SPN 1176/FMI 3 SPN 1176/FMI 4
|
|
- Merry Todd
- 5 years ago
- Views:
Transcription
1 NUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 MBE 900 DATE: August 2013 SUBJECT: SPN 1176/FMI 3, 4 ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change DDC-SVC-MAN-0015 EPA07 MBE 900 SPN 1176/FMI 3 SPN 1176/FMI 4 Six new steps have been added to the procedures, SPN step references are corrected. NOTE: Page numbers are based on the most recent version of the individual publication and may be adjusted throughout the annual print cycle.
2 SPN 1176/FMI 3 This diagnosis is typically Turbo Inlet Pressure Circuit Failed High. Figure 1 Turbo Inlet Pressure Sensor HIGH CIRCUIT CHECK Check as follows: 1. Connect DDDL/DDRS 7.x (latest version). 2. Turn the ignition ON (key ON, engine OFF). 3. Check for multiple codes. [a] If SPN 1172/FMI 3 or SPN 4192/FMI 3 are also present, go to step 4. [b] If only 1176/3 is present, go to step Turn the ignition switch OFF. 5. Disconnect the MCM 120-pin connector. 6. Inspect the MCM 120-pin connector and 120-pin harness connector for signs of damage, bent, spread, corroded or pushed out (unseated) pins, or signs of wire damage. [a] If signs of damage are present, repair as necessary. Refer to [b] If no signs of damage are present, go to step Measure the resistance between pin 105 of the MCM 120-pin connector and each of the following: pin 4 of the Turbo Inlet Pressure sensor harness pin 1 of the Turbo Inlet Temperature sensor harness pin 3 of the Water-In-Fuel (WIF) sensor harness
3 [a] If the resistance measurement is greater than 5 ohms for any of the listed checks, repair the wire between the sensor and pin 105 of the MCM 120-pin harness connector. Refer to [b] If the resistance is less than 5 ohms for each of the resistance checks, go to step Measure the resistance between pin 1 of the Turbo Inlet Pressure sensor harness connector and pin 120 of the MCM 120-pin harness connector. [a] If the resistance is greater than 5 ohms, repair the wire between pin 1 of the Turbo Inlet Pressure sensor harness connector and pin 120 of the MCM 120-pin harness connector. Refer to [b] If the resistance is less than 5 ohms, go to step Measure the resistance between pins 1 and 2 of the Turbo Inlet Pressure sensor harness connector. [a] If the resistance is less than 10K ohms, repair the short in the wires between pins 1 and 2 of the Turbo Inlet Pressure sensor harness connector.refertosection. [b] If the resistance is greater than 10K ohms, go to step Reconnect the MCM 120-pin harness connector. 11. Turn ignition ON (key ON, engine OFF). 12. Measure the voltage between pins 2 and 4 of the Turbo Inlet Pressure sensor harness connector. [a] If the voltage is between 4.5 and 5.5 volts, replace the Turbo Inlet Pressure sensor. Refer to [b] If the voltage is less than 4.5 volts, review the previous steps of this procedure. If the problem is still unresolved, contact the Detroit Diesel Customer Support Center at for additional information. 13. Turn the ignition OFF. 14. Disconnect the MCM 120-pin connector. 15. Inspect the MCM 120-pin connector and 120-pin harness connector for signs of damage, bent, spread, corroded or pushed out (unseated) pins, or signs of wire damage. [a] If signs of damage are present, repair as necessary. Refer to [b] If no signs of damage are present,gotostep Measure the resistance between pin 105 of the MCM 120-pin connector and pin 4 of the Turbo Inlet Pressure sensor. [a] If the resistance measurement is greater than 5 ohms, repair the wire between the sensor and pin 105 of the MCM 120-pin harness connector. Refer to [b] If the resistance is less than 5 ohms, go to step Measure the resistance between pin 1 of the Turbo Inlet Pressure sensor harness connector and pin 120 of the MCM 120-pin harness connector.
4 [a] If the resistance is greater than 5 ohms, repair the wire between pin 1 of the Turbo Inlet Pressure sensor harness connector and pin 120 of the MCM 120-pin harness connector. Refertosection. [b] If the resistance is less than 5 ohms, go to step Measure the resistance between pins 1 and 2 of the Turbo Inlet Pressure sensor. [a] If the resistance is less than 10K ohms, repair the short in the wires between pins 1 and 2 of the Turbo Inlet Pressure sensor. Refer to [b] If the resistance is greater than 10K ohms, go to step Reconnect the MCM 120-pin connector. 20. Turn the ignition ON (key ON, engine OFF). 21. Measure the voltage between pins 2 and 4 of the Turbo Inlet Pressure sensor harness connector. [a] If the voltage is between 4.5 and 5.5 volts, replace the Turbo Inlet Pressure sensor. Refer to [b] Review the previous steps. If a problem still exists, contact the Customer Support Center at for further instructions. VERIFY REPAIRS Verify repairs as follows: 1. Turn ignition OFF. 2. Reconnect any electrical connections that were disconnected to perform the diagnosis. 3. Clear codes with DDDL 7.0 or latest version. 4. Start and bring engine up to operating temperature (over 140 F/60 C). 5. Verify operation is satisfactory and no warning lamps illuminate. If warning lamps illuminate, troubleshoot the codes. If assistance is required, call the Detroit Diesel Customer Support Center ( ).
5 SPN 1176/FMI 4 This diagnosis is typically Turbo Inlet Pressure Circuit Failed Low. Figure 2 Turbo Inlet Pressure Sensor LOW CIRCUIT CHECK Check as follows: 1. Turn the ignition OFF. 2. Disconnect the Turbo Inlet Pressure sensor. 3. Inspect the Turbo Inlet Pressure sensor connector and harness connector for signs of damage, bent, spread, broken, corroded, pushed out (unseated) pins or damage to wiring near connector. [a] If signs of damage are present, repair as necessary. Refer to [b] If only 1176/4 is present, go to step Turn the ignition ON (key ON, engine OFF). 5. Measure the voltage between pins 2 and 4 of the Turbo Inlet Pressure sensor harness connector. [a] If the voltage is between 4.5 and 5.5 volts, go to step 7. [b] If the voltage is less than 4.5 volts, go to step Measure the voltage between pin 2 of the Turbo Inlet Pressure sensor harness connector and battery ground. [a] If the voltage is less than 4.5 volts, repair the wire between pin 85 of the MCM 120-pin harness connector and pin 2 of the Turbo Inlet Pressure sensor and pin 29 of the OEM 31-pin harness connector. See figure 2. Turbo Inlet Pressure Sensor for detail. Refer to [b] If the voltage is between 4.5 and 5.5 volts, go to step 7.
6 7. Turn the ignition OFF. 8. Disconnect the MCM 120-pin harness connector. 9. Inspect the MCM 120-pin connector and 120-pin harness connector for signs of damage, bent, spread, broken, pushed out (unseated ) or corroded pins or signs of wire damage. [a] If signs of damage are present, repair as necessary. Refer to [b] If no signs of damage are present, Go to step Measure the resistance between pin 1 of the Turbo Inlet Pressure sensor harness connector and pin 120 of the MCM 120-pin harness connector. [a] If the resistance is greater than 5 ohms, repair the wire between pin 1 of the Turbo Inlet Pressure harness connector and pin 120 of the MCM 120-pin harness connector. Refer to [b] If the resistance is less than 5 ohms, go to step Measure the resistance between pins 1 and 4 of the Turbo Inlet Pressure harness connector. [a] If the resistance is less than 10K ohms, repair the shorted wires between pins 1 and 4 of the Turbo Inlet Pressure sensor harness connector. Refer to [b] If the resistance is greater than 10K ohms, go to step Measure the resistance between pins 1 and 2 of the Turbo Inlet Pressure sensor. [a] If the resistance is less than 10 K ohms, repair the shorted wires between pins 1 and 2 of the Turbo Inlet Pressure sensor harness connector. Refer to [b] If the resistance is greater than 10K ohms, go to step Measure the resistance between pin 1 of the Turbo Inlet Pressure sensor and battery ground. [a] If the resistance is less than 10K ohms, repair the shorted wire between pin 1 of the Turbo Inlet Pressure sensor harness connector and pin 120 of the MCM 120-pin harness connector. [b] If the resistance is greater than 10K ohms, go to step Reconnect the 120-pin MCM connector. 15. Turn the ignition ON (key ON, engine OFF). 16. Measure the voltage between pins 2 and 4 of the Turbo Inlet Pressure sensor harness connector. [a] If the voltage is between 4.5 and 5.5 volts, replace the Turbo Inlet Pressure sensor. Refer to [b] If the voltage is less than 4.5 volts, review the previous steps of this procedure. If the problem is still unresolved, contact the Detroit Diesel Customer Support Center at for additional information. VERIFY REPAIRS Verify repairs as follows: 1. Turn ignition OFF. 2. Reconnect any electrical connections that were disconnected to perform the diagnosis.
7 3. Clear codes with DDDL 7.0 or latest version. 4. Start and bring engine up to operating temperature (over 140 F/60 C). 5. Verify operation is satisfactory and no warning lamps illuminate. If warning lamps illuminate, troubleshoot the codes. If assistance is required, call the Detroit Diesel Customer Support Center ( ).
8 ADDITIONAL SERVICE INFORMATION Additional service information is available in Power Service Literature. TM Detroit, DDC, Series 60 and the spinning arrows design are registered trademarks of Detroit Diesel Corporation. Copyright 2013 Detroit Diesel Corporation. All rights reserved. Printed in U.S.A.
NUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: October 2010
NUMBER:10 02 10 S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: October 2010 SUBJECT: DOUBLEHYSTERESISTEST ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA10 DD Platform DATE: August 2010
NUMBER: 815 10 S.M. REF.: Listed in Table ENGINE: EPA10 DD Platform DATE: August 2010 SUBJECT: SPN 3226 FMI 13 SCR OUTLET NOX SENSOR SIGNAL NOT AVAILABLE ADDITIONS, REVISIONS, OR UPDATES Publication Number
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: April 2009
NUMBER: 4 7 09 S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: April 2009 SUBJECT: SPN 27 ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page Number(s) DDC-SVC-MAN-0009
More informationAdditions, Revisions, or Updates
1 01 11-16 SUBJECT DATE SPN 647 (MCM)(EPA07-EPA10-GHG14) January 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DDC-SVC-MAN-S084 DD Platform
More informationNUMBER: 08 DDEC VI 16 S.M. REF.: listed in Table 1 ENGINE: DD15 DATE: April 2008 SUBJECT: SPN 1636 AND SPN 2630 PUBLICATION: DDC-SVC-MAN-0029
NUMBER: 08 DDEC VI 16 S.M. REF.: listed in Table 1 ENGINE: DD15 DATE: April 2008 SUBJECT: SPN 1636 AND SPN 2630 PUBLICATION: DDC-SVC-MAN-0029 The procedure and direction for SPN 1636 have changed. SPN
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: April 2009
NUMBER: 4 11 09 S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: April 2009 SUBJECT: SPN 2631 ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page Number(s) DDC-SVC-MAN-0010
More informationAdditions, Revisions, or Updates
1 8 02-14 SUBJECT DATE SPN 4334 (ACM) (GHG14) August 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 4334/FMI 3 - DDC-SVC-MAN-0084 GHG14 DD Platform GHG14
More informationAdditions, Revisions, or Updates
1 3 30-12 SUBJECT DATE SPN 1761/FMI 2, 9 - MY13 March 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 MY13 DD Platform SPN 1761/FMI 2 - MY13
More informationAdditions, Revisions, or Updates
1 10 28-13 SUBJECT DATE SPN 625/FMI 9 EPA10 - GHG14 (ACM) October 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10/ GHG14 DD Platform
More informationAdditions, Revisions, or Updates
1 8 04-12 SUBJECT DATE SPNs 4354/FMI 5, 4355/FMI 5, 4356/FMI 5, 4357/FMI 5 August 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 4354/FMI 5 DDC-SVC-MAN-0084
More informationTwo SPNs and their FMIs have been reassigned numbers as listed in Table 1. The troubleshooting procedures are the same.
NUMBER: 07 DDEC VI 36 S.M. REF.: 129, 130 ENGINE: EPA07 Series 60 DATE: November 2007 SUBJECT: REASSIGNED SPN NUMBERS PUBLICATION: 6SE567 Two SPNs and their FMIs have been reassigned numbers as listed
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: May 2013 SUBJECT: SPN 2631/FMI 2 ADDITIONS, REVISIONS, OR UPDATES
NUMBER: 5 26 13 S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: May 2013 SUBJECT: SPN 2631/FMI 2 ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change DDC-SVC-MAN-0010
More informationAdditions, Revisions, or Updates
1 01 06-16 SUBJECT SPN 4334/FMI 4 (ACM) (GHG14) SPN 4334/FMI 4 (ACM) (GHG17) DATE January 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084
More informationAdditions, Revisions, or Updates
1 10 16-13 SUBJECT DATE SPN 3216/FMI 13 - EPA10/GHG14 October 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10 GHG14 DD Platform SPN
More informationAdditions, Revisions, or Updates
10 15-13 1 10 15-13 SUBJECT DATE SPN 4257/FMI 3, 4 October 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10/ GHG14 DD Platform SPN 4257/FMI
More informationAdditions, Revisions, or Updates
1 8 05-12 SUBJECT DATE SPN 4354/FMI 5, 4356/FMI 5, 4355/FMI 5, 4357/FMI 5 August 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 4354/FMI 5 DDC-SVC-MAN-0084
More informationAdditions, Revisions, or Updates
1 8 09-14 SUBJECT DATE SPN 3361 (ACM) (GHG14) August 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 3361/FMI 3, 4, 5, 31
More informationNUMBER: 08 DDEC VI 10 S.M. REF.: 92 ENGINE: EPA07 Series 60 DATE: March 2008
NUMBER: 08 DDEC VI 10 S.M. REF.: 92 ENGINE: EPA07 Series 60 DATE: March 2008 SUBJECT: SPN 2659 PUBLICATION: DDC-SVC-MAN-0009 (6SE567) Section SPN 2659/FMI 0, refer to section 92.1 SPN 2659/FMI 17, refer
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: September 2009
NUMBER: 9 3 09 S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: September 2009 SUBJECT: TURBOCHARGER WASTEGATE ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page
More informationAdditions, Revisions, or Updates
1 6 05-13 SUBJECT DATE SPN 625/FMI 9 EPA10 - GHG14 June 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10/ GHG14 DD Platform SPN 625/FMI
More informationAdditions, Revisions, or Updates
1 06 10-16 SUBJECT SPN 111 (CPC) (GHG17) and SPN 111 (CPC) (EPA07;EPA10;GHG14) DATE June 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0191
More informationRev Rev. Additions, Revisions, or Updates
1 4 89-12Rev SUBJECT DATE SPN 5927/FMI 2 and 7 - GHG14 April 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 5927/FMI 2 - DDC-SVC-MAN-0084 DD Platform
More informationAdditions, Revisions, or Updates
1 10 09-14 SUBJECT DATE SPN 5016 (ACM) (GHG14) October 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 5016/FMI 3 - DDC-SVC-MAN-0084 GHG14 DD Platform
More informationAdditions, Revisions, or Updates
1 02 01-14 SUBJECT DATE SPN 1761/FMI 3, 4 ( ACM2-EPA10) (ACM2.1-GHG14) February 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform
More informationAdditions, Revisions, or Updates
1 8 03-13 SUBJECT DATE SPN 51/FMI 2, 10, 18 August 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DD Platform SPN 51/FMI 2 All Years Most steps have been
More informationAdditions, Revisions, or Updates
1 5 25-13 SUBJECT DATE SPN 2791/FMI 7 ALL YEARS May 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 2791/FMI 7 Deleted part
More informationNotice Added to Sections Listed Below February Removal of the Bypass Valve. Removal of the Pressure Relief Valve
2 15-12 1 2 15-12 SUBJECT DATE Notice Added to Sections Listed Below February 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0082 Removal of
More informationAdditions, Revisions, or Updates
1 29-13 1 1 29-13 SUBJECT DATE DD Platform GHG 14 SPN 3361 FMI 3, 4, 5 UPDATE January 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 GHG
More informationNUMBER: 08 FSTG 12 REV S.M. REF.: Listed in Table ENGINE: EPA07 DD15 DATE: February 2009
NUMBER: 08 FSTG 12 REV S.M. REF.: Listed in Table ENGINE: EPA07 DD15 DATE: February 2009 SUBJECT: ISB (IDLE SPEED BALANCE) VALUES ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title
More informationAdditions, Revisions, or Updates
1 5 03-14 SUBJECT DATE SPN 3599/FMI 3 and 4 (ACM) May 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3599/FMI 3-1 DDC-SVC-MAN-0084 EPA10/ GHG14 DD Platform
More informationAdditions, Revisions, or Updates
6 12-14 1 6 12-14 SUBJECT DATE SPN 5741 (ACM) (GHG14) May 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 5741/FMI 4 DDC-SVC-MAN-0084 GHG14 DD Platform
More informationAdditions, Revisions, or Updates
1 01 29-14 SUBJECT DATE SPN 3511/FMI 3 and 4 - GHG14 January 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3511/FMI 3 - DDC-SVC-MAN-0084 GHG14 DD Platform
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: February 2009
NUMBER: 2 5 09 S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: February 2009 SUBJECT: VALVE LIFT SPECIFICATIONS ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change
More informationAdditions, Revisions, or Updates
1 6 07-15 SUBJECT DATE SPN 3464 (MCM) (EPA10;GHG14) June 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3464/FMI 3 - DDC-SVC-MAN-0084 EPA10/ GHG14 DD
More informationAdditions, Revisions, or Updates
1 6 13-14 SUBJECT DATE SPN 4259/FMI 4 (MCM) (EPA07) June 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA07 DD Platform SPN 4259/FMI 4
More informationSPN 723/FMI 3, 8, 10, 11, 31 - All Years February SPN 723/FMI 3 - All Years. SPN 723/FMI 8 - All Years. SPN 723/FMI 10 - All Years
1 49-13 1 1 49-13 SUBJECT DATE SPN 723/FMI 3, 8, 10, 11, 31 - All Years February 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 723/FMI 3 - All Years
More informationNUMBER: 1 DDEC VI 07 S.M. REF.: Listed in Table 1 ENGINE: Series 60 DATE: February 2007
NUMBER: 1 DDEC VI 07 S.M. REF.: Listed in Table 1 ENGINE: Series 60 DATE: February 2007 SUBJECT: SENSOR RESISTANCE CHART PUBLICATION: 6SE567 The Series 60 DDEC VI Troubleshooting Guide has been revised.
More informationAdditions, Revisions, or Updates
1 4 09-14 SUBJECT DATE ACM2.1 SPN 3597/FMI 3, 4 - GHG14 April 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 3597/FMI 3,
More informationAdditions, Revisions, or Updates
1 SUBJECT DATE SPN 3250/FMI 0, 15 - EPA10 October 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3250/FMI 0 - DDC-SVC-MAN-0084 EPA10 DD Platform EPA10
More informationAdditions, Revisions, or Updates
1 9 04-11 SUBJECT DATE SPN 3250 / FMI 16 DOC Outlet Temperature High August 2011 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA07 DD13/DD15
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: February 2011
NUMBER: 2 15 11 S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: February 2011 SUBJECT: FAULTY FUEL INJECTOR ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page
More informationAdditions, Revisions, or Updates
1 SUBJECT DATE SPN 3659/FMI 5 GHG14 MCM2.1 May 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 GHG14 DD Platform SPN 3659/FMI 5 GHG14 This
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: August 2009
NUMBER: 8 5 09 S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: August 2009 SUBJECT: CYLINDERHEADCOOLANTVENTLINE ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change
More informationNUMBER: S.M. REF.: Listed in Table 1 ENGINE: DD13 DATE: October 2009
NUMBER: 10 09 09 S.M. REF.: Listed in Table 1 ENGINE: DD13 DATE: October 2009 SUBJECT: INTERMEDIATE FRAME / FUEL INJECTOR WIRING HARNESS ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section
More informationAdditions, Revisions, or Updates
1 5 20-12 SUBJECT DATE SPN 3664/FMI 5 GHG14 June 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 GHG14 DD Platform SPN 3664/FMI 5 GHG14 This
More informationAdditions, Revisions, or Updates
03 57-17 1 03 57-17 SUBJECT DATE SPN 625 (CPC) (GHG17) March 2017 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0191 GHG17 DD Platform SPN 625/FMI
More informationEPA10 DOC Inlet Pressure Sensor November Removal of the EPA10 Diesel Oxidation Catalyst Inlet Pressure Sensor. without Sensor Box
11 10-14 1 11 10-14 SUBJECT DATE EPA10 DOC November 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Removal of the EPA10 DDC-SVC-MAN-0083 EPA10 DD Platform
More informationAdditions, Revisions, or Updates
1 9 19-13 SUBJECT DATE SPN 102/FMI 18 - GHG14 MCM2.1 October 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 102/FMI 18 Complete
More informationAdditions, Revisions, or Updates
01 04-15 1 01 04-15 SUBJECT DATE SPN 3464/ FMI 16, 18 (MCM) (GHG14) January 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: DD15 DATE: March 2009
NUMBER: 3 3 09 S.M. REF.: Listed in Table ENGINE: DD15 DATE: March 2009 SUBJECT: FUEL FILTER ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page Number(s) DDC-SVC-MAN-0037
More informationThe Aftertreatment System Technician's Guide (7SE63) was revised to include three new procedures.
NUMBER: 07 ATS 3 S.M. REF.: Listed in Table 1 ENGINE: ATS DATE: December 2007 SUBJECT: ADDITIONAL PROCEDURES WERE ADDED TO AFTERTREATMENT SYSTEM PUBLICATION: 7SE63 The Aftertreatment System Technician's
More informationAdditions, Revisions, or Updates
1 01 06-15 SUBJECT DATE SPN 3251 (ACM) (EPA10) and (GHG14) January 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3251/FMI 0 - GHG14 DDC-SVC-MAN-0084
More informationNUMBER: S.M. REF.: 8.5 ENGINE: EPA07 Series 60 DATE: November 2008
NUMBER: 08 60-7 S.M. REF.: 8.5 ENGINE: EPA07 Series 60 DATE: November 2008 SUBJECT: EGR RATE MEASUREMENT SYSTEM PUBLICATION: DDC-SVC-MAN-0005 EGR Rate Measurement System has new information added. EGR
More informationPublication Number / Title Platform Section Title Change SPN 5246/FMI 0- EPA10 SPN 5246/FMI 15 - EPA10 SPN 5246/FMI 16 - EPA10 SPN 5246/FMI 0 - GHG14
1 3 04-14 SUBJECT SPN 5246/FMI 0, 15, 16 (ACM2)(EPA10) SPN 5246/FMI 0, 15, 16 (ACM2.1)(GHG14) DATE March 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN
More informationSPN 3480/FMI 0, 1, 3, 4, 14, 21, 31 October 2012 SPN 3480/FMI 0 SPN 3480/FMI 1 SPN 3480/FMI 3 SPN 3480/FMI 4 SPN 3480/FMI 14 SPN 3480/FMI 21
1 10 85-12 SUBJECT DATE SPN 3480/FMI 0, 1, 3, 4, 14, 21, 31 October 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3480/FMI 0 SPN 3480/FMI 1 DDC-SVC-MAN-0084
More informationAdditions, Revisions, or Updates
1 10 26-13 SUBJECT DATE SPN 3216/FMI 16 and 18 October 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 GHG14 DD Platform SPN 3216/FMI 16
More informationAdditions, Revisions, or Updates
1 06 13-16 SUBJECT DATE SPN 1590 (CPC) (GHG17) June 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0193 GHG17 Medium Duty SPN 1590/FMI 9 - GHG17
More informationAdditions, Revisions, or Updates
1 11 19-13 SUBJECT DATE SPN 3216/FMI 2, 18 GHG14 (MCM2.1) November 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3216/FMI 2 DDC-SVC-MAN-0084 GHG14 DD
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: DD Platform DATE: May 2010
NUMBER: 5 04 10 S.M. REF.: Listed in Table ENGINE: DD Platform DATE: May 2010 SUBJECT: FUEL SYSTEM PRIMING USING ESOC 350 FUEL PRIMING PUMP ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA04 MBE 4000 DATE: April 2009
NUMBER: 4 8 09 S.M. REF.: Listed in Table ENGINE: EPA04 MBE 4000 DATE: April 2009 SUBJECT: CYLINDER HEAD INSTALLATION ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page
More informationSPN 3509 (MCM) (EPA10) and SPN 3509 (MCM) (GHG14) June 2014 SPN 3509/FMI 3 - EPA10 SPN 3509/FMI 4 - EPA10 SPN 3509/FMI 3 - GHG14
1 SUBJECT DATE SPN 3509 (MCM) (EPA10) and SPN 3509 (MCM) (GHG14) June 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3509/FMI 3 - EPA10 The diagnostic
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA04 MBE 4000 DATE: September 2009
NUMBER: 9 1 09 S.M. REF.: Listed in Table ENGINE: EPA04 MBE 4000 DATE: September 2009 SUBJECT: ENGINE OIL AND FILTER CHANGING ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title
More informationAdditions, Revisions, or Updates
11 54-16 1 11 54-16 SUBJECT SPN 3242 (ACM) (EPA10;GHG14) SPN 3250 (ACM) (EPA10;GHG14) SPN 3251 (ACM) (GHG14) DATE November 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07/10 DD Platform DATE: September 2010
NUMBER: 9 09 10 S.M. REF.: Listed in Table ENGINE: EPA07/10 DD Platform DATE: September 2010 SUBJECT: INSTALLATION OF THE CAMSHAFT AND ROCKER SHAFT/ENGINE BRAKE ASSEMBLY ADDITIONS, REVISIONS, OR UPDATES
More informationAdditions, Revisions, or Updates
1 3 01-15 SUBJECT SPN 3251 (ACM) (EPA10) and (ACM) (GHG14), 3936 (ACM) (EPA10;GHG14), and 5298 (ACM) (EPA10;GHG14) DATE March 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section
More informationAdditions, Revisions, or Updates
1 9 14-14 SUBJECT DATE SPN 3563 (MCM) (GHG14) September 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 GHG14 DD Platform SPN 3563/FMI 21
More informationAdditions, Revisions, or Updates
1 2 30-14 SUBJECT DATE SPN 4375/FMI 6 - EPA10 February 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10 DD Platform SPN 4375/FMI 6 -
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: June 2012 SUBJECT: E3 FUEL INJECTOR TUBE ADDITIONS, REVISIONS, OR UPDATES
NUMBER: 6 25 12 S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: June 2012 SUBJECT: E3 FUEL INJECTOR TUBE ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change E3 Fuel
More informationAdditions, Revisions, or Updates
1 SUBJECT DATE SPN 51/FMI 10 and 18 March 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 GHG14 DD Platform SPN 51/FMI 10 SPN 51/FMI 18 The
More informationAdditions, Revisions, or Updates
1 SUBJECT SPN 3216 (ACM) (GHG17) SPN 3217 (ACM) (GHG17) DATE March 2017 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0193 GHG17 Medium Duty SPN
More informationAdditions, Revisions, or Updates
1 12 12-14 SUBJECT DATE SPN 3250 (ACM) December 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10 and GHG14 DD Platform SPN 3250/FMI
More informationAdditions, Revisions, or Updates
1 12 05-16 SUBJECT SPN 636 (MCM) (GHG17) SPN 636 (MCM) (EPA07;EPA10;GHG14) SPN 636 (MCM) (GHG14) DATE December 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change
More informationAdditions, Revisions, or Updates
6 22-12 1 6 22-12 SUBJECT DATE SPN 4335/FMI 1 - EPA10 June 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10 DD Platform SPN 4335/FMI
More informationAdditions, Revisions, or Updates
1 4 30-12 SUBJECT DATE SPN 164/FMI 15 (MCM2.1) MY13 April 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 MY13 DD Platform SPN 164/FMI 15
More informationNUMBER: S.M. REF.: Listed in Table 1 ENGINE: DD13 DATE: July 2009
NUMBER: 7 4 09 S.M. REF.: Listed in Table 1 ENGINE: DD13 DATE: July 2009 SUBJECT: EXHAUST GAS RECIRCULATION COOLER WATER MANIFOLD ASSEMBLY ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section
More informationAdditions, Revisions, or Updates
1 2 22-14 SUBJECT DATE SPN 4334/FMI 7 (ACM) (EPA10) February 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform - EPA10- ACM SPN
More informationAdditions, Revisions, or Updates
4 68-12 1 4 68-12 SUBJECT DATE SPN 5018/FMI 18 - GHG14 September 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 5018/FMI
More informationSPN (ACM) (GHG17) and SPN (ACM) (GHG17) February Publication Number / Title Platform Section Title Change
1 02 11-17 SUBJECT DATE SPN 520371 (ACM) (GHG17) and SPN 520372 (ACM) (GHG17) February 2017 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0193 GHG17
More informationAdditions, Revisions, or Updates
2 27-14 1 2 27-14 SUBJECT DATE SPN 4335/FMI 7 - EPA10 February 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 4335/FMI 7
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: August 2013 SUBJECT: VALVE LASH ADJUSTMENTS ADDITIONS, REVISIONS, OR UPDATES
NUMBER: 8 34 13 S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: August 2013 SUBJECT: VALVE LASH ADJUSTMENTS ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change DDC-SVC-MAN-0005
More informationSPN 3480 (MCM)(EPA07;EPA10;GHG14) June Publication Number / Title Platform Section Title Change
6 06-15 1 6 06-15 SUBJECT DATE SPN 3480 (MCM)(EPA07;EPA10;GHG14) June 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Revised step 3,14, and 29. DDC-SVC-MAN-0084
More informationAdditions, Revisions, or Updates
1 01 06-17 SUBJECT DATE SPN 520296 (MCM) (GHG14) and SPN 520296 (MCM) (GHG17) January 2017 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DDC-SVC-MAN-0191
More informationAdditions, Revisions, or Updates
1 7 18-12 SUBJECT DATE SPN 520268/FMI 16, 18 (MCM2.1) July 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 520268/FMI 16 DDC-SVC-MAN-0084 GHG14 DD Platform
More informationAdditions, Revisions, or Updates
1 8 33-13 SUBJECT DATE SPN 3364/FMI 1, 17 (ACM2-EPA10) August 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 3364/FMI 1,
More informationAdditions, Revisions, or Updates
1 01 28-14 SUBJECT Symptom Diagnostics - Rough Running or Stalling - Two Filter Fuel System DATE January 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084
More informationAdditions, Revisions, or Updates
1 8 08-14 SUBJECT DATE SPN 4364 (ACM) (EPA10) August 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 4364/FMI 1 - EPA10 SPN
More informationAdditions, Revisions, or Updates
1 2 19-11 SUBJECT DATE Revised ACM SPN 3364/FMI 1, 2, and 17 February 2011 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10 DD Platform SPN
More informationAdditions, Revisions, or Updates
1 3 21-15 SUBJECT DATE SPN 4364 (ACM) (GHG14) March 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 GHG14 DD Platform SPN 4364/SPN 18 - GHG14
More informationAdditions, Revisions, or Updates
1 03 12-17 SUBJECT DATE SPN 157 (MCM) GHG17 March 2017 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0193 DD Platform - Med Duty SPN 157/FMI 16 -
More information34 FLASH CODE 34 - TBS LOW
34 FLASH CODE 34 - TBS LOW Section Page 34.1 DESCRIPTION OF FLASH CODE 34... 34-3 34.2 SAE J1587 EQUIVALENT CODE FOR FLASH CODE 34... 34-3 34.3 TROUBLESHOOTING FLASH CODE 34... 34-4 Figure 34-1 Turbo Boost
More informationAdditions, Revisions, or Updates
1 03 13-17 SUBJECT DATE SPN 520268 (MCM) (GHG17) March 2017 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0193 DD Platform Med Duty SPN 520268/ FMI
More informationEGR heater plate removal and installation procedure has been added.
NUMBER: 08 60-3 S.M. REF.: 8.3 ENGINE: EPA07 Series 60 DATE:June 2008 SUBJECT: EGR HEATER PLATE PUBLICATION: DDC-SVC-MAN-0005 EGR heater plate removal and installation procedure has been added. 8.3.1 REMOVAL
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: DD15 DATE: February 2009
NUMBER: 2 10-09 S.M. REF.: Listed in Table ENGINE: DD15 DATE: February 2009 SUBJECT: CAMSHAFT TIMING ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page Number(s) DDC-SVC-MAN-0002
More informationFIS Low Pressure Leak Test March Publication Number / Title Platform Section Title Change. FIS Low Pressure Leak Test- Three-Filter Fuel System
1 3 02-13 SUBJECT DATE FIS Low Pressure Leak Test March 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform FIS Low Pressure Leak
More informationEGR Actuator May Description and Operation of the DD13 Exhaust Gas Recirculation Valve Actuator
5 17-13 1 5 17-13 SUBJECT DATE EGR Actuator May 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Description and Operation of the DD13 Exhaust Gas Recirculation
More informationSPN 4364/FMI 17 - GHG17 SPN /FMI 16 - GHG17 SPN /FMI 14 - GHG17 SPN 3216/FMI 16 - GHG17 SPN 3216/FMI 18 - GHG17 SPN 3217/FMI 2 - GHG17
11 29-16 1 11 29-16 SUBJECT SPN 4364 (ACM) (GHG17) SPN 520371 (ACM) (GHG17) SPN 520372 (ACM) (GHG17) SPN 3216 (ACM) (GHG17) SPN 3217 (ACM) (GHG17) SPN 3226 (ACM) (GHG17) SPN 3227 (ACM) (GHG17) Diagnostic
More information33 FLASH CODE 33 - TBS HIGH
33 FLASH CODE 33 - TBS HIGH Section Page 33.1 DESCRIPTION OF FLASH CODE 33... 33-3 33.2 SAE J1587 EQUIVALENT CODE FOR FLASH CODE 33... 33-3 33.3 TROUBLESHOOTING FLASH CODE 33... 33-4 Figure 33-1 Turbo
More informationNUMBER: 1 SECM 03 S.M. REF.: Listed in Table 1 ENGINE: ALL DATE: February 2003
NUMBER: 1 SECM 03 S.M. REF.: Listed in Table 1 ENGINE: ALL DATE: February 2003 SUBJECT: UPDATES FOR TROUBLESHOOTING SERIES 60 AND SERIES 50 EGR RELATED CODES AND FAULTS INTRODUCTION The Series 60 engine
More informationNUMBER: S.M. REF.: Listed in Table 1 ENGINE: DD13 DATE: July 2009
NUMBER: 7 10 09 S.M. REF.: Listed in Table 1 ENGINE: DD13 DATE: July 2009 SUBJECT: CAMSHAFT AND ROCKER SHAFT ASSEMBLIES ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change
More informationPublication Number / Title Platform Section Title Change. Removal of DD15 and DD16 Delphi Exhaust Gas Recirculation Valve Actuator
7 02-15 1 7 02-15 SUBJECT DD15 and DD16 Delphi Exhaust Gas Recirculation Valve Actuator and DD15 and DD16 Sonceboz Exhaust Gas Recirculation Valve Actuator DATE July 2015 Additions, Revisions, or Updates
More information