TABLE OF CONTENTS REYHQ16-24P

Transcription

1 Outdoor Units VRV HEAT RECOVERY REYHQ6-2P TABLE OF CONTENTS REYHQ6-2P Specifications Independent Unit Technical Specifications Electrical Specifications (50Hz) Electrical data Options Capacity tables Combination table Cooling capacity tables Heating capacity tables Capacity correction factor Dimensional drawing & centre of gravity Dimensional drawing Centre of gravity Piping diagram Wiring diagram Wiring diagram Sound data Sound pressure spectrum Sound power spectrum Installation Service space Fixation and foundation of units Refrigerant pipe selection Operation range VRV Systems Outdoor Units

2 i t t - r t Specifications Outdoor Units VRV HEAT RECOVERY REYHQ6-2P e s R mn P e U 2 as 6eoy Ho S Q d H V Y Ru E O RV - INDEPENDENT UNIT REYHQ6PYB REYHQ20PYB REYHQ22PYB REYHQ2PYB Outdoor Unit REMQ8P9YB REMQ8P9YB REMQ0P8YB REMHQ2P8YB REMQ8P9YB REMHQ2P8YB REMHQ2P8YB REMHQ2P8YB -2 TECHNICAL SPECIFICATIONS REYHQ6PYB REYHQ20PYB REYHQ22PYB REYHQ2PYB Capacity Cooling kw Heating kw COP Cooling Heating Capacity range HP Power input Cooling kw (nominal)(50hz ) Heating kw PED category Category II Max n of indoor units to be connected Indoor index Minimum connection Maximum Casing Colour Daikin White Material Painted galvanised steel Heat Dimensions Length mm,778 +,778, ,088, ,088 2, ,088 Exchanger Nr of Rows Fin Pitch mm Nr of Passes Face Area m² Nr of Stages Tube type Hi-XSS (8) Fin Fin type Non-symmetric waffle louvre Treatment Hydrophylic and anti corrosion resistant Fan Type Propeller Quantity 2 Air Flow Rate Cooling m³/min (nominal at 20V) cfm Fan External static pressure Pa 78 Pa in high static pressure Discharge direction Vertical Motor Quantity 2 Model Brushless DC Output motor W x50 2x50 + 2x50 Compressor Quantity 2 Motor Quantity Model Inverter Type Hermetically sealed scroll compressor Speed rpm 7, ,980 7, ,00 6,00 + 6,00 6,00 + 6,00 Motor kw Output Crankcas W e Heater Quantity + + Model ON - OFF ON - OFF ON - OFF Type Hermetically sealed scroll compressor Hermetically sealed scroll compressor Hermetically sealed scroll compressor Speed rpm 2,900 2, ,900 2, ,900 Motor kw Output Crankcas W e Heater Cooling Standard Min CDB VRV Systems Outdoor Units

3 Specifications Outdoor Units VRV HEAT RECOVERY REYHQ6-2P -2 TECHNICAL SPECIFICATIONS REYHQ6PYB REYHQ20PYB REYHQ22PYB REYHQ2PYB Operation Cooling Max CDB Range Heating Min CWB Max CWB Sound level Cooling Sound dba Power (Nominal) Sound Pressure (Nominal) dba Refrigerant Name R-0A Charge kg Control Expansion valve (electronic type) Nr of Circuits Refrigerant Oil Name Synthetic (ether) oil Charged Volume l Piping Liquid (OD) Type Braze connection connections Diameter (OD) mm Gas Type Braze connection Diameter (OD) mm Heat Insulation Both liquid and gas pipes Max total length m,000 Defrost Method Reversed cycle Defrost Control Sensor for outdoor heat exchanger temperature Capacity Control Method Inverter controlled Capacity Control ~ 00 Safety devices HPS Fan motor driver overload protector Over current relay Inverter overload protector PC board fuse Standard Standard Accessories Installation manual Accessories Quantity Standard Accessories Operation manual Quantity Standard Accessories Connection pipes Quantity Notes Nominal cooling capacities are based on : indoor temperature : 27 CDB, 9 CWB, outdoor temperature : 5 CDB, equivalent refrigerant piping : 7.5m, level difference : 0m. Nominal heating capacities are based on : indoor temperature : 20 CDB, outdoor temperature : 7 CDB, 6 CWB, equivalent refrigerant piping : 7.5m, level difference : 0m Sound pressure Sound values Sound values are measured in a semi-anechoic room. - ELECTRICAL SPECIFICATIONS (50HZ) REYHQ6PYB REYHQ20PYB REYHQ22PYB REYHQ2PYB Power Supply Name Y Phase N~ Frequency Hz Voltage V 80-5 VRV Systems Outdoor Units 2

4 Specifications Outdoor Units VRV HEAT RECOVERY REYHQ6-2P - ELECTRICAL SPECIFICATIONS (50HZ) REYHQ6PYB REYHQ20PYB REYHQ22PYB REYHQ2PYB Current Nominal running current (RLA) Cooling A Starting current (MSC) A Z-max Text Minimum Ssc value kva 2,6 2,2 2,02 2,228 Minimum circuit amps A (MCA) Maximum fuse amps (MFA) A Full load amps (FLA) A Voltage range Minimum V Maximum V Wiring connections Power Supply Intake Notes For Power Supply For connection with indoor Quantity Remark Earth wire include Quantity Remark F - F2 Both indoor and outdoor unit MFA is used to select the circuit breaker and the ground fault circuit interrupter (earth leakage circuit breaker) MSC means the maximum current during start up of the compressor Maximum allowable voltage range variation between phases is 2% RLA is based on following conditions : indoor temperature : 27 CDB/9 CWB, outdoor temperature : 5 CDB Select wire size based on the value of MCA or TOCA TOCA means the total value of each OC set Voltage range : units are suitable for use on electrical systems where voltage supplied to unit terminal is not below or above listed range limits In accordance with EN/IEC (), respectively EN/IEC (2), it may be necessary to consult the distribution network operator to ensure that the equipment is connected only to a supply with Zsys() <= Zmax, respectively Ssc() >= minimum Ss VRV Systems Outdoor Units

5 2 Electrical data Outdoor Units VRV HEAT RECOVERY REYHQ6-2P REYHQ-P Coombination of Minimum S sc value [kva] Z max [ ] REYHQ6P REMQ8P9 + REMQ8P REYHQ20P REMQ8P9 + REMQ2P8 22 0,27 REYHQ22P REMQ0P8 + REMHQ2P ,25 REYHQ2P REMHQ2P8 + REMHQ2P ,2 2 NOTES In accordance with EN/IEC (), respectively EN/IEC (2), it may be necessary to consult the distribution network operator to ensure that the equipment is connected only to a supply with Z () sys Z max, respectively S () sc minimum S sc value () 2 European/International technical standard setting the limits for voltage changes, voltage fluctuations and flicker in public low-voltage supply systems for equipment with rated 75A. (2) European/International technical standard setting the limits for harmonic currents produced by equipment connected to public lowvoltage system with input current 6A and 75A per phase. () Short-circuit power () System impedance. TW8-A VRV Systems Outdoor Units

6 Outdoor Units VRV HEAT RECOVERY REYHQ6-2P Options REYHQ-P Wind cover (See note 5) REYQ8~8P+REYHQ6,20,22,2P Multi combination of REMQ~6P+REMHQ2P Description REMQ8P9 REMQ0P8 REMQ2P9 REMHQ2P9 REMQ6P8 2-unit multi -unit multi REMQP8 Refnet header KHRQ2M29H o o o o o o o KHRQ2M6H - - o o o o o KHRQ2M75H o o Refnet joint KHRQ2M20T o o o o o o o KHRQ2M29T9 o o o o o o o KHRQ2M6T - - o o o o o KHRQ2M75T o o Ountdoor unit multipiping connection kit for H/R BHFQ2P o - BHFQ2P o Central drain pan kit KWC26C280 o o o - - See note See note KWC26C o o See note See note Digital pressure gauge kit (See note 2) BHGP26A o o o o o - - BS box for H/R BSVQ00P o o o o o o o BSVQ60P o o o o o o o BSVQ250P o o o o o o o Central BSVQ box (See note 6) BSVQ00P o o o o o o o Sound reduction kit for BSVQ box (See note ) EKBSVQLNP o o o o o o o Full set REMQ8-2 KPS26C280 o o o Full set REMQ-6 + REMHQ2 KPS26C o o - - Top/discharge for REMQ8-2 KPS26C280T o o o - - See note See note Top/discharge for REMQ-6 + REMHQ2 KPS26C50T o o See note See note Left/suction for REMQ8-6 + REMHQ KPS26C50L o o o o o See note See note Right/suction for REMQ8-6 + REMHQ KPS26C50R o o o o o See note See note Rear/suction REMQ8-2P KPS26C280B o o o - - See note See note Rear/suction REMQ-6 + REMHQ2 KPS26C50B o o See note See note TW29- NOTES All options are kits 2 Only option per installation is needed. Only available for standard BSVQ boxes (not possible for central BSVQ). Allows to reduce operating sound of BSVQ-box (requires sound kit per BSVQ-box) To be combined based on the outdoor multi connection table. 5 Only required for technical cooling (outdoor temp < -5 C). 6 Factory pre-assembly of xbsvq00p 5 VRV Systems Outdoor Units

7 Outdoor Units VRV HEAT RECOVERY REYHQ6-2P Capacity tables - Combination table REYHQ-P UNIT REMQ8P9 REMQ0P8 REMHQ2P8 REYHQ6P 2 REYHQ20P REYHQ22P REYHQ2P 2 TW8- VRV Systems Outdoor Units 6

8 Capacity tables - 2 Cooling capacity tables Outdoor Units VRV HEAT RECOVERY REYHQ6-2P REYHQ6P Combination (%) Capacity index Outdoor air temp. ( CDB) TC: Total Capacity: kw ; PI: Power Input: kw (compressor + outdoor fan motor) Indoor air temperature: CDB TC PI TC PI TC PI TC PI TC PI TC PI TC PI kw kw kw kw kw kw kw kw kw kw kw kw kw kw 0% % % % TW82- NOTES - ANMERKUNGEN - - NOTAS - REMARQUES - NOTE - OPMERKINGEN - - NOTLAR The above table shows the average value of conditions which may occur. Die obige Tabelle zeigt den Durchschnittswert der Bedingungen, die auftreten können.. La tabla de arriba muestra el valor medio de condiciones que pueden ocurrir. Le tableau ci-dessus donne la valeur moyenne pour des conditions qui peuvent survenir. La tabella in alto mostra il valore delle condizioni medie che si possono riscontrare. De tabel hierboven geeft de gemiddelde waarde aan van situaties die kunnen voorvallen.,. Yukarıdaki tablo meydana gelebilecek ko ulların ortalama de erini göstermektedir. 7 VRV Systems Outdoor Units

9 Outdoor Units VRV HEAT RECOVERY REYHQ6-2P Capacity tables - 2 Cooling capacity tables REYHQ6P Combination (%) Capacity index Outdoor air temp. ( CDB) TC: Total Capacity: kw ; PI: Power Input: kw (compressor + outdoor fan motor) Indoor air temperature: CDB TC PI TC PI TC PI TC PI TC PI TC PI TC PI kw kw kw kw kw kw kw kw kw kw kw kw kw kw 90% % % % % TW82- VRV Systems Outdoor Units 8

10 Capacity tables - 2 Cooling capacity tables Outdoor Units VRV HEAT RECOVERY REYHQ6-2P REYHQ20P Combination (%) Capacity index Outdoor air temp. ( CDB) TC: Total Capacity: kw ; PI: Power Input: kw (compressor + outdoor fan motor) Indoor air temperature: CDB TC PI TC PI TC PI TC PI TC PI TC PI TC PI kw kw kw kw kw kw kw kw kw kw kw kw kw kw 0% % % % TW82- NOTES - ANMERKUNGEN - - NOTAS - REMARQUES - NOTE - OPMERKINGEN - - NOTLAR The above table shows the average value of conditions which may occur. Die obige Tabelle zeigt den Durchschnittswert der Bedingungen, die auftreten können.. La tabla de arriba muestra el valor medio de condiciones que pueden ocurrir. Le tableau ci-dessus donne la valeur moyenne pour des conditions qui peuvent survenir. La tabella in alto mostra il valore delle condizioni medie che si possono riscontrare. De tabel hierboven geeft de gemiddelde waarde aan van situaties die kunnen voorvallen.,. Yukarıdaki tablo meydana gelebilecek ko ulların ortalama de erini göstermektedir. 9 VRV Systems Outdoor Units

11 Outdoor Units VRV HEAT RECOVERY REYHQ6-2P Capacity tables - 2 Cooling capacity tables REYHQ20P Combination (%) Capacity index Outdoor air temp. ( CDB) TC: Total Capacity: kw ; PI: Power Input: kw (compressor + outdoor fan motor) Indoor air temperature: CDB TC PI TC PI TC PI TC PI TC PI TC PI TC PI kw kw kw kw kw kw kw kw kw kw kw kw kw kw 90% % % % % TW82- VRV Systems Outdoor Units 0

12 Capacity tables - 2 Cooling capacity tables Outdoor Units VRV HEAT RECOVERY REYHQ6-2P REYHQ22P Combination (%) Capacity index Outdoor air temp. ( CDB) TC: Total Capacity: kw ; PI: Power Input: kw (compressor + outdoor fan motor) Indoor air temperature: CDB TC PI TC PI TC PI TC PI TC PI TC PI TC PI kw kw kw kw kw kw kw kw kw kw kw kw kw kw 0% % % % TW82- NOTES - ANMERKUNGEN - - NOTAS - REMARQUES - NOTE - OPMERKINGEN - - NOTLAR The above table shows the average value of conditions which may occur. Die obige Tabelle zeigt den Durchschnittswert der Bedingungen, die auftreten können.. La tabla de arriba muestra el valor medio de condiciones que pueden ocurrir. Le tableau ci-dessus donne la valeur moyenne pour des conditions qui peuvent survenir. La tabella in alto mostra il valore delle condizioni medie che si possono riscontrare. De tabel hierboven geeft de gemiddelde waarde aan van situaties die kunnen voorvallen.,. Yukarıdaki tablo meydana gelebilecek ko ulların ortalama de erini göstermektedir. VRV Systems Outdoor Units

13 Outdoor Units VRV HEAT RECOVERY REYHQ6-2P Capacity tables - 2 Cooling capacity tables REYHQ22P Combination (%) Capacity index Outdoor air temp. ( CDB) TC: Total Capacity: kw ; PI: Power Input: kw (compressor + outdoor fan motor) Indoor air temperature: CDB TC PI TC PI TC PI TC PI TC PI TC PI TC PI kw kw kw kw kw kw kw kw kw kw kw kw kw kw 90% % % % % TW82- VRV Systems Outdoor Units 2

14 Capacity tables - 2 Cooling capacity tables Outdoor Units VRV HEAT RECOVERY REYHQ6-2P REYHQ2P Combination (%) Capacity index Outdoor air temp. ( CDB) TC: Total Capacity: kw ; PI: Power Input: kw (compressor + outdoor fan motor) Indoor air temperature: CDB TC PI TC PI TC PI TC PI TC PI TC PI TC PI kw kw kw kw kw kw kw kw kw kw kw kw kw kw 0% % % % TW82- NOTES - ANMERKUNGEN - - NOTAS - REMARQUES - NOTE - OPMERKINGEN - - NOTLAR The above table shows the average value of conditions which may occur. Die obige Tabelle zeigt den Durchschnittswert der Bedingungen, die auftreten können.. La tabla de arriba muestra el valor medio de condiciones que pueden ocurrir. Le tableau ci-dessus donne la valeur moyenne pour des conditions qui peuvent survenir. La tabella in alto mostra il valore delle condizioni medie che si possono riscontrare. De tabel hierboven geeft de gemiddelde waarde aan van situaties die kunnen voorvallen.,. Yukarıdaki tablo meydana gelebilecek ko ulların ortalama de erini göstermektedir. VRV Systems Outdoor Units

15 Outdoor Units VRV HEAT RECOVERY REYHQ6-2P Capacity tables - 2 Cooling capacity tables REYHQ2P Combination (%) Capacity index Outdoor air temp. ( CDB) TC: Total Capacity: kw ; PI: Power Input: kw (compressor + outdoor fan motor) Indoor air temperature: CDB TC PI TC PI TC PI TC PI TC PI TC PI TC PI kw kw kw kw kw kw kw kw kw kw kw kw kw kw 90% % % % % TW82- VRV Systems Outdoor Units

16 Outdoor Units VRV HEAT RECOVERY REYHQ6-2P Capacity tables - Heating capacity tables REYHQ6P Combination (%) Capacity index Outdoor air temp. TC: Total Capacity: kw ; PI: Power Input: kw (compressor + outdoor fan motor) Indoor air temperature: CDB TC PI TC PI TC PI TC PI TC PI TC PI CDB CWB kw kw kw kw kw kw kw kw kw kw kw kw 0% % % % TW82- NOTES - ANMERKUNGEN - - NOTAS - REMARQUES - NOTE - OPMERKINGEN - - NOTLAR is shown as reference. When selecting the unit models, avoid the Outdoor air temperature range shown by. dient als Verweis. Vermeiden Sie bei der Auswahl der Gerätemodelle den als markierten Temperaturbereich der Außenluft H. k, se muestra como referencia. Cuando seleccione los modelos de unidad, evite el intervalo de temperaturas del aire exterior indicado mediante est montré comme référence.lors du choix des modèles d'unités, évitez la plage de températures de l'air extérieur illustré par valori riportati unicamente come riferimento. Nel selezionare i modelli delle unità, non considerare i valori di temperatura dell'aria esterna indicati con il colore is als referentie getoond. Wanneer modellen van eenheden worden gekozen, vermijd dan het bereik van buitenluchttemperaturen geïllustreerd door., referans olarak gösterilmektedir. Ünite modellerini seçerken, belirtilen Dı hava sıcaklı ı aralı ından kaçının 2 The above table shows the average value of conditions which may occur. Die obige Tabelle zeigt den Durchschnittswert der Bedingungen, die auftreten können.. La tabla de arriba muestra el valor medio de condiciones que pueden ocurrir. Le tableau ci-dessus donne la valeur moyenne pour des conditions qui peuvent survenir. La tabella in alto mostra il valore delle condizioni medie che si possono riscontrare. De tabel hierboven geeft de gemiddelde waarde aan van situaties die kunnen voorvallen.,. Yukarıdaki tablo meydana gelebilecek ko ulların ortalama de erini göstermektedir. 5 VRV Systems Outdoor Units

17 Outdoor Units VRV HEAT RECOVERY REYHQ6-2P Capacity tables - Heating capacity tables REYHQ6P Combination (%) Capacity index Outdoor air temp. TC: Total Capacity: kw ; PI: Power Input: kw (compressor + outdoor fan motor) Indoor air temperature: CDB TC PI TC PI TC PI TC PI TC PI TC PI CDB CWB kw kw kw kw kw kw kw kw kw kw kw kw 90% % % % % TW82- VRV Systems Outdoor Units 6

18 Outdoor Units VRV HEAT RECOVERY REYHQ6-2P Capacity tables - Heating capacity tables REYHQ20P Combination (%) Capacity index Outdoor air temp. TC: Total Capacity: kw ; PI: Power Input: kw (compressor + outdoor fan motor) Indoor air temperature: CDB TC PI TC PI TC PI TC PI TC PI TC PI CDB CWB kw kw kw kw kw kw kw kw kw kw kw kw 0% % % % TW82- NOTES - ANMERKUNGEN - - NOTAS - REMARQUES - NOTE - OPMERKINGEN - - NOTLAR is shown as reference. When selecting the unit models, avoid the Outdoor air temperature range shown by. dient als Verweis. Vermeiden Sie bei der Auswahl der Gerätemodelle den als markierten Temperaturbereich der Außenluft H. k, se muestra como referencia. Cuando seleccione los modelos de unidad, evite el intervalo de temperaturas del aire exterior indicado mediante est montré comme référence.lors du choix des modèles d'unités, évitez la plage de températures de l'air extérieur illustré par valori riportati unicamente come riferimento. Nel selezionare i modelli delle unità, non considerare i valori di temperatura dell'aria esterna indicati con il colore is als referentie getoond. Wanneer modellen van eenheden worden gekozen, vermijd dan het bereik van buitenluchttemperaturen geïllustreerd door., referans olarak gösterilmektedir. Ünite modellerini seçerken, belirtilen Dı hava sıcaklı ı aralı ından kaçının 2 The above table shows the average value of conditions which may occur. Die obige Tabelle zeigt den Durchschnittswert der Bedingungen, die auftreten können.. La tabla de arriba muestra el valor medio de condiciones que pueden ocurrir. Le tableau ci-dessus donne la valeur moyenne pour des conditions qui peuvent survenir. La tabella in alto mostra il valore delle condizioni medie che si possono riscontrare. De tabel hierboven geeft de gemiddelde waarde aan van situaties die kunnen voorvallen.,. Yukarıdaki tablo meydana gelebilecek ko ulların ortalama de erini göstermektedir. 7 VRV Systems Outdoor Units

19 Outdoor Units VRV HEAT RECOVERY REYHQ6-2P Capacity tables - Heating capacity tables REYHQ20P Combination (%) Capacity index Outdoor air temp. TC: Total Capacity: kw ; PI: Power Input: kw (compressor + outdoor fan motor) Indoor air temperature: CDB TC PI TC PI TC PI TC PI TC PI TC PI CDB CWB kw kw kw kw kw kw kw kw kw kw kw kw 90% % % % % TW82- VRV Systems Outdoor Units 8

20 Outdoor Units VRV HEAT RECOVERY REYHQ6-2P Capacity tables - Heating capacity tables REYHQ22P Combination (%) Capacity index Outdoor air temp. TC: Total Capacity: kw ; PI: Power Input: kw (compressor + outdoor fan motor) Indoor air temperature: CDB TC PI TC PI TC PI TC PI TC PI TC PI CDB CWB kw kw kw kw kw kw kw kw kw kw kw kw 0% % % % TW82- NOTES - ANMERKUNGEN - - NOTAS - REMARQUES - NOTE - OPMERKINGEN - - NOTLAR is shown as reference. When selecting the unit models, avoid the Outdoor air temperature range shown by. dient als Verweis. Vermeiden Sie bei der Auswahl der Gerätemodelle den als markierten Temperaturbereich der Außenluft H. k, se muestra como referencia. Cuando seleccione los modelos de unidad, evite el intervalo de temperaturas del aire exterior indicado mediante est montré comme référence.lors du choix des modèles d'unités, évitez la plage de températures de l'air extérieur illustré par valori riportati unicamente come riferimento. Nel selezionare i modelli delle unità, non considerare i valori di temperatura dell'aria esterna indicati con il colore is als referentie getoond. Wanneer modellen van eenheden worden gekozen, vermijd dan het bereik van buitenluchttemperaturen geïllustreerd door., referans olarak gösterilmektedir. Ünite modellerini seçerken, belirtilen Dı hava sıcaklı ı aralı ından kaçının 2 The above table shows the average value of conditions which may occur. Die obige Tabelle zeigt den Durchschnittswert der Bedingungen, die auftreten können.. La tabla de arriba muestra el valor medio de condiciones que pueden ocurrir. Le tableau ci-dessus donne la valeur moyenne pour des conditions qui peuvent survenir. La tabella in alto mostra il valore delle condizioni medie che si possono riscontrare. De tabel hierboven geeft de gemiddelde waarde aan van situaties die kunnen voorvallen.,. Yukarıdaki tablo meydana gelebilecek ko ulların ortalama de erini göstermektedir. 9 VRV Systems Outdoor Units

21 Outdoor Units VRV HEAT RECOVERY REYHQ6-2P Capacity tables - Heating capacity tables REYHQ22P Combination (%) Capacity index Outdoor air temp. TC: Total Capacity: kw ; PI: Power Input: kw (compressor + outdoor fan motor) Indoor air temperature: CDB TC PI TC PI TC PI TC PI TC PI TC PI CDB CWB kw kw kw kw kw kw kw kw kw kw kw kw 90% % % % % TW82- VRV Systems Outdoor Units 20

22 Outdoor Units VRV HEAT RECOVERY REYHQ6-2P Capacity tables - Heating capacity tables REYHQ2P Combination (%) Capacity index Outdoor air temp. TC: Total Capacity: kw ; PI: Power Input: kw (compressor + outdoor fan motor) Indoor air temperature: CDB TC PI TC PI TC PI TC PI TC PI TC PI CDB CWB kw kw kw kw kw kw kw kw kw kw kw kw 0% % % % TW82- NOTES - ANMERKUNGEN - - NOTAS - REMARQUES - NOTE - OPMERKINGEN - - NOTLAR is shown as reference. When selecting the unit models, avoid the Outdoor air temperature range shown by. dient als Verweis. Vermeiden Sie bei der Auswahl der Gerätemodelle den als markierten Temperaturbereich der Außenluft H. k, se muestra como referencia. Cuando seleccione los modelos de unidad, evite el intervalo de temperaturas del aire exterior indicado mediante est montré comme référence.lors du choix des modèles d'unités, évitez la plage de températures de l'air extérieur illustré par valori riportati unicamente come riferimento. Nel selezionare i modelli delle unità, non considerare i valori di temperatura dell'aria esterna indicati con il colore is als referentie getoond. Wanneer modellen van eenheden worden gekozen, vermijd dan het bereik van buitenluchttemperaturen geïllustreerd door., referans olarak gösterilmektedir. Ünite modellerini seçerken, belirtilen Dı hava sıcaklı ı aralı ından kaçının 2 The above table shows the average value of conditions which may occur. Die obige Tabelle zeigt den Durchschnittswert der Bedingungen, die auftreten können.. La tabla de arriba muestra el valor medio de condiciones que pueden ocurrir. Le tableau ci-dessus donne la valeur moyenne pour des conditions qui peuvent survenir. La tabella in alto mostra il valore delle condizioni medie che si possono riscontrare. De tabel hierboven geeft de gemiddelde waarde aan van situaties die kunnen voorvallen.,. Yukarıdaki tablo meydana gelebilecek ko ulların ortalama de erini göstermektedir. 2 VRV Systems Outdoor Units

23 Outdoor Units VRV HEAT RECOVERY REYHQ6-2P Capacity tables - Heating capacity tables REYHQ2P Combination (%) Capacity index Outdoor air temp. TC: Total Capacity: kw ; PI: Power Input: kw (compressor + outdoor fan motor) Indoor air temperature: CDB TC PI TC PI TC PI TC PI TC PI TC PI CDB CWB kw kw kw kw kw kw kw kw kw kw kw kw 90% % % % % TW82- VRV Systems Outdoor Units 22

24 Capacity tables - Capacity correction factor REYHQ6P Outdoor Units VRV HEAT RECOVERY REYHQ6-2P Rate of change in cooling capacity Rate of change in heating capacity NOTES D0588A These figures illustrate the rate of change in capacity of a standard indoor unit system at maximum load (with the thermostat set to maximum) under standard conditions. Moreover, under partial load conditions there is only a minor deviation from the rate of change in capacity shown in the above figures. 2 With this outdoor unit, evaporating pressure constant control when cooling, and condensing pressure constant control when heating is carried out. Method of calculating A/C (cooling / heating) capacity: The maximum A/C capacity of the system will be either the total A/C capacity of the indoor units obtained from capacity characteristic table or the maximum A/C capacity of outdoor units as mentioned below, whichever smaller. Calculating A/C capacity of outdoor units Condition: Indoor unit combination ratio does not exceed 00% Maximum A./C capacity of outdoor units = A/C capacity of outdoor units obtained from performance characteristics table at the 00% combination x capacity change rate due to piping length to the farthest indoor unit Condition: Indoor unit combination ratio exceeds 00% Maximum A./C capacity of outdoor units = A/C capacity of outdoor units obtained from capacity characteristics table at the combination x capacity change rate due to piping length to the farthest indoor unit When overall equivalent pipe length is 90m or more, the diameter of the main liquid pipes (outdoor unit-branch sections) must be increased. When level difference is 50m or more, the diameter of the main gas and liquid pipes (outdoor unit-brach sections) must be increased. [Diameter of above case] Model Liquid REYQ6P9YB Ø5.9 *If available on the site, use this size. Otherwise, not increased. 5 When the main sections of the interunit liquid pipe diameters are increased the overall equivalent length should be calculated as follows. (Heating only) Overall equivalent length = Equivalent length to main pipe x Correction factor + Equivalent length after branching Choose a correction factor from the following table. Example in case of REYQ8PY Equivalent lenght Equivalent lenght Outdoor unit Liquid pipe: Standard size Branch BS-unit Indoor unit In the above case (Heating) Overall equivalent length = 80m x m = 6m The correction factor in capacity when Hp=0m is thus approximately.0 6 In combination wich does not include cooling onlyindoor unit. Calculate the equivalent length pipe by the following when you calculate cooling capacity Overall equivalent length = Equivalent length to main pipe x Equivalent length after branching Example Equivalent lenght Equivalent lenght Outdoor unit Branch BS-unit Indoor unit In the above case (Cooling) Overall equivalent length = 80m x m = 80m The correction factor in capacity when Hp=0m is thus approximately 0.88 EXPLANATION OF SYMBOLS H p : Level difference (m) between indoor and outdoor units where indoor unit in inferior position H M : Level difference (m) between indoor and outdoor units where indoor unit in superior position L : Equivalent pipe length (m) α : Rate of change in cooling / heating capacity [Diameter of pipe (standard size)] Model Liquid REYQ6P9YB Ø2.7 2 VRV Systems Outdoor Units

25 Outdoor Units VRV HEAT RECOVERY REYHQ6-2P Capacity tables - Capacity correction factor J J VRV Systems Outdoor Units 2

26 Capacity tables - Capacity correction factor REYHQ22P Outdoor Units VRV HEAT RECOVERY REYHQ6-2P Rate of change in cooling capacity Rate of change in heating capacity NOTES D0579B These figures illustrate the rate of change in capacity of a standard indoor unit system at maximum load (with the thermostat set to maximum) under standard conditions. Moreover, under partial load conditions there is only a minor deviation from the rate of change in capacity shown in the above figures. 2 With this outdoor unit, evaporating pressure constant control when cooling, and condensing pressure constant control when heating is carried out. Method of calculating A/C (cooling / heating) capacity: The maximum A/C capacity of the system will be either the total A/C capacity of the indoor units obtained from capacity characteristic table or the maximum A/C capacity of outdoor units as mentioned below, whichever smaller. Calculating A/C capacity of outdoor units Condition: Indoor unit combination ratio does not exceed 00% Maximum A./C capacity of outdoor units = A/C capacity of outdoor units obtained from performance characteristics table at the 00% combination x capacity change rate due to piping length to the farthest indoor unit Condition: Indoor unit combination ratio exceeds 00% Maximum A./C capacity of outdoor units = A/C capacity of outdoor units obtained from capacity characteristics table at the combination x capacity change rate due to piping length to the farthest indoor unit When overall equivalent pipe length is 90m or more, the diameter of the main liquid pipes (outdoor unit-branch sections) must be increased. When level difference is 50m or more, the diameter of the main gas and liquid pipes (outdoor unit-brach sections) must be increased. [Diameter of above case] Model Liquid REYQ8P9YB Ø2.7 REYQ22P8YB Ø9. *If available on the site, use this size. Otherwise, not increased. 5 When the main sections of the interunit liquid pipe diameters are increased the overall equivalent length should be calculated as follows. (Heating only) Overall equivalent length = Equivalent length to main pipe x Correction factor + Equivalent length after branching Choose a correction factor from the following table. Model Correction factor REYQ8P9YB 0.2 REYQ22P8YB 0. Example in case of REYQ22P8YB Equivalent lenght Equivalent lenght Outdoor unit Liquid pipe: Standard size Branch BS-unit Indoor unit In the above case (Heating) Overall equivalent length = 80m x m = 6m The correction factor in capacity when Hp=0m is thus approximately.0 6 In combination wich does not include cooling onlyindoor unit. Calculate the equivalent length pipe by the following when you calculate cooling capacity Overall equivalent length = Equivalent length to main pipe x Equivalent length after branching Example Equivalent lenght Equivalent lenght Outdoor unit Branch BS-unit Indoor unit In the above case (Cooling) Overall equivalent length = 80m x m = 80m The correction factor in capacity when Hp=0m is thus approximately 0.88 EXPLANATION OF SYMBOLS H p : Level difference (m) between indoor and outdoor units where indoor unit in inferior position H M : Level difference (m) between indoor and outdoor units where indoor unit in superior position L : Equivalent pipe length (m) α : Rate of change in cooling / heating capacity [Diameter of pipe (standard size)] Model Liquid REYQ8P9YB Ø9.5 REYQ22P8YB Ø VRV Systems Outdoor Units

27 Outdoor Units VRV HEAT RECOVERY REYHQ6-2P Capacity tables - Capacity correction factor H H B J H B J VRV Systems Outdoor Units 26

28 Outdoor Units VRV HEAT RECOVERY REYHQ6-2P 5 Dimensional drawing & centre of gravity 5 - Dimensional drawing REMHQ2P8 5 (Pitch of foundation bolt holes) (Pitch of foundation bolt holes) -5 x 22.5-mm-Oblong holes (foundation bolt hole) (DETAIL FOR FRONT SIDE) (knock-out hole) (knock-out hole) (knock-out hole) (DETAIL FOR BOTTOM SIDE) (knock-out hole): pressure equalizer pipe only. NOTES No. Parts name Remarks For piping connection method (front and bottom sides) see Pressure equalizer pipe 9. Brazing connection. the installation manual. connection port. See note 2 2 Piping connection diameter for field connection. (knock-out hole) shows the dimensions after fixing the accesory pipes. (knock-out hole) 5 Grounding terminal inside of switch box (M8) 6 Power cord routing hole (side) 62 No. Parts name Remarks 7 Power cord routing hole (front) 5 Liquid pipe connection port. 2.7 Brazing connection. 8 Power cord routing hole (front) 27 See note 2 9 Power cord routing hole (bottom) Suction gas pipe connection port Brazing connection. 0 Wire routing hole (front) 27 See note 2 Pipe routing hole (front) See note. High and low pressure gas pipe 22.2 Brazing connection. 2 Pipe routing hole (bottom) See note. connection port See note Pipe routing hole (bottom) 50 See note. D057585A H 2P8 G 27 VRV Systems Outdoor Units

29 Outdoor Units VRV HEAT RECOVERY REYHQ6-2P 5 Dimensional drawing & centre of gravity 5-2 Centre of gravity REMHQ2P8 5 Center of foundation bolt hole Center of foundation bolt hole Center of foundation bolt hole Center of foundation bolt hole (SLOT) Center of foundation bolt hole (SLOT) D057578B VRV Systems Outdoor Units 28

30 6 Piping diagram Outdoor Units VRV HEAT RECOVERY REYHQ6-2P H 2P8 J 6 29 VRV Systems Outdoor Units

31 Outdoor Units VRV HEAT RECOVERY REYHQ6-2P 7 Wiring diagram 7 - Wiring diagram REMHQ2P9 POWER SUPPLY 2 HP 7 TO IN/D UNIT TO OUT/D UNIT TO MULTI UNIT Note 5 indoor (F)(F2) outdoor (F)(F2) outdoor (0)(02) Male connector: BLU Female connector: WHT MALE CONNECTOR: BLK FEMALE CONNECTOR: WHT Position in switch box Position of M~C,M,2F El. compo. box Front layer Detail of MC~MC Detail of MC~MC Male conn: RED Female conn: WHT Indoor unit Magnetic relay VR Diode bridge (AP) Power module (AP,A8P) AP: Main AP,A8P: Fan KR: K2M (AP) KR: Y5S (A5P) V2R Power module (AP) AP~A8P A2P: Noise filter A5P: Sub K2R: KM (AP) K2R: Y6S (A5P) XA~XA Connector (MF, M2F) AP: Inverter A6P,A7P: Current sensor KR: YS (AP) KR: Y2S (AP) X5A Connector (YE) KR~KR Push button switch K5R: YS (AP) K5R: (for option) (A5P) XM Terminal strip (Power supply) BS~BS5 (Mode, Set, Return, Test, Reset) K6R: Y7S (A5P) K7R: EHC (AP) XM Terminal strip (Control) (AP) C, C6, C66 Capacitor K8R: E2HC (AP) K9R: EHC (AP) YE Electronic expansion valve (Main) EHC~EHC Crankcase heater KR: YS (AP) Y2E Electronic expansion valve (Charge) FU, F2U Fuse (T,.5A, 250V) (AP) QRP Reverse phase detection circuit YE Electronic expansion valve (Subcool) FU Fuse (T,.5A, 250V) (A5P) R0 Resistor (current sensor) (AP,A8P) Solenoid valve FU Fuse (8A, DC650V) (AP,A8P) R50, R59 Resistor YS: RMTG Y2S: way valve (pipe) F5U Field fusef R90 Resistor (current sensor) YS~YS YS: way valve (H/E Gas) F00U Fuse (T, 6A, 250V) (A2P) R95 Resistor (current limiting) YS: RMTL Y5S: Hots gas Pilotlamp (service monitor -orange) Thermistor Y6S: EV bypass Y7S: RMTO HP~H8P [H2P] Prepare, Test Flickering RT: Air (AP) RT: H/E Deicer ZC~Z0C Noise filter (ferrite core) Malfunction detection Light up RT~R9T RT: Fin (AP) R5T: Sub cool H/E gas ZF Noise filter (with surge absorber) HAP Pilotlamp (service monitor - orange) R2T: H/E Gas R6T: Sub cool H/E liq RT~RT K: Magnetic relay K2: Magnetic contactor (MC) RT: MC Discharge R7T: H/E Liquid Connector for optional parts K~K K: Magnetic relay K: Magnetic contactor (MC) R2T: M2C Discharge R8T: Suction X7A Operation output (A5P) K2M, KM Magnetic contactor (M2C, MC) RT: MC Discharge R9T: Liquid X9A Power supply (ADAPTER) (A5P) LR Reactor SNPH Pressure sensor (High) MC~MC Motor (Compressor) SNPL Pressure sensor (Low) MF, M2F Motor (Fan) SPH~SPH Pressure switch (High) PS Switching power supply (AP, AP) SD Safety devices input QDI Earth leakage breaker TA Current sensor (A6P, A7P) Rear layer : Terminal Colors: BLK: Black PNK: Pink ORG: Orange : Field wiring RED: Red BRN: Brown BLU: Blue : Connector YLW: Yellow GRY: Grey : Terminal WHT: White GRN: Green : Protective eart (screw) 2TW296-A NOTES When using the option adaptor, refer to the installation manual 2 Refer to the installation manual, for connection wiring to indoor-outdoor transmission F - F2, outdoor transmission F - F2, outdoor-multi transmission Q - Q2 and on how to use BS~BS5 and DS, DS2 switch. Do not operate the unit by short-circuiting protection device SPH~SPH VRV Systems Outdoor Units 0

32 8 Sound data 8 - Sound pressure spectrum Outdoor Units VRV HEAT RECOVERY REYHQ6-2P H 2P8 REYHQ-P 8 Sound power and pressure high cop (cooling) UNIT Sound Power Sound Pressure [dba] [dba] REYHQ6P REYHQ20P 85 6 REYHQ22P 85 6 REYHQ2P TW87-5 NOTE Sound power level is an absolute value that a sound source generates. 2 Sound pressure level is a relative value, depending on the distance and acoustic environment. For more details, please refer to sound level drawings. Mentioned values are theoretical values based on sound results of individually installed units. Possible deviations for sound values due to variety of installation patterns are not taken into account. VRV Systems Outdoor Units

33 Outdoor Units VRV HEAT RECOVERY REYHQ6-2P 8 Sound data 8-2 Sound power spectrum H 2P8 8 VRV Systems Outdoor Units 2

34 9 Installation 9 - Service space Outdoor Units VRV HEAT RECOVERY REYHQ6-2P REYHQ2P8 9 For single unit installation For installation in rows For centralized group layout <Pattern > <Pattern > <Pattern > 00 or more 00 or more 00 or more 0 or more <Front> 0 or more 0 or more 20 or more <Front> 20 or more 0 or more 500 or more 500 or more 0 or more <Front> 600 or more 20 or more 00 or more 0 or more 0 or more <Front> 20 or more 0 or more 500 or more <Front> <Pattern 2> 00 or more <Pattern 2> 00 or more 0 or more <Front> 500 or more 20 or more 0 or more 0 or more 00 or more 20 or more 0 or more 50 or more <Front> 50 or more 500 or more 50 or more 00 or more <Front> 500 or more 00 or more 50 or more <Pattern > 00 or more Wall height unrestricted <Pattern > Wall height unrestricted <Pattern 2> 00 or more 00 or more <Front> 00 or more 200 or more 200 or more <Front> 00 or more 50 or more <Front> 500 or more 00 or more 50 or more 50 or more <Front> 500 or more 00 or more <Front> 50 or more 50 or more <Front> 500 or more 00 or more 50 or more 50 or more 00 or more 00 or more 50 or more <Unit:mm> <Front> <Suction side> NOTES D055M Height of walls in case of Patterns and 2 Front: 500mm Suction side: 500mm Side: Height unrestricted. Installation space to be shown in this drawing is based on the cooling operation at 5 degrees outdoor air temperature. when the design outdoor air temperature exceeds 5 degrees or the load exceeds maximum ability because of much generation load of heat in all outdoor unit, take the suction side space more broadly than the space to be shown in this drawing. 2 If the above wall heights are exceeded then h2/2 and h/2 should be added to the front and suction side service spaces respectively as shown in the figure on the right. When installing the units most appropriate pattern should be selected from those shown above in order to obtain the best fit in the space available always bearing in mind the need to leave enough space for a person to pass between units and wall and for the air circulate freely. (If more units are to be installed than are catered for in the above patterns your layout should take account of the possibility of short circuits.) The units should be installed to leave insufficient space at the front for the on site refrigerant piping work to be carried out comfortably. VRV Systems Outdoor Units