Illustrated Parts List I Ride Mower LTH 1538

Transcription

1 Illustrated Parts List I Ride Mower LTH Illustrated Parts List

2 DECALS Decal, Hood Decal, Hood Panel Decal, Customer Respons Decal, Replacement Decal, Steering Wheel Decal, Engine Decal, Battery Dnge/Poi Decal, Warning Decal, Mower V-Belt Schematic Decal, Fender Warn./Instructions Decal, Bypass Pad, Footrest, LH Pad, Footrest, RH WHEELS AND TIRES Cap Valve Tire Stem Valve Rim Asm 6" front Service Tube Front (Service Item Only) Tire Front 5 x Service Fitting Grease (Front Wheel Only) Bearing Flange (Front Wheel Only) Cap Axle Blk 50 x Tire R T 8 x Service Tube Rear (Service Item Only) Rim Asm 8" rear Service Sealant, Tire (0 oz. Tube) inch = 5.4 mm wheel_art_-tex 8

3 SCHEMATIC RED FUSE BATTERY RED SOLENOID STARTER M WHITE WHITE S B M A G L A CLUTCH/BRAKE (PEDAL UP) ATTACHMENT CLUTCH (CLUTCH OFF) GRAY REVERSE SWITCH (NOT IN REVERSE) 3 SEAT SWITCH (NOT OCCUPIED) 6 GRAY /WHITE JUNCTION CONNECTOR CHASSIS HARNESS SHORTING CONNECTOR BLUE IGNITION UNIT (OPTIONAL) HOUR METER SPARK PLUGS GAP ( PLUGS ON TWIN CYL. ENGINES) BLUE FUEL LINE V POWER OUTLET (IF SO EQUIPPED) FUEL SHUT-OFF SOLENOID (IF SO EQUIPPED) RED CHARGING SYSTEM OUTPUT 5AMPDC@36RPM REGULATOR STATOR ORANGE 8 VOLTS 3600 RPM (REGULATOR DISCONNECTED) BROWN LIGHT SWITCH HEADLIGHTS IGNITION SWITCH POSITION CIRCUIT MAKE OFF M+G+A RUN/OVERRIDE B+A RUN B+A L+A START B+S+A CHASSIS HARNESS CONNECTOR (MATING SIDE) DASH HARNESS CONNECTOR (MATING SIDE) WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING. NON-REMOVABLE CONNECTIONS REMOVABLE CONNECTIONS 9

4 ELECTRICAL

5 ELECTRICAL Battery Bolt Hex Head /4-0 x 3/ Box Battery Switch Interlock Push-In Harness Socket Light W/45J Bulb Light Cable Starter Fuse Nut Keps Hex /4-0 unc Cable, Ground Switch, Seat Switch, Ign Key, Ignition Switch Light / Reset Harness Ign. Dash Screw Thd Cut /4-0 x / Cover, Terminal Solenoid Screw Thdrol 5/6-8 x 3/ Harness Chassis Socket Asm Bulb Twistlock Cover, Terminal Battery Harness Pigtail Reverse Switch Screw Plastite 0-4 x Module Reverse ROS inch = 5.4 mm 3

6 TRACTOR - - MODEL NUMBER LTH538 ( ), PRODUCT NO CHASSIS CHASSIS TEX? GT HUSQ 3

7 CHASSIS Logo Dash Hood Lens LH Grille/Lens Asm Lens RH Plate Engine Screw 5/6-8 x 3/ Fender Nut Crown Lock 5/ Screw THDROL 5/6-8 x / Screw Bumper Dash Cupholder Air Duct Bracket Pivot Shield Browning Screw Crossmember Screw 0-4 x 5/ Bushing Steering Chassis Bushing Mtg. Fender Crgo Dash Lower Bolt 5/6-8 UNC x -/ Screw 5/6-8 x 3/ Insert Reflective Nut Lock Hex Flange 5/ Plug Dash Console Asm. Deck Lift Vent Side Hood RH Vent Side Hood LH Vent Top Hood Skirt Side RH Skirt Side LH Bolt 5/6-8 x 3/ Clip Retainer Rod Pivot Hood X-Piece Hood Stop Stud Fastener Bolt Shoulder 5/ Bumper Hood Spacer Fender Nut Lock 5/6-8 UNC Trim Clip Tinnerman inch = 5.4 mm 33

8 DRIVE drive-tex_3-lt-hydro_t_r3 34

9 DRIVE Transaxle, Hydro Gear T (See Transaxle Breakdown) Key Square Washer 3/3 x 3/6 x 6 Ga Spring, Brake Rod Shift Knob Rod, Brake Ring E Rod, Brake, Park Washer 5/3 x -/4 x 6 Ga Cover, Foot Pedal Bolt Pulley Idler Flat Lock Nut 3/ Idler V-Groove 90" Offset V-Belt, Drive Shaft Asm. Pedal Brake Control Console Bolt Hex 5/6-8 Gr Screw /4 x / Strap Torque Rod Spring Bypass Nut Lock 5/6-8 UNC Nut Lock Hex Flange 5/ Bracket Strap Torque Bolt 5/6-8 x Screw 5/6-8 x 3/ Retainer Spring " Pin Cotter /8 x 3/ Retainer Clip Spring, Return, Clutch Adapter, Transaxle T Bushing Nut Push Latch Brake Parking Keeper Belt Centerspan Bolt Nut Push Shaft Asm Shift Arm Clevis Rod Shift Spring Shift Spacer Axle Handle Parking Brake Bolt Spacer Retainer Washer Link Clutch Ground Drive Bellcrank Ground Drive Keeper Bellcrank Ground Drive Washer 5/3 x -5/8 x 6 Ga Retainer Spring Clip Handle Idler V-Groove.688" Offset Bolt 7/6-4 x Gr Washer Serrated Link Shift inch = 5.4 mm 35

10 ENGINE OPTIONAL EQUIPMENT Spark Arrester engine-bs-cyl-tex_4 36

11 ENGINE Engine Briggs Model No. 3E Muffler Keeper Belt Engine Pulley Engine Tank Fuel Cap Asm Control Throttle Screw 0 x 3/4 Single Lead-Hex Fuel Line Spark Arrester Kit Clamp Hose Washer Lock 7/ Nut Keps Hex /4-0 unc Gasket Screw 5/6-8 x 3/ Tube Drain Oil Easy Plug Drain Oil Screw 3/8-6 x / Bolt Hex 7/6-0 x 4 Gr Screw 3/8-6 x Washer 9/3 x 7/8 x 6 Ga Screw /4-0 x 3/4 inch = 5.4 mm For engine service and replacement parts, call the toll free number for your engine manufacturer listed below: Briggs & Stratton Engine Power Rating Information The gross power rating for individual gas engine models is labeled in accordance with SAE (Society of Automotive Engineers) code J940 (Small Engine Power & Torque Rating Procedure), and rating performance has been obtained and corrected in accordance with SAE J995 (Revision 00-5). Actual gross engine power will be lower and is affected by, among other things, ambient operating conditions and engine-to-engine variability. Given both the wide array of products on which engines are placed and the variety of environmental issues applicable to operating the equipment, the gas engine will not develop the rated gross power when used in a given piece of power equipment (actual on-site or net horsepower). This difference is due to a variety of factors including, but not limited to, accessories (air cleaner, exhaust, charging, cooling, carburetor, fuel pump, etc.), application limitations, ambient operating conditions (temperature, humidity, altitude), and engine-to-engine variability. Due to manufacturing and capacity limitations, Briggs & Stratton may substitute an engine of higher rated power for this Series engine. 37

12 SEAT ASSEMBLY seat-tex_6-tex LT Seat Bracket Pivot Fender Strap, Asm Fender Nut, Lock W/Ins. 3/8-6 unc Spring, Seat Cprsn Bolt 5/6-8 uncx 3/4 w/sems Pan, Seat Bolt, Shoulder 5/ Nut, Lock 5/6-8 unc Handle Slide Seat Spring Latch Seat Bolt Fin Hex 3/8-6 unc x 3/ Washer 3/3 x -3/8 x Ga. inch = 5.4 mm 38

13 STEERING ASSEMBLY Wheel, Steering Axle Asm., Front Spindle Asm., LH Spindle Asm., RH Bearing, Race Thrust Harden Washer 5/3 x -5/8 x 6 Ga Ring, Klip #T Cap, Spindle Washer 5/3 x -/4 x 6 Ga Washer, Lock Hvy Hlcl Spr 3/ Nut, Crown Lock 3/8-4 unf Shaft Steering Plate Steering Boot, Steering Adapter, Wheel Steering Bushing, Strg. Blk Insert, Wheel Steering Screw 3/8-6 x 3/ Washer Lock 5/ Gear, Sector Plate Washer /3 x 3/8 x Ga Washer Hardened.793 x.637 x Bracket Upstop Bolt Shoulder Sector Pivot CFM Washer Thrust Sector Steering Nut Flange Lock 5/ Draglink LH Draglink, RH Screw 5/6-8 x 3/ Retainer Clip Spring Steering Bolt Hex Fghd 7/6-4 x 3 Serr Bushing PM Front Axle Nut Lock Flange 7/6-4 Gr Bracket Deck Susp. Front Shaft Extension Steering Bolt 5/6-8 UNC x 4.5. Gr Washer.5 x.505 x.8 inch = 5.4 mm 39

14 MOWER DECK _Tex-LT_

15 MOWER DECK Mower Housing Retainer Spring Arm Suspension Screw 0 x 3/4 Single Lead Hex Bolt/Washer asm 7/6-0 unf Blade Shaft Assembly, Mandrel Housing, Mandrel Bearing, Ball, Mandrel Bolt, Shoulder Nut, Crownlock 5/6-8 unc Bracket, Deflector Cap, Sleeve Spring, Torsion, Deflector Nut, Push Shield, Deflector Rod, Hinge Screw Thdrol Rolling Wsh Hd Washer, Spacer Pulley, Mandrel Nut, Toplock, Flanged Bolt Carr Sh. 3/8-6 x -/ Gr Washer Keeper Belt LH Mandrel Nut, Lock Flg. 3/8-6 unc Spring Torsion Brake Spring Torsion Retainer Screw /4-0 x 5/ Arm, Idler Spacer, Retainer Screw 3/8-6 x Guard, Tuv Idler Arm Brake Mower RH Arm Brake Mower LH Link Brake Handle Clutch Cable V-Belt Bolt Clutch Asm Manual Pin Attachment Cable Switch Interlock Clutch Cable Bolt Carr. 5/6-8 x 5/ Bolt, Shoulder Wheel, Gauge Nut Lock 3/8-6 UNC Washer 3/8 x 7/8 x 4 Ga Keeper Belt Engine LH Keeper Belt Engine RH Keeper Belt Pulley Idler Spring Return Retainer Spring Bracket Manual Clutch Cable Arm Actuator Lever Control Clutch Stud Fastener Nut Lock Hex Flange Bearing Control Lever Clutch Screw 3/8-6 x 3/ Spring Plunger Actuator Baffle Vortex Washer 3/3 x x Mandrel Assembly (Includes housing, shaft and shaft hardware only-pulley not included) Replacement Mower, Complete inch = 5.4 mm 4

16 MOWER LIFT lift-tex_ Shaft Asm., Lift Lever Asm., Lift Rh Grip, Lever Spring Torsion Pin Cotter 7/6 Bow Tie Lock Spring Lift Assist Washer Clear Zinc Pin Cotter 5/6 Bow Tie Lock Link Asm Lift LH Rear Screw HEx Wsh. THDR 3/8-6 x 3/ Link Lift Susp. Front Mower inch = 5.4 mm 4

17 Rev TH Printed in U.S.A.