> < > < COMMERCIAL HIGH SPEED DIESEL ENGINES MARINE PRODUCT HANDBOOK. 78 mhp [57.4 kw] to 1822 mhp [1340 kw]

Transcription

1 PRODUCT HANDBOOK COMMERCIAL HIGH SPEED S 78 mhp [57.4 ] to 1822 mhp [134 ] > < Head Office Yanmar Co., Ltd. YANMAR FLYING-Y BUILDING, 1-32 Chayamachi, Kita-ku, Osaka, Japan, Regional Office / Sales & Service Yanmar Europe B.V. Brugplein 11, 1332 BS Almere, The Netherlands T +31 () F +31 () > < > < EN-CHSMPH-115 Call for Yanmar solutions

2 Harmony with the Environment IMO Emission Limits Reliability, Economical efficiency & Comfort for customers dedicated to maritime activity. The pollution of the atmosphere by hazardous substances released from marine diesel engines has become a major global issue. The release of hazardous substances into the atmosphere by ships is regulated by the International Convention for the Prevention of Pollution from Ships (MARPOL 73/78). Annex VI: Prevention of Air Pollution from Ships was later passed in September As a result, the regulation of NOx emission levels began for marine diesel engines with a power of above 13 on vessels built on or after January 1,2. A further amendment was passed in October, 28 and engines mounted in vessels built on or after January 1,211 face even stricter Tier II regulations. Technological solutions have been developed to overcome these regulatory challenges including engine technologies, supplementary technologies and post processing technologies. YANMAR is addressing the stricter IMO Tier II regulation NOx limits with improvements to combustion technologies of engine. Our pride is to contribute to tough and valuable activities of customers on the sea. NOx Regulated Value ( g/h ) IMO NOx Emission Limits 18 IMO TierI IMO TierII ( Year 211) IMO TierIII ( Year 216 Emission Control Areas ) Engine Speed ( min -1 ) [ 2 ] [ 3 ]

3 Global Hub Factory for Marine Diesel Engines Marine Operations Division Certified by the six major classification societies. LRS ABS NK BV RINA KR Rating definitions: hp=.7355 Ratings are based on conditions of 1kPa, 3% relative humidity at 25C. S = For applications where use of rated power is less than 3 minutes continuous out of every 9 minutes and operation is less than 1 hours per year. When combined with a correctly matched propeller which allows the engine rated rpm to be achieved in a fully loaded vessel state, the reduced-power. operation. can be at or below 5-1 rpm of the rated speed. L = For applications where use of rated power is less than 2 hours continuous out of every 5 hours and operation is less than 2 hours per year. When combined with a correctly matched propeller which allows the engine rated rpm to be achieved in a fully loaded vessel state, the reduced-power operation can be at or below 5-1 rpm of the rated speed. M = For applications where use of rated power is less than 1 hours continuous out of every 16 hours and operation is less than 3 hours per year. When combined with a correctly matched propeller which allows the engine rated rpm to be achieved in a fully loaded vessel state, the reduced-power operation can be at or below 5-1 rpm of the rated speed. H = For applications where use of rated power is less than 24hours continuous out of every 3 hours and operation is less than 4 hours per year. When combined with a correctly matched propeller which allows the engine rated rpm to be achieved in a fully loaded vessel state, the reduced-power operation can be at or below 5-1 rpm of the rated speed. * Please ask Yanmar or local distributor for the detail of each model. Fuel rates: Specific gravity.835g/cc, low calorific value 427kj/kg (12kcal/kg), Cetane No.45. Note : All Data Subject to Change Without Notice. Photograph may show optional equipment.

4 4CHE36CHE3 ML-rating 57.4~95.6 (78~13mhp) Dimensions C E B F G H I iinjectionhangeooling. Naturspirated4-cylinder. urahydraulimaringear. C E A Model Combu Aspiration Sizehousingand W mm lit. mm Natuted Hydraulic Model Type B F G H I Model (Maximum) (Cubic Curve) Specific Fuel Consumption (Cubic Curve) A B C E (Maximum) F G (Cubic Curve) Specific Fuel Consumption (Cubic Curve) H I 51 55

5 6CH-HTE3/WUTE ML-rating 125~26 (17~28mhp) Dimensions ireinjectiohechangeooling. Turbochargerintercooler. uradrauliarigear. CH-WUTEconfortIMr issiogulations. C E A Model B F G lit. H I u YX-71 YX-71 A B 1111 C E F G H I Sizeofhousingand W 1111 Model YX-71 ern (Maximum) (Cubic Curve) Specific Fuel Consumption (Cubic Curve) (Maximum) (Cubic Curve) Specific Fuel Consumption (Cubic Curve)

6 6CXBM-GT H-rating 265 (36mhp) M-rating 294 (4mhp) Dimensions k W Fuel consumption Power of crank shaft k W Fuel consumption Power of crank shaft

7 6CXBM-GT L-rating 341 (464mhp) S-rating 374 (59mhp) (For planing hull) Dimensions Fuel consumption Fuel consumption k W Power of crank shaft k W Power of crank shaft

8 6HA2M-WHT H-rating 24 (278mhp) Dimensions Fuel Consumption Propeller cubic curve Propeller cubic curve

9 6HA2M-WHT M-rating 257 (35mhp) Dimensions Fuel Consumption Propeller cubic curve Propeller cubic curve

10 6HA2M-WDT M-rating 298 (45mhp) Dimensions Fuel Consumption Propeller cubic curve Propeller cubic curve

11 6HYM-WET H-rating 368 (5mhp) Dimensions Fuel Consumption Propeller cubic curve Propeller cubic curve

12 6HYM-WET M-rating 441 (6mhp) L-rating 478 (65mhp) Dimensions Fuel Consumption Propeller cubic curve Propeller cubic curve Fuel Consumption Propeller power curve 1 (2.5 exponent) Propeller power curve (2.5 exponent)

13 6HYM-WET S-rating 515 (7mhp) (For planing hull) Dimensions Unit:mm No.6 No cylinder, direct injection, heat exchanger cooling. Twin-turbocharger + intercooler. ailable either with marine gear or without marine gear. 4-aler cylinder for higher combution efficiency. Conform to IMO Tier ll eiogulatio Model 6HYM-WET S-rating Bore mm 6 in-line lit Combu Direct injection Turbocharger + intercooler (24V 6.W) Heat exchanger Fuel Consumption 15 3 Size of flywheel and flywheel 1385(without marine gear) (LWH) mm Propeller power curve (2.5 exponent) Engine model : 6HYM-WET S-rating Model YXH Reduction ratio Direction of rotation Dry weight Propeller power curve 1 (2.5 exponent) [ 24 ] [ 25 ]

14 6AYM-WST H-rating 485 (659mhp) Dimensions Fuel Consumption MAXIMUM POWER LINE 4 3 Propeller curve

15 6AYM-WET H-rating 555 (755mhp) Dimensions Fuel Consumption MAXIMUM POWER LINE Propeller curve

16 6AYM-WET M-rating 61 (829mhp) Dimensions Fuel Consumption MAXIMUM POWER LINE Propeller curve

17 6AYM-WGT L-rating 67 (911mhp) Dimensions Fuel Consumption MAXIMUM POWER LINE Propeller curve

18 12AYM-WST H-rating 882 (12mhp) H-rating 13 (14mhp) Dimensions Fuel consumption 4 3 Fuel consumption Propeller power curve Propeller power curve

19 12AYM-WET H-rating 114 (155mhp) M-rating 122 (1659mhp) Dimensions Fuel consumption 4 3 Fuel consumption Propeller power curve 3 Propeller power curve

20 12AYM-WGT L-rating 134 (1822mhp) Dimensions Fuel Consumption Propeller power curve

21 Notes JH series (Life Boat Engines) 18.4~24.3 (25~33mhp) AUXILIARY Dimensions Operating Condition : 1.Operating hours per year, 4. 2.Over load operation, 11/1 load of continuous rating power, (Within 1 hour by 12 hours). 3. Low load operation(against cont. rating power), 1/4(AYL:1/3) load or above, Allowable continuous operation. 1/8 to 1/4(AYL:1/6 to 1/3) load, Within 5(CHL:4) hours. 1/8(AYL:1/6) load or below, Within.5 hours. After running at 1/4(AYL:1/3) load or below, Shall be operated.5 hours or above at 1/2 load or above. Note : All Data Subject to Change Without Notice. Photograph may show optional equipment.

22 4CHL series 38~74hp / 15~18rpm 3~6kVA (24~48) AUXILIARY Dimensions Generator set dimensions for your reference

23 6CHL series 62~145hp / 15~18rpm 5~12 kva (4~96) AUXILIARY Dimensions Generator set dimensions for your reference

24 4HAL2 series 98~183hp / 12~18rpm 8~15kVA (64~12) AUXILIARY Dimensions Generator set dimensions for your reference

25 6HAL2 series 122~414hp / 12~18rpm 1~35kVA (8~28) AUXILIARY Dimensions Generator set dimensions for your reference

26 AUXILIARY 6AYL series 48~668hp /15~18rpm 4~562.5kVA (32~45) Dimensions Generator set dimensions for your reference

27 Notes Notes [ 52 ] [ 53 ]

28 Notes YANMAR CO., LTD. Head Office Umeda Gate Tower, 1-9, Tsurunocho, Kita-ku, Osaka, , Japan YANMAR ENGINE (SHANGHAI) CO., LTD. 1F, E-Block POLY PLAZA, No.18 Dongfanf Road, Pudong Shanghai, China P.R.C 212 Tel : Fax : / YANMAR ASIA (SINGAPORE) CORP. PTE. LTD. 4 Tuas Lane, Singapore Tel : Fax : YANMAR EUROPE B.V. Brugplein 11, 1332 BS Almere-de Vaart, The Netherlands Tel : Fax : YANMAR AMERICA CORP. HEAD OFFICE 11 International Parkway, Adairsville, GA 313, U.S.A. Tel : Fax : YANMAR SOUTH AMERICA INDUSTRIA DE MAQUINAS LTDA. Av. Presidente Vargas 14, Indaiatuba, S.P. CEP: , Brazil Tel : Fax : / 2241 [ 54 ] [ 55 ]