Caterpillar Electronic Technician 2012C v1.0 Product Status Report. 12-Mar :40 PM
|
|
- Gerard Dickerson
- 6 years ago
- Views:
Transcription
1 Page 1 of 11 Caterpillar Electronic Technician 2012C v1.0 Product Status Report 12-Mar :40 PM Product Status Report Comments Monitor ECM Part Number B667HL Software Group Part Number AUG11 Software Group Msngr MG Logged Diagnostic s [Diagnostic Clock = hours] - Monitor Occ. First Last No Logged Diagnostic s Logged Event s [Diagnostic Clock = hours] - Monitor Occ. First Last No Logged Events Active Diagnostic s - Monitor No Active s
2 Page 2 of 11 Active Event s - Monitor No Active Events Current Totals - Monitor Unit Total Operating Hours 3014 hours Configuration - Monitor Unit All Wheel Drive System Installation Status C7 (KHX09207) Engine Serial Number KHX JL Software Group Part Number DEC11 Software Group MG- Logged Diagnostic s [Diagnostic Clock = hours] - C7 (KHX09207) Occ. First Last 42-5 Injector Actuation Valve : Current Below Normal Electrical System Voltage : Voltage Below Normal Logged Event s [Diagnostic Clock = hours] - C7 (KHX09207) Occ. First Last E198 (2) Low Fuel Pressure
3 Page 3 of 11 Active Diagnostic s - C7 (KHX09207) No Active s Active Event s - C7 (KHX09207) No Active Events Current Totals - C7 (KHX09207) Unit Total Operating Hours 3014 hours Total Fuel gal Total Max Fuel gal Total Idle Time 1162:27 hours Total Idle Fuel 1288 gal Lifetime Total Engine Revolutions rev Engine Starts 2735 Configuration - C7 (KHX09207) Unit Engine Serial Number KHX JL ECM Part Number Software Group Part Number DEC11 Software Group MG- Engine Cooling Fan Map Standard Ether Solenoid Configuration Continuous Flow Solenoid Number of Available Engine Power Levels 8 Security System Immobilizer Installation Status Engine Warmup Elevated Idle Feature Enable Status Enabled FLS 4
4 Page 4 of 11 FTS -7 Total Tattletale 1226 Injector Trim Calibration - C7 (KHX09207) Injector Serial Number File Version Tattletale Injector B F3 0 1 Injector B D 0 1 Injector B F 0 1 Injector B FA 0 1 Injector B D9 0 1 Injector B F4 0 1 Monitoring System - C7 (KHX09207) State Trip Point Delay Time Engine Overspeed Least Severe (1) Always On 2600 rpm 0 sec Moderate Severity (2) Always On 2800 rpm 0 sec High Air Filter Restriction Pressure Least Severe (1) Always On 2.0 " H2O 0 sec Moderate Severity (2) Always On 4.0 " H2O 0 sec High Engine Coolant Temperature Least Severe (1) Always On 226 Deg F 10 sec Moderate Severity (2) On 232 Deg F 10 sec Most Severe (3) Off 232 Deg F 10 sec High Engine Inlet Air Temperature Least Severe (1) Always On Deg F 8 sec Moderate Severity (2) Always On Deg F 8 sec High Fuel Filter Pressure Restriction Least Severe (1) On None 3600 sec Moderate Severity (2) On None sec High Fuel Pressure Least Severe (1) Always On psi 8 sec High Fuel Temperature Least Severe (1) Always On Deg F 30 sec Moderate Severity (2) On Deg F 10 sec Low Engine Oil Pressure Least Severe (1) Always On None 8 sec
5 Page 5 of 11 Most Severe (3) Always On None 4 sec Trans/Chassis Transmission Serial Number CZM01278 ECM Part Number JT ECM Location 1 Software Group Part Number SEP2011 Software Group 140 MG Chassis/Trans Logged Diagnostic s [Diagnostic Clock = hours] - Trans/Chassis Occ. First Last Directional Switch : Voltage Above Normal Logged Event s [Diagnostic Clock = hours] - Trans/Chassis Occ. First Last E627 (3) Parking Brake Applied with Machine in Motion Active Diagnostic s - Trans/Chassis No Active s Active Event s - Trans/Chassis No Active Events Current Totals - Trans/Chassis
6 Page 6 of 11 Unit Total Operating Hours 3014 hours Total Hours Coasting In Neutral 7 hours Machine Idle Time hours Configuration - Trans/Chassis Unit Transmission Serial Number CZM01278 Autoshift Feature Installation Status Installed Transmission Minimum Forward Autoshift Gear 3 Transmission Maximum Forward Autoshift Gear 8 Transmission Minimum Reverse Autoshift Gear 3 Transmission Maximum Reverse Autoshift Gear 6 Transmission Maximum Forward Gear 8 Transmission Maximum Reverse Gear 6 Transmission Initial Forward Gear 4 Transmission Initial Reverse Gear 3 Clutch #1 Hold Level Current Command Amps Clutch #2 Hold Level Current Command Amps Clutch #3 Hold Level Current Command Amps Machine Speed Limit 50 mph Machine Speed Correction Factor % Transmission Orifice Plate Installation Status Transmission Oil Type Configuration TDTO SAE 30 Air Conditioning System Installation Status Installed Battery Cable Shield Monitoring System Installation Cold Engine Parasitic Load Reduction Installation Automatic Differential Lock Feature Installation Status Security System Immobilizer Installation Status CAN Communication Protocol Write Security CAN Communication Protocol Read Security Total Tattletale 1 Shift Count Matrix - Trans/Chassis To N R1 R2 R3 R4 R5 R From N
7 Page 7 of 11 R R R R R R Counters - Trans/Chassis Parking Brake Pressure Switch Cycles 7893 Parking Brake Solenoid Cycles 7835 Starter Relay Cycles 3559 Service Brake Pedal Switch Cycles Number of Cold Temperature Transmission Filter Bypasses 620 Total Cold Temperature Transmission Oil Filter Bypass Hours 10 Implement ECM Part Number JT ECM Location 2 Software Group Part Number SEP2011 Software Group 140 MG Master Impl Cntl Logged Diagnostic s [Diagnostic Clock = hours] - Implement
8 Page 8 of 11 Occ. First Last Auxiliary Lever #7 Position Sensor : Voltage Above Normal Logged Event s [Diagnostic Clock = hours] - Implement Occ. First Last E258 (3) No steering detected with command given Active Diagnostic s - Implement No Active s Active Event s - Implement No Active Events Current Totals - Implement Unit Total Operating Hours 3014 hours Configuration - Implement Unit Left Steering Cylinder Maximum Extension Length mm Right Steering Cylinder Maximum Extension Length mm Left Steering Cylinder Minimum Retraction Length mm Right Steering Cylinder Minimum Retraction Length mm Left Steering Cylinder Position Sensor Maximum Pulse Duration usec Right Steering Cylinder Position Sensor Maximum Pulse Duration usec Left Steering Cylinder Position Sensor Minimum Pulse Duration 24.6 usec Right Steering Cylinder Position Sensor Minimum Pulse Duration 24.6 usec Hydraulic Oil Viscosity Rating SAE 10W Machine Shipping Mode Enable Status Disabled Auxiliary Valve #1 Control Lever Configuration Auxiliary Valve #2 Control Lever Configuration Lever #7
9 Page 9 of 11 Auxiliary Valve #3 Control Lever Configuration Auxiliary Valve #4 Control Lever Configuration Auxiliary Valve #5 Control Lever Configuration Auxiliary Valve #6 Control Lever Configuration Auxiliary Valve #7 Control Lever Configuration Auxiliary Lever #1 Float Enable Status Auxiliary Lever #4 Float Enable Status Auxiliary Lever #6 Float Enable Status AccuGrade System Installation Status AccuGrade Enable Status AccuGrade Temporary Installation Status Auxiliary Control Pod Enable Status CAN Communication Protocol Write Security CAN Communication Protocol Read Security Disabled Disabled Disabled Installed Disabled Enabled Calibration Status - Implement Calibration Status Last Successful Completion Articulation Position Sensor Calibration Success 2.7 hours Auxiliary Valve #1 Port B Solenoid Never Calibrated Never Successfully Calibrated Auxiliary Valve #1 Port A Solenoid Never Calibrated Never Successfully Calibrated Auxiliary Valve #2 Port B Solenoid Success 2.8 hours Auxiliary Valve #2 Port A Solenoid Success 2.8 hours Auxiliary Valve #3 Port B Solenoid Never Calibrated Never Successfully Calibrated Auxiliary Valve #3 Port A Solenoid Never Calibrated Never Successfully Calibrated Auxiliary Valve #4 Port B Solenoid Never Calibrated Never Successfully Calibrated Auxiliary Valve #4 Port A Solenoid Never Calibrated Never Successfully Calibrated Auxiliary Valve #5 Port B Solenoid Never Calibrated Never Successfully Calibrated Auxiliary Valve #5 Port A Solenoid Never Calibrated Never Successfully Calibrated Auxiliary Valve #6 Port B Solenoid Never Calibrated Never Successfully Calibrated Auxiliary Valve #6 Port A Solenoid Never Calibrated Never Successfully Calibrated Blade Right Lower Solenoid Calibration Success hours Blade Right Lower Float Solenoid Calibration Success hours Blade Left Lower Solenoid Calibration Success hours Blade Left Lower Float Solenoid Calibration Success hours Circle Right Solenoid Calibration Success hours Circle Left Solenoid Calibration Success hours Blade Right Raise Solenoid Calibration Success hours Blade Left Raise Solenoid Calibration Success hours
10 Page 10 of 11 Blade Sideshift Right Solenoid Calibration Success hours Blade Sideshift Left Solenoid Calibration Success hours Blade Pitch Forward Solenoid Calibration Success hours Blade Pitch Backward Solenoid Calibration Success hours Circle Sideshift Right Solenoid Calibration Success hours Circle Sideshift Left Solenoid Calibration Success hours Articulate Right Solenoid Calibration Success hours Articulate Left Solenoid Calibration Success hours Wheel Lean Right Solenoid Calibration Success hours Wheel Lean Left Solenoid Calibration Success hours Steering Cylinder Position Sensors Calibration Success 2.9 hours Implement Control #2 ECM Part Number JT ECM Location 3 Software Group Part Number SEP2011 Software Group Aux Implement Ctrl #1 Logged Diagnostic s [Diagnostic Clock = hours] - Implement Control #2 Occ. First Last No Logged Diagnostic s Logged Event s [Diagnostic Clock = hours] - Implement Control #2 Occ. First Last No Logged Events Active Diagnostic s - Implement Control #2
11 Page 11 of 11 No Active s Active Event s - Implement Control #2 No Active Events Configuration - Implement Control #2 Unit Advanced Machine Security System Installation Status Sunday Security System Bypass Start Time Sunday Security System Bypass Stop Time Monday Security System Bypass Start Time Monday Security System Bypass Stop Time Tuesday Security System Bypass Start Time Tuesday Security System Bypass Stop Time Wednesday Security System Bypass Start Time Wednesday Security System Bypass Stop Time Thursday Security System Bypass Start Time Thursday Security System Bypass Stop Time Friday Security System Bypass Start Time Friday Security System Bypass Stop Time Saturday Security System Bypass Start Time Saturday Security System Bypass Stop Time Total Tattletale 2
Caterpillar Electronic Technician 2012C v1.0 Product Status Report 11/23/2013 2:25 PM
Page 1 of 13 Caterpillar Electronic Technician 2012C v1.0 Product Status Report 2:25 PM Product Status Report Product ID Comments Implement Control #2 Product ID ECM Part Number 3045687-01 19086375MS ECM
More informationCaterpillar Electronic Technician 2012C v1.0 Product Status Report 9/28/2017 8:32 AM
Page 1 of 8 Caterpillar Electronic Technician 2012C v1.0 Product Status Report 8:32 AM Product Status Report Comments C18 D9 (RHX01781) Engine Serial Number RHX01781 24556258JL Personality Module Part
More informationCaterpillar Electronic Technician 2012A v1.0 Product Status Report 9/23/2013 2:35 PM
Page 1 of 7 Caterpillar Electronic Technician 2012A v1.0 Product Status Report 2:35 PM Product Status Report Parameter Value Equipment ID 740 Comments C15 740 (LHX10244) Parameter Value Equipment ID 740
More informationCat Electronic Technician 2016B v1.0 Product Status Report 1/30/2017 3:49 PM
Page 1 of 7 Cat Electronic Technician 2016B v1.0 Product Status Report 1/30/2017 3:49 PM Cat Monitor System AP1055 () C7 AP1000 Series (KHX01992) Machine Control AP1055 Product Status Report Equipment
More informationCat Electronic Technician 2017A v1.0 Product Status Report 7/10/2017 9:49 AM
Cat Electronic Technician 2017A v1.0 Product Status Report 7/10/2017 9:49 AM Product Status Report Product ID Comments ELIAS MARIN C18 772 (TXH00900) Engine Serial Number TXH00900 ECM Part Number 2622879-01
More informationCaterpillar Electronic Technician 2012A v1.0 Product Status Report 9/23/ :33 AM
Page 1 of 7 Caterpillar Electronic Technician 2012A v1.0 Product Status Report 10:33 AM Product Status Report Product ID Comments Unavailable Soft-Switch Panel ECM Part Number 2437068-00 Software Group
More informationCat Electronic Technician 2016C v1.0 Product Status Report 3/6/ :16 AM
Cat Electronic Technician 2016C v1.0 Product Status Report 3/6/2017 10:16 AM Product Status Report Parameter Product ID Equipment ID Comments Value PAC01146 Monitor Parameter Value ECM Serial Number 067E0525EE
More informationCANDO Diagnostic List Cummins_v8.27
CANDO Diagnostic List Cummins_v8.27 Remark: 1. : means that the system has this function 2. - : means that the system does not have this function 3.compared with the last version, the new added function
More informationDASH RETRIEVED FAULT CODES C ONVENTIONAL FS65 SAF T LINER C2, C2E H YBRID SAF T LINER HDX, HD, ER SAF T LINER EF, EFX A LL Y EARS
DASH RETRIEVED FAULT CODES C ONVENTIONAL FS65 SAF T LINER C2, C2E H YBRID SAF T LINER HD, HD, ER SAF T LINER EF, EF A LL Y EARS PAGE INTENTIONALLY LEFT BLANK TABLE OF CONTENTS EARLY PRODUCTS: J1587/J1708
More information5. Control System CONTROL SYSTEM FUEL INJECTION (FUEL SYSTEM) A: GENERAL FU(H4DOTC)-29
W1860BE.book Page 29 Tuesday, January 28, 2003 11:01 PM 5. Control System A: GENERAL The ECM receives signals from various sensors, switches, and other control modules. Using these signals, it determines
More informationDiagnostic Trouble Codes (continued) GM Specific Codes
85 GM Specific Codes P11XX Fuel and Air Metering P1106 MAP Sensor Circuit Intermittent High Voltage P1107 MAP Sensor Circuit Intermittent Low Voltage P1108 BARO to MAP Signal Comparison Too High P1111
More informationTroubleshooting. 3516B and 3516B High Displacement Engines for Caterpillar Built Machines. For use with 793D Off-Highway Trucks/Tractors
RENR5622 September 2005 Troubleshooting 3516B and 3516B High Displacement Engines for Caterpillar Built Machines FDB1-Up (Machine) 8WM1-Up (Engine) 7TR1-Up (Engine) For use with 793D Off-Highway Trucks/Tractors
More informationOBD-II Diagnostic Powertrain (P) Trouble Codes
OBD-II Diagnostic Powertrain (P) Trouble Codes Please use our new & improved search engine to find information on your trouble codes. Search Now! This list contains standard diagnostic trouble codes (DTC
More informationP Fuel Volume Regulator Control Circuit P Fuel Volume Regulator Control Circuit Range/Performance P Fuel Volume Regulator Control
P0001 - Fuel Volume Regulator Control Circuit P0002 - Fuel Volume Regulator Control Circuit Range/Performance P0003 - Fuel Volume Regulator Control Circuit Low P0004 - Fuel Volume Regulator Control Circuit
More informationENGINE MANAGEMENT SYSTEM. System Sensors
ENGINE MANAGEMENT SYSTEM System Sensors Throttle position sensor - Used to relay throttle position information to the ECU. Throttle opening angle is used by the ECU to determine fuelling and ignition requirements
More informationCUMMINS ENGINE DIAGNOSTIC CODES
ENGINE DIAGNOSTICS GROUP 105 CUMMINS ENGINE DIAGNOSTIC CODES 1 INTRODUCTION... 1 2 TROUBLESHOOTING CODES... 1 1 INTRODUCTION. This group provides information on the engine fault codes that could potentially
More information200C II BRAKE SYSTEM
200C II BRAKE SYSTEM The braking system on the 200C II Kress Coal Hauler uses hydraulic oil pressure from both the System and Steering accumulator circuits. Using oil from both circuits provides braking
More informationDiagnostic Report. Monitor Status Report. Page 1 of 12. Date: 12/18/2016 9:17:03 PM
file:///c:/users/rbirkenholz/app/local/microsoft/windows/temporary%20internet... Page 1 of 12 Diagnostic Report Created by OBDLink - OBD Solutions www.obdsoftware.net Date: 12/18/2016 9:17:03 PM VIN: 1D8HB58287F580896
More informationL (LU4, LJ3, L88) used in Saab 9-5 ENGINE DIAGNOSTIC PARAMETERS
Catalytic Converter Monitoring P0420 Front vs. Rear O2 sensor signal Evaluated data 1,75 times FTP std 80 (unitless) Coolant temp Throttle Delta load, positive Delta load, negative Engine speed, man. trans
More information5. Control System CONTROL SYSTEM FUEL INJECTION (FUEL SYSTEM) A: GENERAL. FU(STi)-27
W1860BE.book Page 27 Tuesday, January 28, 2003 11:01 PM 5. Control System A: GENERAL The ECM receives signals from various sensors, switches, and other control modules. Using these signals, it determines
More informationShift Solenoid "A" Performance (Shift Solenoid Valve S1)
78 DTC P0751 Shift Solenoid "A" Performance (Shift Solenoid Valve S1) DESCRIPTION The ECM uses signals from the output shaft speed sensor and input speed sensor to detect the actual gear position (1st,
More information2 OPERATION 2.1 DDEC BENEFITS FEATURES DDEC SYSTEM--HOW IT WORKS DDEC RELATED PUBLICATIONS...
2 OPERATION Section Page 2.1 DDEC BENEFITS... 2-3 2.2 FEATURES... 2-4 2.3 DDEC SYSTEM--HOW IT WORKS... 2-5 2.4 DDEC RELATED PUBLICATIONS... 2-23 (Rev. 2/03) All information subject to change without notice.
More information3126B Truck Engine 7AS13353-UP(SEBP ) - Document Structure. Media Number -RENR Publication Date -01/07/2010 Date Updated -29/07/2010
Page 1 of 5 Shutdown SIS Previous Screen Product: TRUCK ENGINE Model: 3126B TRUCK ENGINE 7AS Configuration: 3126B Truck Engine 7AS13353-UP Troubleshooting 3126B and 3126E On-highway Engines Media Number
More informationQGP Allegro Bus (Tiffin's ECM Template)
ISL9 EPA 2010 CM2250 Accelerator Interlock Accelerator Options Dual Accelerator Remote Accelerator Pedal or Lever Adjustable Low Air Speed Low Idle Speed Low Idle Speed Adjustment Switch Aftertreatment
More informationModbus Integration Integration for Modbus Functionality for VT8600 Series
Modbus Integration Integration for Modbus Functionality for VT8600 Series Building Management System *For data visualization and analysis Modbus Controller VT8000 Series room controllers 2 TABLE OF CONTENTS
More informationOperations Manual. Automated Fuel Maintenance System FUEL TECHNOLOGIES INTERNATIONAL
Operations Manual Automated Fuel Maintenance System FTI-10A & 20A FUEL TECHNOLOGIES INTERNATIONAL Replacement Manuals Available on Website: www.fueltechnologiesinternational.com 07/15/2015 Rev E Fuel Technologies
More informationShift Solenoid "B" Performance (Shift Solenoid Valve S2)
86 A750E AUTOMIC TRANSMISSION AUTOMIC TRANSMISSION SYSTEM DTC P0756 Shift Solenoid "B" Performance (Shift Solenoid Valve S2) DESCRIPTION The ECM uses signals from the output shaft speed sensor and input
More informationA750E AUTOMATIC TRANSMISSION: AUTOMATIC TRANSMISSION SYSTEM (for 1GR-FE)... Model Year: 2007 Model: 4Runner Doc ID: RM000000XP101WX
Last Modified: 4-26-2007 Service Category: Drivetrain 1.6 C Section: Automatic Transmission/Transaxle Model Year: 2007 Model: 4Runner Doc ID: RM000000XP101WX Title: A750E AUTOMATIC TRANSMISSION: AUTOMATIC
More informationA750F AUTOMATIC TRANSMISSION: AUTOMATIC TRANSMISSION SYSTEM (for 1GR-FE)... Model Year: 2007 Model: 4Runner Doc ID: RM000000W80023X
Last Modified: 4-26-2007 Service Category: Drivetrain 1.6 C Section: Automatic Transmission/Transaxle Model Year: 2007 Model: 4Runner Doc ID: RM000000W80023X Title: A750F AUTOMATIC TRANSMISSION: AUTOMATIC
More informationL (LK9, LQ8) when use in: Saab 9-3
NOTE: Printing this file may require 8.5" x 14" (legal size) paper, depending on your printer setup. Catalytic Converter Monitoring P0420 Time for Rear O2 sensor signal Time for rear O2 to go low. Value
More information2. Air Line AIR LINE FUEL INJECTION (FUEL SYSTEM) A: GENERAL B: MANIFOLD ABSOLUTE PRESSURE SENSOR FU(H4DOTC)-3
W1860BE.book Page 3 Tuesday, January 28, 2003 11:01 PM 2. Air Line A: GENERAL The air filtered by the air cleaner enters the throttle body where it is regulated in the volume by the throttle valve and
More informationL (L36) F-car 4L60-E TRANSMISSION DIAGNOSTIC PARAMETERS. 97c38K_F at.doc
Vehicle Speed Sensor - Low input Vehicle Speed Sensor - Intermittent Trans Fluid Temp Sensor Circuit - Range / Performance P0502 P0503 0 RPM to 6000 RPM low vehicle speed when the vehicle has a large engine
More informationSYTY Trouble Code: ALDL INFORMATION
SYTY Trouble Code: ALDL INFORMATION A -- Ground G -- Fuel Pump B -- Diagnostic Terminal H -- Brake Sense Speed Input F -- TCC M -- Serial Data (special tool needed - Do Not Use) For ECM Trouble Codes,
More informationShift Solenoid "B" Performance (Shift Solenoid Valve S2)
88 A750F AUTOMIC TRANSMISSION AUTOMIC TRANSMISSION SYSTEM DTC P0756 Shift Solenoid "B" Performance (Shift Solenoid Valve S2) DESCRIPTION The ECM uses signals from the output shaft speed sensor and input
More informationDiagnostic Trouble Code (DTC) List - Vehicle
Document ID# 850406 2002 Pontiac Firebird Diagnostic Trouble Code (DTC) List - Vehicle DTC DTC 021 and/or 031 DTC 022 and/or 032 DTC 023 or 033 DTC 24/34 DTC 025 and/or 035 DTC 041 DTC 042 DTC 043 DTC
More informationInjector Solenoid - Test
Injector Solenoid - Test System Operation Description: Use this procedure to troubleshoot the electrical system if a problem is suspected with the injectors or if any one of the diagnostic codes in Table
More informationProECU Subaru DIT. DTC List 2012-onward Model Year. v1.0
ProECU Subaru DIT DTC List 2012-onward Model Year v1.0 Engine DTC List P000A A CAMSHAFT POSITION SLOW RESPONSE (BANK 1) P000B B CAMSHAFT POSITION SLOW RESPONSE (BANK 1) P000C A CAMSHAFT POSITION SLOW RESPONSE
More informationTechnical Specifications
140 Motor Grader Technical Specifications Engine Engine Model Cat C9.3 Net Power ISO 9249/SAE J1349 186 kw 250 hp Net Power EEC 80/1269 186 kw 250 hp Net Power All-Wheel Drive (AWD) 201 kw 270 hp VHP Plus
More informationTorque Converter, Transmission Pump, Screen And Filter
Page 13 of 27 Transmission Hydraulic System In Forward (Engine Running - Type 2 & 3 Control Valve Shown) (4) Transmission control valve. (5) Neutralizer valve. (6) Neutralizer solenoid. (7) Flow control
More informationEngine Performance Troubleshooting Tree - Signature and ISX CM870
File: 70-t02-1001 Page 1 of 64 Engine Performance Troubleshooting Tree - Signature and ISX CM870 This troubleshooting procedure should be followed for the following symptoms: Engine Acceleration or Response
More informationPowertrain DTC Summaries EOBD
Powertrain DTC Summaries Quick Reference Diagnostic Guide Jaguar X-TYPE 2.5L and 3.0L 2001.5 Model Year Revised January, 2002: P0706, P0731, P0732, P0733, P0734, P0735, P0740, P1780 POSSIBLE CAUSES Revised
More informationDiagnostic Trouble Codes (continued) SAE Defined Codes
78 SAE Defined Codes P01XX Fuel and Air Metering P0100 Mass or Volume Airflow Circuit Problem P0101 Mass or Volume Airflow Circuit Range or Performance Problem P0102 Mass or Volume Airflow Circuit Low
More informationIndian Speedometer and Body Control Module Service Tool Users Guide
Indian Speedometer and Body Control Module Service Tool Users Guide Installing speedometer software to your computer 1. Go to the Indian Motorcycle Website: WWW. Indianmotorcycle.com 2. Log in to Service
More informationISC, QSC8.3, and ISL (FIS )
Fault Information System... 1 FIS Usage Recommendations... 2 FIS Usage Recommendations... 2 Diagnostic Methods... 9 Troubleshooting Fault Codes... 9 Information Fault Codes... 3 (fc211) Fault Code 211...
More informationSystems Operation, Testing and Adjusting
Systems Operation, Testing and Adjusting 3176C and 3196 Engines for Caterpillar Built Machines S/N: 4SS00001-UP (Excavators 345B) S/N: 7ZR01004 (ENGINE) Use the bookmarks for navigation inside of the manual
More informationFuel Injector Performance Test. Shirley Echeverria
Fuel Injector Performance Test Shirley Echeverria Why Fuel Injector Performance Test (IPT) is needed? Presently Lack Robust In-Shop Injector Evaluations High Pressure Key Off Leak Down Can Be Used For
More informationPowertrain DTC Summaries OBD II
Powertrain DTC Summaries Quick Reference Diagnostic Guide Jaguar X-TYPE 2.5L and 3.0L 2002 Model Year Revised January, 2002: P0706, P0731, P0732, P0733, P0734, P0735, P0740, P1780 POSSIBLE CAUSES Revised
More informationPowertrain DTC Summaries EOBD
Powertrain DTC Summaries Quick Reference Diagnostic Guide Jaguar S-TYPE V6, V8 N/A and V8 SC 2002.5 Model Year Refer to pages 2 9 for important information regarding the use of Powertrain DTC Summaries.
More information1 of :23
1 of 8 2013.02.09 03:23 Published: 08-Jun-2012 Electronic Engine Controls - TDV8 3.6L Diesel - Electronic Engine Controls 3.6L (TdV8) Diesel Diagnosis and Testing Overview This section covers the components
More informationPart No PRELIMINARY. Troubleshooting Guide Series Marine Auxiliary Engines
Part No 479-0227 GB Troubleshooting Guide 1200 Series Marine Auxiliary Engines Important Safety Information Most accidents that involve product operation, maintenance and repair are caused by failure to
More informationGeneral Motors DTC Reader Instructions
Page 1 of 20 Form 0148A 06/06/2004 Superchips Inc. General Motors DTC Reader Instructions Do not leave the MAX MicroTuner connected and unattended for any length of time to prevent unnecessary battery
More informationG - TESTS W/CODES - 2.2L
G - TESTS W/CODES - 2.2L 1994 Toyota Celica 1994 ENGINE PERFORMANCE Toyota 2.2L Self-Diagnostics Celica INTRODUCTION If no faults were found while performing F - BASIC TESTING, proceed with self-diagnostics.
More informationAlternative Fuel Engine Control Unit
1999 Chevrolet/Geo Cavalier (CNG) Alternative Fuel Engine Control Unit Table 1: AF ECU Function Parameters The (AF ECU) controls alternative fuel engine operation. The control unit monitors various engine
More informationUsing the Gratec Gasoline software
Using the Gratec Gasoline software The Gratec Software is a sophisticated yet user friendly program in which configures the Gratec CNG or LPG system to perform with your vehicle. Software version 2.002
More informationDIAGNOSTIC TROUBLE CODE CHART (SAE Controlled)
1MZFE ENGINE EG2404 (SAE Controlled) HINT: Parameters listed in the chart may not be exactly the same as your reading due to the type of instrument or other factors. DTC No. Detection Item Diagnostic Trouble
More information140H. Motor Grader. Global Version. Cat 3176 ETA Engine. Weights. Variable Horsepower Arrangement. Moldboard. Variable Horsepower Plus Arrangement
140H Motor Grader Global Version Cat 3176 ETA Engine Base Power (all gears) 123 kw Variable Horsepower Arrangement - gears 1-3 123 kw - gears 4-8 138 kw Variable Horsepower Plus Arrangement - gears 1-3
More informationPowertrain DTC Summaries EOBD
Powertrain DTC Summaries Quick Reference Diagnostic Guide Jaguar X-TYPE 2.0 L 2002.25 Model Year Refer to page 2 for important information regarding the use of Powertrain DTC Summaries. Jaguar X-TYPE 2.0
More information2.8 Liter VR6 2V Fuel Injection & Ignition, Engine Code(s): AAA m.y
2.8 Liter VR6 2V Fuel Injection & Ignition, Engine Code(s): AAA m.y. 1996-1997 01 - On Board Diagnostic (OBD) On Board Diagnostic (OBD II) Malfunction Indicator Lamp (MIL) On Board Diagnostic (OBD II),
More informationTECHNICAL MANUAL OPERATOR S, UNIT, INTERMEDIATE (DS) AND INTERMEDIATE (GS) MAINTENANCE MANUAL FOR
TM 5-2815-232-14 TECHNICAL MANUAL OPERATOR S, UNIT, INTERMEDIATE (DS) AND INTERMEDIATE (GS) MAINTENANCE MANUAL FOR ENGINE, DIESEL, CATERPILLAR, MODEL 3508 NSN 2815-01-216-0938 HEADQUARTERS, DEPARTMENT
More informationOregon Fuel Injection
2003 2007 Dodge 5.9L Diesel Diagnostics In order to do proper diagnostics you will need a scan tool and some special tools available from Miller Special Tools http://millerspecialtools.spx.com. High Pressure
More informationPressure Control Solenoid "D" Performance (Shift Solenoid Valve SLT)
116 750E UTOMIC TRNSMISSION UTOMIC TRNSMISSION SYSTEM DTC DESCRIPTION P2714 Pressure Control Solenoid "D" Performance (Shift Solenoid Valve SLT) Line Pressure Control Pressure Current Flow to Solenoid
More informationELECTRONIC DIESEL ENGINE DIAGNOSIS SPECIALIST TEST (L2) MEDIUM/HEAVY COMPOSITE VEHICLE TYPE 3 REFERENCE BOOKLET
ELECTRONIC DIESEL ENGINE DIAGNOSIS SPECIALIST TEST (L2) MEDIUM/HEAVY COMPOSITE VEHICLE TYPE 3 REFERENCE BOOKLET This booklet is intended only for reference when preparing for and taking the ASE Electronic
More informationDiagnostic Trouble Code (DTC) Root Cause. for Omnitek ECM 64A/66A/88A. & Remedial Action
Diagnostic Trouble Code (DTC) Root Cause & Remedial Action for Omnitek ECM 64A/66A/88A Omnitek Engineering Corp. 1945 S Rancho Santa Fe Rd. San Marcos, CA 92078 Tel. 760-591-0089 - Fax. 760-591-0880 -
More informationDATA LIST/ACTIVE TEST
05-406 DATA LIST/ACTIVE TEST 1. DATA LIST HINT: DIAGNOSTICS - SFI SYSTEM (3MZ-FE)(From August, 2004) Using the hand-held tester DATA LIST allows switch, sensor, actuator and other item values to be read
More informationWater Specialist PR Control Valve Programming and Cover Drawing Manual
Water Specialist PR Control Valve Programming and Cover Drawing Manual Page 2 PR Man u al PR Manual Page 3 Table of Contents PR Front Cover and Drive Assembly...4 OEM General Programming Instructions...5
More information2002 Buick Rendezvous - AWD
2002 Buick Rendezvous - AWD DTC P0410 Description The control module activates the secondary air injection (AIR) system by grounding both the pump relay and the vacuum control solenoid control circuits.
More informationON-BOARD DIAGNOSTICS II SYSTEM. 5. Specified Data. Signal (V) Ignition SW ON (Engine OFF)
1. ENGINE CONTROL MODULE (ECM) I/O SIGNAL OBD0092A Crankshaft Camshaft Mass air flow Throttle Signal (+) 8 0 7 +7 Sensor output waveform Signal ( ) 29 0 0 Shield 54 0 0 Signal (+) 7 0 7 +7 Sensor output
More informationParameter Description Unit
DIACOM Diagnostic Status Report 07/07/2008 13:19:38 1. VEHICLE CONFIGURATION Engine Make: Mer Cruiser 5.0L MPI Engine Serial No: 0000000000 Model Year: 2005 System Type: Mer Cruiser PCM555 2. PERFORMANCE
More informationDI 244 DIAGNOSTICS AUTOMATIC TRANSMISSION DIB30 01 PRE CHECK
DI244 DIAGNOSTICS PRECHECK DIB3001 1. DIAGNOSIS SYSTEM (a) Description When troubleshooting OBD II vehicles, the only difference from the usual troubleshooting procedure is that you connect to the vehicle
More informationA U T O M A T I C T R A N S M I S S I O N M U L T I - C H A N N E L T W O - W A Y L C D R E M O T E S T A R T E R AS-2510 TW.
A U T O M A T I C T R A N S M I S S I O N M U L T I - C H A N N E L T W O - W A Y L C D R E M O T E S T A R T E R S Y S T E M AS-2510 TW User Guide Transmitter Part Number and Module Serial Number...2
More informationFlight Systems. Replacement for KASSEC DESCRIPTION
DESCRIPTION The is a universal generator controller that will start, stop, and provide engine protection for most generators. Universal replacement for both the 90353 and 90354 KASSEC Compatible with most
More informationDDEC VI APPLICATION AND INSTALLATION. Parameter Group. Diagnostic Name. Min Max Default Access Range
DDEC VI APPLICATION AND INSTALLATION APPENDIX C: PARAMETER LIST Gov TSC1 Condition 1 Gov TSC1 Condition 2 Gov TSC1 Condition 3 Gov TSC1 Condition 1 1 DI 1 21 DI 15DOFault 1 1 DI 1 15 DI 2 8 DI 2nd Axle
More information2 WAY REMOTE STARTER & ALARM SYSTEM INSTALLATION GUIDE FCC ID NOTICE
REV. ARS. WAY REMOTE STARTER & ALARM SYSTEM INSTALLATION GUIDE FCC ID NOTICE This device complies with Part 5 of the FCC rules. Operation is subject to the following conditions:. This device may not cause
More informationEMISSION CONTROL (AUX. EMISSION CONTROL DEVICES) H4DOTC
EMISSION CONTROL (AUX. EMISSION CONTROL DEVICES) H4DOTC SYSTEM OVERVIEW 1. System Overview There are three emission control systems, which are as follows: Crankcase emission control system Exhaust emission
More informationDTC P0171, P0172, P0174, or P0175
Page 1 of 6 2009 Pontiac G8 G8 Service Manual Document ID: 2076050 DTC P0171, P0172, P0174, or P0175 Diagnostic Instructions Perform the Diagnostic System Check - Vehicle prior to using this diagnostic
More informationLingenfelter NCC-002 Nitrous Control Center Quick Setup Guide
Introduction: Lingenfelter NCC-002 Nitrous Control Center Quick Setup Guide The NCC-002 is capable of controlling two stages of progressive nitrous and fuel. If the NCC-002 is configured only for nitrous,
More informationPSI ENGINE CODES CODE LIST
2007 2009 PSI ENGINE CODES BLINK CODE FUNCTION Although the DST is considered a required tool to access the DTC codes, codes may be retrieved without a laptop computer using the blink code function. To
More informationTelephone: Fax: VAT Registration No.:
Telephone: Fax: VAT Registration No.: Terminal side Wire side Component/circuit description ECM pin Signal Condition Typical value Oscilloscope setting (Suggested settings - Voltage/time per division)
More informationProECU Subaru BRZ Toyota GT86 Scion FR-S
ProECU Subaru BRZ Toyota GT86 Scion FR-S DTC List 2012-onward Model Year v1.0 Engine DTC List P000A Camshaft Position "A" - Timing Slow Response Bank 1 P000B Camshaft Position "B" - Timing Slow Response
More information3406E Truck Engine 5EK01821-UP(SEBP ) - Document Structure. Media Number -RENR Publication Date -01/02/2008 Date Updated -07/02/2008
Page 1 of 11 Shutdown SIS Previous Screen Product: TRUCK ENGINE Model: 3406E TRUCK ENGINE 5EK Configuration: 3406E Truck Engine 5EK01821-UP Systems Operation 3406E Truck Engine Media Number -RENR1273-07
More informationWHEEL LOADER 938H WHEEL LOADER 938H. Power Generation - Bulk Materials Standards I. GENERAL: DESCRIPTIONS FOR CATERPILLAR MODEL 938H WHEEL LOADER:
Power Generation - Bulk Materials Standards I. GENERAL: This standard is intended to provide specifications for the procurement of Caterpillar Model 938H Wheel Loaders that meet specific area operational
More informationThrottle-by-wire. MasterCraft Technical Training Vonore, Tennessee USA. A MasterCraft Technical Services Publication
Throttle-by-wire MasterCraft Technical Training Vonore, Tennessee USA A MasterCraft Technical Services Publication MasterCraft University 2008-2009 Throttle-by-wire Page 1 Electronic Throttle Control Description
More informationAVON MENTOR 2018 ONBOARDING CAMPAIGN CALENDAR
REPRESENTATIVE PROCESSING SCHEDULE 1 (ORANGE) C-1 11/10 11/23 11/29 12/11 12/13 C-2 11/24 12/7 12/11 12/26 12/29 Friday Thursday Wednesday Wednesday Thursday C-3 12/8 12/21 12/27 1/10 1/11 C-4 12/22 1/4
More informationAppendix B. Data Parameters. Current and Past TMC Engines Covered in this Section. Fig. B-1. TL874fB01. Engine Control Systems II - Course 874 B-1
Data Parameters Current and Past TMC Engines Covered in this Section Fig. B-1 TL874fB01 Engine Control Systems II - Course 874 B-1 OBD Data Parameters Signal Category Display Item Parameter Description
More informationInstalling the Throttle Commander
Installing the Throttle Commander Ford 6.0L Diesel Powerstroke 2005-2007 F250-550 Super Duty 2005-2010 E250-550 Econoline (8500+ GVW) Ford 6.4L Diesel Powerstroke 2008-2010 F250-550 Super Duty T500107
More informationÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄ
ELECTRICAL COMPONENT LOCATOR Article Text 1989 Toyota MR2 For RSe 7 HotRod Lane C'Ville VA 22901 Copyright 1997 Mitchell International Monday, May 20, 2002 12:36AM ARTICLE BEGINNING 1989 TOYOTA MR2 Electrical
More informationDESCRIPTION. Chrysler NCV3 Service Info Section 08 > Electronic Modules > MODULE, Transmission Control Information
DESCRIPTION The transmission control module (TCM) receives, processes and sends various digital and analog signals related to the automatic transmission. In addition, it processes information received
More informationHyundai - Specific Trouble Codes
Hyundai - Specific Trouble Codes P1100 Map Sensor - Malfunction P1101 Map Sensor - Abnormal P1102 Map Sensor - Low Input P1103 Map Sensor - High Input P1104 Air Flow P1105 Air Flow - Abnormal P1106 Air
More informationEG1 189 EFI SYSTEM 5S FE ENGINE DIAGNOSIS SYSTEM
5SFE ENGINE EG1189 DIAGNOSIS SYSTEM DESCRIPTION The ECU contains a builtin selfdiagnosis system by which troubles with the engine signal network are detected and a CHECK engine warning light on the combination
More informationDTC P0617 STARTER RELAY CIRCUIT HIGH
0534 DTC P067 STARTER RELAY CIRCUIT HIGH 05DJY0 MONITOR DESCRIPTION While the engine is being cranked, the battery positive voltage is applied to terminal STA of the ECM. If the ECM detects the starter
More information5. Engine Control Module (ECM) I/O Signal
5. A: ELECTRICAL SPECIFICATION B134 B135 B136 B137 17 16 15 14 13 12 11 10 9 8 27 26 25 24 23 22 21 20 19 18 34 33 32 31 30 29 28 19 18 17 16 15 14 13 12 11 10 9 8 27 26 25 24 23 22 21 20 35 34 33 32 31
More informationL (LL8) Engine Diagnostic Parameters
Cam Shaft Position Actuator Control VCP System Performance VCP = variable cam phaser VCP Crank/Cam Correlation Error P0013 P0014 P0016 DESCRIPTION Detects an open or shorted control circuit by monitoring
More informationOn-Board-Diagnosis Binary Values FR (Drive Control)
BW01 Voltage supply, terminal 15 Voltage supply, FR (FMR) control unit, terminal 15 at X2. 18/3. FMR B W 0 1 00 00 00 01 BW01 Starter signal, terminal 50 Voltage supply, FR (FMR) control unit, terminal
More informationQuick Setup Guide for IntelliAg Model YP40 20 Air Pro
STEP 1: Pre-Programming Preparation: The Quick Guide assumes the Virtual Terminal, Master Switch, Working Set Master, Working Set Member, and all sensors have been connected and properly installed. Reference
More informationInstallation and Operations Manual
Excalibur Water Systems 2.0 HIGH CAPACITY SUPER FLOW SERIES DUPLEX WATER SOFTENER Installation and Operations Manual 142 Commerce Park Drive, Units M-O, Barrie ON L4N 8W8 www.excaliburwater.com 2.0 High
More informationTG350 User Manual. Manual Revision: Min. FW Revision: Date Released: 09/01/ DYNAGEN Technologies Inc
TG350 User Manual Manual Revision: 1.4.0 Min. FW Revision: 1.42.01 Date Released: 09/01/2014 Table of Contents 1 Introduction 1.1 Specifications... 3 2 Installation 2.1 Terminal s... 6 2.2 Typical Wiring...
More information1991 TOYOTA Electrical Components MR2. evaporator. compartment. ARTICLE BEGINNING BUZZERS, RELAYS & TIMERS
ELECTRICAL COMPONENT LOCATOR Article Text ARTICLE BEGINNING 1991 TOYOTA Electrical Components MR2 BUZZERS, RELAYS & TIMERS A/C Compressor Clutch Relay Under right side of dash, on evaporator. Circuit Opening
More informationEncore Release Notes
Encore Release Notes Version 1.5.0.10 Overview: The new version 1.5.0.10 contains a major coverage release. Also provided are selected highlights of new features, fixed defects reported by technician,
More informationINSTALLATION GUIDE. FCC ID NOTICE
REV.5 RS. ADVANCED REMOTE STARTER INSTALLATION GUIDE www.security.soundstream.com FCC ID NOTICE This device complies with Part 5 of the FCC rules. Operation is subject to the following conditions:. This
More informationFeature Description. Version History
TA2 Malfunction Indicator Lamp (MIL) and Engine Protection Document Number: FD-0007 Author: J. Goodloe Version: 03 Publish Date: 2016-03-18 Feature Description Version History Version Date Modified Sections
More information