YTH200 Twin. Spare parts Ersatzteile Pièces détachées Reserve onderdelen Repuestos Reservdelar SERVICE. IPL, YTH200 Twin, ,

Transcription

1 SERVICE IPL, YTH00 Twin, 007-0, YTH00 Twin Spare parts Ersatzteile Pièces détachées Reserve onderdelen Repuestos Reservdelar

2 ILLUSTRATED PARTS LIST MODEL NO CUSTOMER CATALOG NO. YTH00 TWIN PRODUCT NO Rev SR

3 DECALS Decal, Warning Syms. CE Decal, Warning Deflect Cutfinger Decal, Warning Eng. Syms Decal, Saddle Brake Parking Decal, Oper. Cruise Sym Decal, Mower Sch Decal, Battery Dan./Poi Decal, Brake/Clutch Sym Decal, Chassis Hot Muffler Decal, Cutfinger CE Decal, Panel Side Decal, Fender DB/CE Decal, Hood Logo Decal, Cutfinger Decal, Replacement Decal, Drawbar Load Limit Decal, Bypass Pad, Footrest, LH Pad, Footrest, RH Manual,Operator's Euro WHEELS AND TIRES Cap, Valve, Tire Stem, Valve Rim Assembly, Front Tube, Front (Ser vice Item Only) Tire, Front Fitting, Grease (Front Wheel Only) Bearing, Flange (Front Wheel Only) Cap, Axle (Front Wheel Only) Tire, Rear Tube, Rear (Service Item Only) Rim Assembly, Rear Sealant, Tire (0 oz. Tube) wheel_art_-vgt NOTE: All component dimensions given in U.S. inches inch = 5.4 mm

4 SCHEMATIC 38 SCH3 A AMMETER (OPTIONAL) RED FUSE BATTERY RED SOLENOID STARTER M WHITE PTO SWITCH (DISENGAGED) WHITE ELECTRIC CLUTCH S B M A G L A BLUE C A H D WHITE RED CLUTCH/BRAKE (PEDAL UP) GRAY B E REVERSE SWITCH (NOT IN REVERSE) 3 SEAT SWITCH (NOT OCCUPIED) A RELAY BLUE A /WHITE 6 JUNCTION CONNECTOR CHASSIS HARNESS GRAY SHORTING CONNECTOR C B A F E D H G BLUE IGNITION UNIT (OPTIONAL) HOUR METER SPARK PLUGS GAP ( PLUGS ON TWIN CYL. ENGINES) PTO SWITCH (MATING SIDE) BLUE FUEL LINE BLUE V POWER OUTLET (OPTIONAL) NOTES ORANGE FUEL SHUT-OFF SOLENOID (IF EQUIPPED) RED CHARGING SYSTEM OUTPUT 9-5 AMP 3600 RPM REGULATOR STATOR 8 VOLTS 3600 RPM (REGULATOR DISCONNECTED) BROWN LIGHT SWITCH HEADLIGHTS IGNITION SWITCH POSITION CIRCUIT MAKE OFF RUN/OVERRIDE RUN M+G+A B+A B+A L+A START B+S+A 3 CHASSIS HARNESS CONNECTOR (MATING SIDE) DASH HARNESS CONNECTOR WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE RE-INSTALLED TO PROPERLY SECURE YOUR WIRING. NON-REMOVABLE CONNECTIONS REMOVABLE CONNECTIONS 3

5 ELECTRICAL 3 T0S With V Outlet Option With Service Minder Option

6 ELECTRICAL Battery Bolt Hex Hd. /4-0 unc x 3/ Battery Box Switch Interlock Harness Socket Light Bulb, Light # Cable Battery Cable Starter Fuse Nut Keps Hex /4-0 unc Cable Ground " Blk. 6 Ga Switch Seat Switch Ignition Key/Chain Switch Light/Reset Harness Ignition Dash Screw Thd. Cut /4-0 x / Cover Terminal Red Solenoid Gauge Hourmeter Switch PTO Screw Thdrol. 5/6-8 x 3/ Harness Chassis Socket Asm. Bulb Twistlock Relay Harness Cover Terminal Battery Strap Battery Screw Hex Wsh. Thdrol. /4-0 x 3/ Washer 9/3 x 7/8 x 6 Ga Pigtail Harness Pigtail Switch reverse NOTE: All component dimensions given in U.S. inches inch = 5.4 mm 5

7 CHASSIS AND ENCLOSURES chassis-tex_gt Husq_4_r

8 CHASSIS AND ENCLOSURES Drawbar Lower Logo Dash Hood Lens LH Grille/Lens Asm Lens RH Plate Engine Screw 5/6-8 x 3/ Fender Nut Lock 5/ Drawbar Upper Screw Thdrol. 5/6-8 x / Screw 0 x 3/4 Single Lead-Hex Bumper Dash Air Duct Shield Browning Screw 3/8-6 x 3/ Console Fuel Window Screw Support Tank Rear Crossmember Screw 0-4 x 5/ Bushing Steering Cargo Net Asm Chassis Bushing Mtg. Fender Crgo Dash Lower Bolt Fin. Hex 5/6-8 unc x -/ Screw 5/6-8 x 3/ Nut Lock Hex Flange 5/ Plug Hole Dash Lower Console Asm. Deck Lift Plate Deck Lift Vent Side Hood RH Vent Side Hood LH Vent Top Hood Skirt Hood Side RH Skirt Hood Side LH Bezel RH Bezel LH Insert Hex Top RH Insert Hex Top LH Insert Hex Bottom RH Insert Hex Bottom LH Bolt 5/6-8 x 3/ Clip Retainer Tinner Rod Pivot X-Piece Hood Stop Reflector LH Stud Fastner Bolt Shoulder 5/ Bumper Hood Spacer Fender Nut Lock 5/6-8 unc Trim Nut, Push NOTE: All component dimensions given in U.S. inches inch = 5.4 mm 7

9 DRIVE drive-tex_k46_pedal_

10 DRIVE 40 NO. NO. DESCRIPTION Transaxle, TUFFTORQ K46 BT Key /4 x Washer 3/3 x 3/6 x 6 Ga Spring, Brake Spring Return Cruise Rod, Brake Ring E Rod, Brake, Park Cover, Foot Pedal Bolt Pulley Idler Flat Lock Nut 3/ Idler V-Groove 90" Offset V-Belt, Drive Shaft Asm. Pedal Brake Control Console Asm Bolt Hex Flghd. 5/6-8 x Gr Screw /4 x / Bracket Strap Torque Bolt Fin. Hex 5/6-8 unc x Rod Bypass Nut Lock Hex Flange 5/ Screw 5/6-8 x 3/ Screw 5/6-8 x / Retainer Spring Pin Cotter /8 x 3/ Retainer Clip Spring, Return, Clutch Rod Pedal Control Nut Push Latch Brake Parking Keeper Belt Centerspan NO. NO. DESCRIPTION Bolt Rdhd. Sqnk. 3/8-6 unc x Spacer Split Handle Parking Brake Bolt Rdhd. Sqnk. 3/8-6 x -/ Spacer Retainer Washer Link Clutch Ground Drive Bellcrank Ground Drive Keeper Bellcrank Ground Drive Screw 3/8-6 x Link Clutch Anti-Rotation Washer Bracket Mount Latch Cruise Latch Control Cruise Gear Sector Control Cruise Rod Control Cruise Rocker Asm. Pedal Control Bearing Nylon Knob Control Cruise Pedal Forward Pedal Reverse Bracket Pulley Idler Reflector RH Retainer Spring Clip Handle Washer /3 x -/4 x 0 Ga Keeper Belt Trans Bracket Mount Touque Washer Hardened NOTE: All component dimensions given in U.S. inches inch = 5.4 mm 9

11 ENGINE SPARK ARRESTER KIT engine-tex_6-kohl

12 ENGINE Engine Kohler Model No. SV Muffler Keeper Belt Engine Clutch Electric Pulley Engine Tank Fuel Cap Asm Control Throttle Screw 0 x 3/4 Single Lead Hex Control Choke Fuel Line Spark Arrester Kit Clip Push-In Hinged Clamp Hose Washer -/ OD x 5/3 ID x Washer Lock 7/ Nut Keps Hex /4-0 unc Shield Heat Gasket Pipe Exhaust RH Pipe Exhaust LH Screw Socket Hd. 5/6-8 x Tube Drain Oil Easy Plug Drain Oil Screw 3/8-6 x Bolt Hex 7/6-0 x 4 x Gr Thr Bolt 5/6-8 unc x 3/4 w/sems Screw 3/8-6 x Bushing.375 OD Screw 5/6-8 x 3/ Shield Side LH Shield Side RH Screw Thdrol. /4-0 x 5/ Cover Asm. Eng. NOTE: All component dimensions given in U.S. inches inch = 5.4 mm

13 STEERING ASSEMBLY steering-tex_special_8_w8 53

14 STEERING ASSEMBLY Wheel, Steering Husq SR Axle Asm., Front Spindle Asm., LH Spindle Asm., RH Bearing, Race Thrust Harden Washer 5/3 x -5/8 x 6 Ga Ring, Clip #T Cap, Spindle Washer 5/3 x -/4 x 6 Ga Washer, Lock Hvy. Hlcl. Spr. 3/ Nut, Crown Lock 3/8-4 unf Shaft Steering Plate Steering Adapter, Wheel Steering Bushing, Strg. Blk Insert, Wheel Steering Husq SR Screw 3/8-6 x 3/ Gear, Sector Plate Washer 9/6 ID x -3/8 OD Ga Nut Hex Jam Toplock /-0 unf Washer Hardened.793 x.637 x Bracket Upstop Bolt Shoulder Sector Pivot CFM Washer Thrust Sector Steering Nut Flange Lock 5/ Draglink LH Draglink, RH Screw 5/6-8 x 3/ Retainer Clip Spring Steering Bolt Hex Fghd. 7/6-4 x 3 Serr Bushing PM Front Axle Nut Lock Flange 7/6-4 Gr Washer.5 x.505 x Bracket Deck Susp. Front Bushing Metal, Axle, Cast NOTE: All component dimensions given in U.S. inches inch = 5.4 mm 3

15 MOWER DECK 44 4

16 MOWER DECK Mower Housing Cover Mandrel RH Cover Mandrel LH Retainer Spring Arm Suspension Bolt/Washer Asm. 7/6-0 unf Blade Mower Shaft Assembly, Mandrel Housing, Mandrel Bearing, Ball, Mandrel Bolt, Shoulder Nut Bracket, Deflector Cap, Sleeve Spring, Torsion, Deflector Nut, Push Shield, Deflector Rod, Hinge Screw Thdrol. Rolling Wsh. Hd Washer, Spacer Pulley, Mandrel Nut, Toplock, Flanged Bolt Carr. Sh. 3/8-6 x -/ Gr Pulley, Idler, Flat Nut, Lock Flg. 3/8-6 unc Screw Arm, Idler Spacer, Retainer Screw Hex Wsh. Thd. 3/8-6 x Guard, Tuv. Idler (94) Bolt 3/8-6 unc x -/4 Gr V-Belt Bolt Bolt, Shoulder Wheel, Gauge Nut Lock 3/8-6 unc Washer 3/3 x -/4 x Ga Pulley Idler Spring Return Stud Fastener Nut Lock Hex Flange Washer 3/3 x x / Ga Washer 3/3 x 3/6 x Ga Baffle Center Front Baffle Front RH Screw 3/8-6 x / Mandrel Assembly (Includes housing, shaft assembly, and bearing only - pulley/nut/ washer and blade bolt/washers not included) Replacement Mower, Complete NOTE: All component dimensions given in U.S. inches inch = 5.4 mm 5

17 SEAT ASSEMBLY seat-tex_7-vgt Seat Bracket Pivot Fender Strap, Asm. Fender Nut, Lock w/ins. 3/8-6 unc Spring, Seat Cprsn Bolt 5/6-8 unc x 3/4 w/sems Pan, Seat Bolt, Shoulder 5/ Nut, Lock 5/6-8 unc Handle Slide Seat Spring Latch Seat Bolt Fin. Hex 3/8-6 unc x 3/ Washer 3/3 x -3/8 x Ga. NOTE: All component dimensions given in U.S. inches inch = 5.4 mm

18 MOWER LIFT * lift-tex_7_r *Key 9 may be substituted for Key Shaft Asm., Lift Lever Asm., Lift RH Grip, Lever Spring Torsion Pin Cotter 7/6 Bow Tie Lock Spring Lift Assist Washer Clear Zinc Pin Cotter 5/6 Bow Tie Lock Link Lift Susp. Mower Rear Screw 3/8-6 x.75 Smgml. Tap/R.Z Link Lift Susp. Front Mower Nut Lock 3/8-6 unc Link Asm Lift FXD NOTE: All component dimensions given in U.S. inches inch = 5.4 mm