Additions, Revisions, or Updates
|
|
- Agatha Osborne
- 5 years ago
- Views:
Transcription
1 SUBJECT DATE SPN 4257/FMI 3, 4 October 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10/ GHG14 DD Platform SPN 4257/FMI 3 SPN 4257/FMI 4 This has update MCM pin # s, engine harness side details, and additional steps to check all circuit wires involved. All information subject to change without notice Copyright 2013 DETROIT DIESEL CORPORATION
2 2 SPN 4257/FMI 3 - EPA10 - GHG14 2 SPN 4257/FMI 3 - EPA10 - GHG14 This diagnostic is typically Injector Amplifier Control Valve Cylinder 1, 2, 3 Shorted to Battery. Table 1. SPN 4257/FMI 3 Description Injector Amplifier Control Valve Cylinder 1, 2, 3 Shorted to Battery Monitored Parameter Injector Amplifier Control Valve Cylinder 1, 2, 3 Typical Enabling Conditions fis_nop_act > 1.85 Monitor Sequence None Execution Frequency Continuous when enabling conditions met Typical Duration 2 Seconds Dash Lamps MIL, CEL Engine Reaction Derate 25% Verification Engine rpm (1 minute) Check as follows: 1. Disconnect the front fuel injector harness 14-pin connector. 2. Turn the ignition ON (key ON, engine OFF). 3. Measure the voltage between pin 5 on the Motor Control Module (MCM) engine harness side of the front fuel injector harness 14-pin connector and battery ground. 4 All information subject to change without notice. Copyright 2013 DETROIT DIESEL CORPORATION
3 a. If there is voltage present, repair the short to power between pin 5 of the engine harness side front fuel injector harness 14-pin connector and pin 13 of the MCM 120-pin connector. b. If there is no voltage present, Go to step Measure the voltage between pin 12 on the MCM side of the engine harness side front fuel injector harness 14-pin connector and ground. a. If there is voltage present, repair the short to power between pin 12 of the engine harness side front fuel injector harness connector and pin 12 of the MCM 120-pin connector. b. If there is no voltage present, Go to step Measure the voltage between pin 9 on the MCM side of the front fuel injector harness 14-pin connector and ground. a. If there is voltage present, repair the short to power between pin 9 of the front fuel injector harness connector and pin 10 of the MCM 120-pin connector. b. If there is no voltage present, repair the short to power between pin 8 of the front fuel injector harness connector and pin 14 of the MCM 120-pin connector. All information subject to change without notice Copyright 2013 DETROIT DIESEL CORPORATION
4 3 SPN 4257/FMI 4 - EPA10 - GHG14 3 SPN 4257/FMI 4 - EPA10 - GHG14 This diagnostic is typically Injector Amplifier Control Valve Cylinder 1, 2, 3 Shorted to Ground. Table 2. SPN 4257/FMI 4 Description Injector Amplifier Control Valve Cylinder 1, 2, 3 Shorted to Ground Monitored Parameter Injector Amplifier Control Valve Cylinder 1, 2, 3 Typical Enabling Conditions fis_nop_act > 1.85 Monitor Sequence None Execution Frequency Continuous when enabling conditions met Typical Duration 2 Seconds Dash Lamps MIL, CEL Engine Reaction Derate 25% Verification Engine rpm (1 minute) Check as follows: 1. Verify that the Motor Control Module (MCM) software is V13.x or newer. a. If MCM software is v13.x or newer, Go to step 2. b. If the MCM software version is not 13.x or newer, reprogram the MCM to the latest software version. After reprogramming, start the engine and increase the rpm to 1500 for two minutes; if fault does not reoccur, release the vehicle. If fault becomes active during the test, Go to step Disconnect the front fuel injector harness 14-pin connector. 3. Inspect the front fuel injector harness 14-pin connector for bent or spread pins; inspect the connector seal for damage (signs of water or oil intrusion). a. If water or oil intrusion, bent or spread pins are found, repair as necessary. 6 All information subject to change without notice. Copyright 2013 DETROIT DIESEL CORPORATION
5 b. If connector shows no signs of damage, Go to step Measure the resistance between pin 5 on the valve cover side of the front fuel injector harness 14-pin connector and battery ground. If you are using J , measure between fuel injector #4 pin 1 and battery ground. a. If the resistance is greater than 3Ω, Go to step 12. b. If the resistance is less than 3Ω, Go to step Remove the rocker cover. Refer to section "Removal of the Rocker Cover". 6. Disconnect the electrical harness connecter on fuel injector #1. 7. Measure the resistance between pin 5 on the valve cover side of the front fuel injector harness 14-pin connector and battery ground. If you are using J , measure between fuel injector #1 pin 1 and battery ground. a. If the resistance is greater than 3Ω, replace fuel injector #1. b. If the resistance is less than 3Ω, Go to step Disconnect the electrical harness connecter on fuel injector #2. 9. Measure the resistance between pin 5 on the valve cover side of the front fuel injector harness 14-pin connector and ground. If you are using J , measure between fuel injector #2 pin 1 and battery ground. a. If the resistance is greater than 3Ω, replace fuel injector #2. b. If the resistance is less than 3Ω, Go to step Disconnect the electrical harness connecter on fuel injector # Measure the resistance between pin 5 on the valve cover side of the front fuel injector harness 14-pin connector and ground. If you are using J , measure between fuel injector #3 pin 1 and battery ground. a. If the resistance is greater than 3Ω, replace the #3 fuel injector. b. If the resistance is less than 3Ω, replace the under valve cover fuel injector harness. 12. Disconnect the 120-pin MCM connector. 13. Inspect the MCM 120-pin connector and the 120-pin harness connector for signs of corrosion, spread, unseated (pushed out) or damaged pins; inspect the connector seal for damage (signs of water or oil intrusion) or signs of wire damage. a. If signs of damage are found, repair as necessary. b. If no signs of damage, Go to step Measure the resistance between pin 5 of the harness side of the front fuel injector harness 14-pin connector and ground. All information subject to change without notice Copyright 2013 DETROIT DIESEL CORPORATION
6 3 SPN 4257/FMI 4 - EPA10 - GHG14 a. If the resistance is greater than 3Ω, Go to step 15. b. If the resistance is less than 3Ω, repair the short to ground between pin 13 of the MCM 120-pin connector and pin 5 of the front fuel injector harness 14-pin connector. 15. Measure the resistance between pin 8 of the harness side of the front fuel injector harness 14-pin connector and ground. a. If the resistance is greater than 3Ω, Go to step 16. b. If the resistance is less than 3Ω, repair the short to ground between pin 14 of the MCM 120-pin connector and pin 8 of the front fuel injector harness 14-pin connector. 16. Measure the resistance between pin 9 of the engine harness side of the front fuel injector harness 14-pin connector and ground. a. If the resistance is greater than 3Ω, Go to step 17. b. If the resistance is less than 3Ω, repair the short to ground between pin 10 of the MCM 120-pin connector and pin 9 of the front fuel injector harness 14-pin connector. 17. Measure the resistance between pin 12 of the harness side of the front fuel injector harness 14-pin connector and ground. a. If the resistance is greater than 3Ω, replace the MCM. Refer to section "Removal of the Motor Control Module". b. If the resistance is less than 3Ω, repair the short between pin 12 of the MCM 120-pin connector and pin 12 of the front fuel injector harness 14-pin connector. 8 All information subject to change without notice. Copyright 2013 DETROIT DIESEL CORPORATION
Additions, Revisions, or Updates
1 6 13-14 SUBJECT DATE SPN 4259/FMI 4 (MCM) (EPA07) June 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA07 DD Platform SPN 4259/FMI 4
More informationAdditions, Revisions, or Updates
1 SUBJECT DATE SPN 3659/FMI 5 GHG14 MCM2.1 May 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 GHG14 DD Platform SPN 3659/FMI 5 GHG14 This
More informationAdditions, Revisions, or Updates
1 5 20-12 SUBJECT DATE SPN 3664/FMI 5 GHG14 June 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 GHG14 DD Platform SPN 3664/FMI 5 GHG14 This
More informationAdditions, Revisions, or Updates
1 6 07-15 SUBJECT DATE SPN 3464 (MCM) (EPA10;GHG14) June 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3464/FMI 3 - DDC-SVC-MAN-0084 EPA10/ GHG14 DD
More informationAdditions, Revisions, or Updates
1 10 28-13 SUBJECT DATE SPN 625/FMI 9 EPA10 - GHG14 (ACM) October 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10/ GHG14 DD Platform
More informationAdditions, Revisions, or Updates
1 02 01-14 SUBJECT DATE SPN 1761/FMI 3, 4 ( ACM2-EPA10) (ACM2.1-GHG14) February 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform
More informationAdditions, Revisions, or Updates
1 01 11-16 SUBJECT DATE SPN 647 (MCM)(EPA07-EPA10-GHG14) January 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DDC-SVC-MAN-S084 DD Platform
More informationAdditions, Revisions, or Updates
1 8 02-14 SUBJECT DATE SPN 4334 (ACM) (GHG14) August 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 4334/FMI 3 - DDC-SVC-MAN-0084 GHG14 DD Platform GHG14
More informationAdditions, Revisions, or Updates
1 5 03-14 SUBJECT DATE SPN 3599/FMI 3 and 4 (ACM) May 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3599/FMI 3-1 DDC-SVC-MAN-0084 EPA10/ GHG14 DD Platform
More informationAdditions, Revisions, or Updates
1 10 16-13 SUBJECT DATE SPN 3216/FMI 13 - EPA10/GHG14 October 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10 GHG14 DD Platform SPN
More informationAdditions, Revisions, or Updates
1 4 09-14 SUBJECT DATE ACM2.1 SPN 3597/FMI 3, 4 - GHG14 April 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 3597/FMI 3,
More informationAdditions, Revisions, or Updates
1 6 05-13 SUBJECT DATE SPN 625/FMI 9 EPA10 - GHG14 June 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10/ GHG14 DD Platform SPN 625/FMI
More informationAdditions, Revisions, or Updates
1 01 06-16 SUBJECT SPN 4334/FMI 4 (ACM) (GHG14) SPN 4334/FMI 4 (ACM) (GHG17) DATE January 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084
More informationSPN 723/FMI 3, 8, 10, 11, 31 - All Years February SPN 723/FMI 3 - All Years. SPN 723/FMI 8 - All Years. SPN 723/FMI 10 - All Years
1 49-13 1 1 49-13 SUBJECT DATE SPN 723/FMI 3, 8, 10, 11, 31 - All Years February 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 723/FMI 3 - All Years
More informationAdditions, Revisions, or Updates
1 10 09-14 SUBJECT DATE SPN 5016 (ACM) (GHG14) October 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 5016/FMI 3 - DDC-SVC-MAN-0084 GHG14 DD Platform
More informationAdditions, Revisions, or Updates
1 06 10-16 SUBJECT SPN 111 (CPC) (GHG17) and SPN 111 (CPC) (EPA07;EPA10;GHG14) DATE June 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0191
More informationAdditions, Revisions, or Updates
1 01 29-14 SUBJECT DATE SPN 3511/FMI 3 and 4 - GHG14 January 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3511/FMI 3 - DDC-SVC-MAN-0084 GHG14 DD Platform
More informationAdditions, Revisions, or Updates
1 8 03-13 SUBJECT DATE SPN 51/FMI 2, 10, 18 August 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DD Platform SPN 51/FMI 2 All Years Most steps have been
More informationAdditions, Revisions, or Updates
1 8 09-14 SUBJECT DATE SPN 3361 (ACM) (GHG14) August 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 3361/FMI 3, 4, 5, 31
More informationAdditions, Revisions, or Updates
1 12 12-14 SUBJECT DATE SPN 3250 (ACM) December 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10 and GHG14 DD Platform SPN 3250/FMI
More informationSPN 3509 (MCM) (EPA10) and SPN 3509 (MCM) (GHG14) June 2014 SPN 3509/FMI 3 - EPA10 SPN 3509/FMI 4 - EPA10 SPN 3509/FMI 3 - GHG14
1 SUBJECT DATE SPN 3509 (MCM) (EPA10) and SPN 3509 (MCM) (GHG14) June 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3509/FMI 3 - EPA10 The diagnostic
More informationAdditions, Revisions, or Updates
1 29-13 1 1 29-13 SUBJECT DATE DD Platform GHG 14 SPN 3361 FMI 3, 4, 5 UPDATE January 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 GHG
More informationAdditions, Revisions, or Updates
03 57-17 1 03 57-17 SUBJECT DATE SPN 625 (CPC) (GHG17) March 2017 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0191 GHG17 DD Platform SPN 625/FMI
More informationAdditions, Revisions, or Updates
1 SUBJECT DATE SPN 51/FMI 10 and 18 March 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 GHG14 DD Platform SPN 51/FMI 10 SPN 51/FMI 18 The
More informationSPN 3480 (MCM)(EPA07;EPA10;GHG14) June Publication Number / Title Platform Section Title Change
6 06-15 1 6 06-15 SUBJECT DATE SPN 3480 (MCM)(EPA07;EPA10;GHG14) June 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Revised step 3,14, and 29. DDC-SVC-MAN-0084
More informationAdditions, Revisions, or Updates
11 54-16 1 11 54-16 SUBJECT SPN 3242 (ACM) (EPA10;GHG14) SPN 3250 (ACM) (EPA10;GHG14) SPN 3251 (ACM) (GHG14) DATE November 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section
More informationAdditions, Revisions, or Updates
1 8 05-12 SUBJECT DATE SPN 4354/FMI 5, 4356/FMI 5, 4355/FMI 5, 4357/FMI 5 August 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 4354/FMI 5 DDC-SVC-MAN-0084
More informationAdditions, Revisions, or Updates
1 8 04-12 SUBJECT DATE SPNs 4354/FMI 5, 4355/FMI 5, 4356/FMI 5, 4357/FMI 5 August 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 4354/FMI 5 DDC-SVC-MAN-0084
More informationAdditions, Revisions, or Updates
1 01 06-17 SUBJECT DATE SPN 520296 (MCM) (GHG14) and SPN 520296 (MCM) (GHG17) January 2017 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DDC-SVC-MAN-0191
More informationAdditions, Revisions, or Updates
1 2 22-14 SUBJECT DATE SPN 4334/FMI 7 (ACM) (EPA10) February 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform - EPA10- ACM SPN
More informationAdditions, Revisions, or Updates
1 06 13-16 SUBJECT DATE SPN 1590 (CPC) (GHG17) June 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0193 GHG17 Medium Duty SPN 1590/FMI 9 - GHG17
More informationAdditions, Revisions, or Updates
1 12 05-16 SUBJECT SPN 636 (MCM) (GHG17) SPN 636 (MCM) (EPA07;EPA10;GHG14) SPN 636 (MCM) (GHG14) DATE December 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change
More informationAdditions, Revisions, or Updates
1 9 19-13 SUBJECT DATE SPN 102/FMI 18 - GHG14 MCM2.1 October 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 102/FMI 18 Complete
More informationAdditions, Revisions, or Updates
1 2 30-14 SUBJECT DATE SPN 4375/FMI 6 - EPA10 February 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10 DD Platform SPN 4375/FMI 6 -
More informationAdditions, Revisions, or Updates
01 04-15 1 01 04-15 SUBJECT DATE SPN 3464/ FMI 16, 18 (MCM) (GHG14) January 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN
More informationAdditions, Revisions, or Updates
1 03 12-17 SUBJECT DATE SPN 157 (MCM) GHG17 March 2017 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0193 DD Platform - Med Duty SPN 157/FMI 16 -
More informationAdditions, Revisions, or Updates
1 3 01-15 SUBJECT SPN 3251 (ACM) (EPA10) and (ACM) (GHG14), 3936 (ACM) (EPA10;GHG14), and 5298 (ACM) (EPA10;GHG14) DATE March 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section
More informationPublication Number / Title Platform Section Title Change SPN 5246/FMI 0- EPA10 SPN 5246/FMI 15 - EPA10 SPN 5246/FMI 16 - EPA10 SPN 5246/FMI 0 - GHG14
1 3 04-14 SUBJECT SPN 5246/FMI 0, 15, 16 (ACM2)(EPA10) SPN 5246/FMI 0, 15, 16 (ACM2.1)(GHG14) DATE March 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN
More informationAdditions, Revisions, or Updates
1 8 08-14 SUBJECT DATE SPN 4364 (ACM) (EPA10) August 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 4364/FMI 1 - EPA10 SPN
More informationAdditions, Revisions, or Updates
1 9 14-14 SUBJECT DATE SPN 3563 (MCM) (GHG14) September 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 GHG14 DD Platform SPN 3563/FMI 21
More informationAdditions, Revisions, or Updates
6 22-12 1 6 22-12 SUBJECT DATE SPN 4335/FMI 1 - EPA10 June 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10 DD Platform SPN 4335/FMI
More informationAdditions, Revisions, or Updates
6 12-14 1 6 12-14 SUBJECT DATE SPN 5741 (ACM) (GHG14) May 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 5741/FMI 4 DDC-SVC-MAN-0084 GHG14 DD Platform
More informationAdditions, Revisions, or Updates
2 27-14 1 2 27-14 SUBJECT DATE SPN 4335/FMI 7 - EPA10 February 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 4335/FMI 7
More informationAdditions, Revisions, or Updates
1 03 13-17 SUBJECT DATE SPN 520268 (MCM) (GHG17) March 2017 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0193 DD Platform Med Duty SPN 520268/ FMI
More informationSPN 1176/FMI 3 SPN 1176/FMI 4
NUMBER: 8 01 13 S.M. REF.: Listed in Table ENGINE: EPA07 MBE 900 DATE: August 2013 SUBJECT: SPN 1176/FMI 3, 4 ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change DDC-SVC-MAN-0015
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA10 DD Platform DATE: August 2010
NUMBER: 815 10 S.M. REF.: Listed in Table ENGINE: EPA10 DD Platform DATE: August 2010 SUBJECT: SPN 3226 FMI 13 SCR OUTLET NOX SENSOR SIGNAL NOT AVAILABLE ADDITIONS, REVISIONS, OR UPDATES Publication Number
More informationSPN 5443 (ACM)(GHG17) and SPN (ACM)(GHG17) May 2016 SPN 5443/FMI 0 - GHG17 SPN 5443/FMI 15 - GHG17 SPN 5443/FMI 16 - GHG17
1 05 18-16 SUBJECT DATE SPN 5443 (ACM)(GHG17) and SPN 520372 (ACM)(GHG17) May 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 5443/FMI 0 - GHG17 SPN 5443/FMI
More informationAdditions, Revisions, or Updates
1 01 06-15 SUBJECT DATE SPN 3251 (ACM) (EPA10) and (GHG14) January 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3251/FMI 0 - GHG14 DDC-SVC-MAN-0084
More informationAdditions, Revisions, or Updates
1 2 19-11 SUBJECT DATE Revised ACM SPN 3364/FMI 1, 2, and 17 February 2011 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10 DD Platform SPN
More informationTwo SPNs and their FMIs have been reassigned numbers as listed in Table 1. The troubleshooting procedures are the same.
NUMBER: 07 DDEC VI 36 S.M. REF.: 129, 130 ENGINE: EPA07 Series 60 DATE: November 2007 SUBJECT: REASSIGNED SPN NUMBERS PUBLICATION: 6SE567 Two SPNs and their FMIs have been reassigned numbers as listed
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: April 2009
NUMBER: 4 7 09 S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: April 2009 SUBJECT: SPN 27 ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page Number(s) DDC-SVC-MAN-0009
More informationAdditions, Revisions, or Updates
1 3 21-15 SUBJECT DATE SPN 4364 (ACM) (GHG14) March 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 GHG14 DD Platform SPN 4364/SPN 18 - GHG14
More informationRev Rev. Additions, Revisions, or Updates
1 4 89-12Rev SUBJECT DATE SPN 5927/FMI 2 and 7 - GHG14 April 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 5927/FMI 2 - DDC-SVC-MAN-0084 DD Platform
More informationAdditions, Revisions, or Updates
1 10 26-13 SUBJECT DATE SPN 3216/FMI 16 and 18 October 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 GHG14 DD Platform SPN 3216/FMI 16
More informationAdditions, Revisions, or Updates
1 5 25-13 SUBJECT DATE SPN 2791/FMI 7 ALL YEARS May 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 2791/FMI 7 Deleted part
More informationNUMBER: 08 DDEC VI 16 S.M. REF.: listed in Table 1 ENGINE: DD15 DATE: April 2008 SUBJECT: SPN 1636 AND SPN 2630 PUBLICATION: DDC-SVC-MAN-0029
NUMBER: 08 DDEC VI 16 S.M. REF.: listed in Table 1 ENGINE: DD15 DATE: April 2008 SUBJECT: SPN 1636 AND SPN 2630 PUBLICATION: DDC-SVC-MAN-0029 The procedure and direction for SPN 1636 have changed. SPN
More informationSPN 3480/FMI 0, 1, 3, 4, 14, 21, 31 October 2012 SPN 3480/FMI 0 SPN 3480/FMI 1 SPN 3480/FMI 3 SPN 3480/FMI 4 SPN 3480/FMI 14 SPN 3480/FMI 21
1 10 85-12 SUBJECT DATE SPN 3480/FMI 0, 1, 3, 4, 14, 21, 31 October 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3480/FMI 0 SPN 3480/FMI 1 DDC-SVC-MAN-0084
More informationNotice Added to Sections Listed Below February Removal of the Bypass Valve. Removal of the Pressure Relief Valve
2 15-12 1 2 15-12 SUBJECT DATE Notice Added to Sections Listed Below February 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0082 Removal of
More informationSPN (ACM) (GHG17) and SPN (ACM) (GHG17) February Publication Number / Title Platform Section Title Change
1 02 11-17 SUBJECT DATE SPN 520371 (ACM) (GHG17) and SPN 520372 (ACM) (GHG17) February 2017 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0193 GHG17
More informationAdditions, Revisions, or Updates
1 11 19-13 SUBJECT DATE SPN 3216/FMI 2, 18 GHG14 (MCM2.1) November 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3216/FMI 2 DDC-SVC-MAN-0084 GHG14 DD
More informationAdditions, Revisions, or Updates
1 3 30-12 SUBJECT DATE SPN 1761/FMI 2, 9 - MY13 March 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 MY13 DD Platform SPN 1761/FMI 2 - MY13
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: October 2010
NUMBER:10 02 10 S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: October 2010 SUBJECT: DOUBLEHYSTERESISTEST ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page
More informationAdditions, Revisions, or Updates
1 02 10-17 SUBJECT DATE SPN 4364 (ACM) (GHG17) February 2017 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0193 GHG17 Medium Duty SPN 4364/FMI 1
More informationAdditions, Revisions, or Updates
1 SUBJECT SPN 3216 (ACM) (GHG17) SPN 3217 (ACM) (GHG17) DATE March 2017 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0193 GHG17 Medium Duty SPN
More informationSPN 4364 (ACM)(EPA10); SPN 4364 (ACM)(GHG14) January Publication Number / Title Platform Section Title Change SPN 4364/FMI 18 - EPA10
01 01-18 1 01 01-18 SUBJECT DATE SPN 4364 (ACM)(EPA10); SPN 4364 (ACM)(GHG14) January 2018 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD
More informationAdditions, Revisions, or Updates
1 7 18-12 SUBJECT DATE SPN 520268/FMI 16, 18 (MCM2.1) July 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 520268/FMI 16 DDC-SVC-MAN-0084 GHG14 DD Platform
More informationAdditions, Revisions, or Updates
1 4 30-12 SUBJECT DATE SPN 164/FMI 15 (MCM2.1) MY13 April 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 MY13 DD Platform SPN 164/FMI 15
More informationEPA10 DOC Inlet Pressure Sensor November Removal of the EPA10 Diesel Oxidation Catalyst Inlet Pressure Sensor. without Sensor Box
11 10-14 1 11 10-14 SUBJECT DATE EPA10 DOC November 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Removal of the EPA10 DDC-SVC-MAN-0083 EPA10 DD Platform
More informationAdditions, Revisions, or Updates
1 SUBJECT DATE SPN 3250/FMI 0, 15 - EPA10 October 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3250/FMI 0 - DDC-SVC-MAN-0084 EPA10 DD Platform EPA10
More informationAdditions, Revisions, or Updates
1 10 18-16 SUBJECT DATE Symptom Diagnostics - Noise October 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change EPA07/10/ DDC-SVC-MAN-0084 GHG14 DD Platform Overhead
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: May 2013 SUBJECT: SPN 2631/FMI 2 ADDITIONS, REVISIONS, OR UPDATES
NUMBER: 5 26 13 S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: May 2013 SUBJECT: SPN 2631/FMI 2 ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change DDC-SVC-MAN-0010
More informationAdditions, Revisions, or Updates
4 68-12 1 4 68-12 SUBJECT DATE SPN 5018/FMI 18 - GHG14 September 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 5018/FMI
More informationSPN 4364/FMI 17 - GHG17 SPN /FMI 16 - GHG17 SPN /FMI 14 - GHG17 SPN 3216/FMI 16 - GHG17 SPN 3216/FMI 18 - GHG17 SPN 3217/FMI 2 - GHG17
11 29-16 1 11 29-16 SUBJECT SPN 4364 (ACM) (GHG17) SPN 520371 (ACM) (GHG17) SPN 520372 (ACM) (GHG17) SPN 3216 (ACM) (GHG17) SPN 3217 (ACM) (GHG17) SPN 3226 (ACM) (GHG17) SPN 3227 (ACM) (GHG17) Diagnostic
More informationNUMBER: S.M. REF.: Listed in Table 1 ENGINE: DD13 DATE: October 2009
NUMBER: 10 09 09 S.M. REF.: Listed in Table 1 ENGINE: DD13 DATE: October 2009 SUBJECT: INTERMEDIATE FRAME / FUEL INJECTOR WIRING HARNESS ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: April 2009
NUMBER: 4 11 09 S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: April 2009 SUBJECT: SPN 2631 ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page Number(s) DDC-SVC-MAN-0010
More informationAdditions, Revisions, or Updates
1 9 04-11 SUBJECT DATE SPN 3250 / FMI 16 DOC Outlet Temperature High August 2011 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA07 DD13/DD15
More informationAdditions, Revisions, or Updates
1 01 28-14 SUBJECT Symptom Diagnostics - Rough Running or Stalling - Two Filter Fuel System DATE January 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084
More informationAdditions, Revisions, or Updates
1 3 03-15 SUBJECT DATE Contaminated Fluids March 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform Fuel in Oil This is a new section.
More informationAdditions, Revisions, or Updates
1 8 33-13 SUBJECT DATE SPN 3364/FMI 1, 17 (ACM2-EPA10) August 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 3364/FMI 1,
More informationPublication Number / Title Platform Section Title Change. Removal of the High Pressure Fuel Pump Drive Gear - Three-Filter System
5 34-13 1 5 34-13 SUBJECT Removal and Installation of the High Pressure Fuel Pump Drive Gear - Three-Filter System DATE June 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section
More informationAdditions, Revisions, or Updates
1 2 07-13 SUBJECT DATE Removal and Installation of the Camshaft Housing February 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0081 EPA07/10/
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: September 2009
NUMBER: 9 3 09 S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: September 2009 SUBJECT: TURBOCHARGER WASTEGATE ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page
More informationRemoval of the Needle, Amplifier, and Pressure Limiting Valve Return Lines Three-Filter System
1 5 02-13 SUBJECT Needle, Amplifier, and Pressure Limiting Valve Return Lines Three- Filter System, Fuel Rail - Three-Filter System DATE February 2013 Additions, Revisions, or Updates Publication Number
More informationNUMBER: 08 FSTG 12 REV S.M. REF.: Listed in Table ENGINE: EPA07 DD15 DATE: February 2009
NUMBER: 08 FSTG 12 REV S.M. REF.: Listed in Table ENGINE: EPA07 DD15 DATE: February 2009 SUBJECT: ISB (IDLE SPEED BALANCE) VALUES ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title
More informationFuel Filter Maintenance Intervals July EPA10/GHG14 DD Series Preventive Maintenance Tables
1 7 14-13 SUBJECT DATE Fuel Filter Maintenance Intervals July 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0080 EPA10/ GHG14 DD Platform EPA10/GHG14
More informationAdditions, Revisions, or Updates
1 3 06-13 SUBJECT DATE Potential Fuel Leak Points - Two-Filter Fuel System DD Platform March 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Potential Fuel
More informationHydrocarbon Fuel Doser Injector Valve Fuel Supply Line December Publication Number / Title Platform Section Title Change
1 SUBJECT DATE Hydrocarbon Fuel Doser Injector Valve Fuel Supply Line December 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Removal of the Hydrocarbon
More informationFuel Injection System Low Pressure Leak Test Two-Filter Fuel System. Potential Fuel Leak Points Two-Filter. System
10 67-12 1 10 67-12 SUBJECT Fuel Injection System Low Pressure Leak Test, Potential Fuel Leak Points, Alternative Contrast Spray Method for Determining a Leak Path, Alternative Fuel Dye Method for Determining
More informationAdditions, Revisions, or Updates
2 15-14 1 2 15-14 SUBJECT DATE Check for Rough Running or Stalling - Three-Filter Fuel System February 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Check
More informationExhaust and Exhaust Gas Recirculation September Testing of the DD13. Exhaust Gas Recirculation Cooler Water Manifold Assembly - In Chassis
1 09 04-16 SUBJECT DATE Exhaust and Exhaust Gas Recirculation September 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Testing of the DD13 DDC-SVC-MAN-0190
More informationSymptom Diagnostics - Belt Coming Off, Shredding or Misalignment September Symptom Diagnostics - Belt Coming Off, Shredding or Misalignment
09 02-16 1 09 02-16 SUBJECT DATE Symptom Diagnostics - Belt Coming Off, Shredding or Misalignment September 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change
More informationRemoval and Installation of the Fuel Injector Cup February Removal of the Fuel Injector Cup Three-Filter System and Two-Filter System
1 2 25-14 SUBJECT DATE Removal and Installation of the Fuel Injector Cup February 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Removal of the Fuel Injector
More informationFIS Low Pressure Leak Test March Publication Number / Title Platform Section Title Change. FIS Low Pressure Leak Test- Three-Filter Fuel System
1 3 02-13 SUBJECT DATE FIS Low Pressure Leak Test March 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform FIS Low Pressure Leak
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: February 2011
NUMBER: 2 15 11 S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: February 2011 SUBJECT: FAULTY FUEL INJECTOR ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page
More informationNUMBER: 08 DDEC VI 10 S.M. REF.: 92 ENGINE: EPA07 Series 60 DATE: March 2008
NUMBER: 08 DDEC VI 10 S.M. REF.: 92 ENGINE: EPA07 Series 60 DATE: March 2008 SUBJECT: SPN 2659 PUBLICATION: DDC-SVC-MAN-0009 (6SE567) Section SPN 2659/FMI 0, refer to section 92.1 SPN 2659/FMI 17, refer
More informationPublication Number / Title Platform Section Title Change. Removal of DD15 and DD16 Delphi Exhaust Gas Recirculation Valve Actuator
7 02-15 1 7 02-15 SUBJECT DD15 and DD16 Delphi Exhaust Gas Recirculation Valve Actuator and DD15 and DD16 Sonceboz Exhaust Gas Recirculation Valve Actuator DATE July 2015 Additions, Revisions, or Updates
More informationAdditions, Revisions, or Updates
1 8 22-13 SUBJECT DATE Water Manifold Assembly August 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Installation of the DD13 EGR Cooler Water DDC-SVC-MAN-0081
More informationEGR Actuator May Description and Operation of the DD13 Exhaust Gas Recirculation Valve Actuator
5 17-13 1 5 17-13 SUBJECT DATE EGR Actuator May 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Description and Operation of the DD13 Exhaust Gas Recirculation
More informationAdditions, Revisions, or Updates
1 12 02-12 SUBJECT DATE Test E - Three-Filter Fuel System December 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform Test E - Three-Filter
More informationAdditions, Revisions, or Updates
1 02 06-16 SUBJECT DATE Fuel Rail - Three-Filter System February 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0082 DD Platform - All Years
More information