Before repair, remove the airbag sensor if shocks are likely to be applied to the sensor during repair.
|
|
- Clyde Marsh
- 6 years ago
- Views:
Transcription
1 NOTICE: hen inspecting or repairing the SS, perform service in accordance with the following precautionary instructions and the procedure, and precautions in the epair Manual applicable for the model year. SS Malfunction symptoms of the SS are difficult to confirm, so the DTCs become the most important source of information when troubleshooting. hen troubleshooting the SS, always inspect the DTCs before disconnecting the battery. ork must be started more than 90 seconds after the ignition S is turned to the OCK position and the negative (-) terminal cable is disconnected from the battery. (The SS is equipped with a back-up power source so that if work is started within 90 seconds from disconnecting the negative (-) terminal cable of the battery, the SS may deploy.) hen the negative (-) terminal cable is disconnected from the battery, the memory of the clock and audio system will be cleared. So before starting work, make a record of the contents in the audio memory system. hen work is finished, reset the audio systems as they were before and adjust the clock. Some vehicles have power tilt steering, power telescopic steering, power seat and power outside rear view mirror which are all equipped with memory function. However, it is not possible to make a record of these memory contents. So when the work is finished, it will be necessary to explain it to your customer, and ask the customer to adjust the features and reset the memory. To avoid erasing the memory in each system, never use a back-up power supply from outside the vehicle. efore repair, remove the airbag sensor if shocks are likely to be applied to the sensor during repair. Do not expose the following parts directly to hot air or flame; Even in cases of a minor collision where the SS does not deploy, the following parts should be inspected; Never use SS parts from another vehicle. hen replacing parts, replace with new parts. For the purpose of reuse, never disassemble and repair the following parts. If the following parts have been dropped, or have cracks, dents and other defects in their case, bracket, and connector, replace with new one. Use a volt/ohmmeter with high impedance (0 kω/v minimum) for troubleshooting electrical circuits of the system. Information labels are attached to the periphery of the SS components. Follow the instructions of the notice. fter work on the SS is completed, check the SS warning light. If the vehicle is equipped with a mobile communication system, refer to the precaution in the IN section of the epair Manual. Steering wheel pad Front passenger airbag assembly Side airbag assembly Curtain shield airbag assembly Seat belt pretensioner Center airbag sensor assembly Front airbag sensor assembly Side airbag sensor assembly 005 HIHNDE (ED59U) 55
2 SS From ower Source System (See age 6) 0 IN 6 6 M E 9 irbag Squib (Front assenger irbag ssembly) S6 Side irbag Sensor Front H S7 Side irbag Sensor Front H SS+ SS- VU ES SS+ SS- VU ES I SS+ SS- VU ES 6(), 7(), 8(C) irbag Sensor ssembly +S - S 5 6 +S - S 9 0 D+ D- D+ D C 0 C 6 C C SS+ SS- 7 C VU 5 C ES C 6 C (*) IK IK - IK IK S - S +S -S 8 irbag Sensor Front H 9 irbag Sensor Front H 0 irbag Squib (Steering heel ad) retensioner H retensioner H HIHNDE (ED59U)
3 * : w/ ear Seat Entertainment System * : w/o ear Seat Entertainment System * : w/ Curtain Shield irbag * : w/o Curtain Shield irbag S Side irbag Sensor ear H S Side irbag Sensor ear H VS ND CS+ CS- VUC ESC CS+ CS- VUC ESC 9 uckle S H Seat osition irbag Sensor H 5 CS+ CS- VUC ESC 8 C C 9 C 0 C CS+ CS- VUC ESC 5 C 6 C IC+ 9 IC- 7 C IC- 0 IC+ 8 C SF+ SF- SF+ SF (*) S+ S- E+ E- E 7 E (* *) - (* *) K K (* *) - (* *) (* *) - (* *) - D S8 Side irbag Squib H S9 Side irbag Squib H C8 Curtain Shield irbag Squib H C9 Curtain Shield irbag Squib H - - 6(), 7(), 8(C) irbag Sensor ssembly 9 I 005 HIHNDE (ED59U) 57
4 SS E E J7 Junction Connector E E * : w/ Curtain Shield irbag * : w/o Curtain Shield irbag * 5 : w/ Navigation System * 6 : w/o Navigation System J 6 Junction Connector 5 IO IO S0(), S() Short Connector 6 5 O 8 Occupant Classification Sensor Front H SVC SI SD O0 Occupant Classification Sensor ear H SVC SI SD SI S C FS+ C FS- FS- 8 FS+ 7 I 7 + SVC SI O 6(), O 7() Occupant Classification ECU SD 5 SVC 9 SI SD DI ND S 9 ND 5 SVC SI 8 SD SVC SI 6 0 SD V - O V E SVC SI SD SVC SI SD M - O 9 Occupant Classification Sensor Front H O Occupant Classification Sensor ear H IO C C 7 uckle S (Front assenger s Side) J8 Junction Connector MX MX 6(), 7(), 8(C) irbag Sensor ssembly C 0 C (*) - ON K E I J6 Junction Connector 7 SI D Data ink Connector - F HIHNDE (ED59U)
5 From ower Source System (See age 6) 7. 5 ECU I 5 9 D 0 K 7 F IC 0 S K 6 F 8 I S 5 ower indow Master S with ECU 7V MX MX 8 I I+ T5 Telltale ight ssembly 5 ateway ECU I (*5) MD MD 9(), 0() ody ECU 5 O 0 IF MX E 5 Engine Control Module S 9 I MX 7 E J 9 MX- MX MX MX+ DIM 6 8 DIM ON - S 6 S 7 5- S 0 F (*6) V(*5) F - 0(), () /C Control ssembly irbag On irbag Off HIHNDE (ED59U) 59
6 SS From ower Source System (See age 6) 0 HETE K S 7 C 9 irbag 7V K S C(), C() Combination Meter - I HIHNDE (ED59U)
7 System Outline The SS is a driver and front passenger protection device which has a supplemental role to the seat belts. hen the ignition S is turned to ON, the current from the IN fuse flows to TEMIN () 5 of the airbag sensor assembly. If an accident occurs while driving, when the frontal impact exceeds a set level, the current from the IN fuse flows to TEMINS (), () 6, () 0, () 8, () 8 (w/ curtain shield airbag), or () (w/o curtain shield airbag) and (C) 9 (w/ curtain shield airbag), or (C) 5 (w/o curtain shield airbag) of the airbag sensor assembly to the airbag squibs and the pretensioners to TEMINS (), () 7, (), () 7, () 7 (w/ curtain shield airbag), or () (w/o curtain shield airbag) and (C) 0 (w/ curtain shield airbag), or (C) 6 (w/o curtain shield airbag) of the airbag sensor assembly to TEMIN () 7, () 8 or OD OUND to OUND, so that current flows to the airbag squibs and the pretensioners and causes them to operate. hen the side impact also exceeds a set level, the current from the IN fuse flows to TEMINS (), (C) 5, () 9 and (C) 8 of the airbag sensor assembly to the side airbag squibs and the curtain shield airbag squibs TEMINS (), (C) 6, () 0 and (C) 7 of the airbag sensor assembly to TEMIN () 7, () 8 or OD OUND to OUND, causing side airbag squibs and curtain shield airbag squibs to operate. The airbag stored inside the steering wheel pad is instantaneously expanded to soften the shock to the driver. The airbag stored inside the passenger s instrument panel is instantaneously expanded to soften the shock to the front passenger. Side airbags are instantaneously expanded to soften the shock of side to the driver and front passenger. The curtain shield airbag can ease an impact on the head of the front and rear passengers and reduce risks of injury. In a head-on crash, the driver moves forward and may strike his/her lower limbs against the instrument panel, the key cylinder, etc. The pretensioners make sure of the seat belt restrainability. : TS OCTION Code See age Code See age Code See age 8 (MZ-FE) C8 O0 7 (w/o ower Seat) 8 0 (Z-FE) C9 6 (w/ ower Seat) O 8 (MZ-FE) D 7 (w/o ower Seat) 9 0 (Z-FE) E J6 6 J6 S6 5 7 J7 S7 5 8 C J (w/ ower Seat) 7 7 (w/o ower Seat) 9 6 (w/ ower Seat) C 6 (w/ ower Seat) O6 7 (w/o ower Seat) O7 O8 O9 6 (w/ ower Seat) C O0 6 (w/ ower Seat) 7 (w/o ower Seat) S0 6 (w/ ower Seat) S 7 (w/o ower Seat) S 5 6 (w/ ower Seat) S 5 7 (w/o ower Seat) T5 6 (w/ ower Seat) S8 7 (w/o ower Seat) 6 (w/ ower Seat) S9 7 (w/o ower Seat) 005 HIHNDE (ED59U) 6
8 SS,,,,,, : JUNCTION OCK ND IE HNESS CONNECTO Code See age Junction lock and ire Harness (Connector ocation) D E 9 Cowl ire and Instrument anel J/ (ower Finish anel) K 8 Instrument anel ire and Instrument anel J/ (ower Finish anel) 9 Cowl ire and Instrument anel J/ (ower Finish anel) 7 Engine oom Main ire and Engine oom J/ (Engine Compartment eft) C 0 E F J K E F M Instrument anel ire and Center J/ (ehind the Instrument anel Center) Cowl ire and assenger Side J/ (ight Side of rove ox) : CONNECTO JOININ IE HNESS ND IE HNESS Code See age Joining ire Harness and ire Harness (Connector ocation) I 5 Front Door H ire and Cowl ire (eft Kick anel) IC 5 Engine oom Main ire and Cowl ire (eft Cowl Side anel) IF 5 Instrument anel ire and Cowl ire (ight Side of Instrument anel J/) IK 5 Engine oom Main ire and Cowl ire (ight Cowl Side anel) I I 5 Instrument anel ire and Cowl ire (Upper Side of assenger Side J/) IO 5 Cowl ire and Floor ire (ight Kick anel) K 56 oof No. ire and Floor ire (ight ear Quarter anel) 58 Floor ire and Front Seat H ire (Under the Front assenger s Seat) : OUND OINTS Code See age round oints ocation I 5 eft Cowl Side anel I 5 ight Instrument anel race F 56 Near the ear Side Marker ight H HIHNDE (ED59U)
9 MEMO 005 HIHNDE (ED59U) 6
Before repair, remove the airbag sensor if shocks are likely to be applied to the sensor during repair.
NOTICE: hen inspecting or repairing the SRS, perform service in accordance with the following precautionary instructions and the procedure, and precautions in the Repair Manual applicable for the model
More informationBefore repairs, remove the airbag sensor if shocks are likely to be applied to the sensor during repairs.
NOTICE: When inspecting or repairing the SRS, perform the operation in accordance with the following precautionary instructions and the procedure and precautions in the Repair Manual for the applicable
More informationBefore repairs, remove the airbag sensor if shocks are likely to be applied to the sensor during repairs.
NOTICE: When inspecting or repairing the SRS, perform the operation in accordance with the following precautionary instructions and the procedure and precautions in the Repair Manual for the applicable
More informationBefore repairs, remove the airbag sensor if shocks are likely to be applied to the sensor during repairs.
NOTICE: When inspecting or repairing the SRS, perform the operation in accordance with the following precautionary instructions and the procedure and precautions in the Repair Manual for the applicable
More informationAudio System with 8 Speaker
udio System with 8 Speaker From ower Source System (See age 6) 7. 5 D N. 5 D N. 4(C), (), 3() adio and layer CC C C NT+ 3 C H 3 K 4 C - - 4E 0 IK3 0 3K 9 3I 3 4E 6 I J8 Junction Connector 8 4D 4 I I -
More informationSUPPLEMENTAL RESTRAINT SYSTEM
PRECAUTION CAUTION: HIGHLANDER is equipped with SRS, which consists of a driver airbag, front passenger airbag, side airbag and curtain shield airbag. Failure to carry out service operations in the correct
More informationFOR ALL OF VEHICLES PRECAUTION
IN10 PRECAUTION IN0FA01 1. FOR VEHICLES EQUIPPED WITH SRS AIRBAG AND SEAT BELT PRETENSIONER (a) The CELICA is equipped with an SRS (Supplemental Restraint System), such as the driver airbag, front passenger
More informationSUPPLEMENTAL RESTRAINT SYSTEM
PRECAUTION CAUTION: The COROLLA MATRIX is equipped with SRS, which comprises a driver airbag, front passenger airbag, and side airbag. Failure to carry out service operations in the correct sequence could
More informationEngine Control for 3MZ-FE
Engine Control for MZ-FE - Y M CC IG ST - Y - R(*) 7 M IG 6 R- (*) ST I - R I Ignition S 8 IG8 - Y 7. M IG - - - R - Y - - R- E 9 C 8 C - G 0 IG - - 0 T 0 M /F 0 EFI EFI Relay C/ON Relay /F HTR Relay C
More informationEngine Control for 1MZ-FE and 3MZ-FE
Engine Control for MZ-FE and MZ-FE CC * : MZ- FE * : TMC Made * : TMMK Made * : Shielded M I ST - Y - Y 7 M I - ST I Ignition S 8 - IF - M - Y - E IF 8 C - - Y - 0 I E 9 C - 0 M /F 0 EFI EFI elay C/OPN
More informationFOR ALL OF VEHICLES PRECAUTION
INTRODUCTION PRECAUTION IN9 1. FOR VEHICLES EQUIPPED WITH SRS AIRBAG (a) The 4RUNNER is equipped with an SRS (Supplemental Restraint System), such as the driver airbag, front passenger airbag and seat
More informationAir Conditioning 4RUNNER (EM03M0U) Y R 15A IG1 60A HEATER Y R Y R Y R Y R E E C E E D. Junction Connector Y R W B HEATER Y R. Relay.
ir Conditioning Y (T) (IG) 8 J 60 HETE 5 IG 0 E Y Y Y Y E E C E E D J 3 W 7. 5 HETE NO. 40 G Y IC4 Y 4 Y 5 3 HETE elay 36 IC4 37 IC4 3 C E J D Y 5 3 IC4 IM 43 Y Y IC4 MG CT elay 3 ressure SW 5 Y G IN Y
More informationPOWER WINDOW AND CONVERTIBLE ROOF (CONVERTIBLE)
POE INDO ND CONVETIE OOF (CONVETIE) FO POE SOUCE SYSTE (SEE PE ) DOO 0 UE 0 POE POE EY J IC D D S J0, J C J E P POE INDO STE S 0 I8 INTETION EY 0 S C I J0, J D0 DOO COUTESY S H D DOO COUTESY S H J0 V I
More informationEngine Control (2KD FTV)
Engine Control (KD FTV) (T) (T) 80 O 5 EFI J E MIN elay 4 D J J 4 J 8 J J EDU elay D55 VV (E) 5 5 E TT E IE 0 (), (), D(C), D(D) Engine ECU + ME 8 C O elay 4 D D5 low lug 04 HICE (ED6E) 8 D + DUT E VF
More informationSRS (SUPPLEMENTAL RESTRAINT SYSTEM)
SRS (SUPPEMENT RESTRINT SYSTEM) NOTICE: When inspecting or repairing the SRS (supplemental restraint system), perform the operation in accordance with the following precautionary instructions and the procedure
More informationSUPPLEMENTAL RESTRAINT SYSTEM
PRECAUTION CAUTION: PRIUS is equipped with SRS, which consists of a driver airbag, front passenger airbag, side airbag and curtain shield airbag. Failure to carry out service operations in the correct
More informationREMOTE CONTROL MIRROR
EMOTE CONTOL MIO FOM OWE SOUCE SYSTEM (SEE E 70) MX MX I D DOO 7 E F H C MX J4, J D, D C, D DIVE SIDE J/ ECU D MX I DI I SI 0 IC I D D4, D DIVE DOO ECU M+ D MSW 0 D /E 7 D MIND D ET D T D ND MX M+ M #MH
More informationEngine Control for 2TR FE
Engine Control for T FE From ower Source System (See age 7) 0A EFI A A/F HEATE A IN AM I 6 C I ST I 7 Ignition S E 7 EA 0A AM C 0A EFI N. A EFI elay E A 0 A A 0 A A A/F HEATE elay A C/N elay F Fuel Suction
More informationCruise Control PRIUS (EM01R0U) 20A HEV 10A GAUGE 15A EFI 15A DOME. Relay IGCT W B W B. J 6 Junction Connector 16 5L. EFI M Relay W B W B
ruise ontrol (T) (I) (T) (T) 0 HE 10 UE 15 DME 15 EFI 1 1M 3 IT elay 1 3J 4 3J 3J 3 3J 16 5 7 5D 16 11 1 8 1 5H 5D J 6 EFI M elay 8 3I 6 3I 7 3I 5 3I EE EE 60 IUS (EM010U) 1 : Shielded (T) 10 ETS 3 T Throttle
More informationECT and A/T Indicator for 2TR FE
ET and /T Indicator for T FE (T) (IG) (IG) (T) 0 EFI IGN 0 IG N. 0 ST I : w/ S : w/o S G ( ) ( ) G ( ) ST T elay S0 Stop amp S 0 I I G ( ) G ( ) ( ) ( ) ( ) ( ) EFI elay 8 ME + TT E E0 7 IGS E (), E (),
More informationEngine Control (1MZ-FE)
Engine Control (MZ-FE) - M CC IG ST - 7 M IG 6 ST - I5 Ignition S IF - - 5 M 3 IF6 C E - G - - - 0 IG - - E 4 9 3 4 C 0 T 30 M 5 /F 0 EFI 5 3 EFI elay C/OPN elay 5 3 /F HT elay 5 3 5 C 6 K 4 D 6 C 7 C
More informationECT and A/T Indicator for 1GR FE
CT and /T Indicator for G F (T) (IG) (IG) (T) 0 FI 5 IGN 0 IG N. 0 ST 5 I C : w/ SC : w/o SC G 5 3 C 5 DD 3 D 0 I I 3 DC DC ST CT elay S0 Stop amp S G G ( ) G FI elay 5 3 30 3 H H 9 33 M + 3 TT + 9 IGS
More informationEngine Control for 2TR FE
Engine Control for T FE (AT) (AT) (I) 0A EFI A A/F HEATE A IN AM I 6 C I ST I 7 Ignition S 7 EA 0A AM C 0A EFI N. A EFI elay A 0 A A 0 A A A/F HEATE elay 4 A C/N elay F Fuel Suction ump and age Assembly
More informationCruise Control for 1GR FE
Cruise Control for G F (AT) 0A FI 0A IG 0A IG N. J H 4 C : w/ VSC : w/o VSC G G ark/neutral osition S IH Y 7 C4 Cruise Control Clutch S G 4 C C C G 40 IA 5 C 0 IA IA FI elay 5 8 M + ATT + S C 5 8 A VTA
More informationSmart Access System with Push Button Start
Smart Access System with ush utton Start 80A E/ M 80A EFI 80A D J/ AT 60A J/ AT H J F 5 C E DF 5 DA DA 5 A 0 K 5 I elay 5 I elay D ACC elay D I elay AISUS elay I elay 9 C 8 C 0 DA 9 DA 9 A 8 A 9 A6() A8
More informationCruise Control for 2TR FE
Cruise Control for T FE (AT) 9 J 0A EFI 0A IG 0A IG N. H C : w/ VSC : w/o VSC G G ark/neutral osition SW IH Y C Cruise Control Clutch SW G C C C G 0 IA IA 5 8 ME + ATT E0 E0 ME0 E 8 A ST VTA VC 0 A 8 A
More informationTheft Deterrent and Door Lock Control
Theft Deterrent and Door ock Control From Power Source System (See Page 0) 0 HORN (), 7(), (C) ody CU HORN SGND 4 GND CY DCTY PCTY C C RCTY 0 HORN Relay 5 G R J Junction Connector F 7 K S G D G R G IC
More informationENGINE CONTROL (1ZZ-FE)
ENGINE ONTO (ZZ-FE) - - - 5 M IG 6 - O 4 IK 6 I - O - - 9 IK I I0 IGNITION S ST 4 IE - - - 6 F 4 H 0 F 4 F 4 3 4 5 6 8 F 9 F 5 7. 5 M 40 MIN ST EY 7. 5 ST 0 EFI NO. 0 EFI NO. 3 3 H 5 /ON EY 3-3 I IE4 4
More informationABS 2002 RAV4 (EWD466U) FROM POWER SOURCE SYSTEM (SEE PAGE 46) 40A ABS 1 10A GAUGE 10A ECU IG 30A ABS 2 10A STOP J 5 JUNCTION CONNECTOR R L R W R W
AS FOM POE SOUCE SYSTEM (SEE PAE 46) 0A AUE 30A AS 40A AS 0A ECU I 0A STOP 9 J 5 E 4 E E 8 J () 3 H 5 (P) ID 46 6 () J 5 (S) Y S 8 STOP LIHT S 6 H E 8 ID (P) 3 5 0 +S +M I STP A 4 AS ACTUATO AND ECU PK
More informationSRS AIRBAG PRECAUTION
SRS AIRBAG PRECAUTION SRS AIRBAG The LEXUS ES300 is equipped with SRS, which comprises a driver airbag and a front passenger airbag. Failure to carry out service operations in the correct sequence could
More informationABS, TRAC, VSC, Auto LSD, DAC and HAC
BS, TC, VSC, uto SD, and HC (BT) (BT) (IG) 0 BS N. 50 BS N. 5 IGN F F 7 C C C 8 4 7 S (), S (C) Skid Control ECU with ctuator 0 NE + + 0 6 5 9 4 4 C B GND GND GND (4D) G B B S 4 Speed Sensor (Front H)
More informationSRS AIRBAG Toyota RAV4. Supplemental Restraint System - RAV4 PRECAUTION CAUTION:
2005 RESTRAINTS Supplemental Restraint System - RAV4 SRS AIRBAG PRECAUTION CAUTION: The TOYOTA RAV4 is equipped with SRS that includes a driver airbag, front passenger airbag, side airbag and curtain shield
More informationInterior Light RUNNER (EWD552U) From Power Source System (See Page 58) Body ECU 7. 5A ACC ACC 22 GND1 4 ILE GND A W- B W- B W W B 3
Interior Light From Power Source System (See Page 58) 4(), 5(), 6(C) ody ECU 7. 5 CC CC GND 6 GND 4 3 ILE H 7 8 8 3 3 E (*) (*) I0 Interior Light 3 ON OFF DOO L Luggage Compartment Light 3 ON OFF DOO P
More informationENGINE CONTROL (3RZ-FE)
ENGINE CONTO (3Z-FE) - - 7 IF - 7 AM IG 3 I FOM POE SOUCE SYSTEM (SEE PAGE 4) AM ACC IG 7. A STA 7. A IGN 0A EFI 7. A OD 0A STOP ST 30A AM P PAK/NEUTA POSITION S 40A AM 0A AT I4 IGNITION S P N 8 IK 8 -
More informationECT and A/T Indicator for 1GR FE
T and /T Indicator for F (T) (T) ata ink 3 0 FI TS N N T 6 3 35 I I 3 I ST lug F J50(), J5(), J5(F) 3 3 J9(), J30() J8 5 3 FI elay 8 3 7 33 3 3 M TT +M N N T (), 5(), 6(), 7(), 8() ngine ontrol Module
More informationWireless Door Lock Control
ireless Door Lock Control From Power Source System (See Page 8) (), (), 6(C) ody ECU 0 J/ 0 D/LCK 7. CC CC D TLY 8 HLY 7 HZ 8 L- G- TIL elay 9 E C 8 J G- L- HED elay 0 HZ 8 EH D Turn Signal Flasher elay
More informationFOREWORD. Applicable models: NHW20 Series PRIUS Repair Manual Volume 1 Volume 2 Volume PRIUS New Car Features
FED This wiring diagram manual has been prepared to provide information on the electrical system of the 004 IUS. pplicable models: NH0 Series For service specifications and repair procedures of the above
More informationHeadlight TOYOTA TACOMA (EWD614U) W W. From Power Source System (See Page 72) R- B R- B 10A IG1 NO. 2 20A DR LCK. 7. 5A ECU- B DIM Relay 1 2C
Headlight From ower Source System (See age 7) 0A IG NO. 0A D LCK 7. 5A ECU- B DIM elay 3 5 HEAD elay 3 5 C 9 IA A HLY 6 C 5 6 IG ALTB ECUB 30 Y- B Y- B IA 5 A DIM B 5(A) Body ECU B HEAD HF HU GND KB L
More informationDoor Lock Control RUNNER (EWD615U) From Power Source System (See Page 62) Body ECU 7. 5A GAUGE 20A DR/LCK 7. 5A ACC 10A DOME 15A IG1 DRLP
Door ock ontrol From Power Source System (See Page 6) (), 5(), 6() ody EU 5 IG 0 DOME 7. 5 GUGE 0 D/K 7. 5 D DP DY SPD 8 J Y- J 7 I G - G- W 9 E V- Y W- V- G SP G- 7 I S8 Skid ontrol EU with ctuator Y-
More informationENGINE CONTROL RUNNER (EWD425U) B- R II4 G- B GR- B B- R B- R FROM POWER SOURCE SYSTEM (SEE PAGE 48) 4 1I W- L G- B 10A IGN 10A STOP 20A EFI BZ1
ENINE CONTRO R- I 7 J FROM POER SOURCE SYSTEM (SEE PE 8) 7 M I 6 ST 8 - R I INITION S STRTER REY 0 F - 0 IN EFI REY R- - R 0 EFI - R F 0 STOP 7 I S STOP IHT S - Y - R Z N IE - - R - R - - I I D D D 0 M
More informationENGINE CONTROL (2RZ FE)
ENINE CONTRO (RZ FE) 7 IF Y R(A/T) 7 AM I 6 I FROM POER SOURCE SYSTEM (SEE PAE ) AM ACC I 7. A STA 7. A IN 0A EFI 7. A OD 0A STOP ST I INITION S 6 0 Y R E E Y R(A/T) O O I Y Y Y O Y Y 0A AM P PARK/NEUTRA
More informationENGINE CONTROL (3RZ FE)
ENINE CONTRO (3RZ FE) 7 IF Y R 7 AM I 6 3 I FROM POER SOURCE SYSTEM (SEE PAE 4) AM ACC I 7. A STA 7. A IN 0A EFI 7. A OD 0A STOP ST 30A AM ATTERY P PARK/NEUTRA POSITION S 40A AM 0A AT I4 INITION S P N
More informationEngine Control COROLLA (EWD533U) B O B W B W I 7 I10. Ignition SW R W R W (A/T) (M/T) E 3 15A AM2. Junction Connector. Clutch Start SW B W B W
Engine Control O 5 M IG 6 ST 4 I 7 I0 Ignition S 5 M 6 3 IM IM I4 I IC 5 IL 8 IK 5 E 3 3 E 0 E O 3 I II 0 I5 P N 6 E 9 30 MIN 5 EFI 3 5 3 4 IG 9 ID IG II G G FL MIN. 0L 9 E 9 II 4 M 5 G (/T) G C 8 Clutch
More informationSUPPLEMENTAL RESTRAINT SYSTEM (SRS)
RESTRAINTS SECTION SRS A SUPPLEMENTAL RESTRAINT SYSTEM (SRS) B C D CONTENTS E PRECAUTION... 2 PRECAUTIONS... 2 Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TEN- SIONER"...2
More informationBuckle SW Rear RH C 1 Camshaft Position Sensor Camshaft Timing Oil Control Valve RH. Crankshaft Position Sensor
A 1 A/C Ambient Temp. Sensor 90980 11070 A 2 A/C Magnetic Clutch and ock Sensor 90980 11016 A 3 A/C Pressure Sensor 90980 10845 A 4 A/C Solenoid 90980 10901 A 5 ABS & TRAC & VSC Actuator 90980 11451 A
More informationELECTRONICALLY CONTROLLED TRANSMISSION
ELECTRONICALLY CONTROLLE TRANSMISSION FROM OWER SOURCE SYSTEM (SEE AE 6) 7. A IN 0A EFI A STO 7. A STA F FUSE OX F W 3 7 IF Y EFI RELAY Y Y IF Y 0 IF Y Y W 3C 3C A (*) (*) A (*) (*) S A, STO LIHT SW R
More informationCIRCUIT INSPECTION. DTC B0100/13 Short in D Squib Circuit CIRCUIT DESCRIPTION WIRING DIAGRAM
DI248 CIRCUIT INSPECTION DI6P303 DTC B0100/13 Short in Circuit CIRCUIT DESCRIPTION The D squib circuit consists of the airbag sensor assembly, spiral cable and steering wheel pad. It causes the airbag
More informationAUTOMATIC AIR CONDITIONING
UTOMTIC I CONDITIONING FOM POE SOUCE SSTEM (SEE PGE ) F 9 FUSIBLE LINK BLOCK 0 HETE 9 HETE 7. GUGE 7. DIO NO. 8 G K 0 K K L B B G H D C D E C L B H 8 HETE EL L L IG +B IG L O B, B 7 C, B 8 D BOD ECU B,
More informationSUPPLEMENTAL RESTRAINT SYSTEM AIRBAG SYSTEM SYSTEM DIAGRAM. Front Airbag Sensor LH Steering Pad (Driver Side Squib)
16 SUPPLEMENTAL RESTRAINT SYSTEM AIRBAG SYSTEM SYSTEM DIAGRAM Front Airbag Sensor LH Steering Pad (Driver Side Squib) Front Airbag Sensor RH Front Passenger Airbag Assembly (Front Passenger Side Squib)
More informationENGINE CONTROL MR2 (EWD498U) R W R W R W B 7 IC1 I10 IGNITION SW R W W R W R 40A MAIN ST 5 AM2 C/OPN RELAY 7. 5A RELAY B Y B Y B L B R G R B Y
ENGINE CONTRO 5 M IG 6 R IC R 7 R 0 R R IC I0 IGNITION S ST 4 R 7 IC R R 5 5 5 M 40 MIN ST REY 7. 5 ST C/OPN REY 3 3 R F FUE PUMP R 4 5 Y (*) Y (*) 0 I3 Y (*) F MIN. 0 C 9 CUTCH STRT S M TTERY (*) I K
More informationSRS AIRBAG CONTROL SYSTEM
RESTRAINTS SECTION SRC A SRS AIRBAG CONTROL SYSTEM B C D CONTENTS E BASIC INSPECTION... 3 DIAGNOSIS AND REPAIR WORK FLOW... 3 Work Flow...3 INTERMITTENT INCIDENT... 5 Inspection Procedure...5 Trouble Diagnosis
More informationFOREWORD. Applicable models: NHW20 Series PRIUS Repair Manual 2006 PRIUS New Car Features
FED This wiring diagram manual has been prepared to provide information on the electrical system of the 006 IUS. pplicable models: NH0 Series efer to the following manuals for additional service specifications
More information- 1 - Electronically Controlled Transmission and A/T Indicator, Engine Control A40 Q14 (BAT) 20A INJ 25A EFI 25A F/PMP B R B R.
Electronically ontrolled Transmission and /T Indicator, Engine ontrol (T) (T) (T) EFI F/M 0 INJ 8 EFI MIN elay EFI NO. elay /ON elay INJ elay 7 8 7 9 ump M Q Fuel Sender age ssembly Q F/M elay 0 Fuel ump
More informationCIRCUIT INSPECTION. DTC B0100/13 Short in D Squib Circuit CIRCUIT DESCRIPTION WIRING DIAGRAM
DI254 CIRCUIT INSPECTION DI18Q37 DTC B0100/13 Short in Circuit CIRCUIT DESCRIPTION The D squib circuit consists of the airbag sensor assembly, spiral cable and steering wheel pad. It causes the airbag
More informationCIRCUIT INSPECTION. DTC B0100/13 Short in D Squib Circuit CIRCUIT DESCRIPTION WIRING DIAGRAM
DI388 CIRCUIT INSPECTION DI18Q35 DTC B0100/13 Short in Circuit CIRCUIT DESCRIPTION The D squib circuit consists of the airbag sensor assembly, spiral cable and steering wheel pad. It causes the airbag
More informationFOREWORD. This wiring diagram manual has been prepared to provide information on the electrical system of the 2001 TOYOTA TACOMA.
FOEOD This wiring diagram manual has been prepared to provide information on the electrical system of the 00 TOYOT TCOM. pplicable models: VZN0,70,9 Series ZN0,0,6, ZN7,9,96 Series For service specifications
More informationENGINE CONTROL (5VZ-FE 2WD M/T)
ENINE CONTRO (Z-FE WD M/T) 7 IF 7 AM I 6 FROM POWER SOURCE SYSTEM (SEE PAE 4) AM ACC I 0A EFI 7. A OD 7. A IN ST W 30A AM W ATTERY 40A AM 0A AT I4 INITION SW - Y- R Y 0 C 9 CUTCH START SW 3 6 8 I F 7.
More informationSRS AIRBAG SECTION SR CONTENTS RESTRAINTS SR-1 PRECAUTION... 2 PREPARATION... 4 REMOVAL AND INSTALLATION... 5
RESTRAINTS SECTION SR A SRS AIRBAG B C D CONTENTS E PRECAUTION... 2 PRECAUTIONS... 2 Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TEN- SIONER"...2 Precaution Necessary
More informationENGINE CONTROL AND ENGINE IMMOBILISER SYSTEM
ENINE CONTRO ND ENINE IMMOIISER SSTEM FROM POER SOURCE SSTEM (SEE PE 0) 7 M I 6 ST 8 O /F HTR O R C 6 C I INITION S C 6 7. IN 6 R IH /F HETER RE CIRCUIT OPENIN RE 8 I 0 M E I M R O F6 FUE PUMP F 9 FUSIE
More informationELECTRONICALLY MODULATED AIR SUSPENSION
ELECTRONICLLY MODULTED IR SUSENSION FROM OWER SOURCE SYSTEM (SEE E 56) 40 H/CTRL 0 ECU I 8 F W E 6 6 IR SUS RELY 4 IJ L R L 4 6 6 H0 HEIHT CONTROL EXHUST LE R 0 IM 9 IM 5 IJ IJ L L R H 9 HEIHT CONTROL
More informationWireless Door Lock Control
Wireless Door ock Control (BAT) (IG) (BAT) 0A HORN 0A IG NO. 0A DR CK W G W G HORN Relay 3 HORN IG ATB KSW GND SWD U3 ACTD B (A) Body ECU 0 A 3 A 3 A 9G B G R GR 0 C 0 K 8 H E W R G B W R G B G R 0 IC3
More informationENGINE CONTROL 2001 AVALON (EWD431U) L- O B- W B- W B- W B- W I15 IGNITION SW W- R B- W B- W B- O B- O I 7 B- O IF1 B- W W- R B- O B- O B- R L- O
ENINE ONTRO - O 7 M I 6 ST 8 - R I5 INITION S IF I 7 - R - O 7 9 6 F J 7 0 M 5 EFI NO. 7. 5 EFI NO. 5 /F 5 I 5 5 5 EFI REY /F REY I REY 0 F F 6, F 7 FUSIE INK OK 8 II IF - F MIN. 0 TTERY ED 8 00 VON (EDU)
More informationWIRELESS DOOR LOCK CONTROL
WIELESS DOO CONTOL FO POWE SOUCE SYSTE (SEE PGE 8) 5 CC G G 6, 7 ODY ECU 9 CC DCTY PCTY CTY KSW UL L UL L UL 9 6 5 0 H 9 H D8 DOO COUTESY SW E LH - D9 DOO COUTESY SW E H - W D6 DOO COUTESY SW FONT LH D7
More informationREPAIR INSTRUCTION PRECAUTION. 1. BASIC REPAIR HINT (a) HINTS ON OPERATIONS
015 PRECAUTION 1. BASIC REPAIR HINT (a) HINTS ON OPERATIONS 010DR01 2 1 3 6 5 4 D25016 1 Looks Always wear a clean uniform. Hat and safety shoes must be worn. 2 Vehicle protection Set a grill cover, fender
More informationSRS AIRBAG SECTION SR CONTENTS RESTRAINTS SR-1 PRECAUTION... 2 PREPARATION... 4 ON-VEHICLE REPAIR... 5
RSTRTS ST S R TTS RUT... 2 RUTS... 2 recaution for Supplemental Restraint System (S) "R " and "ST T R-T- SR"...2 Service...2 ccupant lassification System...2 recautions ecessary for Steering Wheel Rotation
More informationHEADLIGHT (USA, PUERTO RICO)
HEDLIGHT (US, PUETO ICO) W FOM POWE SOUCE SYSTEM (SEE PGE 8) I F FUSILE LINK LOCK 00 LT W C C, C D COMINTION METE I INTEGTION ELY EM C 8 KE 9 9 C C 6 C - L - L D 0 GUGE 6 - G - L - L TIL ELY 6 LG LG LG
More information2006 xa ELECTRICAL WIRING DIAGRAM
00 x EECTRIC WIRIN DIRM INTRODUCTION HOW TO USE THIS MNU TROUESHOOTIN Section Code Page........................................................................ C.... REVITIONS.........................
More informationDESCRIPTION & OPERATION
AIR BAG RESTRAINT SYSTEM 1996 ACCESSORIES/SAFETY EQUIPMENT Toyota Air Bag Restraint System DESCRIPTION & OPERATION WARNING: To avoid injury from accidental air bag deployment, read and carefully follow
More informationELECTRONICALLY CONTROLLED TRANSMISSION (5VZ FE)
EETNIAY NTED TANSMISSIN (5VZ FE) FM WE SUE SYSTEM (SEE AE 54) 0A EFI 0A ST 7. 5A IN 7. 5A STA Y 5 3 W 7 IF W 3E 3E EFI EAY 3 IF Y 5 Y Y IF S 5 ST IHT SW Y W 7 6 W F 3F 3F F W W Y 0 3E 3E Y N 9 Y 8 IK3
More informationSUPPLEMENTAL RESTRAINT SYSTEM (SRS)
H RESTRAINTS A SECTION SUPPLEMENTAL RESTRAINT SYSTEM (SRS) B C D CONTENTS E PRECAUTIONS... 3 Precautions for Supplemental Restraint System (SRS) AIR BAG and SEAT BELT PRE-TEN- SIONER... 3 Precautions for
More informationDTC B0103/12 Short in D and P Squib Circuit (to B+)
DI404 DIAGNOSTICS DI58L02 DTC B0103/12 Short in D and P Squib Circuit (to B+) CIRCUIT DESCRIPTI The D and P squib circuits consist of the airbag sensor assembly, spiral cable, steering wheel pad and front
More informationCruise Control <2AR-FE>, ECT and A/T Indicator <2AR-FE>, Engine Control <2AR-FE> ECM 7. 5A ECU IG2 NO A EFI NO. 1 10A ETCS ( 2) ( 2) R
Cruise Control , ECT and A/T Indicator , Engine Control (AT) (I) (AT) (AT) A5(A), E6() 7. 5A STO 7. 5A ECU I NO. 0A ETCS 7. 5A EFI NO. ATT +M IS ST ST A 9 7 A A A 0 D C C E EA ( ) (
More informationFOR ALL OF VEHICLES PRECAUTION
IN10 INTRODUCTION FOR ALL OF VEHICLES FOR ALL OF VEHICLES PRECAUTION IN0JF01 1. FOR VEHICLES EQUIPPED WITH SRS AIRBAG AND SEAT BELT PRETENSIONER (a) The LAND CRUISER is equipped with an SRS (Supplemental
More informationEngine Control for 5VZ-FE (Access/Standard Cab)
ngine ontrol for 5VZ-F (ccess/standard ab) - - 7 M IG 6 FOM O SOU SSTM (S G 9) (/T) ST - I IGNITION S 0 M TT K/NUTL OSITION S N (/T) (/T) 9 6 J8 - (/T) F H - (/T), J9 J, J J8, J9 FI L J8 - - - 5 - - 5
More informationGROUP 52B CONTENTS. Battery posts, terminals and related accessories contain lead and lead compounds. WASH HANDS AFTER HANDLING.
52B-1 GROUP 52B CONTENTS GENERAL DESCRIPTION......... 52B-3 SERVICE PRECAUTIONS......... 52B-17........ 52B-20 INTRODUCTION..................... 52B-20 TROUBLESHOOTING STRATEGY...... 52B-20 TROUBLE CODE
More informationSUPPLEMENTAL RESTRAINT SYSTEM (SRS)
52B-1 SUPPLEMENTAL RESTRAINT SYSTEM (SRS) CONTENTS GENERAL INFORMATION................ 2 SRS SERVICE PRECAUTIONS........... 3 SPECIAL TOOLS........................ 5 TEST EQUIPMENT......................
More informationDiag. Code 22 Airbag Warning Light System Malfunction CIRCUIT DESCRIPTION ABT 71
SRS AIRBAG ABT71 Diag. Code 22 Airbag Warning Light System Malfunction CIRCUIT DESCRIPTION The airbag warning light is located on the combination meter. When the airbag system is normal, the airbag warning
More informationSUPPLEMENTAL RESTRAINT SYSTEM (SRS)
H RESTRAINTS A SECTION SUPPLEMENTAL RESTRAINT SYSTEM (SRS) B C D CONTENTS E PRECAUTIONS... 3 Precautions for Supplemental Restraint System (SRS) AIR BAG and SEAT BELT PRE-TEN- SIONER... 3 Precautions for
More informationENGINE CONTROL (2RZ FE)
ENGINE CONTROL (RZ FE) IF (A/T) AM IG 6 FROM POER SOURCE SYSTEM (SEE PAGE 44) AM ACC IG ST IF. A STA F FUSE O. A IGN A EFI 0A OD A STOP I4 IGNITION S (A/T) (A/T) F 0 (M/T) Y Y V (A/T) IK3 (A/T) (M/T) 3
More informationSUPPLEMENTAL RESTRAINT SYSTEM (SRS)
H RESTRAINTS A SECTION SUPPLEMENTAL RESTRAINT SYSTEM (SRS) B C D CONTENTS E PRECAUTIONS... 3 Precautions for Supplemental Restraint System (SRS) AIR BAG and SEAT BELT PRE-TEN- SIONER... 3 Precautions for
More informationSUPPLEMENTAL RESTRAINT SYSTEM (SRS)
52B-1 GROUP 52B SUPPLEMENTAL RESTRAINT SYSTEM (SRS) CONTENTS GENERAL DESCRIPTION 52B-3 SERVICE PRECAUTIONS 52B-29 52B-33 INTRODUCTION TO DIAGNOSIS 52B-33 TROUBLESHOOTING STRATEGY 52B-33 DIAGNOSTIC FUNCTION
More informationThis manual provides information on the electrical circuits installed on vehicles by dividing them into a circuit for each system.
HO TO USE THIS MNUL This manual provides information on the electrical circuits installed on vehicles by dividing them into a circuit for each system. The actual wiring of each system circuit is shown
More informationSUPPLEMENTAL RESTRAINT SYSTEM(SRS)
52B-1 GROUP 52B SUPPLEMENTAL RESTRAINT SYSTEM(SRS) CONTENTS GENERAL INFORMATION........ 52B-3 SERVICE PRECAUTIONS......... 52B-15 SRS AIR BAG DIAGNOSIS........ 52B-17 INTRODUCTION.....................
More informationSUPPLEMENTAL RESTRAINT SYSTEM (SRS)
52B-1 GROUP 52B SUPPLEMENTAL RESTRAINT SYSTEM (SRS) CONTENTS GENERAL DESCRIPTION......... 52B-3 SERVICE PRECAUTIONS......... 52B-15 SRS AIR BAG DIAGNOSIS........ 52B-17 INTRODUCTION.....................
More informationFOREWORD. Applicable models: ZZE130 Series COROLLA Repair Manual Volume 1 Volume COROLLA New Car Features Supplement
FOEOD This wiring diagram manual has been prepared to provide information on the electrical system of the 00 COOLL. pplicable models: ZZE0 Series For service specifications and repair procedures of the
More informationSRS AIRBAG CONTROL SYSTEM
RESTRAINTS SECTION SRC A SRS AIRBAG CONTROL SYSTEM B C D CONTENTS E PRECAUTION... 4 PRECAUTIONS... 4 Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TEN- SIONER"...4 Precaution
More informationTaillight and Illumination
Taillight and Illumination L W C 5 L 3 F 5 TIL Relay 0 TIL 3 L W 8 TRLY 9 TIL IL 8 C (), 6(C) 8 ody ECU 50 J/ 8 IH (UZ FE) 0 LT Light Control SW 6 OFF Tail Head C Combination SW F 3 Front Parking Light
More informationWireless Door Lock Control
Wireless Door ock Control From Power Source System (See Page 60) 7. A DOM A DOOR 0A CU B B 6(A), B 7(B), B (C) Body CU B BDR DCTY C PCTY A RCTY 0 M B 70 R W 3A 0 3A 4 G J3 Junction Connector FR G R G F
More informationREPAIR INSTRUCTION PRECAUTION. (b) HINTS ON OPERATIONS 01-5
PRECAUTION (b) HINTS ON OPERATIONS 015 010QJ02 2 1 3 6 5 4 D25016 1 Looks Always wear a clean uniform. Hat and safety shoes must be worn. 2 Vehicle protection Prepare a grille cover, fender cover, seat
More informationCRUISE CONTROL SYSTEM
Negative (-) Battery Terminal CRUISE CONTROL CRUISE CONTROL SYSTEM Cable System name METER / GAUGE SYSTEM D033496E01 CRUISE CONTROL SYSTEM PRECAUTION 1 1. DISCONNECT AND RECONNECT CABLE OF NEGATIVE BATTERY
More informationSUPPLEMENTAL RESTRAINT SYSTEM (SRS)
GROUP 52B SUPPLEMENTAL RESTRAINT SYSTEM (SRS) CONTENTS GENERAL INFORMATION........ 52B-3 SERVICE PRES......... 52B-5 SPECIAL TOOLS................ 52B-8 TEST EQUIPMENTS............. 52B-9............ 52B-10
More informationTrouble in Passenger Airbag ON / OFF Indicator
8 SUPPLEMENTAL RESTRAINT SYSTEM OCCUPANT CLASSIFICATION SYSTEM Trouble in Passenger Airbag ON / OFF Indicator DESCRIPTION The occupant classification system detects the front passenger seat condition and
More informationSUPPLEMENTAL RESTRAINT SYSTEM AIRBAG SYSTEM
262 SUPPLEMENTL RESTRINT SYSTEM IRBG SYSTEM DTC B1825/56 DTC B1826/56 DTC B1827/56 DTC B1828/56 Short in Circuit Open in Circuit Short to GND in Front Passenger Side - Side Squib Circuit Short to B+ in
More information- 1 - Air Conditioner (BAT) 50A HTR 10A ECU B3 10A A/C 1 B 28 2C. Steering Pad Switch Assembly. Temperature. Junction Connector AL5.
(T) (I) (T) 0 HT 0 /C 0 ECU z() Steering ad Switch ssembly C Touch Sensor Micro Computer Temperature Temperature+ 7(), () D 0 ir Inlet I+ EU 0 C lower with Fan Motor Sub ssembly + ND 7 IN (), z() Spiral
More informationSUPPLEMENTAL RESTRAINT SYSTEM (SRS)
52B-1 GROUP 52B SUPPLEMENTAL RESTRAINT SYSTEM (SRS) CONTENTS GENERAL DESCRIPTION 52B-3 SERVICE PRECAUTIONS 52B-16 52B-18 INTRODUCTION TO DIAGNOSIS 52B-18 TROUBLESHOOTING STRATEGY 52B-19 DIAGNOSTIC FUNCTION
More informationRESTRAINT SYSTEM SECTIONRS CONTENTS
RESTRAINT SYSTEM SECTIONRS CONTENTS SEAT BELTS...2 Precautions...2 Front Seat Belt...4 SUPPLEMENTAL RESTRAINT SYSTEM (SRS)...6 Precautions...6 Preparation...7 SRS Configuration...8 Seat Belt Pre-tensioner
More informationDTC B1650/32 Occupant Classification System Malfunction
SUPPLMNTL RSTRINT SYSTM IRG SYSTM 125 DTC 1650/32 System Malfunction DSCRIPTION The occupant classification system circuit consists of the center airbag sensor assembly and the occupant classification
More informationENGINE CONTROL (2RZ-FE) SYSTEM OUTLINE
ENGINE CONTRO (RZ-FE) SYSTEM OUTINE THE ENGINE CONTRO SYSTEM UTIIZES A MICROCOMPUTER AND MAINTAINS OVERA CONTRO OF THE ENGINE, TRANSMISSION, ETC. AN OUTINE OF ENGINE CONTRO IS GIVEN HERE.. INPUT SIGNA
More informationSUPPLEMENTAL RESTRAINTS SYSTEM
SECTION 8B SUPPLEMENTAL RESTRAINTS SYSTEM CAUTION: Disconnect the negative battery cable before removing or installing any electrical unit or when a tool or equipment could easily come in contact with
More informationTECHNICAL INSTRUCTIONS FOR SAFETY RECALL E0G SUB HARNESS (FILTER) INSTALLATION
TECHNICAL INSTRUCTIONS FOR SAFETY RECALL E0G SUB HARNESS (FILTER) INSTALLATION 2003 2004 MODEL YEAR AVALON COLUMN MOUNTED SHIFT LEVER (FRONT BENCH SEAT) All dealership associates involved in the recall
More information