INTERNATIONAL June 18, 2015

Transcription

1 INTERNATIONAL June 18, 215 Thank you for the opportunity to provide you with the following quotation on a new International truck. I am sure the following detailed specification will meet your operational requirements, and I look forward to serving your business needs. MISSION: DIMENSION: ENGINE, DIESEL: TRANSMISSION, MANUAL: CLUTCH: AXLE, FRONT NON-DRIVING: AXLE, REAR, TANDEM: CAB: TIRE, FRONT: TIRE, REAR: SUSPENSION, REAR, TANDEM: PAINT: Model Profile SBA 6X4 (SF625) Requested GVWR: 37. Cale. GVWR: 5235 Wheelbase: 195., CA: 127.9, Axle to Frame: 75. {Navistar N9} EPA 21, SCR, 3 2 RPM, 86 lb-ft 12 RPM, 22 RPM Governed Speed, 3 Peak HP (MAX) {Fuller FR-9218} 1-Speed Manual; With Air Shift {Eaton Fuller Solo 142} Two-Plate, Stamped Angle Spring; Ceramic, 14" Diameter, 7 +1 Low Rate Damper, With 1.75" Spline, Mechanical Pull Type Control and Adjustment Free, 86 lb-ft Torque Capacity {Meritor MFS A} Wide Track, I-Beam Type, 14,-lb Capacity {Meritor MT-4-14X-4DCR} Single Reduction,.433"(11mm) Wall Housing Thickness, 4,-lb Capacity, R Wheel Ends, With Driver Controlled Locking Differential in Forward-Rear and Rear-Rear Axle Gear Ratio: 3.7 Conventional (2) 11 R22.5 G662 FUEL MAX (GOODYEAR) 497 rev/mile, load range G, 14 ply (8) 11 R22.5 G622 RSD (GOODYEAR) 497 rev/mile, load range G, 14 ply {Hendrickson RT-43} Walking Beam Type 52" Axle Spacing; 4,-lb Capacity With Rubber Center Bushings Cab schematic 1GN Location 1: 9219, Winter White (Std) Chassis schematic N/A 1 Proposal:

2 INTERNATIONAL Vehicle Specifications June 18, SBA 6X4 (SF625) Code Description FIR Wt Tot Wt SF625 Base Chassis, Model 74 SBA 6X4 with 195. Wheelbase, CA, 7675/ and 75. Axle to Frame. 157 TOW HOOK, FRONT (2) Frame Mounted 8/ 8 1CAJ FRAME RAILS Heat Treated Alloy Steel (12, PSI Yield); 1.866" x 224/ " x.433" (276.mm x 92.mm x 11.1 mm); 456." (11582mm) Maximum OAL 1LLK BUMPER, FRONT Omit Item -85/15-7 1WDS FRAME EXTENSION, FRONT Integral; 2" In Front of Grille 138/ WGX WHEELBASE RANGE 169" (43cm) Through and Including 219" (555cm) 1 2ARV AXLE, FRONT NON-DRIVING {Meritor MFS A} Wide Track, I- 58/ 58 Beam Type, 14,-lb Capacity : The following features should be considered when calculating Front GAWR: Front Axles; Front Suspension; Brake System; Brakes, Front Air Cam; Wheels; Tires. 3ADD SUSPENSION, FRONT, SPRING Parabolic, Taper Leaf; 14,-lb Capacity; With Shock Absorbers : SPRING PINS Rubber Bushings, Maintenance-Free : The following features should be considered when calculating Front GAWR: Front Axles; Front Suspension; Brake System; Brakes, Front Air Cam; Wheels; Tires. 491 BRAKE SYSTEM, AIR Dual System for Straight Truck Applications 1 : BRAKE LINES Color and Size Coded Nylon : DRAIN VALVE Twist-Type : DUST SHIELDS, FRONT BRAKE : DUST SHIELDS, REAR BRAKE : GAUGE, AIR PRESSURE (2) Air 1 and Air 2 Gauges; Located in Instrument Cluster : PARKING BRAKE CONTROL Yellow Knob, Located on Instrument Panel : PARKING BRAKE VALVE For Truck : QUICK RELEASE VALVE Bendix On Rear Axle for Spring Brake Release: 1 for 4x2, 2 for 6x4 : SLACK ADJUSTERS, FRONT Automatic : SLACK ADJUSTERS, REAR Automatic : SPRING BRAKE MODULATOR VALVE R-7 for 4x2, SR-7 with relay valve for 6x4 : Rear Axle is Limited to 46,-lb GAWR with Code 491 BRAKE SYSTEM, AIR and Standard Rear Air Cam Brakes Regardless of Axle I Suspension Ordered DRAIN VALVE {Berg} Manual; With Pull Chain, for Air Tank 1 2 Proposal:

3 INTERNATIONAL "' Code 4AZA 4EBD Description Vehicle Specifications SBA 6X4 (SF625) : DRAIN VALVE Mounted in Wet Tank AIR BRAKE ABS {Bendix AntiLock Brake System} Full Vehicle Wheel Control System (4-Channel) AIR DRYER {Meritor Wabco System Saver 12} with Heater : AIR DRYER LOCATION Inside Left Rail, Back of Cab June 18, 215 F/RWt Tot Wt / 11/7 18 4EXP BRAKE CHAMBERS, FRONT AXLE {Bendix} 2 Sqln 3/ 3 4EXU BRAKE CHAMBERS, REAR AXLE {Bendix EverSure} 3/3 Spring Brake 1 4JCJ BRAKES, FRONT, AIR CAM S-Cam; 16.5" x 5."; 2 Sq. In. Long Stroke Brake Chambers 1 : The following features should be considered when calculating Front GAWR: Front Axles; Front Suspension; Brake System; Brakes, Front Air Cam; Wheels; Tires. 4NDB BRAKES, REAR, AIR CAM S-Cam; 16.5" x 7."; 3/3 Sq.In. Long Stroke Brake Chamber and Spring Actuated Parking Brake 1 : The following features should be considered when calculating Rear GAWR: Rear Axles; Rear Suspension; Brake System; Brakes, Rear Air Cam; Brake Shoes, Rear; Special Rating, GAWR; Wheels; Tires. 4SBC AIR COMPRESSOR {Bendix Tu-Flo 55} 13.2 CFM Capacity / 4WZJ AIR TANK LOCATION (2): One Mounted Under Each Frame Rail, Front of Rear Suspension, Parallel to Rail STEERING COLUMN Tilting 1 5CAL STEERING WHEEL 2-Spoke, 18" Diam., Black 1 5PSA STEERING GEAR {Sheppard M-1} Power 1 7BEP EXHAUST SYSTEM Switchback Horizontal Aftertreatment Device, Frame Mounted Right Side Under Cab; Single Vertical Tail Pipe, Frame Mounted Right Side Back of Cab 119/ ELECTRICAL SYSTEM 12-Volt, Standard Equipment / : DATA LINK CONNECTOR For Vehicle Programming and Diagnostics In Cab : FUSES, ELECTRICAL SAE Blade-Type : HAZARD SWITCH Push On/Push Off, Located on Top of Steering Column Cover : HEADLIGHT DIMMER SWITCH Integral with Turn Signal Lever : HEADLIGHTS (2) Sealed Beam, Round, with Chrome Plated Bezels : JUMP START STUD Located on Positive Terminal of Outermost Battery : PARKING LIGHT Integral with Front Turn Signal and Rear Tail Light : RUNNING LIGHT (2) Daytime, Included With Headlights : STARTER SWITCH Electric, Key Operated 3 Proposal:

4 INTERNATIONAL Vehicle Specifications June 18, SBA 6X4 (SF625) Code Description F/R Wt Tot Wt : STOP, TURN, TAIL & B/U LIGHTS Dual, Rear, Combination with Reflector : TURN SIGNAL SWITCH Self-Cancelling for Trucks, Manual Cancelling for Tractors, with Lane Change Feature : WINDSHIELD WIPER SWITCH 2-Speed with Wash and Intermittent Feature (5 Pre-Set Delays), Integral with Turn Signal Lever : WINDSHIELD WIPERS Single Motor, Electric, Cowl Mounted : WIRING, CHASSIS Color Coded and Continuously Numbered 8518 CIGAR LIGHTER Ash Cup 1/ 8541 HORN, ELECTRIC (2) Disc Style 1/ 8GXD ALTERNATOR {Leece-Neville AVl16P213} Brush Type; 12 Volt 16 / Amp. Capacity, Pad Mount, With Remote Sense 8HAB BODY BUILDER WIRING Back of Standard Cab at Left Frame or Under 2/ 2 Extended or Crew Cab at Left Frame; Sealed Connectors for Tail/ Amber Turn/Marker/ Backup/Accessory Power/Ground and Sealed Connector for Stop/Turn 8MKL BATTERY SYSTEM {International} Maintenance-Free, (3) 12-Volt 42/ CCA Total 8RKB RADIO {Panasonic CQ12} AM/FM, Multiple Speakers, 2/ 2 Auxiliary Input : SPEAKERS IN CAB (2) Dual-Cone with Deluxe Interior : SPEAKERS IN CAB (4) Coaxial with Premium Interior 8WCL HORN, AIR Black, Single Trumpet, Air Solenoid Operated / 8WPH CLEARANCE/MARKER LIGHTS (5) {Truck Lite} Amber LED Lights, Flush / Mounted on Cab or Sunshade 8WPZ TEST EXTERIOR LIGHTS Pre-Trip Inspection will Cycle all Exterior Lamps / Except Back-up Lights 8WTK STARTING MOTOR {Delco Remy 38MT Type 3} 12 Volt; less Thermal / Over-Crank Protection 8WWJ INDICATOR, LOW COOLANT LEVEL With Audible Alarm / 8XAH CIRCUIT BREAKERS Manual-Reset (Main Panel) SAE Type Ill With Trip / Indicators, Replaces All Fuses Except For 5-Amp Fuses 8XDU BATTERY BOX Steel, With Aluminum Cover, 14" Wide, 3 Battery Capacity, Mounted Left Side Under Cab -3/-2-5 8XGT TURN SIGNALS, FRONT LED, LED Side Marker Lights, Mounted / on Fender 9585 FENDER EXTENSIONS Rubber 6/ 6 9HAN INSULATION, UNDER HOOD for Sound Abatement 1/ 1 9HBM GRILLE Stationary, Chrome / 9HBN INSULATION, SPLASH PANELS for Sound Abatement 2/ 2 4 Proposal:

5 INTERNATIONAL" Vehicle Specifications June 18, SBA 6X4 (SF625) Code Description F/R Wt Tot Wt (lbs) {lbs) 9WAC BUG SCREEN Front End; Mounted Behind Grille 5/ 5 9WBC FRONT END Tilting, Fiberglass, With Three Piece Construction; for 27 / & 21 Emissions 16 PAINT SCHEMATIC, PT-1 Single Color, Design 1 / : PAINT SCHEMATIC ID LETIERS "GN" 1761 PAINT TYPE Base Coat/Clear Coat, 1-2 Tone / 11LEV CLUTCH {Eaton Fuller Solo 142} Two-Plate, Stamped Angle Spring; 24/-2 22 Ceramic, 14" Diameter, 7+1 Low Rate Damper, With 1.75" Spline, Mechanical Pull Type Control and Adjustment Free, 86 lb-ft Torque Capacity : CLUTCH RELEASE BEARING Greasable BLOCK HEATER, ENGINE {Phillips} 12 Volt/125 Watt 2/ 2 : BLOCK HEATER SOCKET Receptacle Type; Mounted below Drivers Door 12NWC ENGINE, DIESEL {Navistar N9} EPA 21, SCR, 3 HP@ 2 RPM, / 86 lb-ft Torque@ 12 RPM, 22 RPM Governed Speed, 3 Peak HP (MAX) : AIR COMPRESSOR AIR SUPPLY LINE Naturally-Aspirated (Air Brake Chassis Only) : ANTI-FREEZE Red Shell Rotella Extended Life Coolant; -4 Degrees F/ -4 Degrees C; for MaxxForce and Navistar Engines : COLD STARTING EQUIPMENT Intake Manifold Electric Grid Heater with Engine ECM Control : CRUISE CONTROL Electronic; Controls Integral to Steering Wheel : ENGINE OIL DRAIN PLUG Magnetic : ENGINE SHUTDOWN Electric, Key Operated : FUEL FILTER Included with Fuel/Water Separator : FUEL/WATER SEPARATOR Fuel/Water Separator and Fuel Filter in a Single Assembly; With Water-in-Fuel Sensor; Engine Mounted : GOVERNOR Electronic : OIL FILTER, ENGINE Spin-On Type : WET TYPE CYLINDER SLEEVES 12THZ FAN DRIVE {Horton Drivemaster Polar Extreme} Direct Drive Type, Two / Speed, With Residual Torque Device for Disengaged Fan Speed : FAN Nylon 12UCV RADIATOR Aluminum, Cross Flow, Series System; 1228 Sqln Core and / 648 Sqln Charge Air Cooler 12UNK FEDERAL EMISSIONS EPA, OBD and GHG Certified for Calendar Year / 214; MaxxForce DT Engines 5 Proposal:

6 INTERNATIONAL Vehicle Specifications June 18, SBA 6X4 (SF625) Code Description F/RWt Tot Wt 12VBC AIR CLEANER Single Element / : GAUGE, AIR CLEANER RESTRICTION Air Cleaner Mounted 12VXT THROTTLE, HAND CONTROL Engine Speed Control; Electronic, / Stationary, Variable Speed; Mounted on Steering Wheel 12VYP ENGINE CONTROL, REMOTE MOUNTED - No Provision Furnished for / Remote Mounted Engine Control 12WZE EMISSION COMPLIANCE Federal, Does Not Comply With California / Clean Air Idle Regulations 13GJT TRANSMISSION, MANUAL {Fuller FR-921B} 1-Speed Manual; With Air / Shift : CLUTCH BRAKE Torque Limiting : FILL PLUG, MAGNETIC 14GVN AXLE, REAR, TANDEM {Meritor MT-4-14X-4DCR} Single Reduction, / "(11mm) Wall Housing Thickness, 4,-lb Capacity, R Wheel Ends, With Driver Controlled Locking Differential in Forward-Rear and Rear-Rear Axle. Gear Ratio: 3.7 : POWER DIVIDER LOCK Electric over Air Operated, Cab Control with Indicator Light : REAR AXLE DRAIN PLUG (2) Magnetic, For Tandem Rear Axle : The following features should be considered when calculating Rear GAWR: Rear Axles; Rear Suspension; Brake System; Brakes, Rear Air Cam; Brake Shoes, Rear; Special Rating, GAWR; Wheels; Tires. 14UHC SUSPENSION, REAR, TANDEM {Hendrickson RT-43} Walking Beam /56 56 Type 52" Axle Spacing; 4,-lb Capacity With Rubber Center Bushings : CROSSMEMBER, SUSPENSION Stamped Steel Double Dogbone : The following features should be considered when calculating Rear GAWR: Rear Axles; Rear Suspension; Brake System; Brakes, Rear Air Cam; Brake Shoes, Rear; Special Rating, GAWR; Wheels; Tires. 14WAL SUSPENSION/REAR-AXLE IDENTITY for Meritor Tandem Rear Axles / With Bar-Pin Beam Attachment Type Suspensions 15SXJ FUEL TANK Top Draw; Non-Polished Aluminum, 24" Diam., 5 U.S. Gal., 21/ L Capacity, Mounted Left Side Under Cab 15WCN DEF TANK 5 U.S. Gal. Capacity; Frame Mounted Outside Left Rail, Under -4/17 13 Cab 163 CAB Conventional / : ARM REST (2) Molded Plastic; One Each Door 6 Proposal:

7 INTERNATIONAL Code 16HBC 16HKA 16HLJ 16JNT Description Vehicle Specifications SBA 6X4 (SF625) : COAT HOOK, CAB Located on Rear Wall, Centered Above Rear Window : CUP HOLDERS Two Cup Holders, Located in Lower Center of Instrument Panel : DOME LIGHT, CAB Rectangular, Door Activated and Push On-Off at Light Lens, Timed Theater Dimming, Integral to Console, Center Mounted : GLASS, ALL WINDOWS Tinted : GRAB HANDLE, CAB INTERIOR (1) "A" Pillar Mounted, Passenger Side : GRAB HANDLE, CAB INTERIOR (2) Front of "B" Pillar Mounted, One Each Side : INTERIOR SHEET METAL Upper Door (Above Window Ledge) Painted Exterior Color : STEP (4) Two Steps Per Door GAUGE CLUSTER Metric With Metric Electronic Speedometer : GAUGE CLUSTER (6) Engine Oil Pressure (Electronic), Water Temperature (Electronic), Fuel (Electronic), Tachometer (Electronic), Voltmeter, Washer Fluid Level : ODOMETER DISPLAY, Miles, Trip Miles, Engine Hours, Trip Hours, Fault Code Readout : WARNING SYSTEM Low Fuel, Low Oil Pressure, High Engine Coolant Temp, and Low Battery Voltage (Visual and Audible) IP CLUSTER DISPLAY Omit Display of Fault Codes in Instrument Cluster and Disable Blink Codes, Requires Service Tool to Retrieve and View Fault Code GAUGE, DEF FLUID LEVEL SEAT, DRIVER {National 2} Air Suspension, High Back With Integral Headrest, Vinyl, Isolator, 1 Chamber Lumbar, With 2 Position Front Cushion Adjust, -3 to +14 Degree Angle Back Adjust : SEAT BELT 3-Point, Lap and Shoulder Belt Type June 18, 215 F/R Wt Tot Wt / / / 28/ SMN SEAT, PASSENGER {National} Non Suspension, High Back, Fixed Back, Integral Headrest, Vinyl 16/ SNB MIRRORS (2) {Lang Mekra} Rectangular, Thermostatically Controlled Heated Heads, Black Heads, Brackets and Arms, Breakaway Type, 7.55" x 14.1" Integral Convex Both Sides, 12" Inside Spacing -3/ -3 16WCT AIR CONDITIONER {Blend-Air} With Integral Heater & Defroster 43/4 47 : HEATER HOSES Premium : HOSE CLAMPS, HEATER HOSE Mubea Constant Tension Clamps : REFRIGERANT Hydrofluorocarbon HFC-134A 16WJS INSTRUMENT PANEL Center Section, Flat Panel / 16WKY HVAC FRESH AIR FILTER / 16WLE STORAGE POCKET, DOOR Molded Plastic, Full Width; Mounted on Passenger Door / 7 Proposal:

8 INTERNATIONAL Code 16WRX Description CAB INTERIOR TRIM Deluxe Vehicle Specifications SBA 6X4 (SF625) : "A" PILLAR COVER Molded Plastic : CAB INTERIOR TRIM PANELS Cloth Covered Molded Plastic, Full Height; All Exposed Interior Sheet Metal is Covered Except for the Following: with a Two-Man Passenger Seat or with a Full Bench Seat the Back Panel is Completely Void of Covering : CONSOLE, OVERHEAD Molded Plastic; With Dual Storage Pockets with Retainer Nets and CB Radio Pocket : DOOR TRIM PANELS Molded Plastic; Driver and Passenger Doors : FLOOR COVERING Rubber, Black : HEADLINER Soft Padded Cloth : INSTRUMENT PANEL TRIM Molded Plastic with Black Center Section : STORAGE POCKET, DOOR (1) Molded Plastic, Full-Length; Driver Door : SUN VISOR (2) Padded Vinyl with Driver Side Toll Ticket Strap, Integral to Console June 18, 215 FIR Wt Tot Wt / 16WSK CAB REAR SUSPENSION Air Bag Type / 27DRN WHEELS, FRONT {Accuride} DISC; 22.5" Painted Steel, 5-Hand Hole, 1- Stud (285.75MM BC) Hub Piloted, Flanged Nut, Metric Mount, 8.25 DC Rims; With.472" Thick Increased Capacity Disc and Steel Hubs 8/ 8 : PAINT IDENTITY, FRONT WHEELS White : Compatible Tire Sizes: 11 R22.5, 12R22.5, 255/7R22.5, 255/8R22.5, 265/75R22.5, 275/7R22.5, 275/8R22.5, 295/75R22.5, 295/8R22,5 28DRN WHEELS, REAR {Accuride} DUAL DISC; 22.5" Painted Steel, 5-Hand Hole, 1-Stud (285.75MM BC) Hub Piloted, Flanged Nut, Metric Mount, 8.25 DC Rims; With.472" Thick Increased Capacity Disc and Steel Hubs /12 12 : PAINT IDENTITY, REAR WHEELS White : Compatible Tire Sizes: 11 R22.5, 12R22.5, 255/7R22.5, 255/8R22.5, 265/75R22.5, 275/7R22.5, 275/8R22.5, 295/75R22.5, 295/8R22, (8) TIRE, REAR 11 R22.5 G622 RSD (GOODYEAR) 497 rev/mile, load range G, 14 ply / (2) TIRE, FRONT 11 R22.5 G662 FUEL MAX (GOODYEAR) 497 rev/mile, load range G, 14 ply 2/ 2 Services Section: 4115 WARRANTY Standard for WorkStar 73/74 (4x2, 4x4, 6x4, 6x6), Effective with Vehicles Built January 2, 215 or Later, CTS-22U / Total Component Weight: 8384/ PRE-DELIVERY PREPARATION AND CLEAN-UP, AND FUEL / Total Goods Purchased: / 8 Proposal:

9 INTERNATIONAL Vehicle Specifications SBA 6X4 (SF625) June 18, 215 The weight calculations included in this proposal are an estimate of future vehicle weight. The actual weight as manufactured may be different from the estimated weight. Navistar, Inc. shall not be liable for any consequences resulting from any differences between the estimated weight of a vehicle and the actual weight. 9 Proposal:

10 INTERNATIONAL Financial Summary SBA 6X4 (SF625) June 18, 215 Description Factory List Prices: Product Items Service Items Total Factory List Price Including Options: Total Goods Purchased: Freight Total Freight: Total Factory List Price Including Freight: (US DOLLAR) $115,42. $. $2,2. $115,42. $35. $2,2. $117,925. Please feel free to contact me regarding these specifications should your interests or needs change. I am confident you will be pleased with the quality and service of an International vehicle. Approved by Seller: Accepted by Purchaser: Official Title and Date Firm or Business Name Authorized Signature Authorized Signature and Date This proposal is not binding upon the seller without Seller's Authorized Signature Official Title and Date The TOPS FET calculation is an estimate for reference purposes only. The seller or retailer is responsible for calculating and reporting/paying appropriate FET to the IRS. 1 Proposal: