Torque Specifications for 2003 Hyundai Tiburon (GK) 2.7L DOHC
|
|
- Dominic Reed
- 6 years ago
- Views:
Transcription
1 Torque Specifications for 2003 Hyundai Tiburon (GK) 2.7L DOHC Engine Mechanical System Camshaft sprocket bolt 90 ~ ~ 1, ~ 80 Cylinder head cover bolt 8 ~ ~ ~ 7.2 Main bearing cap bolt M10 27~ ~ ~24 + (90 ~ M8 13~ ~ ~14 + (90 ~94 ) Connecting rod bolt 16~ ~ ~15 + (90 ~94 ) Cylinder head bolt (Cold engine) 25 + (58 ~92 ) (58 ~92 ) (58 ~92 ) + (43 ~47 ) (43 ~47 ) (43 ~47 ) Oil pan drain plug 35 ~ ~ ~ 33 Lower oil pan bolt 10 ~ ~ ~ 9 Upper oil pan bolt [10 38mm ( in.)] 30 ~ ~ ~ 30 [8 22mm ( in.)] 19 ~ ~ ~ 20 [161.5mm(6.3582in.)] 5 ~ 7 50 ~ 70 4 ~ 5 [152.5mm (6.0039in.)] 5 ~ 7 50 ~ 70 4 ~ 5 Oil screen bolt 15 ~ ~ ~ 16 Oil pump case bolt 12 ~ ~ ~ 11 Oil relief valve plug 40 ~ ~ ~ 36 Oil pressure switch 15 ~ ~ ~ 16 Oil pump cover screw 8 ~ ~ ~ 9 Oil filter 12 ~ ~ ~ 12 Fly wheel bolt 73 ~ ~ ~ 56 Drive plate and adaptor plate bolt 73 ~ ~ ~ 56 Air cleaner body installation bolt 8 ~ ~ ~ 9 Surge tank stay 15 ~ ~ ~ 14 Air intake surge tank to intake manifold (bolt) 15 ~ ~ ~ 14 Air intake surge tank to intake manifold (nut) 15 ~ ~ ~ 14 Intake manifold to cylinder head 19 ~ ~ ~ 15 Heat protector to exhaust manifold 12 ~ ~ ~ 11 Exhaust manifold to cylinder head (Self-locking nut) 30 ~ ~ ~ 26 Oil level gauge guide to engine 12 ~ ~ ~ 11 Water outlet fitting bolt 17 ~ ~ ~ 14 Power steering oil pump bracket to cylinder head 17 ~ ~ ~ 19 Power steering oil pump bracket 17 ~ ~ ~ 19 Crank position sensor wheel screw 5 ~ 6 50 ~ ~ 4.3 Engine mounting insulator bolt 40 ~ ~ ~ 40 Engine mounting bracket nut 60 ~ ~ ~ 58 Engine mounting bracket bolt 60 ~ ~ ~ 58 Engine support bracket stud 30 ~ ~ ~ 59 Front roll stopper bracket to sub cross member bolt 40 ~ ~ ~ 40 Front roll stopper insulator bolt and nut 50 ~ ~ ~ 47 Rear roll stopper bracket to cross member bolt 40 ~ ~ ~ 40 Rear roll stopper insulator bolt and nut 50 ~ ~ ~ 47 Transaxle mounting bracket bolt 40 ~ ~ ~ 40 Transaxle mounting insulator bolt 90 ~ ~ 1, ~ 80 Fuel hose clamp to rear cylinder head assembly 12 ~ ~ ~ 11
2 Transaxle mounting plate 10 ~ ~ ~ 9 Rear plate 10 ~ ~ ~ 9 Oil seal case 10 ~ ~ ~ 9 Crankshaft pulley bolt 180 ~ 190 1,800 ~ 1, ~138 Timing belt cover bolt 10 ~ ~ ~ 9 Engine hanger bracket to engine 20 ~ ~ ~ 20 Alternator mounting bracket to engine 20 ~ ~ ~ 22 Alternator mounting nut (Engine front case side) 20 ~ ~ ~ 22 Alternator mounting bolt (Alternator mounting bracket side) 20 ~ ~ ~ 22 Starter to transmission (Nut) 20 ~ ~ ~ 22 Starter to transmission (Bolt) 27 ~ ~ ~ 25 Driver belt pulley bolt 35 ~ ~ ~ 40 Driver belt tensioner bolt 20 ~ ~ ~ 20 Engine coolant pump to cylinder block bolt (Head mark "7" mark) 15 ~ ~ ~ 16 Engine coolant temperature sensor 20 ~ ~ ~ 29 Engine coolant inlet fitting attaching bolt 17 ~ ~ ~ 14 Throttle body to surge tank bolt 15 ~ ~ ~ 14 Oxygen sensor to exhaust manifold 40 ~ ~ ~ 36 Front exhaust pipe to exhaust manifold nut 30 ~ ~ ~ 29 Front exhaust pipe to catalytic converter bolt 40 ~ ~ ~ 43 Catalytic converter to center exhaust pipe nut 30 ~ ~ ~ 29 Center exhaust pipe to main muffler nut 30 ~ ~ ~ 29 Main muffler hanger support bracket bolt 10 ~ ~ ~ 11 Delivery pipe installation boly 10 ~ ~ ~ 11 Timing belt tensioner pulley bolt 43 ~ ~ ~ 40 Timing belt idler pulley bolt 50 ~ ~ ~ 43 Timing belt tensioner arm fixed bolt 35 ~ ~ ~ 40 Auto tensioner fixed bolt 20 ~ ~ ~ 20 Accelerator cable bracket 4 ~ 6 40 ~ 60 3 ~ 4 Spark plug 20 ~ ~ ~ 22 Engine Electrical System Generator terminal (B+) 5 ~ 7 50 ~ ~ 5.1 Starter motor terminal (B+) 10 ~ ~ ~ 8.8 Battery terminal 4 ~ 6 40 ~ ~ 4.3 Spark plug 20 ~ ~ ~ 22 Emission Control System Positive Crankcase Ventilation Valve 8 ~ ~ ~ 8 Fuel System Delivery pipe installation bolts 10 ~ ~ ~ 11 Engine coolant temperature sensor 20 ~ ~ ~ 29 Heated oxygen sensor 40 ~ ~ ~ 36 Heated oxygen sensor connector bracket bolt 8 ~12 80 ~ ~ 8.7 Fuel pressure regulator installation bolt 7 ~ ~ ~ 8.1 High pressure hose and fuel main pipe 30 ~ ~ ~ 29
3 High pressure hose and fuel filter 25 ~ ~ ~ 25 High pressure hose to delivery pipe 3 ~ 4 30 ~ ~ 3 Fuel pump assembly to fuel tank 2 ~ 3 20 ~ ~ 2.2 High pressure hose at fuel tank 30 ~ ~ ~ 2.2 Throttle body to surge tank 15 ~ ~ ~ 14 Accelerator arm bracket bolts 8 ~ ~ ~ 8.7 ISC actuator 6 ~ 8 60 ~ ~ 5.8 Fuel sender to fuel tank 2 ~ 3 20 ~ ~ 2.2 Clutch System Clutch pedal to pedal support member (Clutch pedal bracket) Clutch pedal support member to master cylinder 19~28 8~10 190~280 80~100 14~20 6~7 Clutch tube flare nut 13~17 130~170 9~13 Clutch tube bracket 4~6 40~60 3~4 Reservoir band 13~17 130~170 9~13 Clutch release cylinder 15~22 150~220 11~16 Clutch release cylinder union bolt 20~25 200~250 15~18 Clutch cover assembly Single mass flywheel 15~22 150~220 11~16 Dual mass flywheel 20~27 200~270 14~19 Manual Transaxle System (6-SPEED M/T) Item N m kg cm lb ft Manual transaxle case to clutch housing bolt 63 ~ ~ ~ 49 Drain plug 30 ~ ~ ~ 28 Reverse lever 11.8 ~ ~ ~ 11.5 Shift check plug 12.7 ~ ~ ~ 12.5 Shift check 22.5 ~ ~ ~ 18.8 Stopper bolt 26.5 ~ ~ ~ 22.4 Control shaft bolt 6.3 ~ ~ ~ 6.0 Shift lever mounting plate 2 ~ 3 20 ~ 30 1 ~ 2 Differential final gear bolt ~ ~ ~ 94 Driveshaft and Axle Item Nm Kgf cm lbf ft Driveshaft nut 2.0L 200 ~ ~ ~ L 200 ~ ~ ~ 207 Knuckle to strut assembly nut 140 ~ ~ ~ 118 Lower arm ball joint to knuckle nut 60 ~ ~ ~ 53 Tie rod end to knuckle 24 ~ ~ ~ 25 Front brake caliper to knuckle 69 ~ ~ ~ 63 Wheel nut 90 ~ ~ ~ 81 Rear hub bearing flange nut 200 ~ ~ ~ 192 Rear brake to rear axle carrier mounting bolt 65 ~ ~ ~ 56 Rear strut to carrier nut 110 ~ ~ ~ 96 Trailing arm to rear axle carrier mounting nut 100 ~ ~ ~ 88 Rear suspension p arm to rear axle carrier mounting gnut 160 ~ ~ ~ 133
4 Suspension System Wheel nut 90~ ~ ~82 Driveshaft nut 2.0L 200~ ~ ~ L 200~ ~ ~207 Front strut upper installation nut 45~60 450~600 33~44 Front strut assembly to knuckle 140~ ~ ~118 Front strut mounting self-locking nut 40~50 400~500 29~37 Lower arm ball joint to knuckle 60~72 600~720 43~52 Lower arm bushing (A) mounting bolt 130~ ~ ~111 Lower arm bushing (G) mounting bolt 130~ ~ ~111 Stabilizer bar bracket mounting bolt 30~45 300~450 22~33 Tie rod end ball joint to knuckle 24~34 240~340 18~25 Tie rod end lock nut 50~55 500~550 37~41 Stabilizer link nut 35~45 350~450 26~33 Rear strut upper mounting nut 30~40 300~400 22~30 Rear strut lower mounting nut 110~ ~ ~96 Rear strut mounting self locking nut 40~60 400~600 30~44 Rear stabilizer link to stabilizer bar 35~45 350~450 26~33 Rear stabilizer bar bracket bolt 17~26 170~260 13~19 Rear suspension arm tie rod nut 50~60 500~600 37~43 Rear suspension arm (A,B) mounting bolt 160~ ~ ~133 Rear cross member mounting bolt 100~ ~ ~88 Trailing arm to bracket nut 40~50 400~500 30~37 Trailing arm bracket to body frame 40~50 400~500 30~37 Trailing arm mounting 100~ ~ ~88 Steering System Power steering column and shaft Steering column and shaft assembly mounting bolt 13 ~ ~ ~ 13.3 Power steering wheel lock nut 35 ~ ~ ~ 33.2 Pinion gear and joint assembly 15 ~ ~ ~ 15 Steering column shaft and universal joint assembly 18 ~ ~ ~ 15 Dust cover mounting bolt 17 ~ ~ ~ 19.2 Power steering gear box Gear box mounting bolt 60 ~ ~ ~ 59 Tie rod end lock nut 50 ~ ~ ~ 40.6 Tie rod end ball joint and knuckle arm mounting nut 24 ~ ~ ~ 25 Feed tube to gear box 10 ~ ~ ~ 11.8 Gear box to valve body 20 ~ ~ ~ 22 Yoke plug lock nut 50 ~ ~ ~ 52 Power steering oil pump Pressure hose to oil pump 55 ~ ~ ~ 47.9 Oil pump adjusting bolt 35 ~ ~ ~ 37 Oil pump mounting bolt 35 ~ ~ ~ 37 Oil pump bracket mounting bolt 35 ~ ~ ~ 37 Power steering hose
5 Power steering reservoir mounting bolt 4 ~ 6 40 ~ ~ 4.4 Power steering hose mounting bolt 4 ~ 6 40 ~ ~ 4.4 Power steering tube mounting bolt 4 ~ 6 40 ~ ~ 4.4 Brake System Item Nm Kgf cm lbf ft Master cylinder to booster mounting nut 8~12 80~120 6~9 Brake booster mounting nut 13~16 130~ ~11.8 Brake booster vacuum hose fitting to surge tank 15~18 150~ ~13.3 Bleeder screw 7~13 70~ ~9.6 Brake tube flare nut, brake hose 13~17 130~ ~12 Caliper guide rod bolt 22~32 220~ ~23.6 Caliper assembly to knuckle 65~75 650~750 48~55 Brake hose to front caliper 25~30 250~300 18~22 Wheel speed sensor mounting bolt 8~9 80~90 6~7 Hydraulic & electronic control unit mounting bolt 8~10 80~100 6~7.4 Hydraulic & electronic control unit mounting bracket bolt 17~26 170~260 13~19 Body (Interior and Exterior) Item Nm Kg cm lb ft Door Door hinge to body 35~42 350~420 25~31 Door hinge to door 10~12 100~120 7~8 Door striker mounting bolt 17~22 170~220 12~16 Tailgate Tailgate hinge to body 22~27 220~270 16~19.5 Tailgate hinge to tailgate 7~9 70~90 5~7 Tailgate latch mounting bolt 7~11 70~110 5~8 Tailgate striker mounting bolt 9~14 90~ ~10 Hood Hood hinge to body 22~27 220~270 16~19.5 Hood hinge to hood 22~27 220~270 16~19.5 Hood latch to body 7~11 70~110 5~8 Gas lifter mounting bolt 9~14 220~270 16~19.5 Seat Front seat to floor, Bolt 35~55 350~550 25~40 Rear seat back center bracket, Bolt 17~26 170~260 12~19 Rear seat back lower side bracket, Bolt 17~26 170~260 12~19 Rear seat cushion mounting, Bolt 17~26 170~260 12~19 Seat belt Front seat belt retractor mounting bolt 40~55 400~550 29~40 Front seat belt upper anchor mounting bolt 40~55 400~550 29~40 Front seat belt sliding bar mounting bolt 40~55 400~550 29~40 Front seat belt height adjuster mounting bolt 40~55 400~550 29~40 Rear seat belt retractor mounting bolt 40~55 400~550 29~40 Rear seat belt upper anchor mounting bolt 40~55 400~550 29~40 Front seat belt buckle mounting bolt 40~55 400~550 29~40 Sunroof Sunroof lid panel mounting, Nut 7~9 70~90 5~6.5 Sunroof assembly mounting, Bolt 7~11 70~110 5~8
A 1 SERVICE SPECIFICATIONS
A1 A2 Clutch CLUTCH Specifications Pedal height (from asphalt sheet) Release point (from pedal stroke end position) Push rod play at pedal top Pedal freeplay Disc rivet head depth Disc runout Diaphragm
More informationPARTIAL ENGINE ASSY COMPONENTS. Clip. Radiator Grille. Clip. Front Bumper Cover. Engine Under Cover LH. N m (kgf cm, ft lbf) : Specified torque
ENGINE MECHANICAL 1417 COMPONENTS 141FP01 Radiator Grille Front Bumper Cover Engine Under Cover RH Engine Under Cover LH A79361 962 1418 ENGINE MECHANICAL Heater Outlet Water Hose 7.0 (71, 62 in. lbf)
More informationPARTIAL ENGINE ASSY (2ZZ GE)
COMPONENTS 14189 140R701 7.0 (71, 62 in. lbf) Cylinder Head Cover No. 2 19 (194, 14) Radiator Support Upper 19 (194, 14) Radiator Hose Inlet Cruise Control Actuator Assy 6.0 (61, 53 in. lbf) Radiator Assy
More informationFastener Tightening Specifications Specification
2008 G6 Applies to: 3.5L Report a problem with this article Fastener Tightening s A/C Compressor Bracket Bolt Camshaft Position Actuator Assembly Bolt 16 Y 12 lb ft Camshaft Position Actuator Magnet Bolt
More informationPARTIAL ENGINE ASSY (2TR FE)
COMPONENTS 147 1421Z01 Clip Hood Subassy x9 Radiator Support to Frame Seal LH 30 (306, 22) 30 (306, 22) Fan and Generator V Belt 5.0 (51, 44 in. lbf) Fan Shroud Fan Pulley Fan w/ Fluid Coupling PRE RUNNER
More informationClass. Class Hexagon head bolt Bolt head No. Hexagon flange bolt 4T 5T 6T 7T. w/ washer hexagon bolt. Hexagon flange bolt 10T 11T
STANDARD BOLT STANDARD BOLT HOW TO DETERMINE BOLT STRENGTH SS1 SS00F01 Mark Class Mark Class Hexagon head bolt Bolt head No. 4 5 6 7 4T 5T 6T 7T Hexagon flange bolt w/ washer hexagon bolt 4 Protruding
More informationATV 50 DVX BLACK-RED (A2008KSA2BUSD) Page 1 of 60 AIR INTAKE ASSEMBLY
2008 ATV 50 DVX BLACK-RED (A2008KSA2BUSD) Page 1 of 60 AIR INTAKE ASSEMBLY 2008 ATV 50 DVX BLACK-RED (A2008KSA2BUSD) Page 2 of 60 AIR INTAKE ASSEMBLY Ref # Part Number Qty S/P/F Description 1 3303-005
More informationCYLINDER. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER 1 J38-11102-00-00 CYLINDER HEAD ASSEMBLY. 1 2 J38-11133-09-00. GUIDE, INTAKE VALVE..... 2 3 99510-12016-00 PIN, DOWEL.............. 2 4 95811-08070-00 BOLT, FLANGE............ 3 5 95811-08045-00
More informationCYLINDER. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER 1 J38-11102-00-00 CYLINDER HEAD ASSEMBLY. 1 2 J38-11133-09-00. GUIDE, INTAKE VALVE..... 2 3 99510-12016-00 PIN, DOWEL.............. 2 4 95811-08070-00 BOLT, FLANGE............ 3 5 95811-08045-00
More informationAcura Plus Comprehensive & Major Component Coverage
Acura Plus Comprehensive & Major Component Coverage ENGINE Cylinder block and all internal parts Cylinder heads and all internal parts Engine mounts Engine seals and gaskets Flywheel Intake and exhaust
More information03 1 SERVICE SPECIFICATIONS
SERVICE SPECIFICATIONS STANDARD BOLT STANDARD BOLT HOW TO DETERMINE BOLT STRENGTH 031 0307K02 Bolt Type Hexagon Head Bolt Normal Recess Bolt Deep Recess Bolt Stud Bolt Weld Bolt Class 4 4T No Mark No Mark
More informationENGINE ASSEMBLY. COMPONENTS (Part 1)
1 of 32 ENGINE ASSEMBLY COMPONENTS (Part 1) 2 of 32 COMPONENTS (Part 2) 3 of 32 COMPONENTS (Part 3) 4 of 32 COMPONENTS (Part 4) 5 of 32 COMPONENTS (Part 5) 6 of 32 COMPONENTS (Part 6) 7 of 32 COMPONENTS
More informationProwler XTX SHARE OUR PASSION ṬM
SHARE OUR PASSION ṬM Prowler XTX Model Number U2009P3T4EUSV (Steel Blue) Model Number U2009P3T4EOSV (Steel Blue) International Model Number U2009P3T4EUSC (M4 Camo) Model Number U2009P3T4EUSQ (Black - LE)
More informationCYLINDER HEAD CONTINUED ON NEXT FRAME. Ref. Part No. Number Description Qty Remarks
A1 A2 A3 A4 CYLINDER HEAD 1 3TB-11101-02-00 CYLINDER HEAD ASSY...... 1 2 4H7-11133-10-00. GUIDE, INTAKE VALVE..... 4 3 93440-12052-00. CIRCLIP................. 4 4 90116-06475-00. BOLT, STUD.............
More informationATV 90 UTILITY CALIFORNIA GREEN (A2008KUB2BCAG) Page 1 of 58 AIR INTAKE ASSEMBLY
2008 ATV 90 UTILITY CALIFORNIA GREEN (A2008KUB2BCAG) Page 1 of 58 AIR INTAKE ASSEMBLY 2008 ATV 90 UTILITY CALIFORNIA GREEN (A2008KUB2BCAG) Page 2 of 58 AIR INTAKE ASSEMBLY Ref # Part Number Qty S/P/F Description
More informationDrawing Page Drawing Page
Contents Drawing Page Drawing Page L4 Engine...1 L4 Engine - Exploded View...2 V6 Engine...3 V6 Engine - Exploded View... 4 Oil Filter...5 VTEC (Variable Timing Electronic Control) System... 6 Fuel and
More informationDVX 90 MODEL NUMBER A2008KSB2BUSD (BLACK-RED) MODEL NUMBER A2008KSB2BUSE (BLACK-CAT GREEN) MORE TO GO ON. TM
2008 DVX 90 Illustrated Parts Manual MODEL NUMBER A2008KSB2BUSD (BLACK-RED) MODEL NUMBER A2008KSB2BUSE (BLACK-CAT GREEN) MORE TO GO ON. TM TABLE OF CONTENTS Black-Red (Model No. A2008KSB2BUSD) Black-Cat
More informationCYLINDER HEAD CONTINUED ON NEXT FRAME. Ref. Part No. Number Description Qty Remarks
A1 A2 A3 A4 CYLINDER HEAD 1 3TB-11101-02-00 CYLINDER HEAD ASSY...... 1 2 4H7-11133-10-00. GUIDE, INTAKE VALVE..... 4 3 93440-12052-00. CIRCLIP................. 4 4 90116-06475-00. BOLT, STUD.............
More informationATV 90 UTILITY GREEN (A2006KUB2BUSG) Page 1 of 60 AIR INTAKE ASSEMBLY
2006 ATV 90 UTILITY GREEN (A2006KUB2BUSG) Page 1 of 60 AIR INTAKE ASSEMBLY 2006 ATV 90 UTILITY GREEN (A2006KUB2BUSG) Page 2 of 60 AIR INTAKE ASSEMBLY Ref # Part Number Qty S/P/F Description 1 3303-005
More informationCYLINDER HEAD. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER HEAD 1 JN6-11102-00-00 HEAD, CYLINDER.......... 1 2 JN6-11133-10-00. GUIDE, VALVE............ 2 3 JN6-11181-00-00 GASKET, CYLINDER HEAD... 1 4 95817-10070-00 BOLT, FLANGE............ 4 5 99530-14016-00
More informationWE JUST MADE YOUR DRIVE A LITTLE MORE RELAXING. THE ENHANCED COVERAGE FOR YOUR BMW CPO VEHICLE.
WE JUST MADE YOUR DRIVE A LITTLE MORE RELAXING. Introducing THE CERTIFIED PRE-OWNED (CPO) WRAP, THE ENHANCED COVERAGE FOR YOUR BMW CPO VEHICLE. When you purchase a Certified Pre-Owned BMW, you look forward
More informationFRONT RACK, BODY PANEL, AND HEADLIGHT ASSEMBLIES
FRONT RACK, BODY PANEL, AND HEADLIGHT ASSEMBLIES 0747-506 1 2506-107 1 Rack, Front - Assembly (inc. 2) 2 0411-576 1 Decal, Warning - Load 3 0441-592 4 Bushing 4 8410-835 4 Screw, Cap 5 0423-669 4 Spacer
More informationProwler XTZ Model Number U2013P4W1PUSU Model Number U2013P4W1POSU - International SHARE OUR PASSION.
2013 Prowler XTZ Model Number U2013P4W1PUSU Model Number U2013P4W1POSU - International TM SHARE OUR PASSION. TABLE OF CONTENTS 2013 Prowler XTZ (Model No. U2013P4W1PUSU) (Model No. U2013P4W1POSU - International)
More informationSupercharged MK1 MR2 Part Diagrams
Supercharged MK1 MR2 Part Diagrams Created by: Charles K. (ckowalc) 1 Table of Contents PART DIAGRAM PAGE ACCELERATOR LINK 9 AIR CLEANER 10 AIR CLEANER 4AGZE 11 ALTERNATOR 4AGZE 12 ANTENNA 13 ARMREST &
More informationSOUL GDI REPAIR AND MAINTENANCE
SOUL 2013-1.6 GDI REPAIR AND MAINTENANCE (First Numbers are page number within section - Numbers in parenthesis are overall document page) GENERAL INFORMATION (23 PAGES) 01-07 (01-07): Identification Number
More information1. COVER COMP CYLINDER HEAD
CONTENTS FIG. 1 COVER COMP CYLINDER HEAD FIG. 2 CAMSHAFT COMP FIG. 3 HOLDER CAMSHAFT COMP FIG. 4 CYLINDER HEAD COMP FIG. 5 CARBURETOR FIG. 6 AIR CLEANER FIG. 7 LEFT CRANKCASE COVER FIG. 8 DRIVE PULLEY
More informationILLUSTRATED PARTS MANUAL
ILLUSTRATED PARTS MANUAL Wildcat Trail Model Number U2014W5T2PUSG Model Number U2014W5T2PUSR Model Number U2014W5T2PUSZ Model Number U2014W5T2POSG - International Model Number U2014W5T2POSR - International
More informationSTANDARD TORQUE VALUES ENGINE & FRAME TORQUE VALUES. P-, i 1-13 I GENERAL INFORMATION ENGINE
STANDARD VALUES GENERAL INFORMATION FASTENER TYPE mm bolt and nut mm bolt and nut mm bolt and nut 0 mm bolt and nut mm bolt and nut. (0.,.) 0 (.0, 7) (.,) (., ) (., ) FASTENER TYPE mm screw mm screw mm
More informationA SYSTEMATIC SEQUENCE FOR PM INSPECTIONS
A SYSTEMATIC SEQUENCE FOR PM INSPECTIONS TYPE OF INSPECTION UNDER THE HOOD GASOLINE AND DIESEL 1 Fuel, oil, exhaust leaks - inspect 2 Oil and fuel lines inspect for kinks and wear 3 Automatic transmission
More informationHexhead Torque Values
Contents: 11: Engine 12: Engine Electrical 13: Fuel Preparation 16: Fuel Supply 17: Cooling 18: Exhaust 21: Clutch 23: Gearbox 31: Front Axle, Front Wheel Steering 32: Steering 33: Rear axle, rear-wheel
More information10th letter in VIN: J
08 0th letter in VIN: J Headlight G Br Speedometer Headlight Light Switch B Br Ignition Switch R B Y/R Brake Light Switch B G/Y Starter Relay Fuse A + G Starter Motor Rear Brake Light G/Y Br G Speed Sensor
More informationXC 450 EFT Model Number A2013KCK4CETT SHARE OUR PASSION.
2013 XC 450 EFT Model Number A2013KCK4CETT TM SHARE OUR PASSION. TABLE OF CONTENTS 2013 XC 450 EFT Green (Model No. A2013KCK4CETT) FRONT BODY ASSEMBLY... 1 REAR BODY AND TAILLIGHT ASSEMBLY... 2 BUMPER,
More informationATV I l. l u. r a. Parts Manual ARCTIC CAT. 250 cc/300 cc
2000 I l l u st ATV 250 cc/300 cc Model No. A2000ATE2AUSG (250 - Green) Model No. A2000ATE2AUSR (250 - Red) Model No. A2000ATF2AUSG (300 2x4 - Green) Model No. A2000ATF2AUSR (300 2x4 - Red) Model No. A2000ATF4AUSG
More informationIllustrated Parts Manual
1 10 Illustrated Parts Manual 2 425 CR EFT Model Number A2011IRK4CETR (Red) S H A R E O U R PA S S IO N. TM TABLE OF CONTENTS 2011 ATV 425 CR EFT Red (A2011IRK4CETR) FRONT RACK, BODY PANEL, AND HEADLIGHT
More informationCYLINDER. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER 1 J38-11102-00-00 CYLINDER HEAD ASSEMBLY. 1 2 99510-12016-00 PIN, DOWEL.............. 2 3 95811-08070-00 BOLT, FLANGE............ 3 4 95811-08045-00 BOLT, FLANGE............ 3 5 J38-11181-00-00
More informationHAMMERHEAD GT200. Page 1 of 9
HAMMERHEAD GT200 Figue Part Number Description F1-1 M200-0101 CYLINDER HEAD SUBASSY F1-2 98056-57713-00 SPARK PLUG (C7HSA NGK) F1-3 M150-1001010 CYLINDER HEAD GASKET F1-4 M150-1001004 CARBURETOR INSULATOR
More informationTorque Guidelines (Z 22 SE)
Page 1 of 14 Torque Guidelines (Z 22 SE) No. Designation Nm 1 Retaining bolts, coolant pump sprocket to coolant pump 2 Retaining bolts, balancer shaft timing chain guide rail to 3 Retaining bolts, balancer
More informationIllustrated Parts Manual. Model Number A2011ICS4BUSG (Green) A2011ICS4BOSG (Green - International)
Illustrated Parts Manual 2 1 10 650 Model Number A2011ICS4BUSG (Green) A2011ICS4BOSG (Green - International) S H A R E O U R PAS S IO N. TM TABLE OF CONTENTS 2011 ATV 650 Green (Model No. A2011ICS4BUSG)
More information700 DIESEL EFT MODEL NUMBER A2008TBT4DETI (RED) MODEL NUMBER A2008TBT4DETM (GREEN) (VADA7D4AV80X VADA7D4AV80X10493) MORE TO GO ON.
2008 700 DIESEL EFT MODEL NUMBER A2008TBT4DETI (RED) MODEL NUMBER A2008TBT4DETM (GREEN) (VADA7D4AV80X10001 - VADA7D4AV80X10493) MORE TO GO ON. TM TABLE OF CONTENTS 2008 ATV 700 Diesel EFT Red (Model No.
More informationX4 (GREEN) (A2000ATF2AUSG) Page 1 of 80 AIR INTAKE ASSEMBLY
2000 300 2X4 (GREEN) (A2000ATF2AUSG) Page 1 of 80 AIR INTAKE ASSEMBLY 2000 300 2X4 (GREEN) (A2000ATF2AUSG) Page 2 of 80 AIR INTAKE ASSEMBLY Ref # Part Number Qty S/P/F Description 1 3570-001 1 /P Intake,
More information400 4x4 Euro MODEL NUMBER A2008IDG4BEUR (RED) MODEL NUMBER A2008IDG4BEUG (GREEN) MODEL NUMBER A2008IDG4BEUZ (CAT GREEN) MORE TO GO ON.
2008 400 4x4 Euro Illustrated Parts Manual MODEL NUMBER A2008IDG4BEUR (RED) MODEL NUMBER A2008IDG4BEUG (GREEN) MODEL NUMBER A2008IDG4BEUZ (CAT GREEN) MORE TO GO ON. TM TABLE OF CONTENTS 2008 ATV 400 4x4
More informationCYLINDER HEAD (for Bank 2 4WD and Pre-Runner)
144 1GR-FE ENGINE MECHANICAL CYLINDER HEAD (for Bank 2 4WD and Pre-Runner) CYLINDER HEAD (for Bank 2 4WD and Pre-Runner) ENGINE 1GR-FE ENGINE MECHANICAL COMPONENTS 88 (897, 65) x4 88 (897, 65) x4 NO. 1
More informationLower Intake Manifold Replacement
Lower Intake Manifold Replacement Removal Procedure 1. Turn OFF all the lamps and the accessories. 2. Ensure the ignition switch is in the OFF position. 3. Disconnect the negative battery cable from the
More information1991 Volkswagen Vanagon Syncro
corner of radiator. See Fig. 1. Fig. 1: Bleeding Cooling System 2. Open bleeder valve in engine compartment (turn counterclockwise). See Fig. 1. Fill expansion tank until full. Start and run engine at
More informationENGINE ASSEMBLY COMPONENTS EM 170 1GR-FE ENGINE MECHANICAL ENGINE ASSEMBLY V-BANK COVER VACUUM HOSE AIR CLEANER ASSEMBLY NO. 2 VENTILATION HOSE
170 ENGINE 1GR-FE MECHANICAL COMPONENTS 1GR-FE ENGINE MECHANICAL ENGINE 7.5 (76, 66 in.*lbf) V-BANK COVER 8.0 (82, 71 in.*lbf) 8.0 (82, 71 in.*lbf) VACUUM HOSE AIR CLEANER NO. 2 VENTILATION HOSE MASS AIR
More informationILLUSTRATED PARTS MANUAL
ILLUSTRATED PARTS MANUAL Wildcat X LTD Model Number U2014WTW1PUSE Model Number U2014WTW1PUSJ Model Number U2014WTW1POSE - International Model Number U2014WTW1POSJ - International TM SHARE OUR PASSION.
More informationHammerhead Rave 150. Parts Manual. This Vehicle is designed for off-road use only
Hammerhead Rave 0 Parts Manual This Vehicle is designed for off-road use only FIG. CYLINDER HEAD ASSY. 0 0 0 CYLINDER HEAD ASSY. REF NO. PART NO. DESCRIPTION REGD NO. M0-00-0 CYLINDER HEAD SUBASSY 0--00
More informationILLUSTRATED PARTS MANUAL
ILLUSTRATED PARTS MANUAL 700 EFT Model Number A2014IBT4EETG TM SHARE OUR PASSION. www.arcticcat.com TABLE OF CONTENTS 2014 ATV 700 EFT (Model No. A2014IBT4EETG) FRONT RACK, BODY PANEL, AND HEADLIGHT ASSEMBLIES...
More informationBMW 327 Price list. engine block, crankshaft, bearings, cylinder head
BMW 327 Price list Tafel 1 engine block, crankshaft, bearings, cylinder head engine block : 3 stud for center main bearing cap 9 4 bushing for oil pump drive 36 5 stud for rear main bearing cover 9 6 tab
More informationManual JNSZ1100TR READ THIS MANUAL CAREFULLY IT CONTAINS IMPORTANT SAFETY INFORMATION. MINIMUM RECOMMENDED OPERATOR AGE: FOR OFF-ROAD USE ONLY
Manual READ THIS MANUAL CAREFULLY IT CONTAINS IMPORTANT SAFETY INFORMATION. JNSZ1100TR MINIMUM RECOMMENDED OPERATOR AGE: 16 FOR OFF-ROAD USE ONLY This vehicle is designed and manufactured for off-road
More information550 EFT Model Number A2013IBO4EETP SHARE OUR PASSION.
2013 550 EFT Model Number A2013IBO4EETP SHARE OUR PASSION. TM TABLE OF CONTENTS 2013 ATV 550 EFT Black (Model No. A2013IBO4EETP) FRONT RACK, BODY PANEL, AND HEADLIGHT ASSEMBLIES... 1 REAR RACK, BODY PANEL,
More informationCOMPONENT LOCATIONS B C D G F C D F G
E ABCDEF 0000 COMPONENT LOCATIONS O H B C D G F J M L K P I O N B A C D J H A E I F G N M FIG. CYLINDER HEAD ASSY. 0 0 0 PARTS MANUAL CYLINDER HEAD ASSY. M0-00-0 HEAD CYLINDER SUBASSY 0--00 PLUG SPARK(CHSA
More information550 TRV EFT Model Number A2013TBO4EETP SHARE OUR PASSION.
2013 550 TRV EFT Model Number A2013TBO4EETP TM SHARE OUR PASSION. TABLE OF CONTENTS 2013 550 TRV EFT (Model No. A2013TBO4EETP) FRONT RACK, BODY PANEL, AND HEADLIGHT ASSEMBLIES... 1 REAR BODY PANEL, FOOTWELL,
More informationIllustrated Parts Manual
Illustrated Parts Manual 2 1 10 550 PS EFT Model Number A2011IBO1PETS (Metallic Gray) S H A R E O U R PAS S IO N. TM TABLE OF CONTENTS 2011 ATV 550 PS EFT Metallic Gray (A2011IBO1PETS) FRONT RACK, BODY
More informationTriumph Tiger 800. Torque settings. Torque (Nm) Camshaft cover to cylinder head 10 Camshaft drive chain tensioner to head 9
Triumph Tiger 800 Torque settings Cylinder Head Camshaft cover to cylinder head 10 Camshaft drive chain tensioner to head 9 Camshaft bearing ladder to head Camshaft sprocket to camshaft 10 Camshaft drive
More information700 XT EFT Model Number A2013AGT1PETV SHARE OUR PASSION.
2013 700 XT EFT Model Number A2013AGT1PETV SHARE OUR PASSION. TM TABLE OF CONTENTS 2013 ATV 700 XT EFT Steel Blue (Model No. A2013AGT1PETV) FRONT RACK, BODY PANEL, AND HEADLIGHT ASSEMBLIES... 1 REAR RACK,
More informationCYLINDER HEAD CONTINUED ON NEXT FRAME. Ref. Part No. Number Description Qty Remarks
A1 A2 A3 A4 CYLINDER HEAD 1 4BD-11101-02-00 CYLINDER HEAD ASSY...... 1 2 93440-10085-00. CIRCLIP................. 2 3 90153-06029-00. SCREW, HEXAGON........ 1 4 90430-06014-00. GASKET................ 1
More informationGTS150. Dune Buggy MINIMUM RECOMMENDED OPERATOR AGE: FOR OFF-ROAD USE ONLY. 10th letter in VIN: D-G
0-06 GTS50 0th letter in VIN: D-G Dune Buggy MINIMUM RECOMMENDED OPERATOR AGE: 6 FOR OFF-ROAD USE ONLY This vehicle is designed and manufactured for off-road use only. USA only: It does not conform to
More informationREPLACEMENT HINT: 11. REMOVE V RIBBED BELT TENSIONER ASSY (a) Remove the 5 bolts and V ribbed belt tensioner.
14142 REPLACEMENT HINT: ENGINE MECHANICAL Refer to CAMSHAFT (RH BANK) or CAMSHAFT (LH BANK) for the replacement procedure of the No.2 chain (see page 14157 or 14175). 1. REMOVE ENGINE ASSEMBLY WITH TRANSAXLE
More informationPRICE LIST ITEM PRICE $ CORE
A/C Clutch $20.00 A/C Compressor $35.00 $10.00 A/C Condenser $25.00 $5.00 A/C Evaporator $15.00 A/C Hose(S) $15.00 Accelerator Cable $10.00 Air Bag $30.00 Air Bag Sensor $10.00 Air Cleaner $15.00 Air Filter
More informationCYLINDER. Ref. Part No. Number Description Qty Remarks
A1 A2 A3 A4 CYLINDER 1 2GU-11111-00-00 HEAD, CYLINDER 1......... 1 2 NGK-B8ES0-00-00 PLUG, SPARK (NGK B8ES)... 2 3 90116-08394-00 BOLT, STUD.............. 8 4 95917-08640-00 BOLT, STUD.............. 2
More informationENGINE 1. ydrax3. Ref No.
A ENGINE JR-900-00-00 A ENGINE ASSEMBLY CYLINDER HEAD JT0--00-00 HEAD, CYLINDER JN--0-00..GUIDE, VALVE JT0--00-00 GASKET, CYLINDER HEAD 90-000-00 BOLT 900-00-00 WASHER, PLATE 990-0-00 PIN, DOWEL 9-0-00
More information2000 Toyota Celica GT-S L4-1762cc 1.8L DOHC MFI - Removal and Installation
Page 1 of 8 Removal and Installation REMOVAL 1. REMOVE HOOD Torque: 13 Nm (130 kgf-cm, 9 ft. lbs.) 2. REMOVE BATTERY 3. REMOVE ECM AND ECM CASE Torque: 6.9 Nm (70 kgf-cm, 61 inch lbs.) 4. REMOVE ECM BRACKET
More information1000 XT Model Number A2013AGW1PUSW Model Number A2013AGW1POSW - International SHARE OUR PASSION.
2013 1000 XT Model Number A2013AGW1PUSW Model Number A2013AGW1POSW - International TM SHARE OUR PASSION. TABLE OF CONTENTS 2013 ATV 1000 XT (Model No. A2013AGW1PUSW) (Model No. A2013AGW1POSW - International)
More informationEngine and A4LDE Automatic Transmission Remove and Install ( ) Remove
Engine and A4LDE Automatic Transmission Remove and Install ( 3 0) Special Tools 068A -068A Engine lifting bracket -540 Bolt tightening angle gauge Workshop Equipment Transmission jack Workshop crane Assembly
More informationCYLINDER HEAD. Ref. Part No. Number Description Qty Remarks
A1 A2 A3 A4 CYLINDER HEAD 1 1UY-11110-02-00 CYLINDER HEAD ASSY...... 1 2 3Y1-11133-11-00. GUIDE, INTAKE VALVE..... 2 3 93440-12052-00. CIRCLIP................. 2 4 90401-06001-00. BOLT, UNION............
More informationE70PL4EEC 1999 : CAMSHAFT [1/23] Page 1 of 49
E70PL4EEC 1999 : CAMSHAFT [1/23] Page 1 of 49 E70PL4EEC 1999 : CAMSHAFT [1/23] 1 5030657 1 CAMSHAFT 2 5030658 1 PLATE, Camshaft thrust 3 5030549 1 SEAL, Camshaft 4 5030989 2 BOLT, Plate 5 5030663 8 ARM,
More informationPART No. PART NAME PNC QTY GB
PART No. PART NAME PNC QTY GB PARTS CATALOGUE LANCER 95 11 Group No. Index - ENGINE Engine Assy - no longer available as new part. Evo II/III used Engine & T/M Assy's Enquire for details and availability
More informationTABLE OF CONTENTS 2001 ATV
TABLE OF CONTENTS 2001 ATV 400/500 cc Manual Transmission 400 2x4 Red (Model No. A2001ATI2AUSR) 400 2x4 Green (Model No. A2001ATI2AUSG) 400 4x4 Red ( Model No. A2001ATI4AUSR) 400 4x4 Green (Model No. A2001ATI4AUSG)
More informationREMOVAL. 10. REMOVE FRONT SUSPENSION MEMBER BRACE Remove the 8 bolts and brace.
EM64 ENGINE MECHANICAL (2JZGE) EM1S801 REMOVAL 1. REMOVE ENGINE UNDER COVER 2. DRAIN ENGINE COOLANT 3. DRAIN ENGINE OIL 4. REMOVE ENGINE COVER Remove the 4 nuts and engine cover. 5. REMOVE AIR CLEANER
More informationHAMMERHEAD KT150. Illustrated Parts Manual
HAMMERHEAD KT0 Illustrated Parts Manual FIG. CYLINDER HEAD ASSY. 0 0 CYLINDER HEAD ASSY. REF NO. PART NO. DESCRIPTION REGD NO. M0-0-0 CYLINDER HEAD SUBASSY 0--00 SPARK PLUG (CHSA NGK) M0-0 CYLINDER HEAD
More informationENGINE MECHANICAL (4A FE)
Maintenance, Engine Mechanical (4AFE) A3 Chassis Brake pads and disc Pad thickness Disc thickness Disc runout Brake linings and drums Lining thickness Drum inside diameter Front Rear Front Rear Drum brake
More information5.7L ENGINE PARTS BOOK. Not for. Reproduction
5.7L ENGINE PARTS BOOK Engine Model: Engine Family: PSI, Industrial Engine Spec N.: 39004120-39004248 Parts Book Revision: December, 2015 TABLE OF CONTENTS SECTION PAGE CYLINDER BLOCK... 3-5 CYLINDER HEAD...
More informationOIL PUMP (for 4WD and Pre-Runner)
1GR-FE BRICATION OIL PUMP (for 4WD and Pre-Runner) OIL PUMP (for 4WD and Pre-Runner) ENGINE 1GR-FE BRICATION COMPONENTS 23 88 (897, 65) 88 (897, 65) NO. 1 ENGINE UNDER COVER SUB-ASSEMBLY FRONT PROPELLER
More informationB B B
FIG CYLINDER Suzuki Worldwide Motorcycle-ATV Page: of -0B00-00 0-00 0-000 0-00 0-0B0-0B0 0-0 0-0 Head, Cylinder Gasket, Cylinder Head Spark Plug (ngk,bphs) Spark Plug (nd,wfp-u) Cylinder Gasket, Cylinder
More informationCS340ES. Property of - Not for Resale A1
A1 CYLINDER HEAD - CYLINDER 1 8G8-11111-00-00 HEAD, CYLINDER 1......... 1 2 8G8-11121-00-00 HEAD, CYLINDER 2......... 1 3 NGK-BR9ES-00-00 PLUG, SPARK............. 2 4 8G8-11181-01-00 GASKET, CYLINDER HEAD
More informationIllustration Engine. PTX 2710 (EPA 3) Pole pruner. 3/27/2017 Page Copyright COMET USA, INC.
Documents Engine Starter assy and clutch Tank and air filter Adjustable telescopic pole Pruner Carburetor WT-1150 Accessories 3/27/2017 Page 1-16 Illustration Engine 3/27/2017 Page 2-16 Illustration Engine
More information700 Diesel EFT Model Number A2013TBT4DETG SHARE OUR PASSION.
2013 700 Diesel EFT Model Number A2013TBT4DETG SHARE OUR PASSION. TM TABLE OF CONTENTS 2013 ATV 700 Diesel EFT Green (Model No. A2013TBT4DETG) FRONT RACK, BODY PANEL, AND HEADLIGHT ASSEMBLIES... 1 REAR
More information400 2x4/4x4 EFT SHARE OUR PASSION ṬM
SHARE OUR PASSION ṬM 400 2x4/4x4 EFT Model Number A2009IDG2BETR (Red - 2x4) Model Number A2009IDG2BETZ (Cat Green - 2x4) Model Number A2009IDG4BETR (Red - 4x4) Model Number A2009IDG4BETG (Green - 4x4)
More informationMODEL: 310A and 3108 Tractor, Loader and Backhoe Volume 1 of 2
John Deere MODEL: 310A and 3108 Tractor, Loader and Backhoe Volume 1 of 2 THIS IS A MANUAL PRODUCED BY JENSALES INC. WITHOUT THE AUTHORIZATION OF JOHN DEERE OR IT'S SUCCESSORS. JOHN DEERE AND IT'S SUCCESSORS
More informationFigure 1. - Cylinder / Cylinder Head
Page 1 of 42 Figure 1. - Cylinder / Cylinder Head Figure 1. Cylinder / Cylinder Head 1 11111-STG-00 Cylinder comp 1 2 11121-STG-00 Head comp, cylinder 1 3 11127-CHP-00 Nut, cylinder head 1 4 11141-ROA-00
More information1000 Mud Pro Model Number A2013MLW1PUSN Model Number A2013MLW1POSN - International SHARE OUR PASSION.
2013 1000 Mud Pro Model Number A2013MLW1PUSN Model Number A2013MLW1POSN - International TM SHARE OUR PASSION. TABLE OF CONTENTS 2013 ATV 1000 Mud Pro (Model No. A2013MLW1PUSN) (Model No. A2013MLW1POSN
More information1992 Clutch. Eclipse, Expo/Expo LRV, Galant, Mirage, Precis, 3000GT
Article Text ARTICLE BEGINNING 1992 Clutch Eclipse, Expo/Expo LRV, Galant, Mirage, Precis, 3000GT DESCRIPTION All clutches are single disc type. Pressure plate assembly uses a diaphragm spring to engage
More informationTORQUE SPECIFICATIONS
TORQUE SPECIFICATIONS TORQUE SPECIFICATIONS Application Ft. Lbs. (N.m) A/C Compressor Bracket Bolts Upper Vertical Bolt 16-21 (22-29) Horizontal Bolts 32-43 (43-58) A/C Compressor-To-Bracket Bolts 32-43
More informationTechnical data. Part Thread (mm) Nm ±10% Tolerance Sidestand
section 3 - Torque settings Frame torque settings Sidestand Stand sensor bolt 5 Pre-applied threadlocker Stand plate fixing screw M10x25 43 Pre-applied threadlocker Side stand fastening pin Side stand
More informationIllustrated Parts Manual. 700 Diesel
ATV Illustrated Parts Manual A R C T I C C A T 700 Diesel Model Number A2007TBT4DUSR (Red) Model Number A2007TBT4DUSG (Green) Model Number A2007TBT4DOSG (Green - International) MORE TO GO ON. TABLE OF
More informationILLUSTRATED PARTS MANUAL
ILLUSTRATED PARTS MANUAL TRV 700 XT EFT Model Number A2014TGT1PETN Model Number A2014TGT1PETX TM SHARE OUR PASSION. www.arcticcat.com TABLE OF CONTENTS 2014 ATV 700 XT EFT (Model No. A2014TGT1PETN) (Model
More informationLINCOLN. Continental 1
3154_U01.qxd 8/1/03 7:28 AM Page 1 Continental 1 BRAKES...1-27 DRIVE TRAIN...1-21 ENGINE REPAIR...1-7 FUEL SYSTEM...1-20 PRECAUTIONS...1-7 SPECIFICATION CHARTS...1-2 STEERING AND SUSPENSION...1-22 A Air
More information650 H1 TRV EFT MODEL NUMBER A2008TBS4BETI (RED) MODEL NUMBER A2008TBS4BETM (GREEN) MODEL NUMBER A2008TBS4BETJ (CAT GREEN)
2008 650 H1 TRV EFT Illustrated Parts Manual MODEL NUMBER A2008TBS4BETI (RED) MODEL NUMBER A2008TBS4BETM (GREEN) MODEL NUMBER A2008TBS4BETJ (CAT GREEN) (VADA644AV80X05001 - VADA644AV80X05250) MORE TO GO
More informationENGINE MECHANICAL <3.0L ENGINE>
11C-1 GROUP 11C ENGINE MECHANICAL CONTENTS GENERAL DESCRIPTION......... 11C-2 ENGINE DIAGNOSIS............. 11C-3 SPECIAL TOOLS................ 11C-4 ON-VEHICLE SERVICE........... 11C-6 DRIVE
More informationDisconnect negative battery cable and remove coolant bottle cap.
1 of 16 3/25/2012 10:18 AM ools Required SA9105E 3-Bar Engine Support Fixture SA9412G Constant Force Clamp Pliers SA9127E Gage Bar Set Powertrain Assembly Removal Caution: Do not allow smoking or the use
More informationCOMPONENT LOCATOR > DISASSEMBLED VIEWS
Page 1 of 45 2006 Pontiac Grand Prix 3.8L Eng Base Service Manual: ENGINE MECHANICAL - 3.8L COMPONENT LOCATOR > DISASSEMBLED VIEWS Fig 1: Engine Block Component Views Callout Component Name 100 Engine
More information10th letter in VIN: H
0 0th letter in VIN: H Headlight G Br Speedometer Headlight Light Switch B Br Ignition Switch R B Y/R Brake Light Switch B G/Y Starter Relay Fuse A + G Starter Motor Rear Brake Light G/Y Br G Speed Sensor
More informationIllustrated Parts Manual
0 1 0 2 Illustrated Parts Manual 1000 Cruiser EFT Model Number A2010TCW4EETI (Desert Red) (Engine Serial Number: 0950TB0010060 and Up) S H A R E O U R PA S S IO N. TM TABLE OF CONTENTS 2010 ATV 1000 Cruiser
More informationReplacement parts to fit FORD ALPHABETICAL INDEX
ALPHABETICAL INDEX A Adaptor, Hydraulic, 247, 249 to 250 Adaptor, PTO Shaft, 210 Air Cleaner, 157 to 158 Bowl, 157 Door, 273 Gasket, 159 Hose, 159 Spring, 158 Tube, 158 Air Conditioning Compressors, 282
More informationREMOVAL 1. DRAIN ENGINE COOLANT 2. REMOVE THROTTLE BODY COVER 3. DISCONNECT TIMING BELT FROM CAMSHAFT TIM- ING PULLEYS (See page EM 14)
EM34 ENGINE MECHANICAL (2UZFE) EM11U02 REMOVAL 1. DRAIN ENGINE COOLANT 2. REMOVE THROTTLE BODY COVER 3. DISCONNECT TIMING BELT FROM CAMSHAFT TIM- ING PULLEYS (See page EM14) A02844 Be careful not to drop
More informationCYLINDER. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER 1 2GU-11111-00-00 HEAD, CYLINDER 1......... 1 2 NGK-B8ES0-00-00 NGK B8ES 10PK........... 2 3 90116-08394-00 BOLT, STUD.............. 8 4 95912-08640-00 BOLT, STUD.............. 2 5 90179-08491-00
More informationNOTE: Do not disassemble upper intake manifold from lower intake manifold unless replacement of one of the components is necessary.
Fig. 2: Lower Intake Manifold Bolt Tightening Sequence INTAKE MANIFOLD (UPPER) NOTE: Do not disassemble upper intake manifold from lower intake manifold unless replacement of one of the components is necessary.
More informationWildcat X. U2013WSW1POSX - International SHARE OUR PASSION.
2013 Wildcat X Model Model Model Model Number Number Number Number U2013WSW1PUSE U2013WSW1POSE - International U2013WSW1PUSX U2013WSW1POSX - International SHARE OUR PASSION. TM TABLE OF CONTENTS (Model
More informationCYLINDER - CYLINDER HEAD
A1 CYLINDER - CYLINDER HEAD 1 3FA-11110-00-00 CYLINDER HEAD ASSEMBLY. 1 2 95612-06625-00. BOLT, STUD............. 2 3 22F-11134-10-00. GUIDE, EXHAUST VALVE... 2 4 93440-10109-00. CIRCLIP.................
More information