Proposal Option List

Transcription

1

2 Proposal Option List 4//0 Customer : Representative : Organization : Requirements Manager: Description : Body : Chassis : Clifford James First In, Inc (PHOENIX OFFICE**) CCBC with 000 Water Tank Pumper, Long, Alum, PMFD CONTENDER Big Block Chassis, Custom, 00 Bid Number : 4 DB Version: Bid Date : Job Number : Line Option Code Type Option Description Qty Build-to-Order, PMFD Product Manufacture Location: Appleton, Wisconsin, (with CBBC Chassis) RFP Location: Appleton, Wisconsin Vehicle Destination, US Boiler Plates, Pumper, PMFD Single Source Compliance Comply NFPA 90 Changes Effective Jan, 009, With Exceptions Pumper Fire Apparatus, PMFD Vehicle Certification, Pumper Agency, Apparatus Certification, Pumper/Tanker, Third Party, PMFD No Fire Department Defined Customer Service Website Unit of Measure, US Gallons Bid Bond, 0%, Pierce Built Chassis Performance Bond, Not Requested No Approval Drawing Req'd. CONTENDER Big Block Chassis, Custom, 00 Wheelbase Wheelbase " GVW Rating GVW rating - 48,00# Frame Rails, 3.38 x 3.0 x.37, DLX/Qtm/Enf/AXT/Imp/Vel/Dash CF Frame Liner not Req'd Axle, Front, Meritor FL-943,,00#, w/assist Suspension, Front, Standens, Taper Leaf,,00 lb, FL-943 Axle Shock Absorbers on Front Axle, DLX/Qtm/AXT/Imp/Vel Oil Seals, Front Axle Tires, Front, Goodyear, G9 MSA, 4/R.0, 0 ply Wheels, Front,.0" x.", Steel, Hub Pilot Axle, Rear, Meritor RS-0, 7,000 lb, Imp/Vel/Dash CF Top Speed of Vehicle, 8 MPH Suspen, Rear, Standens, Spring, 7,000 lb, Imp/Vel/Dash CF, Non-Rescue Oil Seals, Rear Axle Tires, Rear, Goodyear, G RSD, R.0, ply, Single Wheels, Rr, Steel.0" x 8." (R.0 & R.0) Tire Balancing, Counteract Beads Tire Pressure Monitoring Valve Cap Qty, Tire Pressure Ind - Axle Hub Covers w/center hole, S/S, Front Axle Axle Hub Covers, Rear, S/S Baby Moon (Pair) Mud Flaps, w/logo front & rear ABS Wabco Brake System, Single rear axle Brakes, Cam, Front,.0 x.00 (Std FL/RF axle) Brakes, Meritor, Cam, Rear,.0 x 7.00" Air Compressor, Brake, Bendix.8 CFM Brake Reservoirs, Three Air Dryer, Wabco System Saver 00, 00 Brake Lines, Nylon Air Inlet, w/disconnect Coupling, (PMFD) Location, Air Coupling(s) - a) DS Step Well Engine, DDC DD3, 40 hp, 0 ft-lb, EPA 00, CBBC 4//0 3:7:PM Page

3 High Idle w/electronic Engine, Custom Engine Brake, Jacobs, DD3 Switch, Engine Brake - f) DD3 Clutch, Fan, Air Actuated, Horton Drive Master Air Intake, w/ember separator, Imp/Vel Exhaust System, ", 00 DD3, ISX engine, Horizontal, Officer Side Radiator, Imp/Vel Cooling Hoses, Rubber Fuel Tank, gal Lines, Fuel DEF Tank, 4. Gallon, DS Fill, Forward of Rear Axle, DD3, ISL9, ISX Not Required, Fuel Priming Pump Not Required, Shutoff Valve, Fuel Line Cooler, Engine Fuel, Imp/Vel, AXT,Qtm Trans, Allison Gen IV 4000 EVS P, Imp/Vel/CBBC With Prognostics Transmission, Shifter, -Spd, Push Button Trans, ratio EVS, Spd Transmission Oil Cooler, Champ Driveline, Spicer 80 Steering, Ross TAS-8 w/tilt, 3 Line Pump, w/ Cooler Steering assist cylinder on front axle Steering Wheel, 4 Spoke without Controls Logo/Emblem, on Horn Button Text, Row One -. Text, Row Three -. Text, Row Two -. Chocks, Wheel, Pumper, Provided by Fire Department Mounting Brackets, Chocks, Provided by Fire Department Bumper, 9" extended, Imp/Vel Lift & Tow Package, Imp/Vel, AXT, Dash CF No Tow Hooks Required, Due to Lift and Tow package Tray, Hose center, 9" bumper w/outside Air Horns, Imp/Vel Capacity, Bumper Tray - 09) 0' of.0" Grating, Bumper extension - Grating, Rubber Hose Restraint, Bumper Tray, Velcro Straps Location 7 - center Qty, - 0 Cab, Contender Big Block 00, 00 Raised Roof Cab Lift, Elec/Hyd, Imp/Vel Grille, Bright Finished, Front of Cab, Impel/Velocity Trim, S/S, Rect Headlights, CBBC No Chrome Molding, On side of cab Mirrors, Retrac, West Coast Style, Htd/Rmt, w/htd/rmt Convex Door, Half-Height, Raised Roof Cab, Painted Aluminum Panel Not Required, Scuffplates, Cab Door, Imp/Vel Controls, Electric Windows, All Cab Doors, Impel & Velocity Lights, Cab and Crew Cab Access Steps, Ri-Tar, LED w/bezel, Light Per Step Fenders, S/S on cab Window, Side of C/C, Fixed, Imp/Vel Trim, Cab Side Windows, Velocity Not Required, Windows, Front/Side of raised roof Not Required, Windows Rear of Crew Cab, Imp/Vel Not Required, Trim, Cab Rear Windows, No Rear Windows Cab Interior, ABS Console, Painted Side Walls, Imp/Vel Color, Cab Interior Paint - a) gray Color, Cab Interior Vinyl/Fabric - a) Silver/Gray Cab Interior, paint color, Imp/Vel Color, Cab Interior Paint - a) gray Floor, Rubber Padded Cab & Crew Cab, Imp/Vel, Dash CF Heater/defroster, Imp/Vel Air Conditioning, Imp/Vel/CBBC Grab Handles, Driver Door Post & Passenger Dash panel, Imp/Vel 4//0 3:7:PM Page

4 Light, Engine Compt, All Custom Chassis Fluid Check Access, Imp/Vel, AXT Not Required, Side Roll and Frontal Impact Protection Not Required, Frontal Impact Protection, 00 Not Required, Side Roll Protection Package, 00 Seating Capacity, Cab Qty, - 0 Seat, Driver, Air Ride Hi-Back, CBBC Seat, Officer, Fixed, SCBA, CBBC Radio Compt, Under Frt Passenger Seat, Imp/Vel Seat, Rr Facing C/C, DS Outboard, SCBA, CBBC Not Required, Seat, Rr Facing C/C, Center Seat, Rr Facing C/C, PS Outboard, SCBA, CBBC Not Required, Seat, Forward Facing C/C, DS Outboard Seat, Forward Facing C/C, Center, () SCBA, CBBC Not Required, Seat, Forward Facing C/C, PS Outboard Upholstery, Seats In Cab, All Imperial 00, All 9 Color, Cab Interior Vinyl/Fabric - h) Gray/Black Bracket, Air Bottle Ziamatic, ULLH, Load & Lock, 90-04,Cab Seats,Imp/Vel/Q/DCF Qty, - 0 Seat Belt Height Adjustment, Imp/Vel, Dash CF Qty, - 0 Seat Belts, Red Seat Belt Monitoring System Helmet Storage, Provided by Fire Department Lights, Dome, Weldon, Incandescent, Two () Lights, Dual Light and Lens Lights, Dome CC, () Weldon, Incandescent, Red/Clear, MUX only Cab Instruments, Ivory Gauges, Chrome Bezels, Impel/Velocity 00, Dash CF Air Restriction Indicator, Imp/Vel, AXT, Dash CF Switching, Cab, Rocker MUX, Impel/Velocity, AXT MUX, Dash CF Location, Emerg Sw Pnls - Driver's Side Overhead Wiper control, -speed with intermittent, Impel/Velocity, Dash CF Wiring, Spare, A V DC, First vdc power from - a) battery direct Location - on dashboard officer of cab. Qty, - 0 Wire termination - p) amp power point plug Vehicle Information Center, LCD On Gauge Cluster Only Vehicle Data Recorder, Dual Module Antenna, Mount Only, For -way Radio Std, DLX/Enf/AXT/IMP/VEL/Dash CF Pierce Command Zone, Advanced Electronics and Control System Batteries, (4) Exide Grp 3, 90 CCA each, Threaded Stud Battery System, Single Start, All Custom Chassis Battery Compartment, Imp/Vel Charger, Sngl Sys, IOTA, DSL 4, 4 amp Location, Charger/Compr, w/location feature Location - under forward facing seats in crew cab. Not Required, Remote Battery Charger Indicator Shoreline, 0A 0V, Kussmaul Super Auto Eject, PMFD Color, Kussmaul Cover - b) red Connection, Shoreline - Battery Charger Qty, Shoreline - Shoreline Location, Contender Pumper, Tanker, Mini Location, Shoreline (s) - ) DS Cab Side Alternator, 70 amp, Leece-Neville 494PA, Sgl Sys Load Manager/Sequencer, MUX Enable/Disable Hi-Idle - d)high Idle disable Lighting, FMVSS, Cab, Ri-Tar LED Clrnc/ID, Imp/Vel Rect Headlts Light, Front Zone, Whelen M*C LED, Clear Lens, 4-Lts Q Bezel Color, Lt DS Frnt Outside - r) DS Front Outside Red Color, Lt DS Front Inside - r) DS Front Inside Red Color, Lt PS Frnt Outside - r) PS Front Outside Red 4//0 3:7:PM Page 3

5 SP Color, Lt PS Front Inside - r) PS Front Inside Red Alarm, Back-up Warning, PRECO 040 Manual on CD, Fire Apparatus Parts, Custom, PMFD Manual on CD, Chassis Service, Custom, PMFD Manual on CD, Chassis Operation, Custom, PMFD Electrical Diagrams Amp Draw Report, NFPA 009 Edition Amp Draw, NFPA Radio Allowance Pumper, Long, Alum, PMFD Tank, Water, 000 Gallon, Poly, Pumper Long, PMFD Overflow, 4" Water Tank, Poly Foam Cell Required Not Required, Restraint, Water Tank, Heavy Duty No Direct Tank Fill Req'd (No Dump Valve required) Jet Assist Not Req'd (No Dump Chute Required) Not Required, Switch, Tank Dump Master Hose Bed, Aluminum, PMFD Hose Bed Capacity, Additional, Contender Series Capacity, Hosebed - DS 00' of.0" 000' of.00" 00' of.0" PS Divider,." Unpainted Hose Bed, PMFD Qty, Hosebed Dividers - Hose Restraint, Hosebed, Velcro Strap on Top, " Heavy Nylon Web at Rear Nylon Web Color - Black Type of fastener - " cam buckle Type of fastener, Rear - " cam buckle - bottom of hosebed Runningboard,.7" Deep Tailboard, " Deep, Smooth Aluminum Rear Wall Tow Bar, Under Tailboard, Contender Construction, Compt, Alum, PMFD DS " Rollup Full Hgt Ft&Rr, Full Dp Lr Extd Rr, PMFD PS " Rollup, FH Ft&Rr, Full Dp Lr Extd Rr, PMFD Doors, Roll-up, Gortite, Annodized and/or Locking, Side Compts, PMFD Color,Gortite,Roll-upDoor - Satin finish Latch, Gortite, Roll-up - Non-locking Liftbar Qty, Door Accessory - 0 Rear - Rollup Dr/44.0" FF, PMFD Door, Roll-up, Gortite, Satin Finish and/or Locking, Rear Compt, PMFD Latch, Gortite, Roll-up - Non-locking Liftbar No Body Modification Required Guard, Drip Pan, S/S, Roll-up Door Location, Door Accessory - all compartment doors. Qty, Door Accessory - 07 Shelves, Adjustable, lb Capacity Location, Shelf - One shelf in compartments D, D3 P, P3, R, upper portion. Qty, Shelf - 0 Shelf Tracks Location - In body compartments D, D3 P, P3 & R. Qty, Shelf Track - 0 Rubrail, Aluminum Extruded, Side of Body Fender Crowns, Rear, S/S Not Required, Hose, Hard Suction Handrails, Side Pump Panels (), Raised Pumphouse, Contender Handrail, Beavertail -Std. Handrail, Rear Below Hose Bed Compt, Air Bottle in Fender, Cast Prod Dr, Each, PMFD Location, Air Bottle - (3) PS, DS Behind Rr Wheel Qty, Air Bottle Comp - 3 Ladder, 4' Duo-Safety 900A -Sect Ladder, 4' Duo-Safety 77A Roof Ladders Btwn Tank & S.Sht, Encl'd Partial, PS, Metal Rack, PMFD 7 3 4//0 3:7:PM Page 4

6 Ladder, Folding, 0' 8A, Duo-Safety, w/mtg Location, Fold Ladder - d) Ladder comp Pole, Pike 8' Akron, Fiberglass Location - in ladder compartment. Qty, Pike Poles - Pole, Pike ' Akron, Fiberglass Location - in ladder compartment. Qty, Pike Poles - Tubes, Alum, Pike Pole Storage, Contender Series Location, Pike Pole - Ladder Storage Compt Qty, Pike Pole Tubes - 0 No Steps Front of Body (Contender) Steps, Folding, Rear of Body, w/led, Trident Coating, Step - black Step, Folding - Extra, Body Only, Black, w/led, Trident Location, Additional Step - rear of body on driver side for access to hosebed. Qty, Step - 0 Pump, 00 CSU Single Stage,Waterous Packing, Grafoil, Waterous Pump Setup Charges N/A Transmission, Pump, Waterous C0 Series Shift, Air w/ Manual Over, Split Shaft PTO,Waterous Transmission Lock-up, EVS Auxiliary Cooling System (No Transfer Valve Required on Stage Pump) Valve, Relief Intake, Elkhart Controller, Pressure, Class Total Pressure Governor (TPG) Primer, Hale, ESP, For An Other Pump Manuals, Pump (), CD Plumbing, Stainless Steel and Hose, PMFD Not Required, Black Iron Pipe with S/S Plumbing Inlets,.00" - 0 GPM or Larger Pump Cap, Long Handle Pump Inlet, NST - VLH Valves, Akron 8000 series- All Inlet, LH Side,.0" gated No Aux. Inlet on RH Side Valve, Inlet(s) Recessed, Side Cntrl, "Control Zone" Qty, Inlets - Inlet Control At Valve No Rear Inlet (Large Dia) Requested No Rear Suction Cap No Rear Inlet Actuation No Rear Intake Relief Valve Req'd Provision, Front Inlet No Rear Inlet (auxiliary) Requested Valve,.7 Bleeder, Aux. Side Inlet, Swing Handle Line, 3.00" Tank to Pump Outlet,.0" Tank Fill Outlet(s), LH Side,.0", PMFD Qty, Discharges - 0 No Additional Outlet (LH) Requested Outlet(s), RH Side,.0", PMFD Qty, Discharges - 0 No Additional Outlets (RH) Requested Outlet, 4" w/3.0" Akron Valve, Right Outlet, Front,.0" w/.00" plumb & swivel, Top of Bumper Location, Outlet - a) passenger's side Qty, - Outlet, Rear,.0" (Contender) Location, Outlet - b) driver's side Qty, Discharges - 0 No Rear Outlet (Added) Requested 4//0 3:7:PM Page

7 No Hosebed/Running Board Outlet Caps for.0" " Discharges - VLH Valve,.7 Bleeder, Discharges, Swing Handle Elbows, 4 Degree -.0" Outlets LH - VLH No Elbows Req'd (Added LH Outlets) Elbows, 4 Degree -.0" Outlets RH - VLH No Elbow req'd (Added RH Outlet not requested) Elbows, 4 Degree -.0" Outlets Rear - VLH No Elbows Req'd, Added Rear, Large Outlet Elbow, 30 Degree "(F) X.00" Storz Control, Outlets, Manual, Pierce HW if applicable Outlet, 3.00" Deluge ( Riser) No Monitor Requested No Nozzle Req'd Deluge Mount, NPT Crosslays(), Sngl Sheet unpainted,.0", Std. Cap, PMFD No.0" Crosslay Requested Not Required, Speedlays Hose Restraint, Crosslay/Deadlay, " Heavy Nylon Web, Strap Fasteners, Each Side Nylon Web Color - Black Qty, - 0 Restraint Location - Bottom Type of fastener - " cam buckle Hose Restraint, Crosslay/Deadlay, Aluminum Treadplate, Top Only Restraint Location - Front Stay arm, Tray Cover - g) socket and plunger Foam Sys, Husky 3, Single Agent, PMFD Disc, Contender, Foam - CL, Frt Disc Not Required, CAF Compressor Refill, Foam Tank, Integral, Husky 3 Demonstration, Foam System, Dealer Provided Foam Cell, 0 Gallon, Reduce Water Foam, Brand Name - chemguard Type of Foam - Class "A" Drain,.00", Foam Tank #, Husky 3 Foam System Not Required, Foam Tank # Not Required, Foam Tank Drain Pump House, Side Control, 4", "Control Zone", PMFD Pump Panel Configuration, Control Zone Panel, Pump and Gauge, Black Vinyl (Contender) Panel, Pump Access - Pass Side Only Raised Pump House Structure, Side Control, Contender Series Engine Indicators, Included With Pressure Controller Throttle Included w/ Pressure Controller Indicators, Engine, Included with Pressure Controller Gauges, 4" Master - Class, 30"-0-00psi Gauge,.0" Pressure - Class, 30"-0-400psi Gauge, Water Level, Class, Pierce Std. Gauge, Foam Level, () Tank, Class Light Shield, Side Mt Electrical, Impel/Velocity/Contender Big Block/Dash CF Lights, Step, Ri-Tar Model M7HW Super LED Lights, Tail, Weldon 3884 Tri-Light Cluster Lights, Backup, Included in Weldon light cluster (triple or quad) Lights, Identification/Clearance, Rear Light, Do Not Move Apparatus Alarm, Do Not Move Truck - a)alarm Messages, Open Door/Do Not Move Truck, Imp/Vel, AXT, CBBC MUX, Dash CF Lights, Compt, Truck-Lite, Model Incandescent Light, Pump Compt, Contender Lights, Perimeter Scene Cab Exits, Truck-Lite, Model 0 Cab, Perimeter Scene - Cab, 4dr Custom 4//0 3:7:PM Page

8 Lights, Perimeter Scene, Truck-Lite 0 (4) Lts, Contender Series Switch, Location, Perim - Parking brake Lights, Deck, Unity () AG, Rear, Both Flood Portable Hand Light, Provided by Fire Department, Pumper NFPA Classification Air Horns, () Grover in Bumper Outside Frame Location, Air Horn (bmpr) - outboard of frame rails, siren speakers inside of air horns, each side of bumper. Control, Air Horn, Horn Ring, PS Foot Sw Siren, Code W or 00W Location, Elect Siren, Recessed Overhead in Console Location, Elec Siren - Overhead, Above Eng Tunnel DS Control, Elec Siren, PS Foot Sw Speaker, Code-3 PB00C, Chrome Connection, Speaker - siren head Qty, Speakers - Location, Recessed in the Front Bumper, Driver and Passenger Side Lightbar, Whelen, Justice, Contender, 0-R LED, -C LED Flasher, Headlight Alternating Lights, Side Zone Lower, Whelen M*C LED, Clear Lens pr Color, Lt Side Front - r) Side Front Lt Red Color, Lt Side Rear - r) Side Rear Lt Red Location, lights frt side - b)each side bumper Location, lights rear - rear body fender panel, above rear axle, one each side of truck. Lights, Rear Zone Lower, Whelen M*C LED, Clear Lens Color, Lt DS Rear - r) DS Rear Lt Red Color, Lt PS Rear - r) PS Rear Lt Red Lights, Rear, Whelen M*C LED, Clear Lens Color, Light - ae) red Control, light - a) rear upper warning Location - rear body bulkheads, one each side, high as possible. Qty, - 0 Light, Rear Zone Upper, Whelen L3HRFN LED Beacon, Red LED Color, Dome, Rear Warning - j) both domes clear Not Required, Lights, Rear Upper Zone Blocking Mtg, Rear Warn Lts, on Top of Compt Not Required, Brand, Hydraulic Tool System Bag of Nuts and Bolts Qty, Bag Nuts and Bolts - NFPA Required Loose Equipment, Pumper, Provided by Fire Department Soft Suction Hose, Provided by Fire Department, Pumper NFPA Classification No Strainer Required Extinguisher, Dry Chemical, Pumper, Provided by Fire Department Extinguisher,. Gal. Pressurized Water, Pumper, Provided by Fire Department Axe, Flathead, Pumper, Provided by Fire Department Axe, Pickhead, Pumper, Provided by Fire Department Paint, Two Tone w/shield, 90 Red & White, Custom Contender Paint Color - Contender - #90 Candy Apple Red Paint Color-Upper-Contndr - #0 white Paint Chassis Frame Assy. Black, Std. Wheels, Painted Job Color, Outer Wheel Surface Color, Paint - Red #90 Compartment paint, Spatter gray Reflective Band, "-"-" Color, Reflect Band - A - a) white Color, Reflect Band - B - l) white Color, Reflect Band - C - w) white Reflective across Cab Face, Imp/Vel Stripe, Chevron, Rear, Diamond Grade, Pumper Color, Rear Chevron DG - fluorescent yellow green Stripe, Black Outline, Vinyl on Reflective Band Qty, - 03 Stripe, Reflective, Cab Doors Interior 3 4//0 3:7:PM Page 7

9 Color, Reflective - a) white Not Required, Lettering Specs [Lettering not Requested] Warranty, Basic, Year, Apparatus, WA0008 (No Pick Required) Warranty, Frame, 0 Year, Custom Chassis, WA003 (No Pick Required) Warranty, Axle, Year, Meritor, General Service, WA004 Warranty, Axle, Year, Meritor, General Service, WA004 Warranty, Structure, 0 Year, Custom Cab, WA00 Warranty, Paint, 0 Year, Cab, Pro-Rate, WA00 Warranty, Electronics, Year, MUX, WA004 Warranty, -year EVS Transmission, Standard Custom, WA087 Warranty, Water Tank, Lifetime, UPF, Poly Tank, WA003 Warranty, Structure, 0 Year, Body, WA0009 Warranty, Waterous Yrs Warranty, 0 Year S/S Pumbing, WA003 Warranty, Paint, 0 Year, Body, Pro-Rate, WA007 Not Required, Warranty, No Lettering Certification, Engine Installation, Velocity, DDC DD3, CD0087 Certification, Cab Integrity, Velocity Certification, Cab Door Durability, Velocity/Impel, CD000 Certification, Windshield Wiper Durability, Impel/Velocity, CD000 Certification, Electric Window Durability, Velocity/Impel, CD0004 Certification, Seat Belt Anchors and Mounting, Velocity/Impel/CBBC Certification, Cab Heater and Defroster, Velocity/Impel, CD00 FLORIDA DIVISION BODY PIERCE CHASSIS DD3 ENGINE EVS 4000 Series TRANSMISSION WATEROUS PUMP POLY TANK FOAM SYSTEM SIDE CONTROL AKRON VALVES ABS SYSTEM 4//0 3:7:PM Page 8