Technical Specifications
|
|
- Priscilla York
- 5 years ago
- Views:
Transcription
1 TechnicalSpecifications HurricaneP1 Engine AirFilterHONDA0032 Pump ARRSV3G25D+F25 Pressure 1500psi/100 Flow 11.4lpm/2.5gpm HPNozzle Unloader Integrated Pumpoil 10W/40 Noise HurricaneP2&P2HoseReel&P2Combi Engine AirFilterHONDA0031 Pump ARXT13.15 Pressure 2200psi/150Bar Flow 13lpm/2.9gpm HPNozzle Gearbox 2:1Reduction Unloader Minimatic4B ARMM4B/C PumpOil 10W/40 Gearboxoil EP90 Gearbox ARCRXT Noise HurricaneP4&P4HoseReel&P4Combi Engine AirFilterHONDA001 Pump ARRK1520H Pressure 2900psi/200Bar Flow 15lpm/3.3gpm HPNozzle 2505 Gearbox 2:1reduction Unloader Gymatic3BARGM3B250 Pumpoil 10W/40 GearboxOil EP90 Noise
2 HurricaneD1ES&D1ESHoseReel Engine FuelFilter YAN55120 Pump ARRK1520H AirFilterYAN Pressure 2900psi/200Bar InjectorYAN Flow 15lpm/3.3gpm HPNozzle 2505 Gearbox 2:1Reduction Unloader Gymatic3B ARGM3B250 PumpOil 10W/40 GearboxOil EP90 Noise KitsforHurricanemachines Valve Piston Oil Water SupportRings HurricaneP1 ARKIT2186 ARKIT2187 ARKIT2188 ARKIT2189 ARKIT2191 HurricaneP2 ARKIT1864 ARKIT2629 ARKIT1872 ARKIT1874 HurricaneP4 ARKIT1828 ARKIT2757 ARKIT1856 ARKIT1857 ARKIT1829 HurricaneD1ES ARKIT1828 ARKIT2757 ARKIT1856 ARKIT1857 ARKIT1829
3 FAULT FINDER FAULT CAUSE REMEDY Machine stops suddenly P1/P2/P4 low oil x check and top up oil Or will not start. D1 flat battery/fuse x Check/replace battery, reͳ place fuse Sudden pressure loss. Water supply failed. Check water supply. Low pressure No chemical Check chemical drum, close valve HP nozzle worn or unloader set Replace HP nozzle. Set unloader to correct setting. Incorrectly. Low pressure with noise and vibration. Valves worn or Clean/replace as required. blocked. Piston seals Replace. worn. Check water supply pipe and unͳ Pump sucking air. ions. Pump will not byͳpass. Non return valve dirty or jammed. Clean or replace. Water drips from pump box. Pump seals worn. Replace. Oil drips from pump bottom. Oil seal worn. Replace. Oil is milky in colour. Water ingress through oil filter plug. Rinse pump out and replace oil. IF IN DOUBT ASK OUR ADVICE IS FREE AND CAN SAVE YOU MONEY
4 MINIMUMSERVICESCHEDULES DAILYCHECKTHEFOLLOWING a. Oilleveltopupasrequired. b. Fueltanktopupasrequired. c. AllhoseunionsforleaksreplaceOringsifleaking. d. Hoseconditioncutsetc. EVERY500HOURSORSIXMONTHS(WHICHEVERCOMESFIRST) a. Drainandreplacepumpoil. b. Drainandrefillfueltank. c. Replacefuelfilter. d. Cleanwaterfilter. e. Replacehighpressurenozzle. EVERY1000HOURSOR12MONTHS(WHICHEVERCOMESFIRST) a. Complete500hourservice. b. Replacepumpseals. c. Replaceoilseals. d. Checkunloadingpressureandsafetyvalvepressureandadjust. Theaboveserviceschedulesareintendedasaguideonly,actualservicetimesand replacementspartsrequiredwillvaryaccordingtotheareaandtheusageofthe machine.
5 SERVICE PARTS P1 ARKIT2189 SEAL KIT ARKIT2190 AR ARKIT2186 HONDA003 HONDA004 VALVE SEALS PISTONS H P VALVES AIR FILTER SPARK PLUG N26001/25045 HP NOZZLE DEM10115 DETERGENT PIPE AR SEAL CARRIERS X 3 P2 ARKIT1874 SEAL KIT ARKIT2812 AR ARKIT1864 AR HONDA0031 VALVE SEALS PISTONS H P VALVES VALVE TUBES AIR FILTER N26001/25045 HP NOZZLE DEM10115 DETERGENT PIPE AR SEAL CARRIERS X 3
6 SERVICE PARTS P4 & P4HR ARKIT1857 SEAL KIT ARKIT2611 AR AR ARKIT1828 HONDA001 HONDA004 VALVE SEALS RELIEF VALVE PISTONS RELIEF VALVES TUBES HP VALVES AIR FILTER SPARK PLUG N26001/25045 HP NOZZLE DEM10115 DETERGENT PIPE AR SEAL CARRIERS X 3 D1ES&D1ESHR ARKIT1857 SEAL KIT ARKIT2611 AR AR ARKIT1828 YAN YAN55120 RELIEF VALVE SEALS RELIEF VALVE PISTONS RELIEF VALVES TUBES HP VALVES AIR FILTER FUEL FILTER N26001/1505 HP NOZZLE DEM10115 DETERGENT PIPE AR SEAL CARRIERS X 3
7 OPERATINGINSTRUCTIONS SAFETY I Waterathighpressureisdangerousandcancauseseriousinjury.Thismachineistobe usedwithgreatcaution. II Petrolisextremelyflammableandexplosiveundercertainconditions. EXHAUSTFUMESCONTAINCARBONMONOXIDE InhalationofsuchfumescanKILL. III Dieselisflammableandharmfulifswallowed. A Alwaysrefuelinanareawhichisadequatelyventilated. B DONOTsmokewhenrefueling. C Avoidoverfilling. D Shouldfuelbespilt,wipeoffanyfuelspiltonmachineorengine. E Movetheequipmentawayfromtheareawherefuelhasbeenspilt. F DONOTrefuelwhentheengineisrunning. G DONOTruntheengineinanareawhichhasahazardousorexplosiveatmosphere. H Alwaysensurethatthefuelcapissecureafterrefueling. I Keeptheengineatleast3metresormoreawayfromanyotherequipmentor Building. J Takecarenottogetfuelonyourclothing.Ifthishappens CHANGEyourclothing IMMEDIATELY. DONOTstartanenginewhenclothinghasbeencontaminatedwithfuel. K Useonlyapprovedtypecontainersforfuel.DONOTstandthemoutinstrongsunlight, keepthemintheshade.
8 L Alwaysensurethatthereisasuitabletypefireextinguisheravailableandiswithineasy access. M DONOTleaveanenginerunningunattended,ALWAYSSTOPitbeforeleavingthearea. N NEVERpointthehighpressuresprayjetatanyperson,animal,glassorother Materialwhichmayshatter. O PREVENTanyoversprayfrominjuringotherpeopleordamagingproperty. P DONOTeventrytouseapressurewasheronmachineryorelectricalequipmentthatis connectedinanywaytothemainssupply(allswitchesintheoffposition,pulloutplugs, ifpossibleremovefuses).coverorsealelectricmotorsandfittingstoprevententryof water.beforereconnectingelectricmainssupplycheckforwaterpenetration. Q DOALLyoucantokeepplugsandsocketsinadryplaceorcoveredtoprevententryof water. R ALWAYSwhenusingthismachine: wearsafetygogglesandhelmetorhelmetwithavisor. Wearwaterproofclothingandgloves. Takepaticularcarewithdetergentsandchemicals. S NEVERattempttodisconnectanyhosewithpressureinitorallowthehosetobeflattened orkinked. T DONOTuseahighpressurehosefromaladder.Useaplatformtowerorproper scaffolding. U Shouldtheequipmentfailtooperate,DONOTattempttorectifyorrepair,butcontactthe nearestservicecentreforadvice. VAlwaysrinseyourpumpoutafterusingseawater.
9 PREPARATION WaterSupply: A B Ensurethereisanadequatewatersupplyeitherfromthemainsorareservoir. Attachwatersupplyhosestosuitabletaporimmersethesuctionhosewithapprovedsuc tionfilterintothereservoir. NOTE:ONLYCLEANWATERSHOULDBEUSED.THEPUMPMAYBEDAMAGEDIFDIRTYOR CONTAMINATEDWATERISALLOWEDTOPASSTHROUGHTHEPUMP. Hoses:Lowpressureinlet. Formodelsupto13litresperminuteuse½ boresuctionhoseorfeedpipe. Formodelsfrom13litresto24litresperminuteuse¾ boresuctionhoseorfeedpipe. Hoses:Highpressureoutlet. Forallmodelsuse3/8 RITor3/8 R2Thoses. A Checktheconditionofthe O ringsintheendsofthehose. B Attatchthehighpressurehosetothepumpconnection. C Attatchthesprayguntooppositeendsofthehighpressurehose. OPERATION A Turnonthewatersupply. B Starttheengine C Directlanceontosurfacetobecleaned.Pressthelancetrigger.
10 D E F g. h. i. Adjustpressureregulatorasrequiredtoobtainworkingpressureifrequired. NOTE;:Thehighpressurewaterwillcausethegunto kick.makesureyouhaveafirmgrip ofgunandlance. Oncompletionofoperationstoptheengine. Operatelancetrigger Turn OFF watersupply Releaseresidualpressureingunandlancebyoperatingtrigger. WhenusingCleaningAgents: A. B. C. Setmachineupasforwater. Connectdetergenthosetomachineandplacefilterendintodetergent. Oncompletionofwork,flushthroughhoseandgunwithcleanwatertoremoveanyresid ualdetergent. NOTE:CHEMICALPICKUPONLYOPERATESATPRESSURESBELOW250PSI. OPENLANCEVALVEFULLYTOOBTAINTHISPRESSURE.
11
12
13
14
15 HurricaneGeneralArrangementPetrol/Diesel&ElectricStart HurricaneHandle DEM10228 LAB230/40 LAB200 Blackknob&boltreplacement LAB250 DEM LAB270 lab291 Rubber Mounts DEM10370 WheelWHEEL300 PressureGuage WheelCapWHEEL25 DEM20620 Sub base plate MET00193
16 DemonHurricaneRangeArrangementDrawing Petrol/DieselStartwithHoseReel HoseReelLockingPin PressureControlKnob Start/Stopswitch Oilfilter PumptoHoseReelHose HH0020 Fueltap Speedcontrollever
17
18
19 DemonHurricaneRangeArrangementDrawing ElectricStart FuelTap Speedcontrol&Stop OilFilter Guaze(cleanable) GearboxDipstick(EP90)AR PumpDipstick(10W40) AR VoltageRegulator Fuse
20 DemonHurricaneRangeArrangementDrawing ElectricStart RearView BULB DEM KeyStart YAN KeySwitchwithloom YAN2746 Keys Fuel tank cap YAN Batteries HurricaneD1BAT003 AllOTHERSBAT001 TANK YAN
21 Demon Hurricane Combi P2 & P4 Handle Inc Trigger DEM DEM Hose DEM Hose Castor Wheel WHEEL231 Wheel 230 Braked castor wheel WHEEL232 Technical Data P2 Combi P4 Combi Pressure 2200 PSI 2900 PSI Nozzle Size Water Flow (at full pressure) 13 litres/minute 15 litres/minute Engine Honda GX200 Honda GX340 Engine Power 6.5 HP 11 HP Starter Rope Rope Gearbox 2:1 Reduction 2:1 Reduction Weight 45 Kgs 78 Kgs
22 AttachingHurricaneCombi Handle Placehandleontobaseandalign holeswithbracket. Tightenboltandnylocnutusing 17mlspanner. Adjustheightbyinsertingboltinto oneofthethreeholesandtighten blackknob.
23 WARRANTY Thiswarrantycoversthecostofallreplacementpartsandlabourchargesincurred,butdoesnot coverthecostoftransportorcarriage.itistheownersresponsibilitytoreturnthemachinetoa servicedepotorpaythetravelingexpensesofaengineertoattend.demoninternational`sdeci sioninwarrantymattersisfinalandbinding. DemonInternationalLtd,undertaketorepairorreplace,attheirdiscretion,anycomponent whichmayfailduetoamanufacturingfaultwithinaperiodof12monthsfromthedateofpur chase,providedthatanyfaultordamagewasnotsustainedby; A B C D E Lackofregularandpropermaintenance,usernegligence,misuse,ordamagecausedby iceorfrost. Theeffectsofcontaminatedfuelorwater,theuseofnonapprovedchemicals,oranin sufficientorunsuitableelectricalsupply. Theeffectsofunauthorisedmodificationanduse. Compressiondamagetohighpressurehose.(Hosesarewarrantedforonemonthonly) Wornoutitemsconsideredwearandtear. Partswhichmayormaynotwearoutduringthefirstyearandwhichareconsideredservice itemswhichwillneedreplacingfromtimetotime:highpressurenozzle,lance,trigger,hoses, fuelnozzle,fuelfilter,pistonseals,valves,unloaderseatsandseals,waterfilter,nonreturn valve,chemicalbarbs,chemicalpipes,andpumpoilseals. Itistheownersresponsibilitytoensurethepressurewasheriskeptinasafeandsuitableenvi ronmentandanyfaultsreportedbyoperativestoberectifiedattheearliestpossibledate. Itistheoperatorsresponsibilitytocheckthepressurewasherforanyfaultsandreportthemim mediately,andtousethepressurewasherinaccordancewiththemanufacturersspecifications andguidelines. DemonInternationalLtd,undertaketousethehighestqualitycomponentsavailableduring manufacture,butcannotbeheldresponsibleforanyundueconsequencearisingfromtheuseof theirpressurewashers. Thiswarrantyisgiventheoriginalpurchaseronlyandisnottransferablewithoutthefullyauthor izedandwrittenconsentofdemoninternationalltd. The3yearStructuralWarrantyreferstoallDemonfabricatedstructuralparts,butthisdoes excludetheboilercoil.
24 EndUsers WarrantyProcedure Ifyourmachinedevelopsaproblem: 1. PhoneDemonforadvicewiththemodelandserialnumbertohand. 2. Describefullytheproblemasbestyoucan. 3. Iftheproblemcannotberesolvedoverthephonethenthemachinecanbebookedinfor repairandifthefaultsarecoveredbythewarrantytherepairwillbecarriedoutfreeofcharge. 4. Ifyoucannotbringthemachineinforrepairthenwewilldespatchanengineer.Ifthefaultis coveredbythewarrantythenwewillnotchargeforlabourorsparesused,howeverthetrans portchargewillbepayableweatherornottherepairiswarranty. HireCentresandDealers Ifyourmachinedevelopsaproblem: 1. PhoneDemonforadvicewiththemodelandserialnumbertohand. 2. Describefullytheproblem. 3. Wewilladviseyouonthebestcourseofaction,howeverifpartsarerequiredyoumustraise apurchaseordernumbertocovertheparts.whenthepartsarefittedtheymustbereturnedfor examinationbeforeacreditnoteisissued. 4. Ifyouareunabletorepairthemachinethenwewilldespatchanengineertocarryoutthe repair.wewillneedapurchaseordertocoverthecostoftransporttoandfromthesiteandfor partsandlabouriftherepairisnotcoveredunderthewarranty. 5. IfrequiredDemonwillarrangeforacarriertocollectadamagedmachine,ifthewarranty claimisvalidwewillpaythiscost,ifnotitwillbechargedtothecustomer. ForpartswarrantyringDemonandrequestawarrantyclaimformfaxedtoyou.Thisformmust accompanyanyreturnedparts. Notes: Youwillnotinvalidatethewarrantybyinvestigatingfaultsandrepairingthemyourselfproviding youfollowouradvice.hirecentresanddealersareexpectedtocarryoutallrepairsthemselves withdemoncreditingfaultypartsuponreceiptandinspection. Sparepartsfittedtomachinesareguaranteedfor1monthonlyortheremainderofthewarranty periodwhicheverislonger.
25
26 Part Number DEM10031B DEM10031R DEM10032B DEM10032R LanceandMachineColourCodes Description Storm Wall Mounted Cold Water Lance 045 Blue Cold Water Lance 05 Red Hot Water Lance 045 Blue Hot Water Lance 05 Red Storm 1 & 2, FS1 Hurricane Tempest Inc Cabinet Typhoon Tornado & Evolution Mini-Bowser WM1 P1 & P2 N/A N/A N/A P1 & P2 FS4 WM4 P4 & D1 N/A N/A N/A P4 & D1 N/A N/A N/A N/A N/A N/A Tempest 1, 3 & 4 (13.17 pump) Tempest 4 (15.20 Pump) N/A N/A N/A Typhoon 1, 2 & P4 Evo1 & Evo 2 N/A Company/marketing/lancechartissue306/10
27 Ican tgetthepressuretowhereitusedtobe wheredoistart? Well by now you should know to check the nozzle assuming that is correct and you still have no or low pressure the golden rule is to connect the pump to the mains water supply whichever machine you are testing start with a good mains feed. 1. With the gun and lance connected turn the tap on can you see a leak? If so there is your problem, if water can leak out air can get in and the pump won t produce pressure simple as that. (Leaks from underneath the pump are either worn seals or a cracked piston strip to find out which.) Remedy: Fix leak or replace seals or piston. 2. Check enough flow of water can get into the pump. Make sure all the filters are clean. The new Tempest hot water machines have a fine filter which will remove most solids. All Demon machines are now double filtered. Have you checked both of them? Remedy: Strip and inspect filters. 3. There are no leak s what next? With the pump switched off pull the trigger, water will spray out. Keeping the trigger pulled switch the pump on, if the water spray does not improve the valves are the fault. Either worn out or dirty. Strip and inspect. (The high pressure hose will also vibrate on the ground.) Remedy: Replace or clean valves. 4. The valves are OK there are no leaks but it still won t get up to pressure what next? The unloader valve pistonandseataredamagedorwornallowingsomeofthewatertocirculatearoundthecylinderhead strip and inspect, you will see any damage. Remedy: Strip unloader and inspect replace damaged parts. 5. My cold water pressure washer does not feel as powerful as it used to be but the pressure gauge shows the correct pressure. What causes this? The chemical pickup has a nozzle of 1.8mm or 2.0mm size and can get partially blocked. This will allow some but not all of the water to flow to the lance. Remedy: Strip and remove the blockage. 6. The pressure remains high even when I let go of the trigger and the engine or motor is struggling or stalling. The non return valve in the unloader is damaged or jammed. Remedy: Strip and clean or replace. DemonTechnicalSupport
28 COLDWATERLANCES Pos PartNo Description Qty 1 N26001/1504 NozzleP1 1 1 N26001/15045 NozzleP2 1 1 N26001/1505 NozzleP4&D1ES 1 2 MTM90040 AdjustableNozzle 1 3 DEM10031B QRLanceP2 1 3 DEM10031Y QRLanceP1 1 3 DEM10031R QRLanceP4&D1ES 1 4 DEM10030 QRTrigger 1 5 MTM70012 MVGCoupling 1 6 MTM70033 QuickReleaseCoupling 1 7 MTM70033A RubbersealforQRTrigger 1 8 Mtm70032 QRStem 1
29 High Pressure Hoses HoseInsert MV00490(items1&2) 2. Nut 3. HighPressureHose HH00030MVG 4. HoseJoiner MV00500 AlternativeHoseLengths 15Metre HH00050MVG 30Metre HH00100MVG
30
31 Hurricane Combi Rotating Head Position Part Number Description Quantity Grub screw Fitting M12 x 1 F O-ring Body Sst ball bearing O- ring Spacer ring O-ring Seal Ring Rotating pin O-ring Back-up ring Sst ring Seat Coupling 3/8-1/2 Bsp Nut 1/2F Bsp 1
32
33
34
35 HurricanePetrol XT11.14Pump/XT13.12Pump/XT13.15Pump XT1450 Pos CodeNo Description Qty Pos CodeNo Description Qty 1 AR Screw 6 40 AR PumpHead 1 2 AR Plug 1 41 AR ORing 1 7 AR Plug 6 42 AR Plug 1 8 AR ORing 6 43 AR Crankshaft 1 9 AR CompleteValve 6 43 AR Crankshaft 1 10 AR ORing 6 44 AR Key 1 11 AR SupportRing 3 45 AR Bearing 1 12 AR Gasket 3 46 AR Seal 1 13 AR PistonGuide 3 47 AR Screw 4 14 AR ORing 3 48 AR Base 2 15 AR Gasket 3 83 AR Circlip 1 16 AR Seal 3 85 AR Washer 6 19 AR Circlip 1 88 AR PumpHeadpreass 1 20 AR Bearing 1 89 AR Cap 1 21 AR Bushing 1 22 AR PumpHousing 1 23 AR OilPlug 1 24 AR Nut 3 25 AR Washer 3 26 AR Piston 3 27 AR ORing 3 28 AR Spacer 3 29 AR GuidingPiston 3 30 AR PistonPin 3 31 AR Screw 6 32 AR CompleteCover 1 32 AR CompleteCover 1 36 AR ConRoad 3 36 AR ConRoad 3 37 AR Gasket 1 38 AR ORing 2 39 AR Plug 2 ARKIT1864 ARKIT2629 ARKIT1872 ValveKit PistonKit OilSealKit Pos Qty Pos Qty Pos Qty ARKIT1874 WaterSeals
36
37
38 Gearbox for Hurricane P2 ARCRXT
39 GearboxforHurricaneP2ARCRXT
40 GearboxforHurricaneP4&D1ARCRXR
41 GearboxforHurricaneP4&D1ARCRXR
42 HurricaneDiesel RK15.20Pump/RK21.15Pump
43 RKMODEL:15.20H Pos PartNo Description Qty Pos PartNo Description Qty 1 AR ORing 6 36 AR Screw 6 2 AR Plug 6 40 AR mmshim AR Plug 6 40 AR mmshim AR CompleteValve 6 40 AR mmshim AR ORing 6 40 AR mmshim AR Plug 2 42 AR Oring 3 6 AR ORing 2 43 AR /8Gplug 2 11 AR SupportRing 3 44 AR Screw 4 12 AR Gasket 3 45 AR Base 2 13 AR PistonGuide 3 46 AR AR ORing 3 46 AR /8GPlug 1 3/ 8GPlug 1 15 AR Gasket 3 47 AR ORing 1 16 AR Seal 3 48 AR Plug 1 17 AR Screw 8 48 AR Plug 1 18 AR ClosedBearingsup 1 49 AR Pumphead 1 19 AR ORing 1 50 AR Screw 8 20 AR Bearing 1 60 AR Bearing 1 21 AR PumpHousing 1 61 AR Seal 1 22 AR OilCap 1 62 AR ORing 1 23 AR Nut 3 63 AR Shaftcover 1 24 AR Washer 3 66 AR HollowShaft28mm 1 25 ARKIT2757 CeramicPiston 3 66 AR HollowShaft028mm 1 26 AR Spacer 3 66 AR HollowShaft028mm 1 27 AR Oring 3 66 AR HollowShaft028mm 1 28 AR GuidingPiston 3 67 AR ElMotorflange 1 29 AR PistonPin 3 76 AR Screw 4 30 AR Aluminiumconrod 3 86 AR OilIndicator 1 31 AR Ring 3 87 AR SnapRing 1 32 AR Washer 8 88 AR Disc 1 34 AR ORing 1 89 AR ORing 1 35 AR Completecover 1 ValveKit PistonKit OilSealKit ARKIT1828 ARKIT2757 ARKIT1856 WaterSeal ARKIT1857 SupportRing ARKIT1829 Pos Qty Pos Qty Pos Qty Pos Qty Pos Qty
44
45 GYMATIC3/B Pos PartNo Description Qty Pos PartNo Description Qty1 1 AR KnobPlug 1 39 AR DetergentRegKnob 1 2 AR Screw 1 40 AR Bypasshousing 1 3 AR Nut 1 41 AR Washer 1 4 AR Handle 1 42 AR BanjoBolt1/2 G 1 5 AR Pin 1 42 AR BanjoBolt1/2 NPT 1 6 AR AdjustingScrew 1 43 AR Washer 1 7 AR SpringGuide 1 44 AR ORing 1 8 AR Plate 1 50 AR Fitting1/2 G 1 9 AR Spring 1 54 AR Fitting 1 10 AR SpringPlate 1 55 AR RingNut 1 11 AR Pin 1 56 AR Filter 1 12 AR UpperPiston 1 57 AR Ring 1 13 AR ORing 1 14 AR BackupRing 1 15 AR ORing 1 16 AR Jet 1 17 AR Spring 1 18 AR ORing 1 19 AR Banjobolt3/8 G 1 19 AR BanjoBolt3/8 NPT 1 20 AR Washer 1 21 AR ValveHousing 1 22 AR BackUpring 2 23 AR ORing 2 24 AR Washer 1 25 AR Lowerpiston 1 26 AR ORing 1 27 AR Bypassadaptor 1 28 AR ORing 1 29 AR Nut 1 30 AR Fitting3/8 G 1 30 AR Fitting3/8 G 1 30 AR Fitting3/8 G 1 31 AR Spring 1 32 AR Ball 1 33 AR ORing 1 34 AR HoseTail 1 35 AR Adaptor3/8 G 1 35 AR Adaptor3/8 G 1 36 AR HoseTail 1 37 AR ORing 1 38 AR ORing 1 ARKIT2611 Pos Qty Pos Qty Pos Qty
46 HurricaneRangeInletFittings Position PartNo Description Qty 1 DEM MeshSuctionFilter 2 MTM86010 ChemicalFilter 3 MTM73001 QRNippleFemale 4 MTM73020 QRNippleMale 5 HH0053 YellowHose 6 DEM20500 JubileeClip 7 DEM10042 Suctionfilterwith INC(1456) Hoseandfittings 8 DEM10115 DetergentPipe(ChemicalPipe)
47 COMMONPARTNUMBERS DEM WHEEL300 WHEEL25 DEM20620 DEM DEM DEM YAN76821 YAN76820 YAN77710 YAN77540 YAN YAN00013 MTM39001 DEM DEM20220 DEM20230 HurricaneBlackKnob&BoltReplacementKit Wheel WheelCap PressureGauge04000psi PushButtonSwitch RotarySwitch DomedLight RecoilStarter3hole RecoilStarter4hole Rectifier loom L100Injector Throttlecableass EasyStartValve 05TurboNozzle BurstDisc BurstDiscAssembly
TORNADO ELECTRON MINI BOWSER PRESSURE WASHER OPERATOR MANUAL
TORNADO ELECTRON MINI BOWSER PRESSURE WASHER OPERATOR MANUAL Clemas & Co. Unit 5 Ashchurch Business Centre, Alexandra Way, Tewkesbury, Gloucestershire, GL20 8NB. Tel: 01684 850777 Fax: 01684 850707 Email:
More informationTORNADO PRESSURE WASHER OPERATOR MANUAL
TORNADO PRESSURE WASHER OPERATOR MANUAL Clemas & Co. Unit 5 Ashchurch Business Centre, Alexandra Way, Tewkesbury, Gloucestershire, GL20 8NB. Tel: 01684 850777 Fax: 01684 850707 Email: info@clemas.co.uk
More informationDEMON TORNADO MINI BOWSER RANGE. Tornado P4 Mini Bowser. Tornado D70 Mini Bowser Tornado Electron Mini Bowser
DEMON TORNADO MINI BOWSER RANGE Tornado P1 Mini Bowser Tornado P2 Mini Bowser Tornado P4 Mini Bowser Tornado D70 Mini Bowser Tornado Electron Mini Bowser Including electric start variants and bowser washers
More informationDEMON TEMPEST RANGE Tempest 1 Tempest 2 Tempest 3 Tempest 4
DEMON TEMPEST RANGE Tempest 1 Tempest 2 Tempest 3 Tempest 4 A Declaration of Conformity (E.H.S.R.) We, Demon International Limited of Abbots Close, Lee Mill Industrial Estate, Ivybridge, Devon PL21 9GA
More informationIncluding electric start variants and bowser washers. Declara on of Conformity (E.H.S.R.)
DEMON TORNADO MINI BOWSER RANGE Tornado P1 Mini Bowser Tornado P2 Mini Bowser Tornado P4 Mini Bowser Tornado D1ES Mini Bowser Tornado Electron Mini Bowser Tornado Storm 1 Mini Bowser Including electric
More informationHOT WASHER MODEL NO: KING 125 OPERATION & MAINTENANCE INSTRUCTIONS PART NO: LS1009
HOT WASHER MODEL NO: KING 125 PART NO: 7320170 OPERATION & MAINTENANCE INSTRUCTIONS LS1009 INTRODUCTION Thank you for purchasing this Hot Washer. This machine is a portable, high pressure power washer,
More informationElectric Pressure Washer
FEATURES This lightweight, portable high-pressure washer makes the toughest clean-up tasks faster and easier. Weighing only 43 pounds, you can take it virtually anywhere. Ideal for light industrial applications
More informationHOT WATER PRESSURE WASHER BREAKDOWN
HOUR METER TACH / HOUR ON OFF THERMOSTAT BURNER OFF 29 9 20 28 25 4 23 24 3 2 34 33 0 5 8 9 7 6 6 ITEM PART NUMBER DESCRIPTION QTY. 85.600.220 Frame 2 N/A Engine, 3 HP, 389cc (GX390 2QNR) 2 85.578.50 Engine,
More informationTable of Contents WARRANTY
H.E.R.O. Industries a division of Middlefield Bancorp Limited 2719 Lake City Way, Burnaby, B.C., Canada Phone: ( 604 ) 420-6543 Fax: ( 604 ) 420-8725 Toll Free: 1-800-494-4376 E-mail: sales@hero.ca Website:
More informationO:\Machine Manuals & Spare Parts Lists\K4400G PL Page 1
PUMP SET - Cylinder Head 2.1 0 3532-8320A Complete Replacement Pump 1 1 4769-0340 Nozzle Insert only for replacement 1 2 6362-3840 O-Ring Seal 9.0x1.5 2 3 5115-7210 Washer 3 4 5115-7200 Washer 3 5 5110-7070
More informationSAFETY AND OPERATING MANUAL
SAFETY AND OPERATING MANUAL COLD WATER PETROL WATER BLASTERS Read Safety & Operating Instructions Before Commencing Operation THESE INSTRUCTIONS MUST BE READ AND ADHERED TO BEFORE OPERATING THIS MACHINE.
More informationPARTS LIST FOR WP-3200-HDHB
PARTS LIST FOR WP-3200-HDHB ENGINE OIL GRADE: HONDA/ SUBARU: SAE10W-30 ENGINE OIL CAPACITY: 20 oz. PUMP OIL GRADE: Mi-T-M Pump Oil AW-4085-0016 PUMP OIL CAPACITY: 16 oz. NOZZLE SIZE: 3.0 1 This Parts Listing
More informationService Handbook HD /97
Service Handbook HD 1050 5.905-032 07/97 Foreword HD 1050 Foreword Indispensable prerequisites for the competent execution of service procedures are comprehensive, real-life training workshops for technical
More informationTable of Contents WARRANTY
a division of Middlefield Bancorp Limited 2719 Lake City Way, Burnaby, B.C., Canada Phone: ( 604 ) 420-6543 Fax: ( 604 ) 420-8725 Toll Free: 1-800-494-4376 E-mail: sales@hero.ca Website: //www.hero.ca
More informationHOT WATER PRESSURE WASHER
FRAME ASSEMBLY HW353HAD 8 5 6 7 9 20 2 22 23 24 25 2 M:\Drawings\PRIVATE LABEL\BE PRESSURE SUPPLY\HSP LARGE\HSP-3500 ASSEMBLY.iam 5 4 3 2 29 28 0 9 8 7 6 ITEM DESCRIPTION Part # QTY Hose Reel Mounting
More informationService Handbook. High-Pressure Washer Pump
Pump 629 9/28/01 3:22 PM Page 1 Service Handbook High-Pressure Washer Pump 3.532-629.0 10.00 Pump 629 9/28/01 3:22 PM Page 2 Pump 629 9/28/01 3:22 PM Page 3 TROUBLESHOOTING OVERVIEW How to Use This Manual
More informationPARTS LIST FOR CM MEH. Copyright 2015, Mi-T-M Corporation
PARTS LIST FOR CM-1400-1MEH Motor Horsepower: Pump Oil Grade: Pump Oil Capacity: Nozzle Size: 1.5 H.P. Mi-T-M Pump Oil #AW-4085-0016 11.2 oz..95 mm 1 This Parts Listing has been compiled for your benefit.
More informationCW-2004-SME3: PARTS LIST FOR (AFTER SERIAL # ) Motor Horsepower: Pump Oil Capacity: Nozzle Size: CW-2004-SME3: 5.5
PARTS LIST FOR CW-2004-SME3 (AFTER SERIAL #10375000) Motor Horsepower: CW-2004-SME3: 6.0 H.P. Pump Oil Grade: Mi-T-M Pump Oil #AW-4085-0016 Pump Oil Capacity: 41 oz. Nozzle Size: CW-2004-SME3: 5.5 This
More informationPARTS LIST FOR WP MHB WP MKB WP MSB (AFTER SERIAL # )
PARTS LIST FOR WP-3200-0MHB WP-3200-0MKB WP-3200-0MSB (AFTER SERIAL #10854374) ENGINE OIL GRADE: SAE10W-30 ENGINE OIL CAPACITY: 20 oz. PUMP OIL GRADE: Mi-T-M Pump Oil AW-4085-0016 PUMP OIL CAPACITY: 16.9
More informationWA 2719 ( 604 ) ( 604 ) , H.E.R.O.
a division of Middlefield Bancorp Limited 2719 Lake City Way, Burnaby, B.C., Canada Phone: ( 604 ) 420-6543 Fax: ( 604 ) 420-8725 Toll Free: 1-800-494-4376 E-mail: sales@hero.ca Website: www.hero.ca U.S.
More informationBuy Karcher Parts Online: Need Technical Help? Call: Requests to:
Page 1 of 12 Karcher Model:HD 3000 MTD ( 59588400 ) - Parts Section:1.0 PIECE PARTS 1 91825140 1 BOLT 2 91823530 2 CONTROL KNOB 3 91963010 2 SCREW 5 91834050 2 RUBBER BUFFER 6 91963080 2 BOLT 7 91825060
More informationSERVICE PARTS LIST SPECIFY CATALOG NO. AND SERIAL NO. WHEN ORDERING PARTS 13 HP DIRECT DRIVE PRESSURE WASHER CATALOG NO
SPECIFY CATALOG NO. AND SERIAL NO. WHEN ORDERING PARTS HP DIRECT DRIVE PRESSURE WASHER CATALOG NO. 555-22 SERVICE PARTS LIST STARTING SERIAL NUMBER B06A REVISED BULLETIN PAGE OF BULLETIN NO. 5-20-000 DATE
More informationPARTS LIST FOR GC-1002/1502-0ME1 (GRAINGER ITEM #3WB86 AND #3WB87) COLD WATER PRESSURE WASHER (AFTER SERIAL # )
PARTS LIST FOR GC-1002/1502-0ME1 (GRAINGER ITEM #3WB86 AND #3WB87) COLD WATER PRESSURE WASHER (AFTER SERIAL #10817968) MANUFACTURED FOR W.W. GRAINGER INC. FOR REPLACEMENT PARTS CALL GRAINGER PARTS 800-323-0620
More informationAussie Eco-Clean OPERATION & MAINTENANCE MANUAL
Aussie Eco-Clean Monsoon Series High Pressure Blaster (Three Phase Models) OPERATION & MAINTENANCE MANUAL Covers: Monsoon 200 Monsoon 300 Monsoon 300 Maxi Monsoon 400 Monsoon 400 Maxi Hurricane Feb 2010
More informationBuy Karcher Parts Online: Need Technical Help? Call: Requests to:
Page 1 of 11 Karcher Model:HD 2500 MTD ( 59588500 ) - Parts Section:1.0 PIECE PARTS 1 91825140 1 BOLT 2 91823540 2 CONTROL KNOB 3 91963040 2 SAUCER-HEAD SCREW 5 91834050 2 RUBBER BUFFER 6 91963080 2 BOLT
More informationPARTS LIST FOR CM MEH (AFTER SERIAL # ) Copyright 2007, Mi-T-M Corporation
PARTS LIST FOR CM-1400-0MEH (AFTER SERIAL #10568358) Motor Horsepower: Pump Oil Grade: Pump Oil Capacity: Nozzle Size: 1.5 H.P. Mi-T-M Pump Oil #AW-4085-0016 11.2 oz..95 mm 1 This Parts Listing has been
More informationPARTS LIST FOR 4004 SERIES PORTABLE/ALUMINUM GASOLINE DRIVEN/BELT DRIVE COLD WATER PRESSURE WASHER
PARTS LIST FOR 4004 SERIES PORTABLE/ALUMINUM GASOLINE DRIVEN/BELT DRIVE COLD WATER PRESSURE WASHER Engine Oil Grade: SAE 10W-30 Engine Oil Capacity: Honda 37 oz. Pump Oil Grade: Pump Oil #AW-4085-0016
More informationDP556 Pump. 55:1, Air-operated, Grease. General. Operation. Technical Data. Installation. Mounting with Reinforced Cover (Recommended)
DP556 Pump 55:1, Air-operated, Grease General The DP556 Pump is a compressed air-operated reciprocating piston pump. This high capacity demand pump is compatible with mineral and synthetic grease and suitable
More informationHWB Series GENERAL PUMP. Hydraulic Drive Triplex Plunger Pump INDUSTRIAL INDUSTRIAL FEATURES
GENERAL PUMP HWB Series Hydraulic Drive Triplex Plunger Pump FEATURES INDUSTRIAL INDUSTRIAL Innovative drive design eliminates need for auxiliary hydraulic drive Forged brass manifold Built-in Pump Thermal
More informationSERVICE MANUAL MODEL # ORDER # RG
SERVICE MANUAL MODEL # ORDER # RG-232637 1.107-235.0 9.801-589.0 CONTENTS Exploded View... 4 Exploded View Parts List... 5 Legacy Axial Pump...6-7 Troubleshooting... 8 Preventive Manteinance... 9 Oil
More informationPARTS LIST FOR WP MHB/RB. (Serial break# )
PARTS LIST FOR WP-3000-4MHB/RB (Serial break# 10380918) Engine Oil Grade: HONDA/ SUBARU: SAE10W-30 engine Oil Capacity: 20 oz. Pump Oil Grade: Mi-T-M Pump Oil AW-4085-0016 Pump Oil Capacity: 16 oz. nozzle
More informationPARTS LIST FOR CA MHB (AFTER SERIAL # ) Engine Oil Grade: SAE 10W-30 Engine Oil Capacity: 37 oz.
PARTS LIST FOR CA-3504-0MHB (AFTER SERIAL #10168073) Engine Oil Grade: SAE 10W-30 Engine Oil Capacity: 37 oz. Pump Oil Grade: Mi-T-M Pump Oil #AW-4085-0016 Pump Oil Capacity: 18.5 oz. Nozzle Size: 3.5
More informationSERVICE MANUAL MODEL # ORDER # XPERT-HD 3.8/35 P PD DA DD
SERVICE MANUAL MODEL # ORDER # XPERT-HD 3.8/35 P 1.107-108.0 PD4-35324 1.107-096.0 DA-383539 1.107-102.0 DD-383537 1.107-137.0 8.780-001.0 CONTENTS Exploded View... 4 Exploded View Parts List... 5 S.2
More informationDrawing A Crankcase 041 AV SCS
Drawing A Crankcase 1 Drawing A Crankcase Reference Item number Qty Description 1 1110 020 2105 1 Crankcase 2-5, 9, 10, 12 2 9371 470 3120 2 Cylindrical pin 6x20 3 9048 216 1010 8 Pan head screw M5x18
More informationXMV 3400 RPM D VERSION 1 WITH GAS ENGINE FLANGE DIMENSIONS
Plunger Pumps FEATURING MANIFOLD: High strength forged brass for long term use. XMV 3400 RPM D VERSION 1 WITH GAS ENGINE FLANGE DIMENSIONS BOLTS: Eight 6mm grade 12.9. PLUNGERS: A special thick solid ceramic
More informationTable of contents Copyright ANDREAS STIHL AG & Co. KG 2017 (3)
03-2016 USA Table of contents FS 94, FS 94 C, FS 94 R, FS 94 RC 4 Crankcase, Cylinder 6 Rewind starter 8 Rewind starter ErgoStart/Easy2Start 10 Muffler, Shroud, Ignition system 12 Fuel tank 14 Air filter,
More informationBuy Karcher Parts Online: Need Technical Help? Call: Requests to:
Page 1 of 14 Karcher Model:HD 2700 DH Q/C ( 59588430 ) - Parts Section:1.0 PIECE PARTS 2 91823530 2 CONTROL KNOB 3 91963070 2 SAUCER-HEAD SCREW 5 91834050 2 RUBBER BUFFER 6 91963080 2 BOLT 7 91825060 2
More informationSYMPTOM POSSIBLE CAUSES CORRECTIVE ACTION
Troubleshooting SYMPTOM POSSIBLE CAUSES CORRECTIVE ACTION WILL NOT RUN RUNS BUT WON'T SPRAY LOW SPRAY AT NOZZLE UNEVEN SPRAY PATTERN WILL NOT PRODUCE HOT WATER Pump switch in OFF position Place switch
More informationD3000. Troubleshooting Guide
Page 1 of 6 17486-00 Rev B s3 April 2009 Contents Description Page Safety.. 3 Introduction 3 Standard External Controls, Indicators and Normal Alarm Conditions 3 Troubleshooting Table.. 4 Unable to program
More informationPARTS LIST FOR CM-3000-ODLB CM-3000-ODLB-C (AFTER SERIAL # )
PARTS LIST FOR CM-3000-ODLB CM-3000-ODLB-C (AFTER SERIAL #10817968) Displacement: 212 cc Pump Oil Grade: Mi-T-M Pump Oil AW-4085-0016 Pump Oil Capacity: 16 oz. Nozzle Size: # 3.0 1 This Parts Listing has
More informationOPERATING INSTRUCTIONS MODE D EMPLOI GEBRAUCHSANLEITUNG INSTRUCCIONES PARA EL USO CENTER 200
OPERATING INSTRUCTIONS MODE D EMPLOI GEBRAUCHSANLEITUNG INSTRUCCIONES PARA EL USO CENTER 200 PULICAR - di D Annibale e C. S.n.c. 41058 - VIGNOLA (MO) - Via Puccini, 165 - Tel. 059.775061 - Fax 059.764045
More informationCV MMC CV MMC CV MHC CV MHC
The Chore Master PARTS LIST FOR CV-2600-3MMC CV-2600-4MMC CV-2600-4MHC CV-3000-4MHC Engine Oil Grade: SAE10W-30 Engine Oil Capacity: See Model Specifications Nozzle Size: CV-2600 2.7 CV-3000 2.5 1 This
More information8650 Enterprise Drive, Peosta IA / Fax
8650 Enterprise Drive, Peosta IA 52068 563-556-7484 / Fax 563-556-1235 PARTS LIST FOR HSE-1002-0M10 (AFTER SERIAL #15004675) HSE-1502-0M10 (AFTER SERIAL #15006316) HSE-2003-0M10 (AFTER SERIAL #15006268)
More informationTHE JOB PRO PARTS LIST FOR JP-1002/1502-0ME1. Motor Horsepower: Nozzle Size: Copyright 2003, Mi-T-M Corporation
THE JOB PRO PARTS LIST FOR JP-1002/1502-0ME1 Motor Horsepower: jp-1002-0me1: jp-1502-0me1: Pump Oil Grade: Pump Oil Capacity: Nozzle Size: jp-1002-0me1: jp-1502-0me1: 1.5 H.P. 2.0 H.P. Mi-T-M Pump Oil
More informationGT RAPIDFLO ROTARY FUEL PUMP
GT RAPIDFLO ROTARY FUEL PUMP INSTRUCTION MANUAL Introduction Thank you for purchasing a Macnaught Model GT RAPIDFLO Rotary Hand Fuel Pump. Please read and retain this instruction sheet to assist you in
More informationSERVICE MANUAL
SERVICE MANUAL MODEL # ORDER # HD 3.0/27 G 1.107-270.0 HD3.0/27 GB 1.107-271.0 HD 3.4/35 G 1.107-272.0 HD 3.3/35 GB HD 4.0/40 G HD 4.0/40 GB HD 4.0/40 Ge HD 4.0/40 GeB 1.107-273.0 1.107-274.0 1.107-275.0
More informationDS 3000 T (EPA 3) Brushcutter. Documents. DS 3000 T (EPA 3) Brushcutter. Engine. Starter assy and clutch. Tank and air filter.
Documents Engine Starter assy and clutch Tank and air filter Transmission Carburetor WT-1150 Accessories Illustrated parts list (Head "Load&Go" D.130) 4/26/2016 Page 1-16 Illustration Engine 4/26/2016
More informationGENERAL PUMPA member of the Interpump Group
FEATURES Innovative drive design eliminates need for auxiliary hydraulic drive HWB Series Hydraulic Drive - Triplex Plunger Pump HWB2512 & HWB2112 Forged brass manifold No scheduled maintenance required
More informationPETROL POWER WASHER MODEL NO: PLS195, PLS265 OPERATION & MAINTENANCE INSTRUCTIONS PART NO: , LS0616
PETROL POWER WASHER MODEL NO: PLS195, PLS265 PART NO: 7330360, 7330365 OPERATION & MAINTENANCE INSTRUCTIONS LS0616 INTRODUCTION Thank you for purchasing this CLARKE Petrol Power Washer. Before attempting
More informationHD 3.1 / 31 P (03/15)
HD 3.1 / 31 P 9.801-616.0 (03/15) High Pressure Washer Operator Manual Overview... 3 Precautions... 4 Assembly Instructions... 5 Operating Instructions... 6 Using the Accessories... 7 Working with Detergents...
More informationIllustration Engine. PTX 2710 (EPA 3) Pole pruner. 3/27/2017 Page Copyright COMET USA, INC.
Documents Engine Starter assy and clutch Tank and air filter Adjustable telescopic pole Pruner Carburetor WT-1150 Accessories 3/27/2017 Page 1-16 Illustration Engine 3/27/2017 Page 2-16 Illustration Engine
More informationK950 RING. model_enhet_yyyy-mm
A K950 RING 2 3 5 7 1 4 6 8 model_enhet_yyyy-mm Page A K950 Ring Pos. Part No. Description Quantity Notes New Part 1 506 28 09-02 BELT GUARD 1 Incl. 2, 3 2 544 87 25-01 LABEL 1 3 503 20 34-19 SCREW 4 4
More informationDrawing A Crankcase, Cylinder
Drawing A Crankcase, Cylinder 1 Drawing A Crankcase, Cylinder Reference Item number Qty Description 1 4140 021 0300 1 Crankcase 2 9639 003 1230 2 Oil seal12x22x7 3 9503 003 0242 2 Grooved ball bearing
More informationCut off saw - Starter assy and engine
Cut off saw - Starter assy and engine Copyright Comet USA, Inc. 1/9/2015 1-13 Cut off saw - Starter assy and engine Ref.Nu Qty Part number Description Validity from Validity till Notes Bulletin 1 4 097000092AR
More informationHLP M10 HLP M10 (AFTER SERIAL # )
HLP-1502-0M10 HLP-0703-0M10 (AFTER SERIAL #15023661) PUMP OIL GRADE: SAE30W Non-Detergent PUMP OIL CAPACITY: 11 oz. BTU INPUT: 200, 000 (Vapor Only) PRESSURE NOZZLE: HLP-0703-0M10: 5.5 HLP-1502-0M10: 3.0
More informationPARTS LIST FOR GC MAH and GC MGH (GRAINGER ITEM #6CGP0 AND #6CGP1) COLD WATER PRESSURE WASHER (AFTER SERIAL # )
PARTS LIST FOR GC-5004-3MAH and GC-6004-3MGH (GRAINGER ITEM #6CGP0 AND #6CGP1) COLD WATER PRESSURE WASHER (AFTER SERIAL #10738662) MANUFACTURED FOR W.W. GRAINGER INC. FOR REPLACEMENT PARTS CALL GRAINGER
More informationSJV 3400 RPM D VERSION 3/4 WITH GAS ENGINE FLANGE DIMENSIONS
Plunger Pumps FEATURING SJV 3400 RPM D VERSION 3/4 WITH GAS ENGINE FLANGE DIMENSIONS MANIFOLD: High strength forged brass for long term use. BOLTS: Three 8mm grade 8.8. PISTONS: Ceramic coated stainless
More informationPARTS LIST FOR CBA MHB (AFTER SERIAL # ) CBA MVB
PARTS LIST FOR CBA-3504-0MHB (AFTER SERIAL #10202373) CBA-3504-0MVB Engine Oil Grade: Honda: Vanguard: Engine Oil Capacity: Honda: Vanguard: SAE10W-30 Above 40 F = SAE30 Below 40 F = SAE10W-30 37 oz. 51
More information8650 Enterprise Drive, Peosta IA / Fax PARTS LIST FOR JP ME1/0ME3
8650 Enterprise Drive, Peosta IA 52068 563-556-7484 / Fax 563-556-1235 PARTS LIST FOR JP-3004-0ME1/0ME3 Motor Horsepower: 8 H.P. Pump Oil Grade: Mi-T-M Pump Oil #AW-4085-0016 Pump Oil Capacity: 18.5 oz.
More information8650 Enterprise Drive, Peosta IA / Fax PARTS LIST FOR JP ME1/0ME3
8650 Enterprise Drive, Peosta IA 52068 563-556-7484 / Fax 563-556-1235 PARTS LIST FOR JP-2503-0ME1/0ME3 Motor Horsepower: 6 H.P. Pump Oil Grade: Mi-T-M Pump Oil #AW-4085-0016 Pump Oil Capacity: 18.5 oz.
More informationPARTS LIST FOR WP MHB/RB
PARTS LIST FOR WP-4000-4MHB/RB Engine Oil Grade: HONDA/ SUBARU: SAE10W-30 Engine Oil Capacity: 20 oz. Pump Oil Grade: Mi-T-M Pump Oil AW-4085-0016 Pump Oil Capacity: 16 oz. nozzle Size: 3.0 This Parts
More informationHSE M11 (AFTER SERIAL # )
8650 Enterprise Drive, Peosta IA 52068 563-556-7484 / Fax 563-556-1235 PARTS LIST FOR HSE-1002-0M11 (AFTER SERIAL #14999999) C US 201473 PUMP OIL GRADE: Mi-T-M #AW-4085-0016 CAPACITY: 11.2 oz FUEL NOZZLE:
More informationPlunger Pumps. RSV Series Pumps NORTH AMERICA. Description. Operating Instructions and Parts Manual
Please read and save these instructions. Read carefully before attempting to assemble, install, operate or maintain the product described. Protect yourself and others by observing all safety information.
More informationSERVICE MANUAL MODEL # ORDER
SERVICE MANUAL MODEL # ORDER # BD-405039E.07-023.0 BD-455039E.07-024.0 BD-343089E.07-083.0 BD-373539.07-02.0 BD-404029.07-022.0 MP-455034E.07-002.0 MP-343084E.07-082.0 MP-373534.07-00.0 HD 4.0/50 Pb CAGE.575-200.0
More informationBOOM / HANDGUN SPRAYERS
BOOM / HANDGUN SPRAYERS OPERATION, SERVICE & PARTS MANUAL FOR MODELS: GDL200, GDL400, GDL600 & GDL800 April 2011 FORM: GDLsprayer.QXD TABLE OF CONTENTS Introduction...................................................1
More informationAIR BLAST SPRAYERS OPERATION, SERVICE & PARTS MANUAL FOR MODELS: APL200, APL400 & APL600
AIR BLAST SPRAYERS OPERATION, SERVICE & PARTS MANUAL FOR MODELS: APL200, APL400 & APL600 April 2011 FORM: APLsprayer.QXD TABLE OF CONTENTS Introduction...................................................1
More informationSERVICE MANUAL MODEL # ORDER # HD 3.0/27 G HD3.0/27 GB HD 3.5/35 G HD 3.5/35 GB HD 4.
SERVICE MANUAL MODEL # ORDER # HD 3.0/27 G 1.107-270.0 HD3.0/27 GB 1.107-271.0 HD 3.5/35 G 1.107-272.0 HD 3.5/35 GB 1.107-273.0 HD 4.0/40 G 1.107-274.0 HD 4.0/40 GB 1.107-275.0 HD 4.0/40 Ge 1.107-276.0
More informationPARTS LIST FOR HDB H6G HDB K7G
PARTS LIST FOR HDB-3004-0H6G HDB-3004-0K7G ENGINE OIL GRADE: HONDA: KOHLER: SAE10W-30 SAE20W-40 FUEL NOZZLE: BTU INPUT: 343,000 2.25 80 B Delavan PUMP OIL GRADE: PUMP OIL CAPACITY: SAE 20 or 30 Non-Detergent
More informationAQUA 300, 400, 600. Model: AQUA 300 AQUA 400 AQUA 600. Part List US-English
Model: AQUA 300 AQUA 400 AQUA 600 Part List US-English Table of Contents Chassis 300 3 Chassis 400, 600 5 Motor 300 7 Motor 400, 600 9 Unloader valve 300 11 Unloader valve 400, 600 13 Electric parts 300
More informationCOMPRESSORS 09/97 CB-5C-050. Suggested Spare Parts for LB601 and LB601A Compressors: Qty./ Unit
09/97 CB-5C-050 Suggested Spare Parts for LB601 and LB601A Compressors: Part # Description Qty./ Unit Comm. Qty. 794099 Gasket Set - Buna-N, Aluminum T 1 1 1 794259 Suction Valve Sub-Assembly T 2 2 794279
More informationSERVICE MANUAL MODEL # ORDER # MODEL # ORDER # HD 2.3/24 P HD 2.5/27 P HD 3.0/30 P HD 3.8/35 P HD 3.
SERVICE MANUAL CHAUD! READ OWNER'S MANUAL BEFORE OPERATION. LIRE LE MANUEL D'UTILISATEUR AVANT USAGE. VOR INBETRIEBNAHME UNBEDINGT BEDIENUNGSANLEITUNG DURSCHLESEN. NO UTILIZAR SIN ANTES NO HABER LEIDO
More informationATV 50 Y-6 YOUTH CAT GREEN (A2004ATA2BUSZ) Page 1 of 50 A-ARM, FLOOR PANEL, AND BUMPER ASSEMBLY
2004 ATV 50 Y-6 YOUTH CAT GREEN (A2004ATA2BUSZ) Page 1 of 50 A-ARM, FLOOR PANEL, AND BUMPER ASSEMBLY 2004 ATV 50 Y-6 YOUTH CAT GREEN (A2004ATA2BUSZ) Page 2 of 50 A-ARM, FLOOR PANEL, AND BUMPER ASSEMBLY
More informationPrinted from MediaCat
Illustration A Crankcase Illustration A Crankcase Ref.Nr. Item code Quantity Description 1 1106 020 2506 1 Crankcase (2) 2-11 2 0000 988 5217 1 Connector (2) 3 0000 988 5200 2 Connector (2) 4 1106 641
More informationI Illustrated Parts List. Trimmer 125 L. Illustrated Parts List
Illustrated Parts List 2008-02 I0801022 Trimmer 125 L Illustrated Parts List PATS LIST eplaces 2/01/08-9/28/07 NOTE : Illustration may differ from actual model due to design changes. Page: 1 1 2 3 10 WANING
More informationSERVICE MANUAL
SERVICE MANUAL MODEL # ORDER # HD 3.0/27 G 1.107-270.0 HD3.0/27 GB 1.107-271.0 HD 3.4/35 G 1.107-272.0 HD 3.3/35 GB HD 4.0/40 G HD 4.0/40 GB HD 4.0/40 Ge HD 4.0/40 GeB 1.107-273.0 1.107-274.0 1.107-275.0
More informationPARTS LIST FOR HDS SERIES (AFTER SERIAL # and # )
PARTS LIST FOR HDS SERIES (AFTER SERIAL #15028656 and #15045000) ENGINE OIL GRADE: KOLHER / KUBOTA: SAE10W30, API CI-4 OR BETTER HONDA: ABOVE 50 F = SAE30 VANGUARD: ABOVE 40 F = SAE30 BELOW 40 F = SAE10W-30
More informationPARTS LIST FOR CA E2G CA E2G-W. Pump Oil Capacity: Nozzle Size: 4.0
PARTS LIST FOR CA-2503-0E2G CA-2503-0E2G-W Motor Horsepower: 6.0 H.P. Pump Oil Grade: Pump Oil #AW-4085-0016 Pump Oil Capacity: 14 oz. Nozzle Size: 4.0 1 This Parts Listing has been compiled for your benefit.
More informationLB601B PARTS LIST COMPRESSORS CB-5E /06. Bulletins Needed For Complete Parts List. Gasket Set, Repair Kits and Special Tools
COMPRESSORS CB-5E-051 2011/06 LB601B PARTS LIST Serial # ID# Gasket Set, Repair Kits and Special Tools Gasket Set Buna-N & Aluminum 794099 Top End Repair Kit 794237 Includes Piston Rings & Expanders, Packing
More informationGERNI POSEIDON 5-31, 5-54XT
Model: GERNI POSEIDON GERNI POSEIDON 5-54XT Part List US-English Table of Contents Cabinet 3 Frame 5 Motor 7 Pump, kits 9 Cylinder head 11 Pump, oiltank 13 Control safety block (a) 15 Control safety block
More informationAppendix D Outline Dimensions
Appendix D Outline Dimensions Models 91 691 and F91 F691 Bare with Flywheel L L1 M M1 M M1 L L1 Outline Dimensions Inches (Centimeters) Model A B C D E F G H J K 91, F91 1-13/16 2-3/8 3-11/16 13/32 5/8
More informationSTALLION SOFT WASH SYSTEM Operations Manual
STALLION SOFT WASH SYSTEM Operations Manual INTRODUCTION Congratulations on your choice of a Delux Stallion Soft Wash System. We are certain you will be pleased with your purchase. This manual was created
More informationCM-2800-OMVC & CM-2804/3304-OMHC PARTS LIST
8650 Enterprise Drive, Peosta IA 52068 319-556-7484 / Fax 319-556-1235 CM-2800-OMVC & CM-2804/3304-OMHC PARTS LIST Vanguard Engine Oil Grade: Vanguard Engine Oil Capacity: Honda Engine Oil Grade: Honda
More informationGTE SERIES SPRAYERS. FORM: GTE200Book.QXD
GTE SERIES SPRAYERS Operation, Service & Parts Manual For GTE200 FORM: GTE200Book.QXD November 2000 TABLE OF CONTENTS Introduction................................................... Sprayer Operation &
More informationInstruction Manual. Maple 7/15 Pump. Model
Maple 7/15 Pump Model 10 40 41 Page 2 of 16 Specification Pump Ratio 15:1 Max. Air Pressure Inlet Max. Fluid Pressure Nominal Flow Volume / Cycle 7 Bar 105 Bar 0.166 Litres 0.044 US Gall Fluid Output @
More informationAiro Pro 1.5 Gallon Sprayer Airo Pro 1 Gallon Sprayer Airo Pro.5 Gallon Sprayer Airo Pro Sprayer Manual
Airo Pro 1.5 Gallon Sprayer 501-502-180 Airo Pro 1 Gallon Sprayer 501-504-210 Airo Pro.5 Gallon Sprayer 501-505-180 Airo Pro Sprayer Manual Safety Notices Safety Instruction Keep out reach of children
More informationLB361B PARTS LIST COMPRESSORS CB-5E /06. Bulletins Needed For Complete Parts List. Gasket Set, Repair Kits and Special Tools
COMPRESSORS CB-5E-031 2011/06 LB361B PARTS LIST Serial # ID# Gasket Set, Repair Kits and Special Tools Gasket Set Buna-N & Aluminum 793099 Top End Repair Kit 793229 Includes Piston Rings & Expanders, Packing
More informationOPERATOR INSTRUCTION MANUAL COMMANDO 4000
HUGH CRANE Cleaning Equipment Limited FS0962 SOUTH WALSHAM ROAD, ACLE, NORWICH, NORFOLK, NR13 3ES TEL: 01493 750072 - FAX: 01493 751854 - www.hughcrane.co.uk OPERATOR INSTRUCTION MANUAL COMMANDO 4000 For
More informationChainsaw Emak S.p.A.
Chainsaw - Engine Meccanografico RE 005145 C/C Postale 11178423 Partita IVA 00130010358 Codice Fiscale 00130010358 1 / 12 Meccanografico RE 005145 C/C Postale 11178423 Partita IVA 00130010358 Codice Fiscale
More informationEXPLODED VIEW BASE AND PULLEYS Drawing No
Generac NP-50LPG EXPLODED VIEW BASE AND PULLEYS Drawing No. 95865 20 Generac NP-50LPG REPAIR PARTS BASE AND PULLEYS Drawing No. 95865 ITEM DESCRIPTION PART NO. QTY. ITEM DESCRIPTION PART NO. QTY. 1 BASE,
More informationVB 10 - Unloader Valve (discharging)
Last update: 20/04/18 VB 10 - Unloader Valve (discharging) Technical manual: E 212 Pressure regulating unloader valve with discharge control pressure with very low readings. At gun-lance closure, the water
More informationINSTRUCTIONS FOR THE INSTALLATION AND USE OF THE PUMPS HWB
Menu INSTRUCTIONS FOR THE INSTALLATION AND USE OF THE PUMPS HWB 8040--100-110-150-200-250-300 300-400 1 Dear Customer, We would like to thank you for the trust you granted us and are sure that you made
More informationHUGH CRANE. SOUTH WALSHAM ROAD, ACLE, NORWICH, NORFOLK, NR13 3ES TEL: FAX:
HUGH CRANE Cleaning Equipment Limited SOUTH WALSHAM ROAD, ACLE, NORWICH, NORFOLK, NR13 3ES TEL: 01493 750072 - FAX: 01493 751854 - www.hughcrane.co.uk FS0962 OPERATOR INSTRUCTION MANUAL COMMANDO 500P For
More informationHDC SERIES (AFTER SERIAL # )
PARTS LIST FOR HDC SERIES (AFTER SERIAL #15019140) ENGINE OIL GRADE: HONDA: KOLHER: VANGUARD: PUMP OIL GRADE: PUMP OIL CAPACITY: FUEL NOZZLE: HDC-3005/3505: HDC-4004: Above 50 F = SAE30 SAE10W-30 Above
More informationTB90BC 41ADT90C711 Page 1 of 6 Boom & Trimmer
TB90BC 41ADT90C711 Page 1 of 6 Boom & Trimmer TB90BC 41ADT90C711 Page 2 of 6 Boom & Trimmer 1 791-00040 1 Throttle Housing Assembly (includes 2-4) 2 791-00041 1 Throttle Trigger Lock-Out 3 791-00042 1
More informationSERVICE MANUAL
SERVICE MANUAL MODEL # ORDER # HD 3.0/27 G 1.107-270.0 HD3.0/27 GB 1.107-271.0 HD 3.4/35 G 1.107-272.0 HD 3.3/35 GB HD 4.0/40 G HD 4.0/40 GB HD 4.0/40 Ge HD 4.0/40 GeB 1.107-273.0 1.107-274.0 1.107-275.0
More informationPARTS LIST FOR CA MHB/RB (AFTER SERIAL # ) CA MVB
PARTS LIST FOR CA-2403-0MHB/RB (AFTER SERIAL #10173072) CA-2403-0MVB ENGINE OIL GRADE: HONDA/SUBARU: VANGUARD: ENGINE OIL CAPACITY: HONDA/SUBARU: VANGUARD: SAE10W-30 ABOVE 40 F = SAE30 BELOW 40 F = SAE10W-30
More informationMOTOR DATA. Air Air Lubricator Motor Inlet Consumption Drops Per Size Size (cfm) Minute*
AIR HOIST SUPPLEMENT TO 113533-60 (OPERATION, SERVICE & PARTS MANUAL FOR SERIES 700 SHAW-BOX WIRE ROPE ELECTRIC HOISTS) (1 THRU 15 TON RATED LOADS) SHAW-BOX Series 700 Wire Rope Air Hoists use the same
More informationSERVICE MANUAL MODEL # ORDER # XPERT-HD 3.8/35 P XPERT-HD 3.5/40 P PD PD DA DA DD DD
SERVICE MANUAL MODEL # ORDER # XPERT-HD 3.8/35 P XPERT-HD 3.5/40 P PD4-35324 PD4-40324 DA-383539 DA-354039 DD-383537 DD-354037 1.107-108.0 1.107-219.0 1.107-096.0 1.107-220.0 1.107-102.0 1.107-218.0 1.107-137.0
More informationSINGLE-STAGE INJECTOR MODELS 200-3C, 200C, 201C, 202C, 203C, 204C, 206C, 208C
D E M A SINGLE-STAGE MODELS SINGLE-STAGE MODELS 1. PARTS A. Injector B. Backup washer (Models 204C & smaller). C. Ceramic Weight. D. Tubing 8 long w/ foot strainer. E. Three brass nozzle bushings Metering
More informationMPS 1-L Manual Powder System with the PG 1 Powder Gun
bar... 0. m /h 00 00 90 90 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 kv µa E Operating Instructions and Spare Parts List MPS -L Manual Powder System with the PG Powder Gun 0 0 + m /h Issued 0/9 MPS -L / PG An ITW
More information