Super Charger psi Compressor
|
|
- Dylan Hunter
- 6 years ago
- Views:
Transcription
1 Super Charger 4500 psi Compressor
2 COMPRESSOR OPERATION: Get it right first time. Your simple steps to successful operation. 1. Unscrew the Water Tank Cap, on the top of Supercharger. Pour in contents of both bottles (Ice & Antifreeze). Then, top up with water to an inch below the rim. Pure / filtered water is best, tap water is OK, but NEVER use distilled water. Screw glass top cover back on. 2. The self drainage adjust device (right hand side of front panel) allows you to set the moisture drainage frequency. This is dependent on humidity in the environment. The damper it is, the more venting you'll need. Set the knob on the left for the length of venting in seconds. It is suggested that you set it, initially, at 0.5. The knob on the right controls how often it vents in minutes. If filling an air cylinder, set the left hand knob to 1 second and the right hand knob to vent every 15 minutes as a good start point. In warm, dry conditions, you can set it to min.. Frequent and long venting slows down the fill speed. 3. The over-current protector switch should be set to RESET. 4. Plug the power cable in to the Supercharger. Turn on using on/off rocker switch. This activates the water pump and fan. Check that water is flowing by looking through sight glass in the water cap. 5. At the top of the compressor, screw the fill hose in firmly. 6. Set the PSI you require on the main dial by pushing in the knob and turning. The short metal arm pushes the needles into position. Set both needles so they are together. Do not fill air tanks above 4500 PSI, as the burst disc is set to 4800 PSI. If disc bursts, there are spares in the kit pack. (Small, gold circular discs). Use the supplied tweezers, if necessary. 7. Attach the other end of the hose firmly to the tank/cylinder using 1/8 inch quick-connect adaptor. 8. Push green button to start tank-filling. It's normal to hear a rocking/ tapping sound. 9. The Supercharger stops automatically at the correct PSI. Then, close air tank & bleed out excess air from compressor using the Bleed Valve. Air is expelled at rear of compressor. Be sure to release excess air from hose before removing adaptor from tank/gun. ALL RIGHTS RESERVED Copyright and Trademark 2014 Raptor Pneumatics, LLC
3 Where to put your Omega Supercharger Place your Supercharger on a smooth flat surface. Do not operate / store in dusty humid conditions or below 35 F. Allow 2 space behind compressor for air exiting. For long term storage, keep indoors and away from freezing temps. In sub-zero temps, drain water tank and fill with pure antifreeze, run for 1 min. Use supplied cover. Fill times Typically, for a rifle 3-5 min A 12cf tanks takes min from psi A 75cf tank take hrs from psi Maintenance After every 6 hrs of compressor operation or when the red indicating light comes on, turn green grease screw 1 click (1/3 turn). Fill cavity when low (use white grease syringe). Push the red indicating light to reset. Top off water tank as necessary If changing the water, use ½ ounce of Royal Purple ICE and regular 1 ounce of regulator antifreeze. Fill with purified water, never use distilled water. Fill below water flume.
4 Troubleshooting Compressor not on (no lights) Make sure there is power at outlet Make sure power cord is pushed in on the compressor Make sure the red circuit breaker hasn t tripped Take off side panels and look for loose wires Compressor is not running but lights are on Make sure there is water in tank and its flowing, the compressor is equipped with a flow switch, so if the water pump is not working the compressor will not turn on. Tap on water pump to unblock trapped air. Loose wires Compressor not building pressure Make sure bleed screw is tight, as the compressor builds PSI, you might need to retighten. Check burst disc for damage (is air coming out of the tiny hole?). Replacement disc in maintenance bag. Tighten fitting to firm snug. Check main check valve (under 19mm brass fitting). Look for burnt or dirty valve, clean hole where valve is located. New valves are in maintenance bag. Place small end of spring on valve and center, replace brass fitting,tighten to about 5lb. No water flow Make sure there is water in tank, turn the master switch on and off many times so as to prime and push any air bubbles out Check for 12 volts at water pump, if no volts, replace / check wires at circuit board If there is volts, replace water pump
5
6 NO NAME NO NAME NO NAME 1 level 1 cylinder sleeve 36 rubber sleeve 71 water tank cap 2 level 2 cylinder sleeve 37 inner sealed ring 72 handle 3 level 3 cylinder sleeve 38 locating pad 73 high pressure pipe 4 cylinder seat 39 high pressure pole 74 filter body 5 grease port 40 oil-way catch 75 filter's clamp ring 6 grease port seat 41 sealing seat 76 filter cover 7 oil column 42 high pressure pole fixed seat 77 Drain valve gasket 8 cylinder bolt 43 3mm pin 78 Drain valve sealing gasket 9 burst nut 44 fixed seat at bottom 79 Drain valve core 10 burst disc 45 85*6 guide ring 80 Drain valve body 11 burst nut seat 46 Connecting rod pin 81 solenoid 12 check valve 47 Connecting rod check valve gasket 48 high pressure air pipe high pressure pipe 49 crankshaft box oil-way connect pipe 50 crankshaft oil-way locating pin 51 outside shell bottom panel oil-way liner 52 bearing sleeve level 2 piston 53 needle roller bearing mm rubber ball 54 crankshaft cover Level 2 cylinder piston guide ring 55 left cover Level 2 cylinder piston sealing rin 56 crankshaft box cover Level 2 cylinder piston sealing rin 57 Air intake filter cover Level 2 cylinder piston thread nut 58 valves Level 2 cylinder piston guide ring 59 crankshaft box cover mm rubber ball 60 outside shell fixed panel 61 motor *4 guide ring 62 water tank High pressure piston cover 63 right cover High pressure piston gasket 64 bleed valve High pressure valve core 65 bleed valve nut sealed ring outside 66 bleed valve gasket high pressure piston sealing 67 bleed valve seat high pressure piston body 68 bleed valve connect pipe stop ring 69 gauge connect pipe Cone pad 70 gauge 105
7
8 1.Level 2 cylinder piston guide ring 2.Level 2 cylinder piston sealing ring 3.Level 2 cylinder piston guide ring 4.Level 2 cylinder sealing ring 5.Level 2 cylinder piston sealing ring (up) 6.Level 2 cylinder piston sealing ring (down) 7.Level 2 cylinder piston sealing ring 8.Level 2 cylinder piston sealing gasket 9.High pressure piston sealing ring 10.High-pressure piston sealing gasket 11.sealed ring outside 12.rubber ball 13.High pressure valve core 14.φ 3 spring 15.φ 4-φ 7 pagoda spring 16.check valve gasket 17.Burst disc 18.Sealing gasket of bleed valve 19. Nozzle Cleaner 20.special spanner 21.7mm allen wrench
9 RAPTOR PNEUMATICS, LLC ONE YEAR RETAIL LIMITED WARRANTY RAPTOR PNEUMATICS, LLC (RP) warranties to the original consumer of this product that it will be free from workmanship and material defects based upon normal usage during the time of the warranty, or 12 months from the date of purchase. This warranty covers the, materials, labour and parts needed to repair.rebuild or replace the faulty part or equipment, at RP's option, for a period of one (1) year (shipping not included). The warranty period commences from the date on which the original buyer purchases the equipment. This limited warranty covers manufacturing defects that occur during the warranty period. RP will, at its discretion, repair, rebuild or replace the faulty part or equipment in accordance with the terms set forth below. If the customer chooses to repair the problem at their home or facility, then thedamaged part must first be returned to RP and then a replacement part will be shipped out, at the customer's expense, to the address that the customer specifies. Warranty Terms During this 12 month warranty period, the product will be repaired, rebuilt, or replaced at no charge to the consumer, when returned to RP with the sale receipt or invoice (containing date of purchase)according to the following terms. This warranty covers the, materials, labour and parts needed to repair, rebuild or replace the faulty part or equipment, at RP's option, for a period of one (1) year (shipping not included). This owner's limited warranty is only valid, if the item is used in an environment approved by RP for that particular equipment. The warranty is invalid if the product has been misused, abused or damaged from causes not arising out of defects in material or workmanship. RP cannot be held responsible for any subsequent damages to the machine or to the user's human body that may arise from use of this unit after the defect or damage has occurred. This owner's limited warranty applies to the EZ- FILL 4500 PCP, Paint Ball or Scuba Compressor. Warranty repairs will not extend the warranty period. Warranty Restrictions This owner's warranty only covers the following: a. Flaws caused by materials or labour in the equipment that existed when the equipment was originally assembled. b. Faults that occur in normal use as defined in the owner's manual and providing that RP's instructions on start-up, maintenance and use have been followed. c. The original purchaser of the equipment who holds an original proof of purchase. (Continued ) ALL RIGHTS RESERVED Copyright and Trademark 2014 Raptor Pneumatics, LLC
10 This warranty does not extend to, or cover, any of the following: a. Equipment or components that have been modified without the consent of RP. b. Faults resulting from natural wear and tear, use in conditions for which the equipment is not intended, corrosion, or damage incurred during loading or shipping not provided by RP, or by accident, fire, flood, war or acts or God. c. Maintenance activities, such as cleaning, lubricating, or normal checking of parts: or installation procedures that customers can do themselves. d. Damage or equipment failure caused by faulty electrical wiring used to power the equipment. (i) electrical wiring not in compliance with applicable electrical codes. (ii) electrical wiring not in compliance with the owner's manual or (iii) electrical wiring that has not been maintained as outlined in owner's manual. e. Repairs performed by someone other than an authorized RP representative. f. Repairs due to limitations or corrections in the equipment's software. g. Repairs to consumable or cosmetic items, e.g., grips, seals, labels, or wheels. h. Repairs performed on equipment missing a serial number or with a serial tag that has been altered or removed. i. Service calls to correct installation of the equipment or instruct owners on how to use the equipment. j. Pick-up, delivery, or freight charges involved with repairs. RP MAKES NO EXPRESS WARRANTIES OR CONDITIONS BEYOND THOSE STATED IN THIS OWNER'S WARRANTY. RP DISCLAIMS ALL OTHER WARRANTIES AND CONDITIONS, EXPRESS, OR IMPLIED, INCLUDING WITHOUT LIMITATION IMPLIED WARRANTIES AND CONDITION OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE. SOME STATES (OR JURISDICTIONS) DO NO ALLOW LIMITATIONS ON IMPLIED WARRANTIES OR CONDITIONS, SO THIS LIMITATION MAY NOT APPLY TO THE USER OR OWNER. RP'S RESPONSIBILITY FOR MALFUNCTIONS AND DEFECTS IN THE EQUIPMENT IS LIMITED TO REPAIR AND REPLACEMENT AS SET FORTH IN THIS OWNER'S WARRANTY. THESE WARRANTIES GIVE THE USER OR OWNER SPECIFIC LEGAL RIGHTS, AND THE USER OR OWNER MAY ALSO HAVE OTHER RIGHTS, WHICH VARY FROM STATE TO STATE (OR JURISDICTION). RP DOES NOT ACCEPT LIABILITY BEYOND THE REMEDIES SET FORTH IN THIS WARRANTY STATEMENT OR LIABILITY FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES. SOME STATES (OR JURISDICTIONS) DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES, SO THE PRECEDING EXCLUSION OR LIMITATION MAY NOT APPLY TO THE USER OR OWNER. Despite continuous quality control, faults or operating errors in equipment may result from individual components. Delivering the complete piece of equipment for repair is often unnecessary, because the flaw can usually be fixed by replacing just the faulty part. It is preferable that you make any inquiries about the warranty directly to your RP retailer or to RP directly. Please contact the store where you purchased your compressor or to Gilbert Distribution Ltd : info@gilbertdistribution.co.uk ALL RIGHTS RESERVED Copyright and Trademark 2014 Raptor Pneumatics, LLC
11 We, at RP, want to develop our products and services continuously according to the needs and wishes of our customers. For this reason, we kindly ask you to complete the registration card and send it to us as soon as possible, preferably within ten days of purchasing the equipment. If registration is intended, it must be made within two (2) months of the date of purchase. Please fill in all the fields to ensure that we can serve you as efficiently as possible. PLEASE COMPLETE, SCAN, SIGN AND BACK TO: Registration Card Name of Owner: Address: City, State: Zip Code: Phone Number: Serial Number: Date of Purchase: Place or Purchase: Purchaser's Signature: - ALL RIGHTS RESERVED Copyright and Trademark 2014 Raptor Pneumatics, LLC
12 This repair guide applies to the following Omega Compressor Models: Omega Super Charger and Turbocharger Warning Prior to Starting any Repair or Service Make sure the power cord is disconnected from the compressor All air is completely released from the compressor 1. Gauge replacement disconnect the connector on the back of the gauge, unscrew the 3 Philip head screws, take out old gauge, install new gauge and push connector back on, tighten screws. 2. Water pump replacement Drain water from unit, disconnect quick connector at the circuit board, loosen the two (2) hose clamps. Install new water pump and reconnect the connector at circuit board. 3. Fan replacement Disconnect quick connector. Unscrew four (4) Philip head screws. Please Note: The fan placement should be directed so that the air blows into fan. Install new fan and replace all the hardware. 4. Fill hose replacement Use a 14 mm wrench, unscrew fill hose and install the new hose, tighten the new fill hose. Use soapy water to test for any air leaks. 5. Air/Water separator replacement and Automatic solenoid Disconnect the 3 wires on the side of the solenoid, make note of the color and position of wires. Use (2) 14mm wrenches and undo the steel line from the bottom and from the top inside of the air/water separator. Remove all the screws that hold the case on. Carefully remove the case, watch out for wires and hoses that might get caught up. Take out the 2 small screws on top of separator. Carefully pull out and disconnect solenoid. To take apart solenoid, loosen nut on top of black coil, unscrew plunger housing from air/water separator, being careful not to lose the small spring that is inside of plunger, clean plunger and oil it.. Install the new Air/Water separator and put solenoid back together making sure small spring is inside of plunger. Replace all the lines and wires. 6. Burst Disc replacement Use a 19 mm wrench to hold the brass fitting tightly while a 14 mm wrench is used to undo the brass fitting that holds the burst disc in place. Remove the damaged burst disc. Install the new burst disc and gently tighten the brass fitting. Then spray soapy water around the burst disk and check for any air leaks.
COMPRESSOR OPERATION: Get it right first time. Your simple steps to successful operation.
COMPRESSOR OPERATION: Get it right first time. Your simple steps to successful operation. 1. Unscrew the Water Tank Cap, on the top of Turbo Charger. Pour in contents of both bottles (Ice & Antifreeze).
More informationCompressor Operation and initial start up Procedure: Please read directions carefully and follow operatingproceduresbeforeeachuse.
Thank you for purchasing Omega Air Charger compressor for PCP and carbon fiber tank filling. Rapidly fill tank sizes from 6 cubic feet to 120 cubic feet. Aircraft machined aluminum is used extensively
More informationHALLMARK INDUSTRIES INC
Performance Part No. HP. CONVERTIBLE JET PUMP USER S MANUAL GPH of Water @ Total Discharge Pressure of 40 psi Max. Pressure Max suction (shallow well) Max Suction (deep well) Max GPM (@0 head) Max Discharge
More informationUser Instruction Manual
User Instruction Manual NOMAD 4500 PSI Portable Air Compressor AV-MCOMP4500 Ver 1, 7/18 Contents Parts Included...3 Setting up your Nomad Compressor...4 Operation Instructions: 110V or 220V outlet...5-6
More informationUser Instruction Manual
User Instruction Manual Nomad II 4500 PSI Portable Air Compressor AV-MCOMP4500-2 Ver. 1, 10/18 Contents Parts Included...3 Setting up your Nomad II Compressor...4 Operation Instructions: 110V or 220V outlet...5-6
More informationOperating Instructions & Parts Manual. Supa-Lite Lever Grease Gun. Model 48UJ77
Operating Instructions & Parts Manual EN Supa-Lite Lever Grease Gun Model 48UJ77 PLEASE READ AND SAVE THESE INSTRUCTIONS. READ CAREFULLY BEFORE ATTEMPTING TO ASSEMBLE, INSTALL, OPERATE OR MAINTAIN THE
More informationSLR / SLR-S/N. Instruction Manual. Walrus America Inc
SLR / SLR-S/N Instruction Manual Walrus America Inc 1. Installation and Connection 1.1. Pump Installation The pump should be sited in a well ventilated and frost-free position. The distance between pumps-motors
More informationADJUSTABLE COMFORT ASSEMBLY INSTRUCTIONS
ASSEMBLY INSTRUCTIONS ASSEMBLY INSTRUCTIONS For customer service call 1-877-707-7533 or email azcustomerservice@classicbrands.org STEP 1: Carefully open the carton and remove all boxes then lay out the
More information12 Volt Heavy-Duty Air Inflator
12 Volt Heavy-Duty Air Inflator Owner s Manual WARNING: Read carefully and understand all ASSEMBLY AND OPERATION INSTRUCTIONS before operating. Failure to follow the safety rules and other basic safety
More informationQ-Series Winch. Assembly and Installation Manual # X. The Trusted Source REQUIRED TOOLS: SAFETY GLASSES GLOVES TORQUE WRENCH
Q-Series Winch Assembly and Installation Manual # 92122.202X READ ALL SAFETY MESSAGES AND UNDERSTAND ALL INSTRUCTIONS AND PROCEDURE NOTICES BEFORE ATTEMPTING TO INSTALL OR USE THIS PRODUCT. REQUIRED TOOLS:
More information110 Volt/12 Volt Portable Inflator
110 Volt/12 Volt Portable Inflator Owner s Manual WARNING: Read carefully and understand all ASSEMBLY AND OPERATION INSTRUCTIONS before operating. Failure to follow the safety rules and other basic safety
More informationINSTRUCTIONS AND SERVICE MANUAL WITH PARTS LIST
CMP SERIES CPM15-15B (25905F300) CPM15-15B-H/D (25905F301) CPM18-15B (25905F303) CPM18-15B-H/D (25905F304) INDUSTRIAL PUMPS INSTRUCTIONS AND SERVICE MANUAL WITH PARTS LIST NOTE! To the installer: Please
More informationPower. On Your Terms.
Power. On Your Terms. 10 YEAR LIMITED WARRANTY PHI 1310 TM 1 SIMPLIPHI POWER, INC. REV102016 10 YEAR LIMITED WARRANTY: PHI 1310 TM LIMITED PRO-RATED WARRANTY COVERAGE The SimpliPhi Power PHI 1310 as supplied
More informationCUSTOMER SERVICE: 800-973-8374 Frame Assembly Instructions Headboard Installation E 1. Use the remote control to raise the head of the adjustable foundation in order to gain access to the foundation
More informationCRD610 Automatic Fitting Inserter
CRD610 Automatic Fitting Inserter OPERATIONS MANUAL VERSION 1.2 LAST EDITED 12.12.2018 cleanroomdevices.com 1 Table of Contents Title Page. 1 Table of Contents...2 1.0 General Product & Safety Information....3
More informationSeries CP200. Triplex Ceramic Plunger Pump Operating Instructions/ Repair and Service Manual. For Models: CP218 CP219 CP220 CP230
Series CP200 Triplex Ceramic Plunger Pump Operating Instructions/ Repair and Service Manual For Models: CP218 CP219 CP220 CP230 Updated 10/02 Contents: Installation Instructions: page 2 Pump Specifications:
More information22427 SWAY BAR SET 2002-UP SUBARU WRX WAGON
22427 SWAY BAR SET 2002-UP SUBARU WRX WAGON Thank you for your purchase from our line of Subaru WRX parts. Please call us at (877) 4NO-ROLL if you have any questions regarding the service or installation
More informationHydraulic Drum Transporter
Hydraulic Drum Transporter Owner s Manual WARNING: Read carefully and understand all ASSEMBLY AND OPERATION INSTRUCTIONS before operating. Failure to follow the safety rules and other basic safety precautions
More informationModel GX Series. Consumer Pump. Triplex Plunger Pump Operating Instructions/ Repair Instructions Manual
Model GX Series Triplex Plunger Pump Operating Instructions/ Repair Instructions Manual Consumer Pump Horizontal/Vertical Pump with built-in Thermal Relief Valve and Siphon Injector Contents: Installation
More informationINSTALL GUIDE Jeep Wrangler JK 3.6L V6
INSTALL GUIDE 2012-2017 Jeep Wrangler JK 3.6L V6 TABLE OF CONTENTS 3 GETTING STARTED 3 PARTS LIST 4 INSTALLATION INSTRUCTIONS 4 REMOVING THE STOCK INTAKE ASSEMBLY 6 INSTALLING THE HOUSING 7 INSTALLING
More information10 Year Limited Warranty
Power. On Your Terms. 10 Year Limited Warranty PHI 2.7 TM PHI 3.5 TM 60A SIMPLIPHI POWER, INC. REV020618 10 Year Limited Warranty: PHI 2.7 TM PHI 3.5 TM 60A 24V 48V Limited Pro-Rated Warranty Coverage
More informationLevel One Electric Vehicle Charging Station FREE STANDING Product Guide
Level One Electric Vehicle Charging Station FREE STANDING Product Guide Model # SC2-120 Shorepower Technologies 2351 NW York St. Portland, OR 98664 503-892-7345 info@shorepower.com www.shorepower.com 2
More information2015 & 2018 Fender Brace Installation Instructions
2015 & 2018 Fender Brace Installation Instructions Thank you for your purchase of this Hotchkis Performance product. Your Fender Brace set was designed with the performance and durability you ve come to
More informationModel T2642 Wall Mount. Television Wall Mount with Tilt Option
Model T2642 Wall Mount Television Wall Mount with Tilt Option Getting Started Introduction Congratulations on the purchase of your new Audio Solutions T2642 Television Wall Mount. For maximum benefit,
More informationINSTALL GUIDE Dodge/RAM 5.7L HEMI
INSTALL GUIDE 2009-2017 Dodge/RAM 5.7L HEMI TABLE OF CONTENTS 3 GETTING STARTED 3 PARTS LIST 4 INSTALLATION INSTRUCTIONS 4 REMOVING THE STOCK INTAKE ASSEMBLY 6 INSTALLING THE AIR FILTER 7 INSTALLING THE
More informationUser s Guide. Oreck Air Purifier with HEPA Filtration. Important! Read this manual carefully, and keep for future reference.
User s Guide Oreck Air Purifier with HEPA Filtration Important! Read this manual carefully, and keep for future reference. Enjoy Congratulations on your purchase of the Oreck Air Purifier with HEPA Filtration.
More informationCLEAN ROOM DEVICES, LLC "WHERE TUBING AND FITTINGS COME TOGETHER"
CLEAN ROOM DEVICES, LLC "WHERE TUBING AND FITTINGS COME TOGETHER" CRD600 Automatic Fitting Inserter OPERATIONS MANUAL VERSION 2.1 LAST EDITED 7.25.14 DOCUMENT NUMBER 001 cleanroomdevices.com 1 Table of
More informationSingle shot MODEL EGA700 OWNERS MANUAL
Single shot AIR OPERATED GREASE GUN MODEL EGA700 OWNERS MANUAL www.eaglecompressor.com 1-800-551-2406 READ THE ENTIRE MANUAL BEFORE PUTTING THIS TOOL IN SERVICE Limited Air Tool Warranty Eagle warrants
More informationWater Broom. Instruction manual ESPAÑOL: PÁGINA 7 FRANÇAIS : PAGE 13 MODEL PCA270
ESPAÑOL: PÁGINA 7 FRANÇAIS : PAGE 13 Instruction manual Water Broom MODEL PCA270 To learn more about Porter-Cable visit our website at: http://www.porter-cable.com IMPORTANT Please make certain that the
More informationSEWAGE PUMP MODEL # Zoeller is a registered trademark of Zoeller Co. All Rights Reserved. Español p. 14
SEWAGE PUMP Zoeller is a registered trademark of Zoeller Co. All Rights Reserved. MODEL #1261-0001 Español p. 14 ATTACH YOUR RECEIPT HERE Serial Number Purchase Date Questions, problems, missing parts?
More informationUsers Manual Certified Series Direct Drive Pump 1-7 LPM
Users Manual Certified Series Direct Drive Pump 1-7 LPM Safety, Operating, Installation, and Maintenance Instructions 600 S 56 th Street #9 Chandler, AZ 85226 Phone: 480-507-6478 Fax: 480-838-2232 www.fogco.com
More informationThompson Performance, LLC - POWERBLAST PLATE
Thompson Performance, LLC - POWERBLAST PLATE INSTALLATION INSTRUCTIONS FOR PBP EC-56 AND PBP EC-78 IMPORTANT NOTE: Proper installation and safe use of the POWERBLAST PLATE is the responsibility of the
More informationThompson Performance, LLC - POWERBLAST PLATE
Thompson Performance, LLC - POWERBLAST PLATE INSTALLATION INSTRUCTIONS and LIMITED WARRANTY FOR PBP H-1, HD-1 AND HD-2 IMPORTANT NOTE: Proper installation is the responsibility of the purchaser. Improper
More informationOWNER/OPERATOR MANUAL. Airmotor effective dia. in. 2.5
MODELS 282050, 282716 & 283513 AIR OPERATED CHASSIS PUMP SERIES A OWNER/OPERATOR MANUAL SPECIFICATIONS Airmotor effective dia. in. 2.5 Airinlet Material outlet 1/4 NPTF 1/4 NPTF Liquid to Air Pressure
More informationModel AS-RC3260 TV Cart. Rolling Cart for Audio Mount System & Flat Panel TVs
Model AS-RC3260 TV Cart Rolling Cart for Audio Mount System & Flat Panel TVs GETTING STARTED Introduction Congratulations on the purchase of your new Helios AS-RC3260 Rolling Cart. For maximum benefit,
More informationCustomer Support
Portable auxiliary air tanks owner's Manual aux05 aux05a aux10 WWW.CALIFORNIAAIRTOOLS.COM Customer Support 1-866-409-4581 TAbLe OF CONTeNTS INTROduCTION IntroductIon Important Safety InStructIonS components
More informationModel GXR Series. Consumer Pump. Triplex Plunger Pump Operating Instructions/ Repair Instructions Manual
Model GXR Series Triplex Plunger Pump Operating Instructions/ Repair Instructions Manual Consumer Pump Horizontal/Vertical Pump with built-in Regulator, Thermal Relief Valve and Siphon Injector Updated
More information22421 SPORT SWAY BAR SET TOYOTA COROLLA
22421 SPORT SWAY BAR SET 98-01 TOYOTA COROLLA Thank you for your purchase from our line of Corolla parts. Please call us at (877) 4NO-ROLL if you have any questions regarding the service or installation
More informationPARTS MANUAL FOR TWO STAGE AIR COMPRESSOR
PARTS MANUAL FOR TWO STAGE AIR COMPRESSOR SPECIFICATION CHART Model No. Horsepower Voltage-Single Phase Minimum Branch Circuit Requirement *Fuse Type Air Tank Capacity Approximate Cut-in Pressure Approximate
More informationP SERIES PUMPS. 18mm Versions Nickle-Aluminum Bronze Models: P , P , P , P , P , P , P
P200-3100 SERIES PUMPS 18mm Versions Nickle-Aluminum Bronze Models: P217-3100, P218-3100, P219-3100, P220-3100, P221-3100, P227-3100, P230-3100 Triplex Ceramic Plunger Pump Operating Instructions/ Repair
More informationSpecialty Pond Sprayer
Specialty Pond Sprayer 2.75 Gallon Capacity Sprayer Installation & Maintenance Manual (Item # 580121) 1 Year Warranty Specialty Pond Sprayer 2.75 Gallon Capacity Sprayer Thank you for purchasing this compression
More informationUser Manual. Posture+ Adjustable Base. For customer service call:
User Manual Posture+ Adjustable Base For customer service call: 1-877-707-7533 1 IMPORTANT INFORMATION PLEASE READ THESE INSTRUCTIONS THOROUGHLY BEFORE USING THIS PRODUCT. PROPER OPERATION OF YOUR ADJUSTABLE
More informationQUALITY MISTING PUMPS
DIRECT DRIVE TOTALLY ENCLOSED FAN COOLED 60200KH, 60201KH MISTING PUMP MANUAL INCLUDING: SPECIFICATION DATA, GENERAL SAFETY PRECAUTIONS, OPERATION, INSTALLATION, PARTS, MAINTENANCE & WARRANTY QUALITY MISTING
More informationModels P420A-3100 & P420A-5100
Models P420A-3100 & P420A-5100 Triplex Ceramic Plunger Pump Operating Instructions/ Repair and Service Manual Corrossion Resistant Pumps Contents: Installation Instructions: page 2 Specifications: page
More informationModel GXR Series. Consumer Pump. Triplex Plunger Pump Operating Instructions/ Repair Instructions Manual
Model GXR Series Triplex Plunger Pump Operating Instructions/ Repair Instructions Manual Consumer Pump Horizontal/Vertical Pump with built-in Regulator, Thermal Relief Valve and Siphon Injector MADE IN
More informationMK Rittenhouse & Sons Ltd. 115 Litre/30 US Gallon Greenhouse Sprayer Manual
MK Rittenhouse & Sons Ltd. 115 Litre/30 US Gallon Greenhouse Sprayer Manual TABLE OF CONTENTS Introduction 3 Precautions & Maintenance 4-5 Piston pump Care & Maintenance 5-6 Shut Down & Winterizing 6 Troubleshooting
More informationRear Upper Camber Link (12425) Scion tc
Rear Upper Camber Link (12425) Scion tc Thank you for your purchase from our new line of Scion tc parts. Please call us at (877) 4NO-ROLL if you have any questions regarding the service or installation
More informationModel BP6150. Triplex Ceramic Plunger Pump Operating Instructions/ Manual
Model BP6150 Triplex Ceramic Plunger Pump Operating Instructions/ Manual Contents: Installation Instructions: page 2 Pump Specs: page 3 Exploded View: page 4 Parts List / Kits Torque Specifications: page
More informationSmoke Leak Locator. User Manual. For Models: Pro S 25, Pro S 75, Pro S 500T, Pro S 600T, Pro S 1000HD. Ceramic Heating Technology
Smoke Leak Locator User Manual For Models: Pro S 25, Pro S 75, Pro S 500T, Pro S 600T, Pro S 1000HD Ceramic Heating Technology www.proflex-plus.com All models come with a User Manual, Quick Start Guide,
More informationQUICK START GUIDE OWNER S MANUAL AL50 SERIES SAND FILTRATION TECHNOLOGY PLEASE CALL DO NOT RETURN TO STORE
QUICK START GUIDE OWNER S MANUAL SAFETY, INSTALLATION, OPERATION & PARTS AL50 SERIES SAND FILTRATION TECHNOLOGY PLEASE CALL 877-278-2797 DO NOT RETURN TO STORE! WARNING This equipment must be installed
More informationAgxcel GX12i Chemical Injection System
Agxcel GX12i Chemical Injection System Table of Contents System Contents... 3 Specifications... 4 Safety Precautions and Tips... 5 Operations... 6 Installation... 7 Maintenance... 8-9 Troubleshooting...
More informationShock Absorber Rebuild Manual
Shock Absorber Rebuild Manual Model PODIUM RC3 FOX RACING SHOX 130 Hangar Way, Watsonville, CA 95076 PHONE 800.369.7469 FAX 831.768.7026 Email: psservicemw@ridefox.com Website: www.ridefox.com Disclaimer
More informationCRD600 Automatic Fitting Inserter
CRD600 Automatic Fitting Inserter OPERATIONS MANUAL VERSION 2.3 LAST EDITED 12.07.2018 cleanroomdevices.com 1 Table of Contents Title Page.. 1 Table of Contents. 2 1.0 General Product & Safety Information...3
More informationHydraulic Bead Breaker Kit
Hydraulic Bead Breaker Kit Owner s Manual WARNING: Read carefully and understand all ASSEMBLY AND OPERATION INSTRUCTIONS before operating. Failure to follow the safety rules and other basic safety precautions
More informationModel GXR Series. Consumer Pump. Triplex Plunger Pump Operating Instructions/ Repair Instructions Manual
Model GXR Series Triplex Plunger Pump Operating Instructions/ Repair Instructions Manual Consumer Pump Horizontal/Vertical Pump with built-in Regulator, Thermal Relief Valve and Siphon Injector Updated
More informationSPECIFICATIONS CONTENTS:
Model 3052A 1,100 Lbs Air Assist 2 Stage Transmission Jack INSTRUCTION MANUAL CONTENTS: Page 1 Specifications Page 2 Warning Information Page 3 Assembly Page 4 Operating Instructions Page 4 Preventative
More informationSUNC1200 / ITEM #40882 SUBMERSIBLE UTILITY PUMP OPERATIONS MANUAL
SUNC1200 / ITEM #40882 SUBMERSIBLE UTILITY PUMP OPERATIONS MANUAL WWW.SUNRUNNERPOOL.COM Performance Model HP GPH of Water @ Total Feet Of Lift 0 ft. 5 ft. 10 ft. 15 ft. 20 ft. 25 ft. Max. Lift SUNC1200
More informationCLEAN ROOM DEVICES, LLC "WHERE TUBING AND FITTINGS COME TOGETHER"
CLEAN ROOM DEVICES, LLC "WHERE TUBING AND FITTINGS COME TOGETHER" CRD600AF Automatic Fitting Inserter With Auto Feed OPERATIONS MANUAL (Shown with optional alcohol dispenser) 1 VERSION 1.1 LAST EDITED
More informationInstallation Instructions
Installation Instructions Bradley Touch Time Valve for Column Showers Table of Contents Pre-Installation Information...............2 Touch Time Valve Installation............3 Touch Time Valve Wiring Diagram........4
More informationSUBMERSIBLE SUMP PUMPS
SUBMERSIBLE SUMP PUMPS Zoeller is a registered trademark of Zoeller Co. All Rights Reserved. MODELS #1073-0001, 1075-0001 Español p. 9 ATTACH YOUR RECEIPT HERE Serial Number Purchase Date Questions, problems,
More informationPREDICTIVE STEERING HUBS. Service Manual
2015 PREDICTIVE STEERING HUBS Service Manual SRAM LLC WARRANTY EXTENT OF LIMITED WARRANTY Except as otherwise set forth herein, SRAM warrants its products to be free from defects in materials or workmanship
More informationESE Series Cast Iron Sewage Pumps
Owner s Manual ESE Series Cast Iron Sewage Pumps TABLE OF CONTENTS General Safety.................... 2 Specifications..................... 3 Installation.................... 4 & 5 Troubleshooting...................
More informationc EDR /11. ShipShape OWNERS MANUAL. [ power foundations ]
99301115-c EDR11746 4/11 ShipShape OWNERS MANUAL [ power foundations ] contents Advisory... 4 Assembly... 6 Hand Control Function... 15 Accessories... 16 Troubleshooting... 17 1-2-Lifetime Warranty...
More informationSPORT COIL SPRINGS Scion xa & xb Part #19412 INSTALLATION OF HOTCHKIS FRONT COIL SPRINGS
SPORT COIL SPRINGS 2004+ Scion xa & xb Part #19412 Thank you for your purchase from our new line of Scion xa / xb parts. Please call us at (877) 4NO-ROLL if you have any questions regarding the service
More informationBlue Air. Commercial Refrigeration Inc. Installation & Operation Manual Chef Bases
Blue Air Commercial Refrigeration Inc. Installation & Operation Manual Chef Bases Please read this manual completely before installing or operating this unit! BACB53 BACB71 BACB74 BACB83 BACB86 BACB96
More informationAir Compressor. Owner s Manual
35 WARNING! READ AND UNDERSTAND ALL SAFETY PRECAUTIONS IN THIS MANUAL BEFORE OPERATING. FAILURE TO COMPLY WITH INSTRUCTIONS IN THIS MANUAL COULD RESULT IN PERSONAL INJURY, PROPERTY DAMAGE, AND/ OR VOIDING
More informationOwner s Manual Nitrate Series Salt Based Filter System
Owner s Manual Nitrate Series Salt Based Filter System Page 2 Copyright 2012 Enviro Water Solutions Inc. All rights reserved. All information contained herein is the property of Pelican Water Systems.
More informationMODEL G300 Brake Bleeder
MODEL G300 Brake Bleeder Installation, Operation & Repair Parts Information Branick Industries, Inc. 4245 Main Avenue P.O. Box 1937 Fargo, North Dakota 58103 Rev013107 P/N: 81-0035C CAUTION Before using
More informationPRE-PLUMBED SEWAGE SYSTEM
PRE-PLUMBED SEWAGE SYSTEM Zoeller is a registered trademark of Zoeller Co. All Rights Reserved. MODEL #1910-0009 Español p. 13 ATTACH YOUR RECEIPT HERE Serial Number Purchase Date Questions, problems,
More informationCone Skimmers. Instructions. for Models 75G, 150G and 300G. Please read these instructions in their entirety before attempting to use this product.
Cone Skimmers Instructions for Models 75G, 150G and 300G Please read these instructions in their entirety before attempting to use this product. The pumps used with the Coralife 75G, 150G and 300G Cone
More informationAccessory ACCESSORY User Manual
AURORA AURORA EXPLORERS Explorers EDITION Edition Accessory ACCESSORY User Manual SiOnyx, LLC 100 Cummings Center, Suite 135P Beverly, MA 01915 (978) 922-0684 support@sionyx.com Follow us on Facebook @SiOnyxNightVision
More informationseries USER MANUAL
888 534-5994 4000 series USER MANUAL Contents Here s all the information you need for setting and operating your new Lathem time recorder. Service information is also included in this manual, in case any
More informationReach ins, Freeezers & Refrigerators Installation & Operation Manual
Reach ins, Freeezers & Refrigerators Installation & Operation Manual BSR23 BSF23 BSR49 BSF49 BSR72 BSF72 IMPORTANT SAFETY INSTRUCTIONS (SAVE THESE INSTRUCTIONS) Visit us on the web at www.blueairinc.com
More informationModel GP Triplex Ceramic Plunger Pump Operating Instructions/ Manual
Model GP6145-3100 Triplex Ceramic Plunger Pump Operating Instructions/ Manual Contents: Installation Instructions: page 2 Pump Specifications: page 3 Exploded View: page 4 Parts List / Kits: page 5 Repair
More informationStormPro BA Series Sump Pump
Page 1 of 8 Marks & Meanings DANGER: Keep the pump equipment out of the reach of children! Warns that the failure to follow the directions given could cause serious risk to individuals or objects. WARNING:
More informationSport Sway Bar Kit (22431 ) Subaru Forester INSTALLATION OF HOTCHKIS FRONT SWAY BAR
Sport Sway Bar Kit (22431 ) Subaru Forester Thank you for your purchase from our new line of Forester parts. Please call us at (877) 4NO - ROLL if you have any questions regarding the service or installation
More information4-Ton Electric Log Splitter
4-Ton Electric Log Splitter Questions: Support@Powrkraft.com PK65556 2 18ga. @ 20ft, 16ga. @ 50ft, 14 ga. @ 75ft. 12ga @ 100ft, 10ga @ 200ft These are minimum cord requirements. 13-16 Model Number 65556
More informationWhere to Find Us. Pressure Washer. Model Number Revision Serial Number. Date Purchased
Thank you for purchasing this quality-built Troy-Bilt pressure washer. We are pleased that you ve placed your confidence in the Troy-Bilt brand. When operated and maintained according to the instructions
More informationSource Capture Air Purification System
Source Capture Air Purification System HA-SCP-G3 Owner s Manual Table of Contents HealthyAir HA-IFM-1111 Filter 1 Important Safety Instructions 2 Technical Specifications 3 Packaging Reference 4 Packing
More informationModel AS-FM64 Wall Mount. Full Motion Television Wall Mount
Model AS-FM64 Wall Mount Full Motion Television Wall Mount Getting Started Introduction Congratulations on the purchase of your new Audio Solutions AS-FM64 Television Wall Mount. For maximum benefit, please
More informationP/N# Performance Lowering Springs Installation Instructions
P/N# 19110 Performance Lowering Springs Installation Instructions Thank you for your purchase of this Hotchkis Performance product. Your Lowering Spring set was designed with the performance and durability
More informationNot for Reproduction 7 GAL PORTABLE AIR TANK
7 GAL PORTABLE AIR TANK Product Model # 074040-00 Manual # 80018801 Read and understand this operator's manual thoroughly before using the product. It contains important information for your safety as
More informationUltimate 5th Wheel Connection Rail Mount. Part #3200 Gooseneck Mount, 20,000 lbs GTWR - 4,500 lbs Tongue INSTALLATION MANUAL
Ultimate 5th Wheel Connection Rail Mount Part #3200 Gooseneck Mount, 20,000 lbs GTWR - 4,500 lbs Tongue INSTALLATION MANUAL andersenhitches.com Table of Contents Table of Contents Important Safety Information...
More informationWarranty Information North America
Publication No. 47705137 January 1, 2014 Warranty Information North America Industrial and Power Generation Power Systems Parts and Accessories Includes: Power Systems Warranty Statement Parts and Accessories
More information203 TRANSFER CASE CONVERSION
203 TRANSFER CASE CONVERSION PN:501 OUR FOUR TRANSFER CASE WEDGES REPLACE THE SPIDER GEARS AND CONNECT THE PLANETARY GEAR AND REAR OUTPUT SHAFT MAKING ONE UNIT. SIMILAR IN DESIGN & FUNCTION TO THE BEST
More informationDISC BRAKE/DUAL MASTER CYLINDER CONVERSION. Tools, Equipment and Supplies Needed:
Please take the time to read the enclosed instructions carefully. If you have any questions, call our Product Assistance personnel for clarification. It is important to note that these instructions contain
More informationAGRI-COVERTM SWITCH CONTROL INSTRUCTIONS
AGRI-COVERTM SWITCH CONTROL INSTRUCTIONS Use these instructions in place of the rocker switch and solenoid sections in your roll tarp or ROLTECTM Electric Hopper Conversion instructions. Some installs
More informationSeries 007. Double Check Valve Assembly. Installation Service Repair Kits Maintenance. Sizes: 1 2" 3" Watts 3 4" 007M3QT RP/IS-007
Series 007 Double Check Valve Assembly RP/IS-007 Sizes: 1 2" 3" Installation Service Repair Kits Maintenance For field testing procedure, send for IS-TK-DP/DL, IS-TK-9A, IS-TK-99E and IS-TK-99D. For other
More informationAudi R8. Ride-on Car 5F62630 OWNER S MANUAL. Keep instructions for future reference
Audi R8 Ride-on Car 5F62630 OWNER S MANUAL Keep instructions for future reference 1 Safety The owner s manual contains assembly, use and maintenance instructions. The vehicle must be assembled by an adult
More informationDUAL WIDEBAND AIR/FUEL RATIO GAUGE Product Numbers: GS-W702W_Dual, GS-C702W_Dual, GS-T702W_Dual
Installation Instructions Tech Support: 856.768.8300 TechSupport@GlowShiftGauges.com DUAL WIDEBAND AIR/FUEL RATIO GAUGE Product Numbers: GS-W702W_Dual, GS-C702W_Dual, GS-T702W_Dual (1) Gauge (2) Controllers
More informationSPECIFICATIONS CONTENTS:
Model 3052 1,100 Lbs 2 Stage Transmission Jack INSTRUCTION MANUAL CONTENTS: Page 1 Specifications Page 2 Warning Information Page 3 Assembly Page 4 Operating Instructions Page 4 Preventative Maintenance
More informationINSTALL GUIDE Ford F L
INSTALL GUIDE 2011-2014 Ford F-150 5.0L TABLE OF CONTENTS 3 GETTING STARTED 3 PARTS LIST 4 INSTALLATION INSTRUCTIONS 4 REMOVING THE STOCK INTAKE ASSEMBLY 5 INSTALLING THE AIR FILTER 6 INSTALLING THE HOUSING
More informationAqua Ultraviolet Sunami Series Pumps 1/3HP, 3/4HP, 3HP, 4HP, 5HP
TM 42371 Avenida Alvarado Temecula, CA 92590 TOLL FREE (800) 454-2725 TEL (951) 296-3480 FAX (951) 296-3490 www.aquauv.com Aqua Ultraviolet Sunami Series Pumps 1/3HP, 3/4HP, 3HP, 4HP, 5HP Sunami Warranty
More informationSUBMERSIBLE SUMP PUMPS
SUBMERSIBLE SUMP PUMPS Zoeller is a registered trademark of Zoeller Co. All Rights Reserved. MODEL #1099-0001 Español p. 11 ATTACH YOUR RECEIPT HERE Serial Number Purchase Date Questions, problems, missing
More informationRead this entire manual before operation begins.
Read this entire manual before operation begins. Record below the following information which is located on the serial number data plate. Serial No. Model No. Date of Installation Contents Specifications.............
More informationGetz Equipment Innovators 450 lb Portable / Wheeled Unit Dry Chemical Fill System Part No: 3G0061/3G0063
Getz Equipment Innovators 450 lb Portable / Wheeled Unit Dry Chemical Fill System Part No: 3G0061/3G0063 1 Revised 4/12/17 2320 Lakecrest Drive, Pekin IL 61554 PH. (888) 747-4389 Fax (309) 495-0625 Website:
More informationCOOL DRAFT INSTRUCTIONS OWNER S MANUAL CONTENTS. Cool Draft MiniMister 14 Misting Fan CDMP1420BLU
COOL DRAFT BY INSTRUCTIONS OWNER S MANUAL! Keep for future reference. Common problems and solutions are listed within this booklet. IMPORTANT INFORMATION INSIDE: Read, understand, and follow all safety
More informationInstallation & Operation Manual Chef Base
Installation & Operation Manual Chef Base Please read this manual completely before installing or operating this unit! BACB53 BACB53M BACB71 BACB71M BACB74 BACB74M BACB83 BACB83M BACB86 BACB86M BACB96
More informationSport Sway Bar Kit UP SCION xb
Sport Sway Bar Kit 22429 08-UP SCION xb Thank you for your purchase from our new line of Scion parts. Please call us at 877-4NO - ROLL if you have any questions regarding the service or installation of
More informationIMPORTANT OPERATING CONDITIONS. Failure to comply with any of these conditions invalidates the warranty. STANDARD CONFIGURATIONS
X-SERIES TRIPLEX CERAMIC PLUNGER PUMPS OPERATING MANUAL MODELS X8 X10 X20 IMPORTANT OPERATING CONDITIONS Failure to comply with any of these conditions invalidates the warranty. Lubrication - Prior to
More information