Mid-Size ProLine, T-Bar, Gear Drive 13 HP with 91cm Side Discharge Mower

Transcription

1 Form Number Rev B Mid-Size ProLine, T-Bar, Gear Drive 13 HP with 91cm Side Discharge Mower Model No TE and up. Parts Catalog Ordering Replacement Parts To order replacement parts, please supply the part number, the quantity, and the description of each part desired. Understanding Reference Numbers Each Identified part in an illustration has a reference number. The reference number for a part also appears in the parts list, along with other information about the part. This catalog uses two special reference number formats, one to indicate parts in a service assembly and another to indicate the quantity of a given part in an illustration. Service Assembly Reference Numbers Parts in service assemblies have reference numbers in the form a:b. The a represents the reference number of the entire service assembly and the b represents a sequential number unique to each part within the service assembly. For example, a wheel assembly might be identified by reference number 6, the tire by 6:1, the valve by 6:2, and the wheel by 6:3. When you order the assembly identified by reference number 6, you receive all parts identified by reference numbers 6:1, 6:2, and 6:3. However, you may also order any part individually. Reference numbers of this type appear in illustrations and in part lists. Reference Numbers Indicating Quantity In an illustration, if a reference number indicates more than one part, the reference number has the form nx y. The n represents the quantity of the part, the X is the multiplication symbol, and the y represents the reference number. For example, in an illustration, the reference number 2X 37 means that two of the parts identified by reference number 37 are indicated. Register your product at The Toro Company All Rights Reserved

2 Contents Description Engine and Clutch Assembly Frame and Fuel Tank Assembly Lower Control Assembly Transmission and Drive System Assembly Wheel Drive and Brake Assembly Upper Handle Assembly Upper Handle Assembly Carrier Frame Assembly Spindle, Pulley and Belt Assembly Spindle Assembly No Outer Spindle Assembly Roller, Cover and Deflector Assembly Deflector Assembly No Idler Assembly Cylinder / Crankcase Assembly Kawasaki FH381V-AS27 Piston / Crankshaft Assembly Kawasaki FH381V-AS27 Part Description Abbreviations Part descriptions in this catalog may include the following abbreviations. AR as required ASM assembly CARR carriage DEG degrees EXT external FH flat head GA gauge HF hex flange HH hex head HHF hex head flange HHFTF hex head flange thread forming HJ hex jam HLH hex lag head HOC height-of-cut HS hex HSBH hex socket button head HSFH hex socket flat head HSH hex socket head HWH hex washer head Footnotes Not illustrated Page Description Page Lubrication Equipment Assembly Kawasaki FH381V-AS Valve / Camshaft Assembly Kawasaki FH381V-AS Cooling Equipment Assembly Kawasaki FH381V-AS Electric Equipment Assembly Kawasaki FH381V-AS Control Equipment Assembly Kawasaki FH381V-AS Carburetor Assembly Kawasaki FH381V-AS Air-Filter / Muffler Assembly Kawasaki FH381V-AS Fuel Tank / Valve Assembly Kawasaki FH381V-AS Starter Assembly Kawasaki FH381V-AS Decals Kawasaki FH381V-AS Attachments and Accessories List HWHTF hex washer head thread forming HYD hydraulic INC incorporated LH left hand NI nylon insert NPTF national pipe thread fine PPH phillips pan head PRH phillips round head PTH phillips truss head PTO power take off RH right hand ROPS roll over protection system SFH slotted fillister head SHH slotted hex head SHWH slotted hex washer head SPH slotted pan head SQH square head SRH slotted round head STD standard Obtain parts from your local Kawasaki dealer

3 Rev B Engine and Clutch Assembly Filter-Fuel Pulley-Drive 2 1 Engine-Kawasaki, Fh381v-As Key-Square Clamp-Cable Cover-Pulley Decal-Surface, Hot Muffler Clip-Closed, Insulated Clamp-Muffler Adapter Muffler Guard ASM Valve-Drain, Oil Bracket-Guard, Muffler Harness-Wire Screw-HH Nut-Lock, NI Nut-Lock, NI Nut-HF Screw Washer-Lock Washer-Spring Grommet Hose-Drain, Oil Tube-Retainer Washer Grommet-Brake Spacer Strap-Clutch, Brake Screw-HH Washer-Flat Screw-HH R-Clamp Screw-HH Washer Clutch / Brake 3

4 Rev B Gas Cap ASM 1: Gasket-Cap, Gas Fuel Tank ASM 2: Fitting-Fuel, Bulkhead Stud-Threaded Washer-Flat Spring-Tank, Fuel Nut-Lock, NI Gear Frame ASM Clamp Hose-Fuel Valve-Fuel Hose-Fuel Screw-HH Washer-Lock Decal-Shut Off, Fuel Frame and Fuel Tank Assembly 4

5 Rev B Lower Control Assembly Nut-Wing Angle-Mounting Washer-Flat Screw Pin-Hair Guard-Belt, LH Bushing-Nylon Guard-Belt, RH Fitting-Rod Bracket-Mounting, LH Pin-Clevis Screw-HHF Spacer-Pivot, Idler Nut-HF Bracket-Support, LH Bracket-Mounting, RH Bracket-Support, RH Screw-HH Screw-HH Nut-Lock, NI Pulley-Idler Spacer-Pulley Bracket-Idler, LH Bracket-Idler, RH Screw-Leveler Fitting-Rod Spring-Torsion, LH Spring-Torsion, RH Nut-Lock, NI Guard-Shaft, Transmission Screw Panel-Bottom 5

6 Rev B 6 Transmission and Drive System Assembly Grip Bolt-Wheel Lever-Shift Screw-HH Nut-Lock Lever-Idler Washer-Belleville 27: Bushing-Flange Washer Pulley Transmission Nut-Lock, NI Fitting-Grease Screw-HH Coupler Washer-Lock Guard-Coupler Nut-Lock, NI Flange-Output Bracket-Plate, Shift Screw-HH Screw-Hwh, Thread Cut Key-Woodruff Nut-HF Screw-Set Plate-Shift Ring-Retaining Bolt-CARR Pulley-Transmission Decal-Ground Speed Shaft-Output Bearing-Shaft Rod-Shield Shield-Trailing Pulley-Driven Screw-Set, HSH Ring-Snap, External V-Belt Spring 6

7 Rev B Wheel Drive and Brake Assembly Ring-Retaining Band-Brake Ring-Retaining, External Screw-HH Plate-Link, Brake Seal-Grease Brake Arm ASM Spacer-Wheel Pin-Hair Axle ASM Rod-Brake Pin-Cotter Ring-Retaining Nut-HF Brake Link ASM Screw-HHF V-Belt Nut-Lock, NI Bearing-Cone, Tapered Washer-Spacer Nut-SHH Wheel And Tire ASM 16: Tire 16: Wheel 16: Stem-Valve Nut-Lug Cap-Dust Hub/wheel ASM 19: Bearing-Cup, Tapered 19: Fitting-Grease 19: Stud-Wheel Pulley-Wheel 7

8 Rev B Rod-Control Pin-Cotter Grommet-Rubber Decal-Bar, Control Bail ASM Bar-Control Decal-Reverse Control Pivot ASM Pin-Cotter Upper Handle ASM Pin-Clevis Tie-Cable Nut-HF Screw-HHF Decal-Protection, Ear Screw-SHH Lever-Brake, Parking Decal-Lever, Parking Nut-Lock Connector-Body Switch-Bail Upper Handle Assembly 8

9 Rev B Decal-Danger Key-Ignition Cable-Throttle Screw Screw-SHH Nut-Lock, NI Module-Delay Panel-Bottom Screw-HH Nut-Lock Switch-On/off 13: Nut-HH 13: Washer-Tooth R-Clamp Housing-Manual Switch-PTO Panel-Control Decal Cap-Housing Upper Handle Assembly 9

10 Rev B D2 Carrier Frame Assembly Carrier Frame ASM 19: Bearing 1: Insert-Nut 19: Bearing-Outside 1: Bushing 19: Tire-Tubeless 1: Fitting-Grease Bushing-Spanner Cover-Frame, Carrier Screw-HH Decal Pin-Lynch Grommet-Rubber Washer-Thrust Washer-Flat Seal-Strip, 1.5 In Screw-HH Screw Shield-Heat Nut-Speed Spacer-Support, Deck Bushing-Deck Screw-HH Washer-Flat Ring-Retaining Spacer Decal Castor Fork ASM Nut-Lock, Side Castor Wheel ASM 19: Stem-Valve 19: Fitting-Lube, 45 DEG 10

11 D Rev B Spindle, Pulley and Belt Assembly Deck ASM Sleeve-Pivot, Idler 1: Insert-Nut Screw-HH 1: Decal Pulley-Idler 1: Decal-Torque, Blade Bolt Idler Arm ASM 1: Decal-Danger Nut-Lock 1: Decal-Antiscalp, Ce Spring-Extension 1: Decal-Warning Nut-Lock, NI 1: Decal-Warning, Deflector Screw-HH 1: Decal Baffle-Front 1: Decal-Noise V-Belt-Drive, Deck Pulley-Idler Washer-Belleville Washer-Flat Screw-HH Screw-CARR Spindle Housing ASM Nut-HF Blade-Sail, Extra High Stiffener-Blade Washer-Flat Screw-Blade Spindle Housing ASM Screw-HH 11

12 Rev B A Nut-Hex Washer Pulley And Hub ASM Shield-Bearing Bearing Housing-Spindle Spacer-Bearing Shaft-Spindle Spindle Assembly No

13 A Rev B Nut-Hex Washer Pulley And Hub ASM Shield-Bearing Bearing Housing-Spindle Spacer-Bearing Shaft-Spindle Outer Spindle Assembly

14 Rev B D Deflector ASM Spacer Spring-Torsion Nut-Lock, NI Washer-Flat Screw-HH Cover ASM Front Pin ASM Nut-Jam Balljoint Spacer Nut-Lock, NI Rear Pin ASM Pin-Hair Screw-HH Screw-HH Washer-Flat Spacer-Wheel Roller-Anti Scalp Screw-HH Nut-HF Screw-HH Roller, Cover and Deflector Assembly 14

15 A Rev B Screw-CARR Deflector Strap-Discharge Deflector-Rubber Bracket-Hinge, Rear Bracket-Hinge, Front Nut-Lock, NI Deflector Assembly No

16 Rev B D Belt-Drive, PTO Nut-Lock, NI Washer Tube-Idler Idler Arm ASM 6: Sleeve-Bearing 6: Fitting-Grease Screw-HH Screw-HH Washer-Belleville Washer-Flat Pulley-Idler Spring-Extension Idler Assembly 16

17 E Rev B Cylinder / Crankcase Assembly Kawasaki FH381V-AS Gasket-Head Head-Comp-Cylinder, No A Head-Comp-Cylinder, No Case-Rocker Gasket-Case, Rocker Gasket-Cover, Crankcase 11061A Gasket-Breather Cover Cover-Crankcase Crankcase-Comp Joint Pin Seal-Oil, Rvc2 (6x11x10.2) 92049A Seal-Oil, Sd (35x62x8 L Hs) 92049B Seal-Oil, Sd (35x48x8 R Hs) 92049C Seal-Oil, So (8x14x5 Hs) Bushing B Bolt-Flanged 130A 130B Bolt-Flanged 130B 130T Bolt-Flanged 130C 130T Bolt-Flanged G Bolt-Stud 17

18 Rev B E Piston-Engine Pin-Piston Ring Set-Piston Ring Set-Piston (L,0.50) Piston-Engine (L,0.50) Crankshaft-Comp Connecting Rod ASM 13251A Connecting Rod ASM (U/s=0.50) Ring-Snap G Bolt-Flanged Piston / Crankshaft Assembly Kawasaki FH381V-AS27 18

19 E Rev B Shaft Plate Cap ASM Rotor-Pump (In) 16154A Rotor-Pump (Out) Filter-Oil 49065A Filter-Oil Gear-Spur Filler Pin Plug Ball Spring B Bolt-Flanged D O-Ring (16mm) Lubrication Equipment Assembly Kawasaki FH381V-AS27 19

20 Rev B Valve / Camshaft Assembly Kawasaki FH381V-AS27 E3 20

21 Valve / Camshaft Assembly Kawasaki FH381V-AS Valve-Intake Valve-Exhaust Retainer-Spring, Valve Collet Arm-Rocker Tappet Guide 13070A Guide Rod-Push Plate 13271A Plate-Governor Sleeve Spring-Valve, Engine Camshaft-Comp Screw Nut Ring-Snap Ball Spring Bolt Washer 21

22 Rev B E Plate Screen 9H Cover Shroud-Engine 49089A Shroud-Engine Fan Housing-Fan Stud Bolt 92153A Bolt B Bolt-Flanged 130A 130B Bolt-Flanged 130B 130B Bolt-Flanged F Nut-Hex Cooling Equipment Assembly Kawasaki FH381V-AS27 22

23 E Rev B Ignition Coil ASM 21171A Ignition Coil ASM Flywheel-Comp Harness Coil-Charging Stud Screw Plug 92066A Plug Plug-Spark (Rcj8y, Solid) Bolt (12x30) Washer B Bolt-Flanged B Screw-Pan F Nut-Hex A Key-Woodruff Electric Equipment Assembly Kawasaki FH381V-AS27 23

24 Rev B E Shaft Plate Link-Choke Link Spring-Governor Arm-Governor Panel-Control, Comp Screw (4x35) Spring 92145A Spring 92145B Spring Bolt (5x18) Bolt (6x12) Bolt (6x35) Clamp B Screw-Pan B Nut-Hex b Washer-Plain Control Equipment Assembly Kawasaki FH381V-AS27 24

25 E Rev B Carburetor Assembly Kawasaki FH381V-AS Gasket-Insulator Spring 11061A Gasket-Chamber Seal 11061B Gasket-Screw 92093A Seal 11061C Gasket-Cleaner, Air Spring Shaft Bolt Carburetor ASM Screw Screw-Pilot Washer Chamber-Float Valve-Throttle Valve-Float Float Shaft-Choke, Carburetor 16041A Shaft-Throttle, Carburetor Choke Valve ASM Limiter Nozzle-Main Manifold-Intake Screw 92009A Screw O-Ring 92055A O-Ring (Id=31) Jet-Main (No. 78) 92063A Jet-Main (No. 75) 92063B Jet-Main (No. 72) 25

26 Rev B E9 Air-Filter / Muffler Assembly Kawasaki FH381V-AS Case-Filter, Air B Screw-Pan (Cross) Element-Filter, Air B Screw-Pan 11013A Element-Filter, Air B Nut-Hex Bracket R Nut-Hex, Small 9H F Washer-Spring Bracket B O-Ring (10mm) Gasket-Muffler Plate Pipe-Intake Pipe-Exhaust Pipe Muffler-Comp Nut Spacer (6.2x7.9x5) O-Ring Band Clamp Tube Washer Nut 92210A Nut B Bolt-Flanged 130A 130B Bolt-Flanged 130B 130B Bolt-Flanged 26

27 E Rev B Bracket-Comp 9H Filter-Fuel Pump-Fuel Clamp Tube 92191A Tube (6.35x12.7x160) 92191B Tube B Bolt-Flanged Fuel Tank / Valve Assembly Kawasaki FH381V-AS27 27

28 Rev B E Pawl-Starter, Recoil Plate 9H Retainer Case-Recoil, Starter Grip-Recoil, Starter Pulley-Starting Starter-Recoil Reel-Recoil Rope Spring 92145A Spring 92145B Spring Bolt Washer 92200A Washer Nut B Bolt-Flanged Starter Assembly Kawasaki FH381V-AS27 28

29 E Rev B Label-Manual Label-Warning Label-Brand 56080A Label-Brand Decals Kawasaki FH381V-AS27 29

30 Attachments and Accessories For 30314TE - Mid-Size ProLine T-Bar Gear, 13 HP with 91cm Side Discharge Mower Product Name Model/Part Blade-Atomic Inch Recycler Kit Weight Kit Soft Bag (3 Bushel) Steel Grass Catcher Blade Blade-Mulch

31 NOTES

32