PACKAGE HEAT PUMP UNITS

Transcription

1 PACKAGE HEAT PUMP UNITS FOM NO. PTZ-77 EV. Supersedes Form No. PTZ-77 ev. 2 Featuring Earth-Friendly -40A efrigerant earth friendly refrigerant TZCHC- SEE HIGH EFFICIENCY SEIES NOMINAL SIZES -5 TONS [ kw] TZCHC- EE HIGH EFFICIENCY SEIES NOMINAL SIZES 6 TONS [2. kw] Manufactured for Thermal Zone Philadelphia, PA *Unit shown with optional louver panels installed. (4 SEE MODELS ONLY)

2 TABLE OF CONTENTS Introduction...-4 Model Identification Options General Data TZCHC- Series General Data Notes... Performance Data TZCHC- Series Airflow Performance TZCHC- Series Electrical Data TZCHC- Series Units with Heater Kits TZCHC- Series Dimensional Data Accessories Mechanical Specifications...47 Typical Wiring Limited Warranty

3 These quality features are included in the Thermal Zone Outdoor Package Heat Pumps INTODUCTION Control Box Access Compressor Access Blower Access Optional Electric Heater Kit Evaporator Coil/Filter Access

4 INTODUCTION These quality features are included in the Thermal Zone Package Gas Electric Unit TZCHC - 06, 042, 048, 060, 072 STANDAD FEATUES INCLUDE: -40A HFC refrigerant. Complete factory charged, wired and run tested. Scroll compressors with internal line break overload and highpressure protection. Single stage compressor on all models. Convertible airflow. TXV refrigerant metering system on each circuit. High Pressure protection standard on all models. Low Pressure/Loss of charge protection standard on 6 ton model. Solid Core liquid line filter drier on each circuit. Single slab, single pass designed evaporator coil facilitate easy cleaning for maintained high efficiencies. Cooling operation up to 25 degree F ambient. Easy access to filter, blower, electric heat, and compressor/ control compartments permit prompt service. Powder Paint Finish meets ASTMB7 steel coated on each side for maximum protection. G90 galvanized. One piece top cover and one piece base pan with drawn supply and return opening for superior water management. Externally mounted refrigerant gauge ports for easy service diagnostics. Easy to install plug-in; slip in, 00% fully modulating economizer with barometric relief. Forkable base rails for easy handling and lifting. Single point electrical connection. Direct drive or high performance belt drive motor with variable pitch pulleys and quick adjust belt system. Permanently lubricated evaporator and condenser motors. Condenser motors are internally protected, totally enclosed with shaft down design. inch filter standard with slide out design. Colored and labeled wiring. Copper tube/aluminum Fin coils. Molded compressor plug. Supplemental electric heat provides 00% efficient heating. 4

5 MODEL IDENTIFICATION TZCHC- SEIES TZ C H C 6 C K 000 AD A THEMAL ZONE COMMECIAL HEAT PUMP CONVETIBLE SEE NOMINAL COOLING CAPACITY (BTUH) [kw] 6 = 6,000 [0.55] 42 = 42,000 [2.] 48 = 48,000 [4.07] 60 = 60,000 [7.58] 72 = 72,000 [2.0] ELECTICAL DESIGNATION J= V, PH, 60 Hz C= V, PH, 60 Hz D= 460 V, PH, 60 Hz Y= 575 V, PH, 60 Hz DIVE PACKAGE K = DIECT DIVE L = BELT DIVE N = BELT DIVE HIGH STATIC ELECTIC HEAT 000 = NO ESISTANCE HEAT 00 = 0 kw ESISTANCE HEAT 05 = 5 kw ESISTANCE HEAT 020 = 20 kw ESISTANCE HEAT AD = OPTION CODE FO HAIL GUAD NO GAS MOUNT 5

6 OPTIONS TZCHC- SEIES FACTOY INSTALLED OPTION CODES FO TZCHC- (-6 Ton) [ kw] (06, 042, 048, 060) TZCHC- (-5 Ton) [ kw] Option Code AD Hail Guard x Non-ed Convenience Outlet Low Ambient/ Freeze Stat ECONOMIZE SELECTION FO TZCHC- (-6 Ton) [ kw] (06, 042, 048, 060) A x indicates factory installed option. No Economizer x Single Enthalpy Economizer With Barometric elief 6

7 GENEAL DATA TZCHC- SEIES NOMINAL SIZES -5 TONS [ kw] Model TZCHC- Series 6CK 6CM 6DK 6DM Cooling Performance Gross Cooling Capacity Btu [kw] 7,800 [.08] 7,800 [.08] 7,800 [.08] CONTINUED 7,800 [.08] EE/SEE 2.5/.5/.5/.5/ Nominal CFM/AI ated CFM [L/s] 200/200 [566/566] 200/200 [566/566] 200/200 [566/566] 200/200 [566/566] AI Net Cooling Capacity Btu [kw] 6,200 [0.6] 6,200 [0.6] 6,200 [0.6] 6,200 [0.6] Net Sensible Capacity Btu [kw] 27,000 [7.9] 27,000 [7.9] 27,000 [7.9] 27,000 [7.9] Net Latent Capacity Btu [kw] 9,200 [] 9,200 [] 9,200 [] 9,200 [] Net System kw.... Heating Performance (Heat Pumps) Heating Temp. Btuh [kw] ating 4,400 [0.08] 4,400 [0.08] 4,400 [0.08] 4,400 [0.08] System KW/COP 4/.4 4/.4 4/.4 4/.4 Low Temp. Btuh [kw] ating 9,600 [5.74] 9,600 [5.74] 9,600 [5.74] 9,600 [5.74] System KW/COP 2/2. 2/2. 2/2. 2/2. HSPF (Btu/Watts-hr) Compressor No./Type /Scroll /Scroll /Scroll /Scroll Outdoor Sound ating (db) Outdoor Coil Fin Type Louvered Louvered Louvered Louvered Tube Type ifled ifled ifled ifled Tube Size in. [mm] OD 0.75 [9.5] 0.75 [9.5] 0.75 [9.5] 0.75 [9.5] Face Area sq. ft. [sq. m] 6.89 [.57] 6.89 [.57] 6.89 [.57] 6.89 [.57] ows / FPI [FPcm] / 22 [9] / 22 [9] / 22 [9] / 22 [9] efrigerant Control TX Valves TX Valves TX Valves TX Valves Indoor Coil Fin Type Louvered Louvered Louvered Louvered Tube Type ifled ifled ifled ifled Tube Size in. [mm] 0.75 [9.5] 0.75 [9.5] 0.75 [9.5] 0.75 [9.5] Face Area sq. ft. [sq. m] 5.6 [0.48] 5.6 [0.48] 5.6 [0.48] 5.6 [0.48] ows / FPI [FPcm] / [5] / [5] / [5] / [5] efrigerant Control TX Valves TX Valves TX Valves TX Valves Drain Connection No./Size in. [mm] / [25.4] / [25.4] / [25.4] / [25.4] Outdoor Fan Type Propeller Propeller Propeller Propeller No. Used/Diameter in. [mm] /24 [609.6] /24 [609.6] /24 [609.6] /24 [609.6] Drive Type/No. Speeds Direct/ Direct/ Direct/ Direct/ CFM [L/s] 4000 [888] 4000 [888] 4000 [888] 4000 [888] No. Motors/HP at / HP at / HP at / HP at / HP Motor PM Indoor Fan Type FC Centrifugal FC Centrifugal FC Centrifugal FC Centrifugal No. Used/Diameter in. [mm] /0x0 [254x254] /0x0 [254x254] /0x0 [254x254] /0x0 [254x254] Drive Type/No. Speeds Direct/ Belt/Variable Direct/ Belt/Variable No. Motors Motor HP /2 /4 /2 /4 Motor PM Motor Frame Size Filter Type Disposable Disposable Disposable Disposable Furnished Yes Yes Yes Yes (No.) Size ecommended in. [mm] (2)x25x6 [25x65x406] (2)x25x6 [25x65x406] (2)x25x6 [25x65x406] (2)x25x6 [25x65x406] efrigerant Charge Oz. [g] 6 [289] 6 [289] 6 [289] 6 [289] Weights Net Weight lbs. [kg] 57 [25] 57 [25] 57 [25] 57 [25] Ship Weight lbs. [kg] 52 [24] 52 [24] 52 [24] 52 [24] See Page for Notes. 7

8 GENEAL DATA TZCHC- SEIES NOMINAL SIZES -5 TONS [ kw] Model TZCHC- Series 6JK 42CK 42CM 42DK Cooling Performance Gross Cooling Capacity Btu [kw] 7,800 [.08] 44,000 [9] 44,000 [9] CONTINUED 44,000 [9] EE/SEE 2.5/.2/.2/.2/ Nominal CFM/AI ated CFM [L/s] 200/200 [566/566] 400/400 [66/66] 400/400 [66/66] 400/400 [66/66] AI Net Cooling Capacity Btu [kw] 6,200 [0.6] 42,000 [2.] 42,000 [2.] 42,000 [2.] Net Sensible Capacity Btu [kw] 27,000 [7.9],200 [9.4],200 [9.4],200 [9.4] Net Latent Capacity Btu [kw] 9,200 [] 0,800 [.6] 0,800 [.6] 0,800 [.6] Net System kw Heating Performance (Heat Pumps) Heating Temp. Btuh [kw] ating 4,400 [0.08] 4,000 [2.0] 4,000 [2.0] 4,000 [2.0] System KW/COP 4/.4.8/.5.8/.5.8/.5 Low Temp. Btuh [kw] ating 9,600 [5.74] 24,400 [7.5] 24,400 [7.5] 24,400 [7.5] System KW/COP 2/2..2/2..2/2..2/2. HSPF (Btu/Watts-hr) Compressor No./Type /Scroll /Scroll /Scroll /Scroll Outdoor Sound ating (db) Outdoor Coil Fin Type Louvered Louvered Louvered Louvered Tube Type ifled ifled ifled ifled Tube Size in. [mm] OD 0.75 [9.5] 0.75 [9.5] 0.75 [9.5] 0.75 [9.5] Face Area sq. ft. [sq. m] 6.89 [.57] 6.89 [.57] 6.89 [.57] 6.89 [.57] ows / FPI [FPcm] / 22 [9] / 22 [9] / 22 [9] / 22 [9] efrigerant Control TX Valves TX Valves TX Valves TX Valves Indoor Coil Fin Type Louvered Louvered Louvered Louvered Tube Type ifled ifled ifled ifled Tube Size in. [mm] 0.75 [9.5] 0.75 [9.5] 0.75 [9.5] 0.75 [9.5] Face Area sq. ft. [sq. m] 5.6 [0.48] 5.6 [0.48] 5.6 [0.48] 5.6 [0.48] ows / FPI [FPcm] / [5] / [5] / [5] / [5] efrigerant Control TX Valves TX Valves TX Valves TX Valves Drain Connection No./Size in. [mm] / [25.4] / [25.4] / [25.4] / [25.4] Outdoor Fan Type Propeller Propeller Propeller Propeller No. Used/Diameter in. [mm] /24 [609.6] /24 [609.6] /24 [609.6] /24 [609.6] Drive Type/No. Speeds Direct/ Direct/ Direct/ Direct/ CFM [L/s] 4000 [888] 4000 [888] 4000 [888] 4000 [888] No. Motors/HP at / HP at / HP at / HP at / HP Motor PM Indoor Fan Type FC Centrifugal FC Centrifugal FC Centrifugal FC Centrifugal No. Used/Diameter in. [mm] /0x0 [254x254] /0x0 [254x254] /0x0 [254x254] /0x0 [254x254] Drive Type/No. Speeds Direct/ Direct/ Belt/Variable Direct/ No. Motors Motor HP /2 /2 /4 /2 Motor PM Motor Frame Size Filter Type Disposable Disposable Disposable Disposable Furnished Yes Yes Yes Yes (No.) Size ecommended in. [mm] (2)x25x6 [25x65x406] (2)x25x6 [25x65x406] (2)x25x6 [25x65x406] (2)x25x6 [25x65x406] efrigerant Charge Oz. [g] 20 [402] 20 [402] 20 [402] 20 [402] Weights Net Weight lbs. [kg] 57 [25] 52 [26] 52 [26] 52 [26] Ship Weight lbs. [kg] 52 [24] 56 [24] 56 [24] 56 [24] See Page for Notes. 8

9 GENEAL DATA TZCHC- SEIES NOMINAL SIZES -5 TONS [ kw] Model TZCHC- Series 42DM 42JK 48CK 48CM Cooling Performance Gross Cooling Capacity Btu [kw] 44,000 [9] 44,000 [9] 50,000 [4.65] CONTINUED 50,000 [4.65] EE/SEE 2.2/.2/.2/.2/ Nominal CFM/AI ated CFM [L/s] 400/400 [66/66] 400/400 [66/66] 600/600 [755/755] 600/600 [755/755] AI Net Cooling Capacity Btu [kw] 42,000 [2.] 42,000 [2.] 47,500 [.92] 47,500 [.92] Net Sensible Capacity Btu [kw],200 [9.4],200 [9.4] 5,700 [0.46] 5,700 [0.46] Net Latent Capacity Btu [kw] 0,800 [.6] 0,800 [.6],800 [.46],800 [.46] Net System kw Heating Performance (Heat Pumps) Heating Temp. Btuh [kw] ating 4,000 [2.0] 4,000 [2.0] 49,000 [4.6] 49,000 [4.6] System KW/COP.8/.5.8/.5.9/.6.9/.6 Low Temp. Btuh [kw] ating 24,400 [7.5] 24,400 [7.5] 29,000 [8.5] 29,000 [8.5] System KW/COP.2/2..2/2..6/2..6/2. HSPF (Btu/Watts-hr) Compressor No./Type /Scroll /Scroll /Scroll /Scroll Outdoor Sound ating (db) Outdoor Coil Fin Type Louvered Louvered Louvered Louvered Tube Type ifled ifled ifled ifled Tube Size in. [mm] OD 0.75 [9.5] 0.75 [9.5] 0.75 [9.5] 0.75 [9.5] Face Area sq. ft. [sq. m] 6.89 [.57] 6.89 [.57] 6.56 [.54] 6.56 [.54] ows / FPI [FPcm] / 22 [9] / 22 [9] 2 / 22 [9] 2 / 22 [9] efrigerant Control TX Valves TX Valves TX Valves TX Valves Indoor Coil Fin Type Louvered Louvered Louvered Louvered Tube Type ifled ifled ifled ifled Tube Size in. [mm] 0.75 [9.5] 0.75 [9.5] 0.75 [9.5] 0.75 [9.5] Face Area sq. ft. [sq. m] 5.6 [0.48] 5.6 [0.48] 5.6 [0.48] 5.6 [0.48] ows / FPI [FPcm] / [5] / [5] 4 / [5] 4 / [5] efrigerant Control TX Valves TX Valves TX Valves TX Valves Drain Connection No./Size in. [mm] / [25.4] / [25.4] / [25.4] / [25.4] Outdoor Fan Type Propeller Propeller Propeller Propeller No. Used/Diameter in. [mm] /24 [609.6] /24 [609.6] /24 [609.6] /24 [609.6] Drive Type/No. Speeds Direct/ Direct/ Direct/ Direct/ CFM [L/s] 4000 [888] 4000 [888] 4000 [888] 4000 [888] No. Motors/HP at / HP at / HP at / HP at / HP Motor PM Indoor Fan Type FC Centrifugal FC Centrifugal FC Centrifugal FC Centrifugal No. Used/Diameter in. [mm] /0x0 [254x254] /0x0 [254x254] /0x0 [254x254] /0x0 [254x254] Drive Type/No. Speeds Belt/Variable Direct/ Direct/ Belt/Variable No. Motors Motor HP /4 /2 /2 /4 Motor PM Motor Frame Size Filter Type Disposable Disposable Disposable Disposable Furnished Yes Yes Yes Yes (No.) Size ecommended in. [mm] (2)x25x6 [25x65x406] (2)x25x6 [25x65x406] (2)x25x6 [25x65x406] (2)x25x6 [25x65x406] efrigerant Charge Oz. [g] 20 [402] 20 [402] 87 [50] 87 [50] Weights Net Weight lbs. [kg] 52 [26] 52 [26] 55 [24] 55 [24] Ship Weight lbs. [kg] 56 [24] 56 [24] 550 [249] 550 [249] See Page for Notes. 9

10 GENEAL DATA TZCHC- SEIES NOMINAL SIZES -5 TONS [ kw] Model TZCHC- Series 48DK 48DM 48JK 60CK Cooling Performance Gross Cooling Capacity Btu [kw] 50,000 [4.65] 50,000 [4.65] 50,000 [4.65] CONTINUED 6,000 [7.87] EE/SEE 2.2/.2/.2/.5/ Nominal CFM/AI ated CFM [L/s] 600/600 [755/755] 600/600 [755/755] 600/600 [755/755] 2000/2000 [944/944] AI Net Cooling Capacity Btu [kw] 47,500 [.92] 47,500 [.92] 47,500 [.92] 59,000 [7.29] Net Sensible Capacity Btu [kw] 5,700 [0.46] 5,700 [0.46] 5,700 [0.46] 44,050 [] Net Latent Capacity Btu [kw],800 [.46],800 [.46],800 [.46] 4,950 [4.8] Net System kw Heating Performance (Heat Pumps) Heating Temp. Btuh [kw] ating 49,000 [4.6] 49,000 [4.6] 49,000 [4.6] 60,000 [7.58] System KW/COP.9/.6.9/.6.9/ /.6 Low Temp. Btuh [kw] ating 29,000 [8.5] 29,000 [8.5] 29,000 [8.5] 5,800 [0.49] System KW/COP.6/2..6/2..6/2. 4./ HSPF (Btu/Watts-hr) Compressor No./Type /Scroll /Scroll /Scroll /Scroll Outdoor Sound ating (db) Outdoor Coil Fin Type Louvered Louvered Louvered Louvered Tube Type ifled ifled ifled ifled Tube Size in. [mm] OD 0.75 [9.5] 0.75 [9.5] 0.75 [9.5] 0.75 [9.5] Face Area sq. ft. [sq. m] 6.56 [.54] 6.56 [.54] 6.56 [.54] 6.56 [.54] ows / FPI [FPcm] 2 / 22 [9] 2 / 22 [9] 2 / 22 [9] 2 / 22 [9] efrigerant Control TX Valves TX Valves TX Valves TX Valves Indoor Coil Fin Type Louvered Louvered Louvered Louvered Tube Type ifled ifled ifled ifled Tube Size in. [mm] 0.75 [9.5] 0.75 [9.5] 0.75 [9.5] 0.75 [9.5] Face Area sq. ft. [sq. m] 5.6 [0.48] 5.6 [0.48] 5.6 [0.48] 5.6 [0.48] ows / FPI [FPcm] 4 / [5] 4 / [5] 4 / [5] 4 / [5] efrigerant Control TX Valves TX Valves TX Valves TX Valves Drain Connection No./Size in. [mm] / [25.4] / [25.4] / [25.4] / [25.4] Outdoor Fan Type Propeller Propeller Propeller Propeller No. Used/Diameter in. [mm] /24 [609.6] /24 [609.6] /24 [609.6] /24 [609.6] Drive Type/No. Speeds Direct/ Direct/ Direct/ Direct/ CFM [L/s] 4000 [888] 4000 [888] 4000 [888] 4000 [888] No. Motors/HP at / HP at / HP at / HP at / HP Motor PM Indoor Fan Type FC Centrifugal FC Centrifugal FC Centrifugal FC Centrifugal No. Used/Diameter in. [mm] /0x0 [254x254] /0x0 [254x254] /0x0 [254x254] /x9 [279x229] Drive Type/No. Speeds Direct/ Belt/Variable Direct/ Direct/2 No. Motors Motor HP /2 /4 /2 Motor PM Motor Frame Size Filter Type Disposable Disposable Disposable Disposable Furnished Yes Yes Yes Yes (No.) Size ecommended in. [mm] (2)x25x6 [25x65x406] (2)x25x6 [25x65x406] (2)x25x6 [25x65x406] (2)x25x6 [25x65x406] efrigerant Charge Oz. [g] 87 [50] 87 [50] 87 [50] 95 [5528] Weights Net Weight lbs. [kg] 55 [24] 55 [24] 55 [24] 565 [256] Ship Weight lbs. [kg] 550 [249] 550 [249] 550 [249] 580 [26] See Page for Notes. 0

11 GENEAL DATA TZCHC- SEIES NOMINAL SIZES -5 TONS [ kw] Model TZCHC- Series 60CM 60DM 60JK 72CL Cooling Performance Gross Cooling Capacity Btu [kw] 6,500 [8.02] 6,500 [8.02] 6,000 [7.87] CONTINUED 7,000 [2.9] EE/SEE 2.5/.5/.5/ /NA Nominal CFM/AI ated CFM [L/s] 2000/2000 [944/944] 2000/2000 [944/944] 2000/2000 [944/944] 2400/225 [/00] AI Net Cooling Capacity Btu [kw] 59,000 [7.29] 59,000 [7.29] 59,000 [7.29] 70,000 [20.5] Net Sensible Capacity Btu [kw] 44,050 [] 44,050 [] 44,050 [] 50,700 [4.85] Net Latent Capacity Btu [kw] 4,950 [4.8] 4,950 [4.8] 4,950 [4.8] 9,00 [5.65] Net System kw Heating Performance (Heat Pumps) Heating Temp. Btuh [kw] ating 60,000 [7.58] 60,000 [7.58] 60,000 [7.58] 66,000 [9.92] System KW/COP 4.78/ / / /2. Low Temp. Btuh [kw] ating 5,800 [0.49] 5,800 [0.49] 5,800 [0.49] 4,000 [2.0] System KW/COP 4./ 4./ 4./ 5.22/2. HSPF (Btu/Watts-hr) N/A Compressor No./Type /Scroll /Scroll /Scroll /Scroll Outdoor Sound ating (db) Outdoor Coil Fin Type Louvered Louvered Louvered Louvered Tube Type ifled ifled ifled ifled Tube Size in. [mm] OD 0.75 [9.5] 0.75 [9.5] 0.75 [9.5] 0.75 [9.5] Face Area sq. ft. [sq. m] 6.56 [.54] 6.56 [.54] 6.56 [.54] 6.56 [.54] ows / FPI [FPcm] 2 / 22 [9] 2 / 22 [9] 2 / 22 [9] 2 / 22 [9] efrigerant Control TX Valves TX Valves TX Valves TX Valves Indoor Coil Fin Type Louvered Louvered Louvered Louvered Tube Type ifled ifled ifled ifled Tube Size in. [mm] 0.75 [9.5] 0.75 [9.5] 0.75 [9.5] 0.75 [9.5] Face Area sq. ft. [sq. m] 5.6 [0.48] 5.6 [0.48] 5.6 [0.48] 6.5 [0.6] ows / FPI [FPcm] 4 / [5] 4 / [5] 4 / [5] 4 / [5] efrigerant Control TX Valves TX Valves TX Valves TX Valves Drain Connection No./Size in. [mm] / [25.4] / [25.4] / [25.4] / [25.4] Outdoor Fan Type Propeller Propeller Propeller Propeller No. Used/Diameter in. [mm] /24 [609.6] /24 [609.6] /24 [609.6] /24 [609.6] Drive Type/No. Speeds Direct/ Direct/ Direct/ Direct/ CFM [L/s] 4000 [888] 4000 [888] 4000 [888] 4000 [888] No. Motors/HP at / HP at / HP at / HP at / HP Motor PM Indoor Fan Type FC Centrifugal FC Centrifugal FC Centrifugal FC Centrifugal No. Used/Diameter in. [mm] /0x0 [254x254] /0x0 [254x254] /x9 [279x229] /x [279x279] Drive Type/No. Speeds Belt/Variable Belt/Variable Direct/2 Belt/Variable No. Motors Motor HP /2 Motor PM Motor Frame Size Filter Type Disposable Disposable Disposable Disposable Furnished Yes Yes Yes Yes (No.) Size ecommended in. [mm] (2)x25x6 [25x65x406] (2)x25x6 [25x65x406] (2)x25x6 [25x65x406] (4)x6x6 [25x406x406] efrigerant Charge Oz. [g] 95 [5528] 95 [5528] 95 [5528] 22 [6265] Weights Net Weight lbs. [kg] 565 [256] 565 [256] 565 [256] 620 [28] Ship Weight lbs. [kg] 580 [26] 580 [26] 580 [26] 65 [288] See Page for Notes.

12 GENEAL DATA TZCHC- SEIES NOMINAL SIZES -5 TONS [ kw] Model TZCHC- Series 72CM 72DL 72DM 72YL Cooling Performance Gross Cooling Capacity Btu [kw] 7,000 [2.9] 7,000 [2.9] 7,000 [2.9] CONTINUED 7,000 [2.9] EE/SEE 2 /NA /NA /NA /NA Nominal CFM/AI ated CFM [L/s] 2400/225 [/00] 2400/225 [/00] 2400/225 [/00] 2400/225 [/00] AI Net Cooling Capacity Btu [kw] 70,000 [20.5] 70,000 [20.5] 70,000 [20.5] 70,000 [20.5] Net Sensible Capacity Btu [kw] 50,700 [4.85] 50,700 [4.85] 50,700 [4.85] 50,700 [4.85] Net Latent Capacity Btu [kw] 9,00 [5.65] 9,00 [5.65] 9,00 [5.65] 9,00 [5.65] Net System kw Heating Performance (Heat Pumps) Heating Temp. Btuh [kw] ating 68,000 [9.92] 68,000 [9.92] 68,000 [9.92] 68,000 [9.92] System KW/COP 5.79/ / / /.44 Low Temp. Btuh [kw] ating 4,000 [2.0] 4,000 [2.0] 4,000 [2.0] 4,000 [2.0] System KW/COP 5.22/ / / /2. HSPF (Btu/Watts-hr) N/A N/A N/A N/A Compressor No./Type /Scroll /Scroll /Scroll /Scroll Outdoor Sound ating (db) Outdoor Coil Fin Type Louvered Louvered Louvered Louvered Tube Type ifled ifled ifled ifled Tube Size in. [mm] OD 0.75 [9.5] 0.75 [9.5] 0.75 [9.5] 0.75 [9.5] Face Area sq. ft. [sq. m] 6.56 [.54] 6.56 [.54] 6.56 [.54] 6.56 [.54] ows / FPI [FPcm] 2 / 22 [9] 2 / 22 [9] 2 / 22 [9] 2 / 22 [9] efrigerant Control TX Valves TX Valves TX Valves TX Valves Indoor Coil Fin Type Louvered Louvered Louvered Louvered Tube Type ifled ifled ifled ifled Tube Size in. [mm] 0.75 [9.5] 0.75 [9.5] 0.75 [9.5] 0.75 [9.5] Face Area sq. ft. [sq. m] 6.5 [0.6] 6.5 [0.6] 6.5 [0.6] 6.5 [0.6] ows / FPI [FPcm] 4 / [5] 4 / [5] 4 / [5] 4 / [5] efrigerant Control TX Valves TX Valves TX Valves TX Valves Drain Connection No./Size in. [mm] / [25.4] / [25.4] / [25.4] / [25.4] Outdoor Fan Type Propeller Propeller Propeller Propeller No. Used/Diameter in. [mm] /24 [609.6] /24 [609.6] /24 [609.6] /24 [609.6] Drive Type/No. Speeds Direct/ Direct/ Direct/ Direct/ CFM [L/s] 4000 [888] 4000 [888] 4000 [888] 4000 [888] No. Motors/HP at / HP at / HP at / HP at / HP Motor PM Indoor Fan Type FC Centrifugal FC Centrifugal FC Centrifugal FC Centrifugal No. Used/Diameter in. [mm] /x [279x279] /x [279x279] /x [279x279] /x [279x279] Drive Type/No. Speeds Belt/Variable Belt/Variable Belt/Variable Belt/Variable No. Motors Motor HP /2 /2 /2 /2 Motor PM Motor Frame Size Filter Type Disposable Disposable Disposable Disposable Furnished Yes Yes Yes Yes (No.) Size ecommended in. [mm] (4)x6x6 [25x406x406] (4)x6x6 [25x406x406] (4)x6x6 [25x406x406] (4)x6x6 [25x406x406] efrigerant Charge Oz. [g] 22 [6265] 22 [6265] 22 [6265] 22 [6265] Weights Net Weight lbs. [kg] 620 [28] 620 [28] 620 [28] 620 [28] Ship Weight lbs. [kg] 65 [288] 65 [288] 65 [288] 65 [288] See Page for Notes. 2

13 NOTES: GENEAL DATA TZCHC- SEIES. Cooling Performance is rated at 95 F ambient, 80 F entering dry bulb, 67 F entering wet bulb. Gross capacity does not include the effect of fan motor heat. AI capacity is net and includes the effect of fan motor heat. Units are suitable for operation to 20% of nominal cfm. Units are certified in accordance with the Unitary Air Conditioner Equipment certification program, which is based on AI Standard 20/240 or EE and/or SEE are rated at AI conditions and in accordance with DOE test procedures.. Outdoor Sound ating shown is tested in accordance with AI Standard 270.

14 SYSTEMS PEFOMANCE TZCHC- SEIES COOLING PEFOMANCE DATA TZCHC-6 O UT D O O D Y B U LB T E M PE AT U E F [ C] 75 [2.9] 80 [26.7] 85 [29.4] 90 [] 95 [5] 00 [7.8] 05 [40.6] 0 [4.] 5 [46.] ENTEING INDOO 80 F [26.7 C] dbe ➀ wbe 7 F [ C] 67 F [9.4 C] 6 F [7.2 C] CFM [L/s] 440 [680] 200 [566] 960 [45] 440 [680] 200 [566] 960 [45] 440 [680] 200 [566] 960 [45] D ➀ D Depression ratio dbe Entering air dry bulb wbe Entering air wet bulb 46.4 [.60] 27.9 [8.8] 45.5 [.] 27.2 [7.97] [8] 26.6 [7.80] 4 [0] 26. [7.65] 4.6 [] 25.5 [7.47] 40. [.75] 24.9 [7.0] 8.6 [.] 24. [7.2] 7.2 [0.90] 2.5 [6.89]. 5.8 [0.49] 2 [6.65] [] 25.5 [7.47] [7] 24.9 [7.0] 4 [4] 24.4 [7.5] 4.5 [] 2.9 [7.00] 40.2 [.78] 2.4 [6.86] 8.7 [.4] 2 [6.68] 7. [0.9] 2 [6.5] 5.9 [0.52] [6.0] 4.6 [0.4] 20.7 [6.07]. 4. [] 2. [6.77] [0] 2 [6.62] 4.2 [2.07] 22. [6.48] [.72] [6.] 8.7 [.4] [6.2] 7. [0.9] 20.7 [6.07] 5.9 [0.52] 20. [5.89] 4.6 [0.4] 9.5 [5.7]. [9.76] 8.8 [5.5]. Total Total capacity x 000 BTUH Sens Sensible capacity x 000 BTUH KW input 44.0 [0].7 [9.88] [] [9.67] [8] [9.50] 40.6 [.90].9 [9.5] 9.2 [.49]. [9.7] 7.7 [.05] 0.7 [9.00] 6.2 [0.6] 0. [8.82] 4.8 [0.20] 29. [8.59]..4 [9.79] 28.4 [8.2].2 HEATING PEFOMANCE DATA TZCHC-6 IDB CFM [L/s] 0 O UT [-7.8] 5 [26.7] D O O D Y B U LB T E M PE AT U E F [ C] 0 [-] 5 [] 20 [-6.6] 25 [7.8] 0 [-.] 5 [4.] 40 [4.4] 45 [46.] 50 [0].0 [.22].8.4 [.9] [4.66].9 8. [5.6] [6.0].9 2. [6.8] [7.56] [8.29] [9.0] 2.. [9.76] [0.52] 0.8 [.7].8.2 [.87] [4.57].9 8. [5.0] [6.0] [6.74] [7.44] [8.8] [8.9] 2. [9.64] 5.4 [0.7] 0.7 [.4].9 [.8] [4.5] [5.22] [5.92] [6.62] [7.6] [8.06] 0.0 [8.79] [9.50] 4.9 [0.2] 2. 4 [] 0.8 [9.0] [] 0.2 [8.85] 40.5 [.87] 29.7 [8.70] 9.2 [.49] 29. [8.5] 7.8 [.08] 28.6 [8.8] 6.4 [0.67] 28. [8.24] 5.0 [0.26] 27.5 [8.06].6 [9.85] 26.8 [7.85] [9.44] 26.0 [7.62] [.99] 27.9 [8.8] [.72] 27.4 [8.0] 9.0 [.4] 26.9 [7.88] [.08] 26.4 [7.74] 6.5 [0.70] 26.0 [7.62] 5. [0.29] 25.5 [7.47].7 [9.88] 24.9 [7.0] 2. [9.47] 24. [7.2]. [9.] [6.92]. 4.5 [] 8.4 [.25] [.90] 7.7 [.05] [.58] 7. [0.9] 8.2 [.20] 6.8 [0.79] 6.8 [0.79] 6.0 [0.55] 5. [0.5] 5. [0.5].8 [9.9].8 [9.9] 2. [9.47] 2. [9.47] [9.09] [9.09] [.75] 5.2 [0.2] [.49] 4.6 [0.4] 8. [.7] 4.0 [9.96] 6.9 [0.8].5 [9.82] 5.5 [0.40] [9.67] 4. [9.99] [9.52] [9.55].9 [9.5].2 [9.4].2 [9.4] 29.9 [8.76] 29.9 [8.76]. 8.6 [.].9 [9.5] [.08]. [9.7] 6.7 [0.76] 0.9 [9.06] [0.40] 0.4 [8.9] 4.2 [0.02] 29.9 [8.76] [9.6] 29.4 [8.62].4 [9.20] 28.9 [8.47] 0. [8.82] 28. [8.29] 28.8 [8.44] 27.6 [8.09]. NOTES: ➀ When the entering air dry bulb is other than 80 F [27 C], adjust the sensible capacity from the table by adding [.0 x CFM x ( D) x (dbe 80)]. 60 F [5.5 C] 70 F [2. C] 80 F [26.7 C] 440 [680] 200 [566] 960 [45] 440 [680] 200 [566] 960 [45] 440 [680] 200 [566] 960 [45] 9.8 [7] [.60] [4.] [5.04] 9.7 [5.77] 2 [6.5] 24.7 [7.24] [7.97] [8.70] 2. [9.44] 4.8 [0.20] 9.7 [4] [.55] [4.25] 7.0 [4.98] 9.4 [5.69] 2. [6.42] [7.2] [7.85] 29. [8.59].8 [9.2] 4. [0.05] 9.6 [].9 [.49] 4. [4.9] 6.7 [4.89] [5.60] 2. [6.] 24.0 [7.0] 26.4 [7.74] 28.9 [8.47]. [9.7].8 [9.9] 8.4 [6] [.7] 2.. [.90] 5.8 [4.6] 8.2 [5.] 20.7 [6.07] [6.80] 25.7 [7.5] 28.2 [8.26] 0.8 [9.0]. [9.76] 8. [] 0.7 [.4]. [.84] 5.5 [4.54] 8.0 [5.28] 20.4 [5.98] 2 [6.7] 25.4 [7.44] 27.9 [8.8] 0. [8.88] [9.6] 8.2 [0] 0.5 [8] [.78] 5. [4.48] 7.7 [5.9] 20.2 [5.92] 2 [6.62] 25.0 [7.] 27.5 [8.06] 29.9 [8.76] [9.50] IDB Indoor air dry bulb 4

15 COOLING PEFOMANCE DATA TZCHC-42 O UT D O O D Y B U LB T E M PE AT U E F [ C] 75 [2.9] 80 [26.7] 85 [29.4] 90 [] 95 [5] 00 [7.8] 05 [40.6] 0 [4.] 5 [46.] ENTEING INDOO 80 F [26.7 C] dbe ➀ wbe 7 F [ C] 67 F [9.4 C] 6 F [7.2 C] CFM [L/s] 680 [79] 400 [66] 20 [529] 680 [79] 400 [66] 20 [529] 680 [79] 400 [66] 20 [529] D ➀ [6.09] [9.58] 5.6 [5.7] 2.0 [9.8] 52. [5.27]. [9.7] 50.5 [4.80] 0.5 [8.94] 48.9 [4.] 29.8 [8.7] [.86] 29.0 [8.50] [.9] 28.2 [8.26] [5] 27.4 [8.0].7 4 [] 26.5 [7.77].9 5 [5.5] 29.9 [8.76] 5.7 [5.5] 29. [8.59] 50. [4.74] 28.6 [8.8] 48.8 [4.0] 27.9 [8.8] 47.2 [.8] 27.2 [7.97] [.6] 26.5 [7.77]. 44. [2] 25.8 [7.56].5 4 [8] 25.0 [7.] [2.07] 24.2 [7.09].8 SYSTEMS PEFOMANCE TZCHC- SEIES 5. [4.98] 27. [7.94] 49.8 [4.59] 26.5 [7.77] 48.4 [4.8] 25.9 [7.59] 47.0 [.77] 25. [7.4] 45.5 [.] 24.7 [7.24] [0] 24. [7.06].2 4 [6] 2.4 [6.86].4 4. [2.05] 2 [6.65] [.6] 22.0 [6.45] [5.2] 9.2 [.49] 50.2 [4.7] 8.5 [.28] 48.8 [4.0] 7.8 [.08] 47.2 [.8] 7.0 [0.84] 45.6 [.6] 6. [0.64] [7] 5.5 [0.40] [0] 4.7 [0.7] [.96].9 [9.94] [.55] [9.67] [4.59] 5.9 [0.52] 48.5 [4.2] 5.2 [0.2] 47. [.80] 4.5 [0.] 45.5 [.].9 [9.94] 44.0 [0].2 [9.7].2 4 [] [9.52] [.99].8 [9.2] [.55] [9.09] [.4] 0.2 [8.85] [4.04] [9.52] 46.7 [.69].9 [9.5] 45. [.28]. [9.7] 4.9 [7] 0.7 [9.00] 4 [] 0. [8.82] [.99] 29.4 [8.62]. 9.4 [.55] 28.8 [8.44] [.4] 28. [8.24] [0.7] 27.4 [8.0] [4.42] 45. [.28] 47.9 [4.04] 44.6 [7] 46.4 [.60] 4.9 [7] 44.8 [.] 4. []. 4.2 [6] 4 [6] [] 4.4 [2.] [.72] 40.0 [.72] [.28] 8.5 [.28] [0.84] 7.0 [0.84] [.92] 4.5 [] 46.2 [.54] 40.8 [.96] 44.8 [.] 40. [.75] 4. [9] 9.4 [.55] 4.7 [2] 8.8 [.7] [.75] 8.0 [.4]. 8.6 [.] 7. [0.9].5 7. [0.87] 6.6 [0.7] [0.46] 5.7 [0.46] [.42] 7.6 [.02] 44.5 [4] 7.0 [0.84] 4.2 [6] 6.4 [0.67] 4.7 [2] 5.8 [0.49] 40.2 [.78] 5. [0.29]. 8.7 [.4] 4.5 [0.]. 7.2 [0.90].8 [9.9] [0.49]. [9.70] [0.08] [9.50].8 D Depression ratio dbe Entering air dry bulb wbe Entering air wet bulb Total Total capacity x 000 BTUH Sens Sensible capacity x 000 BTUH KW input NOTES: ➀ When the entering air dry bulb is other than 80 F [27 C], adjust the sensible capacity from the table by adding [.0 x CFM x ( D) x (dbe 80)]. HEATING PEFOMANCE DATA TZCHC-42 IDB CFM [L/s] 0 O UT [-7.8] 5 [26.7] D O O D Y B U LB T E M PE AT U E F [ C] 0 [-] 5 [] 20 [-6.6] 25 [7.8] 0 [-.] 5 [4.] 40 [4.4] 45 [46.] 50 [0] 60 F [5.5 C] 70 F [2. C] 80 F [26.7 C] 680 [79] 400 [66] 20 [529] 680 [79] 400 [66] 20 [529] 680 [79] 400 [66] 20 [529] 0.9 [.9] [4.5] [5.69] 2. 2 [6.68] 25.8 [7.56] 28.6 [8.8] 2..2 [9.4] 2..8 [9.9] [0.7] 9.6 [.6] 4 [0] 0.7 [.4] [4.45] [5.60] 2 [6.59] 25.4 [7.44] [8.26] [9.0].4 [9.79] 6. [0.58] 9.0 [.4] 42. [0] 0.6 [.] [4.40] 8.8 [5.5] 22. [6.48] [7.6] [8.5] 0. [8.88] [9.64] 5.6 [0.4] 8.5 [.28] 4.7 [2] 9.6 [] [4.6] 8. [5.0] [6.0] 24.5 [7.8] 27. [8.00] 29.9 [8.76] [9.55] 5. [0.5] 8. [.22] 4.7 [2] 9.5 [8] 4.0 [4.0] 7.8 [5.22] [6.2] 24.2 [7.09] 26.9 [7.88] 29.5 [8.65] 2. [9.4] 4.8 [0.20] 7.8 [.08] 4. [2.05] 9. [].8 [4.04] 7.6 [5.6] 20.9 [6.] 2.8 [6.98] 26.5 [7.77] 29. [8.5].6 [9.26] 4. [0.05] 7.2 [0.90] 40.5 [.87] 8.5 [9]. [.84] 7.0 [4.98] 20.4 [5.98] 2.4 [6.86] 26.2 [7.68] 28.8 [8.44].5 [9.2] 4.2 [0.02] 7.2 [0.90] 40.6 [.90]. 8.4 [6] [.78] 6.7 [4.89] 20. [5.89] 2. [6.77] 25.8 [7.56] 28.4 [8.2] [9.09].7 [9.88]. 6.7 [0.76] [.72] [0] [.72] 6.5 [4.84] 9.8 [5.80] 2 [6.68] 25.5 [7.47] 28.0 [8.2]. 0.6 [8.97]..2 [9.7] [0.6] [.55].2 IDB Indoor air dry bulb 5

16 SYSTEMS PEFOMANCE TZCHC- SEIES COOLING PEFOMANCE DATA TZCHC-48 O UT D O O D Y B U LB T E M PE AT U E F [ C] 75 [2.9] 80 [26.7] 85 [29.4] 90 [] 95 [5] 00 [7.8] 05 [40.6] 0 [4.] 5 [46.] ENTEING INDOO 80 F [26.7 C] dbe ➀ wbe 7 F [ C] 67 F [9.4 C] 6 F [7.2 C] CFM [L/s] 920 [906] 600 [755] 280 [604] 920 [906] 600 [755] 280 [604] 920 [906] 600 [755] 280 [604] D ➀ [7.9] 7.6 [.02] 60. [7.6] 7.0 [0.84] 58.6 [7.7] 6. [0.64] [6.68] 5.5 [0.40] [6.2] 4.5 [0.].6 5 [5.5].5 [9.82] [4.92] [9.55] [4.0].6 [9.26] [.75] 0.8 [9.0] [7.29] 4.4 [0.08] 57.9 [6.97].9 [9.94] 56.6 [6.59].2 [9.7] [6.09] [9.50].4 5. [5.56].6 [9.26].5 5. [4.98] 0.7 [9.00] [4.9] 29.8 [8.7] [.80] 28.9 [8.47] [.28] 28.2 [8.26] [6.65].2 [9.4] 55.8 [6.5] 0.7 [9.00] 54.5 [5.97] 0. [8.82]. 5 [5.50] 29.4 [8.62]. 5. [4.98] 28.6 [8.8] [4.42] 27.8 [8.5] [.86] 27.0 [7.9] [.] 26.2 [7.68] [8] 25.5 [7.47] [6.9] 44.6 [7] 56.6 [6.59] 44.0 [0] [6.8] 4. [9] [5.68] 4 [6] [5.2] 4.5 [] [4.54] 40.6 [.90] [.92] 9.6 [.6] [.] 8.6 [.] [5] 7.8 [.08] [6.2] 40.8 [.96] 54.7 [6.0] 40. [.8] 5. [5.62] 9.6 [.6] [5.2] 8.8 [.7] [4.59] 8.0 [.4] [4.0] 7. [0.87] [.42] 6.2 [0.6] [4] 5. [0.5] [2.] 4.6 [0.4] [5.74] 7.0 [0.84] 5 [5.44] 6.5 [0.70] 5. [5.0] 5.9 [0.52] [4.59] 5.2 [0.2] [4.07] 4.4 [0.08] [.5].6 [9.85] [2] [9.6].9 4 [2.7] 2.0 [9.8] [.84]. [9.7] [5.47] 49.4 [4.48] 5.8 [5.8] 48.7 [4.27] 50.4 [4.77] 48. [4.6] [4.27] 47.4 [.89] [.69] 46. [.5] [] 44.7 [].8 4 [8] 4 [8] [.90] 40.6 [.90] [.] 8.6 [.] [4.95] 45.2 [.25] 50.0 [4.65] 44.7 [] 48.6 [4.24] 44.0 [0] [.75] 4.2 [6] [.22] 4 [].5 4. [] 4.5 [].7 4. [2.05] 40.6 [.90].9 9. [.46] 9. [.46] [0.9] 7. [0.9] [4.9] 40.9 [.99] 48.2 [4.] 40.5 [.87] 46.8 [.72] 9.9 [.69] [.25] 9.2 [.49]. 4.5 [5] 8.4 [.25] [] 7.6 [.02] [.6] 6.8 [0.79] [.05] 6.0 [0.55] [0.52] 5. [0.5] 4.2 D Depression ratio dbe Entering air dry bulb wbe Entering air wet bulb Total Total capacity x 000 BTUH Sens Sensible capacity x 000 BTUH KW input NOTES: ➀ When the entering air dry bulb is other than 80 F [27 C], adjust the sensible capacity from the table by adding [.0 x CFM x ( D) x (dbe 80)]. HEATING PEFOMANCE DATA TZCHC-48 IDB CFM [L/s] 0 O UT [-7.8] 5 [26.7] D O O D Y B U LB T E M PE AT U E F [ C] 0 [-] 5 [] 20 [-6.6] 25 [7.8] 0 [-.] 5 [4.] 40 [4.4] 45 [46.] 50 [0] 60 F [5.5 C] 70 F [2. C] 80 F [26.7 C] 920 [906] 600 [755] 280 [604] 920 [906] 600 [755] 280 [604] 920 [906] 600 [755] 280 [604] 8.5 [5.42] [6.2] 24.0 [7.0] 27.0 [7.9] 0. [8.82]. [9.76] 6.6 [0.7] 40. [.75] 4.7 [] 47.4 [.89] 5.2 [5.0] 8.2 [5.] 20.9 [6.] 2.7 [6.95] 26.6 [7.80] 29.7 [8.70] [9.6] 6. [0.58] 9.5 [.58] 4. [] 46.7 [.69] 50.5 [4.80] 8.0 [5.28] 20.6 [6.04] 2.4 [6.86] 26. [7.7] 29. [8.59] [9.50] 5.6 [0.4] 9.0 [.4] 4 [6] 46. [.5] 49.8 [4.59] 7.0 [4.98] 9.7 [5.77] 2 [6.62] 25.5 [7.47] 28.6 [8.8].8 [9.2] 5. [0.29] 8.6 [.]. 4 [2.7] [.45] [4.57] [4.92] 9.4 [5.69] 2 [6.5] 25.2 [7.9] 28.2 [8.26].4 [9.20]. 4.7 [0.7]. 8. [.7]. 4.6 [] [.28] [4.6]. 6.5 [4.84] 9.2 [5.6] [6.42] 24.8 [7.27] 27.8 [8.5]. 0.9 [9.06]. 4.2 [0.02] [0.99] [2.02] [7]. 48. [4.6] [4.5]. 8. [5.0] [6.] [7.00] [7.9]. 0.2 [8.85].4.5 [9.82] [0.84] [.90] [8] [4.0] [4.45] [5.22] [6.04]. [6.92] [7.80] [8.7].4. [9.70] [0.70] [.72] [] [.89] [4.40]. 7.6 [5.6]. 20. [5.95].4 [6.80] [7.68] [8.59].5 [9.55] [0.55] [.55].7 4 [0] [.72].8 IDB Indoor air dry bulb 6

17 COOLING PEFOMANCE DATA TZCHC-60 O UT D O O D Y B U LB T E M PE AT U E F [ C] 75 [2.9] 80 [26.7] 85 [29.4] 90 [] 95 [5] 00 [7.8] 05 [40.6] 0 [4.] 5 [46.] ENTEING INDOO 80 F [26.7 C] dbe ➀ wbe 7 F [ C] 67 F [9.4 C] 6 F [7.2 C] CFM [L/s] 2500 [80] 2000 [944] 500 [708] 2500 [80] 2000 [944] 500 [708] 2500 [80] 2000 [944] 500 [708] D ➀ [5] 45. [.28].7 7 [2.4] 44.6 [7] [20.8] 4.7 [] [20.22] 4 [4] [9.55] 4.8 [5] [8.87] 40.7 [.9] [8.4] 9.6 [.6] [7.44] 8.5 [.28] [6.76] 7.4 [0.96] [20.8] 40.6 [.90] [20.40] 9.9 [.69] [9.90] 9. [.46] [9.4] 8. [.22] [8.70] 7.4 [0.96] [8.05] 6.5 [0.70] [7.5] 5.5 [0.40] [6.68] 4.5 [0.] [6.0].5 [9.82] 5.4 SYSTEMS PEFOMANCE TZCHC- SEIES 67.7 [9.84] 5.9 [0.52] [9.46] 5. [0.5] [8.99] 4.6 [0.4] [8.46].8 [9.9] [7.85] [9.67] [7.2] [9.44] [6.56].4 [9.20] [5.9] 0.5 [8.94] 5. 5 [5.0] 29.6 [8.67] [20.87] 55.0 [6.2] [20.46] 54.2 [5.88] [9.9] 5. [5.62] [9.4] 5 [5.6] [8.70] 5.4 [5.06] [7.99] 50.4 [4.77] [7.29] 49. [4.45] [6.56] 48.2 [4.] [5.88] 47. [.80] [9.96] 49.2 [4.42] [9.58] 48.5 [4.2] [9.08] 47.8 [4.0] [8.49] 46.9 [.75] [7.88] 46.0 [.48] [7.20] 45. [.22] [6.5] 44. [2] [5.86] 4. [] [5.2] 4 [2.7] [9.05] 4.5 [5] [8.67] 4 [7] [8.20] 4 [2.7] [7.64] 4.5 [] [7.06] 40.7 [.9] [6.4] 9.8 [.66] [5.77] 9.0 [.4] [5.2] 8. [.7] [4.5] 7.2 [0.90] [9.84] 6.4 [8.58] [9.4] 6 [8.2] [8.90] 62.0 [8.7] 4. 6 [8.2] 6.0 [7.88] [7.64] 59.6 [7.47] [6.97] 57.9 [6.97] [6.24] 55.4 [6.24] [5.5] 5 [5.5] [4.86] 50.7 [4.86] [8.96] 56.8 [6.65] [8.58] 56. [6.44] [8.08] 55. [6.2] [7.50] 54.5 [5.97] [6.88] 5.6 [5.7] [6.2] 5 [5.44] [5.5] 5.7 [5.5] [4.86] 50.7 [4.86] [4.2] 48.5 [4.2] [8.] 50.2 [4.7] [7.7] 49.6 [4.54] [7.26] 48.9 [4.] [6.7] 48. [4.0] [6.2] 47. [.86] [5.47] 46.5 [.6] [4.8] 45.7 [.9] [4.8] 44.8 [.] [.57] 4.9 [7] 5.2 D Depression ratio dbe Entering air dry bulb wbe Entering air wet bulb Total Total capacity x 000 BTUH Sens Sensible capacity x 000 BTUH KW input NOTES: ➀ When the entering air dry bulb is other than 80 F [27 C], adjust the sensible capacity from the table by adding [.0 x CFM x ( D) x (dbe 80)]. HEATING PEFOMANCE DATA TZCHC-60 IDB CFM [L/s] 0 O UT [-7.8] 5 [26.7] D O O D Y B U LB T E M PE AT U E F [ C] 0 [-] 5 [] 20 [-6.6] 25 [7.8] 0 [-.] 5 [4.] 40 [4.4] 45 [46.] 50 [0] IDB Indoor air dry bulb 60 F [5.5 C] 70 F [2. C] 80 F [26.7 C] 2500 [80] 2000 [944] 500 [708] 2500 [80] 2000 [944] 500 [708] 2500 [80] 2000 [944] 500 [708] 2. [6.8] 26. [7.65] 0.0 [8.79] 4.6 [0.4]. 9.7 [.6] [.6] [4.62] [5.94] [7.00] [7.7] [8.02].7 2 [6.7] 25.6 [7.50] 29.4 [8.62]. 4.0 [9.96] [.4]. 44. [2] [4.6] [5.65] [6.7] [7.4] [7.70].8 2 [6.59] [7.9] [8.47].2.4 [9.79]. 8. [.22].4 4. [9] [4.0].6 5 [5.9] [6.4] [7.2] [7.8].9 2. [6.24]. 24. [7.06] [8.2].5 [9.55] [.05].6 4 [7] [4.04].8 5 [5.6] [6.4] [7.4] [7.44] [6.5] [6.95] [8.06] [9.8] [0.84].8 4 [2.7] [.80] [5.09] [6.5] [6.85] [7.4] [6.04].5 2. [6.8] [7.9].7.5 [9.2] [0.67] [2.] [.54] [4.8] [5.86] [6.56] [6.82] [5.80].9 2 [6.62] [7.74] 4.0. [9.] [0.6] [2.] [.60] [4.92] [5.97] [6.7] [7.00] [5.69] [6.5] [7.62] [8.94] [0.40] [.9] [.6] [4.65] [5.7] [6.4] [6.68] [5.60] 4. [6.9] [7.47] [8.79] [0.2] [.69] [.] [4.9] [5.42] [6.2] [6.8] 5.0 7

18 SYSTEMS PEFOMANCE TZCHC- SEIES COOLING PEFOMANCE DATA TZCHC-72 O UT D O O D Y B U LB T E M PE AT U E F [ C] 75 [2.9] 80 [26.7] 85 [29.4] 90 [] 95 [5] 00 [7.8] 05 [40.6] 0 [4.] 5 [46.] ENTEING INDOO 80 F [26.7 C] wbe 7 F [ C] 67 F [9.4 C] 6 F [7.2 C] CFM [L/s] 2880 [59] 225 [00] 920 [906] 2880 [59] 225 [00] 920 [906] 2880 [59] 225 [00] 920 [906] D ➀ [26.7] 72.0 [2.] [26.] 67.5 [9.8] [25.5] 6.5 [8.6] [24.9] 60.4 [7.7] [24.] 57.7 [6.9] [2.7] 55.8 [6.4] [] 54.6 [6.0] [2] 54.0 [5.8] [22.] 54. [5.9] [25.] 56. [6.5] [24.5] 5 [5.4] [2.9] 49.2 [4.4] [2.4] 46.6 [.7] [2] 44.5 [.] [22.] 4 [] [] 42.0 [2.] 6. 7 [2.] 4.6 [] [20.8] 4.8 [2.] [24.6] 52. [5.] [24.] 48.7 [4.] [2.5] 45.6 [.4] [2] 4.2 [] [2] 4.2 [2.] [] 9.7 [.6] [] 8.9 [.4] [20.9] 8.5 [.] [20.4] 8.8 [.4] [25.] 82. [24.] [24.5] 77.5 [2] [2.9] 7.6 [] [] 70.2 [20.6] [2] 67.7 [9.9] [22.] 65.8 [9.] [] 64.6 [8.9] [2.0] 6.9 [8.7] [20.5] 64. [8.8] [] 65.2 [9.] [2] 6.4 [8.0] [2] 58. [7.0] [] 55.4 [6.2] 5. 7 [2.] 5.4 [5.7] [20.8] 5.9 [5.2] [20.] 50.9 [4.9] [9.8] 50.5 [4.8] [9.] 50.7 [4.9] [] 60.9 [7.9] [2] 57. [6.8] [22.0] 54.2 [5.9] [] 5.7 [5.2] [20.9] 49.8 [4.6] [20.4] 48. [4.2] [9.9] 47.5 [.9] [9.4] 47. [.8] [8.9] 47.4 [.9] [24.] 8 [24.] [2.7] 80.8 [2.7] [2.] 78.7 [2.] [2] 76.7 [2] [] 74.7 [] [2.] 7 [2.] [20.8] 70.9 [20.8] [20.] 69. [20.] [9.7] 67. [9.7] [2] 7.7 [] [2] 69.9 [20.5] [] 66.6 [9.5] [2.] 6.9 [8.7] [20.6] 6.9 [8.2] [20.0] 60.4 [7.7] [9.5] 59.4 [7.4] [9.0] 59.0 [7.] [8.5] 59.2 [7.4] [2] 69.0 [20.2] [] 65.5 [9.2] [2.] 6 [8.] [20.7] 59.9 [7.6] [20.2] 57.9 [7.0] [9.7] 56.5 [6.6] [9.2] 55.6 [6.] [8.7] 55. [6.2] [8.2] 55.5 [6.] 6.8 D Depression ratio dbe Entering air dry bulb wbe Entering air wet bulb Total Total capacity x 000 BTUH Sens Sensible capacity x 000 BTUH KW input NOTES: ➀ When the entering air dry bulb is other than 80 F [27 C], adjust the sensible capacity from the table by adding [.0 x CFM x ( D) x (dbe 80)]. HEATING PEFOMANCE DATA TZCHC-72 IDB CFM [L/s] 0 O UT [-7.8] 5 [26.7] D O O D Y B U LB T E M PE AT U E F [ C] 0 [-] 5 [] 20 [-6.6] 25 [7.8] 0 [-.] 5 [4.] 40 [4.4] 45 [46.] 50 [0] 60 F [5.5 C] 70 F [2. C] 80 F [26.7 C] 2880 [59] 225 [00] 920 [906] 2880 [59] 225 [00] 920 [906] 2880 [59] 225 [00] 920 [906] 26.0 [7.6] [8.9] [0.] [.6] [] [4.2] [5.6] [6.9] [8.2] [9.5] [20.9] [7.4] [8.7] [0.0] [.] [] [.9] [5.2] [6.5] [7.8] [9.] [20.4] [7.4] [8.7] [0.0] [.] [] [.8] [5.] [6.4] [7.7] [8.9] [20.2] [7.2] [8.5] [9.8] [.] 7. 4 [] [.8] [5.] [6.4] [7.8] [9.] [20.4] [7.0] [8.] 8.2 [9.6] [0.9] [] [.5] [4.7] [6.] [7.] [8.6] [9.9] [6.9] [8.2] 8. [9.5] [0.8] [2.] [.4] [4.7] [5.9] [7.2] [8.5] [9.8] [6.7] [8.0] [9.4] [0.7] [2.0] [.] [4.7] [6.0] [7.] [8.6] [20.0] [6.6] [7.9] [9.] [0.4] [.7] [] [4.] [5.6] [6.9] [8.2] [9.5] [6.5] [7.8] 8. [9.] [0.] [.6] [] [4.2] [5.5] [6.8] [8.] [9.] 4.8 IDB Indoor air dry bulb 8

19 AIFLOW PEFOMANCE TZCHC- SEIES DIECT-DIVE BLOWE 208 AIFLOW PEFOMANCE Nominal Cooling Capacity Tons [kw] Factory Motor Speed Manufacturer ecommended Air-Flow ange (Min/Max) CFM Blower Size/ Motor HP [w] & # of Speeds Motor Speed CFM [L/s] Air Delivery/PM/Watts 208 Volts Side Discharge Wet Coil External Static Pressure Inches W.C. [kpa] 0. [.02] 0.2 [.05] 0. [.07] 0.4 [.0] 0.5 [.2] 0.6 [.5] 0.7 [.7] 0.8 [.20] 0.9 [.22].0 [.25] [0.55] 0x0 Low 050/50 /2 HP [7] Low Speed Motor CFM 275 [602] 25 [58] 20 [57] 8 [557] 2 [54] 045 [49] Watts [2.0] Low 225/575 0x0 /2 HP [7] Speed Motor Med CFM 97 [659] 44 [64] 9 [622] 297 [62] 249 [589] 47 [54] Watts [4.07] Low 400/800 0x0 /2 HP [7] Speed Motor High CFM 766 [8] 79 [8] 67 [789] 67 [76] 550 [72] 465 [69] Watts [7.6] Low 750/2250 x9 HP [746] 2 Speed Motor Low High CFM 974 [92] 95 [9] 897 [895] 860 [878] 82 [860] 788 [844] 75 [827] Watts CFM 285 [0] 248 [04] 22 [997] 2076 [980] 2040 [96] 2005 [946] 970 [90] 79 [8] 95 [9] Watts [796] 900 [897] DIECT-DIVE BLOWE 20/460 AIFLOW PEFOMANCE Nominal Cooling Capacity Tons [kw] [0.55].5 [2.0] 4.0 [4.07] Factory Motor Speed Med. High Manufacturer ecommended Air-Flow ange (Min/Max) CFM 225/ /800 Blower Size/ Motor HP [w] & # of Speeds 0x0 /2 HP [7] Speed Motor 0x0 /2 HP [7] Speed Motor Motor Speed 0x0 Low 050/50 /2 HP [7] Speed Low Motor Med Med CFM 964 [927] 902 [898] 89 [868] 77 [86] CFM [L/s] Air Delivery/PM/Watts 20/460 Volts Side Discharge Wet Coil External Static Pressure Inches W.C. [kpa] 0. [.02] 0.2 [.05] 0. [.07] 0.4 [.0] 0.5 [.2] 0.6 [.5] 0.7 [.7] CFM 455 [687] 42 [672] 88 [655] 45 [65] 289 [608] 24 [57] Watts CFM 60 [756] 56 [77] 57 [76] 466 [692] 40 [66] 7 [622] Watts [799] 602 [756] Watts [.20] 0.9 [.22].0 [.25] *5.0* [7.6] Low 750/2250 x9 HP [746] 2 Speed Motor Low High CFM 974 [92] 95 [9] 897 [895] 860 [878] 82 [860] 788 [844] 75 [827] Watts CFM 285 [0] 248 [04] 22 [997] 2076 [980] [96] 2005 [946] 970 [90] 79 [8] [9] Watts [796] 900 [897] *There is not a 5-ton 460 Volt Direct Drive. 9

20 AIFLOW PEFOMANCE TZCHC- SEIES BELT-DIVE AIFLOW PEFOMANCE Air Flow CFM [L/s] Models TZCHC-6 [0.55 kw] & A042 [2. kw] Heat Pump ( SEE) Voltage 208/ Phase External Static Pressure Inches of Water [kpa] 0. [.02] 0.2 [.05] 0. [.07] 0.4 [.0] 0.5 [.2] 0.6 [.5] 0.7 [.7] 0.8 [.20] 0.9 [.22].0 [.25]. [.27].2 [.0]. [.2].4 [.5].5 [.7] PM W PM W PM W PM W PM W PM W PM W PM W PM W PM W PM W PM W PM W PM W PM W 900 [425] [472] [59] [566] [64] [66] [708] [755] [802] [850] NOTE: Bold lines separate L, M and N drives respectively. Drive Package L M N (Field-Supplied) Motor H.P. [w] /2 [7] (/4 [559] - 575V) /4 [559] /4 [559] Blower Sheave 6.9 Pitch Diameter 6.4 Pitch Diameter 6.4 Pitch Diameter Motor Sheave Adjustable -.4 Pitch Diameter Adjustable Pitch Diameter Adjustable Pitch Diameter Turns Open PM PM ange Factory sheave settings are shown in bold print. BELT-DIVE AIFLOW PEFOMANCE Models TZCHC-48 [4.06 kw] Heat Pump ( SEE) Air Voltage 208/ Phase Flow External Static Pressure Inches of Water [kpa] CFM [L/s] 0. [.02] 0.2 [.05] 0. [.07] 0.4 [.0] 0.5 [.2] 0.6 [.5] 0.7 [.7] 0.8 [.20] 0.9 [.22].0 [.25]. [.27].2 [.0]. [.2].4 [.5].5 [.7] PM W PM W PM W PM W PM W PM W PM W PM W PM W PM W PM W PM W PM W PM W PM W 200 [566] [64] [66] [708] [755] [802] [850] [897] [944] NOTE: Bold lines separate L, M and N drives respectively. Drive Package L M N (Field-Supplied) Motor H.P. [w] /2 [7] (/4 [559] - 575V) /4 [559] /4 [559] Blower Sheave 6.9 Pitch Diameter 6.4 Pitch Diameter 6.4 Pitch Diameter Motor Sheave Adjustable -.8 Pitch Diameter Adjustable Pitch Diameter Adjustable Pitch Diameter Turns Open PM PM ange Factory sheave settings are shown in bold print. Note: See component air resistance table in this manual. 20

21 AIFLOW PEFOMANCE TZCHC- SEIES BELT-DIVE AIFLOW PEFOMANCE Air Flow CFM [L/s] Model TZCHC-60 [7.58 kw] Heat Pump ( SEE) Voltage 208/ Phase External Static Pressure Inches of Water [kpa] 0. [.02] 0.2 [.05] 0. [.07] 0.4 [.0] 0.5 [.2] 0.6 [.5] 0.7 [.7] 0.8 [.20] 0.9 [.22].0 [.25]. [.27].2 [.0]. [.2].4 [.5].5 [.7] PM W PM W PM W PM W PM W PM W PM W PM W PM W PM W PM W PM W PM W PM W PM W 400 [66] [708] [755] [802] [850] [897] [944] [99] [08] [085] [] NOTE: L-Drive left of bold line, M-Drive right of bold line. Drive Package L M Motor H.P. [w] /4 [559] [746] Blower Sheave 6.4 Pitch Diameter 6.4 Pitch Diameter Motor Sheave Adjustable -.8 Pitch Diameter Adjustable Pitch Diameter Turns Open PM Factory sheave settings are shown in bold print. COMPONENT AI ESISTANCE Component Standard Indoor Airflow CFM [L/s] 000 [472] 200 [566] 400 [66] 600 [755] 800 [850] 2000 [944] 2200 [08] 2400 [] esistance Inches Water [kpa] Wet Coil Downflow Economizer.A. Damper NOTES:. Performance shown with dry coil, standard " [25.4 mm] filters & side discharge. Add component resistance to determine total E.S.P. 2. Standard lbs./cu. ft.. Motor efficiency = 80% 4. BHP = Watts x Motor Eff

22 AIFLOW PEFOMANCE TZCHC- SEIES AIFLOW PEFOMANCE 6 TON [2. kw] SIDEFLOW Air Flow CFM [L/s] Model TZCHC-72 Voltage 208/ Phase External Static Pressure Inches of Water [kpa] 0. [.02] 0.2 [.05] 0. [.07] 0.4 [.0] 0.5 [.2] 0.6 [.5] 0.7 [.7] 0.8 [.20] 0.9 [.22].0 [.25]. [.27].2 [.0]. [.2].4 [.5].5 [.7] PM W PM W PM W PM W PM W PM W PM W PM W PM W PM W PM W PM W PM W PM W PM W 900 [897] [944] [99] [08] [085] [] [80] [227] [274] [2] [68] NOTE: L-Drive left of bold line, M-Drive right of bold line. Drive Package L M Motor H.P. [w].5 [8.5].5 [8.5] Blower Sheave AK66 AK59 Motor Sheave VP-44 VP-50 Turns Open PM NOTES:. Factory sheave settings are shown in bold type. 2. Do not set motor sheave below minimum or above maximum turns open shown.. e-adjustment of sheave required to achieve rated airflow at AI minimum External Static Pressure 4. Drive data shown is for horizontal airflow with dry coil. Add component resistance (below) to duct resistance to determine total External Static Pressure. COMPONENT AI ESISTANCE 6 TON [2. kw] Wet Coil Downflow Component Downflow Economizer A Damper Open Horizontal Economizer A Damper Open Concentric Grill XN-FA65 or XN-FA75 & Transition XMC-CC04 Standard Indoor Airflow CFM [L/s] 900 [897] 2000 [944] 200 [99] 2200 [08] 200 [085] 2400 [] 2500 [80] 2600 [227] esistance Inches Water [kpa] [.0] [.0] [.02] [.02] [.02] [.02] [.02] [.02] [.0] [.0] [.0] [.0] [.02] [.02] [.02] [.02] 2700 [274] [.02] [.02] [.02] [.02] [.02] [.02] [.02] [.0] [.0] [.0] [.02] [.02] [.02] [.02] [.02] [.02] [.02] [.0] [.0] [.0] [.02] [.02] [.02] [.02] [.0] [.0] [.04] [.04] [.05] [.05] 0. [.0] 0.09 [.02] [2] 0. [.0] 0.0 [.02] [68] 0.2 [.0] 0.0 [.02] 0.2 [.0] 0.2 [.0] 0.2 [.06] 22

23 ELECTICAL DATA TZCHC- SEIES Unit Information Compressor Motor Condenser Motor Evaporator Fan Unit Operating Voltage ange Minimum Circuit Ampacity 9/9 Minimum Overcurrent Protection Device Size Maximum Overcurrent Protection Device Size 25/25 25/25 No. Volts 208/20 Phase HP PM 450 Amps (LA) 0.4/0.4 Amps (LA) 88/88 No. Volts 208/20 Phase HP / Amps (FLA).5 Amps (LA) No. Volts 208/20 Phase HP /2 Amps (FLA) /9 25/25 25/25 208/20 /.5 208/20 /4.2 Amps (LA) / /0.4 88/88 ELECTICAL DATA TZCHC SEIES 6CK 6CM 6DK 6DM 6JK 42CK 42CM 42DK 42DM 42JK 48CK / / Horsepower Per Compressor. 2. Amp Draw Per Motor. Multiply Value By Number of Motors to Determine Total Amps / / /27 5/5 40/40 208/ /6.7 79/79 208/20 /.5 208/20 / /2 0/0 5/5 208/ /.5 88/88 208/20 /.5 208/20 / /22 0/0 5/5 208/ /.5 88/88 208/20 /.5 208/20 / / / / / /28 5/5 45/45 208/ /7.9 2/2 208/20 /.5 208/20 / /2 0/0 5/5 208/ /.7 8./8. 208/20 /.5 208/20 /

24 ELECTICAL DATA TZCHC- SEIES Unit Information Compressor Motor Condenser Motor Evaporator Fan Unit Operating Voltage ange Minimum Circuit Ampacity Minimum Overcurrent Protection Device Size Maximum Overcurrent Protection Device Size 2/2 0/0 5/5 No. Volts 208/20 Phase HP.5 PM 450 Amps (LA).7/.7 Amps (LA) /8. No. Volts 208/20 Phase HP / Amps (FLA).5 Amps (LA) No. Volts 208/20 Phase HP /4 Amps (FLA).2 Amps (LA) ELECTICAL DATA TZCHC SEIES / / Horsepower Per Compressor. 2. Amp Draw Per Motor. Multiply Value By Number of Motors to Determine Total Amps. 48CM 48DK 48DM 48JK 60CK 60CM 60DM 60JK / / / 40/40 50/50 208/ / 7/7 208/20 /.5 208/20 / /25 0/0 40/40 208/ /6 0/0 208/20 / / /26 0/0 40/40 208/ /6 0/0 208/20 / / / /9 45/45 60/60 208/ /26.4 4/4 208/20 / /

25 ELECTICAL DATA TZCHC- SEIES Unit Information Compressor Motor Condenser Motor Evaporator Fan Unit Operating Voltage ange Minimum Circuit Ampacity Minimum Overcurrent Protection Device Size Maximum Overcurrent Protection Device Size ELECTICAL DATA TZCHC SEIES 4/4 40/40 50/50 No. Volts 208/20 Phase HP 450 PM 7 /2 Amps (LA) / Amps (LA) /2 No. Volts 208/20 Phase HP / Amps (FLA).8/.8 Amps (LA)./. No. Volts 208/20 Phase HP /2 Amps (FLA) 5.8/ /20 /2 5.8/5.8 Amps (LA) 4/4 4/4. Horsepower Per Compressor. 2. Amp Draw Per Motor. Multiply Value By Number of Motors to Determine Total Amps. 72CL 72CM 72DM /4 40/40 50/50 208/ /2 / 2/2 208/20 /.8/.8./ Volts 208/20 208/ / / 460 /2 7 25

26 UNITS WITH HEATE KITS TZCHC- SEIES 6JK 42JK 48JK 60JK Model No. TZCHC- XJJ- Heater Kit Nominal kw VOLT, THEE PHASE, 60 HZ, AUXILIAY ELECTIC HEATE KITS CHAACTEISTICS AND APPLICATION Single Supply For Both Unit and Heater Kit Separate Supply For Both Unit and Heater Kit ated Heater V Heater V Heater V Unit Min. Ckt V Over Current Protective Device V No Heat 27/27 5/40 5/40 A06J+ 4.2/5.6 4./ /2. 52/56 60/60 60/60 A0J+ 7.2/ /5 4.7/ /77 70/70 80/80 *AJ+* 7.2/ /5 4.7/ /77 70/70 80/80 A2J+ 8.4/ / / /85 80/80 90/90 A5J+ 0.8/ / / /02 00/00 0/0 A20J+ 4.4/ / /80.0 /27 25/25 50/50 *A2J+* 4.4/ / /80.0 /27 25/25 50/50 No Heat 28/28 5/45 5/45 A06J+ 4.2/5.6 4./ /2. 54/58 60/60 60/60 A0J 7.2/ /5 4.7/ /78 80/80 80/80 *AJ+* 7.2/ /5 4.7/ /78 80/80 80/80 A2J+ 8.4/ / / /87 80/80 90/90 A5J 0.8/ / /60.0 9/0 00/00 0/0 A20J+ 4.4/ / /80.0 5/28 25/25 50/50 *A2J+* 4.4/ / /80.0 5/28 25/25 50/50 No Heat / 40/50 40/50 A06J+ 4.2/5.6 4./ /2. 58/62 60/70 70/70 A0J+ 7.2/ /5 4.7/ /8 80/80 90/90 *AJ+* 7.2/ /5 4.7/ /8 80/80 90/90 A2J+ 8.4/ / / /92 90/90 00/00 A5J 0.8/ / / /08 00/00 0/0 A20J 4.4/ / / / 25/25 50/50 *A2J+* 4.4/ / / / 25/25 50/50 No Heat 9/9 45/60 45/60 A06J+ 4.2/5.6 4./ /2. 64/68 70/80 70/80 A0J+ 7.2/ /5 4.7/ /89 90/90 90/00 *AJ+* 7.2/ /5 4.7/ /89 90/90 90/00 A2J+ 8.4/ / / /97 90/00 00/0 A5J 0.8/ / / /4 0/0 25/25 A20J 4.4/ / / /9 25/25 50/50 *A2J+* 4.4/ / / /9 25/25 50/50 Heater Kit Min. Ckt. Ampacity Heater Kit Max. Fuse Size Heat Pump Min. Ckt. Ampacity V Heat Pump Over Current Protective Device V 27/27 5/40 5/40 26/0 0/0 44/50 45/50 44/50 45/50 5/59 60/60 65/75 70/80 87/00 90/00 87/00 90/00 28/28 5/45 5/45 26/0 0/0 44/50 45/50 44/50 45/50 5/59 60/60 65/75 70/80 87/00 90/00 87/00 90/00 / 40/50 40/50 26/0 0/0 44/50 45/50 44/50 45/50 5/59 60/60 65/75 70/80 87/00 90/00 87/00 90/00 9/9 45/60 45/60 26/0 0/0 44/50 45/50 44/50 45/50 5/59 60/60 65/75 70/80 87/00 90/00 87/00 90/00 + Field Installed Only * = For Canadian Use Only. Uses P Fuses for Inductive Circuit. 26

27 UNITS WITH HEATE KITS TZCHC- SEIES 6CK 42CK 48CK 60CK Model No. TZCHC- XJJ- Heater Kit Nominal kw VOLT, THEE PHASE, 60 HZ, AUXILIAY ELECTIC HEATE KITS CHAACTEISTICS AND APPLICATION Single Supply For Both Unit and Heater Kit Separate Supply For Both Unit and Heater Kit ated Heater V Heater V Heater V Unit Min. Ckt V Over Current Protective Device V No Heat 9/9 25/25 25/25 A06C+ 4.2/5.6 4./9.0.7/.5 4/6 5/40 40/40 A0C+ 7.2/ /5 20.0/2. 44/48 45/45 50/50 *AC+* 7.2/ /5 20.0/2. 44/48 45/45 50/50 A2C+ 8.4/ / / /5 50/50 60/60 A5C+ 0.8/ /49. 0./4.7 57/62 60/60 70/70 A20C+ 4.4/ / / /77 70/70 80/80 *A2C+* 4.4/ / / /77 70/70 80/80 No Heat 2/2 0/5 0/5 A06C+ 4.2/5.6 4./9.0.7/.5 8/40 40/45 0/45 A0C+ 7.2/ /5 20.0/2. 48/52 50/50 60/60 *AC+* 7.2/ /5 20.0/2. 48/52 50/50 60/60 A2C+ 8.4/ / / /57 60/60 60/60 A5C+ 0.8/ /49. 0./4.7 6/66 70/70 70/70 A20C+ 4.4/ / /46.2 7/8 80/80 90/90 *A2C+* 4.4/ / /46.2 7/8 80/80 90/90 No Heat 2/2 0/5 0/5 A06C+ 4.2/5.6 4./9.0.7/.5 8/40 40/45 0/45 A0C+ 7.2/ /5 20.0/2. 48/52 50/50 60/60 *AC+* 7.2/ /5 20.0/2. 48/52 50/50 60/60 A2C+ 8.4/ / / /57 60/60 60/60 A5C+ 0.8/ /49. 0./4.7 6/67 70/70 70/70 A20C+ 4.4/ / /46.2 7/8 80/80 90/90 *A2C+* 4.4/ / /46.2 7/8 80/80 90/90 No Heat 25/25 0/40 0/40 A06C+ 4.2/5.6 4./9.0.7/.5 40/42 50/50 45/50 A0C+ 7.2/ /5 20.0/2. 50/54 50/60 60/60 *AC+* 7.2/ /5 20.0/2. 50/54 50/60 60/60 A2C+ 8.4/ / / /59 60/60 60/60 A5C+ 0.8/ /49. 0./4.7 6/69 70/70 70/70 A20C+ 4.4/ / / /8 80/80 90/90 *A2C+* 4.4/ / / /8 80/80 90/90 Heater Kit Min. Ckt. Ampacity Heater Kit Max. Fuse Size Heat Pump Min. Ckt. Ampacity V Heat Pump Over Current Protective Device V 9/9 25/25 25/25 5/7 5/20 25/29 25/0 25/29 25/0 0/4 0/5 8/44 40/45 50/58 50/60 50/58 50/60 2/2 0/5 0/5 5/7 5/20 25/29 25/0 25/29 25/0 0/4 0/5 8/44 40/45 50/58 50/60 50/58 50/60 2/2 0/5 0/5 5/7 5/20 25/29 25/0 25/29 25/0 0/4 0/5 8/44 40/45 50/58 50/60 50/58 50/60 25/25 0/40 0/40 5/7 5/20 25/29 25/0 25/29 25/0 0/4 0/5 8/44 40/45 50/58 50/60 50/58 50/60 72CL Model No. TZCHC- XJJ- Heater Kit Nominal kw VOLT, THEE PHASE, 60 HZ, AUXILIAY ELECTIC HEATE KITS CHAACTEISTICS AND APPLICATION Single Supply For Both Unit and Heater Kit Separate Supply For Both Unit and Heater Kit ated Heater V Heater V Heater V Unit Min. Ckt V Over Current Protective Device V No Heat 4/4 40/50 40/50 A5C 0.8/ /49. 0./4.7 72/78 80/80 80/80 A20C 4.4/ / / /92 90/90 00/00 A24C 8/24 6.4/ / /07 00/00 0/0 Heater Kit Min. Ckt. Ampacity Heater Kit Max. Fuse Size Heat Pump Min. Ckt V Heat Pump Over Current Protective Device V 4/4 40/50 40/50 8/44 40/45 5/58 60/60 6/7 70/80 + Field Installed Only * = For Canadian Use Only. Uses P Fuses for Inductive Circuit. 27

28 UNITS WITH HEATE KITS TZCHC- SEIES 6CM 42CM 48CM 60CM 72CM Model No. TZCHC- XJJ- Heater Kit Nominal kw VOLT, THEE PHASE, 60 HZ, AUXILIAY ELECTIC HEATE KITS CHAACTEISTICS AND APPLICATION Single Supply For Both Unit and Heater Kit Separate Supply For Both Unit and Heater Kit ated Heater V Heater V Heater V Unit Min. Ckt V Over Current Protective Device V No Heat 8/8 25/25 25/25 A06C+ 4.2/5.6 4./9.0.7/.5 /5 5/40 0/40 A0C+ 7.2/ /5 20.0/2. 4/47 45/45 50/50 *AC+* 7.2/ /5 20.0/2. 4/47 45/45 50/50 A2C+ 8.4/ / / /52 50/50 60/60 A5C+ 0.8/ /49. 0./4.7 56/62 60/60 70/70 A20C+ 4.4/ / / /76 70/70 80/80 *A2C+* 4.4/ / / /76 70/70 80/80 No Heat 22/22 0/5 0/5 A06C+ 4.2/5.6 4./9.0.7/.5 7/9 40/45 40/45 A0C+ 7.2/ /5 20.0/2. 47/5 50/50 60/60 *AC+* 7.2/ /5 20.0/2. 47/5 50/50 60/60 A2C+ 8.4/ / / /56 60/60 60/60 A5C+ 0.8/ /49. 0./4.7 60/66 60/60 70/70 A20C+ 4.4/ / / /80 80/80 80/80 *A2C+* 4.4/ / / /80 80/80 80/80 No Heat 2/2 0/5 0/5 A06C+ 4.2/5.6 4./9.0.7/.5 7/9 40/45 40/45 A0C+ 7.2/ /5 20.0/2. 48/5 50/50 60/60 *AC+* 7.2/ /5 20.0/2. 48/5 50/50 60/60 A2C+ 8.4/ / / /56 60/60 60/60 A5C+ 0.8/ /49. 0./4.7 60/66 60/60 70/70 A20C+ 4.4/ / /46.2 7/80 80/80 80/80 *A2C+* 4.4/ / /46.2 7/80 80/80 80/80 No Heat 26/26 0/40 0/40 A06C+ 4.2/5.6 4./9.0.7/.5 4/4 45/50 45/50 A0C+ 7.2/ /5 20.0/2. 5/55 60/60 60/60 *AC+* 7.2/ /5 20.0/2. 5/55 60/60 60/60 A2C+ 8.4/ / / /60 60/60 60/60 A5C+ 0.8/ /49. 0./4.7 64/70 70/70 70/70 A20C+ 4.4/ / / /84 80/80 90/90 *A2C+* 4.4/ / / /84 80/80 90/90 No Heat 4/4 40/50 40/50 A5C+ 0.8/ /49. 0./4.7 72/78 80/80 80/80 A20C+ 4.4/ / / /92 90/90 00/00 A24C+ 8/24 6.4/ / /07 00/00 0/0 Heater Kit Min. Ckt. Ampacity Heater Kit Max. Fuse Size Heat Pump Min. Ckt V Heat Pump Over Current Protective Device V 8/8 25/25 25/25 5/7 5/20 25/29 25/0 25/29 25/0 0/4 0/5 8/44 40/45 50/58 50/60 50/58 50/60 22/22 0/5 0/5 5/7 5/20 25/29 25/0 25/29 25/0 0/4 0/5 8/44 40/45 50/58 50/60 50/58 50/60 2/2 0/5 0/5 5/7 5/20 25/29 25/0 25/29 25/0 0/4 0/5 8/44 40/45 50/58 50/60 50/58 50/60 26/26 0/40 0/40 5/7 5/20 25/29 25/0 25/29 25/0 0/4 0/5 8/44 40/45 50/58 50/60 50/58 50/60 4/4 40/50 40/50 8/44 40/45 5/58 60/60 6/7 70/80 + Field Installed Only * = For Canadian Use Only. Uses P Fuses for Inductive Circuit. 28

29 UNITS WITH HEATE KITS TZCHC- SEIES 6DK 42DK 48DK Model No. TZCHC- XJJ- Heater Kit Nominal kw 480 VOLT, THEE PHASE, 60 HZ, AUXILIAY ELECTIC HEATE KITS CHAACTEISTICS AND APPLICATION Single Supply For Both Unit and Heater Kit Separate Supply For Both Unit and Heater Kit ated Heater 480 V Heater 480 V Heater 480 V Unit Min. Ckt. 480 V Over Current Protective Device V No Heat 5 5 A06D A0D *AD+* A2D A5D A20D *A2D+* No Heat 5 5 A06D A0D *AD+* A2D A5D A20D *A2D+* No Heat 5 5 A06D A0D *AD+* A2D A5D A20D *A2D+* Heater Kit Min. Ckt. Ampacity Heater Kit Max. Fuse Size Heat Pump Min. Ckt. 480 V Heat Pump Over Current Protective Device V DL Model No. TZCHC- XJJ- Heater Kit Nominal kw 480 VOLT, THEE PHASE, 60 HZ, AUXILIAY ELECTIC HEATE KITS CHAACTEISTICS AND APPLICATION Single Supply For Both Unit and Heater Kit Separate Supply For Both Unit and Heater Kit ated Heater 480 V Heater 480 V Heater 480 V Unit Min. Ckt. 480 V Over Current Protective Device V No Heat 7 20/25 A5D /45 A20D /50 A24D /60 Heater Kit Min. Ckt. Ampacity Heater Kit Max. Fuse Size Heat Pump Min. Ckt. 480 V Over Current Protective Device V 7 20/ Field Installed Only * = For Canadian Use Only. Uses P Fuses for Inductive Circuit. 29

30 UNITS WITH HEATE KITS TZCHC- SEIES 6DM 42DM 48DM 60DM 72DM Model No. TZCHC- XJJ- Heater Kit Nominal kw 480 VOLT, SINGLE PHASE, 60 HZ, AUXILIAY ELECTIC HEATE KITS CHAACTEISTICS AND APPLICATION Single Supply For Both Unit and Heater Kit Separate Supply For Both Unit and Heater Kit ated Heater 480 V Heater 480 V Heater 480 V Unit Min. Ckt. 480 V Over Current Protective Device V No Heat A06D A0D *AD+* A2D A5D A20D *A2D No Heat 5 5 A06D A0D *AD+* A2D A5D A20D *A2D+* No Heat 5 5 A06D A0D *AD+* A2D A5D A20D *A2D+* No Heat 5 20 A06D A0D *AD+* A2D A5D A20D *A2D+* No Heat 7 20/25 A5D /45 A20D /50 A24D /60 + Field Installed Only * = For Canadian Use Only. Uses P Fuses for Inductive Circuit. Heater Kit Min. Ckt. Ampacity Heater Kit Max. Fuse Size Heat Pump Min. Ckt. Ampacity 480 V Heat Pump Over Current Protective Device V /

31 UNITS WITH HEATE KITS TZCHC- SEIES 72YL Model No. TZCHC- XJJ- Heater Kit Nominal kw 600 VOLT, THEE PHASE, 60 HZ, AUXILIAY ELECTIC HEATE KITS CHAACTEISTICS AND APPLICATION Single Supply For Both Unit and Heater Kit ated Heater 600 V Heater 600 V Heater 600 V Unit Min. Ckt. 600 V Over Current Protective Device V No Heat 4 5/20 A5Y /5 A20Y /40 A24Y /45 Heater Kit Min. Ckt. Ampacity Separate Supply For Both Unit and Heater Kit Heater Kit Max. Fuse Size Heat Pump Min. Ckt. Ampacity 600 V Heat Pump Over Current Protective Device V 4 5/ Field Installed Only * = For Canadian Use Only. Uses P Fuses for Inductive Circuit.

32 UNIT DIMENSIONS TZCHC- SEIES UNIT DIMENSIONS PACKAGE HEAT PUMPS -5 TON [ kw] 2

33 UNIT DIMENSIONS TZCHC- SEIES UNIT DIMENSIONS PACKAGE HEAT PUMPS -5 TON [ kw] BOTTOM VIEW

34 UNIT DIMENSIONS TZCHC- SEIES UNIT DIMENSIONS PACKAGE HEAT PUMPS 6 TON [2. kw] 4

35 UNIT DIMENSIONS TZCHC- SEIES UNIT DIMENSIONS PACKAGE HEAT PUMPS 6 TON [2. kw] 5

36 UNIT DIMENSIONS TZCHC- SEIES SELECTION POCEDUE. Determine cooling and heating requirements at design conditions. Example: Total cooling capacity...4,600 BTUH [8 kw] Sensible cooling capacity...4,000 BTUH [9.96 kw] Condenser entering air...95 F [5 C] Evaporator entering air...6 F [7 C] wb/76 F [24 C] db Indoor air flow CFM [755 L/s] External static pressure... in wg equired efficiency... SEE 2. Select unit to meet cooling requirements. Since total cooling is within the range of 4 ton [4.07 kw] unit and requires SEE efficiency level, enter cooling performance table, at 95 F [5 C] outdoor temperature, 6 F [7 C] wb entering indoor air, and 600 CFM [755 L/s]: Total capacity...46,700 BTUH [.68 kw] input... kw And also, at 76 F [24 C] db indoor entering air, and using the formula at the bottom of the page: Sensible capacity...,70 BTUH [9.87 kw]. Determine blower speed and power to meet the system requirements. At the given external static pressure of. in wg, the belt model must be selected. Enter the belt drive blower performance table at 600 CFM [755 L/s] and. in wg ESP: PM Watts Drive...M 4. Calculate indoor blower BTUH heat effect. BTUH = Watts x.4 = Calculate net cooling capacities. Net total cooling = 46, = 44,226 BTUH [6 kw] Net sensible cooling =, =.242 BTUH [9.6 kw] 6

37 UNIT DIMENSIONS TZCHC- SEIES WEIGHTS -5 Ton [ kw] 6 Ton [2. kw] Accessory Shipping Operating Shipping Operating lbs [kg] lbs [kg] lbs [kg] lbs [kg] Economizer with Single Enthalpy 70 [2] 60 [27] 80 [6] 70 [2] Exhaust 9 [9] 6 [7] 2 [0] 7 [8] Fresh Air Damper (Manual) [5] 9 [4] 4 [6] 2 [5] Fresh Air Damper (Motorized) [6] [5] 6 [7] 4 [6] oof Curb 4" 92 [42] 88 [40] 92 [42] 88 [40] oof Curb 24" 08 [49] 04 [47] 08 [49] 04 [47] Concentric Diffuser 8" Flush 7 [7] 26 [2] 7 [7] 26 [2] Concentric Diffuser 20" Flush 54 [24] 42 [9] 54 [24] 42 [9] Side Discharge Concentric Diffuser XN-FA60 5 [6] 20 [9] Side Discharge Concentric Diffuser XN-FA65 55 [25] 40 [8] 55 [25] 40 [8] CLEAANCES ( to 6 Ton [0.6 to 2. kw] Models) The following minimum clearances are recommended for proper unit performance and serviceability. ecommended Clearance in. [mm] 48 [29] A - Front Location 8 [457] B - Condenser Coil *2 [05] C - Duct Side 6 [94] D - Evaporator End 60 [524] E - Above *57" [448 mm] With Economizer NOTE: Supply duct may be installed with 0 inch clearance to combustible materials, provided " [25.4 mm] minimum. Fiberglass insulation is applied either inside or on the outside of the duct. CENTE OF GAVITY (C.G.) Capacity Tons [kw] A in. [mm] B in. [mm] -5 [ ] 8 /4 [972] 25 /4 [654] 6 [2.] 9 [99] 26 /8 [664] Capacity Tons [kw] Corner Weights by Percentage A B C D -5 [ ] 22% 27% 2% 28% 6 [2.] 2% 29% 2% 27% CLEAANCES to 6 Ton [0.6 to 2. kw] Models 7

38 ACCESSOIES TZCHC- SEIES ACCESSOY EQUIPMENT Model Number Description -5 Ton [ kw] 6 Ton [2. kw] Factory Installed (TZCHC-) (TZCHC-) XJJ-A06* (J,C,D) XJJ-A0* (J,C,D) XJJ-A* (J,C,D) Electric Heater Kits XJJ-A2* (J,C,D) XJJ-A5* (C,D,Y) XJJ-A20* (C,D,Y) See Heater Kit XJJ-A5* (J,C,D) XJJ-A24* (C,D,Y) Electric Table XJJ-A20* (J,C,D) XJJ-A2* (J,C,D) XJJ-A24* (J,C,D) oofcurb 4" XKG-CAD4 XKG-CAD4 No oofcurb 24" XKG-CAD24 XKG-CAD24 No XX-BBCDB2 oofcurb Adaptors XX-BBCDB22 XX-BBCDB2 N/A No Economizer with Single Enthalpy XD-MECM XD-MCCM Yes Dual Enthalpy Kit XX-AV02 XX-AV02 No CO2 Sensor XX-A02 XX-A02 No Exhaust XX-BGF04* (C or D) (use C for J voltage) XX-BGF0* (C,D,Y) Fresh Air Damper Manual XF-FBA XF-FCA No Fresh Air Damper Motorized XF-FBB XF-FCB No ectangular to ound 8" Duct Adaptors for Concentric Diffuser XMC-CB0 N/A No ectangular to ound 20" Duct Adaptors for Concentric Diffuser Concentric Diffuser 8" Step (Side discharge) XMC-CB04 XMC-CC04 No XN-FA60 N/A No Concentric Diffuser 20" Step (Side discharge) XN-FA65 XN-FA65 No Concentric Diffuser 8" Flush XN-FA70 N/A No Concentric Diffuser 20" Flush XN-FA75 XN-FA75 No ectangular to ound 6" Side XMC-BB0 N/A No Louver Kit ( Sides) XX-AAD0B XX-AAD0B Yes Time Delay XMS-B0 N/A Yes Low Ambient Control to 0 F [-8ºC] XPZ-G0 XPZ-G0 Yes *Voltage NOTES: ➀ Economizer is designed for downflow J = VAC-PH-60HZ D = 460 VAC-PH-60HZ or horizontal applications. C = VAC-PH-60HZ Y = 575 VAC-PH-60HZ No 8

39 ACCESSOIES TZCHC- SEIES oofcurb Adapters Old Models OLD CUB MODEL OOFCUB ADAPTE NEW MODEL MEDIUM CABINET ( TON [ kw]) 2 SEIES XPA-CA2 () XA-DB2 (2) XX-BBCDB2 LAGE CABINET (-.5 TON [-2 kw]) 22 SEIES XPA-CA22 () XA-DB22 (2) XX-BBCDB22 TZCHC- EXTA LAGE CABINET (.5-5 TON [2-8 kw]) 2 SEIES XPA-CA2 () XA-DB2 (2) XX-BBCDB2 () SLOPE TYPE (2) FULL PEIMETE TYPE Field Installed esistance Heater Kits Electric Heater Kits are designed for field installation using either single-point power wiring or dual circuit wiring. Low voltage plugs are provided to allow for quick connection to the unit. emoving a blockoff panel on the unit allows the heater elements to be inserted into the supply air down stream from the indoor coil and supply air blower. Model Number Identifier: X J J A 5 C Electrical Designation J = V, PH, 60 Hz C = V, PH, 60 Hz D = 460 V, PH, 60 Hz Y = 575 V, PH, 60 Hz Nominal Heater kw 06 = 6 kw 5 = 5 kw 0 = 0 kw 20 = 20 kw = kw * 2 = 2 kw * 2 = 2 kw 24 = 24 kw * Canadian Models Only Design Series A = Initial Design Accessory Designation J = Electric Heater Accessory Classification J = Package Heat Pump X = Accessory = Trade Name 9

40 ACCESSOIES TZCHC- SEIES OOFCUBS (Full Perimeter) Thermal Zone s new roofcurb design can be utilized on through 6 ton [ kw] models. Two available heights (4" [56 mm] and 24" [60 mm]) for ALL models. Quick assembly corners for simple and fast assembly. TYPICAL INSTALLATION Opening provided in bottom pan to match the Thru the Curb electrical connection opening provided on the unit base pan. 2" [5 mm] x 4" [02 mm] Nailer provided. Insulating panels provided. Sealing gasket (28" [7 mm]) provided with oofcurb. Packaged for easy field assembly. oofcurb Model XKG-CAD4 XKG-CAD24 Height of Curb 4" [56 mm] 24" [60 mm] 40

41 ACCESSOIES TZCHC- SEIES OOFCUBS (Cont.) OOFCUB CONFIGUATION FO -5 TON [ kw] MODELS OOFCUB CONFIGUATION FO 6 TON [2. kw] MODELS Note: oofcurb kits are the same for all models. (Figures above show locations for cross members that are model specific) 4