ADB22X Disc Brake / Hub Parts Information Book
|
|
|
- Sophia Grant
- 5 years ago
- Views:
Transcription
1 ADB22X Disc Brake / Hub Parts Information Book C CONTENTS NEXT PAGE END
2 Contents 3 Dana Australia Sales & Customer Service Contact List 4 ADB22X Disc Brake / Hub Parts Information 6 Spicer Hubs & Rotors 7 Parts Information 9 Wheel Seals START Dana Australia ADB22X Disc Brake / Hub Parts Information Book 2
3 Dana Australia Sales & Customer Service Contact List Brad Wolstenholme Head of Sales & Marketing Commercial Vehicle Aftermarket Paul French Shane Carey Michael Parker Sales Manager Commercial Vehicle Customer Support Manager Business Development Aftermarket Jock Pickford Jagath Dharmabandu Warren Farrugia Fleet & Area Manager Commercial Vehicle Aftermarket Program Manager Business Development Aftermarket Customer Service & General Information John Ramsey Business Development Aftermarket Suzanne Westwell, Nicole Noy or Vivian Cameron DANA Dana Australia ADB22X Disc Brake / Hub Parts Information Book 3
4 ADB22X Disc Brake / Hub Parts Information Rotor Surface Inspection Inspect the rotor at each change of pads for grooves and cracks. The action to take depends on the type of rotor, and also the size, depth and direction of the imperfections, see Figure 22. Change the rotor when the rotor thickness is 37mm. A B C D E Thickness of a new pad (1.181 in.) (30mm). Backing plate thickness (0.360 in.) (9mm). Minimum thickness of friction material (0.080 in.) (11mm); replace pads. Minimum thickness of a worn pad (0.433 in.). Minimum rotor thickness (1.46 in.) (37mm). Thickness of a new rotor (1.77 in.) (45mm). Minimum rotor thickness (1.46 in.) (37mm). Rotor Turning (Grinding) Bendix rotors are normally service-free. Turning of Bendix spline rotors is not permitted. Conventional rotors may be turned when changing pads, but is not normally necessary. In the case of severe grooving of the entire friction surface, however, turning could be useful, and may increase the load-bearing surface of the pads. To meet Bendix recommendations, the minimum rotor thickness after turning must be greater than 1.53 in. (39mm). Dana Australia ADB22X Disc Brake / Hub Parts Information Book 4
5 ADB22X Disc Brake / Hub Parts Information SD Bendix ADB22X, ADB22X-V Air Disc Brakes SECTION ONE: AIR DISC BRAKE OVERVIEW 1.1 DESCRIPTION Bendix ADB22X and ADB22X-V Air Disc Brakes Bendix ADB22X-V Sections in this Document Section Page Full Index - see Page 38 FIGURE 2 - TYPICAL PART NUMBER LABEL LOCATION Bendix Part Number Serial No. Customer Part Number FIGURE 3 - PART NUMBER LABEL INFORMATION For further service / maintenance information for models: ADB22X & ADB22X-V Bendix Spicer Foundation Brakes refer to manual SD FIGURE 1 - BENDIX ADB22X AIR DISC BRAKES Section One Section Page Dana Australia ADB22X Disc Brake / Hub Parts Information Book 5
6 Spicer Hubs & Rotors Item No. Item Description Hub & Rotor FF Front Preset Alum 285 ABS 2.59 Stud Hub & Rotor FF Front Preset CI 285 ABS 2.50 Stud Hub & Rotor FL Front Preset CI 285 ABS 2.56 Stud Hub & Rotor R Drive Preset AL 285 ABS 3.27 Stud For further service / maintenance information for Conmet Hubs steer and drive models: Refer to manual Drive Hub Steer Hub Above: Splined Disc Rotor on Aluminium Drive Hub Above: Splined Disc Rotor on Aluminium Steer Hub Dana Australia ADB22X Disc Brake / Hub Parts Information Book 6
7 Parts Information (FF) E-Series Steer Axle (Type 18 Booster) (FL) D2000 Steer Axle (Type 18 Booster) Part Description RH AM RH LH AM LH RH AM RH LH AM LH Caliper Assembly Steer K K K K Caliper Assembly Fwd Drive Caliper Assembly Rear Drive Pad Kit (One Axle) K K K K Splint Kit (25 in kit) Shear Adaptor (Box of 10) K K K K Adjuster Cover N N N N Wheel End Kit K K K K Guide Pin, Seal & Boot Kit N N N N Guide Pin Grease 5g II14525 II14525 II14525 II14525 Guide Pin Grease 100g K K K K Spring Brake Actuator (Steer) K K K K Spring Brake Actuator (Drive) Steer Axle Pad Sheild Kit Drive Axle Pad & Rotor Sheild Kit Splined Disc Rotor ConMet Pre-set Wheel Bearing Kit Steer ConMet Wheel Bearing Wheel Bearing Kit Drive Hub & Rotor Assembly Alloy Hub Hub & Rotor Assembly Cast Iron Hub Wheel Seal Not Sold Separately Wheel Seal & Spacer Kit Inner Cup & Cone Set Outer Cup & Cone Set Inner Cone Inner Cup Outer Cone Outer Cup Spacer Use Seal & Spacer Kit Wheel Stud ABS Ring Service Kit Hubcap LMS Blue Cap Splined Disc Rotor Attaching Kit K K K K Dana Australia ADB22X Disc Brake / Hub Parts Information Book 7
8 Parts Information Drive Axle (Neway 18/24 Air Chamber) Drive Axle (Airglide 18/24 Air Chamber) Part Description RH AM RH LH AM LH RH AM RH LH AM LH Caliper Assembly Steer Caliper Assembly Fwd Drive K K K K K K K K Caliper Assembly Rear Drive K K K K K K K K Pad Kit (One Axle) K K K K Splint Kit (25 in kit) Shear Adaptor (Box of 10) K K K K Adjuster Cover N N N N Wheel End Kit K K K K Guide Pin, Seal & Boot Kit N N N N Guide Pin Grease 5g II14525 II14525 II14525 II14525 Guide Pin Grease 100g K K K K Spring Brake Actuator (Steer) Spring Brake Actuator (Drive) K K K K Steer Axle Pad Sheild Kit Drive Axle Pad & Rotor Sheild Kit Splined Disc Rotor ConMet Pre-set Wheel Bearing Kit Steer ConMet Wheel Bearing Wheel Bearing Kit Drive Hub & Rotor Assembly Alloy Hub Hub & Rotor Assembly Cast Iron Hub Wheel Seal Not Sold Separately Wheel Seal & Spacer Kit Inner Cup & Cone Set Outer Cup & Cone Set Inner Cone Inner Cup Outer Cone Outer Cup Spacer Use Seal & Spacer Kit Wheel Stud ABS Ring Service Kit Hubcap LMS Blue Cap Splined Disc Rotor Attaching Kit K K K K Dana Australia ADB22X Disc Brake / Hub Parts Information Book 8
9 Wheel Seals Wheel Seals for the Spicer / Bendix ADB22X Disc Brake New Dana Part-No Description Replaces Discontinued Item Wheel Seal & Spacer Kit to suit FF (Dana E Series) Steer Axles Wheel Seal & Spacer Kit to suit FL (Dana D Series) Steer Axles Wheel Seal & Spacer Kit to suit R Drive Axles Hub & Rotor FF Front PreSet CI 285 ABS 2.50 Stud with ConMet Seal Hub & Rotor FL Front PreSet CI 285 ABS 2.56 Stud with ConMet Seal Hub & Rotor FF Front PreSet AL 285 ABS 2.59 Stud with ConMet Seal Hub & Rotor R Drive PreSet AL 285 ABS 3.27 Stud with ConMet Seal Individual wheel seals are no longer available and are now available as a seal and spacer kit. Note: Spacers SHOULD NOT be reused, and must be replaced with new when fitting a new wheel seal. Dana Australia ADB22X Disc Brake / Hub Parts Information Book 9
10 Dana Australia 8 Hudson Court, Keysborough VIC 3173 Phone: DANA Copyright Dana Australia 2018 All rights reserved. Dana Australia. Published in Australia, May 2018 START C CONTENTS PREVIOUS PAGE
Axle Components. 12,000 lbs. Capacity
12,000 lbs. Heavy Duty Components 27-358 Unitized Oil Seal - disc or drum (Dimensions are 3.125 x 4.506 x.605) 2 010-056-00 27-342 3984 Inner Bearing (Inside diameter 2.625 ) 3 031-020-02 27-343 3920 Inner
Telephone (925) Fax (925) Lawrence Drive, Livermore, CA 94551
Telephone (95) 454-9500 Fax (95) 454-950 5 Lawrence Drive, Livermore, CA 9455 PARTS MANUAL INDEX STEERABLE DRIVE AXLE ASSEMBLY STEERABLE DRIVE END ASSEMBLY BRAKE CALIPER ASSEMBLY TO USE THIS BOOK:. Refer
PARTS LIST TRAILER BRAKE SYSTEMS. LIT NO: DATE: October 2017 REVISION: H
PARTS LIST TRAILER BRAKE SYSTEMS LIT NO: 97-097 DATE: October 07 REVISION: H TABLE OF CONTENTS INTRODUCTION ABBREVIATIONS DRUM BRAKES & 6. DRUM FOUNDATION BRAKE HXS Brakes P-TYPE DRUM FOUNDATION BRAKE
RTR READY-TO-ROLL. Trailer Suspension and Axle Systems
RTR READY-TO-ROLL Trailer Suspension and Axle Systems CONTENTS DRUM BRAKE COMPONENTS Brake Adjusters... 2 Brake Chambers... 4 Brake Drums... 8 ABS Sensor... 9 COMPONENTS Dust Shield... 10 Axle Nut Kits...
SD Bendix ADB22X, ADB22X-V Air Disc Brakes SECTION ONE: AIR DISC BRAKE OVERVIEW 1.1 DESCRIPTION. 1.2 Air Disc Brake Identification
SD-23-7541 Bendix ADB22X, ADB22X-V Air Disc Brakes SECTION ONE: AIR DISC BRAKE OVERVIEW 1.1 DESCRIPTION Bendix ADB22X and ADB22X-V Air Disc Brakes (ADB) use a fl oating caliper design to provide foundation
Service Bulletin No. 2874
MODEL TYPE SECTION/GROUP DATE SUBJECT 102 E / E4500 / J4500 Series Coaches Service Information 04--Brakes MERITOR BRAKE CALIPER SERVICE PARTS CHART Dec. 24, 2003 CONDITIONS may be purchased from MCI Service,
JK 8 Lug Front Locking Hub Conversion Kit
JK 8 Lug Front Locking Hub Conversion Kit Kit #3034411 w/ Performance Rotors Kit #3034410 w/ Performance Slotted Rotors Kit #3034412 w/ Big Brake Kit Kit #3034413 w/ Big Brake Kit and Slotted Rotors Important
TMC PAN 22 DISC BRAKE
TMC PAN 22 DISC BRAKE AXLE SERVICE MANUAL TMC DISC BRAKE AXLE TMC Australia Pty Ltd Telephone: + 61 3 8786 3688 78 Star Crescent Facsimile: + 61 3 8786 3699 Hallam E-Mail: info@tmcaus.com.au Victoria 3803
New Brake Kits NO CORES.
Brake & Wheel End Solutions Wasting TIME and MONEY managing brake cores? New Brake Kits NO CORES. EVERYDAY DELIVERY SILVERBACK & WISBOM CORE FREE BRAKE SHOE KITS New Brake Kits NO CORES. New Steel 20K,
SPARE PARTS BOOK. Rear Tandem Axle FRDP FRDP16S0879/011&013 Up to S/N (Nov 2004) Book No. 247 (2/2007)
SPARE PARTS BOOK Rear Tandem Axle ) Sisu Axles, Inc. Autotehtaantie 1 PO Box 19 FIN-101 Hameenlinna Finland Phone +35 20 55 99 Fax +35 20 55 00 2.2.2007 1 Axle L71 2 1 5 3 9 7 10 11 1 1 15 Breather 1 Breather
*THIS KIT IS NOT INTENDED FOR VEHICLES WITH ABS*
*THIS KIT IS NOT INTENDED FOR VEHICLES WITH ABS* Notes: New full-cast rotors from 1990 or newer Wrangler must be used with this kit, this rotor (ITT #65225 or equivalent) has a.25 thick mounting flange.
ROR Trailer Products Axle & Brake Parts List LM and LC Series Axles including disc and drum brake variants
ROR Trailer Products Axle & Brake Parts List LM and LC Series Axles including disc and drum brake variants LM/LC Hub Assembly 14 1 3 10 9 19 20 8 5 6 7 11 1 4 2 18 16 13 17 15 13 12 2 LM/LC Hub Assembly
QUICK REFERENCE GUIDE FOR SAF CBX SERIES AIR SUSPENSIONS COLLECTIBLE NUMBER 5
QUICK REFERENCE GUIDE FOR SAF CBX SERIES SUSPENSIONS COLLECTIBLE 5 CBX SUSPENSIONS FIXED FRAME MODELS OTHER MODEL CONFIGURATIONS AVAILABLE CBX23 CBX25 CBX23u CBX25u CBX25/30 23,000 lbs. 25,000 lbs. 23,000
TMC PAN 19 DISC BRAKE
TMC PAN 19 DISC BRAKE AXLE SERVICE MANUAL TMC DISC BRAKE AXLE TMC Australia Pty Ltd Telephone: + 61 3 8786 3688 78 Star Crescent Facsimile: + 61 3 8786 3699 Hallam E-Mail: info@tmcaus.com.au Victoria 3803
Page 1 of 7 Section 05-03A: Axle, Front Drive, Dana Models 44 and 50 1996 Bronco/F-Series Workshop Manual DESCRIPTION AND OPERATION Procedure revision date: 06/19/2000 Hubs, Automatic Lock Refer to Section
Premium wheel-end brake products. Supplement to BW7253
Premium wheel-end brake products Bendix ESD-225 Air Disc Brake Supplement to BW7253 I l l u s t r a t e d P a r t s L i s t Table of Contents Table of Contents Introduction About this Parts Book...2 Abbreviations...2
Page 1 of 5 Section 05-03A: Axle, Front Drive, Dana Models 44 and 50 1996 Bronco/F-Series Workshop Manual REMOVAL AND INSTALLATION Procedure revision date: 06/19/2000 Spindle, RH and LH Shaft and Joint
REPLACEMENT 1. REMOVE FRONT WHEEL
3028 REPLACEMENT 1. REMOVE FRONT WHEEL 300HC03 2. REMOVE FRONT DISC BRAKE CALIPER ASSY LH (a) Remove the bolt and separate the brake tube bracket from the steering knuckle. (b) Using, disconnect the brake
Meritor Axle & Brake Parts List. LM and LMC Series Axles including Disc and Drum Brake variants
Meritor Axle & Brake Parts List LM and LMC Series Axles including Disc and Drum Brake variants LM Parts List 14 1 3 10 9 19 20 8 5 6 7 11 1 4 2 18 16 13A 17 15 13 12 2 LM Parts List LM Hub Assembly Parts
ROR Trailer Products Axle & Brake Parts List TA and TC Series Axles including disc and drum brake variants
ROR Trailer Products Axle & Brake Parts List TA and TC Series Axles including disc and drum brake variants TA Hub Assembly 14 1 3 10 9 9 20 21 8 5 6 7 11 1 4 2 19 16 13 20 15 17 21 13 18 12 19 2 TA/TC
SPARE PARTS BOOK. Front Axle FSDP-09/10-S. Book No. 201 (12/2009)
SPARE PARTS BOOK Front Axle S Sisu Axles, Inc. Autotehtaantie 1 PO Box 189 FIN-13101 Hameenlinna Finland Phone +358 20 55 2999 Fax +358 20 55 2900 1.12.2009 1 Axle L577 10 8 9 12 1 13 11 "A" "B" 6 5 1
OVERHAUL. Remove the union bolt and a gasket from the disc brake cylinder, then disconnect the flexible hose from the disc brake cylinder.
OVERHAUL COMPONENTS: See page 3232 Overhaul the RH side by the same procedures with LH side. Two types of brake pad exist; one is with slit and the other without slit. 1. REMOVE REAR WHEEL 2. DRAIN FLUID
Wheel Bearing & Hub Seal Application Chart
Wheel Bearing & Hub Seal Application Chart Make Axle Inner Cone Inner Cup Outer Cone Outer Cup Hub Seal BPW New Gen - 6.4-9t 33116 Assy 32310 Assy FQ4546 BPW New Gen - 10-12t 33118 Assy 33213 Assy FQ4536
SERVICE MANUAL. PreSet Hub Assemblies. Conventional. Hub & Rotor Assemblies. PreSet Plus. For Steer, Drive and Trailer Hub Assemblies.
Conventional Hub Assemblies PreSet Hub Assemblies PreSet Plus Hub Assemblies Hub & Rotor Assemblies SERVICE MANUAL For Steer, Drive and Trailer Hub Assemblies About This Manual Before You Begin Read this
FRONT AXLE HUB SUB-ASSY LH
3038 DRIVE SHAFT / PROPELLER SHAFT REPLACEMENT HINT: COMPONENTS: SEE PAGE 304 Replace the RH side by the same procedures with LH side. 1. REMOVE FRONT WHEEL 300OI02 2. REMOVE FRONT AXLE HUB LH NUT (a)
General Applications. Axle Types. d30 & D35 leaf spring lbs. capacity 10 10F 10L Lbs. Capacity
General Applications Axle Types 300-000 Lbs. Capacity Complete service manual Precision machined steel spindles and integral cast iron hub/drums Press-in wheel studs " x ¹ ₂" and " x ¹ ₄" CSA approved
Circled numbers are Forward Axle Assembly parts. SUPPLEMENTAL DRAWING CARRIERS WITH INTERNAL A.B.S.
Circled numbers are Forward Axle Assembly parts. SUPPLEMENTAL DRAWING CARRIERS WITH INTERNAL A.B.S. FIGURE 1 FORWARD CARRIERS OF TANDEM AXLES (USE WITH CHART 1) Circled numbers are diff. lock parts or
Rear Axle Hub, Bearing, Cup, and/or Seal Replacement
Page 1 of 11 Rear Axle Hub, Bearing, Cup, and/or Seal Replacement Special Tools J 8092 Universal Driver Handle - 3/4 inch - 10 J 2222-C Wheel Bearing Nut Wrench J 24426 Wheel Bearing Race Installer - Outer
Service Parts Drum Brake Axle. Service Parts Air Disc Brake (ADB) Axle. Maintenance Preventive Maintenance...35 Torque Specifications...
Terms and coverage in this warranty apply only to the United States and Canada. Warranty Ridewell Suspensions warrants the suspension systems manufactured by it to be free of defects in material and workmanship.
CATALOGUE INDEX. Profiles & Dimensions - Non Braked Profiles & Dimensions - Braked. Dimensions - Non Braked Dimensions - Braked
Page: Warranty CATALOGUE INDEX 8 9 0 8 9 0 Australian Design Rules Calculating Pitch Circles Non Braked Hubs & Stubs Non Braked Hubs & Stubs Non Braked Hubs & Stubs Non Braked Hubs & Stubs Disc Braked
Product Catalogue. Version 8.0. Section. FUWA Axle Components
Product Catalogue Section E Version 8.0 FUWA Section E Fuwa - Cam and Brake Assembly E:48 PRODUCT CATALOGUE 8.0 Fuwa - Cam and Brake Assembly Part List - 6 axle tube (square) - 5 axle tube (round) TL-11-427-800045
Detroit Speed, Inc. Detroit Speed C7 Rear Full Floater Kit P/N: , , , , &
Detroit Speed, Inc. Detroit Speed C7 Rear Full Floater Kit P/N: 070512, 070607, 070616, 070626, 070636 & 070649 Thank you for purchasing the Detroit Speed Inc., C7 Rear Full Floater Kit. The Detroit Speed
Spearhead STARCUT 500 STARCUT 500. Edition Jan 2013 Post Serial No. S Part No
STARCUT 500 Edition 2.0 - Jan 2013 Post Serial No. S136498 Part No. 8999040 1 Contents Ordering Your Parts 3 Centre Section 4 Wing Section 6 Centre Axle 8 Wing Axle 10 Std Drawbar 12 Tie-Bar Assembly 14
Meritor Axle & Brake Parts List. LM and LMC Series Axles including Disc and Drum Brake variants
Meritor Axle & Brake Parts List LM and LMC Series Axles including Disc and Drum Brake variants LM Parts List 14 1 3 10 9 19 20 6 7 11 1 4 2 1 16 13 17 1 13 12 2 LM Parts List LM Hub Assembly Parts List
SPARE PARTS BOOK. Rear Tandem Axle FRDP-13/16-S. Since No (11/2004) Book No. 292 (5/2009)
SPARE PARTS BOOK S Sisu Axles, Inc. Autotehtaantie 1 PO Box 189 FIN-13101 Hameenlinna Finland Phone +358 204 55 2999 Fax +358 204 55 2900 31.1.2012 1 Axle L870 2 1 11 12 12 5 12 10 12 3 9 6 4 7 15 13 14
Service Parts Drum Brake Axle. Service Parts Air Disc Brake (ADB) Axle. Maintenance Preventive Maintenance...35 Torque Specifications...
Terms and coverage in this warranty apply only to the United States and Canada. Warranty Ridewell Suspensions warrants the suspension systems manufactured by it to be free of defects in material and workmanship.
Ilustrated Parts List
Spicer Drive Axles Ilustrated Parts List Spicer All Wheel 4 x 4 Drive System AXIP-0400 November 1999 Page to Insert The Spicer 4x4 Drive System Axle models and other equipment covered in this publication
1 RS-300/D 320/D 340/D 350H Parts Manual
300/D 320/D 340/D 350H Parts Manual Table Of Contents Three Point Hitch / Hitch Frame Assembly... 3 Tongue Pull Hitch Assembly... 7 Main Gearbox... 11 Crank Handle & Gear... 13 Hydraulic Lift... 15 Rotor
DRAIN BRAKE FLUID NOTICE:
OVERHAUL Overhaul procedure of the RH side is the same as that of with LH side. 1. REMOVE FRONT WHEEL 2. DRAIN BRAKE FLUID Wash off the brake fluid immediately if it comes into contact with a painted surface.
REAR AXLE PARTS.BOOK SS-842 DATE: SPICER PS-7036 AXLE USED WITH PS-1350 AXLE STEERING CYLINDER & steering CYLINDER
:. :. :. - I _ REAR AXLE PARTS.BOOK SS-8 o DATE: 7--9 SPICER PS-703 AXLE USED WITH PS-350 AXLE 7-9-30 STEERING CYLINDER & 7-9-3 steering CYLINDER o BARAGA PRODUCTS, INC. 55 N. Superior AYe. Baraga. Ul
Meritor trailer wheel end & suspension parts CAtALoGue ideas driving results
Meritor TRAILER wheel end & suspension PARTS CATALOGUE IDEAS DRIVING RESULTS IMPORTANT INFORMATION AFTERMARKET PARTS WARRANTY We warrant all new parts for one year from date of shipment to the buyer against
Service, Parts & Maintenance Information Book
Service, Parts & Maintenance Infmation Book C CONTENTS NEXT PAGE END Contents 3 Dana Australia Sales & Customer Service Contact List 4 Dana Component Terminology 6 Drive Pinion and Ring Gear Identification
Spearhead Multicut 460 MULTICUT th Edition - July 2015 Part No
MULTICUT 460 14 th Edition - July 2015 Part No. 8999023 1 Spearhead Multicut 460 Parts Book 14 th Edition July 2015 Spearhead Machinery Ltd Green View Salford Priors Evesham Worcestershire WR11 8SW Tel:
Bendix Air Disc Brakes Manual
We have made it easy for you to find a PDF Ebooks without any digging. And by having access to our ebooks online or by storing it on your computer, you have convenient answers with bendix air disc brakes
1 HR-301/D Parts Manual. Table Of Contents
Table Of Contents 301/D Parts Manual 3 Point Hitch...2 Pull-Type Hitch...4 Main Frame...6 Angle Adjuster - Serial Number 44982 & Prior...8 Rotor Assembly - Serial Number 44982 & Prior...10 Rotor Assembly
PARTS VIEW. See page 5 for: Weweler-MBS Ø146mm beam s-cam details.
KF22 & KF29 DRUM BRAKE () See page 5 for: Weweler-MBS Ø146mm beam s-cam details. KF29 Long Pin P brake, Page 6, E For ConMet wheel end part numbers go to page 5 www.khitch.com.au Uncontrolled document
DRIVE AXLE INFO DA D170 & D190 OUTPUT SHAFT BEARING RACE PARTS CHANGE SERVICE/TECHNICAL DATE: 24/5/2012. All service & parts departments
D170 & D190 OUTPUT SHAFT BEARING RACE PARTS CHANGE DATE: 24/5/2012 DA022012 SERVICE/TECHNICAL TO: All service & parts departments Dana has made a significant design change to the output shaft bearing components
General Applications. Axle Types LBS. CAPACITY Lbs. Capacity
General Applications Axle Types 600-1100 Lbs. Capacity Ideal application for light utility, for hauling personal watercraft and motorcycles Complete service manual Heavy duty 1¹ ₁₆" spindle design Precision
Edition October 2014 Part No
Edition 1.3 - October 2014 Part No. 8999076 1 Contents Ordering Your Parts... 3 Centre Section - S180025.70... 5 Wing Section - S180025.71/72...7 Centre Axle - S180025.110... 9 Wing Axle - S180025.111...10
RED LINE LANDCRUISERS LLC. FJ40-70 series BIG BRAKE KIT INSTRUCTIONS
RED LINE LANDCRUISERS LLC. FJ40-70 series BIG BRAKE KIT INSTRUCTIONS Tired of not have the brake performance on your land cruiser? Have you upgraded to 35,37" Tires, a V8? Well, This brake kit is for you.
PARTS CATALOGUE. We ve got. all the Parts
PARTS CATALOGUE We ve got all the Parts Ingersoll Axles Parts Catalogue P: 1-(519)-485-2210 Parts Store: www.parts.ingersollaxles.com TF: 1-(800)-663-2953 W: www.ingersollaxles.com E: info@ingersollaxles.com
1984 Dodge W250 PICKUP
1984 Dodge W250 PICKUP Submodel: Engine Type: V8 Liters: 5.2 Fuel Delivery: CARB Fuel: GAS Dana 44 MODELS THROUGH 1984 2. Raise and safely support the vehicle, then remove the wheel hub and bearings as
FRONT AXLE GROUP CONTENTS GENERAL DESCRIPTION FRONT AXLE DIAGNOSIS DRIVE SHAFT ASSEMBLY SPECIAL TOOLS...
26-1 GROUP 26 CONTENTS GENERAL DESCRIPTION 26-2 DIAGNOSIS 26-2 TROUBLESHOOTING STRATEGY 26-2 SYMPTOM CHART 26-3 SYMPTOM PROCEDURES 26-3 SPECIAL TOOLS 26-4 ON-VEHICLE SERVICE 26-6 WHEEL BEARING END PLAY
Professional Service Technician WORKBOOK
Professional Service Technician WORKBOOK Issue 2, 2011 Volume 34 Air Disc Brakes Bendix air disc brakes use a floating caliper design to provide foundation braking on all axles of heavy commercial vehicles,
DRAIN BRAKE FLUID NOTICE:
REAR DISC OVERHAUL Overhaul the RH side by the same procedure as the LH side. 1. REMOVE REAR WHEEL 2. DRAIN FLUID Wash the brake fluid off immediately if it comes into contact with any painted surface.
Product Catalogue. Version 8.0. Section. Arvin Meritor (ROR) Axle Components
Product Catalogue Section E Version 8.0 Arvin Meritor (ROR) Axle Components PRODUCT CATALOGUE 8.0 ArvinMeritor (ROR) Axle Type Capacity Wheel Fixing 300-0003-1D0F5 TM/T25010/ZMX 11,690 kg 10 stud M22 x
REMOVAL & INSTALLATION
REMOVAL & INSTALLATION FRONT DISC BRAKE PADS 1. Raise and support front of vehicle. Remove wheels. Remove caliper bolt and brakeline bracket bolts. Pivot caliper aside. Remove pads and pad shim. Remove
Dura Force Disc Brake System Service Manual
TS 20809_a 3501 Shotwell Drive ISO/TS 16949:2002 Registered (PH): 937.743.8125 Franklin, OH 45005 www.waltheremc.com (FX): 937.743.8232 Table of Contents General Description 1 3 Fastener Torque Chart 4
X Light Axle Parts for Nissan Applications August 2014
Light Axle Parts for Nissan Applications August 2014 The Spicer is a comprehensive catalog that delivers the information you need about light axle parts for Nissan applications all in one convenient place.
WRANGLER, CHEROKEE AND COMANCHE, FRONT AXLE WHEEL HUB CONVERSION KIT
WRANGLER, CHEROKEE AND COMANCHE, FRONT AXLE WHEEL HUB CONVERSION KIT -YA WU-07 5 x 4.5 -YA WU-08 5 x 5.5 *THIS KIT IS NOT INTENDED FOR VEHICLES WITH ABS AND YA WU-08 WILL CHANGE BOLT PATTERN TO 5 ON 5.5*
Illustrated Parts List
Spicer Steer Axles Illustrated Parts List Spicer EFA Family AXIP-0074 February 2008 Table of Contents Table of Contents Introduction...2 About this Parts Book...2 Abbreviations...2 Genuine Spicer Parts...2
DRAIN BRAKE FLUID NOTICE:
OVERHAUL Overhaul procedure of the RH side is the same as that of with LH side. 1. REMOVE REAR WHEEL 2. DRAIN BRAKE FLUID Wash off the brake fluid immediately if it comes into contact with a painted surface.
SPICER. WEATHERLYINDEX084 T21 O-ES70-5 October 1993 ES70-5 Series Main Transmission
SPICER WEATHERLYINDEX084 T2 O-ES70-5 October 993 ES70-5 Series Main Transmission ES70-5 Series Main Transmission For parts or service call us Pro Gear & Transmission, Inc. (877) 776-4600 (407) 872-90 parts@eprogear.com
FRONT AXLE 26-1 CONTENTS ON-VEHICLE SERVICE... 5 GENERAL INFORMATION... 2 SERVICE SPECIFICATIONS... 3 LUBRICANTS... 3 HUB AND KNUCKLE ASSEMBLY...
26-1 FRONT AXLE CONTENTS GENERAL INFORMATION... 2 SERVICE SPECIFICATIONS... 3 LUBRICANTS... 3 SPECIAL TOOLS... 3 ON-VEHICLE SERVICE... 5 Wheel Bearing Axial Play Check... 5 Hub bolt replacement... 5 HUB
Aftermarket. Supersessions. Month Year Old Part Number Description New Part Number
August 2012 1227E1045 Nut Outer R002462 August 2012 B422061R370 Gearset 3.70 Ratio A422061R370 August 2012 21225419 Arm Trailing O/Slung 21225499 August 2012 MBLK4102 Brake Lining Kit MBLK8104 August 2012
HUB - DRUMS - DISC JEEP CJ AVANT FRONT
HUB - DRUMS - DISC JEEP CJ 72-86 AVANT FRONT 1 300101 Wheel bearing seal drum brake (CJ 72-78) 2.125" spindle diameter 2 300102 Wheel bearing seal disc brake (CJ 77-86) 2.313" spindle diameter 3 300103
X Dodge / Chrysler /2. Model 44 /216 Disconnect Front Axles for. W1500 and W2500 Ram
Dodge / Chrysler 1994-1998 1 /2 Model 44 /216 Disconnect Front Axles for W1500 and W2500 Ram 15 Exploded View 16 Parts Listing ITEM NO. PART NUMBER DESCRIPTION 1 (3) Housing Axle Service 2 (1) Drive Pinion
JK 8 Lug Front Locking Hub Conversion Kit
1 JK 8 Lug Front Locking Hub Conversion Kit Kit #3034411 w/ Performance Rotors Kit #3034410 w/ Performance Slotted Rotors Kit #3034412 w/ Big Brake Kit Kit #3034413 w/ Big Brake Kit and Slotted Rotors
Webinar Series APTA Standards Quarterly Webinar Series
1 Webinar Series APTA Standards Quarterly Webinar Series Presented by APTA Brake and Chassis Working Group Disc Brake Wheels On Inspection January 26, 2017 2 Moderator Presenter Jerry Guaracino Assistant
SPARE PARTS BOOK. Front Axle SSDP-12-S. Book No. 209 (4/2010)
SPARE PARTS BOOK Front Axle Sisu Axles, Inc. Autotehtaantie 1 PO Box 189 FIN-13101 Hameenlinna Finland Phone +8 20 2999 Fax +8 20 2900 16.8.2012 1 Axle L96 2 22 2 7 8 9 10 20 21 1 26 27 22 2 23 19 13 21
PARTS MANUAL FOR R22N/H REAR AXLE
PARTS MANUAL FOR REAR AXLE MARMON-HERRINGTON ALL-WHEEL DRIVE 13001 Magisterial Drive Louisville, KY 40223 TABLE OF CONTENTS REPLACEMENT PARTS & WARRANTY CLAIM PROCEDURE......... 3 DIFFERENTIAL CARRIER
1 KW-550T Parts Manual. Table Of Contents
KW-550T Parts Manual Table Of Contents Drawbar... 2 Central Gearbox - Serial No. 523800-554988... 4 Central Gearbox - Serial No. 523800-554988... 6 Central Gearbox - Serial No. 554989-... 8 Central Gearbox
UFP PRODUCTS. Unique Functional Products. 1. Actuator. 2. Couplers. 3. Stainless Steel Bearing Protectors, Buddy Brake
1. Actuator 2. Couplers 3. Stainless Steel Bearing Protectors, Buddy Brake 4. Wheel Bearing Kits, Grease Seals 5. Spindo Seal Kits 6. Trailer Buddy Products 7. Hubs & Hub/Drums 8. Disc Brakes 9. Springs
MAZ BUS Axle P/N: XXXXXXXXXXXXX. Customer: Axle Model: XXXXXXXXXXXXX XXXXXXXXXXXXX IPL-0005 D.
IIPL-0005 IILLUSTRATED PART LIIST Customer: Axle Model: MAZ 10.24 BUS Axle P/N: 826264 XXXXXXXXXXXXX 826265 XXXXXXXXXXXXX 826266 XXXXXXXXXXXXX Document: Issue: IPL-0005 D IPL-0005 Rev. D 1 The description,
JK 8-Lug Front Full Float Kit
1 Kit #3034411 w/ Performance Rotors Kit #3034410 w/ Performance Slotted Rotors Kit #3034412 w/ Big Brake Kit Kit #3034413 w/ Big Brake Kit and Slotted Rotors JK 8-Lug Front Full Float Kit www.teraflex.com
AXLE PARTS. In This Section: AXLE NUTS. Check Out Our New Website! AXLE NUT WRENCHES
Check Out Our New Website! www.bwpindustries.com Registered BWP Customers Have Access To: Current Pricing Real-Time Inventory Searchable Interchange 24/7/365 Online Ordering Free registration is available
DESCRIPTION & OPERATION
DESCRIPTION & OPERATION BRAKE BOOSTER Delco-Moraine Single Diaphragm A combined vacuum-hydraulic unit which uses a combination of intake manifold vacuum and atmospheric pressure to provide power assist.
PARTS VIEW 22.5 DRUM BRAKE AXLE KF22 / KF29
DRUM BRAKE AXLE KF22 / KF29 KF29 Long Pin P brake, Page 6, E For CONMET wheel end part numbers go to page 5 www.khitch.com.au Uncontrolled document when printed Bulletin No: KPS-001-0912 Rev6 1 QUANTITY
SECTION C: Wheel Hubs and Bearings Full Floating Axle Dana
SECTION 205-02C: Wheel Hubs and Bearings Full Floating Axle Dana REMOVAL AND INSTALLATION 2007 F-53 Motorhome Chassis Workshop Manual Procedure revision date: 12/04/2006 Wheel Hub Material Item Premium
Illustrated Parts List
Spicer Drive Axles Illustrated Parts List AXIP-00322 February 2015 Two-Speed-Planetary Double Reduction 19055T/P, 21065T/P, 22065T/P, 23065T/P Model Table of Contents General Information... 3 How To Use
BASIC BRAKE SYSTEM Click on the applicable bookmark to selected the required model year
BASIC BRAKE SYSTEM 5A-2 BASIC BRAKE SYSTEM CONTENTS GENERAL INFORMATION.................. SERVICE SPECIFICATIONS................. 4 LUBRICANTS.............................. 5 SEALANT..................................
JK CRD60 Front Fixed Spindle Conversion Kit
1 JK CRD60 Front Fixed Spindle Conversion Kit www.teraflex.com Kit # 3060000 JK CRD60 Front Fixed Spindle Conversion Kit Important Notes: Prior to beginning this or any installation read these instructions
X-Trainer 43mm fork service manual. Beta USA, Inc This work should be performed by a trained motorcycle technician.
X-Trainer 43mm fork service manual Beta USA, Inc. 2016 This work should be performed by a trained motorcycle technician. Table of contents Page Introduction/special tools... 2 Fork exploded view... 3 Legend.
KNORR DISC BRAKE. SKH... SH... Axles 9t ECO, 9t and 10-12t ECO Plus Spare Parts Catalouge FOR AUSTRALIAN ASSEMBLED DISC BRAKE AXLES
KNORR DISC BRAKE SKH... SH... Axles 9t ECO, 9t and 10-12t ECO Plus Spare Parts Catalouge FOR AUSTRALIAN ASSEMBLED DISC BRAKE AXLES The information and advice contained in this brochure including prices
General Applications. Axle Types. d60 & D70 leaf spring lbs. capacity Lbs. Capacity
General Applications Axle Types 00-000 Lbs. Capacity Complete service manual Precision machined, forged steel spindles Precision machined integral cast iron hub/drums -bolt and bolt (UTG) hubs available
Average isn t good enough when it comes to replacement pads for your Bendix air disc brakes.
Bendix ADB22X Air Disc Brake Replacement Pads Maintain optimum performance, safety & service life. Average isn t good enough when it comes to replacement pads for your Bendix air disc brakes. Bendix can
REAR DRIVE SHAFT (3S GTE ENGINE)
SA52 REAR DRIVE SHAFT (3SGTE ENGINE) COMPONENTS SA53 NOTICE: The axle bearing could be damaged if it is subjected to the vehicle weight, such as when moving the vehicle with the drive shaft removed. Therefore,
SuperTrac. Axle. Service & Maintenance. Manual
SuperTrac Axle Service & Maintenance Manual Table of Contents Page Exploded Views Section 1: General Information General Warnings Description of Axle Models Identifications Section 2: Installation Axle
SD Bendix ADB 22X, ADB 225, SN6, SN7, SK7 Air Disc Brakes DESCRIPTION OPERATION. Brake Release and Adjustment
SD-23-7541 Bendix ADB 22X, ADB 225, SN6, SN7, SK7 Air Disc Brakes DESCRIPTION Bendix Air Disc Brakes use a fl oating caliper design to provide foundation braking on all axles of heavy commercial vehicles,
Webinar Series. APTA Bus Technical Maintenance Committee Webinar Series. Disc Brake Wheels On Inspection. Presents
1 Webinar Series APTA Bus Technical Maintenance Committee Webinar Series Presents Disc Brake Wheels On Inspection January 28, 2015 2 Introduction Welcome to today s webinar in which we will cover a wheels
4. SEPARATE SPEED SENSOR FRONT LH (a) Remove the bolt and disconnect the speed sensor wire and flexible hose from the shock absorber assy.
OVERHAUL Refer to components: See page 304 Use the same procedures for the RH side and LH side. The procedures listed below are for the LH side. 1. DRAIN TRANSAXLE OIL (a) Using a #10 socket hexagon wrench,
PRODUCT IN FOCUS - Meritor Wheel Bearing & Seal Kits. Advantages BULLS EYE APRIL Aftermarket
Aftermarket In this Issue: Product In Focus New Products Supersessions Getting Technical Staff Profile BULLS EYE APRIL 2017 PRODUCT IN FOCUS - Meritor Wheel Bearing & Seal Kits Advantages A convenient
TRUCK TRAILER TRANSIT BRAKE PRODUCT CATALOG
TRUCK TRAILER TRANSIT BRAKE PRODUCT CATALOG 2018 TRUCK : TRANSIT TRAILER TRANSIT BRAKE PRODUCT BRAKE PRODUCT CATALOG CATALOG TRUCK TRAILER TRANSIT YOUR SOURCE FOR BRAKE SYSTEMS MAINTENANCE NEEDS OUR MISSION
1. SPECIFICATIONS Part-time transfer case. Mating surface of front flange kg (including oil)
3240-01 07-3 1. SPECIFICATIONS Type Total length Description Mating surface of front flange Weight Oil capacity Oil type Location Specifications Part-time transfer case 343 mm 40 mm 32.4 kg (including
Lotus Europa S1/S2 Parts Manual - Section CA - Suspension - Front - Page 1
Lotus Europa S1/S2 Parts Manual - Section CA - Suspension - Front - Page 1 Lotus Europa S1/S2 Parts Manual - Section CA - Suspension - Front - Page 2 Item Lotus # Description Change Point Notes Bulletin
PRE-INSTALLATION. INSTALLATION INSTRUCTIONS Front Ford F150 4WD 4" Suspension Lift Kit
2015 Ford F150 4WD 4" Suspension Lift Kit PRE-INSTALLATION 2 - Knuckle (Driv/Pass) 2 - Crossmember (Front/Rear) 2 - Differential Bracket (Driv/Pass) 1 - Diff. Brace Bracket (Pass) 2 - Front Brake Line
PARTS VIEW KF22 / KF29 DRUM BRAKE AXLE (22.5 )
KF22 / KF29 DRUM BRAKE () See page 5 for: Weweler-MBS Ø146mm beam s-cam details. KF29 Long Pin P brake, Page 6, E For CONMET wheel end part numbers go to page 5 www.khitch.com.au Uncontrolled document
Airflex Floating Housing Brake
Airflex Floating Housing Brake Airflex FHB Brake Elements Dimensional & Technical Data Overview Eaton Airflex has introduced a revolutionary new design in disc brake technology called the Floating Housing
Expand Your Business into the Medium-Duty Vehicle Aftermarket. for medium-duty vehicles through both the original equipment and aftermarket channels.
Deliver More Expand Your Business into the Medium-Duty Vehicle Aftermarket Medium-duty vehicles work hard every day delivering goods, services, packages and even people to their destinations, but maintaining
1 x 250ml bottle of Kelgate brake fluid (Rear caliper mounting brackets are not included and should be ordered separately)
Pt No. Description 00-8070 KELGATE 125CC CIK APPROVED BRAKE SYSTEM (ICC) 2 x Adjustable front wheel hub assemblies (Please State stub axle diameter 17mm or 25mm) 2 x 120mm x 8mm Fully vented discs 2 x