Caterpillar Electronic Technician 2012C v1.0 Product Status Report 11/23/2013 2:25 PM

Transcription

1 Page 1 of 13 Caterpillar Electronic Technician 2012C v1.0 Product Status Report 2:25 PM Product Status Report Product ID Comments Implement Control #2 Product ID ECM Part Number MS ECM Location 3 Software Group Part Number SEP2011 Software Group Aux Implement Ctrl #1 Logged Diagnostic s [Diagnostic Clock = hours] - Implement Control #2 Occ. First Last No Logged Diagnostic s Logged Event s [Diagnostic Clock = hours] - Implement Control #2 Occ. First Last No Logged Events Active Diagnostic s - Implement Control #2

2 Page 2 of 13 No Active s Active Event s - Implement Control #2 No Active Events Configuration - Implement Control #2 Unit Advanced Machine Security System Installation Status Sunday Security System Bypass Start Time Sunday Security System Bypass Stop Time Monday Security System Bypass Start Time Monday Security System Bypass Stop Time Tuesday Security System Bypass Start Time Tuesday Security System Bypass Stop Time Wednesday Security System Bypass Start Time Wednesday Security System Bypass Stop Time Thursday Security System Bypass Start Time Thursday Security System Bypass Stop Time Friday Security System Bypass Start Time Friday Security System Bypass Stop Time Saturday Security System Bypass Start Time Saturday Security System Bypass Stop Time Total Tattletale 0 Implement Product ID ECM Part Number MS ECM Location 2 Software Group Part Number SEP2011 Software Group 140 MG Master Impl Cntl

3 Page 3 of 13 Logged Diagnostic s [Diagnostic Clock = hours] - Implement Occ. FirstLast Auxiliary Lever #7 Position Sensor : Voltage Above Normal Auxiliary Lever #7 Position Sensor : Abnormal Frequency, Pulse Width, or Period Auxiliary Lever #7 Position Sensor : Voltage Below Normal Primary Steering Valve Control Module : Failure Logged Event s [Diagnostic Clock = hours] - Implement Occ. First Last E192 (3) Steering System Malfunction E257 (3) Steering Output Detected with No Command Given Active Diagnostic s - Implement No Active s Active Event s - Implement No Active Events Current Totals - Implement Unit Total Operating Hours 5790 hours Configuration - Implement Unit Left Steering Cylinder Maximum Extension Length mm Right Steering Cylinder Maximum Extension Length mm Left Steering Cylinder Minimum Retraction Length mm Right Steering Cylinder Minimum Retraction Length mm Left Steering Cylinder Position Sensor Maximum Pulse Duration usec

4 Page 4 of 13 Right Steering Cylinder Position Sensor Maximum Pulse Duration usec Left Steering Cylinder Position Sensor Minimum Pulse Duration 24.1 usec Right Steering Cylinder Position Sensor Minimum Pulse Duration 24.5 usec Hydraulic Oil Viscosity Rating SAE 10W Machine Shipping Mode Enable Status Disabled Auxiliary Valve #1 Control Lever Configuration Auxiliary Valve #2 Control Lever Configuration Lever #7 Auxiliary Valve #3 Control Lever Configuration Auxiliary Valve #4 Control Lever Configuration Auxiliary Valve #5 Control Lever Configuration Auxiliary Valve #6 Control Lever Configuration Auxiliary Valve #7 Control Lever Configuration Auxiliary Lever #1 Float Enable Status Disabled Auxiliary Lever #4 Float Enable Status Disabled Auxiliary Lever #6 Float Enable Status Disabled AccuGrade System Installation Status AccuGrade Enable Status Disabled AccuGrade Temporary Installation Status Auxiliary Control Pod Enable Status Enabled CAN Communication Protocol Write Security Unavailable CAN Communication Protocol Read Security Unavailable Calibration Status - Implement Calibration Status Last Successful Completion Articulation Position Sensor Calibration Success hours Auxiliary Valve #1 Port B Solenoid Never Calibrated Never Successfully Calibrated Auxiliary Valve #1 Port A Solenoid Never Calibrated Never Successfully Calibrated Auxiliary Valve #2 Port B Solenoid Success 2.9 hours Auxiliary Valve #2 Port A Solenoid Success 2.9 hours Auxiliary Valve #3 Port B Solenoid Never Calibrated Never Successfully Calibrated Auxiliary Valve #3 Port A Solenoid Never Calibrated Never Successfully Calibrated Auxiliary Valve #4 Port B Solenoid Never Calibrated Never Successfully Calibrated Auxiliary Valve #4 Port A Solenoid Never Calibrated Never Successfully Calibrated Auxiliary Valve #5 Port B Solenoid Never Calibrated Never Successfully Calibrated Auxiliary Valve #5 Port A Solenoid Never Calibrated Never Successfully Calibrated Auxiliary Valve #6 Port B Solenoid Never Calibrated Never Successfully Calibrated Auxiliary Valve #6 Port A Solenoid Never Calibrated Never Successfully Calibrated Blade Right Lower Solenoid Calibration Success 2.7 hours Blade Right Lower Float Solenoid Calibration Success 2.7 hours

5 Page 5 of 13 Blade Left Lower Solenoid Calibration Success 2.7 hours Blade Left Lower Float Solenoid Calibration Success 2.8 hours Circle Right Solenoid Calibration Success 2.8 hours Circle Left Solenoid Calibration Success 2.8 hours Blade Right Raise Solenoid Calibration Success 2.8 hours Blade Left Raise Solenoid Calibration Success 2.8 hours Blade Sideshift Right Solenoid Calibration Success 2.8 hours Blade Sideshift Left Solenoid Calibration Success 2.8 hours Blade Pitch Forward Solenoid Calibration Success 2.8 hours Blade Pitch Backward Solenoid Calibration Success 2.8 hours Circle Sideshift Right Solenoid Calibration Success 2.9 hours Circle Sideshift Left Solenoid Calibration Success 2.9 hours Articulate Right Solenoid Calibration Success 2.9 hours Articulate Left Solenoid Calibration Success 2.9 hours Wheel Lean Right Solenoid Calibration Success 2.9 hours Wheel Lean Left Solenoid Calibration Success 2.9 hours Steering Cylinder Position Sensors Calibration Success hours Trans/Chassis Product ID Transmission Serial Number ECM Part Number MS ECM Location 1 Software Group Part Number SEP2011 Software Group 140 MG Chassis/Trans Logged Diagnostic s [Diagnostic Clock = hours] - Trans/Chassis Occ. First Last Secondary Steering System Steer Right Solenoid : Current Below Normal Logged Event s [Diagnostic Clock = hours] - Trans/Chassis Occ. First Last

6 Page 6 of 13 E192 (3) Steering System Malfunction E258 (3) No steering detected with command given Active Diagnostic s - Trans/Chassis No Active s Active Event s - Trans/Chassis No Active Events Current Totals - Trans/Chassis Unit Total Operating Hours 5790 hours Total Hours Coasting In Neutral 11 hours Machine Idle Time hours Configuration - Trans/Chassis Unit Transmission Serial Number Autoshift Feature Installation Status Transmission Minimum Forward Autoshift Gear Transmission Maximum Forward Autoshift Gear Transmission Minimum Reverse Autoshift Gear Transmission Maximum Reverse Autoshift Gear Transmission Maximum Forward Gear 8 Transmission Maximum Reverse Gear 6 Transmission Initial Forward Gear 2 Transmission Initial Reverse Gear 2 Clutch #1 Hold Level Current Command Unavailable Amps Clutch #2 Hold Level Current Command Unavailable Amps Clutch #3 Hold Level Current Command Unavailable Amps Machine Speed Limit 50 mph Machine Speed Correction Factor % Transmission Orifice Plate Installation Status Unavailable

7 Page 7 of 13 Transmission Oil Type Configuration TDTO SAE 30 Air Conditioning System Installation Status Installed Battery Cable Shield Monitoring System Installation Cold Engine Parasitic Load Reduction Installation Automatic Differential Lock Feature Installation Status Security System Immobilizer Installation Status CAN Communication Protocol Write Security Unavailable CAN Communication Protocol Read Security Unavailable Total Tattletale 0 Shift Count Matrix - Trans/Chassis To N R1 R2 R3 R4 R5 R From N R R R R R R Counters - Trans/Chassis Parking Brake Pressure Switch Cycles Parking Brake Solenoid Cycles Starter Relay Cycles 5625 Service Brake Pedal Switch Cycles Number of Cold Temperature Transmission Filter Bypasses 1096 Total Cold Temperature Transmission Oil Filter Bypass Hours 10

8 Page 8 of 13 C7 (KHX13324) Engine Serial Number KHX JL Software Group Part Number AUG11 Software Group MG- Logged Diagnostic s [Diagnostic Clock = hours] - C7 (KHX13324) Occ. First Last 42-5 Injector Actuation Valve : Current Below Normal Logged Event s [Diagnostic Clock = hours] - C7 (KHX13324) Occ. First Last No Logged Events Active Diagnostic s - C7 (KHX13324) No Active s Active Event s - C7 (KHX13324) No Active Events Current Totals - C7 (KHX13324) Unit Total Operating Hours 5790 hours Total Fuel gal Total Max Fuel gal Total Idle Time 2325:15 hours

9 Page 9 of 13 Total Idle Fuel 2285 gal Lifetime Total Engine Revolutions rev Engine Starts 4540 Configuration - C7 (KHX13324) Unit Engine Serial Number KHX JL ECM Part Number Software Group Part Number AUG11 Software Group MG- Engine Cooling Fan Map Standard Ether Solenoid Configuration Number of Available Engine Power Levels 4 Security System Immobilizer Installation Status Engine Warmup Elevated Idle Feature Enable Status Enabled FLS -14 FTS 43 Total Tattletale 1835 Injector Trim Calibration - C7 (KHX13324) Injector Serial Number File Version Tattletale Injector B DD 0 0 Injector B C 0 0 Injector B D4 0 0 Injector B Injector B E 0 0 Injector B C1 0 0 Monitoring System - C7 (KHX13324) State Trip Point Delay Time Engine Overspeed Least Severe (1) Always On 2600 rpm 0 sec Moderate Severity (2) Always On 2800 rpm 0 sec

10 Page 10 of 13 High Air Filter Restriction Pressure Least Severe (1) Always On 30.1 " H2O 15 sec Moderate Severity (2) Always On 30.1 " H2O 30 sec High Engine Coolant Temperature Least Severe (1) Always On 226 Deg F 10 sec Moderate Severity (2) On 232 Deg F 10 sec Most Severe (3) Off 232 Deg F 10 sec High Engine Inlet Air Temperature Least Severe (1) Always On Deg F 8 sec Moderate Severity (2) Always On Deg F 8 sec High Fuel Filter Pressure Restriction Least Severe (1) On None 3600 sec Moderate Severity (2) On None sec High Fuel Pressure Least Severe (1) Always On psi 8 sec High Fuel Temperature Least Severe (1) Always On Deg F 30 sec Moderate Severity (2) On Deg F 10 sec Low Engine Oil Pressure Least Severe (1) Always On None 8 sec Most Severe (3) Always On None 4 sec Product Link Machine Serial Number Dealer Identification E140 DBS Machine Make AA 1608B867LQ Wireless Transmission Device Serial Number DQCAT Software Group Part Number APR2008 Software Group PL Logged Diagnostic s [Diagnostic Clock = hours] - Product Link Occ. First Last No Logged Diagnostic s

11 Page 11 of 13 Logged Event s [Diagnostic Clock = hours] - Product Link Occ. First Last No Logged Events Active Diagnostic s - Product Link No Active s Active Event s - Product Link No Active Events Configuration - Product Link Unit Maintenance Mode Off Machine Serial Number DBS Machine Make AA Dealer Identification E140 Registration Address Username JOSE.DELGADO Registration Address Domain HOLTCAT.COM Event/Diagnostic Report Interval (SMU) 4 hours Event/Diagnostic Message Interval (RT) 168 hours Report Start Time 1/1/ :00 AM Warning Level 3 Report Configuration Report Immediately Warning Level 2 Report Configuration Report Immediately Warning Level 1 Report Configuration Report at Next Scheduled Diagnostic Report Configuration Report at Next Scheduled Operating Hours Report Configuration On Number of Daily Machine Location Messages Configuration 4 Position Report Minimum Location Change 0 feet Fuel Consumed Report Configuration On Global Gram Enable Status Disabled GPS Fix Validity Time Duration 60.0 min Preferred Wireless Service Configuration Satellite Premium #2 Digital Sensor Input #1 Type Configuration

12 Page 12 of 13 Digital Input #1 Monitoring Condition All Conditions Digital Sensor Input #1 DIGITAL INPUT 1 Digital Sensor Input #1 Delay Time 30.0 sec Digital Sensor Input #2 Type Configuration Digital Input #2 Monitoring Condition All Conditions Digital Sensor Input #2 DIGITAL INPUT 2 Digital Sensor Input #2 Delay Time 30.0 sec Digital Sensor Input #3 Type Configuration Digital Input #3 Monitoring Condition All Conditions Digital Sensor Input #3 DIGITAL INPUT 3 Digital Sensor Input #3 Delay Time 30.0 sec Digital Sensor Input #4 Type Configuration Digital Input #4 Monitoring Condition All Conditions Digital Sensor Input #4 DIGITAL INPUT 4 Digital Sensor Input #4 Delay Time 30.0 sec Embedded Communication Adapter Installation Status Monitor Product ID ECM Part Number B024HL Software Group Part Number OCT10 Software Group Msngr MG Logged Diagnostic s [Diagnostic Clock = hours] - Monitor Occ. First Last No Logged Diagnostic s Logged Event s [Diagnostic Clock = hours] - Monitor Occ. First Last No Logged Events

13 Page 13 of 13 Active Diagnostic s - Monitor No Active s Active Event s - Monitor No Active Events Current Totals - Monitor Unit Total Operating Hours 5790 hours Configuration - Monitor Unit Product ID All Wheel Drive System Installation Status