T H QL Recommendations based on standard conditions. Installation must conform to all local and national codes.

Transcription

1 Catalog Number System For illustrative purposes only. Circuit Breaker Selection Guide T H QL 5 GE Identification Interrupting Rating Type Poles Voltage mpere Rating Insert for Specials H = 0kIC QL = Plug-in = 20/240Vac GF = pole HH = 22kIC QP = 2 Plug-In 2 = 240V GFCI = 65kIC QB = Bolt-on Omit for THQP GF = 2-pole breakers GFCI (all 20/240Vac) F = FCI Recommendations based on standard conditions. Installation must conform to all local and national codes. pplication Selection Recommended Circuit Breaker ppliance verage Watts Volts mps Wire Size 2-inch -inch ir Conditioner Up to,000 BTU #2 THQP20 THQL20 Up to 23,000 BTU #2 THQP220 THQL220 Up to 30,000 BTU #0 THQP230 THQL230 ttic Fan Up to 2 HP #4 THQP5 THQL5 Up to HP #2 THQP20 THQL20 Bathroom or Outdoor Receptacles #4 THQL5GF #2 THQL20GF Bedroom Receptacles (for maximum #4 THQL5F safety; required by 2002 NEC) #2 THQL20F Branch Circuits (Indoor Receptacles) #4 THQP5 THQL #2 THQP20 THQL20 Clothes ryer #0 THQP230 THQL230 ishwasher #2 THQP20 THQL20 oorbell Transformer #4 THQP5 THQL5 Electric Heater #2 THQP20 THQL20 Electric Range #6 THQP250 THQL250 Electric Welder (240V; over 0 away) #6 THQP250 THQL250 Fixed Lighting #4 THQP5 THQL5 Garbage isposal #4 THQP20 THQL20 Hot Tub or Spa #8 THQL240GF #8 THQL250GF Hot Water Heater #0 THQP230 THQL230 Motors (Single Phase) Up to 2 HP #4 THQP5 THQL5 2 to HP #2 THQP20 THQL20 to 2 HP #4 THQP25 THQL25 2 to 3 HP #0 THQP230 THQL230 Refrigerator or Freezer #4 THQP5 THQL5 Sump Pump Up to 2 HP #4 THQP5 THQL5 2 to HP #2 THQP20 THQL20 [ RELIBILITY N ECONOMY. ] Q Line Circuit Breakers 5 Washing Machine #4 THQP5 THQL5 Well Pump Up to 2 HP #2 THQP20 THQL #4 THQP25 THQL25 2 to HP #0 THQP30 THQL #2 THQP220 THQL #8 THQP240 THQL240 Special Safety Circuit Protection Products Included among GE s circuit protection products are several that add the extra measure of safety that is increasingly important to today s new home buyers and remodelers. See page 8 for details. Safety Need Safety Solution mp Rating Ground fault protection for circuits supplying power to outdoor, bathroom, kitchen, garage and spa area receptacles. GFCIs (ground fault circuit interrupters) 5-50 Maximum protection against fires through detection and interruption of arcing caused by damaged wire insulation or extension cords. The 2002 NEC FCIs (arc fault will require this protection in bedroom circuits. circuit interrupters) 5-20 Whole house protection of sensitive electronic equipment computers, fax machines, televisions, stereos, VCRs from electrical surges. Surge arrester N

2 H I G H E R Q U L I T Y. L O W E R I N S T L L E C O S T. H I G H E R Q U L I T Y. L O W E R I N S T L L E C O S T [ HIGHER QULITY. LOWER INSTLLE COST.] PowerMark Gold Load Centers 0 Packaging features comprehensive selection and application data. Fronts are packed in inner cartons for added protection during shipment and at the job site. complete family of meter socket load centers ring style and ringless, wide and narrow, meter mains, farm panels and more deliver specialized solutions for special situations. Main lug load centers offer an economical solution for subpanels and similar applications. ll main lug units 25 and above convert easily to main breaker. GE s residential load centers reach into commercial applications as well, with riser panels, auxiliary gutters, three-phase units with standard 22kIC ratings, and all the accessories needed to complete the job. ll PowerMark Gold load centers are designed and built for faster installation and more dependable performance. One-piece interior removes and reinstalls easily. Full-length neutrals are easier to wire, reducing installation time and cost. Minimum 00% neutral terminations. Sturdy copper bus and galvanized box increase durability and reliability. Combination slotted/robertson screws speed wiring. ll holes are rated for 4-4 wire. 00% rated split neutral on each side. Load centers accept Q Line circuit breakers, including GE s exclusive 2 THQPs. The PowerMark Gold line includes a wide range of outdoor as well as indoor units. ccessories & Options oor lock & handle Equipment ground kits Sub-feed & feedthru lugs Front filler plates Handle lock & ties Hardware kits Main breaker retainers Neutral kits Universal raintight hubs

3 Catalog Number System For illustrative purposes only. Load Center Selection Guide Main Breaker Load Centers Max. Branch Main mp Breaker Rating (mps) Rating THQL 2 THQP Total -pole Base Cu l -pole 2-pole -pole 2-pole Spaces Suffix 2 Suffix TM860 F,S CUGEN TM20 C,R CU TM200 C,R CU TM320 C CU TM242 C,R CU TM22 C,R CU TM62 C CU TM85 R CUFL TM245 C,R CU TM325 C,R CU TM65 C,R CU TM820 R CUFL TM620 C CU TM2020 C,R CU TM3220 C,R CU TM4020 C,R CU Convertible Load Centers Max. Branch Main mp Breaker Rating (mps) Rating THQL 2 THQP Total -pole Base Cu l -pole 2-pole -pole 2-pole Spaces Suffix 2 Suffix TLM62 S,F CU, TLM82 S,F CU, TLM242 C,R CU TLM22 C,R CU TLM62 C CU TLM205 C CU TLM245 C,R CU TLM620 C,R CU TLM2020 C,R CU TLM3220 C CU TLM4020 C,R CU Main Lug Load Centers Max. Branch Main mp Breaker Rating (mps) Rating THQL 2 THQP Total -pole Base Cu l -pole 2-pole -pole 2-pole Spaces Suffix 2 Suffix TL240 C,R CU TL270 C,R CU T M C CU B GE Identification Type Maximum Number Insert for 3-phase, Bus mpere Rating Enclosure Type Insert for Insert for Specials of Spaces 4-wire Load Centers PowerMark Gold M = Main Breaker = 00 C = Combination Flush CU = Copper Bus G or T = Factory Installed L = Main Lug 2 = 25 and Surface, Indoor Ground Bar LM = Convertible 5 = 50 F = Flush B = Bottom Feed Main Breaker PL = Main Lug, 20 = 200 S = Surface FL = Factory installed Thermoplastic 22 = 225 R = Outdoor Feed-thru Lugs Enclosure 40 = 40 = Optional door for = 60 circuit indoor panels. (oors 70 = 70 are standard on all other units.) (For details on these and other load centers, see the selection tables on the following pages.) TPL42 C,R TL42 C, R [ HIGHER QULITY. LOWER INSTLLE COST. ] PowerMark Gold Load Centers Catalog number is constructed by adding Suffix and Suffix 2 to Base Catalog Number. 2 F = Flush mount indoor S = Surface mount C = Combination flush/surface mount indoor R, R = Outdoor 3 CU = Copper bus CUFL = Copper bus, feed-thru lugs CUGEN = Copper bus, generator panel with dual main circuit breakers = Optional door for 6- and 8-circuit indoor panels (door standard on outdoor panels)

4 S E L E C T I O N T B L E S. S E L E C T I O N T B L E S. S E L E C T I O N T B L E S. S E L E C T I O N T B L E S. [ SELECTION TBLES. ] PowerMark Gold & Plus Load Centers UL Listed (Panelboards No. 67) 60 C/75 C Conductor Rating Indoor Fronts Combination Surface/Flush Suitable for Use as Service Entrance Equipment When Installed in ccordance with the National Electrical Code 22kIC RMS Symmetrical, Except Where Noted Main Lug & Convertible Load Centers Single-phase, Three-wire, 20/240 Volts ac, Top Feed Factory Installed Main Lugs (TLM units convertible to main breaker) PowerMark Plus catalog numbers shown in italics 2 Equipment Indoor Type Enclosure23 Outdoor Type 3R Enclosure3 Main Main Wire Size Ground Kit mpere THQL Total Box No. Box No. WG/ kcmil Order Separately 2 THQP Rating -pole See See Cu-l See Page 6 p 2p p 2p Spaces Page 24 Page TL240SCU4 TL240RCU R 4-4 TGK TL270SCU4 TL270RCU R 6-3 TGK TL42C➄ 2 TL42R➅ R TGL TL42CT➄8 2 TL42RT➅ R TGL Installed TL42R2➅ RB -2/0 TGL TPL42C➄7 2 TPL42R➅7 R TGL TPL42CT➄ 2 TPL42RT➅8 R TGL Installed TLM62FCU, SCU0 3B, 3 TLM62RCU0 R2 TGK TLM82FCU, SCU90 3B, 3 TLM82RCU0 R2 TGK TLM22CCU 4 TLM22RCU R3 TGL TLM22CCUG 4 TGK24 Installed 6-2/ TLM62CCU 4 TGK2 or TGK TLM242CCU 7 TLM242RCU R4 TGK2 or TGK TLM205CCU 8 TGK32-3/0 (Cu) 2-3/0 (l) TLM245CCU 9 TLM245RCU R6 TGK24 or TGK TLM220RCU R5 TGK TLM620CCU 8 TLM620RCU R5 TGK TLM620CCUG 8 TGK32 Installed TLM2020CCU 9 TLM2020RCU R6-250 (Cu) 2/0-250 (l) TGK24 or TGK TLM2020CCUG 9 TGK42 Installed TLM3220CCU 2 TGK TLM4020CCU 3 TLM4020RCU R8 TGK TLM4222CCU 4 TLM4222RCU R8-300 (Cu) 2/0-300 (l) TGK TL2440F,S 6 TL2440R R9 (2) TGL2 (2) 2/ TL4240F,S 2 6 TL4240R 2 R9 (2) TGL TL4260F,S 2 7 TL4260R 2 R9 (2) (Cu) (2) (l) (2) TGL circuit devices UL Listed for bottom mounted lugs by installing complete unit (box, interior and front) upside down. For bottom feed door handle, see page amp single-phase devices have removable closing caps. Larger ampere devices require field-cut openings. Order hubs separately (see page 7). 3 TPL load center enclosures are thermoplastic; TL and TLM load center enclosures are galvanized steel. 4 No door. ➄ No door, 0kIC. 6 0 kic. 7 Maximum branch or main circuit breaker rating: 90 amp with Cu, 70 amp with l amp maximum branch capacity. 9 FCU indicates flush mount enclosure; SCU indicates surface mount enclosure. dd to catalog number for optional door (example: TLM62SCU). 0 For main breaker, order THQLRK2 retainer kit plus 2-pole circuit breaker. See page 7. For main breaker, order TQMH000. lso order 2-pole THQL, THHQL or TQL circuit breaker. See page 6. 2 Not suitable for use as service entrance equipment.

5 Main Breaker Load Centers Single-phase, Three-wire, 20/240 Volts ac, Top Feed Factory Installed Main Breaker PowerMark Plus catalog numbers shown in italics Equipment Indoor Type Enclosure Outdoor Type 3R Enclosure2 Main Main Wire Size Ground Kit mpere THQL Total Box No. Box No. WG/ kcmil Order Separately 2 THQP Rating -pole See See Cu-l See Page 6 p 2p p 2p Spaces Page 24 Page TM20CCU 4 TM20RCU R3 TGK2 or TGK TM20CCUG 4 TGK24 Installed TM200CCU 6 TM200RCU R4 4-/0 TGK TM320CCU TGK TM22CCU 4 TM22RCU R4 TGK2 or TGK TM22CCUG 4 TGK24 Installed TM62CCU 4-2/0 TGK2 or TGK TM62CCUG 4 TGK24 Installed TM242CCU 6 TGK TM85RCUFL R5 TGK TM65CCU 7 TM65RCU R5 TGK24 or TGK32-3/0 (Cu) TM65CCUG 7 TGK32 Installed 2-3/0 (l) TM245CCU 9 TM245RCU R6 TGK24 or TGK TM325CCU TM325RCU R7 TGK TM820RCUFL R5 TGK TM620CCU 8 TGK TM620CCUG 8 TGK32 Installed -250 (Cu) TM2020CCU 9 TM2020RCU R6 TGK24 or TGK42 2/0-250 (l) TM2020CCUG 9 TGK42 Installed TM3220CCU 2 TM3220RCU R7 TGK TM4020CCU 3 TM4020RCU R8 TGK TM4222CCU 4 TM4222RCU R8-300 (Cu) 2/0-300 (l) (2) TGL TM4230F,S 7 (2) TGL TM2440R R0 (2) 2/0-250 (2) TGL TM4240F,S 7 TM4240R R (2) TGL2 [ SELECTION TBLES. ] PowerMark Gold & Plus Load Centers amp devices available with main breaker bottom mounted at same list price. dd B suffix to catalog number, e.g., TM4240FB. UL Listed amp devices have removable closing cap. Larger ampere devices require field-cut openings. Order hubs separately. See page 7. Generator Panels Single-phase, Three-wire, 20/240 Volts ac, Top Feed Two Interlocked Main Breakers Factory Installed Equipment Main Main Wire Size Ground Kit mpere THQL Total Indoor Type Indoor Type Box No. Outdoor Box No. WG/ kcmil Order Separately 2 THQP Rating -pole Enclosure, Flush Enclosure, Surface See Type 3R See Cu-l See Page 6 p 2p p 2p Spaces Mount Mount Page 24 Enclosure Page TM860FCUGEN TM860SCUGEN 9 TM860RCUGEN R2 6- TGK2 Single phase, 2 interlocked 60 main breakers, 8 circuits max. Safety and convenience when using a generator 4,000 peak wattage,,520 continuous load, 48 amps at 240 volts Maintains power to such critical circuits as those for furnace, pump, refrigerator, lights Connected dual breaker mechanism ensures that only one source is active at a time Generator Panel

6 imensions (in inches) Box No. Width Height epth R R RB R R R R R R R R R R [ IMENSIONS N KNOCKOUTS. ] PowerMark Gold & Plus Load Centers Outdoor Enclosures Knockouts Symbol B C E F G H J K L M N P Q R S T U V W Y Z BB CC Conduit Size in Inches Mounting provided for universal Hubs HUB [ IMENSIONS N KNOCKOUTS. ] PowerMark Gold & Plus Load Centers W B W Box R W Box R2 G B Box R K 25 Q R K Q Q U R U Q H Box R3, R4, R5, R6, R7 J Box R8 B Box R9 Box R0, R