REPAIR PARTS MANUAL. MODEL NO. REN1192(REN11T92A) Lawn Tractor. Ihr Ersatzteilspezialist im Internet

Size: px

Start display at page:

Download "REPAIR PARTS MANUAL. MODEL NO. REN1192(REN11T92A) Lawn Tractor. Ihr Ersatzteilspezialist im Internet"

Eugenia Lamb
5 years ago
Views:

1 MANUAL MODEL NO. REN119(REN11T9A) Lawn Tractor TR PRINTED IN U.S.A.

2 HOW TO USE THIS MANUAL This manual is designed to provide the customer with a means to identify the parts on his/her tractor when ordering repair parts. The illustrations may or may not represent the actual assemblies; there fore, it is not recommended to use this manual as a guide to assemble or disassemble the tractor. Some hardware and parts are drawn larger in order to more readily identify them. Each tractor has its own model number. The model number for your tractor can be found on the fender under the seat. When ordering parts, always give the following information: Product - Lawn Tractor Model Number - REN119 (REN11T9A) Part Number Part Description TABLE OF CONTENTS SCHEMATIC...3 ELECTRICAL...4- CHASSIS AND ENCLOSURES...- DRIVE...-9 STEERING WHEEL SEAT...1 DECALS... ENGINE MOWER LIFT MOWER DECK

3 TRACTOR - - MODEL NUMBER REN119 (REN11T9A), PRODUCT NO SCHEMATIC RED BLACK BATTERY A AMMETER (OPTIONAL) RED FUSE RED M STARTER BLACK WHITE RED B S M G L CLUTCH / BRAKE (PEDAL UP) SOLENOID WHITE BLACK IGNITION SWITCH WHITE SEAT SWITCH (NOT OCCUPIED) BLACK BLACK BLACK BLUE BLACK HOUR METER (OPTIONAL) FUEL LINE BLACK BLACK ATT'MENT CLUTCH (CLUTCH OFF) IGNITION UNIT GROUNDING CONNECTOR SPARK PLUG GAP ( PLUGS ON TWIN CYL. ENGINES) CHARGING SYSTEM OUTPUT 3 AMP 300 RPM VOLTS AC 300 RPM (CHARGING SYSTEM DISCONNECTED) FUEL SHUT-OFF SOLENOID (IF SO EQUIPPED) RED LIGHTING SYSTEM OUTPUT AMP 300 RPM DIODE ALTERNATOR S M B L G IGNITION SWITCH POSITION CIRCUIT OFF M + G ON B + L START B + S + L WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING. 14 VOLTS AC 300 RPM (LIGHTS OFF) NON-REMOVABLE CONNECTIONS REMOVABLE CONNECTIONS 3

4 TRACTOR - - MODEL NUMBER REN119 (REN11T9A), PRODUCT NO ELECTRICAL

5 TRACTOR - - MODEL NUMBER REN119 (REN11T9A), PRODUCT NO ELECTRICAL Battery Bolt Hex Hd 1/4-0 unc x 3/ Box Battery Fender Switch Interlock Cable Battery Ga. 11" Red Cable Battery Ga. Red w/1 wire 44" Fuse Nut Keps Hex 1/4-0 unc Cable Ground Ga. 1" black Switch Plunger Nc Gray Switch Ign Key Harness Ing Bolt Blk Fin Hex 1/4-0 x 1/ Cover Terminal Red Solenoid Adapter Ammeter Rectangular Protection Wire Loop Cover Terminal Battery NOTE: All component dimensions given in U.S. inches. 1 inch =.4 mm.

6 TRACTOR - - MODEL NUMBER REN119 (REN11T9A), PRODUCT NO CHASSIS Chassis-Elite_Basic_LT_4

7 TRACTOR - - MODEL NUMBER REN119 (REN11T9A), PRODUCT NO CHASSIS Chassis Drawbar BumperHood/Dash Saddle Clip, Retainer Slide-On Dash Bolt, Carriage 3/-1 x Dashboard, Panel LH Dashboard, Panel RH Machine screw /1-1 unc x 3/ Nut, Keps /1-1 unc Hood Pnt BumperHood Bolt, Hex Head, Fin. 3/-1 x 1 Gr Washer /3 x /1 x 1 Ga Nut Lock Hex w/ins. 3/-1 unc Grille Fender Fender Bracket Footrest, LH Footrest, RH Bolt 3/-1 x 3/ Screw Thdrol /1-1 x 1/ Bracket Asm. Pivot Mower Rear Bracket Pivot Rod Pivot Chassis/Hood Screw Hi-Lo #-1 x 3/ Screw Thdrol 3/-1 x 1/ Bolt Shoulder /1-1 TT Screw Thdrol 3/-1 x 1/ Screw Hexwsh Thdr 3/-1 x 3/ Button Plug NOTE: All component dimensions given in U.S. inches. 1 inch =.4 mm.

8 TRACTOR - - MODEL NUMBER REN119 (REN11T9A), PRODUCT NO DRIVE drive-saddle_33

9 TRACTOR - - MODEL NUMBER REN119 (REN11T9A), PRODUCT NO DRIVE Transaxle, Peerless, Model 04-0B (Order parts from transaxle manufacturer) Spring, Brake Return Pulley, Transaxle Ring, Retainer Strap, Torque Screw, /1-1 x 3/4 SMGML Bracket, T/A, Saddle Shift Rod, Shifter Pin, Cotter 1/ x Washer, Shift Plate Washer 1/3 x 3/4 x Bolt 1/4- unf Gr. w/patch Washer Lock Bolt, Hex Flghd /1-1 Gr Nut lock / Bolt, Fin Hex 3/-1 unc x 1 Gr Locknut 3/ Knob Rod, Brake Nut, Hex Jam 3/ Spring, Rod, Brake 19-1 Washer /3 x /1 x 1 Gauge Pin, Cotter 1/ x 3/ Rod, Brake, Park Cap, Plunger Bracket, Transaxle, L.H Bolt Hex Hd /1-1 Unc x 3/ Shaft, Foot Pedal Bearing Nylon Washer 1/3 x 1 x 1 Gauge Pin,Roll 3/1 x Pulley Idler Bolt RDHD 3/-1 unc x -3/4 Gr Keeper, Belt Pulley, Idler Bellcrank Asm Clutch Retainer, Belt Bolt, 3/-1 x 1-1/ Gr Nut, Crownlock 3/ Nut, Crownlock / Link, Clutch Spring, Return, Clutch Screw 3/-1 x 1-1/ V-Belt, Drive Keeper Belt Center Span Screw 3/-1 x Cover, Foot Pedal Pulley, Engine Bolt, Hex /1-0 x 4 Gr Washer, Lock Hvy Hlcl Spr / Keeper, Belt Engine F-Proof Guide Belt Mower Drive RH Spacer, Split Washer /3 x 1-1/4 x 1 Ga E-Ring Key Square Washer /3 x 1-/ x 1 Ga Key Woodruff #9 3/1 x 3/ Retainer Spring 1" Ziinc/Cad Washer 9/3 x 3/4 x 10 Ga Strap Torque L.H. Lt Bolt RDHD SQNK 3/-1 Unc x Nut Lock Flg. 3/-1 Unc SpacerRetainer Washer /3 x x 10 Ga Keeper, Belt, Transaxle Bolt Carr Sh 3/-1 x 1-3/4 Gr Nut Hex Flange Lock Screw 3/-1 x 3/4 NOTE: All component dimensions given in U.S. inches 1 inch =.4 mm 9

10 TRACTOR - - MODEL NUMBER REN119 (REN11T9A), PRODUCT NO STEERING ASSEMBLY steering_pl.lt_4 10

11 TRACTOR - - MODEL NUMBER REN119 (REN11T9A), PRODUCT NO STEERING ASSEMBLY Wheel Steering Opp. Sears Blk Axle Asm Spindle Asm LH Spindle Asm RH Bearing Race Thrust Harden Washer /3 x 1-/ x 1 Ga Washer /3 x 1-1/4 x 1 Ga Ring Klip #t Bearing Col Strg Blk Link Drag Washer Lock Hvy Hlcl Spr 3/ Nut Hex Jam Toplock 1/-0 Unf 3-1 Spacer Brace Axle Nut Hexfl ange Lock Shaft Asm Strg Bushing Link Drag Blk LR Washer /3 x / x 1 Ga Screw 3/-1 x Pin Cotter 1/ x 3/4 Cad Rod Tie Wire Form 19 Mech Bushing Strg Nat.3/.1Id Screw TT #10-3 x x 3/ Flange Cap Wheel Steer P/L Washer 9/1 ID x -3/ OD 1 Gr Nut crownlock 3/ Adaptor Wheel Strg Boot Shaft Steering Washer /3 x 1 1/4 x 1 Ga Extension Steering Cap Spindle Fr Top Blk Fitting Grease Nut Crownlock 1/ Bolt Hex 1/4- Unf x 1-1/4 Gr Spacer Brace Axle Bolt RDHD SQ 3/-1 Unc x -1/ Brace Axle Steering Asm Bracket Susp. Chassis Front Bolt Shoulder / Cup Steering Washer Hardened NOTE: All component dimensions given in U.S. inches. 1 inch =.4 mm. 11

12 TRACTOR - - MODEL NUMBER REN119 (REN11T9A), PRODUCT NO SEAT ASSEMBLY seat_lt.bolt_ Seat Bracket Pivot Seat Bolt Fin Hex 3/-1 Unc x Washer /3 x 1 x 10 Ga Clip Push-In Nut Lock Hex w/wsh 3/-1 Unc Spring Seat Cprsn 0 Blk Zi Screw 3/-1 x Washer /3 x 1 x 14 Ga Pan Seat Bracket Mounting Switch Bushing Snap Blk Nyl 0 Id Bolt Rdhd Sht Nk 1/4-0 x 1-1/ Spacer Split x 9 Yel Zinc Spring Cprsn 1 Blk Pnt Nut Lock 1/4 Lge Flg Gr Zinc Bolt Shoulder /1-1 Unc -A Nut Lock Hex W/Insert /1-1 Unc Bolt Hex Washer 1/3 x 1-3/1 x 1 Ga Bolt Shoulder /1-1 x Washer Lock Hvy HLCLSPR 1/ NOTE: All component dimensions given in U.S. inches. 1 inch =.4 mm

13 TRACTOR - - MODEL NUMBER REN119 (REN11T9A), PRODUCT NO DECALS Decal Bat Dan/Poi P/L Symbols Decal Engine Decal Chas Decal Saddle Brake Parking Decal Read Owners Manual Syms Decal Chassis Hot Muffl er Decal Mower Cut fi nger Symbol Decal 100 Dba Decal Brake/Clutch Decal V-Belt Sch Decal Drawbar Load Limit Decal Lift Handle (Lift Handle) Decal Tec. 3 yr. warranty Manual Operator s Euro Manual Operator s Scan Manual Parts WHEELS & TIRES 1, 4,10 3, Cap Valve Tire Stem Valve Tire F Ts 1 x - Service Tube Front (Service Item Only) Rim Asm " front Service Fitting Grease (Front Wheel Only) Bearing Flange (Front Wheel Only) Rim Asm " rear Service Tire R Ts 1 x 9.- C. Service Tube Rear (Service Item Only) Cap Axle Blk 1 0 x 1 00 NOTE: All component dimensions given in U.S. inches 1 inch =.4 mm wheel_1

14 TRACTOR - - MODEL NUMBER REN119 (REN11T9A), PRODUCT NO ENIGNE OPTIONAL EQUIPMENT Spark Arrester engine-tecumseh_ 14

15 TRACTOR - - MODEL NUMBER REN119 (REN11T9A), PRODUCT NO ENIGNE Control Th/ch Flag Screw Hex Thd Cut 1/4-0 x 1/ Engine Tec Model No. OV3EA (Order parts from engine manufacturer) Muffl er Gasket Eng Tube Drain Oil Easy Shield Brn/Dbr Guard Kit Spark Arrecter Tank Fuel Front Cap Asm Fuel W/sym Vented Clamp Hose Blk Line Fuel 0" Plug Oil Drain Easy Bushing Snap Nyl Blk Fuel Line Screw Hexwsh Thdrol 1/4-0 x 3/ Screw Hexwsh Thdrol 3/-1 x 3/ Washer 9/3 x / x 1 Ga Washer Lock Hvy Hlcl. Spr. / Screw 3/-1 x 1-1/ Nut Keps Hex 1/4-0 unc Bolt Hex Hd Phillips NOTE: All component dimensions given in U.S. inches 1 inch =.4 mm 1

16 TRACTOR - - MODEL NUMBER REN119 (REN11T9A), PRODUCT NO MOWER LIFT lift-rh.1piece_3 1

17 TRACTOR - - MODEL NUMBER REN119 (REN11T9A), PRODUCT NO MOWER LIFT Wire Asm Inner W/Plunger Shaft Asm Lift Pin Groove E Ring # Washer PLTD 1/3 x 1 x 1Ga Bearing Nylon Blk 9 Id Grip Handle Bicycle Matte Blk Button Plunger Black Link Lift LH Link Lift RH Retainer Spring Link Front Nut Jam Hex 1/- unc Trunnion Nut Lock W/Wsh 1/- unc Arm Suspension Rear Retainer Spring Bearing Pvt Lift Nut Crownlock 3/-4 NOTE: All component dimensions given in U.S. inches 1 inch =.4 mm 1

18 3 4 TRACTOR - - MODEL NUMBER REN119 (REN11T9A), PRODUCT NO MOWER _clutch_mod_ _deck_LT_1 9 1

19 TRACTOR - - MODEL NUMBER REN119 (REN11T9A), PRODUCT NO MOWER Mower Deck Assembly Bolt Bracket Assembly,Sway Bar Bracket Sway Bar Retainer Spring Bar Sway Deck Keeper Belt 3 0- Bolt, Hex 3/-4 x 1. Gr Washer, Lock Hvy Hlcl 3/ Washer,Hardened Blade, Mower 3-4 Shaft Assembly, Mandrel, Vented Housing, Mandrel, Vented Bearing, Ball, Mandrel Stripper, Mower Deck Bolt, Shoulder Nut Crownlock / Bracket, Mower Deflector Cap, Sleeve Spring, Torsion, Defl ector Nut, Push Shield, Defl ector Washer 11/3 x / x 1 Ga Rod, Hinge Screw Thdrol Washer, Spacer Pulley, Mandrel Nut, Toplock, Flanged Bolt Rdhd 3/-1 x 1-3/ Pulley, Idler, Flat Nut Crownlock 3/ Retainer, Spring Brake Assembly Washer,Hardened Idler Arm Assembly Spacer, Retainer Knob RD 3/-1 Plstc Thd Belt Washer /3 x /1 x 11 Ga Spacer, Retainer Stiffener, Idler Arm Screw Thdrol /1-1 x 1/ Rod, Brake, LH Rod, Brake, RH Bolt Carriage Idler Spring Return Idler Retainer Spring Yellow Zinc Washer 9/3 x 3/4 x 10 Ga Cable Clutch Screw Hex Thd Cut 1/4-0 x 1/ Bracket Asm Idler Support Bracket Deck Cable Bracket Asm Suspension Bracket Suspension RF Brace Support Susp. Frt Bracket Suspension LF Head Asm Cable Clutch Mandrel Assembly (Includes Housing, Shaft and Shaft Hardware Only - Pulley Not Included) Replacement Mower,Complete NOTE: All component dimensions given in U.S. inches 1 inch =.4 mm 19

20 T E C U M S E H Issued January 190 Revised January 1991 SERVICE POL I CY WARRANTY LIMITED WARRANTIES FOR NEW PEERLESS GEAR POWER TRAIN COMPONENTS T E C U M S E H A. Products Warranted Peerless Gear and Machine Division of Tecumseh Products Company ( Tecumseh ), subject to the limitations contained below, will, at its option, repair or replace, without charge for parts or labor only, any part of a new Power Train Component (which as used herein means and includes the transaxle, gear box, trans mis sion, differential and right angle drives, and any part of the Power Train Component), EXCEPT any new Power Train Component incorporated in equipment used for commercial or rental pur pos es, which is found upon examination by any Tecumseh Authorized Service Outlet or by Tecumseh s factory in Grafton, Wisconsin, to be DE FEC TIVE IN MATERIAL AND/OR WORK MAN SHIP if received by Tecumseh or a Tecumseh Authorized Service Outlet for such examination within TWO YEARS from the date of sale to the original consumer purchaser of Peerless Series 0, 900, 910, 91, 90, 930 transaxles and Series 1100 angle drive and ONE YEAR for all other Peerless products. New Power Train Components incorporated in equipment used for commercial purposes are warranted in the same manner and to the same extent EXCEPT such Power Train Components are warranted for NINETY (90) DAYS ONLY, and must be received by Tecumseh or by a Tecumseh Authorized Service Outlet for such examination within 90 days from the date of sale to the original purchaser. New Power Train Components Incorporated in equipment used for rental purposes are warranted in the same manner and to the same extent EXCEPT such Power Train Components are warranted for THIRTY (30) DAYS ONLY, and must be received by Tecumseh or a Tecumseh Authorized Service Outlet within 30 days from the date of sale to the original purchaser. B. Products And Items Not Warranted 1. Alterations or Modifi cations of Power Train Components.. Accidents, Normal Maintenance, Failure to follow the Orig i nal Equipment Man u fac tur er s Manual. This warranty covers only parts of new Power Train Com po nents which are found upon examination to be defective in material or workmanship as delivered to the original purchaser. This warranty does not cover defects caused by depreciation or damage caused by normal wear, accidents, improper main te nance, improper use or abuse of the product, failure to follow the instructions contained in an Instruction Manual for the operation of the Power Train Component and parts. The cost of normal maintenance and replacement of service items which are not defective shall be paid for by the original purchaser. C. Securing Warranty Service Warranty service can be arranged for by contacting either a Tecumseh Authorized Service Outlet (any Tecumseh Reg is tered Service Dealer, Tecumseh Authorized Service Distributor, or Tecumseh Central Warehouse Distributor) or by contacting Tecumseh, c/o Service Manager, Engine and Transmission Group Service Division, 900 North Street, Grafton, Wisconsin 304. Warranty service can only be performed by a Tecumseh Authorized Service Outlet or by Tecumseh at its factory in Grafton, Wisconsin. At the time of requesting warranty service, evidence must be presented of the date of sale to the original purchaser. The purchaser shall pay any charges for making service calls and/or for transporting the product to and from the place where the inspection and/or warranty work is performed. The purchaser shall be responsible for any damage or loss incurred in connection with the transportation of Power Train Components and/or part(s) of the Power Train Components submitted for inspection and/or warranty work. D. Limitation of Damages and Implied Warranties The foregoing EXPRESSED WARRANTY IS IN LIEU OF ALL OTHER EXPRESS WARRANTIES. Neither Tecumseh nor any of its affi liates makes any warranties, representations or promises, written or oral, as to the quality of the Power Train Component or any of its parts, other than as set forth herein. ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE, TO THE EXTENT THAT EITHER MAY APPLY TO ANY PART(S) OF POWER TRAIN COMPONENTS, SHALL BE LIMITED IN DURATION TO THE PERIODS OF THE EXPRESSED WARRANTIES DEFINED IN PARAGRAPH A HEREOF. IN NO EVENT WILL TECUMSEH BE LIABLE FOR ANY INCIDENTAL, CONSEQUENTIAL OR SPECIAL DAMAGES AND/OR EXPENSES. Some states do not allow limitations on how long an implied warranty lasts or the exclusion or limitation of incidental or consequential damages, so the above limitation(s) or exclusion(s) may not apply to you. This warranty gives you specifi c legal rights and you may also have other legal rights which vary from state to state. E. No Dealer Warranty Tecumseh neither assumes nor authorizes any other person, natural or corporate, to assume for Tecumseh any other obligations or liabilities in connection with or with respect to any part(s) of a Power Train Component. The seller or dealer of part(s) of a Power Train Component has no authority, whatsoever, to make any representations or promises on behalf of Tecumseh or to modify the terms or limitations of Tecumseh s warranty in any way.

PARTNER 11.0 HP 36" MOWER DECK LAWN TRACTOR MODEL NO. P1192 (P1192C)

PARTNER 11.0 HP 36 MOWER DECK LAWN TRACTOR MODEL NO. P1192 (P1192C) ILLUSTRATED PARTS BREAK DOWN PARTNER 11.0 HP 3" MOWER DECK LAWN TRACTOR MODEL NO. P119 (P119C) 94 14-01 1911 0.1.04 RD PRINTED IN U.S.A. SCHEMATIC RED BATTERY A AMMETER (OPTIONAL) RED FUSE RED M STARTER