1965/72 FORD CAR CATALOG FINAL ISSUE. Master Parts and Accessories. Form FP 7635-A & B. Supersends All Previous Issues, Changes and Revisions

Transcription

1 1965/72 FORD CAR FINAL ISSUE Master Parts and Accessories CATALOG Form FP 7635-A & B Supersends All Previous Issues, Changes and Revisions May, 1975 FINAL ISSUE COPYRIGHT FORD MOTOR -- DEARBORN, MICHIGAN COMPANY

2 Copyright 2005, David E. LeBlanc, Woodbridge, Virginia All Rights Reserved. No part of this book may be used or reproduced in any manner whatsoever without written permission of David E. LeBlanc. For information write to Forel Publishing Company, LLC, 3999 Peregrine Ridge Ct., Woodbridge, VA Library of Congress Catalog Card Number: ISBN: Forel Publishing Company, LLC 3999 Peregrine Ridge Ct. Woodbridge, VA address: Website: Dedication To my sons, David and Michael Disclaimer Although every effort was made to ensure the accuracy of this book, no representations or warranties of any kind are made concerning the accuracy, completeness or suitability of the information, either expressed or implied. As a result, the information contained within this book should be used as general information only. The author and Forel Publishing Company, LLC shall have neither liability nor responsibility to any person or entity with respect to any loss or damage caused, or alleged to be caused, directly or indirectly by the information contained in this book. Further, the publisher and author are not engaged in rendering legal or other professional services. If legal, mechanical, electrical, or other expert assistance is required, the services of a competent professional should be sought.

3 Introduction Congratulations on purchasing the 1965/1972 Ford Car Master Parts and Accessory Catalog. If you are restoring a classic Ford car, this catalog will be an invaluable resource in determining the correct service part for your project. This Ford Car Master Parts Catalog contains replacement parts and accessories information for Ford, Fairlane/Torino, Mustang, Thunderbird, Bronco, Falcon, Maverick and Pinto for model years 1965 through 1972 for U.S. and Canadian built vehicles. Use the "Text" catalog (FP A) which contains the complete part number in conjunction with the Illustration" catalog (FP B) which contains the illustrations of all the parts. This product is reproduced from the original Ford Motor Company manuals used during the era. As a result of using the original authentic documents, some of the pages may have imperfections such as folds, lines, or off-center alignment of the pages. However, because this catalog has not been re-typed or re-written in any way, you can be assured that what you are reading is exactly how it appeared to Ford technicians of the era. Only the Main Menu pages are not part of the original catalog and are provided simply to help explain how to use this manual. How this Catalog is Organized With over 6000 pages of information in the Master Parts and Accessory Catalog, it is important to understand how the book is organized. The following information is provided as a more detailed explanation to what is found in the General Information sections of the Text and Illustration catalogs. Catalogs The Master Parts and Accessory Catalog is actually comprised of two separate catalogs: 1) a Text" catalog (FP A) which contains the complete part number and 2) an Illustration" catalog (FP-7635-B) which contains the exploded illustrations of all the parts. Both catalog volumes are used together to identify the correct part for a vehicle. Master Parts and Accessory Catalog Text Catalog (FP-7635-A) o Chassis Group Section 10 Index Part Numbers Section 20 etc. thru Section 190 o Body Group Section 100 Section 200 etc. thru Section 600 Illustration Catalog (FP-7635-B) o Chassis Group Section 10 Index Illustrations Section 20 etc. thru Section 190 o Body Group Section 100 Section 200 etc. thru Section 600 Groups There are two major groups within each catalog: Chassis Group and Body Group. The Chassis Group contains items such as the engine, transmission, brakes, rear axle, heater, springs, etc. The Body Group contains items

4 such as dash panel, doors, instrument panel, floor, rear seat, etc. Sections Both Chassis and Body Groups are then further divided into Sections which relate to a general category of parts. For example, Front Suspension components are in Section 30; Rear Axle is Section 40; etc. The applicable exploded illustrations for a component are generally contained in the corresponding section of the Illustration catalog. For example, if Front Suspension part numbers are in Section 30 of the Text Catalog, then the corresponding illustrations are generally found in Section 30 of the Illustration Catalog. In addition, a Section contains the group numbers (part numbers) for the entire group. That is, Section 20 would contain all numbers from Click on the bookmark on the left to link to the quick reference list of sections. Or, for a detailed list of sections go to page 4,5 or 6 of the Chassis General Information. Group Numbers (Chassis) Each Section is organized by the Group Number in sequential order. The Group Number should not be confused with the Chassis Group and Body Group which are simply categories of parts and not part numbers. As you will see later, the Group Number is an integral part of the basic part number and overall part number. The Section numbers are the leading numbers of the Group number. So, for example, if you are in Section 20, the first two Group Numbers will be 20, 21, 22, to 29. If you are in Section 150, the first three numbers will be 150, 151, 152, to 159. Following the first two (or three) numbers will be two additional numbers to uniquely identify the part. Therefore, the group number can quickly help determine which section of the catalog the part number can be found. For example, 2440 = Section 20 of the catalog because the first two digits 24 are between B450 = Section 20 of the catalog because the first two digits 24 (ignore the letter B) are between = Section 40 because 43 is between = Section 130 because 134 is between Expanded Numbers - Letters (A, B, C) may be included in the standard Group Number to make them expanded numbers. Letters were added to the group number to accommodate new part number into the system. For example, if Ford produced a new part or a variation to a part, they might assign a letter to the group number. If a letter is added to a group number, the expanded numbers will be considered to follow the same sequence as the regular basic numbers from which they are expanded and are arranged in Catalogs as follows. This would be the sequential order with expanded group numbers from Section 35 and 36: C A635 Group Number (Body) Body Group numbers contain two additional numbers to identify the body style. Therefore, the Body Type Code are the first two digits signify the body style (2 door sedan, 4 door sedan, etc). Body Type Codes are found on pages of the Chassis General Information.

5 Example: D0DZ A Body Type Code = 62 (Falcon, 2 door sedan) Group Number = (Vehicle Identification Retainer) On the right is the diagram from page 4 of the Chassis General Information section on how to decipher the Body Parts Group Numbering System: For a detailed list of Body Group Numbers, go to page 9 of the Chassis General Information. Note: Illustrations contain basic or group numbers only, therefore, it is necessary to refer to the basic or group within the "text" catalog for complete applicable part numbers How to Read Chassis and Body Part Numbers: Chassis parts and Body parts have two different formats, so it is important to understand the differences. Chassis Part Numbers: Chassis Parts have a four character prefix, a four or five digit basic part number, and a one-letter suffix. The first two numbers of the basic part number identify the section. Chassis part numbers range from 1001 to 19A998 Example: C5ZZ-5255-F (Exhaust "turn-down" tailpipe on ' V Non-GT Mustangs) First digit: Decade The first digit is a character entry relating to the decade of production. A = 1940's (often omitted) D = 1970's B = 1950's E = 1980's C = 1960's F = 1990's Second digit: Year The second digit is the last digit of the year of part introduction or revision. 5 = = = = = = = = 1972 Third digit: Model

6 The third digit is the model application. For example a part with a model code of B would generally apply to Bronco s. However, there are numerous examples where the model code is actually used for different models. For example, some of the Mustang Boss 429 parts have a C9AE prefix which corresponds to a 1969 Galaxie. Code Description Code Description A Ford (Generic) / Galaxie R Rotunda (Generic)( ) Ford of Europe (1970-up) B Bronco ( ) S Thunderbird C Remanufactured Parts ( ) D Falcon ( ) Maverick ( ) E Truck (Cab over Engine) ( ) T Bronco ( , Except ) U V Econoline/Club Wagon Van Lincoln F Foreign / Trans Am Racing W Cougar ( ) G Comet ( ) Montego ( ) X Truck (Short Highway) ( ) H Holman/Moody HiPo Part Y Meteor (Canada) ( ) J Industrial Z Mustang K Tilt Cab ( ) 2 Pinto ( ) L Lincoln 4 Comet ( ) M Mercury 6 Pantera ( ) Topaz (1984-up) N Tractor 7 Courier ( ) O Fairlane Torino ( ) 8 Capri (U.S. Parts) ( ) P Autolite (Later Motorcraft) 9 Turbine Engine Parts ( ) Fourth digit: Design Engineer Office The fourth digit is the design engineering office. The design office, as the name implies, was the office responsible for the design of the part. Some of the more common codes are: B=body, C=chassis and E=engine. Code A B C D E F H J L M N Design Engineering Office Light Truck Engineering Division Body and Electrical Product Division Chassis Overseas Product Engineering Engine General Parts/Electrical and Electronics Division Climate Control Autolite/Ford Parts & Service Division Industrial Engine Parts & Service Performance/Special Vehicle Operations Tractor Parts

7 P R S T U W X Y Z Auto Transmission Manual Transmission Light and Heavy Truck Special Order Parts Heavy Truck Engineering Special Vehicle Operations Axle and Driveshaft Emissions, Economy and Special Vehicle Engineering (also known as Muscle Car Parts) Lincoln/Mercury Service Parts Ford Service Parts Fifth thru Eighth (or ninth, or tenth) digit: Group Number (also referred to as the Basic Part Number) The fifth thru perhaps the tenth digit is the Group Number or the Basic Part Number. Example (Group numbered bolded for emphasis): C5ZZ-5255-F C8TZ-1A401-A (with an expanded basic part number) Last Digit or Suffix The last digit is usually a letter (A, B, C, etc.) and indicates a revision or change to a particular part. If the part did not change, the suffix is not used. The letter A=the first change, B=second change, etc. Body Part Numbers: Body part numbers are similar to Chassis part numbers with one exception, the group number or basic part number uses a seven digit number. The first two digits identify the body type (see pages of the Chassis General Instructions) and the last five numbers ("Body Group") identify the specific part within a general body area. A one to three-letter suffix may be used, usually to indicate color. Therefore, the first four characters of a body part number use the same format as the chassis part number (see Chassis Part Numbers above). Example #1: D0DZ A Body Type Code = 62 (Falcon, 2 door sedan) Group Number = (Vehicle Identification Retainer) Example#2: C6ZZ BAB Body Type Code = 65 (Mustang, 2 door hardtop) Group Number = (Instrument Panel, Black) Note: Example #2 is a Body Part number, but because it is an instrument panel pad, it is considered a Soft Trim item. Therefore, this item is NOT found in the body parts section. Instead, it is found in the Soft Trim Section. In this case, look under Soft Trim > 1966 > (page 47 of the Soft Trim section). Engineering or Casting Numbers Service Part numbers differ from Engineering or Casting numbers. Part numbers were used for

8 servicing, ordering and inventory purposes and were marked on parts boxes, tags, and labels attached to the part. Engineering or casting numbers were normally stamped or cast into the part itself for identification during the manufacturing process. Engineering or Casting numbers are not interchangeable with Service Part Numbers. The Ford Car Master Parts and Accessory Catalog contains Service Part Numbers but does provide some cross references to engineering numbers. A service part may differ from a part installed during the production of a vehicle, however, the service part is what Ford would use to repair or replace it during servicing. Right Hand and Left Hand Parts The driver's side is the left hand side of the vehicle and determines whether such parts as fenders, lamps, etc. are right or left hand, Most Right Hand and Left Hand parts are listed in the manner shown in the following examples. The model application pertaining to the Right Hand part also pertains to the Left Hand part. EXAMPLE #1 - Right Hand and Left Hand on separate lines EXAMPLE #2 - Right Hand and Left Hand implied by quantity EXAMPLE 3 - Right Hand and Left Hand in adjacent columns

9 How to Find Part Numbers in this Manual There are generally three methods to finding part numbers: Method #1 - By Part Name Method #2 - By Illustration Method #3 - By Identification Number Before beginning a search for a part number, you must have a few pieces of information about the vehicle: year, model (i.e. car line code). The warranty plate on vehicles provides most of the information needed (see page of the Chassis, General Information). For example: suppose you want to locate a part number for a 1971 Thunderbird rear brake backing plate. The year is 1971 and car line code is S. Knowing this information will allow you to begin your search for the rear brake backing plate. Method #1 - By Part Name: Step #1 Because the Plate (rear brake backing) is a chassis part, begin with the Index in the Chassis Parts Group.

10 Step #2 Click on the alphabetical index under the letter P for the word plate. Under the letter P in the index, scroll through the entries until locating Plate (rear brake backing). The group number listed is for the part is Step #3 With a group number of , this means the part number will be located in Section 20 of the Text Catalog because this section contains group numbers ranging from 2000 to Click on Section 20 Brake Systems

11 Step #4 Once in Section 20, you must locate the part number for group Because the group number is in the range, click on the bookmark (2200) to quickly locate the general area. Next, scroll down the page until locating group number (Note it is thought that either the example or the catalog itself contains an error because the group number is listed as but should be ) Now that you are in the correct group, locate the vehicle catalog code "S" (for Thunderbird). Find 1971 (71) in the "YEAR" column. The part numbers shown are C7AZ E for right hand and C7AZ 2212-E for left hand.

12 Method #2 - By Illustration When searching for a part number By Illustration, it is assumed that the part name or description is unknown, but the general location on where the part is installed is known. In the example of the 71 Thunderbird, Plate (Rear Brake Backing), it is assumed that you know the part is a brake component. Therefore, the search begins in the Illustration Catalog in Section 20 Brake Systems. Step #1 Refer to the Illustration Catalog using the bookmark Section 20 Brake Systems. " Step #2 Refer to the index within the section. In this example, Ford did not create a separate index for Section 20. Generally, each section has its own index but in a few sections the indexes were consolidated. So, under the index bookmark you are directed to where the brake illustration index is located, in Section 10.

13 Step #2 Cont. Unlike the Text Catalog where the index is alphabetical, the Illustration Catalog indexes are by model year (1965, 1966, etc). Therefore, for our example of a 1971 Thunderbird, click on the index for Within the 1971 model year, find the car line code S for a Thunderbird. Knowing that the part is a brake component, look under "BRAKES" to find the general area where the part might be illustrated. In this case the "Brake details (drum rear)" illustration for the 1971 Thunderbird is a good starting point. The illustration information (enlarged) for the Brake details drum rear is found in Section 20.1 on page 4. The Illustration number is P Step #3 Now that you know the Illustration section and Illustration number, simply return to the Illustration Section 20, then to Sec 20.1 and scroll to page four (4). Or, use the By Diagram Number listing and click on P3380.

14 Step #4 Because you knew what the part looked like, but did not know the name, locate the part on the illustration. Each part has a group number. In this case, Note: Illustrations contain basic or group numbers only, therefore, it is necessary to refer to the basic or group within the "text" catalog for complete applicable part numbers Step #5 Because illustrations only contain basic or group numbers, simply go to the same Section number in the Text Catalog (i.e. Section 22) and locate the part number in the same way described in Method #1. Refer to group number in this Text Catalog and locate vehicle catalog code "S" (for Thunderbird). Find 1971 (71) in the "YEAR" column. The part numbers shown are C7AZ 2211-E for right hand and C7AZ 2212-E for left hand

15 Method #3 - By Identification Number Certain parts and most major assemblies are identified with an identification number (sometimes an engineering or casting number) shown on an attached tag or plate or on the part itself. Reference to identification numbers is made throughout the catalog and cross reference charts are included in some sections to provide immediate knowledge of the service part number when the identification number is known. For example, on page 4 of Section 40 Rear Axles, Drive Shafts contains information about Identification Tags for a Rear Axle. Using the ID will provide valuable information. For example, a WDL-W-1 for a 66/69 was 3.00 with a 28 spline shaft. The ID code is also useful in determining the correct part number as shown in this example.

16 How to Use Bookmarks Bookmarks are provided to help navigate through the thousands of pages of part numbers and illustration. Bookmarks themselves are a feature of Adobe Reader and are located on the left margin of each page. Clicking on a bookmark will quickly take you to a specific location within the catalog. The Main Menu contains bookmarks to each major section of the catalog and as such, allows you to go anywhere in the catalog. This is important, because while in a specific section (for example Section 10), only Section 10 pages are visible. If you need to view pages in Section 20 or Section 50, you will need to return to the Main Menu. To allow rapid access to the Main Menu a bookmark is provided at the top of each section. In addition, each section generally contains bookmarks for an index (expandable), group numbers, diagram numbers (illustration catalog only) and some cross reference links. Some cross reference links are provided to other catalog sections for ease of use. For example, in the Text Catalog, there is generally a link to the corresponding section in the Illustration Catalog. That is, if you are in Section 10 of the Text Catalog and want to quickly go to Section 10 of the Illustration Catalog, a bookmark is provided. And, conversely, a bookmark is provided in the Illustration Catalog to return to the Text Catalog.

17 Vehicle Catalog Codes Vehicle catalog codes are used throughout the catalog to identify a specific model. For example, X designates a Falcon produced before January Vehicles Catalog Codes Catalog Codes Bronco U A Ford Vehicles Falcon (before 1/70) X B Fairlane / Torino *Falcon Falcon (from 1/70) B F Mustang Fairlane / Torino B L Pinto Ford A P Maverick Maverick P S Thunderbird Mustang F U Bronco Pinto L X Falcon (before 1/70) Thunderbird S * Includes unit built from January 1970 Note: The Ford Galaxie and LTD are not listed on page 11 of the Chassis, General Information section but the catalog codes for these cars are thought to be A. Quick Reference (Text Catalog) Chassis Parts Group (Sorted by Section Number) Chassis Section Major Group Description DVD Bookmarks 10 Wheels Paint, Wheel- 20 Brake System Brake System 30 Front Suspension Front Suspension, Steering, Front Axle 30 Steering Linkage Front Suspension, Steering, Front Axle 30 Suspension (Front) Front Suspension, Steering, Front Axle 35 Steering Gear Front Suspension, Steering, Front Axle 40 Rear Axle Rear Axle, Drive Shaft 46 Drive Shaft Rear Axle, Drive Shaft 50 Frame Frame, Muffler, Springs 52 Exhaust System Frame, Muffler, Springs 53 Springs Frame, Muffler, Springs

18 Chassis Section Major Group Description DVD Bookmarks 54 Stabilizer Frame, Muffler, Springs 60 Engine Engine 70 Transmission (Manual) Manual Xmsn, Clutch 71 Gear Shift Lever Manual Xmsn, Clutch 75 Clutch Manual Xmsn, Clutch A70 Automatic Transmission Auto Xmsn 80 Cap (Radiator) Cooling, Grille 80 Cooling System Cooling, Grille 80 Grille Cooling, Grille 80 Hose (Radiator) Cooling, Grille 80 Radiator Cooling, Grille 80 Shroud (Fan) Cooling, Grille 85 Pulley (Water Pump) Cooling, Grille 85 Pump (Water) Cooling, Grille 85 Spacer (Pulley to Fan) Cooling, Grille 85 Thermostat (Water) Cooling, Grille 85 Water Pump Cooling, Grille 86 Clutch Assy. (Fan) Cooling, Grille 86 Fan, Drive Belt Cooling, Grille 90 Air Cleaner Fuel, Carburetor, Accelerator 90 Fuel Tank Fuel, Carburetor, Accelerator 93 Fuel Pump Fuel, Carburetor, Accelerator 94 Manifold Fuel, Carburetor, Accelerator 94 Thermactor Fuel, Carburetor, Accelerator 95 Carburetor Fuel, Carburetor, Accelerator 97 Accelerator Linkage Fuel, Carburetor, Accelerator 97 Speed Control Fuel, Carburetor, Accelerator 100 Generator Generators and Alternators 100 Voltage Regulator Generators and Alternators 103 Alternator Generators and Alternators 106 Battery Generators and Alternators 106 Instrument Cluster Generators and Alternators 110 Ignition Switch Starter and Drive Assemblies 120 Distributor Distributors and Spark Systems 130 Bulbs Lamps, Wiring 130 Lamps Lamps, Wiring 137 Horns Lamps, Wiring

19 Chassis Section Major Group Description DVD Bookmarks 140 Main Wiring Wiring 150 Electrical Accessories Electrical Accessories 160 Fenders Fender, Hood 166 Hood Fender, Hood 170 Jack Speedometer, Bumper 170 Speedometer Speedometer, Bumper 173 Tachometer Speedometer, Bumper 175 Windshield Wiper Speedometer, Bumper 176 Windshield Washer Speedometer, Bumper 177 Mirrors Speedometer, Bumper 178 Bumpers Speedometer, Bumper 180 Shock Absorber Shocks, Heater, Radio 184 Heater Shocks, Heater, Radio 184 Radio Shocks, Heater, Radio 190 Air Conditioner Air Conditioner Note: Please refer to the Text Catalog, General Information, pages 4-10 for a detailed listing of Section, Chassis Group, and Body Group numbers. Chassis Parts Group (Sorted by Bookmark) Major Group Description DVD Bookmarks Chassis Section Accelerator Linkage Fuel, Carburetor, Accelerator 97 Air Cleaner Fuel, Carburetor, Accelerator 90 Air Conditioner Air Conditioner 190 Alternator Generators and Alternators 103 Automatic Transmission Auto Xmsn A70 Battery Generators and Alternators 106 Brake System Brake System 20 Bulbs Lamps, Wiring 130 Bumpers Speedometer, Bumper 178 Cap (Radiator) Cooling, Grille 80 Carburetor Fuel, Carburetor, Accelerator 95 Clutch Manual Xmsn, Clutch 75 Clutch Assy. (Fan) Cooling, Grille 86 Cooling System Cooling, Grille 80

20 Major Group Description DVD Bookmarks Chassis Section Distributor Distributors and Spark Systems 120 Drive Shaft Rear Axle, Drive Shaft 46 Electrical Accessories Electrical Accessories 150 Engine Engine 60 Exhaust System Frame, Muffler, Springs 52 Fan, Drive Belt Cooling, Grille 86 Fenders Fender, Hood 160 Frame Frame, Muffler, Springs 50 Front Suspension Front Suspension, Steering, Front Axle 30 Fuel Pump Fuel, Carburetor, Accelerator 93 Fuel Tank Fuel, Carburetor, Accelerator 90 Gear Shift Lever Manual Xmsn, Clutch 71 Generator Generators and Alternators 100 Grille Cooling, Grille 80 Heater Shocks, Heater, Radio 184 Hood Fender, Hood 166 Horns Lamps, Wiring 137 Hose (Radiator) Cooling, Grille 80 Ignition Switch Starter and Drive Assemblies 110 Instrument Cluster Generators and Alternators 106 Jack Speedometer, Bumper 170 Lamps Lamps, Wiring 130 Main Wiring Wiring 140 Manifold Fuel, Carburetor, Accelerator 94 Mirrors Speedometer, Bumper 177 Pulley (Water Pump) Cooling, Grille 85 Pump (Water) Cooling, Grille 85 Radiator Cooling, Grille 80 Radio Shocks, Heater, Radio 184 Rear Axle Rear Axle, Drive Shaft 40 Shock Absorber Shocks, Heater, Radio 180 Shroud (Fan) Cooling, Grille 80 Spacer (Pulley to Fan) Cooling, Grille 85 Speed Control Fuel, Carburetor, Accelerator 97 Speedometer Speedometer, Bumper 170 Springs Frame, Muffler, Springs 53

21 Major Group Description DVD Bookmarks Chassis Section Stabilizer Frame, Muffler, Springs 54 Steering Gear Front Suspension, Steering, Front Axle 35 Steering Linkage Front Suspension, Steering, Front Axle 30 Suspension (Front) Front Suspension, Steering, Front Axle 30 Tachometer Speedometer, Bumper 173 Thermactor Fuel, Carburetor, Accelerator 94 Thermostat (Water) Cooling, Grille 85 Transmission (Manual) Manual Xmsn, Clutch 70 Voltage Regulator Generators and Alternators 100 Water Pump Cooling, Grille 85 Wheels Paint, Wheel- 10 Windshield Washer Speedometer, Bumper 176 Windshield Wiper Speedometer, Bumper 175 Body Parts Group (Sorted by Section) Section Major Group Description DVD Bookmarks Section 000 Dash, Cowl, Console, Windshield, Vents, Instrument Panel Dash, Cowl, Vents Section 100 Floor Pan, Reinforcements, Unibody and related Floor, Underbody, Sill Section 200 Front/Rear Doors, Quarter panels, rear door glass, belt rails Front/Rear Doors, Quarters Section 300 Quarter Window and Trim Quarter Window, Trim Section 400 Section 500 Back Door, Rear Window, Convertible Top, Tailgate, Trunk, Luggage Compartment Roof, Drip Moldings, Headlining, Landau Top, Folding Top, Luggage Carrier Section 600 Seating and related, Seat Belts, Headrests Seat Soft Trim Upholstery, windlace, door panels, carpet, visors, floor mats Soft Trim Back Door, Luggage Compartment Roof, Headlining, Top The following are found in the Body Illustrations Group (not in the Text catalog) Sheet Metal Body Sheet Metal Sheet Metal Exterior Moldings Molding/Nameplates Exterior Moldings Interior Trim Door Handles, Trim Panels and related Interior Trim

22 FORD CAR PARTS MASTER PARTS AND ACCESSORIES CATALOG FORM FP 7635-A (Text Only) Ford Motor Company INDEX GENERAL INFORMATION Abbreviations 16,17 Attaching Parts (Nuts, Bolts, etc.) 12 Body Type Codes 12 Build Date See Owner Card D.S.O 13 Engine Assembly Plant Codes 39 F.S.O 13 Formats 11 General Instructions '2 How to Order Parts 13 How to Use This Catalog 2 Identification 3 Liquid measure 12 L.P.O 13 Locator Codes 12 Metric to Inches Conversion Chart 14,15 Model Year Application 12 Owner Card 23 Soft Trim 12 Symbols Used Regularly in Catalog 11 Vehicle Catalog Codes 11 FORD PART NUMBERING SYSTEM Body Parts Group Numbering System 4 Explanation of the Ford Part Numbering System 3 Ford Basic Part Numbering 8 thru 10 Group Numbers and Related Catalog Sections 7 Motorcraft Sales Numbers 11 Part Name Index (Body Parts) 6 Part Name Index (Chassis) 4 thru 6 WARRANTY PLATE and CERTIFICATION LABEL (except BRONCO) Assembly Plant Codes 24 Body Type Codes 31 thru 34 Car Line Codes 39 Certification Label Diagram 22 Color Codes (Exterior Paint) 35 Diagrams and Instructions 18 thru 23 District Codes 39 Drive Codes 38 Engine Assembly Plant Codes 39 Engine Codes 29,30 Month Codes 36 Numerical Sequence of Assembly 30 Owner Card Diagram 23 Rear Axle Ratio Codes 37 Serial Number 22 Series Codes 25 thru 28 Transmission Codes 38 Trim Codes 35 Vehicle Identification Number 22 Warranty Plate Diagrams 18 thru 21 Year Codes 24 BRONCO WARRANTY PLATE and CERTIFICATION LABEL Assembly Plant Codes 43 Body Type Codes 43 Certification Label Diagram 42 Color Codes (Exterior Paint) 44 Diagrams and Instructions 40 thru 42 Engine Codes 43 Front Axle Codes 44 Model Codes 43 Numerical Sequence of Assembly 43 Rear Axle Ratio Codes 44 Transmission Codes 44 Trim Codes 44 Warranty Plate Diagrams 40,41 May, FORD MOTOR COMPANY -DEARBORN, MICHIGAN FINAL ISSUE 1

23 2 GENERAL INFORMATION FORD CAR PARTS GENERAL INSTRUCTIONS This Ford Car Master Parts Catalog contains replacement parts and accessories information for Ford, Fairlane/Torino, Mustang, Thunderbird, Bronco, Falcon, Maverick and Pinto for model years 1965 through 1972 for U.S. and Canadian built vehicles. Unique Canadian part numbers and applications have been identified by a symbol (a) and footnoted. Unique U.S. part numbers and applications have been identified by a symbol (a) and footnoted. Use this "text" catalog in conjunction with the "illustration" catalog, Form FP-7635-B. Refer to the Index on page 1 for a listing of the various items appearing in the General Information Section. HOW TO USE THIS CATALOG There are three ways of finding part numbers. 1. By Part Name. 2. By Illustration 3. By Identification. Should an inquiry be received for a rear carrier plate for a 1971 Thunderbird: BY PARTNAME - A. Refer to the Chassis Parts Alphabetical Index. B. Refer to the alphabetical nomenclature and find the part name "Plate (rear carrier)". The group number listed is C. Refer to group number and locate vehicle catalog code "S" (for Thunderbird). Find 1971 (71) in the "YEAR" column. D. The part numbers shown are C7AZ 2211-E for right hand and C7AZ 2212-E for left hand. BY ILLUSTRATION - A. Refer to the Illustration Catalog (Form FP B) to the divider marked "WHEELS, BRAKES". B. Refer to the index immediately behind the divider and find the illustration titles for 1971 S (Thunderbird). C. Under the heading "BRAKES" find the "Brake details (drum rear)" illustration for the 1971 Thunderbird. D. Refer to the illustration designated (on page 4 of Illustration Section 20.1) and find the group number for the rear carrier plate to be E. Refer to group number in this Text catalog and locate vehicle catalog code "S" (for Thunderbird). Find 1971 (71) in the "YEAR" column. F. The part numbers shown are C7AZ 2211-E for right hand and C7AZ 2212-E for left hand.

24 FORD CAR PARTS GENERAL INFORMATION 3 BY IDENTIFICATION - Certain parts and most major assemblies are identified with a part number shown on an attached tag or plate or on the part itself. Reference to identification numbers is made throughout the catalog and cross reference charts are included in some sections to provide immediate knowledge of the service part number when the identification number is known. IMPORTANT - Identification tags and plates must be retained with the part or assembly with which they are originally supplied. R. H. and L. H. PARTS The driver's side is the left hand side of the vehicle and determines whether such parts as fenders, lamps, etc. are right or left hand. Most Right Hand and Left Hand parts are listed in the manner shown in the following examples. The model application pertaining to the Right Hand part also pertains to the Left Hand part. EXAMPLE 1 - Right Hand and Left Hand on separate lines GROUP NUMBER YEAR BODY TYPE DESCRIPTION PART NUMBER QTY SPRING - DOOR LATCH TOGGLE r67 A,B,F,S,U,X - -- R.H. 68 A 68/70 S L.H. C7AZ B 1 or 2 1 of 2 C7AZ B o 2 2 EXAMPLE 2 - Right Hand and Left Hand implied by quantity 68/69 B(54,71) C8OZ A 2 68/69 B(62,63,76) C8OZ A I 2 EXAMPLE 3 - Right Hand and Left Hand in adjacent columns GROUP YEAR BODY TYPE DESCRIPTION PART NUMBER QTY. NUMBER PANEL - QUARTER - continued - Drill holes as required -B - RIGHT HAND LEFT HAND 67 1B(66) ~C7OZ A _ C7OZ A 1 67 II B(71) I C70Z A I C7AZ A 1 EXPLANATION OF THE FORD PART NUMBERING SYSTEM For greater convenience this catalog is divided into specific sections ; such as brakes, front suspension, engine, transmission, etc. For example. FRONT SUSPENSION appears in Section 30. STEERING in Section 35, REAR AXLE in Section 40, etc. The applicable exploded illustrations are contained in separate sections which are related to the Text Section numbers. For example STEERING Illustrations appear in Illustration Section 35 of the "Illustrations" Catalog, Form FP-7635-B. The basic part number groups and the section numbers under which each is listed are shown on page 7 of the General Information Section. The basic part number groups shown on page 7 have been expanded as shown in the Charts on pages 8, 9 and 10 to provide for additional groups to accommodate new lines. In numerical listings, expanded numbers will be considered to follow the same sequence as the regular basic numbers from which they are expanded and are arranged in Catalogs as follows C A634 Illustrations contain basic or group numbers only, therefore, it is necessary to refer to the basic or group within this "text" catalog for complete applicable part numbers.. May, FORD MOTOR -DEARBORN. MICHIGAN COMPANY FINAL ISSUE

25 A 4 GENERAL INFORMATION FORD CAR PARTS BODY PARTS GROUP NUMBERING SYSTEM FOLLOWING 15 A DIAGRAM OF THE BODY PARTS GROUP NUMBERING SYSTEM R BODY GROUP BODY TYPE CHANGE IN FINISH, TRIM OR DESIGN 54-4 DOOR SEDAN 62-2 DOOR SEDAN 76 - CONVERTIBLE ETC. DOOR ASSEMBLY (FRONT) - R.H. These five digits comprise the Body Group Numbers used throughout each body parts section. A complete group index of body parts has been included at the end of the Alphabetical Index. PART NAME INDEX Below are various major groups appearing in the Chassis and Body Sections of this catalog. CHASSIS PARTS INDEX MAJOR GROUP *TABBED DIVIDER TITLE SECTION Bumpers Air Cleaner 96 Accelerator Linkage Fuel-Carburetor-Accelerator 97 Air Conditioner Speedometer-Bumper 190 Alternator Generator-Starter-Distributor 103 Automatic Transmission Automatic Transmission A70 Axle (Rear) Front Suspension-Steering-Rear Axle 40 Battery Generator-Starter -Distributor 106 Belt (Drive) Cooling-Grille 86.1 Brake System Paint-Wheel-Brake 20 Bulbs Lamps - Wiring 130 Speedometer-Bumper 1711 Cap (Radiator) Cooling-Grille 80 Carburetor Fuel-Carburetor-Accelerator 95 Carrier (Wheel) Paint-Wheel-Brake 10 Clutch Manual Transmission-Clutch '75 Clutch Assy. (Fan) Cooling-Grille 86 Cooling System Cooling-Grille 80 Distributor Generator-Starter-Distributor 120 Drive Belt Cooling - Grille 86.1 Drive Shaft Front Suspension-Steering-Rear Axle 46 Engine Engine 60 Exhaust System Frame -Muffler -Spring 52 Applicable to Loose Leaf Catalogs only

26 FORD CAR PARTS PART NAME INDEX CHASSIS PARTS INDEX - continued GENERAL INFORMATION 5 MAJOR GROUP *TABBED DIVIDER TITLE SECTION Fan Cooling-Grille 86 Fenders Fender-Hood 160 Frame Frame-Muffler-Spring 50 Front Suspension Front Suspension-Steering-Rear Axle 30 Fuel Pump Fuel-Carburetor-Accelerator 93 Fuel Tank Fuel-Carburetor-Accelerator 90 Gear Shift Lever Manual Transmission-Clutch 71 Generator Generator-Starter-Distributor 100 Grille Cooling -Grille 80 Heater Speedometer-Bumper 184 Hood Fender-Hood 166 Horns Lamps-Wiring 137 Hose (Radiator) Cooling -Grille 80 Ignition Switch Generator-Starter-Distributor Ito Instrument Cluster Generator-Starter-Distributor 106 Jack Speedometer-Bumper 170 Lamps Lamps-Wiring 130 Lever (Gearshift) Manual Transmission - Clutch 71 Linkage (Accelerator) Fuel-Carburetor-Accelerator 97 Linkage (Steering) Front Suspension-Steering-Rear Axle 30 Manifold Fuel-Carburetor-Accelerator 94 Mirrors Speedometer-Bumper 176 Main Wiring Lamps - Wiring 140 Pulley (Water Pump) Cooling-Grille 85 Pump (Fuel) Fuel-Carburetor-Accelerator 93 Pump (Water) Cooling-Grille 85 Radiator Cooling-Grille 80 Radio Speedometer-Bumper 184 Rear Axle Front Suspension-Steering-Rear Axle 40 Regulator (Voltage) Generator-Starter-Distributor 100 Shaft (Drive) Front Suspension-Steering-Rear Axle 46 Shift (Gear) Manual Transmissioh-Clutch 71 Shock Absorber Speedometer-Bumper 180 Shroud (Fan) Cooling-Grille 80 Spacer (Pulley to Fan) Cooling-Grille 85 Speed Control Fuel-Carburetor-Accelerator 97 Speedometer Speedometer-Bumper 170 Springs Frame-Muffler-Spring 53 Stabilizer Frame-Muffler-Spring 54 Steering Gear Front Suspension-Steering-Rear Axle 35 Steering Linkage Front Suspension-Steering-Rear Axle 30 Suspension (Front) Front Suspension-Steering-Rear Axle 30 Tachometer Speedometer-Bumper 173 Tank (Fuel) Fuel-Carburetor-Accelerator 90 Thermactor Fuel-Carburetor-Accelerator 94 Thermostat (Water) Cooling-Grille 85 Transmission (Automatic) Automatic Transmission A70 Transmission (Manual) Manual Transmission-Clutch 70 Voltage Regulator Generator-Starter-Distributor 100 May, 1975 COPYRIGHT C FORD MOTOR -DEARBORN, MICHIGAN COMPANY FINAL ISSUE

27 DIVIDER TITLE *TABBED 6 GENERAL INFORMATION FORD CAR PARTS PART NAME INDEX CHASSIS PARTS INDEX - continued MAJOR GROUP SECTION Water Pump Cooling-Grille 85 Wheels Paint-Wheel-Brake 10 Windshield Washer Speedometer -Bumper 176 Windshield Wiper Speedometer-Bumper 175 Wiring (Main) Lamps-Wiring 140 BODY and SOFT TRIM PARTS INDEX Auxiliary Seat Center Body Pillar Console Cowl Dash Panel Door (Front) Door (Rear) Seat Side-Door-Pillar-Quarter Body Front-Floor Body Front-Floor Body Front-floor Side-Door-Pillar-Quarter Side-Door-Pillar-Quarter Floor Folding Top Folding Top Mechanism Front Door Front Seat Track Glove Compartment Instrument Panel Luggage Compartment Package Tray Pillar (Center Body) Quarter Rear Door Rear Seat Roof Seat (Auxiliary) Seat (Rear) Tail Gate Top (Folding) Top Mechanism (Folding) Track (Front Seat) Windshield Body Front-Floor Soft Trim Back-Luggage Compartment Side-Door-Pillar-Quarter Seat Body Front-Floor Body Front-Floor Back-Luggage Compartment Back-Luggage Compartment Side-Door-Pillar-Quarter Side-Door-Pillar-Quarter Side-Door-Pillar-Quarter Seat Back-Luggage Compartment Seat Seat Back-Luggage Compartment Soft Trim Back-Luggage Compartment Seat Body Front-Moor 100 Soft Trim Soft Trim Applicable to Loose Leaf Catalogs only

28 FORD CAR PARTS GENERAL 7 INFORMATION GROUP NUMBERS and RELATED CATALOG SECTIONS Following is an index of the basic group numbers and their related catalog section numbers. A more detailed listing of the basic group numbers, their related expansion numbers and functional areas is shown on the next three pages. CHASSIS PARTS r BODY PARTS BASIC GROUP CATALC G BASIC GROUP CATALOG BASIC GROUP ~~ CATALOG BASIC GROUP BODY NUMBER SECTION NO NUMBER SECTION NO NUMBER SECTION NO. NUMBER SECTION NO. Miscellaneous Paint Manual Trans. - Carburetor Kit 95A !]99 A70.1 thru except Linkage Components A Identification and Application Chart Parts Lists and / Kit Contents G/4/S-1971/ 70.2 Alternator Ident E/4/S / 70.2 Chart /0-1965/ Alternator 103.2, / 70.4 Parts Lists 103,4, D/4/S / F/4/S / , W /4/S / _ ) Transfer Case ,37 Starter Ident P/S Kits 36.1 ~/(,tnutil Trans - - Chart Starter Parts thru Linkage,etc _ 7299 Lists Distributor Ident Chart 290 Automatic trans, Distributor Parts thru Exhaust Charts thru except Linkage Lists Identification and Spring Charts 53.65thru Application Charts A , Parts List DO C/M / A C4-1965/ A C6-1966/ A Engine [dent. Chart Automatic Trans. 4 cyl linkage, etc cyl. 170, A cyl , A A cyl. 260,289, Spec cyl. 302 ; , SpeedometerGeart 302 Spec. 172 Fan Belt Ident. 86, Speedometer Gear Chart Application thru cyl ,5A Ford Racing Belts 86.2 Charts Spec. Belt Application thru SOFTTRIM - By 8 cyl. 352, Charts AS APPLICABLE) MODEL YEAR Spec cyl ' 8 cyl cyl. 428, Spec. Carburetor thru Parts Lists AA-. inn.: COPYRIGHT a FORD MOTOR -DEARBORN. MICHIGAN VENN AI I n np,imp' COMPANY

29 8 GENERAL INFORMATION FORD CAR PARTS FORD BASIC PART NUMBERING SYSTEM CHASSIS, ENGINE and ELECTRICAL BASIC NUMBER SERIES 8ASIC BASIC PARTS WHICH QUALIFY BASIC PART NO. SERIES BY FUNCTIONAL AREA PART NO. SERIES EXPANSION SERIES IA000-1A250 Wheels, hubs, and drums A251-1A349 Open numbers A350-1A499 Spare wheel carrier A500-1A724 Tires and tubes A725-1A Open numbers A000-2A874 Brakes A875-2A Air compressor A000-3A499 Front axles and fr ont suspensions A500-3A776 Steering gear and steering wheel A777-3A999 Open numbers A000-4A999 Rear axle and driveshaft and coupling shaft A000-5A149 `Frame and brackets I A150-5A199 1* A200-5A299 Muffler, exhaust pipes, and brackets BASIC SERIES EXPANSION PARTS WHICH QUALIFY BY FUNCTIDNAL AREA I3A000-I3A299 Headlamps & parking lamps 13A300-13A399 Turn signal 13AI00-t3A699{License, tail, and stop lamps 13A700-13A7991 Courtesty, dome and instrument lamps and switches 13A800-13A949 Horn 13A950-13A999 Open numbers 14A000-14A689 WirinE and circuit breakers. terminals and connectors. window regulator, fuse panel 14A690-14A724.Seat regulator (electrical) 14A725-14A999 Junction boxes and electric Conduit I5A000-15A074 Clocks & cigar lighter 15A075-15A114 Lamp assy. -cluster 15A115-15A A300-5A350 Front springs A351-5A416 Sub-frame (for cab mounting) A417-5A454 10pen numbers A455-5A481 'Front springs-clips, studs, and bushings A482-5A499 Stabilizer and attaching parts A500-5A515 Front spring covers I5699 5A516-5A999 (Rear springs and attaching parts A000-6A Engine and mounts A900-BA A 945-6A 999 Eng. instal'ation & dress-up kits A000-7A999 Transmission and clutch A000-8A Radiator and grille parts ; 8A500-8A591 Water pumps A600-8A86c' Fan and brackets A670-8A 999 Open numbers A000-9A423 (Fuel tank, gauges, pumps & lines A000-9A Fuel tank, gauges, pumps & lines I 9A424-9A499 Manifold,clamps,thermos'.ats etc, A500-9A Carburetors & air cleaners A700-9A899 Thermostatic rhoke, arc. spark & throttle control rods A900-9A A000-10A399 Generators & alternators A400-10A499 i Open numbers ,0649 I10A500-10A649IGenerator regulator A050-10A837 i Batteries & ammeters A838-10A999instrument cluster & controls A000-11A529IStarting motor & starter switch A A568' Openn numbers A A619 : %nit ton switch 15A200-15A399 Road & spotlamps 15A400-15A489 Lamp assy, -marker 15A490-15A579 Lamp assy. bark up & utility 1 15A580-15A599 Lamp assy, -Police flasher 15A600-15A649 15A650-15A655, Maplamp 15A656-15A699Top control 115A700-15A724 Engine compartment lamp 15A725-15A750 Commercial pump motors Vote; not.ascd Passenger Car, Truck & Industrial Engines 15A760-15A799 Open numbers 15A800-15A849 Lamp assy, -transmission control selector indicator I15A850-15A874 Parking brake signal 15A875-15A899 Open numbers 15A900-15A999 16A000-16A299 Front fender, aprons & shields 16A300-16A449 Rear fenders 16A450-16A549 Running boards and brackets 16A550-16A579Splash shields 16A580-IOA599 Open numbers 16A600-16A999 Hood, brackets and controls 17A000-17A149 Tools 17A130-17A219 17A250-17A384 17A385-17A399 17A400-17A674 17A675-17A748 17A749-17A999 Open numbers Speedometer and tachometer Open numbers Wipers and washers Rear view mirrors Front and rear bumpers and stone deflectors A620-1IA644 Open numbers A645-11A688 bighting switch A689-11A Open numbers A000-12A Coil, distributor & spark plugs A428-12A449 Open numbers A450-12A499 Engine governor A500-12A999 Open numbers A000-18A199 Shock absorbers 18A200-18A241 18A242-18AC99 ' Heaters 18A700-18A799 18A800-19A499 19A500-19A549 19A550-19A999 Air brakes Radio Miscellaneous Accessories Air conditioners * This series has become inactive and parts qualifying wilt be identified with part numbers from a more appropriate series.

30 FORD CAR PARTS BODY BASIC NUMBERS and CORRESPONDING FUNCTIONS GENERAL INFORMATION 9 BASIC PART NO. SERIES BASIC SERIES EXPANSION 1 q OOA00-OOOA99 001AOO-003A99 014A00-014A99 015AOO-015A99 016AOO-017A99 018A00-019A99 020A00-026A99 027A00-028A99 029AO0-029A99 Beaty assy. & trim sets Front end assembly Ventilating ducts & valves 13rake pedal support Dash assembly Ventilating ducts & valves Cowl & front body pillar Open Body front tae bow braces, etc. Windshield assembly 030A00-039A99 040A00-042A49 Visor assembly 042A50-043A99' Front belt rail Inst. panel assy, 044A00-045A99 Panel assy. -instr. panel details 046AOO-047A99 Cigar lighter assy. & instr. cluster SERIES EXPANSION PARTS WHICH QUALIFY BY FUNCTIONAL AREA AOO-259A99 I Open AOO- 261A99 262AO0-263A99 264AOO-266A90 262A00-267A99 268AO0-268A99 269A00-269A99 Rear door reinforcement Rear door glass frame Rear door lock & handles Open Rear door hinge Open A00-272A99 Rear door check&regulator A00-273A99 Rear door regalator vacuum lift AO0-276A99 277A00-280A99 281A06-283A99 284AO0-284A99 285A00-286A A00-287A99 Rear door trim Quarter & quarter panel assy. Quarter lock pillar Open quarter header & frame Quarter belt rail ] A00-048A99 Ash receptacle assy. 049A00-059A99 1 Open 060A00-061A99 j Glove compt. assy. 062AOO-099A99 100A00-109A AOO-110A99 111A00-114A09 115AOO-117A99 118A00-119A99 120A00-120A99 Open Floor side & cross members Underbody assy. Floor pan assy, silencers & pads Floor board assy. Open Floor board riser Floor trans. cover dust sealer 121A00-122A AOO-125A99 Open A00-126A99 Floor skid strip AO0-129A99! Open ! 130AOO- 13 1A99 Floor mat & carpet AO0-132A99iFlo- scuff plate AOO-134A99 Open AO0-135A99 Floor tool box AO0-137A99 Open A A 99 Member assy, body side frt.& rt A00-142A991SH1 assy. -floor pan cross front :143AOO-199A99s.Open A00-207A99iBody side and front door A00-2IOA99 Front door garnish mldg AOO-212A99 Front door reinforcement AO0-213A99 Open A00-223A99 Front door glass, lock&frame AOO-224A99 ; Front dour handles '225AO0-225A99 :Open A00-226A09 'Front door handles-inside A00-289A99 290AO0-291A99 292AO0-295A99 296A00-299A AOO-301A99 302A00-302A99 303A A A00-307A99 308A00-309A99 310AO6-314A99 315A00-3I5A99 316A06-318A 99 3I9AOO-319A 32OA00-321A09 322AOO-323A99 Open Quarter window garnish mldg. Quarter reinf, braces & brkts. Quarter window, glass & channel Quarter glass run & regulator Quarter vent. window Qtr, window regulator & frame Quarter armrest ash receptacle Open Quarter trim assy. & assist loop Open Qtr.arm rest assy. Quarter panel spare wheel comet. Open Side slats-trim sticks-antisqueaks 324AOO-324A 9f1 Quarter folding campt. -pkg. 325AOO-399A99 Open 400A00-401A9D Backdoor & luggage compartment 402A00-403A99 Tail gate & back panel assv. 404A00-404A 99 I.Ift gate 405AO0-405A 90 Open _06A00-406A99 Luggage compt, door panel 407AOO-407A99 Tall mate panel assy. 408A A99 Bark door & tail gate frame assy. 410AOO-410A99 Back door pillar fillers 411A00-411A99 Open 412AOO-412A 9P Deck pillar group 413AOO-413A09 Luggage comet, & lift gate door header A00-227A99 Open 228AO0-228A99 Front door hinge 229AOO-229A99 Front dolor ventilating windo,. 230A00-233A99 Front door dovetail & regulator 231A A99 Front door & window regulators 234A00-235A 2 Front cloor check 236A00-236A99 Open 237A00-241A99 Front door trim & arm rest 242A A99 Hydraulic window operating 243AO0-245A99 Center pillar assy. 246A00-249A99 Rear door assy. & panels 250AO0-250A99 Rear door frame & pillar assy. 251AOO-253A 92 Rear door heavier & bottom 254A00-258A99 Rear door glass & garnish tnidg I A01-415A9PI Open 416AO0-416A90 Tail gate framing 412A00-418A A A90 420A A99 423AOO-424A 9P 425A00-425A A A A00-428A09 429A00-429A99 430A00-430A99 431AOO-431A99 432A00-433A99 Back belt rail Bark door glass & framing Back window glass & frame assy. Luck windowgarnish moulding Backdoor finishstrip-mouldings Tail gate cross finish strip Luggage compt, hinge assy. - lamp assy. Back door hinge & reinf, assy. Tail gate hinge assy. Back door & tail gate lack Luggage compt. lock assy. May, 1975 COPYRIGHT *1975- FORD MOTOR COMPANY -DEARBORN, MICHIGAN FINAL ISSUE

31 I 0 GENERAL INFORMATION FORD CAR PARTS BODY BASIC NUMBERS and CORRESPONDING FUNCTIONS - continued BASIC PART ND SERIES BASIL SERIES EXPANSION PARTS WHICH QUALIFY BY FUNCTIONAL AREA BASIC BASIC PARTS 4'iHICH QUALIFY PART NO. SERIES BY FUNCTIDNAL AREA SERIES EXPANSION A00-434A99 Back door handle assembly A00-551A99 Top luggage carrier A00-436A99 Luggage comp.locking handle A00-559A99 Open A00-438A99 Backdoor&lugg. compt. w/strip A00-600A24 Front seat complete-less trim A00-439A99 Tail gate bumper & dowel A25-600A49 Rear seat assy. -opera seat assy A00-440A99 Back window regulator assy A50-600A99 Front & rear seat assy A00-441A99 Back door check assy A00-601A24 Driver's seat adjustment A00-442A99 Luggage compt.lid support A25-601A99 Rear & deck seat-back assy A00-443A99 Open A00-602A99 Driver's seat back assy. comp A00-445A99 Tail gate support A00-604A99 Front seat cushion frame assy A00-446A99 Back reinforcement brackets A00-607A99 Rear. aux. & opera cushion A00-447A99 Back door reinf. framing A00-450A99 1,/compt, opening &tail gate reinf A00-612A99 Front seat cushion &back frame AOO-451A99 Luggage compt. drain trough AO0-613A99, Rear seat back frame A00-453A99 Back trim & curtain A00-614A99 Rear seat side pillar-front seat A00-455A99 Luggage compt. trim side board A00-456A90 Luggage tool compartment A00-615A99 Rear seat side panel A00-457A99 Luggage comp. partition board A00-616A99 Front seat back panel A00-458A99 Luggage compt. shelf board A00-620A.99 Front seat adjusting A00-459A99 Luggage compt.lamp assy A00-624A99 Front & rear seat back reinf r 460A00-460A99 Compartment pkg. compartment A00-625A99 Driver & passenger seat suppt A00-461A99 Tool compartment rear seat legs A00-462A99 Deck step A00-627A99 Front seat floor rest toe guard A00-463A99 Back door trim A00-628A99 Front seat back robe cord A00-464A99 Luggage compartment trim front seat back ash receptacle A00-469A99 Package tray A00-631A99 Front seat cushion cover A00-472A99 Spare wheel compartment center seat opera seat cushion A00-479A99 Open A00-631A99 Front, center, opera & rear A00-480A90 Rear rack assy, scat cushion springs A00-499A99 Open A00-634A9P Seat cushion pad, facing & end pipe A00-502A99 Roof & top assy A00-636A99 Cushion button & welt bindin A00-507A99 Folding top parts A00-512A90 Roof reinforcement retainers A00-637A99 Front seat side carpet A00-513A99 Roof rail assembly A00-638A99 Rear & deck seat cushion cover A00-515A99 Top bow assy, & dome lamp A00-640A99 Driver's seal rear cover brackets & attaching parts A00-643A99 Partition window operating mech A00-516A90 Roof rib & slats A00-645A99 Frout seat back cushion cover A00-517A99 Roof drip & finish moulding A00-646A99 Seat back, pad & division frame A00-518A99 Roof partition A00-647A99 Front & center seat spring & pad A00-522A90 Roof headlining & support A00-649A99 Front, renter & opera seat pad, A00-524A99 Roof binding & cardboard cardboard & cover A00-525A99 1Top back curtain A00-650A99 Front seat back facing A00-526A99 Open A00-651A99 Front seat back trim rail A00-529A99 Top deck & slide quarter A00-652A99 Front seat hack cushion welt & A00-530A99, Top stack-toggle moulding A00-531A99Top landau-folding pillar A00-653A99 Front seat back wadding AO0-654A99IIFront seat hack misc. trim A0O-533A99 Top back curtain & hyd. mech. hassock assy.!!ll Front seat back bellows A00-534A99 Top curtain container A00-655A A00-536A99tTop side curtain front & rear A00-659A99 Open A00-537A99I Top covers, pads and retainers A00-660A99 Pedestal seat A00-538A99, Quarter curtain AOO-665A99 Open A00-542A99 Foldingtop & back stay pad A00-6$8A99Rear &dockseat back cover, pad A00-543A99 Roof pads & wadding-silencers & spring A00-544A99 Top dust hood & container A00-670A99 'Rear seat cardboard & facing A00-545A99 Open A00-671A99 Rear seat back arm rest cover A00-547A99 Folding top compt. & w/strip A00-672A99 Rear seat arm rest A00-548A99 Top hold down strap A00-675A99 'Rear seat silencer heelhoard A00-549A99 Roof ventilator IMPORTANT : AS EACH INDIVIDUAL EXPANSION SERIES BECOMES EXHAUSTED of NUMBERS, ANOTHER SERIES WILL BE ESTABLISHED BY USE of THE NEXT ALPHABETICAL EXPANSION LETTER SUCH AS "8" thru "2".

32 FORD CAR PARTS GENERAL 11 INFORMATION MOTORCRAFT SALES PART NUMBERS To facilitate the stocking and handling of those service parts which are assigned both service part numbers and Motorcraft Sales Part Numbers, the Motorcraft Sales Part Numbers are shown in parenthesis immediately following or below the service part numbers. For example, refer to Section 96, Group The service part number for a carburetor air cleaner element used on a 1969 Mustang with a 6 cylinder 250 C.I.D. engine is C9ZZ 9601-A and the Motorcraft Sales Part Number is FA-68. In the catalog this item will be shown as C9ZZ 9601-A(FA-68). SYMBOL USED REGULARLY IN CATALOG * Symbol Indicates part is not supplied for service due to the following: a. Part is superseded and replaced as indicated in the description column of text. b. Part can be improvised as indicated in the description column of text. c. Due to its function there would be little or no demand. NOTE : ALWAYS REFER TO THE DESCRIPTION COLUMN DE THE TEXT FOR POSSIBLE SUBSTITUTION,OR FOR MATERIAL SPECIFICATIONS AND DIMENSIONS WHICH MAY BE HELPFUL IN OBTAINING THE NoN SERvlcED PART LOCALLY. FORMATS Various formats are used throughout this catalog to coincide with the normal procedure for selecting the affected part numbers. Most areas of the catalog use a format arranged in the order shown below: Column - 1 Model year 2 Type of vehicle or equipment within a specific model year 3 Description, size, etc. 4 Quantity required per vehicle 5 Complete part number Formats peculiar to a particular area of the catalog are generally self explanatory. When necessary, instructions are shown at the beginning of the affected group. For instance, the various charts and parts list method of cataloging in the Carburetor Section are explained on Page 1 of Section 95. VEHICLES and RELATED CATALOG CODES CATALOG CODES and RELATED VEHICLES sass_ Bronco U A Ford Falcon X(Before 1/70) B Fairlane/Torino and *Falcon Falcon B(From 1/70) F Mustang Fairlane/Torino B L Pinto Ford A P Maverick Maverick P S Thunderbird Mustang F U Bronco Pinto L X Falcon (1965/70 - Built before January, 1970 Thunderbird S see Code B for units built from January, 1970) For Falcon Club Wagons - refer to Ford Truck Master Parts Catalog (Form AF 7636-A) * Includes Falcon units built from January May, 1975 COPYRIGHT C FORD MOTOR -DEARBORN, MICHIGAN COMPANY FINAL ISSUE

33 12 GENERAL INFORMATION FORD CAR PARTS MODEL YEAR APPLICATION Model year application is indicated by showing the first year followed by a diagonal line to indicate continued usage in all subsequent years until the insertion of the last year of usage, which :ill then be inserted after the diagonal line. If no diagonal line is shown, the part is applicable only tothe year indicated. Example : 65/ Indicates part used 1985 through 1972 as shown in this catalog, for possible application beyond 1972 see 1973/ Ford Parts Catalog, Form FP 8094-A. 66/68 Indicates part used 1966 through 1968 model years. 67 Indicates part used 1967 model year only. 72 Indicates part used 1972 model year, for possible usage beyond 1973/ see Ford Car Parts Catalog, Form FP 8094-A. BODY TYPE CODES Most body parts and some chassis parts are identified by Body Type Codes. A complete listing of body type codes is shown on pages 31 thru 34 of this General Information Section. Similar body types are identified by the same code number ; the body type suffix is used to identify a particular body type. For instance, in 1968 (Ford) body type code 54 was used as follows: 1968 A(54A) Galaxie "500" 4 Door Sedan A(54B) Custom "500" 4 Door Sedan A(54C) "LTD" 4 Door Sedan A(54E) Custom 4 Door Sedan A(54) 4 Door Sedans Body type codes (less suffix) are shown in the model column of the catalog text or with illustration titles when all body types of a related group are affected. For example, when Body Type Code 54 is shown, it includes 54A, 54B, 54C and 54E. SOFT TRIM Soft Trim parts are arranged in separate sections by model year i.e. 1965, 1966 etc. Each includes facsimile trim swatches and complete trim codes. To determine the complete part number of a trim part, it is necessary to know the "Trim Code" which is shown on the Warranty Plate or Certification Label of the vehicle (refer to Pages 18 thru 22). Instructions for selecting soft trim parts are contained at the beginning of each Soft Trim Section. ATTACHING PARTS (NUTS, BOLTS ETC.) and LOCATOR CODES Standard and utility hardware, such as bolts, screws, fittings, etc. are listed below the part with which they are used. To facilitate the stocking and handling of standard and utility parts by Ford Dealers, locator codes are preassigned by Ford Motor Company. The locator codes are shown in parentheses immediately following or below the standard and utility part numbers. For an example, refer to Body Section 030, Page 1, Group The part number for a 1/4-20 x 1/2" hex. head bolt is S8 and the locator code is (340). In the catalog this item will be shown as SB (B40). LIQUID MEASURE Most liquid measures listed in this catalog are in U.S. sizes and certain other liquid measures (unique to Canada) listed in this catalog are in Canadian sizes. The following chart provides an understanding and a translation of U.S. to Canadian and Canadian to U.S. sizes. 1/2 pt. Pint (capacity in ounces) Quart Gallon - capacity in ounces) Canada U.S Example: 5 U.S. Quarts (160 ounces) equal 4 Canadian Quarts (160 ounces) or 1 Canadian Gallon.

34 FORD CAR PARTS GENERAL INFORMATION 13 D.S.O., I.S.O. or I.P.O. (SPECIAL ORDERS} The District Code Number will appear in the D.S.O. space on the Warranty Plate or Certification Label for all units including regular production. Always furnish appropriate Warranty Plate or Certification Label information and D.S.O. Number, if applicable, when ordering parts not listed in the catalog. If the unit is D.S.O., F.S.O. or L.P.O. (Special Order), the complete Order Number will appear in the D.S.O. space in addition to the District Code Number. HOW TO ORDER PARTS When ordering parts, always give the complete part number. In the event the part number is not known, the following information should be included. A. Complete description of part. B. Model year and body type. C. Dimension, number of teeth, size, etc. ; if possible rough sketch of part. D. If applicable to engine, transmission, axle, steering, etc. ; specify type; such as 390 C.I.D., Fordomatic, Power Steering. etc. E. Advise how shipment is to be made - Freight, Express, Air, Parcel Post. May, 1975 COPYRIGHT FORD MOTOR -DEARBORN, MICHIGAN COMPANY FINAL ISSUE

35 14 GENERAL INFORMATION MM FORD CAR PARTS INCHES and MILLIMETERS CONVERSION CHART MILLIMETERS TO DECIMAL [inches) EQUIVALENT DECIMAL MM _ DECIMAL MM = DECIMAL - (Inches) (Inches) (Inches) MM _ DECIMAL (Inches) ' , , I , , , ' DECIMAL (inches) TO METRIC EQUIVALENT DECIMAL = MM DECIMAL = MM DECIMAL = MM DECIMAL = MM DECIMAL = (Inches) (Inches) MM DECIMAL = MM (Inches) (Inches) (Inches) (Inches) I , , ,004, , U : ill :/ % I I , : %. + I % I.01 % ~'7j11~If:,a.' , 1., :TTI 1:. 1 I I Il. o o I 1 '7111flflflfl><. # YI~ IQI)ifiCEllll~i~dlf["~. 1111~~ :411>"'.i 45u f`i I I YII~. :i/l~r(t11ff :la! :.o s 1. III 111 ' / 1. i ' I ~C1111~R:Y (1~. I f 1 1 to 1 1 :. I I'I`I.110 ' I 1. 1 I I, I I I 2540, 000

36 FORD CAR!ARTS GENERAL 15 INFORMATION INCHES and MILLIMETERS CONVERSION CHART - continued FRACTIONS (inches) TO DECIMALS (inches) and METRIC EQUIVALENTS F R A C T I O N (Inches) DECIMAL Unc h es ) MM F R A C T 1 0 N (Inches) DECIMAL (Inches) = >a p , , / _41/64, , I 21132, / , 588 _ 43164, / ,984 11/16._ / , /s / / , /32 I56 3.D x / / / , 828, /32, , 844 _ / , _ , 225 1/ , , /32, , / ,54I 15/ / , / , /32 _._ $ ,128 3/8, , /64, 391 9, / / , I , / _ /611_ /32.53I y / I /64, , ,081 :9/64_ 609.,_ OO.O p0_ May, 1975 COPYRIGHT D FORD MOTOR COMPANY -DEARBORN, MICHIGAN FINAL ISSUE

37 16 GENERAL INFORMATION FORD CAR PARTS ARQIIE V IATI0 %S 2/b or 2/v 2 barrel 3 ri or 3/S/T 3 sp eed trans. 3 or 4/5/T 3 or 4 speed trans 4/b or 4/v 4 barrel 4/T or 4/S/T 4 speed trans. 6/b or 6/V 6 barrel 8/b or 8/V 8 barrel A/C air conditioner AR As Required A/5 air suspension A/T or automatic transmission auto. trans. A.T.C automatic temperature control abs absorber accel accelerator adj adjustment alt alternator alter alternating alum aluminum amp ampere approx - -.approximately assy assembly attach attached b1t block brg bearing brlcr breaker brkt bracket bus business B/W Borg Warner col column Corr co Compressor compt compartment con control cond conditioning corn connecting Ctr center cvr. or cov cover cyl cylinder D/4/S Dagenham 4 speed def defroster defl deflector dia. or Warn diameter cliff differential disp displacement (list distributor E.S.C Electronic Spark Control E/H/D Extra Heavy Duty elec electric em/re emission reduction eng engine equal equalizer ev/em evaporative emission exh exhaust ext external F/L Fairlane gen generator g/compt glove compartment gov governor gr gear GTW gross tongue weight H-1 Halley 1 barrel carb. H-2 Holley 2 barrel carb. H-4 Holley 4 barrel carb. H/D heavy duty H/O high output HP norsepower lid head h/lamp headlamp hex hexagon hsg housing htr heater hyd hydraulic I. D inside diameter I/P integral power steering ident identification ign ignition Imco Improved Combustion Emission Control System Indic indicator instru instrument int internal inter intermediate K.D shipped in disassembled form CJ Cobra Jet (engine) C4 and/or C6 type of automatic transmission C/CW counter clockwise C. I. D cubic inch displacement C/M cruise-o-matic C.P. or cp candle power CS California Special (Mustang) C/W clockwise c/member crossmeniber c./pin cotter pin c/shaft crankshaft carb carburetor Chg/L Change level clstr cluster F-1 Ford 1 barrel carb. F-2 Ford 2 barrel carb. F-4 Ford 4 barrel carb. F/4/S Ford 4 speed fdr fill flex fir fender fillister flexible floor frt front ft foot f/wheel flywheel L. H lb left hand pound 1/compt luggage compartment it. /frame light weight frame lub lubricator 1/washer or 1/w lockwasher lwr lower M/I Mainline M/5 manual steering M/T --manual transmission man manifold med :ec :iu m mm millimeter m.p.h miles per hour n11dg moulting mtd mounted mtg mounting mtr motor

38 FORD CAR PARTS ABBREVIATIONS GENERAL INFORMATION 17 No nu m per R.F regular fuel R. H right hand R. P.M. or RPM..revolutions per minute T/E Thermactor Emission Control System T.V throttle valve q.d outside diameter O/D or o/drive,,,,,,,,,,,,, overdrive O. H. V over head valve O/s oversize o/all overall oz ounce P/A power assist steering P/C Police Car P/I Police Interceptor P/L Par Mane P/S power stc ring P. F premium fuel pass passenger pea pieces press pressure pt pint rad radiator rd round reg regulator reinf reinforcement repl replaced req'd required ret retainer rr rear S/C standard cooling S/CJ Super Cobra Jet (engine) s /compt storage compartment S/Tl Sedan Delivery S/E Special Economy carb, S/L Sunliner S/T standard transmission S/W Station Wagon tack tachometer temp temperature t/gate tail gate thd unread trans trans mission Trans/ign. or Trans. ign Transistorized Ignition T,R.S Transmission Regulated Spark Control D/5 undersize u/joint or u/jt, universaljoint vac vacuum vent ventilat.nn qtr quarter qty quantity R/A rocker arm rib or R/B replaced by R/D regular duty R/O ring gear s/member side member s/ring snap ri!i;, speedo speedometer spkrs speakers sprg spring std standard strg steering suppt support susp suspension w/o without W/4/S Warner 4 speed w/shield or w/s windshield w/strip weather strip warn warning wt weight X/C or x/c extra cooling May, 1975 COPYRIGHT FORD MOTOR COMPANY -DEARBORN, MICHEGAN FINAL ISSUE

39 18 GENERAL INFORMATION FORD CAR PARTS 1965 WARRANTY PLATE - TYPICAL [U. S. built vehicles) Located on the latch face of the left Front Door. The Warranty Plate Includes. 1. Miscellaneous vehicle data (first line) consisting of codes which identify Body Type, Color of Exterior Paint, Trim, Production Date, District (and D.S.O. number where applicable), Rear Axle Ratio and Transmission. 2. Vehicle Warranty Number (second line) consisting of Codes which identify Model Year, Assembly Plant, Series, Engine and Numerical Sequence of Assembly. The page number(s) on which the Codes are listed is shown in parenthesis. MISCELLANEOUS VEHICLE DATA (54A EM K FIRST LINE (36) PRODUCTION DATE CODE (35) TRIM CODE (35) BOOS' COLOR CODE (31,hno 34) BODY TYPE CODE 1 I I 54A EM K MONTH CODE (36) (((DISTRICT CODE ) ( } (39) DSO NUMBER ) REAR AXLE RATIO CODE (37) TRANSMISSION CODE (36) "54A"---- Galaxie Door Sedan "RM"---- Ivy Green lower body, Wimbledon White upper body (For two tone vehicles first digit indicates lower body color and second digit indicates upper body color.) Numerals following the color Code are for Company information. "58"---- Ivy Gold cloth and vinyl Refer to 1965 Soft Trim Section for complete instructions and Trim Code listing. "17"---- Seventeenth Day of Month "K"---- October " 26" ---- Washington District (and DSO number when applicable) Refer to Page 34 for complete explanation " 1" ---- Rear Axle Ratio of 3.00 to 1 I ' 4" ---- (EX) Dual Range Transmission BODY COLOR TRIM DATE D.S.O AXLE TRANS Black Background Plate Identifies a Unit Painted with M30J (Non-Acrylic) Enamel. (Solid Color Unit or the Lower Body Color when Unit is Two-Tone.) 54A RM 58 17K VEHICLE WARRANTY NUMBER '5562X ' HOT FOR TITLE OR REGISTRATION PURPOSES THIS VEHICLE IS MANUFACTURED UNDER ISSUED AND PENDING UNITED STATES AND FOREIGN PATENTS Grey Background Plate Identifies a Unit Painted with M32J (Acrylic) Enamel. (Solid Color Unit or the LowerBodyColor when Unit is Two-Tone.) A PRODUCT OF MOTOR COMPANY MADE IN U.S.A VEHICLE WARRANTY NUMBER ('5562X100001') SECOND LINE S 62 X P.3941 (24) MODEL YEAR CODE (24) ASSEMBLY PLANT CODE (25 ( ht. 26) SERIES CODE Il NUMERICAL SEQUENCE (30) OF ASSEMBLY ENGINE CODE (29,30) ---- Asterisks precede and follow the vehicle Warranty Number to prevent unauthorized addition of numbers or symbols. " 5" Model " S" ---- Assembled at Pilot Plant "62" Door Sedan "X" cyl. Engine--352 C.I.D.-- 4 Venturi carburetor "100001"---- First Ford Series vehicle assembled at Pilot Plant during Model Year

40 FORD CAR PARTS 1965 WARRANTY PLATE - TYPICAL (Canadian built vehicles) GENERAL 19 INFORMATION Located on the latch face of the left Front Door. The Warranty Plate Includes: 1. Miscellaneous vehicle data (first line) consisting of codes which identify Color of Interior and Exterior Paint, Trim, Engine and Special Order Number (where applicable). 2. Vehicle Serial Number (second line) consisting of codes which identify Car Line, Body Type, Model year, Drive and Numerical Sequence of Assembly. The page number(s) on which the Codes are listed is shown in parenthesis. MISCELLANEOUS VEHICLE DATA (1RR ) FIRST LINE (3S) TRIM CODE (53) EXTERIOR PAINT CODE. (35) INTERIOR PAINT CODE 1 ENGIN CODE 1 RR B FOR INTERNAL CONTROL ONLY-DISREGARD i 1-7 TRANSMI55(ON CODE (36) SPECIAL ORDER NUMBER "1"---- Red interior "RR"---- Rangoon Red lower body and Rangoon Red upper body "631"---- Red vinyl and red cloth "J" cyl. Engine C.I.A. "3"---- Automatic Transmission "02-001"---- Special Order Number (when applicable) Refer to Page 13 for complete explanation SERIAL NUMBER (463B 65L (39). CAR LINE CODE) OAKVILLE ONTARIO ENGINE SERIAL NO, IS LOCATED ON ENGINE BLOCK O PAINT TRIM ENGINE SPECIAL ORDER NO. `^] v 1RR] 631 JB j SERIAL NUMBER 463B 65L P ) SECOND LINE 4 63B 65 L NUMERICAL SEQUENCE (30) OF ASSEMBLY (31 h nu 34) BODY TYPE CODE DRIVE CODE (16) MODEL YEAR CODE (34) "4"---- Ford with 8 cylinder engine "63B"---- Galaxie Door Hardtop (Fastback) "65" Model "L"---- Left Hand Drive "700000"---- First Ford Series Vehicle assembled at Oakville during Model Year May, 1975 COPYRIGHT FORD MOTOR -DEARBORN, MICHIGAN COMPANY FINAL ISSUE

41 20 GENERAL FORD CAR PARTS INFORMATION 1966/69 WARRANTY PLATE - TYPICAL 'ALSO USED ON 1970 MAVERICK BEFORE 8/11/69( Located on the latch face of the left Front Door. The Warranty Plate includes: 1. Warranty Number (first line) consisting of Codes which identify Model Year, Assembly Plant, Series, Engine and Numerical Sequence of Assembly, 2. Miscellaneous Vehicle Data (second line) consisting of Codes which identify Body Type, Color of Exterior Paint, Trim, Production Date, District (and D.S.O. number where applicable), Rear Axle Ratio and Transmission. The page numbers) On which the Codes are listed is shown in parenthesis. WARRANTY NUMBER (6562X FIRST LINE {25 Ihru 261 SERIES coin (201 ASSEMBte PLANT CODE (24) MODEL YEAR CODE ENGINE CODE (79,301 NUMERICAL SEQUENCE (30( OF ASSEMBLY "S" Model "S"--- Assembled at Pilot Plant. " 62"--- 4 Door Sedan "X"--- S CyL. Engine C.I.D. - 4 Venturi Carburetor "100001"--- First Ford Series vehicle assembled at Pilot Plant during Model Year Black Background Plate identifies a Unit Painted with M32J (Acrylic) Enamel. (Solid Color Unit or the Lower BodyColor when Unit 1a Twe-Tune.) MADE IN INDICATES U.S. BUILT VEHICLES,+y r CANADA 6562X WARRANTY NUM6EE MADE IN NOT FOR TIRE OR REGISTRATION V4ATL r } 154A YM 32 17K 33 6 BODY COLOR TRIM DATE D.5.0. AXLE TRANS. INDICATES CANADIAN MIT VEHICLES Crey Background Plate identifies a Unit Painted with M30J (Non-Acrylic) Enamel. (Solid Color Unit or the Lower Body Color when Unit is Two-Tone. P.521B MISCELLANEOUS VEHICLE DATA 154A YM K SECOND LINE 54A YM K (31?hr. 34) BODY TYPE CODE TRANSMISSION CODE (38) (35) BODY COLOR CODE REAR AXLE RATIO CODE ( 371 (35( TRIM CODE DISTRICT CODE D.S.o. NUMBER (391 (36) PRODUCTION DATE CODE MONTH CODE (36) "54A"--- Galaxie Door Sedan "YM"--- Silver Blue lower body, Wimbledon White upper body "32"--- Blue cloth and vinyl Refer to appropriate Soft Trim Section for complete instructions and Trim Code listing. "17"--- Seventeenth Day of Month "K"--- October "Sr- Detroit District (and D.S.O. number when applicable) Refer to Page 13 for complete explanation Rear Axle Ratio of 3,00 to 1 C4 Automatic 3 Speed Dual Range Transmission

42 FORD CAR PARTS GENERAL 21 INFORMATION 1969/70 SPECIAL PERFORMANCE VEHICLE WARRANTY PLATE - TYPICAL Located on the latch face of the left Front Door. The Warranty Plate includes: 1. Warranty Number (first line) consisting of Codes which identify Model Year, Assembly Plant, Series, Engine and Numerical Sequence of Assembly. 2. Miscellaneous Vehicle Data (second line) consisting of Codes which identify Body Type, Color of Exterior Paint, Trim, Production Date, District Code (and D.S.O. number where applicable), Rear Axle Ratio and Transmission. The page numbers(s) on which the Codes are listed is shown in parenthesis. WARRANTY NUMBER (9F02R ) FIRST LINE (25 rhrki 2e) SERIES CODE ENGINE CODE (29,30) (24) ASSEMBLY PLANT CODE NUMERICAL SEQUENCE OF ASSEMBLY (30) (24) MODEL YEAR CODE 9 F 02 R " " Model Year Assembled at Dearborn Plant 2 Door Hardtop (Fastback) 8 Cyl. Engine C.I.D. Cobra Jet Ram Air - 4 Venturi Carburetor First Shelby Automotive Mustang assembled at Dearborn during Model Year Black Background Plate Identifies a Unit Painted with M32J(Acrylic)Enamel. (Solid Color Unit or the Lower Body Color when Unit is Two-Tone.) Grey Background Plate Identifies a Unit Painted with M30J (Non-Acrylic) Enamel. (Solid Color Unit or the Lower Body Color when Unit is Two-Tone.) P-6817 MISCELLANEOUS VEHICLE DATA (63A Y 4A 20 J 71 W 6) SECOND LINE (31rhra341 BODY TYPE CODE (35) BODY COLOR CODE (3s} TRIM CODE (36) PRODUCTION DATE CODE 63A Y 4A 20 W ~ T T TRANSMISSION CODE (38) REAR AXLE RATIO CODE (37) DISTRICT CODE (39) D.S.O. NUMBER MONTH CODE (36) "63A" ---- Mustang - 2 Door Hardtop (Fastback) " Y'' ---- Indian Fire (Burnt Orange Metallic) " 4A" ---- Black all vinyl Refer to appropriate Soft Trim Section for complete instructions and Trim Code listing. "20" ---- Twentieth Day of Month "J" ---- September 71" ---- Los Angeles District (and D.S.O. number when applicable) Refer to Page 13 for complete explanation W'' ---- Rear Axle Ratio of 4.30 to 1 6" Speed Transmission - Close Ratio (2.32 First Gear) May, 1975 COPYRIGHT O FORD MOTOR -DEARBORN, MICHIGAN COMPANY FINAL ISSUE

43 22 FORD CAR PARTS GENERAL INFORMATION 1970/ SAFETY STANDARDS CERTIFICATION LABEL - TYPICAL (REPLACES METAL WARRANTY PLATE) ALL EXCEPT BRONCO - REFER TO PAGES 40 THRU 44 FOR BRONCO WARRANTY PLATE CDDES) (NOT USED ON 1970 MAVERICK BEFORE 8/11/69) Located on the latch face of the left Front Door. The Certification Label includes. 1. Built date (e.g. 9 '69) in upper left hand corner which indicates the month and year in which the unit was built. 2. Vehicle Identification Number (Ieft half of first line) consisting of Codes which identify Model Year, Assembly Plant, Series, Engine and Numerical Sequence of Assembly (also shown in upper right hand corner). 3. Miscellaneous Vehicle Data (right half of first line plus second line) consisting of Codes which identify Body Type, Color of Exterior Paint, Trim, Rear Axle Ratio, Transmission and District (and D.S.O. number where applicable). The page number(s) on which the Codes are listed is shown in parenthesis. (25 Rh.u 24) SERIES CODE (24) ASSEMBLY PLANT CODE (24) MODEL YEAR CODE VEHICLE IDENTIFICATION NUMBER (OS54H100001) FIRST LINE I 0 S 54 H ENGINE CODE (29,33) NUMERICAL SEQUENCE (30) OF ASSEMBLY "0" Model Year "S" -- Assembled at Pilot Plant "54" -- 4 Door Sedan "H" Cyl. Engine Venturi Carburetor " " -- First Ford Series Vehicle assembled at Pilot Plant during Model Year. "9/69" ---- Built during September,1969 U.S. VEHICLES CANADIAN VEHICLES MANUFACTURED BY ; FORD MOTOR COMPANY 9/69 THIS VEHICLE CONFORMS TO ALL APPLICABLE U.S. FEDERAL MOTOR VEHICLE SAFETY STAN- DARDS IN EFFECT ON DATE OF MANUFACTURE SHOWN ABOVE, MANUFACTURED BY FORD MOTOR COMPANY /69 THIS VEHICLE CONFORMS TO ALL APPLICABLE FEDERAL MOTOR VEHICLE SAFETY STAN. DARDS IN EFFECT ON DATE OF MANUFACTURE SHOWN ABOVE -, OS54H A B A j B 5A 6 X 33 NOT FOR TITLE OR REGISTRATION (31 rh,u 34) BODY TYPE CODE (35) BODY COLOR CODE (35) TRIM CODE MADE IN U.S.A. 5A 6 X 33 NOT FOR TITLE OR REGISTRATION MADE IN CANADA MISCELLANEOUS VEHICLE DATA (54A B 5A 6 X 33) SECOND LINE 54A T P-7184 DISTRICT CODE (39) D.S.O. NUMBER l1 TRANSMISSION CODE (3a} REAR AXLE RATIO CODE (37) "54A" ---- "5A" ---- Solid colors Two tones -- - Galaxie "500" 4 Door Sedan Dark Maroon Black cloth and vinyl 1970/71 Single digit code 1972 Two digit code 1970/71 Two digit code 1972 Four digit code Refer to appropriate Soft Trim Section for complete instructions and Trim Code listing. Rear Axle Ratio of to 1 FMX - Cruise-O-Matic Transmission Detroit District (and D. S.O. number when applicable) Refer to Page 13 for complete explanation

44 FORD CAR PARTS GENERAL INFORMATION / OWNER CARD - TYPICAL (ALL EXCEPT BRONCO) OW NER t':; A R,,t,f!r:, 11'W'.1-...; A FORD BUYER 1970 EVERY STREET HOMETOWN U.S.A. 57D-5G "12H W N P.8190 Effective dates shown in the catalog, e.g. "Before 12/15/69" and From 12/15/69" may be determined through interpretation of the build date shown on the owner card. This information corresponds to that shown on the warranty plate from 1965 to The numerical position of the build date represents the day of the month. The alphabetical portion of the build date represents the month in which the unit was built. For example - 29D indicates 29th day of month D - April Refer to page 36 for a complete list of month codes and the corresponding month. May, 1975 COPYRIGHT C FORD MOTOR -DEARBORN, MICHIGAN COMPANY FINAL ISSUE

45 24 GENERAL INFORMATION FORD CAR Pars WARRANTY PLATE or CERTIFICATION LABEL (Refer to Pages 40 thru 44 for Bronco Warranty Plate Codes) YEAR CODES 1965 U.S. BUILT VEHICLES 1966/ U.S. and CANADIAN BUILT VEHICLES THE FIRST DIGIT OF THE WARRANTY OR VEHICLE IDENTIFICATION NUMBER IDENTIFIES THE MODEL YEAR OF THE VEHICLE. THE FOLLOWING CHART LISTS THESE CODES AND THE CORRESPONDING MODEL YEAR. CERTIFICATION LABEL SHOIIN ;ARRANT}' PLATE TYPICAL NOT FOR TITLE MADE CODE YEAR I CODE YEAR CODE YEAR I CODE YEAR I YEAR CODES THE FIFTH MD SIXTH DIGITS OF THE SERIAL NUMBER INDICATE THE MODEL YEAR OF THE VEHICLE CANADIAN BUILT VEHICLES NEE LOCATED 0 _ \..- i.t NE E:fll Code Model Year U.S. BUILT VEHICLES 1966/ U.S. and CANADIAN BUILT VEHICLES ASSEMBLY PLANT CODES THE SECOND DIGIT OF THE WARRANTY OR VEHICLE IDENTIFICATION NUMBER IDENTIFIES THE PLANT AT WHICH THE VEHICLE WAS ASSEMBLED. THE FOLLOWING CHART LISTS THESE CODES AND THE CORRESPONDING ASSEMBLY PLANT. CERTIFICATION LABEL SI/OWN' RARRA,VTY PL ;II6 TYPICAL t e a r,2 5A 6 I NOT FOR TITLE MADE CODE ASSEMBLY PLANT CODE ASSEMBLY PLANT CODE ASSEMBLY PLANT CODE ASSEMBLY PLANT A Atlanta 14 Lorain IT San Jose W Wayne B Oakville J Los Angeles X St. Thomas S Pilot Plant D Dallas K Kansas City (Allen Park) Y Wixom E Mahwah i, Long Beach (1965) Z St. Louis F G Dearborn Chicago N Norfolk T Metuchen P Twin Cities U Louisville 1 -

46 FORD CAR PARTS GENERAL INFORMATION 25 WARRANTY PLATE or CERTIFICATION LABEL (Refer to Pages 40 thru 44 for Bronco Warranty Plate Codes) SERIES CODES 1965 U.S. BUILT VEHICLES 1966/ U.S. and CANADIAN BUILT VEHICLES THE THIRD AND FOURTH DIGITS OF THE WARRANTY OR VEHICLE IDENTIFICATION NUMBER IDENTIFY THE BODY SERIES. THE FOLLOWING CHART LISTS THESE CODES (IN CONJUNCTION WITH THE 500Y TYPE CODES} AND THE SERIES OR MODEL WHICH THEY REPRESENT. CERTIFICATIOA LARAL Si/OWN CARRA :.TY PLATE. TYPICAL, CODE D E S C R I P T I O N CODE SERIES 1TYPE YEAR1 SERIES) TYPE YEAR D E S C R I P T I O N (A) FORD 1965/ e r r 51 : ~ f Custom 4 Door Sedan 51 54E 1 67/70 j.custom 4 Door Sedan { 57B 57H 65/66 GaL3.xie Dorn- Hardt.nn (Factharkl X71/ ' LTD 4 Door Hardtop ; 65/66 Custom 5C0 2 Dnnr Sedan _ 65 76A 65/66 Galaxie 500 Convertible /6G f Custom Door Sedan 52 62B Custom ~0 2 Door Sedan K 71T LTD Brougham 4.Door Pillared gar top 52 65D 71/ I Custom Door Hardtop _66 57F 67/70 LTD 4 Door Hardtop T _ /66 Galaxie Door Hardtop (Fastback) 53 54B. 67/70 : Custom : 00 4 Door Sedan 53 54D : 71/ "Custom Door Sedan 67 57K 71/ LTD Brougham 4 Door Hardtop 53 62E 1 65 /66 1 Custom 2 Door Sedan F 65/66 LTD 2 Door Fastback A 67/70 ]Galaxie 500 4Door Sedan C- 65/66 Galaxie 500 XL 2 Door Fastback(I3uckct seats ) 54 --_ 54F 65/66 C uctnm 4 :7nnr S p cl n 68 65K 71/ - LTD Brougham 2 Door Hardtop 54 54F 1 71/ I Galaxie Door Sedan /66 Galaxie 500 XI. Convertible 55 63B ' 67 Galaxie Door Hardtop _ ~ B 8/70 Galaxie 5002Door Hardtop (Fastback) } 71B 71/ 4 Door Custom Ranch Wagon D 67/70 4 Door Ranch Wagon (6 passenger] 56 57B 67/70 Galaxie Door Hardtop.---, 56 _57F 71/ Galaxie Door Hardto p Door Country Sedan (6 passenger) /66 4 Door Ranch Wagon (6 passenger) 57 76A 67/69 Galaxie 500 Convertible 71 71H 68/7014 Door Custom 500 Ranch Wagon(6 pass. ) 58 63C 67 IGalaxie 500XL 2Door Har~itop(Bucket seats] 72 7IB 65/66 14 Door Country Sedan (6 passenger) 58 65C _ :68/7_0 ; Galaxie 500 2Door Hardto p (Fo_rmal Roof) 72 7IC D 67 f 4 Door Country Sedan (13 passenger} 65F 711 Galaxie DoorHardtop 717 ^ 4 Door Custom 500 Ranch Wagon _ 72 71J 68/70 4 Boor. Custom 500 Ranch Wagon110 na_s_s. Y Galaxie 500 XL Convertible (L3ucke_t seats M 70 Custom Dnnr Hardtop 73 71B 66/70 4 Door Country Sedanf6 passenger) 73 ' 71E 67 4 Door Country Squire (6 passenger) 60 ' 57F 65/66. I.TD 4 Door Fastback 74 71A i 67 :4 Door Country Squire (10 passeneer) 80 :3C 8/70 2 Door Iar top Fastback) 74 7IC : 65/66, 4 Door Country Sedan (10 passenger) 6817pI e n o ' arc( p as ac T4 f 71F i 7/ 14 Door Country Sedan 61 _ 7013 l Convertib e _ 7ZiH LTD Convertible E 168/70. 4 Daor Country Squire(6 passeneer)! J D Door Sedan, 76 f 71A G /7Q Door Country Squire (I0 passenger) oor Hardtop 76 71E 65/66-4 Door Country Squire f6 passen ger) 62 5A F I moor Har.too orma Roo 76 71H ` 71/ 14 Door Country~aquire 8 H LTD 2 Door Hardtop A ;65/66. 4 Door Country Squire (10 passenger} 63 53H LTD 4 Dour Pillared Hardtop - - -~ D ~ 7 itre Converts e - - ~- xr_.., n-rr rndvar-ur n 1O]c _... nnnnnn ~( # A. COMPANY

47 26 GENERAL INFORMATION FORD CAR PARTS CDDE SERIE, TYPE YEAR] WARRANTY PLATE or CERTIFICATION LABEL (Refer to Pages 40 thru 44 for Bronco Warranty Plate Codes) SERIES CODES - continued D E S C R I P T I O NCODE SERIES [ TYPE (B) FAIRLANE/TORINO 1965/ YEAR E q E S C R I P T I O k 25 i 65A 71 2 Door Hardtop (Formal Roof) 41 54C 68 4 Door Sedan 25 65B 72 2 Door Hardtop (Formal Roof) 41 62B 65/ Door Sedan 27 MA 71 Torino 4 Door Sedan _ Door Station Wagon 27 53B-72 4 Door Pillared Hardtop 41 76C 87 VA XL Convertible Door Sedan 29 65B Door Hardtop 42 63D 68 GT 2 Door Hardtop (Fastback) G'ir`l TSoor Hardtop (Fastback-Bucket seats) 30 62A 67 2 Door Sedan A Door Hardtop (Formal R~ 42 63F 69 GT 2 Door Hardtop [Fastback) 30 65C 70 2 Door Hardtop : 42 54B Door Sedan 30 65C 71 Torino Door Hardtop (Formal Roof) 42 ; 63D G T 2 Door Hardtop 30 65C 71 ' :3oardfop (Formal Root) 42 71C 70 4 Door Station Wagon 30 65D 72 Gran Torino 2 Door Hardtop (Formal Roof) 42 71C Door Station Wagon 42 71D 72 Gran Torino 4 Door Station Wagon 31 54A 67/69 _ 4 Door Sedan 31 MC 70 4 Door Sedan 43 63B Door Hardtop 31 54C Door Sedan 43 65A Door Hardtop 31 62A 65/66 2 Door Sedan 43 71E 70/71 Squire 4 Door Station Wagon D 72 Gran Torino 4 Door Pillare3 Hardtop 43 76D GT Convertible 43 76D 68/69 GT Convertible (Bucket seats) 43 76F 69 GT Convertible (Bench seat) A 6/66 4Dopr Sedan 32 ' 57C 70 4 Door Hardtop K 72 Gran Torino Squire 4 Dpar Station Wagon 32 57C Door Hardtop 32 71D 67]69 4 Door Station Wagon 44 65D 68 GT 2 Door Hardtop (Formal Roof) D 69 GT 2 Door Hardtop {Formal Roof-Bucket 33 62B t boor Sedan seats) / D or Hardtop (Forma Roo f) 44 65F 69 UT` 2 Door Hardtop (Formal Roof) 33 65E 68/ Door Hardtop (Formal Roof-Bucket D GT Convertible seats) 33 65E 70/71 Broug ham 2 Door Hardto p (Formal Roof) 45 65E 69 Cobra 2 Door Hardtop(Formal Roof-Bucket / Door Sedan seats). 63C Door Hardtop (Fastback) ' 45 65A 69 Cobra 2 Door Hardtop (Formal Roof-Bench seat) Door Hardtop Convertible /69 ' Door HardtoD - 'astback) 35 63E 68/ Door Hardto p (Fastback-Bucket seats) 46 63B 69 Cobra 2 Door Hardtop Fastback-l3enchseat) 35 63F 70/71 GT 2 Door Hardtop (Fastback) 46 63E 69 Cobra 2 Door Hardtop [Fastback-Bucket 35 63R 1 '?2 Gran Torino 2 Door Hardtop (Fastback] seats) 46 66A 70/71 Ranchero 36 57E 70/71 Brougham 4 Door Hardtop 46 76C XL C onver tibl e 36 ' / Convertible E 68/ Convertible (Bucket seats) 47 63C XL 2 Door Hardtop Door Hardtop Sport Coupe / Door Station w axon 47 66A 67/69 Ranchero 37 76F 70/11 G 1 Convertible 47 66B 70/ Ranchero 47 97D 500 Ranchero H 70/71 : Cobra 2 Door Hardtop d (Fas1-lrack) 38 71t. 6-5/66 4 Door Ranch Wagon 48 66B 67/ Ranchero _- _ 38 7IE 67 Squire 4 Door Station Wagon _ 48 66C 70/71 GT Ranchero 38 _$ 71E 68/69 Souire 4 Door Station Wagon B 65 4 Door Custom Ranch Wagon 3a 65R 72 Gran Torino Sport 2 Door Hardtop (Formal 48 71B { Door Custom Ranch Wagon Root) 49 97R 72 GT Ranchero 40 63C XL 2 Door Hardtop 40 63D GT 2 Door Hardtop 40 65C 6W69 2 Door Hardtop (Formal Roof) 40 71D 71 4 Door Station Wagon TD Door Station Wagon ' 49, 66C 69 ~ GT Ranchero (Bench seat) 49 66D [ XL Ranchero (Bucket seats) 49 66D 68/69. GT Ranchero 49 66E. 70/71 Squire Ranchero 49 11E 66 Sauire 4 Door Station Wagon wire Ranchero

48 FORD CAR PARTS GENERAL INFORMATION WARRANTY PLATE OR CERTIFICATION LABEL (Refer to Pages 40 thru 44 for Bronco Warranty Plate C(xies) CODE %RTES! TYPE SERIES CODES - continued YEAR CODE D E S C R I P T I O N YEAR I D E S C R I P T I O N SERIES I I TYPE (B) FALCON Units Built from 1/1/70 (For Falcon units built prior to 1%1/70 - see Catalog Symbol " X" on the next page) A 70 Falcon 2 Door Sedan 4~ { _ Falcon 4 Door Station Wagon 27 54A 111 b Falcon 4 Door Sedan ~ Ol 65A 67/7q 2 Door Hardtop 01 65B 67/691' 2Door Hardtop (Luxury trim) l~ Flair 2 Door Hardtop 01 I65C 67/68 2 Door Hardtop 01 65C 169 I 2 Door Hardtop 01 65D L68/6 r~ 2 Door Hardtop (Luxurv trlm)_ 65D 1/ 2 Door Hardtop (6-5E 69 Grande 2 Door Hardtop TA 167 ; ~ 2 Door Hardtop (Fastback) _ 6P/70 m-4 6sT3f67/65 2Door Hardtop (Fastback-Luxury trim) 63B 70 ^ Flair 2 Door Hardtop (Fastback) 2 63C 68 2 Door Hardtop (Fastback) 12 63C 66, awah T Doo- rte dtop as ha ck) D 68 2 Door HardtopTFastback-Luxury Trimj OE_. 63D 71/ 2 Door Hardtop (Fastback (F) MUSTANG 1965/ 03 f 76A 167/701 Convertible B 68/69Convertible (Luxury trim) 03 76Bt70 1 Flair Con vertible C167 1Convertible 03 76D 167 Convertible (Luxury trim) 03 ~76D ~ l 71-/ )Convertible 04 65E 170 IGrande 2 Door Hardtop 04 65F 71/ 1Grande 2 Door Hardtop ) C 70 _Mach_ 12 Poor Hasdtop (Fastback) R.f Mach I 2 Door HadtopTF- tbc 07 65A j 65/66 I 1' 2 Door Hardtop /66~ 2 Door Har_c_to LLuxury trim)- 07 fi~c 165/66'-'for d top -08 I 76A1. 65/66 Conierlihle J66" Convertible (Luxury trim)_ OR 76C 65/661 Convertible 09 68A 165/66 2 Door Hardtop (Fastback) 03 I63B 65/66 2 Door Hardtop (Fastback-Luxury -trim) _62Bi T--Moor Sedan `-'`- (L) PINTO 1971/ if 1 I B 71/ i 8-Door Sedan (Ruti'05Out) Thor Station Wagon 1 f May, 1975 COPYRIGHT O FORD MOTOR -DEARBORN, MICHIGAN COMPANY FINAL ISSUE

49 28 GENERAL INFORMATION FORD CAR PARTS CODE SERIES TYPE YEAR WARRANTY PLATE OR CERTIFICATION LABEL (Refer to Pages 40 thru 44 for Bronco Warranty Plate Codes) SERIES CODES - continued C OU E D E S C R I P T I O N YEAR D E S C R I P T I O N SERIES TYPE A770/ (2Door Sedan-. 92 j54a 71/ 4 Door Sedan (P) MAVERICK 1970/ D, 71, Grab er 2 Door Sedan 81-63C 66 2 Door Hardtop (Blind Quarter) 65A ~67 12 Door Hardtop 82 T De%Landau 83 63A 65/66 2 Door Hardtop 1 65A 68T71 f2 Door Hardtop (Bucket seats) -AY 65C (68/71 2 Door Hardtop encti seat) it (S) THUNDERBIRD 1965/ Door Laiidau /71 2 Door Landau (Bucket seats) 84 65D BSr71' 2 Door Landau (Bench seat) 85 76A 65/6- Convertible B 68/69 4 Door Landau (Bucket seats) /7I 4 Door Landau (Split A^nch) 87 57C 68/71 4 Door Iandau {Bench seat) 87 63B Door-Landau 87 i 651C 72 2 Door Hardtop A 165 f, 66 --T-2--Door Sedan 2 Door Sedan 62D 65 2 boor Sedan 02 54A 65/66 ' 4 Dooedan _ 02 54D oor Se a i 171A 66 (X) FALCON 1965/70 - (For Falcon Units built from 1/1/70 4 Door Station Wagon 10 62A 67/70 2 Door Sedan fl ' 54A 67/70 f-4 Door Sedan Door Sedan Isoor Sedan A 67/68 4 Door Station Wagon 12 7IA 169/70 4 Door StandaṟTc Station Wagon -la Door Sedan TDTfcTet seat A 85 i Convertible-(Bench seat T5 ~- 7B 65 j Convertible73ucket seats 15 76D 65 I Convertible }. lfi~ 54Ei ) 6 Futura 4 boor Sedan t13ench seat) ' 66` -4 Uoor Dluxe Station Wagon rutura 211oor T~rdtop (B seat) 17 r63c 65 2 Do'o-r-TE-ir-df nFor Hardtop (Socket seats) Includes Units built before 1/1/70 see Catalog Symbol " B' on preceding page) Futura 2-Door Sedan Bach seat) Futura 2--Door; Sedan -20 L 62P 68/70 Futura 2 Door Sedan (Bench seat) 21 54B l ufura 4ordan 21 69A ld m Station Wagon C T67/69I2Door Sedan (Buc et eats) 22 71A 65 ( 4 Door Station Wagon uturatdoor Station Wagon 24 f Futura 4-Door Station Wagon C 65 4 Door Squire I-,-6-6-A- 66A 6 ;76 StandarcTT~anc ero _ 27 66B 15 Deluxe-Rancero 27 66C 65 Standard '1Taiichero -(Bucket seats ) ` H 1 65 Deluxe Ranchero -- 6' Custarri t is zero 2T `1 Custom Ranchero 2P~ 6A T5 Standard Sedan DeTe7ry

50 FORD CAR PARTS GENERAL INFORMATION 29 WARRANTY PLATE or CERTIFICATION LABEL (Refer to Pages 40 thru 44 for Bronco Warranty Plate Codes) ENGINE CODES 1965 U.S. BUILT VEHICLES 1966/ U.S. and CANADIAN BUILT VEHICLES THE FIFTH DIGIT OF THE WARRANTY OR VEHICLE IDENTIFICATION NUMBER INDICATES BASIC ENGINE IDENTIFICATION. Li:i :Ebtit THE FOLLOWING CHART LISTS THESE CODES AS WELL AS NUMBER OF CYLINDERS, NOT FOR Td1LE CUBIC INCH DISPLACEMENT AND NUMBER OF CARBURETOR VENTURI. FOR FURTHER ENGINE IDENTIFICATION REFER TO SECTION 60 IN THIS CATALOG. CERTIFICATION LAREL N Q%S Ii ARRAN TY PLATE TYPICAL T YEAR Er LINE T INE CARE R E k A R K S CODE YEAR GARB CYC.I.D CYL. C.I.D REMARK S A -65/6-7--I" 289 4V PJF -g ~ 300 4v ~~ -_- P/C 65/10 6 X46` 1V P/C a.. ' v V x,`'65/ `- V V GT V _~ Cobra Jet _.._ - R 65/67 Hi-performance D V 68 I 428 Cobra Jet thyd. lifters) -69/ V Si Taxi 71/ V Boss --E-"---65/ V' Taxi 35ff GT -F f T E -1- G _..- $ I 4V Boss r U H 66/ V -- _ - = _ 69% V NOTE 1 Mg. J 68 $ 302 4V "~ Hi-per ormance 70/11 S :429 4V obra Jet 71/ cc or 1.6 Titres IK- 65/67 $ 289 4VFtl-per}brniance _ X9/ V ` i/ 4 12_2-2V 00 cc or E.U litres ~_R L 69J V - Y 1I 3V gg. I V P ~~ X50 2v 1t/F.-- IiS 69/71 ' V -~ /68. I! 8 4V N 68/ V _ 4V Refer to nine IdentlfIcatlon Tag or Label to determine if Cleveland (351C) or Hlndsor (351 W) bu '. t engine. May, 1975 COPYRIGHT O FINAL ISSUE FORD MOTOR -DEARBORN, MICHIGAN COMPANY

51

52 GENERAL INFORMATION FORD CAR PARTS CHASSIS PARTS ILLUSTRATION INDEX Following is a general index of the major groups shown in the Chassis and Body Parts Illustration Sections. For more specific information refer to the Index appearing in front of the Section number listed below. MAJOR GROUP TABBED DIVIDER TITLE INDEX SECTION Accelerator Linkage Fuel 90 Accessories Air Cleaner Listed in their appropriate groups as identified in this index Fuel 90 Air Conditioner Speedometer, Bumper 175 Alternator Generator, Alternator, Starter, Distributor 100 Automatic Transmission Automatic Transmission A70 Axle (rear) Rear Axle, Driveshaft 40 Battery Generator, Alternator, Starter, Distributor 100 Brake System Wheels, Brakes 10 Bumpers Speedometer, Bumper 175 Carburetor Fuel 90 Carrier (Wheel) Wheels, Brakes 10 Clutch Standard Transmission, Clutch 70 Cooling System Cooling, Grille 80 Distributor Generator, Alternator, Starter, Distributor 100 Driveshaft Rear Axle, Driveshaft 40 Electrical Generator, Alternator, Starter, Distributor 100 Electrical Lamps, Wiring 130 Engine Engine 60 Exhaust System Frames, Mufflers, Springs 50 Fan Cooling, Grille 80 Fenders Fender, Hood 160 Frame Frames, Mufflers, Springs 50 Front Suspension Front Suspension, Steering 30 Fuel Pump Fuel 90 Fuel System Fuel 90 Fuel Tank Fuel 90 Gearshift Lever Standard Transmission, Clutch 70 Generator Generator, Alternator, Starter, Distributor 100 Grille Cooling, Grille 80 Heater Speedometer, Bumper 175 Hood Fender, Hood 160 Horn Lamps, Wiring 130 Instrument Cluster Generator, Alternator, Starter, Distributor 100 Lamps Lamps, Wiring 130 Lever (Gearshift) Standard Transmission, Clutch 70 Manifolds Fuel 90 Mirrors Speedometer, Bumper 175 Muffler Frames, Muffler, Springs 50 Pump (Fuel) Fuel 90 Pump (Water) Cooling, Grille 80 Radiator Cooling, Grille 80 Rear Axle Rear Axle, Driveshaft 40 plicable to Loose Leaf Catalogs only.

53 FORD CAR PARTS GENERAL INFORMATION 3 CHASSIS PARTS ILLUSTRATION INDEX - contd. MAJOR GROUP TABBED DIVIDER TITLE INDEX SECTION Speedometer Speedometer, Bumper 175 Springs Frames, Mufflers, Springs 50 Stabilizer (Front) Front Suspension, Steering 30 Stabilizer (Rear) Frames, Mufflers, Springs 50 Starter Generator, Alternator, Starter, Distributor 100 Steering Front Suspension, Steering 30 Suspension (Front) Front Suspension, Steering 30 Tachometer Generator, Alternator, Starter, Distributor 100 Tank (Fuel) Fuel 90 Transfer Case Standard Transmission Clutch 70 Transmission (Automatic) Automatic Transmission A70 Transmission (Standard) Standard Transmission, Clutch 70 Voltage Regulator Generator, Alternator, Starter, Distributor 100 Water Pump Cooling, Grille 80 Wheels Wheels, Brakes 10 Windshield Wiper Speedometer, Bumper 175 Wiring Lamps, Wiring 130 BODY PARTS ILLUSTRATION INDEX Auxiliary Seat Seat 600 Back Window Back, Luggage Compartment 400 Body Sheet Metal Body Sheet Metal Body Sheet Metal Console Body Front, Floor 000 Door (Front) Body Sides, Quarter 230 Door (Rear) Body Sides, Quarter 230 Exterior Trim Exterior Moulding Exterior Moulding Floor Sheet Metal Body Sheet Metal Body Sheet Metal Folding Top Back, Luggage Compartment 400 Front Door Body Sides, Quarter 230 Front Seat Seat 600 Front Seat Track Seat 600 Glove Compartment Body Front, Floor 000 Instrument Panel Body Front, Floor 000 Interior Trim Interior Trim Interior Trim Liftgate Back, Luggage Compartment 400 Luggage Compartment Door Mechanism Back, Luggage Compartment 400 Luggage Compartment Trim Interior Trim Interior Trim Package Tray Interior Trim Interior Trim Quarter Window Body Sides, Quarter 230 Rear Door Body Sides, Quarter 230 Rear Seat Seat 600 Roof Back, Luggage Compartment 400 Sheet Metal Body Sheet Metal Body Sheet Metal Tailgate Back, Luggage Compartment 400 Top (Folding) Back, Luggage Compartment 400 Track (Front Seat) Seat 600 Vent System Body Front, Floor 000 Windshield Body Front, Floor 000 Applicable to Loose Leaf Catalogs only. May, 1975 COPYRIGHT FORD MOTOR -DEARBORN, MICHIGAN COMPANY FINAL ISSUE

54 GENERAL INFORMATION FORD CAR PARTS, PROCEDURE FOR 'USING CATALOG There are three ways of finding part numbers 1. By Part Name 2. By Illustration 3. By Identification Should an inquiry be received for a rear brake backing plate for a 1965 Thunderbird - BY PART NAME A. Refer to the Chassis Parts Alphabetical Index in the Text Catalog, form FP 7635-A. B. Refer to the alphabetical nomenclature and find the part name "Plate (rear brake backing)". The group number listed is C. Refer to group number and locate 1965 in the "YEAR" column. Find the vehicle catalog code "S" (for Thunderbird) in the "MODEL" column. D. The part numbers shown are C6SZ 2211-A for right hand and C6SZ 2212-A for left hand. BY ILLUSTRATION A. Refer to the tabbed divider marked 'WHEELS, BRAKES" in this catalog. B. Refer to the index immediately behind the divider and find the illustration titles for 1965 S(Thunderbird). C. Under the heading "BRAKES" find the 'Brake details (drum rear)" illustration for the 1965 S(Thunderbird). D. Refer to the illustration designated (on page 4 of Illustration Section 20.1) and find the group number for the rear brake backing plate to be E. Refer to group number in the Text Catalog and locate 1965 in the "YEAR" column. Find the vehicle catalog code "S" (for Thunderbird) in the "MODEL" column. F. The part numbers shown are C6SZ 2211-A for right hand and C6SZ 2212-A for left hand. BY IDENTIFICATION Certain parts and most major assemblies are identified with a part number shown on an attached tag or plate or on the part itself. Reference to identification numbers is made throughout the catalog and cross reference charts are included in some sections w provide immediate knowledge of the service part number when the identification number is known. All identification information other than charts will be preceded by the symbol (#). IMPORTANT - Identification tags and plates must be retained with the part or assembly with which they are originally supplied. HOW TO ORDER PARTS When ordering parts, always give the complete part number. In the event the part number is not known, the following information should be included. A. Complete description of part. B. Model year and body type. C. Dimension, number of teeth, size, etc., if possible rough sketch of part. D. If applicable to engine, transmission, axle, steering, etc., specify type, such as 400 cubic inch, Automatic Transmission, Power Steering, etc. E. Advise how shipment is to be made - Freight, Express, Air, Parcel Post. EXPLANATION OF SYMBOL * * Symbol indicates part is not supplied for service due to the following a. Part is superseded and replaced as indicated in the description column of the text catalog. b. Part can be improvised as indicated in the description column of text catalog. c. Due to its function there would be little or no demand. NOTE - ALWAYS REFER TO THE DESCRIPTION COLUMN OF THE TEXT FOR POSSIBLE SUBSTITUTION, OR FOR MATERIAL SPECIFICATIONS AND DIMENSIONS WHICH MAY BE HELPFUL IN OBTAINING THE NON-SERVICED PART LOCALLY.

55 FORD CAR PARTS INDEX ILLUSTRATIO N SECTION 10 A THIS INDEX SECTION INCLUDES BRAKES, WHEELS and RELATED PART S A (FORD ) TITLE SECTION~ PAGE ILLUS. NO BRAKE S Brake & clutch pedals 75 1 P Drum brake system 20 1 P Brake booster installation Booster details (Midland - Ross) P Brake cylinder details - front & rear P Brake details - front & rear P Brake master cylinder details P-3098 Parking brake system 20 1 P Front & rear wheel, hub, & bearings 10 1 P Hub cap & wheel cover - refer to text Group Spare wheel & jack storage P B (FAIRLANE/TORINO) BRAKE S Brake & clutch pedals 75 2 P Drum brake system 20 3 P Brake booster installation (Midland - Ross) 20 3 P Booster details (Midland - Ross) 23 2 P Brake cylinder details - front & rear P Brake details - front & rear P-3703 Brake master cylinder details P-3098 Parking brake system 20 3 P Front & rear wheel, hub, & bearings 10 1 P Hub cap & wheel cover - Refer to text Group Spare wheel and jack storage - except station wagon - station wagon P P F (MUSTANG ) BRAKES _ Brake & clutch pedals 75 5 P-4472 Disc brake system 20 6 P-4470 Brake booster installation (Bendix) 23 1 P Booster details (Bendix) 23 3 P Brake cylinder details - rear P-2990 Brake details - disc front P-4604 Brake details - drum rear P Brake master cylinder detail s P Drum brake system P Brake booster installation (Bendix) 23 1 P Booster details (Bendix) P Brake cylinder details - front & rea r P-2990 Brake details - front & rear P Brake master cylinder details P-3098 Parking brake system 20 6 P-4470 Front & rear wheel, hub, & bearings 10 1 Hub cap 8z-wheel cover - refer to text Group P Spare wheel & iaek storage P455c Wheel lug nuts (M Stang GT350/500) -refer to text Group 1012 I I I laic COPYRIGHT FORD MOTOR -DEARBORN. MICHIGAN Mau Al I I N! COMPANY

56 B ILLUSTRATION SECTION 10 FORD CAR PARTS S (THUNDERBIRD ) INDEX TITLE SECTION I PAGE ~ ILLUS. NO BRAKES Brake pedal 20 7 P Disc brake system 20 7 P Brake booster installation 20 7 P Booster details (Bendix) 23 4 P-4892 Brake cylinder details - rear P Brake details - disc front P-4603 _ Brake details - drum rear P Brake master cylinder details P-3098 Parking brake system 20 7 i P WHEELS Front & rear wheel, hub, & bearings 10 1 P Hub cap & wheel cover - refer to text Group Spare wheel & jack storage P-4597 X (FALCON ) BRAKES Brake & clutch pedal - manual gear shift 75 7 P-3130 Brake pedal - automatic transmission 75 7 P-3131 Drum brake system 20 4 P Brake booster installation Booster details (Bendix) 23 3 P Brake cylinder - front & rear P Brake details - front & rear P Brake master cylinder details P-3098 Parking brake system 20 4 P WHEELS Front & rear wheel, hub, & bearings 10 1 P Hub cap & wheel cover - refer to text Group 1130 Spare wheel & jack storage P _ A (FORD ) 1966 BRAKES Brake & clutch pedals 75 1 P Disc brake system 20 2 P Brake booster installation 20 2 P Booster details (Midland - Ross) 23 2 P Brake cylinder details - rear P Brake details - disc front P Brake details - drum rear P Brake master cylinder details P-3098 Drum brake system 20 1 P Brake cylinder details - front & rear P-2284 _ Brake details - front & rear P-3380 Brake master cylinder details P Parking brake system 20 1 P-4610 WHEELS Front & rear wheel, hub, & bearings 10 I1 I P Hub cap & wheel cover - refer to text Group 1130 Spare wheel & jack storage P-4823

57 FORD CAR PARTS INDEX ILLUSTRATIO N SECTION 1 0 C B (FAIRLANE/TORINO ) SECTION ~ PAGE ~ ILLUS TITLE. NO Brake & clutch pedals 75 4 P Drum brake system 20 5 P Brake booster installation 20 5 P Booster details (Midland - Ross) 23 2 P Brake cylinder details - front & rear P Brake details - front & rear _ P Brake master cylinder details P Parking brake system 20 5 P WHEEL S Front & rear wheel, hub, & bearings 10 1 P Hub cap & wheel cover - refer to text Group 1130 Spare wheel & jack storage - except station wago n - station wagon P P F (MUSTANG) BRAKES Brake & clutch pedals 75 5 P Disc brake system 20 6 P Brake booster installation (Bendix) 23 1 P Booster details (Bendix) 23 3 P-4590 Brake cylinder details - rear P Brake details - disc front P Brake details - drum rear P-3703 Brake master cylinder details P Drum brake system 20 6 P-4470 Brake booster installation (Bendix) 23 1 P Booster details (Bendix) 23 3 P-4590 Brake cylinder details - front & rear P Brake details - front & rear P Brake master cylinder details P-3098 Parking brake system 20 6 P-4470 WHEELS Front & rear wheel, hub, & bearings 10 1 P Hub cap & wheel cover - refer to text Group Spare wheel & jack storage P Wheel lug nuts (Mustang GT350/500) - refer to text Group S (THUNDERBIRD) BRAKES Brake pedal 20 7 P-4240 Disc brake system 20 '7 P-4240 Brake booster installation 20 7 P-4240 Booster details (Bendix) 23 4 P-4892 Brake cylinder details - rear P Brake details - disc front P Brake details - drum rear P-3380 Brake master cylinder details P-3098 Parking brake system 20 7 P-4240 WHEELS Front & rear wheel, hub, & bearings 10 1 P Hub cap & wheel cover - refer to text Group 1130 Spare wheel & jack storage P-4597 May, 1975 COPYRIGHT FORD MOTOR company -DEARBORN, MICHIGAN FINAL ISSUE

58 D ILLUSTRATION FORD CAR PARTS SECTION 10 U (BRONCO ) INDEX TITLE 'SECTION' PAGE ILLUS. NO BRAKE S Brake & clutch pedals 75 6 P Drum brake system 20 8 P Brake cylinder details - front & rear P Brake details - front & rear P-6602 Brake master cylinder details P Parking brake system 20 8 P WHEELS Free running hub - Dana~Spicer~ 10 P-7799 _ Front hub & bearings 30 7 P-5312 Hub cap & wheel cover - refer to text Group Spare wheel & jack storage - Before Ser. 830,001 - From Ser. 830, P-4982 P _ X (FALCON ) BRAKE S Brake & clutch pedals 75 4 P Drum brake system 20 5 P Brake booster installation Booster details (Midland - Ross) P P Brake cylinder details - front & rear P Brake details - front & rear P Brake master cylinder details P-3098 Parking brake system 20 5 P WHEELS Front & rear wheel, hub, & bearings 10 1 P Hub cap & wheel cover - refer to text Group Spare wheel & jack storage - except Ranchero & station wagon - Ranchero & station wagon P P A (FORD ) 1967 BRAKES Brake & clutch pedals 75 1 P Disc brake system P Brake booster installation P Brake cylinder details - rear P Brake details - disc front P Brake details - drum rear P Drum brake system 20 9 P Brake cylinder details - front & rear P Brake details - front & rear P Parking brake system 20 9 P-5482 WHEEL S Front & rear wheel, hub, & bearings 10 1 P Hub cap & wheel cover - refer to text Group Spare wheel & jack storage P-5'779

59 FORD CAR PARTS ILLUSTRATIO N SECTION 1 0 E B (FAIRLANE/TORINO) INDEX TITLE SECTION PAGE I ILLUS. NO BRAKES Brake & clutch pedals 75 9 P Disc brake system P Brake booster installation P Brake cylinder details - rear P Brake details - disc front P-4604 Brake details - drum rear P Drum brake system P Brake booster installation P Brake cylinder details - front & rear P-3906 Brake details - front & rear P-3703 Parking brake system P WHEEL S Front & rear wheel, hub, & bearings 10 1 P Hub cap & wheel cover - refer to text Group Spare wheel & jack storage - except Ranchero & station wagon - Ranchero & station wagon P P F (MUSTANG) BRAKES Brake & clutch pedals P Disc brake system P Brake booster installation P Brake cylinder details - rear P Brake details - disc front P-4604 Brake details - drum rear P-3703 Drum brake system P Brake cylinder details - front & rear P Brake details - front & rear P-3703 Parking brake system P-5518 WHEELS Front & rear wheel, hub, & bearings 10 1 P Hub cap & wheel cover - refer to text Group Spare wheel & jack storage P-4596 WheTlug nuts (Mustang GT350/500) - refer to text Group S (THUNDERBIRD ) BRAKES Disc brake system P-5480 Brake booster installation P-5480 Brake cylinder details - rear P-3906 Brake details - disc front P-4603 Brake details - drum rear P-3380 Parking brake system P Front & rear wheel, hub, & bearings Hub cap & wheel cover - refer to text Group f 10 I 1 I P Spare wheel & jack storage P-5780 _ BE 1~S COPYRIGHT FORD MOTOR - DEASSORN. MICHIQAN MAI n MAIM COMPAN Y I

60 F ILLUSTRATIO N SECTION 10 FORD CAR PARTS INDEX U (BRONCO ) TITI F SECTION ~ PAGE ~ ILLUS. NO BRAKES Brake & clutch pedals 75 6 P Drum brake system 20 8 P _., Brake cylinder details - front & rear P Brake details - front & rear P Parking brake system 20 8 P WHEELS Free running hub - Dana (picer) 10 3 P Front hub, & bearings 30 7 Hub cap & wheel cover - refer to text Group 1130 Spare wheel & jack storage P-6599 X (FALCON ) BRAKE S Brake & clutch pedals 75 9 P Disc brake system P Brake booster installation P Brake cylinder details - rear P Brake details - disc front P Brake details - drum rear P-3703 Drum brake system P Brake booster installation P Brake cylinder details - front & rear P Brake details - front & rear P-3703 Parking brake system P WHEELS Front & rear wheel, hub, & bearings 10 1 P Hub cap & wheel cover - refer to text Group 1130 Spare wheel & jack storage - except station wago n - station wagon A (FORD ) P P BRAKES Brake & clutch pedals 75 1 P Disc brake system P Brake booster installation P Brake cylinder details - rear P Brake details - disc front P-6219 Brake details - drum rear P-3380 Drum brake system 20 9 P-5482 Brake cylinder details - front & rear P Brake details - front & rear P-3380 Parking brake system 20 9 P-5482 WHEELS Front & rear wheel, hub. & bearin gs 10 I 1 I P Hub cap & wheel cover - refer to text Group 1130 Spare wheel & jack storage P-577 9

61 FORD CAR PARTS INDEX ILLUSTRATIO N SECTION 10 G B (FAIRLANE/TORINO ) TITLE SECTION PAGE 1 ILLUS. NO BRAKES Brake & clutch pedals P Disc brake system P Brake booster installation P Brake cylinder details - rear P Brake details - disc front P Brake details - drum rear P Drum brake system P Brake booster installation P Brake cylinder details - front & rear P Brake details - front & rear P Parking brake system P WHF.F.T.S Front & rear wheel, hub, & bearings 10 1 P Hub cap & wheel cover - refer to text Group 1130 Spare wheel & jack storage - except Ranchero & station wagon - Ranchero & station wagon P P-5212 F (MUSTANG) BRAKE S Brake & clutch pedals P Disc brake system P Brake booster installation P Brake cylinder details - rear P Brake details - disc front P Brake details - drum rear P-3703 Drum brake system P Brake booster installation P Brake cylinder details - front & rear P Brake details - front & rear P Parking brake system P Front & rear wheel, hub, & bearings 10 1 P Hub cap & wheel cover - refer to text Group 1130 Spare wheel & jack storage P Wheel lug nuts (Mustang GT350/500) - refer to text Group 1012 S (THUNDERBIRD ) BRAKE S Disc brake system 20 ' 14 P Brake booster installation P Brake cylinder details - rear 20.1 P Brake details - disc front P _ Brake details - drum rear P Parking brake system P Front & rear wheel, hub, & bearings 10 1 P Hub cap & wheel cover - refer to text Group Spare wheel & jack storage P-5780 ay, GVMYNNY -DEARBORN. MICHIGAN FINAL ISSUE

62 H ILLUSTRATIO N SECTION 10 U (BRONCO) FORD CAR PARTS INDEX TITLE SEGT'.-'N I " ILLUS. NO BRAKES Brake & clutch pedals 75 6 P Drum brake system 20 8 P Brake cylinder details - front & rear P Brake details - front & rear P Parking brake system 20 8 P WHEEL S Free running hub - Dana Spfcei) 10 3 P Front hub & bearings 30 7 P Hub cap & wheel cover - refer to text Group 1130 Jack parts P-6600 Spare wheel carrier - swing away 10 2 P-6232 X (FALCON) BRAKE S Brake & clutch pedals P-6541 Disc brake system P Brake booster installation P Brake cylinder details - rear P Brake details - disc front P Brake details - drum rear P Brake master cylinder details P-5518 _ Drum brake system P Brake booster installation P Brake cylinder details - front & rear P Brake details - front & rear P Parking brake system P WHEELS Front & rear wheel, hub, & bearings 10 1 P Hub cap & wheel cover - refer to text Group Spare wheel & jack storage - except station wagon - station wagon A (FORD ) P P BRAKES Brake & clutch pedals P Disc brake system - power - except New York taxi - non-power - New York taxi P-6718 P-6720 Brake booster installation P Brake cylinder details - rear P-2284 Brake details - disc front P Brake details - drum rear P Drum brake system P Brake cylinder details - front & rear P-2284 Brake details - front & rear P Parking brake system P w nlr :i.s Front & rear wheel, hub, & bearings 10 1 P Hub cap & wheel cover - refer to text Group are wheel & jack storage - except model model P P-7056

63 B (FAIRLANE/TORINO ) FORD CAR!ARTS INDEX ILLUSTRATION SECTION 10 TITLE ~SECTION PAGE ILLUS. NO BRAKE S Brake & clutch pedals P Disc brake system P Brake booster installation P Brake cylinder details - rear P Brake details - disc front P Brake details - drum rear P Drum brake system P Brake booster installation P Brake cylinder details - front & rear P Brake details - front & rear P-3703 Parking brake system P J Front & rear wheel, hub, & bearings 10 1 Hub cap & wheel cover - refer to text Group P Spare wheel & jack storage - except Ranchero & station wago n - Ranchero & station wagon P P F (MUSTANG) BRAKE S Brake & clutch details P-6756 Disc brake system P-6754 Brake booster installation P-6754 Brake cylinder details - rear P Brake details - disc front P Brake details - drum rear P Drum brake system P-6754 Brake cylinder details - front & rear P Brake details - front & rear P Parking brake system P Front & rear wheel, hub, & bearings 1o 1 P Hub cap & wheel cover - refer to text Group Spare wheel & jack storage P Wheel lug nuts (Mustang GT350/500) - refer to text Group S (THUNDERBIRD ) BRAKE S Disc brake system P Anti-skid control system P Brake booster installation P Brake cylinder details - rear P Brake details - disc front P Brake details - drum rear P Parking brake system P-6400 Front & rear wheel, hub, & bearings _ 10 1 P-1780 Hub cap & wheel cover - refer to text Group 1130 Spare wheel & jack storage P-5780 ay, f nupanv -DEARBORN, MICHIGAN FINAL- ISSUE

64 K ILLUSTRATION FORD CAR PARTS SECTION 10 U (BRONCO ) INDEX TITLE [SECTION' PAGE 1 ILLUS. NO BRAKE S Brake & clutch pedals 75 6 P Drum brake system 20 8 P Brake cylinder details - front & rear P Brake details - front & rear P Parking brake system 20 8 P Free running hub - Dana (Spicer) 10 3 P-7799 Front hub & bearings 30 7 P Hub cap & wheel cover - refer to text Group 1130 Jack parts P Spare wheel carrier - swing away 10 2 P X (FALCON) Brake & clutch pedals P-6541 Disc brake system P Brake booster installation P Brake cylinder details - rear P Brake details - disc front P-6218 Brake details - drum rear P Drum brake system P Brake booster installation P Brake cylinder details - front & rear P Brake details - front & rear P Parking brake system P Front & rear wheel, hub, & bearings 10 1 P Hub cap & wheel cover - refer to text Group Spare wheel & jack storage - except station wago n P station wagon P A (FORD) 1970 BRAKES Brake & clutch pedals P Disc brake system P-7500 Brake booster installation P-7500 Brake cylinder details - rear P Brake details - disc front P Brake details - drum rear P-3380 Drum brake system P Brake booster installation P Brake cylinder details - front & rear P-2284 Brake details - front & rear P-3380 Parking brake system P WHEEL S Front & rear wheel, hub & bearing 1 10 I 1 I P-1780 Hub cap & wheel cover - refer to text Group 1130 Spare wheel & jack storage - except model model P P-7056

65 B (FAIRLANE/TORINO) FORD CAR PARTS INDEX ILLUSTRATIO N SECTION 10 TITLE SECTION PAGE ~ ILLUS. NO R(FALCON)FROM 1/2/7 0 BRAKE S Brake & clutch pedals P Disc brake system P Brake booster installation P-7308 Brake cylinder details - rear P Brake details - disc front P Brake details - drum rear P-3703 Drum brake system P Brake cylinder details - front & rear P Brake details - front & rear P-3703 Parking brake system P WHEEL S Front & rear wheel, hub & bearings 10 1 P Hub cap & wheel cover - refer to text Group Spare wheel jack storage - except Ranchero & station wago n - Ranchero & station wagon P P L F (MUSTANG) BRAKE S Brake & clutch pedals P Disc brake system P Brake booster installation P-6754 Brake cylinder details - rear P-3906 Brake details - disc front P Brake details - drum rear P Drum brake system P Brake cylinder details - front & rear P-3906 Brake details - front & rear P Parking brake system P WHEEL S Front & rear wheel, hub & bearings 10 1 P Hub cap & wheel cover - refer to text Group Spare wheel & jack storage P P (MAVERICK ) BRAKES Brake & clutch pedals P Drum brake system P Brake cylinder details - front & rear P Brake details - front & rear P Parking brake system P WHEELS Front & rear wheel, hub, & bearings I 10 I 1 I P Hub cap & wheel cover - refer to text Group Spare wheel & jack storage P M[ COPYRIGHT FORD MOTOR -DEARBORN. MICHIGAN M---_ COMPANY

66 M ILLUSTRATION SECTION 10 S (THUNDERBIRD ) FORD CAR PARTS INDEX TITLE I SECTION I PAGE I ILLUS. NO BRAKE S Disc brake system P Anti-skid control system Tsue~sack)- ore /70 " P "From 1/12/70" P Brake booster installation P-6399 Brake cylinder details - rear P Brake details - disc front P Brake details - drum rear P Parking brake system P WHEEL S Front & rear wheel, hub & bearings 10 1 P-1780 Hub cap & wheel cover - refer to text Group 1130 Spare wheel & jack storage P U (BRONCO ) BRAKE S Brake & clutch pedals 75 6 P Drum brake system 20 8 P Brake cylinder details - front & rear P Brake details - front & rear P-6602 Parking brake system 20 8 P WHEELS Free running hub -Dana (Spicer) 10 3 P-7799 Front hub & bearings 30 7 P Hub cap & wheel cover - refer to text Group Jack parts P Spare wheel carrier - swing away 10 2 P X (FALCON) mono 1/2/7 0 FOR UNITS BUILT FROM 1/2/70, REFER TO $(FALCON ) BRAKE S Brake & clutch pedals P-6541 Disc brake system P Brake booster installation P Brake cylinder details - rear P Brake details - disc front P Brake details - drum rear P Brake master cylinder details P Drum brake system P Brake booster installation P Brake cylinder details - front & rear P-3906 Brake details - front & rear P-3703 Parking brake system P WHEEL S Front & rear wheel, hub & bearings 10 1 P Hub cap & wheel cover - refer to text Group Spare wheel & jack storage - except station wagon - station wagon P P-5212

67 FORD CAR PARTS ILLUSTRATIO N SECTION 10 N A (FORD) TITLE INDEX 1971!SECTIONI AC f BRAKES Brake & clutch pedals P Disc brake system P Brake booster installation P-7500 Brake cylinder details - rear P-2284 Brake details - disc front P-6219 _ Brake details - drum rear P Drum brake system 20 P= Brake booster installation P Brake cylinder details - front & rear P Brake detailswont-rear _._- _. I- p _ Brake master cylinder details P-5518 Parking brake system P Front & rear wheel -hi-lbw.tearing Hub cap& wheel cover - rd-erto text Group - 1T20- Spare wheel & jack storage - excel mode3 7I-- - model 71 B (TORINO) i0 175: P P BRAKES Brake & clutch p a _ 5 - -f5 - P-7306 Disc brake system P Brake booster installation P-7308 Brake cylinder details - rear P 'rake details--disc fion --- ~D. 3-10P-62 8 Brake details-arum rear Brake master cylinder details P Drumbrake s yys~exn P4308 Brake cylinder details - front & rea r P Siake~etuTs = front~i rear - 20 T =3'703 Parking brake system P20 7 _.- FrontTear eel, hub & bearing s P Hub cap & wheel cover - refer to teext-oronp 1130 Spare wheel jack storag e - except-etanc3i ero tation wagon P Ranchero & station wagon P-5212 F (MUSTANG ) --Maas -_ -- ~rar~e ~iclues ~pe~ats P Disc brake system P Brake booster fns~alla~ion P Brake cylinder details - rear P-3906 Brake details -disc front 20.I-i0 P Brake details - drumrear P-3703 Brake master cylinder details P-5518 Drum brake system - 20 ' 3b P Brake cylinder details - front & rear P Brake detail-s = front & rear P Brake master cylinder detail s _ - Parking brake system WHEELS P P=U43 '- - _ Front & rear w.eei, hub o c bearings 10 1 P Hub cap & wheel cover - refer to - O-coup - Ti30 Spare wheel & Jack stora ge P4063 _ as_-_. Me `^PY!! :C : IT DRD MOTOR - DEAneOnn. MI{a1IMAN AIAI AI Il NI I! COMPANY -

68 P ILLUSTRATIO N SECTION 10 L (PINTO ) FORD CAR PARTS INDEX TITLE SECTION I PAGE ~ ILLUS. NO BRAKES Brake and clutch pedals P Disc brake system P Brake cylinder details - rear P Brake details - disc front P-7937 Brake details -drum rear ~0~-5 P Drum brake system P Brake cylinder details - front & rear P Brake details - front & rear P-3703 Parking brake system P WHEELS _ - F-raiif &-f-ear wheel,-- hub C-liearinga Hub cap & wheel cover - Refer to text Group P Spare *Tel and j k storag e TI--P P (MAVERICK ) BRAKE S Brake & clutch ped-als Drum brake system P Brake cylinder details - front & rear P Brake details - front & rear P-3'70 3 Parking brake system P HEELS Front & rear wheel, hub, & bearings Hub cap & wheel cover - refer to text Group 1130 S (THUNDERBIRD) BRAKE S Disc brake system = Anti-skid control system (sure traek) P Brake booster installation Brake cylinder details - rear P Brake details - disc front I. ~~ P Drake details - drum rear I. P- : e Parking brake system P-6400 WHEELS Front & rear wheel, hub & bearings 10 1 P-1780 Hub cap & wheel cover - refer to text Group 1130 Spare wheel & jack storage P-5780 U (BRONCO ) BRAKE S Brake & clutch pedals 75 6 P Drum brake system P Brake cylinder details - front & rear P-3906 Brake details - front & rear P-6602 Parking brake system P WHEELS Free running hub - Dana (Spicer) 10 3 P-7799 Front hub & bearings _ 30 7 P-5312 Hub cap & wheel cover - refer to text Group 1130 Jack parts P-6600 Spare wheel carrier - swing away 10 2 P-623 2

69 FORD CAR PARTS ILLUSTRATION SECTION 10 Q A (FORD ) INDEX TITLE SECTION I PAGE ILLUS. NO BRAKE S Disc brake system P Brake booster installation P Brake cylinder details - rear P Brake details - disc front P Brake details - drum rear P Brake master cylinder details P Drum brake system P Brake booster installation P Brake cylinder details - front & rear P-2284 Brake details - front & rear P Parkmg brake sys P-6721 _ Front & rear wheel, hub & bearing 10 1 P Hub cap & wheel cover - refer to text Group 13 0 Spare wheel & jack stora g e - except model model 71 B (TORINO ) T P P BRAKES Brake & clutch pedals P-M12 Disc brake system P Brake booster installation P Brake cylinder details - rear P Brake details - disc front P Brake details - drum rear P-370f Parking brake system P-R511 4 Front & rear wheel, hub & bearings 10 1 P Hub cap & wheel cover - refer to text Group 13 0 Spare wheel & jack storage - except Ranchero & Station wagon P Ranchero P Station Wagon P-9974 F (MUSTANG) BRAKES Brake &crutch pedals P Disc brake system P Brake booster installation P Brake cylinder details - rear P Brake details - disc front P Brake details - drum rear P Drum brake system P Brake cylinder details - front & rear P Brake details - front & rear P-3703 Parking brake system P Front & rear Wlleel,hub & bearings 10 1 P Hub cap-& wheel cover - refer to text Group Spare 1 eel & jack storage P ma. ioic COPYRIGHT O FORD MOTOR -DEARBORN. MICHIGAN w.u- n ~ww nn w COMPANY ru r.b.,jaws

70 R ILLUSTRATION FORD CAR PARTS SECTION 10 L (PINTO ) INDEX TITLE SECTION...._' NC _ BHAi b Brake and clutch pedals P-7933 Disc brake system P-7934 Brake cylinder details - rear P-3906 Brake details - disc front P Brake details - drum rear P-3703 Drum brake system P Brake cylinder details - front & rear P Brake details - front & rear P-3703 Brake master cylinder details Z0.1 1 P Parking brake system P-8064 WHEELS on rear w ee, arings - 10 P Hub cap & wheel cover Refer to text Group Spare wheel and jack storage P-8407 P (MAVERICK) Brake & clutch pedals P Drum brake system P Brake cylinder details - front & rear P Brake details - front & rear P-3703 Parking brake system P4882 WHEEL S Front & rear wheel, hub & bearings 10 1 P Hub cap & wheel cover - refer to text Group Spare wheel & jack storage P-6925 S (THUNDERBIRD ) BRAKE S Disc brake system P Anti-skid control system (Sure-track) P-8820 Brake booster installation P Brake cylinder details - rear P Brake details - disc front P Brake details - drum rear P-3380 Brake master cylinder details Parking brake system 20 WHEELS Front & rear wheel, hub & bearings 1 0 Hub cap & wheel cover - refer to text G roup Spare wheel & jack storage U (BRONCO) 1 38 P P P P-9973 S31CAK.hS brake a =ten pedals 75 6 P-4972 Drum brake system P Brake cylinder details - front & rear P Brake details - front & rear P-6602 Parking brake system P WHEELS Free n inning hub - Dana (Spicer) IP Front hub & bearings P Hub cap & wheel cover - refer to text Group 1130 Jack parts ' P blame wheel carrier - awing &way t l P_6232

71 FORD CAR PARTS ILLUSTRATION, 1 SECTION t FRONT WHEELS ONLY - REFER TO GROUP 1102 FOR PART NUMBER & MODEL APPLICATIO N REAR FRON T FRONT & REAR WHEEL, HUB. & BEARINGS - TYPICAL 1965/72 FORD, THUNDERBIRD 1190 n REAR % FRONT t FRONT WHEELS ONLY - REFER TO GROUP 1102 FOR PART NUMBER & MODEL APPLICATION ',REFER TO GROUP 1130 IN TEXT SECTIO N FOR THE DESIRED WHEEL COVER OR HUB CA P P May, 1975 FRONT & REAR WHEEL. HUB, & BEARINGS - TYPICA L FAIRLANE TORINO FA k N ; F 1 COPYRIGHT FORD MOTOR DEARBORN, MICHIGAN COMPANY +, r FINAL ISSUE

72 hr I_r AC y W O. Z. 00 Z

73 P-7799 r m n C 0 ; Z a r 0 0 Z 1A05 1 A S (QQ-81 ) _ S S (KK-52-A) (QQ-40 ) 1A050 Al A030 1A029 `-\ A ALSO SERVICED IN B9TZ A SEAL and LOCK RING KIT

74

75 S (XX-364) S 2471 (R-5) S (NN-128-A) 2A In r. nc Z~ 0 0 Z 2B129 (U-269) S\ (1-20) 2A S\ ( 1-20) S S (4) (GG-154-B) S (4) (U-265) S( S I 20) 2A040 (M-52) S ( ww-130) S (X-66)

76 P-3678 es, ẕ co (GG-207) S--A (GG-154-B) S (U-269) S air (GG-95) S (GG 207) I-23) S ( A) W/AUTO. TRANS. * S W/STD. TRANS OR S S (NN-128) (RR-4-A) J S (X-19) S (X-66) S (M-32) S ( I-20) S r '2A040 (X-66)~~~~ 24201\ S 7945-S- ( 1-23) *2A S (11-1)68) W/AUTO. TRA x`87384-s W/STD. TRA N.

77 AL CO S (N-6) (72004-SIN-41) S S 2631 (N-41) S 2A S (M-32) (M-32) A A605

78 22$ POWER BRAKE BOOSTER-ALL MODELS WITH 8 CYLINER 390 ENGINES S (U-264) 2005 (POWER BRAKE ROOSTER) 2365 POWER BRAKE BOOSTER-ALL MODELS EXCEPT 8 CYLINDER 390 ENGINES FAIRLANE STATION WAGON AND ALL FALCON MODELS *FAIRLANE MODELS 63C & D AND 76C & D. COMET - ALL MODELS EXCEPT STATION WAGON

79 P-4470 ON Nr ar, AC IS, 0 oc Z i# (II-65) t#13480 (U 269) 4263 s ~4075 * * 2A (11. 65) Y 4A * (GG-234) G360 )S (G ~~ (4267-R.H R.H L.H S 2262-L.H. 2A (x-67) "'~p~-2268 _~ _ / 2814 ~ S A635 ' (R-6) s R6) q S 2265 (GG-207) 2A635 ~ i S. 24b5 Ye 4649 i-+t210 (U-269-D) 265 * S *73880-S (U-262 / y 2853, / ) IX-19) ! o ~t (M-32) A S 1 M-79) I J1 478 B~_ (U-254) 2780 #1965 ONLY *DISC BRAKE ONLY 2853 N *31491-S (U-254)

80 P I -m O w Z>4 00 Z 2261 R.N L.H S (I-20) S/ ( 1-20),r.-2A R.H L.H s (B-48) S C.)._ S (X-64) 2282 s o?.: E,n * S ( 1-20) *2B112, i.r -2B11 3 ( I-51-B).1,JIL 2264-' ' v * S ) st.- o.., r-65) (XX )6) (M-93) *REFER TO BODY GROUP NUMBER S (N-17) S(N-51) S (BB-572-A) 2853

81 CC Nr AC ~N 0,5 z~ OD Z OL(e.= g Ro 8 t1 ta-ec) Z.-3 oa p-3u) Ov~ ZH g L1

82 P oa, ;,m S 2263 (U-265) 2A S (MM-105-F) B S (1-20) t2b264 / %% 28112;, S (1-20) S (U-265) * S 2078 s

83 P S S (XX-364) 2140 (MASTER CYL.) (NN-128-F) (BOOSTER) / ~~=> S ()-20) S W w-i 30) 2A S 2031-R.H (MM-105_F) 2032-L.H. 2B129 *2E1253,, F S (MM-105-F) *6 CYL. 240 A8 CYL. 390 & 42B,,c8 CYL. 427 i 8 CYL. 289 / S.. - 2A047 (PART OF BOOSTER ASS".., (I-2D) S (I-20; S 2263 (MM-105-F)~ FORD TAXI NON-POWER 2264 DISC BRAKES WITH AUTO. TRANS. ONLY **87384-S-ELBOW A S (II-162) ELBOW 9A474 ELBOW USED WITH ANY COMBINATION OF VACUUM ACCESSORIES & POWER BRAKES < S (I-20) / t2b S 2E1112 (MM-105-F) S (1-20) S (I-40) (U-265) S S (BB-539-F)-- (I I-64-A) 1967 DISC BRAKES j-also SERVICED IN 2B257 VALVE ASSY.

84 4465 N m r,n nc 4 Z nl 0 O Z A POWER BRAKE S (19671 (MM -103) _ S (U-253-B) (MM-103) 2265 * B S S(U-264) * , *28266-* SW-264) ALTERNATE `" S 2078 (UU-52-AF) S CS ' 1968 DISC BRAKES f ~ a e i 1 *2A R.H *28453 * 26)19-L.H. h S (L20) q / S([-20) V, S- :BRAKES D R.H S 4464-L.H. ( U-464) (MM 103) 4k' * 'STANDARD & POWER DRUM BRAKE (1-20) B269 A S(I-40) POWER DISC BRAKE f ALSO SERVICED IN 2B257 VALVE ASSY ',- 32 8' S )RR-4-A) (GG-245) 4482, S *55802-S P-5515

85 P-5516 * 2A040 t S(1.20) ti S(U-464) \ (U-254) 2261-R.H. 2A790 I L.H R.1-I L.H. *2A040 *28253 POWER BRAKE DRUM DISC S(GG-143) R.H L.H. -,.2 colzl 51 cao 2263-R.H. 644.H S (BB- 817-CS) l a0 H S(MM-103) 2061-R.H L.H (X-19) S0MM-173-M DISC BRAKES XU-469) S S(N-254) (NN27-B) 2780

86 Nr mr n C O m zy - o Z S BOLT (B-156) *34941-SL.W 2267-R. H S (B8-575-A) / S ~(MM-105-F) 2B253 *2A S(MM-103) ` * 5-5(XX-355) 5768-S 2471 OR~ \1\ 2A (RR-4-A) S(I-23) 2420 A474 / 2A A481 ri 2A635-R.H R H H 2A ' F LR.H H.% (U-265) S 75C96-S S(MM-1 03) (MM-1 05-F) (MM F) (U-265) * 2A S(I-20 / / * S S(I -20) ~t 48264,.2082, 2263 ''t2b112~ S s. - (MM-103) S * / (U-265) (MM-105-H)

87 P * S 2A S (MM-173-MX) S -'.A, S, -(MM-173-J) 2005 *40980-S (1-23) 2471 BRAKE BOOSTER WITH ' *2A040,«.~ :ods:s_c ~~ 1\ SPEED CONTROL *2B253 I/ 48149~> *2A188 (CYLINDER) / 2B S (BOOSTER) (XX-355) BRAKE BOOSTER WITHOUT SPEED CONTROL S *2A ( ) -S (MM S -F) (GG-274) ` ~ ~ * SSS (MM-1 05-F) PART OF ASSY S (M-50) -~~, S (X-65) / (UU-52-AF) (M_5 * ) '' S S (1-20) (MM-103) S (GG-154B) 2263 '~,~_._~~ *28266 g1 */56120-S S (UU-52-AF) _S (UU-52-AF) S (BB-539-F) L.H. SHOWN R.H. SIMILAR #8 CYL. 429 AND 460 ENGINES *8 CYL. 390 ENGINE t ALSO SERVICED IN 2B257 VALVE ASSY.

88 2A602 2A635-R.H. -40" S T _i IRR-4-A) 2A S (MM-173-M) VACUUM RELEASE CONTROL MOTOR IS SERVICED ONLY AS PART OF 2780 PARKING BRAKE CONTROL ASSY.

89 I m AC 1 N O'0 Z 0 0 Z

90 *REFER TO BODY GROUP NUMBER OPTIONAL INSTALLATION P S S (U-254-F) (NN-128-J) *40980-S S (GG-143) S (NN-128-F) * S S (MM-173-JB) S k2b113 (MM-1 05-F) S k o \ IUU-52-AF) Nog 00 O S (ISM-103) ~ * l S (MM-102) ` S S, imm-103) (liu-52-af) R.H S 2262-L.11. `~ (MM-102)