Reproduction. Not for

Size: px

Start display at page:

Download "Reproduction. Not for"

Morgan Richard
5 years ago
Views:

1 This product is not serviced by Briggs & Stratton. For parts and service, please contact Husqvarna Outdoor Products (HOP) via Or use our dealer locator at to find your nearest dealer.

2 REPAIR PARTS MANUAL MODEL NO. 4L15G60X8A ( ) LAWN TRACTOR Rev.

3 HOW TO USE THIS MANUAL This manual is designed to provide the customer with a means to identify the parts on his/her tractor when ordering repair parts. The illustrations may or may not represent the actual assemblies; therefore, it is not recommended to use this manual as a guide to assemble or disassemble the tractor. Some hardware and parts are drawn larger in order to more readily identify them. Each tractor has its own model number. The model number for your tractor can be found on the fender under the seat. When ordering parts, always give the following information: Product - Tractor Model Number - 4L15G60X8A ( ) Part Number Part Description TABLE OF CONTENTS SCHEMATIC... 3 ELECTRICAL CHASSIS DRIVE ENGINE STEERING SEAT...14 DECALS MOWER DECK MOWER LIFT... 18

4 SCHEMATIC SCH03 BATTERY RED A AMMETER (OPTIONAL) RED FUSE RED SOLENOID STARTER M B S M G A1 L A BLUE WHITE CLUTCH / BRAKE (PEDAL UP) ATTACHMENT CLUTCH (CLUTCH OFF) BLACK BLACK BLACK SEAT SWITCH (NOT OCCUPIED) BLACK BLUE RED BLACK BLACK/WHITE BLUE FUEL LINE FUEL SHUT-OFF SOLENOID REVERSE SWITCH NOT IN REVERSE IGNITION UNIT HOUR METER (OPTIONAL) GRAY BLACK BLACK SPARK PLUGS GAP ( PLUGS ON TWIN CYL. ENGINES) LIGHT SWITCH ORANGE CHARGING SYSTEM OUTPUT 3 AMP 3600 RPM SHORTING CONNECTOR LIGHTING SYSTEM OUTPUT 5 AMP 3600 RPM STATOR DIODE GRAY 8 VOLTS AC 3600 RPM (CHARGING SYSTEM DISCONNECTED) 14 VOLTS AC 3600 RPM (LIGHTS OFF) BROWN BLACK IGNITION SWITCH POSITION CIRCUIT MAKE OFF M+G+A1 RUN/OVERRIDE B+A1 RUN B+A1 L+A START B+S+A1 NOTE YOUR TRACTOR IS EQUIPPED WITH A SPECIAL ALTERNATOR SYSTEM. THE LIGHTS ARE NOT CONNECTED TO THE BATTERY, BUT HAVE THEIR OWN ELECTRICAL SOURCE. BECAUSE OF THIS, THE BRIGHTNESS OF THE LIGHTS WILL CHANGE WITH ENGINE SPEED. AT IDLE THE LIGHTS WILL DIM. AS THE ENGINE IS SPEEDED UP, THE LIGHTS WILL BECOME THEIR BRIGHTEST. 3 HEADLIGHTS NON-REMOVABLE CONNECTIONS REMOVABLE CONNECTIONS WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE RE-INSTALLED TO PROPERLY SECURE YOUR WIRING.

5 ELECTRICAL L With Ammeter Option D.C. AMPERES Without Ammeter Option With Service Minder Option Without Service Minder Option 5 4

6 ELECTRICAL Battery Bolt Hex Hd 1/4-0 unc x 3/ Box Battery Switch Interlock Harness Asm Light w/415j 415J Bulb Light # Cable Battery 6 Ga. 11" Red Cable Battery Fuse 0 AMP Nut Keps Hex 1/4-0 unc Cable Ground 6 Ga. 1" Black Switch Seat Switch Ign Key/Chain X Switch Light/Reset Harness Ign Bolt Blk Fin Hex 1/ Cover Terminal Red Solenoid Socket Asm. Bulb Twistlock Cover Terminal Battery Harness Pigtail Screw Plastite x Module Reverse ROS NOTE: All component dimensions given in U. S. inches 1 inch = 5.4 mm. 5

7 CHASSIS chassis-stlt_alpha_

8 CHASSIS Chassis Drawbar, Stretch Bumper, Hood/Dash X010 Dash Bolt, Carriage 3/8-16 x Panel Dash LH X010 Panel Slkscr Dash RH X48 Hood Bumper Hood Bolt Fin Hex 3/8-16 unc x 1 Gr Washer 13/3 x 13/16 x 1 Ga Nut Lock Hex w/ins 3/8-16 unc X48 Grille X599 Lens Grille Bar X48 Fender Bracket Fender Repl X Footrest Pnt LH Footrest Pnt RH Bolt Rdhd Sht Sqnk 3/8-16 x 3/ Screw Thdrol 5/16-18 x 1/ TYT Bracket Asm. Pivot Mower Bracket Pivot Dash Lower Keeper Belt Rear LH Screw 3/8-16 x 1-1/ Plate Reinforcement Rod Pivot Hood Screw Thdrol 3/8-16 x 1/ Screw 5/16-18 x 1/ Screw Thdrol 3/8-16 x 1/ Screw Hex Wsh Thdrol 3/ Nut Hexflange Lock Insert Lens Reflect Screw #10 x BOS Thread J Plug Button Blk 359 Dia Choke Plug Dome Plastic NOTE: All component dimensions given in U.S. inches 1 inch = 5.4 mm. 7

9 DRIVE 8

10 DRIVE Transaxle Peerless Model C (Order parts from transaxle manufacturer) Spring Return Brake X Pulley Transaxle 18" Tires Ring Retainer # X Strap Torque 30 Degrees RH Screw 5/16-18 x 3/ Rod Shifter Blk Pin Cotter 1/8 x 1 Cad X Washer Plate Shf 388 Sq Hole Bolt 1/4-8 unf Gr. 8 w/patch Washer Lock Hvy Helical 1/ Bolt Hex Flghd 5/16-18 Gr Nut 5/ Bolt Fin Hex 3/8-16 unc x 1 Gr Nut Lock Hex w/ins 3/8-16 unc X Knob Rod Brake LT Nut Hex Jam 3/8-16 unc X Spring Rod Brake 00 Zinc Washer 13/3 x 13/16 x 16 Ga Pin Cotter 1/8 x 3/4 Cad Rod Brake Parking LT/YT X Cap Brake Parking Bracket Transaxle Bolt Fin Hex 5/16-18 x 3/ Shaft Asm Pedal Foot Nibbed X Bearing Nylon Blk 69 Id Washer 1/3 x 1 x 16 Ga H Pin Roll 3/16 x 1" Pulley Composite Flat Bolt 3/8-16 x -3/ Keeper Belt Idler Pulley Idler V Groove Plastic Bellcrank Clutch Grnd Drv STL X Retainer Belt Style Spring Bolt Carr Sh 3/8-16 x 1-1/ Gr Nut Crownlock 3/8-16 unc Nut Crownlock 5/16-18 unc Link Clutch X Spring Return Clutch Screw 3/8-16 x 1-1/ V-Belt Ground Drive R Cover Pedal Blk Round Engine Pulley LT/YT Bolt Hex 7/16-0 x 4 Gr Washer Lock Hvy Hlcl Spr 7/ Keeper Belt Engine Screw 1/4 x 1/ unc Guide Belt Mower Drive RH Spacer Axle X Washer 5/3 x 1 1/4 x 16 Ga E-ring # X Key Square 0 x 1845/ X Washer 5/3 x 1-5/8 x 16 Ga. 79 8M Key Woodruff Arm Shift Transaxle Shaft Asm Cross Taper Spring Torsion Shift Washer 17/3 x 3/4 x 16 Ga Link Transaxle Nut Lock Center 1/ X48 Console Shift H Retainer Spring 1" Washer 9/3 x 3/4 x 10 Ga X Strap Torque 90 Degrees LH Bolt Rdhd Sq Neck 3/8-16 x Nut Lock Flg 3/ Spacer Retainer Lt Washer 13/3 x x 10 Ga Washer Srrrtd 5/16 ID x 1.0 x Bracket Shift Mount Hub Shift Bolt 1/4-0 x 3/4 Gr Nut Crownlock 1/4-0 unc Bolt Hex Fin 1/4-0 unc x 1 Gr Bracket Pivot Lever Screw 5/16-18 x 5/ Bolt Shoulder 5/16-18 x Plate Fastening Keeper, Belt Transaxle Nyliner Snap-In 5/ Washer Nylon Bolt Carr Sh 3/8-16 x 1-3/4 Gr Nut Hex Flg Lock NOTE: All component dimensions given in U.S. inches 1 inch = 5.4 mm 9

11 ENGINE OPTIONAL EQUIPMENT Spark Arrester engine-stlt_bs_5_r

12 ENGINE Engine Power Rating Information X505 Control Th/ch Paddle Screw Hex Thd Cut 1/4-0 x 1/ Engine, B&S 31A B1 (Order parts from engine manufacturer) Muffler Exhaust B&S Gasket Eng Id Tin Plated Tube Drain Oil Easy Shield BRN/DBR Guard Kit Spark Arrestor (Flat Scrn) Tank Fuel Front Cap Fuel X Clamp Hose Line Fuel 0" Valve Drain Oil X Bushing Snap Nyl Blk Fuel Line Screw Thdrol 1/4-0 x 3/ Screw Hex Wsh Thdrol 3/ Washer 9/3 x 7/8 x 16 Ga Screw Socket Head 5/16-18 x 3/ Screw 3/8-16 x 1-1/ Nut Keps Hex 1/4-0 unc NOTE: All component dimensions given in U.S. inches 1 inch = 5.4 mm For engine service and replacement parts, call the toll free number for your engine manufacturer listed below: Briggs & Stratton The gross power rating for individual gas engine models is labeled in accordance with SAE (Society of Automotive Engineers) code J11940 (Small Engine Power & Torque Rating Procedure), and rating performance has been obtained and corrected in accordance with SAE J1995 (Revision 00-5). Actual gross engine power will be lower and is affected by, among other things, ambient operating conditions and engine-to-engine variability. Given both the wide array of products on which engines are placed and the variety of environmental issues applicable to operating the equipment, the gas engine will not develop the rated gross power when used in a given piece of power equipment (actual on-site or net horsepower). This difference is due to a variety of factors including, but not limited to, accessories (air cleaner, exhaust, charging, cooling, carburetor, fuel pump, etc.), application limitations, ambient operating conditions (temperature, humidity, altitude), and engine-to-engine variability. Due to manufacturing and capacity limitations, Briggs & Stratton may substitute an engine of higher rated power for this Series engine. 11

13 STEERING Steering-stlt_OPP_

14 STEERING Wheel Steering Axle Asm Spindle Asm LH Spindle Asm RH 5 666H Bearing Race Thrust Harden X Washer 5/3 x 1-5/8 x 16 Ga Washer 7/3 x 1-1/4 x 16 Ga Ring Clip #T R Bearing Col Strg Blk Link Drag Washer Lock Hvy Hlcl Spr 3/ Spacer Bearing Axle Front Hexflange Lock Shaft Asm Strg X Bushing Link Drag Blk LR Washer 13/3 x 7/8 x 16 Ga Screw 3/8-16 x 3/ Pin Cotter 1/8 x 3/4 Cad Rod Tie Wire Form Mech Washer Lock 5/ Bushing Strg 5/8 Id Dash Screw Cap Wheel Steering Washer 11/3 x x 1 Ga Nut Crownlock 3/ Adaptor Wheel Strg X48 Boot Dash Mtl Steering Blk X Washer 5/3 x 1 1/4 x 16 Ga Extension Steering X Cap Spindle Fr Top Blk Spacer Brace Axle Bolt RDHD SQNK 3/8-16 x -1/ Brace Axle Steering Asm Bracket Susp Chassis Front Bolt Shoulder 7/ Clip Steering Washer Harden.793 x x Bolt 5/16-18 x 4 Gr. 5 NOTE: All component dimensions given in U.S. inches 1 inch = 5.4 mm. 13

15 SEAT seat_lt.bolt_ Seat Bracket Seat Pivot Bolt Hex 3/8-16 x Washer 13/3 x 1 x10 Ga Clip Push-In Hinged Nut Lock Hex w/ins 3/ X Spring Seat Cprsn 50 Blk Zi Screw 3/8-16 x Washer 13/3 x 1 x 14 Ga Pan Pnt Seat Bracket Pnt Mounting Switch X Bushing Snap Blk Nyl Bolt Rdhd Sht Nk 1/4-0 x 1-1/ Spacer Split.8 x X Spring Cprsn X Nut Lock 1/4 Lge Flg Bolt Shoul der 5/16-18 unc-a Nut Lock Hex w/ins 5/ Bolt Hex Washer 17/3 x 1-3/16 x 1 Ga X Bolt Shoul der 5/16-18 x Washer Lock Hvy Hlcl Spr 1/ NOTE: All component dimensions given in U.S. inches 1 inch = 5.4 mm. 14

16 DECALS Decal, Warning Eng Sym Decal, Warning Symbols Decal, Engine HP Decal, Warning Cutfinger Decal, Lower Dash Decal, Cutfinger Decal, Ins Str Wh Decal, Fender Decal, V-Belt Sch. WHEELS & TIRES 1 6 5, , Decal, Hood LH/RH Set Decal, Saddle Brake Parking Decal, Caution, Battery Decal, Brake/Clutch Sym Decal, Drawbar Load Limit Decal, Handle Lft Height Adj Manual, Operator's (English/Spanish) Manual, Operator's (Portuguese) Manual, Parts (English) 3,9 wheel_ Cap, Tire Valve Stem, Valve 3 106X Tire, Front Tube, Front (Service item only) X64 Rim Assembly, 6" Front 6 78H Fitting, Grease (Front wheel only) H Bearing, Flange (Front wheel only) X64 Rim Assembly, 8" Rear Tire, Rear J Tube, Rear (Service item only) X48 Cap, Hub Axle Sealant, Tire (10 oz. Tube) NOTE: All component dimensions given in U.S. inches 1 inch = 5.4 mm 15

17 MOWER DECK _clutch_mod_

18 MOWER DECK Mower Deck Assembly, 4" Bolt Bracket Asm Fr. Sway Bar 3/ Bracket Asm Deck 4" Sway Bar M Retainer Spring Bar Sway Deck Bolt/Washer Asm. 7/16 (The following blades are available) Blade Mower 4 Hi-Lift (for bagging and discharging) Shaft As m Mandrel Housing Mandrel X Bearing, Ball, Mandrel Bolt, Carriage 5/16-18 x 5/ Bolt, Shoulder Baffle, Vortex Nut Bracket, Deflector Mower 4" X Cap, Sleeve 80 x 11 Blk Mower X Spring, Torsion, Deflector X Nut, Push Phos & Oil X48 Shield, Deflector 4" Blk Washer 11/3 x 5/8 x 16 Ga Rod, Hinge 4" 6 75 W/G Screw Thdrol Washer, Spacer Mower Vented Pulley, Mandrel Nut, Toplock Bolt Carr SH 3/8-16 x 1-1/ Gr Pulley, Idler, Flat Nut Lock 3/ Guard, Mandrel, LH H Retainer Screw, Thdrol 1/4-0 x 5/8 T Washer, Hardened Bolt, Shoulder 5/16-18 unc Arm Assembly, Pad, Brake Washer, Hardened Arm, Idler Spacer, Retainer Guard TUV Idler X Knob Round V-Belt, 4" Mower Anchor Spring Brake Mower Bracket Arm Idler 4" Keeper Belt 4" Clutch Cable Pulley Idler Flat Bolt Carriage Idler Spring Extension Spring Return Idler Retainer Spring Yellow Washer 9/3 x 3/4 x 10 Ga Clutch Cable 4" Screw Hex Thd Cut 1/4-0 x 1/ Bolt Rdhd Sqn 3/8-16 unc x 1-3/ Washer 13/3 x 7/8 x 10 Ga Head Asm Cable Clutch Screw 3/8-16 x 1/ Mandrel Assembly (Includes housing, shaft assembly, and bearing only - pulley/nut/washer and blade bolt/ washers not included) Replacement Mower, Complete NOTE: All component dimensions given in U.S. inches 1 inch = 5.4 mm 17

19 MOWER LIFT lift-rh.1piece_ Plunger Asm Lift Lever Shaft Asm Lift RH X Pin Groove Zinc E Ring # Washer 1/3 x 1 x 1 Ga X Bearing Nylon Blk 69 Id X Grip Handle X Button Plunger Link Lift LH Fixed Length Link Lift RH Fixed Length M Retainer Spring Link Front Nut Jam Hex 1/-13 unc Trunnion Nut Lockw/Wsh 1/-13 unc Arm Suspension Rear Pin Cotter 7/16 Bow Tie Lock Bearing Pvt Lift Nut Crownlock 3/8-4 NOTE: All component dimensions given in U.S. inches 1 inch = 5.4 mm.

20 SERVICE NOTES 19

21 JA Printed in the U.S.A.

TRACTOR - - MODEL NUMBER PXT16542 ( ), PRODUCT NO SCHEMATIC SCH03

TRACTOR - - MODEL NUMBER PXT16542 ( ), PRODUCT NO SCHEMATIC SCH03 SCHEMATIC SCH03 BATTERY RED A AMMETER (OPTIONAL) RED FUSE RED SOLENOID STARTER M B S M G A1 L A BLUE WHITE CLUTCH / BRAKE (PEDAL UP) ATTACHMENT CLUTCH (CLUTCH OFF) BLACK BLACK BLACK SEAT SWITCH (NOT OCCUPIED)