CG161 LAWN TRACTOR LIST OF PARTS

Transcription

1 CG161 LAWN TRACTOR LIST OF PARTS GB Ransomes Way, Ipswich, England, IP3 9QG RANSOMES Publication No G (rev.0) (RSJ )

2

3 GB INTRODUCTION ITEM NUMBER Each part which is identified in the illustrations has an item number. Parts which do not have an item number may not be readily identified in the illustration but are usually closely associated with the immediately adjacent part. ASSEMBLIES A complete assembly, e.g. a wheel motor or hydraulic motor or roll assembly, is listed as a complete item with subsequent individual components listed separately. The assembly is listed under it's part number with component parts being listed offset to the right, e.g:- ITEM RANSOMES DESCRIPTION PART NO. QTY 1 LMSD798 Roll Assy. 1 2 MBB4490 Tube 1 3 LMSD926 End Cap Assy. 2 4 MBB6851 End Cap 1 5 H Bearing 1 6 MBB2356 Seal Housing 1 7 A Seal 2 * A Screw 2 It may not be possible to illustrate every item. With certain items purchased from outside suppliers some component parts may not be available from Ransomes and may need to be specially ordered from the supplier e.g. Volvo hydraulic motor components. QUANTITIES Quantities shown are for one assembly or sub-assembly. USING THE PARTS LIST Determine the function and application of the part required. Turn to the main index page and select the appropriate section. Locate the part on the illustration and parts list and read off the quantity from the appropriate MODEL column. NUMERICAL INDEX This is a summary of all part numbers used in the manual arranged in numerical sequence and showing the page and item number under which the parts appear. ORDERING OF SPARE PARTS When ordering replacement parts, it is most important to quote the SERIAL NUMBER of the machine, PART NUMBER, DESCRIPTION and QUANTITY required. 1

4 SPECIFICATIONS ENGINE Type Shibaura E673 Horsepower (SAE J1349)16(11.9kw) Number of Cylinders 3 Bore 2.64 in.(6.7cm) Stroke 2.52 in.(6.4cm) Displacement 41.3 cu. in. (676cc) Compression Ratio 23.5 to 1 Firing Order Low Idle Speed rpm Maximum Speed: High Idle rpm Rated 3200 rpm Valve Clearance (Cold Engine): Intake in. (.2Omm) Exhaust in. (.2Omm) CAPACITIES Fuel lank 4.2 U.S. Gals. 3.5 Imp. Gals. 16 Litres Rear Axle and Transmission 10.1 U.S. Qts. ( Includes Hydraulics 8.5 Imp. Qts. and Power Steering) 9.6 Litres Engine Crankcase: Less Filter 2.6 U.S. Qts. 2.2 Imp. Qts. 2.5 Litres With Filter 3.2 U.S. Qts. 2.6 Imp. Qts. 3.0 Litres Cooling System 3.5 U.S. Qts. 2.9 Imp. Qts. 3.3 Litres COOLING SYSTEM ELECTRICAL SYSTEM Alternator 12-volt, 14 amps Regulator (Alternator) Thyrister Battery 12-volt, 332 amps at 0 F cold cranking Reserve Capacity 52 minutes Starting Motor Solenoid Engaged FUEL SYSTEM Type of Fuel to Use Temperature Type Diesel Above 20 F No.2D Cetane (-6.7 C) Rating 40 Below 20 F No. 1 D Cetane (-6.7 C) Rating 40 Injection Pump: Type In-Line Timing 25 BTDC Fuel Pump electric P.T.O CLUTCH Type BRAKES Type Size STEERING Belt Drive Disc 5.5 in. Diameter (14cm) Turn Lock to Lock Steering Wheel Free-play Front Wheel Toe-In 30mm - 40mm 0-13/64 in.(0-5cm) Turning Radius at centre line of inside rear tire (Without Brake) 32 in (81 cm) Type Water Pump: Type Drive Water Pump Belt Deflection Fan Diameter Thermostat: Start to Open Fully Open Radiator Cap Pressurised Liquid with Recalculating Bypass Centrifugal V-Belt 7/16 to 9/16 (10/lSmm) when lbs. (9/11kg) Thumb Force is Applied Midway Between Pulleys in. (24cm) 1 67~F (75~C) 194F (90C) 1 3 psi (.9bar) POWER TAKE-OFF Type Belt Drive Pie Speed 2719 rpm Horsepower PTO Observed 13 HYDRAULIC LIFT SYSTEM Pump Type Gear Pump Capacity 3.0 Gpm (11.5 Litres pm) System Relief rpm Setting 471 psi (3244 kpa) Power Steering System Relief Valve Setting 889 psi (6123 kpa) 2

5 SPECIFICATIONS TYRES Front: Standard (TURF) Rear: Standard (TURF) LUBRICANTS Engine Oil Temperature Class Year Around Below 32 C (0 F) 16x G2 2PR 23x G2 2PR Viscosity Grade and API SAE 10w30, 10w40 SF/CD SAE 10w SF/CD 32 to 50 F SAE 20w SF/CD (0-10 C) TEST DATA SOUND MEASUREMENTS Sound Power rpm Sound Pressure rpm VIBRATION Condition at engine speed 3200 rpm At steering wheel On cutter deck - Operating On cutter deck stopping At operators step On cutter deck - Operating On cutter deck stopping At operators seat On cutter deck - Operating On cutter deck stopping 6.9m/s2 3.9m/s2 16.6m/s2 13.7m/s2 0.7m/s2 0.3m/s2 Above 50 F (10 C) SAE 30w SF/CD Transmission, Rear Axle; Hydraulic System and Power Steering System Oil Hyd. System Oil ISO VG Lubrication Fittings NLGI No.2 GENERAL DIMENSIONS Length 74.4in. (189cm) Height Top of Seat in.(121cm) Mm. Max. Width 37in. 39in. (94cm) (99cm) Minimum Ground Clearance 6.3in. (16cm) Wheelbase 50in. (127cm) Tread Width Front 30.3in. (77 cm) Rear in. ( cm) Weight (Less Mower) 382 kg TORQUES Front Wheel Wheel Boss to Axle Rear Wheel Disc-to-Axle lbs. ft. (26-34 Nm) lbs. ft. (44-56 Nm) 3

6 4

7 CONTENTS RADIATOR... 7 CYLINDER BLOCK... 9 CYLINDER HEAD CRANKSHAFT, PISTON OIL PUMP, WATER PUMP TIMING GEAR CASE INJECTION LINE, CAMSHAFT INJECTOR PUMP INJECTOR AIR CLEANER MUFFLER STARTER, ALTERNATOR ENGINE MOUNT FRONT P.T.O FRONT AXLE STEERING, POWER POWER STEERING PARTS INSTRUMENT PANEL CHASSIS, DASH BOARD PROPELLER SHAFT HYDROSTATIC TRANSMISSION TRANSMISSION TRANSMISSION WHEEL SHAFT CASE SPEED CONTROL BRAKE HYDRAULIC PIPING CONTROL VALVE LIFT CYLINDER FUEL LINE SEAT WIRING HARNESS WHEELS BONNET STEPS, FENDERS TRACTOR DECALS AND TOOLS GEARBOX AND BLADE GEARBOX AND BLADE MOWER DECK LINK DECK DECALS

8 RANSOMES CG161 LAWN TRACTOR 6

9 RADIATOR LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S RADIATOR ASSY 1 3 S CAP ASS Y 1 4 S COCK 1 5 S O-RING 1 6 S OVER FLOW PIPE 1 7 S SCREEN 1 8 S SHROUD 1 9 S BUFFLE PLATE 1 10 S BOLT 4 11 S RADIATOR HOSE 1 12 S RADIATOR HOSE 1 13 S HOSE BAND 2 14 S HOSE BAND 1 15 S HOSE BAND 1 16 S RUBBER 2 17 S RUBBER 2 18 S BOLT 2 19 S WASHER 1 20 S SPRING WASHER 1 21 S BOLT 2 22 S CLAMP 1 23 S WASHER 2 24 S CLAMP 4 * Not Illustrated 7

10 RANSOMES CG161 LAWN TRACTOR 8

11 CYLINDER BLOCK LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S CYLINDER BLOCK 1 2 S SEALING CAP 1 3 S SEALING CAP 2 4 S SEALING CAP 4 5 S BLANK PLUG 5 6 S BLANK PLUG 1 8 S BLANK PLUG 4 9 S IDLEGEAR SHAFT 1 10 S BUSHING 1 11 S BUSHING;S.T.D S BUSHING;U.S S BUSHING;U.S S BALL BEARING 1 13 S EXPANSION PLUG 1 14 S NEEDLE BEARING 1 15 S DOWEL PIN 2 16 S DOWEL PIN 2 17 S DOWEL PIN 2 18 S SPRING PIN 2 19 S STUDBOLT 2 20 S STUD BOLT 1 21 S STUD BOLT 1 22 S SNAP RING 1 23 S GASKET 1 24 S OIL PAN 1 25 S BOLT S BOLT 1 27 S SEAL WASHER 1 28 S OIL SEAL 1 29 S PLATE 1 30 S BOLT S BOLT 2 33 S COCK 1 34 S JOINT, FILTER 1 35 S OIL FILTER 1 36 S GUIDE 1 37 S O-RING 2 38 S BOLT 1 39 S GAUGE 1 40 S TAPPET 6 41 S ROD,PUSH 6 42 S RELEAF VALVE 1 43 S O-RING 1 44 S COVER 1 45 S NUT 1 46 S GASKET KIT 1 * Not Illustrated 9

12 RANSOMES CG161 LAWN TRACTOR 10

13 CYLINDER HEAD LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S HEAD ASSY, CYLINDER 1 2 S SEALING CAP 2 3 S SEALING CAP 2 4 S SEALING CAP 6 5 S BLANK PLUG 4 6 S VALVE, INTAKE 3 7 S VALVE, EXHAUST 3 8 S SEAL, VALVE GUIDE 6 9 S SPRING 6 10 S RETAINER 6 11 S COTTER S STUD BOLT 1 13 S GASKET, CYLINDER HEAD 1 13 S GASKET, CYLINDER HEAD 1 14 S HEADBOLT S HEADBOLT 3 16 S STUD BOLT 3 17 S LOCKER ARM 1 18 S LOCKER ARM 3 19 S LOCKER ARM 3 20 S SCREW 6 21 S NUT 6 22 S BRACKET 3 23 S SHAFT, ROCKER ARM 1 24 S SPRING 2 25 S PLUG 2 26 S SPRING PIN 1 27 S SHIM 4 30 S NUT 3 31 S GASKET 1 32 S GASKET 1 33 S COVER, CYLINDER HEAD 1 34 S STOPPER, OIL 1 35 S STOPPER, OIL 1 36 S BOLT 2 37 S GASKET 7 38 S CAP NUT 3 39 S CAP 1 40 S O-RING 1 42 S VINYL TUBE 1 43 S BOLT 4 44 S GASKET 1 45 S SPRING 1 46 S THERMOSTAT 1 47 S THERMOSTAT CASE 1 48 S LIFT EYE 1 * Not Illustrated 11

14 RANSOMES CG161 LAWN TRACTOR 12

15 CYLINDER HEAD LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 49 S BOLT 1 50 S EYE BOLT 2 51 S PRESSURE UNIT, OIL 1 53 S NUT 2 54 S PIPE, OIL 1 55 S STUD BOLT 2 56 S SEAT, VALVE 3 57 S VALVE CAP 6 * Not Illustrated 13

16 RANSOMES CG161 LAWN TRACTOR 14

17 CRANKSHAFT, PISTON LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S CRANKSHAFT COMPL 1 2 S GEAR, CRANKSHAFT 1 3 S DOWEL PIN 1 4 S BEARING HOLDER ASSY 1 5 S BEARING HOLDER ASSY 1 6 S BEARING HOLDER ASSY 1 7 S BOLT 2 8 S DOWEL PIN 2 9 S METAL;U.S S METAL;U.S S METAL;U.S S METAL S.T.D S METAL;U.S S METAL;U.S S METAL;U.S S METAL;U.S S METAL;UPPER, S.T.D S METAL; LOWER, S.T.D S METAL;U.S S METAL;U.S S BOLT 2 14 S BOLT 2 15 S PISTON ASSY 3 15 S PISTON ASSY 3 16 S RING KIT 3 16 S RING KIT 3 17 S PIN, PISTON 3 18 S SNAP RING 6 19 S CONNECTING ROD ASSY 3 20 S BUSHING 3 21 S BOLT, CONNECTING ROD 2 22 S NUT 2 23 S METAL;S.T.D S METAL;U.S S METAL;U.S S FLYWHEEL 1 25 S GEAR, RING 1 26 S BOLT 4 27 S NUT 1 28 S PULLEY 1 29 S V-BELT;FM S WASHER 1 31 S KEY 1 * Not Illustrated 15

18 RANSOMES CG161 LAWN TRACTOR 16

19 OIL PUMP, WATER PUMP LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S WASHER, THRUST 1 2 S GEAR ASS Y, IDLE 1 3 S ROTOR 1 4 S OIL PUMP COVER 1 5 S SHIM; S SHIM; S SHIM; S SHIM; S COLLAR 1 8 S SNAP RING 1 9 S O-RING 1 9 S SPRRING 1 10 S OIL PIPE 1 11 S FILTER, SUCTION 1 12 S BOLT 4 13 S PLATE, FRONT 1 14 S GASKET 1 15 S BOLT 2 16 S PUMP ASS Y, WATER 1 17 S PLATE 1 18 S THERMO SWITCH 1 19 S SPRING 1 20 S GASKET 1 21 S SETPLATE 1 22 S GASKET 1 23 S BOLT 3 24 S BOLT 2 25 S NUT 1 27 S PULLEY, FAN 1 28 S FAN, COOLING 1 29 S BOLT 4 30 S ADJUST PLATE 1 31 S ALTERNATERASSY 1 32 S BOLT 1 34 S WASHER 1 35 S BOLT 1 36 S BOLT 1 37 S NUT 2 * Not Illustrated 17

20 RANSOMES CG161 LAWN TRACTOR 18

21 TIMING GEAR CASE LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S CASE, GEAR 1 2 S SPRING PIN 1 3 S GASKET 1 4 S OIL SEAL 1 5 S LEVER ASSY, GOVERNOR 1 6 S LEVER, GOVERNOR 1 7 S WASHER 1 8 S SNAP RING 1 9 S SNAP PIN 1 10 S SPRING;MAIN 1 11 S ARM 1 12 S O-RING 1 13 S SNAP RING 1 14 S LEVER, GOVERNOR 1 15 S BOLT 1 16 S WASHER 2 18 S NUT 3 19 S SHAFT, GOVERNOR 1 20 S O-RING 1 21 S SNAP RING 1 22 S STAY 1 23 S BOLT 2 24 S BOLT 1 25 S ARM 1 26 S SNAP RING 1 27 S O-RING 1 28 S SPRING 1 29 S WASHER 1 30 S NUT 2 31 S LEVER 1 32 S SPRING 1 33 S BOLT 4 34 S BOLT 3 35 S BOLT 2 36 S BOLT 2 37 S SPRING 1 38 S COVER 1 39 S GASKET 1 40 S NUT 1 * Not Illustrated 19

22 RANSOMES CG161 LAWN TRACTOR 20

23 INJECTION LINE, CAMSHAFT LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S PUMP ASS Y, INJECTIO 1 2 S ADJUSTING SHIM 1 2 S ADJUSTING SHIM 1 2 S ADJUSTING SHIM 1 2 S ADJUSTING SHIM 1 4 S BOLT 2 5 S NUT 2 6 S INJECTOR 3 7 S GASKET 3 8 S GASKET 3 9 S CHAMBER,COMBUSTION 3 10 S PIPE, RETURN 1 11 S PIPE, INJECTION 1 12 S PIPE, INJECTION 1 13 S PIPE, INJECTION 1 14 S CLAMP 4 16 S BOLT 2 17 S NUT 2 18 S RUBBERPIPE 1 19 S CLIP 1 20 S PLUG, GLOW 1 21 S CONNECTOR 3 22 S COVER 1 23 S GASKET 1 24 S BOLT 1 25 S SMOKE SET ASS Y 1 26 S SEAL WASHER 1 27 S SOLENOID 1 28 S SEAL WASHER 1 29 S SEAL WASHER 1 30 S BOLT 1 31 S NUT 1 32 S SEAL WASHER 1 33 S EYE BOLT 1 33 S SCREW 1 35 S CAMSHAFT ASSY 1 36 S GEAR ASSY, CAMSHAFT 1 37 S KEY 1 38 S GEAR 1 39 S SPACER 3 40 S BALL BEARING 1 41 S SLIDER COMPL 1 42 S PLATE 1 43 S SHAFT COMPL 1 44 S BOLT 2 45 S BOLT 1 * Not Illustrated 21

24 RANSOMES CG161 LAWN TRACTOR 22

25 INJECTOR PUMP LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S INJECTOR PUMP ASSY 1 2 S HOLDER 3 3 S O-RING 3 4 S SPRING 3 5 S GASKET 3 6 S VALVE, DELIVERY 3 7 S ELEMENT 3 8 S SLEEVE SUB ASSY. 3 9 S SEAT, SPRING 3 10 S SPRING 3 11 S SEAT, SPRING 3 12 S PLALE 1 12 S PLATE 1 12 S PLATE 1 12 S PLATE 1 12 S PLATE 1 12 S PLATE 1 12 S PLATE 1 12 S PLATE 1 12 S PLATE 1 12 S PLATE 1 12 S PLATE 1 12 S PLATE 1 12 S PLATE 1 12 S PLATE 3 13 S TAPPET 3 14 S RAKE, CONTROL 1 15 S BRACKET 1 16 S SCREW 2 17 S SCREW 1 18 S WASHER 2 19 S NIPPLE 1 20 S PLATE SET VALVE 3 21 S SCREW 3 22 S PIN 3 * Not Illustrated 23

26 RANSOMES CG161 LAWN TRACTOR 24

27 INJECTOR LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 0 S INJECTOR ASSY 3 1 S NUT 1 2 S WASHER 1 3 S BODY SUB ASSY 1 4 S SHIM 1 4 S SHIM 1 4 S SHIM 1 4 S SHIM 1 4 S SHIM 1 4 S SHIM 1 4 S SHIM 1 4 S SHIM 1 4 S SHIM 1 4 S SHIM 1 4 S SHIM 1 4 S SHIM 1 4 S SHIM 1 4 S SHIM 1 4 S SHIM 1 4 S SHIM 1 4 S SHIM 1 4 S SHIM 1 4 S SHIM 1 4 S SHIM 1 4 S SHIM 1 4 S SHIM 1 5 S SPRING 1 6 S PIN 1 7 S DISTANCE PIECE 1 8 S NOZZLE ASSY 1 9 S NUT 1 * Not Illustrated 25

28 RANSOMES CG161 LAWN TRACTOR 26

29 AIR CLEANER LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S AIR CLEANER ASSY 1 2 S ELEMENT 1 3 S PACKING 1 4 S PACKING 1 5 S WING BOLT 1 7 S VALVE 1 8 S HOSE BAND 3 9 S AIR CLEANER HOSE;B 1 10 S AIR CLEANER HOSE;A 1 11 S COLLAR 2 12 S NUT 4 13 S BSTAY 1 14 S BAND CLEANER 1 15 S RUBBER 1 16 S BOLT 1 * Not Illustrated 27

30 RANSOMES CG161 LAWN TRACTOR 28

31 MUFFLER LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S PIPE 1 2 S MUFFLER, EXHAUST 1 3 S GASKET 1 4 S MANIFOLD, EXHAUST 1 5 S GASKET 1 6 S BOLT 1 7 S NUT 2 8 S BOLT 3 9 S STUD BOLT 2 10 S BOLT 3 11 S WASHER 1 12 S BOLT 1 13 S WASHER 2 14 S BAND 1 15 S BOLT 4 16 S NUT 2 * Not Illustrated 29

32 RANSOMES CG161 LAWN TRACTOR 30

33 STARTER, ALTERNATOR LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 0 S STARTER ASSY 1 1 S LEVER ASSY 1 2 S SWITCH ASSY 1 3 S BOLT 1 4 S BRACKET 2 5 S SLEEVE BEARING 1 6 S STOPPER SET 1 7 S CLUTCH, PINION 1 8 S ARMATURE ASSY 1 9 S WASHER SET 1 10 S YORK ASSY 1 12 S HOLDER ASSY, BRUSH 1 14 S REAR BRUSH 1 15 S BRACKET 1 16 S SLEEVE BEARING 1 17 S SCREW SET 1 20 S ALTERNATOR ASS Y 1 21 S FLY WHEEL COMPL 1 22 S BALL BEARING 2 23 S PLATE 1 24 S STATOR COMPL 1 25 S PLATE 2 26 S SCREW 2 27 S CLAMP 1 28 S SCREW 1 29 S COLLAR 1 30 S WASHER 1 31 S SPRING WASHER 1 32 S NUT 1 * Not Illustrated 31

34 RANSOMES CG161 LAWN TRACTOR 32

35 ENGINE MOUNT LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S BELT GUIDE 2 2 S ENGINE BED COMPL 1 3 S ENGINE BED COMPL 1 4 S RUBBER 4 5 S SPRING WASHER 8 6 S NUT 8 7 S BOLT 8 8 S RUBBER 1 9 S BOLT S WASHER 2 11 S PULLEY 1 12 S BOLT 3 13 S NUT 1 14 S BELT COVER 1 * Not Illustrated 33

36 RANSOMES CG161 LAWN TRACTOR 34

37 FRONT P.T.O. LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S PIVOT SHAFT 1 2 S P.T.O SHAFT 1 4 S PULLEY 2 5 S PULLEY 1 6 S BOLT 1 7 S SNAP RING 1 8 S V-BELT 2 11 S ARM 1 12 S SNAP RING 1 13 S WASHER 4 14 S TENTION ROLLER 1 15 S GREASE NIPPLE 1 16 S BOLT 4 17 S WASHER 1 18 S COVER 1 19 S BELT GUIDE 1 20 S SPRING 1 21 S SPRING 1 22 S WIRE;PTO 1 23 S LEVER 1 24 S ARM 1 25 S SPRING;TORQUE 1 26 S SPRING PIN 1 27 S GRIP 1 28 S FELT 1 29 S SNAP RING 2 30 S SPLIT PIN 1 31 S SPRING WASHER 4 32 S NUT 4 33 S HOSE 1 34 S SNAP RING 1 35 S BOLT 4 36 S BALL BEARING 1 37 S NEEDLE BEARING 1 38 S BOLT 2 39 S BOLT 6 40 S LOCK NUT 1 * Not Illustrated 35

38 RANSOMES CG161 LAWN TRACTOR 36

39 FRONT AXLE LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 2 S AXLE SHAFT ASSY 1 4 S BUSH 4 5 S GREASE NIPPLE 2 6 S KING PIN L 1 7 S KING PIN R 1 8 S SPACER 1 9 S KEY 1 10 S THRUST WASHER 1 11 S KNUCKLE ARM 1 12 S BOLT 1 13 S NUT 1 14 S SPRING WASHER 4 15 S SNAP RING 1 17 S ROD;TIE ROD 1 18 S TIE ROD END 1 19 S TIE ROD END 1 20 S TIE ROD END 1 21 S SPRING WASHER 2 22 S NUT 1 23 S NUT 1 24 S NUT 2 27 S NUT 1 28 S NUT 1 29 S CYLINDER ASSY 1 30 S OIL HOSE;A 1 31 S OIL HOSE;B 1 32 S PIN 1 33 S WASHER 1 34 S SPLIT PIN 2 35 S SPLIT PIN 2 * Not Illustrated 37

40 RANSOMES CG161 LAWN TRACTOR 38

41 STEERING, POWER LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S STE-CASE ASSY 1 2 S NUT 4 3 S WASHER 4 4 S SPRING WASHER 4 5 S STE-SHAFT 1 6 S JOINT 1 7 S SNAP RING 2 8 S STE-SHAFT 1 9 S SNAP RING 1 10 S PIPE HANDLE 1 11 S BUSH 2 12 S BALL BEARING 1 13 S SNAP RING 1 14 S HOLDER 2 15 S BOLT 4 16 S RUBBER 1 17 S STE-WHEEL ASSY 1 18 S HANDLE CAP 1 19 S SPRING WASHER 2 20 S STAY 1 21 S RUBBER 1 22 S CLAMP 1 23 S BOLT 2 24 S WASHER 1 25 S SUB FRAME 1 26 S SPRING WASHER 4 27 S SPRING 2 28 S GROMET 1 29 S BUSH 1 31 S LEVER 1 32 S SPRING 2 33 S NUT 2 34 S GRIP 1 35 S SCREW 1 37 S SNAP RING 1 38 S OIL PIPE 1 39 S OIL PIPE 1 40 S OIL PIPE 1 41 S OIL PIPE 1 42 S OIL PIPE 1 43 S CLAMP 1 44 S BOLT 1 45 S U-NUT 1 46 S NUT 4 47 S GREASE NIPPLE 3 48 S NUT 2 * Not Illustrated 39

42 RANSOMES CG161 LAWN TRACTOR 40

43 STEERING, POWER LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 49 S SPRING WASHER 2 50 S NUT 1 51 S WIRE:THROTTLE 1 52 S SPLIP PIN 1 53 S WASHER 1 54 S ADAPTOR 1 55 S ADAPTOR 1 * Not Illustrated 41

44 RANSOMES CG161 LAWN TRACTOR 42

45 POWER STEERING PARTS LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 0 S STEERING ASSY 1 1 S NUT 4 2 S PORT COVER 1 3 S SEAL RING 5 4 S O-RING 5 5 S CARTRIDGE 1 6 S O-RING 1 7 S HEX PLUG ASSY 1 8 S PORT MANIFOLD 1 9 S SPRING KIT 1 10 S HEX DRIVE ASSY 1 11 S PIN KIT 1 12 S DRIVE LING 1 13 S BOLT KIT 1 14 S DRIVE PLATE 1 15 S SPACER 1 16 S BEARING ;THRUST 1 17 S SPACER 1 18 S PLATE 1 19 S COVER;UPPER 1 20 S BOLT KIT 1 21 S SEAL KIT 1 22 S SEAL 1 * Not Illustrated 43

46 RANSOMES CG161 LAWN TRACTOR 44

47 INSTRUMENT PANEL LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S INSUTRUMENT PANEL 1 3 S METER ASSY 1 4 S SCREW 4 5 S FUEL METER 1 6 S SWITCH ASSY 1 7 S SWITCH ASSY 1 8 S KEY 1 9 S KEY CAP COMP 1 10 S WIRE HARNESS 1 13 S LAMP ASSY 1 14 S BULB ;3.4W 4 * Not Illustrated 45

48 RANSOMES CG161 LAWN TRACTOR 46

49 CHASSIS, DASH BOARD LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S CHASSIS ASSY 1 2 S SUPPORT 1 3 S BUSH 2 4 S BUSH 2 5 S WASHER 1 6 S NUT 1 7 S BOLT 10 8 S RUBBER 1 9 S FELT 1 10 S DASH BOARD;L 1 11 S DASH BOARD;R 1 12 S BOLT 8 13 S WASHER 9 14 S DASH BOARD 1 15 S SPLIT PIN 1 16 S BAFFLE PLATE 1 17 S SCREW 4 18 S WASHER 4 19 S SPRING 2 20 S BUFFLE PLATE;L(D) 1 21 S BUFFLE PLATE;R(D) 1 22 S BOLT S FELT SPONGE 1 25 S RUBBER 1 26 S GROMET 1 27 S FELT SPONGE 1 28 S FELT 2 29 S FELT 1 30 S FELT 2 31 S FELT 2 33 S FELT 1 34 S FELT 1 * Not Illustrated 47

50 RANSOMES CG161 LAWN TRACTOR 48

51 PROPELLER SHAFT LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S COUPLING 1 2 S BOLT 6 3 S FAN 1 4 S BOLT 1 5 S WASHER 10 6 S BOSS 1 12 S PROPELLER SHAFT 1 15 S SPRING WASHER 4 16 S FLANGE BOSS 1 17 S BOLT 2 18 S PLATE 1 19 S BOLT 2 20 S NUT 2 21 S COLLAR 2 * Not Illustrated 49

52 RANSOMES CG161 LAWN TRACTOR 50

53 HYDROSTATIC TRANSMISSION LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 0 S HST ASSY 1 5 S BLOCK SUB ASSY 2 6 S PUMP SUB ASSY 1 7 S PLATE;VALVE 1 8 S PLATE;VALVE 1 9 S SHAFT 1 10 S SHAFT 1 11 S PLATE 2 12 S PLATE 2 13 S SNAP RING 1 14 S PLATE 1 15 S WASHER 2 16 S PIN;TRANION 1 17 S PIN;TRANION 1 18 S BALL BEARING 1 19 S BALL BEARING 1 20 S NEEDLE BEARING 2 21 S BUSH 2 22 S PLUG 2 23 S SPOOL SUB ASSY 2 24 S POPPET 2 25 S VALVE 1 26 S VALVE 1 27 S HOLDER;SPRING 2 28 S SPRING 2 29 S SPRING 1 30 S SPRING 2 31 S SNAP RING 2 32 S PLUG 2 33 S SNAP RING 3 34 S SNAP RING 1 35 S SNAP RING 1 36 S SNAP RING 1 37 S PIN 1 46 S PIN 4 47 S SPRING PIN 2 48 S SPRING PIN 2 49 S PIN 2 50 S BOLT 2 51 S BOLT 4 52 S PLUG 2 53 S PLUG 2 54 S SEAL KIT 1 * Not Illustrated 51

54 RANSOMES CG161 LAWN TRACTOR 52

55 TRANSMISSION LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S TRANSMISSION ASSY 1 2 S TRANSMISSION CASE 1 3 S MULTISTAGE GEAR 1 4 S BALL BEARING 1 5 S MIDDLE SHAFT 1 6 S SHIFT GEAR 1 7 S SPUR GEAR 1 8 S SNAP RING 2 9 S BALL BEARING 1 10 S BALL BEARING 1 11 S SHIM 1 12 S SHIM 1 13 S SNAP RING 1 14 S OIL SEAL 1 15 S SHIFTER FORK 1 16 S SPRING 1 17 S STEEL BALL 1 18 S SHIFTER SHAFT 1 19 S O-RING 1 20 S PLATE 1 21 S BOLT S SHIFT ARM COMPL 1 23 S O-RING 1 24 S STOPPER 1 25 S BOLT 1 26 S BREATHER 1 27 S GAUGE COMPL 1 28 S ADAPTOR 2 29 S HOSE 1 30 S SHAFT 1 31 S GEAR WITH BOSS 1 32 S SPUR GEAR 1 33 S COLLAR 2 34 S DRIVE PINION ASSY 1 35 S TAPER ROLLER BEARIN 2 36 S SNAP RING 2 37 S WASHER, THRUST 1 38 S SHIM 1 39 S SHIM 1 40 S SHIM 1 41 S LOCK NUT 2 42 S LOCK WASHER 1 43 S GEAR WITH BOSS 1 44 S BALL BEARING 1 45 S SNAP RING 1 46 S SPACER 1 * Not Illustrated 53

56 RANSOMES CG161 LAWN TRACTOR 54

57 TRANSMISSION LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 47 S BOLT 4 48 S SPRING WASHER 4 49 S BOLT 1 50 S BOLT 2 51 S BOLT 1 52 S SEAL WASHER 1 53 S HST ASSY 1 54 S GRIP 1 55 S O-RING 1 56 S BOLT 2 57 S SPRING WASHER 2 58 S SHIM 1 59 S SHIM 1 60 S SHIM 1 61 S CHANGE LEVER 1 62 S SPRING PIN 1 63 S CLIP 2 * Not Illustrated 55

58 RANSOMES CG161 LAWN TRACTOR 56

59 WHEEL SHAFT CASE LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S CASING ASSY 1 2 S DOWEL PIN 2 3 S WHEEL SHAFT CASE 1 4 S BOLT 8 5 S DIFF. HOUSING 1 6 S WASHER 4 7 S BOLT 8 8 S DIFF GEAR 2 9 S THRUST WASHER 2 10 S DIFF PINION 2 11 S THRUST WASHER 2 12 S PINION SHAFT 1 13 S CLIP 1 14 S DIFF. HOUSING 1 15 S WASHER 3 17 S BALL BEARING 2 18 S SHIM 2 19 S SHIM 2 20 S SHIM 2 21 S WHEEL SHAFT 2 22 S BALL BEARING 2 23 S SNAP RING 4 24 S SPACER 2 25 S SNAP RING 2 26 S OIL SEAL 2 27 S PLUG 1 28 S SEAL WASHER 1 29 S BLANK PLUG 1 30 S BLANK PLUG 8 * Not Illustrated 57

60 RANSOMES CG161 LAWN TRACTOR 58

61 SPEED CONTROL LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S BRAKE DISC 1 2 S BRAKE LINING 1 3 S BOLT 2 4 S WASHER 3 5 S SPRING WASHER 2 6 S NUT 2 7 S LEVER 1 8 S SPRING PIN 1 9 S HST PEDAL 1 10 S SPRING PIN 4 11 S RUBBER 1 12 S ROD 1 13 S FORK JOINT 1 14 S NUT 4 15 S PIN 1 16 S WASHER 7 17 S SPLIT PIN 3 18 S ARM;A 1 19 S BALL BEARING 1 20 S SNAP RING 2 21 S SPRING PIN 1 22 S DANPER ASSY 1 23 S END BOLT 1 24 S SPLIT PIN 1 25 S SPRING WASHER 4 26 S PIN 1 27 S SPLIT PIN 1 28 S ARM ASSY 1 29 S BUSH 1 30 S BASE 1 31 S BOLT 2 32 S BOSS 1 33 S BOLT 1 34 S BOLT 1 35 S SPRING 1 36 S ARM 1 37 S PLATE 1 38 S PIN 1 39 S PIN 1 40 S LEVER 1 42 S SNAP RING 2 43 S SPRING 1 44 S LEVER 1 45 S ROD 1 46 S ROD 1 47 S TURN BUCKLE 1 * Not Illustrated 59

62 RANSOMES CG161 LAWN TRACTOR 60

63 SPEED CONTROL LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 48 S SPLIT PIN 1 49 S LEVER 1 50 S GRIP 1 51 S BRAKE LEVER 1 52 S BRAKE SHOE 1 53 S PIN 1 54 S PIN 1 55 S SNAP PIN 1 * Not Illustrated 61

64 RANSOMES CG161 LAWN TRACTOR 62

65 BRAKE LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S BRAKE ASSY 1 2 S BUSH 2 3 S RUBBER 1 4 S BRAKE LEVER 1 5 S PIN 1 6 S WASHER 5 7 S SPLIT PIN 3 8 S ROD 1 9 S PIN 1 10 S GREASE NIPPLE 1 11 S NUT 1 12 S SPRING 1 13 S SPRING 1 14 S NUT 2 15 S BRAKE DISC 1 16 S SNAP RING 1 17 S PAD(1) 1 18 S PAD(2) 1 19 S COVER 1 20 S COVER 1 21 S BOLT 5 22 S SPRING 1 23 S PIN 1 25 S LEVER 1 26 S SPLIT PIN 3 27 S SPRING 1 28 S GRIP 1 29 S BUSH 1 30 S ROD 1 * Not Illustrated 63

66 RANSOMES CG161 LAWN TRACTOR 64

67 HYDRAULIC PIPING LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S CONTROL VALVE ASSY 1 2 S PIPE 1 3 S PLATE 1 4 S O-RING 2 5 S ADAPTOR 1 6 S ADAPTOR 1 8 S ADAPTOR 1 10 S OIL PIPE COMPL 1 11 S OIL PIPE COMPL 1 12 S ADAPTOR 2 13 S O-RING 2 14 S O-RING 4 15 S ADAPTOR 2 16 S OIL PIPE COMPL 1 17 S OIL PIPE COMPL 1 18 S ADAPTOR 1 19 S OIL PIPE COMPL 1 20 S HOSE 1 21 S HOSE BAND 2 22 S BOLT 1 23 S OIL FILTER 1 24 S JOINT 1 25 S OIL FILTER 1 26 S JOINT, FILTER 1 27 S LEVER;LIFT 1 28 S GRIP 1 29 S LEVER GUIDE 1 30 S BOLT 4 31 S BOSS 1 32 S SPRING PIN 1 33 S WASHER 4 34 S SPRING PIN 1 36 S BOLT 2 37 S BAND 1 9A S ADAPTOR 1 * Not Illustrated 65

68 RANSOMES CG161 LAWN TRACTOR 66

69 CONTROL VALVE LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 0 S BALVE ASSY 1 3 S VALVE ASSY 1 4 S O-RING 2 5 S WIPER 2 6 S SEAL PLATE 2 7 S BOLT 2 8 S BOLT 2 9 S PLUG 2 10 S KIT, DETENT 1 11 S SNAP RING 1 12 S KIT, SEAL 1 * Not Illustrated 67

70 RANSOMES CG161 LAWN TRACTOR 68

71 LIFT CYLINDER LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S ARM SHAFT 1 2 S ARM 1 3 S BRACKET 1 4 S PIN 1 5 S PIN 1 7 S SNAP RING 1 8 S BRACKET 1 9 S PIN 1 10 S STOPPER 1 11 S BOLT 2 12 S BOLT 1 13 S CYLNDER 1 14 S CYLNDER TUBE ASSY 1 16 S CYLNDER HEAD KIT 1 17 S CYLNDER REPAIR KIT 1 19 S NUT 1 20 S PIN 1 21 S WASHER 1 22 S SPLIT PIN 2 23 S SNAP PIN 1 24 S SPLIT PIN 1 * Not Illustrated 69

72 RANSOMES CG161 LAWN TRACTOR 70

73 FUEL LINE LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S TANK ASSY 1 2 S TANK CAP ASSY 1 3 S BOLT 5 4 S FUEL PIPE 2 5 S FILTER STRAINER 1 6 S PLATE 1 7 S NUT 4 8 S SPRING WASHER 4 9 S BOLT 1 10 S FUEL PIPE ASSY 1 11 S FUEL PUMP 1 12 S RUBBER 1 13 S SCREW 2 14 S FUEL PIPE ASSY 1 15 S HOSE CLIP 8 16 S BAND 2 17 S FUEL PIPE(D) 1 18 S FUEL PIPE 1 19 S SNAP RING 2 20 S WIRE HOLDER 1 21 S FUEL PIPE 1 22 S FUEL FILTER 1 23 S STAY(D) 1 24 S BOLT 2 25 S BOLT 1 26 S SPRING WASHER 4 27 S FUEL PIPE ASSY 1 28 S HOSE 2 29 S HOSE 1 30 S HOSE CLIP 8 31 S CONNECTOR 1 32 S FUEL PIPE ASSY 1 33 S HOLDER, TANK 1 34 S RUBBER 8 35 S BOLT 2 36 S WASHER 2 37 S BOLT 4 38 S RUBBER 2 39 S RUBBER 3 42 S FILTER ELEMENT 1 43 S O-RING 1 44 S O-RING 1 47 S SWITCH 1 48 S BOLT 2 49 S RUBBER 1 * Not Illustrated 71

74 RANSOMES CG161 LAWN TRACTOR 72

75 SEAT LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S BRACKET 1 2 S BOLT 2 3 S SEAT SUPPORT 1 4 S SEAT SUPPORT;R 1 5 S BOLT 4 6 S BOLT 2 7 S STAY 1 8 S STAY 1 9 S BOLT 4 10 S SPONGE 4 11 S SEAT SUPPORT 1 12 S SEAT SUPPORT 1 13 S SEAT SUPPORT 1 14 S NUT S SPRING WASHER 4 16 S SEAT 1 17 S BAR 1 18 S SNAP PIN 2 19 S SEAT SUPPORT 1 20 S SPRING 1 21 S WASHER 3 22 S SPLIT PIN 3 23 S SPRING 2 24 S BOLT 2 25 S LEVER 1 26 S COVER 1 27 S BOLT 4 28 S BUSH 1 29 S WASHER 2 * Not Illustrated 73

76 RANSOMES CG161 LAWN TRACTOR 74

77 WIRING HARNESS LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S BATTERY 1 2 S BATTERY HOLDER 1 3 S BATTERY ROD 2 4 S NUT 2 5 S SPRING WASHER 2 6 S SPACER 2 7 S BATTERY CABLE 1 9 S HARNESS;MAIN 1 10 S SWITCH ASSY 1 11 S SWITCH ASSY 1 12 S SWITCH ASSY 1 13 S NUT 1 17 S RELAY 2 18 S BOLT 2 19 S HARNESS 1 20 S BATTERY CABLE 1 21 S REGULATER 1 22 S BOLT 2 23 S GLOW CONTROLER 1 24 S BOLT 1 25 S NUT 1 26 S WASHER 1 27 S BAND 3 28 S BAND 1 28 S BAND 2 28 S BAND 4 29 S OIL PRESSER 1 30 S SOLENOIDE 1 31 S FUEL PUMP 1 32 S SENSOR 1 33 S ALTER NATOR 1 34 S STARTER ASSY 1 * Not Illustrated 75

78 RANSOMES CG161 LAWN TRACTOR 76

79 WHEELS LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S TIRE ASSY 2 2 S WHEEL 2 3 S TIRE 1 4 S VALVE 1 5 S CAP 4 6 S BALL BEARING 4 7 S WASHER 2 8 S CASTLE NUT 2 9 S SPLIT PIN 2 10 S CAP 2 11 S TIRE ASSY 2 12 S WHEEL 2 13 S RTIRE 2 14 S BOLT 8 15 S STUD BOLT 4 16 S NUT 4 17 S SPRING WASHER 4 * Not Illustrated 77

80 RANSOMES CG161 LAWN TRACTOR 78

81 BONNET LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S BONNET 1 2 S FRONT MASK 1 3 S GUARD (L) 1 4 S GUARD (R) 1 5 S WASHER 20 6 S NUT 8 7 S SPRING WASHER 8 8 S PLATE 2 11 S HEAD LIGHT ASSY 1 12 S BULB 2 13 S NUT 4 14 S SPRING WASHER 4 15 S WASHER 4 16 S FELT SPONGE 1 17 S FELT 2 18 S LIGHT STAY 1 19 S BOLT 8 20 S SUPPORT;L 1 21 S SUPPORT;R 1 10A S BOLT 4 * Not Illustrated 79

82 RANSOMES CG161 LAWN TRACTOR 80

83 STEPS, FENDERS LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S FENDER ASSY 1 2 S STEP 1 3 S BOLT 4 4 S COVER 2 5 S FASTENER 1 6 S SCREW 2 7 S WASHER 2 8 S SPRING WASHER 2 9 S NUT 2 10 S SCREW 4 11 S NUT 6 12 S RUBBER 1 13 S RUBBER 1 14 S SCREW 4 15 S BOLT 4 16 S WASHER 8 17 S REFLECTOR 2 18 S NUT 2 19 S SPRING WASHER 2 20 S NUT 4 21 S SPRING WASHER 4 22 S SPRING WASHER 6 23 S STOPPER 1 24 S SCREW 2 25 S WASHER 2 26 S SUPPORTER 4 * Not Illustrated 81

84 RANSOMES CG161 LAWN TRACTOR 82

85 TRACTOR DECALS AND TOOLS LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S TOOL KIT 1 2 S BAG, TOOL 1 3 S DRIVER 1 4 S SPANNER 1 5 S SPANNER 1 6 S INSTRUCTION BOOK 1 8 S ASSEMBLY MANUAL 1 1 S CAUTION PLATE 1 2 S MARK 1 3 S CAUTION PLATE 1 4 S MARK 1 5 S PLATE 1 6 S CHANGE MARK 1 7 S CHANGE MARK 1 8 S CHANGE MARK 1 9 S MARK;BONNET L.H 1 10 S MARK;BONNET R.H 1 11 * ID PLATE 1 12 S MARK;SAUND LEVEL 1 13 S CAUTION PLATE 1 14 S CAUTION PLATE 1 15 S CAUTION PLATE 1 16 S CAUTION PLATE 1 17 S CAUTION PLATE 1 18 S NAME PLATE 2 19 S NAME PLATE;REAR 1 20 OPERATOR S MANUAL 1 * Not Illustrated 83

86 RANSOMES CG161 LAWN TRACTOR 84

87 GEARBOX AND BLADE LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S GEAR BOX 1 2 S PLUG 1 3 S STAY;L.H 1 4 S STAY;R.H 1 5 S BOLT 4 6 S SPRING WASHER 8 7 S BOLT 4 8 S SHAFT 1 9 S BEVEL GEAR 1 10 S BALL BEARING 3 11 S SNAP RING 3 12 S OILSEAL 2 13 S SPRING WASHER 8 14 S BOLT 1 15 S NUT 1 16 S SPLIT PIN 1 17 S PIN 1 18 S WASHER 6 19 S SPLIT PIN 1 20 S SHAFT 1 21 S BEARING CASE 1 22 S SEAL WASHER 1 23 S PLUG 1 24 S PULLEY 1 25 S BALL BEARING 1 26 S COLLER 2 27 S SNAP RING 1 28 S BALL BEARING 2 29 S BALL BEARING 3 31 S KEY 3 32 S SPACER 3 33 S SPRING WASHER 3 34 S BOLT 3 35 S BLADE 3 36 S GEAR BOX COVER 1 37 S BOLT 4 38 S GASKET 1 39 S SNAP RING 1 40 S BALL BEARING 1 41 S BAVEL GEAR 1 42 S SHIM 1 43 S SHIM 1 45 S PULLEY 2 46 S SPINDLE CASE 2 47 S SHAFT 2 48 S SEAL WASHER 2 * Not Illustrated 85

88 RANSOMES CG161 LAWN TRACTOR 86

89 GEARBOX AND BLADE LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 49 S SPRING WASHER 2 50 S NUT 2 51 SE VENT 1 52 S SPRING WASHER 2 53 S BOLT 8 54 S V-BELT 1 55 S PLATE 1 56 S BOLT 1 57 S NUT 1 58 S BELT COVER 1 59 S BELT COVER 1 60 S O-RING 1 61 S BOLT 1 62 S WASHER S PLUG 2 65 S FELT 1 66 S FELT 1 67 S FELT 1 68 S FELT 1 69 S FELT 1 70 S UNI-JOINT ASSY 1 72 S JOINT KIT 2 73 S SNAP RING 8 * Not Illustrated 87

90 RANSOMES CG161 LAWN TRACTOR 88

91 MOWER DECK LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S DECK 1 2 S SHAFT 3 3 S ROLLER 4 4 S SPRING WASHER 8 5 S CAP NUT 4 6 S COVER;DISCHARGE 1 7 S SPRING 1 8 S BOLT 4 9 S SPRING WASHER 4 10 S NUT 1 11 S SHAFT 1 12 S SPRING PIN 2 13 S BRACKET 2 14 S BOLT 4 15 S PIN 6 16 S SPRING PIN 4 17 S SPRING 4 18 S COLLAR 2 19 S PIN 1 20 S TENSION ARM 1 21 S BUSH 2 22 S SPACER 3 23 S PULLEY 1 24 S BALL BEARING 2 25 S SNAP RING 1 26 S SNAP RING 1 27 S SPRNG 1 28 S ROD 1 29 S NUT 2 30 S SNAP RING 2 31 S PIN 2 32 S GRESE NIPPLE 2 33 S ARM;CASTER L.H 1 34 S ARM;CASTER R.H 1 35 S WASHER 2 36 S GAUGE WHEEL ASSY 2 37 S BUSH 4 38 S SPACER 2 * Not Illustrated 89

92 RANSOMES CG161 LAWN TRACTOR 90

93 LINK LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S LINK, L.FR 1 2 S LINK, R.FR 1 3 S SHAFT 1 4 S PIN, 10ü~ S BRACKET 2 6 S NUT 2 7 S ROD, LIFT 2 8 S SPRING 2 9 S PIN 2 10 S PIN, SPRING 2 11 S PIN, SNAP 2 12 S WASHER 2 13 S PIN, SPRING 1 14 S WASHER 4 15 S PIN, SPLIT 6 16 S WASHER 6 17 S PIN 6 18 S ROD, LIFT 2 19 S PIN 4 20 S SPRING 4 21 S PIN, SPRING 4 22 S WASHER 2 * Not Illustrated 91

94 RANSOMES CG161 LAWN TRACTOR 92

95 DECK DECALS LIST OF PARTS ITEM RANSOMES PART NO DESCRIPTION GB QTY REMARKS 1 S MARK 1 2 S CAUTION PLATE 1 3 S CAUTION PLATE 2 4 S MARK; C-ARM LH 2 5 S MARK; C-ARM RH 2 6 S CAUTION PLATE 1 7 S NAME PLATE 1 * Not Illustrated 93

96

97

98 The following warning is for users of this product in California USA and is as required by proposition 65. CALIFORNIA Proposition 65 Warning Diesel engine exhaust and some of its constituents are known to the State of California to cause cancer, birth defects, and other reproductive harm. Ransomes Way, Ipswich, England, IP3 9QG RANSOMES