Hustler Raptor Flip-Up Parts Manual (CE)

Transcription

1 Hustler Raptor Flip-Up Parts Manual (CE)

2 General Information 1 Frame Frame 3-1 Transmissions & Steering Transmission Assembly 4-1 Transmission Service Parts Transmission Service Parts Steering & Deck Lift Controls S/N & Higher (Multi-Page) 4-4 Steering & Deck Lift Controls S/N Prior to (Multi-Page) 4-5 Steering & Deck Lift Controls Sub-Assembly 4-6 Wheels & Tires Wheel & Tire 5-1 Front Tire Breakdown 5-2 Drive Wheel Breakdown 5-3 Engine & Fuel System Engine (Multi-Page) 6-1 Engine Service Parts 6-2 Fuel System 6-3 Electrical, Fenders, Instrument Panel Battery 7-1 Fenders & Instrument Panel (Multi-Page) 7-2 Deck 48" Side Discharge Service Deck " Side Discharge Deck Pulleys & Spindles " Side Discharge Deck " Rear Discharge Service Deck " Rear Discharge Deck Pulleys & Spindles " Rear Discharge Deck 8-6 Rear Discharge Deck Shield 8-7 Deck Carrier (Multi-Page) 8-8 Seat Seat, Standard 9-1 Seat Service Parts - Standard Seat 9-2 Seat, Seats Inc. 9-3 Seat Service Parts, Seats Inc. 9-4 Appendice AIndice pagine A Appendice BIndice parti B

3

4

5

6 Frame Frame Frame Tue Sep 19 12:17:01 UTC

7 Frame Elemento Parte n. Nome Q.ta Udm SVC, FRAME RFU 1 EA MOUNT, PUSH BUTTON 3 EA WIRE TIE, SMALL/SHORT 4 EA NT HXG5 4 EA FW 0.343SAE 4 EA GREASE FITTING STRAIGHT 10 EA CS x1.50FLT SH ZY 4 EA GUIDE BLOCK, CARRIER 2 EA RIVET NUT, 3/8-16 THREA 6 EA NT FLKG5 6 EA CS X0.750FLK 8 EA NT HXG5 2 EA FW x x EA MUFFLER SHIELD 1 EA SVC, BUMPER RFU 1 EA DECAL, HOT 1 EA CB X 1.00 G5 ZNY 2 EA HAND GRIP, 7/8 I.D. 1 EA W/A, FRAME LATCH 1 EA SUPPORT, FUEL TANK W/A 1 EA DECAL, TIP OVER DANGER 1 EA Not Shown Not Shown WIRE HARNESS 1 EA WIRE TIE, 1 EA Comments for Page: Frame jmumford@excelii.com on Nov 6, The frame includes the decal (605650). 2. The bumper (552922) includes the decal (602041). Frame Tue Sep 19 12:17:01 UTC

8 Transmissions & Steering Transmission Assembly Transmission Assembly Tue Sep 19 12:17:02 UTC

9 Transmission Assembly Elemento Parte n. Nome Q.ta Udm BELT, A " EL 1 EA CS X 2.25 HXG5ZY 1 EA PULLEY, IDLER EA IDLER SPACER 1 EA TENSION ARM W/A 1 EA NT NLG8 1 EA BUSHING 1 EA SPRING, PUMP IDLER 1 EA FW.406X.688X.060 ZNYC 1 EA CS X1.250 HX G5 1 EA FW 0.625X1.000X EA NT HX G5 ZNYC 1 EA CS X1.250HXG5 1 EA FW 0.781X1.250X EA BUSHING, UHMW 2 EA FW.760X1.625X EA SB.750X SH EA CS X2.500HXG5 4 EA CS X3.000HXG5 4 EA FW 0.343SAE 16 EA NT HXG5 8 EA ZT2800, 20.69:1 TRANS 1 EA ZT2800, 20.69:1 TRANS 1 EA CS X2.000HXG5 2 EA FW x x EA SPACER TUBE 1 EA FW 0.281SAE 2 EA NT HXZY NL 2 EA EXPANSION TANK, ZT EA Transmission Assembly Tue Sep 19 12:17:02 UTC

10 Transmission Assembly Elemento Parte n. Nome Q.ta Udm Not Shown CAP, OVERFLOW TANK 1 EA WIRE TIE, SMALL/SHORT 1 EA GM, 2.25IDX 3.0ODX 2.5GD 1 EA CB X.625 ZNYC 2 EA CS X0.750FLK 1 EA SPRING CLAMP,.75" DIA 6 EA OVERFLOW HOSE, 6" 1 EA FTG, -8MBT/-8MBT, 90 1 EA HP0.080X EA LINK, TOW VALVE 2 EA FTG, -6MORB/-8MBT STR 1 EA NT FLKG5 1 EA OVERFLOW HOSE, 7" 1 EA HOSE CLAMP 1" (FS) 1 EA OVERFLOW HOSE, 19" 1 EA FTG, 90-9/16 SAE 1 EA Comments for Page: Transmission Assembly jmumford@excelii.com on Apr 22, Torque to 23 N m. 2. Torque to 136 N m. 3. Torque to 41 N m. 4. The overflow tank includes the cap. Transmission Assembly Tue Sep 19 12:17:02 UTC

11 Transmission Service Parts Transmissions & Steering Transmission Service Parts Tue Sep 19 12:17:02 UTC

12 Transmission Service Parts Elemento Parte n. Nome Q.ta Udm FAN / PULLEY KIT 1 EA GUARD, TRANS FILTER 1 EA CS X.75 HX FLG 3 EA FILTER, OIL 1 EA HG RTN CW 1 EA HG RTN SPRING 1 EA KIT, HUB, 4 BOLT 1 EA ZT2800 BRAKE ARM EA CLIP, RETAINING 1 EA Transmission Service Parts Tue Sep 19 12:17:02 UTC

13 Transmission Service Parts Transmissions & Steering Transmission Service Parts Tue Sep 19 12:17:03 UTC

14 Transmission Service Parts Elemento Parte n. Nome Q.ta Udm FAN / PULLEY KIT 1 EA GUARD, TRANS FILTER 1 EA CS X.75 HX FLG 3 EA FILTER, OIL 1 EA KIT, HUB, 4 BOLT 1 EA HG RTN CCW 1 EA HG RTN SPRING 1 EA ZT2800 BRAKE ARM EA CLIP, RETAINING 1 EA Comments for Page: Transmission Service Parts jmumford@excelii.com on May 1, RS filter guard (600974) includes hardware. 2. Hub kit (600970) includes the hub nut. Transmission Service Parts Tue Sep 19 12:17:03 UTC

15 Steering & Deck Lift Controls S/N & Higher (Multi-Page) Transmissions & Steering Steering & Deck Lift Controls S/N & Higher (Multi-Page) Tue Sep 19 12:17:04 UTC

16 Steering & Deck Lift Controls S/N & Higher (Multi-Page) Elemento Parte n. Nome Q.ta Udm NT NLG5 8 EA NT HXZY NL 2 EA FW 0.281SAE 2 EA SB0.312X0.750SH EA CN x.200 MAX THK 2 EA FW 0.343SAE 19 EA BALL STUD, DAMPER 4 EA DAMPER 2 EA STEERING ROD S/A 2 EA NT NLG5 2 EA BRAKE ROD 2 EA NT HXG5 2 EA NT NLG8 9 EA FW x x EA CS X1.500HXG5 4 EA TURNBUCKLE, FRAME LATCH 2 EA SPRING EA CLIP, SAFETY 2 EA SPRING, BRAKE ARM RET. 2 EA BRAKE SPRING LINK, LS 1 EA BRAKE SPRING LINK, RS 1 EA NT FLKG5 2 EA CS X0.750HXG5 2 EA OVERTRAVEL SPRING 2 EA CS X1.250 HX G5 1 EA LATCH ARM 1 EA BUSHING,IGUS#0608 (FS) 3 EA CS X2.000HXG5 2 EA SPACER, CAM FOLLOWER 2 EA Steering & Deck Lift Controls S/N & Higher (Multi-Page) Tue Sep 19 12:17:04 UTC

17 Steering & Deck Lift Controls S/N & Higher (Multi-Page) Steering & Deck Lift Controls S/N & Higher (Multi-Page) Tue Sep 19 12:17:04 UTC

18 Steering & Deck Lift Controls S/N & Higher (Multi-Page) Elemento Parte n. Nome Q.ta Udm BUSHING, LATCH BEARING 2 EA BUSHING,.500X EA CS x 2.00 BH BO 1 EA W/A, CARRIER LATCH 2 EA CS X 1.5 BH BO 1 EA SB.50X.75SH TD 2 EA SPRING, TENSION.625OD 2 EA ACTUATOR SPACER, INNER 1 EA LIFT PIVOT PLATE, LH 1 EA CS X4.000HXG5 1 EA FW 0.500X1.250X EA LIFT PIVOT PLATE, RH 1 EA LIFT PIVOT SPACER 1 EA ACTUATOR SPACER, OUTER 1 EA FW.656X 1.312X.090 ZNY 1 EA FW.531 x x EA CS X3.000HXG5 1 EA CE 0.500X4.00X3.50 HDLS 1 EA LYNCH PIN DIA 1 EA NT UNTG8 1 EA 50 N/A SERIAL NO. / SPEC DECAL 1 EA DECAL, CE MARK 1 EA CE DBA LIMIT DECAL 1 EA CS X1.000HXG5 2 EA NT FLKG5 11 EA CS X1.000 HXFLK 4 EA SB.500X SH EA W/A, ACTUATOR MOUNT 1 EA ACTUATOR S/A 1 EA Steering & Deck Lift Controls S/N & Higher (Multi-Page) Tue Sep 19 12:17:04 UTC

19 Steering & Deck Lift Controls S/N & Higher (Multi-Page) Steering & Deck Lift Controls S/N & Higher (Multi-Page) Tue Sep 19 12:17:04 UTC

20 Steering & Deck Lift Controls S/N & Higher (Multi-Page) Elemento Parte n. Nome Q.ta Udm CS X1.000HXG5 2 EA NUT PLATE,.420 CENTERS 1 EA SWITCH BRACKET 1 EA SWITCH PLUNGER, NC/NO 1 EA CS #10-24X0.750FLKG5 2 EA 64 N/A CONTROL ASSEMBLY 1 EA NT HXZY NL THIN 1 EA CS X1.00 BTNHD ZN 2 EA PLUNGER BRKT 1 EA SPRING PLUNGER, LOCKING 1 EA STEERING BAR W/A, RH 1 EA Not Shown GRIP, STEERING BAR 1 EA STEERING BAR W/A, LH 1 EA CS X1.000HXG5 4 EA CS X0.750FLK 7 EA Steering & Deck Lift Controls S/N & Higher (Multi-Page) Tue Sep 19 12:17:04 UTC

21 Steering & Deck Lift Controls S/N & Higher (Multi-Page) Steering & Deck Lift Controls S/N & Higher (Multi-Page) Tue Sep 19 12:17:04 UTC

22 Steering & Deck Lift Controls S/N & Higher (Multi-Page) Comments for Page: Steering & Deck Lift Controls S/N & Higher (Multi-Page) on Apr 22, Part of the transmission. 2. The nut must be flush with the end of the brake rod. 3. Torque to 19 N m. 4. Part of the actuator assembly, Serial number decal. In the event the serial number decal becomes damaged or illegible, please contact your dealer to order a replacement. 6. The steering handles include the grips. Steering & Deck Lift Controls S/N & Higher (Multi-Page) Tue Sep 19 12:17:04 UTC

23 Steering & Deck Lift Controls S/N Prior to (Multi-Page) Transmissions & Steering Steering & Deck Lift Controls S/N Prior to (Multi-Page) Tue Sep 19 12:17:05 UTC

24 Steering & Deck Lift Controls S/N Prior to (Multi-Page) Elemento Parte n. Nome Q.ta Udm NT NLG5 8 EA NT HXZY NL 2 EA FW 0.281SAE 2 EA SB0.312X0.750SH EA CN x.200 MAX THK 2 EA FW 0.343SAE 19 EA BALL STUD, DAMPER 4 EA DAMPER 2 EA STEERING ROD S/A 2 EA BRAKE ROD 2 EA NT HXG5 2 EA NT NLG8 9 EA FW x x EA CS X1.500HXG5 8 EA TURNBUCKLE, FRAME LATCH 2 EA SPRING EA CLIP E.66 X.303 X EA SPRING, BRAKE ARM RET. 2 EA BRAKE SPRING LINK, LS 1 EA BRAKE SPRING LINK, RS 1 EA NT FLKG5 2 EA CS X0.750HXG5 2 EA OVERTRAVEL SPRING 2 EA CS X1.250 HX G5 1 EA LATCH ARM 1 EA BUSHING,IGUS#0608 (FS) 3 EA CS X2.000HXG5 2 EA SPACER, CAM FOLLOWER 2 EA BUSHING, LATCH BEARING 2 EA Steering & Deck Lift Controls S/N Prior to (Multi-Page) Tue Sep 19 12:17:05 UTC

25 Steering & Deck Lift Controls S/N Prior to (Multi-Page) Steering & Deck Lift Controls S/N Prior to (Multi-Page) Tue Sep 19 12:17:05 UTC

26 Steering & Deck Lift Controls S/N Prior to (Multi-Page) Elemento Parte n. Nome Q.ta Udm BUSHING,.500X EA CS x 2.00 BH BO 1 EA W/A, CARRIER LATCH 2 EA CS X 1.5 BH BO 1 EA SB.50X.75SH TD 2 EA SPRING, TENSION.625OD 2 EA ACTUATOR SPACER, INNER 1 EA LIFT PIVOT PLATE, LH 1 EA CS X4.000HXG5 1 EA FW 0.500X1.250X EA LIFT PIVOT PLATE, RH 1 EA LIFT PIVOT SPACER 1 EA ACTUATOR SPACER, OUTER 1 EA FW.656X 1.312X.090 ZNY 1 EA FW.531 x x EA CS X3.000HXG5 1 EA CE 0.500X4.00X3.50 HDLS 1 EA LYNCH PIN DIA 1 EA NT UNTG8 1 EA 49 N/A SERIAL NO. / SPEC DECAL 1 EA DECAL, CE MARK 1 EA CE DBA LIMIT DECAL 1 EA CS X1.000HXG5 2 EA NT FLKG5 11 EA CS X1.000 HXFLK 4 EA SB.500X SH EA W/A, ACTUATOR MOUNT 1 EA ACTUATOR S/A 1 EA CS X1.000HXG5 2 EA Steering & Deck Lift Controls S/N Prior to (Multi-Page) Tue Sep 19 12:17:05 UTC

27 Steering & Deck Lift Controls S/N Prior to (Multi-Page) Steering & Deck Lift Controls S/N Prior to (Multi-Page) Tue Sep 19 12:17:05 UTC

28 Steering & Deck Lift Controls S/N Prior to (Multi-Page) Elemento Parte n. Nome Q.ta Udm NUT PLATE,.420 CENTERS 1 EA SWITCH BRACKET 1 EA SWITCH PLUNGER, NC/NO 1 EA CS #10-24X0.750FLKG5 2 EA 63 N/A CONTROL SUB-ASSEMBLY 1 EA NT HXZY NL THIN 1 EA CS X1.00 BTNHD ZN 2 EA PLUNGER BRKT 1 EA SPRING PLUNGER, LOCKING 1 EA STEERING BAR W/A 2 EA Not Shown GRIP, STEERING BAR 1 EA CS X1.000HXG5 4 EA CS X0.750FLK 7 EA NT HXG5 4 EA Steering & Deck Lift Controls S/N Prior to (Multi-Page) Tue Sep 19 12:17:05 UTC

29 Steering & Deck Lift Controls S/N Prior to (Multi-Page) Steering & Deck Lift Controls S/N Prior to (Multi-Page) Tue Sep 19 12:17:06 UTC

30 Steering & Deck Lift Controls S/N Prior to (Multi-Page) Comments for Page: Steering & Deck Lift Controls S/N Prior to (Multi-Page) on Apr 22, Part of the transmission. 2. Part of the actuator assembly, Serial number decal. In the event the serial number decal becomes damaged or illegible, please contact your dealer to order a replacement. 4. The steering handles include the grips. Steering & Deck Lift Controls S/N Prior to (Multi-Page) Tue Sep 19 12:17:06 UTC

31 Transmissions & Steering Steering & Deck Lift Controls Sub-Assembly Steering & Deck Lift Controls Sub-Assembly Tue Sep 19 12:17:06 UTC

32 Steering & Deck Lift Controls Sub-Assembly Elemento Parte n. Nome Q.ta Udm SVC, CONTROL ASSY RFU 1 EA CS X4.250HXG5 2 EA DECAL, STEERING L.S. 1 EA CS x2.00 HX FLTHD 2 EA NT NLG8 3 EA FW 0.281SAE 4 EA NUT PLATE,.420 CENTERS 2 EA SWITCH, PUSH BUTTON 2 EA STOP, STEERING 2 EA CS X0.750HXG5 2 EA BUSHING,IGUS#0608 (FS) 4 EA NT NLG5 4 EA FW 0.343SAE 8 EA DECAL, STEERING R.S. 1 EA BRAKE BLCRNK, LH 1 EA BRAKE BLCRNK, RH 1 EA SPACER, STEERING 2 EA NT NLG5 2 EA CS #10-24X0.750FLKG5 4 EA CS X3.500HXG5 2 EA STEERING BOX SUB, LH 1 EA Not Shown STEERING BOX SUB, LH 1 EA STEERING BOX SUB, RH 1 EA Not Shown STEERING BOX SUB, RH 1 EA BRAKE LINK 2 EA LATCH SPACER 1 EA BUSHING,.625 I.D. 1 EA FRAME LATCH 1 EA Steering & Deck Lift Controls Sub-Assembly Tue Sep 19 12:17:06 UTC

33 Steering & Deck Lift Controls Sub-Assembly Elemento Parte n. Nome Q.ta Udm FW 0.406X1.000X0.120HD 1 EA CS X1.750HXG5 1 EA NT HXG5 1 EA BUSHING,.500X EA BUSHING, LATCH BEARING 1 EA FW.531X.812X.089 HD 1 EA CS X1.250HSG5 1 EA DECAL, ENGINE COMPART 1 EA BUSHING, UHMW 4 EA Comments for Page: Steering & Deck Lift Controls Sub-Assembly jmumford@excelii.com on Aug 17, and are used on mowers S/N & higher; and are used on mowers S/N prior to The steering cover (552923) includes decals. Steering & Deck Lift Controls Sub-Assembly Tue Sep 19 12:17:06 UTC

34 Wheels & Tires Wheel & Tire Wheel & Tire Tue Sep 19 12:17:07 UTC

35 Wheel & Tire Elemento Parte n. Nome Q.ta Udm TIRE/WHEEL ASSY 20x EA WHEEL NUT 8 EA CS X1.250HSG5 2 EA FW.510X 2.15X.187 SPL 2 EA FW 0.531X1.375X EA BEARING 4 EA SPACER 2 EA 8 N/A FRONT TIRE ASSEMBLY 1 EA Comments for Page: Wheel & Tire jmumford@excelii.com on Apr 22, Torque to N m. Wheel & Tire Tue Sep 19 12:17:07 UTC

36 Wheels & Tires Front Tire Breakdown Front Tire Breakdown Tue Sep 19 12:17:08 UTC

37 Front Tire Breakdown Elemento Parte n. Nome Q.ta Udm W/A CASTER 1 EA NT JAM NY LK 1 EA FW.531 x x EA CS X G5 Z 1 EA SPACER, GAUGE WHEEL 1 EA WHEEL, 9.0X3.5X4.0 HUB 1 EA Front Tire Breakdown Tue Sep 19 12:17:08 UTC

38 Wheels & Tires Drive Wheel Breakdown Drive Wheel Breakdown Tue Sep 19 12:17:08 UTC

39 Drive Wheel Breakdown Elemento Parte n. Nome Q.ta Udm TIRE 20X EA WHEEL 10X7 RIM, 4-4 BC 1 EA TIRE VALVE TR-412 GOODY 1 EA Drive Wheel Breakdown Tue Sep 19 12:17:08 UTC

40 Engine & Fuel System Engine (Multi-Page) Engine (Multi-Page) Tue Sep 19 12:17:09 UTC

41 Engine (Multi-Page) Elemento Parte n. Nome Q.ta Udm 1 ENGINE, KAW FR691V 1 EA HOSE, OIL DRAIN 1 EA MUFFLER, FR730V 1 EA FW x x EA CS x1.25 HXG8 P85 4 EA CB X 1.00 G5 ZNY 2 EA PULLEY, ENG 4.094OP 1 EA CLUTCH ANCHOR 1 EA NT HXG5 2 EA KEY 1/4 SQ X 0.66 LG(FS) 1 EA BUSHING, CLUTCH 1 EA WIRE TIE, SMALL/SHORT 7 EA K CLUTCH KIT, EA FW.453X 1.12X.119 HRD 1 EA CS X3.25 HXG5 P85 1 EA HARNESS, CLUTCH PIGTAIL 1 EA Commenti per num parte brian on Aug 28, 2015 Pigtail was updated with epoxy to hold the wires steady. The wire sheath was also updated to a more flexible material CS M8-1.25X16HX FL EA FW 0.343SAE 1 EA LW INT-EXT 1 EA CS X0.750HXG5 2 EA FW 0.281SAE 6 EA STARTER SOLENOID HW KIT 1 EA NT #10-32HXG5 1 EA NT HXG5 4 EA CLIP, HOSE CLAMP 4 EA Engine (Multi-Page) Tue Sep 19 12:17:09 UTC

42 Engine (Multi-Page) Engine (Multi-Page) Tue Sep 19 12:17:09 UTC

43 Engine (Multi-Page) Elemento Parte n. Nome Q.ta Udm FUEL LINE, 1/4" 33 cm IN FUEL SHUT-OFF VALVE 1 EA VAPOR LINE, 3/16 FORMED 1 EA CS M5-0.8 X 50 MM 1 EA Comments for Page: Engine (Multi-Page) jmumford@excelii.com on Apr 22, 2016 FUEL LINE LENGTHSA: 16.5 cm fuel line from the tank to the valveb: 16.5 cm fuel line from the valve to the engine1. Supplied with the engine.2. Torque to N m. Replace (do not reuse) the cap screw if it is removed or loosened. Use only hand tools to install this fastener.3. Torque to N m. Replace (do not reuse) the cap screw if it is removed or loosened. Use only hand tools to install this fastener.4. Torque to 23 N m.5. Part of the wire harness.6. Part of the fuel system. Engine (Multi-Page) Tue Sep 19 12:17:09 UTC

44 Engine & Fuel System Engine Service Parts Engine Service Parts Tue Sep 19 12:17:09 UTC

45 Engine Service Parts Elemento Parte n. Nome Q.ta Udm FUEL FILTER IN-LINE 1 EA AIR FILTER, KAW 1 EA OIL FILTER, KAW ENG. 1 EA FUEL STABILIZER, CARTON 1 EA Commenti per num parte brian on Sep 14, 2017 CONTAINS 6-8 FL. OZ. BOTTLES PER CASE OIL 10W-30, CARTON 1 EA Commenti per num parte brian on Sep 14, 2017 CONTAINS 12-1 U.S. QUART BOTTLES PER CASE Engine Service Parts Tue Sep 19 12:17:10 UTC

46 Engine & Fuel System Fuel System Fuel System Tue Sep 19 12:17:10 UTC

47 Fuel System Elemento Parte n. Nome Q.ta Udm CS X0.750FLK 6 EA FUEL TANK STRAP 2 EA SEAL 3/8x3/4 SOLD BY FT 72 cm FT CAP, 3.5" RATCHETING GAS 1 EA FUEL TANK, 1 EA FLEXIBLE TRIM UNI-GRIP 10 cm FT FUEL NECK DOUBLER 1 EA NT FLKG5 2 EA VAPOR LINE, 3/16 FORMED 1 EA GM.750X.188X1.00X.12 1 EA TEE, 3/16" PLASTIC 1 EA BOOT, 3/16 TO 3/16 1 EA FILTER, VAPOR SYSTEM 1 EA Comments for Page: Fuel System jmumford@excelii.com on Apr 22, 2016 WEATHERSTRIP & TRIM LENGTHS: A: 18 cm B: 10 cm Fuel System Tue Sep 19 12:17:10 UTC

48 Electrical, Fenders, Instrument Panel Battery Battery Tue Sep 19 12:17:11 UTC

49 Battery Elemento Parte n. Nome Q.ta Udm STRAP, TIE DOWN 1 EA CS x 7.50 HX G5 2 EA FW 0.281SAE 2 EA BATTERY CBL BOOT-RED(FS) 1 EA NT HXG5 2 EA LW0.250INTEXT 4 EA CS X0.750HXG5 2 EA CN X.150 MAX THK 2 EA WIRE TIE, SMALL/SHORT 2 EA Comments for Page: Battery jmumford@excelii.com on Aug 17, When performing service on the mower, disconnect the negative battery cable and do not reconnect it to the battery until ready to start the engine. Battery Tue Sep 19 12:17:11 UTC

50 Electrical, Fenders, Instrument Panel Fenders & Instrument Panel (Multi-Page) Fenders & Instrument Panel (Multi-Page) Tue Sep 19 12:17:11 UTC

51 Fenders & Instrument Panel (Multi-Page) Elemento Parte n. Nome Q.ta Udm SWITCH, PTO EA GAUGE, FUEL/HOURMETER 1 EA IGNITION SWITCH 1 EA KEY ASSEMBLY 1 EA SWITCH, ROCKER SPDT 1 EA FW 0.281SAE 12 EA NT HXZY NL 4 EA CONTROLLER 1 EA CB X.500 ZYNC 6 EA DECAL INST PANEL FU 1 EA SVC, INSTRUMENT PANEL 1 EA CS X0.750HXG5 4 EA CS X0.750FLK 2 EA WIRE TIE, SMALL/SHORT 2 EA CB X.75 FUL ZN 4 EA FENDER BRACKET, RH 1 EA NT HXG5 4 EA FUSE BRKT 1 EA FW 0.219X0.500X EA NT #10-24 HX NL ZN 6 EA CABLE, THROTTLE 1 EA NT FLKG5 2 EA CABLE, CHOKE 1 EA CS X.75 HX FLG 5 EA CS BH TX BZ 4 EA FW X X EA RH FENDER 1 EA RIVET NUT, 1/4-20 THREA 4 EA LH FENDER 1 EA Fenders & Instrument Panel (Multi-Page) Tue Sep 19 12:17:11 UTC

52 Fenders & Instrument Panel (Multi-Page) Fenders & Instrument Panel (Multi-Page) Tue Sep 19 12:17:11 UTC

53 Fenders & Instrument Panel (Multi-Page) Elemento Parte n. Nome Q.ta Udm RESERVOIR MOUNT 1 EA CN X.150 MAX THK 1 EA FENDER BRACKET, LH 1 EA DECAL, SAFE OPERATE-GRAY 1 EA DECAL, KICK PAN RFU 1 EA WIRE HARNESS ADAPTER 1 EA KIT, CLUTCH CONN. REP. 1 EA HOLDER, FUSE 1 EA RELAY, SEALED W/BRACKET 2 EA WIRE HARNESS 1 EA BREAKER, 15AMP 1 EA Comments for Page: Fenders & Instrument Panel (Multi-Page) jmumford@excelii.com on Nov 6, Part of the wire harness. 2. The instrument panel (552925) includes the decal (605645). 3. The sealed relay (601053) includes a bracket. Fenders & Instrument Panel (Multi-Page) Tue Sep 19 12:17:12 UTC

54 Deck 48" Side Discharge Service Deck 48" Side Discharge Service Deck Tue Sep 19 12:17:12 UTC

55 48" Side Discharge Service Deck Elemento Parte n. Nome Q.ta Udm SVC, DECK DECAL 48" SD 1 EA DECAL, DANGER / CHUTE 1 EA DECAL, BELT ROUTING 1 EA DECAL, DANGER / OBJECTS 1 EA DECAL,48"DECK ID 1 EA Comments for Page: 48" Side Discharge Service Deck jmumford@excelii.com on Nov 10, The deck includes decals. 48" Side Discharge Service Deck Tue Sep 19 12:17:12 UTC

56 Deck 48" Side Discharge Deck Pulleys & Spindles 48" Side Discharge Deck Pulleys & Spindles Tue Sep 19 12:17:13 UTC

57 48" Side Discharge Deck Pulleys & Spindles Elemento Parte n. Nome Q.ta Udm CS X1.250HSG5 3 EA FW.515X1.65X.125 HD ZY 3 EA SPACER, SPINDLE PULLEY 6 EA PULLEY, DECK DRIVE B-SEC 3 EA NT HXG5 12 EA FW x x EA NT NLG5 3 EA FW.531 x x EA BELT GUIDE KIT 1 EA BELT GUIDE, DUAL 1 EA SPACER, BELT GUIDE 2 EA PULLEY, IDLER 5.00" O.D. 1 EA IDLER PULLEY, 4.00" FLAT 2 EA CS X1.250HXG5 2 EA FW 0.625X1.000X EA IDLER, V 4.9" OD 1 EA NT FLKG5 1 EA PIVOT BUSHING 1 EA BEARING DISC, UHMW 2 EA SHIELD, PIVOT IDLER 48" 1 EA FW 0.343SAE 1 EA CS X0.625HXG5 1 EA IDLER ARM DUAL PIVOT W/A 1 EA PULLEY, IDLER FLAT 4.00" 1 EA BELT, B " EL 1 EA SPRING, DECK IDLER 1 EA SPINDLE ASSEMBLY 3 EA CS X EA FW.531 x 2.25 x.25 ZNY 3 EA 48" Side Discharge Deck Pulleys & Spindles Tue Sep 19 12:17:13 UTC

58 48" Side Discharge Deck Pulleys & Spindles Elemento Parte n. Nome Q.ta Udm CS X3.500HXG5 2 EA CS X2.750HXG5 1 EA CB X.750 FUL ZN 1 EA Comments for Page: 48" Side Discharge Deck Pulleys & Spindles jmumford@excelii.com on Apr 22, Torque to 41 N m. 2. Torque to 99 N m. 3. Make sure the idler arm pivots freely. 48" Side Discharge Deck Pulleys & Spindles Tue Sep 19 12:17:13 UTC

59 Deck 48" Side Discharge Deck 48" Side Discharge Deck Tue Sep 19 12:17:13 UTC

60 48" Side Discharge Deck Elemento Parte n. Nome Q.ta Udm PULLEY COVER, 48" DECKS 2 EA CS X.75 HX FLG 2 EA DISCHARGE CHUTE 1 EA PIN, DISCHARGE CHUTE 1 EA CHUTE SPRING 1 EA NT NLG8 1 EA CS X1.375 HXFLG5 2 EA PULLER W/A, FLIP-UP 1 EA PIVOT SPACER BUSHING 2 EA NT FL NY GF 2 EA NT NLG5 4 EA FW.531 x x EA WHEEL ASSY, ANTI SCALP 2 EA BLADE, 16.50"-L-F-CW 3 EA Not Shown Not Shown Not Shown Not Shown Not Shown BLADE, F16.50"-L-F-CW 3 EA BLADE, F16.50"-H-F-CW 3 EA BLADE, 16.50"-MUL-F-CW 3 EA BLADE, 16.50"-GAT-F-CW 3 EA BLADE, 16.50"-CAT-F-CW 3 EA CW.678 X X EA CS X1.250HXG5 3 EA CB X 4.50 STD ZN 2 EA SPACER, ANTI-SCALP EA WHEEL, ANTI-SCALP 2 EA CS X4.250HXG5 1 EA ANTI-SCALP WHEEL 1 EA NT JAMG5 1 EA 48" Side Discharge Deck Tue Sep 19 12:17:14 UTC

61 48" Side Discharge Deck Comments for Page: 48" Side Discharge Deck on Apr 22, Torque to 160 N m. 2. Torque to 5 13 N m on these self-tapping screws. 3. Do not torque; the discharge chute must pivot freely. 4. Do not torque; the puller must pivot freely. 48" Side Discharge Deck Tue Sep 19 12:17:14 UTC

62 Deck 48" Rear Discharge Service Deck 48" Rear Discharge Service Deck Tue Sep 19 12:17:14 UTC

63 48" Rear Discharge Service Deck Elemento Parte n. Nome Q.ta Udm SVC, DECK DECAL 48" RD 1 EA DECAL,48"DECK ID 1 EA DECAL, DANGER / OBJECTS 2 EA DECAL, BELT ROUTING 1 EA Comments for Page: 48" Rear Discharge Service Deck jmumford@excelii.com on Nov 10, The deck includes the decals. 48" Rear Discharge Service Deck Tue Sep 19 12:17:14 UTC

64 Deck 48" Rear Discharge Deck Pulleys & Spindles 48" Rear Discharge Deck Pulleys & Spindles Tue Sep 19 12:17:14 UTC

65 48" Rear Discharge Deck Pulleys & Spindles Elemento Parte n. Nome Q.ta Udm CS X1.250HXG5 2 EA FW 0.625X1.000X EA IDLER, V 4.9" OD 1 EA PULLEY, IDLER FLAT 4.00" 1 EA BELT, B " EL 1 EA NT FLKG5 1 EA PIVOT BUSHING 1 EA BEARING DISC, UHMW 2 EA NT NLG5 3 EA FW.531 x x EA FLIP UP GUARD 1 EA BELT GUIDE, DUAL 1 EA CS X1.250HSG5 3 EA FW.515X1.65X.125 HD ZY 3 EA SPACER, SPINDLE PULLEY 6 EA PULLEY, DECK DRIVE B-SEC 3 EA PULLEY, IDLER 5.00" O.D. 1 EA SPACER, BELT GUIDE 2 EA IDLER ARM DUAL PIVOT W/A 1 EA IDLER PULLEY, 4.00" FLAT 2 EA NT HXG5 12 EA FW x x EA SPRING, DECK IDLER 1 EA FW.531 x 2.25 x.25 ZNY 3 EA CS X2.750HXG5 1 EA CB X.750 FUL ZN 1 EA CS X3.500HXG5 2 EA SPINDLE ASSEMBLY 3 EA CS X EA 48" Rear Discharge Deck Pulleys & Spindles Tue Sep 19 12:17:14 UTC

66 48" Rear Discharge Deck Pulleys & Spindles Comments for Page: 48" Rear Discharge Deck Pulleys & Spindles on Nov 10, Torque to 41 N m. 2. Torque to 99 N m. 3. The idler arm must pivot freely. 48" Rear Discharge Deck Pulleys & Spindles Tue Sep 19 12:17:14 UTC

67 Deck 48" Rear Discharge Deck 48" Rear Discharge Deck Tue Sep 19 12:17:15 UTC

68 48" Rear Discharge Deck Elemento Parte n. Nome Q.ta Udm PULLEY COVER, 48" DECKS 2 EA CS X.75 HX FLG 2 EA SHIELD, PIVOT IDLER 48" 1 EA FW 0.343SAE 1 EA CS X0.625HXG5 1 EA CS X1.375 HXFLG5 2 EA NT NLG5 3 EA FW.531 x x EA CB X 7.50 STD ZN 1 EA PIVOT SPACER BUSHING 2 EA NT FL NY GF 2 EA PULLER W/A, FLIP-UP 1 EA WHEEL, ANTI-SCALP 1 EA SPACER, ANTI- SCALP EA SPACER, ANTI-SCALP EA WHEEL, ANTI-SCALP 2 EA CB X 4.50 STD ZN 2 EA BLADE, 16.50"-L-F-CW 3 EA Not Shown Not Shown Not Shown BLADE, F16.50"-L-F-CW 3 EA BLADE, 16.50"-MUL-F-CW 3 EA BLADE, 16.50"-GAT-F-CW 3 EA CW.678 X X EA CS X1.250HXG5 3 EA Comments for Page: 48" Rear Discharge Deck jmumford@excelii.com on Nov 10, Torque to 160 N m. 2. Torque to 3 7 N m on these 2 self-tapping screws. 48" Rear Discharge Deck Tue Sep 19 12:17:15 UTC

69 3. Do not torque; the puller must pivot freely. 48" Rear Discharge Deck 48" Rear Discharge Deck Tue Sep 19 12:17:15 UTC

70 Deck Rear Discharge Deck Shield Rear Discharge Deck Shield Tue Sep 19 12:17:16 UTC

71 Rear Discharge Deck Shield Elemento Parte n. Nome Q.ta Udm CS X3.000HXG5 4 EA FW 0.343SAE 8 EA CN x.200 MAX THK 8 EA NT HXG5 4 EA FLIP UP BRACKET RS 1 EA FLIP UP BRACKET LS 1 EA CS X1.000HXG5 8 EA FW 0.344X1.000X0.120HD 8 EA MOUNT PLATE W/A RS 1 EA MOUNT PLATE W/A LS 1 EA FLIP UP SHIELD 1 EA Rear Discharge Deck Shield Tue Sep 19 12:17:16 UTC

72 Deck Deck Carrier (Multi-Page) Deck Carrier (Multi-Page) Tue Sep 19 12:17:16 UTC

73 Deck Carrier (Multi-Page) Elemento Parte n. Nome Q.ta Udm SVC, FLOOR PAN RFU 1 EA DECAL QUICKFLIP 1 EA DECAL, PUMP BELT WARNING 1 EA CB X.750 STD ZN 4 EA SVC, FOOTREST RFU 1 EA CS X0.875HXG5 4 EA FW 0.343SAE 4 EA RIVET NUT, 5/16-18 THRE 4 EA DECAL, HUSTLER ID 1 EA SPACER, DECK LIFT LINK 4 EA DECK LIFT LINK 1 EA FW x x EA CS X1.000HXG5 4 EA NT HXG5 8 EA NT FLKG5 16 EA DECK LIFT LINK, 4 EA CS X1.750HXG5 8 EA NT FL NY GF 2 EA PIVOT SPACER BUSHING 2 EA CS X1.375 HXFLG5 2 EA W/A, CUT HT. INDICATOR 1 EA SVC, CUT HT, BRKT OUTER 1 EA PIN, DECK HEIGHT STOP 1 EA DECAL, DECK HEIGHT 1 EA NT FLKG5 2 EA CUT HT. BRKT INNER 1 EA CB X 1.00 G5 ZNY 2 EA BALL SWITCH, N.O. 1 EA WIRE TIE, SMALL/SHORT 4 EA Deck Carrier (Multi-Page) Tue Sep 19 12:17:16 UTC

74 Deck Carrier (Multi-Page) Deck Carrier (Multi-Page) Tue Sep 19 12:17:16 UTC

75 Deck Carrier (Multi-Page) Comments for Page: Deck Carrier (Multi-Page) on Aug 17, The floor pan, footrest and outer cutting height bracket include decals. Deck Carrier (Multi-Page) Tue Sep 19 12:17:17 UTC

76 Seat Seat, Standard Seat, Standard Tue Sep 19 12:17:17 UTC

77 Seat, Standard Elemento Parte n. Nome Q.ta Udm SEAT, MICHIGAN STANDARD 1 EA MOUNT, PUSH BUTTON 1 EA SVC, SEAT PAN RFU 1 EA DECAL, LEVEL FUEL BLOWM 1 EA NT NLG8 2 EA WIRE TIE, SMALL/SHORT 1 EA FW 0.343SAE 8 EA CS X1.000HXG5 6 EA NT NLG5 2 EA SEAT BUMPER 2 EA CS X1.000HXG5 2 EA DECAL, BATTERY WARNINGS 1 EA WEATHERSTRIP.12X cm FT Comments for Page: Seat, Standard jmumford@excelii.com on Apr 22, 2016 WEATHERSTRIP LENGTH: A: 10 cm 1. Torque to 9.5 N m. 2. Do not torque; the seat pan must pivot freely. Seat, Standard Tue Sep 19 12:17:17 UTC

78 Seat Seat Service Parts - Standard Seat Seat Service Parts - Standard Seat Tue Sep 19 12:17:18 UTC

79 Seat Service Parts - Standard Seat Elemento Parte n. Nome Q.ta Udm Not Shown SEAT, MICHIGAN STANDARD 1 EA SWITCH, SEAT 1 EA EXT. ARMREST KIT R.H. 1 EA EXT. ARMREST KIT L.H. 1 EA ARMREST,STOP ASSY 2 EA Seat Service Parts - Standard Seat Tue Sep 19 12:17:18 UTC

80 Seat Seat, Seats Inc. Seat, Seats Inc. Tue Sep 19 12:17:18 UTC

81 Seat, Seats Inc. Elemento Parte n. Nome Q.ta Udm SEAT, SEATS INC EA FW.406X.750X.250 ZNYC 4 EA MOUNT, PUSH BUTTON 1 EA SVC, SEAT PAN RFU 1 EA DECAL, LEVEL FUEL BLOWM 1 EA NT NLG8 2 EA WIRE TIE, SMALL/SHORT 1 EA FW 0.343SAE 8 EA CS X1.000HXG5 6 EA NT NLG5 2 EA SEAT BUMPER 2 EA CS X1.000HXG5 2 EA DECAL, BATTERY WARNINGS 1 EA WEATHERSTRIP.12X cm FT Comments for Page: Seat, Seats Inc. jmumford@excelii.com on Nov 10, 2016 WEATHERSTRIP LENGTH A: 10 cm 1. Torque to 23 N m. 2. Do not torque; the seat pan must pivot freely. 3. The seat pan includes decals. Seat, Seats Inc. Tue Sep 19 12:17:18 UTC

82 Seat Seat Service Parts, Seats Inc. Seat Service Parts, Seats Inc. Tue Sep 19 12:17:18 UTC

83 Seat Service Parts, Seats Inc. Elemento Parte n. Nome Q.ta Udm Not Shown SEAT, SEATS INC EA SVC, ARM PADS 2 EA SVC, ARMEST SET 1 EA SVC, OPS 1 EA SVC, BACK CUSHION 1 EA SVC, SEAT CUSHION 1 EA Comments for Page: Seat Service Parts, Seats Inc. jmumford@excelii.com on Oct 20, The arm bracket kit includes right and left side brackets. Seat Service Parts, Seats Inc. Tue Sep 19 12:17:19 UTC

84 Appendice AIndice pagine 48" Rear Discharge Deck " Rear Discharge Deck Pulleys & Spindles " Rear Discharge Service Deck " Side Discharge Deck " Side Discharge Deck Pulleys & Spindles " Side Discharge Service Deck 8-1 Battery 7-1 Deck Carrier (Multi-Page) 8-8 Drive Wheel Breakdown 5-3 Engine (Multi-Page) 6-1 Engine Service Parts 6-2 Fenders & Instrument Panel (Multi-Page) 7-2 Frame 3-1 Front Tire Breakdown 5-2 Fuel System 6-3 General Information 1 Rear Discharge Deck Shield 8-7 Seat Service Parts - Standard Seat 9-2 Seat Service Parts, Seats Inc. 9-4 Seat, Seats Inc. 9-3 Seat, Standard 9-1 Steering & Deck Lift Controls Sub-Assembly 4-6 Steering & Deck Lift Controls S/N & Higher (Multi-Page) 4-4 Steering & Deck Lift Controls S/N Prior to (Multi-Page) 4-5 Transmission Assembly 4-1 Transmission Service Parts Transmission Service Parts Wheel & Tire 5-1 Tue Sep 19 12:17:19 UTC 2017 A-1

85 Appendice BIndice parti , 4-1, 6-1, 7-1, 7-2, 8-8, 9-1, , , , 4-4, , , , , 4-1, 4-4, 4-5, 6-3, 7-2, , , 7-1, , 6-1, , 8-2, , 4-1, 4-4, 4-5, 6-3, , , , , 4-1, 4-4, 4-5, , , 4-5, 8-7, 9-1, , 4-5, 8-8, 9-1, , , 4-4, , 4-5, 6-1, 8-2, 8-5, , 4-5, 4-6, 6-1, 7-1, , 4-5, 4-6, 9-1, , , 4-5, , , 4-4, 4-5, , , 4-4, 4-5, 4-6, 8-3, 9-1, , , , , , 4-5 Tue Sep 19 12:17:19 UTC 2017 B-1

86 , , , , , , , , , , , , , , , , , , , 4-5, Tue Sep 19 12:17:19 UTC 2017 B-2

87 , , , , , , 4-5, , , , , , , , , , , , , , , , 9-1, , 4-3, 7-2, 8-3, , 8-6, , , 8-5 Tue Sep 19 12:17:19 UTC 2017 B-3

88 , , , , , , , , , , , , , , , , , 8-6, , K , 4-5, , 4-5, , , , 8-6, , , , , Tue Sep 19 12:17:19 UTC 2017 B-4

89 , , , 5-1, 8-2, , , , , , 4-5, , 4-1, 4-4, 4-5, 6-1, 8-2, 8-5, , 4-5, 5-2, 8-2, 8-3, 8-5, , 4-4, 4-5, 4-6, 6-1, 7-1, , 4-1, 4-4, 4-5, 4-6, 6-1, 8-2, 8-6, 8-7, 8-8, 9-1, , , , , , 8-2, 8-3, 8-5, , , 8-2, 8-3, 8-5, , , CE 4-4, , , , , 8-6 Tue Sep 19 12:17:19 UTC 2017 B-5

90 , Tue Sep 19 12:17:19 UTC 2017 B-6