PXT12538 LAWN TRACTOR MODEL: REPAIR PARTS MANUAL Rev CL Printed in the U.S.A. WARNING:

Size: px

Start display at page:

Download "PXT12538 LAWN TRACTOR MODEL: REPAIR PARTS MANUAL Rev CL Printed in the U.S.A. WARNING:"

Isabella Bishop
5 years ago
Views:

1 IMPORTANT MANUAL DO NOT THROW AWAY 000 REPAIR PARTS MANUAL MODEL: PXT138 LAWN TRACTOR WARNING: Read this Man u al and follow all Warnings and Safety Instructions. Fail ure to do so can re sult in serious in ju ry. ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: Rev CL Printed in the U.S.A.

2 SCHEMATIC 38 SCH03 BATTERY RED A AMMETER (OPTIONAL) RED FUSE RED SOLENOID STARTER M B S M G A1 L A BLUE WHITE CLUTCH / BRAKE (PEDAL UP) ATTACHMENT CLUTCH (CLUTCH OFF) BLACK BLACK BLACK SEAT SWITCH (NOT OCCUPIED) BLACK GRAY GRAY BLACK REVERSE SWITCH NOT IN REVERSE SHORTING CONNECTOR BLACK BLACK/WHITE IGNITION UNIT SPARK PLUGS GAP ( PLUGS ON TWIN CYL. ENGINES) BLUE FUEL LINE HOUR METER (OPTIONAL) BLACK BLUE RED LIGHT SWITCH FUEL SHUT-OFF SOLENOID ORANGE CHARGING SYSTEM OUTPUT 3 AMP 300 RPM LIGHTING SYSTEM OUTPUT AMP 300 RPM STATOR DIODE 8 VOLTS AC 300 RPM (CHARGING SYSTEM DISCONNECTED) 14 VOLTS AC 300 RPM (LIGHTS OFF) BROWN BLACK IGNITION SWITCH POSITION CIRCUIT MAKE OFF M+G+A1 RUN/OVERRIDE B+A1 RUN B+A1 L+A START B+S+A1 NOTE YOUR TRACTOR IS EQUIPPED WITH A SPECIAL ALTERNATOR SYSTEM. THE LIGHTS ARE NOT CONNECTED TO THE BATTERY, BUT HAVE THEIR OWN ELECTRICAL SOURCE. BECAUSE OF THIS, THE BRIGHTNESS OF THE LIGHTS WILL CHANGE WITH ENGINE SPEED. AT IDLE THE LIGHTS WILL DIM. AS THE ENGINE IS SPEEDED UP, THE LIGHTS WILL BECOME THEIR BRIGHTEST. 3 HEADLIGHTS NON-REMOVABLE CONNECTIONS REMOVABLE CONNECTIONS WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE RE-INSTALLED TO PROPERLY SECURE YOUR WIRING.

3 ELECTRICAL 3 L

4 ELECTRICAL Battery Bolt Hex Hd 1/4-0 unc x 3/ Box Battery Switch Interlock Harness Asm Light w/41j 41J Bulb Light # Cable Battery Ga. 11" Red 4197 Cable Battery 1718 Fuse 0 AMP Nut Keps Hex 1/4-0 unc Cable Ground Ga. 1" Black Switch Seat Switch Ign Key/Chain X Switch Light/Reset Harness Ign Bolt Blk Fin Hex 1/ Cover Terminal Red Solenoid Socket Asm. Bulb Twistlock Cover Terminal Battery Harness Pigtail Screw Plastite x Module Reverse ROS 1 inch =.4 mm.

5 CHASSIS AND ENCLOSURES 39

6 CHASSIS AND ENCLOSURES Chassis 174 Drawbar, Stretch 17 Bumper, Hood/Dash X010 Dash Bolt, Carriage 3/8-1 x Panel Dash LH X010 Panel Slkscr Dash RH X0 Hood Bumper Hood Bolt Fin Hex 3/8-1 unc x 1 Gr Washer 13/3 x 13/1 x 1 Ga Nut Lock Hex w/ins 3/8-1 unc 8 187X48 Grille X99 Lens Grille Bar X0 Fender Bracket Fender Repl X X0 Footrest Pnt LH X0 Footrest Pnt RH Bolt Rdhd Sht Sqnk 3/8-1 x 3/ Screw Thdrol /1-18 x 1/ TYT Bracket Asm. Pivot Mower Bracket Pivot Dash Lower Plate Reinforcement Rod Pivot Chassis/Hood X48 Cupholder Screw Thdrol 3/8-1 x 1/ Screw /1-18 x 1/ Screw Thdrol 3/8-1 x 1/ Screw Hex Wsh Thdrol 3/ Insert Lens Reflect Screw #10 x 0.70 BOS Thread J Plug Button Blk 39 Dia Choke Plug Dome Plastic 1 inch =.4 mm. 7

7 DRIVE drive-stlt_peerless_fender_18 8

8 DRIVE Transaxle Peerless 0-4C 148 Spring Return Brake T/a Zinc 3 13X Pulley Transaxle 18" Tires Ring Retainer # X Strap Torque 30 Degrees Screw /1-18 x 3/ Rod Shift Fender Adjust Lt Pin Cotter 1/8 x 1 Cad X Washer Plate Shf 388 Sq Hole Bolt 1/4-8 unf Gr. 8 w/patch Washer Lock Hvy Helical Bolt Hex FLGHD /1-18 x Nut Lock Hex w/ins / Bolt, Fin Hex 3/8-1 unc x 1 Gr Nut Lock 3/8-1 unc X Knob Rod Brake Nut Hex Jam 3/8-1 unc 10888X Spring Rod Brake 00 Zinc Washer 13/3 x 13/1 x 1 Ga Pin Cotter 1/8 x 3/4 Cad Rod Brake Parking LT/YT Cap Brake Parking Bracket Mtg Transaxle Bolt Hex Hd /1-18 unc x 3/ Shaft Asm Pedal Foot X Bearing Nylon Blk 9 Id Washer 1/3 x 1 x 1 Ga H Pin Roll 3/1 x 1" Pulley Composite Flat Bolt RDHD 3/8-1 unc x -3/4 Gr Keeper Belt Flat Idler Pulley Idler V Groove Plastic Bellcrank Asm X Retainer Belt Style Spring Bolt Carr. Sh. 3/8-1 x 1-1/ Gr Nut Crownlock 3/8-1 unc Nut Crownlock /1-18 unc Link Clutch 10709X Spring Return Clutch Screw 3/8-1 x 1-1/ V-Belt Ground Drive 8883R Cover Pedal Blk Round Engine Pulley Bolt Hex Washer Lock Hvy Hlcl Spr 7/ Keeper Belt Engine Foolproof Screw Hex wsh HiLo 1/4 x 1/ unc Guide Belt Mower Drive RH Spacer Axle X Washer /3 x 1 1/4 x 1 Ga E-ring # X Key Square 0 x 184/ X Washer /3 x 1-/8 x 1 Ga. 79 8M Key Woodruff #9 3/1 x 3/ Arm Shift Shaft Asm Cross Tapered PMST/ Spring Torsion T/a Washer 17/3 x 3/4 x 1 Ga Link Transaxle Nut Lock Center 1/4-8 FNTHD X48 Console Shift STLT H Retainer Spring 1" Washer 9/3 x 3/4 x 10 Ga X Strap Torque LT Bolt Rdhd Sq Neck 3/8-1 x Nut Lock Flg. 3/8-1 unc Spacer Retainer Washer 13/3 x x Washer Srrted /1ID x Bracket Shift Mount Hub Tapered Flange Shift Lt Bolt Rdhd Sqnk 1/4-0 x 3/ Nut Crownlock 1/4-0 unc Bolt Hex Fin 1/4-0 unc x 1 Gr Bracket Pivot Lever Screw /1-18 x / Bolt Shoulder /1-18 x Plate Fastening Keeper Belt Transaxle Gear Nyliner Snap-In Washer Nyliner Bolt RdHd 3/8-1 unc x 1-3/4 Gr Spacer Transaxle 1 inch =.4 mm 9

9 ENGINE OPTIONAL EQUIPMENT engine-stlt_bs_1 Spark Arrester 10

10 ENGINE Control Th/ch Flag Screw Hex Thd Cut 1/4-0 x 1/ Engine, B&S B Muffler Exhaust B&S Gasket Eng Id Tin Plated Shield BRN/DBR Guard Kit Spark Arrester (Flat Scrn) Tank Fuel Front 3 41 Cap Asm Fuel X Clamp Hose Line Fuel X Bushing Snap Nyl Blk Fuel Line Screw Thdrol 1/4-0 x 3/ Screw Hex Wsh Thdrol 3/ Washer 9/3 x 7/8 x 1 Ga Screw Socket Head /1-18 x 3/ Screw 3/8-1 x 1-1/ Nut Keps Hex 1/4-0 unc Extension Drain Oil 1 inch =.4 mm Engine Power Rating Information The gross power rating for individual gas engine models is labeled in accordance with SAE (Society of Automotive Engineers) code J1940 (Small Engine Power & Torque Rating Procedure), and rating performance has been obtained and corrected in accordance with SAE J199 (Revision 00-0). Torque values are derived at 300 RPM; horsepower values are derived at 300 RPM. Actual gross engine power will be lower and is affected by, among other things, ambient operating conditions and engine-to-engine variability. Given both the wide array of products on which engines are placed and the variety of environmental issues applicable to operating the equipment, the gas engine will not develop the rated gross power when used in a given piece of power equipment (actual on-site or net power). This difference is due to a variety of factors including, but not limited to, accessories (air cleaner, exhaust, charging, cooling, carburetor, fuel pump, etc.), application limitations, ambient operating conditions (temperature, humidity, altitude), and engine-toengine variability. Due to manufacturing and capacity limitations, Briggs & Stratton may substitute an engine of higher rated power for this Series engine. 11

11 STEERING ASSEMBLY Steering-lt_OPP_

12 STEERING ASSEMBLY Wheel Steering Axle Asm Spindle Asm LH Spindle Asm RH H Washer Thrust.7 x X Washer /3 x 1-/8 x 1 Ga Washer 7/3 x 1-1/4 x 1 Ga Ring Klip #t R Bearing Col Strg Blk Link Drag Washer Lock Hvy Hlcl Spr 3/ Spacer Brace Axle Lock Nut Flg. 3/8-1 unc Shaft Asm Strg 1847X Bushing Link Drag Blk LR Washer 13/3 x 7/8 x 1 Ga Screw 3/8-1 x 3/ Pin Cotter 11/3 ID x 3/8 OD x 1 Ga Rod Tie Wire Form 19 7 Mech Washer Lock / Bushing Strg /8 Id Dash Screw Cap Wheel Steer Washer 11/3 x 3/8 OD x 1 Ga Nut Crownlock 3/ Adaptor Wheel Strg X48 Boot Dash Mtl Steering Blk X Washer /3 x 1 1/4 x 1 Ga Extension Steering 4 113X Cap Spindle Fr Top Blk Spacer Brace Axle Bolt RDHD SQNK 3/8-1 x -1/ Brace Axle Steering Asm Bracket Susp Chassis Front Bolt Shoulder 7/ Clip Steering Washer Harden.793 x 1.37 x Bolt Fin Hx /1-18 x 4 w/patch 1 inch =.4 mm. 13

13 DECALS Decal, Replacement Decal, Engine HP Decal, Warning Decal, Fender Service 4118 Decal, Fender Warning Decal, Ins Str Wh Decal, Side Panel Decal, Fender Decal, V-Belt Sch Decal, Hood Decal, Caution, Battery X48 Pad Foot Rest RH X48 Pad Foot Rest LH Decal, Handle Lft Height Adj Manual, Operator's, English/French Manual, Operator's, Spanish Manual, Parts, English/French WHEELS & TIRES 1,8 7 4,10 3, Cap, Tire Valve 139 Stem, Valve X Tire, Front 4 41 Tube, Front (Service item only) 414X43 Rim Assembly, " Front 78H Fitting, Grease (Front wheel only) H Bearing, Flange (Front wheel only) X43 Rim Assembly, 8" Rear X Tire, Rear J Tube, Rear (Service item only) X43 Cap, Hub Axle Sealant, Tire (10 oz. Tube) wheel_1 1 inch =.4 mm 14

14 SEAT ASSEMBLY seat_lt.bolt_ Seat 1401 Bracket Seat Pivot Bolt Hex 3/8-1 x Washer 13/3 x 1 x10 Ga Clip Push-In Hinged Nut Lock Hex w/ins 3/ X Spring Seat Cprsn 0 Blk Zi Screw 3/8-1 x Washer 13/3 x 1 x 14 Ga Pan Pnt Seat Bracket Pnt Mounting Switch X Bushing Snap Blk Nyl Bolt Rdhd Sht Nk 1/4-0 x 1-1/ Spacer Split.8 x X Spring Cprsn X Nut Lock 1/4 Lge Flg Bolt Shoul der /1-18 unc-a Nut Lock Hex w/ins / Bolt Hex Washer 17/3 x 1-3/1 x 1 Ga X Bolt Shoul der /1-18 x Washer Lock Hvy Hlcl Spr 1/ 1 inch =.4 mm. 4 3

15 MOWER DECK _clutch_mod_ _deck-manual_ 1 8

16 MOWER DECK Mower Housing Assembly Bolt Carriage /1-18 x 3/ Bracket Asm Fr. Sway Bar Bracket Deck Sway Bar 38"/4" 4939M Retainer Spring Bar Sway Deck Nut Lock Hex w/ins. /1-18 unc Bolt 3/8-4 x 1. Gr Blade Mower Blade 38" Hi-Lift Shaft Assembly, Mandrel, Vented Housing, Mandrel, Vented X Bearing, Ball, Mandrel Bolt Rdhd. Sqnk. /1-18 x / Bolt, Shoulder Baffle Vortex Front Nut Bracket, Mower Deflector X Cap, Sleeve 1970 Spring, Torsion, Deflector 1104X Nut, Push 7 197X48 Shield, Deflector Rod, Hinge Screw Thdrol Washer, Spacer Pulley, Mandrel Nut, Toplock Pulley, Idler, Flat Pulley Idler Flat Nut, Crownlock 3/8-1 unc H Retainer Spring Idler Arm Assembly 173 Spacer, Retainer X Knob V-Belt Spring Brake Return Washer 13/3 x 13/1 x 11 Ga Spacer Retainer Stiffener, Idler Arm Rod, Brake LH Rod, Brake RH Keeper Belt Idler Tension Spring Return Idler Retainer Spring Yellow Washer 9/3 x 3/4 x 10 Ga Clutch Cable 38"/4" Screw Hex Thd. Cut. 1/4-0 x 1/ Head Asm. Cable Clutch Screw Hex Wsh. Thdrol. 3/8-1 x -3/ Keeper Belt Bolt Carriage Idler Stand, Brake Arm, Brake Spacer, Brake Keeper Belt RH Mandrel Guard Brake Washer Screw Thdrol 3/8-1 x 1/ Bolt/Washer Asm. / Brake Assembly (Includes Stand, Arm and Guard Components) Mandrel Assembly (Includes housing, shaft assembly, and bearing only - pulley/nut/washer and blade bolt/washers not included) Replacement Mower, Complete 1 inch =.4 mm 17

17 MOWER LIFT lift-rh.1piece_ Plunger Asm Lift Lever Shaft Asm Lift RH X Pin Groove 1 00 Zinc E Ring # Washer 1/3 x 1 x 1 Ga X Bearing Nylon Blk 9 Id 7 131X Grip Handle 8 14X Button Plunger Black Link Lift LH Fixed Length Link Lift RH Fixed Length M Retainer Spring Link Front Nut Jam Hex 1/-13 unc Trunnion Nut Lockw/Wsh 1/-13 unc Arm Suspension Rear Pin Cotter 7/1 Bow Tie Lock Bearing Pvt Lift Nut Crownlock 3/ Pin Cotter /1 Bow Tie Lock 1 inch =.4 mm. 18

TRACTOR - - MODEL NUMBER PXT16542 ( ), PRODUCT NO SCHEMATIC SCH03

TRACTOR - - MODEL NUMBER PXT16542 ( ), PRODUCT NO SCHEMATIC SCH03 SCHEMATIC SCH03 BATTERY RED A AMMETER (OPTIONAL) RED FUSE RED SOLENOID STARTER M B S M G A1 L A BLUE WHITE CLUTCH / BRAKE (PEDAL UP) ATTACHMENT CLUTCH (CLUTCH OFF) BLACK BLACK BLACK SEAT SWITCH (NOT OCCUPIED)