STARTER CIRCUIT TROUBLESHOOTING
|
|
- Meryl Merritt
- 5 years ago
- Views:
Transcription
1 2000 Honda Accord EX Sedan V6-3.0L Vehicle > Starting and Charging > Starting System > Starter Motor > Testing and Inspection > Component Tests and General Diagnostics STARTER CIRCUIT TROUBLESHOOTING Starter Circuit Troubleshooting NOTE: - Air temperature must be between 59 1 and 100 F (15 and 38 C) during this procedure. - After this test, or any subsequent repair, reset the Powertrain Control Module (PCM) to clear any Diagnostic Trouble Code (DTC). - The battery must be in good condition and fully charged. Recommended Procedure: - Use a starter system tester. - Connect and operate the equipment in accordance with the manufacturer's instructions. Alternate Procedure 1/5
2 1. Hook up the following equipment: - Ammeter, A - Voltmeter, 0-20 V (accurate within 0.1 volt) - Tachometer, rpm 2. Remove the No.46 (15 A) fuse from the under-dash fuse/relay box. 3. With the shift lever in [N] or [P], turn the ignition switch to start (III). Did the starter crank the engine normally? YES - The starting system is OK. NO - If the starter will not crank the engine at all, go to step 4. If it cranks the engine erratically or too slowly, go to step 7. If it won't disengage from the torque converter ring gear when you release the key, check for the following until you find the cause. - Solenoid plunger and switch malfunction - Dirty drive gear or damaged overrunning clutch. 4. Check the battery condition. Check electrical connections at the battery, the negative battery cable to body, engine ground cables, and the starter for looseness and corrosion. Then try starting the engine again. Did the starter crank the engine? YES - The starting system is OK. NO - Go to step /5
3 5. Make sure the transmission is in neutral, then disconnect the BLK/WHT wire (A) from the starter solenoid (B). Connect a jumper wire from the battery positive terminal to the solenoid terminal. Did the starter crank the engine? YES - Go to step 6. NO - Remove the starter and repair or replace as necessary. 6. Check the following items in the order listed until you find the open circuit. - Check the BLK/WHT wire and connectors between the driver's under-dash fuse/relay box and the ignition switch, and between the driver's under-dash fuse/relay box and the starter. - Check the ignition switch. - Check the transmission range switch and connector. - Substitute a known-good starter relay. 7. Check the engine speed while cranking the engine. Is the engine speed above 100 rpm? 3/5
4 YES - Go to step 8. NO - Replace the starter, or remove and disassemble the starter, and check for the following until you find the cause. - Excessively worn starter brushes - Open circuit in commutator brushes - Dirty or damaged helical spline or drive gear - Faulty drive gear clutch 8. Check the cranking voltage and current draw. Is cranking voltage no less than 8.5 volts, and current draw no more than 380 amps? YES - Go to step 9. NO - Replace the starter, or remove and disassemble the starter, and check for the following until you find the cause. - Open circuit in starter armature commutator segments - Starter armature dragging - Shorted armature winding - Excessive drag in engine 9. Remove the starter and inspect its drive gear and the torque converter ring gear for damage. Replace any damaged parts. 4/5
5 5/5
1 of 16 1/10/2015 7:25 AM STARTER MOTOR 2009 Hyundai Accent 1.6L Eng GS REQUESTED INFORMATION DISASSEMBLY 1. Disconnect the M-terminal (A) on the magnet switch assembly (B). Fig 1: Identifying M-Terminal
STARTING SYSTEMS 8B - 1 STARTING SYSTEMS CONTENTS
TJ STARTING SYSTEMS 8B - 1 STARTING SYSTEMS CONTENTS page DESCRIPTION AND OPERATION STARTER MOTOR... 2 STARTER RELAY... 3 STARTING SYSTEM... 1 DIAGNOSIS AND TESTING STARTER MOTOR... 8 STARTER MOTOR NOISE
1993 ELECTRICAL Volkswagen Starters - Bosch. Volkswagen; Cabriolet, EuroVan, Golf, GTI, Jetta
Article Text ARTICLE BEGINNING 1993 ELECTRICAL Volkswagen Starters - Bosch Volkswagen; Cabriolet, EuroVan, Golf, GTI, Jetta DESCRIPTION Starter is a brush type, series-wound electric motor with an overrunning
1991 Mazda MX-5 Miata. STARTER - DIRECT DRIVE ELECTRICAL Mazda Starters - Direct Drive ELECTRICAL Mazda Starters - Direct Drive
DESCRIPTION STARTER - DIRECT DRIVE 1990-92 ELECTRICAL Mazda Starters - Direct Drive Nippondenso direct drive starter is a conventional 12-volt, 4-pole, brush-type starter. The integral solenoid is attached
Battery Operation. Battery Construction. Battery State Of Charge. Battery Load Test. Battery Rating Systems 2/14/12
Battery Operation Batteries, Charging and Donald Jones Brookhaven College Batteries convert chemical energy into electrical energy During discharge the battery s plate composition is changed During charging
./#0#. 1"&." 1994 ELECTRICAL Suzuki of America Corp. - Starters. Swift
!"" #$%!& '()!)((*(+,*)- 1994 ELECTRICAL Suzuki of America Corp. - Starters Swift Two types of starter motors are used, conventional and reduction gear. Both types of starters consist of yoke assembly,
2001 Cougar Workshop Manual
Page 1 of 7 SECTION 303-06: Starting System 2001 Cougar Workshop Manual DIAGNOSIS AND TESTING Procedure revision date: 09/14/2001 Starting System Refer to Wiring Diagrams Section 303-06 for schematic and
DESCRIPTION & OPERATION
STARTER - REDUCTION GEAR 1997 STARTING & CHARGING SYSTEMS Mazda - Starters - Reduction Gear DESCRIPTION & OPERATION Reduction gear starter is a conventional 12-volt, 4-pole, brush-type starter. The integral
2001 CIVIC - Immobilizer System Troubleshooting
Page 1 of 5 2001 CIVIC - Immobilizer System Troubleshooting 1. Turn the ignition switch ON (II) with a programmed key. 2. Check to see if the immobilizer indicator comes on. Does the indicator come on?
1994 Mazda MX-5 Miata. STARTER - REDUCTION GEAR 1994 ELECTRICAL Mazda Starter - Reduction Gear
DESCRIPTION STARTER - REDUCTION GEAR 1994 ELECTRICAL Mazda Starter - Reduction Gear The Nippondenso reduction gear starter is a conventional 12-volt, 4-pole, brush-type starter. The integral solenoid is
It is normal for the A/C compressor to turn off under certain conditions, such as low idle, high engine coolant temperature, or hard acceleration.
2007 Honda Odyssey 3.5L Eng LX 1Search AC COMPRESSOR CLUTCH A/C Compressor Clutch Circuit Troubleshooting NOTE: It is normal for the A/C compressor to turn off under certain conditions, such as low idle,
STARTER - HITACHI Isuzu Trooper II DESCRIPTION TESTING STARTER PERFORMANCE TESTS Starters HITACHI. Isuzu
STARTER - HITACHI 1986 Trooper II 1984 Starters HITACHI DESCRIPTION Starter is a conventional 12-volt, 4-pole brush-type motor, with direct or reduction gear drive. The starter-mounted solenoid shifts
CHAPTER 22 STARTER Models J05C-TD, J08C-TP and TR
1 INDEX STARTER 22-1 22-114E-03 CHAPTER 22 STARTER TROUBLESHOOTING...22-2 STARTER...22-4 22 22-2 STARTER 1 page 1 TROUBLESHOOTING Symptom Possible cause Remedy Engine does not crank, or cranks slowly Key
PGM-FI MAIN RELAY CIRCUIT TROUBLESHOOTING
PGM-FI MAIN RELAY CIRCUIT TROUBLESHOOTING 1. Turn the ignition switch OFF, then disconnect the PGM-FI main relay 7P connector. 2. Check for continuity between body ground and PGM-FI main relay 7P connector
1997 Mazda MX-5 Miata. STARTER - DIRECT DRIVE 1997 STARTING & CHARGING SYSTEMS Mazda - Starters - Direct Drive
STARTER - DIRECT DRIVE 1997 STARTING & CHARGING SYSTEMS Mazda - Starters - Direct Drive DESCRIPTION & OPERATION Direct drive starter is a conventional 12-volt, 4-pole, brush-type starter. The integral
1994 Mazda MX-5 Miata. STARTER - DIRECT DRIVE 1994 ELECTRICAL Mazda Starter - Direct Drive
DESCRIPTION STARTER - DIRECT DRIVE 1994 ELECTRICAL Mazda Starter - Direct Drive Nippondenso direct drive starter is a conventional 12-volt, 4-pole, brush-type starter. The integral solenoid is attached
STARTER SYSTEM TESTING 5.6
STARTER SYSTEM TESTING 5.6 ON-MOTORCYCLE TESTS Starter Relay Test NOTE Starter relay test also applies to ignition and key switch relays.. See Figure 5-5. Locate starter relay. The relay is attached to
ST- 1 STARTING SYSTEM. Page TROUBLESHOOTING... ST-2 STARTER... ST-3 STARTER RELAY... ST- 12 CLUTCH START SWITCH... ST-1 2
ST- 1 STARTING SYSTEM Page TROUBLESHOOTING... ST-2 STARTER... ST-3 STARTER RELAY... ST- 12 CLUTCH START SWITCH... ST-1 2 ST-2 STARTING SYSTEM - Troubleshooting TROUBLESHOOTING Problem Possible cause Remedy
STARTING SYSTEM TEST STARTING SYSTEM
2013 Dodge or Ram Truck RAM 1500 Truck 2WD V8-5.7L Vehicle > Starting and Charging > Starting System > Testing and Inspection > Component Tests and General Diagnostics STARTING SYSTEM TEST STARTING SYSTEM
1. SPECIFICATION Typ. HPS EPS Capacity 120 A 140 A. 76/140 A at 1,800/6,500 rpm. 70/120 A at 1,800/6,500 rpm. Normal output.
145300 093 1. SPECIFICATION Typ. HPS EPS Capacity 120 A 140 A Alternator Battery Normal output 70/120 A at 1,800/6,500 rpm 76/140 A at 1,800/6,500 rpm Regulator voltage 14.6 V Brush Length 12.5 mm Wear
STARTER SYSTEM TESTING 5.6
STARTER SYSTEM TESTING 5.6 ON-MOTORCYCLE TESTS b088x5x Starter Relay Test NOTE Starter relay test also applies to ignition and key switch relays.. See Figure 5-5. Locate starter relay. The relay is attached
SECTION 9 CRANKING SYSTEM CONTENTS
SECTION 9 CRANKING SYSTEM CONTENTS 9-1. 9-2. 9-3. 9-4. 9-5. 9-6. 9-7. 9-8. GENERAL DESCRIPTION.,...,..., 9-2 SPECIFICATIONS.......................................... 9-4 LUBRICATION 9-5 REMOVAL AND INSTALLATION...
20. ELECTRIC STARTER 20-1 SYSTEM DIAGRAM 20-2 STARTER MOTOR 20-6 SERVICE INFORMATION 20-3 STARTER RELAY SWITCH TROUBLESHOOTING 20-4 DIODE 20-15
20. SYSTEM DIAGRAM 20-2 SERVICE INFORMATION 20-3 TROUBLESHOOTING 20-4 STARTER MOTOR 20-6 STARTER RELAY SWITCH 20-13 DIODE 20-15 20 20-1 SYSTEM DIAGRAM IGNITION SWITCH ENGINE STOP SWITCH CLUTCH SWITCH STARTER
STARTER Mitsubishi Montero DESCRIPTION BENCH TESTING STARTER NO-LOAD TEST ELECTRICAL Mitsubishi Starters. Montero
STARTER 1993 Mitsubishi Montero 1993 ELECTRICAL Mitsubishi Starters Montero DESCRIPTION The starter is a conventional 12-volt, 4-pole brush-type motor, with gear reduction drive. The starter-mounted solenoid
A/T INTERLOCK SYSTEM Acura TSX AUTOMATIC TRANSMISSIONS A/T Interlock System - TSX COMPONENT LOCATION INDEX
A/T INTERLOCK SYSTEM COMPONENT LOCATION INDEX 2004 AUTOMATIC TRANSMISSIONS A/T Interlock System - TSX Fig. 1: Locating A/T Interlock System Components CIRCUIT DIAGRAM Wednesday, March 12, 2008 9:52:31
ARTICLE BEGINNING DESCRIPTION TROUBLE SHOOTING ON-VEHICLE TESTING REMOVAL & INSTALLATION STARTER DOES NOT CRANK ENGINE
Article Text ARTICLE BEGINNING 1995-96 STARTING & CHARGING SYSTEMS Volkswagen Starters Cabrio, Golf III, GTI, Jetta III DESCRIPTION Starter is a brush type, series-wound electric motor with an overrunning
23. ELECTRIC STARTER (TRX450ER)
23. ELECTRIC STARTER (TRX450ER) COMPONENT LOCATION 23-2 STARTER MOTOR 23-6 SYSTEM DIAGRAM 23-2 STARTER RELAY SWITCH 23-13 SERVICE INFORMATION 23-3 CLUTCH DIODE 23-14 TROUBLESHOOTING 23-4 23-1 COMPONENT
Starting Systems & Traction Motor Systems. ATASA 5 th. ATASA 5 TH Study Guide Chapter 18 Pages Starting & Traction Motor Systems 62 Points
ATASA 5 TH Study Guide Chapter 18 Pages 537 570 Starting & Traction Motor Systems 62 Points Please Read The Summary 1. Electric are used to start the engine & in hybrids are used to move the vehicle. Motors
2003 PILOT - Power Window Multiplex Control Unit Input Test
2003 PILOT - Power Window Multiplex Control Unit Input Test Passenger's Unit 1. Before testing the power window control functions, troubleshoot the multiplex control system. 2. Remove the passenger's multiplex
STARTING SYSTEM (1ZZ FE) (April, 2003)
STARTING & CHARGING STARTING SYSTEM (1ZZ FE) (April, 2003) STARTING SYSTEM (1ZZ FE) (April, 2003) INSPECTION 19 1 190QO 02 1. INSPECT STARTER ASSY NOTICE: These tests must be performed within 3 to 5 seconds
STARTING SYSTEM STARTING SYSTEM ST 1
ST1 ST2 Troubleshooting TROUBLESHOOTING Problem Possible cause Remedy Page Engine will not crank Battery charge low Battery cables loose, corroded or worn Clutch start switch faulty (M/T) Neutral start
ENGINE ELECTRICAL GROUP CONTENTS CHARGING SYSTEM IGNITION SYSTEM STARTING SYSTEM
16-1 GROUP 16 ENGINE ELECTRICAL CONTENTS CHARGING SYSTEM 16-3 GENERAL DESCRIPTION 16-3 CHARGING SYSTEM DIAGNOSIS 16-4 SPECIAL TOOL 16-6 ON-VEHICLE SERVICE 16-7 GENERATOR OUTPUT LINE VOLTAGE DROP TEST 16-7
GENESIS COUPE(BK) > 2010 > G 3.8 DOHC > Engine Electrical System
GENESIS COUPE(BK) > 2010 > G 3.8 DOHC > Engine Electrical System Engine Electrical System > General Information > Specifications Specifications Ignition System Items Specification Ignition coil Primary
COMPONENT LOCATION INDEX
COMPONENT LOCATION INDEX 2003-04 ACCESSORIES & EQUIPMENT Gauges - Element Fig. 1: Identifying Gauges Component Locations Page 1 Fig. 2: Locating Gauges & Gauge Connectors & Identifying Gauge Connector
Before performing symptom troubleshooting, check for power train DTCs (see GENERAL TROUBLESHOOTING INFORMATION ).
2003 Honda Civic 1.7L Eng LX Component AC PRESSURE SENSOR A/C Pressure Switch Circuit Troubleshooting NOTE: Do not use this troubleshooting procedure if any of the following items are operative; condenser
CHARGING SYSTEM 8C - 1 CHARGING SYSTEM CONTENTS
ZG CHARGING SYSTEM 8C - 1 CHARGING SYSTEM CONTENTS page GENERAL INFORMATION OVERVIEW... 1 DESCRIPTION AND OPERATION BATTERY TEMPERATURE SENSOR... 2 CHARGING SYSTEM OPERATION... 1 ELECTRONIC VOLTAGE REGULATOR...
2000 F-150 Workshop Manual
Page 1 of 14 SECTION 303-06: Starting System 2000 F-150 Workshop Manual DIAGNOSIS AND TESTING Procedure revision date: 06/17/1999 Starting System Refer to Wiring Diagrams Cell 20, Starting System for schematic
VAGABOND S HANDBOOK TRANSMISSION
03/24/07 TRANSMISSION Transmission won t engage into Gear This is caused usually by too low a Voltage to get into the ECM. This unit requires a minimum of 9VDC in order to operate at all. Almost all erratic
1 of 6 3/7/2013 9:56 AM 2002 Chevrolet TrailBlazer - 4WD Bravada, Envoy, TrailBlazer VIN S/T Service Manual DTC P1481 Circuit Description The powertrain control module (PCM) uses the cooling fan speed
2005 ODYSSEY - Front Door Panel Removal/Installation
2005 ODYSSEY - Front Door Panel Removal/Installation Special Tools Required KTC trim tool set SOJATP2014 Trim pad remover, Snap-on A 177A or equivalent, commercially available NOTE: Use the appropriate
Distributor Ignition DI System Diagnosis
Page 1 of 8 2004 Chevrolet K Silverado - 4WD Sierra, Silverado VIN C/K Service Manual Engine Engine Controls - 4.3L Diagnostic Information and Procedures Document ID: 848577 Distributor Ignition DI System
DTC P1259: VTEC System Malfunction. Special Tools Required
DTC P1259: VTEC System Malfunction Special Tools Required Pressure gauge adapter 07NAJ-P07010A A/T low pressure gauge w/panel 07406-0070300 A/T pressure hose 07406-0020201 A/T pressure hose, 2,210 mm 07MAJ-PY4011A
2007 Dodge Nitro R/T ENGINE Starting - Service Information - Nitro. Starting - Service Information - Nitro
STARTING INFORMATION DESCRIPTION DESCRIPTION 2007 ENGINE Starting - Service Information - Nitro The Remote Starting System allows the vehicle to be started up to 300 feet (91 meters) away from the vehicle
TL - Keyless Entry/Security Alarm System Control Unit Input Test
1999 3.2TL - Keyless Entry/Security Alarm System Control Unit Input Test '99-01 Models 1. Before testing the keyless entry/security control functions, troubleshoot the multiplex control system. Multiplex
2001 Honda Accord DX DTC P0135: PRIMARY HO2S (SENSOR 1) HEATER CIRCUIT MALFUNCTION, DTC P0141: SECONDARY HO2S (SENSOR 2) HEATER CIRCUIT MALFUNCTION
DTC P0135: PRIMARY HO2S (SENSOR 1) HEATER CIRCUIT MALFUNCTION, DTC P0141: SECONDARY HO2S (SENSOR 2) HEATER CIRCUIT MALFUNCTION NOTE: Information marked with an asterisk (*) applies to DTC P0141. 1. Reset
Emission Control System
Emission Control System Exhaust Gas Recirculation (EGR) System [B18A1 engine: A/T] Troubleshooting Flowchart The Malfunction Indicator Lamp (MIL) indicates Diagnostic Trouble Code (DTC) 12: A problem in
1. SPECIFICATION
000000 093 1. SPECIFICATION Specification HPS EPS Alternator Crankshaft pulley : Alternator Pulley 1 : 2.94 Normal output (idling/2200 rpm) 70/120 A 70/140A Regulator voltage 14.6 V Brush Length 12.5 mm
20. Install and tighten the cap screws that hold the end frame and field frame together
4006-30 19. Fill the oil reservoir in the bearing bore of the end frame with SAE 10 engine oil. Then put the the end frame on the armature shaft. Align the marks on the end frame and field frame and push
INFORMATION. covering use of Ammeter and Voltmeter ON and 1915 Model Six-54 Electrical System
INFORMATION covering use of Ammeter and Voltmeter ON- 1914 and 1915 Model Six-54 Electrical System Hudson Motor Car Company Detroit, Michigan, IX S. A USE OF AMMETER ON 1914 AND 1915 MODEL SIX-54 With
No signal from the CMP sensor for 3 seconds with the PCM receiving an engine start signal.
DTC P0340 Circuit Description The DTC P0340 Camshaft Position (CMP) Sensor Circuit diagnostic monitors the output of the CMP sensor. The CMP sensor is located in the distributor and consists of a signal
If the terminals are bent, loose or corroded, repair them as necessary, and recheck the system.
POWER WINDOW MULTIPLEX CONTRO... 2003 ODYSSEY Power Window Multiplex Control Unit Input Test 1. Before testing the power window control functions, troubleshoot the multiplex control system. Driver's Multiplex
A/C Generator Systems
A/C Generator Systems What is the function of the charging system? Provide power for all electrical loads Recharge the starting battery What happens if the charging systems puts out too much power? Voltage
Fuel Pump Electrical Circuit Diagnosis
Page 1 of 6 Document ID# 599891 2000 Chevrolet Camaro Feedback Print Fuel Pump Electrical Circuit Diagnosis Circuit Description When the ignition switch is ON, the powertrain control
GROUP CONTENTS CHARGING SYSTEM IGNITION SYSTEM SPECIAL TOOL GENERAL DESCRIPTION
16-1 GROUP 16 CONTENTS CHARGING SYSTEM 16-3 GENERAL DESCRIPTION 16-3 SPECIAL TOOL 16-4 CHARGING SYSTEM DIAGNOSIS 16-4 ON-VEHICLE SERVICE 16-6 GENERATOR OUTPUT LINE VOLTAGE DROP TEST 16-6 OUTPUT CURRENT
DIAGNOSTIC INFORMATION AND PROCEDURES > CHARGING SYSTEM TEST
Page 1 of 5 Service Manual: BATTERY, CHARGING SYSTEM AND Print Date: STARTING SYSTEM DIAGNOSTIC INFORMATION AND PROCEDURES > CHARGING SYSTEM TEST Charging System Test 2005 Pontiac Montana SV6 3.5L Eng
P0882-TCM POWER INPUT LOW
- JK - JEEP WRANGLER - L V6 (SMPI) P-TCM POWER INPUT LOW BATTERY BATT A FUSE J 5A POWER DIESEL GAS Z 6 BK Z 4 BK Z 6 BK 5 7A 7 6 ELECTRONICS 6 C C T6 6 T5 YL/OR YL/BR 5 C C T6 6 T5 YL/OR YL/BR S6 T6 T6
G - TESTS W/CODES - 2.2L
G - TESTS W/CODES - 2.2L 1994 Toyota Celica 1994 ENGINE PERFORMANCE Toyota 2.2L Self-Diagnostics Celica INTRODUCTION If no faults were found while performing F - BASIC TESTING, proceed with self-diagnostics.
Power Supply Circuit For Transfer Control Unit
Page 1 of 7 2005 Nissan Xterra 4.0L Eng S Power Supply Circuit For Transfer Control Unit CONSULT-II REFERENCE VALUE IN DATA MONITOR MODE Data are reference value. DATA MONITOR MODE REFERENCE Monitored
DIAGNOSIS AND TESTING Procedure revision date: 06/21/2000
2001 F-350 Applies to: Gasoline Report a problem with this article Subarticles Inspection and Verification Symptom Chart Pinpoint Tests Component Tests SECTION 303-06A: Starting System Gasoline Engines
Starter, Delco Remy 15.01
Starter, Delco Remy.0 General Information General Information The Delco Remy starter mounts at the forward face of the flywheel bell housing on the right side of the engine. The starter assembly consists
MASS AIR FLOW (MAF) SENSOR, CHECKING - BOSCH
2004 Audi A6 Sedan (4B2) V6-2.7L Turbo (BEL) Vehicle > Powertrain Management > Computers and Control Systems > Testing and Inspection > Component Tests and General Diagnostics > Component Tests > Mass
POWER DOOR LOCK CONTROL
BE60 POWER DOOR LOCK CONTROL SYSTEM PARTS LOCATION TROUBLESHOOTING The table below will be useful for you in troubleshooting these electrical problems. The most likely causes of the malfunction are shown
SCHEMATIC AND ROUTING DIAGRAMS
2004 ACCESSORIES & EQUIPMENT Theft Deterrent - Corvette SCHEMATIC AND ROUTING DIAGRAMS THEFT DETERRENT SYSTEM SCHEMATICS Fig. 1: Theft Deterrent Relay, Security Indicator, Lighting and Horn References
TRANSMISSION - NGC. Symptom: P0706-CHECK SHIFTER SIGNAL. When Monitored and Set Condition:
Symptom: P0706-CHECK SHIFTER SIGNAL When Monitored and Set Condition: P0706-CHECK SHIFTER SIGNAL When Monitored: Continuously with the ignition on. Set Condition: After 3 occurrences in one ignition cycle
1984 Jeep CJ7. IGNITION SYSTEM - SOLID STATE' 'Distributors & Ignition Systems MOTORCRAFT SOLID STATE IGNITION (SSI)
TESTING SECONDARY CIRCUIT CHECK CAUTION: When checking secondary voltage, do not remove spark plug wires from spark plugs No. 3 on 4-cylinder, No. 1 or 5 on 6-cylinder and No. 3 or 4 on V8 Engines. 1.
ENGINE ELECTRICAL GROUP CONTENTS CHARGING SYSTEM IGNITION SYSTEM STARTING SYSTEM
16-1 GROUP 16 ENGINE ELECTRICAL CONTENTS 16-2 GENERAL INFORMATION 16-2 GENERAL SPECIFICATIONS 16-3 SERVICE SPECIFICATIONS 16-3 DIAGNOSIS 16-3 SPECIAL TOOL 16-6 ON-VEHICLE SERVICE 16-7 GENERATOR OUTPUT
STARTING & CHARGING SYSTEM SECTIONSC CONTENTS IDX
STARTING & CHARGING SYSTEM SECTIONSC GI MA EM LC EC CONTENTS FE PRECAUTIONS...2 Supplemental Restraint System (SRS) AIR BAG and SEAT BELT PRE-TENSIONER...2 Wiring Diagrams and Trouble Diagnosis...2 BATTERY...3
Individual ignition coil system,
Page 1 of 11 28-17 Individual ignition coil system, checking Ignition coils, checking Notes: Measuring the primary resistance of the ignition coils is normally not necessary for this test (primary resistance
ON-VEHICLE INSPECTION
CH2 P11586 CHARGING CHARGING SYSTEM ONVEHICLE INSPECTION 1. CHECK BATTERY ELECTROLYTE LEVEL Check the electrolyte quantity of each cell. MaintenanceFree Battery: CH03L01 If under the lower level, replace
Automotive Electrical Systems
Automotive Electrical Systems 1 Electrical Circuits Contain 4 main parts 1. Power source battery alternator 2. Load 3. Control 4. Path 2 3 Batteries What is a Battery? An electrochemical device which stores
DTC P Shift Solenoid Circuit Electrical
1998 Pontiac Grand Prix DTC P0753 1-2 Shift Solenoid Circuit Electrical Circuit Description The 1-2 Shift Solenoid Valve (1-2 SS Valve) controls the fluid flow acting on the 1-2 and 3-4 shift valve. The
THE ALT AL ERNA RN T A OR
THE ALTERNATOR Initial Voltage of the Battery (Engine Not Running) Charging Voltage for the Battery (Engine Running) Testing for Maximum Output of the Alternator Inspecting the Regulator Positive Side
CRUISE CONTROL SYSTEM
CRUISE CONTROL SYSTEM 1993 Mitsubishi Montero 1993 ACCESSORIES & EQUIPMENT Mitsubishi Cruise Control Systems Montero DESCRIPTION & OPERATION The cruise control system is electronically and vacuum controlled.
19. ELECTRIC STARTER 19-0 ELECTRIC STARTER XCITING 500/250
19 ELECTRIC STARTER STARTING SYSTEM LAYOUT ----------------------------------------- 19-1 SERVICE INFORMATION------------------------------------------------ 19-2 TROUBLESHOOTING-----------------------------------------------------
STARTING SYSTEM SECTION STR CONTENTS ENGINE STR-1 BASIC INSPECTION... 2 FUNCTION DIAGNOSIS... 5 PREPARATION...14 COMPONENT DIAGNOSIS...
ENGINE SECTION STR A STARTING SYSTEM STR C D CONTENTS E BASIC INSPECTION... 2 DIAGNOSIS AND REPAIR WORKFLOW... 2 Work Flow...2 FUNCTION DIAGNOSIS... 5 STARTING SYSTEM... 5 System Diagram...5 System Description...5
1998 Acura 3.5RL. F - BASIC TESTING' '1998 ENGINE PERFORMANCE Acura - Basic Diagnostic Procedures
FUEL PUMP 1. Remove fuel tank filler cap. Listen for fuel pump operation noise at fuel tank filler. Fuel pump should operate for 2 seconds after ignition switch is turned on. If fuel pump operates as specified,
Troubleshooting Guide
Troubleshooting Guide P/N 0153180 July 1999 P.O. Box 1160 St. Joseph, MO 64502-1160 1-800-255-0317 Fax: 816-360-9379 www.snorkelusa.com GENERAL INFORMATION This manual contains procedures for locating
1995 Honda Accord LX. ANTI-LOCK BRAKE SYSTEM' ' BRAKES Honda - Anti-Lock
TROUBLE SHOOTING ANTI-LOCK (ABS) WARNING LIGHT NOTE: ABS system is okay if ABS warning light goes out after engine is started. Diagnostic Trouble Code (DTC) Recognition 1. ABS control unit recognizes system
CHAPTER 10 ELECTRIC SYSTEM
CHAPTER 10 ELECTRIC SYSTEM 1. ELECTRIC SYSTEM ELECTRIC SYSTEM 1.1 WIRING DIAGRAM CK20-USA 196WA00A S196-WOO Jul. 2003 10-3 CK20(M) CHAPTER 10 CK20-EU 196WA51A 10-4 S196-WOO Jul. 2003 ELECTRIC SYSTEM 1.2
2001 Honda Civic EX ACCESSORIES & EQUIPMENT' 'Cruise Control Systems - Civic & CR-V 2001 ACCESSORIES & EQUIPMENT
DESCRIPTION 2001 ACCESSORIES & EQUIPMENT Cruise Control Systems - Civic & CR-V Cruise control system uses mechanical and electrically operated devices to maintain vehicle speed settings greater than 25
2002 Ford Explorer STARTING & CHARGING SYSTEMS' 'Generators & Regulators - Explorer & Mountaineer STARTING & CHARGING SYSTEMS
DESCRIPTION 2002-03 STARTING & CHARGING SYSTEMS Generators & Regulators - Explorer & Mountaineer System consists of generator, regulator, battery, fuses, PCM and associated wiring. Generators have an electronic
STARTING SYSTEM Model 811FJ SERVICE MANUAL 2003 Chevrolet Impala
STARTING SYSTEM Model 811FJ SERVICE MANUAL 2003 Chevrolet Impala ATech Training, Inc. 12290 Chandler Drive Walton, KY 41094 USA Toll Free: 1-888-738-9924 Phone: (859) 485-7229 Fax (859) 485-7299 Email:
Engine Electrical System(D4FA - DSL1.5)
Engine Electrical System(D4F - DSL1.5) GENERL CHRGING SYSTEM LTERNTOR TTERY STRTING SYSTEM STRTER STRTER RELY PREHETING SYSTEM EE -2 GENERL ENGINE ELECTRICL SYSTEM(D4F - DSL1.5) SPECIFICTION E63F15E2 STRTING
P0743-TCC SOLENOID CIRCUIT
- XK - JEEP COMMANDER -.L MAGNUM V P-TCC CIRCUIT RUN-START F JUNCTION BLOCK FUSE A ELECTRO RELAY- - - SHIFT TCC -/ -5 SUPPLY VOLTAGE MODULATION HYDRAULIC UNIT (.L/DIESEL) T T T T5 T T T 5 A /LG DG/ C Z
VEHICLE SPEED CONTROL SYSTEM
J VEHICLE SPEED CONTROL SYSTEM 8H - 1 VEHICLE SPEED CONTROL SYSTEM CONTENTS page DIAGNOSIS... 2 GENERAL INFORMATION... 1 page SERVICE PROCEDURES... 9 GENERAL INFORMATION The vehicle speed control system
ALTERNATOR PRECAUTIONS. Some precautions should be taken when working on this, or any other, AC charging system.
The alternator charging system is a negative (-) ground system which consists of an alternator, a regulator, a charge indicator, a storage battery and wiring connecting the components, and fuse link wire.
P0750-LR SOLENOID CIRCUIT
6 - HB - DODGE DURANGO - 5.7L HEMI V - MDS P75-LR CIRCUIT BATT A FUSE 5 5A INTEGRATED POWER 5-6 7 C 7 C 9 C4 Z95 T5 BK YL/BK 4 G T C T S T T TO OTHER MODULES /TRS 7 9 7 T5 YL/BK T T T T6 YL/RD T DG T9
2/2/2018 Feed Circuit Test (Starting System) - ALLDATA
2005 Jeep Truck Grand Cherokee 2WD V8-5.7L VIN 2 Vehicle > Starting and Charging > Starting System > Testing and Inspection > Component Tests and General Diagnostics FEED CIRCUIT TEST The starter feed
The engine is running. DTC P0351, P0352, P0353, and P0354 run continuously once the above condition has been met.
Page 1 of 6 DTC P0351-P0354 Circuit Description DTCs P0351 through P0354 Ignition Coil Primary/Secondary Feedback Circuit diagnostic monitors the primary circuitry of individual ignition coils for the
SELF-DIAGNOSTIC TESTS
Page 1 of 10 1997 Chrysler Sebring 2.5L Eng JX SELF-DIAGNOSTIC TESTS NOTE: When using diagnostic tests, DO NOT skip any steps or incorrect diagnosis may result. Ensure battery is fully charged. in appropriate
DTC P1655 Evaporative Emission (EVAP) Purge Solenoid Control Circuit
Page 1 of 5 1997 Pontiac Grand Am Achieva, Grand Am, Skylark (VIN N) Service Manual Document ID: 58460 DTC P55 Evaporative Emission (EVAP) Purge Solenoid Control Circuit Circuit Description Output Driver
Starting and Charging
The Starting and Charging System is a critical system in your vehicle. The Starting system provides the ability to crank the engine electrically from the drivers position. The first car with electric starting
Engine Cranks But Does Not Run
Page 1 of 5 2000 GMC Truck GMC K Sierra - 4WD Sierra, Silverado, Suburban, Tahoe, Yukon (VIN C/K) Service Manual Engine Engine Controls - 4.8L, 5.3L, and 6.0L Diagnostic Information and Procedures Engine
1999 Mercury Cougar ACCESSORIES & EQUIPMENT' 'Passive Anti-Theft Systems - Cougar 1999 ACCESSORIES & EQUIPMENT
DESCRIPTION 1999 ACCESSORIES & EQUIPMENT Passive Anti-Theft Systems - Cougar Passive Anti-Theft System (PATS) is available on some vehicles. The system is passive in that it does not require any activity
STARTING SYSTEM LOCATION INDEX [LF]
1. Remove the battery cover. 2. Disconnect the negative battery cable. (See BATTERY REMOVAL/INSTALLATION [LF].) 3. Remove the side cover. (LH) 2007 Mazda MX-5 Miata Sport 2007 ENGINE Starting System -
Volkswagen > New Beetle, New Beetle Convertible > Liter 4-Cyl. 2V Generic Scan Tool, Engine Code(s): AEG 24 - Components, Checking
Page 1 of 9 Volkswagen > New Beetle, New Beetle Convertible > 1998-2008 2.0 Liter 4-Cyl. 2V Generic Scan Tool, Engine Code(s): AEG 24 - Components, Checking. Throttle Valve Control Module J338, Checking
Starting Systems. State a major safety precaution when removing or working around a starting motor
Starting Systems State a major safety precaution when removing or working around a starting motor Always unhook the battery ground before attempting to remove the starter motor. Starting Systems Identify
1999 Toyota RAV ACCESSORIES & EQUIPMENT Cruise Control Systems - RAV4
1999 ACCESSORIES & EQUIPMENT Cruise Control Systems - RAV4 DESCRIPTION WARNING: Deactivate air bag system before performing any service operation. See AIR BAG RESTRAINT SYSTEMS article. DO NOT apply electrical
Troubleshooting Guide
Troubleshooting Guide diesel - gasoline - LPG P/N 0172021 June 1999 P.O. Box 1160 St. Joseph, MO 64502-1160 1-800-255-0317 Fax: 816-360-9379 www.snorkelusa.com GENERAL INFORMATION This manual contains
OVERHAUL. 1. REMOVE REPAIR SERVICE STARTER KIT (a) Remove the nut, and disconnect the lead wire from the repair service starter kit.
STARTING & CHARGING 195 OVERHAUL 190C702 1. REMOVE REPAIR SERVICE STARTER KIT (a) Remove the nut, and disconnect the lead wire from the repair service starter kit. A57559 (b) (c) (d) Remove the 2 screws