AS440S56T/P ( CURSOR 13 EURO 4 / 5 )

Transcription

1 N. : DT TECHNICAL DESCRIPTION AS440S56T/P ( CURSOR 13 EURO 4 / 5 ) The information in this literature is intended to be of a general nature only. Iveco reserves the right to modify or change specification at any time. 1

2 ZF 1AS-530TO Wheelbase Cab Drive Vcb 3650 ACT. SPACE LEFT HAND DRIVE ZGGB1B1 ACT. SPACE RIGHT HAND DRIVE ZGGB1BA 3800 ACT. SPACE LEFT HAND DRIVE ZGGB3B1 ACT. SPACE RIGHT HAND DRIVE ZGGB3BA ZF 16S50 TO Wheelbase Cab Drive Vcb 3650 ACT. SPACE LEFT HAND DRIVE ZGGB1A1 ACT. SPACE RIGHT HAND DRIVE ZGGB1AA 3800 ACT. SPACE LEFT HAND DRIVE ZGGB3A1 ACT. SPACE RIGHT HAND DRIVE ZGGB3AA 7/05/006

3 DIMENSIONS (mm) (AU 180-D ACT. SPACE) A Wheelbase B Overall length C Front overhang D Rear overhang E Max cab width F Front axle to back of cab K Overall height to top of cab, unladen L Frame height at end of frame, unladen M Front track N Rear track P Minimum ground clearance ( Axle ) Turning radius wall to wall Turning radius kerb to kerb Frame height at front axle, unladen Frame height at rear axle, unladen /05/006

4 Weights (kg) (BU 1151-D ACT. SPACE) Wheelbase EEC - Design EEC - Design Plated weight on axle 1 EEC Plated weight on axle 1 - Design Plated weight on axle EEC Plated weight on axle - Design Max body & payload EEC Max body & payload - Design Semitrailer weight EEC Total vehicle kerbweight 1 Total vehicle kerbweight Tractor kerbweight /05/006

5 Engine F3B E3681A*P ( EU 007-D) Name Position Direction of engine Cycle Aspiration type CURSOR 13 - F3B FRONT VERTICAL DIESEL TC+AFTERCOOLER No. of cylinders 6 IN-LINE Fuel type 4 Stroke / Stroke cycle Total displacement cm³ DIESEL Bore / Stroke mm 135 / 150 Max power (1) 41 kw 560 HP 1900 rpm Max torque () 55 kgm 500 Nm rpm Power loss Dry weight kg Oil capacity kg Crankshaft supported by 0% up to Bearings 1500 m sea level Injection pump type Injection pump governor type Cooling system UNIT-INJECTOR EDC WATER Hydraulic steering pump Cold starting type Type of turbocharging Emissions according regulations THERMOSTARTER VGT Euro 4 (F3B E3681A*P) / Euro 5 (F3B E3681A*M as an option) 5 7/05/006

6 Engine F3B E3681A*P ( EU 007-D) The central electronic system controls the following functions:. Engine preheating, fuel preheating, VGT, injection control, engine brake, control of engine speed and torque, data exchange OBD with ScanTool, engine diagnostic (on- and off-board), control of blink-code and failure indicator light on dashboard, control of engine idling speed and max. engine speed, data exchange with VCM (vehicle control module), data exchange with DCU (Urea dosing module), supervision of emission values. Fuelling (ABU 0007-D) No. of tanks Material Total tank capacity l. Position on frame 1 ALUMINIUM 300 RIGHT SIDE Fuel pump Prefilter Filter Fuel separator Air intake (AC 0001-D) Filter type Snorkel position Air intake DRY BEHIND THE CAB ON THE LEFT WITH SNORKEL Cooling (AD AS001-D) Cooling system Fan type WATER ELECTROMAGNETIC Clutch 17'' (FU 000-D) Type Actuation Release control Adjustment SINGLE DRY PLATE PULL TYPE HYDRAULIC AUTOMATIC ZF 16S50 TO (GU 0069-D) Type Installation Control No. of gears (.+..reverse) Casing material opening SYNCHROMESH ENGINE FLANGED MANUAL DOUBLE H 16+ ALUMINIUM /05/006

7 Gear ratios 1st nd 3rd 4th 5th 6th 7th 8th 9th 10th 11th 1th 13th 14th 15th 16th Rev. 1st Rev. nd ZF 1AS-530TO (GU 0056-D) Type Installation Control No. of gears (.+..reverse) Casing material AUTOMATED ENGINE FLANGED ELECTR.-PNEUM. 1+ ALUMINIUM Gear ratios 1st nd 3rd 4th 5th 6th 7th 8th 9th 10th 11th 1th Rev. 1st Rev. nd /05/006

8 Front steering axle (LU 0001-D ) Identification Type Steering angle (ext.) Steering angle (int.) Axle material Axle construction Beam section 5876 RIGID 5 36 STEEL FORGED "I" Rear drive axle (MU 0065-D ) Identification Axle Wheel arrangement Reduction type MS13-175/D SINGLE TWIN SINGLE Differential lock Suspensions (NU 0336-D) Front steering axle Rear drive axle SINGLE RATE PARABOLIC SPRING AIR SPRING Frame lifting Main features Axle no. Air tank capacity 1 0 Bellow diameter (mm) 190 Leaf width (mm) 90 Main leaf spring length (mm) No. of main leaves spring No. of bellows Number of air tanks Number of levelling valves 4 1 ECAS Shock absorber (PU 000-D) Shock absorber no. (front) Shock absorber no. (rear) Shock absorber type HYDRAULIC TELESCOPIC 8 7/05/006

9 Anti-roll bars (OU 000-D) Position Type FRONT AND REAR AXLE TORSION BAR Wheels (QU 000-D) Wheel type Wheel material Wheel dimensions DISC STEEL.5" x 8.5" (RU 0010-D) Tyre dimensions Load-index Speed index Rolling radius mm Rolling circumference mm Axle 1 95/80 R.5 15/148 M = Mounting SINGLE TWIN Steering (KU 0009-D) Type Adjustment type Steering wheel diameter (mm) HYDRAULIC HEIGHT + STEERING WHEEL ANGLE 470 No of parts in steering column Chassis (mm) (JU 0097-D) Frame section Front crossmember fixing Middle crossmember fixing Rear crossmember fixing DOUBLE JOGGLE BOLTED RIVETED BOLTED Wheelbase Side member material Side member section Flange thickness Web thickness Upper flange width Lower flange width Side member max. height Frame width at rear 3650 STEEL "C" STEEL "C" Angles for the 5th wheel support plate fixing: 105 x 63 x 8 (mm) 9 7/05/006

10 Brakes (SU 016-D) Rear braking control Air dryer Auxiliary brake / Engine brake Emergency brake Parking brake Service brake Parking brake axle(s) Total tank capacity l. Air compressor displacement cm³ Air compressor Brake standards No. of circuits Number of air tanks DECOMPRESSION ENGINE BRAKE COMBINED WITH PARKING BRAKE MECHANICAL WITH SPRING CYLINDER AIR REAR DRIVE AXLE(S) SINGLE CYLINDER EEC 3 Axle no. Brake type No. of cylinders Brake cylinder diameter (sqin) Disk diameter (mm) Friction area cm² Axle 1 DISC Axle DISC Electrics (VU 0034-D) Voltage V Alternator power No. of batteries V/A 4 8/90 Battery voltage V 1 Battery capacity Ah Starter motor power kw MUX - Iveco Multiplex System for control of cab and vehicle functions Lighting (WU 0013-D) Type of lamps HALOGEN Front parking lights Rear lights Front side marker lights Reverse lights Hazard lights Number plate lights Front fog lights 10 7/05/006

11 Lighting (WU 0013-D) Rear fog light(s) Side lights Rear marker lights Stop lights Front direction indicators Side direction indicators Rear direction indicators Rear cab lighting Provision for front fog lights Cab ACT. SPACE (YU 00-D) Cab type Version Material No of steps Tilting device Tilt angle Roof hatch control system FORWARD CONTROL SLEEPER CAB (ACTIVE SPACE) STEEL PLATE 3 HYDRAULIC 60 ELECTRICAL Central lock Window operation (front) FULL ELECTRICAL Front fairing Side spoiler Roof spoiler Roof material STEEL, INTERNALLY COVERED WITH WASHABLE FABRIC Roof light Windscreen type Windscreen Windscreen according to standards: No. of windscreen wipers No. of windscreen wiper speeds Front suspension type Rear suspension type Rear view mirrors no. Mirror control LAMINATED ONE PIECE - CURVED EEC/USA AIR AIR 4 ELECTRIC Rear view mirror heating Kerbside approach mirror No. of places No. of seats Driver seat type Driver seat adjustment No. of fan speeds 1 1 AIR HEIGHT, LONGITUDINAL AND BACK INCLINATION /05/006

12 Cab ACT. SPACE (YU 00-D) Heating control MANUAL Lighter CB wiring Radio wiring Remarks: Athermic windows, doors with fabric carpeting, storage compartments, defrost system for door windows, arm rest; Corrosion protection, underseal and cavety sealing with wax. Driver's seat: Adjustable seat surface, adjustable lumbar support, head rest, seat belts, heated, velvet covering, "antidive". Roof panel: Prearrangement for revolving roof lamp Roof hatch (electrical control) with athermic glass and protection net. Floor: Flat floor, completely passable, carpet covered Removable mats. Interior equipment: Adjustable steering column (pneumatic control), storage compartments, parcel shelves in overhead console, parcel shelves on floor level, sun visor (electrical control), interior lights, 4 spotlights, thermo-box (isothermal box), side seats convertible to bunk. Interior equipment - prearrangement for: Aerial, passenger seat, rack, wall-mounted table, top bunk, bottom bunk, fridge, additional air heater, additional head lamps and fog lamps, horns, suit carrier, small safe, torch, satellite navigator. Central console: can holders, small storage compartment, central panel, adjustable air vents, illuminated ash-tray, parking brake. Exterior equipment: External storage box (on side wall) opened from inside (contents: towing hook, jack, warning triangle), front bumper with steps, mudguard, front grille, pre-arrangement for front towing hook (removable), side spoilers as splash protection, mudflaps, external engine starter (when cab is tilted) including safety device. In cab equipment (TU 0016-D) Warning lights High beam Direction indicators Direction indicators (trailer) Hazard lights External lights Low ranges Speed limiter Rear transversal differential lock Hand brake on ASR Brake failure Front brake wear Rear brake wear 1 7/05/006

13 Warning lights Engine preheating Power take off Low engine oil pressure Water in fuel prefilter Clogged air filter Air pressure for air suspensions Cab lockdown unlocked Lifted third axle (6x only) Battery charge Hydraulic steering power failure Hydraulic steering power failure no. (8 x 4 only) ABS failure ABS failure (trailer) EDC Retarder Clogged engine oil filter Engine brake Equipment prearrangement CB Switches External lights Hazard lights Rear fog lights + warning light Loading platform light Right hand side internal spot light Left hand side internal spot light Headlights adjustment Light dimmer switch Lamp tester Rear cab light Headlamp wipers Fog lights Instruments Tachometer Rev counter Clock Air brakes pressure gauge Engine oil pressure gauge + warning light Trip computer Tachograph (1driver) Tachograph ( drivers) 13 7/05/006

14 Instruments Water temperature indicator Outside temperature Fuel consumption gauge Fuel gauge Socket Oil level gauge and indicator lamp Multifunction stalk High beam Headlamp flash Indicator lights Windscreen wiper Windscreen wiper with intermittent wipe Cruise control speed memory Cruise control speed set Other test lamps, on cluster (instrument panel): Additional headlamps - General warning lights (STOP) - General alarm - Front fog lamps - Rear fog lamps - Auxiliary during starting - Mirror heating - Second PTO - Instrument panel failure - Immobilizer - Tachograph trouble - Coolant temperature. on display: Windscreen defroster - Loading deck light (tractor only) - Door open - High engine coolant temperature - Low front axle brake air pressure - Low rear axle brake air pressure - Low trailer brake air pressure - Automatic chains - Seat belts - Low windscreen washer reservoir level - Economy/power - Trailer without EBS/ABS - Low engine oil level - High engine oil temperature - Minimum engine coolant level - Fuel filter clogged - EDC trouble - Low parking brake air pressure. Controls on steering wheel: There are buttons on the steering wheel to select and control some functions: Lower central area for horn Left side: 1. UP / DOWN button. + / - button Right side: 3. MENU / OK button 4. PAGE button 5. ESCAPE button Multifunction stalks (other): Headlight wipers - engine brake and intarder. Miscellaneous (XU 0101-D) Rear mudguards Jack Front towing hitch SCR (Selective Catalytic Reduction) Standard tank AdBlue: 55 litres Exhaust pipe position: left side for LHD - right side for RHD Front underrun protection Trailer light connection Platform behind cab. 14 7/05/006

15 Drawings (DU 0836-D) Wheelbase Left hand drive vehicle drawing Right hand drive vehicle drawing Sleeper cab frame drawing /05/006

16 ZF 1AS-530TO 13 R.5 Rear axle ratio ratio Max. speed ,7 3,4 3, 3,0,8 4,3 4,0 3,7 3,5 3,3 5,0 4,7 4,4 4,1 3,8 5,8 5,4 5,0 4,7 4,5 6,6 6, 5,8 5,5 5, 7,7 7, 6,7 6,3 6,0 38,0 1,0 41,0 51,0 58,0, 67,0,6 34,0 0,9 38,0 41,0 46,0 5,0,0 60,0,4 34,0 0,9 37,0 40,0 51,0,0 58,0,3 9,0 0,7 3,0 0,9 35,0 38,0,0 ZF 1AS-530TO 95/80 R.5 Rear axle ratio ratio Max. speed ,1 3,8 3,5 3,3 3,1 4,7 4,4 4,1 3,9 3,7 5,5 5,1 4,8 4,5 4, 6,3 5,9 5,5 5, 4,9 7, 6,8 6,3 6,0 5,6 8,3 7,8 7,3 6,9 6,5 41,0 1, 55,0,1 63,0,5 74,0,9 37,0 41,0 50,0 57,0, 66,0,6 36,0 1,0 40,0 44,0 55,0, 64,0,6 31,0 0,8 34,0 1,0 38,0 4,0 54,0, 16 7/05/006

17 ZF 1AS-530TO 305/70 R.5 Rear axle ratio ratio Max. speed ,3 4,0 3,7 3,5 3,3 4,9 4,6 4,3 4,1 3,8 5,7 5,3 5,0 4,7 4,4 6,5 6,1 5,7 5,4 5,1 7,5 7,0 6,6 6, 5,8 8,6 8,1 7,6 7,1 6,7 4,0 46,0 51,0 58,0, 66,0,6 78,0 3,0 39,0 4,0 5,0,0 59,0,3 69,0,7 38,0 41,0 46,0 51,0 58,0,3 67,0,7 33,0 0,9 35,0 39,0 56,0,3 ZF 1AS-530TO 315/60 R.5 Rear axle ratio ratio Max. speed ,7 4,4 4,1 3,8 3,6 5,4 5,0 4,7 4,4 4, 6, 5,8 5,4 5,1 4,8 7,1 6,6 6, 5,8 5,5 8,1 7,6 7,1 6,7 6,3 9,3 8,7 8, 7,7 7,3 46,0 50,0 56,0,0 63,0,4 73,0,8 87,0 3,3 4,0 46,0 51,0 57,0, 65,0,5 76,0 3,0 41,0 1, 55,0,1 63,0,5 74,0,9 35,0 1,0 38,0 1, 4,0 53,0,1 61,0,5 17 7/05/006

18 ZF 1AS-530TO 315/70 R.5 Rear axle ratio ratio Max. speed ,3 4,0 3,7 3,5 3,3 4,9 4,6 4,3 4,0 3,8 5,7 5,3 5,0 4,7 4,4 6,5 6,1 5,7 5,4 5,1 7,5 7,0 6,6 6, 5,8 8,6 8,0 7,6 7,1 6,7 4,0 46,0 51,0 58,0, 66,0,5 78,0 3,0 39,0 4,0 5,0,0 59,0,3 69,0,7 38,0 41,0 51,0 58,0,3 67,0,7 3,0 0,9 35,0 39,0 56,0,3 ZF 1AS-530TO 315/80 R.5 Rear axle ratio ratio Max. speed ,9 3,6 3,4 3, 3,0 4,6 4, 4,0 3,7 3,5 5,3 4,9 4,6 4,3 4,1 6,1 5,7 5,3 5,0 4,7 7,0 6,5 6,1 5,8 5,4 8,0 7,5 7,1 6,7 6,3 39,0 48,0 53,0,0 61,0,4 71,0,8 36,0 1,0 39,0 1, 48,0 55,0,1 63,0,5 35,0 1,0 38,0 1, 4,0 53,0,1 6,0,5 30,0 0,8 33,0 1,0 36,0 1, 40,0 5,0,1 18 7/05/006

19 ZF 16S50 TO 13 R.5 Rear axle ratio ratio Max. speed ,3 4,0 3,7 3,5 3,3 4,9 4,6 4,3 4,0 3,8 5,6 5,3 4,9 4,6 4,4 6,4 6,0 5,6 5,3 5,0 7,4 6,9 6,5 6,1 5,7 8,5 7,9 7,4 7,0 6,6 5,0 59,0,1 68,0,5 80,0,9 39,0 53,0 60,0,3 70,0,7 38,0 4,0 46,0 5,0 59,0, 69,0,6 33,0 0,9 36,0 40,0 44,0 50,0 57,0, ZF 16S50 TO 95/80 R.5 Rear axle ratio ratio Max. speed ,7 4,4 4,1 3,9 3,7 5,4 5,1 4,7 4,4 4, 6, 5,8 5,4 5,1 4,8 7,0 6,6 6,1 5,8 5,5 8,0 7,5 7,0 6,6 6, 9,1 8,6 8,0 7,6 7, 5,0 57,0,0 65,0,4 75,0,8 90,0 3, 5,0 58,0,1 67,0,5 79,0,9 4,0 46,0 51,0 57,0,1 65,0,4 76,0,9 36,0 1,0 39,0 1, 48,0 54,0,1 63,0,4 19 7/05/006

20 ZF 16S50 TO 305/70 R.5 Rear axle ratio ratio Max. speed ,9 4,6 4,3 4,1 3,8 5,6 5,3 4,9 4,6 4,4 6,4 6,0 5,6 5,3 5,0 7,3 6,8 6,4 6,0 5,7 8,3 7,7 7,3 6,8 6,5 9,5 8,9 8,3 7,8 7,4 54,0 60,0,1 68,0,5 79,0,9 95,0 3,3 44,0 54,0 61,0, 70,0,6 83,0 3,0 53,0 59,0, 68,0,5 80,0 3,0 37,0 41,0 50,0 57,0,1 66,0,5 ZF 16S50 TO 315/60 R.5 Rear axle ratio ratio Max. speed ,0 5,4 5,0 4,7 4,4 4, 59,0 6,1 5,7 5,4 5,0 4,8,0 66,0 6,9 6,5 6,1 5,7 5,4,3 75,0 7,9 7,4 6,9 6,5 6,1,7 88,0 8,9 8,4 7,8 7,4 7,0 3,1 10,0 9,5 9,0 8,4 8,0 3,6 48,0 53,0 59,0,1 67,0,4 77,0,8 93,0 3,3 5,0 57,0,1 65,0,4 75,0,8 90,0 3, 40,0 1, 44,0 54,0,0 6,0,4 7,0,8 0 7/05/006

21 ZF 16S50 TO 315/70 R.5 Rear axle ratio ratio Max. speed ,9 4,6 4,3 4,0 3,8 5,6 5, 4,9 4,6 4,4 6,4 6,0 5,6 5,3 5,0 7,3 6,8 6,4 6,0 5,7 8,3 7,7 7,3 6,8 6,4 9,4 8,8 8,3 7,8 7,4 54,0 60,0,1 68,0,5 79,0,9 95,0 3,3 44,0 48,0 54,0 61,0, 70,0,6 8,0 3,0 5,0 59,0, 68,0,5 80,0 3,0 37,0 40,0 50,0 56,0,1 65,0,5 ZF 16S50 TO 315/80 R.5 Rear axle ratio ratio Max. speed ,6 4, 4,0 3,7 3,5 5, 4,9 4,6 4,3 4,0 5,9 5,5 5, 4,9 4,6 6,8 6,3 5,9 5,6 5,3 7,7 7, 6,8 6,4 6,0 8,8 8,3 7,8 7,3 6,9 50,0 55,0 6,0,3 7,0,6 85,0 3,1 41,0 1, 50,0 56,0,0 64,0,4 75,0,8 40,0 1, 44,0 55,0,0 6,0,3 73,0,7 35,0 1,0 38,0 1, 4,0 46,0 5,0,0 60,0,3 1 7/05/006