TechnicalData. Specifications& Capacities. Telescopic Boom Truck Crane

Transcription

1 1 5565(supersedes 5542) L8 TechnicalData Specifications& Capacities Telescopic Boom Truck Crane 60ton(50.0metricton) CAUTION: This material is supplied for reference use only. Operator must refer to in---cab Crane Rating Manual and Operator s Manual to determine allowable crane lifting capacities and assembly and operating procedures.

2 5565(supersedes 5542) L8 Table Of Contents Boom, Attachments, and Upper Structure... 1 Boom... 1 Boom Head... 1 Boom Elevation... 1 Auxiliary Lifting Sheave--- Optional... 1 Hook Blocks and Balls--- Optional... 1 Fly---Optional... 1 Upper Operator s Cab and Controls... 1 Swing... 2 Electrical... 2 Load Hoist System... 3 Load Hoist Performance M Main and Optional Auxiliary Winches... 3 Hydraulic System... 3 Counterweight... 3 Carrier... 4 General... 4 Outriggers... 4 Steering and Axles... 4 Suspension... 4 Tires and Wheels... 4 Brakes... 4 Electrical... 4 Engine... 4 Transmission... 4 Carrier Speeds and Gradeability... 5 Fuel Tank... 5 Hydraulic System... 5 Pump Drive... 5 Lower Cab and Controls... 6 Additional Equipment... 6 Axle Loads... 7 AxleLoadswith2--AxleBoomDolly... 8 General Dimensions... 9 Working Range Diagram Boom Extend Modes... 11

3 5565(supersedes 5542) L8 Main Boom Lift Capacity Charts-- Standard ,500 lb Counterweight--- Fully Extended Outriggers Rotation ,500 lb Counterweight--- On Tires--- Stationary--- Boom Centered Over Rear ,500lbCounterweight---OnTires---Pick&Carry(1mph)---BoomCenteredOverRear Main Boom Lift Capacity Charts-- Optional ,100 lb Counterweight--- Fully Extended Outriggers Rotation ,100 lb Counterweight--- On Tires--- Stationary--- Boom Centered Over Rear ,100lbCounterweight---OnTires---Pick&Carry(1mph)---BoomCenteredOverRear Fly Attachment Lift Capacity Charts-- Optional ,500 lb Counterweight--- Fully Extended Outriggers Rotation ,100 lb Counterweight--- Fully Extended Outriggers Rotation Main Boom Lift Capacity Charts-- Optional(Metric) kg Counterweight--- Fully Extended Outriggers Rotation kg Counterweight--- On Tires--- Stationary--- Boom Centered Over Rear kg Counterweight--- On Tires--- Pick& Carry(1.6km/h)--- Boom Centered Over Rear kg Counterweight--- Fully Extended Outriggers Rotation kg Counterweight--- On Tires--- Stationary--- Boom Centered Over Rear kg Counterweight--- On Tires--- Pick& Carry(1.6km/h)--- Boom Centered Over Rear Fly Attachment Lift Capacity Charts-- Optional(Metric) kg Counterweight--- Fully Extended Outriggers Rotation kg Counterweight--- Fully Extended Outriggers Rotation HTC II Link---Belt Cranes

4 5565(supersedes 5542) L8 1 Boom, Attachments, and Upper Structure Boom Design--- Four section, box type construction of high tensile steel consisting of one base section and three telescoping sections. The vertical side plates have diamond shaped impression for superior strength to weight ratio. The first telescoping section extends independently by means of one double---acting, single stage hydraulic cylinder with integrated holding valves. The second and third telescoping sections extend proportionally by means of one double---acting, single stage cylinder with integrated holding valves and cables. Boom ft( m)four---sectionfullpowerboom Twomodeboomextension:A---maxmodeprovidessuperior capacities by extending the first telescope section to 60.3 ft(18.4m). Standard mode synchronizes all the telescoping sections proportionally to 110 ft(33.5m). Controlled from operator s cab. Mechanicalboomangleindicator MaximumtipheightforA---maxmodeis68.8ft(21.0m) and standard mode is ft(35.8m). Boom Head Four16.5in(41.9cm)rootdiameternylonsheavesto handleuptoeightpartsofline Easilyremovablewireropeguards Ropedeadendlugsoneachsideoftheboomhead Boomheadisdesignedforquick---reeveofthehook block Boom Elevation Onedoubleactinghydrauliccylinderwithintegralholding valve Boomelevation: ---3 to78 Auxiliary Lifting Sheave--- Optional Single16.5in(41.9m)rootdiameternylonsheave Easilyremovablewireropeguards Doesnotaffecterectionoftheflyoruseofthemainhead sheaves Hook Blocks and Balls--- Optional 25ton(22.7mt)3sheavequick---reevehookblockwith safety latch 40ton(36.3mt)4sheavequick---reevehookblockwith safety latch 50ton(45.4mt)5sheavequick---reevehookblockwith safety latch 8.5ton(7.7mt)swivelandnon---swivelhookballswith safety latch Fly---Optional 28.5ft(8.7m)onepiecelatticefly,stowable,offsettableto 2,20,and40. Maximumtipheightis144.8ft(44.1m) ft( m)twopiecebi---foldlatticefly, stowable,offsettableto2,20 and40. Maximumtip height is ft(50.9m). UpperOperator scabandcontrols Environmental Cab--- Fully enclosed, one person cab of galvaneal steel structure with acoustical insulation. Equipped with: Tintedandtemperedglasswindows Extra---largefixedfrontwindowwithwindshieldwiperand washer Swinguproofwindowwithwindshieldwiper Slidingleftsidedoorwithlargefixedwindow Slidingrearandrightsidewindowsforventilation Sixwayadjustable,cushionedseatwithseatbeltand storage compartment Dieselfiredwarm---waterheaterwithairductsforfront windshield defroster and cab floor Defrosterfanforthefrontwindow Bubblelevel Circulatingfan Adjustablesunvisor Domelight Cupholder Fireextinguisher Leftsideviewingmirror Pull---outcabwalk Twopositiontravelswinglock Air Conditioning--- Optional--- Integral with cab heating system utilizing the same ventilation outlets Armrest Controls--- Two dual axis hydraulic joystick controllers or optional single axis hydraulic controllers for: Swing Boomhoist Mainrearwinch Auxiliaryfrontwinch---optional Drumrotationindication Drumrotationindicatoractivationswitch Swingparkbrakeswitch Winchhigh/lowspeedanddisableswitch(es) Dieselparticulatefilterswitch(EPA2007EngineOnly) Telescopeoverrideswitch Warninghornbutton Outrigger Controls--- Hand held control box with umbilical cord gives the operator the freedom to view operation while setting the outriggers. Drive and Steer Controls--- Optional--- Hand held control box with umbilical cord gives the operator the ability to drive and steerthecraneatlowspeedfromtheoperator scab. Foot Controls Boomtelescope Swingbrake Enginethrottle Carrierservicebrake---optional

5 2 5565(supersedes 5542) L8 Right Front Console--- Controls and indicators for: Engineignition Bubblelevel Enginethrottlelock 12voltpowerconnection Pumpenable Airconditioning---optional Functiondisable Boomfloodlight---optional Frontwindshieldwiper Rotatingbeaconorstrobe and washer light switch--- optional Cabfloodlights Carrierparkbrake---optional Warninghorn Thirdwrapselectorswitch--- Heatingcontrols optional Consoledimmerswitch Cab Instrumentation--- Ergonomically positioned, analog instrumentation for crane operation including: Checkandstopengineindicators Lowairpressurewarningindicator Swingparkbrakeindicator Dieselparticulatefilterindicator(2007EPAEngineOnly) Highexhausttemperatureindicator(2007EPAEngineOnly) Enginecoolanttemperaturewithwarningindicator Hydraulicoiltemperaturewithwarningindicator Fuellevel Tachometer Rated Capacity Limiter--- Microguard graphic audio---visual warning system integrated into the dash with anti---two block and function limiter. Operating data available includes: Craneconfiguration Boomlengthandangle Boomheadheight Allowedloadand%ofallowedload Boomangle Radiusofload Actualload Operatorsettablealarms(include): Maximumandminimumboomangles Maximumandminimumtipheight Maximumboomlength Left/rightswingpositions Operatordefinedarea(imaginaryplane) Internal RCL Light Bar--- Optional--- Visually informs the operator when crane is approaching maximum load capacity with a series of green, yellow, and red lights. External RCL Light Bar--- Optional--- Visually informs the ground crew when crane is approaching maximum load capacity withaseriesofgreen,yellow,andredlights. Swing Motor/Planetary--- Bi---directional hydraulic swing motor mounted to a planetary reducer for 360 continuous smooth swingat2.5rpm. Swing Park Brake , electric over hydraulic,(spring applied/hydraulic released) multi---disc brake mounted on the speed reducer. Operated by a switch from the operator s cab. Swing Brake , foot operated, hydraulic applied disc brake mounted to the speed reducer. Swing Lock--- Two---position swing lock(boom over front or rear) operated from the operator s cab. 360 Positive Swing Lock--- Optional--- Meets New York City requirement. Electrical Swing Alarm--- Audio warning device signals when the upper is swinging. Lights Twoworkinglightsonfrontofthecab Onerotatingamberbeaconontopofthecab---optional Oneamberstrobebeaconontopofthecab---optional Boomfloodlight---optional

6 5565(supersedes 5542) L8 3 LoadHoistSystem Load Hoist Performance Main(Rear) and Auxiliary(Front) Winches--- 5/8 in(16mm) Rope Maximum Line Pull Normal Line Speed High Line Speed Layer Total Layer lb kg ft/min m/min ft/min m/min ft m ft m 1 15, , , , , , Maximum Diameter Wire Rope Application Type Permissible Load in mm lb kg Main(Rear) Winch Standard 5/8 16 6x19 IWRC--- right regular lay(type DB) 11, Optional 5/ x19 rotation resistant--- right regular lay(type RB) 9, Auxiliary(Front) Standard 5/8 16 6x19 IWRC--- right regular lay(type DB) 11, Winch Optional 5/ x19 rotation resistant--- right regular lay(type RB) 9, M Main and Optional Auxiliary Winches Axialpiston,fullandhalfdisplacement(2---speed)motors driven through planetary reduction unit for positive control under all load conditions. Groovedlagging Powerup/downmodeofoperation Hoistdrumcablefollower---optional Drumrotationindicator Drumdiameter:10.63in(27.0cm) Ropelength: Main:550ft(167.6m) Auxiliary:450ft(137.2m)or550ft(167.6m) Terminatorstylesocketandwedge Third wrap indicator--- optional--- Visually and audibly warnstheoperatorwhenthewireropeisonthefirst/bottom layerandwhenthewireropeisdowntothelastthree wraps. HydraulicSystem Counterbalance Valves--- All hoist motors, boom extend cylinders, and boom hoist cylinder are equipped with counterbalance valves to provide load lowering and to prevent accidental load drop if hydraulic power is suddenly reduced. Hydraulic Oil Cooler--- Carrier mounted cooler removes heat from the hydraulic oil. Cooler is integral to the engine radiator/ charge air cooler. Boom Hoist Float Valves(Optional)--- For transporting the boomovertherearofthecranewithaboomdolly. Allowshydraulic oil within the boom hoist cylinder to flow between piston sideandrodside,allowingtheboomtofloatwhileontheboom dolly. Swing Brake Release--- For transporting the boom over the rearofthecranewithaboomdolly. Holdsthe360ºswingpark brake in the released position allowing free rotation of the upper structure. Counterweight Standard--- 11,500 lb(5 216kg) total counterweight consisting of two, hydraulically removable 3,600 lb(1 633kg) counterweights with capacities for 4,300 lb(1 950kg) and 7,900 lb(3,583kg) counterweight configurations. Assembled and disassembled by hydraulic cylinders controlled from both sides of the upper structure. Optional--- 3,600 lb(1 633kg) in addition to standard counterweightforatotalof15,100lb(6849kg). Counterweight Usage Combinations 4,300 lb (1 950kg) Standard 7,900 lb (3 583kg) 11,500 lb (5 216kg) Optional ,100 lb (6 849kg) 1 X X X 2 X X 3 X

7 4 5565(supersedes 5542) L8 Carrier General 8ft6in(2.6m)wide 23ft10in(7.26m)wheelbase(centerlineoffirstaxleto centerline of fourth axle) Frame---Box---type,torsionresistant,weldedconstruction made of high tensile steel. Equipped with front and rear towing and tie---down lugs, tow connections, and access ladders. Outriggers Boxes---Twodoublebox,frontandrearweldedtothecarrier frame. Beams and Jacks--- Four single stage beams with Confined Area Lifting Capacities(CALC) provide selectable outrigger extensions of full, intermediate, and retracted positions. Jacks with integral check valve, hydraulically controlled from the operator s cabandonbothsidesofcarrier. Afifthfrontbumperoutrigger with integral check valve is hydraulically controlled from the operator scabandatthefrontbumperofcarrier. Pontoons--- Four lightweight, stow n go, 23.5 x (59.7 x 69.2cm)hexagonalsteelpontoonswithacontactareaof485in 2 (3129cm 2 )canbestoredforroadtravelineitherthestorage racks on the carrier or under the outrigger boxes. MainJackReaction---76,000lb( kg)forceand157psi ( kPa) ground bearing pressure SteeringandAxles Sheppardfullintegralmastergear/slavegearsteering system provides hydraulic assisted steering with mechanical link between steering wheel and wheels Drive---8x4foron/off---highwaytravel Axle1&2---Tandemsteered,non---driven Axle3&4---Tandemnon---steered,drivenwithreduction:5.38to1 Inter---AxleDifferentialLock---Tractionaddingdevice thatlocksaxle3withaxle4. Operatedbyaswitchfrom the carrier cab. Suspension Front--- Raydan Air Link walking beam air suspension Rear--- Raydan Air Link walking beam air suspension AxleLiftSystem---Optional---Improvesreartire ground clearance when the crane is up on outriggers. Therearairsuspensioncanberaisedorloweredwitha switchinthecarriercab. Theaxleliftsystemcanbecontrolledwithaswitchonbothsidesofthecarrier. TiresandWheels Front--- Four(single) 425/65R22.5 tires on aluminum disc wheels Rear--- Eight(dual) 11R22.5 tires on aluminum outer/steel inner disc wheels Sparetiresandwheels---optional Tireinflationkit---optional Brakes Service--- Full air anti---lock(abs) brakes on all wheel ends. Dual circuit compressed air system with air dryer. Parking/Emergency--- Spring loaded type, acting on 3rd and 4th axles automatically apply when air pressure drops below 40 psi(275.8kpa) in both circuits. Electrical Battery--- Three batteries provide 12 volt starting and operation Lights Frontlightingincludestwomainheadlights,twohigh beam lights, two parking/directional indicators, and three cab marker lights. Sidelightingincludesthreeparking/directionalindicators per side. Rearlightingincludestwoparking/directionalindicators, two parking/brake lights, two reverse lights, three marker lights, and a license plate light. Otherequipmentincludeshazard/warningsystem,cab light, instrument panel light, and signal horn. Oneamberstrobebeaconontopofthecab---optional Daytimerunninglights---optional Engine Specification Caterpillar C13 Cummins QSM Emissions Compliance Level: Maximum Allowable Sulfur Content of Fuel (PPM): Numbers of cylinders: EPA2007 (1) TierIII/StageIIIA (2) Cycle: 4 4 Bore and Stroke: inch(mm) Piston Displacement: in 3 (L) Max. Brake Horsepower: hp(kw) PeakTorque:ftlb (Nm) Alternator: volts--- amps Crankcase Capacity: qt(l) 5.12x6.18(130x157) 4.9x5.8(125x147) 763(12.5) 660(10.8) 365(272.2)@ 1,800 rpm 350(261.0)@ 2,100 rpm 1,350(1830.4)@ 1,200 rpm 400(298)@ 1,800 rpm 375(280)@ 2,100 rpm 1,400(1898)@ 1,300 rpm (40.1) 40(38) Cruisecontrol CATC13---Threestagecompressionbrake Cummins QSM--- Two stage compression brake Thermostaticallycontrolled,hydraulicallydrivenradiatorfan 120voltengineblockheater Etherinjectionsystem---optional (1) Complies with EPA emissions standards effective January (2) Complies with Tier III and Stage IIIA emissions standards effective January Transmission Automated--- ZF AS---TRONIC(no clutch pedal) manual transmission with 12 forward gears and 2 reverse gears.

8 5565(supersedes 5542) L8 5 CarrierSpeedsandGradeability Governed Speed ZF Astronic EPA 2007 Tier III/Stage IIIA Gear Ratio mph km/h mph km/h Gradeability (@ Peak Torque Except Creep@ Idle) EPA 2007 %Grade Tier III/ Stage IIIA 12th th th th th th th th th rd nd st Reverse Reverse nd Creep@idle 1st Reverse Reverse Basedonagrossvehicleweightof78,000lb(35380kg) FuelTank One 75 gal(283.9l) capacity tank HydraulicSystem All functions are hydraulically powered allowing positive, precise control with independent or simultaneous operation of all functions. Main Pumps Fourfixeddisplacementgearpumpswithautomaticdisconnect for the main and auxiliary winches, swing, boom hoist, control circuit, and telescope for use when crane is in travel mode Onefixeddisplacementgearpumpforsteeringandthe front bumper outrigger Twofixeddisplacementgearpumpsforenginecooling fan and main outriggers. These pumps also provide flow tothewinchesandboomhoistfor pick&carry mode. Operatedbyaswitchinthecarriercab. Combinedpumpcapacityof190gpm(719.2Lpm) Hydraulic Reservoir gal(545.1l) capacity equipped with sight level gauge. Diffusers built in for deaeration. Filtration--- One 10 micron, full flow, return line filter. All oil is filtered prior to return to reservoir. Accessible for easy filter replacement. PumpDrive All pumps are mechanically driven by the diesel engine. Main and auxiliary winches, swing, boom hoist, control circuit, and telescope pumps are mounted to an automatic pumpdisconnectontherearofthetransmissiontoaidin coldweatherstartingaswellastoreducepumpwearwhile traveling.

9 6 5565(supersedes 5542) L8 LowerCabandControls Environmental Cab--- Fully enclosed, one person cab of composite structure with acoustical insulation. Equipped with: Tintedandtemperedglasswindows Rolldownleftsidewindowforventilation Slidingrearandrightsidewindowsforventilation Windshieldwiperandwasher Sixwayadjustableandairsuspendeddriver sseatwith seat belt Twoadjustablerearviewmirrors Enginedependentwarm---waterheaterwithairductsfor windshield defroster and cab floor Adjustablesunvisor Domelight 12voltconnection Fireextinguisher Air Conditioning--- Integral with cab heating system utilizing the same ventilation outlets Cab Instrumentation--- Ergonomically positioned analog instrumentation for driving including: Speedometerwithodometer,hourmeter,tripodometer, and clock Frontandrearairpressurewithwarningindicator Enginecoolanttemperaturewithwarningindicator Engineoilpressurewithwarningindicator Voltageindicatorwithwarningindicator Fuellevel Tachometer Right Side Console--- Controls and indicators for: Transmissiongearshifting Transmissiondigitalreadout Cruisecontrols Enginecompressionbrakecontrols Dash Mounted Controls For: Carrierlights Carrier/upperthrottlecontrol Enginecoolingfanoverride Cabheater/airconditioning Consoledimmerswitch Anti---lockbrakediagnosticswitch Dieselparticulatefilterswitch Parkbrake Pick&carryswitch Inter---axledifferentiallockswitch Rearaxleliftsystemswitch---optional Dash Mounted Indicator For: Check,stop,andserviceengine Turnsignalindication Parkbrake Cruiseactivation Highbeamheadlights Checkanti---lockbrakesystem Checkanti---locktrailerbrakesystem Dieselparticulatefilterindication(EPA2007EngineOnly) Highexhausttemperatureindication(EPA2007Engine Only) Steering Column Controls For: Engineignition Warninghorn Turnindicators Highbeamheadlights Steeringwheeladjustments Intermittentwindshieldwiperandwasher Hazardlights Foot Controls For: Carrierservicebrakes Enginethrottle AdditionalEquipment Standard: Aluminumfulldeckfenderswithmudflaps Leftandrightbubblelevels Airhoseconnectionports Clearanceflags Optional: Pneumaticandelectricalquickdisconnectconnectors mountedontherearfortrailerorboomdollybrakesand lights Leftsidealuminumstoragebox Rearmountedpintlehook

10 5565(supersedes 5542) L8 7 Axle Loads Basecranewithfulltankoffuel and 4,300 lb( kg) counterweight Gross Vehicle Weight ( 1 ) Front Axles Rear Axles lb kg lb kg lb kg 65, , , Driver in carrier cab Rear pintle hook Pneumatic and electrical connectors for trailer or boom dolly Carrier aluminum storage box Air ride lift system--- rear axles Ether injection Air conditioning--- carrier Hoist drum follower--- main Auxiliary winch with 450 ft(137.2m) of 5/8 (16mm) type DB rope Hoist drum follower--- auxiliary Substitute type DB rope with RB rope--- main Substitute type DB rope with RB rope--- auxiliary Substitute 450 ft(137.2m) with 550 ft(167.6m) rope--- auxiliary Remove 550 ft(167.6m) of rope from rear(main) winch Remove 450 ft(137.2m) of rope from front(auxiliary) winch Air conditioner--- operator s cab mechanical swing lock Remote steer One slab of counterweight on upper 3, , , Two slabs of counterweight on upper 7, , , Three slabs counterweight on upper 10, , , Floodlight to the front of boom base section Fly mounting brackets to boom base section for fly options ft(8.7m) offsettable, one--- piece lattice fly--- stowed 1, , ft( m) offsettable, two--- piece(bi--- fold) lattice fly--- stowed 1, , Auxiliary lifting sheave ton(22.7mt) 3--- sheave hook block at boom head , ton(36.3mt) 4--- sheave hook block at boom head , ton(45.4mt) 5--- sheave hook block at boom head 1, , ton(54.4mt) 5--- sheave hook block at boom head 1, , ton(7.7mt) hook ball at boom head Hook block/ball storage box ton(22.7mt) 3--- sheave hook block in storage box ton(36.3mt) 4--- sheave hook block in storage box , ton(45.4mt) 5--- sheave hook block in storage box 1, , ton(54.4mt) 5--- sheave hook block in storage box 1, , ton(7.7mt) hook ball in storage box Counterweight Load Transfer Front Axles Rear Axles lb kg lb kg Transfer one 3,600lb( kg) slab of counterweight to carrier deck 4, , Transfer two 3,600lb( kg) slabs of counterweight to carrier deck 8, , Transfer three 3,600lb( kg) slabs of counterweight to carrier deck 12, , Axle Front Rear Maximum Load@ 65 mph(105km/h) 45,400 lb(20 593kg)--- aluminum disc wheels with 425/65R22.5 tires 47,250 lb(21 432kg)--- aluminum disc wheels with 11R22.5 tires ( 1 )Adjustgrossvehicleweightandaxleloadingaccordingtocomponentweight. Allweightsare±3%.

11 5565(supersedes 5542) L8 9 General Dimensions C of Rotation L (13.27m) 35 6 (10.82m) 66 (1.68m) (3.52m) (3.33m) (2.00m) 17 Ground Clearance (0.35m) (1.57m) (2.44m) 4 2 (1.27m) (4.48m) (0.34m) 5 (1.52m) (1.54m) (0.43m) (3.04m) (3.01m) (7.86m) (3.41m) 8 6 (2.59m) Turning Radius English Metric Wall to wall over carrier m Wall to wall over boom m Wall to wall over boom attachment m Centerline of tire m Tail Swing English Metric With counterweight m Without counterweight m 9.56 (0.24m) (0.35m) (2.37m) Full Retraction (4.31m) Intermediate Extension (6.25m) Full Extension (0.83m) (0.59m)

12 (supersedes 5542) L8 Working Range Diagram Height In Feet(Meters) Above Ground 180 (54.9) 170 (51.8) 160 (48.8) 150 (45.7) 140 (42.7) 130 (39.6) 120 (36.6) 110 (33.5) 100 (30.5) 90 (27.4) 80 (24.4) 70 (21.3) 60 (18.3) 50 (15.2) 40 (12.2) 30 (9.1) 20 (6.1) 10 (3.0) (51.8) 160 (48.8) 10 (3.0m) 150 (45.7) 140 (42.7) 8.5 (2.6m) 130 (39.6) 120 (36.6) 110 (33.5) 100 (30.5) 90 (27.4) 40 Offset 80 (24.4) (21.3) Offset (18.3) (15.2) (12.2) Operating Radius From Axis Of Rotation In Feet(Meters) (9.1) 2 Offset (6.1) 10 (3.0) C L Of Rotation 110 (33.5m) + 51 (15.5m) 90 (27.4m) + 51 (15.5m) 110 (33.5m) (8.7m) 90 (27.4m) (8.7m) 110 (33.5m) 100 (30.5m) 90 (27.4m) 80 (24.4m) 70 (21.3m) 60.3 (18.4m) A-Max Mode 60 (18.3m) B Standard Mode 50 (15.2m) 40 (12.2m) 35.5 (10.8m) A & B Modes 78 Maximum Boom Angle Boom Length Boom + Fly Length Note: Boom and fly geometry shown are for unloaded condition and crane standing level on firm supporting surface. Boom deflection, subsequent radius, and boom angle change must be accounted for when applying load to hook. WARNING DoNotLowerTheBoomBelowTheMinimumBoomAngleForNoLoadStabilityAsShownInTheLift Charts For The Boom Lengths Given. Loss Of Stability Will Occur Causing A Tipping Condition.

13 5565(supersedes 5542) L8 11 Boom Extend Modes BoomMode A (A--Max) Only inner mid section telescopes Boom Length ft(m) Inner Mid Section 298 (7.57m) Stroke Base Section 35.5(10.8) 40(12.2) 50(15.2) 60.3(18.3) Boom Mode B (Standard) Innermid,outermid,andtip sections telescope simultaneously Boom Length ft(m) 35.5(10.8) 40(12.2) 50(15.2) 60(18.3) 70(21.3) 80(24.4) 90(27.4) 100(30.5) 110(33.5) Tip Section 298 (7.57m) Stroke Outer Mid Section 298 (7.57m) Stroke Inner Mid Section 298 (7.57m) Stroke Base Section

14 (supersedes 5542) L8 Main Boom Lift Capacity Charts-- Standard Radius (ft) 11,500 lb Counterweight-- Fully Extended Outriggers Rotation (All Capacities Are Listed In Pounds) Boom Length(ft) ,000* ,000 80,900 72, ,000 73,200 65,800 50,900 37, ,800 63,600 57,700 47,300 37,900 35, ,500 52,000 47,500 39,300 37,900 34,700 28, ,500 40,300 40,000 37,900 37,900 34,300 28,300 24,000 19, ,600 30,300 30,600 30,800 30,400 24,900 22,600 19, ,800 23,200 23,400 23,400 22,100 20,100 18, ,700 18,200 18,400 18,500 18,600 18,000 16, ,600 14,800 15,000 15,000 15,100 14, ,900 12,200 12,300 12,400 12,400 12, ,100 10,300 10,400 10,400 10, ,400 8,600 8,700 8,800 8, ,200 7,400 7,400 7, ,000 6,200 6,300 6, ,200 5,300 5, ,400 4,500 4, ,800 3, ,100 3, , , * Special Conditions Or Wire Rope Required Radius (ft) This information is not for crane operation. Operator must refer to the in---cab information for crane operation. Rated lifting capacitiesshownonfullyextendedoutriggersdonotexceed85%ofthetippingloadsandontiresdonotexceed75%ofthetippingloads.

15 (supersedes 5542) L8 Main Boom Lift Capacity Charts-- Optional Radius (ft) 15,100 lb Counterweight-- Fully Extended Outriggers Rotation (All Capacities Are Listed In Pounds) Boom Length(ft) ,000* ,000 80,900 72, ,000 73,200 65,800 50,900 37, ,800 63,600 57,700 47,300 37,900 35, ,400 52,000 47,500 39,300 37,900 34,700 28, ,900 41,700 40,300 37,900 37,900 34,300 28,300 24,000 19, ,900 33,600 33,900 32,900 30,400 24,900 22,600 19, ,400 25,800 25,900 26,100 22,100 20,100 18, ,900 20,400 20,600 20,700 19,800 18,000 16, ,500 16,700 16,800 16,900 16,200 14, ,500 13,800 13,900 14,000 14,100 13, ,500 11,700 11,800 11,800 11, ,700 9,900 10,000 10,100 10, ,400 8,600 8,600 8, ,100 7,300 7,400 7, ,200 6,300 6, ,300 5,400 5, ,600 4, ,000 4, , , * Special Conditions Or Wire Rope Required Radius (ft) This information is not for crane operation. Operator must refer to the in---cab information for crane operation. Rated lifting capacitiesshownonfullyextendedoutriggersdonotexceed85%ofthetippingloadsandontiresdonotexceed75%ofthetippingloads.

16 (supersedes 5542) L8 Fly Attachment Lift Capacity Charts-- Optional Radius (ft) 110ftMainBoomLength 2 Fly Offset 11,500 lb Counterweight-- Fully Extended Outriggers Rotation (All Capacities Are Listed In Pounds) 110ftMainBoomLength 20 Fly Offset 110ftMainBoomLength 40 Fly Offset Fly Length(ft) Radius Fly Length(ft) Radius Fly Length(ft) (ft) (ft) , , ,400 6, , ,400 6, , , ,300 6, , , ,600 6, ,000 4, , ,000 6, ,400 4, , ,000 5, ,000 4, , ,000 5, ,500 4, ,200 3, ,200 5, ,600 4, ,900 3, ,400 4, ,800 4, ,200 3, ,800 4, ,200 3, ,400 3, ,200 3, ,600 3, ,800 3, ,700 3, ,000 3, ,200 3, ,300 2, ,500 3, ,700 3, ,900 2, ,100 2, ,200 3, ,500 2, ,700 2, , ,200 1, ,300 2, , , , , , , ,100 This information is not for crane operation. Operator must refer to the in---cab information for crane operation. Rated lifting capacitiesshownonfullyextendedoutriggersdonotexceed85%ofthetippingloadsandontiresdonotexceed75%ofthetippingloads.

17 5565(supersedes 5542) L8 17 Radius (ft) 110ftMainBoomLength 2 Fly Offset 15,100 lb Counterweight-- Fully Extended Outriggers Rotation (All Capacities Are Listed In Pounds) 110ftMainBoomLength 20 Fly Offset 110ftMainBoomLength 40 Fly Offset Fly Length(ft) Radius Fly Length(ft) Radius Fly Length(ft) (ft) (ft) , , ,400 6, , ,400 6, , , ,300 6, , , ,600 6, ,000 4, , ,000 6, ,400 4, , ,500 5, ,000 4, , ,000 5, ,500 4, ,200 3, ,100 5, ,200 4, ,900 3, ,300 4, ,700 4, ,200 3, ,600 4, ,000 3, ,400 3, ,000 4, ,300 3, ,800 3, ,500 3, ,700 3, ,200 3, ,000 3, ,200 3, ,700 3, ,500 3, ,700 3, ,200 3, ,200 2, ,300 3, , ,800 2, ,900 2, , ,500 1, ,500 2, , ,200 1, , , , , , , This information is not for crane operation. Operator must refer to the in---cab information for crane operation. Rated lifting capacitiesshownonfullyextendedoutriggersdonotexceed85%ofthetippingloadsandontiresdonotexceed75%ofthetippingloads.