LGT2554 Illustrated Parts List / /

Transcription

1 0300 LGT554 Illustrated Parts List / / 009-0

2 DECALS Decal, Warning Decal, Ethanol E Decal, Hood Cust Resp Decal, Caution Decal, Mower Sch Decal, Battery Dnge/Poi Decal, Panel Side Decal, Panel Side Decal, Hood Logo Decal, Replacement Decal, Bypass Pad, Footrest, LH Pad, Footrest, RH WHEELS AND TIRES Cap, Valve, Tire Stem, Valve Rim Assembly, Front Tube, Front (Ser vice Item Only) Tire, Front Fitting, Grease (Front Wheel Only) Bearing, Flange (Front Wheel Only) Cap, Axle (Front Wheel Only) Tire, Rear Tube, Rear (Service Item Only) Rim Assembly, Rear Sealant, Tire (0 oz. Tube) inch = 5.4 mm wheel_art_-tex

3 SCHEMATIC SCH A AMMETER (OPTIONAL) RED FUSE BATTERY RED SOLENOID STARTER M WHITE PTO SWITCH (DISENGAGED) WHITE ELECTRIC CLUTCH S B M A G L A RED C A H D WHITE RED CLUTCH/BRAKE (PEDAL UP) GRAY B E REVERSE SWITCH (NOT IN REVERSE) 3 SEAT SWITCH (NOT OCCUPIED) GRAY /WHITE JUNCTION CONNECTOR CHASSIS HARNESS SHORTING CONNECTOR C B A F E D H G BLUE IGNITION UNIT (OPTIONAL) HOUR METER SPARK PLUGS GAP ( PLUGS ON TWIN CYL. ENGINES) PTO SWITCH (MATING SIDE) BLUE FUEL LINE BLUE V POWER OUTLET (OPTIONAL) NOTES ORANGE FUEL SHUT-OFF SOLENOID (IF EQUIPPED) RED CHARGING SYSTEM OUTPUT 9-AMPDC@300 RPM REGULATOR STATOR VOLTS 300 RPM (REGULATOR DISCONNECTED) BROWN LIGHT SWITCH HEADLIGHTS IGNITION SWITCH POSITION CIRCUIT MAKE OFF RUN/OVERRIDE RUN M+G+A B+A B+A L+A START B+S+A 3 CHASSIS HARNESS CONNECTOR (MATING SIDE) 5 4 DASH HARNESS CONNECTOR WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE RE-INSTALLED TO PROPERLY SECURE YOUR WIRING. NON-REMOVABLE CONNECTIONS REMOVABLE CONNECTIONS

4 ELECTRICAL T07S With V Outlet Option With Service Minder Option

5 ELECTRICAL Battery Bolt Hex Hd /4-0 unc x 3/ Battery Box Switch Interlock Harness Socket Light Bulb, Light # Cable Battery Cable Starter Fuse Nut Keps Hex /4-0 unc Cable Ground " Blk Ga Switch Seat Switch Ign Key/Chain Switch Light/Reset Harness Ign. Dash Screw Thd Cut /4-0 x / Cover Terminal Red Solenoid Gauge Hourmeter Switch PTO Screw Thdrol 5/- x 3/ Outlet -Volt Harness Ign Chassis Socket Asm Bulb Cover Terminal Battery Strap Battery Harness Pigtail Reverse Switch Screw Plastite 0-4 X Module Reverse ROS Screw Hexwsh Thdrol /4-0 x 3/ Washer 9/3 x 7/ x Ga Harness Pigtail V Outlet inch = 5.4 mm 3

6 CHASSIS chassis-tex_tex GT HUSQ_40_r 33 3

7 CHASSIS Dash Hood Asm Lens LH Grille Asm Lens RH Plate Engine Screw 5/- x 3/ Fender Nut Crown Lock 5/ Bracket Fender Screw 5/- x / Screw #0 x.750 BOS Thread Bumper Dash Duct Heat Hood Shield Browning/Debris Screw Hex Wsh Hi-Lo /4 x / Bracket Support Tank Crossmember Screw 0-4 x 5/ Bushing Steering Cargo Asm. Net Chassis Bushing Mtg. Fender Crgo Dash Lower Bolt Fin Hex 5/- unc x -/ Screw 5/- x 3/ Nut Lock Hex Flange 5/ Console Asm. Deck Lift Plate Deck Lift Vent Side Hood RH Vent Side Hood LH Vent Asm Hood Top Skirt Hood Side RH Skirt Hood Side LH Bezel RH Bezel LH Insert Hex Top RH Insert Hex Top LH Insert Hex Bottom RH Insert Hex Bottom LH Bolt Hex Hd 5/- unc x 3/ Clip Retainer Rod Pivot Hood Stop Reflector LH Stud Fastener Bolt, Shoulder Bumper Hood Spacer Fender Nut Center Lock 5/- unc Plug Cruise/Phone Trim Nut Push Logo inch = 5.4 mm 33

8 DRIVE drive-tex_k4_fender_

9 DRIVE Transaxle, TUFFTORQ K4 AW (Internal parts not available) 53 - Key Hub Asm. Wheel Rear " TX GT Bolt Hub Wheel Rear Washer 3/3 x 3/ x Ga Spring Brake Rod Shift Knob Rod, Brake Ring E Rod Brake Park Cover Foot Pedal Bolt Pulley Idler Flat Lock Nut 3/ Idler V-Groove 90" Offset V-Belt Drive Shaft Asm. Pedal Brake Control Console Asm Bolt Hex Flghd 5/- Gr Screw /4 x / Strap Torque Rod Bypass Nut Lock Hex Flange 5/ Screw 5/- x 3/ Screw 5/- x / Retainer Spring Pin Cotter / x 3/ Retainer Clip Spring Return Clutch Spacer Transaxle and Nut Push Latch Brake Parking Keeper Belt Centerspan Nut Push Shaft Asm Shift Arm Clevis Rod Shift Spring Shift Spacer Split Handle Parking Brake Bolt Rdhd Sqnk 3/- x -3/4 Gr Spacer Retainer Washer Link Clutch Ground Drive Bellcrank Ground Drive Keeper Bellcrank Ground Drive Screw 3/- x Link Clutch Anti-Rotation Washer Bushing Brake Shaft Bracket Pulley Idler Reflector RH Retainer Spring Clip Handle Keeper Belt Trans Bracket Mount Torque Washer Hardened Idler V-Groove." Offset Washer Serrated Bolt 7/-4 x Gr Link Shift Spacer Split.00 X.350 " T inch = 5.4 mm 35

10 ENGINE SPARK ARRESTER KIT Engine-tex_Kohl-cyl r Engine Kohl Model No. SV Muffler Keeper Belt Engine Clutch Electric Pulley Engine Tank Fuel Cap Asm Control Throttle Screw #0 x.750 BOS Thread Control Choke Fuel Line Spark Arrester Kit Clamp Hose Washer -/ OD x 5/3 ID x Washer Lock 7/ Nut Keps Hex /4-0 unc Shield Heat Muffler Gasket Tube Exhaust LH Tube Exhaust RH Screw Socket Head 5/- x Tube Drain Oil Easy Plug Drain Oil Screw 3/- x Bolt Hex 7/-0 x 3.75 Gr Bolt 5/- unc x w/sems Screw 3/- x Bushing inch = 5.4 mm 3

11 SEAT ASSEMBLY seat-tex_.5sl_ Seat Bracket Pivot Fender Strap, Asm Fender Nut, Lock w/ins. 3/- unc Spring, Seat Cprsn Bolt 5/- unc x 3/4 w/sems Pan, Seat Bolt, Shoulder 5/ Nut, Lock 5/- unc Handle Slide Seat Spring Latch Seat Bolt 3/- x 3/ Washer 3/3 x -3/ x Ga. inch = 5.4 mm 37

12 STEERING ASSEMBLY * * PREM HUSQ SR 5 45 * steering-tex_special_3_r 3

13 STEERING ASSEMBLY Wheel, Steering Axle Asm., Front Spindle Asm., LH Spindle Asm., RH Bearing, Race Thrust Harden Washer 5/3 x -5/ x Ga Ring, Clip #T Cap, Spindle Washer 5/3 x -/4 x Ga Washer, Lock Hvy Hlcl Spr 3/ Nut, Crown Lock 3/-4 unf Shaft Steering Plate Steering Adapter, Wheel Steering Bushing, Strg. Blk Insert, Wheel Steering Screw 3/- x 3/ Gear, Sector Plate Washer 9/ x -3/ x Ga Nut Hex Jam Toplock /-0 unf Washer Hardened.793 x.37 x Bracket Upstop Bolt Shoulder Sector Pivot CFM Washer Thrust Sector Steering Nut Flange Lock 5/ Draglink, LH Draglink, RH Screw 5/- x 3/ Retainer Clip Spring Steering Bolt Hex Fghd 7/-4 x 3 Serr Bushing PM Front Axle Nut Lock Flange 7/-4 Gr Washer.5 x.505 x Bracket Deck Susp. Front inch = 5.4 mm 39

14 MOWER DECK mower_deck 54-tex_ 40

15 MOWER DECK Deck Weldment Mower Cover Mandrel LH Cover Mandrel RH Bolt 7/ Asm. Blade Blade Bagging Blade Mulching Rod Anti Sway Shaft Asm. w/lower Bearing Housing, Mandrel Washer 3/ Bearing, Ball, Mandrel Bolt Carriage 5/- x 5/ Pin Cotter 5/ Bowtie Nut, Crownlock 5/- unc Cap Sleeve Spring, Torsion Nut, Push Deflector Shield Rod, Hinge Screw, Thdroll Washer Head Washer, Spacer Mower Vented Pulley, Mandrel Nut, Flg. Top Lock Nut Crownlock 3/- unc Pulley, Idler, Stationary LH Arm, Idler Screw, Thdroll. /4-0 x 5/ Belt Deck Drive Nut, Lock Flg. 3/- unc Bolt Rdhd Sqnk 3/- unc x Pulley Idler Baffle Right Baffle Left Baffle Center Washer Hardened Spring Drive Bolt Rdhd Sqnk 5/- x 3/ Rod Tension Relief Bolt, Shoulder Gauge Wheel Washer 3/3 x -/4 x Ga Bushing Tension Relief Nut Lock Flange 7/-4 Gr Stud Fastener w/"d" Anti-Rotation Nut Lock Hex Flange Arm Susp. Mower Rear Bolt Shoulder Keeper Belt Idler Bolt Carr Sqnk 7/-4 x Bolt Rdhd 3/- x -/ Gr Screw Washout Port Coupling, Quick Connect Mandrel Assembly (Includes housing, shaft assembly, and bearing only - pulley/nut/washer and blade bolt/washers not included) Replacement Mower, Complete inch = 5.4 mm 4

16 MOWER LIFT lift-tex_ Shaft Asm., Lift Lever Asm., Lift RH Grip, Lever Spring Torsion Pin Cotter 7/ Bow Tie Lock Spring Lift Assist Washer Clear Zinc Pin Cotter 5/ Bow Tie Lock Link Lift Susp Mower Rear Screw 3/- x 3/ Link Lift Susp. Front Mower inch = 5.4 mm 4