Drying Tumblers 120 Pound Capacity Refer to Page 3 for Model Numbers Cover

Transcription

1 HIGH LOAD READY MEDIUM TEMPERATURE LOW LOW AIR FLOW NON REV REV PUSH TO START Drying Tumblers 0 Pound Capacity Refer to Page 3 for Model Numbers Cover Parts COOLING DRYING T0C Part No. M4847R July 000

2 Table of Contents Title Page Parts Ordering Information... Nameplate Location... Model Identification... 3 Dual Timer Controls... 4 Temperature Controls... 6 Access and Lint Panels... 8 Front Panel... 0 Door Assembly... Vent Pipe and Elbow... 4 Lint Screen and Drive Guard... 6 Drive Sheave, Step Pulley and Belts... 8 Trunnion Bearings... 0 Cylinder Drive Motor... Fan and Motor Assembly... 4 Fan and Motor Assembly... 6 Cylinder and Trunnion Shaft... 8 Gas Burner Unit Steam Heating Unit... 3 Reversing Control Air Flow Switch Assembly Wire Harnesses Burner Orifices Parts Index Copyright 000, Alliance Laundry Systems LLC All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher. M4847

3 If literature or replacement parts are required, contact the source from whom the machine was purchased or contact Alliance Laundry Systems at (90) for the name and address of the nearest authorized parts distributor. For technical assistance, call (90) Parts Ordering Information When calling or writing about your product, be sure to mention model and serial numbers. Model and serial numbers are located on nameplate(s) as shown. Nameplate Location JUNCTION BOX COVER NAMEPLATE WIRING DIAGRAM M4847

4 Model Identification Information in this manual is applicable to these drying tumblers: DT0FG DT0CSH M4847 3

5 Notes

6 Dual Timer Controls PUSH TO START COOLING DRYING T56P 4 M4847

7 Dual Timer Controls REF PART # DESCRIPTION COMMENTS M Light 60 Hertz M Light 50 Hertz M Push-To-Start Switch 3 M4009 Relay 60 Hertz M4009 Relay 50 Hertz Screw 5 M40900P Cooling Timer 60 Hertz; 5 minute M4090P Cooling Timer 50 Hertz; 5 minute 6 M4090P Drying Timer 60 Hertz; 60 minute M40903P Drying Timer 50 Hertz; 60 minute 7 H Screw 8 M405 Screw 9 M Timer Knob 0 M40007 Screw M4964 Timer Graphics Panel Black M4847 5

8 Temperature Controls T34P 6 M4847

9 Temperature Controls REF PART # DESCRIPTION COMMENTS 904 Fuse Holder Fuse Terminal Block Signal Buzzer 60 Hertz Signal Buzzer 50 Hertz M Instant Electronic Ignition Control 60 Hertz M48 Instant Electronic Ignition Control 50 Hertz M Light 60 Hertz M Light 50 Hertz 3 M4333 Thermostat 4 H96443 Reversing/Nonreversing Switch 5 M4344 Temperature Knob Screw 7 M4965 Graphics Plate Black M4847 7

10 Access and Lint Panels Front Panel T57P 8 M4847

11 Access and Lint Panels REF PART # DESCRIPTION COMMENTS Screws 6 required; Not included with M4558 M4963 Nameplate H Screw 3 M4090 Screw 4 M4348* Top Access Panel Painted M4349 Top Access Panel Stainless Steel 5 H87000 Roller Catch 6 M Screw Nut 8 M4453* Lint Panel Painted M4454 Lint Panel Stainless Steel Screw 0 M4443 Kickplate M4558 Bumper Black * Add letter to designate color: L - Almond W - White V - Orange K - Red B - Battina Green H - Harvest Gold X - Electric Blue P - Turquoise M4847 9

12 Front Panel T58P 0 M4847

13 Front Panel REF PART # DESCRIPTION COMMENTS M489 Wire Harness For door switch M4383* Front Panel Painted M4384 Front Panel Stainless Steel M4089 Warning Label 3 H Insulator 4 H9644 Door Switch 5 H88556 Lockwasher 6 H Nut 7 M4009 Hinge Pin 8 M4004 Upper Panel Hinge 9 H Screw 0 M40067 Washer M4004 Lower Panel Hinge M4093 Warning Label 3 H88067 Screw 4 M40007 Screw 5 M403 Door Catch 6 H Screw * Add letter to designate color: L - Almond W - White V - Orange K - Red B - Battina Green H - Harvest Gold X - Electric Blue P - Turquoise M4847

14 Door Assembly T59P M4847

15 Door Assembly REF PART # DESCRIPTION COMMENTS M4089* Door Assembly Painted M4090 Door Assembly Stainless Steel M40066 Door Strike Screw Not included with door assembly 3 Q663 Nut Not included with door assembly 4 H Door Gasket Not included with door assembly 5 H Screw Hinge Mounting Not included with door assembly 6 M Screw Hinge Mounting Not included with door assembly 7 M40030 Upper Door Hinge Not included with door assembly 8 M4003 Lower Door Hinge Not included with door assembly 9 M Actuator Not included with door assembly Nut Not included with door assembly M Door Glass Seal M409899P Door Glass and Seal Kit Includes M M40033 Door Handle 4 M Screw * Add letter to designate color: L - Almond W - White V - Orange K - Red B - Battina Green H - Harvest Gold X - Electric Blue P - Turquoise M4847 3

16 Vent Pipe and Elbow T530P 4 M4847

17 Vent Pipe and Elbow REF PART # DESCRIPTION COMMENTS M Screw H Bracket M4847 5

18 Lint Screen and Drive Guard M4847

19 Lint Screen and Drive Guard REF PART # DESCRIPTION COMMENTS M43 Drive Guard Bottom M44 Drive Guard Side M4 Drive Guard Top 3 M Screw 4 M4 Drive Guard Cover 5 M40965 Lint Screen Frame 6 M40977 Lint Screen M4847 7

20 Drive Sheave, Step Pulley and Belts Motor Sheave T53P 8 M4847

21 Drive Sheave, Step Pulley and Belts REF PART # DESCRIPTION COMMENTS H Step Pulley Bearings Outer H Step Pulley Bearings Inner H Retainer Ring required H8755H Sheave H Tube 3 H Bolt 4 M4337 Eyebolt 5 M Nut 6 M Washer 7 M40004 Lockwasher Nut 9 H Jackshaft Assembly Screw H Belt H Step Pulley 3 H Retainer Ring 4 H P Belt Set of 3 5 H875985H Bushing M4847 9

22 Trunnion Bearings T533P 0 M4847

23 Trunnion Bearings REF PART # DESCRIPTION COMMENTS 074 Nut H Screw 3 M40004 Lockwasher 4 M40008 Washer 5 H Trunnion Bearing 6 H88703 Screw 7 H Nut 8 H8858 Lockwasher 9 H Mounting Bracket Screw M4847

24 Cylinder Drive Motor M4847

25 Cylinder Drive Motor REF PART # DESCRIPTION COMMENTS 074 Nut M Washer 3 M40004 Lockwasher 4 H87599 Taper Bushing 60 Hertz H8759 Taper Bushing 50 Hertz 5 H Drive Sheave 60 Hertz H Drive Sheave 50 Hertz 6 M40863 Cylinder Drive Motor Volt, 60 Hertz, 3 Phase M40864 Cylinder Drive Motor Volt, 50 Hertz, 3 Phase 7 H875006H Key Screw 9 H Bracket 0 H Motor Base H Nut H8858 Lockwasher 3 M Nut 4 H Tube 5 H Screw 6 M4337 Eyebolt M4847 3

26 Fan and Motor Assembly (60 Hertz Models) T535P 4 M4847

27 Fan and Motor Assembly (60 Hertz Models) REF PART # DESCRIPTION COMMENTS M4403 Thermostat High Limit H H Thermostat Load Ready M40860 Motor Volt, 60 Hertz, 3 Phase H875006H Key 3 M Damper and Hinge 4 H8759 Bushing 5 H Fan 6 H88455 Screw 7 H Fan Cover Lockwasher Nut 0 H Motor Bracket H Screw 8 Screw M4847 5

28 Fan and Motor Assembly (50 Hertz Models) M4847

29 Fan and Motor Assembly (50 Hertz Models) REF PART # DESCRIPTION COMMENTS H876830H Flangette required M4337 Eyebolt H8759 Bushing 3 H Sheave 4 M4086 Fan Motor Volt, 50 Hertz, 3 Phase 5 H Motor Base 6 M Damper and Hinge 7 H87590 Bushing 8 H Fan 9 H Bracket 0 M455 Thermostat High Limit H H Thermostat Load Ready H Cover H8768H Bearing Insert 3 H Base for Fan Shaft 4 H87600H Pillow Block Bearing 5 H Tube 6 H875006H Key 7 H Sheave 8 H Fan Shaft 9 H875370H Belt M4847 7

30 Cylinder and Trunnion Shaft T537P 6 8 M4847

31 Cylinder and Trunnion Shaft REF PART # DESCRIPTION COMMENTS H Cylinder Galvanized M Cylinder Stainless Steel M Cylinder Poly Coated H Trunnion Assembly 3 M Nut 4 M4040 Spacer 5 H88304 Rib Rod 6 H Cylinder and Shaft Assembly Galvanized M Cylinder and Shaft Assembly Stainless Steel M Cylinder and Shaft Assembly Poly Coated M4847 9

32 Gas Burner Unit Burner Orifice M4847

33 Gas Burner Unit REF PART # DESCRIPTION COMMENTS M4573P3 Conversion Kit 60 Hertz; Natural to L.P. (Liquefied Petroleum) Gas M4577P3 Conversion Kit 50 Hertz; Natural to L.P. Gas M464 Elbow Screw 3 M464 Clamp 4 M465 Gas Pipe 5 M46 Bracket Wire Harness Bracket 8 M4404 Thermostat 60 Hertz; High Limit M455 Thermostat 50 Hertz; High Limit 9 M405 Burner 3 required 0 M454 Spud Holder M Igniter M4549 High Voltage Lead 3 M449 Union 4 M447 Nipple 5 M48 Gas Valve 60 Hertz; Natural and L.P. M4544 Gas Valve 50 Hertz; Natural M46 Gas Valve 50 Hertz; L.P. 6 M463 Shut-Off Valve 7 M459 Bracket 8 M Cover M4847 3

34 Steam Heating Unit T44P 3 3 M4847

35 Steam Heating Unit REF PART # DESCRIPTION COMMENTS H Bearing Flangette required H Bearing Insert 3 M4395 Steam Solenoid Valve All 60 Hertz M4398 Steam Solenoid Valve All 50 Hertz M4399 Coil for Solenoid Valve 0 Volt, 60 Hertz M4330 Coil for Solenoid Valve 40 Volt, 50 Hertz 4 H Housing Cover 5 H Damper Link 6 H Damper Shaft A Damper Motor 8 M4333 Counterweight 4 required 9 H Actuator Arm Assembly 0 H Chain H Connecting Link H Damper Drive Wheel 3 H Bracket 4 H Damper required 5 H Steam Coil required 6 H Actuator 7 H Filter required M

36 Reversing Control T53P 34 M4847

37 Reversing Control REF PART # DESCRIPTION COMMENTS 3356 Screw M469 Reversing Contactor 0 Volt, 60 Hertz M4055 Reversing Contactor 40 Volt, 50 Hertz Screw 4 M4683 Reversing Timer 5 M4039 Transformer On 50 Hertz models, transformer is located in temperature control area. 6 M Terminal Block 60 Hertz M Terminal Block 50 Hertz 7 M4050 Din Rail 8 M4059 Fan Contactor 60 Hertz, 4 Pole M40457 Fan Contactor 50 Hertz M

38 Air Flow Switch Assembly (Mounted on Back of Cabinet) T7P 36 M4847

39 Air Flow Switch Assembly (Mounted on Back of Cabinet) REF PART # DESCRIPTION COMMENTS M40938 Screw H83055 Switch 0 Amp 3 H Bracket 4 H Hex Nut Lockwasher 6 H Insulation Cotter Pin Vane M

40 Wire Harnesses PART NO. DESCRIPTION GAS STEAM M486 Timer Harness X X M487 Rear Control Box to Timer X X M488 Rear Control Box to Front Temperature Control Area X X M490 Internal Rear Control Box Wiring X X M49 Air Flow Switch X X M49 Air Flow Switch to Exhaust High Limit X X M493 Blower Motor X X M494 Reversing Drive Motor X X M495 Stove High Limit Thermostat X M496 IEI Igniter Control X M4637 Steam Damper Motor X M4699 Steam Solenoid Valve X Burner Orifices Gas Type Altitude (feet) Orifice Part No. Natural Gas 0,000 No. M437,00 4,000 No. 4 M437 4,00 6,000 No. 6 M4373 6,00 8,000 No. 7 M4374 8,00 0,000 No. 9 M40995 L.P. 0,000 No. 33 M400 (Liquefied Petroleum),00 4,000 No. 35 M ,00 6,000 No. 36 M4375 6,00 8,000 No. 38 M4376 8,00 0,000 No. 40 M M4847

41 Parts Index A Actuator H M Actuator Arm Assembly H Air Flow Switch M Air Flow Switch to Exhaust High Limit M B Base for Fan Shaft H Bearing Flangette H Bearing Insert H8768H... 7 H Belt H875370H... 7 H H P... 9 Blower Motor M Bolt H Bracket H H H H , 7 M M Bumper M Burner M Bushing H , 7 H H875985H... 9 C Chain H Clamp M Coil for Solenoid Valve M M Connecting Link H Conversion Kit M4573P3...3 M4577P3...3 Cooling Timer M40900P...5 M4090P...5 Cotter Pin Counterweight M Cover H M Cylinder H M M Cylinder and Shaft Assembly H M M Cylinder Drive Motor M M D Damper H Damper and Hinge M , 7 Damper Drive Wheel H Damper Link H Damper Motor 85008A...33 Damper Shaft H Din Rail M Door Assembly M M Door Catch M Door Gasket H Door Glass M Door Glass and Seal Kit M409899P...3 Door Handle M Door Strike Screw M Door Switch H Drive Guard Bottom M M

42 Drive Guard Cover M Drive Guard Side M Drive Guard Top M Drive Sheave H H Drying Timer M4090P... 5 M40903P... 5 H Hex Nut H High Voltage Lead M Hinge Pin M Housing Cover H E Elbow M Eyebolt M , 3, 7 F Fan H , 7 Fan Contactor M M Fan Cover H Fan Motor M Fan Shaft H Filter H Flangette H876830H... 7 Front Panel M M Fuse Fuse Holder G Gas Pipe M Gas Valve M M M Graphics Plate M I IEI Igniter Control M Igniter M Instant Electronic Ignition Control M M Insulation H Insulator H Internal Rear Control Box Wiring M J Jackshaft Assembly H K Key H875006H...3, 5, 7 Kickplate M L Light M , 7 M , 7 Lint Panel M M Lint Screen M Lint Screen Frame M Lockwasher H , 3 H M ,, M4847

43 Lower Door Hinge M Lower Panel Hinge M Rib Rod H Roller Catch H M S Motor M Motor Base H , 7 Motor Bracket H Mounting Bracket H N Nameplate M Nipple M Nut H H , 3 M , 3, 9 Q ,, Screw H H H H H H , 9, H H M M , M , 7 M M M M ,, , Screw Hinge Mounting H M Screws P Pillow Block Bearing H87600H... 7 Push-To-Start Switch M R Rear Control Box to Front Temperature Control Area M Rear Control Box to Timer M Relay M M Retainer Ring H H Reversing Contactor M M Reversing Drive Motor M Reversing Timer M Reversing/Nonreversing Switch H Sheave H H H8755H...9 Shut-Off Valve M Signal Buzzer Spacer M Spud Holder M Steam Coil H Steam Damper Motor M Steam Solenoid Valve M M M Step Pulley H Step Pulley Bearings H H Stove High Limit Thermostat M Switch H M4847 4

44 T Taper Bushing H H Temperature Knob M Terminal Block M M Thermostat H H... 5, 7 M M M M M Timer Controls M Timer Graphics Panel M Timer Knob M Top Access Panel M M Transformer M Trunnion Assembly H Trunnion Bearing H Tube H , 7 H U Union M Upper Door Hinge M Upper Panel Hinge M V Vane W Warning Label M M Washer M , 3 M M Wire Harness M M4847