property of their respective owners. The contents of this publication are presented for information purposes only, and while every effort has been made to ensure their accuracy, they are not to be construed as warranties or guarantees, express or implied, regarding the products or services described herein or their use or applicability. ll sales are governed by our terms and conditions, which are available on request. We reserve the right to modify or improve the designs or specifications of our products at any time without notice.