ECP44304T-4 300HP,1785RPM,3PH,60HZ,449T,A44152M,TEFC

Transcription

1 Product Information Packet EP44304T-4 300HP,785RPM,3PH,60HZ,449T,A445M,TEF opyright All product information within this document is subject to Baldor Electric ompany copyright protection, unless otherwise noted.

2 Part Detail Revision: M Status: PRD/A hange #: Proprietary: No Type: A Elec. Spec: A44WG556 D Diagram: Mfg Plant: Mech. Spec: Layout: Poles: 04 reated Date: Base: Eff. Date: Leads: 3#/0 (0 per group) Specs atalog Number: EP44304T-4 Heater Indicator: No Heater Enclosure: TEF Insulation lass: F Frame: 449T Inverter ode: Not Inverter Frame Material: Iron KVA ode: G Frequency: HZ Lifting Lugs: No Lifting Lugs Synchronous Frequency: HZ Motor Lead Quantity/Wire Size: /0 AWG Frequency: HZ Motor Type: A445M XP lass and Group: None Mounting Arrangement: F XP Division: Division II Power Factor: 88 Agency Approvals: SA EEV Pulley End Bearing Type: Ball Auxillary Box: No Auxillary Box Pulley Face ode: Standard Base Indicator: Rigid Shaft Ground Indicator: No Shaft Grounding Bearing Grease Type: Polyrex EM (-0F +300F) Shaft Rotation: Reversible onstant Torque Speed Range: Shaft Slinger Indicator: Shaft Slinger Voltage: V Speed ode: Single Speed Design ode: B Motor Standards: NEMA Drip over: No Drip over Starting Method: Direct on line Duty Rating: ONT Thermal Device - Bearing: None Page of 0

3 Feedback Device: NO FEEDBAK Thermal Device - Winding: None XP Temp ode: T Page 3 of 0

4 Nameplate NP338 AT NO EP44304T-4 SPE NO. P44G3954 HP 300 AMPS 334 VOLTS 460 DESIGN B FRAME 449T RPM 785 HZ 60 AMB 40 SF.5 D.E. BRG.DATA 638 O.D.E. BRG.DATA 638 PH 3 DUTY ONT INSUL.LASS F D.E. BRG. 90B03J30X TYPE P ENL TEF ODE G O.D.E. BRG. 90B03J30X POWER FATOR 88 NEMA NOM EFFIIENY 96. 3/4 LOAD EFF MAX ORR KVAR 5.0 GUARANTEED EFFIIENY 95.8 TEMP ODE T TEMP = 30 HP HZ T HZ VT HZ 0-60 INVERTER-TEMP-ODE T SER.NO. MOTOR WEIGHT 306 Page 4 of 0

5 xt RPM 785 S.F..5 ROTOR ZE 449T VOLTS 460 NEMA DESIGN B TEST S.O. TYPIAL DATA 300 AMPS 334 ODE LETTER G TEST DATE --- P DUTY ONT ENLOSURE TEF STATOR RES.@ /60 AMB /INSUL 40/F E/S OHMS (BETWEEN LINES) REL. S.O. FRAME HP TYPE PHASE/HERTZ Page 5 of 0 REMARKS: AMPERES SHOWN FOR VOLT ONNETION, IF OTHER VOLTAGE ONNETIONS ARE AVAILABLE, THE AMPERES WILL VARY INVERSELY WITH THE RATED VOLTAGE. DR. BY K. BY APP. BY DATE!!" #$# A- MOTOR PERFORMANE URVES ISSUE DATE $## Printed on 3/4/4 ragsun

6 xt REL. S.O. AMPS E/S FRAME HP TYPE 449T 300 P 3/ DUTY 334 ONT 40/F.5 B G TEF ROTOR AMB / INSUL. S.F. TEST S.O ZE PERFORMANE LOAD HP AMPERES RPM NO LOAD /4 /4 3/4 4/4 5/4 LOKED ROTOR PULL UP BREAKDOWN FULL LOAD PHASE/ HERTZ NEMA DESIGN TEST DATE SPEED TORQUE RPM TORQUE % FULL LOAD RPM ODE LETTER % POWER FATOR TORQUE LB.-FT. VOLTS ENL. STATOR RES.@5 OHMS (BETWEEN LINES) % EFFIIENY AMPERES Page 6 of 0 AMPERES SHOWN FOR 460. VOLT ONNETION. IF OTHER VOLTAGE ONNETIONS ARE AVAILABLE, THE AMPERES WILL VARY INVERSELY WITH THE RATED VOLTAGE REMARKS: TYPIAL DATA NEMA NOM. EFF % GUAR. MIN. EFF % DR. BY K. BY APP. BY DATE A- MOTOR J.J.HARRISON T.G.KELATI T.G.KELATI PERFORMANE 06/03/0 ISSUE DATE 03/04/0 DATA A44WG556-R00 Printed on 3/4/4 ragsun

7 xt RPM 785 S.F..5 ROTOR ZE 449T VOLTS 460 NEMA DESIGN B TEST S.O. TYPIAL DATA 300 AMPS 334 ODE LETTER G TEST DATE --- P DUTY ONT ENLOSURE TEF STATOR RES.@ /60 AMB /INSUL 40/F E/S REL S.O. FRAME HP TYPE PHASE/HERTZ! & && && & & & &) &) #$! " " "!'!(!! " & *) ( $ *)" (! OHMS (BETWEEN LINES) % Page 7 of 0 AMPERES SHOWN FOR ONNETION, IF OTHER VOLTAGE ONNETIONS ARE AVAILABLE, THE AMPERES WILL VARY INVERSELY WITH THE RATED VOLTAGE. DR. BY K. BY APP. BY DATE Printed on 3/4/4 ragsun A- MOTOR PERFORMANE URVES ISSUE DATE

8 F DUTY MASTER ALTERNATING URRENT MOTORS SQUIRREL-AGE INDUTION F ENLOSURE: TOTALLY ENLOSED FRAME 449T ABOVE NEMA RATINGS (800 RPM MAX) OOLING: FAN OOLED MOUNTING: FOOT INLUDES 447T FRAME MOUNTING HOLES E E D 8.39 D SQ. KEY LEAD OPENING /6 8 HOLES B B GROUND HOLES QTY /-3 TAP; QTY 3/8-6 TAP VARIES +.00,-.06 VARIES +.000,-.00 ON STANDARD MOTORS THIS IS ONDUIT SIZE. ON XT AND ORROSION PROOF MOTOR THIS IS PIPE TAP. MOTOR WEIGHTS MAY VARY BY 5% DEPENDING ON RATING. OBSTRUTION MUST NO ENROAH ON AIR INLET 5 WEIGHT (LBS): 3080 DRIVE END AIR DEFLETOR IS ONLY INLUDED WHEN NEESSARY. A SHEET NUMBER OF ONDUIT BOX LOATED ON OPPOSITE SIDE WHEN F-. IF MOUNTING LEARANE DETAILS ARE REQUIRED, ONSULT FATORY. MAXIMUM PERMISSIBLE SHAFT RUNOUT WHEN MEASURED AT END OF STANDARD SHAFT EXTENSION IS.003" T.I.R. TO 5 INH DIA DIMENSIONS ARE IN INHES; SEE SHEET FOR DIMENSIONS IN MILLIMETERS USTOMER IS RESPONSIBLE FOR DETERMINING THAT MOTOR PERFORMANE IS SUITABLE IN THE APPLIATION. REV. DES: NEW DRAWING REV: B VERSION: 0 REVISED: :3:36 0/3/07 TDR: MODEL NO BY: RAGRA 4 3 G449T/447T STD FOOTED SIDE/ENTER /B A Page 8 of 0

9 F DUTY MASTER ALTERNATING URRENT MOTORS SQUIRREL-AGE INDUTION F ENLOSURE: TOTALLY ENLOSED FRAME 449T ABOVE NEMA RATINGS (800 RPM MAX) OOLING: FAN OOLED MOUNTING: FOOT INLUDES 447T FRAME MOUNTING HOLES E E D 3 D SQ. KEY LEAD OPENING /6 8 HOLES B B GROUND HOLES QTY /-3 TAP; QTY 3/8-6 TAP VARIES +.00,-.06 VARIES +.000,-.00 ON STANDARD MOTORS THIS IS ONDUIT SIZE. ON XT AND ORROSION PROOF MOTOR THIS IS PIPE TAP. MOTOR WEIGHTS MAY VARY BY 5% DEPENDING ON RATING. OBSTRUTION MUST NO ENROAH ON AIR INLET 5 WEIGHT (KGS): 400 DRIVE END AIR DEFLETOR IS ONLY INLUDED WHEN NEESSARY. A SHEET NUMBER OF ONDUIT BOX LOATED ON OPPOSITE SIDE WHEN F-. IF MOUNTING LEARANE DETAILS ARE REQUIRED, ONSULT FATORY. MAXIMUM PERMISSIBLE SHAFT RUNOUT WHEN MEASURED AT END OF STANDARD SHAFT EXTENSION IS.08 MM T.I.R. TO 7 MM DIA DIMENSIONS ARE IN MILLIMETERS; SEE SHEET FOR DIMENSIONS IN INHES USTOMER IS RESPONSIBLE FOR DETERMINING THAT MOTOR PERFORMANE IS SUITABLE IN THE APPLIATION. REV. DES: NEW DRAWING REV: B VERSION: 0 REVISED: :3:36 0/3/07 TDR: MODEL NO BY: RAGRA 4 3 G449T/447T STD FOOTED SIDE/ENTER /B A Page 9 of 0

10 Page 0 of 0