McQuay. Roofpak Applied Rooftop Units. RPS, RCS, RFS Vintage B. RBS, RDS, RHS, RWS Vintage B

Transcription

1 Replacement Parts List No Revision AC 06/2016 McQuay Roofpak Applied Rooftop Units RPS, RCS, RFS Vintage B RBS, RDS, RHS, RWS Vintage B To find your Daikin Applied parts distributor, call or visit

2 Table of Contents Parts List Revision History... 4 Unit Model & Serial Nomenclature... 5 Unit Nomenclature Complete Model R*S Electrical Legend... 10, 11 Control Box Component Location Diagram Condenser Section Condenser Control Box Diagrams... 13, 14 Compressor Contactor Components Condenser Fan Motor Contactor Components Miscellaneous Components... 17, 18 Compressor Pressure Controls Fan Assembly Refrigerant Piping Compressor Model Information Miscellaneous Compressor Components Coils Condensing Coils Direct Expansion Evaporator Coils Single Draw-through Evaporator Coil / Unit Sizes 018B-030B, Single Blow-through Evaporator Coil / Unit Sizes 036B-040B / Single Blow-through Evaporator Coil / Unit Sizes 041B-100B / Dual Blow-through Evaporator Coil / Unit Sizes 081B-100B / Upper Main Control Panel: Non MicroTech (Code 20= 30, 31) Unit Controller Diagrams - All sizes Diagram and Components - All sizes Upper Main Control Panel: MicroTech (Code 20= 1M, 2M, 4M) Unit Controller Diagrams Components , 35 Lower Main Control Panel Component Location Diagram - All Sizes Components - All Sizes Miscellaneous Controls Control Locations Components Electric Heat Control Panel Electric Heat Power Panel Diagram & Components Components - All Sizes Hi-Limit, Disc Type Gas Burner Section Forced Draft Burner (FDB Vintage A) Gas Burner Final Assembly Burner Components... 66, 67 Control Box Diagrams & Components Gas Control Box Diagrams & Components, FDB110A thru 200A Gas Train Components Modulating OR Single Stage Burner Diagrams Components... 72, 73 Modulating OR Single Stage Burner Controls Heat Exchangers and Primary Components... 75, 76 Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 2

3 Table of Contents, Continued Supply Air Fan Supply Air Drive Nomenclature Forward Curved (FC) Fan Forward Curved (FC) Fan Forward Curve (FC) Fans - 27 & Airfoil (AF) Fans & Variable Inlet Fans Airfoil (AF) Fans & Variable Inlet Fans - 27 & Forward Curve (FC) Fans Airfoil (AF) & Variable Inlet Fans Variable Inlet Vanes Return Air Fan Return Air Drive Nomenclature Forward Curve (FC) Fan Forward Curve (FC) Fan Forward Curve (FC) Fan Forward Curve (FC) Fan Airfoil (AF) Fans - Variable Inlet Fans Airfoil (AF) & Variable Inlet Fans Airfoil (AF) & Variable Inlet Fans Airfoil (AF) Fan-Horizontal Mount Variable Inlet Vanes - Horizontal Mount Variable Inlet Vanes , 103 Typical Blower Supply Air Blower Spring Vibration Mounts Return Air Blower Spring Vibration Mounts Fan Blower Motors - Supply & Return Air Filter Selection Diagrams Filters , 121 Economizer Damper Standard Type Damper...122, 123 Low Leak Type Damper Bottom Discharge Air & Return Air Opening Dampers , 128 Miscellaneous Cabinetry Diagrams Components Wall Mounted Controls and Accessories Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 3

4 Parts List Revision History Revision Date Description A 4/98 Supersedes Replacement Parts List No Y-00 dated 4/89. Includes new information. Completely redone to be consistent with OnLine/CD format. B 2/99 Page 60: Corrected part number for Fan Wheel Housing, Variable Inlet Fan (Bubble #35). C 12/99 Page 48: Corrected description for Enthalpy Control (Electromechanical) and added Enthalpy Control (Electronic), Schematic Symbol EC1. D 8/00 Page 16: Added motor, 1.5 hp, 3 ph, 575/6/3, p/n E 2/01 Page 105: Bub #11 Damper Blade part # s changed; was , is now ; was , is now ; was , is now F 7/01 Page 39-46: Added note. G 5/02 Pages 66 & 67: Bubbles 69 and 70 were switched. H 9/03 Page 23: Model number was incorrect in table heading, 610B is now 061B. J 10/04 Page 18: Removed Copeland compressor information. K 9/05 Page 56: Schematic Symbol R13 pn was changed to Page 28: Added footnote #1. L 1/06 Page 18: Removed note from compressor table. M 7/06 Page 48: Schematic symbol TC4 pn changed from to N 11/08 Pages 39-46: Note change from SMG in Minneapolis to McQuay Parts. Pages 96, 97, 98: Added the word Return to heading. Page 3: Added the word Return to Fan Blower Motors - Supply & Air in TOC. O 12/09 Updated Cover and Revision page with current logo design. Page 78: Corrected Bub 97 p/n from to P 3/10 Page 48: Changed description of Type of Unit Control system for DM1 & EM1 from All Types to Honeywell/Conventional. No DM1 or EM1 available for MicroTech controls. Q 11/10 Converted form to current software and corrected various formatting issues. Removed all references to Figure numbers. Page 2, 3: Updated TOC as required. Page 5: Created new page titled: Unit Model & Serial Nomenclature. Page 6-8: Added Unit Model Nomenclature Complete section. Page 9, 10: Renamed Model R*S Legend section Model R*S Electrical Legend. Page 59-66: Updated Gas Burner section with information from RPL Y-00 and IM Page 67: Added SAF drive nomenclature page per dwg: C00 and repaginated document. Page 82: Added RAF drive nomenclature page per dwg: C00 and repaginated document. Page : Added footnote regarding the changes in spring colors and to contact McQuay Parts. Page 108: Updated motor section. Repaginated document. R 3/11 Various: Corrected misc. spelling and formatting issues. Page 67: Updated fan size list to include codes A, 2, 4, 5, 6, 7, 8, 9 only. Page 82: Corrected Fan Size Code 3 from 22 to 40 Re-wrote footnotes to clarify information. S 7/11 Page 118: Updated and re-arranged drawings and added Bubble numbers. Page 119: Added additional cabinet p/ns per archived information and soft bills. T 3/12 Cover, Pg. 4: Updated to current Daikin McQuay logo format. Page 119: Added in Bubs #80 Door Latch Angle- L.H & #81 Door Latch Angle- R.H U 5/12 Page 21: Corrected Compressor chart changed duplicate XIII to XII. V 7/12 Various: Changed McQuay Parts to Daikin McQuay Parts. Page 9, 10: Added in Microtech Schematic Symbols ref IM Page (New): Added pages for Microtech control diagrams and components. Repaginated document and updated TOC. W 8/12 Page: 6-8: Added in RCS, RDS, RBS nomenclature. Page: 9 (New): Added page for additional coding. Repaginated form and updated TOC. X 9/13 Page 55: Changed DHL for MT from to Changed Type of unit description from All Types to All except MicroTech. Y 12/13 Cover, Rev. pg.: Changed to Daikin Applied logo format. Various: Changed McQuay, Daikin McQuay to Daikin Applied. Page 22: Added 460V PW note to footnotes. Z 06/14 Page 63-70: Added footnote #1. Page 71, 86: Rewrote footnote #2. AA 01/15 Page 7, 8: Deleted MT 3M option for Code 20 & 24. Page 34, 35: Updated/corrected code references. Page (NEW): Added Single Stage and Mod. burner components. Repaginated form & updated TOC. Page 75, 76: (NEW): Added pgs. for Heat Exch. & related components. Repaginated form & updated TOC. Page 117 (OLD) 121 (NEW): Added Damper profile dwg. & Note. Page 118 (OLD 122 (NEW): Moved Low Leak Type Damper Linkage dwg. to new pg Added Low Leak dmpr. assy. table. Page 125 (NEW): Added pg. for Low Leak Type Damper Linkage dwg. & dmpr. profile dwg. Repaginated form & updated TOC. AB 01/16 Cover: Updated to Daikin Legacy format. Page 76: Corrected Heat Exch. p/ns. AC 06/16 Page 37: Changed qty of FB9 75, 100HP AL 200A@600V Fuseblock from 1 to 3. (1 pole block.) Daikin Applied, Industrial Park Blvd., P.O. Box 1551, Minneapolis, MN (763) Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 4

5 Unit Model & Serial Nomenclature Model R P S B E ROOFPAK UNIT CONFIGURATION P = Heating, Mechanical Cooling F = Heating, Future Mechanical Cooling C = Condensing Section Only W = Heating, Water Cooling H = Heating Only B = Blow-through Air Handler D = Draw-through Air Handler HEAT TYPE A = Natural Gas E = Electric F = Fuel Oil S = Steam W = Hot Water Y = None (Cooling Only) DESIGN VINTAGE SINGLE ZONE UNIT NOMINAL CAPACITY (TONS) OR CABINET SIZE RPS, RFS, RCS: RBS, RDS, RHS, RWS: 018, 020, 025, , , 051, 060, , 071, , 090, Serial 3 7A Factory 3= Faribault,MN Engineering Revision Serial Year and Month of Manufacture Year Month U= 1989 A= Jan. V= 1990 B= Feb. W= 1991 C= Mar. X= 1992 D= Apr. Y= 1993 E= May Z= 1994 F= Jun 5= 1995 G= Jul 6= 1996 H= Aug 7= 1997 J= Sep. 8= 1998 K= Oct. 9= 1999 L= Nov. M= Dec. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 5

6 Unit Nomenclature Complete R*S***B A 27 AL D Y YA Y 1 E104 Y J21F1 1 B S11YY A Y YYYYY 1M YYYY YYYY Code A YYYYYY UUYY A 1 YYYY A A Code 03= Type of Heat Y= No Heat A= Natural Gas B= Propane (RPS) B= Blank Section (RDS, RBS) E= Electric F= Fuel Oil S= Steam W= Hot Water X=Special Code 04= Electric Power Supply 12= 208/60/3 29= 230/60/3 28= 380/50/3 27= 460/60/3 37= 575/60/3 44= 415/50/3 Code 05= Starting Option AL= Across the Line PW= Part Winding Start (Compressors only) PP= Part Winding Start (Compressors & Fan Motors) Code 06= Compressor Type (RPS, RCS) D= Discus Y= Reed Code 06= Electrical Power Supply (RDS, RBS) Y= None A= SAF 1HP- 20HP B= SAF 25HP- 40HP C= SAF 50HP- 60HP E= SAF & RAF 1HP- 40HP total F= SAF & RAF 45HP- 80HP total G= SAF & RAF 85HP- 125HP total X=Special Code 07= SA/RA Fan Motor Type Y= Standard Efficiency H= High Efficiency Code 08= Capacity Control Digit 1 ( of Unloaders Furnished) Y= 1 ( ) & 0 ( ) 1= 2 ( ) & 3 ( ) 2= 3 (051), 4 ( ), 5 ( ), & 6 ( ) X= Special Digit 2 (Method of Control) A= Compressor from Remote, Unloaders from Pressure Control C= Compressors and Unloaders from Remote, No Pressure Control X= Special Code 09= Hot Gas Bypass Y= None 1= Capacity Control Circuit #1 2= Capacity Control Circuits #1 & 2 3= Capacity Control Circuits #1, 2, 3 X= Special Code 11= Cooling Specification YYYY= None AAAA= Section Less Coils E001= Std. Evap Coil (2 Row , 800) (3 Row , ) E003= 3 Row Evap Coil ( Only) E103= 3 Row Evap Coil (10 FPI) E123= 3 Row Evap Coil (12 FPI) E004= 4 Row Evap Coil E083= 3 Row Evap Coil E084= 4 Row Evap Coil (8 FPI) E104= 4 Row Evap Coil (10 FPI) E124= 4 Row Evap Coil (12 FPI) E005= 5 Row Evap Coil (8 FPI) E085= 5 Row Evap Coil (8 FPI, Only) E105= 5 Row Evap Coil (10 FPI) E125= 5 Row Evap Coil (12 FPI) D003= 3 Row Dual Staggered Evap Coil (808) D004= 4 Row Dual Staggered Evap Coil (808) D005= 5 Row Dual Staggered Evap Coil (808) D006= 6 Row Dual Staggered Evap Coil (808) Digit 1 (Chilled Water Coil Type) H= 5WH L= 5WL S= 5WS Digit 2 (Fin Series) A= 6 FPI B= 8 FPI C= 10 FPI D= 12 FPI Digit 3 (Rows) 3= 3 Rows 4= 4 Rows 5= 5 Rows 6= 6 Rows Digit 4 (Coil Size) S= Single Coil D= 2 Staggered Coils Digit 1 (Contractor Coil Codes) C= Contractor Coil F= Contractor Coil w/ F & B Digit 2 (Fin Length) S= 73 L= 79 Digit 3 (Filler Piece/Fin Height) Y= None 1= 3 2= 6 3= 9 4= 12 5= 15 6= 18 7= 21 8= 24 9= Code 12= Optional MicroTech Hardware Y= None M= Phone Modem Code 13= Supply (SAF) Fan Drive *****= 5 Digit Drive Code (See Supply Air Drive Code Nomenclature Section.) Code 10= Compressor Isolation Y= None 1= Resilient 2= Spring with Vibration Eliminators on Piping Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 6

7 Unit Nomenclature Complete, Continued Code 14= Air Discharge Y= None/Full Front B= Bottom G= Bottom w/ Plenum H= Front w/ Plenum 1= Bottom X= Special Code 15= Air Return Y= None/Full Back G= Bottom w/ Plenum and/or Economizer H= Back w/ Plenum and/or Economizer J= Outside air Hood K= Outside air Hood B= Bottom F= Back X= Special Code 16= Heating Specifications YYYYY= None XXXXX= Special Electric Heat (Multi-Stage) E02Y3= 20KW E21Y3= 210KW E03Y3= 30KW E22Y3= 220KW E04Y3= 40KW E24Y3= 240KW E06Y3= 60KW E27Y3= 270KW E08Y3= 80KW E28Y3= 280KW E09Y3= 90KW E30Y3= 300KW E10Y3= 100KW E32Y3= 320KW E12Y3= 120KW E33Y3= 330KW E14Y3= 140KW E36Y3= 360KW E15Y3= 150KW E40Y3= 400KW E16Y3= 160KW E44Y3= 440KW E18Y3= 180KW E48Y3= 480KW E20Y3= 200KW Gas Furnace Digit 1-3 (BTU Output) 020= 200MBH 079= 800MBH 025= 250MBH 080= 800MBH 032= 320MBH 100= 1000MBH 040= 400MBH 110= 1100MBH 050= 500MBH 140= 1400MBH 064= 640MBH 150= 1500MBH 065= 650MBH 200= 2000MBH Digit 4 (Heat Exchanger Material) A, B, C, D= Stainless Steel Primary, Aluminum Secondary S, T, U, V= Stainless Steel Primary, Stainless Steel Secondary Digit 5 (Burner Type) A= One Stage Gas- Electronic C= Two Stage Gas- Electronic E= Modulating Gas- Electronic G= One Stage Fuel Oil- Cad Cell H= One Stage Fuel Oil- Electronic J= Two Stage Fuel Oil- Cad Cell K= Two Stage Fuel Oil- Electronic Steam Digit 1-3 (Coil) S11= 5JA0601H, OR 8JA0601B S12= 5JA1201H, OR 8JA1201B Digit 4 (2-Way Valve Size) D= 1 H= 2 ½ E=1 ¼ J= 3 F= 1 ½ Y= None G= 2 Digit 5 (Valve Control) Y= None M= Modulating w/ Spring Open Code 16= Heating Specifications, Continued Hot Water Digit 1-3 (Coil) W11= 4WH1201H, OR 5WH0901H W22= 4WS1202H, OR 5WS0902C Digit 4 (2-Way Valve Size) D= 1 H= 2 ½ E=1 ¼ J= 3 F= 1 ½ Y= None G= 2 Digit 5 (Valve Control) Y= None M= Modulating w/ Spring Open Code 17= Filters Y= None A= 2 Throwaway (Angular Rack) B= 2 Cleanable (Angular Rack) C= D AND/OR E Less Filters (Rack Only) D= 45% OR 65% Eff. Cartridge/Bag Type w/ Prefilters (Flat Rack) E= 95% Eff. Cartridge/Bag Type w/ Prefilters (Flat Rack) F= A AND/OR B Less Filters (Angular Rack) G= 2 35% Eff. Pleated Throwaway (Angular Rack) X= Special Code 18= Damper Control Y= None A= 0-30% OA, Manual Operation B= 0-100% OA, Manual Operation C= 0-100% OA, Remote Rheostat D= 0-100% Economizer Package G= 0-100% Economizer Package w/ RA Smoke Control H= 0-100% Economizer Package w/ RA & SA Smoke Control X= Special Code 19= Return (RA) Fan Drive YYYYY= None *****= 5 Digit Drive Code (See Return Air Drive Code Nomenclature section.) Code 20= Temperature Control Packages YY= None 20= Honeywell W973 21, 22= Contact Daikin Applied. 30= Field Supplied Discharge Air Control 31, 36= Honeywell W = Discharge air w/ NO Controls 1M, 2M, 4M= MicroTech Control Code 21= Remote Control Panel (RPS, RWS, RHS) Digit 1 (System Signal) Y= None 1= Heat Fail 2= Cool Fail 3= 1 AND 2 X= Special Digit 2 (Fan Signal) Y= None 1= Fan On X= Special Digit 3 (Valve Control) Y= None 1= With Filter Switch X= Special Digit 4 (Remote Potentiometer) Y= None 1= With Remote Potentiometer X= Special Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 7

8 Unit Nomenclature Complete, Continued Code 21= Heating Specification (RDS) YYYY= None XXXX= Special S11Y= 5JA0601H S12Y= 5JA1201H W11Y= 5WH0901H W22= 5WS0902C Code 22= Auxiliary Control Packages (RPS, RWS, RHS) Digit 1 (Smoke Control) Y= None 1= Shut down Fan(s) AND Close Dampers 2= Shut down SA Fan, Close Return Dampers, AND Run RA Fan X= Special Digit 2 (Morning Warmup) Y= None 1= Energize one Stage Full Heat, Close OA Dampers, AND Lock Out Cooling X= Special Digit 3 (Freezestat) Y= None 1= Shut Down Fan(s), Close OA Dampers AND Open Valve Full Thru Coil X= Special Digit 4 (Reset) Y= None 1= Reset From Outside air Signal 2= Reset From Space/Return Air Signal (Field Installed) X= Special Code 22= Heating Specification (RDS) E001= Std. Evap Coil (2 Row 800) (3 Row ) E003= 3 Row Evap Coil E004= 4 Row Evap Coil E005= 5 Row Evap Coil D003= 3 Row Dual Staggered Evap Coil (808) D004= 4 Row Dual Staggered Evap Coil (808) D005= 5 Row Dual Staggered Evap Coil (808) D006= 6 Row Dual Staggered Evap Coil (808) Digit 1 (Chilled Water Unit Coil Type) H= 5WH L= 5WL S= 5WS Digit 2 (Fin Series) A= 6 FPI B= 8 FPI C= 10 FPI D= 12 FPI Digit 3 (Rows) 3= 3 Rows 4= 4 Rows 5= 5 Rows 6= 6 Rows Digit 4 (Coil Size) S= Single Coil D= 2 Staggered Coils Digit 1 (Contractor Coil Codes) C= Contractor Coil F= Contractor Coil w/ F & B Digit 2 (Fin Length) S= 73 L= 79 Code 22= Heating Specification (RDS), Continued Digit 3 (Coil Position) A=5 B= 5 & 6 C= 5 & 7 D= 5-8 Digit 4 (Filler Piece/Fin Height) 1= 3 2= 6 3= 9 4= 12 5= 15 6= 18 7= 21 8= 24 9= Code 23= Disconnect Switch Y= None A= Integral Disconnect Switch (Non-Auto) E= SAF and/or RAF 1HP- 40HP total F= SAF and/or RAF 45HP- 80HP total G= SAF and/or RAF 85HP- 120HP total X= Special Code 24= Air Flow Control Packages (RPS, RWS, RHS) Non-MicroTech Control: Code 20= 30, 31 Digit 1 (Type of System) Y= None D= Discharge Damper V= Inlet Vane X= Special Digit 2 (Type of Control) Y= None E= Electronic F= Floating X= Special Digit 3 ( of Sensors) Y= None 1-6= of included Sensors X= Special Digit 4 (Remote Potentiometer) Y= None M= Unit Mounted X= Special Digit 5 Remote Return) Y= None 1= With Remote Return X= Special Digit 6 (Remote Metering) Y= None 1= With Remote Metering X= Special MicroTech Control: Code 20= 1M, 2M, 4M Digit 1 (Type of System) Y= None D= Discharge Damper V= Inlet Vane X= Special Digit 2 (Type of Control) Y= None M= MicroTech X= Special Digit 3 ( of Sensors) Y= None 1= 1 Duct 2= 2 Duct 3= 1 Duct AND 1 Space 4= 1 Space X= Special Digit 4 (Remote Potentiometer) Y= None X= Special Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 8

9 Unit Nomenclature Complete, Continued Code 24= Air Flow Control Packages (RPS, RWS, RHS), Cont. Digit 5 (No Requirement) Y= None X= Special Digit 6 (No Requirement) Y= None X= Special Code 24= Discharge Dampers (RDS, RBS) YYYYYY= None D11111= Supply Air Dampers B11111= Supply & Return Air Dampers XXXXXX= Special Code 30= Heat Exchanger Warranty Y= None A= Standard One Year Heat Exchanger R= Extended Nine Year Heat Exchanger/Ten Year Total Z=Special Code 31= Latest Code Sheet Revision **= Two Digit Code Code 25= Approval Listing Digit 1 (Unit Approval) Y= None C= ETL/Canada OR CSA/MEA E= ETL/MEA L= LA Code U= UL Digit 2 (Burner Approval) Y= None C= ETL-C ( Feet Altitude) OR CSA D= ETL-C ( Feet Altitude) OR CSA U= UL Digit 3 (Burner Approval) Y= None A= FIA F= FM Digit 4 (No Requirement) Y= None Code 26= Parts Warranty A= Standard One Year Parts C= Extended One Year Parts/Two Year Total Z=Special Code 27= Packaging 1= Steel Skid D= Open Crate F= Sheathed Crate S= Split Unit Z= Same as 1 except Consolidated Shipment X=Special Code 28=Miscellaneous YYYY= None 1111= Oil Circulating Tank: Code 03= F 2005= High Pressure Regulator 0.5 Min. Inlet Pressure 2010= High Pressure Regulator 1.0 Min. Inlet Pressure 2020= High Pressure Regulator 2.0 Min. Inlet Pressure 2030= High Pressure Regulator 3.0 Min. Inlet Pressure 2050= High Pressure Regulator 5.0 Min. Inlet Pressure 2075= High Pressure Regulator 7.5 Min. Inlet Pressure 2100= High Pressure Regulator 10.0 Min. Inlet Pressure XXXX= Special Code 29= Compressor Warranty A= Standard One Year Compressor Q= Extended Four Year Compressor/Five Year Total Z=Special Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 9

10 Designation Description Standard Location ACT1 ACT2 ADI AS AUX Model R*S Electrical Legend ACTUATOR MOTOR SUPPLY FAN (VANE OR DAMPER)... SUPPLY AIR SECTION ACTUATOR MOTOR RETURN FAN (VANE OR DAMPER)... RETURN AIR SECTION ANALOG TO DIGITAL INTERFACE (MICROTECH)... MAIN CONTROL BOX BLOWER AIR SWITCH... FURNACE SECTION AUXILIARY ALARM CKTS. FSG... FURNACE SECTION BM CS1, 2, 3 CP1 DAC1 DAS1 DB1 DHL DM1 DS1 DS1 DT1 EC1 EM1 EMS EPC ES1 FB1, 2, 3 FB4, 5, 6, 7, 8 FB 9,10 FB11, 12 FB13 FB24, 25, 26, 27 FD FLC FPS FSG FS1 F1 F2 GF1 GRD GV1 GV2 HL1,2,3,4,5,6,7,8,9,10,11,12 HL13,14,15,16 HP HP4 HS HTR1, 2, 3 IT LP LP4 LT1 LT2 LT3 LT4 BURNER BLOWER MOTOR... FURNACE SECTION SWITCHES, REFRIGERANT CKTS... CONDENSER CONTROL BOX CENTRAL PROCESSOR... MAIN CONTROL BOX DISCHARGE AIR CONTROLLER... MAIN CONTROL BOX DISCHARGE AIR SATELLITE... MAIN CONTROL BOX DAUGHTER BOARD (EARLY MICROTECH)... MAIN CONTROL BOX DUCT HIGH LIMIT... EVAPORATOR SECTION DAMPER MOTOR OUTSIDE AIR... DAMPER SECTION DISCONNECT SWITCH, MAIN (W/ ELECTRIC HEAT)... ELECTRIC HEAT SECTION DISCONNECT SWITCH, MAIN (W/O ELECTRIC HEAT)... MAIN CONTROL BOX DISCHARGE AIR TEMPERATURE SENSOR... DISCHARGE AIR SECTION ENTHALPY CONTROL... ECONOMIZER SECTION ECONOMIZER MOTOR... ECONOMIZER SECTION ENERGY MANAGEMENT SYSTEM... MAIN CONTROL BOX ELECTRONIC PRESSURE CONTROL... MAIN CONTROL BOX ELECTRONIC SEQUENCER... ELECTRIC HEAT SECTION FUSE BLOCK, COMPRESSOR MOTORS... CONDENSER CONTROL BOX FUSE BLOCK, CONDENSER FAN MOTORS... CONDENSER CONTROL BOX FUSE BLOCK, SUPPLY AIR FAN MOTOR... MAIN CONTROL BOX FUSE BLOCK, RETURN AIR FAN MOTOR... MAIN CONTROL BOX FUSE BLOCK, CONTROL POWER... MAIN CONTROL BOX FUSE BLOCK, ELECTRIC HEAT... ELECTRIC HEAT CONTROL BOX FLAME DETECTOR... FURNACE SECTION FAN LIMIT CONTROL... FURNACE SECTION FLOATING PRESSURE SWITCH... SUPPLY AIR OUTLET FLAME SAFEGUARD... FURNACE SECTION FREEZESTAT CONTROL... EVAPORATOR SECTION FUSE, CONTROL CIRCUIT... MAIN CONTROL BOX FUSE, BURNER MOTOR... MAIN CONTROL BOX GROUND FAULT INTERRUPTER... MAIN CONTROL BOX GROUND... MAIN CONTROL BOX PILOT GAS VALVE... FURNACE SECTION` MAIN GAS VALVE... FURNACE SECTION ELECTRIC HEATER LIMITS... ELECTRIC HEAT CONTROL BOX LINEAR LIMIT, ELECTRIC HEAT... ELECTRIC HEAT CONTROL BOX HIGH PRESSURE CONTROL... PRESSURE CONTROL BOX CONDENSER HIGH PRESSURE SWITCH... FURNACE SECTION HEATING SWITCH, ELECTRIC... MAIN CONTROL BOX CRANKCASE HEATER... ON COMPRESSORS IGNITION TRANSFORMER... FURNACE SECTION LOW PRESSURE SWITCH... FURNACE SECTION LOW PRESSURE SWITCH... FURNACE SECTION LIGHT DUCT HI-LIMIT... MAIN CONTROL BOX FURNACE ON LIGHT... FURNACE SECTION PILOT GAS VALVE ON LIGHT... FURNACE SECTION MAIN GAS VALVE ON LIGHT... FURNACE SECTION MCB1 MICROPROCESSOR CONTROL BOARD (MICROTECH)... MAIN CONTROL BOX MJ MECHANICAL JUMPER... TERMINAL BLOCKS MP COMPRESSOR MOTOR PROTECTOR... COMPRESSOR CONTROL BOX M1,2,3,4,5,6,7 CONTACTORS, COMPRESSOR... CONDENSER CONTROL BOX M9,10,11,12,13,14,15,16,17,19 CONTACTORS, CONDENSER FANS... CONDENSER CONTROL BOX M20, 21 CONTACTORS, SUPPLY FAN MOTOR... MAIN CONTROL BOX M22, 23 CONTACTORS, RETURN FAN MOTOR... MAIN CONTROL BOX M24, 25, 26, 27 CONTACTOR, ELECTRIC HEAT POWER... ELECTRIC HEAT CONTROL BOX M28 CONTACTOR, BURNER MOTOR... FURNACE SECTION NB NSB OA OBA, B, C OL1, 2 OL3, 4 OP PC1, 2 PC3 PC4 NEUTRAL BLOCK... CONTROL BOX NIGHT SETBACK... MAIN CONTROL BOX OUTSIDE AIR POTENTIOMETER... MAIN CONTROL BOX OUTPUT BOARDS (MICROTECH)... MAIN CONTROL BOX OVERLOAD SUPPLY FAN MOTOR... MAIN CONTROL BOX OVERLOAD RETURN FAN MOTOR... MAIN CONTROL BOX OIL PRESSURE CONTROL... PRESSURE CONTROL BOX CONDENSER PRESSURE CONTROL UNLOADERS... PRESSURE CONTROL BOX CONDENSER CLOGGED FILTER INDICATOR... FILTER SECTION AIRFLOW SWITCH... COIL SECTION Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 10

11 Model R*S Electrical Legend, Continued Designation Description Standard Location PCB POT1, 2, 3 PR PS1, 2, 3 PTC1 PRINTED CIRCUIT BOARD... SUPPLY AIR OUTLET POTENTIOMETER COMPRESSOR LOCKOUT (0-8 MIN.)... CONDENSER CONTROL BOX PARALLELED RELAY (ACT 2)... RETURN AIR SECTION PUMPDOWN SWITCHES... CONDENSER CONTROL BOX PROPORTIONAL TEMP. CONTROL ECONOMIZER... ECONOMIZER SECTION REC RECEPTACLE... MAIN CONTROL BOX R1, 2, 3 COMPRESSOR LOCKOUT RELAYS... CONDENSER CONTROL BOX R5, 6, 7, 9, 10, 11 UNLOADER CONTROL RELAYS... CONDENSER CONTROL BOX R14 HIGH STAGE HEAT RELAY... HEAT SECTION R16 SUPPLY FAN RELAY... MAIN CONTROL BOX R17 ECONOMIZER RELAY... MAIN CONTROL BOX R18, 19, 43 COOL RELAYS... MAIN CONTROL BOX R20, 21, 27 HEAT RELAYS... MAIN CONTROL BOX R22 COOLING INTERLOCK, SUPPLY FAN... MAIN CONTROL BOX R23 HEATING INTERLOCK, SUPPLY FAN... MAIN CONTROL BOX R24, 25, 44 COOL ALARM RELAYS... MAIN CONTROL BOX R26 NIGHT SETBACK RELAY... MAIN CONTROL BOX R28, 29, 30, 31 ELECTRIC HEAT RELAY... HEAT SECTION R32, 33, 34, 35 HEAT RECLAIM RELAYS... MAIN CONTROL BOX R36, 37 SMOKE DETECTOR RELAY... MAIN CONTROL BOX R38, 39 HUMIDISTAT RELAYS... MAIN CONTROL BOX R41 DUCT HI-LIMIT RELAY... MAIN CONTROL BOX R42 FLOATING PRESSURE CONT. RELAY... MAIN CONTROL BOX R45, 46 HEAT FAIL ALARM RELAYS (OIL)... FURNACE SECTION R51, 52, 53 COMPRESSOR INTERLOCK RELAYS... MAIN CONTROL BOX R54 WATER MODE CYCLE RELAY... MAIN CONTROL BOX R55 WATER MODE CYCLE RELAY... CONDENSER CONTROL BOX R56 WATER CONDENSER FREEZE RELAY... MAIN CONTROL BOX R60-70 SPECIALS... MAIN CONTROL BOX SB1, 2 SD1 SD2 SL1 SL1 SPS1, 2, 3, 4, 5, 6 SR1, 2, 3, 4 SS1 SV1, 2, 5 SV3, 4, 6 SV7, 8, 9 SV10, 11, 12 S1 S2 STAGING BOARD (MICROTECH)... MAIN CONTROL BOX SMOKE DETECTOR, RETURN AIR... RETURN AIR SECTION SMOKE DETECTOR, SUPPLY AIR... SUPPLY AIR SECTION SOLENOID DOOR LOCK... CONDENSER CONTROL BOX SOLENOID DOOR LOCK... MAIN CONTROL BOX STATIC PRESSURE SENSORS... SUPPLY AIR OUTLET SEQUENCER RELAYS, ELECTRIC HEAT... ELECTRIC HEAT SECTION SATELLITE SEQUENCER... MAIN CONTROL BOX SOLENOID VALVES, LIQUID LINE... CONDENSER SECTION SOLENOID VALVES, HOT GAS BYPASS... CONDENSER SECTION SOLENOID VALVES, WATER CONDENSER... CONDENSER SECTION SOLENOID VALVES, AIR CONDENSER... CONDENSER SECTION SYSTEM SWITCH... MAIN CONTROL BOX FURNACE TERMINAL BLOCK... MAIN CONTROL BOX TB1 POWER TERMINAL BLOCK... MAIN CONTROL BOX TB2 TERMINAL BLOCK, 24V, CUSTOMER... MAIN CONTROL BOX TB4, 5 TERMINAL BLOCK, CONDENSER... CONDENSER CONTROL BOX TB6 TERMINAL BLOCK, HEATING... MAIN CONTROL BOX TB7, 8 TERMINAL BLOCK, CONDENSER & MAIN CONTROL... MAIN CONTROL BOX TB9 TERMINAL BLOCK, 24V, FACTORY... MAIN CONTROL BOX TB10 TERMINAL BLOCK, VANE OR DAMPER CONTROL... MAIN CONTROL BOX TB11, 12, 13 TERMINAL BLOCK, ELECTRIC HEAT POWER... ELECTRIC HEAT SECTION TB14 TERMINAL BLOCK, BURNER... FURNACE SECTION TC1, 2, 3, FANTROL THERMOSTATS... CONDENSER CONTROL BOX TC4 FIRESTAT, RETURN AIR... ECONOMIZER SECTION TC5 FIRESTAT, SUPPLY AIR... MAIN CONTROL BOX TC6 CHANGEOVER STAT, COOLING, SUMMER & WINTER... MAIN CONTROL BOX TC8 WATER COND. FREEZESTAT... MAIN CONTROL BOX TC10 MORNING WARMUP... FILTER SECTION TD1, 2, 3 TIME DELAY, COMPRESSOR LOCKOUT (0-8 MINUTES)... CONDENSER CONTROL BOX TD5, 6, 7 TIME DELAY, PART WINDING COMPRESSOR... CONDENSER CONTROL BOX TD8 TIME DELAY, PART WINDING, SUPPLY AIR... MAIN CONTROL BOX TD9 TIME DELAY, PART WINDING, RETURN AIR... MAIN CONTROL BOX T10 TIME DELAY, OIL VALVE... FURNACE SECTION T12, 13, 14 TIME DELAY, WATER CONDENSER... CONDENSER CONTROLBOX T1 MAIN CONTROL TRANSFORMER... MAIN CONTROL BOX T2 24V CONTROL TRANSFORMER... MAIN CONTROL BOX T3 ECONOMIZER TRANSFORMER... MAIN CONTROL BOX T4, 5 ELECTRIC HEAT CONTROL TRANSFORMER... ELECTRIC HEAT SECTION T6 TRANSFORMER, VANE OR DAMPER CONTROL... MAIN CONTROL BOX U1, 2 UNLOADERS... COMPRESSOR VM1 VM2 VALVE MOTOR, HEATING... HEAT SECTION VALVE MOTOR, COOLING... COOLING SECTION Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 11

12 Control Box Component Location Diagram Electric Heat Control Panel Upper Main Control Panel Lower Main Control Panel Compressor Control Box 036B thru 100B Condenser Control Box 018B, 020B, 025B, 030B 061B, 071B, 080B, 081B, 090B, 100B Condenser Control Box 036B, 040B, 041B, 051B 060B, 070B Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 12

13 Condenser Section Condenser Control Box Diagrams NOTE: See Control Box Component Location diagram for reference Condenser Control Box - Sizes 018B, 020B, 025B, 030B FB4 FB6 FB1 T B 4 TD 1 R1 M9 M10 NB R 5 TD5 M11 M1 M5 PC2 HP1 LP1 OP1 Condenser Control Box - Sizes 036B, 040B, 041B, 051B, 060B, 070B FB4 FB5 FB1 TD 5 FB2 TD 6 FB6 M9 M13 M11 TC1 TC2 T B 4 TD 1 TD 2 M1 M5 M2 M6 M10 M14 M12 R5 R9 R6 R10 R2 R1 Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 13

14 Condenser Section Condenser Control Box Diagrams, Continued NOTE: See Control Box Component Location diagram for reference Condenser Control Box - 061B, 071B, 080B, 081B, 090B, 100B Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 14

15 Condenser Section Compressor Contactor Components Schematic Symbol * Contactor Rating Contactor, Compressor M1 M2 M3 M5 M6 M7 Compressor Voltage Part 40 Amp w/ Aux. Contact Amp w/ Aux. Contact V 75 Amp w/ Aux. Contact Amp w/ Aux. Contact Amp w/ Aux. Contact Amp w/ Aux. Contact 230V Amp w/ Aux. Contact Amp w/ Aux. Contact Amp w/ Aux. Contact Amp w/ Aux. Contact 460V Amp w/ Aux. Contact Amp w/ Aux. Contact Amp w/ Aux. Contact Amp w/ Aux. Contact 208V Amp w/ Aux. Contact Amp w/ Aux. Contact /460V 75 Amp w/ Aux. Contact Amp w/ Aux. Contact /230/460V 75 Amp w/ Aux. Contact Amp w/o Aux.Contact Amp w/o Aux.Contact V 75 Amp w/o Aux.Contact Amp w/o Aux.Contact Amp w/o Aux.Contact Amp w/o Aux.Contact 230V Amp w/o Aux.Contact Amp w/o Aux.Contact Model - Pieces Per Unit 018B 020B 025B 030B 036B 040B 041B 051B 060B 070B 061B 071B 080B 081B 090B 100B 75 Amp w/o Aux.Contact 208V Amp w/o Aux.Contact Amp w/o Aux.Contact V 75 Amp w/o Aux.Contact Amp w/o Aux.Contact /230V 75 Amp w/o Aux.Contact *NOTE: Schematic symbols appear on wiring diagram and components have been marked with schematic symbol during unit manufacture. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 15

16 Condenser Section Condenser Fan Motor Contactor Components Model - Pieces Per Unit Schematic Symbol * Part Description Part 018B 020B 025B 030B 036B 040B 041B 051B 060B 070B 061B 071B 080B 081B 090B 100B Contactor, Condenser Fan Motor M M M M M13 3 Amp with Adapter Plate M M M M *NOTE: Schematic symbols appear on wiring diagram and components have been marked with schematic symbol during unit manufacture. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 16

17 Condenser Section Miscellaneous Components Schematic Symbol * Fuseblock Rating Description Voltage Part Fuseblock, Compressor Note: All fuseblocks hold 3 fuses FB1 FB2 FB3 250V 208/230V V 208/230V V 380/460V V 380/460V V 208/230V V 208/230V V 380/460V A 380/460V V 208/230V A 208/230V V 380/460V A 380/460V Fuseblock, Condenser Fan Motor Note: All fuseblocks hold 3 fuses FB4 250V 208/230V FB4 600V 380/460V FB5 250V 208/230V FB5 600V 380/460V FB6 250V 208/230V FB6 600V 380/460V FB7 250V 208/230V FB8 250V 208/230V Terminal Block TB4 14 Pole Model - Pieces Per Unit 018B 020B 025B 030B 036B 040B 041B 051B 060B 070B 061B 071B 080B 081B 090B 100B TB4 24 Pole TB5 14 Pole NB Neutral Bar Potentiometer POT1 3 meg ohm, 0-8 min POT2 3 meg ohm, 0-8 min POT3 3 meg ohm, 0-8 min Pumpdown Switch PS1 Toggle, SPST, 6 Amp PS2 Toggle, SPST, 6 Amp PS3 Toggle, SPST, 6 Amp Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 17

18 Condenser Section Miscellaneous Components, Continued Model - Pieces Per Unit Schematic Symbol * Part Description Part 018B 020B 025B 030B 036B 040B 041B 051B 060B 070B 061B 071B 080B 081B 090B 100B Relay, Unloader R1 DPDT, 120V AC Coil R2,R5,R6 DPDT, 120V AC Coil R9 DPDT, 120V AC Coil R10 DPDT, 120V AC Coil R3,R7,R11 DPDT, 120V AC Coil Terminal Block TB4 14 Pole TB5 14 Pole Fantrol Thermostat TC o F, 120 VAC TC o F, 120 VAC TC o F, 120 VAC Time Delay Relay TD1 0-8 Min TD2 0-8 Min TD3 0-8 Min TD5 Compressor, Part Winding Start TD6 Compressor, Part Winding Start TD7 Compressor, Part Winding Start Control Switch CS1 Toggle, SPST, 6 Amp CS2 Toggle, SPST, 6 Amp CS3 Toggle, SPST, 6 Amp * NOTE: Schematic symbols appear on unit wiring diagrams and components have been marked with schematic symbol during unit manufacture. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 18

19 Condenser Section Compressor Pressure Controls Compressor Control Box - Pressure Controls NOTE: This diagram shows sizes 036B - 100B. Refer to Condenser Control Box Diagram for sizes 018B-030B. Model - Pieces Per Unit Schematic Symbol * Part Description Part 018B 020B 025B 030B 036B 040B 041B 051B 060B 070B 061B 071B 080B 081B 090B 100B HP Pressure Control, High LP Pressure Control, Low OP Pressure Control, Oil PC1, PC2 Unloader (Option) Quantites may vary - Push to Reset Grommet Quantites may vary *NOTE: Schematic symbols appear on wiring diagram and components have been marked with schematic symbol during unit manufacture. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 19

20 Condenser Section Fan Assembly Model - Pieces Per Unit Ref. Bubble Description Part 018B 020B 025B 030B 036B 040B 041B 051B 060B 070B 061B 071B 080B 081B 090B 100B A Fan Guard B Motor Mount (2 pieces req d each mount) C Fan Blade D Rain Slinger E Motor, 1.5 hp, 3 ph, 200/230V E Motor, 1.5 hp, 3 ph, 460/60/3V E Motor, 1.5 hp, 3 ph, 575/60/3V F Top Panel Painted Assembly Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 20

21 Refrigerant Piping P Legend A... COMPRESSOR B... DISCHARGE LINE C... CONDENSER COIL D... EVAPORATOR COIL E... RECEIVER VALVE, MANUAL SHUT-OFF F... FILTER-DRIER G... LIQUID LINE SOLENOID VALVE H... SIGHTGLASS I... LIQUID LINE J... SUCTION LINE K... THERMAL EXPANSION VALVE L... DISTRIBUTOR M... HOT GAS BYPASS SOLENOID VALVE (OPT.) N... HOT GAS BYPASS LINES (OPTIONAL) O... HOT GAS BYPASS VALVE (OPTIONAL) P... HIGH PRESSURE RELIEF VALVE Model - Pieces Per Unit Ref. Letter Description Part 018B 020B 025B 030B 036B 040B 041B 051B 060B 070B 061B 071B 080B 081B 090B 100B EXPANSION VALVES, SPORLAN 40 Ton Ton K 20 Ton Ton SOLENOID VALVES, LIQUID LINE G Sporlan - 39 Ton G Sporlan - 25 Ton SOLENOID VALVE, HOT GAS BYPASS M Sporlan - 25 Ton (Max. Qty/Unit) PRESSURE VALVE, HOT GAS BYPASS O Valve with Remote Bulb (Max. Qty/Unit) RECEIVER VALVE E Shutoff, King Valve FILTER DRIER, SEALED CORE F Sporlan F Sporlan P Relief Valve, High Pressure SIGHTGLASS H Body H Cap Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 21

22 Compressor Model Information Compressor 018B 020B 025B 030B 036B 040B 041B 051B 060B 061B 070B 071B 080B 081B 090B 100B WITHOUT UNLOADERS Circuit 1 IV IV VIII VIII VIII XI or XI or VIII VIII VIII XI or XIII XIII XIII Circuit 2 Not Applicable IV IV IV VIII VIII XI or XI or VIII VIII VIII XI or XIII XIII XIII Circuit 3 IV IV VIII VIII WITH SINGLE UNLOADER Additional bank of unloading available with kits on next page. Circuit 1 I or III or VI or IX or XII or III III IX IX IX XII, XII, IX IX IX XII, II V VII X XIV XIV, XIV, XIV, XV XV XV Circuit 2 III III III IX IX XII, XII, IX IX IX XII, Not Applicable XIV, XIV, XIV, XV XV XV Circuit 3 III III IX IX Refer to Chart Above HP Voltage Amps Daikin Applied Part I /460V** 64/ II V III /460V** 76/ IV /460V** 76/ V V VI*** /460V** 98/ VII*** V VIII /460V** 116/ IX*** /460V** 116/ X*** V XI V XII*** V XIII /460V** 138/ XIV*** /460V** 138/ XV*** V **PW start available on 208 or 230V only. 460V PW starting units require 460V ONLY compressors (V, X, XV). ***Additional bank of unloading available with kits on next page. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 22

23 Miscellaneous Compressor Components Compressor Part Qty. Description Horsepower Per Compr. UNLOADER KIT, Includes 115V Coil 25, 30, MOTOR PROTECTOR (See note below) Post-1981 Units: Copeland or All Texas Instruments 15AA1600B Pre-1980 Units: Copeland or- 25, 35, 40 hp / all voltages -or Robertshaw MP , 20, 30 hp, 460V, PW Pre-1980 Units: Copeland , 20, 30 hp except 460V, PW CRANKCASE HEATER, 120 volt 20, 25, 30, VIBRATION MOUNTING PAD WITH STEEL PLATE All VIBRATION MOUNTING SPRING KIT (4 SPRINGS) , VIBRATION ELIMINATOR, DISCHARGE LINE 20, , 35, VIBRATION ELIMINATOR, SUCTION LINE 20, , 35, NOTE: When ordering motor protectors for compressors in units built between January 1980 and December 1981 or if you are unsure of unit manufacture date, please refer to vendor and model number of motor protector taken from nameplate on protector device. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 23

24 Coils Condensing Coils Condenser Coil Orientation 018B-030B 036B-040B 041B-071B 080B-100B RPS/RFS Model - Pieces Per Unit Ref. Letter Part 018B 020B 025B 030B 036B 040B 041B 051B 060B 070B 061B 071B 080B 081B 090B 100B A 3 CZ x A 3 CZ x B 3 CZ x B 3 CZ x C 3 CZ x D 3 CZ x D 3 CZ x E 3 CZ x E 3 CZ x F 3 CZ x G 3 CZ x G 3 CZ x G 3 CZ x H 3 CZ x H 3 CZ x H 3 CZ x I 3 CZ x I 3 CZ x I 3 CZ x J 3 CZ x J 3 CZ x J 3 CZ x K 3 CZ x K 3 CZ x L 3 CZ x L 3 CZ x M 3 CZ x N 3 CZ x O 3 CZ x O 3 CZ x P 3 CZ x P 3 CZ x Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 24

25 Coils Direct Expansion Evaporator Coils Single Draw-through Evaporator Coil / Unit Sizes 018B-030B, Single Draw-through Evaporator Coil SINGLE DRAW-THROUGH EVAPORATOR COIL SUPPLY AIR FAN AIR FLOW Part Model - Pieces Per Unit 018B 020B 025B 030B 036B 040B 041B 051B 060B 070B 061B 071B 080B 081B 090B 100B 5 EZ x Row (Before 11/92) EZ x Row (Before 11/92) EZ x Row (Before 11/92) EZ x Row (Before 11/92) EZ x Row* EZ x Row* EZ x Row* EZ x Row* EZ x Row* EZ x Row* EZ x Row* EZ x Row* EZ x Row* EZ x Row (Before 11/92) EZ x Row (Before 11/92) EZ x Row (Before 11/92) EZ x Row (Before 11/92) EZ x Row* EZ x Row* EZ x Row* EZ x Row* EZ x Row* EZ x Row* EZ x Row* EZ x Row* EZ x Row* * Used with sloped drain pan, beginning approx. 11/92. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 25

26 Coils Direct Expansion Evaporator Coils Single Blow-through Evaporator Coil / Unit Sizes 036B-040B / Single Blow-through Evaporator Coil SINGLE BLOW-THROUGH EVAPORATOR COIL SUPPLY AIR FAN AIR FLOW Part Model - Pieces Per Unit 018B 020B 025B 030B 036B 040B 041B 051B 060B 070B 061B 071B 080B 081B 090B 100B Single Blow-through Evaporator Coil (Fig. 8B) 5 EZ x Row (Before 11/92) EZ x Row (Before 11/92) EZ x Row (Before 11/92) EZ x Row* EZ x Row* EZ x Row* EZ x Row* EZ x Row* EZ x Row* EZ x Row* EZ x Row* EZ x Row* EZ x Row (Before 11/92) EZ x Row (Before 11/92) EZ x Row (Before 11/92) EZ x Row* EZ x Row* EZ x Row* EZ x Row* EZ x Row* EZ x Row* EZ x Row* EZ x Row* EZ x Row* * Used with sloped drain pans, beginning approx. 11/92. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 26

27 Coils Direct Expansion Evaporator Coils Single Blow-through Evaporator Coil / Unit Sizes 041B-100B / Model - Pieces Per Unit Part 018B 020B 025B 030B 036B 040B 041B 051B 060B 070B 061B 071B 080B 081B 090B 100B Single Blow-through Evap. Coil, (Fig. 8B), Cont d. 5 EZ x Row EZ x Row EZ x Row EZ x Row EZ x Row EZ x Row EZ x Row EZ x Row EZ x Row EZ x Row EZ x Row EZ x Row EZ x Row EZ x Row EZ x Row Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 27

28 Coils Direct Expansion Evaporator Coils Dual Blow-through Evaporator Coil / Unit Sizes 081B-100B / Dual Blow-through Evaporator Coil SUPPLY AIR FAN AIR FLOW DUAL BLOW-THROUGH EVAPORATOR COIL DUAL BLOW-THROUGH EVAPORATOR COIL Part Model - Pieces Per Unit 018B 020B 025B 030B 036B 040B 041B 051B 060B 070B 061B 071B 080B 081B 090B 100B Dual Blow-through Evaporator Coil (Fig. 8C) 5 EZ x Row EZ x Row EZ x Row EZ x Row EZ x Row EZ x Row Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 28

29 Upper Main Control Panel: Non MicroTech (Code 20= 30, 31) Unit Controller Diagrams - All sizes Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 29

30 Upper Main Control Panel: Non MicroTech (Code 20= 30, 31) Diagram and Components - All sizes Upper Main Control Panel NOTE: Most common locations of controls are shown. Actual location of controls may vary with unit size & unit options. UNIT CONTROLLER Schematic* Symbol General Function Coil Volt. No. of Poles Part Quantity Per Unit (When Option Exists) R16 Fan Relay 24V SPDT R17 Economizer Relay 24V SPDT R18 Cool Relay No. 1 24V SPDT R19 Cool Relay No. 2 24V 3PDT R20 Gas & Oil Heat Relay 24V DPDT R20 Electric Heat Relay 120V DPDT R20 Electric Heat Relay 24V DPDT R20 Steam & Hot Water 24V DPDT R21 Electric Heat Relay 24V SPDT R22 Cooling Fan Interlock 120V 3PDT R23 Heat Fan Interlock 120V DPDT *NOTE: Schematic symbols appear on unit wiring diagrams and components are marked with them at time of manufacture. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 30

31 Upper Main Control Panel: Non MicroTech (Code 20= 30, 31) All Sizes, Continued Part General Function No. of Poles R24 Cool Alarm Coil Voltage; 120V SPDT Schematic* Symbol Quantity Per Unit (When Option Exists) R25 Cool Alarm Coil Voltage, 120V SPDT R26 Night Setback Coil Voltage, 24V 3PDT R27 Electric Heat Relay Coil Voltage, 24V SPDT R37 Smoke Trip Coil Voltage, 120V 3PDT R41 Duct High Limit Coil Voltage, 120V SPDT R42 Floating Pressure Control Coil Voltage, 120V SPDT R43 Cool Relay Coil Voltage, 24V SPDT R44 Cool Alarm Coil Voltage, 120V SPDT TERMINAL BLOCKS TB6 Heating Circuits 7 Pole TB7 Main Control, 120V 8 Pole TB7 Main Control, 120V 14 Pole TB7 Main Control, 120V 28 Pole TB7 Main Control, 120V 30 Pole TB9 24V Factory Connection 14 Pole TB10 VAV Float Controls 7 Pole NB Neutral Bar 7 Pole NB Neutral Bar 16 Pole THERMOSTATS TC5 125 o Firestat, Units with Cooling Only TC5 225 o Firestat, Units with Heating TC6 Summer-Winter Changeover (Compr. Lockout) TRANSFORMERS T2 24 Volt Control Circuit, V,.045 KVA T3 Economizer, V,.045 KVA T6 Variable Air Volume Control, V,.020 KVA SWITCHES S1 System Switch SPST-Use on all units except with gas or oil heat S1 System Switch DPST-Use on all units with oil or gas heat HS Heat Switch SPST None Test Switch with Leads, Units with W7100 (DAC1) POTENTIOMETER, UNIT MOUNTED OA Outside Air Potentiometer (Units with Electric Heat) OA Outside Air Potentiometer (Units without Electric Heat) None Knob for Potentiometer FUSE F1 Fuse Holder F1 Fuse, 15 Amp F1 Fuse, 6 Amp *NOTE: Schematic symbols appear on unit wiring diagrams and components are marked with them at time of manufacture. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 31

32 Upper Main Control Panel: Non MicroTech (Code 20= 30, 31) Components - All Sizes, Continued Schematic* Symbol Part Quantity Per Unit (When Option Exists) INDICATOR LIGHT LT1 Duct High Limit Neon Light, Red RECEPTACLE RECP 120V Service Receptacle CONTROLLERS CP1 W973B Solid-State Central Processor NSB W974A Night Setback Module DAC1 W7100A Discharge Air Controller, RPS/RFS units only (includes 600 ohm resistor) W7100D Discharge Air Controller, RHS/RWS units only (includes 1000 ohm resistor) DAC1 Resistor, 200 ohm, 2 stage control DAC1 Resistor, 301 ohm, 3 stage control DAC1 Resistor, 402 ohm, 4 stage control DAC1 Resistor, 499 ohm, 5 stage control DAC1 Resistor, 600 ohm, 6 stage control DAC1 Resistor, 806 ohm, 8 stage control DAC1 Resistor, 909 ohm, 9 stage control Resistor (W7100D Only) 1000 ohm Resistor Kit (includes all of above resistors) DAS1 W7101A Satellite Sequencer, RPS/RFS Units w/more than 6 stages EPC Vanetrol, Electronic Pressure Controller OBSOLETE CONTROLLERS (Not Shown) Consult Daikin Applied for availability. SC Step Controller, 6 stage, Honeywell S984-P SC Step Controller, 10 stage, Honeywell S984-J PTC2 Proportional Temp. Control, Solid-state, Pressure-Johnson PC *NOTE: Schematic symbols appear on unit wiring diagrams and components are marked with them at time of manufacture. 1 When a unit has hydronic heat (C03= W or S) and a modulating valve (C16=****M) the CP1 part number is: Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 32

33 Upper Main Control Panel: MicroTech (Code 20= 1M, 2M, 4M) Diagrams Upper Main Control Panel NOTE: Most common locations of controls are shown. Actual location of controls may vary with unit size & unit options. Not all possible components are shown in the below diagrams. MicroTech controls were mostly used in sizes although some larger units were made as specials. Lower Main Control Panel components do not change from Non- MicroTech equipped units Units and Before Keypad Display MCB1 P M 1 T B 1 0 R6 R5 R24 T2 T3 R26 R20 TB6 TB4 TB3 DB1 TB5 TB2 OBA SB1 OBB TB8 NB1 TB5 See Lower Main Control Section 1996 Units and Later T2 OBA P M 1 Keypad Display MCB1 R24 T3 R26 R20 R29 SPS1 SPS2 DHL NB1 ADI SB1 OBB See Lower Main Control Section Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 33

34 Upper Main Control Panel: MicroTech (Code 20= 1M, 2M, 4M) Components Sch.* Part Part Sym. Description Qty. Switches S1 Toggle Switch- Control: Units with Gas Heat (Code 03= A) Toggle Switch- Control: Units without Gas Heat (C03= E, W, S, Y, X) S6 Switch- VIV Units HS1 Switch- Electric Heat Shutdown (Code 03= E) PS3 Toggle Switch- Unit Pumpdown Fusing F1 Fuse- Control Circuit- 15A/250V Fuse Holder for F F3 Fuse- Gas Heat Burner Motor Fuse Holder for F Receptacle REC1 Receptacle- Standard, 1P/3W/15A Receptacle- Duplex Feed thru GF1, 2P/3W/15A Receptacle- Duplex GF1, 2P/3W/15A Receptacle- Duplex Feed thru GF1, 2P/3W/20A Terminal Blocks TB1 Terminal Block- Service Recepticle Circuit, 115V Field, 3 Pole TB2 Terminal Block- Field Code 20= 1M- (14 pole portion) Code 20= 1M- (24 pole portion) Code 20= 2M, 4M TB5 Terminal Block- Control TB6 Terminal Block- Control TB7 Terminal Block- Factory TB8 Terminal Block- Factory TB10 Terminal Block- Heating NB1, 2 Neutral Block, 7 Pole Transformers T2 Transformer- Unit T3 Transformer- Controller T4 Transformer- Power Relief Dampers until 5/ /02 & later Rectifier- T Terminal Block- T4 & Rectifier T5 Transformer- Specials *NOTE: Schematic symbols appear on unit wiring diagrams and components are marked with them at time of manufacture. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 34

35 Upper Main Control Panel: MicroTech (Code 20= 1M, 2M, 4M) Components , Continued Sch. Part Part Sym. Description Qty. Relays R20 Relay- Gas Heat On/Off R24 Relay- Gas Heat Alarm R26 Relay- Occupied/Unoccupied R27 Relay- Powered Relief Dampers R28 Relay- Isolation Damper R29 Relay- Final Filter Transducer and Pressure Controls SPS1 Sensor- Duct Static Pressure (Code 24 [Digit 3]= 1, 2, 3) SPS2 Sensor- Duct Static Pressure (Code 24 [Digit 3]= 2) Sensor- Building Static Pressure (Code 24 [Digit 3]= 3, 4) DHL Switch- Duct Hi- Limit Fitting for DHL Main MicroTech Controller and Associated Boards MCB1 Microprocessor (must be programmed- requires unit GO or Serial No.) Fuse- MCB Keypad Keypad/Display Assembly Ribbon Cable- MCB to Keypad ADI ADI Board DB1 Daughter Board Fuse, DB Ribbon Cable- MCB to DB OBA Output Board- 16 position Ribbon Cable- MCB to OBA OBB Output Board- 4 position- Cooling OBB Output Board- 8 position- Cooling OBC Output Board- 8 position- Heating OB Output Board Relay Standard Relay SB1 Small Relay Cooling Staging Board 4 or 6 stages cooling and no unloaders stages cooling and 2 unloaders per circuit stages cooling and 1 unloader per circuit SB2 Heating Staging Board- 4 to 8 stages of Heat Room Sensors Sensor #1- Standard VAV Sensor #2- Enhanced VAV (includes tenant override) Sensor #9- Standard CAV Units built prior to 1995 used a Daughter Board (DB1). In 1996, the Daughter board was replaced with an ADI board. 2 Quantity varies depending on options. 3 Used on VAV units (Code 20= 2M, 4M) with 4 stages of cooling (Code 42= 4). CAV units (Code 20= 1M) units have all cooling control directly from MCB to OBA. Ribbon cable connecting OBB to SB1 is p/n Used on VAV units (Code 20= 2M, 4M) with 6 or 8 stages of cooling (Code 42= 6, 8). CAV units (Code 20= 1M) units have all cooling control directly from MCB to OBA. Ribbon cable connecting OBB to SB1 is p/n Used on CAV units (Code 20= 1M) with more than 4 stages of electrical heat. Ribbon cable connecting OBC to SB2 is p/n Prior to 1/92 use p/n for VAV and p/n for CAV. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 35

36 Lower Main Control Panel Component Location Diagram - All Sizes Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 36

37 Lower Main Control Panel Components - All Sizes Schematic* Symbol Part Quantity FUSE, GAS/OIL BURNER MOTOR F2 Fuseblock; Gas/Oil Burner Motor Fuse - 20 Amp; Gas/Oil Burner Motor Fan HP Fan Voltage Fan Starting Fuseblock Rating FUSEBLOCK, SUPPLY AIR FAN Across the Line 250V & Across the Line 250V & Across the Line 250V Across the Line 250V Across the Line 250V & Across the Line 250V Across the Line 250V & Across the Line 250V Across the Line 250V Across the Line 250V & Across the Line 250V & Across the Line 250V or 460 Across the Line 600V or 460 Across the Line 600V FB9 50 & or 460 Across the Line 600V & or 460 Across the Line 600V Part Winding 250V Part Winding 250V Part Winding 250V & Part Winding 250V Part Winding 250V Part Winding 250V & Part Winding 250V & Part Winding 250V Across the Line 250V Across the Line 250V & Across the Line 250V Across the Line 250V & Across the Line 250V & Across the Line 250V Part Winding 250V FB Part Winding 250V Part Winding 250V & Part Winding 250V Part Winding 250V Part Winding 250V & Part Winding 250V & Part Winding 250V * NOTE: Schematic symbols appear on unit wiring diagrams and components are marked with them at time of manufacture. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 37

38 Lower Main Control Panel Components - Continued Schematic* Symbol Fan Horsepower FUSEBLOCK, RETURN AIR FAN FB11 FB Across the Line 250V & Across the Line 250V & Across the Line 250V Across the Line 250V Across the Line 250V Across the Line 250V & Across the Line 250V Across the Line 250V Across the Line 250V & Across the Line 250V or 460 Across the Line 600V or 460 Across the Line 600V or 460 Across the Line 600V Part Winding 250V Part Winding 250V Part Winding 250V Part Winding 250V Part Winding 250V & Part Winding 250V Across the Line 250V Across the Line 250V Across the Line 250V & Across the Line 250V Part Winding 250V Part Winding 250V Part Winding 250V Part Winding 250V Part Winding 250V & Part Winding 250V FUSEBLOCK, MAIN CONTROL TRANSFORMER FB13 Unit Voltage Fan Voltage Fan Starting Fuseblock Rating Fuseblock Rating Part Part Quantity 208 or V or V * NOTE: Schematic symbols appear on unit wiring diagrams and components are marked with them at time of manufacture. Quantity Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 38

39 Lower Main Control Panel Components - Continued Schematic* Symbol Fan Horsepower Fan Voltage CONTACTOR, SUPPLY AIR FAN M20 Fan Starting Contactor Rating (FLA) Part Quantity Across the Line 25 AMP Across the Line 30 AMP Across the Line 40 AMP Across the Line 50 AMP Across the Line 75 AMP Across the Line 90 AMP Across the Line 50 AMP Across the Line/Part Winding 75 AMP , Across the Line/Part Winding 90 AMP Across the Line/Part Winding 120 AMP Across the Line/Part Winding 200 AMP Part Winding 25 AMP , Part Winding 40 AMP Part Winding 50 AMP Across the Line 25 AMP Across the Line 30 AMP Across the Line 50 AMP Across the Line 60 AMP Across the Line 75 AMP Across the Line 90 AMP Across the Line 60 AMP Across the Line 75 AMP Across the Line 90 AMP Across the Line/Part Winding 120 AMP Across the Line/Part Winding 200 AMP Part Winding 25 AMP Part Winding 30 AMP Part Winding 40 AMP , Part Winding 50 AMP , Part Winding 75 AMP ,460 Across the Line 25 AMP ,460 Across the Line 30 AMP ,460 Across the Line 40 AMP ,460 Across the Line 50 AMP ,460 Across the Line 60 AMP ,460 Across the Line 75 AMP ,460 Across the Line 90 AMP ,460 Across the Line 100 AMP ,460 Across the Line 200 AMP * NOTE: Schematic symbols appear on unit wiring diagrams and components are marked with them at time of manufacture. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 39

40 Lower Main Control Panel Components - Continued Schematic* Symbol Fan Horsepower CONTACTOR, SUPPLY AIR FAN M21 Fan Voltage Fan Starting Contactor Rating (FLA) Part Quantity Across the Line 50 AMP Across the Line 75 AMP , Across the Line 90 AMP Across the Line 120 AMP Across the Line 200 AMP Part Winding 25 AMP , Part Winding 40 AMP Part Winding 50 AMP Part Winding 75 AMP , Part Winding 90 AMP Part Winding 120 AMP Part Winding 200 AMP Across the Line 60 AMP Across the Line 75 AMP Across the Line 90 AMP Across the Line 120 AMP Across the Line 200 AMP Part Winding 25 AMP Part Winding 30 AMP Part Winding 40 AMP , Part Winding 50 AMP , Part Winding 75 AMP Part Winding 120 AMP Part Winding 200 AMP * NOTE: Schematic symbols appear on unit wiring diagrams and components are marked with them at time of manufacture. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 40

41 Lower Main Control Panel Components - Continued Schematic* Symbol Fan Horsepower Fan Voltage Fan Starting Contactor Rating (FLA) Part Quantity CONTACTOR, RETURN AIR FAN Across the Line 25 AMP Across the Line 30 AMP Across the Line 40 AMP Across the Line 50 AMP Across the Line 75 AMP Across the Line 90 AMP Across the Line 50 AMP Across the Line 75 AMP , Across the Line 90 AMP Part Winding 25 AMP , Part Winding 40 AMP Part Winding 50 AMP Part Winding 75 AMP M22 50, Part Winding 90 AMP Across the Line 25 AMP Across the Line 30 AMP Across the Line 50 AMP Across the Line 60 AMP Across the Line 75 AMP Across the Line 90 AMP Across the Line 60 AMP Across the Line 75 AMP Across the Line 90 AMP Part Winding 25 AMP Part Winding 30 AMP Part Winding 40 AMP , Part Winding 50 AMP , Part Winding 75 AMP ,460 Across the Line 25 AMP ,460 Across the Line 30 AMP ,460 Across the Line 40 AMP ,460 Across the Line 50 AMP ,460 Across the Line 60 AMP ,460 Across the Line 75 AMP ,460 Across the Line 90 AMP * NOTE: Schematic symbols appear on unit wiring diagrams and components are marked with them at time of manufacture. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 41

42 Lower Main Control Panel Components - Continued Schematic* Symbol Fan Horsepower Fan Voltage Fan Starting CONTACTOR, RETURN AIR FAN - PART OR DUAL WINDING M23 Contactor Rating (FLA) Part Quantity Across the Line 50 AMP Across the Line 75 AMP , Across the Line 90 AMP Across the Line 120 AMP Across the Line 200 AMP Part Winding 25 AMP , Part Winding 30 AMP Part Winding 50 AMP Part Winding 75 AMP , Part Winding 90 AMP Part Winding 120 AMP Part Winding 200 AMP Across the Line 60 AMP Across the Line 75 AMP Across the Line 90 AMP Part Winding 25 AMP Part Winding 30 AMP Part Winding 40 AMP , Part Winding 50 AMP , Part Winding 75 AMP * NOTE: Schematic symbols appear on unit wiring diagrams and components are marked with them at time of manufacture. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 42

43 Lower Main Control Panel Components - Continued Part s Schematic* Symbol Horsepower Voltage Fan Starting Overload Relay Heater OVERLOAD RELAY & HEATER, SUPPLY & RETURN FAN OL1 & OL Across the Line Across the Line , 460 Across the Line Across the Line Across the Line , 460 Across the Line Across the Line Across the Line , 460 Across the Line Across the Line Across the Line , 460 Across the Line Across the Line Across the Line , 460 Across the Line Across the Line Across the Line , 460 Across the Line Across the Line Across the Line , 460 Across the Line Across the Line Part Winding Across the Line Part Winding , 460 Across the Line Across the Line Part Winding Across the Line Part Winding , 460 Across the Line Across the Line Part Winding Across the Line Part Winding , 460 Across the Line Across the Line,Part Winding Part Winding Across the Line , 460 Part Winding Note: 3 heaters per overload relay. 1, 2 or 4 overload relays per unit. OL1 & OL2=Supply fan overloads. OL3 & OL4=Return fan overloads. * NOTE: Schematic symbols appear on unit wiring diagrams and components are marked with them at time of manufacture. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 43

44 Lower Main Control Panel Components - Continued Part s Schematic* Symbol Horsepower Voltage Fan Starting Overload Relay Heater OVERLOAD RELAY & HEATER, SUPPLY & RETURN FAN OL1 & OL Across the Line/Part Winding Across the Line/Part Winding ,460 Across the Line Across the Line/Part Winding Across the Line/Part Winding ,460 Across the Line Across the Line/Part Winding Across the Line/Part Winding ,460 Across the Line Across the Line/Part Winding Across the Line/Part Winding ,460 Across the Line Across the Line/Part Winding Across the Line/Part Winding ,460 Across the Line OL2 & OL Part Winding Part Winding Part Winding Part Winding Part Winding Part Winding Across the Line/Part Winding Part Winding Across the Line/Part Winding Across the Line/Part Winding Across the Line/Part Winding Across the Line/Part Winding Across the Line/Part Winding Across the Line/Part Winding Across the Line/Part Winding Across the Line/Part Winding Across the Line/Part Winding Across the Line/Part Winding Note: 3 heaters per overload relay. 1, 2 or 4 overload relays per unit. OL1 & OL2=Supply fan overloads. OL3 & OL4=Return fan overloads. * NOTE: Schematic symbols appear on unit wiring diagrams and components are marked with them at time of manufacture. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 44

45 Lower Main Control Panel Components - Continued Schematic* Unit Symbol Voltage TRANSFORMERS Type of Heat (If Any) RPS/RFS-018B, 020B, 025B, 030B; RHS/RWS/RBS/RDS-800B Part 208 Electric or None Step-Down, V, 0.500KVA Gas Step-Down, V, 1.000KVA Fuel Oil Consult Daikin Applied 230 Electric or None Step-Down, V, 0.500KVA Gas Step-Down, V, 1.000KVA Fuel Oil Consult Daikin Applied 380 Electric or None Step-Down, V, 0.500KVA Gas Step-Down, V, 1.000KVA Fuel Oil Consult Daikin Applied 460 Electric or None Step-Down, V, 0.500KVA Gas Step-Down, V, 1.000KVA Fuel Oil Consult Daikin Applied RPS/RFS-036B, 040B, 041B, 051B, 060B, 070B; RHS/RWS/RBS/RDS-802B, 804B 208 Electric, Gas, None Step-Down, V, 1.000KVA Fuel Oil Consult Daikin Applied 230 Electric, Gas, None Step-Down, V, 1.000KVA Fuel Oil Consult Daikin Applied T1 380 Electric, Gas, None Step-Down, V, 1.000KVA Fuel Oil Consult Daikin Applied 460 Electric, Gas, None Step-Down, V, 1.000KVA Fuel Oil Consult Daikin Applied RPS/RFS-061B, 071B, 080B, 081B, 090B, 100B; RHS/RWS/RBS/RDS-806B, 808B 208 Electric or None Step-Down, V,1.000 KVA Gas Step-Down, V,1.000 KVA-Htr.Model # Gas Step-Down, V,2.000 KVA-Htr.Model # Fuel Oil Consult Daikin Applied 230 Electric or None Step-Down, V,1.000 KVA Gas Step-Down, V,1.000 KVA-Htr.Model # Gas Step-Down, V,2.000 KVA-Htr.Model # Fuel Oil Consult Daikin Applied 380 Electric or None Step-Down, V,1.000 KVA Gas Step-Down, V,1.000 KVA-Htr.Model # Gas Step-Down, V,2.000 KVA-Htr.Model # Fuel Oil Consult Daikin Applied 460 Electric or None Step-Down, V,1.000 KVA Gas Step-Down, V,1.000 KVA-Htr.Model # Gas Step-Down, V,2.000 KVA-Htr.Model # Fuel Oil Consult Daikin Applied * NOTE: Schematic symbols appear on unit wiring diagrams and components are marked with them at time of manufacture. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 45

46 Lower Main Control Panel Components - Continued Schematic* Symbol CIRCUIT BREAKERS Note: If the unit has electric heat, the DS1 is located in the electric heat section. Unit Voltage RPS/RFS - 018B Supply Air Fan HP Return Air Fan HP Part 208/ None, Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / None 100 Amp, 600 Volt, 3 Pole / All 250 Amp, 600 Volt, 3 Pole / None, All 250 Amp, 600 Volt, 3 Pole DS1 380/ None, All 60 Amp, 600 Volt, 3 Pole / None, Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / None, All 100 Amp, 600 Volt, 3 Pole RPS/RFS-020B 208/230 All All 250 Amp, 600 Volt, 3 Pole / None, All 60 Amp, 600 Volt, 3 Pole / None, Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / None 60 Amp, 600 Volt, 3 Pole / All 100 Amp, 600 Volt, 3 Pole / None, All 100 Amp, 600 Volt, 3 Pole / None, Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / None, Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole RPS/RFS-025B 208/ None, All 250 Amp, 600 Volt, 3 Pole / None, All 250 Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / None, Amp, 600 Volt, 3 Pole / None, All 100 Amp, 600 Volt, 3 Pole / None, Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / None, All 250 Amp, 600 Volt, 3 Pole * Schematic symbols appear on unit wiring diagrams and components are marked with them at time of manufacture. DUE TO UNIT SPECIALS - Request vendor information and contact Daikin Applied. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 46

47 Lower Main Control Panel Components - Continued Schematic* Symbol Unit Voltage CIRCUIT BREAKERS Note: If the unit has electric heat, the DS1 is located in the electric heat section. RPS/RFS-030B Supply Air Fan HP Return Air Fan HP Part 208/ None, All 250 Amp, 600 Volt, 3 Pole / None, Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / None, Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / None, All 400 Amp, 600 Volt, 3 Pole DS1 (Continued from previous page) 380/ None, All 100 Amp, 600 Volt, 3 Pole / , Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / None 100 Amp, 600 Volt, 3 Pole / All 250 Amp, 600 Volt, 3 Pole / None, All 250 Amp, 600 Volt, 3 Pole RPS/RFS-036B, 040B, 041B 208/230 All All 400 Amp, 600 Volt, 3 Pole /460 All All 250 Amp, 600 Volt, 3 Pole RPS/RFS-051B 208/230 All None 400 Amp, 600 Volt, 3 Pole All 400 Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole All 600 Amp, 600 Volt, 3 Pole All 400 Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole /460 All All 250 Amp, 600 Volt, 3 Pole * NOTE: Schematic symbols appear on unit wiring diagrams and components are marked with them at time of manufacture. DUE TO UNIT SPECIALS - Request vendor information and contact Daikin Applied. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 47

48 Schematic* Unit Symbol Voltage CIRCUIT BREAKERS Lower Main Control Panel Components - Continued Note: If the unit has electric heat, the DS1 is located in the electric heat section. RPS/RFS-060B Supply Air Fan HP Return Air Fan HP Part 208/ , Amp, 600 Volt, 3 Pole / None 400 Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole DS1 (Continued from previous page) All 600 Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole None 600 Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole , Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole None 400 Amp, 600 Volt, 3 Pole / None 600 Amp, 600 Volt, 3 Pole / None, All 250 Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole RPS/RFS-070B 208/ None, All 600 Amp, 600 Volt, 3 Pole None, All 400 Amp, 600 Volt, 3 Pole None, All 600 Amp, 600 Volt, 3 Pole None, All 400 Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole None, 2.0, Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole None, All 250 Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / None, Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / None 250 Amp, 600 Volt, 3 Pole / All 400 Amp, 600 Volt, 3 Pole / None, All 400 Amp, 600 Volt, 3 Pole * NOTE: Schematic symbols appear on unit wiring diagrams and components are marked with them at time of manufacture. DUE TO UNIT SPECIALS - Request vendor information and contact Daikin Applied. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 48

49 Lower Main Control Panel Components - Continued Note: If the unit has electric heat, the DS1 is located in the electric heat section. Schematic* Symbol Unit Voltage Supply Air Fan HP CIRCUIT BREAKERS RPS/RFS-061B, 071B Return Air Fan HP Part None 600 Amp, 600 Volt, 3 Pole , Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole , Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole , Amp, 600 Volt, 3 Pole DS1 (Continued from previous page) None 400 Amp, 600 Volt, 3 Pole , Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole , Amp, 600 Volt, 3 Pole , Amp, 600 Volt, 3 Pole , Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / , Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / None, 5.0, Amp, 600 Volt, 3 Pole / , Amp, 600 Volt, 3 Pole / , , Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / None, Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / None, Amp, 600 Volt, 3 Pole / None 250 Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / None, Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole * NOTE: Schematic symbols appear on unit wiring diagrams and components are marked with them at time of manufacture. DUE TO UNIT SPECIALS - Request vendor information and contact Daikin Applied. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 49

50 Lower Main Control Panel Components - Continued Schematic* Unit Symbol Voltage CIRCUIT BREAKERS DS1 (Continued from previous page) Note: If the unit has electric heat, the DS1 is located in the electric heat section. Supply Air Fan HP RPS/RFS-080B, 081B Part 208/ Amp, 600 Volt, 3 Pole / , Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / , 50.0 None, 5.0, Amp, 600 Volt, 3 Pole / , Amp, 600 Volt, 3 Pole / None 600 Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole , Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole , Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole / , 7.5 None, Amp, 600 Volt, 3 Pole / None 250 Amp, 600 Volt, 3 Pole / , , Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / None, All 400 Amp, 600 Volt, 3 Pole RPS/RFS-090B Return Air Fan HP 208/ None, Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / ,30.0 None, Amp, 600 Volt, 3 Pole / , Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / None 600 Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / , Amp, 600 Volt, 3 Pole / , 60.0 None, All 800 Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole , Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole /460 All All 400 Amp, 600 Volt, 3 Pole * NOTE: Schematic symbols appear on unit wiring diagrams and components are marked with them at time of manufacture. DUE TO UNIT SPECIALS - Request vendor information and contact Daikin Applied. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 50

51 Lower Main Control Panel Components - Continued Schematic* Unit Symbol Voltage CIRCUIT BREAKERS Note: If the unit has electric heat, the DS1 is located in the electric heat section. RPS/RFS-100B Supply Air Fan HP Return Air Fan HP Part 208/ None, Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / , 20.0 None 600 Amp, 600 Volt, 3 Pole / , Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / None 800 Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole DS1 (Continued from previous page) , , Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole , 30.0 None 800 Amp, 600 Volt, 3 Pole , Amp, 600 Volt, 3 Pole , , Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole , 30.0 None 600 Amp, 600 Volt, 3 Pole , Amp, 600 Volt, 3 Pole /460 All All 400 Amp, 600 Volt, 3 Pole RHS/RWS/RBS/RDS-800B 208/ None, All 60 Amp, 600 Volt, 3 Pole / , 15.0 None, Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / , Amp, 600 Volt, 3 Pole / , Amp, 600 Volt, 3 Pole / , Amp, 600 Volt, 3 Pole / None, Amp, 600 Volt, 3 Pole /460 All All 60 Amp, 600 Volt, 3 Pole RHS/RWS/RBS/RDS-802B 208/ None, Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / None 60 Amp, 600 Volt, 3 Pole / , Amp, 600 Volt, 3 Pole / , Amp, 600 Volt, 3 Pole / None 100 Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole /460 All Amp, 600 Volt, 3 Pole /460 All Amp, 600 Volt, 3 Pole * NOTE: Schematic symbols appear on unit wiring diagrams and components are marked with them at time of manufacture. DUE TO UNIT SPECIALS - Request vendor information and contact Daikin Applied. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 51

52 Lower Main Control Panel Components - Continued Schematic* Symbol Unit Voltage CIRCUIT BREAKERS Note: If the unit has electric heat, the DS1 is located in the electric heat section. Supply Air Fan HP RHS/RWS/RBS/RDS-804B Return Air Fan HP Part 208/ None, Amp, 600 Volt, 3 Pole / None, Amp, 600 Volt, 3 Pole / , Amp, 600 Volt, 3 Pole / None 60 Amp, 600 Volt, 3 Pole / , Amp, 600 Volt, 3 Pole / , 25.0 None 100 Amp, 600 Volt, 3 Pole / None 250 Amp, 600 Volt, 3 Pole DS1 (Continued from previous page) Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole All 250 Amp, 600 Volt, 3 Pole None 250 Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole , Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole None 100 Amp, 600 Volt, 3 Pole None 250 Amp, 600 Volt, 3 Pole / None, All 60 Amp, 600 Volt, 3 Pole / None, Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / , Amp, 600 Volt, 3 Pole / , Amp, 600 Volt, 3 Pole / None 60 Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole * NOTE: Schematic symbols appear on unit wiring diagrams and components are marked with them at time of manufacture. DUE TO UNIT SPECIALS - Request vendor information and contact Daikin Applied. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 52

53 Lower Main Control Panel Components - Continued Schematic* Unit Symbol Voltage CIRCUIT BREAKERS DS1 (Continued from previous page) Note: If the unit has electric heat, the DS1 is located in the electric heat section. Supply Air Fan HP RHS/RWS/RBS/RDS-806B, 808B Return Air Fan HP Part 208/ None 60 Amp, 600 Volt, 3 Pole / All 100 Amp, 600 Volt, 3 Pole / All 250 Amp, 600 Volt, 3 Pole / None 100 Amp, 600 Volt, 3 Pole / None, 5.0, Amp, 600 Volt, 3 Pole / , Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / , , Amp, 600 Volt, 3 Pole / , Amp, 600 Volt, 3 Pole / None, All 60 Amp, 600 Volt, 3 Pole / None 60 Amp, 600 Volt, 3 Pole / All 100 Amp, 600 Volt, 3 Pole / , Amp, 600 Volt, 3 Pole / , Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / None 100 Amp, 600 Volt, 3 Pole / , Amp, 600 Volt, 3 Pole / , Amp, 600 Volt, 3 Pole * NOTE: Schematic symbols appear on unit wiring diagrams and components are marked with them at time of manufacture. DUE TO UNIT SPECIALS - Request vendor information and contact Daikin Applied. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 53

54 Miscellaneous Controls Control Locations Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 54

55 Miscellaneous Controls Components Schematic* Symbol Type of Unit Control System Part ACT1 Actuator, Damper Control, Supply Air (Discharge) All Types ACT1 Actuator, Inlet Vanes, Supply Air Motor, 5-10 Hp All Types ACT1 Actuator, Inlet Control, Supply Air Motor, Hp All Types ACT1 Actuator, Inlet Vanes, Supply Air Motor, Hp All Types Qty/ Unit ACT2 Actuator, Damper Control, Return Air All Types ACT2 Actuator, Inlet Vanes, Return Air Motor, 5-10 Hp All Types ACT2 Actuator, Inlet Control, Return Air Motor, Hp All Types ACT2 Relay for ACT-2, Unit w/floating Pressure Switch All Types ACT2 Resistor for ACT-2, 5 ohms 50W Units with Floating All Types Pressure Switch DHL Duct High Limit, Pressure Switch. Units with Variable All except MicroTech Inlet Vanes. MicroTech Controls DM1/EM1 Economizer/Damper Motor Honeywell/Conventional DT1 Discharge Temp. Sensor, Units with CP1 (W973B) Solid-state DT1 Discharge Averaging Sensor Units w/dac1 (W7100) Discharge Air EC1 Enthalpy Control (Electronic) All Types EC1 Enthalpy Control (Electromechanical) All Types EC1 Knob for Enthalpy Control All Types FPS Floating Pressure Switch All Types FS1 Low Limit Freezestat, Thermostat All Types PC3 Pressure Control, Clogged Filter Switch All Types PCB Printed Circuit Board. Units w/electronic Pressure All Types Control (EPC) PTC1 Proportional Temp. Control, Economizer Mixed Air Conventional SD1 Smoke Detector Control, Return Air All Types prior to 9/ SD2 Smoke Detector Control, Supply Air All Types prior to 9/ SD1 Smoke Detector Control, Return Air All Types after 9/ SD2 Smoke Detector Control, Supply Air All Types after 9/ SPS1- Static Pressure Sensor Units with Electronic All Types SPS6 Pressure Control (EPC) TC4 Thermostat Control, Firestat 125 o All Types TC10 Thermostat Control, Morning Warm-up All Types VM1, Valve Motor, Modulating with Spring Return. Solid-state Units with Steam Heat VM2 Valve Motor, Modulating with Spring Return. Solid-state (Not Units with Cooling or Hot Water Heating Coil. Shown) Transformer for VM1, VM2 Solid-state Valve Motor, Modulating with Spring Return. Discharge Air RWS Units with W7100D Control Only. * Schematic symbols appear on unit wiring diagrams and components are marked with them at time of manufacture. NOTES: There are three types of optional control systems; A) Discharge Air Control - Units with Honeywell W7100 (DAC 10). B) Solid-state Control - Units with Honeywell W973B (CP1). C) Conventional Control - Units less W7100 (DAC1) and W973B (CP1). Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 55

56 Electric Heat Control Panel Note: Figure depicts all optional components. Various combinations of parts shown occur according to heater voltage, total heater wattage, and unit size. Schematic* Symbol Part SR1, 2, 3, 4 Electric Sequencer, Time Delay, 24VAC Coil R28, 29, 30 Relay, Control, SPDT, 120 VAC Coil T4, 5 Transformer, Control, 120 V/60 Hz, Primary, 25 V Secondary * NOTE: Schematic symbols appear on unit wiring diagrams and components are marked with them at time of manufacture. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 56

57 Electric Heat Power Panel Diagram & Components Note: Figure depicts highest heater wattage application, various combinations of parts shown occur according to total heater wattage and unit size. Fuses & Fuseblocks Contactors Schematic* Symbol CONTACTORS M24, 25, 26,27 All 3 Pole, VAC Coil 600 Volts FUSE BLOCKS FB24, 25, 26, Fuse, 3 Pole Volt FUSES Heater Voltage Fuse, 3 Pole Volt FB24, 25, 26, Cartridge Dual Element Volt Cartridge Dual Element Volt HEATER LIMIT, LINEAR (NOT SHOWN) HL13, 14, 15, 16 All High Limit, Thermostat, Opens at o F, 66 Long Capillary *Schematic symbols appear on unit wiring diagrams. Rating Part Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 57

58 Electric Heat Power Panel Components - All Sizes Schematic* Symbol CIRCUIT BREAKER DS1 Total Heater Kilowatts Heater Voltage RPS/RFS- 018B, 020B, 025B, 030B, 036B, 040B Part 20, 40, 60, / Amp, 600 Volt, 3 Pole , 40, 60, / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole , 140, / Amp, 600 Volt, 3 Pole , 140, / Amp, 600 Volt, 3 Pole , / Amp, 600 Volt, 3 Pole , / Amp, 600 Volt, 3 Pole ALL ALL Handle, for all circuit breakers RPS/RFS- 041B, 051B, 060B, 070B 30, 60, 90, / Amp, 600 Volt, 3 Pole , 60, 90, / Amp, 600 Volt, 3 Pole , / Amp, 600 Volt, 3 Pole , / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole , 300, / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole ALL ALL Handle, for all circuit breakers RPS/RFS- 061B, 071B, 080B, 081B 40, 80, 120, / Amp, 600 Volt, 3 Pole , 80, 120, / Amp, 600 Volt, 3 Pole , 240, 280, / Amp, 600 Volt, 3 Pole , 240, 280, / Amp, 600 Volt, 3 Pole , 400, 440, / Amp, 600 Volt, 3 Pole ALL ALL Handle, for all circuit breakers * NOTE: Schematic symbols appear on unit wiring diagrams and components are marked with them at time of manufacture. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 58

59 Electric Heat Power Panel Components - All Sizes, Continued Schematic* Symbol Total Heater Kilowatts Heater Voltage Part CIRCUIT BREAKER RPS/RFS-090B DS Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole ALL ALL Handle, for all circuit breakers * NOTE: Schematic symbols appear on unit wiring diagrams and components are marked with them at time of manufacture. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 59

60 Electric Heat Power Panel Components - All Sizes, Continued Schematic* Total Heater Symbol Kilowatts CIRCUIT BREAKER DS1 RPS/RFS-100B Heater Voltage Part 40, / Amp, 600 Volt, 3 Pole , / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole , / Amp, 600 Volt, 3 Pole ALL ALL Handle, for all circuit breakers RHS/RWS-800B, 802B 20, / Amp, 600 Volt, 3 Pole , / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole ALL ALL Handle, for all circuit breakers * NOTE: Schematic symbols appear on unit wiring diagrams and components are marked with them at time of manufacture. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 60

61 Electric Heat Power Panel Components - All Sizes, Continued Schematic* Total Heater Symbol Kilowatts CIRCUIT BREAKERS RHS/RWS-804B DS1 Heater Voltage Part / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole ALL ALL Handle, for all circuit breakers RHS/RWS-806B, 808B / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole / Amp, 600 Volt, 3 Pole , / Amp, 600 Volt, 3 Pole , / Amp, 600 Volt, 3 Pole , / Amp, 600 Volt, 3 Pole , / Amp, 600 Volt, 3 Pole ALL ALL Handle, for all circuit breakers * NOTE: Schematic symbols appear on unit wiring diagrams and components are marked with them at time of manufacture. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 61

62 Electric Heater Hi-Limit, Disc Type All Sizes Heater, Hi-Limit Control included with heater Heater Individual Heater Modual Kilowatts Voltage Part ELECTRIC HEATERS / / / / / / / / HEATER HI-LIMIT, DISC TYPE ALL ALL Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 62

63 Gas Burner Section Forced Draft Burner (FDB Vintage A) 1 Gas Burner Final Assembly Diagrams - All Sizes Front View Rear View Gas Burner Final Assembly 1 NOTE: Later Single Stage Burner equipped units used a slightly different assembly. Many of the parts are shared between the FDB and Single Stage Burner Assemblies, but for proper part identification it is important to determine which assembly was installed. If unsure as to which assembly is installed, contact Daikin Applied with model and serial number information and a picture of the burner assembly (if possible) so that the correct part(s) can be identified. Applied Rooftop; R*S Series / Vintage B Rev. AC 06/16 RPL / Page 63