Automotive Electrical Systems
|
|
- Norman Cain
- 5 years ago
- Views:
Transcription
1 Automotive Electrical Systems 1
2 Electrical Circuits Contain 4 main parts 1. Power source battery alternator 2. Load 3. Control 4. Path 2
3 3
4 Batteries What is a Battery? An electrochemical device which stores chemical energy and converts it to electrical energy on demand Purpose: Provides current for starting, ignition and accessories. Automotive batteries are a Lead-acid type Anode: Cathode: Lead Lead dioxide Electrolyte: Diluted Sulfuric Acid 4
5 Battery Ratings: Cold Cranking Amps (CCA) The number of amperes that can be supplied by a battery at 0 F (-18 C) for 30 seconds and still maintain a voltage or 1.2 V per cell or higher (7.2 V for a 12 Volt battery and 3.6 V for a 6 Volt battery) Reserve Capacity The number of minutes the battery can produce 25 A and still have a battery voltage of 1.75 V per cell (10.5 Volts) This rating is actually a measurement of the time a car can be driven in the event of a charging system failure. Amp-Hour Rating Determined by discharging a fresh, fully charged battery at a constant rate so selected that at the end of 20 hours, the voltage will have fallen to 1.75 V per cell (10.5 V in a 12 V battery) This discharge current, times 20 hours, gives the battery s amp-hour rating 5
6 Battery Main Components: Case Caps Positive Plates Negative Plates Electrolyte Separators Terminals 6
7 Battery Electrolyte: React chemically with positive & negative plates to produce electron flow Composition: 36% Sulphuric Acid H 2 SO 4 64% Water H 2 O Mixed by weight 7
8 Battery Plates: Positive Plates: Has a lack of electrons (positive charge) Negative Plates: Has an abundance of electrons (negative charge) 8
9 9
10 Battery Separators: Prevent positive and negative plate groups from contacting Made from treated wood, glass fiber, porous rubber 10
11 Battery Cells: A fully charged 12V battery contains 12.6V WHY??? It contains 6 cells each producing 2.1V of electricity 11
12 Connecting / Disconnecting a Battery Which cable gets disconnected first??? NEGATIVE Which cable gets connected first??? POSITIVE DISCONNECT NPPN CONNECT 12
13 13
14 Battery Tests: 1 Visual Cracks, bulges, dirt, leaks, corrosion 2 Hydrometer test (specific gravity) Full charge ¾ charge ½ charge ¼ charge Very Weak Discharged Maximum variation Capacity (Load) Test 14
15 Specific Gravity: Determines the density of a liquid Water Sulfuric Acid Electrolyte Condition of Battery Specific Gravity of Electrolyte When Electrolyte Freezes (Temp.) (F ) (C ) Discharged Fully-Charged
16 16
17 Load (capacity) Test: 3 x Amp hour Rating or ½ Cold Cranking Rating for 15 seconds Voltage should not drop below 9.6 volts 3 Minute Fast Charge Test: amps for 3 minutes Maximum voltage reading should not exceed 15.5 volts 17
18 18
19 Starting Systems Starting Systems Motor Operating Principles A) A single wire is placed in a loop between two different magnetic poles B) Current flow in the loop creates a magnetic field C) Opposing magnetic fields between the wire and the permanent magnets causes the loop to rotate D) Once the loop rotates 180 degrees the current is reversed in the loop thought the brushes and continues to flip E) Adding more loops increases power F) Use of electricity to create a Field
20 Starting Systems Starting Systems Starter Motor Parts A) armature B) commutator C) brushes D) Field Magnets
21 Starting Systems Starting Systems Motor Operating Principles Rules of electricity related to Magnetism? #1 Unlike Poles (North &South) Attract! Like Poles Repel! #2 A moving magnet passing a wire in a complete circuit creates electron movement in that wire ( Electricity ) Factors that determine the amount of electrical current created -Speed of the moving magnetic field -Strength of the magnetic field - Size and type of conductor #3 Electron Flow in a wire creates a magnetic field around that wire (Electro Magnets)
22 Starting Systems Starting Systems Making the Starter Work! A) Starter Solenoid B) Starter Final Drive
23 Starting Systems Starting Systems Starter Curcuit
24 Alternators 24
25 Alternators Belt Driven Creates Current to run electrical systems when the vehicle is running Charges the battery when vehicle is running Battery should show a voltage of Volts when vehicle is running 25
26 Charging Systems Charging Systems Alternator basics A) A spinning magnetic (engine driven) within a loop creates current flow in the wire B) Every 180 degrees of magnet rotation causes the current flow to reverse ( AC Current) C) Instead of a permanent magnet an electro magnet is used, this allows current flow to determine the strength of the magnetic field D) Slip rings allow current flow to maintain the same direction into the electro magnet (rotor) E) Instead of one loop of wire, there are many (stator)
27 Charging Systems Charging Systems Regulators A) Determine the amount of current required to operate the system (Load) B) Determine the state of charge of the battery C) Regulate the amount of electricity to the rotor to get an output D) Activate a light for the driver or show charging on a ammeter E) To stop overcharging
28 Charging Systems Charging Systems Problems 1) Low Battery a) start and stop driving d) battery will not accept a charge b) Accessories left on e) defective connections c) Loose drive belt f) defective alternator or regulator 2) Overcharged Battery a) short in stator field b) defective regulator 3) Faulty indicator lamp action a) defective wiring b) defective alternator or regulator 4) Noise a) worn bearings b) loose mountings c) worn belt drive
29 Connecting Jumper Cables Proper order is important so that there is no chance of an explosion from the battery Engine or Frame Ground 3 29
30 Batteries, Starting & Charging Systems! Demo! Testing with a VAT (Voltage Amperage Tester ) 400 A)Battery Load Testing B)Starter Draw Test C) Alternator Output Test
Battery Operation. Battery Construction. Battery State Of Charge. Battery Load Test. Battery Rating Systems 2/14/12
Battery Operation Batteries, Charging and Donald Jones Brookhaven College Batteries convert chemical energy into electrical energy During discharge the battery s plate composition is changed During charging
More informationUnit AE01K Knowledge of Locating and Correcting Simple Electrical Faults in the Automotive Workplace
Assessment Requirements Unit AE01K Knowledge of Locating and Correcting Simple Electrical Faults in the Automotive Workplace Content: Basic electrical principles a. Explain the direction of current flow
More informationELECTRICAL. CDTA Technical Training Center
ELECTRICAL ATOMIC STRUCTURE Protons positive charge Electron negative charge Neutron - neutral Electricity is the movement of electrons from atom to atom ELECTRON FLOW CONDUCTOR - Materials which have
More information1. SPECIFICATION
000000 093 1. SPECIFICATION Specification HPS EPS Alternator Crankshaft pulley : Alternator Pulley 1 : 2.94 Normal output (idling/2200 rpm) 70/120 A 70/140A Regulator voltage 14.6 V Brush Length 12.5 mm
More informationStarting and Charging
The Starting and Charging System is a critical system in your vehicle. The Starting system provides the ability to crank the engine electrically from the drivers position. The first car with electric starting
More informationBATTERY 8A - 1 BATTERY CONTENTS
TJ BATTERY 8A - 1 BATTERY CONTENTS page DESCRIPTION AND OPERATION BATTERY... 1 DIAGNOSIS AND TESTING BATTERY... 3 SERVICE PROCEDURES BATTERY CHARGING... 13 DESCRIPTION AND OPERATION BATTERY DESCRIPTION
More informationBatteries, Alternators, and Chargers
FAMA BUYER S GUIDE TC035 Batteries, Alternators, and Chargers Prepared by the FAMA Electrical Subcommittee This guide does not endorse any manufacturer or product Page 1 of 8 Contents Introduction...3
More informationBATTERY 8A - 1 BATTERY CONTENTS
ZJ BATTERY 8A - 1 BATTERY CONTENTS page GENERAL INFORMATION INTRODUCTION... 1 OVERVIEW... 1 DESCRIPTION AND OPERATION BATTERY MOUNTING... 3 BATTERY SIZE AND RATINGS... 2 BATTERY... 2 DIAGNOSIS AND TESTING
More informationElectricity MR. BANKS 8 TH GRADE SCIENCE
Electricity MR. BANKS 8 TH GRADE SCIENCE Electric charges Atoms and molecules can have electrical charges. These are caused by electrons and protons. Electrons are negatively charged. Protons are positively
More informationBattery. Student booklet
Battery Student booklet Battery - INDEX - 2006-04-07-12:51 Battery Batteries are all over the place, in our cars, our PCs, laptops, portable MP3 players and cell phones. A battery is essentially a can
More information1. SPECIFICATION Typ. HPS EPS Capacity 120 A 140 A. 76/140 A at 1,800/6,500 rpm. 70/120 A at 1,800/6,500 rpm. Normal output.
145300 093 1. SPECIFICATION Typ. HPS EPS Capacity 120 A 140 A Alternator Battery Normal output 70/120 A at 1,800/6,500 rpm 76/140 A at 1,800/6,500 rpm Regulator voltage 14.6 V Brush Length 12.5 mm Wear
More informationSTARTER CIRCUIT TROUBLESHOOTING
2000 Honda Accord EX Sedan V6-3.0L Vehicle > Starting and Charging > Starting System > Starter Motor > Testing and Inspection > Component Tests and General Diagnostics STARTER CIRCUIT TROUBLESHOOTING Starter
More informationBASIC ELECTRICS MECHANICS BASIC LEVEL. An initiative of:
BASIC ELECTRICS 2 BASIC LEVEL MECHANICS An initiative of: Table of Contents TRANSMISSIONS AND DRIVETRAIN 1. Basic Electrics 1 1.1 Introduction 1 1.2 Charging Circuit 2 1.2.1 The Battery 2 2. Generators
More informationPage 1 of 1 ALTERNATORS. Overview. Intek TM V-Twin Cylinder OHV Engine Service Manual Version 1.0. Copyright 1999 by Briggs and Stratton Corporation
Overview Alternator Identification Page 1 of 3 The alternator systems installed on Briggs & Stratton Intek V-Twin Cylinder OHV Engines can easily be identified by the color of the stator output wires and
More informationUnderstanding the Battery
Understanding the Battery Materials Needed For this lesson, you will need the following materials: Student Manual Dummy Battery Visuals Understanding a Battery training video Battery Application Guide
More informationElectrical Systems. Introduction
Electrical Systems Figure 1. Major Components of the Car s Electrical System Introduction Electricity is used in nearly all systems of the automobile (Figure 1). It is much easier to understand what electricity
More informationBATTERY 8A - 1 BATTERY TABLE OF CONTENTS
DN BATTERY 8A - 1 BATTERY TABLE OF CONTENTS page DESCRIPTION AND OPERATION BATTERY...1 BATTERY CABLES...3 BATTERY HOLD DOWNS...4 BATTERY TRAY...4 DIAGNOSIS AND TESTING BATTERY...5 BATTERY CABLES...14 SERVICE
More informationPhysical Science Lecture Notes Chapter 13
Physical Science Lecture Notes Chapter 13 I. Section 13-1 Electricity, Magnetism & Motion A. Electrical & mechanical energy 1. Magnetic forces repel when alike and attract when opposite 2. Electric current
More informationA/C Generator Systems
A/C Generator Systems What is the function of the charging system? Provide power for all electrical loads Recharge the starting battery What happens if the charging systems puts out too much power? Voltage
More informationIMPORTANT SAFETY INSTRUCTIONS
ASSOCIATED Model 6039 Battery Tester Operator's Manual IMPORTANT SAFETY INSTRUCTIONS 1. SAVE THESE INSTRUCTIONS This manual contains important safety and operating instructions for the battery tester you
More informationCHAPTER 10 ELECTRIC SYSTEM
CHAPTER 10 ELECTRIC SYSTEM 1. ELECTRIC SYSTEM ELECTRIC SYSTEM 1.1 WIRING DIAGRAM CK20-USA 196WA00A S196-WOO Jul. 2003 10-3 CK20(M) CHAPTER 10 CK20-EU 196WA51A 10-4 S196-WOO Jul. 2003 ELECTRIC SYSTEM 1.2
More informationTable No. 1 provides a means of identifying the various alternator systems. Note: All output figures are rated at 3600 RPM. TABLE NO.
The alternator systems installed on Briggs & Stratton Intek OHV-Twin Cylinder Engines can easily be identified by the color of the stator output wires and the connector. Table No. 1 provides a means of
More informationELECTRICAL BATTERY/STARTING/CHARGING SYSTEMS DIAGNOSTICS
Z ELECTRICAL 8A - 1 ELECTRICAL GROUP INDEX page AUDIO SYSTEMS... 8F BATTERY/STARTER/GENERATOR SERVICE... 8B BATTERY/STARTING/CHARGING SYSTEMS DIAGNOSTICS... 8A CHIME WARNING/REMINDER SYSTEM... 8U HORNS...
More informationLAWN & GARDEN PRODUCT ELECTRICAL SYSTEM INFORMATION FOR S 1612
LAWN & GARDEN PRODUCT ELECTRICAL ELECTRICAL SYSTEM INFORMATION FOR LAWN & GARDEN PRODUCT 106 ELECTRICAL LAWN & GARDEN PRODUCT 20 & 22 BATTERY INFORMATION GENERAL INFORMATION (COURTESY OF HAWKER ENERGY
More informationSECTION 1E ENGINE ELECTRICAL
SECTION 1E ENGINE ELECTRICAL CAUTION: Disconnect the negative battery cable before removing or installing any electrical unit or when a tool or equipment could easily come in contact with exposed electrical
More informationHandout Activity: HA773
Charging system HA773-2 Handout Activity: HA773 Charging system The charging system allows for a means to recharge the battery and allow for electrical usage of components in the vehicle. The charging
More informationMDX-300 Series. For 12-volt automotive starting batteries and starting/charging systems INSTRUCTION MANUAL
For 12-volt automotive starting batteries and starting/charging systems INSTRUCTION MANUAL Blank page Contents Caution... 4 Capabilities... 4 Display and Keypad... 4 Preparations Before the Test... 6 Connecting
More informationCHARGING SYSTEM PRECAUTION CH 1
1NZ-FE ARGING ARGING SYSTEM ARGING SYSTEM PRECAUTION 1 1. Check that the battery cables are connected to the correct terminals. 2. Disconnect the battery cables when the battery is given a quick charge.
More informationINFORMATION. covering use of Ammeter and Voltmeter ON and 1915 Model Six-54 Electrical System
INFORMATION covering use of Ammeter and Voltmeter ON- 1914 and 1915 Model Six-54 Electrical System Hudson Motor Car Company Detroit, Michigan, IX S. A USE OF AMMETER ON 1914 AND 1915 MODEL SIX-54 With
More informationBattery Management Innovation. For 12-volt automotive starting batteries and starting/charging systems INSTRUCTION MANUAL
Battery Management Innovation For 12-volt automotive starting batteries and starting/charging systems INSTRUCTION MANUAL ! CAUTION Because of the possibility of personal injury, always use extreme caution
More informationATASA 5 th. Batteries. Please Read The Summary. ATASA 5 TH Study Guide Chapter 17 Pages Battery Theory & Service 70 Points
ATASA 5 TH Study Guide Chapter 17 Pages 501 535 Battery Theory & Service 70 Points ATASA 5 th Please Read The Summary 1. Electrical energy in a battery is produced by the that occurs between two dissimilar
More informationElectricity. Chapter 20
Electricity Chapter 20 Types of electric charge Protons + charge Electrons - charge SI unit of electric charge is the coulomb (C) Interactions between charges Like charges repel Opposite charges attract
More informationStarting Systems & Traction Motor Systems. ATASA 5 th. ATASA 5 TH Study Guide Chapter 18 Pages Starting & Traction Motor Systems 62 Points
ATASA 5 TH Study Guide Chapter 18 Pages 537 570 Starting & Traction Motor Systems 62 Points Please Read The Summary 1. Electric are used to start the engine & in hybrids are used to move the vehicle. Motors
More informationDeep Cycle Battery Safety. First. Battery Handling, Maintenance & Test Procedures
Deep Cycle Battery Safety. First. Battery Handling, Maintenance & Test Procedures Crown deep cycle batteries employ a low-maintenance design. They do require periodic maintenance and effective charging
More informationSimplified Check Program for Charging Systems
SB-3 Battery Load Tester Instruction Manual Simplified Check Program for Charging Systems The SB-3 is a variable load battery tester that provides a simplified check for the alternator and starter. CONGRATULATIONS
More informationCELLS AND BATTERIES Understand the general features of cells and batteries Describe the relationship between cells and batteries. Describe the basic
Cell & Batteries CELLS AND BATTERIES Understand the general features of cells and batteries Describe the relationship between cells and batteries. Describe the basic operation of a battery. Compare between
More informationStarting and Charging System Principles
C H A P T E R 1 9 Starting and Charging System Principles Chapter Objectives At the conclusion of this chapter you should be able to: Identify battery ratings and battery types. Identify battery service
More informationSTARTING & CHARGING SYSTEM SECTIONSC CONTENTS IDX
STARTING & CHARGING SYSTEM SECTIONSC GI MA EM LC EC CONTENTS FE PRECAUTIONS...2 Supplemental Restraint System (SRS) AIR BAG and SEAT BELT PRE-TENSIONER...2 Wiring Diagrams and Trouble Diagnosis...2 BATTERY...3
More informationThis chapter contains information on DC Generation, External Power, and Electrical Load Distribution.
CIRRUS AIRPLANE MAINTENANCE MANUAL Electrical Power CHAPTER 24-00: ELECTRICAL POWER GENERAL 24-00: ELECTRICAL POWER 1. General This chapter contains information on DC Generation, External Power, and Electrical
More informationSTARTING SYSTEMS 8B - 1 STARTING SYSTEMS CONTENTS
TJ STARTING SYSTEMS 8B - 1 STARTING SYSTEMS CONTENTS page DESCRIPTION AND OPERATION STARTER MOTOR... 2 STARTER RELAY... 3 STARTING SYSTEM... 1 DIAGNOSIS AND TESTING STARTER MOTOR... 8 STARTER MOTOR NOISE
More information2013 Edge, MKX Workshop Manual
7. Remove the 3 bolts and the generator. Installation 1. Position the generator and hand tighten the 3 bolts. Tighten in the sequence shown. Tighten to 25 Nm (18 lb-ft). 2. Connect the generator electrical
More informationAl-Saudia Virtual Academy Online Tuition Pakistan Pakistan Online Tutor Magnet and Electromagnetism
Al-Saudia Virtual Academy Online Tuition Pakistan Pakistan Online Tutor Magnet and Electromagnetism DEFINITION: A substance having ability to attract magnetic materials is called magnet. The properties
More information2006 MINI Cooper S GENINFO Battery - Overview - MINI
2002-07 GENINFO Battery - Overview - MINI MINI BATTERY MINI BATTERY Purpose of the Automotive Battery The battery is the primary Electromotive Force (EMF) source in the automobile. In addition the battery
More informationScience 30 Unit C Electromagnetic Energy
Science 30 Unit C Electromagnetic Energy Outcome 1: Students will explain field theory and analyze its applications in technologies used to produce, transmit and transform electrical energy. Specific Outcome
More informationSTARTING/CHARGING SYSTEMS Brought to you by Eris Studios NOT FOR RESALE
STARTING/CHARGING SYSTEMS General Description 1. General Description A: SPECIFICATION Vehicle model Starter Generator Item Specification Type Reduction type Model 428000-5760 Manufacturer DENSO Voltage
More information24-00 ELECTRICAL POWER
ELECTRICAL POWER 1. GENERAL This chapter contains information on DC Generation, External Power, and Electrical Load Distribution. The airplane is equipped with a two-alternator, two-battery, 28-volt direct
More informationHow is lightning similar to getting an electric shock when you reach for a metal door knob?
How is lightning similar to getting an electric shock when you reach for a metal door knob? Electricity Electric charges are from protons, which are positive (+) and electrons, which are negative (-).
More information2006 MINI Cooper S GENINFO Starting - Overview - MINI
MINI STARTING SYSTEM * PLEASE READ THIS FIRST * 2002-07 GENINFO Starting - Overview - MINI For information on starter removal and installation, see the following articles. For Cooper, see STARTER WITH
More informationable of Contents Sr. No: Content Page No: 1. A: Apply Safety Precautions and Guidelines at Workplace 5 2. B:Repair Lighting System of Vehicle 6
able of Contents Sr. No: Content Page No: 1. A: Apply Safety Precautions and Guidelines at Workplace 5 2. B:Repair Lighting System of Vehicle 6 3. C:TestBattery Performance 9 4. D: Install and Repair Starting
More informationElectromagnets & Induction Vocabulary
Electromagnets & Induction Vocabulary Term Definition Coil Solenoid Electric Motor Parts of an electric motor: Rotor commutator armature brushes Electromagnetic Induction Faraday s Law of Induction Generator
More informationMODEL 6010A 6 12 VOLT BATTERY CHARGER ASSOCIATE
MODEL 600A 6 VOLT BATTERY CHARGER ASSOCIATE IMPORTANT SAFETY INSTRUCTIONS. SAVE THESE INSTRUCTIONS. This manual contains important safety and operating instructions for the battery charger you have purchased.
More informationEnergy Power and Transportation Final Exam
Class: Date: Energy Power and Transportation Final Exam Multiple Choice Identify the choice that best completes the statement or answers the question. 1. Technician A says a 12-volt light bulb has a resistance
More informationBattery Tester. GxT Incorporated, Cheboygan MI, U.S.A. All Rights Reserved E040-01G. 40 & 42HD Operator s Manual
Battery Tester GxT Incorporated, Cheboygan MI, U.S.A. All Rights Reserved E040-01G 40 & 42HD Operator s Manual SPECIFICATIONS Measurement Range...Ferret 40... Ferret 42HD Battery Volts... 4.0 to 19.99...
More informationSTARTING SYSTEM (1ZZ FE) (April, 2003)
STARTING & CHARGING STARTING SYSTEM (1ZZ FE) (April, 2003) STARTING SYSTEM (1ZZ FE) (April, 2003) INSPECTION 19 1 190QO 02 1. INSPECT STARTER ASSY NOTICE: These tests must be performed within 3 to 5 seconds
More informationIT 0335 US ARMY INTELLIGENCE CENTER INTRODUCTION TO CELLS AND BATTERIES
SUBCOURSE IT 0335 EDITION B US ARMY INTELLIGENCE CENTER INTRODUCTION TO CELLS AND BATTERIES INTRODUCTION TO CELLS AND BATTERIES Subcourse Number IT0335 EDITION B US ARMY INTELLIGENCE CENTER FORT HUACHUCA,
More informationDESCRIPTION & OPERATION
STARTER - REDUCTION GEAR 1997 STARTING & CHARGING SYSTEMS Mazda - Starters - Reduction Gear DESCRIPTION & OPERATION Reduction gear starter is a conventional 12-volt, 4-pole, brush-type starter. The integral
More informationIT 0335 US ARMY INTELLIGENCE CENTER INTRODUCTION TO CELLS AND BATTERIES
SUBCOURSE IT 0335 EDITION B US ARMY INTELLIGENCE CENTER INTRODUCTION TO CELLS AND BATTERIES INTRODUCTION TO CELLS AND BATTERIES Subcourse Number IT0335 EDITION B US ARMY INTELLIGENCE CENTER FORT HUACHUCA,
More informationParts of an atom. Protons (P + ) Electrons (e - ) Neutrons. Have a positive electric charge. Have a negative electric charge
Electricity Parts of an atom Protons (P + ) Have a positive electric charge Electrons (e - ) Have a negative electric charge Neutrons Are neutral Have no charge Electric Charge In most atoms, the charges
More information1 of 16 1/10/2015 7:25 AM STARTER MOTOR 2009 Hyundai Accent 1.6L Eng GS REQUESTED INFORMATION DISASSEMBLY 1. Disconnect the M-terminal (A) on the magnet switch assembly (B). Fig 1: Identifying M-Terminal
More informationElectricity and Magnetism. Module 6
Electricity and Magnetism Module 6 What is electricity? The collection or flow of electrons in the form of an electric charge What is static electricity? When two objects rub against each other electrons
More informationCHARGING SYSTEM 7.7 GENERAL TROUBLESHOOTING. Alternator. Voltage Regulator. Battery. Wiring. Voltage Regulator Inspection HOME
CHARGING SYSTEM 7.7 GENERAL 8740 The charging system consists of the alternator and regulator. Charging system circuits are shown in Figure 7-5. Never install accessory wiring between battery post and
More information2008 Toyota RAV ELECTRICAL Charging (2AZ-FE) - RAV4
2008 ELECTRICAL Charging (2AZ-FE) - RAV4 CHARGING SYSTEM PRECAUTION 1. Check that the battery cables are connected to the correct terminals. 2. Disconnect the battery cables if a quick charge is given
More informationAUT 125 ELECTRICAL II CH 54 & 55 CHARGING SYSTEMS
Name: Class: Date: AUT 125 ELECTRICAL II CH 54 & 55 CHARGING SYSTEMS Multiple Choice Identify the choice that best completes the statement or answers the question. 1. Technician A says that the diodes
More information1993 ELECTRICAL Volkswagen Starters - Bosch. Volkswagen; Cabriolet, EuroVan, Golf, GTI, Jetta
Article Text ARTICLE BEGINNING 1993 ELECTRICAL Volkswagen Starters - Bosch Volkswagen; Cabriolet, EuroVan, Golf, GTI, Jetta DESCRIPTION Starter is a brush type, series-wound electric motor with an overrunning
More informationChapter 3. Direct Current Power. MElec-Ch3-1
Chapter 3 Direct Current Power MElec-Ch3-1 Overview Batteries Safety Precautions Marine Storage Battery Charging Systems Battery Utilization MElec-Ch3-2 Batteries Cells and Battery Battery Chemistry Primary
More informationTHE ALT AL ERNA RN T A OR
THE ALTERNATOR Initial Voltage of the Battery (Engine Not Running) Charging Voltage for the Battery (Engine Running) Testing for Maximum Output of the Alternator Inspecting the Regulator Positive Side
More informationThe Electromagnet. Electromagnetism
The Electromagnet When you have completed this exercise, you will be able to explain the operation of an electromagnet by using a coil of wire. You will verify your results with a compass and an iron nail.
More informationChapter 8 Magnetism and Its Uses. Section 1: Magnetism Section 2: Electricity and Magnetism Section 3: Producing Electric Current
Chapter 8 Magnetism and Its Uses Section 1: Magnetism Section 2: Electricity and Magnetism Section 3: Producing Electric Current Section 1: Magnetism Standard 6: Demonstrate an understanding of the nature,
More informationBATTERIES. Contents PRODUCT INFORMATION
PRODUCT INFORMATION 2017 BATTERIES Contents Battery Specification Chart...P-2 P-4 BCI/DIN/EN Reference Chart...P-5 Group Size Dimensions...P-6 Product Features... P-7 P-12 Glossary...P-13 P-14 Battery
More informationUnit 32 Three-Phase Alternators
Unit 32 Three-Phase Alternators Objectives: Discuss the operation of a three-phase alternator. Explain the effect of rotation speed on frequency. Explain the effect of field excitation on output voltage.
More informationThe Effects of Cold on Batteries. and what to do about it
The Effects of Cold on Batteries and what to do about it House Cleaning REMINDER: This Webinar is being Recorded Please Turn Off Cell Phones About the Presenter Charley Gipe Sales & Service Engineer Charley
More information2001 Cougar Workshop Manual
Page 1 of 7 SECTION 303-06: Starting System 2001 Cougar Workshop Manual DIAGNOSIS AND TESTING Procedure revision date: 09/14/2001 Starting System Refer to Wiring Diagrams Section 303-06 for schematic and
More informationIntroduction of Diesel Electrical and Electronic Systems
CDX Diesel Electrical and Electronic Systems Introduction of Diesel Electrical and Electronic Systems ÂÂ Basic Electrical Principles Basic Electronic Principles Sources of Electricity Effects of Electricity
More informationBBT-205. For 12-volt automotive starting batteries and starting/charging systems INSTRUCTION MANUAL
For 12-volt automotive starting batteries and starting/charging systems INSTRUCTION MANUAL Blank page Contents Registering Your tester... 5 Caution... 6 Capabilities... 6 Display and Keypad... 6 Preparations
More informationAutomatic taper of charge rate for superior battery life through good equalization of cells and low water use rate.
FEATURES Automatic taper of charge rate for superior battery life through good equalization of cells and low water use rate. Silicon diodes with inherent surge protection operated at a conservative percentage
More informationCh. 3 Magnetism and Electromagnetism
Ch. 3 Magnetism and Electromagnetism Multiple Choice Identify the choice that best completes the statement or answers the question. 1. Magnetic field lines around a bar magnet a. are only perpendicular
More information2/10/50 AMP 12 VOLT BATTERY CHARGER/ ENGINE STARTER
2/10/50 AMP 12 VOLT BATTERY CHARGER/ ENGINE STARTER WARNING This product contains or, when used, produces a chemical known to the State of California to cause cancer and birth defects or other reproductive
More informationWhat is represented by this BrainBat?
What is represented by this BrainBat? What is represented by this BrainBat? Hint: Say what you see. What is represented by this BrainBat? Hint: Say what you see. Answer: Octopi Electricity and Magnetism
More informationTRADE OF HEAVY VEHICLE MECHANIC
TRADE OF HEAVY VEHICLE MECHANIC PHASE 2 Module 2 Basic Electricity/Batteries UNIT: 3 Table of Contents 1. Learning Outcome... 1 1.1 Key Learning Points... 1 2.0 Lead-acid battery... 2 2.1 Function of the
More informationCHARGING SYSTEM CHARGING SYSTEM CH 1
CH1 CH2 Precautions PRECAUTIONS 1. Check that the battery cables are connected to the correct terminals. 2. Disconnect the battery cables when the battery is given a quick charge. 3. Do not perform tests
More informationPeriod 16 Activity Sheet: Motors and Generators
Name Section Period 16 Activity Sheet: Motors and Generators Activity 16.1: How Are Electric Motors and Generators Related? a) Generators. 1) Attach a hand-cranked generator to a small motor and turn the
More informationStarting Systems. State a major safety precaution when removing or working around a starting motor
Starting Systems State a major safety precaution when removing or working around a starting motor Always unhook the battery ground before attempting to remove the starter motor. Starting Systems Identify
More information1994 Mazda MX-5 Miata. STARTER - REDUCTION GEAR 1994 ELECTRICAL Mazda Starter - Reduction Gear
DESCRIPTION STARTER - REDUCTION GEAR 1994 ELECTRICAL Mazda Starter - Reduction Gear The Nippondenso reduction gear starter is a conventional 12-volt, 4-pole, brush-type starter. The integral solenoid is
More information2017 NEC Electrical Review RV
PLEASE DO NOT BOOKMARK ANY ANYTIMECE WEBPAGES! Our system will remember the last page you viewed when logging out and back in but please DO NOT exit out when taking a test. Your place will NOT be saved.
More informationCharging Systems. ATASA 5 th. ATASA 5 TH Study Guide Chapter 19 Pages Charging Systems 42 Points. Please Read The Summary
ATASA 5 TH Study Guide Chapter 19 Pages 571 595 42 Points Please Read The Summary 1. The primary purpose of the charging system is to the battery with a constant and relatively low charge after it has
More informationCongratulations. on your purchase from Trojan Battery Company, the manufacturer of the
U S E R S G U I D E Congratulations on your purchase from Trojan Battery Company, the manufacturer of the world s most trusted deep-cycle batteries. The battery you purchased was engineered by Trojan to
More informationWORKSHOP MANUAL ELECTRICITY
WORKSHOP MANUAL ELECTRICITY GB reference : 754282 DC/ATR 04/2000 1. Electric units:...2 2. Key formulae to remember:...2 3. Definitions:...3 4. Elements:...4 Resistances:...4 Lights:...5 Condensers:...5
More informationC.E. Niehoff & Co. N1601, N1602, N1603, and N1604 Alternator Troubleshooting Guide NOTICE. Hazard Definitions. Battery Charge Volt and Amp Values
C.E. Niehoff & Co. N1601, N1602, N1603, and N1604 Alternator Troubleshooting Guide Hazard Definitions These terms are used to bring attention to presence of hazard(s) of various risk levels or to important
More informationMAINTENANCE-FREE BATTERY CONSTRUCTION
MAINTENANCE-FREE BATTERY CONSTRUCTION INTRODUCTION A battery is formed when two chemically dissimilar plates, divided by a separator, are placed in a solution called electrolyte. In all automotive type
More informationATD Amp Carbon Pile Battery Tester User s Manual WARNING
ATD-5489 500 Amp Carbon Pile Battery Tester User s Manual WARNING Failur e to follow instructions may cause damage or explosion, always shield eyes. Read entire instruction manual before use. Warning:
More informationQuality Test Equipment Since 1957 OPERATOR S MANUAL
Quality Test Equipment ince 1957 OPERATOR MANUAL Congratulations! On your new purchase of Auto Meter s Charging/tarting ystem Analyzer. It is designed to test each component of a vehicle s electrical system
More informationWhich one? All are capable of doing the job
TM9-4910-509-10 Which one? All are capable of doing the job Now is the time to get it off the shelf and get acquainted with it. The LVCT can make you a topnotch vehicle electrical troubleshooter It s a
More informationSTARTING & CHARGING SYSTEM
K ELECTRICAL SECTION SC A STARTING & CHARGING SYSTEM B C D CONTENTS E PRECAUTIONS... 2 Precautions for Supplemental Restraint System (SRS) AIR BAG and SEAT BELT PRE-TEN- SIONER... 2 Precautions for Power
More informationSTARTER Mitsubishi Montero DESCRIPTION BENCH TESTING STARTER NO-LOAD TEST ELECTRICAL Mitsubishi Starters. Montero
STARTER 1993 Mitsubishi Montero 1993 ELECTRICAL Mitsubishi Starters Montero DESCRIPTION The starter is a conventional 12-volt, 4-pole brush-type motor, with gear reduction drive. The starter-mounted solenoid
More information2000 F-150 Workshop Manual
Page 1 of 14 SECTION 303-06: Starting System 2000 F-150 Workshop Manual DIAGNOSIS AND TESTING Procedure revision date: 06/17/1999 Starting System Refer to Wiring Diagrams Cell 20, Starting System for schematic
More informationHEAVY EQUIPMENT SERVICES MÉCANIQUE DE MACHINERIE LOURDE POST-SECONDARY NIVEAU POSTSECONDAIRE
TEST PROJECT 5 OF 6 PROJET D ÉPREUVE 5 DE 6 HEAVY EQUIPMENT SERVICES MÉCANIQUE DE MACHINERIE LOURDE POST-SECONDARY NIVEAU POSTSECONDAIRE Electrical System (5 of 6) TASK Competitor number Judge s name Start
More informationSTARTER - HITACHI Isuzu Trooper II DESCRIPTION TESTING STARTER PERFORMANCE TESTS Starters HITACHI. Isuzu
STARTER - HITACHI 1986 Trooper II 1984 Starters HITACHI DESCRIPTION Starter is a conventional 12-volt, 4-pole brush-type motor, with direct or reduction gear drive. The starter-mounted solenoid shifts
More informationIntroduction: Electromagnetism:
This model of both an AC and DC electric motor is easy to assemble and disassemble. The model can also be used to demonstrate both permanent and electromagnetic motors. Everything comes packed in its own
More informationJust what is a starter?
Just what is a starter? The car starter works by harnessing the power of the automotive battery. The battery supplies electricity to the starter to engage and spin over the engine. Once the ignition key
More informationCURRENT ELECTRICITY - II
SALIENT FEATURES Faraday s laws of electrolysis Magnetic effects of electricity Electro magnetic induction CURRENT ELECTRICITY - II FARADAY S LAWS OF ELECTROYLYSIS ELECTROLYSIS The process of decomposition
More information