(8) 295/75R22.5 G395 LHS FUEL MAX (GOODYEAR) 517 rev/mile, load range

Transcription

1 August 04, 2008 Prepared For: San Pedro Bay Ports Patrick Couch 1 Park Plz Irvine, CA (949) Presented By: WESTRUX INT'L., INC. Doug Baldwin VALLEY VIEW AVE. SANTA FE SPRINGS CA (562) Model Profile MISSION: Requested GCWR: Calc. GVWR: Calc. Geared Speed: 75.6 MPH DIMENSION: Wheelbase: , CA: , Axle to Frame: ENGINE, DIESEL: {International MaxxForce 11} RPM Governed Speed, 1400 lbft 1000 RPM; 390 Peak HP (Max) TRANSMISSION, MANUAL: {Fuller FRO-16210B} 10-Speed Manual, With Overdrive, With Air Shift, With CLUTCH: Internal Lube Oil Pump {Eaton Fuller EP1552} Easy-Pedal Plus, Two-Plate, Cast Angle Spring; Ceramic, 15.5" Diameter, Soft Clutch 7-Spring Damper, Mechanical Pull-Type Control, With Kwik-Adjust(Manual) Feature, 1700 lb-ft Torque Capacity AXLE, FRONT NON-DRIVING: {Dana Spicer E-1202W} Wide Track, I-Beam Type, 12,000-lb Capacity AXLE, REAR, TANDEM: {Dana Spicer DST40/RST40} Single Reduction 40,000-lb Capacity; With 200 Wheel Ends Gear Ratio: 3.90 CAB: TIRE, FRONT: TIRE, REAR: SUSPENSION, REAR, AIR, TANDEM: PAINT: Extended Conventional (2) 295/75R22.5 G395 LHS FUEL MAX (GOODYEAR) 517 rev/mile, load range G, 14 ply (8) 295/75R22.5 G395 LHS FUEL MAX (GOODYEAR) 517 rev/mile, load range G, 14 ply {International} Ride Optimized Suspension (IROS) Heavy Duty; 52" Axle Spacing; 40,000-lb Capacity, 9.25" Ride Height, With Shock Absorbers, Heavy Duty Spring Hangers, Crossmembers and Fasteners Cab schematic 100GH Location 1: 9219, Winter White (Std) 1 Proposal:

2 August 04, 2008 Chassis schematic N/A 2 Proposal:

3 Description Base Chassis, Model 8600 SBA 6X4 with Wheelbase, CA, and Axle to Frame. FRAME RAILS WITH TAPERED REAR FRAME RAILS Heat Treated Alloy Steel (120,000 PSI Yield); " x 3.580" x 0.312" (257.2mm x 90.9mm x 8.0mm); 420.0" (10668mm) Maximum OAL BUMPER, FRONT Full Width, Aerodynamic, Steel; 0.142" Material Thickness, With Flexible End Caps WHEELBASE RANGE 173" (440cm) Through and Including 230" (585cm) AXLE, FRONT NON-DRIVING {Dana Spicer E-1202W} Wide Track, I-Beam Type, 12,000-lb Capacity SUSPENSION, FRONT, SPRING Parabolic, Taper Leaf; 12,000-lb Capacity; With Shock Absorbers : SPRING PINS Rubber Bushings, Maintenance-Free BRAKE SYSTEM, AIR Dual System for Tractor Applications : BRAKE CHAMBERS, SPRING (2) Rear Parking : BRAKE LINES Color and Size Coded Nylon : DRAIN VALVE Manually Cable Operated (On Wet Tank Only) : GAUGE, AIR PRESSURE (2) Air 1 and Air 2 Gauges; Located in Instrument Cluster : GLAD HANDS (2) One for Service and One for Emergency; Trailer Hoses from Cab : HAND CONTROL VALVE, AIR Mounted on Steering Column : HOSE TENDER Back of Cab Mounted : PARKING BRAKE VALVE and Combination Valve for Tractor and Trailer; Color-Coded Yellow and Red Knobs, Located on Instrument Panel : SLACK ADJUSTERS, FRONT Automatic : SLACK ADJUSTERS, REAR Automatic : SWITCH, AUXILIARY Interrupter for Cab and Trailer Clearance/Marker Lights (Blinks Lights with Headlight Switch in "OFF" or "ON" Position) Instrument Panel Mounted : TRACTOR PROTECTION VALVE AIR BRAKE ABS {Bendix AntiLock Brake System} Full Vehicle Wheel Control System (4-Channel) AIR DRYER {Meritor-Wabco System Saver 1200} Mounted in Standard Location BRAKES, FRONT, AIR CAM S-Cam; 15.0" x 4.0"; 20 Sq. In. MGM Long Stroke Brake Chambers BRAKES, REAR, AIR CAM 16.5" x 7.0"; MGM TR3030 Long Stroke Brake Chamber and Heavy Duty Spring Actuated Parking Brake AIR COMPRESSOR {Knorr Bremse LP-360 DLU} 15.9 CFM Capacity, Single Cylinder STEERING COLUMN Tilting and Telescoping STEERING WHEEL 2-Spoke, 18" Diam., Black STEERING GEAR {Sheppard M-100} Power Vehicle Specifications August 04, 2008 DRIVESHAFT SYSTEM {Dana Spicer} SPL170XL in lieu of 1760 Series and SPL170XL Inneraxle Shaft 3 Proposal:

4 Description EXHAUST SYSTEM Single, Vertical Aftertreatment Device Frame Mounted Right Side; Vertical Tail Pipe & Guard : MUFFLER/TAIL PIPE GUARD Non-Bright Finish ELECTRICAL SYSTEM 12-Volt, Standard Equipment : BATTERY BOX Steel; Mounted Left Side, Under Cab : DATA LINK CONNECTOR For Vehicle Programming and Diagnostics In Cab : FUSES, ELECTRICAL SAE Blade-Type : HAZARD SWITCH Push On/Push Off, Located on Top of Steering Column Cover : HEADLIGHT DIMMER SWITCH Integral with Turn Signal Lever : HORN, ELECTRIC Single : JUMP START STUD Located on Positive Terminal of Outermost Battery : PARKING LIGHT Integral with Front Turn Signal and Rear Tail Light : RUNNING LIGHT (2) Daytime, Included With Headlights : STARTER SWITCH Electric, Key Operated : STOP, TURN, TAIL & B/U LIGHTS Dual, Rear, Combination with Reflector : TURN SIGNAL SWITCH Self-Cancelling for Trucks, Manual Cancelling for Tractors, with Lane Change Feature : TURN SIGNALS, FRONT Reflectors and Auxiliary Side Turn Signals, Solid State Flashers; Flush Mounted : WINDSHIELD WIPER SWITCH 2-Speed with Wash and Intermittent Feature (5 Pre-Set Delays), Integral with Turn Signal Lever : WINDSHIELD WIPERS Single Motor, Electric, Cowl Mounted : WIRING, CHASSIS Color Coded and Continuously Numbered CIGAR LIGHTER Ash Cup POWER SOURCE Cigar Type Receptacle without Plug and Cord ALTERNATOR {Bosch LH160} Brush Type, 12 Volt 160 Amp. Capacity, Pad Mounted BATTERY SYSTEM {International} Maintenance-Free, (3) 12-Volt 1950CCA Total RADIO {Panasonic CQR-111} AM/FM, With Cassette Player, Multiple Dual Cone Speakers : SPEAKERS IN CAB (2) Dual-Cone with Deluxe Interior : SPEAKERS IN CAB (4) Coaxial with Premium Interior Vehicle Specifications August 04, 2008 HORN, AIR Black, Single Trumpet, Air Solenoid Operated, Mounted Behind Bumper on Right Rail WINDSHIELD WIPER SPD CONTROL Force Wipers to Slowest Intermittent Speed When Park Brake Set and Wipers Left on for a Predetermined Time HEADLIGHTS Halogen; Composite Aero Design for Two Light System; Daytime Running Lights TEST EXTERIOR LIGHTS Pre-Trip Inspection will Cycle all Exterior Lamps Except Back-up Lights HEADLIGHTS ON W/WIPERS Headlights Will Automatically Turn on if Windshield Wipers are turned on 4 Proposal:

5 Description ALARM, PARKING BRAKE Electric Horn Sounds in Repetitive Manner When Vehicle Park Brake is "NOT" Set, With Ignition "OFF" and any Door Opened STARTING MOTOR {Mitsubishi Electric Automotive America 105P} 12-Volt, Less Thermal Over Crank Protection GRILLE Chrome FRONT END Tilting, Fiberglass, With Three Piece Construction : BUG SCREEN Front End; Mounted Behind Grille PAINT SCHEMATIC, PT-1 Single Color, Design 100 : PAINT SCHEMATIC ID LETTERS "GH" PAINT TYPE Base Coat/Clear Coat, 1-2 Tone FIFTH WHEEL, AIR SLIDE {Fontaine SL7ATB775036} 36" Slide, 7.75" Above Top of Frame, Left Side Release GPS SYSTEM PREWIRE {Cadec} Wire Routed Under Scuff Plate and Carpet and Then Through Hole in Carpet and Coiled and Strapped Between Driver and Passenger Seat MUD FLAP HOLDER Spring Loaded, Painted Black; With Red and White Reflective Tape; Less Flaps QUARTER FENDERS for Rear Wheels, Black Plastic; Frame Mounted. CLUTCH {Eaton Fuller EP1552} Easy-Pedal Plus, Two-Plate, Cast Angle Spring; Ceramic, 15.5" Diameter, Soft Clutch 7-Spring Damper, Mechanical Pull-Type Control, With Kwik-Adjust(Manual) Feature, 1700 lb-ft Torque Capacity : CLUTCH RELEASE BEARING Greasable ENGINE, DIESEL {International MaxxForce 11} RPM Governed Speed, 1400 lb-ft 1000 RPM; 390 Peak HP (Max) : AIR COMPRESSOR AIR SUPPLY LINE Naturally-Aspirated : COLD STARTING EQUIPMENT Automatic; With Engine ECM Control : CRUISE CONTROL Electronic; Controls Integral to Steering Wheel : ENGINE BLOCK Compacted Graphite Iron : ENGINE SHUTDOWN Electric, Key Operated : FUEL FILTER Top Access, Cartridge Type Filter Element; Engine Mounted : FUEL SYSTEM High Pressure Common Rail : GOVERNOR Electronic : HEAT MANAGEMENT SYSTEM Eco-Therm : OIL FILTER, ENGINE Drop-In Cartridge Type : OIL PAN Laminate Steel Composite : TURBO Twin Series : WET TYPE CYLINDER SLEEVES FAN DRIVE {Horton V-Master-Ultra} Viscous Vehicle Specifications August 04, Proposal:

6 Vehicle Specifications August 04, 2008 Description : FAN Nylon FEDERAL EMISSIONS 2007 for International MaxxForce 11 Liter Engines RADIATOR Aluminum; Front to back system SqIn, Main, Down flow; 1381 SqIn, Aux, Cross flow Radiator : ANTI-FREEZE Red Shell Rotella Extended Life Coolant -40F (-40C) : DEAERATION SYSTEM Clear Remote Mounted Coolant Reservoir/Surge Tank With Pressure Rated Cap : RADIATOR HOSES Premium, Rubber AIR CLEANER Single Element : AIR CLEANER with Vacuator : GAUGE, AIR CLEANER RESTRICTION Air Cleaner Mounted COLD STARTING EQUIPMENT Automatic; With Engine ECM Control EMISSION COMPLIANCE Tamper-Proof Engine Shutdown System, Complies With California Clean Air Regulations TRANSMISSION, MANUAL {Fuller FRO-16210B} 10-Speed Manual, With Overdrive, With Air Shift, With Internal Lube Oil Pump : CLUTCH BRAKE Torque Limiting : FILL PLUG, MAGNETIC CLUTCH HOUSING Aluminum; Available With 1350 to 2050 lb-ft Capacity Fuller Transmissions OIL COOLER,MANUAL TRANSMISSION Effects for Water to Oil Type Included in Radiator (REQUIRES TRANSMISSION LUBE PUMP) TRANSMISSION OIL {EmGard 50W} Synthetic; 22 thru Pints SUSPENSION AIR CONTROL VALVE Pressure Release Control In Cab AXLE, REAR, TANDEM {Dana Spicer DST40/RST40} Single Reduction 40,000-lb Capacity; With 200 Wheel Ends. Gear Ratio: 3.90 : POWER DIVIDER LOCK Air Operated, Cab Control with Indicator Light in Cluster : REAR AXLE DRAIN PLUG (2) Magnetic, For Tandem Rear Axle SUSPENSION, REAR, AIR, TANDEM {International} Ride Optimized Suspension (IROS) Heavy Duty; 52" Axle Spacing; 40,000-lb Capacity, 9.25" Ride Height, With Shock Absorbers, Heavy Duty Spring Hangers, Crossmembers and Fasteners AXLE, REAR, LUBE {EmGard 75W-90} Synthetic Oil; 65 thru Pints FUEL/WATER SEPARATOR {Davco Fuel Pro 382 (382030)} With Fuel Heated Fuel Heater, Thermostatic Fuel Temperature Control, Mounted In Standard Position FUEL TANK Non-Polished Aluminum, 26" Diam., 100 U.S. Gal., 378 L Capacity Mounted Left Side Under Cab 6 Proposal:

7 Vehicle Specifications August 04, 2008 Description CAB Extended Conventional : ARM REST (2) Molded Plastic; One Each Door : CLEARANCE/MARKER LIGHTS (5) Flush Mounted : COAT HOOK, CAB Located on Rear Wall, Centered Above Rear Window : CUP HOLDERS Two Cup Holders, Located in Lower Center of Instrument Panel : DOME LIGHT, CAB Rectangular, Door Activated and Push On-Off at Light Lens, Timed Theater Dimming, Integral to Console, Center Mounted : GLASS, ALL WINDOWS Tinted : GRAB HANDLE, CAB INTERIOR (1) "A" Pillar Mounted, Passenger Side : GRAB HANDLE, CAB INTERIOR (2) "B" Pillar Mounted, One Each Side : PLEASE NOTE: 26" CA Loss : STEP (4) Two Steps Per Door : WINDOWS, PRIVACY GLASS Rear Side Windows and Rear Window, Dark PrivaGuard Glass GAUGE CLUSTER English With English Electronic Speedometer : GAUGE CLUSTER (6) Engine Oil Pressure (Electronic), Water Temperature (Electronic), Fuel (Electronic), Tachometer (Electronic), Voltmeter, Washer Fluid Level : ODOMETER DISPLAY, Miles, Trip Miles, Engine Hours, Trip Hours, Fault Code Readout : WARNING SYSTEM Low Fuel, Low Oil Pressure, High Engine Coolant Temp, and Low Battery Voltage (Visual and Audible) IP CLUSTER DISPLAY On Board Diagnostics Display of Fault Codes in Gauge Cluster SEAT, DRIVER {National 2000} Air Suspension, High Back With Integral Headrest, Vinyl, Isolated, With 2 Position Front Cushion Adjustment, -3 to +14 Degree Seat Back Adjustment, Single Chamber Air Lumbar Support : SEAT BELT 3-Point, Lap and Shoulder Belt Type SEAT, PASSENGER {Gra-Mag} Non Suspension, High Back With Integral Headrest, Vinyl, With Fixed Back : SEAT BELT 3-Point, Lap and Shoulder Belt Type BUNK, LOWER 26" Wide; Mattress, Occupant Restraints and Under Bunk Storage Compartment MIRROR, CONVEX, LOOK DOWN {Lang Mekra} Right Side; 6" x 10 1/4" MIRROR, CONVEX, HOOD MOUNTED {Lang Mekra} Right Side; 7.44" Sq. MIRRORS (2) {Lang Mekra} Rectangular, 7.44" x 14.84", Brackets Breakaway Type, With 102" Wide Spacing, With 7.44" sq. Convex Both Sides, With Black Heads, Brackets & Arms INSTRUMENT PANEL Center Section, Ergonomic Panel AIR CONDITIONER {International Blend-Air} With Integral Heater & Defroster : HEATER HOSES Premium : REFRIGERANT Hydrofluorocarbon HFC-134A 7 Proposal:

8 Vehicle Specifications August 04, 2008 Description FRESH AIR FILTER for HVAC STORAGE POCKET, DOOR Molded Plastic, Full Width; Mounted on Passenger Door CAB REAR SUSPENSION Air Bag Type CAB INTERIOR TRIM Deluxe; for Extended Cab : "A" PILLAR COVER Molded Plastic : CAB INTERIOR TRIM PANELS Cloth Covered Molded Plastic, Full Height; All Exposed Interior Sheet Metal is Covered Except for the Following: with a Two-Man Passenger Seat the Back Panel is Only Partially Covered and with a Full Bench Seat the : CONSOLE, OVERHEAD Molded Plastic with Dual Storage Pockets and Retainer Nets and CB Radio Pocket : DOOR TRIM PANELS Molded Plastic; Driver and Passenger Doors : FLOOR COVERING Rubber, Black : HEADLINER Soft Padded Cloth : INSTRUMENT PANEL TRIM Molded Plastic with Black Center Section : STORAGE POCKET, DOOR (1) Molded Plastic, Full-Length; Driver Door : SUN VISOR (2) Padded Vinyl with Driver Side Toll Ticket Strap, Integral to Console WHEELS, FRONT DISC; 22.5" Painted Steel, 5 Hand Hole, 10-Stud (285.75MM BC) Hub Piloted, Flanged Nut, Metric Mount, 8.25 DC Rims; With Steel Hubs. : PAINT IDENTITY, FRONT WHEELS White : WHEEL SEALS, FRONT Oil Lubricated, Wheel Bearings WHEELS, REAR DUAL DISC; 22.5" Painted Steel, 5 Hand Hole, 10-Stud (285.75MM BC) Hub Piloted, Flanged Nut, Metric Mount, 8.25 DC Rims; With Steel Hubs. : PAINT IDENTITY, REAR WHEELS White : WHEEL SEALS, REAR Oil Lubricated, Wheel Bearings WARRANTY Heavy Duty Standard (2) TIRE, FRONT 295/75R22.5 G395 LHS FUEL MAX (GOODYEAR) 517 rev/mile, load range G, 14 ply (8) TIRE, REAR 295/75R22.5 G395 LHS FUEL MAX (GOODYEAR) 517 rev/mile, load range G, 14 ply FIFTH WHEEL LOCATION 06.0" Ahead of Rear Axle Centerline Tire Monitor/Reifll/Fire&Tri/Fuel/install AVL 8 Proposal: