NUMBER: 08 DDEC VI 16 S.M. REF.: listed in Table 1 ENGINE: DD15 DATE: April 2008 SUBJECT: SPN 1636 AND SPN 2630 PUBLICATION: DDC-SVC-MAN-0029
|
|
- Edgar Melvyn Nash
- 6 years ago
- Views:
Transcription
1 NUMBER: 08 DDEC VI 16 S.M. REF.: listed in Table 1 ENGINE: DD15 DATE: April 2008 SUBJECT: SPN 1636 AND SPN 2630 PUBLICATION: DDC-SVC-MAN-0029 The procedure and direction for SPN 1636 have changed. SPN 1636 indicates a problem with the intake manifold temperature circuit. SPN 2630 has been added. This code indicates a problem with the intake air temperature circuit. Section SPN 1636, refer to section 90 SPN 2630, refer to section 94 Table 1 Manual Changes and Additions Changes/Additions SPN 1636/FMI 3, intake manifold temperature circuit failed high SPN 1636/FMI 4, intake manifold temperature circuit failed low SPN 2630/FMI 3, intake air temperature circuit failed high SPN 2630/FMI 4, intake air temperature circuit failed low
2 SPN 1636 This SPN indicates the intake manifold temperature is outside of normal operating range. SPN 1636/FMI 3 This diagnostic condition is typically intake manifold temperature circuit failed high. Check as follows: 1. Check for multiple codes. [a] If 1636/3 and 2630/3 are present, go to step 6. [b] If only 1636/3 is present, go to the next step. 2. Disconnect the Intake Manifold Temperature Sensor. 3. Turn the ignition ON (key On, engine OFF). 4. Measure the voltage between pins 1 and 2 of the Intake Manifold Temperature Sensor harness [a] If the voltage is between 2.8 and 3 volts, replace the Intake Manifold Temperature Sensor. [b] If the voltage is less than 2.8 volts, go to the next step.
3 5. Measure the voltage between pin 2 of the Intake Manifold Temperature Sensor and ground. [a] If the voltage is between 2.8 and 3 volts, repair the wire between pin 1 of the Intake Manifold Temperature Sensor connector and pin 52 of the MCM 120 pin [b] If the voltage is less than 2.8 volts, repair the wire between pin 2 of the Intake Manifold Temperature Sensor connector and pin 106 of the MCM 120 pin 6. Measure the voltage between pins 1 and 2 of the Intake Manifold Temperature Sensor harness [a] If the voltage is greater than 3 volts, repair the short to power on either pin 106 or 119 of the MCM 120 pin [b] If no voltage is present, repair the open between pin 52 of the MCM 120 pin connector and the Intake Manifold Temperature Sensor and the Intake Air Temperature Sensor. SPN 1636/FMI 4 This diagnostic condition is typically intake manifold temperature circuit failed low. Repair the short to ground between pin 2 of the Intake Manifold Temperature Sensor harness connector and pin 106 of the MCM 120 pin
4 SPN 2630 This SPN indicates the intake air temperature is outside of normal operating range. SPN 2630/FMI 3 This diagnostic condition is typically intake air temperature circuit failed high. Check as follows: 1. Check for multiple codes. [a] If codes 1636/3 and 2630/3 are active at the same time, go to step 6. [b] If only fault 2630/3 is active, go to the next step. 2. Disconnect the Intake Air Temperature Sensor. 3. Turn the ignition ON (key On, engine OFF). 4. Measure the voltage between pins 1 and 2 of the Intake Air Temperature Sensor harness [a] If the voltage is between 2.8 and 3 volts, replace the Intake Air Temperature Sensor. [b] If the voltage is less than 2.8 volts, go to the next step.
5 5. Measure the voltage between pin 2 of the Intake Air Temperature Sensor harness and ground. [a] If the voltage is between 2.8 and 3 volts, repair the wire between pin 1 of the Intake Air Temperature Sensor connector and pin 52 of the MCM 120 pin [b] If the voltage is less than 2.8 volts, repair the wire between pin 2 of the Intake Air Temperature Sensor connector and pin 119 of the MCM 120 pin 6. Measure the voltage between pins 1 and 2 of the Intake Air Temperature Sensor harness [a] If voltage is greater than 3 volts, repair the short to power on either pin 106 or 119 of the MCM 120 pin [b] If the no voltage is present, repair the open between pin 52 of the MCM 120 pin connector and the Intake Air Temperature Sensor and Intake Manifold Temperature Sensor. Verify repairs. SPN 2630/FMI 4 This diagnostic condition is typically intake air temperature circuit failed low. Repair the short to ground between pin 2 of the Intake Air Temperature Sensor harness connector and pin 119 of the MCM 120 pin Verify Repairs.
6 ADDITIONAL SERVICE INFORMATION Additional service information is available in one of the DDEC VI troubleshooting guides. Detroit Diesel, DDC, Series 60 and the spinning arrows design are registered trademarks of Detroit Diesel Corporation. Copyright 2008 Detroit Diesel Corporation. All rights reserved. Printed in U.S.A.
Two SPNs and their FMIs have been reassigned numbers as listed in Table 1. The troubleshooting procedures are the same.
NUMBER: 07 DDEC VI 36 S.M. REF.: 129, 130 ENGINE: EPA07 Series 60 DATE: November 2007 SUBJECT: REASSIGNED SPN NUMBERS PUBLICATION: 6SE567 Two SPNs and their FMIs have been reassigned numbers as listed
More informationNUMBER: 1 DDEC VI 07 S.M. REF.: Listed in Table 1 ENGINE: Series 60 DATE: February 2007
NUMBER: 1 DDEC VI 07 S.M. REF.: Listed in Table 1 ENGINE: Series 60 DATE: February 2007 SUBJECT: SENSOR RESISTANCE CHART PUBLICATION: 6SE567 The Series 60 DDEC VI Troubleshooting Guide has been revised.
More informationNUMBER: 08 DDEC VI 10 S.M. REF.: 92 ENGINE: EPA07 Series 60 DATE: March 2008
NUMBER: 08 DDEC VI 10 S.M. REF.: 92 ENGINE: EPA07 Series 60 DATE: March 2008 SUBJECT: SPN 2659 PUBLICATION: DDC-SVC-MAN-0009 (6SE567) Section SPN 2659/FMI 0, refer to section 92.1 SPN 2659/FMI 17, refer
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA10 DD Platform DATE: August 2010
NUMBER: 815 10 S.M. REF.: Listed in Table ENGINE: EPA10 DD Platform DATE: August 2010 SUBJECT: SPN 3226 FMI 13 SCR OUTLET NOX SENSOR SIGNAL NOT AVAILABLE ADDITIONS, REVISIONS, OR UPDATES Publication Number
More informationSPN 1176/FMI 3 SPN 1176/FMI 4
NUMBER: 8 01 13 S.M. REF.: Listed in Table ENGINE: EPA07 MBE 900 DATE: August 2013 SUBJECT: SPN 1176/FMI 3, 4 ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change DDC-SVC-MAN-0015
More informationAdditions, Revisions, or Updates
1 8 04-12 SUBJECT DATE SPNs 4354/FMI 5, 4355/FMI 5, 4356/FMI 5, 4357/FMI 5 August 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 4354/FMI 5 DDC-SVC-MAN-0084
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: October 2010
NUMBER:10 02 10 S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: October 2010 SUBJECT: DOUBLEHYSTERESISTEST ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page
More informationAdditions, Revisions, or Updates
1 8 05-12 SUBJECT DATE SPN 4354/FMI 5, 4356/FMI 5, 4355/FMI 5, 4357/FMI 5 August 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 4354/FMI 5 DDC-SVC-MAN-0084
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: April 2009
NUMBER: 4 7 09 S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: April 2009 SUBJECT: SPN 27 ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page Number(s) DDC-SVC-MAN-0009
More informationThe Aftertreatment System Technician's Guide (7SE63) was revised to include three new procedures.
NUMBER: 07 ATS 3 S.M. REF.: Listed in Table 1 ENGINE: ATS DATE: December 2007 SUBJECT: ADDITIONAL PROCEDURES WERE ADDED TO AFTERTREATMENT SYSTEM PUBLICATION: 7SE63 The Aftertreatment System Technician's
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: April 2009
NUMBER: 4 11 09 S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: April 2009 SUBJECT: SPN 2631 ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page Number(s) DDC-SVC-MAN-0010
More informationAdditions, Revisions, or Updates
1 6 07-15 SUBJECT DATE SPN 3464 (MCM) (EPA10;GHG14) June 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3464/FMI 3 - DDC-SVC-MAN-0084 EPA10/ GHG14 DD
More informationAdditions, Revisions, or Updates
1 3 30-12 SUBJECT DATE SPN 1761/FMI 2, 9 - MY13 March 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 MY13 DD Platform SPN 1761/FMI 2 - MY13
More informationAdditions, Revisions, or Updates
1 02 01-14 SUBJECT DATE SPN 1761/FMI 3, 4 ( ACM2-EPA10) (ACM2.1-GHG14) February 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform
More informationSPN 3509 (MCM) (EPA10) and SPN 3509 (MCM) (GHG14) June 2014 SPN 3509/FMI 3 - EPA10 SPN 3509/FMI 4 - EPA10 SPN 3509/FMI 3 - GHG14
1 SUBJECT DATE SPN 3509 (MCM) (EPA10) and SPN 3509 (MCM) (GHG14) June 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3509/FMI 3 - EPA10 The diagnostic
More informationAdditions, Revisions, or Updates
1 06 10-16 SUBJECT SPN 111 (CPC) (GHG17) and SPN 111 (CPC) (EPA07;EPA10;GHG14) DATE June 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0191
More informationRev Rev. Additions, Revisions, or Updates
1 4 89-12Rev SUBJECT DATE SPN 5927/FMI 2 and 7 - GHG14 April 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 5927/FMI 2 - DDC-SVC-MAN-0084 DD Platform
More informationAdditions, Revisions, or Updates
1 01 29-14 SUBJECT DATE SPN 3511/FMI 3 and 4 - GHG14 January 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3511/FMI 3 - DDC-SVC-MAN-0084 GHG14 DD Platform
More informationAdditions, Revisions, or Updates
1 6 05-13 SUBJECT DATE SPN 625/FMI 9 EPA10 - GHG14 June 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10/ GHG14 DD Platform SPN 625/FMI
More informationAdditions, Revisions, or Updates
1 01 11-16 SUBJECT DATE SPN 647 (MCM)(EPA07-EPA10-GHG14) January 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DDC-SVC-MAN-S084 DD Platform
More informationAdditions, Revisions, or Updates
10 15-13 1 10 15-13 SUBJECT DATE SPN 4257/FMI 3, 4 October 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10/ GHG14 DD Platform SPN 4257/FMI
More informationAdditions, Revisions, or Updates
1 5 25-13 SUBJECT DATE SPN 2791/FMI 7 ALL YEARS May 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 2791/FMI 7 Deleted part
More informationAdditions, Revisions, or Updates
1 6 13-14 SUBJECT DATE SPN 4259/FMI 4 (MCM) (EPA07) June 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA07 DD Platform SPN 4259/FMI 4
More informationPublication Number / Title Platform Section Title Change SPN 5246/FMI 0- EPA10 SPN 5246/FMI 15 - EPA10 SPN 5246/FMI 16 - EPA10 SPN 5246/FMI 0 - GHG14
1 3 04-14 SUBJECT SPN 5246/FMI 0, 15, 16 (ACM2)(EPA10) SPN 5246/FMI 0, 15, 16 (ACM2.1)(GHG14) DATE March 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN
More informationSPN 723/FMI 3, 8, 10, 11, 31 - All Years February SPN 723/FMI 3 - All Years. SPN 723/FMI 8 - All Years. SPN 723/FMI 10 - All Years
1 49-13 1 1 49-13 SUBJECT DATE SPN 723/FMI 3, 8, 10, 11, 31 - All Years February 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 723/FMI 3 - All Years
More informationNotice Added to Sections Listed Below February Removal of the Bypass Valve. Removal of the Pressure Relief Valve
2 15-12 1 2 15-12 SUBJECT DATE Notice Added to Sections Listed Below February 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0082 Removal of
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: September 2009
NUMBER: 9 3 09 S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: September 2009 SUBJECT: TURBOCHARGER WASTEGATE ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page
More informationAdditions, Revisions, or Updates
1 5 03-14 SUBJECT DATE SPN 3599/FMI 3 and 4 (ACM) May 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3599/FMI 3-1 DDC-SVC-MAN-0084 EPA10/ GHG14 DD Platform
More informationAdditions, Revisions, or Updates
1 10 16-13 SUBJECT DATE SPN 3216/FMI 13 - EPA10/GHG14 October 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10 GHG14 DD Platform SPN
More informationAdditions, Revisions, or Updates
1 10 28-13 SUBJECT DATE SPN 625/FMI 9 EPA10 - GHG14 (ACM) October 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10/ GHG14 DD Platform
More informationAdditions, Revisions, or Updates
1 4 09-14 SUBJECT DATE ACM2.1 SPN 3597/FMI 3, 4 - GHG14 April 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 3597/FMI 3,
More informationAdditions, Revisions, or Updates
1 01 06-15 SUBJECT DATE SPN 3251 (ACM) (EPA10) and (GHG14) January 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3251/FMI 0 - GHG14 DDC-SVC-MAN-0084
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: May 2013 SUBJECT: SPN 2631/FMI 2 ADDITIONS, REVISIONS, OR UPDATES
NUMBER: 5 26 13 S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: May 2013 SUBJECT: SPN 2631/FMI 2 ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change DDC-SVC-MAN-0010
More informationAdditions, Revisions, or Updates
03 57-17 1 03 57-17 SUBJECT DATE SPN 625 (CPC) (GHG17) March 2017 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0191 GHG17 DD Platform SPN 625/FMI
More informationAdditions, Revisions, or Updates
1 8 03-13 SUBJECT DATE SPN 51/FMI 2, 10, 18 August 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DD Platform SPN 51/FMI 2 All Years Most steps have been
More informationAdditions, Revisions, or Updates
6 12-14 1 6 12-14 SUBJECT DATE SPN 5741 (ACM) (GHG14) May 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 5741/FMI 4 DDC-SVC-MAN-0084 GHG14 DD Platform
More informationNUMBER: S.M. REF.: 8.5 ENGINE: EPA07 Series 60 DATE: November 2008
NUMBER: 08 60-7 S.M. REF.: 8.5 ENGINE: EPA07 Series 60 DATE: November 2008 SUBJECT: EGR RATE MEASUREMENT SYSTEM PUBLICATION: DDC-SVC-MAN-0005 EGR Rate Measurement System has new information added. EGR
More informationAdditions, Revisions, or Updates
1 01 06-17 SUBJECT DATE SPN 520296 (MCM) (GHG14) and SPN 520296 (MCM) (GHG17) January 2017 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DDC-SVC-MAN-0191
More informationAdditions, Revisions, or Updates
1 8 02-14 SUBJECT DATE SPN 4334 (ACM) (GHG14) August 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 4334/FMI 3 - DDC-SVC-MAN-0084 GHG14 DD Platform GHG14
More informationAdditions, Revisions, or Updates
1 06 13-16 SUBJECT DATE SPN 1590 (CPC) (GHG17) June 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0193 GHG17 Medium Duty SPN 1590/FMI 9 - GHG17
More informationAdditions, Revisions, or Updates
1 SUBJECT DATE SPN 51/FMI 10 and 18 March 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 GHG14 DD Platform SPN 51/FMI 10 SPN 51/FMI 18 The
More informationAdditions, Revisions, or Updates
1 10 09-14 SUBJECT DATE SPN 5016 (ACM) (GHG14) October 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 5016/FMI 3 - DDC-SVC-MAN-0084 GHG14 DD Platform
More informationAdditions, Revisions, or Updates
1 01 06-16 SUBJECT SPN 4334/FMI 4 (ACM) (GHG14) SPN 4334/FMI 4 (ACM) (GHG17) DATE January 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084
More informationNUMBER: S.M. REF.: Listed in Table 1 ENGINE: DD13 DATE: October 2009
NUMBER: 10 09 09 S.M. REF.: Listed in Table 1 ENGINE: DD13 DATE: October 2009 SUBJECT: INTERMEDIATE FRAME / FUEL INJECTOR WIRING HARNESS ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section
More informationAdditions, Revisions, or Updates
1 SUBJECT DATE SPN 3659/FMI 5 GHG14 MCM2.1 May 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 GHG14 DD Platform SPN 3659/FMI 5 GHG14 This
More informationAdditions, Revisions, or Updates
1 29-13 1 1 29-13 SUBJECT DATE DD Platform GHG 14 SPN 3361 FMI 3, 4, 5 UPDATE January 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 GHG
More informationAdditions, Revisions, or Updates
1 5 20-12 SUBJECT DATE SPN 3664/FMI 5 GHG14 June 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 GHG14 DD Platform SPN 3664/FMI 5 GHG14 This
More informationSection 7.3 Water Manifold has been updated.
NUMBER: 08 DD15-11 S.M. REF.: 7.3 ENGINE: DD15 DATE: September 2008 SUBJECT: WATER MANIFOLD PUBLICATION: DDC-SVC-MAN-0002 Section 7.3 Water Manifold has been updated. 7.3 WATER MANIFOLD Coolant flows from
More informationNUMBER: 08 FSTG 12 REV S.M. REF.: Listed in Table ENGINE: EPA07 DD15 DATE: February 2009
NUMBER: 08 FSTG 12 REV S.M. REF.: Listed in Table ENGINE: EPA07 DD15 DATE: February 2009 SUBJECT: ISB (IDLE SPEED BALANCE) VALUES ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title
More informationAlternator Ground Check Verify Repairs
DDEC III/IV SINGLE ECM TROUBLESHOOTING GUIDE 16.3.6 Alternator Ground Check Perform the following steps to check the alternator ground. 1. Connect all connectors. 2. Remove alternator belt or disable alternator
More informationEGR heater plate removal and installation procedure has been added.
NUMBER: 08 60-3 S.M. REF.: 8.3 ENGINE: EPA07 Series 60 DATE:June 2008 SUBJECT: EGR HEATER PLATE PUBLICATION: DDC-SVC-MAN-0005 EGR heater plate removal and installation procedure has been added. 8.3.1 REMOVAL
More informationAdditions, Revisions, or Updates
1 8 09-14 SUBJECT DATE SPN 3361 (ACM) (GHG14) August 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 3361/FMI 3, 4, 5, 31
More informationSPN 3480 (MCM)(EPA07;EPA10;GHG14) June Publication Number / Title Platform Section Title Change
6 06-15 1 6 06-15 SUBJECT DATE SPN 3480 (MCM)(EPA07;EPA10;GHG14) June 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Revised step 3,14, and 29. DDC-SVC-MAN-0084
More informationAdditions, Revisions, or Updates
1 12 05-16 SUBJECT SPN 636 (MCM) (GHG17) SPN 636 (MCM) (EPA07;EPA10;GHG14) SPN 636 (MCM) (GHG14) DATE December 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: February 2009
NUMBER: 2 5 09 S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: February 2009 SUBJECT: VALVE LIFT SPECIFICATIONS ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change
More informationAdditions, Revisions, or Updates
1 12 12-14 SUBJECT DATE SPN 3250 (ACM) December 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10 and GHG14 DD Platform SPN 3250/FMI
More informationAdditions, Revisions, or Updates
4 68-12 1 4 68-12 SUBJECT DATE SPN 5018/FMI 18 - GHG14 September 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 5018/FMI
More informationAdditions, Revisions, or Updates
1 4 30-12 SUBJECT DATE SPN 164/FMI 15 (MCM2.1) MY13 April 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 MY13 DD Platform SPN 164/FMI 15
More informationAdditions, Revisions, or Updates
1 9 19-13 SUBJECT DATE SPN 102/FMI 18 - GHG14 MCM2.1 October 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 102/FMI 18 Complete
More informationSPN 3480/FMI 0, 1, 3, 4, 14, 21, 31 October 2012 SPN 3480/FMI 0 SPN 3480/FMI 1 SPN 3480/FMI 3 SPN 3480/FMI 4 SPN 3480/FMI 14 SPN 3480/FMI 21
1 10 85-12 SUBJECT DATE SPN 3480/FMI 0, 1, 3, 4, 14, 21, 31 October 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3480/FMI 0 SPN 3480/FMI 1 DDC-SVC-MAN-0084
More informationAdditions, Revisions, or Updates
11 54-16 1 11 54-16 SUBJECT SPN 3242 (ACM) (EPA10;GHG14) SPN 3250 (ACM) (EPA10;GHG14) SPN 3251 (ACM) (GHG14) DATE November 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section
More informationEPA10 DOC Inlet Pressure Sensor November Removal of the EPA10 Diesel Oxidation Catalyst Inlet Pressure Sensor. without Sensor Box
11 10-14 1 11 10-14 SUBJECT DATE EPA10 DOC November 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Removal of the EPA10 DDC-SVC-MAN-0083 EPA10 DD Platform
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA04 MBE 4000 DATE: April 2009
NUMBER: 4 8 09 S.M. REF.: Listed in Table ENGINE: EPA04 MBE 4000 DATE: April 2009 SUBJECT: CYLINDER HEAD INSTALLATION ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: DD15 DATE: March 2009
NUMBER: 3 3 09 S.M. REF.: Listed in Table ENGINE: DD15 DATE: March 2009 SUBJECT: FUEL FILTER ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page Number(s) DDC-SVC-MAN-0037
More informationAdditions, Revisions, or Updates
1 03 12-17 SUBJECT DATE SPN 157 (MCM) GHG17 March 2017 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0193 DD Platform - Med Duty SPN 157/FMI 16 -
More informationAdditions, Revisions, or Updates
01 04-15 1 01 04-15 SUBJECT DATE SPN 3464/ FMI 16, 18 (MCM) (GHG14) January 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN
More informationAdditions, Revisions, or Updates
1 03 13-17 SUBJECT DATE SPN 520268 (MCM) (GHG17) March 2017 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0193 DD Platform Med Duty SPN 520268/ FMI
More informationAdditions, Revisions, or Updates
1 SUBJECT DATE SPN 3250/FMI 0, 15 - EPA10 October 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3250/FMI 0 - DDC-SVC-MAN-0084 EPA10 DD Platform EPA10
More information81 FLASH CODE 81 OIL LEVEL, EXHAUST TEMP, EGR TEMP OR EGR DELTA-PRESSURE, CIRCUIT FAILED HIGH
81 FLASH CODE 81 OIL LEVEL, EXHAUST TEMP, EGR TEMP OR EGR DELTA-PRESSURE, CIRCUIT FAILED HIGH Section Page 81.1 DESCRIPTION OF FLASH CODE 81... 81-3 81.2 SAE J1587 EQUIVALENT CODE FOR FLASH CODE 81...
More informationAdditions, Revisions, or Updates
1 9 04-11 SUBJECT DATE SPN 3250 / FMI 16 DOC Outlet Temperature High August 2011 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA07 DD13/DD15
More informationAdditions, Revisions, or Updates
1 01 28-14 SUBJECT Symptom Diagnostics - Rough Running or Stalling - Two Filter Fuel System DATE January 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084
More informationNUMBER: S.M. REF.: Listed in Table 1 ENGINE: DD13 DATE: July 2009
NUMBER: 7 4 09 S.M. REF.: Listed in Table 1 ENGINE: DD13 DATE: July 2009 SUBJECT: EXHAUST GAS RECIRCULATION COOLER WATER MANIFOLD ASSEMBLY ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: DD Platform DATE: May 2010
NUMBER: 5 04 10 S.M. REF.: Listed in Table ENGINE: DD Platform DATE: May 2010 SUBJECT: FUEL SYSTEM PRIMING USING ESOC 350 FUEL PRIMING PUMP ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform
More information82 FLASH CODE 82 OIL LEVEL, EXHAUST TEMP, EGR TEMP OR EGR DELTA-PRESSURE, CIRCUIT FAILED LOW
82 FLASH CODE 82 OIL LEVEL, EXHAUST TEMP, EGR TEMP OR EGR DELTA-PRESSURE, CIRCUIT FAILED LOW Section Page 82.1 DESCRIPTION OF FLASH CODE 82... 82-3 82.2 SAE J1587 EQUIVALENT CODE FOR FLASH CODE 82... 82-3
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: February 2011
NUMBER: 2 15 11 S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: February 2011 SUBJECT: FAULTY FUEL INJECTOR ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page
More informationAdditions, Revisions, or Updates
1 7 18-12 SUBJECT DATE SPN 520268/FMI 16, 18 (MCM2.1) July 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 520268/FMI 16 DDC-SVC-MAN-0084 GHG14 DD Platform
More informationAdditions, Revisions, or Updates
1 2 30-14 SUBJECT DATE SPN 4375/FMI 6 - EPA10 February 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10 DD Platform SPN 4375/FMI 6 -
More informationAdditions, Revisions, or Updates
2 15-14 1 2 15-14 SUBJECT DATE Check for Rough Running or Stalling - Three-Filter Fuel System February 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Check
More informationAdditions, Revisions, or Updates
1 2 22-14 SUBJECT DATE SPN 4334/FMI 7 (ACM) (EPA10) February 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform - EPA10- ACM SPN
More informationAdditions, Revisions, or Updates
1 9 14-14 SUBJECT DATE SPN 3563 (MCM) (GHG14) September 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 GHG14 DD Platform SPN 3563/FMI 21
More informationAdditions, Revisions, or Updates
1 10 26-13 SUBJECT DATE SPN 3216/FMI 16 and 18 October 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 GHG14 DD Platform SPN 3216/FMI 16
More informationAdditions, Revisions, or Updates
1 11 19-13 SUBJECT DATE SPN 3216/FMI 2, 18 GHG14 (MCM2.1) November 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3216/FMI 2 DDC-SVC-MAN-0084 GHG14 DD
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: August 2009
NUMBER: 8 5 09 S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: August 2009 SUBJECT: CYLINDERHEADCOOLANTVENTLINE ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change
More informationThere are changes to the fuel system leak detection and threshold resetting procedure.
NUMBER: 08 FSTG 1 S.M. REF.: 5.6 ENGINE: DD15 DATE: May 2008 SUBJECT: FUEL SYSTEM LEAK DETECTION TEST AND THRESHOLD RESETTING PUBLICATION: DDC-SVC-MAN-0037 There are changes to the fuel system leak detection
More informationAdditions, Revisions, or Updates
1 12 02-12 SUBJECT DATE Test E - Three-Filter Fuel System December 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform Test E - Three-Filter
More informationAdditions, Revisions, or Updates
1 8 33-13 SUBJECT DATE SPN 3364/FMI 1, 17 (ACM2-EPA10) August 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 3364/FMI 1,
More information34 FLASH CODE 34 - TBS LOW
34 FLASH CODE 34 - TBS LOW Section Page 34.1 DESCRIPTION OF FLASH CODE 34... 34-3 34.2 SAE J1587 EQUIVALENT CODE FOR FLASH CODE 34... 34-3 34.3 TROUBLESHOOTING FLASH CODE 34... 34-4 Figure 34-1 Turbo Boost
More informationAdditions, Revisions, or Updates
1 02 10-17 SUBJECT DATE SPN 4364 (ACM) (GHG17) February 2017 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0193 GHG17 Medium Duty SPN 4364/FMI 1
More informationAdditions, Revisions, or Updates
2 27-14 1 2 27-14 SUBJECT DATE SPN 4335/FMI 7 - EPA10 February 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 4335/FMI 7
More informationAdditions, Revisions, or Updates
1 10 18-16 SUBJECT DATE Symptom Diagnostics - Noise October 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change EPA07/10/ DDC-SVC-MAN-0084 GHG14 DD Platform Overhead
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07/10 DD Platform DATE: September 2010
NUMBER: 9 09 10 S.M. REF.: Listed in Table ENGINE: EPA07/10 DD Platform DATE: September 2010 SUBJECT: INSTALLATION OF THE CAMSHAFT AND ROCKER SHAFT/ENGINE BRAKE ASSEMBLY ADDITIONS, REVISIONS, OR UPDATES
More informationAdditions, Revisions, or Updates
1 3 01-15 SUBJECT SPN 3251 (ACM) (EPA10) and (ACM) (GHG14), 3936 (ACM) (EPA10;GHG14), and 5298 (ACM) (EPA10;GHG14) DATE March 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section
More informationSPN (ACM) (GHG17) and SPN (ACM) (GHG17) February Publication Number / Title Platform Section Title Change
1 02 11-17 SUBJECT DATE SPN 520371 (ACM) (GHG17) and SPN 520372 (ACM) (GHG17) February 2017 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0193 GHG17
More information33 FLASH CODE 33 - TBS HIGH
33 FLASH CODE 33 - TBS HIGH Section Page 33.1 DESCRIPTION OF FLASH CODE 33... 33-3 33.2 SAE J1587 EQUIVALENT CODE FOR FLASH CODE 33... 33-3 33.3 TROUBLESHOOTING FLASH CODE 33... 33-4 Figure 33-1 Turbo
More informationSPN 4364 (ACM)(EPA10); SPN 4364 (ACM)(GHG14) January Publication Number / Title Platform Section Title Change SPN 4364/FMI 18 - EPA10
01 01-18 1 01 01-18 SUBJECT DATE SPN 4364 (ACM)(EPA10); SPN 4364 (ACM)(GHG14) January 2018 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD
More informationFIS Low Pressure Leak Test March Publication Number / Title Platform Section Title Change. FIS Low Pressure Leak Test- Three-Filter Fuel System
1 3 02-13 SUBJECT DATE FIS Low Pressure Leak Test March 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform FIS Low Pressure Leak
More informationAdditions, Revisions, or Updates
6 22-12 1 6 22-12 SUBJECT DATE SPN 4335/FMI 1 - EPA10 June 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10 DD Platform SPN 4335/FMI
More informationAdditions, Revisions, or Updates
1 8 08-14 SUBJECT DATE SPN 4364 (ACM) (EPA10) August 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 4364/FMI 1 - EPA10 SPN
More informationHigh pressure fuel line and transfer tube removal and installation procedures have been updated.
NUMBER: 08 MBE 4000-3 S.M. REF.: 2.3 ENGINE: EPA04 MBE 4000 DATE: July 2008 SUBJECT: HIGH PRESSURE FUEL LINE AND TRANSFER TUBE PUBLICATION:DDC-SVC-MAN-0023 High pressure fuel line and transfer tube removal
More informationNUMBER: 1 SECM 03 S.M. REF.: Listed in Table 1 ENGINE: ALL DATE: February 2003
NUMBER: 1 SECM 03 S.M. REF.: Listed in Table 1 ENGINE: ALL DATE: February 2003 SUBJECT: UPDATES FOR TROUBLESHOOTING SERIES 60 AND SERIES 50 EGR RELATED CODES AND FAULTS INTRODUCTION The Series 60 engine
More information