Amana Domestic Washer Technical Information 120 V, 60 Hz Models

Transcription

1 mana Domestic Washer echnical nformation 0 V, 0 Hz Models DW0W DW0W Due to possibility of personal injury or property damage, always contact an authorized technician for servicing or repair of this unit. efer to ervice Manual 0000 for detailed installation, operating, testing, troubleshooting, and disassembly instructions. efer to arts Manual 000 for part number information.! C ll safety information must be followed as provided in this echnical heet and in ervice Manual 0000.! W o avoid risk of electrical shock, personal injury or death, disconnect power to unit before servicing, unless testing requires it. Models DW0W Models DW0W ower ource Wash cycles Voltage C 0 VC Water temperatures mperage (ingle nit) 0 eatures requency 0 Hz teady pin alance ystem X Motor horsepower / elf-adjusting rear leveling legs X eceptacle -0 0 gitation stroke X lug -0 ri ction wash system X Dimensions Cabinet Height overall 4 Motor speed speed Height of cabinet pin speed (revolutions per minute) 40 / 4 rpm Width gitation speed (strokes per minute) Depth 8 High 9 spm Clearance washer lid / Medium 4 spm Weight Crated 9 lbs. January ev. 0

2 Component esting nformation! W o avoid risk of electrical shock, personal injury, or death, disconnect power to washer before servicing, unless llustration Component est rocedure esults 4000 emperature switch Disconnect wires from component to properly measure the resistance of the component. 4 4 = lace switch in the following positions = and measure across the terminals =, below: 4 =, 4 Hot / Cold -4 > Ω Warm / Cold -, -4, -4 - > Ω Cold / Cold - > Ω Mixing valve Measure resistance of terminals on each valve. esistance across each valve. pproximately 000 Ω ± 0% imer Verify input and output voltage is present. ee timing sequence chart for functional description of the component. Verify wiring is correctly connected to the timer ressure switch Do not disconnect the pressure hose from pressure switch to perform measurements. Measure resistance across the following terminals on the pressure switch: erminal to erminal to efer to wiring diagram/schematic for correct contacts. ir pressure that actuates switch is determined by the water level of the tub. Continuity (no pressure) Continuity (pressure) id switch Disconnect wire terminals from switch. est terminals with switch closed. est terminals with switch open. Continuity nfinite > Ω MΩ rake pad kit f washtub does not stop spinning within seven seconds after opening loading door. f brake pads make noises. eplace all three brake pads. pply a thin layer of silicone (594) on pads, see ervice ulletin Q 000 ev. 0 January 00

3 Component esting nformation! W o avoid risk of electrical shock, personal injury, or death, disconnect power to washer before servicing, unless llustration Component est rocedure esults Motor ype of motor: wo speed ee following section nternal Motor Diagram and chematic for correct wiring contacts Drain pump Verify drain pump is not clogged or damaged. emove clog and verify proper operation. eplace drain pump if damaged ransmission assembly ype of transmission: 40 rpm xternally identical, must be identified by part number. f transmission locks-up, replace Drive belt ype of drive belt: 40 rpm efer to arts Manual, to verify which drive belt and pulley size is required. efer to arts Manual for proper pulley size. January ev. 0

4 nternal Motor Diagram and chematic! W o avoid risk of electrical shock, personal injury, or death, disconnect power to washer before servicing, unless ne or wo peed Motors tart erminals Continuity exists between switch terminal and ed wire. Y Manually depress actuator. Continuity broken between switch terminal and ed wire. noperative start switch. eplace switch. Y Continuity exists between switch terminal and ed wire. High peed erminals Y Manually depress actuator. Continuity broken between switch terminal and ed wire. noperative high speed switch. eplace switch. Y ow peed erminals Continuity broken between switch terminal and Violet wire. Y Manually depress actuator. Continuity exists between switch terminal and Violet wire. noperative low speed switch. eplace switch. Y Motor switch checks. tart Winding 4-5 ohms between rown wire and ed wire. noperative start winding. eplace motor. Y High peed Winding - ohms between lue wire and Yellow wire. noperative high speed winding. eplace motor. Y ow peed Winding - ohms between Yellow wire and Violet wire. noperative low speed winding. eplace motor. Y rotector Continuity exists between Yellow wire and White wire. noperative common lead. eplace motor. Y ll motor windings checks. 000 ev. 0 4 January 00

5 nternal Motor Diagram and chematic! W o avoid risk of electrical shock, personal injury, or death, disconnect power to washer before servicing, unless Wire harness connection block W Y White rown Yellow lue Violet ed W Y White Yellow rown Yellow 4 M M lue ed Violet verload protector ux. Motor ssembly (two speed motor) January ev. 0

6 Wiring Diagram and chematic! W o avoid risk of electrical shock, personal injury, or death, disconnect power to washer before servicing, unless CC DM M 4 H V H 4 Y / D/ M 5 WH/D 8 9 Y/ / M D WH/ M V 8. M. WCH.. CC WH D D /Y Y WH/D 9 9 D/ WCH / D WCH CM. V D D M = W CD MX VV D H CD C CC /Y D WH/D Y /Y H 5 5 WH/D 8 V WH M 000 ev. 0 January 00

7 Wiring Diagram and chematic! W o avoid risk of electrical shock, personal injury, or death, disconnect power to washer before servicing, unless CHMC 0 V.C. 0 HZ WCH MX VV CD H W M. WCH H CD WM CD CD CD - -, - - D WCH.. W M. WCH H V Y = CD M M H W M M M 8 HH 4 DC M January ev. 0

8 imer Cycle Chart! W o avoid risk of electrical shock, personal injury, or death, disconnect power to washer before servicing, unless CM WCH M C D D Y & - W M M- W M M HH M M-H W Y - H W -H CD W -V V M D WH M WH & & M & & M M WH M DC HD WH ailure to install, maintain, and/or operate this machine according to manufacture's instructions may result in conditions which can produce bodily injury and/or property damage. H MCH MCD D M H W : D :,5,84;,88,55;,8454 CD :,008,5; 994,85 H D CC CC CD V H H M M Y "" DC CD W ± CD. "" DC CD M ± CD. 4 H W D WH/ 5 4 x 9 8 Y/ 0 V 5 WH/ D 4 8 D 0 9 / 4 Y D/ / 000 ev. 0 8 January 00