Reel Catalog NORDIC SERIES 7000 / SERIES NOW INCLUDING. Wind Things Up With Reelcraft. Series 3900 See page 34.

Transcription

1 Reel Catalog NORDIC NOW INCLUDING Series Series 3900 See page 34 Series 7000 Wd Thgs Up With Reelcra SERIES 7000 / SERIES 8000 Reelcra Industries is ISO 9001:00 Certified Sce

2 Wd Thgs Up With Reelcra PRODUCT SOLUTIONS Engeered for Excellence Why use hose reels? 7000 Series Why use hose reels? Because they ake hose handlg ore efficient and safer. Your hoses, cables and cords will last up to five ties longer. You will iprove hose anageent, which decreases labor costs. Your chances of juries fro trippg hazards will decrease, which Series saves lost work tie, edical bills and higher surance. You also save the cost of replacg expensive hoses, cables and cords that get run over by fork lis and other vehicles, which saves equipent costs. Here are the ost copellg reasons to use hose, cord and cable reels. Efficiency An organized, clean workplace is proven to be ore efficient Safety Reduce accidents and surance expense: Slips, trips, and falls are the leadg causes of work stoppage losses dustry Fry s Napa AutoCare Center, Colubia City, Indiana 7000 Series Wabash National Corporation, Lafayette, Indiana The Botto Le: Increase Productivity Locatg hoses and cords where and when you need the creases productivity. All of these factors contribute to an iproved work environent, which saves tie, equipent and oney Orchard Ridge Country Club Fort Wayne, Indiana Orchard Ridge Country Club Fort Wayne, Indiana Protect Equipent Hoses and cords last five ties longer when stored on a reel. Stop Leakages Hoses on reels can reduce the threat of expensive air and water leakages. OSHA says reduce your slips, trips and falls Slips, trips and falls constitute the ajority of general dustry accidents, which cause % of all accidental deaths, and are second only to otor vehicles as a cause of fatalities. The OSHA standards for walkg and workg surfaces apply to all peranent places of eployent, except where only doestic, g, or agricultural work is perfored ( ii North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Reelcra Industries is ISO 9001:00 Certified Sce 1996 Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

3 PRODUCT SOLUTIONS Engeered for Excellence Reelcra: Better by Design Reelcra s reels are better by design because of our lastg coitent to excellence. Our engeerg tea is well known for designg durable, high quality products. Our standard features clude durable, corrosion-resistant Reforced Steel The steel-staped guide ar is reforced to reduce bendg due to angular pull. Iproved Connection The elongated brass connector and proprietary adhesion process provide a better crip to the hose. Stress-free Swivel Our full-flow design cobes the highest grade seal design with supportg bearg surfaces to sure the longest possible life. Corrosion-Resistant Steel coponents are dividually powder coated to virtually eliate corrosion. Long Service Life Field-proven swivel assures long service life. Fish with Quality Our coponents undergo a special five-stage cleang process and are dividually powder-coated for the highest quality pat adhesion. Excess powder is reclaied to be environentally friendly. powder coat pat, ulti-position guide ars for versatile ountg options and heavyduty, reforced steel stapgs for creased strength. Our reels are peranently factorylubricated for a long, trouble-free service life. Kkless Hose High quality PVC hose is specially blended for use on reels Sealed Connection Pots Swivel and hose let connections seal agast leaks Adjustable Guide Ar Multiple guide ar positions provide versatile uses and easier field adjustent Trouble-Free Perforance Fewer coponents crease the service life of the reel and iprove perforance All of these features, and any ore, add up to ake The Reelcra Difference. Rely on Reelcra s coitent to excellence for the highest quality hose, cord and cable reels. Long Life Drive Sprg Declutchg arbor virtually eliates possibility of sprg daage due to reverse wdg of reel spool. Shown: 7850 OLP Enclosed Drive Sprg Drive echanis is enclosed for protection agast the environent. Robust Latch Wide profile cobed with special sprg assures axiu service life. Structural Strength Welded heavy gauge steel frae cludes draatically flanged edges and stiffeng ribs for lighter weight, yet stronger coponents for ease of handlg and stallation. Easy to Mount Attaches to ost structurally sound surfaces. Edges are curved for safety. North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra iii

4 Wd Thgs Up With Reelcra R eelcra Industries, Inc. supports our coplete le of products with ore than years experience the design and anufacture of hose, cord and cable TABLE OF CONTENTS Sprg Driven Hose Reels reels. Storg hoses, cables and cords on a reel creases safety, efficiency, productivity and provides ergonoic advantages to the work environent. Reelcra is the dustry leader for hose, cord and cable reels available anywhere the world. Our key focus is to develop quality products that ake hoses, cords and cables ore productive, keep the easily accessible and ake the last longer. Reelcra is a highly novative copany our product developent and our anufacturg techniques. We are the only U.S. hose reel anufacturer to hold ISO 9001:00 accreditation and we lead the dustry developg new cuttg edge products. Our lean anufacturg and Six Siga progras give us the core copetencies to contue to deliver the world s best reel products. Walt Sternean President of Reelcra Industries Sprg Driven Hose Reels Lighter, Econoical 7 ReelTek, Series RT 1/4, 3/8, 1/2 I.D. A new, econoical lighter hose reel designed for low, ediu and high pressure applications. Copact Reels 8 Series 4000/5000/5005 1/4, 3/8, 1/2 I.D. For all general air, water, oil or grease applications. Heavy Duty Reels 9 Series /4, 3/8, 1/2, 3/4 I.D. Our best-sellg reel for low, ediu and high pressure applications. Dual Pedestal Reels 10 Series DP7000 1/4, 3/8, 1/2 I.D. Copact terlockg base and balanced swivel. NEW! DP7850 OLP Patent Pendg RT650-OLP Patent No. 7,0,4 A5850 OLP Two Year Liited Warranty 7850 OLP D8850 OLP 800 OLP Reelcra now offers a two year liited warranty. All products anufactured by Reelcra Industries, Inc. are warranted to be free of defects due to faulty aterial or workanship for onths fro date of shipent, except hose. Noral wear and tear is not considered a defect aterial or workanship. Reelcra s liability shall be liited to repair or replaceent of defective aterial durg the warranty period and will be at Reelcra s discretion when returned pre-paid to its plant or authorized service depot. The warranty does not cover daage caused by accident, abuse, neglect or iproper stallation. Reelcra products ust be stalled, ataed and operated accordance to the recoendation of Reelcra and the anual of structions. Failure to use circuit breakers on electric otors, filter, lubricators on air otors and flexible let connections will void warranty. Equipent, products, coponents and hoses not anufactured by Reelcra are subject to the origal anufacturer s guarantee and warranties. Hoses carry a 6 onth warranty as listed by the anufacturer. Reelcra will assist filg clais, but does not have any additional responsibility if origal anufacturer denies warranty clai. Products built to custoer specifications and requireents, Nordic series and series 40 or products corporatg variation fro cataloged ites are considered special and are not subject to cancellation or returnable for credit under any circustances. Reelcra reserves the right to odify or alter product, diensions, design and construction to iprove perforance. NOTE: For coplete warranty foration, onle warranty registration, service anuals, and return foration please visit Mobile Base Reels 11 Series 8000 & D8000 1/4, 3/8, 1/2 I.D. The aluu cast base and ar offer the highest rigidity aong this class of hose reels. Dual Pedestal Reels 12 Series & D /8, 1/2, 3/4, 1 I.D. Our largest pedestal-style hose reel with heavy-duty, ball-bearg style swivel for low, ediu and high pressure applications. Large Frae Auto-Rewd Series 00/4800 1/4, 3/8, 1/2, 3/4, 1, 1½ I.D. Heavy fabricated frae with robust drive sprg. Designed for auto retraction of long lengths of hose up to 100. Large Mobile Reels Series E9000 1/2, 3/4, 1, 1¼, 1½ I.D. Great for high volue air, water, fuel and petroleu applications. Visit our web site for coplete warranty foration Series 4800 E 9350 OLPBW 2 North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Reelcra Industries is ISO 9001:00 Certified Sce 1996 Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

5 TABLE OF CONTENTS Sprg Driven Hose Reels W e anufacture a coplete le of products for ost applications, cludg dustrial, agricultural, golf and autootive arkets. For coplete product foration or help solvg FD875 OLP Groundg Reels G 50 Y G OMS TH86050 OMP Tw Hydraulic Series TH 1/4, 3/8, 1/2 I.D. Mediu pressure for operatg hydraulic cylders, otors or tools. Fuel Reels 3/4, 1, 1 1/4, 1 1/2 I.D. For low pressure applications. Equipped with fuel-grade hose. Groundg Reels Series G 00 Used to dissipate static electricity when transferrg flaable aterials on fuel trucks, cheical plants and ore. Coplete Le of Staless Steel Staless Steel Reels Series OMS 3/8, 1/2, 3/4, 1 I.D. Full le of staless steel reels for low and ediu pressure applications. a hose or cord handlg proble, please contact our friendly custoer service representatives at or visit SGA3650 OLP CU6050 LN H000 EA312 L12D NEW! 5835 OLPSW Located Northeast Indiana sce 1971, Reelcra s global headquarters office and anufacturg space is a state-of-the-art 1,000 square foot facility. Because we are centrally located the US, we can quickly ship our standard products the sae day for doestic orders received by 11: a local tie. Pre-rse & Potable Water Hose Reels 3/8, 1/2 I.D. Several odels for pre-rse applications and potable (drkg) water. Econoical Coposite Reels S Series 3/8, 1/2 I.D. Lightweight, easy-to-handle for low pressure air or water. Ideal for wash-down applications. Pressure Wash 1/4, 3/8, 1/2 I.D. Many odels for high pressure applications. Sprg driven, hand crank and otor driven rewd. General Use Series CU & H 3/8, 1/2, 3/4 I.D. Ideal for ediu duty general use hand crank applications. Heavy Duty Series 000 1/2, 3/4, 1 I.D. For low and ediu pressure applications requirg long hose. Hand crank, air otor, bevel crank and electric otor rewd. Reelcra s global offices serve: Europe/UK Canada Asia/Philippes Central Aerica South Aerica Middle East TABLE OF CONTENTS North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra 3

6 Wd Thgs Up With Reelcra O ur ission: It is the goal of Reelcra Industries, Inc. to anufacture the best dustrial hose, cord and cable reels and reel-related products the world. TABLE OF CONTENTS Large Frae Reels Reelcra will contually strive to provide the quality of product, tieless of delivery and econoy of price that will satisfy our custoers needs. Reelcra s product quality starts with odern engeerg techniques for axiu strength through better design, better aterials and tested and proven products. We are coitted to superior anufacturg processes by producg our steel coponents fro hard toolg (dies) that crease product strength and reliability copared with siply bendg etal press breaks. In addition, we offer ore levels of dustrial products: Good, Better, Best and Ultiate. Our custoers report that superior value is why they choose Reelcra reels. All of these qualities and ore add up to ake The Reelcra Difference. ISO 9001:00 Certified Large Frae Hose Reels All Welded A Frae 28 Series /2, 3/4, 1 I.D. Welded A frae design for creased rigidity and axiu durability. Hand crank or otor driven. Steel Large Frae 32 Series 00/3900/3700/5900 1/2, 3/4, 1, 1 1/2, 2, 3, 4 I.D. Rugged and durable, gear-drive, crank rewd or cha and sprocket drive are powered by electric otor. Modular, T-Slot 33 Series 40 1, 1 1/4, 1 1/2 I.D. New durable, reliable, odular large frae reel is fully custoizable to fit your specs. Gear drive, cha drive, hand crank and bevel crank. Series 1010 Series 3900 Fire Fightg Reels 37 Series /2, 3/4, 1 I.D. Lightweight, aluu frae with ountg brackets, designed specifically for fire fightg applications. Propane Reels 38 Series 40/00// 80000/D /4, 1, 1 1/2 I.D. Propane reels designed with U/L certified swivel for LPG dispensg. Motor driven and sprg driven reels. Petroleu Service 40 Series /2, 2 I.D. Inverted reel fits under the canopy of petroleu service trucks. Fluid path is designed for dispensg petroleu. Series 3800 Sgle Wrap Reels 41 Series /2, 2, 3 I.D. Sgle wrap reel offers the narrowest profile available to store and retrieve fuelg hoses. Guide Ar Positions & Suffix Codes Guide Ar Suffix Codes: The suffix codes (as dicated at right) ust be added aer the odel nuber to specify desired guide ar position. For exaple, 5 OLP SW designates side wd guide ar position. Additional Notes: D 9000 O series reels are shipped the BW position and all other series reels are shipped the TW position unless otherwise specified. Series 4000 and 5000 reels ordered the BW position are available constant tension only. The Series is shipped the SW position. TW Series 40: Gear drive SW BW Series 6000 TW SW Series 5000 Series 40 Suffix Codes Top Wd Ceilg and under floor Side Wd Wall or colun; floor or pit BW Botto Wd 4 North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Reelcra Industries is ISO 9001:00 Certified Sce 1996 Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

7 TABLE OF CONTENTS Power & Light / Weldg Reels NEW! LD 3 9 NEW! LG Power Cord & Light Reels Light & Mediu Duty 42 Series LD & LG Light and power cord reels for less deandg applications. Quality aterials offerg light weight solutions. NEW! STW3450 OLP Coplete Faily of Weldg Reels Dual Hose Reels 48 Series TW and BA 1/4, 3/8 I.D. For low pressure oxygen/ acetylene applications. Includes T grade reels for a variety of gases. NEW! Hand Crank Reels 42 Series LH Portable power ade easier with the storage of up to 100 of 10/3 power cord. WC7000 Sprg Driven Weldg Cable 50 Series WC7000/WC80000 Stores work lead or electrode lead cable when not use. L H80 3 L Heavy Duty Reels 43 Series L4000, L5000, 000, Nordic CR A variety of light and power source options. NEW! LE2 1 12D To place an order, please advise: 1. Model nuber. 2. Product to be handled such as air, oil, water, etc. 3. Maxiu operatg pressure P.S.I. 4. Maxiu operatg teperature degrees Fahrenheit. 5. Hose side and outside diaeters and length. 6. Installation height, especially if ore than feet. 7. Desired guide ar position by addg one of the suffixes to the odel nuber. Exaple: 5 OLP SW for side wd. Refer to the guide ar chart for guide ar suffix codes. CEA006 T-62-0 Hand Crank Weldg Cable 50 Series CEA 000 Stores work lead or electrode lead cable when not use. Multi-Configurations 51 Safe-T-Reel Series Ideal where space, weight and flexibility are key for anual wdg of hose, cord, oxygen/ acetylene and weldg cable. Additional Considerations: A flexible connection between the reel and the source of supply is required to prevent possible isalignent and bdg. Non-flexible connections will void the warranty. The pressure ratg of let hose ust be equal or greater than the ratg of the reel. Accessories Reels ordered with hose and buper are assebled coplete and ready to stall. Order bupers separately for reels without hoses. Refer to the Table of Contents for a coplete list of accessories. Additional questions? Please visit our website or call for assistance. For ore than years, our specialty is offerg hose handlg solutions. TABLE OF CONTENTS North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra 5

8 Wd Thgs Up With Reelcra TABLE OF CONTENTS Specialty Products/Accessories Index DESCRIPTION PAGE Accessories Adapter Asseblies 53 Adjustable Hose Bupers 55 Cha Shrouds 54 Inlet Hoses 55 Hose Asseblies 56 Hose Roller Guide Asseblies 53 Motors 54 Operatg Switches 54 Pivot Base 53 Rewd Motors 54 Top Mountg Channels & Bea Claps 53 Tw Weldg Inlet Hose 55 T Grade Tw Weldg 56 Roller Brackets 53 Wall Mounted Swg Bracket 53 Reels Listed by Function Cart with Hose Reel Copact Reels 8 Dual Pedestal Reels 12 Fuel Reels Groundg Reels Heavy Duty Reels 10 Large Frae Reels 28 Mobile Base Reels PVC Reels Power & Light Cord Reels 43 Pre-Rse & Drkg Water Pressure Wash Reels ReelTek, Series RT 7 Safe-T-Reels 51 Staless Steel Reels Tool Balancers 52 Trailer & Reels Tw Hydraulic Reels Weldg Reels 48 Reels Listed by Series NORDIC 00/4800 NORDIC NORDIC 1010T/00T 29 NORDIC NORDIC NORDIC NORDIC NORDIC NORDIC Series Series 4000/5000/ Series Series Series 000 Series Series 80000/D Series BA 48 Series CU Series CEA/WC 50 Series DP Series D Series E9000 Series FD Series F7000/FE9000/FF9000 F80000/FD80000 Series G00 Series H Series H006 Series L4000/L Series LD, LG & LH 42 Series OMS Series PW80000 Series RT (ReelTek) 7 Series S Series TB 52 Series T 51 Series TH Series TW 48 Specialty Products Two-Wheel Portable Hose Reel and Cart Great for grounds atenance, turf care and uch ore. Reel & Trailer Hose Caddy Ideal for applications requirg long lengths of hose. Readily adapts to door/outdoor use. Tool Balancers 52 TB Series Makes tools nearly weightless. Reduces operator fatigue and daage fro droppg tools. EIGHT REEL DISPLAY STAND S Reelcra s new reel display stand conveniently displays up to eight reels and features reovable universal brackets for ease of ountg. The new stand is alost entirely ade of aluu akg it lighter and ore anageable. It is easily assebled/disassebled and bears the Reelcra logo. Reels sold separately. Weight: 64lbs. (29 kg). S Six Reel Display Stand. S600539* - Eight Reel Centerpiece Display Stand. Portable Hose Reel & Cart Heavy Duty Tool Balancer TBL 10- *Any four Series 4000 or 5000 can be stalled on the top. *Any four Series RT, 5005, or 7000 can be stalled on the botto. *Series RT and 5005 require either 6006 or 6000 additional ountg brackets. Eight Reel Centerpiece Display Stand - S Reel and Trailer shown with optional accessories Eight Reel Display Stand S Mountg Brackets 53 Adapter Assebly Cha Shrouds & Roller Brackets 53 & 54 Cha Shrouds Motors & Switches 54 Electric/ Copressed Air Motors Low pressure Air/Water Hose Three Way Roller Guide Hose Bupers & Inlet Hose Asseblies 55 Adjustable Bupers Wall-ounted swg bracket Hose Asseblies 56 Quick Ship Table 57 Full list of Quick Ship odels with descriptions. Operatg Switches 6 North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Reelcra Industries is ISO 9001:00 Certified Sce 1996 Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

9 LIGHTWEIGHT, ECONOMICAL Series RT Sprg Driven Air/Water/Oil/Grease Series RT - 1/4, 3/8, 1/2 I.D. Reelcra presents ReelTek, a new, lighter sprg-driven hose reel designed for applications that are less deandg, yet require a product that can withstand dustrial use. Structural Strength Heavy gauge steel stapgs with re-enforced ribs crease strength. Trouble-Free Matenance The dustrial-grade drive sprg is protected fro the environent. Hose Retracts Every Tie The latch echanis is ounted on the guide ar to eliate latch-out at full extension of hose. Long Lastg Latch Sprg A staless steel torsion sprg is used on the latch to sure axiu life. Long Swivel Life Our field-proven swivel assures long service life. Corrosion Resistance Steel coponents are dividually powder coated and teaed with coposite aterials, which virtually eliates corrosion. Versatile Mountg The guide ar can be adjusted to seven convenient locations. Lightweight Coposite spool and steel coponents ake the reel strong yet lighter. RT650-OLP Patent No. 7,0,4 DIMENSIONS Series RT / A See Chart E 1 / G 7 / X 2 1 / 4 57 Y 6 2 MODELS WITH HOSE HOSE CAPACITY MODELS WITHOUT HOSE MODEL WEIGHT PRESSURE I.D. O.D. (M)NPTF OUTLET (F)NPTF INLET LENGTH MODEL WEIGHT PRESSURE A lbs / kg psi / bar / / / lbs / kg psi / bar / LOW PRESSURE AIR/WATER REELS Maxiu Teperature 0 F (65 C) RT4-OLP / /4 3/8 8 RT402-OLP ¾ 6 RT435-OLP / /4 3/ RT403-OLP ¾ 6 RT450-OLP / /4 3/8 50 RT405-OLP ¾ 6 RT6-OLP / /4 3/8 8 RT602-OLP ¾ 6 RT-OLP / /4 3/ RT603-OLP ¾ 6 RT650-OLP / /4 1/2 50 RT605-OLP ¼ 9 RT8-OLP / /4 1/2 8 RT802-OLP ¼ 9 RT835-OLP 0 1 / /2 1/ RT803-OLP ¼ 9 RT850-OLP / /2 1/2 50 RT805-OLP ¼ 9 MEDIUM PRESSURE OIL REELS Maxiu Teperature 0 F (65 C) RT6-OMP / /8 3/8 8 RT602-OMP ¾ 6 RT-OMP / /8 3/ RT603-OMP ¾ 6 RT650-OMP / /8 1/2 50 RT605-OMP ¾ 197 RT8-OMP /2.8 1/2 3/8 8 RT802-OMP ¼ 9 RT835-OMP /2.8 1/2 1/ RT803-OMP ¼ 9 HIGH PRESSURE GREASE REELS Maxiu Teperature 0 F (65 C) RT4-OHP / /4 3/8 8 RT402-OHP ¾ 6 RT435-OHP / /4 3/ RT403-OHP ¾ 6 RT6-OHP / /8 3/8 8 RT602-OHP ¾ 6 RT-OHP / /8 1/ RT603-OHP ¼ 9 RT650-OHP / /8 1/2 50 RT605-OHP ¾ 197 INDEX / SERIES RT North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra 7

10 Wd Thgs Up With Reelcra COMPACT QUIET LATCH Series 4000, 5000 & 5005 A5850 OLP ENCLOSED MODEL 5435 ELP Sprg Driven Air/Water/Oil/Grease Series 4000, 5000 & /4, 3/8, 1/2 I.D. Series 4000 & 5000 reels are all steel construction and copact for a wide range of applications with critical space requireents. A full flow sha and swivel assures axiu product delivery. The Quiet Speed latch echanis offers quiet operation cobed with latch ca technology surg longer latchg life and trouble-free perforance. Series 5000 E reels are the sae as 5000 O reels except E Series reels are fully enclosed. To order, change the odel nuber suffix letter O to E, Exaple: 54 OHP becoes 54 EHP. Add 8 lbs. to open reel weight. Enclosed version not available for series 5005 reels. Four 5/" (8) diaeter ountg holes. DIMENSIONS , 5605 & A5805 A5806 / / / / A 12 7 / / / / B 12 5 / / / / C / / / 4 8 D 2 1 / / / / 2 64 E 5 3 / MODELS WITH HOSE HOSE CAPACITY MODELS WITHOUT HOSE MODEL WEIGHT PRESSURE I.D. O.D. (M)NPTF OUTLET (F)NPTF INLET LENGTH MODEL WEIGHT PRESSURE lbs / kg psi / bar / / / lbs / kg psi / bar LOW PRESSURE AIR/WATER REELS* Maxiu Teperature 0 F (65 C) 44 OLP 8 0 1/ /4 3/ OLP OLP / /4 3/ OLP OLP / /4 3/ OLP OLP / /4 3/ OLP OLP / /4 3/ OLP OLP / /4 3/ OLP OLP / /4 3/ OLP OLP / /4 3/ OLP A58 OLP / /2 3/8 8 A5800 OLP A5835 OLP / /8 3/ A5805 OLP A5850 OLP / /2 3/8 50 A5806 OLP MEDIUM PRESSURE OIL REELS** Maxiu Teperature 0 F (99 C) 5435 OMP / /4 3/ OMP OMP 5 3/ /8 3/ OMP A58 OMP /2.8 1/2 3/8 8 A5800 OMP A5835 OMP /2.8 1/2 3/ A5805 OMP HIGH PRESSURE GREASE REELS*** Maxiu Teperature 0 F (99 C) 54 OHP / /4 1/ OHP OHP / /4 1/ OHP OHP / /4 1/ OHP *Low pressure hose reels furnished standard with PVC hose. Copressed air hoses should not be converted to oxygen service - ay cause explosion when O 2 ixes with fuel. **Mediu pressure reels furnished standard with S.A.E. 100 R1T one wire braid hose. Floor tank ount only - do not ount on ceilg. ***High pressure reels furnished standard with S.A.E. 100 R2T two wire braid hose, suitable for grease applications only. See page 53 for optional ountg bases and brackets. See page 55 for let hose asseblies and adjustable buper stops. 8 North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Reelcra Industries is ISO 9001:00 Certified Sce 1996 Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

11 HEAVY DUTY REEL Series 7000 Fry s Napa AutoCare Center, Colubia City, IN INSET: ENCLOSED MODEL 7650 ELP APPLICATIONS Industrial Autootive Service Centers Transission Shops Fleet Matenance Facilities Pneuatic Tools Aircra Matenance For all etric thread connections over 1/2" add the suffix nuber 70 to dicate BSPT threads - exaple 7900 OLP OLP Tire Stores Agriculture Far & Ranch Service Trucks Wash Down Air & Water Series 7000 E reels are the sae as 7000 O reels except E Series reels are fully enclosed. To order, change the odel nuber suffix letter O to E. Exaple, 7650 OHP becoes 7650 EHP. Add lbs. to open reel weight. Sprg Driven Air/Water/Oil/Grease Series /4, 3/8, 1/2, 3/4 I.D. Series 7000 is very robust and ideal for the ost deandg applications. The reel s base and guide ars are fored fro high-grade steel and engeered with structural fors and gussets to yield the greatest aount of strength. The standard low pressure hose is for air or water service only. The basic reel without hose can be used for air, water or oil. Consult Reelcra for other products and hoses. Four 1/2" (12.7) diaeter ountg holes. DIMENSIONS 7000 O 7000 E / / A 1 / / 4 5 B / 4 5 C 7 7 / / 8 0 D 3 7 / / 8 98 E MODELS WITH HOSE HOSE CAPACITY MODELS WITHOUT HOSE MODEL (M)NPTF (F)NPTF WEIGHT PRESSURE I.D. O.D. LENGTH MODEL WEIGHT PRESSURE OUTLET INLET lbs / kg psi / bar / / / lbs / kg psi / bar LOW PRESSURE AIR /WATER REELS* Maxiu Teperature 0 F (65 C) 7650 OLP / /4 1/ OLP OLP / /4 1/ OLP OLP / /8 1/ OLP OLP / /4 3/ OLP F79 OLP / /4 3/4 8 F7900 OLP MEDIUM PRESSURE OIL REELS** Maxiu Teperature 0 F (99 C) 7650 OMP / /2 1/ OMP OMP /2.8 1/2 1/ OMP HIGH PRESSURE GREASE REELS*** Maxiu Teperature 0 F (99 C) 7450 OHP / /4 1/ OHP OHP / /4 1/ OHP *Low pressure reels furnished standard with PVC hose. **Mediu pressure reels furnished standard with S.A.E. 100 R1T one wire braid hose. ***High pressure reels furnished standard with S.A.E. 100 R2T Two wire braid hose, suitable for grease or hydraulic oil applications only. Series F79 OLP supplied with fuel grade hose and UL3 & UCL approved hose with a 0 psi ( bar) iu burst. See page 55 for let hose asseblies and adjustable buper stops. See page 53 for optional ountg bases and brackets. SERIES 4000, 5000 & 5005 / SERIES 7000 North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra 9

12 Wd Thgs Up With Reelcra NEW! Meets or Exceeds Military Vibration for Truck Transport test. MIL-STD-810F 500,000 ile equivalent DIMENSIONS MODEL A B / / LOW PRESSURE REELS DP7450 OLP DP7650 OLP DP7850 OLP MEDIUM PRESSURE REELS DP7650 OMP DP7850 OMP HIGH PRESSURE REELS DP7450 OHP DP7650 OHP DP7850 OLP Patent Pendg COMPACT DUAL PEDESTAL Series DP7000 Sprg Driven Air/Water/Oil/Grease Series DP7000-1/4, 3/8, 1/2 I.D. A breakthrough dual pedestal base design, Reelcra Industries now offers the stability of a dual pedestal reel a superbly engeered and extreely copact, yet strong design. Reelcra s new DP7000 Series features our patented terlockg base design, which akes the base assebly especially strong and resistant to vibration. Independent testg has proven these reels to stand up to heavy vibration, akg the ideal for truck ounted applications. FEATURES Strength & Stability Interlockg dual base and guide ars are staped fro heavy gauge dustrial steel and engeered gussets throughout ake these reels strong and vibration resistant. Lightweight Latch pawl, ca, and hubs are die-cast aluu for superior strength and to eliate excessive weight. Superior Corrosion-Resistance A double adhesive gasket seals the sprg case and steel parts are powder coated to provide excellent protection agast weatherg. Low Matenance A peranent oil ipregnated bronze bushg and staless steel torsion sprg are corporated to ensure that, through frequent use, these reels require ial atenance. Ease of Operation The latch pawl is ounted on the guide ar to prevent latch out at full extension and the high ipact, nylon filled guide rollers ake retraction and pay out nearly effortless. MODELS WITH HOSE HOSE CAPACITY MODELS WITHOUT HOSE MODEL WEIGHT PRESSURE I.D. O.D. (M)NPTF (F)NPTF OUTLET INLET LENGTH MODEL WEIGHT PRESSURE lbs / kg psi / bar / / / lbs / kg psi / bar LOW PRESSURE AIR/WATER REELS Maxiu Teperature 0 F (65 C) w/hose / 0 F (99 C) w/o hose DP7450 OLP / /4 1/2 50 DP7400 OLP DP7650 OLP / /4 1/2 50 DP7600 OLP DP7850 OLP / /8 1/2 50 DP7800 OLP MEDIUM PRESSURE OIL REELS Maxiu Teperature 0 F (99 C) DP7650 OMP / /8 1/2 50 DP7600 OMP DP7850 OMP /2.8 1/2 1/2 50 DP7800 OMP HIGH PRESSURE GREASE REELS Maxiu Teperature 0 F (99 C) DP7450 OHP / /4 1/2 50 DP7400 OHP DP7650 OHP / /4 1/2 50 DP7600 OHP North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Reelcra Industries is ISO 9001:00 Certified Sce 1996 Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

13 MOBILE BASE REELS Series D8000 Sprg Driven Air/Water/Oil/Grease Series D8000-1/4, 3/8, 1/2 I.D. The aluu cast base and ar of the Series D8000 offer the highest rigidity aong this class of hose reels. The quality and reliability the professional expects the tools and equipent they vest is et and exceeded by Reelcra products. Series D8000 E reels are the sae as D8000 reels except E Series reels are fully enclosed. To order, change the odel nuber suffix letter O to E, add lbs to the open reel weight. INSET: ENCLOSED MODEL D8650 ELP FEATURES Aluu guide ar and base are cast fro 40,000 P.S.I. tensile strength aterial with 7% elongation which assures ultiate shock resistance. Cast aluu frae gives axiu strength with iu payload weight A special heavy, double adhesive sided sprg case gasket protects the a sprg fro daage (failure) caused by water, dirt or other foreign atter enterg the sprg case Guide ar is field adjustable for floor, wall, ceilg, pit and truck ountg Full flow sha and swivel Reel sprgs are anufactured fro the highest quality scaleless blue tepered steel Each coponent is coated dividually with a durable bakedon powder coat fish. This provides an excellent high quality ultra violet radiation (sunlight) weather and chip resistant fish that will stay bright through years of use Inlet is 1/2" Outlet is 1/2" Four 1/2" (12.7) diaeter ountg holes. DIMENSIONS D8000 O / D8650 OLP D8000 E / A 1 / / B / 8 5 C 7 3 / / D 3 3 / / 4 96 E 9 1 / / 2 7 Series D8000 E reels are the sae as D8000 O reels except E Series reels are fully enclosed. To order, change the odel nuber suffix letter O to E. Exaple, D8650 OHP becoes D8650 EHP. Add pounds to open reel weight. MODELS WITH HOSE HOSE CAPACITY MODELS WITHOUT HOSE MODEL (M)NPTF (F)NPTF WEIGHT PRESSURE I.D. O.D. LENGTH MODEL WEIGHT PRESSURE OUTLET INLET lbs / kg psi / bar / / / lbs / kg psi / bar LOW PRESSURE AIR/WATER REELS* Maxiu Teperature 0 F (65 C) w/hose / 0 F (99 C) w/o hose D8650 OLP / /4 1/2 50 D8600 OLP D8670 OLP / /4 1/2 70 D8600 OLP D8850 OLP / /8 1/2 50 D8800 OLP MEDIUM PRESSURE OIL REELS** Maxiu Teperature 0 F (99 C) D8650 OMP / /2 1/2 50 D8600 OMP D8840 OMP /2.8 1/2 1/2 40 D8800 OMP D8850 OMP /2.8 1/2 1/2 50 D8800 OMP HIGH PRESSURE GREASE REELS*** Maxiu Teperature 0 F (99 C) D8450 OHP / /4 1/2 50 D8400 OHP D8650 OHP / /4 1/2 50 D8600 OHP Note: For lubricated truck version change D to E. For exaple E8650 OLP *Low pressure reels furnished standard with PVC hose. / **Mediu pressure reels are furnished standard with S.A.E. 100 R1T one wire braid hose. ***High pressure reels furnished standard with SAE 100R2T two wire braid hose, suitable for grease applications only. SERIES D8000 / SERIES DP7000 North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra 11

14 Wd Thgs Up With Reelcra DUAL PEDESTAL REEL Series & D80000 Sprg Driven Air/Water/Oil/Grease Series & D /8, 1/2, 3/4, 1 I.D. Copact Base Fits areas where space is liited 800 OLP DIMENSIONS D hose / / A B 3 / / C 11 3 / / 1 ¾ ¼ 362 D 10 1 / ¼ 387 E 10 1 / F 7 1 / Inlet is 1/2" or 3/4" NPTF (F) or 3/4" BSPT. Reel outlet is 1/2" or 3/4" NPTF (F) or 3/4" BSPT. Four 1/2" (12.7) diaeter ountg holes Reelcra s Series and D80000 OLP sprg retractable reels corporate the ost current design and anufacturg techniques to guarantee long life and trouble-free perforance. All-steel construction and a baked-on powder coat fish cobe to produce a rugged corrosion resistant product suitable for a wide variety of heavy duty applications. Series D80000 reels are also supplied with Reelcra s new ball-bearg style swivel. FEATURES Hose anti-latch out feature ensures hose retracts every tie. Guide ar is field adjustable for wall, ceilg, or truck ountg positions. Dual pedestal base and guide ar design, structurally reforced. Five--one heat treated aluiu castg corporates a sha, ratchet, sprg arbor and let/outlet plubg one piece castg. Contaerized sprg assebly. Provides safe and easy handlg durg atenance. Two sealed ball beargs for sooth rotation of a sha MODELS WITH HOSE HOSE CAPACITY MODELS WITHOUT HOSE MODEL (M)NPTF (F)NPTF WEIGHT PRESSURE I.D. O.D. LENGTH MODEL WEIGHT PRESSURE OUTLET INLET lbs / kg psi / bar / / / lbs / kg psi / bar LOW PRESSURE AIR/WATER REELS Maxiu Teperature 0 F (65 C) w/hose / 0 F (99 C) w/o hose OLP / /8 1/ OLP OLP / /2 1/ OLP OLP / /2 1/ OLP OLP / /4 3/ OLP F850 OLP* / /4 3/4 50 F800 OLP D875 OLP / /4 3/4 75 D800 OLP D84050 OLP / D84000 OLP MEDIUM PRESSURE OIL REELS Maxiu Teperature 0 F (99 C) 875 OMP /2.8 1/2 1/ OMP OMP / /4 3/ OMP HIGH PRESSURE GREASE REELS Maxiu Teperature 0 F (99 C) OHP / /8 1/ OHP OHP / /8 1/ OHP UL3 and ULC approved hose. 0 psi iu burst. ( Bar) / For all etric thread connections over 1/2" add the suffix nuber -70 to dicate BSPT threads - exaple 850-OLP70. Low pressure reels furnished standard with PVC hose. Mediu pressure reels are furnished standard with S.A.E. 100 R1T one wire braid hose. Modification - Reels without hose can be odified to handle gasole and diesel fuel, to order place prefix "F" before odel nuber (F800 OLP). *Model F850 OLP equipped with fuel grade hose. Inlet hoses & buper stops. High pressure reels furnished standard with SAE 100R2T two wire braid hose, suitable for grease applications, only. 12 North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Reelcra Industries is ISO 9001:00 Certified Sce 1996 Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

15 LARGE FRAME REELS Nordic Series 00 / 4800 SPRING DRIVEN REELS NORDIC SERIES 00 / 4800 ½, ¾ or 1½ Fluid Path for ¼ through 1½ I.D. Hose Series 4800 INLET: ½ up to 1 feale/ale NPT 90 swivel jot. GOOSENECK: ½ up to 1 feale/ale NPT. Series 48 reels handle hose fro ½ through 1 I.D. Inlet is ½ up to 1 feale/ale NPT 90 swivel jot. Gooseneck is ½ up to 1 feale/ale NPT. Series 4800 reels handle hose fro 1 through 1½ I.D. 2 straight victaulic is standard. 1½ ale or feale NPT straight swivel jot ay be specified at no extra cost. Gooseneck is 1 to 1½ feale/ale NPT. Series 00 reels handle hose fro ¼ through 1 I.D. ROLLER POSITION: You ust specify roller position BW, SW or TW. If roller position is not specified, reels will be shipped with rollers POSITION BW. See page. HOSE STOP: A hose stop should be used to prevent daage to rollers and nozzles and to perit adjustent of free hose length. See description on page 55. Hose stops are available at extra cost. Series 00 / 48 product teperatures fro -60 to +4 F and DIMENSIONS DIAGRAM standard pressures to 1000 p.s.i. Series 4800 product teperatures E B fro -80 to F at standard pressures to 0 p.s.i. Reels to operate at other teperatures or pressures can be furnished at G extra cost. Consult anufacturer. C NOTE: Other sizes and/or threads can be furnished for gooseneck when specified. Series 01 reels use a stronger sprg assebly for heavy H duty applications. D J A F Tw hose odels are available as standard. See nuberg syste on page for coplete part nubers. Standard color is red or gray. HOSE I.D. 1/4 6 3/8 10 1/2 3/ / /2 38 SPECIFICATIONS - HOSE CAPACITY AND REEL DIMENSIONS HOSE O.D. 5/8 3/4 19 7/8 1 9/ / 1 / 2 1/ * () dia dru on Model# for ½ and ¾ hose MODEL HOSE LENGTH Est. Weight A B C D E F G H J LB 39 KG ½ LB 40 KG ½ LB 40 KG ½ LB 41 KG ½ LB 41 KG ½ 394 ½ LB 42 KG ½ 394 ½ LB 43 KG ½ 445 ½ LB 44 KG ½ 495 ½ X LB 55 KG 10½ 7 5½ ½ 34½ LB 57 KG ½ ½ 34½ *90 * *100 * LB 58 KG * *381 ½ ½ 34½ LB 55 KG ½ 34½ LB 57 KG ¼ ½ 34½ 876 SERIES / SERIES 00 & 4800 North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra

16 Wd Thgs Up With Reelcra MOBILE BASE REEL Series E9000 Sprg Driven Air/Water/Oil/Grease Series E9000-1/2, 3/4, 1, 1 1/4, 1 1/2 I.D.se These obile base reels offer the greatest aount of stability for high volue air, water, fuel and petroleu. Ideal for portable service trucks, peranent service or plant work areas. Basic reels without hose will handle air, water or oil; consult Reelcra for other applications. Hose Guide Roller Position A suffix code (see diagra) ust be added aer the odel nuber to specify desired position. Reels are shipped the BW position unless specified otherwise. FF 95/9600 BW only. E9350 OLPBW Four 7/" (11.2) diaeter ountg holes. DIMENSIONS E9000 FE9000 D9000 / / / A 1 / / / B 1 / / / C 3 / / / D 12 1 / / / 8 8 E 1 / / / 4 6 F 1 / / / G 3 3 / / H / / J 7 3 / / / K 2 3 / / / NEW MODELS WITH HOSE HOSE CAPACITY MODELS WITHOUT HOSE MODEL WEIGHT PRESSURE I.D. O.D. (M)NPTF OUTLET (F)NPTF INLET LENGTH MODEL WEIGHT PRESSURE lbs / kg psi / bar / / / lbs / kg psi / bar LOW PRESSURE AIR/WATER REELS* Maxiu Teperature 0 F (65 C) E9299 OLP / /2 1/2 100 E90 OLP E9350 OLP / /4 3/4 50 E90 OLP FE9350 OLP / /4 3/4 50 FE90 OLP E9375 OLP / /4 3/4 75 E90 OLP D9399 OLPBW / /4 3/4 100 D95 OLPBW E9450 OLP / E9400 OLP FE9450 OLP / FE9400 OLP NOT AVAILABLE WITH HOSE 1 1 / /4 1 1/4 50 FF9500 OLPBW NOT AVAILABLE WITH HOSE 1 1 / /2 1 1/2 50 FF9600 OLPBW MEDIUM PRESSURE OIL REELS** Maxiu Teperature 0 F (99 C) E95 OMP /2.8 1/2 1/2 75 E90 OMP E9350 OMP / /4 3/4 50 E90 OMP HIGH PRESSURE GREASE REELS*** Maxiu Teperature 0 F (99 C) E95 OHP / /2 3/8 75 E9100 OHP Models equipped with fuel grade hose. UL3 and VLC approved hose. 0 PSI iu burst ( Bar) *Low pressure reels furnished standard with PVC hose. / **Mediu pressure reels are furnished standard with S.A.E. 100 R1T one wire braid hose. ***High pressure reels furnished standard with SAE 100R2T two wire braid hose suitable for grease applications only. For all etric thread connections over 1/2" add the suffix nuber 70 to dicate BSPT threads - exaple E90 OLP70. FF9500 and FF9600 odels will have BSPP threads. Note: To specify our lighter duty odel, change prefix fro E to D. Not available on FE9500 or FE9600. Modification - Reels without hose can be odified to handle gasole and diesel fuel, to order place prefix "F" before odel nuber - exaple (FF90 OLP). See Page 55 for let hose asseblies and adjustable buper stops. North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Reelcra Industries is ISO 9001:00 Certified Sce 1996 Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

17 TWIN HYDRAULIC SERVICE Series TH Sprg Driven Tw Hose Series TH - 1/4, 3/8, 1/2 I.D. The hydraulic series reel corporates conteporary engeerg and anufacturg techniques to give trouble free perforance. Used for ediu pressure hydraulic applications, Series TH reels are ideal for operatg hydraulic cylders, tools and equipent. They have a high volue dual-body swivel for axiu product delivery (excludg the 80000). Reels are all steel construction and copact for applications with critical space requireents. DIMENSIONS TH MP TH 7000 OMP TH MP / / / A 1 / / / B 1 / C 9 3 / / D 2 1 / / E C and D diensions are ountg hole patterns. Four 5/" (8) diaeter ountg holes for the 5000 O. Four 1/2" (12.7) diaeter ountg holes for the 7000 O & Questions? We can help! Our friendly custoer service tea is ready to help you with expert assistance. When you call us, you get a live voice and fast, friendly service. Cranes Construction Equipent Hydraulic Tools Vehicle Extraction Tools Aerial Device FEATURES TH7445 OMP Constant tension or pos-i-latch spool echanis All steel construction Reels have a durable, abrasion resistant baked-on powder coat fish sprg otor Copact design for critical space requireents Hydraulic Cylders Tree Cutters Digger Derricks Railroad Matenance Tools MODELS WITH HOSE HOSE CAPACITY MODELS WITHOUT HOSE MODEL (M)NPTF (F)NPTF WEIGHT PRESSURE I.D. O.D. LENGTH MODEL WEIGHT PRESSURE OUTLET INLET lbs / kg psi / bar / / / lbs / kg psi / bar MEDIUM PRESSURE HYDRAULIC HOSE REELS Maxiu Teperature 0 F (99 C) TH54 OMP / /4 1/4 8 TH5400 OMP TH7445 OMP / /4 1/4 45 TH7400 OMP THA76 OMP / /8 3/8 9 THA7600 OMP MEDIUM PRESSURE HOSE REELS - Maxiu Teperature 0 F (99 C) TH86050 OMP / /8 3/8 50 TH86000 OMP TH88050 OMP / /2 1/2 50 TH88000 OMP Adustable hose bupers listed on page 55. See page 53 for optional accessories, ountg brackets and bases. APPLICATIONS SERIES E9000 / SERIES TH North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra

18 Wd Thgs Up With Reelcra Ultra Heavy Duty Truck and Mobile Mount FE9450 OLPBW FUEL REELS Series F7000 / FE9000 /FD9000/ FF9000 / F80000 / FD80000 Sprg Driven Fuel Reels Series F7000-3/4 I.D. Series FE9000-3/4, 1 I.D. Series FF 9500, FF9600-1¼, 1½ I.D. Series F /4 I.D. Series FD /4, 1 I.D. Reelcra s fuel sprg retractable reels, equipped with Viton seals, are ideal for deliverg fuel. The reels corporate etal fors to sure the greatest possible strength and function equally well both obile and peranent ount applications. These rugged, corrosion-resistant reels are suitable for a wide variety of applications. F79 OLP Heavy Duty Sgle Pedestal Mediu Capacity NEW SWIVEL FEATURES Ball-bearg design reduces load and iizes wear Full flow design iizes pressure drop Nickel plated for additional corrosion resistance ADDITIONAL FEATURES (80000 Series) Five--one aluu castg Contaerized sprg assebly Hose anti-latch out feature Two sealed ball beargs for sooth rotation of a sha Dual pedestal and dual guide ar support For fuel reel odels #s See chart on page High Capacity Heavy Duty Dual Pedestal APPLICATIONS FD875 OLP Industrial Agriculture Autootive Service Centers Far & Ranch Mg (above ground) Service Trucks Fleet Matenance Facilities Fluid Transfer Aircra Matenance Fuel Transfer Inlet is 3/4" or 1" NPTF (F) and atches hose ID. Outlet is 3/4" or 1" NPTF (F) and atches hose ID. Four 1/2" (12.7) diaeter ountg holes DIMENSIONS hose FD80000 / A B 3 / C 11 3 / D 3 /4 1 / / E 10 1 / 2 7 F 7 7 / NOTE: For reel diensions not listed on this page, please see page 9 for F7000 diensions and page for FF9000 diensions. North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Reelcra Industries is ISO 9001:00 Certified Sce 1996 Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

19 STATIC DISCHARGE REELS Series G DIMENSIONS G 00 SERIES G 50 Y 50 Cable G Cable Four 3 / 8 (10) diaeter ountg holes NOTE: Diensions for GA00 N are 9. x 4. x 9 3/4 (LxWxH) SPECIFICATIONS Includes cable stalled on reel GA00 N 100 Cable Cable Included MODEL CABLE EXTENDED Y CABLE NOTES WEIGHT / / lbs / kg G N/A Sgle 7 x 7 stranded steel* G 50 Y 50 (4.8) 35 (9.2) plus dual (4.6) for Y * Total extension 50 () G 50 N 50 N/A Nylon covered cable** GA00 N 100 N/A Nylon covered cable** 10 * Static discharge reels are supplied coplete with 3/32" OD steel aircra cable. DC resistance is approxiately one oh per 50. of steel cable. ** Nylon covered cable (1/8" O.D.). NOTE: Diensions for GA00 N are 9. x 4. x 9 3/4 (LxWxH) Fuel reels Contued fro page Sprg Driven Series G 00 Static discharge reels are used to ground equipent operatg hazardous atospheres, such as fuel trucks or carts transferrg flaable aterials. When properly claped to ground, the static discharge reel dissipates static electrical buildup, reduces chances of sparkg and the potential for explosion. F79 OLP FD875 OLP FE9450 OLPBW Additional Fuel Reel Inforation MODELS WITH HOSE HOSE CAPACITY MODELS WITHOUT HOSE MODEL WEIGHT PRESSURE I.D. O.D. (M)NPTF (F)NPTF OUTLET INLET LENGTH MODEL WEIGHT PRESSURE lbs / kg psi / bar / / / lbs / kg psi / bar LOW PRESSURE FUEL REELS Maxiu Teperature 0 F (65 C) w/hose / 0 F (99 C) w/o hose F79 OLP* 53 * ¾ /4 3/4 8 F7900 OLP F850 OLP* * ¾ /4 3/4 50 F800 OLP FD875 OLP* 1 58 * ¾ /4 3/4 75 FD800 OLP FD84050 OLP* 1 54 * FD84000 OLP FE9350 OLP* 0 64 * ¾ /4 3/4 50 FE90 OLP FE9450 OLP* 7 72 * FE9400 OLP FD9350 OLP* 0 64 * ¾ /4 3/4 50 FD90 OLP FD9450 OLP* 7 72 * FD9400 OLP Models not available with hose 1¼ /4 1 1/4 50 FF9500 OLPBW ½ /2 1 1/2 50 FF9600 OLPBW * Models equipped with fuel grade hose. UL3 and ULC approved hose. 0 PSI iu burst ( Bar) For all etric thread connections 1" and under add the suffix nuber -70 to dicate BSPT threads - exaple FD80000-OLP70. For all etric threads above 1 add -70 for BSPP threads. FF Models supplied with 1½ let. Reel let on all odels this chart is NPTF (F) and atches hose I.D. FUEL REELS / SERIES G North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra

20 Wd Thgs Up With Reelcra CORROSION RESISTANT Staless Steel Series APPLICATIONS Restaurants Car Washes Laboratories A HS000M Four 7 / ch (11.2) diaeter ountg holes F Inlet 7000 O Dairies Maras Grocery Stores Photo Fishg Meat Packg Plants Cheical Plants Prtg Industry Pharaceutical Food Processg Ships DIMENSIONS 5000 O 7000 O D80000 HS000 M / / / / / A 1 / / / / B 3 / / 8 6 C 9 3 / / / D 2 1 / / / E / / / /2" NPTF (F) 3 HOSE REEL INLET F 3 /8 " NPTF (F) 1 /4" /2" NPTF (F) NPTF (F) 3 /4" NPTF (F) Series 5000 has four 5/" (8) diaeter ountg holes. Series 7000, & D80000 has four 1/2" () diaeter ountg holes. Series HS 000 has four 7/" (11) diaeter ountg holes. Series & D80000 let atches recoended hose I.D. NOTE: For D9000 diensions see chart on page -- refer to E9000 diensions. 1" NPTF (F) MODELS WITHOUT HOSE HOSE CAPACITY ADDITIONAL INFORMATION MODEL WEIGHT PRESSURE I.D. O.D. (F)NPTF INLET LENGTH Reels not cataloged with hose. Hoses are quoted lbs / kg psi / bar / / / separately on request. MEDIUM & LOW PRESSURE REELS 5600 OLS / / Maxiu teperature 0 F (99 C) 5600 OMS / / OLS / / OMS / / OMS /2.8 1/2 50 D90 OLS / /2 100 D90 OLS / /4 75 D9400 OLS D90 OMS /2.8 1/2 100 D90 OMS / / OLS / / OMS /2.8 1/ OLS / / OMS / /4 50 Consult anufacturer for higher teperature. 1 /2" NPTF (F) For all etric thread connections over 1/2 add the suffix nuber 70 to dicate BSPT threads - exaple D800 OLS70 D800 OLS / /4 75 MAXIMUM HOSE CAPACITY D84000 OLS I.D. ¼ 6 3 /8 10 ½ ¾ 19 1 MANUAL CRANK MEDIUM PRESSURE REELS O.D HS000 M / HS28000 M / See chart HS19000 M See chart at right 3/ at right HS29000 M / NEW HS37000 L HOSE LENGTH North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Reelcra Industries is ISO 9001:00 Certified Sce 1996 Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

21 CORROSION RESISTANT Staless Steel Series Sprg Driven Air/Water/Oil Staless Steel Series - 3/8, 1/2, 3/4, 1 I.D. Reelcra s staless steel hose reels will crease the life of expensive cheical fluid transfer and wash down hoses. By properly storg hose when not use, occupational safety will iprove by eliatg the trippg hazard of unstored hose and sanitation will iprove. Staless steel hose reels are ideal for food processg, pre-rse, wash down, cheical transfer and dustrial solvent handlg. Also suitable for coastal, offshore and on-board ship are applications where the harsh environent of salt water spray requires the use of staless steel hose reels. Swivels clude Viton "O" rgs. FEATURES Full-flow staless steel sha and swivel assures axiu product delivery. Exception: Series aluu fluid path. Heavy duty brackets to eliate bendg due to angular hose pull Banded drive sprg gives sooth autoatic hose retrieval Multi-position guide ar perits wall, floor, ceilg, pit or truck ountg Nylon guide rollers reduce hose drag and abrasion Pos-i-latch will ata the desired workg length of hose. Mechanis assures a positive latch of the hose All reels are peranently factory lubricated 7000 Series offers weatherproof gasketed sprg otor, assures axiu service life Vibration-proof self-lockg fasteners assures assebly tegrity 4L grade of staless steel Passivated for electro polish fish *Series & D80000 staless reels have an aluu fluid path and ay not be suitable for all applications SERIES 5000 SERIES Heavy Duty HS000 M D 9000 SERIES Copact Great for areas where space is critical General Use Many versatile applications corrosive or sanitary environents SERIES Ultra Heavy Duty Heavy duty dual pedestal for axiu strength STAINLESS STEEL North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra 19

22 Wd Thgs Up With Reelcra PRE-RINSE & POTABLE WATER Series 4000 & OLPSW5 Optional 360 Swivel 6008 Drkg Water Boats, RVs, buses and uch ore Four 5/" (8) diaeter ountg holes. SPECIFICATIONS Spray Valve OLBSW UL LISTED Hot water washdown and food prep Coercial use, restaurants, schools, hoe/garden and ore DIMENSIONS E / / / A 12 7 / / / B 12 5 / / C / / 4 8 D 2 1 / / / 2 64 E 5 3 / MODEL (F)NPTF I.D. O.D. INLET LENGTH WEIGHT PRESSURE / / / lbs / kg psi / bar PRE-RINSE REELS 46 OLPSW5 3 / / OLPSW5 3 / / ELPSW5 3 / / PRE-RINSE STAINLESS STEEL REELS 5 OLSSW5 3 / / ELSSW5 3 / / POTABLE (Drkg) WATER REELS OUTLET - Garden Hose Fittg 3/4 N/H Threads (F) A5835 OLBSW* 1 / /2 Male * Maxiu operatg teperature is 86 F ( C) Sprg Driven Potable (Drkg) Water Reel - 1/2 I.D. Our potable water reel is classified 7P by Underwriters Laboratories as a Drkg Water Syste Coponent accordance with ANSI/NSF Standard 61. ANSI: Aerican National Standards Institute NSF: National Sanitation Foundation POTABLE WATER REEL FEATURES Staless steel, full flow sha and swivel Convenient fast hook-up and disconnect Sprg Driven Pre-Rse Reels - 3/8 I.D. Craed for use corrosion-resistant appliances of restaurants, stitutions, hoe and garden applications, Reelcra s pre-rse reels clude a standard lever-operated spray valve and staless steel sprg hose guard. Available staless or powder fish. Rated for hot water up to 0 F (99 C). PRE-RINSE REEL FEATURES Lever-operated spray valve and staless steel hose guard are cluded Optional 360 rotatg swivel (6008) offers degrees of angular otion Dra and standard feale garden hose let fittg are standard Maxiu operatg teperature 86 F ( C) Push-Lok, field replaceable, hose-end fittgs Reels can be ounted on the wall, ceilg, or under a counter, akg water conveniently available Latchg echanis hold hoses at desired length North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Reelcra Industries is ISO 9001:00 Certified Sce 1996 Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

23 LIGHTWEIGHT, DURABLE S Series Sprg Driven Coposite Reels S Series - 3/8, 1/2 I.D. & Weldg Reels The S Series is econoical, durable and lightweight utilizg a practical cobation of the latest coposite aterials and etals with applications cludg water, air, hot wash (pre-rse), cheical delivery and oxygen acetylene. A unique cobation of coposites & etals The tough coposite poly-propylene outer case houses solid brass swivel and fluid path, a steel a sha and high quality sprg steel otor. Corrosion-resistant & durable The tough coposite poly-propylene outer case is UV stabilized and resistant to ost acids and alkalis with excellent ipact resistance akg these reels suitable not only for general applications but also for environents where corrosion is an issue. NEW Positive latchg syste The design of the latchg syste ensures positive latchg any ountg position. Unique ountg The ountg bracket syste supplied with the reel allows for ountg any position with the advantage of the swivel feature standard. Lighter Weight Pound for pound the S series offers distct weight advantages due to the coposite case construction. DIMENSIONS S SERIES / A 19 1 / B 3 / C 9 1 / 2 0 D E 9 1 / 2 5 Coposite / S Series SGA3650 OLP Cobation Air/Water Water Service Hot Water Wash SPECIFICATIONS MODEL WEIGHT PRESSURE I.D. O.D. LENGTH (M)NPTF (F)NPTF HOSE OUTLET REEL INLET (with hose) lbs / kg psi / bar / / / AIR* & WATER* REELS Workg Teperature 0 F (65 C). SGA3650 OLP / /8 3/8 SGA3665 OLP / /8 3/8 SGA3850 OLP / /2 1/2 WATER REEL Garden-style hose end. Workg Teperature 0 F (65 C). SWA3850 OLP / /4 NH 1/2 HOT WATER WASH REEL NOTE: Workg Teperature 5 F (85 C). Workg pressure is related to workg teperature. SHA3850 OLP / /2 1/2 CHEMICAL DELIVERY REEL SCA3850 OLP / /2 1/2 OXYGEN/ACETYLENE REEL Workg Teperature 0 F (65 C). STW3450 OLP / / (F)LH-RH 9/ (F)LH-RH STW3450 OLP C diension = / 285. *NOTE: Air hose can be used for water on these odels. SGA3650 OLP Shown with ountg brackets and optional wire stand #S98 Cheical Delivery Oxygen Acetylene Arbor Fars Nursery, Fort Wayne, Indiana Best Coposite Reel Suitable for all position ountg. Series S reels are ade Australia. SERIES S / PRE-RINSE & POTABLE WATER REELS North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra

24 Wd Thgs Up With Reelcra PRESSURE WASH REELS Series 000 / H006 / PW Sprg Driven, Hand Crank & Motor Driven Series 000 / H006 / PW - 1/4, 3/8, 1/2 I.D. Copact design and quality steel construction are corporated to Reelcra s newest le of pressure wash reels rated up to 4500 PSI. The Series 000, H006 and PW reels are able to carry 50 to 400 feet of tangle-free hose and coe coplete with Super Swivel for axiu product delivery. Super Swivel is designed to handle a broad range of pressures, teperatures and cheicals; perfect for agricultural/are, equipent cleang and pressure washg applications. PW7650 OHP Agricultural Mare H & 000 APPLICATIONS Equipent Cleang Pressure washg PW CA38106 M Hose not lcuded Caution: To prevent dru daage, all hoses should be extended before pressurizg. NEW CAPACITY / / / Hose I.D. 1 /4 6 3 / /2 HOSE CAPACITY & REEL DIMENSIONS Hose O.D DIMENSIONS WEIGHT MODEL LENGTH A B C D E F / / / lbs / kg / / / / / / Sprg Driven - Pressure 4500 psi / 345 bar (*hose cluded) PW7600 OHP ¼ / / 8 98 PW7650 OHP* ¼ / / 8 98 PW81000 OHP / / 1 10½ Hand Crank - Pressure 00 psi / 7 bar H006 M ½ 0 7¾ 197 5½ 0 CA38106 M ¾ CA38112 M ¾ Electric Motor Driven - Pressure 00 psi / 7 bar EA38106 M12D / ¾ EA38112 M12D / 600 ¾ North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Reelcra Industries is ISO 9001:00 Certified Sce 1996 Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

25 Hand Crank Air/Water Series CU - 3/8 I.D. The Series CU is designed for lighter-duty applications that require longer lengths of low pressure air/water hose. These reels are hand crank with a balanced brass swivel and brass let. The product of lightweight coponents and forward-thkg design, the Series CU is an econoic choice for storg and retrievg hose. SPECIFICATIONS MODEL HOSE I.D. (M)NPTF OUTLET (F)NPTF INLET LENGTH WEIGHT PRESSURE / / lbs / kg psi / bar LOW PRESSURE AIR/WATER REELS : Maxiu Teperature 0 F (65 C) CU6050LN 3/8 10 3/8 3/ CU0LN 3/8 10 3/8 3/ Reels are supplied w/o hose; asseblies will be quoted upon request. DIMENSIONS H000 H000 H19000 H28000 H29000 H28005 H29005 CU6050LN CU0LN / / / / / A / / / B C D / 2 7 E 12 1 / / / / 4 5 / F 5 3 / / / / / 2 0 SPECIFICATIONS MODEL HOSE I.D. HOSE O.D. (F)NPTF INLET LENGTH WEIGHT PRESSURE / / / lbs / kg psi / bar LOW PRESSURE AIR/WATER REELS : Maxiu Teperature 0 F (65 C) H000 3/ / H000 1/ / H / / H / / H / / H / / H / / MEDIUM PRESSURE OIL REELS : Maxiu Teperature 0 F (99 C) H000 M 3/ / H000 M 1/2.8 1/ H19000 M 3/ / H29000 M 3/ / HIGH PRESSURE GREASE REELS : Maxiu Teperature 0 F (99 C) H000 H 3/ / Reels are supplied w/o hose; asseblies will be quoted upon request. CAUTION: To prevent dru daage fully extend and pressurize hose and rewd on the reel. Staless odels available. See page & 19. GENERAL USE HAND CRANK Series CU & H NEW! CU0LN CU6050LN Hand Crank Air/Water/Oil/Grease Series H - 3/8, 1/2, 3/4 I.D. An econoical reel designed for ediu duty applications requirg long lengths of hose. Equally suited for plant or field use such as lawn care, pest control, stea cleang and ore. Shipped copletely assebled, ready to stall. H000 PRESSURE WASH REELS / SERIES CU & H North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra

26 Wd Thgs Up With Reelcra VERSATILE CONFIGURATIONS Series 000 CA312L SPECIFICATIONS Hand Crank FEATURES Adjustable spool rotation drag that eliates hose backlash Nickel-plated swivel with four O rg options: AFLAS (std), Buna, Viton or -EPR* seals Full flow sha and ball bearg swivel (excludes 1/2" odels) Peranently lubricated dual a beargs *Standard swivel Motor ountg at either end of reel All bolted construction - no welds Optional lock p to prevent spool rotation when the reel is not use S Teperature operatg range fro - F (-29 C) to +0 F (1 C) Vibration-proof self-lockg fasteners to ensure assebly tegrity Note: Many ore reel odels available addition to chart Please call anufacturer for details on odels not listed here MODEL HOSE I.D. HOSE O.D. (F)NPTF REEL INLET CAPACITY WEIGHT PRESSURE A B C D / / / lbs / kg psi / bar / / / / HAND CRANK CA6 L 1 / / N/A 9 3 / 4 8 CA2 L 1 / / N/A 3 / CA8 L 1 / / N/A 3 / CA3 L 1 / / N/A 3 / CA328 L 1 / / N/A 3 / CA6 M 1 / / N/A 9 3 / 4 8 CA2 M 1 / / N/A 3 / CA6 L 3 / / N/A 9 3 / 4 9 CA312 L 3 / / N/A 3 / CA3 L 3 / / N/A 3 / CA312 M 3 / / N/A 3 / CA3 M 3 / / N/A 3 / CA371 L* N/A 3 / BEVEL CRANK REELS BA36112 L 1 /4 7 Tw Weldg 1/ N/A 3 / BA34112 M 1 /2 Tw Hydraulic 1/ N/A 3 / ELECTRIC MOTOR DRIVEN REELS EA6 L10A 1 / / N/A / / 4 9 EA2 L12D 1 / / N/A / / EA8 L12D 1 / / N/A / / EA312 M12D 3 / / N/A / / EA328 M12D 3 / / N/A / / EA312 L12D 3 / / N/A / / EA312 MD 3 / / N/A / / EA371 L12D* N/A / AIR MOTOR DRIVEN REELS - Filter, regulator, lubricator required AA2 L4A 1 / / N/A / / AA6 L4A 3 / / N/A / / 4 9 AA312 L6A 3 / / N/A / / All 000 series reels are supplied without hose. Asseblies quoted upon request. *Series reels do not have a gooseneck. North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Reelcra Industries is ISO 9001:00 Certified Sce 1996 Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

27 VERSATILE CONFIGURATIONS Series 000 B WIDTH DIMENSIONS & SPECS HOSE I.D. HOSE O.D. WEIGHT HOSE CAPACITY 1/4" 3/8" 1/2" 3/4" 1 (6.35) (9.53) (12.70) (19.05) (.40).5".688".854" 1.8" (.4) (.5) (.5) (.2) (35.0) 6" 38 lb 0' 0' 100' 50' (3 ) ( kg) (61 ) (43 ) ( ) ( ) N/A 12" 46 lb 4' 0' 0' 100' (5 ) ( kg) (1 ) (91 ) (61 ) ( ) N/A " 54 lb 6' 450' 3' 5' 100 (458 ) ( kg) (191 ) (7 ) (99 ) (54 ) ( ) " 58 lb 780' 550' 400' 2' 1 ( ) ( kg) (8 ) (8 ) (1 ) (69 ) (38 ) " 66 lb 1000' 700' 500' 5' 0 (712 ) ( kg) (5 ) (3 ) (3 ) (84 ) (47 ) Hand Crank & Motor Driven Series 000-1/4,1/2, 3/4, 1 I.D. Reelcra's Series 000 reels are designed for rugged, heavy duty applications requirg long lengths of hose and large storage capacity. All-bolted unitized construction with no welds to fatigue. Full flow swivel and heavy gauge steel frae, spool and dru ensure longest service life. Low pressure water Long hose lengths ideal for grounds atenance and ore Electric Motor Four 1/2 ch (12.7) diaeter ountg holes Note: Weights listed are for crank driven - Add for power driven, electric - all explosion proof 45 lb. (.41 kg); 12 Volt D.C. 1/3 H.P. lb. (.61 kg); Air 6 AM 36 lb. (.33 kg). * Note: capacity chart is reference only. For all etric thread connections over 1/2" add the suffix nuber 70 to dicate BSPT threads - exaple CA312 M70. Photo courtesy of DEMCO Dethers Manufacturg Copany, Boyden, Iowa EA312 L12D CAUTION: To prevent dru daage, fully extend and pressurize hose, then wd on the reel. The 000 series should always be wound under pressure. MODEL NUMBER SIGNIFICANCE Drive Type AA - Air, Pneuatic otor driven BA - Bevel crank - Front position CA - Hand crank direct drive EA - Electric driven, AC or DC HA - Hydraulic driven 0 No Swivel 2 1/2 (12) I.D. 3 3/4 (19) I.D. 4 1/2 (12) Dual 5 3/4 (19) Dual 6 1/4 (6.4) Dual 7 1 (.4) I.D. 8 1/2 Pressure Wash EA L 12 D X Swivel Size NOTE: This chart is for reference purposes only. Reels cannot be ordered by selectg fro this chart. Please see selection charts or consult anufacturer for additional odels not listed selection chart or for any questions about option cobations. Power Source Electric Current Type Explosion Proof X A A.C. D D.C. Electric Motor only Volt D.C. Volt D.C Volt A.C. Pressure Type 4A 1 1/2 hp (Air Motor) 6A 4 hp (Air Motor) Width of Spool L PSI (69 bar) M - 00 PSI (7 bar) 06-6 (0) Width of spool (0) Width of spool - (450) Width of spool - (560) Width of spool 28- ( ) Width of spool Refer to le drawg above SERIES 000 North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra

28 Wd Thgs Up With Reelcra PORTABLE HOSE REEL & CART Series Four possible handle adjustents. See chart. Hose Reel Cart Package APPLICATIONS Grounds Matenance Sports Turf/Athletic Fields Far & Ranch Pressure Wash Golf Courses Pest Control Nurseries/Orchards Resorts/Hotels C A B Orchard Ridge Country Club, Fort Wayne, Indiana A CONVENIENT PACKAGES: We ve ade it easy to select a coplete hose reel with cart or trailer fro the charts cluded on pages and. CART SIZE 12 5 / / Adjustable* B 3 / / 4 7 C 1 / / * Handle height of cart is adjustable to 35 5 /8 ", 38 5 / 8 ", 41 1 / 2 " or 44 1 / 2 " Eight 5/" (8 ) diaeter ountg holes Durable abrasion resistant baked on powder coat fish ½" diaeter steel axle 12 or width CAPACITY Up to 5/8 ID x 0 or 3/4 ID x 100 water hose HOSE REEL AND CART PACKAGES PACKAGE Rugged 1" square tubular steel frae High grade ball beargs, pregreased and sealed for longer service life, sooth rollg 8" seipneuatic or 8 ¾" pneuatic rubber tires ITEMS INCLUDE: (1) CA2 L : 12" hand crank hose reel with a 1/2" fluid path for 1/2" dustrial water hose or 5/8" garden hose. 0 feet capacity. (1) : 12" hand cart with pneuatic tires. (1) : 10' let hose with feale garden hose fittg and ale garden hose fittg for the outlet of reel. (1) CA2 L : 12" hand crank hose reel with a 1/2" fluid path for 1/2" dustrial water hose or 5/8" garden hose. 0 feet capacity. (1) : 12" hand cart with sei-pneuatic tires. (1) : 10' let hose with feale garden hose fittg and ale garden hose fittg for the outlet of the reel. (1) CA312 L : 12" hand crank hose reel with a 3/4" fluid path for 5/8" garden hose or 3/4" dustrial water hose. 100 feet capacity. (1) : 12" hand cart with pneuatic tires. 1) : 10' let hose with feale garden hose fittg and ale garden hose fittg for the outlet of the reel. (1) CA371 L : " hand crank hose reel with a 1" fluid path for 1" garden hose. 100 feet capacity (1) : " hand cart with pneuatic tires. (1) : 10' let hose with feale garden hose fittg. Male fittg not needed, reel outlet is 1.00" ale, N.P.T. EA371 L12D Note: Refer to pages and for Series diensions SPECIFICATIONS MODEL TYPE HOSE I.D. HOSE O.D. (F)NPTF REEL INLET CAPACITY WEIGHT PRESSURE / / / lbs / kg psi / bar CA371 L Hand Crank EA371 L12D Motor Driven CA3 L Hand Crank 3 / / EA3 L12D Motor Driven 3 / / Trailer only - does not clude reel or hose. Above reels fit trailer diensions. Trailer weight 4 lbs / 70 kg) All Series 000 reels supplied without hose. Asseblies quoted upon request. Inlet is NPTF (F) and atches swivel size. Outlet is 1 NPTF ale. CAUTION: To prevent dru daage fully extend and pressurize hose and rewd on the reel. North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Reelcra Industries is ISO 9001:00 Certified Sce 1996 Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

29 REEL & TRAILER HOSE CADDY Series Hand Crank & Motor Driven Series /4, 1 I.D. Hand Cart and Trailer Hose Caddy Reelcra s Series reels are designed for grounds atenance applications requirg up to 1 I.D. x 100 of hose and readily adapt to door or outdoor applications. Series reels are designed to fit on Reelcra s cart or trailer. Reels are shipped copletely assebled, ready to stall. Installation structions are cluded with each reel. Trailer, reel and accessories sold separately. CAPACITY 1 ID x 100 or 3/4 ID x 0 water hose Reel and Trailer Package Orchard Ridge Country Club, Fort Wayne, Indiana Trailer # shown (above) with reel odel EA371 L12D and accessories as follows: operatg switch, top and botto roller guides, battery box, battery connector, cha guard, 10 let hose and 1 I.D. by 100 hose. Order reel and trailer package # Reel and Trailer shown with optional accessories 5Five Key Benefits 1. Respond Faster React quickly and easily, reduce tangled hoses, power-rewd hose 2. Reduce Turf Daage Avoid turf wear and daage fro draggg hoses 3. Save Labor, Save Money Save labor by iprovg response tie, reduce hose wear by storg on a reel 4. Enhance Existg Syste Provide quick suppleental irrigation to enhance your existg syste 5. Save Equipent Eliate the need for a dedicated atenance vehicle TRAILER PACKAGES PACKAGE ITEMS INCLUDED (1) : Trailer (1) CA371 L: Hand rewd hose reel to handle 100 of 1 I.D. hose (hose not cluded) (1) : Roller Bracket, top wd (1) : 10 Lead hose (1) : Trailer (1) EA371 L 12D: Hose reel to handle 100 of 1 I.D., without hose (12V DC Motor) (1) S600808: Switch (coplete) (1) : Battery box (battery not cluded) (1) 6005: Cha guard (1) : Roller bracket, top wd (1) : Roller bracket, botto wd (1) : 10 Lead hose with 1 I.D APPLICATIONS Golf Courses Athletic Fields/Sports Turf Pest Control ADDITIONAL ACCESSORIES S Operatg switch Top hose roller guide Botto hose roller guide 6005 Cha guard Battery box (Battery not cluded) TRAILER DIMENSIONS Grounds Matenance Agricultural Nurseries Hotels, Resorts 6008 Battery cable connector Hose, 1 I.D. X NPT x 1 NPSH Hose, 3/4 I.D. X 0 3/4 NPT x 3/4 NH Inlet hose, 1 I.D. X 10 1 NPT x 1 NPSH Trailer designed for off-road use only, not for passenger transport. Maxiu weight capacity 400 pounds. Maxiu speed iles per hour. Trailer, reel and accessories sold separately. SERIES North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra

30 Wd Thgs Up With Reelcra POWER / MANUAL REWIND REELS NORDIC SERIES /2, 3/4 or 1 Fluid Path for 1/4 through 1 I.D. Hose REWIND: Direct crank rewd or cha and sprocket drive powered by A.C. or D.C. electric otor, copressed air otor or hydraulic otor. Crank is not supplied on power rewd odels. A p lock assebly is optional on anual rewd reels. INLET: ½ up to 1 feale/ale NPT 90 swivel jot. Straight swivel jot ay be specified at extra cost. GOOSENECK: ½ up to 1 feale/ale NPT. Other sizes and/or threads, cludg garden hose thread, can be furnished when specified. Product teperatures range fro - to +2 F and standard pressures to 1000 p.s.i. Other teperatures or pressures can be furnished at extra cost. Consult anufacturer. Series 1010 LARGE FRAME REELS Nordic Series 1010 The standard color for this series is red or gray. Note: Weights shown chart are for crank rewd odels. Add these aounts and odel nuber prefix for power rewd odels. Prefix Type LB / KG E Electric / 12 A Air / 11 H Hyd / 11 DIMENSIONS DIAGRAM E B E B G C G C H H D F A D A F HOSE I.D. HOSE O.D. MODEL 1/2 3/ /8 1 9/32 1 9/ HOSE LENGTH EST. WEIGHT SPECIFICATIONS - HOSE CAPACITY AND REEL DIMENSIONS A B C D LB KG ¼ ½ LB KG ¼ ½ LB KG 6¼ ½ LB KG 686 6¼ ½ LB KG ¼ ½ LB KG ½ ½ 495 ½ ½ LB KG ½ ½ ½ ½ LB KG ½ ½ ½ ½ LB KG ½ ½ ½ ½ Refer to page to build a coplete odel nuber. E CRK E ELC E AIR F CRK F ELC F AIR G H 28 North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

31 TWIN FLUID PATH Nordic Series 1010T/00T NORDIC SERIES 1010T ¼ or ½ Fluid Path for ¼ through ½ I.D. Hose REWIND: Manual disc rewd or cha and sprocket drive powered by A.C. or D.C. electric otor, copressed air otor, or hydraulic otor. INLETS: ¼ or ½ feale/ale NPT 90 swivel jots. Series 1010T GOOSENECK: ¼ or ½ feale/ale NPT. Other sizes and/or threads can be furnished when specified. The standard color for this series is red or gray. Reels can be chroe plated or ade fro aluu for fire and rescue operations. HOSE I.D. HOSE O.D. MODEL E DIMENSIONS DIAGRAM D H G HOSE LENGTH B A F 1/4 3/8 1/2 3/ /8 3/4 7/8 1 9/32 1 9/ C EST. WEIGHT NORDIC SERIES 00T ½, ¾ or 1 Fluid Path for ½ through 1 I.D. Hose REWIND: Gear-drive crank rewd with cha and sprocket drive powered by A.C. or D.C. electric otor, copressed air otor or hydraulic otor. INLETS: ½ to 1 feale/ale NPT 90 swivel jots. GOOSENECK: ½ to 1 feale/ale NPT. Other sizes and/or threads can be furnished when specified. The standard color for this series is red or gray. E D DIMENSIONS DIAGRAM SPECIFICATIONS - HOSE CAPACITY AND REEL DIMENSIONS A B C D 1010T LB KG ¼ ½ T LB KG ¼ ½ T LB 19 KG 6¼ ½ T LB KG ¼ ½ ½ 495 ½ ½ T LB KG ¼ ½ ½ 495 ½ 6 19½ T LB KG 6¼ ½ ½ ½ ½ T LB 33 KG ½ T LB 35 KG ½ T LB 40 KG ½ T LB 34 KG 8 3 ½ T LB 34 KG ½ 8 00T LB 36 KG ½ 8 00T LB 37 KG ½ 8 Refer to page to build a coplete odel nuber. E CRK H E ELC G E AIR F CRK B A F F ELC C F AIR Series 00T Shown with optional cha guard and otor. G H SERIES 1010 / SERIES 1010T & 00T North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra 29

32 Wd Thgs Up With Reelcra LARGE FRAME REELS Heavy Duty Solutions When a reel application requires strength and quality, it deands Reelcra s le of large frae reels. Our standard large frae products range size fro 1 I.D. up to 4 I.D. and we offer special products beyond 4. S40 Electric Motor Safety Guard Option The copact design of the recessed otor saves space and the optional drive cover shields the otor for iproved safety. The drive cover option is recoended to be copliance with ost safety standards. Passed Military Vibration for Truck Transport test. MIL-STD-810F 500,000 ile equivalent NEW! Reelcra s le of large frae reels offers a heavy duty, durable solution to your hose, cord and cable needs. Our welded steel fraes, cobed with an engeered swivel design and sturdy tie plates ake Reelcra s Diensional Flexibility Specify height, width and depth diensions to fit your space requireents. Custo configurations are built as standard orders just five workg days. Reversible goose neck large frae reels aong the ost dependable reels on the arket. Reelcra is known for supplyg engeered product solutions to answer your specific needs, gog well beyond standard catalog product. Series 40 Corrosion Resistance The spun edge design of the powder coated flanges, plus an aluu frae and zc-plated fasteners offer the greatest aount of corrosion protection and durability. Aluu and staless steel flanges are available upon request. Durable Lkage Drive Robust gear drive is less affected by heavy vibration and changes teperature. Oversized 1/2 cha drive also available as standard. Iportant Note: The catalog part nubers listed the chart are provided for your convenience. We can configure odels to your exact diensional needs as standard orders just five workg days. Contact Reelcra s custoer service departent with your specific specfications. Refer to the chart for paraeters. Patent Pendg Crush Resistant Spool Wrapper Spoke design offers greater strength and allows for hose flexg under pressure without spool distortion. Right/Le Front/Back Flexibility The otor, drive, crank and fluid path can be arranged to either side of the reel, front or back. T-Slot Aluu Frae T-Slots provide extra structural strength. Longer Life Self-lubricatg and self-aligng bearg provides longer service life. Breakthrough Technology! North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Reelcra Industries is ISO 9001:00 Certified Sce 1996 Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

33 LARGE FRAME REELS Nordic Heavy Duty Solutions Reelcra s Engeered Product Solutions Full Flow Design The goose neck is contoured to atch the dru diaeter, which allows sooth hose wrappg and unipeded flow. Long Service Life Swivel corporates a peranently lubricated ball bearg. Adjustable Hose Tension The brake can be adjusted to suit the application requireents. Trouble-Free Rewdg Cha and sprocket drive ensures sooth and consistent operation. PREFIX (POWER) Electric Explosion Proof Hydraulic Air Storage Manual E EP H A S Materials of Construction 1/2 P Sprockets Aluu Staless SERIES TTw TTw 00 00TTw TTw xx05 xx50 xx90 Passed Military Vibration for Truck Transport test. MIL-STD-810F 500,000 ile equivalent HEAD DRUM DIA. LENGTH Fro Chart or Special Calculations MISC. NORDIC SERIES HOSE SIZE SIZE SUFFIX 1/4 37 3/8 50 1/2 75 3/ /4 1-3/8 1-1/ / B Air Brake A 1 V AC J V DC X(nn) Special Dru Dia. Long Service Life The spool axial is supported by dependent self-aligng bearg. OPTIONS D90 BRZ BSP BW CH C CT F FF G H HP I N R SS Z(nn) Free Rotation While Pressurized The swg jot & spdle allows reel to freely rotate while fluid is pressurized. Precise Rigid Construction Proprietary unitized tie rods are zc plated offerg greater strength and resistance to vibration and corrosion. Ultiate Corrosion Resistance Individually powder coated coponents sure axiu coverage and resistance to corrosion. Staless steel fasteners are standard. 90 Inlet Bronze Fluid Path BSP Threads Botto Wd Chroe Plated Clutch Constant Tension Feale Gooseneck Feale In/Out Galvanized Heavy Duty Frae High Pressure Idler Inboard Motor Right Hand In/Out Staless Steel Fluid Path Special Reels SEE SPECIFICATIONS Exaple: EP3900--ASS EP(explosion proof otor)3900(series 3900 hose reel)--a(1v)(1-1/2 hose)ss(staless steel fluid path) LARGE FRAME REELS Heavy Duty Solutions North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra

34 Wd Thgs Up With Reelcra LARGE FRAME REELS Nordic Series 00 POWER / MANUAL REWIND REELS NORDIC SERIES 00 ½, ¾ or 1 Fluid Path for ½ through 1 I.D. Hose REWIND: Gear-drive crank rewd or cha and sprocket drive powered by A.C. or D.C. electric otor, copressed air otor or hydraulic otor. INLET: ½ up to 1 feale/ale NPT 90 swivel jot. Straight swivel jot ay be specified at extra cost. GOOSENECK: ½ up to 1 feale/ale NPT. Other sizes and/or threads, cludg ale NST and ale garden hose thread, can be furnished when specified. Product teperatures fro - to +2 F and standard pressures to 1000 p.s.i. Reels to operate at other teperatures or pressures can be furnished at extra cost. Consult anufacturer. Series 00 E DIMENSIONS DIAGRAM B The standard color for this series is red or gray. ADD 12 to E diension when crank is rewd position. G C Note: Weights shown chart are for crank rewd odels. Prefix Type LB / KG EP Electric 42 / 19 D H F A Add these aounts and odel nuber prefix for power rewd odels. A Air / 12 H Hyd / 12 HOSE I.D. 1/2 3/ HOSE O.D. 7/8 1 9/32 1 9/ SPECIFICATIONS - HOSE CAPACITY AND REEL DIMENSIONS MODEL HOSE LENGTH EST. A B C D E E E E F F F F WEIGHT CRK ELC AIR HYD CRK ELC AIR HYD G H LB KG ¼ ½ LB 34 KG 11 ¼ 686 ½ LB 35 KG 11 ¼ ½ LB 36 KG 11 ¼ ½ LB 38 KG 11 ¼ ½ LB 33 KG ¼ ½ LB 34 KG 11 ¼ 686 ½ LB 34 KG ¼ 32½ LB 35 KG ¼ 32½ LB 36 KG ¼ ½ 8 Refer to page to build a coplete odel nuber. 32 North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

35 LARGE FRAME REELS Series 40 FEATURES Standard straight ball bearg swivel jot with feale NPT threads and 2 victaulic groove. 90 swivel available, no extra charge. Hand crank, bevel crank, gear and cha drives chart. Also available as standard, explosion proof 12VDC, 1 AC, hydraulic and pneuatic otor. Powder coated steel flanges cluded, aluu also available as standard. Open spool spacer allows for easy access to reversible goose neck and open spool design allows for hose flexg under pressure without spool distortion. Plubg and otor shown on le side; however, any configuration is available as a standard order. Standard colors are powder coat red with black frae. Other colors available upon request. Max pressure: 600 psi. Standard seals axiu teperature 4 F (79 C) & iu teperature - F (-29 C). Extree teperature seals axiu teperature 400 F (4 C) & iu teperature -50 F (-45 C). Cha/gear guard is a recoended option, sold separately. Contact Reelcra for guard, switch and roller brackets. Shown with optional accessories: hose and roller bracket sold separately. Straight swivel is standard on Series 40 reels. 90 swivel available upon request. Series 40 Patent Pendg Also available standard drive types: Explosion proof 12VDC VDC 1VAC Pneuatic Motor Hydraulic Motor Auxiliary Bevel Crank Part Nuber Options LC Hose ID: 1 = 1 hose 2 = 1 ¼ hose 3 = 1 ½ hose 4 = 2 hose Drive Type: CG = Hand Crank BG = Bevel Crank (only) DH = 12VDC, Gear Drive EH = 12VDC, Cha Drive SPECIFICATIONS HOSE SERIES 41 SERIES 42 SERIES 43 SERIES CAPACITY / / / / HOSE I.D. 1 1 ¼ 32 1 ½ HOSE O.D. 1 9 / 40 1 / / / 65 DIMENSIONS MODEL HOSE LENGTH B E F Bevel F Electric G X / / / / / / / / / / LC ¾ 603 ¾ 654 ¾ LC ¾ ¾ 502 ¾ LC ¾ ¾ 7 ¾ LC ¾ 502 ¾ 552 ¾ LC ¾ ¾ ¾ LC ¾ 781 ¾ 781 ¾ LC ¾ ¾ 7 ¾ LC ¾ ¾ ¾ LC ¾ ¾ ¾ 578 Verify application diensions and weight requireents prior to orderg. Installation Note: For the warranty to be valid, a flexible connector MUST be used between the swivel and the let pipg. SERIES 00 / SERIES 40 North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra 33

36 Wd Thgs Up With Reelcra LARGE FRAME REELS Nordic Series 3900 POWER / MANUAL REWIND REELS NORDIC SERIES ½ Fluid Path for 1 through 1½ I.D. Hose REWIND: Gear-drive crank rewd or cha and sprocket drive powered by A.C. or D.C. electric otor, copressed air otor or hydraulic otor. INLET: 2 straight victaulic with 1½ feale NPT straight swivel jot is standard. 2 victaulic 90 with 1½ NPT feale available at extra cost. GOOSENECK: 1, 1¼ and 1½ feale/ale NPT outlet. Other sizes and/or threads can be furnished and ust be specified. ADD 12 to E diension when crank is rewd position. DIMENSIONS DIAGRAM E D Refer to page to build a coplete odel nuber. H G F A B C Series 3900 The standard color for this series is red or gray. Standard seals axiu teperature 4 F (79 C) and iu teperature - F (-29 C). Extree teperature seals axiu teperature 400 F (4 C) and iu teperature -50 F (-45 C) and standard pressures to 0 p.s.i. Other teperatures or pressures can be furnished at extra cost. Consult anufacturer. Note: Weights shown chart are for crank rewd odels. Add these aounts and odel nuber prefix for power rewd odels. Prefix Type LB / KG EP Electric 42 / 19 A Air / 12 H Hyd / 12 HOSE I.D /4 1 3/8 1 1/ HOSE O.D. 1 9/ 1 / 2 2 1/ SPECIFICATIONS - HOSE CAPACITY AND REEL DIMENSIONS MODEL HOSE LENGTH EST. A B C D E E E E F F F F WEIGHT CRK ELC AIR HYD CRK ELC AIR HYD G H LB 41 KG ½ LB 42 KG ½ LB 39 KG 12 5 ½ LB 45 KG ½ LB 43 KG ½ LB 45 KG ½ LB 47 KG ½ LB 50 KG ½ LB 40 KG 12 5 ½ LB 44 KG ½ LB 42 KG 5 32½ LB 44 KG ½ LB 45 KG ½ 8 34 North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

37 LARGE FRAME REELS Nordic Series 3700 POWER / MANUAL REWIND REELS NORDIC SERIES Fluid Path for 1½ through 2 I.D. Hose REWIND: Gear-drive crank rewd or cha and sprocket drive powered by A.C. or D.C. electric otor, copressed air otor or hydraulic otor. INLET: 2 straight victaulic is standard. 2 ale NPT straight swivel jot ay be specified at no extra cost. 2 victaulic 90 available at extra cost. GOOSENECK: 2 feale/ale NPT. Other sizes and/or threads can be furnished and ust be specified. Standard seals axiu teperature 4 F (79 C) and iu teperature - F (-29 C). Extree teperature seals axiu teperature 400 F (4 C) and iu teperature -50 F (-45 C). Standard pressures to 0 p.s.i. Series 3700 HOSE I.D. HOSE O.D. DIMENSIONS DIAGRAM E D 1 1/ / 2 9/ H G F B A C Other teperatures or pressures can be furnished at extra cost. Consult anufacturer. The standard color for this series is red or gray. ADD 12 to E diension when crank is rewd position. Note: Weights shown chart are for crank rewd odels. Add these aounts and odel nuber prefix for power rewd odels. SPECIFICATIONS - HOSE CAPACITY AND REEL DIMENSIONS Prefix Type LB / KG EP Electric 42 / 19 A Air / 12 H Hyd / 12 MODEL HOSE LENGTH EST. A B C D E E E E F F F F WEIGHT CRK ELC AIR HYD CRK ELC AIR HYD G H LB 52 KG ½ LB 56 KG ½ LB 58 KG ½ LB 62 KG ½ LB 61 KG ½ LB 64 KG ½ LB 67 KG ½ LB 83 KG ½ LB 86 KG ½ 1029 Refer to page to build a coplete odel nuber. SERIES 3900 / SERIES 3700 North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra 35

38 Wd Thgs Up With Reelcra LARGE FRAME REELS Nordic Series 5900 POWER / MANUAL REWIND REELS NORDIC SERIES or 4 Fluid Path for 2 through 4 I.D. Hose REWIND: Gear-drive crank rewd or cha and sprocket drive powered by A.C. or D.C. electric otor, copressed air otor or hydraulic otor. INLET: 3 straight victaulic is standard. 90 victaulic swivel jot available at extra cost. GOOSENECK: 3 feale NPT. Other sizes and/or threads can be furnished and ust be specified. Product teperatures fro -50 F to +400 F and standard pressures to 0 p.s.i. Other teperatures or pressures can be furnished at extra cost. Consult anufacturer. NOTE: 4 x 90 victaulic let, 4 feale NPT gooseneck and diaeter dru are standard on 4 reels. Series 5900 E DIMENSIONS DIAGRAM B The standard color for this series is red or gray. ADD 12 to E diension when crank is rewd position. G C Note: Weights shown chart are for crank rewd odels. Prefix Type LB / KG EP Electric 42 / 19 D H F A Add these aounts and odel nuber prefix for power rewd odels. A Air / 12 H Hyd / 12 HOSE I.D. HOSE O.D / / 3 3/ 3 3/4 4 3/ SPECIFICATIONS - HOSE CAPACITY AND REEL DIMENSIONS MODEL HOSE LENGTH EST. A B C D E E E E F F F F WEIGHT CRK ELC AIR HYD CRK ELC AIR HYD G H LB 41 KG ½ LB 42 KG ½ LB 39 KG ½ LB 42 KG LB 43 KG LB 45 KG ½ LB 47 KG ½ LB 50 KG ½ 1029 Refer to page to build a coplete odel nuber. 36 North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

39 LARGE FRAME REELS Nordic Series 5000 POWER / MANUAL REWIND REELS FIRE SERVICE - BOOSTER HOSE Nordic SERIES 5000 ½, ¾ or 1 Fluid Path for ½ through 1 I.D. Hose The ALUMINUM SERIES 5000 Reel for booster hose is corrosion resistant and weighs up to 50% less than standard steel booster reels. As it features an aluu spool and frae assebly, plated steel fluid path and plated sprocket and fasteners, it requires NO PAINTING OR FINISHING. REWIND: Gear-drive crank rewd or cha and sprocket drive powered by A.C. or D.C. electric otor, copressed air otor or hydraulic otor. Vertical and rewd echaniss are also available at extra cost. Series 5000 E D DIMENSIONS DIAGRAM H G F A B C INLET: 1 feale/ale NPT 90 swivel jot rated at 1000 p.s.i. Straight swivel jot ay be specified at extra cost. GOOSENECK: Standard 1 ale NST x 8 threads per ch. Other sizes and/or threads can be furnished and ust be specified. NOTE: Weights shown chart are for electric rewd odels. Add 12 to E diension when crank is rewd position. HOSE I.D. 1/2 3/ HOSE O.D. 7/8 1 9/32 1 9/ SPECIFICATIONS - HOSE CAPACITY AND REEL DIMENSIONS MODEL HOSE LENGTH EST. A B C D E E E E F F F F WEIGHT CRK ELC AIR HYD CRK ELC AIR HYD G H LB 34 KG ½ LB 34 KG 686 ½ LB 35 KG ½ LB 36 KG ½ LB 37 KG ½ LB 33 KG 8 3 ½ LB 34 KG 686 ½ LB 34 KG ½ LB 34 KG ½ LB 36 KG ½ 8 Refer to page to build a coplete odel nuber. SERIES 5900 / SERIES 5000 North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra 37

40 Wd Thgs Up With Reelcra LIQUID PROPANE REELS Series 40 / / D80000 Motor Driven Series 40-1 I.D. SHOWN: Series 40 Propane Reel Aluu with Electric Motor Easily reversible goose neck Standard all aluu or powder coated steel flanges* All otors are explosion proof Oversized ½ cha drive or durable gear drive available DRIVE TYPE OPTIONS Cha Drive XH 12VDC Explosion Proof XJ VDC Explosion Proof XA 1 VAC Explosion Proof HC Hydraulic Motor AC Air Motor Gear Drive MH 12VDC Explosion Proof MJ VDC Explosion Proof MA 1 VAC Explosion Proof HG Hydraulic Motor AG Air Motor 41 1L M 12 OPTIONS Flange/End Plate Material C Carbon Steel A Aluu Choose a reel odel fro the chart below, then use the suffx codes at le to choose a flange/ end plate aterial. Sprg Driven Series ½, ¾ I.D.s Series D I.D. OPTIONS Choose a reel odel fro the chart below, then use the suffx codes below to choose a flange/ end plate aterial. LP800 OL G E Two sealed ball beargs for sooth rotation of a sha Versatile guide ar is field adjustable Available staless or powder coated steel Contaerized sprg assebly for easy atenance Flange/End Plate Material S Staess Steel P Carbon Steel Y X F Series Staless steel With Full Circle swivel Hose not cluded Dual pedestal and guide ar support for structural strength Series Carbon steel With Full Circle swivel Hose not cluded SPECIFICATIONS MODEL HOSE I.D.HOSE O.D. CAPACITY PRESSURE WEIGHT B E F G X Y / / psi / bar lbs / kg / / / / / / SERIES / D80000: SPRING DRIVEN REELS LP800 OL * ½ / LP800 OL * ¾ / LPD800 OL * ¾ / / / ½ 7 LPD84000 OL * / / / ½ 7 SERIES 40: MOTOR DRIVEN REELS 41 1L M* 1 1¼ ¾ ½ L M* 1 1¼ ¾ ½ L M* 1 1¼ ¾ ½ L M* 1 1¼ ¾ ½ L M* 1 1¼ ¾ ½ L M* 1 1¼ ¾ ½ 368 * Choose drive type and flange/end plate aterial fro charts above. 38 North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Reelcra Industries is ISO 9001:00 Certified Sce 1996 Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

41 LARGE FRAME REELS Nordic Series 00/ POWER / MANUAL REWIND REELS LIQUID PROPANE SERVICE NORDIC SERIES 00 1½ Fluid Path for 1 through 1½ I.D. Hose Series 00 REWIND: Gear-drive crank rewd, or cha and sprocket drive powered by explosion proof A.C. or D.C. electric otor, copressed air otor or hydraulic otor. E D DIMENSIONS DIAGRAM H G F B A C POWER / MANUAL REWIND REELS DUAL PROPANE SERVICE NORDIC SERIES 1 through 1½ I.D. Liquid Hose ¾ through 1 I.D. Vapour Hose INLET: 1½ feale NPT 90 swivel jot, rated at 1000 p.s.i. Straight swivel jots available at no extra cost. GOOSENECK: 1 and 1½ feale NPT. Other sizes and/or threads can be furnished and ust be specified. Series 00 has a 2 fluid path for 1½ or 2 ID hose. Series cobes an electric rewd and a gear crank rewd reel on a sgle frae. The standard color for both series is red or gray. E D DIMENSIONS DIAGRAM HOSE I.D /4 1 1/2 2 1/2 3/ HOSE O.D. 1 9/ 1 / 2 1/ 2 9/ 7/8 1 9/32 1 9/ SPECIFICATIONS - HOSE CAPACITY AND REEL DIMENSIONS MODEL HOSE LENGTH Est. Weight A B1 B2 C D E F G H J LB 47 KG ½ LB 45 KG ½ LB 48 KG ½ LB 50 KG ½ LB 46 KG 686 ½ LB 48 KG ½ LB 51 LG ½ LB 46 KG ½ LB 52 KG ½ LB 98 KG ½ LB 103 KG ½ LB 111 KG ½ LB 112 KG ½ Refer to page to build a coplete odel nuber. HOSE CAPACITY - B HOSE CAPACITY - B1 H G J B1 C A F C B2 SERIES 40 & Liquid Propane / SERIES 00 & North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra 39

42 Wd Thgs Up With Reelcra LARGE FRAME REELS Nordic Series 3800 POWER / MANUAL REWIND REELS PETROLEUM SERVICE NORDIC SERIES ½ or 2 Fluid Path for 1¼ through 2 I.D. Hose REWIND: Cha and sprocket drive powered by A.C. or D.C. electric otor, copressed air otor or hydraulic otor. anual rewd assebly. INLET: 90 2 victaulic is standard. Straight swivel jots ay be specified at no extra cost. GOOSENECK: 1¼, 1½ or 2 feale/ale NPT is available. Specify ale or feale fittg and hose size when orderg. BRAKES AND LOCKS: Manual friction brake is standard. Air operated caliper brake is available at extra cost. F A DIMENSIONS DIAGRAM E D Series 3800 C HOSE I.D. HOSE O.D. B MODEL G H 1 1/4 1 3/8 1 1/ / 2 2 1/ 2 9/ HOSE LENGTH EST. WEIGHT Standard seals axiu teperature 4 F (79 C) and iu teperature - F (-29 C). Extree teperature seals axiu teperature 400 F (4 C) and iu teperature -50 F (-45 C). Standard pressures to 0 p.s.i. Other teperatures or pressures can be furnished at extra cost. Consult anufacturer. The standard color for this series is red or gray. SPECIFICATIONS - HOSE CAPACITY AND REEL DIMENSIONS A B C D E F G H LB 79 KG ½ 978 ¼ ½ LB 80 KG ½ 978 ¼ ½ LB 82 KG ½ 978 ¼ ½ LB 96 KG ½ 1105 ¼ ½ LB 97 KG ½ ¼ ½ LB 98 KG ½ 1105 ¼ ½ LB 81 KG ½ 978 ½ ½ LB 99 KG ½ 1105 ½ ½ LB 102 KG ½ 1105 ½ ½ 546 Refer to page to build a coplete odel nuber. 40 North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

43 LARGE FRAME REELS Nordic Series 6000 POWER / MANUAL REWIND REELS PETROLEUM SERVICE - SINGLE WRAP NORDIC SERIES ½, 2 or 3 Fluid Path for 1 through 3 I.D. Hose REWIND: Cha and sprocket drive powered by A.C. or D.C. electric otor, copressed air otor or hydraulic otor. INLET: 2 victaulic is standard. 90 swivel jots ay be specified at no extra cost. GOOSENECK: 1, 1¼, 1½ or 2 feale/ale NPT is available. Specify ale/feale fittg and hose size when orderg. BRAKES AND LOCKS: Air operated caliper brake and idler assebly is standard. Manual friction brake optional. NOTE: 3 straight victaulic let and 3 feale NPT gooseneck are standard on 3 reels. HOSE I.D. HOSE O.D. MODEL DIMENSIONS DIAGRAM E D H G HOSE LENGTH B A F 1 1 1/4 1 3/8 1 1/ / / 1 / 2 2 1/ 2 9/ 3 3/ 3 3/ C Series 6000 SPECIFICATIONS - HOSE CAPACITY AND REEL DIMENSIONS EST. WEIGHT MATERIALS: Standard frae and spool assebly are of heavy duty steel construction. Also available aluu. Standard seals axiu teperature 4 F (79 C) and iu teperature - F (-29 C). Extree teperature seals axiu teperature 400 F (4 C) and iu teperature -50 F (-45 C). Standard pressures to 0 p.s.i. Other teperatures or pressures can be furnished at extra cost. Consult anufacturer. The standard color for this series is red or gray. A B C D E F G H LB 6 KG ¾ 3 38½ ½ LB 9 KG ¾ 3 38½ ¾ 28¼ LB 1 KG ¾ 3 38½ ¼ 08 33¼ LB 8 KG ½ ½ LB 1 KG ½ ¾ 28¼ LB 4 KG ½ ¾ 46 34¾ LB 8 KG ½ ¾ 28¼ LB 6 KG ½ ¾ 46 34¾ 883 Refer to page to build a coplete odel nuber. SERIES 3800 / SERIES 6000 North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra 41

44 Wd Thgs Up With Reelcra Light/Mediu Duty Cord Reels Series LD, LG & LH NEW! Reelcra s new le of light and ediu duty cord reels are designed for less strenuous applications which a capable and long-lastg reel is required. These reels accoodate lengths of /3, /3, 12/3, and 10/3 diaeter cable. They help ake the workplace safe by keepg long electrical cords up and out of har s way. Series LD Cord Reels Reelcra s new light duty cord reel series is designed to provide oderate lengths of cable for light dustrial applications. These reels feature a powder coated steel housg, adjustable cable stop, and circuit breaker that can be reset. Ideally suited to be ounted overhead, these reels are copact and require little space. LIGHT DUTY CORD REELS MODEL CORD CORD SPECIFICATIONS WGT. VOLTS AMPS (with cable) ENDING AWG / Cond. No. Length / Type lbs / kg LD40 3 2* Style SJTW LD 3 9 Style SJTW LD 3 9 Style SJTW Designed for ceilg ount. *Requires a iu of five feet hangg cable (outside reel). LIGHT/MEDIUM DUTY CORD REELS Series LD, LG & LH NEW NEW NEW Style #8 watt fluorescent light features an on/off switch on the handle and an outlet. CORD OPTIONS Style #2 watt fluorescent light features a durable shock resistant lap holder and shatter-resistant tube with switch. Style #9 Triple outlet with grounded recepticles. For axiu ratgs consult anufacturer. Series LG Cord Reels The ediu duty dustrial cord reel series features longer lengths of heavier gauge cord. They are constructed fro high-ipact resistant coposite aterials to be light and copact. Their unique design allows the to be ounted overhead, on a wall, or detatched fro their ountg bracket akg the copletely portable. These reels also feature adjustable cable stop and circuit breaker that can be reset. MEDIUM DUTY INDUSTRIAL CORD REELS MODEL CORD CORD SPECIFICATIONS WGT. (with cable) VOLTS AMPS ENDING AWG / Cond. No. Length / Type lbs / kg LG50 3 8* Style SJTW LG Style SJTW 1 7 LG Style SJTW 1 7 *Requires a iu of five feet hangg cable (outside reel). Series LH Hand Crank Reels Made with the contractor d, these ediu duty hand crank reels are copletely portable and deliver power where and when it is necessary. Four circuit breaker protected outlets are built to the reel itself. Steel coponents are powder coated for axiu corrosion resistance. MEDIUM DUTY HAND CRANK REELS MODEL CORD CORD SPECIFICATIONS WGT. VOLTS AMPS (with cable) ENDING AWG / Cond. No. Length / Type lbs / kg LH Outlets SJTW LH00* 4 Outlets STW *Does not clude cable Products on this page are warranted for 90 days. NEW NEW NEW NEW NEW LD 3 9 LG LH00 LD LG LH North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Reelcra Industries is ISO 9001:00 Certified Sce 1996 Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

45 Better by Design Adjustable Buper Stop Allows any desired length of cord to be ataed outside the reel Corrosion-Resistant Steel coponents are dividually powder coated to virtually eliate corrosion Reelcra offers eight styles of outlets and laps Sgle receptacle Duplex outlet box w/ GFCI (F) - 2 styles available R.V. plug Fluorescent - 2 styles available Incandescent - 2 styles available Easy to Mount Attaches to ost structurally sound surfaces. Edges are curved for safety. NOTE: Swg brackets should be used if cords are pulled at ore than 45, see page 53. MODEL NUMBER SIGNIFICANCE This chart is for reference purposes only. Reels cannot be ordered by selectg fro this chart. Please see Selection Charts on pages or consult anufacturer for any questions about option cobations. BUMPER ASSEMBLIES FOR CORD REELS PART OUTSIDE DIA. CORD SPECIFICATIONS NUMBER OF CORD AWG / 2 # Cond. Type SJO 1-HR1004-A SJO SO 1-HR SO 3-HR SO POWER CORD & LIGHT REELS Adjustable Guide Ar Multiple guide ar positions for versatile uses and easier field adjustent SERIES 4000 & 5000 CORD REELS L LATCH TYPE L = LATCHING C = CONSTANT TENSION REEL SERIES 40 = 4000 SERIES REEL 45 = 4500 SERIES REEL 55 = 5500 SERIES REEL 57 = 5700 SERIES REEL CSA CERTIFIED UL LISTED WIRE SIZE 10 = 10 GAUGE 12 = 12 GAUGE = GAUGE LENGTH OF CORD 00 = W/O CORD 35 = 35 FEET 45 = 45 FEET 50 = 50 FEET NO. OF CONDUCTORS 2 = TWO CONDUCTOR 3 = THREE CONDUCTOR Series 4000 & 5000 Enclosed Drive Sprg Drive echanis is enclosed for protection agast the environent Long Life Drive Sprg Declutchg arbor virtually eliates possibility of sprg daage due to reverse wdg of reel spool Structural Strength Robotically welded heavy gauge steel frae FOR REFERENCE ONLY STYLE NUMBERS NONE. OPEN END 1 = INCANDESCENT LAMP 2 = FLUORESCENT LAMP 3 = SINGLE RECEPTACLE 4 = R.V. PLUG (M) 5 = INCANDESCENT NON-SPARKING 6x = FLUORESCENT EXPLOSION PROOF 7 = DUPLEX OUTLET BOX (F) W/GFCI 8 = FLUORESCENT W/OUTLET SERIES LD, LG & LH / ELECTRIC CORD REELS North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra 43

46 Wd Thgs Up With Reelcra POWER CORD & LIGHT REELS Series 4000 & 5000 Style #7 Metal outlet box with dual AMP receptacles and GFCI protection with flip-top lid. POWER SOURCE STYLE OPTIONS Style #4 Male rubber plug used with recreational vehicles (RV's). Style #3 Two Options #6009 Sgle AMP receptacle with clap type stra relief. (Cord size - AWG) Sprg retractable with latch Copact for critical space requireents Durable abrasion and corrosion resistant baked-on powder coat fish Wall, ceilg or bench ount Engeered for dustrial use All odels supplied with cord are coplete with approxately 4-5 foot pigtail and three-prong plug Adjustable cord stop The GFCI Receptacle is designed to protect people fro the le-to-ground shock hazards which could occur fro defective power tools or appliances operatg fro this device or fro down le outlets protected by it. #6001 Style #3A Sgle AMP Sgle AMP receptacle. receptacle with clap type stra relief. (Cord size - 12 AWG) Style #3B Sgle AMP receptacle with twist lock connector. The Ground Fault Circuit Interrupter does not protect agast short circuits or overloads. This is the function of the fuse or circuit breaker. DIMENSIONS L4000 L4500 L5000 L5400 L5500 L5700 / / / A 1 / / / B 12 5 / / / C / / 4 8 D 2 1 / / / 2 64 E 9 3 / / / 2 * 8 Series 4000 and 5000 odels have four 5/" diaeter ountg holes. F / / / 8 54 Series L5700 E diension is 12 1 / 2. * Series L5700 E diension is 12½ L POWER CORD & CABLE REEL SELECTION CHART For door non-weather tight applications only MODEL ACCESSORY CORD SPECIFICATIONS VOLTS AMPS WEIGHT AWG / 2 No. Length Cond. / Type * lbs / kg L Sgle Receptacle SJTOW 1 10 L Sgle Receptacle SJTOW 1 12 L Sgle Receptacle SJEOW 1 28 L Sgle Receptacle STOW 1 47 L A Sgle Connector SJEOW 1 29 L B Twist Lock Connector SJEOW 1 29 L R.V. Plug SO L R.V. Plug SO Duplex Outlet Box L A w/gfci (F) SJEOW 1 28 L Duplex Outlet Box w/gfci (F) SJEOW 1 ** 29 L Duplex Outlet Box w/gfci (F) STOW 1 ** 47 *All odels UL listed at 1 Volt 60 HZ sgle phase. Base power cord reels without cord ends are suitable for 2V. **Inlet plug is NEMA5-P configuration. Plug ends not set up for ap. NOTE: Swg brackets should be used if cords are pulled at ore than 45, see page 53. L L 5700 UL LISTED CSA CERTIFIED POWER CORD & CABLE REEL SELECTION CHART For door non-weather tight applications only MODEL ACCESSORY REEL CAPABILITIES sold w/o cable VOLTS AMPS WEIGHT AWG / 2 No. Length Cond. * / Type lbs / kg L 4000 Reel w/o electric cord SJO 1 10 L 4100 Reel w/o electric cord SJO 1 10 L 4500 Reel w/o electric cord SJO 1 9 L 5000 Reel w/o electric cord SO L 5400 Reel w/o electric cord SO 1 12 L 5500 Reel w/o electric cord SO 1 34 L 5700 Reel w/o electric cord SO L 7000 Reel w/o electric cord SO *All odels UL listed at 1 Volt 60 HZ sgle phase; suitable for 2 V. For door use only. 44 North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Reelcra Industries is ISO 9001:00 Certified Sce 1996 Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

47 POWER CORD & LIGHT REELS Series 4000 & 5000 Fluorescent Light Style #2 Durable shock absorbg lap holder Shatter-resistant tube with switch Style #8 One foot #/3 conductor SJTOW-A yellow cord with olded NEMA 5-P plug 1v-ap receptacle is located le on cord SAF-T-TIE keeps the light plugged to receptacle Scratch guard protects lap cover Order odel Illuate your work area with retractable lights L LIGHT STYLE OPTIONS Style #6 Explosion Proof watt fluorescent hand lap Autoatic on/off switch at reel guide ar Suitable for Class 1, group C & D locations Note: Reel is not explosion-proof. Incandescent Hand Laps Style #5 Rubber handle with vyl-coated cage W/O switch or receptacle Autoatic on/off switch at reel guide ar Coplies with NEC #511-3,f., portable lightg equipent. Meets OSHA Style #1 requireents. Sgle receptacle tool tap Push-through switch Metal grounded guard. UL LISTED CSA CERTIFIED Auto-Switch Light Cord Reels Models equipped with an autoatic on/off switch corporate a guide ar ounted switch that activates power with a pull of the cord. LIGHT CORD REEL SELECTION CHART For door non-weather tight applications only MODEL ACCESSORY CORD SPECIFICATIONS VOLTS AMPS WEIGHT AWG / 2 No. Length Cond. / Type * lbs / kg L *Incandescent SJTOW 1 10 L *Incandescent SJTOW 1 11 L 4035 A3 5** *Incandescent SJOW 1 12 L 55 A3 6X** Fluorescent SEOW L Fluorescent SJTOW L Fluorescent SJTOW L Fluorescent Light & Outlet SJTO L Fluorescent Light & Outlet SJTO * Incandescent bulb 75 watt axiu. All odels UL listed at 1 Volt 60 HZ sgle phase. Base power cord reels without cord ends are suitable for 2 V. For door use only. See accessories page for optional ountg brackets and bases. **Models are equipped with autoatic on/off switch that activates power. NOTE: Swg brackets should be used if cords are pulled at ore than 45, see page 53. ON OFF L 55 A 3 6X L L Note: Reel is not explosion proof Five retractable light cord options Illuate your work area with candescent, fluorescent or explosionproof hand laps POWER CORD & CABLE / ELECTRIC LIGHT CORD North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra 45

48 Wd Thgs Up With Reelcra HIGH CAPACITY CABLE REELS NORDIC SERIES CR1010/CR00/CR00/CR4800 for 3-conductor service REWIND: Direct crank rewd or cha and sprocket drive powered by A.C. or D.C. electric otor or copressed air otor. Series CR crank is not supplied on power rewd odels. Series CR00 - an adjustable sprg drag device is used to brake the reel. Series CR00/CR powered by a rugged sprg protected by a taperproof housg, a rachet echanis locks on payout of cable, but is easily disengaged with a pull to provide rewd. CABLE ROLLERS: All odels supplied with a 4-way roller guide assebly. Roller position ust be specified. If not specified, botto wd will be supplied. Can be supplied or stalled. Consult anufacturer. LARGE FRAME REELS Nordic Series CR Series CR4800 Series CR1010 CABLE STOP: A hose/cable stop should be used to prevent daage to rollers and to perit adjustent of free cable length. Many ore sizes, fro standard coponents, available on request. Consult anufacturer. DIMENSIONS DIAGRAM E G B C E G B C E G C B H H H D J A F D CR00 / CR4800 CR1010 CR00 A F D A F MODEL NO. Gauge / No. of Conductors /3 /3 12/3 10/3 8/3 Cable O.D. Inches and Millieters SPECIFICATIONS - HOSE CAPACITY AND REEL DIMENSIONS F diension based on 3 conductor slip rg. See nuberg syste on page for coplete part nubers. MODEL HOSE LENGTH EST. WEIGHT A B C D E E PWR F F PWR Less Motor G H J SPRING DRIVEN REELS CR LB 42 KG ½ 6 3 CR LB 44 KG ½ CR LB 54 KG 9¼ ½ ½ 876 HAND CRANK / MOTOR DRIVEN REELS CR LB KG ¼ CR LB KG ¼ CR LB 33 KG ½ 6 3 CR LB 36 KG ½ 8 Refer to page to build a coplete odel nuber. 46 North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

49 Heavy Duty Cord & Cable Storage Reels Series 000 Reelcra has expanded its Series 000 platfor to clude power cord and cable storage reels. These reels are designed to handle long lengths of 10/3, 12/3, and /3 cable. Cable storage reels are available hand crank only, while the power cord reels are available either bevel crank, hand crank, or electric otor driven rewd. These dustrious reels are constructed of heavy-gauge steel and assebled with vibration-proof, self-lockg fasteners to ensure assebly tegrity. They undergo a five-stage cleang process and are dividually powder-coated for the highest quality pat adhesion, which results a durable, unifor fish that protects and beautifies. Safety - Keeps long lengths of expensive electrical cord off the ground and out of har s way. Corrosion Resistant - Baked-on powder coat fish akes it nearly ipervious to the perils associated with dustrial use. NEW NEW SPECIFICATIONS MODEL (without cable) CA106-CS CA112-CS DRIVE TYPE Hand Crank Hand Crank HEAVY DUTY CORD REELS Series 000 NEW! CORD SPECIFICATIONS VOLTS AMPS AWG / ² No. Length Cond / This reel is for cable storage only. Not tended to be live This reel is for cable storage only. Not tended to be live. LE2 1 12D DIMENSIONS CA106-CS CA112-CS LB2 1 LB2 103 LC2 103 LC2 103 LE2 1 12D LE D / / / / / A B 9¾ 8 ¾ 400 ¾ 400 ¾ 400 ¾ 400 C D N/A N/A ¾ 603 ¾ 603 ¾ 603 Four 1/2 ch (12.7) diaeter ountg holes. E ¼ / WEIGHT lbs / kg LB2 1 Bevel Crank LB2 103 Bevel Crank LC2 1 Hand Crank LC2 103 Hand Crank *LE2 1 12D *Motor Driven *LE D *Motor Driven NOTE: Cord ust be fully unspooled before use. Actual fill capacities vary with cord O.D. and jacket type. Consult anufacturer for applications requirg cord types other than SO, SOW, or SJO. Reel suited for door, non-weather tight applications only. Power source ust be disconnected while reelg/de-reelg. Through sha on cable storage reels facilitates cable sizes up to.969 O.D. for other sizes, consult anufacturer. *All otor driven odels are 12 volt DC non-explosion proof. Other otor options available upon request. NEW NEW NEW NEW NEW NEW CA112-CS NEW! SERIES CR / HEAVY DUTY CORD REELS SERIES 000 North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra 47

50 Wd Thgs Up With Reelcra SPRING DRIVEN Oxygen/Acetylene/Fuel Most Copact Ideal for locations where space is liited NEW TW54 OLP Bevel Crank Longest hose lengths up to 0 BA36 L APPLICATIONS Workshop Industrial Weldg Trucks Autootive Construction Equipent Railroads Cranes Bridge Builders Crane Riggers Mobile Service Agricultural Mg (above ground) DUAL HOSE REELS FOR OXYGEN/ACETYLENE AND OXYGEN/FUEL GAS APPLICATIONS TW5000 O TW7000 O BA36 L BA36112 L TW80000 O / / / / / A 1 / / / / / B 3 / / / C 9 3 / / D 2 1 / / / / E / / Model TW5000 O has 5/" (8) diaeter ountg holes. TW7000 O has 1/2" (12.7) ountg holes and the TW80000 has 1/2" (12.7) diaeter ountg holes. Acetylene (red) let 1/4" FPT / oxygen (green) let 1/4" FPT. TW80000 odels lets are 9/" (.28). MODELS WITH HOSE HOSE CAPACITY MODELS WITHOUT HOSE MODEL WEIGHT PRESSURE I.D. O.D. LENGTH MODEL WEIGHT lbs / kg psi / bar / / / lbs / kg OXYGEN/ACETYLENE REELS TW54 OLP 0 1 / TW5400 OLP 9 STW3450 OLP / TW7450 OLP / TW7400 OLP TW7460 OLP / TW7400 OLP SERIES 000 HAND CRANK 1 / BA36L 50 SERIES 000 HAND CRANK 1 / BA36112L 57 WELDING GAS (T-GRADE) REELS TW54 OLPT 0 1 / TW5400 OLPT 9 TW7450 OLPT / TW7400 OLPT TW7460 OLPT / TW7400 OLPT TW84100 OLPT / TW84000 OLPT TW86075 OLPT / TW86000 OLPT Acetylene and fuel gas (red) let 1/4" FPT / oxygen (green) let 1/4"FPT.TW84000 and TW86000 have B size 9/" - UNF ale weldg lets. 90 Straight MODEL NO. HOSE INLET CONNECTING FITTINGS - OPTIONAL INLET CONNECTION FITTINGS S0090 ACETYLENE Bsize 9/ - LH (M) x 1/4" NPT (M) S0091 OXYGEN Bsize 9/ - RH (M) x 1/4" NPT (M) 71 OXYGEN Bsize 9/ - RH (M) x 3/8" NPT (M) 72 ACETYLENE/fuel gas - Bsize 9/ - LH (M) x 3/8" NPT (M) Hose supplied on oxygen/acetylene reels is tw-siaese type eetg R.M.A. and C.G.A. type V.D., grade RM specifications. For foration on weldg cable reel see page 50. NOTE: Reels without hose. Model Series TW5400 OLP, TW 7400 OLP, TW OLPT and TW OLPT are U/L listed #70H2. UL LISTED In a hurry? We can ship sae day! See page 57 for a coplete list of our Quick Ship reels 48 North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Reelcra Industries is ISO 9001:00 Certified Sce 1996 Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

51 FEATURES COMPLETE WELDING SERIES Series TW & BA NEW! Designed to crease safety the work area with a resultg crease productivity and efficiency Full flow sha swivels Independent dual swivel body anufactured fro aluu and hard coated for wear resistance assures positive separation of gases due to its unique design Double-sealed, "O" rgs prevent leakage Swivel body and let are both peranently identified with ached groves on the acetylene side to assure proper stallation Durable abrasion and corrosion resistant baked-on red powder-coated fish Reel frae, spool and dru are fabricated of heavy gauge steel Teperature operatg range - F / -29 C to +0 F / +1 C Econoical Lightweight for hose lengths up to 50 UL LISTED TW7450 OLP STW3450 OLP *See page for additional details. Most Popular Sprg driven for hose lengths up to 60 "T" grade hose reels are used for a wide variety of gases such as app gas, propane gas, natural gas and fuel gases. Dual swivel is an exclusive Reelcra design Independent dual swivel body anufactured fro aluu and hard coated for wear resistance. Assures positive separation of gases due to its unique design. Double - sealed, special olded "O" rgs prevent leakage. Swivel body and let are both peranently identified with ached grooves on the acetylene side to assure proper stallation. Available with TW 5000 & TW 7000 series reels. High Volue Dual weldg, sprg driven for high volue of gas "T" GRADE FUEL GAS REELS When orderg any weldg hose reels you ust specify the type of gas beg used. UL LISTED Available T grade only TW84100 OLPT To order "T" Grade reels, add a suffix "T" to the TW Models. Exaple - TW 54 OLPT. SERIES TW & BA North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra 49

52 Wd Thgs Up With Reelcra WELDING CABLE Series CEA & Series WC CEA006 Hand Crank Series CEA Designed to crease safety the work area with a resultg crease efficiency and productivity Weldg cable reels store work lead or electrode lead, up to #2/0, safely and effectively when not use. Each lead requires a separate reel. When weldg also refer to ANSI/Asc Z 49.1 Cable reels have a current path through a contuous 400 AMP, 90VDC (axiu) rated enclosed slip rg Stores cable when not use eliatg tangled, kked weldg cables Matas proper bend radius of cables - providg longer cable life Keeps work area and vehicles better organized resultg better space utilization WC80000 Caution: If cable reels are to be used for extended periods of tie, unwd all cable fro reel to prevent heat build-up. For door non weather-tight applications only. Shown with electrode, clap and cable (not cluded) APPLICATIONS Steel Mills & Foundries Metal Workg and fabrication Auto / Truck Service Power Generation and transission Agricultural Railroads Mg (above ground) WC7000 Sprg Driven Series WC FEATURES All bolted heavy gauge steel construction provides long life and ease of use and atenance. Manual dru lock prevents spool fro turng when not use preventg unwanted pay out of cable. SPECIFICATIONS All reels sold without cable MODEL REEL CAPACITY WEIGHT CABLE SIZE #2 ( 2 ) #1 (39 2 ) #1/0 (50 2 ) #2/0 (62 2 ) / / / / lbs / kg CEA CEA * 2 500* WC WC WC *May exceed axiu cable length allowable for ost weldg applications NOTE: Each cable requires separate reel. WC DIMENSIONS WC7000 WC80000 / / A ¼ / B C 7 7 / D 3 7 / Four 1/2 ch (12.7) diaeter ountg holes. E ¾ CEA DIMENSIONS CEA006 CEA012 / / A B 9¾ 8 ¾ 400 C 11 9 D 381 Four 1/2 ch (12.7) diaeter ountg holes. E North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Reelcra Industries is ISO 9001:00 Certified Sce 1996 Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

53 Safe-T-Reel Series Up to 0 fuel gas Up to 0 12/3 cable Ideal for applications where space, weight and flexibility are key, these reels are designed for anual wdg of air/water/fuel gases hose, electric cord and weldg cable. Versatile function, select configurations to suit specific needs. Safe-T-Reels offer trouble-free anageent of large capacities of hose or cord. SINGLE SPOOL REELS MODEL REEL AMP CAPACITY WEIGHT CABLE A B E / lbs / kg AWG/Cond / / / SINGLE WELDING CABLE 600 V T ¼ 4 SINGLE POWER CABLE - 3 CONDUCTOR T / ¾ 400 T * / ¾ 400 T * / ¾ 400 T * / ¾ 400 T * / ¾ 400 * cludes cable DUAL SPOOL REELS REEL MODEL AMP CAPACITY WEIGHT A B E / lbs / kg / / / DUAL SIDE-BY-SIDE WELDING CABLE (2) 600 V T DUAL SIDE-BY-SIDE POWER CABLE / AIR HOSE T * 35 0 / 0 39½ DUAL STACKED WELDING CABLE (2) 600 V T-64-O ¼ 4 * Air hose side has ½ (12.7) let SINGLE SPOOL REELS MULTI CONFIGURATIONS Safe-T-Reel Series T-62-0 Dual Spool Side-by-side cobations Hose and cable not cluded. Detail of our heavy duty sha with tapered roller bearg for high rigidity MODEL HOSE I.D. HOSE O.D. CAPACITY WEIGHT PRESSURE A B E / / / lbs / kg / / / / SINGLE AIR/WATER Maxiu teperature 0 F (65 C) T ½ ½ ¾ 400 T ½ ½ ¾ 552 T ¾ ¾ 400 T ¾ ¾ 552 SINGLE OXYGEN-ACETYLENE T-GRADE SEALS Maxiu teperature 0 F (65 C) T ¼ / T T ¼ / T / / Dual Spool Stacked cobations Sgle Spool T T Sha sizes are 1 to 1. diaeter, supported by tapered roller beargs with 2 to 2.3 housgs. T-64-0 DIMENSIONS MODEL C D ches T-11 / T ½ T-12 / T ½ T-60 / T ½ T-11 / T ½ T ½ T ½ T ½ All reels have four ½ ( ) diaeter outg holes Caution: Copressed air hoses should not be converted to oxygen service. Copressed air hoses are oen contaated with an oil coatg, which can react explosively when oxygen is troduced. Oxygen/Acetylene cannot be cobed with weldg cable or power cord. Note: Models listed are without hose and/or cable. Weights listed above are actual product weight without packagg aterials. Safe-T-Reels are available with cable or hose and various cobations. Please consult Reelcra custoer service for additional foration. A A A B C B C B C D E C E D D E C D C SERIES CEA & WC / SAFE-T-REEL SERIES North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra 51

54 Wd Thgs Up With Reelcra TOOL BALANCERS Mediu & Heavy Duty TOP FIVE BENEFITS 1. Balances the weight of assebly tools akg the nearly weightless 2. Reduces operator fatigue 3. Iproves safety and ergonoics 4. Increases productivity, keeps tools positioned for iediate use with ial operator otion 5. Reduces tool daage, prevents tools fro beg accidentally dropped SERIES TB 1-5 DIMENSIONS ALL DIMENSIONS IN INCHES () Mediu Duty TB 1-5 SAFETY CLIP 11 Bright zc plated steel safety latch for tool attachent and other uses. Measures 2.375" (60) long. Included with each odel. Heavy Duty TBL 10- Tool balancers ake tools nearly weightless, reduce fatigue TOOL BALANCERS Mediu Duty Selection Chart MODEL MIN - MAX LOAD CABLE LENGTH* REEL WEIGHT lbs / kg / lbs / kg TB TB TB *Cable lengths listed are "active" or "workg" cable. Safety tool clip and cable stop cluded. TOOL BALANCERS Heavy Duty Selection Chart MODEL MIN - MAX CABLE REEL RATCHET LOAD LENGTH* WEIGHT LOCK lbs / kg / lbs / kg Constant pull reels - ay be adjusted to balance through 6-. (2-) range. TB NO TB NO TB NO TB NO Reels with ratchet lock - retract tool upward when anually released TBL YES TBL YES TBL YES TBL YES *Cable lengths listed are "active" or "workg" cable. Safety tool clip and cable stop cluded. TB 10- DIMENSIONS ALL DIMENSIONS IN INCHES () OPTIONAL ACCESSORIES Cables can be cobed for added length OVERHANG CABLE MODEL NO. LENGTH / 91.5 c / 2.4 c SAFETY CABLE/CHAIN MODEL NO. LENGTH * 1.0 /.5 c ** 1.0 /.5 c * Nylon covered steel cable (1 to 5 lbs odels) ** Steel lk cha (10 to lbs odels) Strongly recoended, secondary steel cable or steel lk cha. Prevents balancer fro accidental fall. Balancers have extra holes for cable or cha. Nylon covered steel cable with safety clip. Brgs tools closer to work area without unwdg cable fro reel or ountg reel at lower height. 52 North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Reelcra Industries is ISO 9001:00 Certified Sce 1996 Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

55 REEL ACCESSORIES HR 1059 HR S Operatg switch Top hose roller guide Botto hose roller guide ROLLER HOSE GUIDE ASSEMBLIES MODEL ACCOMMODATES WEIGHT DIMENSION NUMBER HOSE O.D. A B C D E F () lbs / kg / / / / / / HR () () / / / / / 29.8 N/A HR (6.4) -.6 (.9) / / / / / 29.8 N/A HR.603 () () / / / / S () (50.8) / / / () (34.9) / / / / These four-way roller guide asseblies are for use with reels on cabet door opengs and for siilar locations where sharp edges ay cut or daage the hose, four-way design perits pullg or retractg hose at any angle. Model S0109 has nylon rollers ounted on an 11 gauge steel frae with pre-drilled ountg holes. ADDITIONAL ACCESSORIES 340 PIVOT BASE Aligns reel to the direction of hose or cord run. May be ounted with reel upright or hangg. Weight 10 lbs. (5kg). Note: Use if hoses or cords are pulled at ore than 45. WALL-MOUNTED UNIVERSAL SWING BRACKET Bracket will pivot approxiately 0. All steel construction with a durable baked on powder coat fish. Weight 6 lbs (3kg). Note: Use if hoses or cords are pulled at ore than 45. Note: Not for overhead ountg. ADDITIONAL SERIES 000 ACCESSORIES 6005 Cha guard Battery box (Battery not cluded) 6008 Battery cable connector Hose, 1 I.D. X Hose, 3/4 I.D. X Inlet hose, 1 I.D. X 10 Note: A hose buper should be used with the four-way roller hose guide asseblies to prevent daage to rollers and nozzles. See chart on page 55. FOR REEL SERIES PART # RT / 4000 / 5000 / 5005 / / D80000 / FOR REEL SERIES PART # RT / RT / 4000 / 5000 / 5005 / / D TOP MOUNTING CHANNELS & BEAM CLAMPS Top channel & bea claps -for one reel Top channel & bea claps -for two reels For ountg Series 4000 through 7000 reels to I-bea or overhead support. Mountg channels can be ounted end to end to ount three or ore reels Adaptor Assebly Channels are designed to accoodate Series 7000 reels. Adaptor #6000 perits the ountg of Reelcra Series 4000, 5000, 5005, electric cord reels and ReelTek on ountg channel. Used with top channels and bea claps only. ROLLER GUIDE ASSEMBLIES Spools and blocks are zc-plated to resist corrosion and abrasion. Rollers speed handlg and reduce wear on hose. All pated parts are fished with durable abrasion resistant baked-on powder coat. Delr bearg surfaces give a quiet operation with iu wear and all features cobe to give trouble-free axiu service life. Hose Reel Spool Size Botto Wd Roller Bracket Assebly Model Nuber Top Wd Roller Bracket Assebly Model Nuber / Series Four Way Rollers Multi Position Roller Bracket Assebly Model Nuber 6 3 S S S S S S S S S600-3 S S S S S S600-5 Series Three Way Rollers 6 3 S S S S S S S S S S Botto wd and top wd ay be used with all odels except bevel crank. Multi position ay not be used on odels with a cha guard or series reels. Four- way rollers (ulti-position) Three-way rollers ACCESSORIES / SERIES TB North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra 53

56 Wd Thgs Up With Reelcra REEL ACCESSORIES S04 OPERATING SWITCHES For 1 and 0 volt DC reel otors. Push button switch with 10 AMP fuse. Used for otor #S For 1 and 0 volt DC reel otors. Push button switch with 10 AMP fuse and adjustable speed control. Used for otor #S Adjustable speed control only. To be used a syste which already has a switch. Used for otor #S / VDC speed control. Used for otor #S0409, S0583, 0450 and S Push-button switch. Used for all 12 or volt reel otors #S0409 and 0450; up to 1/3 h.p. S switch when packaged with ountg bracket. Used for otor #S0409 and Push-button switch. Used for all 12 or volt reel otors #S0583 and S06; up to 2/3 h.p. Reels are equipped with REWIND electric or copressed air MOTORS otors to drive cha and sprocket rewd echaniss. ELECTRIC MOTORS S0409 Reversible type, 12 Volt D.C. 1/3 HP Reversible type, Volt D.C. 1/3 HP. S04 Reversible type, sgle phase, explosion proof, Class 1 Group D, 1 volt A.C. 1/2 HP. An explosion proof, Class I Group D junction box is available for wirg A.C. otors. #04. S06 Volt D.C. 2/3 HP. Electric otor reversible type. Explosion proof. S Volt D.C. 2/3 HP. Electric otor reversible type. Explosion proof. HYDRAULIC MOTOR RPM, 668 lb-, 00 psi terittent 00 psi contuous. S S Switch, speed control with AMP circuit breaker. Used for otor #S0409; up to 1/3 h.p Switch, speed control with 40 AMP circuit breaker. Used for otor #S0583; up to 2/3 h.p. S04 40 AMP circuit breaker. Recoended for use with D.C. electric rewd otors. Manual reset, push-button ust be pressed firly to reset. S04 Startg solenoid, 12 volt D.C. for activation of otor. AIR MOTORS AM delivers up to 1 1/2 horsepower, 1/4" N.P.T. (F) let AM delivers up to 4 horsepower, 1/2" N.P.T.F. (F) let. ADDITIONAL ACCESSORIES S6005 Optional cha shroud for series 000 reels Sealed push-button oentary contact switch with rubber cap. For 12 or volt D.C. service. 04 Explosion proof switch, class 1 group D, for direct startg and control for A.C. rewd otor. Press to start, release to stop. May also be used with solenoid for 12 or volt D.C. service Cobation ountg bracket for circuit, solenoid and startg switch. 46 Right Side 46-1 Le Side Optional cha shroud for Series 40 reels Pneuatic on/off flow control valve assebly, 1/4" N.P.T. (F) let and outlet to be used with 4 AM copressed air otors, We also recoend usg a filter, regulator, and lubricator with copressed air otors. See page for series 000 hand crank and otor driven reels Sae as above with 3/8" N.P.T.F. (F) let and outlet, to be used with 6 AM otors. 54 North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Reelcra Industries is ISO 9001:00 Certified Sce 1996 Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

57 REEL ACCESSORIES Bupers/Inlet Asseblies ADJUSTABLE HOSE BUMPERS Adjustable hose bupers are solid olded rubber assurg a long life and nonslip grip. Hose bupers allow the desired length of hose to be peranently stored outside the reel. Hose bupers are cluded on the reels purchased with hose. Reels purchased without hose do not clude the hose buper. When orderg, advise the part nuber, reel odel and the hose I.D. and O.D. FOR REEL SERIES PART HOSE O.D. HOSE I.D. DIA. B-C-E DIA. D WEIGHT NUMBER () / / / lbs / kg 4000 / 5000 / RT400 / / L4500 / L HR1004-A.438 (11) -.6 () ¼ 6 2½ 64 1¼ / 5000 / D8000 / RT400 RT600 / HR1004.6() (19) 3 /8 10 2½ 64 1¼ / / E8000 / 00 RT800 / 5000 / D HR () (19) 3 / ¼ / A5005 / 7000 / D8000 / E8000 / RT800 2-HR (19) () ½ or 3 / 8 or ¼ / 8000 / D8000 / GC7000 / F7000 / F80000 / L7000 / DGM 3-HR () - 1. (33) ¾ ¼ TW5000 / TW7000 / 00T TW80000 /TWD HR () tw ¼ tw ¼ TH80000 / TW80000 / 00T TH7000 / TW () tw 3 /8 tw 10 3½ T / 4800T / TH () tw ½ tw 3½ HR HR D9000 / E9000 / 00 / HR (19) () ½ 3½ / D9000 / E9000 / FE9000 / 00 / HR () (35) ¾ 19 3½ / D80000 / D8000 / D9000 / E9000 / FD9000 / FE9000 / 00 / HR (35) (39) 1 3½ / FE9500 / FF9500 / 4800 S (39) (44) 1¼ 32 3¾ / FE9600 / FF9600 / 4800 S (44) (52) 1½ 38 3¾ / HR1005 INLET HOSE ASSEMBLIES A flexible hose connection ust be used between the hose reel let and the source of supply to prevent possible isalignent and bdg or warranty is void. The let size of reel series 4000 O, 5000 O and 5000 E is 3/8" (9.5) NPTF (F), 7000 O & 7000 E is 1/2" (12.7) NPTF (F), D8000 O and D8000 E is 1/2" (12.7) NPTF (F) dependg on hose size. Please furnish the followg foration when orderg: Part nuber-product and pressure to be handled. Other sizes available as well. FOR REEL SERIES NPFT (M) WORKING PART HOSE I.D. LENGTH (FITTINGS) PRESSURE WEIGHT NUMBER / / / psi / bar lbs / kg 4000 / 5000 / 5005 S / /8 x 3 / 8 10 x / 8000 / / RT605 / 300 S ½ ½x ½ x D8000 S x ¾ x D8000 / ¾ ¾ x ¾ 19 x / 5005 (OMP & EMP) / /8 x 3 / 8 10 x / (O & EMP) S-0043 ½ ½ x ½ x / 5005 (O & EHP) S-0044 ¼ ¼ x ¼ 6 x O / D8000 O / D8000 EHP S / ½ x 3 / 8 x TWIN WELDING INLET HOSE (OXYGEN/ACETYLENE) TW 5000 / TW 7000 S ¼ (Male/Feale) TW 5000 / TW 7000 S ¼ (Male/Feale) TW 5000 / TW 7000 S ¼ (Male/Feale) T GRADE TWIN WELDING INLET HOSES TW 5000 T / TW 7000 T S ¼ (Feale both ends) TW 5000 T / TW 7000 T S ¼ (Feale both ends) TW 5000 T / TW 7000 T S ¼ (Feale both ends) REEL ACCESSORIES North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra 55

58 Wd Thgs Up With Reelcra REEL ACCESSORIES Replaceent Hose Asseblies REPLACEMENT HOSE ASSEMBLIES Partial list PART NUMBER I.D. O.D. LENGTH PRESSURE BRAID END FITINGS WGT ches ches feet psi ches lbs LOW PRESSURE Air and water / Nylon Braid ¼ x ¼ NPTF(M) / Nylon Braid ¼ x ¼ NPTF(M) / Nylon Braid ¼ x ¼ NPTF(M) 4.5 S / Nylon Braid ¼ x ¼ NPTF(M) / Nylon Braid ¼ x ¼ NPTF(M) / Nylon Braid ½ x ¼ NPTF(M) / Nylon Braid ½ x 3/ 8 NPTF(M) / Nylon Braid ½ x ¼ NPTF(M) / Nylon Braid ½ x 3/ 8 NPTF(M) / Nylon Braid ½ x ½ NPTF(M) / Nylon Braid ½ x ½ NPTF(M) / Nylon Braid ¾ x ¾ NPTF(M) / Nylon Braid ¾ x ¾ NPTF(M) Nylon Braid 1 x ¾ NPTF(M).8 MEDIUM PRESSURE Oil and petroleu fluids /8.7 1 Wire 3/ 8 x 3/ 8 NPTF(M) /8.7 1 Wire 3/ 8 x 3/ 8 NPTF(M) / Wire ½ x ½ NPTF(M) / Wire ½ x ½ NPTF(M).1 HIGH PRESSURE Chassis grease / Wire ¼ x ¼ NPTF(M) / Wire 3/ 8 x ¼ NPTF(M) / Wire ¼ x ¼ NPTF(M) / Wire 3/ 8 x ¼ NPTF(M) 19.2 TWIN WELDING ¼ Oxygen-acetylene ¼ dual 0 1 Fabric 9/- LH/RH (F) ¼ dual Fabric 9/- LH/RH (F) ¼ dual Fabric 9/- LH/RH (F) ¼ dual Fabric 9/- LH/RH (F).2 TWIN WELDING ¼ T Grade ¼ dual 0 1 Fabric 9/- LH/RH (F) ¼ dual Fabric 9/- LH/RH (F) ¼ dual Fabric 9/- LH/RH (F) ¼ dual Fabric 9/- LH/RH (F). CAUTION : Be sure workg pressure required does not exceed above ratgs. Misapplication can result serious operator jury. NOTE : Advise product to be handled, axiu teperature and pressure fittg size or sizes when orderg. Return Policy Materials/products returned pre-paid to Reelcra for warranty spection/consideration and found to be defective will be repaired/replaced at no charge to the custoer per Reelcra s discretion. Materials/products deeed not defective will require custoer authorization to repair or replace at custoer s expense. Warranty Return Protocol: 1. Contact Reelcra custoer service at and request the Return Goods Coordator for the authorization nuber. Warranty clais will require the followg foration before a return authorization nuber (RGA) can be issued. 1. Product/odel nuber. 2. Serial nuber. 3. Invoice nuber. Additional foration regardg the specific reason for return will be required to process requests. 2. If a replaceent is required prior to Reelcra receivg your return, the ites beg sent will be voiced to your account until the warranty process is copleted. 3. Once given an RGA nuber, all correspondg quiries, paperwork and boxes will require this nuber. Reelcra reserves the right to refuse returns without an RGA nuber. 4. Upon receipt of your warranty return and all the warranty conditions are et, a credit eo will be issued to your account and forwarded for your records. If there is a proble with your return, a custoer service representative will contact you to discuss it further. 5. If you desire, a warranty report is available to be forwarded or discussed with you regardg your specific return and Reelcra s fdgs. Please contact our Return Goods Coordator at NOTE: For coplete warranty foration, onle warranty registration, service anuals and return foration please visit LOW PRESSURE AIR & WATER HOSE ASSEMBLY 0043 MEDIUM PRESSURE OIL & PETROLEUM FLUIDS 0044 HIGH PRESSURE CHASSIS GREASE 56 North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Reelcra Industries is ISO 9001:00 Certified Sce 1996 Models listed with an icon can be shipped sae day upon request when the order is received by 11: AM local tie for quantities of 5 or fewer. Indiana Warehouse California Warehouse Indiana & California Canadian Warehouse Warehouses

59 S = Sprg Driven H = Hand Crank E = Electric Motor * Without Hose or Cable IN: Indiana Warehouse CA: California Warehouse CN: Canadian Warehouse NOTE: Unless specified with an asterisk, all Quick Ship reels clude hose or cord stalled. Refer to for the ost up-to-date Quick Ship listg QUICK SHIP REELS The odels listed below can be shipped sae day upon request when the order is received by 11:a local tie for quantities of 5 or fewer. Part/Warehouse Capacity Part/Warehouse Capacity Pg# Model # CA IN CN Size Length Ratg Drive Description Pg# Model # CA IN CN Size Length Ratg Drive Description 8 44 OLP X X 1/4 0 psi S Air/Water PW81000 OHP* X X X 3/ psi S Pressure Wash 8 44 OLP X X X 1/4 0 psi S Air/Water CA6 M* X 1/ psi H Air/Water OLP X 1/ psi S Air/Water CA2 M* X X X 1/ psi H Air/Water 7 RT435 OLP X 1/ psi S Air/Water H000 M* X 1/ psi H Air/Water Hose OLP X X X 1/ psi S Air/Water CA8 M* X 1/ psi H Air/Water Hose 7 RT450 OLP X X X 1/ psi S Air/Water CA371 L* X X psi H Air/Water OLP X 1/ psi S Air/Water OLS* X 3/ psi S Staless, Air/Water OLP X X X 1/ psi S Air/Water OLS* X X 1/ psi S Staless, Air/Water 7 RT6 OLP X X 3/8 0 psi S Air/Water 19 HS000 M* X 1/ psi H Staless, Air/Water 8 46 OLP X X X 3/8 0 psi S Air/Water 19 HS19000 M* X 3/ psi H Staless, Air/Water OLP* X X 3/8 500 psi S Air/Water OMS* X 1/ psi S Staless, Air/Water 7 RT OLP X X 3/ psi S Air/Water THA7600 OMP* X 3/8 00 psi S Dual Hydraulic OLP* X 3/ psi S Air/Water TH88000 OMP* X X 1/ psi S Dual Hydraulic 8 5 OLP X X X 3/ psi S Air/Water TH88050 OMP X 1/ psi S Dual Hydraulic 7 RT605 OLP* X 3/ psi S Air/Water 42 LD X /3 40 1V S Electric Cord, Fluorescent 7 RT650 OLP X X X 3/ psi S Air/Water 42 LD 3 9 X /3 1V S Electric Cord, Triple Outlet SGA3650 OLP X X 3/ psi S Air Hose 42 LD 3 9 X /3 1V S Electric Cord, Triple Outlet OLP* X X X 3/ psi S Air/Water 42 LG X /3 50 1V S Electric Cord, Fluorescent OLP X X X 3/ psi S Air/Water 42 LG X /3 50 1V S Electric Cord, Triple Outlet OLP X X X 3/ psi S Air/Water 42 LG X 12/3 40 1V S Electric Cord, Triple Outlet OLP* X X X 3/ psi S Air/Water 42 LH80 3 X /3 80 1V H Electric Cord OLP X X 3/ psi S Air/Water 42 LH00 X 10/ V H Electric Cord OLP X X X 3/ psi S Air/Water 44 L X X X 12/3 45 1V S Electric Cord, Duplex Outlet 7 RT8 OLP X 1/2 0 psi S Air/Water 44 L X X 12/3 50 1V S Electric Cord, Duplex Outlet 8 A58 OLP X X X 1/2 0 psi S Air/Water 45 L X X X /3 50 1V S Electric Cord, Incandescent 7 RT803 OLP X 1/ psi S Air/Water 45 L X X /2 50 1V S Electric Cord, Fluorescent 7 RT835 OLP X X 1/ psi S Air/Water 44 L X X X 12/3 45 1V S Electric Cord, Sgle Recept 7 RT850 OLP X X X 1/ psi S Air/Water 44 L X /3 35 1V S Electric Cord, Sgle Recept 8 A5850 OLP X X 1/ psi S Air/Water 44 L X X X /3 50 1V S Electric Cord, Sgle Recept OLP* X X X 1/ psi S Air/Water 44 L X X 12/3 50 1V S Electric Cord, Sgle Recept OLP X X X 1/ psi S Air/Water 51 T * X 12/3 0 35ap/2V H Electric Cord, 3 conductor 11 D8850 OLP X X 1/ psi S Air/Water F7900 OLP* X 3/4 500 psi S Fuel OLP X 1/ psi S Air/Water F79 OLP* X X 3/4 -- S Fuel OLP* X X X 1/ psi S Air/Water F800 OLP* X 3/ psi S Fuel OLP X X 1/ psi S Air/Water F850 OLP X 3/ psi S Fuel 9 79 OLP X X 3/4 0 psi S Air/Water FD90 OLP* X 3/ psi S Fuel OLP X 3/ psi S Air/Water FD800 OLP* X X 3/ psi S Fuel OLP X X X 3/ psi S Air/Water FD84000 OLP* X X X psi S Fuel 12 D875 OLP X 3/ psi S Air/Water FD84050 OLP X psi S Fuel 12 D84000 OLP X psi S Air/Water FD9400 OLP* X psi S Fuel 12 D84050 OLP X psi S Air/Water FF9500 OLPBW* X 1¼ 50 0 psi S Fuel OMP* X X 3/ psi S Oil/Fluid FF9600 OLPBW* X 1½ 50 0 psi S Fuel 8 56 OMP X X 3/8 psi S Oil/Fluid G 50 X X X 3/32 50 S Static Discharge OMP X 3/ psi S Oil/Fluid G 50 Y X X 3/32 50 S Static Discharge, 2@ 7 RT835 OMP X 1/ psi S Oil/Fluid G 50 N X X 3/32 50 S Static Discharge, Jacketed OMP X X X 1/ psi S Oil/Fluid GA00 N X 3/ S Static Discharge, Jacketed OMP X X X 1/ psi S Oil/Fluid 52 TB 01 X X 6 0~1.5 lbs S Tool Balancer 8 A58 OMP X 1/2 00 psi S Oil/Fluid 52 TB 03 X X 6 1.5~3 lbs S Tool Balancer 8 A5800 OMP* X 1/ psi S Oil/Fluid 52 TB 05 X X 6 3~5 lbs S Tool Balancer 11 D8850 OMP X X 1/ psi S Oil/Fluid 52 TB 10 X 8 5~10 lbs S Tool Balancer 11 E8850 OMP X 1/ psi S Oil/Fluid 52 TB 12 X 8 8~12 lbs S Tool Balancer OMP X 3/ psi S Oil/Fluid 52 TB X 8 10~ lbs S Tool Balancer OMP* X 1/ psi S Oil/Fluid 52 TB X 8 ~ lbs S Tool Balancer 8 54 OHP X 3/ psi S Grease 52 TBL 10 X 8 5~10 lbs S Tool Balancer, w/ Rachet OHP X 3/ psi S Grease 52 TBL 12 X 8 8~12 lbs S Tool Balancer, w/ Rachet OHP* X 3/ psi S Grease 52 TBL X 8 10~ lbs S Tool Balancer, w/ Rachet OHP X 3/ psi S Grease 52 TBL X 8 ~ lbs S Tool Balancer, w/ Rachet 11 D8650 OHP X 3/ psi S Grease 50 CEA006* X X #2/ ap H Weldg Cable OHP X 3/ psi S Grease 50 CEA012* X #2/ ap H Weldg Cable EA312 L12D X 3/ psi E Air/Water 48 TW54 OLP X 1/4 0 psi S Weldg Gas, Tw Oxy/Ace. EA2 L12D* X 1/ psi E Air/Water 48 TW54 OLPT X 1/4 0 psi S Weldg Gas, Tw T-Grade EA8 L12D* X 1/ psi E Air/Water 48 STW3450 OLP X 1/ psi S Weldg Gas, Tw Oxy/Ace. CA6 L* X X X 1/ psi H Air/Water 48 TW7400 OLP* X 1/ psi S Weldg Gas, Tw Oxy/Ace. 51 T-11-08* X 1/2 0 0 psi H Air/Water 48 TW7450 OLP X X X 1/ psi S Weldg Gas, Tw Oxy/Ace. CA2 L* X X X 1/ psi H Air/Water 48 TW7450 OLPT X 1/ psi S Weldg Gas, Tw T-Grade H000* X 1/ psi H Air/Water 48 TW84100 OLPT X X 1/ psi S Weldg Gas, Tw T-Grade CA8 L* X X 1/ psi H Air/Water 51 T X 1/2 0 0 psi H Air/Water CA3 L* X 1/ psi H Air/Water 51 T-12-04* X 1/4 0 0 psi H Weldg Gas, Tw T-Grade CA6 L* X X X 3/ psi H Air/Water 51 T-60-0* X 4/ ap H Weldg Cable CA312 L* X X X 3/ psi H Air/Water 51 T * X 8/ ap H Power Cable, 3 Conductor CA3 L* X 3/ psi H Air/Water 51 T-62-0* X X 4/ ap H Weldg Cable, Dual H006 M* X 1/ psi H Pressure Wash 51 T-64-0* X X 4/ ap H Weldg Cable, Dual H19000 M* X 3/ psi H Pressure Wash REEL ACCESSORIES / QUICK SHIP REELS North Aerica: Asia: +63 (45) Europe: +44 (0) Lat Aerica: Quick Ship Ite Wd Thgs Up With Reelcra 57

60 MCAT Reel and Trailer Orchard Ridge Country Club Fort Wayne, IN Work Sarter North Aerica Europe Corporate Headquarters Unit Cron Courtyard One Reelcra Center P.O. Box 8 Weldon South Industrial Estate Colubia City, IN Corby Northaptonshire NN 8AG Ph: Fax: United Kgdo Ph: Fax: Ph: +44 (0) e-ail: reelcra@reelcra.co Fax: +44 (0) e-ail: europe@reelcra.co Canada 05 Argentia Rd. Unit #7 Mississauga, ON L5N 3A9 Ph: Fax: e-ail: reelcra@reelcra.co Lat Aerica & The Middle East Thopson International, Inc. P.O. Box Ft. Wayne, IN Ph: Fax: e-ail: fo@t-i-i.co Asia Pacific 7550 A Bonifacio Ave., Cargohaus Buildg Clark Special Econoics Zone, Clark Field Papanga, Philippes Ph: +63 (45) Fax: +63 (45) e-ail: rap@coclark.co Australia Recoila PO Box 6463 BC, Blacktown, NSW 48, Australia Ph: +61 (2) Fax: +61 (2) sales@recoila.co MCAT-001S Condensed Catalog available Spanish, French & Geran. For # Wd Thgs Up With Reelcra reelcra.co Reelcra Industries is ISO 9001:00 Certified Sce 1996