AutoFarm GPS AutoSteer Hardware Installation Guide
|
|
- Joshua Henry
- 5 years ago
- Views:
Transcription
1 AutoFarm GPS AutoSteer Hardware Installation Guide Supported Models: Maxxum MXM-175 and MXM-190 MFD, New Holland TM-190, New Holland TM-175 PN: A
2 Special Requirements Tools This list consists of special tools that are not normally needed. A complete set of common installation tools is assumed. If you find that you are using additional special tools, please notify Documentation@Novariant.com. Metric open wrenches Metric socket wrenches up to 24mm Soft brush Clean rags Oil collection pan (for collecting oil if hose connections are opened) Attention Tighten all screws, bolts, nuts, hose connections and cable connections after the final assembly of the AutoFarm Steering System on the vehicle. Technician Feedback Please contact Novariant via to Documentation@Novariant.com with: outdated pictures or instructions tips for other installers general comments or suggestions i
3 Table of Contents Special Requirements i Tools i Attention i Technician Feedback i Install Roof Module Safety Notes Install the Mounting Rail Mount the Roof Module Install the User Terminal Assemble and Mount the User Terminal Bracket Mount and Adjust the User Terminal Install the Wheel Angle Sensor (WAS) Mount Tie Rod and Sensor Brackets Adjust the Sensor and Linkage Arms Assemble and Mount the Hydraulic Valve Install the Hydraulic Valve Install the Hydraulic Hoses Route the Hydraulic Hoses AutoSteer Valve Port Connections Connect the Hydraulic Hoses Attach the Pressure Transducer Install the SA Module Mount the SA Module Bracket Mount the SA Module to the Bracket Install the Main Cable Harness Attach the Main Cable Harness to the User Terminal Attach the Cable to the Power Supply Attach the Main Cable Harness to the Roof Module Install the SA Module Cable Harness Attach the Cable to the SA Module Connect the SA Module Harness to the Hydraulic Valve Connect the SA Module Harness to the Wheel Angle Sensor Attach SA Module Cable Harness to Main Cable Harness Final Checklist ii
4 1. Install Roof Module 1.1 Safety Notes The AutoFarm system must be powered OFF when installing or removing the roof module. The supplied locking pin or a padlock must be in place whenever the vehicle is in operation. The roof module must be removed when transporting the vehicle at speeds above 30 mph. Make sure that you are in a stable position on the tractor platform when removing the roof module, so that you do not fall or drop the roof module. 1.2 Install the Mounting Rail Remove the cab roof bolts. 1
5 Attach the mounting rail brackets to the roof. Align the mounting rail to mounting holes and fasten the mounting rail to the mounting rail brackets. The lettered holes should be on the left side of the tractor. 2
6 1.3 Mount the Roof Module Slide the roof module into locked position. The cable connection must be on the left side of the tractor, facing the rear. cable connector Make sure that the spring lock is in place. locked position 3
7 Insert and close the locking pin through the holes in the roof module and the mounting rail. Note that a padlock can replace the locking pin. locking pin Attach the radio modem antenna. Note: The antenna should be attached hand tight - do not use any tools to tighten the antenna. 4
8 2. Install the User Terminal 2.1 Assemble and Mount the User Terminal Bracket Mount the bracket assembly to the cab post. 2.2 Mount and Adjust the User Terminal Attach the adjustable arm to the user terminal. mounting plate 5
9 Remove the travel stop on the bracket assembly. Install user terminal arm onto the cab bracket. 6
10 Tighten the arm onto the cab bracket. Replace the travel stop. 7
11 Adjust user terminal arm tightness. Adjust user terminal viewing angle. 8
12 3. Install the Wheel Angle Sensor (WAS) 3.1 Mount Tie Rod and Sensor Brackets Mount the sensor bracket and attach the Wheel Angle Sensor. wheel angle sensor sensor bracket Mount the linkage bracket and attach the linkage arm. 9
13 Attach and connect the two linkage arms. 3.2 Adjust the Sensor and Linkage Arms Adjust linkage arm length and/or linkage bracket position to obtain between 3200 and 3800 counts. Turn the wheels all the way in both directions to make sure the linkage arms can move without interference. Note: This step is done during the calibration and tuning steps. 10
14 4. Assemble and Mount the Hydraulic Valve 4.1 Install the Hydraulic Valve Fasten bracket into place. valve bracket Mount the hydraulic valve. 11
15 5. Install the Hydraulic Hoses 5.1 Route the Hydraulic Hoses Route the left/right Steer In Steer Out hoses from the AutoSteer valve, under the cab, to the front right of the tractor. Note: Secure the hoses with cable ties and be sure they are clear of moving parts and heat sources. 5.2 AutoSteer Valve Port Connections Hydraulic Hose Steer In (Right) Steer In (Left) Steer Out (Right) Steer Out (Left) Pressure Return Load Sense Pressure Transducer Valve Port Label SR SL Right Left P T LS Trans 12
16 5.3 Connect the Hydraulic Hoses Detach existing steer hoses. Original right and left Steering hoses that will be opened to connect the AutoSteer hoses Open the tractor s steering lines and connect AutoSteer IN/OUT hoses. Connect the right Steer In hose to the bottom hose on the tractor steering unit. Connect the left Steer In hose to the top hose on the tractor steering unit. Connect the right Steer Out AutoSteer hose to the bottom steel steering line. Connect the left Steer Out AutoSteer hose to the top steel steering line. Note: Right steering hoses must be connected to right steering lines and Left steering hoses must be connected to left steering lines. Check for oil leaks after final assembly and the tractor engine has been turned on and steered. 13
17 Connect power beyond hoses to valve. return load sense pressure Connect hoses to power beyond unit. return load sense pressure 14
18 5.4 Attach the Pressure Transducer Attach the 90 degree fitting to the port marked trans on the AutoSteer valve. Note: Use teflon tape to ensure a good seal. Attach the pressure transducer to the 90 degree fitting. Note: Use teflon tape to ensure a good seal. 15
19 Attach the cable connector from the valve harness to the pressure transducer. pressure transducer cable connector make sure to line up the connectors correctly. do not force the connection. 16
20 6. Install the SA Module 6.1 Mount the SA Module Bracket Locate the area to mount the bracket. area for mounting bracket Mount the bracket. 17
21 6.2 Mount the SA Module to the Bracket Note: It is essential that the SA Module is NOT mounted so that the cable connection is on the top or on the side with the cable going up. 18
22 7. Install the Main Cable Harness 7.1 Attach the Main Cable Harness to the User Terminal. 7.2 Attach the Cable to the Power Supply 7.3 Attach the Main Cable Harness to the Roof Module Route the cable out the rear of the cab floor, behind the seat, under the floor mat. The existing hole may need to be widened or a new hole drilled. 19
23 Attach the cable to the roof module. Route the cable down the left side of the cab and secure with cable ties. 20
24 8. Install the SA Module Cable Harness 8.1 Attach the Cable to the SA Module Connect the cable to the SA Module. SA module cable connector locking mechanism in open position Close the cable connector locking mechanism. locked position 21
25 Note: To disconnect the cable from the SA module, the connector must first be unlocked as shown. pinch here pull upwards 8.2 Connect the SA Module Harness to the Hydraulic Valve Attach the two connectors from the SA Module to the hydraulic valve. (Different vehicle shown in picture.) two connectors 22
26 8.3 Connect the SA Module Harness to the Wheel Angle Sensor Route and secure the WAS cable from the SA Module beneath the cab to the WAS. 23
27 8.4 Attach SA Module Cable Harness to Main Cable Harness Route the SA Module cable into the cab through the floor of the cab behind the seat using the same hole used to route the main cable harness. (It may be necessary to drill this hole.) Attach the harnesses with two connectors. 24
28 9. Final Checklist Check all hose connections. Check all cable connections. Power up the vehicle and check for hydraulic leaks. Check manual steering. Power up the AutoSteer system and begin the calibration and tuning process. 25
AutoFarm GPS AutoSteer Hardware Installation Guide
AutoFarm GPS AutoSteer Hardware Installation Guide Supported Models: Case AFX-8010 Combines PN: 602-0039-01-A Special Requirements Tools This list consists of special tools required to complete the installation.
More informationAutoFarm GPS AutoSteer Hardware Installation Guide
AutoFarm GPS AutoSteer Hardware Installation Guide Supported Models: John Deere 7220 John Deere 7320 John Deere 7420 John Deere 7520 PN: 602-0022-02 Special Requirements Tools This list consists of special
More informationAutoFarm GPS AutoSteer Hardware Installation Guide
AutoFarm GPS AutoSteer Hardware Installation Guide Supported Models: Deutz 215 Agrotron, 235 Agrotron, 265 Agrotron PN: 602-0047-01-A Special Requirements Tools This list consists of special tools required
More informationAutoFarm GPS AutoSteer Hardware Installation Guide
AutoFarm GPS AutoSteer Hardware Installation Guide Supported Models: Deutz 130 Agrotron, 140 Agrotron, 150 Agrotron, 165 Agrotron PN: 602-0046-01-A Special Requirements Tools This list consists of special
More informationAutoFarm GPS AutoSteer Hardware Installation Guide
AutoFarm GPS AutoSteer Hardware Installation Guide Supported Models: Cat Challenger 65-E Track Cat Challenger 75-E Track Cat Challenger 85-E Track Cat Challenger 95-E Track PN: 602-0051-01-B i Special
More informationAutoFarm GPS AutoSteer Hardware Installation Guide
AutoFarm GPS AutoSteer Hardware Installation Guide Supported Models: John Deere 9120 Wheeled John Deere 9220 Wheeled John Deere 9320 Wheeled John Deere 9420 Wheeled John Deere 9520 Wheeled John Deere 9620
More informationSupported Models: Case SPX 3320 Case SPX 4410 Case SPX AutoFarm GPS AutoSteer. Hardware Installation Guide
Supported Models: Case SPX 3320 Case SPX 4410 Case SPX 4420 AutoFarm GPS AutoSteer Hardware Installation Guide P/N: 602-0150-01-A February 2008 Special Requirements Tools This list consists of special
More informationAutoSteer Installation Guide
AutoSteer Installation Guide Covers AutoSteer (IK#180-0054-01 Rev 01) installation on the following tractors: AutoFarm NOVARIANT INC. 1350 Willow Road, Menlo Park/CA www.novariant.com JD-7720 MFWD JD-7820
More informationSupported Models: Ag-Chem Terragator 6103, 6203 Ag-Chem Terragator 8103, AutoFarm GPS AutoSteer. Hardware Installation Guide
Supported Models: Ag-Chem Terragator 6103, 6203 Ag-Chem Terragator 8103, 8203 AutoFarm GPS AutoSteer Hardware Installation Guide P/N: 602-0147-01-A January 2008 Special Requirements Tools This list consists
More informationAutoSteer Installation Guide
AutoSteer Installation Guide Covers AutoSteer (IK#180-0006-03 Rev A) installation on the following MFWD tractors: JD-8100 JD-8200 JD-8300 JD-8400 JD-8110 JD-8210 JD-8310 JD-8410 JD-8120 JD-8220 JD-8320
More informationGPS AutoSteer System Installation Manual
GPS AutoSteer System Installation Manual Supported Vehicles Non-AccuGuide Ready and Non-IntelliSteer Ready Case STX Wheeled or Quadtrac Case STEIGER Wheeled or Quadtrac New Holland TJ New Holland T 380
More informationGPS AutoSteer System Installation Manual
GPS AutoSteer System Installation Manual Supported Vehicles John Deere Sprayers 4700 4710 4720 Non-AutoTrac Ready PN: 602-0228-01-A LEGAL DISCLAIMER Note: Read and follow ALL instructions in this manual
More informationGPS AutoSteer System Installation Manual
GPS AutoSteer System Installation Manual John Deere MFWD AutoTrac Ready Supported Models 8225R 8245R 8270R 8295R 8320R 8345R PN: 602-0254-01-A LEGAL DISCLAIMER Note: Read and follow ALL instructions in
More informationKit. Hydraulic Kit Installation Guide REV A Item Component Part Number Qty
Hydraulic Kit Installation Guide Item Component Part Number Qty 1. HOSE 5/8 X 48" -8F X -12F 90 DEG ORFS F451TC-JSJ9081210-48 2 2. HOSE 1/4" X 48" -4F X -6F ORFS F451TC-JCJC040604-48 1 3. HOSE 5/8 X 72"
More informationGPS AutoSteer System Installation Manual
GPS AutoSteer System Installation Manual Supported Vehicles Case STX Wheeled or Quadtrack Case STEIGER Wheeled or Quadtrack New Holland TJ New Holland T 380 380 380 9030 430 385 430 9040 480 430 480 9050
More informationGPS AutoSteer System Installation Manual
GPS AutoSteer System Installation Manual Supported Vehicles Agco Gleaner Combines R65 R66 R75 R76 PN: 602-0288-01-A LEGAL DISCLAIMER Note: Read and follow ALL instructions in this manual carefully before
More informationGPS AutoSteer System Installation Manual
GPS AutoSteer System Installation Manual Supported Vehicles Case IH Vehicles Case 2577 Combines Case 2588 Combines Accuguide Ready PN: 602-0233-01-A LEGAL DISCLAIMER Note: Read and follow ALL instructions
More informationGPS AutoSteer System Installation Manual
GPS AutoSteer System Installation Manual John Deere MFWD Valve Install Vehicles Supported Models 7200 7210 7400 7410 7600 7510 7700 7610 7800 7710 7810 PN: 602-0212-01-A LEGAL DISCLAIMER Note: Read and
More informationInstallation Manual. AutoSteer. Gleaner Combine. AutoGuide 2 Steer Ready. Supported Models A66 A76 R66 R76 S67 S77 PN: A
Installation Manual AutoSteer Gleaner Combine AutoGuide 2 Steer Ready Supported Models A66 A76 R66 R76 S67 S77 PN: 602-0312-01-A LEGAL DISCLAIMER Note: Read and follow ALL Instructions in this manual carefully
More informationKit. Hydraulic Kit Installation Guide REV B Table 1 Component List. Item Component Part Number Qty
Hydraulic Kit Installation Guide Table 1 Component List Item Component Part Number Qty 1. Hose 5/8 X 36-8F X -12F 90 DEG ORFS F451TC-JSJ9081210-36 2 2. HOSE ASSY. 1/4" X 36" -4F X -6F ORFS F451TC-JCJC040604-36
More informationGPS AutoSteer System Installation Manual
GPS AutoSteer System Installation Manual Supported Vehicles Case IH Vehicles Case 5088 Combines Case 6088 Combines Case 7088 Combines Accuguide Ready PN: 602-0250-01-A LEGAL DISCLAIMER Note: Read and follow
More informationGPS AutoSteer System Installation Manual
GPS AutoSteer System Installation Manual John Deere Track Supported Models 8295RT 8320RT 8345RT PN: 602-0255-01-A LEGAL DISCLAIMER Note: Read and follow ALL instructions in this manual carefully before
More informationGPS AutoSteer System Installation Manual
GPS AutoSteer System Installation Manual Supported Vehicles Case IH Combines 7010 7120 8010 8120 AFX 8010 9120 PN: 602-0283-01-A LEGAL DISCLAIMER Note: Read and follow ALL instructions in this manual carefully
More informationKit. Hydraulic Kit Installation Guide REV A Item Description Part Number Qty
Hydraulic Kit Installation Guide Item Description Part Number Qty 1. HOSE ASSY. 1/2" X 174" -8F X -8F 90 DEG. ORFS F451TC-JCJ9080808-174 1 2. HOSE ASSY. 1/2" X 96" -8F X -10F ORFS F451TC-JCJC081008-96
More informationGPS AutoSteer System Installation Manual
GPS AutoSteer System Installation Manual Closed Center High Flow Valve Custom Hardware Installation Guidelines and Recommendations THIS MANUAL IS FOR TRAINED AUTOSTEER DEALERS ONLY PN: 602-0203-01-A LEGAL
More informationGPS AutoSteer System Installation Manual
GPS AutoSteer System Installation Manual Supported Vehicles New Holland Combines CR 9040 CX 9040 CR 9050 CX 9050 CR 9060 CX 9060 CR 9070 CX 9070 CR 9080 CX 9080 IntelliSteer Ready PN: 602-0231-01-A LEGAL
More informationPN: A. Reactive Steering Kit Installation Manual
PN: 602-0275-01-A Reactive Steering Kit Installation Manual LEGAL DISCLAIMER Note: Read and follow ALL instructions in this manual carefully before installing or operating the AutoSteer system. Note: Take
More informationGPS AutoSteer System Installation Manual
GPS AutoSteer System Installation Manual Supported Vehicles MacDon M150 M200 PN: 602-0232-01-A LEGAL DISCLAIMER Note: Read and follow ALL instructions in this manual carefully before installing or operating
More informationGPS Steering System Installation Manual
GPS Steering System Installation Manual Supported Vehicles Challenger Massey Ferguson AGCO MT-645C, MT-645D MF-8650 DT-205B MT-655C, MT-655D MF-8660 DT-225B MT-665C, MT-665D MF-8670 DT-250B MT-675C, MT-675D
More informationA5 AutoSteer Closed Center Compact Valve Custom Hardware Installation Guidelines and Recommendations
A5 AutoSteer Closed Center Compact Valve Custom Hardware Installation Guidelines and Recommendations THIS MANUAL IS FOR TRAINED AUTOFARM DEALERS ONLY AutoFarm GPS AutoSteer Hardware Installation Guide
More informationINSTALLATION MANUAL. AutoSteer. Install Kit: Upgrade from A5
INSTALLATION MANUAL AutoSteer Install Kit: 186-0066-01 Please refer to this manual prior to beginning the installation of the AutoSteer system Upgrade from A5 Custom Hardware Installation 2014-05 PN 602-0432-02
More informationINSTALLATION MANUAL. AutoSteer Install Kit: AutoTrac Ready Installation
INSTALLATION MANUAL AutoSteer Install Kit: 186-0002-01 186-0002-02 186-0002-03 186-0002-04 Please refer to this manual prior to beginning the installation of the AutoSteer system AutoTrac Ready Installation
More informationINSTALLATION MANUAL. Install Kit: AutoTrac Ready Installation
INSTALLATION MANUAL Install Kit: 188-0089-02 Please refer to this manual prior to beginning the installation of the ParaDyme system AutoTrac Ready Installation Supported Models. John Deere S680 S690 2013-05
More informationAutoSteer Installation Guide
AutoSteer Installation Guide John Deere JD-9860 STS Combine Harvester Covers AutoSteer (IK#180-0051-01 Rev A) installation on the following combine models having single cylinder rear axle: JD-9650 STS
More informationINSTALLATION MANUAL. Fendt VarioGuide Ready COM 3 Supported Models PN REV A
INSTALLATION MANUAL Fendt VarioGuide Ready COM 3 Supported Models 922 924 927 930 933 936 PN 602-0264-02 REV A LEGAL DISCLAIMER Note: Read and follow ALL instructions in this manual carefully before installing
More informationKit. Hydraulic Kit Installation Guide REV A. Item Component Part Number Qty
Hydraulic Kit Installation Guide Item Component Part Number Qty 1. HOSE ASSY. 3/8" X 110" -8F ORFS X -8F ORFS 90 DEG F451TC-JCJ9080806-110 1 2. HOSE ASSY. 3/8" X 110" -6F ORFS X -8F ORFS 90 DEG F451TC-JCJ9060806-110
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. All 30528 INTERFACE 2006 CR-V Issue Date SEP 2005 PARTS LIST XM Radio Unit Kit (sold separately): P/N 08A15-EX5-000 2 Wire tie with clips
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. CD CHANGER ATTACHMENT KIT 2004 CR-V AII 26118 Issue Date SEP 2003 PARTS LIST CD Changer Attachment Kit (sold separately): P/N 08B26-S9A-100
More informationREARVIEW MIRROR AND BACKUP CAMERA KIT
REARVIEW MIRROR AND BACKUP CAMERA KIT P/N 2881483 APPLICATION Verify accessory fitment at Polaris.com. BEFORE YOU BEGIN Read these instructions and check to be sure all parts and tools are accounted for.
More informationKit. Hydraulic Kit Installation A. Item Component Part Number Qty
Hydraulic Kit Installation Item Component Part Number Qty 1. 2. 3. 4. Hose, 1/2 x 60-8F ORFS x -8F ORFS 90 Hose, 3/8 x 60-6F ORFS x -8F ORFS 90 Hose, 1/4 x 60-4F ORFS x -4F ORFS 45 Hose, 1/4 x 60-4F ORFS
More informationSteer Ready Kit Installation Guide
Fits CaseIH Tractors: Puma 130 Puma 200 Puma 145 Puma 215 Puma 160 Puma 230 Puma 170 Puma 185 Steer Ready Kit Installation Guide Kit: EDX-SR-CPuma, P/N 911-3016-000 Read and Follow Safety Messages In these
More informationTOYOTA im NAVIGATION UPGRADE Preparation
Preparation Part Number: PT296-00170 PT296-12170 (Extension Module w/ AHA) Kit Contents Item # Quantity Reqd. Description 1 1 Extension Module 2 1 BT cable 3 1 DA/Ext Harness 4 1 GPS Antenna kit 5 6 Bolt
More informationINSTALLATION INSTRUCTIONS Autopilot Kit
INSTALLATION INSTRUCTIONS Autopilot Kit MODELS Case IH MX20 MX230 MX255 MX285 Note: This kit is to be installed by a Trimble-trained technician only. 2004 Trimble Printed in U.S.A. 40394-25-AP Issued 2/04
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory S P/N 08V67-SJC-101 Application 2012 RIDGELINE Publications No. AII 12006 Issue Date NOV 2011 PARTS LIST Back-up sensor harness 3 Wire ties with small clips (2 Not used)
More informationSCION im PREMIUM AUDIO Preparation
SCION im 2016 - PREMIUM AU Preparation Part Number: PT296-12160 (Extension Module w/ AHA) Kit Contents Item # Quantity Reqd. Description 1 1 Extension Module 2 1 BT cable 3 1 DA/Ext Harness 4 1 GPS Antenna
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 25876 2004 PILOT (LX only) Issue Date AUG 2003 The subwoofer cannot be installed on a vehicle equipped with a navigation unit. Subwoofer
More informationREAR ROOF SPEAKER KIT
REAR ROOF SPEAKER KIT P/N 2882876 APPLICATION Verify accessory fitment at Polaris.com. BEFORE YOU BEGIN Read these instructions and check to be sure all parts and tools are accounted for. Please retain
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory S P/N 08V67-SJC-101 Application 2010 RIDGELINE Publications No. AII 42117 Issue Date AUG 2009 PARTS LIST Back-up sensor harness 3 Wire ties with small clip (2 Not used)
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. AUTOMATIC AII 27160 2005 CR-V Issue Date ATTACHMENT KIT SEP 2004 PARTS LIST Automatic Day/Night Mirror Attachment Kit (sold separately)
More informationSCION xb SIRIUS SATELLITE RADIO TUNER Preparation
Preparation Part Number: PTS3-52050 NOTE: Part number of this accessory may not be the same as the part number shown. Kit Contents Item # Quantity Reqd. Description Antenna, Exterior 2 Wire Harness 3 Bracket,
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 23086 SYSTEM CR-V Issue Date NOV 2001 PARTS LIST Security System P/N 08E51-EP4-100 Security System Attachment P/N 08E55-S9A-100 Security
More informationOpen Center Compact Valve Custom Installation Guide Rev A
200-0762-01 Open Center Compact Valve Custom Installation Guide 602-0575-01 Rev A 2014-12 Overview This guide provides information for completing a custom AutoSteer valve installation on wheeled farm vehicles
More informationInstallation. Manual. OnTrac2+ GPS Assisted Steering System PN: A
Installation OnTrac2+ GPS Assisted Steering System Manual PN: 602-0208-02-A Copyright Copyright 2012. All rights reserved. This document is copyrighted and all rights are reserved. Information in this
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. SYSTEM 2005 ACCORD All 27511 (DX, LX) 2-AND 4-DOOR Issue Date AUG 2004 PARTS LIST Security System Attachment (LX): P/N 08E55-SDA-100A Unit
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. P/N 08E49-S2A-100 2004 S2000 AII 26325 Issue Date OCT 2003 PARTS LIST Hood switch harness TOOLS AND SUPPLIES REQUIRED #2 Phillips screwdriver
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. SECURITY SYSTEM P/N 08E49-SDA-100 ACCORD 2- AND 4-DOOR AII 30666 Issue Date AUG 2005 PARTS LIST Hood switch harness Illustration of the
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. XM RADIO SYSTEM (EXCEPT LX) 2006 ODYSSEY All 30392 Issue Date AUG 2005 PARTS LIST XM Radio Attachment (sold separately): P/N 08B15-SHJ-100
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. XM SATELLITE RADIO SYSTEM (EX) 2008 PILOT All 37110 Issue Date JUN 2007 PARTS LIST XM Radio Attachment (sold separately) P/N 08B15-S9V-100A
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. ELEMENT AII 24282 Issue Date DEC 2002 PARTS LIST 2 Screw-grommets CD Changer Attachment Kit: P/N 08B26-SCV-100 CD changer plate 2 Self-tapping
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. CASSETTE/IN-DASH 6-DISC AII 41821 CD CHANGER 2010 ODYSSEY Issue Date ATTACHMENT KIT JUNE 2009 PARTS LIST Player Attachment Kit (sold separately):
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. CASSETTE/IN-DASH 6 DISC/ AII 27341 MP3 ODYSSEY Issue Date ATTACHMENT KIT SEP 2004 PARTS LIST Player Attachment Kit (sold separately): P/N
More informationAutomated Steering Hydraulic Installation Kit
Automated Steering Hydraulic Installation Kit P/N: ED-JD4060 Fits John Deere Tractor Models: 4560 4760 4960 Overview A series of equipment specific hydraulic installation kits have been developed to work
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 26042-26353 XM INTERFACE ODYSSEY EXCEPT EX-L WITH NAVI/RES Issue Date FEB 2004 PARTS LIST 8 Wire ties XM Radio Attachment P/N 08B15-S0X-100
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 22903-22963 ODYSSEY Issue Date MAY 2002 PARTS LIST Subwoofer Kit: P/N 08A39-EP7-100 Subwoofer 2 Cushion tapes 8 Wire ties (1 not used)
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. BII 30230 2006 RSX P/N 08U96-S6M-200 Issue Date JULY 2005 PARTS LIST Cigarette lighter 3. Turn the two knobs counterclockwise, and remove
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 40454 XM SATELLITE RADIO 2009 S2000 Issue Date AUG 2008 PARTS LIST Template XM Radio Unit Kit (sold separately): P/N 08A53-S2A-101 XM
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 24664-25319 SYSTEM 2003 CR-V Issue Date MAY 2003 PARTS LIST Security System (sold separately) P/N 08E51-EP4-100 Security System Attachment
More informationPRELIMINARY INSTALLATION INSTRUCTIONS PARTS LIST. Combination light switch Right fog light. 4 Self-tapping washer-screws.
INSTALLATION INSTRUCTIONS Accessory S P/N 08V31-SCV-100D Application 2009 ELEMENT (SC) Publications No. AII 40515 Issue Date OCT 2008 PARTS LIST Combination light switch Right fog light Left fog light
More informationSCION tc PREMIUM AUDIO Preparation. Part Number: PT (Extension Module w/ AHA)
Preparation Part Number: PT296-12160 Kit Contents Item # Quantity Reqd. Description 1 1 Extension Module 2 1 BT cable 3 1 DA/Ext Harness 4 1 GPS Antenna kit 5 6 Bolt (M5x8) 6 5 Wire tie (10 ) Hardware
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. KIT P/N 08E49-S9V-100 2003 PILOT LX AII 23629 Issue Date MAY 2002 PARTS LIST Illustration of the Security System installed on the Vehicle
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 33373 ATTACHMENT KIT (TRUNK MOUNT) 2007 S2000 Issue Date AUG 2006 PARTS LIST Plain washer CD Changer Attachment Kit: P/N 08B26-S2A-100A
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. All 27176 2005 CR-V Issue Date P/N 08V31-S9A-114 SEP 2004 PARTS LIST 25 Wire ties Left fog light 6 Washer-bolts Right fog light 6 Spring
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 27363 ODYSSEY Issue Date SEP 2004 PARTS LIST Compact Subwoofer Kit: P/N 08A39-5E1-010 4 Flange bolt, 6 x 12 mm Subwoofer 3 Cushion tapes
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. / All 33055 2007 PILOT (LX) Issue Date JULY 2006 Player Attachment Kit (sold separately) : P/N 08B06-S9V-100A Cassette Player (sold separately)
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory HITCH Application 2009 CR-V Publications No. AII 40373 Issue Date AUG 2008 PARTS LIST Plain washer, 12 mm Trailer Hitch Kit P/N 08L92-SWA-100 Trailer hitch 6 Spring
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. SYSTEM S2000 AII 26324 Issue Date OCT 2004 PARTS LIST Headrest Speaker System P/N 08A54-S2A-100 3 Small wire ties 2 Headrest speakers 9
More informationDodge Ram Quad Cab A Dodge Ram Quad Cab 2500/ A Dodge Ram Mega Cab A
INSTALLATION GUIDE APPLICATION MODEL YR AMP PART # Dodge Ram Quad Cab 1500 2002-2008 5101-01A Dodge Ram Quad Cab 2500/3500 2003-2009 5101-01A Dodge Ram Mega Cab 2006-2009 5118-01A INSTALLATION TIME 3-5
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. All 27176-28932 2005 CR-V Issue Date S P/N 08V31-S9A-115 FEB 2005 PARTS LIST 6 Washer-bolts Left fog light 6 Spring nuts Harness bracket
More informationAutoFarm AutoSteer System Installation, Calibration & Tuning Guide
AutoFarm AutoSteer System Installation, Calibration & Tuning Guide Model: John Deere 8000 Series Tracked Tractor PN: 602-0002-01 Rev A April 21, 2004 Purpose: This document guides certified field technicians
More informationLexion 570R/575R, 580R/585R, 590R/595R
Note: Indented items indicate parts included in an assembly listed above Quantity by Model 2006+ All Years Part Name/Description Part Number 570R 575R 580R 585R Instruction Kit Lexion 570/580/590 2005500-5
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. SYSTEM P/N 08E60-SLN-100 2007 FIT AII 31719 Issue Date MAR 2006 PARTS LIST Fuse label B Keyless entry harness User s information Fuse label
More informationAutomated Steering Kit Installation Guide
Fits Buhler Versatile and New Holland Tractor Models: 2270 9280 9282 9184 2290 9480 9482 9384 2310 9680 9682 9484 2335 9880 9882 9684 2360 9884 2375 2425 Read and Follow Safety Messages Automated Steering
More informationA CAB FRAME WITH A KIOTI ROOF KIT ON KIOTI CK SERIES TRACTOR (SHOWN WITH OPTIONAL HARD DOORS) OPTIONAL ACCESSORIES SOLD SEPARATELY
A-11718 CAB FRAME WITH A-11682 KIOTI ROOF KIT ON KIOTI CK SERIES TRACTOR (SHOWN WITH OPTIONAL HARD DOORS) OPTIONAL ACCESSORIES SOLD SEPARATELY A-11636 VINYL SOFT DOORS KIT A-11637 HARD DOORS WITH NON-SLIDER
More informationINSTALLATION INSTRUCTIONS Accessory Application Publications No. All 38163 XM SATELLITE RADIO SYSTEM 2008 ODYSSEY Issue Date OCT 2007 PARTS LIST XM Radio Attachment (sold separately): P/N 08B15-SHJ-100A
More informationRANGER MIDSIZE WINCH KIT
RANGER MIDSIZE WINCH KIT P/N 2881669 APPLICATION ALL MY RANGER 400; MY11 AND NEWER RANGER 500 EXCEPT CREW BEFORE YOU BEGIN Read these instructions thoroughly and make sure all parts and tools are accounted
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. All 12035 SYSTEM 2012 RIDGELINE Issue Date NOV 2011 PARTS LIST Security System Attachment Kit: P/N 08E55-SJC-101 Flange bolt Unit bracket
More informationJanuary Rev. B Rel. 2
Automated Steering Hydraulic Installation Kit P/N: ED-JD4040 Fits John Deere Tractor Models: 4050 4055 4250 4255 4440 4450 4455 4555 4640 4650 4755 4840 4850 4955 Overview A series of equipment-specific
More informationTOYOTA PRIUS XM SATELLITE RADIO Preparation
Preparation Part Number: Mounting Kit PT546-4700 Tuner Assy 8680-0W03 NOTE: Part number of this accessory may not be the same as the part number shown. Tuner Assembly Kit Contents (8680-0W03) Item # Quantity
More informationPage 1. File: Motolight caliper one-piece Harley Date: 8/15/2006
Page 1 Harley-Davidson FL Caliper Mount Installation One-piece mounting brackets You should allow about two to three hours for installation. We suggest you use a well-lighted space for installation. PLEASE
More informationSCION tc 2005 LEATHER STEERING WHEEL Preparation. Part Number: (Silver/Dark Gray)
Preparation Part Number: 08460 21810 (Silver/Dark Gray) NOTE: Part number of this accessory may not be the same as the part number shown. Kit Contents Item # Quantity Reqd. Description 1 1 Steering Wheel
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 26320 ATTACHMENT KIT 2004 S2000 Issue Date OCT 2003 PARTS LIST CD Changer Attachment Kit: P/N 08B26-S2A-100A Plain washer Template CD
More informationRZR WINCH KIT KIT P/N
RZR WINCH KIT KIT P/N 2878787; 2879334 Application All RZR Models except RZR XP Before you begin, read these instructions twice and check to be sure all parts and tools are accounted for. Please retain
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory P/N 08E10-TA0-100 Application 2008 ACCORD 2-AND 4-DOOR Publications No. AII 35358 Issue Date AUG 2007 PARTS LIST Ambient Light Kit 2 Ambient lights Fuse label Washer
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. AUTOMATIC PILOT AII 23597 Issue Date MAY 2002 PARTS LIST Automatic Day/Night Mirror Attachment Kit P/N 08V03-S9V-100A Day/night mirror Upper
More informationJOHN DEERE GATOR SWITCH PANEL INSTRUCTIONS FITS 1GTRXUV2 AND 1GTRXUV4 CABS (p/n: 1XUVSP)
P. 1 of 5 JOHN DEERE GATOR SWITCH PANEL INSTRUCTIONS FITS 1GTRXUV2 AND 1GTRXUV4 CABS (p/n: 1XUVSP) Note: Harness Extension Kit Required for 4 Passenger (p/n: 1XUV4WHEK) This manual is the property of the
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory Application Publications No. All 26124 CR-V Issue Date SEP 2003 P/N 08V31-S9A-112 PARTS LIST 4 Washer-bolts, 6 x 20 mm Left fog light 2 Small spring nuts Right fog light
More informationINSTALLATION INSTRUCTIONS
Accessory Application Publications No. INSTALLATION INSTRUCTIONS S (LX, EX) CIVIC 2- AND 4- DOOR AII 25449 Issue Date SEP 2003 NOTE: Fog Lights cannot be installed if the vehicle is equipped with an optional
More informationAutoGlideXR Installation Procedures for Bestway Sprayer (Can be used for universal fitment)
AutoGlideXR Installation Procedures for Bestway Sprayer (Can be used for universal fitment) AutoGlideXR systems ship 1 of 4 ways. In figure 1 you will see a base 2-sensor (70802XR) system with all the
More informationJohn Deere 4730, 4830 Installation Manual JD8
JD8 John Deere 4730, 4830 Installation Manual Printed in Canada Copyright 2012 by NORAC Systems International Inc. Reorder P/N: UC4.5-BC-JD8-INST Rev E (John Deere 4730, 4830) NOTICE: NORAC Systems International
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS Accessory ACCESSORY HANDSFREELINK Application 2010 ACCORD 2 AND 4-DOOR Publications No. AII 42231 Issue Date AUG 2009 PARTS LIST HFL retainer HFL Attachment Kit P/N 08E02-TA0-100
More information