NUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: February 2009

Size: px
Start display at page:

Download "NUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: February 2009"

Transcription

1 NUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: February 2009 SUBJECT: VALVE LIFT SPECIFICATIONS ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page Number(s) DDC-SVC-MAN-0026 EPA07 MBE A Table 1-86, Section 13 Valve Lift Spec has been removed 1-179, 13-5, 13-8 NOTE: Page numbers are based on the most recent version of the individual publication and may be adjusted throughout the annual print cycle.

2 1A ADDITIONAL INFORMATION Valve Type Intake Exhaust Adjust to: mm (in.) 0.40 mm (0.016 in.) 0.60 mm (0.024 in.) Table 1 Valve Lash Adjustment METHOD ONE ADJUST EACH CYLINDER IN FIRING ORDER 1. Remove the cylinder head covers. Refer to section "Removal of Head Cover." 2. Remove the inspection cover on the flywheel housing. 3. Install the engine barring tool (J 46392) into the inspection hole on the flywheel housing. See Figure Inspection Cover Figure 1 Placement of Engine Barring Tool 4. For each cylinder, use the engine barring tool (J 46392) to turn over the crankshaft until the piston is exactly at top dead center (TDC) in the compression stroke. The valves must be closed and it must be possible to turn the pushrods without effort. NOTE: When the piston in cylinder #1 is at ignition TDC, the valves of cylinder #6 will overlap, meaning that both intake and exhaust valves are partially open, and show no measurable play when tested with a feeler gauge.

3 5. Check each valve and adjust it (if necessary), using the procedures under the heading "Adjusting Valve Lash." 6. For each valve, measure the valve lash with an angled feeler gauge between the rocker arm and valve bridge. It should be possible to pull the feeler gauge through with light resistance. Table 2 Valve Type Intake Exhaust Valve Lash Checking and Adjustment Adjust to: mm (inches) 0.40 mm (0.016 in.) 0.60 mm (0.024 in.)

4 METHOD TWO ADJUST ALL VALVES USING TWO CRANKSHAFT POSITIONS 1. Remove the cylinder head covers. See Figure 2. Refer to section "Removal of Head Cover." 1. Nut 4. Bridge 2. Head Cover 5. Head 3. Stud Figure 2 Head Cover and Related Components 2. Remove the inspection cover on the flywheel housing.

5 3. Attach the engine barring tool (J 46392) into the inspection hole on the flywheel housing. See Figure Inspection Cover Figure 3 Placement of Engine Barring Tool 4. Using the engine barring tool (J 46392), turn the crankshaft until cylinder #1 is at the ignition TDC position (all valves are closed) and cylinder #6 is at the valve overlap position (all valves are open).

6 NOTE: When the piston in cylinder #1 or #6 is at ignition TDC, there will be a small beveled alignment mark visible through the inspection hole. See Figure 4. Figure 4 Flywheel Alignment Mark 5. Check the valves in the "Ignition TDC" row listed in Table, and adjust them (if necessary), using the procedures under the headings "Checking Valve Lash" and "Adjusting Valve Lash." Engine #1 Crankshaft Position MBE 4000 Ignition TDC I/E I E I E MBE 4000 Valve Overlap E I E I I/E * I= Intake Valve and E= Exhaust Valve Table 3 Valve Adjustment (Method Two) 6. Using the engine barring tool (J 46392), turn the crankshaft until cylinder #6 is at the ignition TDC position (all valves are closed) and cylinder #1 is at the valve overlap position (all valves are open). 7. Using the same procedure, check the valves in the "Valve Overlap" row listed in Table and adjust them (if necessary), using the procedures under the headings "Checking Valve Lash" and "Adjusting Valve Lash."

7 8. For each valve, measure the valve lash with a feeler gauge between the rocker arm and valve bridge. It should be possible to pull the feeler gauge through with light resistance. Table 4 Valve Type Intake Exhaust Valve Lash Checking and Adjustment Adjust to: mm (inches) 0.40 mm (0.016 in.) 0.60 mm (0.024 in.)

8 ADDITIONAL SERVICE INFORMATION Additional service information is available in Power Service Literature. Detroit Diesel, DDC, Series 60 and the spinning arrows design are registered trademarks of Detroit Diesel Corporation. Copyright 2009 Detroit Diesel Corporation. All rights reserved. Printed in U.S.A.

NUMBER: S.M. REF.: Listed in Table ENGINE: EPA04 MBE 4000 DATE: April 2009

NUMBER: S.M. REF.: Listed in Table ENGINE: EPA04 MBE 4000 DATE: April 2009 NUMBER: 4 8 09 S.M. REF.: Listed in Table ENGINE: EPA04 MBE 4000 DATE: April 2009 SUBJECT: CYLINDER HEAD INSTALLATION ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page

More information

NUMBER: S.M. REF.: Listed in Table ENGINE: DD15 DATE: February 2009

NUMBER: S.M. REF.: Listed in Table ENGINE: DD15 DATE: February 2009 NUMBER: 2 10-09 S.M. REF.: Listed in Table ENGINE: DD15 DATE: February 2009 SUBJECT: CAMSHAFT TIMING ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page Number(s) DDC-SVC-MAN-0002

More information

NUMBER: S.M. REF.: Listed in Table 1 ENGINE: DD13 DATE: July 2009

NUMBER: S.M. REF.: Listed in Table 1 ENGINE: DD13 DATE: July 2009 NUMBER: 7 10 09 S.M. REF.: Listed in Table 1 ENGINE: DD13 DATE: July 2009 SUBJECT: CAMSHAFT AND ROCKER SHAFT ASSEMBLIES ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change

More information

NUMBER: S.M. REF.: Listed in Table ENGINE: EPA10 DD Platform DATE: August 2010

NUMBER: S.M. REF.: Listed in Table ENGINE: EPA10 DD Platform DATE: August 2010 NUMBER: 815 10 S.M. REF.: Listed in Table ENGINE: EPA10 DD Platform DATE: August 2010 SUBJECT: SPN 3226 FMI 13 SCR OUTLET NOX SENSOR SIGNAL NOT AVAILABLE ADDITIONS, REVISIONS, OR UPDATES Publication Number

More information

NUMBER: S.M. REF.: Listed in Table ENGINE: EPA07/10 DD Platform DATE: September 2010

NUMBER: S.M. REF.: Listed in Table ENGINE: EPA07/10 DD Platform DATE: September 2010 NUMBER: 9 09 10 S.M. REF.: Listed in Table ENGINE: EPA07/10 DD Platform DATE: September 2010 SUBJECT: INSTALLATION OF THE CAMSHAFT AND ROCKER SHAFT/ENGINE BRAKE ASSEMBLY ADDITIONS, REVISIONS, OR UPDATES

More information

NUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: August 2013 SUBJECT: VALVE LASH ADJUSTMENTS ADDITIONS, REVISIONS, OR UPDATES

NUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: August 2013 SUBJECT: VALVE LASH ADJUSTMENTS ADDITIONS, REVISIONS, OR UPDATES NUMBER: 8 34 13 S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: August 2013 SUBJECT: VALVE LASH ADJUSTMENTS ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change DDC-SVC-MAN-0005

More information

SPN 1176/FMI 3 SPN 1176/FMI 4

SPN 1176/FMI 3 SPN 1176/FMI 4 NUMBER: 8 01 13 S.M. REF.: Listed in Table ENGINE: EPA07 MBE 900 DATE: August 2013 SUBJECT: SPN 1176/FMI 3, 4 ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change DDC-SVC-MAN-0015

More information

NUMBER: S.M. REF.: Listed in Table ENGINE: DD15 DATE: March 2009

NUMBER: S.M. REF.: Listed in Table ENGINE: DD15 DATE: March 2009 NUMBER: 3 3 09 S.M. REF.: Listed in Table ENGINE: DD15 DATE: March 2009 SUBJECT: FUEL FILTER ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page Number(s) DDC-SVC-MAN-0037

More information

NUMBER: S.M. REF.: Listed in Table 1 ENGINE: DD13 DATE: October 2009

NUMBER: S.M. REF.: Listed in Table 1 ENGINE: DD13 DATE: October 2009 NUMBER: 10 09 09 S.M. REF.: Listed in Table 1 ENGINE: DD13 DATE: October 2009 SUBJECT: INTERMEDIATE FRAME / FUEL INJECTOR WIRING HARNESS ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section

More information

NUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: August 2009

NUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: August 2009 NUMBER: 8 5 09 S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: August 2009 SUBJECT: CYLINDERHEADCOOLANTVENTLINE ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change

More information

NUMBER: S.M. REF.: Listed in Table ENGINE: EPA04 MBE 4000 DATE: September 2009

NUMBER: S.M. REF.: Listed in Table ENGINE: EPA04 MBE 4000 DATE: September 2009 NUMBER: 9 1 09 S.M. REF.: Listed in Table ENGINE: EPA04 MBE 4000 DATE: September 2009 SUBJECT: ENGINE OIL AND FILTER CHANGING ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title

More information

NUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: October 2010

NUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: October 2010 NUMBER:10 02 10 S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: October 2010 SUBJECT: DOUBLEHYSTERESISTEST ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page

More information

NUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: April 2009

NUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: April 2009 NUMBER: 4 7 09 S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: April 2009 SUBJECT: SPN 27 ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page Number(s) DDC-SVC-MAN-0009

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 8 04-12 SUBJECT DATE SPNs 4354/FMI 5, 4355/FMI 5, 4356/FMI 5, 4357/FMI 5 August 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 4354/FMI 5 DDC-SVC-MAN-0084

More information

NUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: June 2012 SUBJECT: E3 FUEL INJECTOR TUBE ADDITIONS, REVISIONS, OR UPDATES

NUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: June 2012 SUBJECT: E3 FUEL INJECTOR TUBE ADDITIONS, REVISIONS, OR UPDATES NUMBER: 6 25 12 S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: June 2012 SUBJECT: E3 FUEL INJECTOR TUBE ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change E3 Fuel

More information

NUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: February 2011

NUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: February 2011 NUMBER: 2 15 11 S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: February 2011 SUBJECT: FAULTY FUEL INJECTOR ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page

More information

NUMBER: 08 DDEC VI 16 S.M. REF.: listed in Table 1 ENGINE: DD15 DATE: April 2008 SUBJECT: SPN 1636 AND SPN 2630 PUBLICATION: DDC-SVC-MAN-0029

NUMBER: 08 DDEC VI 16 S.M. REF.: listed in Table 1 ENGINE: DD15 DATE: April 2008 SUBJECT: SPN 1636 AND SPN 2630 PUBLICATION: DDC-SVC-MAN-0029 NUMBER: 08 DDEC VI 16 S.M. REF.: listed in Table 1 ENGINE: DD15 DATE: April 2008 SUBJECT: SPN 1636 AND SPN 2630 PUBLICATION: DDC-SVC-MAN-0029 The procedure and direction for SPN 1636 have changed. SPN

More information

NUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: April 2009

NUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: April 2009 NUMBER: 4 11 09 S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: April 2009 SUBJECT: SPN 2631 ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page Number(s) DDC-SVC-MAN-0010

More information

NUMBER: S.M. REF.: Listed in Table 1 ENGINE: DD13 DATE: July 2009

NUMBER: S.M. REF.: Listed in Table 1 ENGINE: DD13 DATE: July 2009 NUMBER: 7 4 09 S.M. REF.: Listed in Table 1 ENGINE: DD13 DATE: July 2009 SUBJECT: EXHAUST GAS RECIRCULATION COOLER WATER MANIFOLD ASSEMBLY ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section

More information

NUMBER: 08 FSTG 12 REV S.M. REF.: Listed in Table ENGINE: EPA07 DD15 DATE: February 2009

NUMBER: 08 FSTG 12 REV S.M. REF.: Listed in Table ENGINE: EPA07 DD15 DATE: February 2009 NUMBER: 08 FSTG 12 REV S.M. REF.: Listed in Table ENGINE: EPA07 DD15 DATE: February 2009 SUBJECT: ISB (IDLE SPEED BALANCE) VALUES ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title

More information

NUMBER: S.M. REF.: 8.5 ENGINE: EPA07 Series 60 DATE: November 2008

NUMBER: S.M. REF.: 8.5 ENGINE: EPA07 Series 60 DATE: November 2008 NUMBER: 08 60-7 S.M. REF.: 8.5 ENGINE: EPA07 Series 60 DATE: November 2008 SUBJECT: EGR RATE MEASUREMENT SYSTEM PUBLICATION: DDC-SVC-MAN-0005 EGR Rate Measurement System has new information added. EGR

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 8 05-12 SUBJECT DATE SPN 4354/FMI 5, 4356/FMI 5, 4355/FMI 5, 4357/FMI 5 August 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 4354/FMI 5 DDC-SVC-MAN-0084

More information

EPA10 DOC Inlet Pressure Sensor November Removal of the EPA10 Diesel Oxidation Catalyst Inlet Pressure Sensor. without Sensor Box

EPA10 DOC Inlet Pressure Sensor November Removal of the EPA10 Diesel Oxidation Catalyst Inlet Pressure Sensor. without Sensor Box 11 10-14 1 11 10-14 SUBJECT DATE EPA10 DOC November 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Removal of the EPA10 DDC-SVC-MAN-0083 EPA10 DD Platform

More information

NUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: May 2013 SUBJECT: SPN 2631/FMI 2 ADDITIONS, REVISIONS, OR UPDATES

NUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: May 2013 SUBJECT: SPN 2631/FMI 2 ADDITIONS, REVISIONS, OR UPDATES NUMBER: 5 26 13 S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: May 2013 SUBJECT: SPN 2631/FMI 2 ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change DDC-SVC-MAN-0010

More information

NUMBER: S.M. REF.: Listed in Table ENGINE: DD Platform DATE: May 2010

NUMBER: S.M. REF.: Listed in Table ENGINE: DD Platform DATE: May 2010 NUMBER: 5 04 10 S.M. REF.: Listed in Table ENGINE: DD Platform DATE: May 2010 SUBJECT: FUEL SYSTEM PRIMING USING ESOC 350 FUEL PRIMING PUMP ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 10 18-16 SUBJECT DATE Symptom Diagnostics - Noise October 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change EPA07/10/ DDC-SVC-MAN-0084 GHG14 DD Platform Overhead

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 1 38-13 SUBJECT DATE Inspection of the Main and Connecting Rod Bearings In-Chassis January 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Inspection of

More information

High pressure fuel line and transfer tube removal and installation procedures have been updated.

High pressure fuel line and transfer tube removal and installation procedures have been updated. NUMBER: 08 MBE 4000-3 S.M. REF.: 2.3 ENGINE: EPA04 MBE 4000 DATE: July 2008 SUBJECT: HIGH PRESSURE FUEL LINE AND TRANSFER TUBE PUBLICATION:DDC-SVC-MAN-0023 High pressure fuel line and transfer tube removal

More information

NUMBER: 08 MBE REV S.M. REF.: 1.4 ENGINE: EPA07 MBE 4000 DATE: February 2008 SUBJECT: CYLINDER BLOCK LINER SERVICE PROCEDURE

NUMBER: 08 MBE REV S.M. REF.: 1.4 ENGINE: EPA07 MBE 4000 DATE: February 2008 SUBJECT: CYLINDER BLOCK LINER SERVICE PROCEDURE NUMBER: 08 MBE 4000-1 REV S.M. REF.: 1.4 ENGINE: EPA07 MBE 4000 DATE: February 2008 SUBJECT: CYLINDER BLOCK LINER SERVICE PROCEDURE PUBLICATION: DDC-SVC-MAN-0026 (6SE420) Amended tool number J-46180. New

More information

Camshaft and Idler Gear August Removal of the Camshafts. Installation of the Camshafts. Removal of the Intake Rocker Shaft Assembly

Camshaft and Idler Gear August Removal of the Camshafts. Installation of the Camshafts. Removal of the Intake Rocker Shaft Assembly 08 11-16 1 08 11-16 SUBJECT DATE Camshaft and Idler Gear August 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Removal of the Camshafts Added notice and

More information

Removal and Installation of the Camshaft Housing Assembly February Removal of the Camshaft Housing Assembly

Removal and Installation of the Camshaft Housing Assembly February Removal of the Camshaft Housing Assembly 1 SUBJECT DATE Removal and Installation of the Camshaft Housing Assembly February 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Removal of the Camshaft

More information

Publication Number / Title Platform Section Title Change. Removal of the High Pressure Fuel Pump Drive Gear - Three-Filter System

Publication Number / Title Platform Section Title Change. Removal of the High Pressure Fuel Pump Drive Gear - Three-Filter System 5 34-13 1 5 34-13 SUBJECT Removal and Installation of the High Pressure Fuel Pump Drive Gear - Three-Filter System DATE June 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 5 03-14 SUBJECT DATE SPN 3599/FMI 3 and 4 (ACM) May 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3599/FMI 3-1 DDC-SVC-MAN-0084 EPA10/ GHG14 DD Platform

More information

Section 7.3 Water Manifold has been updated.

Section 7.3 Water Manifold has been updated. NUMBER: 08 DD15-11 S.M. REF.: 7.3 ENGINE: DD15 DATE: September 2008 SUBJECT: WATER MANIFOLD PUBLICATION: DDC-SVC-MAN-0002 Section 7.3 Water Manifold has been updated. 7.3 WATER MANIFOLD Coolant flows from

More information

Fuel Filter Maintenance Intervals July EPA10/GHG14 DD Series Preventive Maintenance Tables

Fuel Filter Maintenance Intervals July EPA10/GHG14 DD Series Preventive Maintenance Tables 1 7 14-13 SUBJECT DATE Fuel Filter Maintenance Intervals July 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0080 EPA10/ GHG14 DD Platform EPA10/GHG14

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 5 33-13 SUBJECT Removal and Installation of the High Pressure Fuel Pump -Three- Filter System DATE May 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Removal

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 SUBJECT DATE Camshaft Housing Assembly March 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Removal of the Camshaft Housing DDC-SVC-MAN-0081 DD Platform

More information

NUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: September 2009

NUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: September 2009 NUMBER: 9 3 09 S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: September 2009 SUBJECT: TURBOCHARGER WASTEGATE ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page

More information

Adjusting valve clearance

Adjusting valve clearance Adjusting valve clearance Engines314, 352, 352 A 355, 355 A 360, 360 A 362 LA 364, 366, 366 A/ LA Adjustment values in mm Engine Intake valve Exhaust valve Tolerance range 1) 314, 352, 352 A.V 2) 0.20

More information

Hydrocarbon Fuel Doser Injector Valve Fuel Supply Line December Publication Number / Title Platform Section Title Change

Hydrocarbon Fuel Doser Injector Valve Fuel Supply Line December Publication Number / Title Platform Section Title Change 1 SUBJECT DATE Hydrocarbon Fuel Doser Injector Valve Fuel Supply Line December 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Removal of the Hydrocarbon

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 6 07-15 SUBJECT DATE SPN 3464 (MCM) (EPA10;GHG14) June 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3464/FMI 3 - DDC-SVC-MAN-0084 EPA10/ GHG14 DD

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 01 06-15 SUBJECT DATE SPN 3251 (ACM) (EPA10) and (GHG14) January 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3251/FMI 0 - GHG14 DDC-SVC-MAN-0084

More information

SPN 723/FMI 3, 8, 10, 11, 31 - All Years February SPN 723/FMI 3 - All Years. SPN 723/FMI 8 - All Years. SPN 723/FMI 10 - All Years

SPN 723/FMI 3, 8, 10, 11, 31 - All Years February SPN 723/FMI 3 - All Years. SPN 723/FMI 8 - All Years. SPN 723/FMI 10 - All Years 1 49-13 1 1 49-13 SUBJECT DATE SPN 723/FMI 3, 8, 10, 11, 31 - All Years February 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 723/FMI 3 - All Years

More information

Updated gear lash procedures for the compact gear train assembly have been added to the Series 60 Service Manual.

Updated gear lash procedures for the compact gear train assembly have been added to the Series 60 Service Manual. NUMBER: 14 60 03 S.M. REF.: 1.21 ENGINE: 60 DATE: November 2003 SUBJECT: GEAR TRAIN AND CAMSHAFT GEAR LASH PROCEDURES FOR THE COMPACT GEAR TRAIN ASSEMBLY INTRODUCTION Updated gear lash procedures for the

More information

EGR heater plate removal and installation procedure has been added.

EGR heater plate removal and installation procedure has been added. NUMBER: 08 60-3 S.M. REF.: 8.3 ENGINE: EPA07 Series 60 DATE:June 2008 SUBJECT: EGR HEATER PLATE PUBLICATION: DDC-SVC-MAN-0005 EGR heater plate removal and installation procedure has been added. 8.3.1 REMOVAL

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 2 07-13 SUBJECT DATE Removal and Installation of the Camshaft Housing February 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0081 EPA07/10/

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 02 06-16 SUBJECT DATE Fuel Rail - Three-Filter System February 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0082 DD Platform - All Years

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 12 05-16 SUBJECT SPN 636 (MCM) (GHG17) SPN 636 (MCM) (EPA07;EPA10;GHG14) SPN 636 (MCM) (GHG14) DATE December 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change

More information

High Pressure Fuel Rail Feed Lines September Platform Section Title Change

High Pressure Fuel Rail Feed Lines September Platform Section Title Change 9 10-14 1 9 10-14 SUBJECT DATE High Pressure Fuel Rail Feed Lines September 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0082 DDC-SVC-MAN-0182

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 06 10-16 SUBJECT SPN 111 (CPC) (GHG17) and SPN 111 (CPC) (EPA07;EPA10;GHG14) DATE June 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0191

More information

Installation of the DD13,DD15, and DD16 Cylinder Head February Installation of the DD13 Cylinder Head

Installation of the DD13,DD15, and DD16 Cylinder Head February Installation of the DD13 Cylinder Head 5 02-12Rev 1 5 02-12Rev SUBJECT DATE Installation of the DD13,DD15, and DD16 Cylinder Head February 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Installation

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 10 15-13 1 10 15-13 SUBJECT DATE SPN 4257/FMI 3, 4 October 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10/ GHG14 DD Platform SPN 4257/FMI

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 6 13-14 SUBJECT DATE SPN 4259/FMI 4 (MCM) (EPA07) June 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA07 DD Platform SPN 4259/FMI 4

More information

Removal of the High Pressure Fuel Pump April Publication Number / Title Platform Section Title Change. Removal of the High Pressure Fuel Pump

Removal of the High Pressure Fuel Pump April Publication Number / Title Platform Section Title Change. Removal of the High Pressure Fuel Pump 4 99-12 1 4 99-12 SUBJECT DATE Removal of the High Pressure Fuel Pump April 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Removal of the High Pressure Fuel

More information

Removal and Installation of the Fuel Injector Cup February Removal of the Fuel Injector Cup Three-Filter System and Two-Filter System

Removal and Installation of the Fuel Injector Cup February Removal of the Fuel Injector Cup Three-Filter System and Two-Filter System 1 2 25-14 SUBJECT DATE Removal and Installation of the Fuel Injector Cup February 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Removal of the Fuel Injector

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 02 01-14 SUBJECT DATE SPN 1761/FMI 3, 4 ( ACM2-EPA10) (ACM2.1-GHG14) February 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform

More information

https://quickserve.cummins.com/qs2/pubsys2/xml/en/procedures/40/ tr.html

https://quickserve.cummins.com/qs2/pubsys2/xml/en/procedures/40/ tr.html Page 1 of 7 NOTE: The timing pin is used to accurately locate TDC for setting the overhead. The timing pin is typically located below the fuel pump. for front gear train engines, in the front gear housing

More information

Two SPNs and their FMIs have been reassigned numbers as listed in Table 1. The troubleshooting procedures are the same.

Two SPNs and their FMIs have been reassigned numbers as listed in Table 1. The troubleshooting procedures are the same. NUMBER: 07 DDEC VI 36 S.M. REF.: 129, 130 ENGINE: EPA07 Series 60 DATE: November 2007 SUBJECT: REASSIGNED SPN NUMBERS PUBLICATION: 6SE567 Two SPNs and their FMIs have been reassigned numbers as listed

More information

Publication Number / Title Platform Section Title Change SPN 5246/FMI 0- EPA10 SPN 5246/FMI 15 - EPA10 SPN 5246/FMI 16 - EPA10 SPN 5246/FMI 0 - GHG14

Publication Number / Title Platform Section Title Change SPN 5246/FMI 0- EPA10 SPN 5246/FMI 15 - EPA10 SPN 5246/FMI 16 - EPA10 SPN 5246/FMI 0 - GHG14 1 3 04-14 SUBJECT SPN 5246/FMI 0, 15, 16 (ACM2)(EPA10) SPN 5246/FMI 0, 15, 16 (ACM2.1)(GHG14) DATE March 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 3 30-12 SUBJECT DATE SPN 1761/FMI 2, 9 - MY13 March 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 MY13 DD Platform SPN 1761/FMI 2 - MY13

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 01 29-14 SUBJECT DATE SPN 3511/FMI 3 and 4 - GHG14 January 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3511/FMI 3 - DDC-SVC-MAN-0084 GHG14 DD Platform

More information

Notice Added to Sections Listed Below February Removal of the Bypass Valve. Removal of the Pressure Relief Valve

Notice Added to Sections Listed Below February Removal of the Bypass Valve. Removal of the Pressure Relief Valve 2 15-12 1 2 15-12 SUBJECT DATE Notice Added to Sections Listed Below February 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0082 Removal of

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 3 03-15 SUBJECT DATE Contaminated Fluids March 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform Fuel in Oil This is a new section.

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 10 28-13 SUBJECT DATE SPN 625/FMI 9 EPA10 - GHG14 (ACM) October 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10/ GHG14 DD Platform

More information

NUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: October 2012 SUBJECT: REFERENCES TO THE TURBOCHARGER PURGE ROUTINE

NUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: October 2012 SUBJECT: REFERENCES TO THE TURBOCHARGER PURGE ROUTINE NUMBER: 10 01 12 S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: October 2012 SUBJECT: REFERENCES TO THE TURBOCHARGER PURGE ROUTINE ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 6 05-13 SUBJECT DATE SPN 625/FMI 9 EPA10 - GHG14 June 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10/ GHG14 DD Platform SPN 625/FMI

More information

NUMBER: 08 DDEC VI 10 S.M. REF.: 92 ENGINE: EPA07 Series 60 DATE: March 2008

NUMBER: 08 DDEC VI 10 S.M. REF.: 92 ENGINE: EPA07 Series 60 DATE: March 2008 NUMBER: 08 DDEC VI 10 S.M. REF.: 92 ENGINE: EPA07 Series 60 DATE: March 2008 SUBJECT: SPN 2659 PUBLICATION: DDC-SVC-MAN-0009 (6SE567) Section SPN 2659/FMI 0, refer to section 92.1 SPN 2659/FMI 17, refer

More information

Removal of the Needle, Amplifier, and Pressure Limiting Valve Return Lines Three-Filter System

Removal of the Needle, Amplifier, and Pressure Limiting Valve Return Lines Three-Filter System 1 5 02-13 SUBJECT Needle, Amplifier, and Pressure Limiting Valve Return Lines Three- Filter System, Fuel Rail - Three-Filter System DATE February 2013 Additions, Revisions, or Updates Publication Number

More information

Installation of the Fuel Rail -Three-Filter System January Publication Number / Title Platform Section Title Change

Installation of the Fuel Rail -Three-Filter System January Publication Number / Title Platform Section Title Change 1 1 20-13 SUBJECT DATE Installation of the Fuel Rail -Three-Filter System January 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Installation of the Fuel

More information

SPN 3509 (MCM) (EPA10) and SPN 3509 (MCM) (GHG14) June 2014 SPN 3509/FMI 3 - EPA10 SPN 3509/FMI 4 - EPA10 SPN 3509/FMI 3 - GHG14

SPN 3509 (MCM) (EPA10) and SPN 3509 (MCM) (GHG14) June 2014 SPN 3509/FMI 3 - EPA10 SPN 3509/FMI 4 - EPA10 SPN 3509/FMI 3 - GHG14 1 SUBJECT DATE SPN 3509 (MCM) (EPA10) and SPN 3509 (MCM) (GHG14) June 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3509/FMI 3 - EPA10 The diagnostic

More information

EGR Actuator May Description and Operation of the DD13 Exhaust Gas Recirculation Valve Actuator

EGR Actuator May Description and Operation of the DD13 Exhaust Gas Recirculation Valve Actuator 5 17-13 1 5 17-13 SUBJECT DATE EGR Actuator May 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Description and Operation of the DD13 Exhaust Gas Recirculation

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 5 25-13 SUBJECT DATE SPN 2791/FMI 7 ALL YEARS May 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 2791/FMI 7 Deleted part

More information

Symptom Diagnostics - Belt Coming Off, Shredding or Misalignment September Symptom Diagnostics - Belt Coming Off, Shredding or Misalignment

Symptom Diagnostics - Belt Coming Off, Shredding or Misalignment September Symptom Diagnostics - Belt Coming Off, Shredding or Misalignment 09 02-16 1 09 02-16 SUBJECT DATE Symptom Diagnostics - Belt Coming Off, Shredding or Misalignment September 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change

More information

Valve Rocker Arm and Push Rod Installation (6.2L LS3)

Valve Rocker Arm and Push Rod Installation (6.2L LS3) 9. Tighten the cylinder head bolts: 10.1. Tighten the M11 cylinder head bolts (1-10) a first pass in sequence to 30 N m (22 lb ft). 10.2. Tighten the M11 cylinder head bolts (1-10) a second pass in sequence

More information

Removal and Installation of the DD15 and DD16 Cylinder Head April Removal of the DD15 and DD16 Cylinder Head

Removal and Installation of the DD15 and DD16 Cylinder Head April Removal of the DD15 and DD16 Cylinder Head 4 102-12 1 4 102-12 SUBJECT DATE Removal and Installation of the DD15 and DD16 Cylinder Head April 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0081

More information

Publication Number / Title Platform Section Title Change. Removal of DD15 and DD16 Delphi Exhaust Gas Recirculation Valve Actuator

Publication Number / Title Platform Section Title Change. Removal of DD15 and DD16 Delphi Exhaust Gas Recirculation Valve Actuator 7 02-15 1 7 02-15 SUBJECT DD15 and DD16 Delphi Exhaust Gas Recirculation Valve Actuator and DD15 and DD16 Sonceboz Exhaust Gas Recirculation Valve Actuator DATE July 2015 Additions, Revisions, or Updates

More information

Exhaust Gas Recirculation Crossover Pipe December Description and Operation of the EGR Crossover Pipe (Cast)

Exhaust Gas Recirculation Crossover Pipe December Description and Operation of the EGR Crossover Pipe (Cast) 1 12 12-18 SUBJECT DATE Exhaust Gas Recirculation Crossover Pipe December 2018 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Description and Operation of the

More information

The EPA07 Series 60 Workshop Manual has been revised. Listed in Table 1 are the revisions.

The EPA07 Series 60 Workshop Manual has been revised. Listed in Table 1 are the revisions. NUMBER: 08 60-6 S.M. REF.: 2.3.1 and 2.3.2 ENGINE: EPA07 Series 60 DATE: September 2008 SUBJECT: E3 INJECTOR TUBE PUBLICATION: DDC-SVC-MAN-0005 The EPA07 Series 60 Workshop Manual has been revised. Listed

More information

Exhaust and Exhaust Gas Recirculation September Testing of the DD13. Exhaust Gas Recirculation Cooler Water Manifold Assembly - In Chassis

Exhaust and Exhaust Gas Recirculation September Testing of the DD13. Exhaust Gas Recirculation Cooler Water Manifold Assembly - In Chassis 1 09 04-16 SUBJECT DATE Exhaust and Exhaust Gas Recirculation September 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Testing of the DD13 DDC-SVC-MAN-0190

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 6 08-15 1 6 08-15 SUBJECT DATE NOx Sensors June 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Removal of the GHG14 1-BOX Aftertreatment DDC-SVC-MAN-0083

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 8 22-13 SUBJECT DATE Water Manifold Assembly August 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Installation of the DD13 EGR Cooler Water DDC-SVC-MAN-0081

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 2 22-14 SUBJECT DATE SPN 4334/FMI 7 (ACM) (EPA10) February 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform - EPA10- ACM SPN

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 2 15-14 1 2 15-14 SUBJECT DATE Check for Rough Running or Stalling - Three-Filter Fuel System February 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Check

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 5 08-14 SUBJECT DATE Model 4 Axle Bearing Cage Update May 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0141 Model 4 Axle Axle Bearing Cage

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 3 06-13 SUBJECT DATE Potential Fuel Leak Points - Two-Filter Fuel System DD Platform March 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Potential Fuel

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 12 12-14 SUBJECT DATE SPN 3250 (ACM) December 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10 and GHG14 DD Platform SPN 3250/FMI

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 4 97-12 SUBJECT DATE EPA10 Aftertreatment Regeneration Strategy May 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0083 EPA10 DD Platform EPA10

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 SUBJECT DATE Model 4 Single Model 4 Rear Tandem Pinion Bearing Repair October 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0141 Detroit Axles

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 10 16-13 SUBJECT DATE SPN 3216/FMI 13 - EPA10/GHG14 October 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10 GHG14 DD Platform SPN

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 2 27-14 1 2 27-14 SUBJECT DATE SPN 4335/FMI 7 - EPA10 February 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 4335/FMI 7

More information

Oil Pan July DDC-SVC-MAN-0081 DD Platform Installation of the Oil Pan Added graphics, additional torque specs.

Oil Pan July DDC-SVC-MAN-0081 DD Platform Installation of the Oil Pan Added graphics, additional torque specs. 7 17-13 1 7 17-13 SUBJECT DATE Oil Pan July 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0081 DD Platform Installation of the Oil Pan Added

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 2 30-14 SUBJECT DATE SPN 4375/FMI 6 - EPA10 February 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10 DD Platform SPN 4375/FMI 6 -

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 3 26-15 SUBJECT DATE Main Shaft Speed Sensor March 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0140 Transmission Removal of the Main Shaft

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 8 03-13 SUBJECT DATE SPN 51/FMI 2, 10, 18 August 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DD Platform SPN 51/FMI 2 All Years Most steps have been

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 1 01 11-16 SUBJECT DATE SPN 647 (MCM)(EPA07-EPA10-GHG14) January 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DDC-SVC-MAN-S084 DD Platform

More information

Piston and Connecting Rod Assembly August Removal of the Piston and Connecting Rod Assembly

Piston and Connecting Rod Assembly August Removal of the Piston and Connecting Rod Assembly 1 8 17-13 SUBJECT DATE Piston and Connecting Rod Assembly August 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Removal of the Piston DDC-SVC-MAN-0081 DD

More information

Section 13.2 Valve Lash, Injector Height (Timing) and Jake Brake Lash Adjustments

Section 13.2 Valve Lash, Injector Height (Timing) and Jake Brake Lash Adjustments Page 1 of 15 Section 13.2 Valve Lash, Injector Height (Timing) and Jake Brake Lash Adjustments Accurate adjustment of clearance between valve buttons, intake and exhaust valves is important if maximum

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 10 06-17 1 10 06-17 SUBJECT DATE Symptom Diagnostics - Belt Coming Off October 2017 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0191 DDC-SVC-MAN-0084

More information

FIS Low Pressure Leak Test March Publication Number / Title Platform Section Title Change. FIS Low Pressure Leak Test- Three-Filter Fuel System

FIS Low Pressure Leak Test March Publication Number / Title Platform Section Title Change. FIS Low Pressure Leak Test- Three-Filter Fuel System 1 3 02-13 SUBJECT DATE FIS Low Pressure Leak Test March 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform FIS Low Pressure Leak

More information

Additions, Revisions, or Updates

Additions, Revisions, or Updates 6 12-14 1 6 12-14 SUBJECT DATE SPN 5741 (ACM) (GHG14) May 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 5741/FMI 4 DDC-SVC-MAN-0084 GHG14 DD Platform

More information