INSTALLATION INSTRUCTIONS

Size: px
Start display at page:

Download "INSTALLATION INSTRUCTIONS"

Transcription

1 INSTALLATION INSTRUCTIONS Accessory FABRIC FRONT DOORS P/N 0SR90-HL4-211A (BLACK) P/N 0SR90-HL4-221A (CAMO) Application SXS1000M3/M3P/M5P/M5D Honda Dealer: Please give a copy of these instructions to your customer. Publication No. MII Issue Date October 2015 PARTS LIST (1) (2) (3) (4) (5) (6) (7) (8) (9) (10) (11) (11) 2015 American Honda Motor Co., Inc - All Rights Reserved. 0SR90-HL4-211A & 0SR90-HL4-221A 1 of 11

2 No. Description Qty (1) Handle 2 (2) 6 mm washer 2 (3) 6 x 45 mm torx bolt 2 (4) Jacknut 10 (5) 6 x mm bolt 1 (6) 8 mm flange nut 1 (7) 6 x 25 mm flange bolt 16 (8) Threadlocker and alcohol pad 1 ea. (9) Outer door bracket 4 (10) Left and Right door filler 1 ea. (11) Front door (Right and Left) 1 ea. (12) Installation Instruction URL (not shown) 1 TOOLS AND SUPPLIES REQUIRED Gloves Safety goggles Awl Power drill Drill bits (7 mm, 9.5 mm, 11.5 mm) Open-end wrench (10 mm, 13 mm) Hex wrench (4 mm) Torx wrench (T30) Sockets (10 mm, 13 mm, T30 Driver) Torque wrench TORQUE CHART Tighten all screws, bolts, and nuts to their specified torque values. Refer to the Service Manual for the torque values of the removed parts. Item N m kgf m lbf ft 6 mm fasteners USE AND CARE INFORMATION Completely read and understand the instructions before installing this accessory. Do not tow the vehicle on an open trailer with this accessory installed, as the accessory is not designed for use at highway speeds. To clean, sponge with mild soap and cold water, rinse with a hose and allow it to drip-dry. Do not machine wash or dry. Use mild detergent to remove stubborn stains. Do not force the zipper on window. In case of a jam, unzip and remove any obstructions. If problems persist, the zipper must be cleaned. The zipper should be cleaned using a toothbrush with soap and water and rinsed as needed to keep it free of dust and dirt. Once the zipper is cleaned, the teeth should be lubricated with beeswax. NOTICE: If the vehicle is equipped with color panels on the front doors, refer to the Service Manual for the vehicle and remove them. Apply thread locker to the 16 6 x 25 mm bolts and the two 6 x 45 mm bolts following the instructions on the packet. The adhesive loop fastener must be applied at room temperature and given at least 60 minutes to cure before use. INSTALLATION 1. If the vehicle is equpipped with a 2-piece windscreen, trim the left and right door fillers using scissors. Note the placement of the magnet and be sure to avoid cutting into it. MAGNET Jacknut Cut out if equipped with a 2-piece windscreen. 2 of 11 0SR90-HL4-211A & 0SR90-HL4-221A 2015 American Honda Motor Co., Inc - All Rights Reserved.

3 B A 2. Remove the trim clips from the front side cover holes closest to the front A-pillar as shown. 3. Install the left and right door fillers between the A-pillar and the front side cover: Fold the lower portion of the door filler to sit underneath the front side cover, so the front portion sits behind the A-pillar as shown. Secure the door filler to the A-pillar with the hook and loop strap. Reinstall the trim clip through the door filler as shown. Be sure the side net buckle (not shown) is free and to the inside of the door filler. TRIM CLIP A-PILLAR HOOK AND LOOP STRAP DOOR FILLER 4. Drill holes into the lower doors: Cut out the drilling templates from pages 7, 9, and 11. Tape the Door, Inside Drill Templates to the inside of the left door as shown. Using an awl, mark the door at the center of each cross-hair. Tape the Door, Outside Drill Templates to the outside of the left door as shown. Using an awl, mark the door at the center of each cross hair. Close the lower door. Align the left fabric door inside of the vehicle cab frame, on top of the lower door, as it will be installed. Verify that all marked hole centers on the interior of the door line up with the centers of the slots on the door brackets. Remove the fabric door. Remove the drill templates from the left door, turn them over and apply them to the right door. Mark and verify the right door following the steps above. Drill 11.5 mm holes at the marked points on the outside of each door. Drill 9.5 mm holes at the upper row marked points of the inside of each door. Drill 7 mm holes at the lower row marked points of the inside of each door. LEFT DOOR SHOWN: <DOOR, INSIDE DRILL TEMPLATE> Drill 9.5 mm holes. FRONT SIDE COVER Align with B Align with A This side up for LHS This side up for LHS door or drill templ ate B HL4 door drill template B HL4 door drill template pate A Drill 7 mm holes. <DOOR, OUTSIDE DRILL TEMPLATE> B B A A This side up for LHS This side up This side up for LHS Drill 11.5 mm holes American Honda Motor Co., Inc - All Rights Reserved. 0SR90-HL4-211A & 0SR90-HL4-221A 3 of 11

4 5. Install the jacknuts: Apply a tapping/cutting or general use oil to the threads of the jacknut. Press the jacknut into the 9.5 mm hole on the inside of the door. Align the 8mm flange nut over the jacknut with the flange down. Thread the 6 x mm bolt through the flange nut and into the jacknut until it is finger tight. Tighten the bolt to the jacknut torque value specified in the Torque Chart. Use a wrench to keep the flange nut from spinning and ensure that the jacknut is seated against the plastic. Remove the 6 x mm bolt. Repeat for each 9.5 mm hole in both doors (four jacknuts total per door). 6. Loosely install a 6 x 25 mm flange bolt into each jacknut, leaving at least 4 mm between the head of the bolt and the jacknut. Install the two spacer plates from the outside of the door and loosely secure them with the 6 x 25 mm flange bolts from the inside. 7. Install the fabric door onto the lower door by pushing the brackets onto the head of each 6 x 25 mm flange bolt, through the keyhole slots in the brackets. Seat the fabric door down on top of the lower door and tighten all the 6 x 25 mm bolts on each door. 8. The rear section of the fabric door frame has a through-hole for a 6 mm bolt. Mark the top edge of the lower door through the center of this hole with a transfer punch or similar. Loosen the 6 x 25 mm flange bolts and remove the fabric door. 9. Drill a 9.5 mm hole into the top edge of the lower door at the marked point. 10. Install a jacknut into the hole using the same process as in Step 5. Reinstall the fabric door and tighten the flange bolts. Install a 6 x 45 torx bolt and 6 mm washer through the hole in the fabric door frame as shown. 6 x 45 mm TORX BOLT WASHER JACKNUT SPACER PLATE JACKNUT 9.5 mm DRILLED HOLE BRACKET FLANGE BOLT 4 of 11 0SR90-HL4-211A & 0SR90-HL4-221A 2015 American Honda Motor Co., Inc - All Rights Reserved.

5 11. Remove the self adhesive loop fastener from the hook and loop tab at the top of the fabric door. Clean the surface of the upper cab frame, adjacent to the hook and loop tab, with the provided alcohol pad and allow it to dry. Apply the self adhesive loop fastener around the upper cab frame tube, adjacent to the hook and loop tab on the fabric door. 12. Remove the middle two upper bolts from the fabric door brackets. Install the fabric door handle with the removed bolts. Remove the self adhesive Velcro from the flaps and attach it to the brackets, adjacent to with the Velcro on the flaps. Attach the webbing with J-hook onto the lower door handle. UPPER BOLT WEBBING WITH J-HOOK HANDLE SELF-ADHESIVE LOOP FASTENER DOOR BRACKET LOWER DOOR HANDLE 2015 American Honda Motor Co., Inc - All Rights Reserved. 0SR90-HL4-211A & 0SR90-HL4-221A 5 of 11

6 THIS PAGE LEFT BLANK INTENTIONALLY 6 of 11 0SR90-HL4-211A & 0SR90-HL4-221A 2015 American Honda Motor Co., Inc - All Rights Reserved.

7 <TEMPLATE> Door, Inside Drill Template A NOTICE If you print this template from your local computer, make sure the printer settngs do not scale or shrink the page. edge of textured plastic This side up for Left Door Align with B American Honda Motor Co., Inc - All Rights Reserved. 0SR90-HL4-211A & 0SR90-HL4-221A 7 of 11

8 THIS PAGE LEFT BLANK INTENTIONALLY 8 of 11 0SR90-HL4-211A & 0SR90-HL4-221A 2015 American Honda Motor Co., Inc - All Rights Reserved.

9 <TEMPLATE> Align with A Door, Inside Drill Template B NOTICE If you print this template from your local computer, make sure the printer settngs do not scale or shrink the page. This side up for Left Door American Honda Motor Co., Inc - All Rights Reserved. 0SR90-HL4-211A & 0SR90-HL4-221A 9 of 11

10 THIS PAGE LEFT BLANK INTENTIONALLY 10 of 11 0SR90-HL4-211A & 0SR90-HL4-221A 2015 American Honda Motor Co., Inc - All Rights Reserved.

11 <TEMPLATE> NOTICE If you print this template from your local computer, make sure the printer settngs do not scale or shrink the page. A This side up for Left Door B This side up for Left Door Door, Outside Drill Template Cut out parts and tape together Align A with A and B with B This side up for Left Door A B American Honda Motor Co., Inc - All Rights Reserved. 0SR90-HL4-211A & 0SR90-HL4-221A 11 of 11

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS HARD ROOF (5P) P/N 0SR85-HL4-501 SXS1000M5D/M5P MII 16083 Issue Date February 2017 Honda Dealer: Please give a copy of these instructions

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory TWO-PIECE POLY (HARD COAT) P/N 0SR71-HL4-A00 Application SXS1000M/M3P/M5D/M5P Honda Dealer: Please give a copy of these instructions to your customer. Publication No.

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS 2 PIECE FOLDING POLY WINDSCREEN (OPTICAL) P/N 0SR72-HL3-100 SXS700M4/M2 Honda Dealer: Please give a copy of these instructions to your customer.

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory HARD ROOF (3P) P/N 0SR85-HL4-1 Application SXS00M3/M3P Honda Dealer: Please give a copy of these instructions to your customer. Publication No. MII 16083 Issue Date

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory HARD FRONT DOORS P/N 0SU95-HL3-104A Application After 16 SXS700M2/M2D/M4/M4D Honda Dealer: Please give a copy of these instructions to your customer. Publication No.

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory HARD FRONT DOORS P/N 0SU95-HL4-104 Application SXS1000M3/M3P/M3L/M5D/ M5P/M5L Honda Dealer: Please give a copy of these instructions to your customer. Publication No.

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory HARD FRONT DOORS P/N 0SU95-HL4-105 Application SXS1000M3/M3P/M3L/M5D/ M5P/M5L Honda Dealer: Please give a copy of these instructions to your customer. Publication No.

More information

SWING DOOR SOFT ENCLOSURE (part# 16733)

SWING DOOR SOFT ENCLOSURE (part# 16733) 800-643-7332 americanlandmaster.com This kit is for use with all fullsize, 2 passenger ALM utility vehicles. SWING DOOR SOFT ENCLOSURE (part# 16733) NOTE TOOLS REQUIRED Drill 1/4 Drill Bit 7/16 Wrench

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 24081 ACCORD 2-DOOR Issue Date SEP 2002 PARTS LIST INSTALLATION NOTE: Rear under spoiler Be careful not to damage the rear bumper and

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS WINCH MOUNT KIT P/N 08L77-HL3-A00 SXS700M4/M2 Honda Dealer: Please give a copy of these instructions to your customer. MII 14607 Issue Date

More information

Installation Instructions Supertop for Truck

Installation Instructions Supertop for Truck Installation Instructions Supertop for Truck US Patent 6827391 Vehicle Application: Toyota Tacoma Double Cab 2005-2011 (5 ft.) Part Number: 76308 INSTALLATION TIME SKILL LEVEL 1-1/2 Hours 2 - Moderately

More information

Installation Instructions Supertop for Truck

Installation Instructions Supertop for Truck Installation Instructions Supertop for Truck Vehicle Application: Toyota Tacoma Double Cab 2005 - Current (5 ft.) Part Number: 76308 US Patent 6827391 www.bestop.com - We re here to help! Visit our web

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS SADDLEBAG P/N 08L70-MGZ-A80 COMMON Honda Dealer: Please give a copy of these instructions to your customer. MII 15802 Issue Date March 2016

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS GENUINE PARTS INSTALLATION INSTRUCTIONS 1. DESCRIPTION: Rear s 2. APPLICATION: Titan King Cab and Crew Cab 3. PART NUMBER: 999N4 WQ1CC and 999N4 WQ1KC 4. KIT CONTENTS: Item No. Qty Description 1) 1, 60

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. MII 11775 AUDIO ATTACHMENT KIT P/N 08B08-MEA-100 VTX1300S/R Issue Date October 2006 Honda Dealer: Please give a copy of these instructions

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory HITCH Application 2009 CR-V Publications No. AII 40373 Issue Date AUG 2008 PARTS LIST Plain washer, 12 mm Trailer Hitch Kit P/N 08L92-SWA-100 Trailer hitch 6 Spring

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. SPOILER (DECK LID) ACCORD 4-DOOR AII 24063 Issue Date AUG 2002 PARTS LIST Trunk spoiler Right trunk spring (marked green) Left trunk spring

More information

INSTALLATION & OWNER S MANUAL

INSTALLATION & OWNER S MANUAL Rev. B, p. 1 of 25 INSTALLATION & OWNER S MANUAL POLARIS RANGER RCS (for models XP or HD) (for model years 2009-) cab without doors kit (p/n 1POLRCWD) cab with doors kit (p/n 1POLRC) doors only kit (p/n

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS WINCH MOUNT P/N 08L73-HL4-F01 After 16 SXS1000M3/M3P/M3LE SXS1000M5P/M5D/M5LE MII 16083 Issue Date February 2017 PARTS LIST No. Description

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory S P/N 08V67-SJC-101 Application 2012 RIDGELINE Publications No. AII 12006 Issue Date NOV 2011 PARTS LIST Back-up sensor harness 3 Wire ties with small clips (2 Not used)

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory LED BRAKE LIGHT P/N 08U76-MKC-A00 Application GL1800/D/DA GL1800B/BD Honda Dealer: Please give a copy of these instructions to your customer. Publication No. MII 16426

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory S P/N 08V67-SJC-101 Application 2010 RIDGELINE Publications No. AII 42117 Issue Date AUG 2009 PARTS LIST Back-up sensor harness 3 Wire ties with small clip (2 Not used)

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory LED FOGLIGHT ATTACHMENT KIT P/N 08V70-MKC-A00 Application GL1800/B/BD/D/DA Honda Dealer: Please give a copy of these instructions to your customer. Publication No. MII

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS PARTS LIST Accessory Application Publications No. MII 13038 GL1800 P/N 08E75-MCA-100K Issue Date November 2009 Honda Dealer: Please give a copy of these instructions to your customer.

More information

Installation Instructions

Installation Instructions Equipment Required: Fastener Kit: F Wrenches: 3/4, 15/16 Drill Bits: 1/4 Other Tools: Drill Installation Instructions Short & Long Bed All Megacabs 9464/9474 HIDE-A-GOOSE HITCH INSTALLATION WARNING: Under

More information

SPECIALTY TOP CO. STC. INSTALLATION INSTRUCTIONS TOYOTA FAST TRAC Z TOP Toyota FJ PART #222-31X 82 1/8" 82 1/8"

SPECIALTY TOP CO. STC. INSTALLATION INSTRUCTIONS TOYOTA FAST TRAC Z TOP Toyota FJ PART #222-31X 82 1/8 82 1/8 STC INSTALLATION INSTRUCTIONS TOYOTA FAST TRAC Z TOP Toyota FJ-40 1963-1983 PART #222-31X SPECIALTY TOP CO. Thank you for purchasing Specialty's Convertible Top for your Toyota. It has been designed for

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Honda Dealer: Please give a copy of these instructions to your customer. PARTS LIST (15) (8) (12) (14) (13) (10) (11) (18) (17) (1) Accessory Application Publications No. TRX500FA/FGA

More information

Ref Qty Part Description Part Number -1- Kit ( ) Contents:

Ref Qty Part Description Part Number -1- Kit ( ) Contents: REAR CANVAS DOOR KIT 900 XP RANGER CREW P/N 2879899 Application RANGER 900 XP CREW Before you begin, read these instructions twice and check to be sure all parts and tools are accounted for. Please retain

More information

Installation Instructions Supertop for Truck

Installation Instructions Supertop for Truck Installation Instructions Supertop for Truck US Patent 6827391 Vehicle Application: Ford F150 1987-1996 (8 ft.) Part Number: 76315 Ford F250 1987-1998 (8 ft.) Part Number: 76315 Ford F350 1987-1998 (8

More information

Installation Instructions Supertop for Truck

Installation Instructions Supertop for Truck Installation Instructions Supertop for Truck Vehicle Application: Ford F-150 Regular / Super Cab 2004 2011 (6.5 ft.) Part Number: 76305 US Patent 6827391 www.bestop.com - We re here to help! Visit our

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publication No. WINCH MOUNT P/N 08L74-HR3-A20 After 13 TRX420 (All except TRX420FA/FPA) After 13 TRX500 (All except TRX500FA/FPA) MII 15067 Issue Date Revised:

More information

SPECIALTY TOP CO. STC INSTALLATION INSTRUCTIONS BRONCO ZIPPER FASTTRAC TOP PART # BRONCO

SPECIALTY TOP CO. STC INSTALLATION INSTRUCTIONS BRONCO ZIPPER FASTTRAC TOP PART # BRONCO STC INSTALLATION INSTRUCTIONS BRONCO ZIPPER FASTTRAC TOP PART #331-310 BRONCO 1966-1977 SPECIALTY TOP CO. Thank you for purchasing Specialty's Convertible Top for your Bronco. It has been designed for

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publication No. MII 15249 WINCH MOUNT KIT P/N 08L70-HL3-A41 SXS700/M4/M2 Issue Date September 2015 PARTS LIST No. Description Qty (1) Winch bracket 1 (2)

More information

HiBoy Maverick/Commander Doors Part # HiBoy4 Maverick/Commander Doors Black

HiBoy Maverick/Commander Doors Part # HiBoy4 Maverick/Commander Doors Black Racing 3191 N Washington St. Suite 2 Chandler, AZ 85225 1 (800) 708-9803 http://www.racing.com HiBoy Maverick/Commander Doors Part # 07-2001 HiBoy4 Maverick/Commander Doors Black Congratulations on your

More information

Assembly Instructions

Assembly Instructions Assembly Instructions Part Number Description Model Approx. Assembly Time 99994-049 Cab Enclosure MULE SX 3-4 Hours WARNING Improper installation of this accessory could result in an accident causing serious

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. SPOILER (LOW) 2005 ACCORD 4-DOOR AII 27503 Issue Date AUG 2004 PARTS LIST Trunk spoiler Right trunk spring (marked green) Left trunk spring

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS AUTOMOTIVE PRODUCTS, INSTALLATION INSTRUCTIONS Thrasher Board APPLICATION: 007-017 Chevy Silverado / GM Sierra / 1500-500-3500 Extended / Double / Crew Cab PART NUMBER: 8-8105, 8-81035 ITEM QUANTITY DESCRIPTION

More information

P/N Rev 01 04/14-1- NOTE: If you are ordering hinges for your rear doors, order and/or

P/N Rev 01 04/14-1- NOTE: If you are ordering hinges for your rear doors, order and/or REAR CANVAS DOOR KIT 900 XP RANGER CREW P/N 2879899 Application RANGER 900 XP CREW Before you begin, read these instructions twice and check to be sure all parts and tools are accounted for. Please retain

More information

INSTALLATION & OWNER S MANUAL

INSTALLATION & OWNER S MANUAL p. 1 of 15 INSTALLATION & OWNER S MANUAL John Deere Gator PathPro SS Cab (fits all HPX and XUV models with the O.P.S. system installed) (p/n: 1GTRXUV) (O.P.S. = Operator Protective Structure) The contents

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS CHROME TRUNK RACK P/N 08L70-MKC-A00 GL1800/D/DA GL1800B/BD Honda Dealer: Please give a copy of these instructions to your customer. MII 16426

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory SPOILER (LOW) P/N 08F10-TA0-100 Application 2009 ACCORD 4-DOOR Publications No. AII 40062 Issue Date JULY 2008 PARTS LIST Trunk spoiler Right trunk spring (marked red)

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory S Application 2011 PILOT Publications No. AII 43298 Issue Date MARCH 2010 PARTS LIST Back-up Sensor Attachment Kit P/N 08V67-SZA-100A Back-up sensor harness Fuse label

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publication No. SADDLEBAG SUPPORT BRACKETS P/N 08L73-MGS-A30 2012 Only NC700X/XD Honda Dealer: Please give a copy of these instructions to your customer.

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application 2011 CIVIC 4-DOOR Si Publications No. AII 44423 Issue Date AUG 2010 PARTS LIST Template Front under spoiler TOOLS AND SUPPLIES REQUIRED 4 Self-tapping screws

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. ATTACHMENT (EX-L WITH NAVI) 2008 RIDGELINE AII 36587 Issue Date MAY 2007 PARTS LIST Attachment Kit P/N: 08B21-SJC-102 Template Rear camera

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. All 30482 S 2006 PILOT Issue Date P/N 08F23-S9V-100A SEP 2005 PARTS LIST Left front trim piece Right front trim piece Left rear trim piece

More information

PRELIMINARY INSTALLATION INSTRUCTIONS. PARTS LIST Left front trim piece

PRELIMINARY INSTALLATION INSTRUCTIONS. PARTS LIST Left front trim piece INSTALLATION INSTRUCTIONS Accessory Application Publications No. All 30482 S 2006 PILOT Issue Date P/N 08F23-S9V-100A SEP 2005 PARTS LIST Left front trim piece Right front trim piece Left rear trim piece

More information

CHROME SADDLEBAG SUPPORTS KIT VT750C2B P/N 08L56-MEG-100J. Honda Dealer: Please give a copy of these instructions to your customer.

CHROME SADDLEBAG SUPPORTS KIT VT750C2B P/N 08L56-MEG-100J. Honda Dealer: Please give a copy of these instructions to your customer. PARTS LIST Accessory Application Publications No. CHROME SADDLEBAG MII 12987 INSTALLATION SUPPORTS KIT Issue Date P/N 08L56-MEG-100J INSTRUCTIONS September 2009 Honda Dealer: Please give a copy of these

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. SPOILER (LOW) 2011 CIVIC 4-DOOR All 44416 Issue Date AUG 2010 PARTS LIST Trunk spoiler Right trunk spring (marked red) Left trunk spring

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. BII 24813 UNDER 2004 TSX Issue Date APRIL 2003 PARTS LIST Rear under spoiler 2 Short step bolts TOOLS AND SUPPLIES REQUIRED Phillips screwdriver

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. SPOILER (LOW) ACCORD 4-DOOR AII 30276 Issue Date AUG 2005 PARTS LIST Trunk spoiler Right trunk spring (marked green) Left trunk spring (marked

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 25877 PILOT Issue Date AUG 2003 Optional ATF and power steering coolers are required when installing the trailer hitch. 2 Spacers PARTS

More information

Parts List. Tools Required

Parts List. Tools Required Assembly, Installation, Operation and Maintenance Instructions Universal Bracket Kit Part # 31563 / 05515 Use with Base Rail Kit 31323 / 07058 Dealer / Installer: Provide a copy of these Instructions to

More information

Installation Instructions Supertop for Truck

Installation Instructions Supertop for Truck Installation Instructions Supertop for Truck Vehicle Application: Ford F-150 5.5 Ft. Styleside 2004 and newer Part Number: 76309 www.bestop.com - We re here to help! Visit our web site and click on Ask

More information

Installation Instructions

Installation Instructions Equipment Required: Fastener Kit: F Wrenches: 3/4, 15/16 Drill Bits: 1/4 Other Tools: Drill WARNING: Under no circumstances do we recommend exceeding the towing vehicle manufacturers recommended vehicle

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory TRAILER HITCH Application 2014 ODYSSEY Publications No. AII 49544 Issue Date JUNE 2013 PARTS LIST Bumper edge trim Trailer Hitch Kit P/N 08L92-TK8-100 Trailer hitch

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory HITCH Application 2012 CROSSTOUR Publications No. AII 46198 Issue Date JULY 2011 PARTS LIST Trailer Hitch Kit P/N 08L92-TP6-101 Upper spacer A (5 mm) (Some are not used.)

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. UNDER 2007 CIVIC SI All 33529 Issue Date AUG 2006 PARTS LIST Rear under spoiler Clip Rubber washer 6 Flange bolts 6 Flange nuts TOOLS REQUIRED

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. SPOILER (LOW) CIVIC 4-DOOR All 30833 Issue Date SEP 2005 PARTS LIST Trunk spoiler Right trunk spring (marked red) Left trunk spring (marked

More information

ASSEMBLY & INSTALLATION INSTRUCTIONS

ASSEMBLY & INSTALLATION INSTRUCTIONS ASSEMBLY & INSTALLATION INSTRUCTIONS VEHICLE MOUNT KIT 99101087 AND VEHICLE CENTER MEMBER For 26 Series: 99100890 TO FIT 2009 & Later FORD F150 4x4 (without EcoBoost V6) 2011 & Later FORD F150 4x4 (with

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS HORN MOUNT P/N 08Z77-HL4-A00 SXS1000M3/M3P/M5D/M5P Honda Dealer: Please give a copy of these instructions to your customer. MII 15262 Issue

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS PARTS LIST Accessory Application Publications No. TRX420 (All) MII 13032 WINCH KIT P/N 08L94-HP5-100 Accessory Weight 35 lbs (16 kg) Honda Dealer: Please give a copy of these

More information

Installation Instructions Supertop for Truck

Installation Instructions Supertop for Truck Installation Instructions Supertop for Truck US Patent 6827391 Vehicle Application: Dodge Ram 1500 / 2500 Regular / Quad / Mega Cab 6.5' Bed 2002 2011 Part Number: 76304 www.bestop.com - We re here to

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory TRAILER HITCH Application 2011 ODYSSEY Publications No. AII 43937 Issue Date SEP 2010 PARTS LIST Trailer Hitch Kit P/N 08L92-TK8-100 Trailer Hitch Harness Kit P/N 08L91-TK8-100

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. 3RD ROW P/N 08R12-SHJ-100 2006 ODYSSEY AII 30563-31117 Issue Date OCT 2005 PARTS LIST Left side rear sunshade Driver s Side 1. Remove the

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS NAVI ATTACHMENT P/N 08B70-MJL-D30 NC750X/XA/XD MII Issue Date November 2013 PARTS LIST RELAY SET Sold separately (4) (9) (5) (1) (2) (10)

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 30518 KIT 2006 PILOT Issue Date NOV 2005 NOTE: Accessory ATF and power steering coolers are required when installing the trailer hitch.

More information

INSTALLATION INSTRUCTIONS Accessory P/N 08L96-SZA-100A Application 2015 PILOT Publications No. AII 51544 Issue Date MAY 2014 PARTS LIST Advanced cargo net 2 Anchors A (Large) 4 Anchors B 6 Self-tapping

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. SYSTEM S2000 AII 26324 Issue Date OCT 2004 PARTS LIST Headrest Speaker System P/N 08A54-S2A-100 3 Small wire ties 2 Headrest speakers 9

More information

Installation Instructions Supertop NX

Installation Instructions Supertop NX Installation Instructions Supertop NX Vehicle Application: Jeep Wrangler JK 2 Door 2007 Current Part Number: 54722 www.bestop.com - We re here to help! Visit our web site and click on Ask a Question. Click

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory P/N 08F02-T0A-100 Application 2015 CR-V Publications No. VERSION 1 Issue Date SEP 2014 PARTS LIST 3 Adhesive sealing washers Tailgate spoiler 2 Hook and loop fasteners

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. Bll 30250 UNDER SPOILER 2006 RSX Issue Date JULY 2005 PARTS LIST Rear under spoiler 5 Stepped bolts 2 Bolts 7 Flange nuts, 6 mm 3 Square

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. CD CHANGER ATTACHMENT KIT 2005 CIVIC SI AII 27936 Issue Date AUG 2004 PARTS LIST CD Changer Attachment Kit (sold separately): P/N 08B26-S5T-100

More information

INSTALLATION & OWNER S MANUAL

INSTALLATION & OWNER S MANUAL Rev. E p. of 3 INSTALLATION & OWNER S MANUAL V446 Front Cab Kit and V446 Rear Cab Kit for RTV 40 INSTALLATION & OWNER S MANUAL The contents of this envelope are the property of the owner. Be sure to leave

More information

SUBARU FORESTER - SIDE STEP DIESEL VERSION INSTALLATION INSTRUCTIONS

SUBARU FORESTER - SIDE STEP DIESEL VERSION INSTALLATION INSTRUCTIONS SUU FORESTER - SIDE STEP DIESEL VERSION INSTALLATION INSTRUCTIONS SS00 VEHICLE DESCRIPTION: PART NUMBER: SUU FORESTER SACC00 R 9 L 0 Care Instructions: Clean Side Steps with a mild detergent and water

More information

Supertop Installation Instructions

Supertop Installation Instructions Supertop Installation Instructions For: 1980-1986 CJ7 and Part Number: 51600 1988-1995 Wrangler with Steel Half Doors Special Note: This door may be installed on 1986-1987 vehicles. However, the door retainer

More information

Supertop Installation Instructions

Supertop Installation Instructions Supertop Installation Instructions For: CJ7 1980-1986 and Wrangler (All) Part Number: 51603 Rotary Latch Paddle Handle WARNING This product is designed primarily to enhance the appearance of the vehicle

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory TRAILER HITCH Application 2012 ODYSSEY Publications No. AII 46755 Issue Date SEP 2011 PARTS LIST Trailer Hitch Kit P/N 08L92-TK8-100 Trailer Hitch Harness Kit P/N 08L91-TK8-100

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. 3RD ROW AII 27366 ODYSSEY Issue Date P/N 08R12-SHJ-100 SEP 2004 PARTS LIST Left side rear sunshade Driver s Side 1. Remove the left speaker

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS R5 MODULAR WHEEL TO WHEEL NERF STEP BARS APPLICATION: 2007-2019 Chevy Silverado / GMC Sierra 2500-3500 Crew Cab (8ft. Bed) Excl. Dually PART NUMBER: 28-534580, 28-534585 ITEM

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS PANNIER SUPPORT STAY P/N 08L71-MJJ-D30 NC700X/XA/XD NC700S/SA/SD NC700D MII Issue Date February 2013 PARTS LIST No. Description Qty (1) (((

More information

INSTALLATION & OWNER S MANUAL

INSTALLATION & OWNER S MANUAL Rev. A, p. of 0 INSTALLATION & OWNER S MANUAL MASSEY FERGUSON GC2400 cab kit p/n MFGC2400 Installation Instructions The contents of this envelope are the property of the owner. Be sure to leave with the

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS 12V ACCESSORY SOCKET P/N 08U79-MKC-A00 GL1800/B/BD/D/DA Honda Dealer: Please give a copy of these instructions to your customer. MII 16426

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. 2006 ACCORD AII 30277-31251 4-DOOR SPOILER (WING) P/N 08F12-SDA-100 Issue Date AUG 2005 PARTS LIST Trunk spoiler Right trunk spring (marked

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory TRAILER HITCH Application 2011 ODYSSEY Publications No. AII 43937 Issue Date SEP 2010 PARTS LIST Trailer Hitch Kit P/N 08L92-TK8-100 Trailer Hitch Harness Kit P/N 08L91-TK8-100

More information

WARNING indicates a potentially hazardous situation which, if not avoided, could result in property damage, serious personal injury or even death.

WARNING indicates a potentially hazardous situation which, if not avoided, could result in property damage, serious personal injury or even death. Comfort Ride Third axle slipper leaf spring system (part numbers 2560-50, 2570-50 and 2580-50) and shock absorber system (part numbers 2450-50, 2460-50 and 2470-50) Installation Instructions All specifications

More information

Size Grade Torque 9/ ft/lbs. 5/ ft/lbs. 3/ ft/lbs. 7/ ft/lbs ft/lbs.

Size Grade Torque 9/ ft/lbs. 5/ ft/lbs. 3/ ft/lbs. 7/ ft/lbs ft/lbs. Ford 150 5 1/2, 6 1/2 & 8 Boxes 4/16 HJ32003,Rev 2 BOlT TORQUE SPECIFICATIONS STANDARD BOlTS: Size Grade Torque 5/16 5 20 ft/lbs. 3/8 5 35 ft/lbs. 7/16 5 56 ft/lbs. 1/2 5 85 ft/lbs. Size Grade Torque 9/16

More information

INSTALLATION & OWNER S MANUAL

INSTALLATION & OWNER S MANUAL p. 1 of 15 INSTALLATION & OWNER S MANUAL Polaris Ranger 500-800 PathPro SS Cab (fits 2010 - current) (p/n: 1POLRFS1) The contents of this envelope are the property of the owner. Be sure to leave with the

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. S 1998 CIVIC 2/3/4-DOOR All 18767 Issue Date SEP 1997 PARTS LIST Fog Light Kit: P/N 08V31-S01-100 Right fog light (marked R ) Fuse label

More information

Required tools General hand tools 21/64" drill bit Torque wrench Threadlocker Center punch

Required tools General hand tools 21/64 drill bit Torque wrench Threadlocker Center punch Slipper Spring Kit (part numbers 2560, 2570 and 2580) Item Qty Part number Description 1... 8... 350054-50...3/8-16 x 1" grade 8 self-tapping screw 2... 4... 350084-00...7/16-14 x 4" grade 5 3... 6...

More information

Ground Effects, P/N: (V6), (V8)

Ground Effects, P/N: (V6), (V8) , P/N: 92248596 (V6), 92248560 (V8) 3. Open trunk and remove 3 scrivets per side. Retain. Remove LH and RH tail lamp access cover. Retain. Refer to Figure 1. NOTE: Installation is made easier with the

More information

POLY TIP-DOWN WINDSHIELD KIT

POLY TIP-DOWN WINDSHIELD KIT POLY TIP-DOWN WINDSHIELD KIT P/N 2881919 APPLICATION Verify accessory fitment at Polaris.com. BEFORE YOU BEGIN Read these instructions and check to be sure all parts and tools are accounted for. Please

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS 3.5 CONTOUR BULL BAR AUTOMOTIVE PRODUCTS, APPLICATION: 0-06 Chevrolet Silverado 500 PART NUMBER: 3-3000, 3-3005, 3-3005T, 3-3090, 3-3095, 3-3095T ITEM QUANTITY DESCRIPTION TOOLS

More information

SCION FR-S CENTER ARMREST Preparation

SCION FR-S CENTER ARMREST Preparation Preparation Part Number: PT478 18130 Kit Contents Item # Quantity Reqd. Description 1 1 LH Bracket 2 1 RH Bracket 3 1 LH Extrusion 4 1 RH Extrusion 5 1 Slide Assembly 6 4 4.0mm PT (Torx) Screws 7 1 Armrest

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory P/N 08L92-TX4-200 Application 2013 RDX Publications No. BII 13467 Issue Date MAR 2012 PARTS LIST 4 Nuts, Trailer hitch 10 Plain washers, Ball mount 6 Spring washers,

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS AUTOMOTIVE PRODUCTS, INSTALLATION INSTRUCTIONS HDX DROP STEP APPLICATION: 2007-2017 Chevy Silverado / GM Sierra / 1500-2500-3500 Ext. / Double / Crew Cab PART NUMBER: 56-13715, 56-13725 ITEM QUANTITY DESCRIPTION

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS DCT FOOT SHIFTER P/N 08U71-MKC-A00 GL1800BD/D/DA Honda Dealer: Please give a copy of these instructions to your customer. MII 16426 Issue

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. FENDER FLARES P/N 08P21-S3V-200 2003 MDX BII 24553 Issue Date SEP 2002 PARTS LIST Right rear fender flare Left front fender flare Right

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS REAR CARRIER P/N 08L70-MJJ-D30 NC700X/XA/XD NC700S/SA/SD NC700D MII Issue Date January 2013 PARTS LIST PANNIER STAY (Sold separately) (8)

More information

INSTALLATION & OWNER S MANUAL

INSTALLATION & OWNER S MANUAL p. 1 of 13 INSTALLATION & OWNER S MANUAL Polaris Ranger 400-EV PathPro SS Cab (fits 2010 - current) (p/n: 1PRG400FS) The contents of this envelope are the property of the owner. Be sure to leave with the

More information