TECHNICAL MANUAL UNIT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LISTS

Transcription

1 TECHNICAL MANUAL UNIT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LISTS TRACTOR, FULL TRACKED, LOW SPEED, HEAVY DRAWBAR PULL, (SIZE T-11 ) W/ANGLE DOZER, WINCH AND ROPS CATERPILLAR MODEL D8K-8A-58 (CCE) NSN AND W/BULLDOZER ( SEMI-U-TILT ), RIPPER AND ROPS CATERPILLAR MODEL D8K-8S-8 (CCE) NSN This manual supersedes TM P, 1 May 1986 Approved for Public Release; Distribution is Unlimited HEADQUARTERS, DEPARTMENT OF THE ARMY 27 JUNE 1988

2 TECHNICAL MANUAL HEADQUARTERS DEPARTMENT OF THE ARMY * Washington, D.C., 27 June 1988 UNIT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LISTS FOR TRACTOR, FULL TRACKED, LOW SPEED, HEAVY DRAWBAR PULL, (SIZE T-11) W/ANGLE DOZER, WINCH AND ROPS NSN CATERPILLAR MODEL D8K-8A-58 (CCE) AND W/BULLDOZER (SEMI-U-TILT), RIPPER AND ROPS NSN CATERPILLAR MODEL D8K-8S-8 (CCE) Current as of 21 MARCH 1988 REPORTING ERRORS AND RECOMMENDING IMPROVEMENTS You can help improve this manual. If you find any mistakes or if you know of a way to improve the procedures, please let us know. Mail your letter, DA Form 2028 (Recommended Changes to Publications and Blank Forms), or DA Form located in back of this manual direct to: U.S. Army Tank- Automotive Command, ATTN: AMSTA-MB, Warren, MI A reply will be furnished to you. Approved for Public Release; Distribution is Unlimited TABLE OF CONTENTS Page SECTION I. INTRODUCTION REPAIR PARTS LIST Illus Fig GROUP 01 ENGINE 0105-VALVES, CAMSHAFTS, AND TIMING SYSTEM ROCKER ARMS, LIFTERS AND PUSH RODS ROCKER ARM COVER *This publication supersedes, 1 May 1986

3 TABLE OF CONTENTS Page Illus Fig 0106-ENGINE LUBRICATION SYSTEM OIL FILTER, BASE AND BRACKET OIL FILLER AND BREATHER ASSEMBLY OIL LEVEL GAUGE ENGINE OIL COOLER LINES OIL MANIFOLD LINES OIL LINES GROUP 03 FUEL SYSTEM AIR CLEANER AIR CLEANER AIR CLEANER AND RELATED PARTS SUPERCHARGER, BLOWER, TURBOCHARGER OR ALTITUDE COMPENSATOR MANIFOLD AIR LINES TANKS, LINES, FITTINGS, HEADERS FUEL LINES FUEL LINES (FOR USE WITH SERIAL RANGE 77V9411 THRU 77V9475) FUEL FILTERS PRIMARY FUEL FILTER FUEL FILTER ENGINE STARTING AIDS GLOW PLUG AND LEAD (ENGINE SERIAL RANGE 17S5088 AND UP) GROUP 04 EXHAUST SYSTEM MUFFLER AND PIPES EXHAUST MUFFLER MUFFLER GROUP 05 COOLING SYSTEM 0501-RADIATOR, EVAPORATIVE COOLER, OR HEAT EXCHANGER RADIATOR (REAR VIEW, USE WITH SERIAL RANGE 77V5006 THRU 77V5953) RADIATOR (SIDE VIEW, USE WITH SERIAL RANGE 77V5006 THRU 77V5953) RADIATOR (SIDE VIEW) RADIATOR CAP PROTECTIVE COVER WATER MANIFOLD, HEADERS, THERMOSTATS AND HOUSING GASKET WATER MANIFOLD WATER MANIFOLD LINES AND RELATED PARTS FAN ASSEMBLY FAN GUARD AND BELT FAN DRIVE GROUP 06 ELECTRICAL SYSTEM 0601-ALTERNATOR ALTERNATOR, BRACKET AND PULLEY DELCO REMY ALTERNATOR ii

4 TABLE OF CONTENTS Illus Page Fig STARTING MOTOR STARTER (USE WITH ENGINE SERIAL RANGE 17S5088 THRU 17S10786) STARTER AND RELATED PARTS (USE WITH ENGINE SERIAL RANGE 17S10787 AND UP) INSTRUMENT PANEL INSTRUMENT PANEL AND VANDALISM GUARD INSTRUMENT CONTROL PANEL SWITCHES AND CIRCUIT BREAKERS IGNITION LOCK SWITCH ELECTRIC HOURMETER BACKUP WARNING ALARM HARNESS LIGHTS LAMP ASSEMBLY LAMP GUARDS AND BRACKETS (USE WITH SERIAL RANGE 77V8516 THRU 77V9475) SENDING UNITS AND WARNING SWITCHES BACKUP WARNING ALARM (FOR USE WITH ROPS) BACKUP WARNING ALARM COOLANT FLOW WARNING ALARM (USE WITH ENGINE SERIAL RANGE 17S5966 THRU 17S9688) HORN, SIREN ELECTRIC HORN AND ATTACHING PARTS (USE WITH SERIAL RANGE 77V8516 THRU 77V9475) DUAL ELECTRIC HORNS (USE WITH SERIAL RANGE 77V9163 THRU 77V9475) CENTER MOUNTED ELECTRIC HORN ELECTRIC HORN BATTERIES. STORAGE BATTERY AND CABLES BATTERY BOX BATTERY BOX STRAP HULL OR CHASSIS WIRING HARNESS MAIN WIRING HARNESS (USE WITH SERIAL RANGE 77V5006 THRU 77V8515) WIRING HARNESS (USE WITH ENGINE SERIAL RANGE 17S5966 THRU 17S9688) MAIN ELECTRIC WIRING HARNESS (USE WITH SERIAL RANGE 77V8516 THRU 77V9475) HEADLIGHT WIRING HARNESS RIPPER LIGHT WIRING GROUP 07 TRANSMISSION TRANSMISSION SHIFTING COMPONENTS TRANSMISSION SHIFTER AND LINKAGE (SIDE VIEW) COOLERS, PUMPS, MOTORS TRANSMISSION OIL FILTER TRANSMISSION FLUID FILTER (MAGNETIC) TRANSMISSION OIL LINES POWER TRAIN OIL LINES TRANSMISSION OIL LINES AND MOUNTING PARTS iii

5 TABLE OF CONTENTS Page Illus Fig GROUP 09 PROPELLER, PROPELLER SHAFTS, UNIVERSAL JOINTS, COUPLER AND CLAMP ASSEMBLY 0900-PROPELLER SHAFTS UNIVERSAL JOINT ASSEMBLY GROUP 13 WHEELS AND TRACKS 1301-SUSPENSION ASSEMBLY TRACK ROLLER FRAME TRACK IDLERS AND BRACKETS FRONT IDLER (EXTERNAL VIEW) TRACK DRIVE SPROCKETS HUB AND SPROCKET SEGMENTS TRACK (SEALED AND LUBRICATED) TRACK (SEALED AND NON-LUBRICATED) GROUP 14 STEERING 1403-STEERING BRAKES BRAKE BAND AND LINING STEERING CLUTCH CONTROL LINKAGE (SIDE VIEW) GROUP 15 FRAME, TOWING ATTACHMENTS, DRAWBARS, AND ARTICULATION SYSTEMS 1503-PINTLES AND TOWING ATTACHMENTS FRONT PULL HOOK AND DRAWBAR SWINGING DRAWBAR GROUP 18 BODY, CAB, HOOD AND HULL 1801-BODY, CAB, HOOD AND HULL ASSEMBLIES BRUSH GUARD HEAVY DUTY CRANKCASE GUARD CRANKCASE GUARD HOOD AND DASH HOOD AND DASH (FOR USE WITH SERIAL RANGE THRU 77V5953) FENDERS, RUNNING BOARDS WITH MOUNTING AND ATTACHING PARTS, OUTRIGGERS, WINDSHIELD, GLASS, ETC RIGHT HAND FENDER LEFT HAND FENDER FLOORS, SUBFLOORS, AND RELATED COMPONENTS FLOOR PLATE UPHOLSTERY SEATS AND CARPETS ADJUSTABLE SEAT SEAT BASE GROUP 20 HOIST, WINCH, CAPSTAN, WINDLASS, POWER CONTROL UNIT, AND POWER TAKE OFF 2001-HOIST, CAPSTAN, WINDLASS, CRANE OR WINCH ASSEMBLY SHEAVE, CABLE AND HITCH iv

6 TABLE OF CONTENTS Page Illus Fig WINCH FILTER RELATED PARTS WINCH CONTROLS (FRONT VIEW) WINCH CONTROLS (SIDE VIEW) BULLDOZER TRIPOD, MAIN FRAME, JACK AND MOUNTING WINCH VALVE WINCH FAIRLEADS (USE WITH LOW SPEED AND STANDARD WINCH) WINCH PUMP LINES CHAIN HOIST ASSEMBLY WINCH MOUNTING GROUP 22 BODY, CHASSIS, AND HULL ACCESSORY ITEMS 2210-DATA PLATES DATA PLATES GROUP 24 HYDRAULIC AND FLUID SYSTEMS MANIFOLD AND CONTROL VALVES RIPPER SELECTOR VALVE PIN PULLER CONTROL VALVE DUAL VALVE FOR RIPPER SELECTOR VALVE (TYPES 1 AND 2) TILT CYLINDERS AND TILT CRANK TILT CYLINDERS AND TILT CRANK STRAINERS, FILTERS, LINES AND FITTINGS, ETC PUMP LINES, TYPE2 (USE ON 8A BULLDOZER WITH SINGLE VALVE) PUMP LINES, TYPE3 (USE ON 8A BULLDOZER WITH SINGLE VALVE) PUMP HOSES, TYPES 1,2 AND 3 (USE WITH DOUBLE VALVE) PUMP LINES TYPES 1 AND 3 (USE WITH DOUBLE VALVE) PUMP LINES, TYPE 2 (USE WITH DOUBLE VALVE) RIPPER PIN PULLER LINES, TYPES 1, 2 AND PIN PULLER LINES RIPPER LINES, LEFT AND RIGHT BULLDOZER LINES BULLDOZER LINES AND FITTINGS TILT CYLINDER HYDRAULIC LINES TILT CYLINDER LINES HYDRAULIC FILTER HYDRAULIC CYLINDERS LIFT CYLINDERS, LEFT AND RIGHT HAND RIPPER CYLINDER LEFT AND RIGHT RIPPER CYLINDER, CENTER LIQUID TANKS OR RESERVOIRS HYDRAULIC TANK CAP PROTECTION COVER GROUP 47 GAGES, WEIGHING AND MEASURING DEVICES 4702-GAGES, MOUNTINGS, LINES, AND FITTINGS PRESSURE GAGES v

7 TABLE OF CONTENTS Page Illus Fig SERVICE METER PRESSURE GAGES LINES AND FITTINGS GROUP 60 STEAM BOILERS, WATER HEATERS, HEATING UNITS, BURNERS WATER HEATER ASSEMBLY WATER HEATER JACKET GROUP 74 CRANES, SHOVELS, AND EARTH MOVING EQUIPMENT COMPONENTS MISCELLANEOUS VALVES EXTERNAL QUICK DROP VALVE MOLDBOARD ASSEMBLY STRAIGHT BULLDOZER BLADE LIFT ARMS AND PIVOT ASSEMBLIES BULLDOZER PUSH ARM ARM AND BRACE BLADE CYLINDER MOUNTING ROOTERS, RIPPERS, PLOWS, HARROWS RIPPER LINK GROUP 94 REPAIR KITS 9401-REPAIR KITS...KIT-1 KIT...KIT-1 KIT GROUP 95 GENERAL USE STANDARDIZED PARTS 9501-BULK MATERIEL...BULK-1 BULK MATERIEL...BULK-1 BULK I SPECIAL TOOLS LIST (NOT APPLICABLE) SECTION IV CROSS-REFERENCE INDEXES I-1 NATIONAL STOCK NUMBER INDEX I-1 PART NUMBER INDEX I-19 FIGURE AND ITEM NUMBER INDEX I-67 vi

8 UNIT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LIST SECTION I. INTRODUCTION 1. Scope. This RPSTL lists and authorizes spares and repair parts; special tools; special test, measurement, and diagnostic equipment (TMDE); and other special support equipment required for performance of Unit Maintenance of the Tractor. It authorizes the requisitioning, issue, and disposition of spares, repair parts and special tools as indicated by the source, maintenance and recoverability (SMR) codes. 2. General. In addition to Section I. Introduction, this Repair Parts and Special Tools List is divided into the following sections: 3. Explanation of Columns (Sections II and III). a. ITEM NO. (Column (1)). Indicates the number used to identify items called out in the illustration. b. SMR CODE (Column (2)). The Source, Maintenance, and Recoverability (SMR) code is a 5-position code containing supply/requisitioning information, maintenance category authorization criteria, and disposition instructions, as shown in the following breakout: 1st two positions Source Code XXxxx a. Section II. Repair Parts List. A list of spares and repair parts authorized by this RPSTL for use in the performance of maintenance. The list also includes parts which must be removed for replacement of the authorized parts. Parts lists are composed of functional groups in ascending alphanumeric sequence, with the parts in each group listed in ascending figure and item number sequence. Bulk materials are listed in item name sequence. Repair kits are listed separately in their own functional group within Section II. Repair parts for repairable special tools are also listed in the section. Items listed are shown on the associated illustration(s)/figure(s). 3d position Who can install, replace or use the item How you get an item Maintenance Code xxxxx 4th position Who can do complete repair* on the item b. Section III Special Tools List. A list of special tools, special TMDE, and other special support equipment authorized by this RPSTL (as indicated by Basis of Issue (BOI) information in DESCRIPTION AND USABLE ON CODE column) for the performance of maintenance. c. Cross-reference Indexes. A list, in National Item Identification Number (NIIN) sequence, of all National stock numbered items appearing in the listing, followed by a list in alphanumeric sequence of all part numbers appearing; in the listings. National stock numbers and part numbers are crossreferenced to each illustration figure and item number appearance. The figure and item number index lists figure and item numbers in alphanumeric sequence and cross-references NSN, FSCM, and part numbers. Recoverability Code xxxxx 5th position Who determines disposition action on an unserviceable item *Complete Repair: Maintenance capacity, capability, and authority to perform all corrective maintenance tasks of the "Repair" function in a use/user environment in order to restore serviceability to a failed item. 1

9 (1) Source Code. The source code tells you how to get an item needed for maintenance, repair, or overhaul of an end item/equipment. Explanations of source codes follows: Code PA PB PC PD PE PF PG KD KF KB MO-(Made at UM/ AVUM Level MF-(Made at IDS/ AVUM Level MH-(Made at IGS Level) ML-(Made at Specialized Repair act (SRA)) MD-(Made at Depot) AO-(Assembled by UM/AVUM Level) AF-(Assembled by IGS Category AL-(Assembled by SRA) AD-(Assembled by Depot) XA- Application/Explanation Stocked items; use the applicable NSN to request/requisition items with these source codes. They are authorized to the category indicated by the code entered in the 3d position of the SMR code. **Items coded PC are subject to deterioration. Items with these codes are not to be requested/requisitioned individually. They are part of a kit which is authorized to the maintenance category indicated in the 3d position of the SMR code. The complete kit must be requisitioned and applied. Items with these codes are not to be requested/requisitioned individually. They must be made from bulk material which is identified by the part number in the DESCRIPTION AND USABLE ON CODE (UOC) column and listed in the Bulk Material group of the repair parts list in this RPSTL. If the item is authorized to you by the 3d position code of the SMR code, but the source code indicates it is made at a higher level, order the item from the higher level of maintenance. Items with these codes are not to be requested/requisitioned individually. The parts that make up the assembled item must be requisitioned or fabricated and assembled at the level of maintenance indicated by the source code. If the 3d position code of the SMR code authorizes you to replace the item, but the source code indicates the item is assembled at a higher level, order the item from the higher level of maintenance. Do not requisition an "XA"-coded item. Order its next higher assembly. (Also, refer to the NOTE below.) XB- XC- XD- If an "XB" item is not available from salvage, order it using the FSCM and part number given. Installation drawing, diagram, instruction sheet, field service drawing, that is identified by the manufacturer s part number. Item is not stocked. Order an "XD"-coded item through normal supply channels using the FSCM and part number given, if no NSN is available. NOTE: Cannibalization or controlled exchange, when authorized, may be used as source of supply for items with the above source codes, except for those source coded "XA" or those aircraft support items restricted by requirements of AR (2) Maintenance Code. Maintenance codes tell you the level(s) of maintenance authorized to USE and REPAIR support items. The maintenance codes are entered in the third and fourth positions of the SMR Code as follows: (a) The maintenance code entered in the third position tells you the lowest maintenance level authorized to remove, replace, and use an item. The maintenance code entered in the third position will indicate authorization to one of the following levels of maintenance. Code Application/Explanation C- Crew or operator maintenance done within unit maintenance or aviation unit maintenance. O - Unit maintenance or aviation unit category can remove, replace, and use the item. (b) The maintenance code entered in the fourth position tells whether or not the item is to be repaired and identifies the lowest maintenance level with the capability to do complete repair (i.e., perform all authorized repair functions.) (NOTE : Some limited repair may be done on the item at a lower level of maintenance, if authorized by the Maintenance Allocation Chart (MAC) and SMR codes.) This position will contain one of the following maintenance codes: Code Application/Explanation O- Unit maintenance or Aviation unit is the lowest level that can do complete repair of the item. F- Intermediate Direct support or aviation intermediate is the lowest level that can do complete repair of the item. H- Intermediate General support is the lowest level that can do complete repair of the item. 2

10 D- Depot is the lowest level that can do complete repair of the item. L- Specialized repair activity is the lowest level that can do complete repair of the item. Z- Nonreparable. No repair is authorized. B- No repair is authorized. (No parts or special tools are authorized for the maintenance of a "B" coded item). However, the item may be reconditioned by adjusting, lubrication, etc., at the user level. (3) Recoverability Code. Recoverability codes are assigned to items to indicate the disposition action on unserviceable items. The recoverability code is entered in the fifth position of the SMR Code as follows: Code Application/Explanation Z- Nonreparable item. When unserviceable, condemn and dispose of the item at the level of maintenance shown in 3d position of SMR Code. O- Reparable item. When uneconomically reparable, condemn and dispose of the item at unit maintenance or aviation unit level. F- Reparable item. When uneconomically reparable, condemn and dispose of the item at the intermediate direct support or aviation intermediate level. H- Reparable item. When uneconomically reparable, condemn and dispose of the item at the intermediate general support level. D- Reparable item. When beyond lower level repair capability, return to depot. Condemnation and disposal of item not authorized below depot level. L- Reparable item. Condemnation and disposal of item not authorized below specialized repair activity (SRA). A- Item requires special handling or condemnation procedures because of specific reasons (e.g., precious metal content, high dollar value, critical material, or hazardous material). Refer to appropriate manuals/directives for specific instructions. c. FSCM (Column (3)). The Federal Supply Code for Manufacturer (FSCM) is a 5-digit numeric code which is used to identify the manufacturer, distributor, or Government agency, etc., that supplies the item. d. PART NUMBER (Column (4)). Indicates the primary number used by the manufacturer (individual, company, firm, corporation, or Government activity), which controls the design and characteristics of the item by means of its engineering drawings, specifications standards, and inspection requirements to identify an item or range of items. NOTE: When you use a NSN to requisition an item, the item you receive may have a different part number form the part ordered. e. DESCRIPTION AND USABLE ON CODE (UOC) (Column (5)). This column includes the following information: (1) The Federal item name and, when required, a minimum description to identify the item. (2) Physical security classification. Not applicable (3) Items that are included in kits and sets are listed below the name of the kit or set on Figure KIT. (4) Spare/repair parts that make up and assembled item are listed immediately following the assembled item line entry. (5) Part numbers for bulk materials are referenced in this column in the line item entry for the item to be manufactured/fabricated. (6) When the item is not used with all serial numbers of the same model, the effective serial numbers are shown on the last line(s) of the description (before UOC). Not applicable. (7) The usable on code, when applicable (see paragraph 5, Special information) (8) In the Special Tools List section, the basis of issue (BOI) appears as the last line(s) in the entry for each special tool, special TMDE, and other special support equipment. When density of equipments supported exceeds density spread indicated in the basis of issue, the total authorization is increased proportionately. (9) The statement "END OF FIGURE" appears just below the last item description in Column 5 for a given figure in both Section II and Section III. f. QTY (Column (6)). The QTY (quantity per figure column) indicates the quantity of the item used in the breakout shown on the illustration figure, which is prepared for a functional group, subfunctional group, or an assembly. A "V" appearing in this column in lieu of a quantity indicates that the quantity is variable and the quantity may vary from application to application. 4. Explanation of Columns (Section IV). a. NATIONAL STOCK NUMBER (NSN) INDEX. 3

11 (1) STOCK NUMBER column. This column lists the NSN by National item identification number (NIIN) sequence. The NIIN consists of the last nine NSN digits of the NSN (i.e., ) When using NIIN this column to locate an item, ignore the first 4 digits of the NSN. However, the complete NSN should be used when ordering items by stock number. (2) FIG. Column. This column lists the number of the Figure where the item is identified/located. The figures are in numerical order in Section II and Section III (3) ITEM column. The item number identifies the item associated with the figure listed in the adjacent FIG. column. This item is also identified by the NSN listed on the same line. b. PART NUMBER INDEX. Part numbers in this index are listed by part number in ascending alphanumeric sequence (i.e., vertical arrangement of letter and number combination which places the first letter or digit of each group in order A through Z, followed by the numbers 0 through 9 and each following letter or digit in like order.) (1) FSCM column. The Federal Supply Code for Manufacturer (FSCM) is a 5 digit numeric code used to identify the manufacturer, distributor, or Government agency, etc., that supplies the item. (2) PART NUMBER column. Indicates the primary number used by the manufacturer (individual, firm, corporation, or Government activity), which controls the design and characteristics of the item by means of its engineering drawings, specifications standards, and inspection requirements to identify an item or range of items. (3) STOCK NUMBER column. This column lists the NSN for the associated part number and manufacturer identified in the PART NUMBER and FSCM columns to the left. (4) FIG. column. This column lists the number of the figure where the item is identified/located in Section II and III. (5) ITEM column. The item number is that number assigned to the item as it appears in the figure referenced in the adjacent figure number column. c. FIGURE AND ITEM NUMBER INDEX. (1) FIG. column. This column lists the number of the figure where the item is identified/located in Section II and III. (2) ITEM column. The item number is that number assigned to the item as it appears in the figure referenced in the adjacent figure number column. (3) STOCK NUMBER column. This column lists the NSN for the item. (4) FSCM column. The Federal Supply Code for Manufacturer (FSCM) is a 5-digit numeric code used to identify the manufacturer, distributor, or Government agency, etc., that supplies the item. (5) PART NUMBER column. Indicates the primary number used by the manufacturer (individual, firm, corporation, or Government activity), which controls the design and characteristics of the item by means of its engineering drawings, specifications standards, and inspection requirements to identify an item or range of items. 5. Special Information. Use the following subparagraphs as applicable: a. USABLE ON CODE. The usable on code appears in the lower left corner of the Description column heading. Usable on codes are shown as "UOC:... "in the Description Column (justified left) on the first line following applicable item description/nomenclature. Uncoded items are applicable to all models. Identification of the usable on codes used in the RPSTL are: Code T24 T25 Used On D8K-8A-58 (CCE) D8K-8S-8 (CCE) b. FABRICATION INSTRUCTIONS. Bulk materials required to manufacture items are listed in the Bulk Material Functional Group of this RPSTL. Part numbers for bulk materials are also referenced in the description column of the line item entry for the item to be manufactured/fabricated. c. ASSEMBLY INSTRUCTION. Items that make up the assembly are listed immediately following the assembly item entry or reference is made to an applicable figure. d. KITS. Line item entries for repair parts kits appear in group 9401 in Section II. e. INDEX NUMBERS. Items which have the word BULK in the figure column will have and index number shown in the item number column. This index number is a cross-reference between the National Stock Number/Part Number Index and the bulk material list in Section II. 4

12 f. ASSOCIATED PUBLICATIONS. The publications listed below pertain to the Tractor and its components: Publication TM &P- 1 TM &p-2 TM P Short Title Tractor Tractor Tractor g. The illustrations in this manual are identical to those published in the TM P. Only those parts coded "C" or "O" in the third position of the SMR code are listed in the tabular listing; therefore, there may be a break in the item number sequence. Only illustrations containing organizational unit authorized items appear in this manual. 6. How to locate Repair Parts. a. When National Stock Number or Part Number is Not Known. (1) First. Using the table of contents, determine the assembly group or subassembly group to which the item belongs. This is necessary since figures are prepared for assembly groups and subassembly groups, and listings are divided into the some groups. (2) Second. Find the figure covering the assembly group or subassembly group to which the item belongs. (3) Third. Identify the item on the figure and use the Figure and Item Number Index to find the NSN. b. When National Stock Number or Part Number is Known: (1) First Using the National Stock Number or the Part Number Index, find the pertinent National Stock Number or Part Number. The NSN index is in National Item Identification Number (NIIN) sequence (see 4.1(1)). The part numbers in the Part Number index are listed in ascending alphanumeric sequence (see 4.b). Both indexes crossreference you to the illustration/figure and item number of the item you are looking for. (2) Second. Turn to the figure and item number, verify that the item is the one you re looking for, then locate the item number in the repair parts list for the figure. 7. Abbreviations. For standard abbreviations see MIL-STD-12D, Military Standard Abbreviations For Use On Drawings, Specifications, Standards And In Technical Documents. 5

13 1 2 FIGURE 1. ROCKER ARMS, LIFTERS AND PUSH RODS. TA23512

14 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 01 ENGINE GROUP 0105 VALVES, CAMSHAFTS, AND TIMING SYSTEM FIG 1 ROCKER ARMS, LIFTERS AND PUSH RODS 1 PFOOO FE874 SHAFT PFOZZ B622.PLUG, EXPANSION PFOZZ B4508 WASHER LOCK PFOZZ NUT, PLAIN, HEXAGON PFOZZ B7302 ROD, ENDITHREADED PFOZZ DX2261 PIN, COTTER PFOZZ H1022 STUD, TRACTOR PFOZZ MS NUT, PLAIN, HEXAGCN PFOZZ S2365 ROCKER ARM, ENGINE P PFOZZ SLEEVE, VALVE, ENGINE PFOZZ A1884 SPRING,HELICAL, COMP PFOZZ H411 WASHER, FLAT PFGZZ MS C PLUG,PIPE PFOZZ A744 SETSCREW PFOZZ MS51S6-11 NUT, PLAIN, HEXAGON PFOZZ SPRING, HELICAL, COMP PFOZZ H6236 PUSH ROD, ENGINE P PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ H3451 LOCKING PLATE, NUT A PFOZZ B7114 YOKE, VALVE LIFT GUI PFOZZ H7302 GUIDE, ENGINE POPPET PFOZZ S1220 LIFTER, VALVE PFOZZ F8584 BRACKET, VALVE ROCKE... 6 END OF FIGURE 1-1

15 TM P TA FIGURE 2. ROCKER ARM COVER.

16 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0105 VALVES, CAMSHAFTS, AND TIMING SYSTEM FIG 2 RGOCKER ARM COVER 1 PFOZZ M2315 COVER, ENGINE POPPET PFOZZ F8526 WASHER, SPECIAL PFOZZ K8977 NUT PFOLZ F4994 PACKING, PPEFORMED PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ M2894 WASHER,FLAT PFOZZ L1143 BOLT,,MACHINE PFOZZ XX3S58 BOLT,MACHINE PFOZZ M2617 GASKET XDOZZ M2314 BASE PFOZZ M2616 GASKET... 2 END OF FIGURE 2-1

17 5 6 TA FIGURE 3. OIL FILTER, BASE AND BRACKET.

18 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0106 ENGINE LUBRICATION SYSTEM FIG 3 OIL FILTER, BASE AND BRACKET 1 PFOZZ MS SCREW, CAPHEXAGON H USE WITH... 3 ENGINE SERIAL RANGE 175S5088 THRU 17S PFOZZ S1568 BOLT, MACHINE PFOZZ B4506 WASHER, LOCK USE WITH ENGINE SERIAL RANGE 17S5088 THRU 17S XDOZZ N7570 PLATE ASSEMBLY USE WITH ENGINE... 1 SERIAL RANGE 17S5088 THRU 17S XDOZZ P5084 SUPPORT PFOOO P4301 BASE ASSEMBLY PFOZZ P43C4.STUD PFOZZ M3182 SPRING, HELICAL, COMP PFOZZ P3761 COVER, ACCESS PFOZZ P3760 GASKET PFOZZ M853 PLUNGER PFOZZ MS WASHER, FLAT PFOZZ P43C5 GASKET PFOZZ M6214 PLUGIPIPE PFOZZ P5085 SUPPORT PFOZZ P5155 GASKET USE WITH ENGINE SERIAL... 1 RANGE 17S5088 THRU 17S PFOZZ MS NUT, PLAIN, HEXAGON USE WITH ENGINE... 1 SERIAL RANGE THRU 17S PFOZZ N7082 SHIELD PFOZZ PER69 FILTER ELEMENT, FLUI PFOZZ MS SCREW, DRIVE PFOZZ A4639 BOLT, MACHINE PFOZZ D4717 NUT, HEXAGON... 2 END OF FIGURE 3-1

19 THRU TA FIGURE 4. OIL FILLER AND BREATHER ASSEMBLY.

20 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0106 ENGINE LUBRICATION SYSTEM FIG 4 OIL FILLER AND BREATHER ASSEMBLY 1 PFOZZ F7559 GASKET PFOZZ B4615 PINTCGTTER PFOZZ F4103 CAP, FILLER CPE NING PFOZZ F4099 GASKET PFOZZ B5980 SPACER, RING PFOZZ F4102 PLATE, FILLER CAP PFOOO M9542 BREATHER ASSEMBLY PFOOO MS549.COVER,ACCESS PFOZZ P GASKET PFOZZ H6095.FILTER ELE MEFT, INTA PFOZZ M9423 HOSE, PREFORMED PFOZZ C LAMP PFODO H7187 ELBGW ASSEBLY,OIL PFOZZ H9671.SHIELD,ELBOW PFOZZ H7376 GASKET PFOZZ H7033 GASKET PFOZZ WASHER,LOCK PFOZZ A NUT, PLAI N, HEXAGCN PFOZZ S1588 BOLT,MACHINE PFOZZ BOLT, MACHINE XDOZZ P3822 TUBE ASSEMBLY PFOZZ H3460 CABLE ASSEMBLY... 1 END OF FIGURE 4-1

21 3 4 TA FIGURE 5. OIL LEVEL GAUGE.

22 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0106 ENGINE LUBRICATION SYSTEM FIG 5 OIL LEVEL GAUGE 1 PFOZZ S6518 GAGE PFOZZ P5094 TUBE ASSE1BLY PFOOO S1326 ADAPTER, STRAIGHT, PI PFOZZ F8998.INVERTED NUT, TUBE C... 1 END OF FIGURE 5-1

23 15 16 THRU 22 FIGURE 6. ENGINE OIL COOLER LINES. TA

24 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0106 ENGINE LUBRICATION SYSTEM FIG 6 ENGINE CIL COOLER LINES 1 PFOZZ B8428 BOLT, MACHINE PFOZZ H4759 GASKET XDOZZ N85 ELBOW PFOZZ M4991 PACKING, PPEFORMED PFOZZ H8217 GASKET PFOLZ S Lr, MACHIIE PFOZZ MS SCREW, CAP, HEXAGON H XDOZZ P5100 TUBE ASSEMBLY PFOZZ BOLT, MACHINE XDOZZ P5097 TUBE ASSEMBLY USE WITH ENGINE... 1 SERIAL RANGE 17S5088 THRU XDOZZ N6674 TUBE ASSEMBLY USE WITH ENGINE... 1 SERIAL RANGE 17S14747 AND UP PFOZZ H7370 PACKING, PREFORMED PFOZZ 1L083 S1588 BOLT, MACHINE USE WITH ENGINE... 2 SERIAL RANGE 17S14747 AND UP PFOZZ S1594 BOLT, MACHINE USE WITH ENGINE... 2 SERIAL RANGE 17S5088 THRU 17S PFOZZ M2894 WASHER,FLAT PFOZZ L GASKET PFOOO P5089 VALVE PFOZZ S6814.PIN, STRAIGHT, HEADLE PFOZZ B830.COVER, ACCESS PFOZZ MS BOLT, MACHINE PFOLZ MS WASHER, LOCK PFOZZ S6744.GASKET PFOZZ M3182.SPRING, HELICAL, COMP PFOZZ P PLUNGER, DETENT PFOZZ MS NUT, PLAIN, HEXAGON PFOZZ P5086 GASKET XDOZZ P5102 TUBE ASSEM8LY XDOZZ N82 ELBOW XDOZZ N77 TUBE ASSEMBLY PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ WASHER, FLAT PFOZZ L1143 BOLT, MACHINE XDOZZ N79 TUBE ASSEMBLY... 1 END OF FIGURE 6-1

25 THRU 9 35 AND THRU THRU 53 TA FIGURE 7. OIL MANIFOLD LINES.

26 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0106 ENGINE LUBRICATION SYSTEM FIG 7 OIL MANIFOLD LINES 1 PFOZZ INVERTED NUT.TUBE C PFOZZ L3616 FITTING PFOOO H4050 MANIFOLD ASSEMBLY, O USE WITH... 1 ENGINE SERIAL RANGE 17S8028 AND UP... 3 PFOOO S14349 MANIFOLD ASSEMBLY, ( USE WITH... 1 ENGINE SERIAL RANGE 17S5089 THRU 17S PFOZZ F1050.PLUG, EXPANSION PFOOO H4043 TUBE ASSEMBLY, METAL PFOZZ F2738.SLEEVE FUEL TRANSFE PFOZZ L1547.NUT, TUBE COUPLING PFOZZ F5224.FERRULE, OIL LINE PFOZZ F5222.INVERTED NUT, TUBE C PFOZZ FC236 ADAPTER, STRAIGHT, TU PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ L364 LOCK PLATE PFQZZ T225 GASKET PFOZZ TUBE ASSEMBLY PFOZZ N4298 TUBE ASSEMBLY USE WITH ENGINE... 1 SERIAL RANGE 17S8944 AND UP PFOZZ MS SCREW, CAP, HEXAGON H USE WITH... 3 ENGINE SERIAL RANGE 17S8944 AND UP PFOZZ S5717 NUT, PLAIN, CASTELLAT USE WITH... 3 ENGINE SERIAL RANGE 17S8944 THRU 17S PFOZZ K4973 LOCKNUT USE WITH ENGINE SERIAL... 3 RANGE 17S11434 AND UP PFOZZ M2894 WASHER, FLAT USE WITH ENGINE SERIAL... 3 RANGE 17S8944 AND UP XDOZZ M6425 CLIP USE WITH ENGINE SERIAL RANGE S8944 AND UP PFOZZ L CLAMP1LCCP USE WITH ENGINE SERIAL... 3 RANGE 17S8944 AND UP PFOZZ SE897 SPACER PFOZZ M5376 GASKET PFOZZ S1619 BOLT, MACHINE PFOZZ K9194 ELBOW USE WITH ENGINE SERIAL RANGE S8944 AND UP PFOZZ MS51500A6 ADAPTER, STRAIGHT, PI USE WITH... 2 ENGINE SERIAL RANGE 17S8944 AND UP PFOZZ L1546 ADAPTER, STRAIGHT, PI USE WITH... 1 ENGINE SERIAL RANGE 17S8028 AND UP PFOZZ P1713 LUBE ASSEMBLY PFOZZ S4173 CLIP PFOZZ BS549 SPRINGTHELLCAL, CCMP PFOZZ MS WASHER, FLAT PFOZZ NUT, PLAIN, CASTELLAT PFOZZ PK379 PIN, COTTER

27 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 33 PFOZZ KS243 ELBOW, PIPE TO TUBE PFOOO H4380C TUBE ASSEMBLY PFOZZ F5224 FERRULE,OIL LINE PFOZZ F5222.INVERTED NUT, TUBE C PFOZZ H8985.FITTING PFOZZ C7454 SPACER, RING PFOZZ H3369 ELBOW PFOZZ M4446 PACKING, PREFORMED PFOOO H4047 TUBE ASSEMBLY, METAL PFOZZ F2738.SLEEVE, FUEL TRANSFE PFOZZ L1547.NUT, TUBE COUPLING PFOZZ F5224.FERRULE, OIL LINE PFOZZ F5222.INVERTED NUT, TUBE C PFOZZ H3035 TUBE USE WITH ENGINE SERIAL RANGE S8028 AND UP MOOZZ C TUBE MAKE FRCM TUBE P/N 5P PFOZZ H8878 CLAMP, LOOP PFOOO H4045 TUBE ASSEM.BLY, METAL PFOZZ F2738 SLEEVE, FUEL TRANSFE PFOZZ L1547 NUT, TUBE COUPLING PFOZZ F5224 FERRULE, OIL LINE PFOZZ F5222 INVERTED NUT, TUBE C... 1 END OF FIGURE 7-2

28 TA FIGURE 8. OIL LINES.

29 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0106 ENGINE LUBRICATION SYSTEM FIG 8 OIL LINES 1 PFOZZ H8997 TUBE, BENT, METALLIC PFOOO F6068 ADAPTER,STRAIGHT,PI PFOZZ F5362.INVERTED NUT, TUBE C PFOOO F3278 ADAPTER, STRAIGHT,PI PFOZZ F1344.INVERTED NUT, TUBE C PFOZLZ N4173 TUBE ASSEMBLY, METAL OIL SUPPLY PFOZZ NS246 TUBE ASSEMBLY, METAL OIL SUPPLY PFOZZ H7292 TUBE, BENT, METALLIC PFOZZ B3243 CLAMP, LOOP PFOZZ BS302 CLIP PFOZZ MS SCREW, CAP,HEXAGON H PFOZZ S GASKET PFOZZ GASKET PFOZZ L1351 BOLT, MACHINE PFOZZ N7811 TUBE ASSEMBLY, METAL OIL DRAIN PFOZZ S1476 CLIP PFOZZ L1365 CLAMP, LOOP PFOLZ MS SCREW, CAP, HEXAGON H PFOZZ A9109 WASHER, FLAT PFOZZ MS CLAMP, LOOP PFOZZ H3142 TUBE, BENT, METALLIC PAOZZ N0076 ELBOW PFOZZ M4849 SEAL, RING PFOOO B9673 ADAPTER, STRAIGHT, PI PFOZZ F1344.INVERTED NUT, TUBE C PFOZZ S1594 BOLT, MACHINE PFOZZ L2070 BOLT, MACHINE PFOZZ F7590 GASKET PFOOO B ELBOW, PIPE TO TUBE PFOZZ F1344.INVERTED NUT, TUBE C PFOOO LB3-8X1-4 ELBOW, PIPE TO TUBE PFOZZ F8997.INVERTED NUT, TUBE C PFOOO B9003 ELBOW, PIPE TO TUBE PFOZZ F1344.INVERTED NUT, TUBE C PFOZZ B4442 NUT, PLAIN, CASTELLAT USE WITH... 1 ENGINE SERIAL RANGE 17S5088 THRU 17S PFOZZ K4973 LOCKNUT USE WITH ENGINE SERIAL... 1 RANGE 17S11434 AND UP PFOZZ MS WASHER, FLAT USE WITH ENGINE SERIAL... 1 RANGE 17S5088 TO PFOZZ M2894 WASHER, FLAT USE WITH ENGINE SERIAL... 1 RANGE 17S11434 AND UP PFOZZ PK379 PIN, CCTTER USE WITH ENGINE SERIAL... 1 RANGE 17S5088 THRU 17S END OF FIGURE

30 SECTION THRU 8 TA FIGURE 9. AIR CLEANER.

31 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 03 FUEL SYSTEM GROUP 0304 AIR CLEANER FIG 9 AIR CLEANER 1 PFOZZ N9244 TUBE ASSEMBLY PFOZZ NUT, PLAIN, HEXAGON PFOZZ B4506 WASHER, LOCK PFOOO P6450 AIR CLEANER ASSY PFOZZ P7360.FILTER ELEMENT, INTA SECONDARY PFOZZ FILTER ELEMENT, INTA PRIMARY PFOZZ P7748.CUP ASSEMBLY PFOZZ M3695.ROD ASSEMBLY PFOZZ M5173 PACKING, PREFORMED PFOZZ P3860 CLAMP, HOSE PFOZZ S8379 HOSE PFOZZ A1460 BOLT, MACHINE PFOZZ B4508 WASHER, LOCK PFOZZ D4572 SCREW PFOZZ N5966 ELBOW, HOSE PFOZZ A NUT PLAIN, HEXAGON PFOZZ H7954 SCREW, CAP, HEXAGON H PFOZZ S7680 CLAMP... 1 END OF FIGURE 9-1

32 THRU 6 12 AND TA FIGURE 10. AIR CLEANER AND RELATED PARTS.

33 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0304 AIR CLEANER FIG 10 AIR CLEANER AND RELATED PARTS 1 PFOZZ K4973 LOCKNUT PFOOO S7455 PRECLEANER ASSEMBLY PFOZZ S8473.BODY ASSEMBLY PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ A NUT, PLAIN, HEXAGON PFOZZ S84 72.HOOD ASSEMBLY PFOZZ P6832 GASKET PFOZZ M6952 PACKING, PREFORMED PFOZZ CLAMP, HOSE MOOZZ HOSE MAKE FROM HOSE P/N 5P PFOOO N9317 PIPE ASSEMBLY PFOZZ M6214.PLUG, PIPE PFOZZ P STRAINER ELEMENT, SE PAOZZ T822 BOLT, MACHINE PFOZZ N7094 PIPE ASSEMBLY PFOZZ A NUT, PLAIN, HEXAGON PFOZZ B3235 BOLT, MACHINE PFOOO P6834 ADAPTER ASSEMBLY PFOZZ M2151 STUD, CONTINUOUS THR... 8 END OF FIGURE 10-1

34 TA FIGURE 11. MANIFOLD AIR LINES.

35 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0305 SUPERCHARGER, BLOWER, TURBOCHARGER OR ALTITUDE COMPENSATOR FIG 11 MANIFOLD AIR LINES 1 PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ P4729 ELBOW XDOOO P4727 PIPE, METALLIC PFOZZ L8855 SEAL RING, METAL PFOZZ L8854 RING, PISTON PFOZZ P4726 ELBOW, HOSE PFOZZ L1143 BOLT, MACHINE PFOZZ B5355 NUT, PLAIN, HEXAGON PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ L COUPLING, TURBOCHARG... 1 END OF FIGURE 11-1

36 TA FIGURE 12. FUEL LINES.

37 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0306 TANKS, LINES, FITTINGS, HEADERS FIG 12 FUEL LINES 1 MOOZZ HOSE MAKE FROM HOSE P/N 5P1442, USE 1 WITH SERIAL RANGE 77V5259 THRU 77V9Y PFOZZ R3837 COCK, SHUTOFF, SCREW USE WITH SERIAL 2 RANGE 77V5259 THRU 77V PFOZZ S3916 CLIP USE WITH SERIAL RANGE 77V THRU 77V PFOZZ S1594 BOLT, MACHINE USE WITH SERIAL RANGE 4 77V5259 THRU 77V PFOZZ M894 WASHER, FLAT USE WITH SERIAL RANGE 7 77V5259 THRU 77V XDOZZ P6144 BRACKET USE WITH SERIAL RANGE 1 77V5259 THRU 17V PFOZZ P5970 TUBE, BENT, METALLIC USE WITH SERIAL... 2 RANGE 77V5259 THRU 77V PFOZZ P4791 STRAINER, SEDIMENT USE WITH SERIAL 1 RANGE 77V5259 THRU 77V PFOOO L482 ELBOW, PIPE TO TUBE USE WITH SERIAL 4 RANGE 77V5006 THRU 77V PFOZZ H2663.NUT, TUBE COUPLING 1 11 PFOZZ H2662.BUSHING, RUBBER 1 12 PFOZZ MS BUSHING, PIPE USE WITH SERIAL RANGE 1 77V5259 THRU 77V PFOOO L480 COUPLING, TUBE USE WITH SERIAL 4 RANGE 77V5006 THRU 77V PFOZZ H2663.NUT, TUBE COUPLING 2 15 PFOZZ H2662.BUSHING, RUBBER 1 16 MOOZZ P TUBE MAKE FROM TUBE P/N 5P1201, USE 2 WITH SERIAL RANGE 77V5006 THRU 77V PFOZZ B CLIP, SPRING TENSION USE WITH 4 SERIAL RANGE 77V5006 THRU 77V PFOZZ A2029 BOLT, MACHINE USE WITH SERIAL RANGE 2 77V5006 THRU 77V PFOZZ A NUT, PLAIN, HEXAGON USE WITH SERIAL 4 NUMBER 77V5006 THRU 77V PFOZZ L1351 BOLT, MACHINE USE WITH SERIAL RANGE 2 77V5006 THRU 77V MOOZZ P TUBE MAKE FROM TUBE P/N 5P1201, USE 2 WITH SERIAL RANGE 77V5006 THRU 17V PFOZZ MS CLAMP, LOOP USE WITH SERIAL RANGE 2 77V5006 THRU 77V PFOZZ MS SCREW, CAP, HEXAGON H USE WITH 2 SERIAL RANGE 77V5006 THRU 77V PFOZZ MS WASHER, FLAT USE WITH SERIAL- RANGE 2 77V5006 THRU 77V

38 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 25 PFOZZ B4506 WASHER, LOCK USE WITH SERIAL RANGE 3 77V5006 THRU 77V MOOZZ P TUBE MAKE FROM TUBE P/N 5P1201, USE 1 WITH SERIAL RANGE 77V5259 THRU 77V MOOZZ P TUBE MAKE FROM TUBE P/N 5P1201, USE 1 WITH SERIAL RANGE 77V5006 THRU 77V PFOZZ M3464 CLAMP, LOOP USE WITH SERIAL RANGE 2 77V5006 THRU 77V PFOZZ M849 WASHER, FLAT USE WITH SERIAL RANGE 2 77V5006 THRU 77V PFOOO L3446 FITTING ASSEMBLY, FU USE WITH 2 SERIAL RANGE 77V5006 THRU 77V PFOZZ H2663.NUT, TUBE COUPLING PFOZZ H2662.BUSHING, RUBBER PFOZZ S5100 VALVE ASSEMBLY USE WITH SERIAL 1 RANGE 77V5006 THRU 77V XDOOO S5110 VALVE ASSEMBLY USE WITH SERIAL 1 RANGE 77V5006 THRU 77V PFOZZ VALVE ASSEMBLY PFOZZ SCREEN PFOZZ K6776 PLUG, TUBE FITTING, T USE WITH 1 SERIAL RANGE 77V5006 THRU 77V PFOZZ F-E ADAPTER, STRAIGHT, PI USE WITH 1 SERIAL RANGE 77V5259 THRU 77V PFOZZ B6489 COUPLING USE WITH SERIAL RANGE 2 77V5259 THRU 77V END OF FIGURE 12-2

39 AND 3 8 AND AND AND AND 43 FIGURE 13. FUEL LINES (FOR USE WITH SERIAL RANGE 77V9411 THRU 77V9475). TA235240

40 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0306 TANKS, LINES, FITTINGS, HEADERS FIG 13 FUEL LINES (FOR USE WITH SERIAL RANGE 77V9411 THRU 77V9475) 1 PFOOO L480 COUPLING, TUBE PFOZZ H2663.NUT, TUBE COUPLING PFOZZ H2662.BUSHING, RUBBER MOOZZ P TUBE MAKE FROM TUBE P/N 5PL PFOZZ MS CLAMP, LOOP MOOZZ P TUBE MAKE FROM TUBE P/N 5P PFOOO L482 ELBOW, PIPE TO TUBE PFOZZ H2663.NUT, TUBE COUPLING PFOZZ H2662.BUSHING, RUBBER PFOZZ L1351 BOLT, MACHINE PFOZZ B CLIP, SPRING TENSION PFOZZ A2029 BOLT, MACHINE PFOZZ A NUT, PLAIN, HEXAGON PFOZZ M2894 WASHER, FLAT PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ M5942 CLAMP, LOOP PFOZZ M849 WASHER, FLAT MOOZZ HOSE MAKE FROM HOSE P/N 5P PFOZZ 3078C 322F-E ADAPTER, STRAIGHT, PI PFOOO P5397 ANGLE ASSEMBLY PFOZZ F2978.NUT, PLAIN, WELDING PFOZZ M7167 SPACER, SLEEVE PFOOO P5400 LEVER ASSEMBLY PFOZZ H3895.BUSHING, SLEEVE PFOZZ 1l083 2G2588.PIN, STRAIGHT, HEADLE PFOZZ D2861 SPRING, FLAT PFOOO P5398 ANGLE ASSEMBLY PFOZZ F2978.NUT, PLAIN, WELDING PFOZZ F748.NUT, PLAIN, WELDING PFOZZ S1588 BOLT, MACHINE PFOZZ A1460 BOLT, MACHINE PFOZZ F7960 WASHER, FLAT PFOOO P5395 LEVER, MANUAL CONTRO PFOZZ MS WASHER, FLAT PFOZZ PK379 PIN, COTTER PFOZZ MS WASHER, FLAT PFOZZ VALVE, BALL PFOZZ ELBOW, PIPE PFOZZ S ELBOW, PIPE MOOZZ P TUBE MAKE FROM TUBE P/N 5P PFOOO L3446 FITTING ASSEMBLY, FU PFOZZ H2663.NUT, TUBE COUPLING PFOZZ H2662.BUSHING, RUBBER END OF FIGURE

41 1 2 THRU 15 TA FIGURE 14. PRIMARY FUEL FILTER.

42 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0309 FUEL FILTERS FIG 14 PRIMARY FUEL FILTER 1 PFOOO S7608 PRIMARY FUEL FILTER PFOZZ H2767.PACKING, PREFORMED PFOZZ L3769.RING PFOZZ A WASHER, FLAT PFOZZ H2807.NUT, SLEEVE PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ B4506.WASHER LOCK PFOZZ MS WASHER, FLAT PFOZZ S5091.BASE PFOZZ H2810.FILTER BODY, FLUID PFOZZ S9323.SPRING, HELICAL, COMP PFOZZ H9678.SEAT, HELICAL COMPRE PFOZZ MS RING, RETAINING PAOZZ M2341.FILTER ELEMENT, FLUI PFOZZ H2778.GASKET... 1 END OF FIGURE 14-1

43 12 13 THRU 15 FIGURE 15. FUEL FILTER. TA235248

44 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0309 FUEL FILTERS FIG 15 FUEL FILTER 1 PFOZZ S5011 PACKING, PREFORMED PFOZZ N7016 COVER, FILTER PFOZZ P537 WASHER PFOZZ M SCREW, CAP, HEXAGON H PFOZZ MS WASHER, FLAT PFOZZ B4506 WASHER, LOCK PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ F3901 SEAT, AIR VENT, VALVE PFOZZ A1927 NEEDLE, VALVE PFOZZ S1588 BOLT, MACHINE PFOZZ S1269 GASKET PFOOO P5168 BASE ASSEMBLY PFOZZ PLUG, PIPE PFOZZ S4167.STUD PFOZZ H3171.PLUG, PIPE PFOZZ PER53 FILTER ELEMENT, FLUI PFOZZ H5330 BOLT, ENGINE PFOZZ P5125 GASKET PFOZZ P4679 ADAPTER PFOZZ P5124 GASKET PFOZZ J5268 PACKING, PREFORMED PFOZZ H7954 SCREW, CAP, HEXAGON H PFOZZ P5123 SPACER, SLEEVE PFOZZ MS BOLT, MACHINE PFOZZ MS WASHER, LOCK PFOZZ S777 FLANGE, PIPE PFOZZ M6542 GASKET PFOZZ P5051 HOUSING... 1 END OF FIGURE 15-1

45 TA FIGURE 16. GLOW PLUG AND LEAD (ENGINE SERIAL RANGE 17S5088 AND UP).

46 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0311 ENGINE STARTING AIDS FIG 16 GLOW PLUG AND LEAD (ENGINE SERIAL RANGE 17S5088 AND UP) 1 PFOZZ S658 WASHER, FLAT PFOZZ N652 LEAD ASSEMBLY, ELECT PFOZZ P7324 GLOW PLUG... 6 END OF FIGURE 16-1

47 6 7 FIGURE 17. EXHAUST MUFFLER. TA235252

48 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 04 EXHAUST SYSTEM GROUP 0401 MUFFLER AND PIPES FIG 17 EXHAUST MUFFLER 1 PFOZZ F8814 CLAMP PFOZZ CAP ASSEMBLY, PROTEC XDOZZ N5435 EJECTOR ASSEMBLY PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ B5355 NUT, PLAIN, HEXAGON PFOOO N7212 MUFFLER, EXHAUST PFOZZ S532.STUD, PLAIN XDOZZ N5968 SUPPORT PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ A NUT, PLAIN, HEXAGON PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ M2894 WASHER, FLAT... 2 END OF FIGURE 17-1

49 FIGURE 18. MUFFLER. TA235253

50 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0401 MUFFLER AND PIPES FIG 18 MUFFLER 1 PFOZZ CAP ASSEMBLY, PROTEC PFOZZ N4577 MUFFLER, EXHAUST PFOZZ M5S WASHER, FLAT PFOZZ B4506 WASHER, LOCK PFOZZ S1594 BOLT, MACHINE PFOZZ A NUT, PLAIN, HEXAGON PFOZZ N9221 BRACKET PFOZZ K3256 STUD PFOZZ F8814 CLAMP PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ NUT, PLAIN, HEXAGON... 1 END OF FIGURE 18-1

51 12 13 TA FIGURE 19. RADIATOR (REAR VIEW, USE WITH SERIAL RANGE 77V5006 THRU 77V5953).

52 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 05 COOLING SYSTEM GROUP 0501 RADIATOR, EVAPORATIVE COOLER, OR HEAT EXCHANGER FIG 19 RADIATOR (REAR VIEW, USE WITH SERIAL RANGE 77V5006 THRU 77V5953) 1 XDOZZ N6157 STRIP PFOZZ S4629 GASKET PFOZZ M19 74 WASHER, FLAT PFOZZ S5080 BOLT, MACHINE PFOZZ S1218 THERMOSTAT, FLOW CON PFOZZ S1211 COVER, ACCESS PFOZZ S1213 PLATE PFOZZ A2029 BOLT, MACHINE PFOZZ M2894 WASHER, FLAT PFOZZ N7517 STRIP PFOZZ S2087 SCREW, CAP, HEXAGON H PFOOO N799 SHIELD ASSEMBLY PFOZZ F2978.NUT, PLAIN, WELDING PFOZZ P3864 SCREW, CAP, HEXAGON H PFOZZ N876 BAFFLE PFOZZ N877 STRIP PFOZZ N812 TANK ASSEMBLY PFOZZ S1594 BOLT, MACHINE PFOZZ N793 ELBOW, HOSE TO BOSS PFOZZ N875 GASKET PFOZZ P3C PLUG, PIPE PFOZZ H9819 ADAPTER, DRAIN PLUG PFOZZ H9818 GASKET PFOZZ PLUG, MACHINE THREAD XDOZZ N919 BAR PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ N961 BAFFLE ASSEMBLY PFOZZ N7518 STRIP PFOZZ P598 CLAMP, HOSE MOOZZ HOSE MAKE FROM HOSE P/N 5P END OF FIGURE 19-1

53 AND THRU FIGURE 20. RADIATOR (SIDE VIEW, USE WITH SERIAL RANGE 77V5006 THRU 77V5953). TA235255

54 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0501 RADIATOR, EVAPORATIVE COOLER, OR HEAT EXCHANGER FIG 20 RADIATOR (SIDE VIEW, USE WITH SERIAL RANGE 77V5006 THRU 77V5953) 1 PFOZZ N6855 HOSE PFOZZ P598 CLAMP, HOSE PFOZZ N795 ELBOW, HOSE TO BOSS PFOZZ H1717 BOLT, MACHINE PFOZZ P6434 GASKET PFOOO S7809 CAP, FILLER OPENING PFOZZ S9979.RING PFOZZ S2846.WASHER, FLAT PFOZZ P3230.GASKET PFOZZ S7807.INSERT... 1 END OF FIGURE 20-1

55 35 36 THRU 39 TA FIGURE 21. RADIATOR (SIDE VIEW).

56 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0501 RADIATOR, EVAPORATIVE COOLER, OR HEAT EXCHANGER FIG 21 RADIATOR (SIDE VIEW) 1 PFOZZ P598 CLAMP, HOSE USE WITH SERIAL RANGE 2 77V 5954 THRU 77V MOOZZ HOSE MAKE FROM HOSE P/N 5PL263, USE 1 WITH SERIAL RANGE 77V5954 THRU 77V9475W... 3 PFOZZ N64 ELBOW, HOSE TO BOSS USE WITH SERIAL 1 RANGE 77V5954 THRU 77V PFOZZ H1717 BOLT, MACHINE USE WITH SERIAL RANGE 2 77V5954 THRU 77V PFOZZ P6434 GASKET USE WITH SERIAL RANGE 1 77V5954 THRU 77V PFOOO S7809 CAP, FILLER OPENING USE WITH SERIAL... 1 RANGE 77V5954 THRU 77V PFOZZ S9979.RING PFOZZ S2846.WASHER, FLAT PFOZZ P3230.GASKET PFOZZ S7807.INSERT... 1 END OF FIGURE 21-1

57 TA FIGURE 22. RADIATOR CAP PROTECTIVE COVER.

58 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0501 RADIATOR, EVAPORATIVE COOLER, OR HEAT EXCHANGER FIG 22 RADIATOR CAP PROTECTIVE COVER 1 PFOOO S6096 CAP GROUP RADIATOR CAP PFOZZ P3230.GASKET PFOZZ M8649.RING PFOZZ S7949.PADLOCK GROUP PFOZZ M439.KEY PFOZZ N2957.COVER PFOZZ N5565.CAP, FILLER OPENING PFOZZ S2846.WASHER, FLAT PFOZZ S9979.RING... 1 END OF FIGURE 22-1

59 27 28 THRU 30 FIGURE 23. WATER MANIFOLD. TA235260

60 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0503 EATER MANIFOLD, HEADERS, THERMOSTATS AND HOUSING GASKET FIG 23 WATER MANIFOLD 1 PFOZZ S764 GASKET PFOZZ P597 CLAMP, HOSE MOOZZ P HOSE MAKE FROM HOSE P/N 5P PFOZZ N8724 TUBE ASSEMBLY, METAL PFOZZ M2894 WASHER, FLAT PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ F7767 GASKET PFOZZ S795 GASKET PFOZZ P4730 MANIFOLD PFOZZ A NUT, PLAIN, HEXAGON PFOZZ L2070 BOLT, MACHINE PFOZZ F8146 PACKING, PREFORMED PFOZZ N6544 SUPPORT PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ N6545 SUPPORT PFOZZ S5128 COVER PFOZZ A2029 BOLT, MACHINE PFOZZ H2906 GASKET PFOZZ H2902 MANIFOLD PFOZZ MS NUT, PLAIN, HEXAGON PFOZZ A615 GASKET PFOZZ H5572 GASKET PFOZZ S6989 TUBE ASSEMBLY, METAL PFOZZ L1143 BOLT, MACHINE PFOZZ F3202 GASKET PFOZZ S9192 ELBOW ASSEMBLY, PIPE XDOOO S763 COVER ASSEMBLY PFOZZ S SEAL, PLAIN ENCASED PFOZZ B4845.PLUG, MACHINE THREAD PFOZZ M1336.SLEEVE, COMPRESSION, PFOZZ L1352 BOLT, MACHINE PFOZZ THERMOSTAT, FLOW CON PFOZZ S1588 BOLT, MACHINE PFOZZ N797 TUBE ASSEMBLY, METAL... 1 END OF FIGURE 23-1

61 TA FIGURE 24. WATER MANIFOLD LINES AND RELATED PARTS.

62 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0503 WATER MANIFOLD, HEADERS, THERMOSTATS AND HOUSING GASKET FIG 24 WATER MANIFOLD LINES AND RELATED PARTS 1 PFOZZ M6214 PLUG, PIPE USE WITH ENGINE SERIAL 2 RANGE 17S5088 THRU 17S PFOZZ S361 TUBING, NONMETALLIC USE WITH ENGINE 1 SERIAL RANGE 17S5088 THRU 17S PFOZZ B ELBOW, PIPE TO TUBE USE WITH ENGINE 2 SERIAL RANGE 17S5088 THRU 17S PFOZZ lf1344 INVERTED NUT, TUBE-C USE WITH 2 ENGINE SERIAL RANGE 17S5088 THRU 17S PFOZZ N1014 TUBE ASSEMBLY, METAL USE WITH 1 ENGINE SERIAL RANGE 17S5088 THRU 17S PFOZZ MS51504A4 ELBOW, PIPE TO TUBE USE WITH ENGINE 1 SERIAL RANGE 17S5966 AND UP... 7 PFOZZ N3840 COVER, ACCESS USE WITH ENGINE 1 SERIAL RANGE 17S5966 AND UP... 8 PFOZZ MS BOLT, MACHINE USE WITH ENGINE 6 SERIAL RANGE 17S5088 AND UP... 9 PFOZZ M1974 WASHER, FLAT USE WITH ENGINE SERIAL 6 RANGE 17S5088 AND UP PFOZZ N8901 SWITCH ASSEMBLY USE WITH ENGINE 1 SERIAL RANGE 17S9689 AND UP PFOZZ N8434 TUBE ASSEMBLY, METAL USE WITH 1 ENGINE SERIAL RANGE 17S5966 AND UP PFOZZ MS51500A4 ADAPTER, STRAIGHT, PI USE WITH 1 ENGINE SERIAL RANGE 17S5966 AND UP PFOZZ S1594 BOLT, MACHINE USE WITH ENGINE 8 SERIAL RANGE 17S5966 AND UP PFOZZ K9197 ELBOW, TUBE USE WITH ENGINE SERIAL 1 RANGE 17S5966 AND UP PFOZZ H2007 GASKET PFOZZ L1883 FLANGE PFOZZ N96 BONNET PFOZZ N95 GASKET PFOZZ B1915 BOLT PFOZZ N790 GASKET PFOZZ M2894 WASHER, FLAT PFOZZ N7199 COVER PFOZZ N4306 ADAPTER PFOZZ M5414 GASKET PFOZZ N4302 ADAPTER PFOZZ M4217 PACKING, PREFORMED PFOZZ T65 BOLT, MACHINE PFOZZ IA2029 BOLT, MACHINE PFOZZ N89 FLANGE PFOZZ M6214 PLUG, PIPE

63 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 31 PFOZZ N8502 COVER USE WITH ENGINE SERIAL RANGE AND UP PFOZZ N3840 COVER, ACCESS USE WITH ENGINE 1 SERIAL RANGE THRU 17S PFOZZ N3841 GASKET PFOZZ N8433 PIPE USE WITH ENGINE SERIAL RANGE 1 17S5966 AND UP PFOZZ S2093 FLANGE PFOZZ H2652 PACKING, PREFORMED PFOZZ H9008 GASKET PFOZZ P3C PLUG, PIPE... 1 END OF FIGURE 24-2

64 TA FIGURE 25. FAN GUARD AND BELT.

65 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0505 FAN ASSEMBLY FIG 25 FAN GUARD AND BELT 1 PFOZZ P1117 GUARD ASSEMBLY PFOZZ L1351 BOLT, MACHINE PFOZZ M2894 WASHER, FLAT PFOZZ N737 GUARD ASSEMBLY PFOZZ la2029 BOLT, MACHINE PFOZZ N874 FAN ASSEMBLY PFOZZ MS SCREW, CAP, HEXAGON H PAOZZ S8268 BELTS, V, MATCHED SET... 1 END OF FIGURE 25-1

66 THRU THRU 30 TA FIGURE 26. FAN DRIVE.

67 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0505 FAN ASSEMBLY FIG 26 FAN DRIVE 1 PFOZZ MS FITTING, LUBRICATION PFOZZ S203 HOSE ASSEMBLY PFOZZ MS ADAPTER, STRAIGHT, PI PFOZZ N5959 SPRING PFOZZ B1419 PIN, STRAIGHT, HEADED PFOZZ MS PIN, COTTER PFOOO N7678 BRACKET ASSEMBLY PFOOO N744 BRACKET ASSEMBLY PFOZZ N7677.SHAFT USE WITH P/N 6N PFOZZ N718.SHAFT USE WITH P/N 6N PFOZZ N4301 SPACER USE WITH ENGINE SERIAL... 1 RANGE 17S5088 THRU 17S PFOZZ H1566 SPACER PFOZZ L2070 BOLT, MACHINE PFOZZ S585 SPACER, SLEEVE PFOZZ N762 PULLEY PFOZZ H6184 PACKING, PREFORMED PFOZZ N7591 NUT USE WITH ENGINE SERIAL RANGE 2 17S5088 THRU 17S PFOZZ S1588 BOLT, MACHINE PFOZZ M909 RETAINER, NUT AND BO PFOZZ S1175 SPACER, PLATE PFOZZ N726 COVER PFOZZ MS SCREW, CAP, HEXAGON H XDOZZ N9742 HUB PFOZZ S1461 SHIM PFOOO P1131 ARM ASSEMBLY PFOZZ S9029.BUSHING PFOZZ S6746.SHAFT PFOZZ PIN, STRAIGHT, HEADLE PFOZZ M2894 WASHER, FLAT PFOOO P1132 BASE ASSEMBLY PFOZZ PIN, STRAIGHT, HEADLE PFOZZ S8002.SHAFT PFOZZ B1891.PIN, STRAIGHT, HEADLE PFOZZ S7818 PLATE PFOZZ B2327 RING, RETAINING PFOZZ B1124 BEARING, BALL, ANNULA PFOZZ S WASHER, FLAT LARGE PFOZZ L1351 BOLT, MACHINE PFOZZ S6150 PLATE, FAN BELT TIGH PFOZZ MS BOLT, MACHINE PFOZZ S6151 GASKET PFOZZ P1129 PULLEY PFOZZ S6105 SPACER, SLEEVE PFOZZ M9735 SEAL, PLAIN ENCASED PFOZZ D1683 ELBOW, PIPE PFOZZ A2029 BOLT, MACHINE

68 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 44 PFOZZ H9628 GASKET PFOZZ W55 BEARING, BALL, ANNULA PFOZZ D7794 CLAMP, LOOP PFOZZ M9739 SEAL, PLAIN ENCASED PFOZZ S1566 BOLT, MACHINE PFOZZ N4307 SPACER PFOZZ S2388 HOSE ASSEMBLY, NONME... 1 END OF FIGURE 26-2

69 10 11 THRU 13 TA FIGURE 27. ALTERNATOR, BRACKET AND PULLEY.

70 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 06 ELECTRICAL SYSTEM GROUP 0601 ALTERNATOR FIG 27 ALTERNATOR, BRACKET AND PULLEY 1 PFOZZ B3235 BOLT, MACHINE PFOZZ B4508 WASHER, LOCK XDOZZ S2319 BRACKET ASSEMBLY PFOZZ NUT, PLAIN, HEXAGON PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ P5590 STRAP PFOZZ A1460 BOLT, MACHINE XDOZZ S4223 SPACER PFOZZ M4791 WASHER, FLAT AOOOO D674 WIRE ASSEMBLY MOOZZ C WIRE MAKE FROM WIRE P/N 5P PFOZZ H1188.TERMINAL, LUG PFOZZ H1186.TERMINAL, LUG PFOZZ H8260 BOLT, MACHINE XDOZZ P5065 BRACKET ASSEMBLY PFOZZ A2029 BOLT, MACHINE PFOZZ B4506 WASHER, LOCK PFOZZ H1416 GASKET PFOZZ N5390 PULLEY PFOZZ S9078 BELTS, V, MATCHED SET PFOOO N9294 ALTERNATOR... 1 END OF FIGURE 27-1

71 THRU THRU THRU 39 FIGURE 28. DELCO REMY ALTERNATOR.

72 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0601 ALTERNATOR FIG 28 DELCO REMY ALTERNATOR 1 PFOFF IPD5S9088 GENERATOR, ENGINE AC... 1 END OF FIGURE 28-1

73 THRU 51 9 THRU THRU 44 TA FIGURE 29. STARTER (USE WITH ENGINE SERIAL RANGE 17S5088 THRU 17S10786).

74 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0603 STARTING MOTOR FIG 29 STARTER (USE WITH ENGINE SERIAL RANGE 17S5088 THRU 17S PFOFF MOTOR, STARTING... 1 END OF FIGURE 29-1

75 FIGURE 30. STARTER AND RELATED PARTS (USE WITH ENGINE SERIAL RANGE 17S10787 AND UP). TA235272

76 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0603 STARTING MOTOR FIG 30 STARTER AND RELATED PARTS (USE WITH ENGINE SERIAL RANGE 17S10787 AND UP) 1 PFOZZ S2332 BOLT, MACHINE PFOZZ MS WASHER, LOCK PFOZZ S2325 ADAPTOR PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ S4459 GASKET PFOZZ S2331 BOLT PFOZZ M6853 GASKET PFOFF MOTOR... 1 END OF FIGURE 30-1

77 TA FIGURE 31. INSTRUMENT PANEL AND VANDALISM GUARD.

78 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0607 INSTRUMENT PANEL FIG 31 INSTRUMENT PANEL AND VANDALISM GUARD 1 XDOZZ P9372 COVER ASSEMBLY XDOZZ S8576 PANEL PFOZZ MS SCREW, DRIVE PFOZZ M3222 EYE PADLOCK PFOZZ S7949 PADLOCK GROUP WITH KEY... 1 END OF FIGURE 31-1

79 THRU 6 8 THRU 9 16 THRU AND THRU 32 TA FIGURE 32. INSTRUMENT CONTROL PANEL SWITCHES AND CIRCUIT BREAKERS.

80 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0607 INSTRUMENT PANEL FIG 32 INSTRUMENT CONTROL PANEL SWITCHES AND CIRCUIT BREAKERS 1 PFOZZ F253 WASHER, LOCK PFOOO S6402 SWITCH, ROTARY LIGHT PFOZZ S5432.KNOB PFOZZ H27.NUT PFOZZ H4393.WASHER, LOCK PFOZZ MS SCREW, MACHINE PFOOO P2717 WIRE ASSEMBLY USE WITH SERIAL 1 RANGE 77V8516 THRU 77V PFOOO K3934 WIRE A MOOZZ WIRE ELECTRICAL MAKE FROM WIRE P/ 1 N , USE WITH P/N 9P MOOZZ WIRE MAKE FROM WIRE P/N 5P616, USE 1 WITH P/N 6K PFOZZ L8066.TERMINAL, LUG PFOZZ A2109 AMMETER PFOZZ H5165 PLATE, MENDING PFOZZ F4879 BOLT, MACHINE PFOZZ B4506 WASHER, LOCK PFOZZ P230 SWITCH OIL PRESSURE, USE WITH 1 SERIAL RANGE 77V8516 THRU 77V PFOOO SWITCH, ROTARY HEAT START PFOOO N4160 SWITCH, ROTARY HEAT START, USE WITH 1 SERIAL RANGE 77V9443 THRU 77V PFOZZ F3437.KNOB PFOZZ L7200.SCREW, MACHINE PFOZZ MS WASHER, LOCK PFOZZ MS WASHER, LOCK USE WITH P/N 7N PFOZZ F9327.SCREW, MACHINE USE WITH P/N 7N PFOZZ F253.WASHER, LOCK USE WITH P/N 7N PFOZZ H27 NUT USE WITH P/N 7N PFOOO M4233 LIGHT, PANEL USE WITH ENGINE SERIAL 1 RANGE 77V8516 THRU 77V PFOZZ MS LAMP, INCANDESCENT PFOOO P2189 LEAD, ELECTRICAL USE WITH SERIAL 1 RANGE 77V8516 THRU 77V MOOZZ P WIRE MAKE FROM WIRE P/N 5P PFOZZ MS TERMINAL, LUG PFOZZ PDM-40 CIRCUIT BREAKER PFOOO S4301 WIRE A PFOZZ MS TERMINAL, LUG MOOZZ WIRE MAKE FROM WIRE P/N 5P MOOZZ WIRE MAKE FROM WIRE P/N 5P PFOZZ L8066.TERMINAL, LUG PFOZZ L4507 SCREW PFOZZ M6668 SCREW, MACHINE USE WITH SERIAL 2 RANGE 77V8516 THRU 77V END OF FIGURE

81 1 2 THRU 6 TA FIGURE 33. IGNITION LOCK SWITCH.

82 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0607 INSTRUMENT PANEL FIG 33 IGNITION LOCK SWITCH 1 PFOOO N0718 SWITCH, LOCK, IGNITIO PFOZZ H5303.NUT PFOZZ SWITCH, LOCK PFOZZ MS WASHER, LOCK PFOZZ F7259.WASHER, LOCK PFOZZ NUT, PLAIN, HEXAGON... 4 END OF FIGURE 33-1

83 THRU 4 8 THRU 9 11 THRU 12 TA FIGURE 34. ELECTRIC HOURMETER.

84 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0607 INSTRUMENT PANEL FIG 34 ELECTRIC HOURMETER 1 PFOZZ N3700 METER, TIME TOTALIZI AOOOO L1454 WIRE ASSEMBLY MOOZZ WIRE MAKE FROM WIRE P/N M BKEO... 3 MOOZZ P497-4.WIRE MAKE FROM WIRE P/N 5P PFOZZ MS TERMINAL, LUG PFOZZ MROB TEE, PIPE PFOZZ G8010 SWITCH, PRESSURE AOOOO H8840 WIRE ASSEMBLY MOOZZ WIRE MAKE FROM WIRE P/N M16878/ 1 1BKEO... 9 PFOZZ MS TERMINAL, LUG AOOOO D122 WIRE ASSEMBLY PFOZZ F9224.TERMINAL MOOZZ WIRE MAKE FROM WIRE P/N M16878/ 1 1BKEO... END OF FIGURE 34-1

85 FIGURE 35. BACKUP WARNING ALARM HARNESS.

86 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0607 INSTRUMENT PANEL FIG 35 BACKUP WARNING ALARM HARNESS 1 PFOZZ S5014 CONTACT PFOZZ S5013 SPRING PFOZZ S5011 BODY PFOZZ S2093 STRAP MOOZZ P384-5 TUBE MAKE FROM TUBE P/N 5P MOOZZ P TUBE MAKE FROM TUBE P/N 5P MOOZZ P497-1 WIRE MAKE FROM WIRE P/N 5P PFOZZ MS TERMINAL, LUG... 1 END OF FIGURE 35-1

87 1 3 2 THRU 6 4 THRU 6 TA FIGURE 36. LAMP ASSEMBLY.

88 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0609 LIGHTS FIG 36 LAMP ASSEMBLY 1 PFOOO M2875 FLOODLIGHT, ELECTRIC PFOZZ MS LAMP, INCANDESCENT PFOOO P2541.HOUSING, LIGHT PFOZZ M5282..RETAINER, LENS PFOZZ M5284..MOULDING ASSEMBLY PFOZZ M6668..SCREW,MACHINE... 2 END OF FIGURE 36-1

89 FIGURE 37. LAMP GUARDS AND BRACKETS (USE WITH SERIAL RANGE 77V8516 THRU 77V9475). TA235283

90 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0609 LIGHTS FIG 37 LAMP GUARDS ANC BRACKETS (USE WITH SERIAL RANGE 77V8516 THRU 77V9475) 1 XDOZZ P5659 BRACKET, ANGLE PFOZZ K700 GROMMET, NONMETALLIC PFOZZ M3070 GUARD, LAMP LEFT HAND PFOZZ IM3069 GUARD, LAMP RIGHT HAND PFOZZ F1240 GROMMET, NONMETALLIC PFOZZ A2029 BOLT, MACHINE PFOZZ B4506 WASHER, LOCK PFOZZ MS NUT, PLAIN, HEXAGON PFOZZ MS WASHER, LOCK PFOZZ BE352 WASHER, SPRING TENSI PFOZZ S1594 BOLT, MACHINE... 8 END OF FIGURE 37-1

91 THRU TA FIGURE 38. BACKUP WARNING ALARM (FOR USE WITH ROPS).

92 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0610 SENDING UNITS AND WARNING SWITCHES FIG 38 BACKUP WARNING ALARM (FOR USE WITH ROPS) 1 XDOZZ P9999 PLATE ASSEMBLY PFOZZ MS WASHER, FLAT PFOZZ S1594 BOLT, MACHINE PFOZZ B4506 WASHER, LOCK PFOZZ K700 GROMMET, NONMETALLIC AOOOO P3896 WIRE ASSEMBLY MOOZZ P TUBE MAKE FROM TUBE P/N 5P MOOZZ P WIRE MAKE FROM WIRE P/N 5P PFOZZ MS TERMINAL, LUG PFOZZ S5012.CAP PFOZZ S5014.CONTACT PFOZZ PE989 FUSE PFOZZ P8990 SWITCH ASSEMBLY PFOZZ D5578 MAGNET ASSY PFOZZ J8668 STUD, CONTINUOUS THR PFOZZ MS NUT, PLAIN, HEXAGON XDOZZ P5035 LEVER PFOZZ A4639 BOLT, MACHINE PFOZZ A NUT, PLAIN, HEXAGON PFOZZ M620 STUD, PLAIN XDOZZ P5058 BRACKET ASSEMBLY PFOZZ B2183 NUT PFOZZ K806 STRAP XDOZZ P2243 SPEAKER ASSEMBLY PFOZZ S1570 BOLT, MACHINE PFOZZ WASHER, LOCK XDOOO P5100 GUARD ASSEMBLY PFOZZ SPACER... 2 END OF FIGURE 38-1

93 THRU THRU THRU 45 TA FIGURE 39. BACKUP WARNING ALARM.

94 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0610 SENDING UNITS AND WARNING SWITCHES FIG 39 BACKUP WARNING ALARM 1 PFOZZ S9191 BOLT, MACHINE PFOOO HORN, ELECTRICAL PFOZZ P6725.LEAD ASSEMBLY, ELECT PFOZZ BOLT, MACHINE PFOZZ A NUT, PLAIN, HEXAGON PFOZZ WASHER, LOCK PFOZZ H5166 RETAINER, WIRING HAR PFOZZ P8989 FUSE AOOOO P6216 WIRE ASSEMBLY MOOZZ P WIRE MAKE FROM WIRE P/N 5P PFOZZ S5012.CAP PFOZZ S5014.CONTACT PFOZZ MS TERMINAL, LUG PFOZZ P2290 SPRING, SPIRAL, TORSI PFOZZ P2289 RETAINER, NUT AND BO XDOZZ H8909 NUT, SELF-LOCKING, HE PFOZZ P5582 SCREW, MACHINE PFOZZ NUT, SELF-LOCKING, HE PFOZZ WA1248 WASHER, FLAT XDOZZ P4029 BUMPER PFOZZ M7758 RIVET, BLIND XDOZZ P2292 PLATE XDOZZ P4027 GUIDE XDOZZ P4925 LEVER ASSEMBLY PFOZZ D9483 SETSCREW PFOZZ MS NUT, PLAIN, HEXAGON PFOZZ M2894 WASHER, FLAT PFOZZ P4923 BEARING, WASHER, THRU XDOZZ P9395 ACTUATOR PFOOO P4107 SWITCH ASSEMBLY XDOZZ P4115.SWITCH MOOZZ P TUBE MAKE FROM TUBE P/N 5P MOOZZ P WIRE MAKE FROM WIRE P/N 5P PFOZZ M7928/54.SPLICE, CONDUCTOR PFOZZ STRAP PFOZZ CLAMP, LOOP PFOZZ MS WASHER, FLAT PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ L1351 BOLT, MACHINE AOOOO P4108 HARNESS ASSEMBLY MOOZZ P WIRE MAKE FROM WIRE P/N 5P PFOZZ MS TERMINAL, LUG PFOZZ S5011.BODY PFOZZ S5013.SPRING PFOZZ S5014.CONTACT XDOZZ P4028 BRACKET END OF FIGURE

95 THRU 8 10 THRU THRU 19 TA FIGURE 40. COOLANT FLOW WARNING ALARM (USE WITH ENGINE SERIAL RANGE 17S5966 THRU 17S9688).

96 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0610 SENDING UNITS AND WARNING SWITCHES FIG 40 COOLANT FLOW WARNING ALARM (USE WITH ENGINE SERIAL RANGE 17S5966 THRU 17S9688) 1 PFOZZ D HORN, ELECTRICAL PFOZZ S2093 STRAP PFOZZ N8901 SWITCH ASSEMBLY COOLANT FLOW PFOZZ N3841 GASKET AOOOO P5878 WIRE ASSEMBLY AOOOO P5877 WIRE ASSEMBLY PFOZZ L3916.TERMINAL, QUICK DISC MOOZZ P WIRE MAKE FROM WIRE P/N 5P5624, 1 USE WITH P/N 8P MOOZZ P WIRE MAKE FROM WIRE P/N 5P5624, 1 USE WITH PIN 8P PFOZZ MS TERMINAL, LUG AOOOO P5875.WIRE ASSEMBLY PFOZZ L3916.TERMINAL, QUICK DISC MOOZZ P WIRE MAKE FROM WIRE P/N 5P PFOZZ MS TERMINAL, LUG PFOZZ HKP-HH/5 FUSEHOLDER, EXTRACTO XDOZZ N2867 CAP PFOZZ FUSE, CARTRIDGE FIVE AMPERE AOOOO P5876 WIRE ASSEMBLY PFOZZ MS TERMINAL, LUG MOOZZ P WIRE MAKE FROM WIRE P/N 5P PFOZZ L3916.TERMINAL, QUICK DISC PFOZZ A NUT, PLAIN, HEXAGON PFOZZ MS WASHER, FLAT PFOZZ BOLT PFOZZ S1594 BOLT, MACHINE PFOZZ B4506 WASHER, LOCK PFOZZ P5881 BRACKET, ANGLE PFOZZ M527L83-10 WASHER, FLAT PFOZZ JM56 NUT, PLAIN, HEXAGON PFOZZ WASHER, LOCK PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ N214 SWITCH, SOLID STATE PFOZZ NUT, PLAIN, HEXAGON PFOZZ M2048F WASHER, FLAT PFOZZ MS BOLT, MACHINE PFOZZ MS WASHER, LOCK... 2 END OF FIGURE 40-1

97 THRU 8 10 THRU THRU 18 TA FIGURE 41. ELECTRIC HORN AND ATTACHING PARTS (USE WITH SERIAL RANGE 77V8516 THRU 77V9475).

98 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0611 HORN, SIREN FIG 41 ELECTRIC HORN AND ATTACHING PARTS (USE WITH SERIAL RANGE 77V8516 THRU 77V9475) 1 PFOZZ N214 SWITCH SOLID STATE PFOZZ MS BOLT, MACHINE PFOZZ MS WASHER, LOCK PFOZZ M2G48F WASHER, FLAT AOOOO P5876 WIRE ASSEMBLY PFOZZ MS TERMINAL, LUG MOOZZ P WIRE MAKE FROM WIRE P/N 5P PFOZZ L3916.TERMINAL, QUICK DISC AOOOO P5878 WIRE ASSEMBLY MOOZZ P WIRE MAKE FROM WIRE P/N 5P PFOZZ MS TERMINAL, LUG PFOZZ L3916.TERMINAL, QUICK DISC PFOZZ D4484 HORN, ELECTRICAL PFOZZ S36 NUT, PLAIN, HEXAGON AOOOO P5875 WIRE ASSEMBLY PFOZZ MS TERMINAL, LUG MOOZZ P WIRE MAKE FROM WIRE P/N 5P PFOZZ L3916.TERMINAL, QUICK DISC PFOZZ P5881 BRACKET, ANGLE PFOZZ WASHER, SQUARE CONE PFOZZ S1588 BOLT, MACHINE PFOZZ JM56 NUT, PLAIN, HEXAGON PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ WASHER, LOCK PFOZZ MS WASHER, FLAT PFOZZ HKP-HH/15 FUSEHOLDER, EXTRACTO PFOZZ S6024 FUSE, CARTRIDGE... 1 END OF FIGURE 41-1

99 2 3 THRU 5 VIEW A TA FIGURE 42. DUAL ELECTRIC HORNS (USE WITH SERIAL RANGE 77V9163 THRU 77V9475).

100 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0611 HORN, SIREN FIG 42 DUAL ELECTRIC HORNS (USE WITH SERIAL RANGE 77V9163 THRU 77YV9475) 1 XDOZZ N9356 HORN 24 VOLT PFOOO P1342 LEAD, ELECTRICAL MOOZZ P WIRE MAKE FROM WIRE P/N 5P PFOZZ L3916.TERMINAL, QUICK DISC PFOZZ MS TERMINAL, LUG XDOZZ N9357 HORN 24 VOLT PFOZZ P9614 SETSCREW XDOZZ S5937 NUT, SELF-LOCKING, HE PFOZZ MS WASHER, LOCK PFOZZ P537 WASHER PFOZZ D6235 NUT, SELF-LOCKING, HE PFOZZ S1615 BOLT, MACHINE PFOZZ B4506 WASHER, LOCK PFOZZ A2029 BOLT, MACHINE XDOZZ G2570 BRACKET... 1 END OF FIGURE 42-1

101 THRU 9 11 THRU THRU THRU 35 VIEW A TA FIGURE 43. CENTER MOUNTED ELECTRIC HORN.

102 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0611 HORN, SIREN FIG 43 CENTER MOUNTED ELECTRIC HORN 1 XDOZZ P230 SWITCH, PUSH AOOOO P1268 WIRE ASSEMBLY PFOZZ S5011.BODY PFOZZ S5013.SPRING PFOZZ S5014.CONTACT PFOZZ S2093.STRAP MOOZZ C TUBE MAKE FROM TUBING P/N 5P MOOZZ A WIRE MAKE FROM WIRE P/N 6A PFOZZ MS TERMINAL, LUG AMMETER AOOOO P1269 WIRE ASSEMBLY PFOZZ S7837.TERMINAL, LUG PFOZZ S2093.STRAP MOOZZ C TUBE MAKE FROM TUBING P/N 5P MOOZZ A WIRE MAKE FROM WIRE PIN 6A PFOZZ L3916.TERMINAL, QUICK DISC XDOZZ S1043.BUTT PFOZZ H5166 RETAINER, WIRING HAR PFOZZ HORN, ELECTRICAL PFOZZ S2087 SCREW, CAP, HEXAGON H PFOOO P1342 LEAD, ELECTRICAL MOOZZ A WIRE MAKE FROM WIRE P/N 6A PFOZZ MS TERMINAL, LUG PFOZZ L3916.TERMINAL, QUICK DISC XDOZZ P1382 MOUNT PFOZZ WASHER, LOCK PFOZZ L1351 BOLT, MACHINE PFOZZ MS SCREW, CAP, HEXAGON H XDOZZ R4850 BLOCK XDOZZ P1270 BRACKET XDOZZ HORN ASSEMBLY AOOOO P3222 WIRE ASSEMBLY PFOZZ S5012.CAP PFOZZ S5014.CONTACT MOOZZ A WIRE MAKE FROM WIRE P/N 6A PFOZZ MS TERMINAL, LUG PFOZZ FO2A32V15A FUSE, CARTRIDGE PFOZZ S2093 STRAP... 5 END OF FIGURE 43-1

103 THRU THRU THRU THRU 41 TA FIGURE 44. ELECTRIC HORN.

104 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0611 HORN, SIREN FIG 44 ELECTRIC HORN 1 XDOZZ K670 SWITCH XDOZZ F8088 SCREW PFOZZ P16598 NUT, PLAIN, HEXAGON PFOZZ WASHER, LOCK PFOZZ S2093 STRAP AOOOO P1598 WIRE ASSEMBLY MOOZZ P TUBE MAKE FROM TUBE P/N 5P MOOZZ P WIRE MAKE FROM WIRE PIN 5P PFOZZ S2093.STRAP XDOZZ BUTT PFOZZ MS TERMINAL, LUG PFOZZ L3916.TERMINAL, QUICK DISC XDOZZ P3132 BRACKET XDOZZ P6984 MOUNT PFOZZ S2087 SCREW, CAP, HEXAGON H PFOZZ L1351 BOLT, MACHINE PFOZZ B4506 WASHER, LOCK PFOZZ M2894 WASHER, FLAT PFOZZ HORN, ELECTRICAL AOOOO WIRE ASSEMBLY MOOZZ P497-8.WIRE MAKE FRCM WIRE P/N 5P PFOZZ MS TERMINAL, LUG PFOZZ L3916.TERMINAL, QUICK DISC XDOZZ S4871 HORN ASSEMBLY PFOZZ H5166 RETAINER, WIRING HAR PFOZZ F02A32V15A FUSE, CARTRIDGE AOOOO P3222 WIRE ASSEMBLY MOOZZ P WIRE MAKE FROM WIRE P/N 5P PFOZZ S5012.CAP PFOZZ S5014.CONTACT PFOZZ MS TERMINAL, LUG XDOZZ P1726 SUPPORT ASSEMBLY XDOZZ GROMMET AOOOO P3131 WIRE ASSEMBLY MOOZZ TUBE MAKE FROM TUBING P/N 5P MOOZZ P WIRE MAKE FROM WIRE PIN WIRE P/N 5P PFOZZ S2093.STRAP PFOZZ MS TERMINAL, LUG PFOZZ S5011.BODY PFOZZ S5013.SPRING PFOZZ S5014.CONTACT... 1 END OF FIGURE 44-1

105 THRU 10 9 AND THRU AND THRU AND THRU 33 FIGURE 45. BATTERY AND CABLES. TA235291

106 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0612 BATTERIES, STORAGE FIG 45 BATTERY AND CABLES 1 PFOOO CABLE ASSEMBLY PFOOO S4613 CABLE A USE WITH SERIAL RANGE 1 77V8516 THRU 77V MOOZZ P CONDUIT MAKE FROM CONDUIT P/N 1 5P695, USE WITH P/N 1S MOOZZ P CONDUIT MAKE FROM CONDUIT P/N 1 5P695, USE WITH P/N 9S MOOZZ P CABLE MAKE FROM CABLE P/N 5P 747, 1 USE WITH P/N 1S MOOZZ P CABLE MAKE FROM CABLE P/N 5P 747, 1 USE WITH P/N 9S PFOZZ S2244.BOOT PFOZZ S4515.LINER PFOZZ S2093.STRAP PFOZZ S7251.TERMINAL, LUG PFOOO S6049.CHAMBER, CABLE TERMI PFOZZ M6120..NUT, SLEEVE PFOZZ M6119..BOLT, MACHINE PFOOO D5882 CABLE ASSEMBLY USE WITH SERIAL 1 RANGE 77V8516 THRU 77V PFOOO MS TERMINAL, LUG PFOZZ M6119..BOLT, MACHINE PFOZZ M6120..NUT, SLEEVE MOOZZ P747-8.CABLE MAKE FROM CABLE P/N 5P PFOOO P37C2 CABLE A USE WITH SERIAL RANGE 1 77V8516 THRU 77V PFOOO TERMINAL, LUG PFOZZ M6119..BOLT, MACHINE PFOZZ M6120..NUT, SLEEVE MOOZZ P CABLE MAKE FROM CABLE P/N 5P PFOZZ S7252.TERMINAL PFOZZ BATTERY, STORAGE USE WITH SERIAL 2 RANGE 77V8516 THRU 77V PFOZZ S994 CLAMP, LOOP USE WITH SERIAL RANGE 4 77V8516 THRU 77V PFOZZ MS SCREW, CAP, HEXAGON H USE WITH 5 SERIAL RANGE 77V8516 THRU 77V PFOZZ B4506 WASHER, LOCK USE WITH SERIAL RANGE 5 77V8516 THRU 77V PFOZZ S2093 STRAP USE WITH SERIAL RANGE 10 77V8516 THRU 77V PFOOO CABLE A USE WITH SERIAL RANGE 1 77V8516 THRU 77V PFOZZ S7252.TERMINAL MOOZZ P CONDUIT MAKE FROM CONDUIT P/N 1 5P MOOZZ P CABLE MAKE FROM CABLE P/N 5P PFOZZ S2244.BOOT

107 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 32 PFOZZ S4915.LINER PFOZZ STRAP PFOZZ CLIP USE WITH SERIAL RANGE 77V THRU 77V PFOZZ P699 GROMMET USE WITH SERIAL RANGE 2 77V8516 THRU 77V PFOZZ M287 CLIP, SPRING TENSION USE WITH 2 SERIAL RANGE 77V8516 THRU 77V PFOZZ K6705 BOLT, MACHINE USE WITH SERIAL RANGE 2 77V8516 THRU 77V PFOZZ P8245 WASHER, FLAT USE WITH SERIAL RANGE 2 77V8516 THRU 77V PFOZZ H5165 PLATE, MENDING USE WITH SERIAL 1 RANGE 77V8516 THRU 77V END OF FIGURE 45-2

108 AND 7 16 TA FIGURE 46. BATTERY BOX.

109 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0612 BATTERIES, STORAGE FIG 46 BATTERY BOX 1 PFOZZ S1594 BOLT, MACHINE XDOZZ ROD ASSEMBLY PFOZZ H8524 NUT, PLAIN, HEXAGON PFOZZ MS WASHER, FLAT XDOOO S4944 COVER ASSEMBLY PFOZZ CLIP, ELECTRICAL PFOZZ PIN PFOZZ H7366 ROD PFOZZ B9920 SPRING, HELICAL, COMP PFOZZ H7365 HANDLE PFOZZ B2938 PIN PFOZZ MS PIN, COTTER PFOZZ J4384 PIN, STRAIGHT, HEADED PFOZZ PIN, COTTER PFOOO S2539 RETAINER, BATTERY PFOZZ M5617.GROMMET, NONMETALLIC PFOZZ BOLT PFOZZ TUBE PFOZZ B3235 BOLT, MACHINE PFOZZ NUT, PLAIN, HEXAGON PFOZZ WASHER, LOCK XDOZZ S5061 BRACKET ASSEMBLY PFOZZ WASHER, LOCK... 6 END OF FIGURE 46-1

110 VIEW A TA FIGURE 47. BATTERY BOX STRAP.

111 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0612 BATTERIES, STORAGE FIG 47 BATTERY BOX STRAP 1 MOOZZ P TUBE MAKE FROM TUBE P/N 5P PFOZZ S5645 SPRING, HELICAL, EXTE PFOZZ MS PIN, COTTER... 2 END OF FIGURE 47-1

112 1 2 THRU 13 TA FIGURE 48. MAIN WIRING HARNESS (USE WITH SERIAL RANGE 77V5006 THRU 77V8515).

113 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0613 HULL OR CHASSIS WIRING HARNESS FIG 48 MAIN WIRING HARNESS (USE WITH SERIAL RANGE 77V5006 THRU 77V8515) 1 PFOOO P5886 HARNESS ASSEMBLY PFOZZ S5014.CONTACT PFOZZ S5012.CAP MOOZZ WIRE MAKE FROM WIRE P/N 5P V 4 MOOZZ P WIRE MAKE FROM WIRE P/N 5P V 4 MOOZZ P WIRE MAKE FROM WIRE P/N M16878/... V 1BKEO... 5 MOOZZ P TUBE MAKE FROM TUBE P/N 5P PFOZZ S7837.TERMINAL, LUG PFOZZ S5016.TERMINAL PFOZZ S8183.CONNECTOR PFOZZ L8071.TERMINAL, LUG PFOZZ L8066.TERMINAL, LUG PFOZZ L8054.TERMINAL., LUG PFOZZ S5011 BODY PFOZZ S5013.SPRING... 1 END OF FIGURE 48-1

114 THRU THRU 25 FIGURE 49. WIRING HARNESS (USE WITH ENGINE SERIAL RANGE 17S5966 THRU 17S9688). TA235295

115 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0613 HULL OR CHASSIS WIRING HARNESS FIG 49 WIRING HARNESS (USE WITH ENGINE SERIAL RANGE 17S5966 THRU 17S9688) 1 AOOOO P5883 WIRING HARNESS MOOZZ P WIRE MAKE FROM WIRE P/N 5P MOOZZ P WIRE MAKE FROM WIRE P/N 5P MOOZZ P WIRE MAKE FROM WIRE P/N 5P MOOZZ P WIRE MAKE FROM WIRE P/N 5P MOOZZ P WIRE MAKE FROM W-IRE P/N 5P PFOZZ L3916.TERMINAL, QUICK DISC MOOZZ P WIRE MAKE FROM WIRE P/N 5P PFOZZ P2957.TERMINAL MOOZZ P WIRE MAKE FROM WIRE P/N 5P MOOZZ P WIRE MAKE FROM WIRE P/N 5P PFOZZ MS TERMINAL, LUG AOOOO P5884 WIRING HARNESS MOOZZ P WIRE MAKE FROM WIRE P/N 5P MOOZZ P WIRE MAKE FROM WIRE P/N 5P PFOZZ P6725.LEAD ASSEMBLY, ELECT MOOZZ P WIRE MAKE FROM WIRE P/N 5P PFOZZ L3916.TERMINAL, QUICK DISC MOOZZ P WIRE MAKE FROM WIRE P/N 5P MOOZZ P WIRE MAKE FROM WIRE P/N 5P PFOZZ P2957.TERMINAL, LUG MOOZZ P WIRE MAKE FROM WIRE P/N 5P MOOZZ P WIRE MAKE FROM WIRE P/N 5P PFOZZ MS TERMINAL, LUG MOOZZ P WIRE MAKE FROM WIRE P/N 5P END OF FIGURE 49-1

116 THRU THRU 23 TA FIGURE 50. MAIN ELECTRIC WIRING HARNESS (USE WITH SERIAL RANGE 77V8516 THRU 77V9475).

117 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0613 HULL OR CHASSIS WIRING HARNESS FIG 50 MAIN ELECTRIC WIRING HARNESS (USE WITH SERIAL RANGE 77V8516 THRU 77V9475) 1 AOOOO P7908 WIRING HARNESS MOOZZ P WIRE MAKE FROM WIRE P/N M16878/ V 3BMGO... 2 MOOZZ WIRE MAKE FROM WIRE P/N 5P V 2 MOOZZ P WIRE MAKE FROM WIRE P/N 5P V 3 PFOZZ N9587.TERMINAL, QUICK DISC PFOZZ MS TERMINAL, LUG PFOZZ S5014.CONTACT PFOZZ S5013.SPRING PFOZZ S5011.BODY PFOZZ S5012.CAP PFOZZ P3160.CONNECTOR, PLUG, ELEC PFOZZ R1034.SHELL PFOZZ M6018.TERMINAL ASSEMBLY PFOZZ WASHER, FLAT PFOZZ L8071.TERMINAL, LUG PFOZZ MS TERMINAL, LUG PFOZZ L8054.TERMINAL, LUG PFOZZ L3916.TERMINAL, QUICK DISC PFOZZ P2957.TERMINAL, LUG PFOZZ S7837.TERMINAL, LUG PFOZZ MS TERMINAL, LUG PFOOO S8624 LEAD, ELECTRICAL PFOZZ TERMINAL MOOZZ P747-1.CABLE MAKE FROM CABLE P/N 5P PFOZZ S7251.TERMINAL, LUG PFOZZ S1594 BOLT, MACHINE PFOZZ B4506 WASHER, LOCK PFOZZ H5165 PLATE, MENDING PFOZZ H5166 RETAINER, WIRING HAR PFOZZ N1075 ADAPTER, CONNECTOR... 1 END OF FIGURE 50-1

118 THRU 7 15 THRU 20 TA FIGURE 51. HEADLIGHT WIRING HARNESS.

119 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0613 HULL OR CHASSIS WIRING HARNESS FIG 51 HEADLIGHT WIRING HARNESS 1 PFOOO P7234 WIRE MOOZZ P WIRE MAKE FROM WIRE P/N 5P PFOZZ MS TERMINAL, LUG LAMPS PFOZZ S7837.TERMINAL, LUG MOOZZ TUBING, NONMETAL MAKE FROM TUBING 1 P/N 5P PFOZZ S1043.BUTT PFOZZ S2093.STRAP PFOZZ M287 CLIP, SPRING TEN SION XDOZZ P5659 BRACKET, ANGLE PFOZZ B4506 WASHER, LOCK PFOZZ S1594 BOLT, MACHINE PFOZZ K700 GROMMET, NONMETALLIC PFOZZ H5166 RETAINER, WIRING HAR PFOOO P7233 WIRE ASSEMBLY PFOZZ S7837.TERMINAL, LUG PFOZZ BUTT MOOZZ P WIRE MAKE FROM WIRE P/N 5P PFOZZ MS TERMINAL, LUG MOOZZ G TUBING, NONMETAL MAKE FROM TUBING 1 P/N 5P PFOZZ S2093.STRAP PFOZZ H5165 PLATE, MENDING PFOZZ H1717 BOLT, MACHINE PFOZZ NUT, PLAIN, HEXAGON PFOZZ WASHER, LOCK PFOZZ MS NUT, PLAIN, HEXAGON PFOZZ MS WASHER, LOCK PFOZZ B8352 WASHER, SPRING TENSI PFOZZ M3070 GUARD, LAMP PFOZZ F1240 GROMMET, NONMETALLIC PFOZZ M3C69 GUARD, LAMP PFOZZ A2029 BOLT, MACHINE PFOZZ K8781 FUSE... 1 END OF FIGURE 51-1

120 1 2 THRU 6 TA FIGURE 52. RIPPER LIGHT WIRING.

121 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0613 HULL OR CHASSIS WIRING HARNESS FIG 52 RIPPER LIGHT WIRING 1 AOOOO P6005 WIRE ASSEMBLY MOOZZ P WIRE MAKE FROM WIRE P/N 5P MOOZZ P TUBE MAKE FROM TUBE P/N 5P PFOZZ S2093.STRAP PFOZZ TERMINAL, LUG PFOZZ MS TERMINAL, LUG PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ A NUT, PLAIN, HEXAGON PFOZZ D4278 WASHER PFOZZ B4506 WASHER, LOCK PFOZZ H5166 RETAINER, WIRING HAR PFOZZ S1594 BOLT, MACHINE PFOZZ H4005 GROMMET, NONMETALLIC PFOZZ M456 FUSE, CARTRIDGE PFOZZ MS NUT, PLAIN, HEXAGON PFOZZ MS WASHER, LOCK... 1I 17 PFOZZ WASHER, SPRING TENSI XDOZZ P5659 BRACKET, ANGLE... 1 END OF FIGURE 52-1

122 TA FIGURE 53. TRANSMISSION SHIFTER AND LINKAGE (SIDE VIEW).

123 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 07 TRANSMISSION GROUP 0705 TRANSMISSION SHIFTING COMPONENTS FIG 53 TRANSMISSION SHIFTER AND LINKAGE (SIDE VIEW) 6 PFOZZ M706 KNOB PFOZZ M8908 KNOB... 1 END OF FIGURE 53-1

124 1 6 2 THRU 24 7 TA FIGURE 54. TRANSMISSION OIL FILTER.

125 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0721 COOLERS, PUMPS, MOTORS FIG 54 TRANSMISSION OIL FILTER 1 PFOOO P4243 FILTER TRANSMISSION PFOZZ S5816.SPRING PFOZZ B3235.BOLT, MACHINE PFOZZ S4191.PLUG, MACHINE THREAD PFOZZ PACKING, PREFORMED XAOOO S4785.COVER PFOZZ STUD, PLAIN PFOZZ K4472.PACKING, PREFORMED... I 9 PFOZZ D9157.SEAL PFOZZ P4166.HOUSING ASSEMBLY PFOZZ S4781.RETAINER PAOZZ J6064.FILTER ELEMENT, FLUI PFOZZ RETAINER PFOZZ A MILP2573.PACKING, PREFORMED PFOZZ PLUG, ASSEMBLY PFOZZ H3788.NUT PFOZZ H8128.PACKING, PREFORMED PFOZZ L1250.NUT, PLAIN, HEXAGON PFOZZ P3668.INSULATOR PFOZZ P9600.SEAL PFOZZ P2086.SCREW, CAP, HEXAGON H.... 1I 22 PFOZZ P2085.PLUG, MACHINE THREAD PFOZZ P369.PACKING, PREFORMED PFOZZ TERMINAL, LUG... 1 END OF FIGURE 54-1

126 1 8 2 THRU 12 9 TA FIGURE 55. TRANSMISSION FLUID FILTER (MAGNETIC).

127 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0721 COOLERS, PUMPS, MOTORS FIG 55 TRANSMISSION FLUID FILTER (MAGNETIC) 1 PFOOO M8669 FILTER, FLUID PFOZZ D2871.STUD PFOZZ A.NUT, PLAIN, HEXAGON PFOZZ S3439.COVER PFOZZ WASHER, SPRING TENSI PFOZZ F149.PACKING, PREFORMED PFOZZ FILTER ELEMENT, FLUI PFOOO TUBE ASSEMBLY PFOZZ M7160.MAGNET PFOZZ J8668.STUD, CONTINUOUS THR PFOZZ M1047.STUD, CONTINUOUS THR PFOZZ M4779.STUD PFOZZ B4506.WASHER, LOCK PFOZZ M7166.HOUSING, STRAINER... 1 END OF FIGURE 55-1

128 5 6 TA FIGURE 56. TRANSMISSION OIL LINES.

129 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0721 COOLERS, PUMPS, MOTORS FIG 56 TRANSMISSION OIL LINES 1 PFOZZ P5931 HOSE A PFOZZ CLIP, SPRING TENSION PFOZZ P7838 HOSE A PFOZZ M8429 CLAMP, LOOP XDOOO P7676 BRACKET ASSEMBLY PFOZZ F748.NUT, PLAIN, WELDING PFOZZ M2894 WASHER, FLAT PFOZZ BOLT, MACHINE PFOZZ MS CLAMP, LOOP PFOZZ A2029 BOLT, MACHINE PFOZZ WASHER, LOCK PFOZZ P7679 ELBOW PFOZZ S1588 BOLT, MACHINE PFOZZ M5252 PACKING, PREFORMED PFOZZ MS51527A6 ELBOW, TUBE TO BOSS PFOZZ RING PFOZZ P7808 ELBOW PFOZZ M4436 PACKING PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ M4987 PACKING, PREFORMED XDOZZ P8005 PLATE PFOZZ P4577 FLANGE, PIPE PFOZZ S NUT, PLAIN, HEXAGON PFOZZ MS WASHER, FLAT PFOZZ S1595 BOLT, MACHINE PFOZZ C8 WASHER, LOCK XDOZZ S4780 BRACKET PFOZZ P4165 CLAMP, LOOP PFOZZ P4110 HOSE ASSEMBLY PFOZZ P6629 CLAMP, LOOP PFOZZ B4280 WASHER, FLAT XDOZZ P683 BASE PFOZZ P4582 FLANGE PFOZZ M5010 PACKING, PREFORMED PFOZZ S440 TUBE ASSEMBLY, METAL PFOZZ WASHER, FLAT PFOZZ M5639 CLAMP, LOOP PFOZZ M5640 CLAMP, LOOP PFOZZ P685 HOSE ASSEMBLY PFOZZ MS SCREW, CAP, HEXAGON H XDOZZ P5929 MANIFOLD PFOZZ B3235 BOLT, MACHINE PFOZZ M4989 PACKING, PREFORMED PFOZZ M4986 PACKING, PREFORMED... 2 END OF FIGURE 56-1

130 39 40 TA FIGURE 57. POWER TRAIN OIL LINES.

131 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0721 COOLERS, PUMPS, MOTORS FIG 57 POWER TRAIN OIL LINES 1 PFOZZ MS51525-A8 ADAPTER, STRAIGHT, TU USE WITH SERIAL RANGE 77V6524 THRU 77V PFOZZ K360 PACKING, PREFORMED USE WITH SERIAL RANGE 77V6524 THRU 77V XDOZZ P2390 BLOCK USE WITH SERIAL RANGE 77V6524 THRU 77V PFOZZ M4987 PACKING, PREFORMED PFOZZ S4182 PLUG, MACHINE THREAD PFOZZ J7354 PACKING, PREFORMED PFOZZ MS21044N6 NUT, SELF-LOCKING, HE PFOZZ MS WASHER, FLAT PFOZZ S7139 SPRING, HELICAL, COMP PFOZZ L1143 BOLT, MACHINE PFOZZ S8744 WASHER, LOCK XDOZZ S7370 BLOCK ASSEMBLY PFOZZ WASHER, LOCK PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ F6647 GASKET PFOZZ S8656 GASKET PFOZZ S7372 TUBE ASSEMBLY, METAL PFOZZ M4445 PACKING, PREFORMED PFOZZ M547L VALVE, CHECK PFOZZ D7091 WASHER, FLAT PFOZZ S7369 ELBOW, PIPE PFOZZ P1454 HOSE ASSEMBLY, NONME PFOZZ H8829 PLUG, MACHINE THREAD PFOZZ F7062 WASHER, FLAT PFOZZ S1588 BOLT, MACHINE PFOZZ P4577 FLANGE, PIPE PFOZZ S7906 ADAPTER, STRAIGHT, FL PFOZZ P5628 TUBE ASSEMBLY, METAL PFOZZ CLIP PFOZZ S24 CLIP PFOZZ P4578 FLANGE, PIPE PFOZZ H5368 BOLT, MACHINE PFOZZ B4279 WASHER, FLAT PFOZZ ELBOW, FLANGE TO HOS PFOZZ S7368 HOSE A PFOZZ S7507 ELBOW, PIPE TO TUBE PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ CLIP, SPRING TENSION PFOOO B8996 ADAPTER, STRAIGHT, PI PFOZZ F8997.INVERTED NUT, TUBE C PFOZZ L1351 BOLT, MACHINE PFOZZ S8311 TUBE ASSEMBLY, METAL PFOZZ P4576 FLANGE, PIPE PFOZZ M PACKING, PREFORMED PFOZZ P8230 HOSE A

132 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 46 PFOZZ A2029 BOLT, MACHINE PFOZZ A NUT, PLAIN, HEXAGON XDOZZ P400 BRACKET PFOZZ MS CLAMP, LOOP PFOZZ S7375 TUBE, METALLIC... 1 END OF FIGURE 57-2

133 36 37 THRU 39 TA FIGURE 58. TRANSMISSION OIL LINES AND MOUNTING PARTS.

134 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0721 COOLERS, PUMPS, MOTORS FIG 58 TRANSMISSION OIL LINES AND MOUNTING PARTS 1 PFOZZ M4988 PACKING, PREFORMED PFOZZ WASHER, LOCK PFOZZ S1594 BOLT, MACHINE PFOZZ P5749 TUBE ASSEMBLY, METAL USE WITH 1 SERIAL RANGE 77V5006 THRU 77V PFOZZ H7702 GUIDE ASSEMBLY PFOZZ M381 PLUNGER ASSEMBLY PFOZZ S2254 SPOUT PFOZZ M902 PLUG, PIPE PFOZZ L1124 GASKET PFOZZ AL BREATHER USE WITH SERIAL RANGE 1 77V6524 THRU 77V PFOZZ S7905 PLUG, MACHINE THREAD USE WITH 1 SERIAL RANGE 77V8763 THRU 77V PFOZZ K6830 HOSE A PFOZZ S8665 CLAMP, LOOP XDOZZ S4569 FLANGE PFOZZ M4987 PACKING, PREFORMED PFOZZ MS SCREW, CAP, HEXAGON H XDOZZ COVER PFOZZ F5640 GASKET PFOZZ A2029 BOLT, MACHINE PFOZZ S4551 HOSE A PFOZZ P4578 FLANGE, PIPE PFOZZ M4986 PACKING, PREFORMED PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ WASHER, FLAT PFOZZ H5368 BOLT, MACHINE XDOZZ S7997 SUPPORT PFOZZ S1588 BOLT, MACHINE XDOZZ BOLT, SHOULDER PFOZZ H RETAINER, NUT AND BO PFOZZ MS NUT, PLAIN, HEXAGON PFOZZ M2675 TUBE, BENT, METALLIC RIGHT HAND MOOZZ P TUBE MAKE FROM TUBE P/N 5P PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ MS CLAMP, LOOP XDOZZ P8319 BRACKET ASSEMBLY PFOOO S7230 HOSE USE WITH SERIAL RANGE 77V THRU 77V PFOZZ S8606 SLEEVE PFOZZ S9727 ELBOW, TUBE TO HOSE 45 DEGREES PFOZZ COUPLING ASSEMBLY STRAIGHT MOOZZ HOSE MAKE FROM HOSE P/N 5P PFOZZ F8513 CLAMP, LOOP SPRING TENSION PFOZZ L1351 BOLT, MACHINE PFOZZ S1583 BOLT, MACHINE... I 58-1

135 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 43 PFOZZ MS WASHER, LOCK PFOZZ MS WASHER, FLAT PFOZZ L1143 BOLT, MACHINE PFOZZ P5934 HOSE A PFOZZ XX3958 BOLT, MACHINE PFOZZ H7954 SCREW, CAP, HEXAGON H PFOZZ A NUT, PLAIN, HEXAGON PFOZZ P4577 FLANGE, PIPE PFOZZ F5940 GASKET PFOZZ S3913 CLIP, SPRING TENSION PFOZZ F2978 NUT, PLAIN, WELDING PFOZZ P7757 TUBE ASSEMBLY, METAL... 1 END OF FIGURE 58-2

136 1 2 2 THRU 7 3 TA FIGURE 59. UNIVERSAL JOINT ASSEMBLY.

137 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 09 PROPELLER, PROPELLER SHAFTS UNIVERSAL JOINTS, COUPLER AND CLAMP ASSEMBLY GROUP 0900 PROPELLER SHAFTS FIG 59 UNIVERSAL JOINT ASSEMBLY 7 PFOZZ MS FITTING, LUBRICATION... 2 END OF FIGURE 59-1

138 THRU AND TA FIGURE 60. TRACK ROLLER FRAME.

139 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 13 WHEELS AND TRACKS GROUP 1301 SUSPENSION ASSEMBLY FIG 60 TRACK ROLLER FRAME 1 PFOZZ B8490 FITTING, LUBRICATION... 2 END OF FIGURE 60-1

140 24 25 FIGURE 61. FRONT IDLER (EXTERNAL VIEW). TA235338

141 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1303 TRACK IDLERS AND BRACKETS FIG 61 FRONT IDLER (EXTERNAL VIEW) 6 PFOZZ VALVE HYDRAULIC... 6 END OF FIGURE 61-1

142 1 2 THRU 5 TA FIGURE 62. HUB AND SPROCKET SEGMENTS.

143 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1304 TRACK DRIVE SPROCKETS FIG 62 HUB AND SPROCKET SEGMENTS 1 PFOFF P8120 SEGMENT SPROCKET USE WITH SERIAL 1 RANGE 77V7008 THRU 77V PFOFF P4132 SEGMENT SPROCKET USE WITH SERIAL 1 RANGE 771V5006 THRU 77V END OF FIGURE 62-1

144 1 6 2 THRU 19 7 THRU 19 TA FIGURE 63. TRACK (SEALED AND LUBRICATED).

145 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1305 TRACK ASSEMBLY FIG. 63 TRACK (SEALED AND LUBRICATED) 1 PFOFF P9512 TRACK 24 INCH GROUSER SHOE, EXTREME 2 SERVICE, USE WITH P/N 6P PFOFF P9514 TRACK 20 INCH GROUSER SHOE, EXTREME 2 SERVICE, USE WITH P/N 6P PFOFF P9513 TRACK SHOE ASSEMBLY 22 INCH 2 GROUSER SHOE, EXTREME SERVICE, USE WITH P/N 6P PFOFF P9518 TRACK 24 INCH GROUSER SHOE, USE 2 WITH P/N 6P PFOFF P9517 TRACK 26 INCH GROUSER SHOE, USE 2 WITH P/N 6P PFOFF P9516 TRACK 28 INCH GROUSER SHOE, USE 2 WITH P/N 6P PFOFF TRACK 22 INCH GROUSER SHOE, USE 2 WITH PIN 6P END OF FIGURE 63-1

146 1 6 2 THRU 16 7 THRU 16 TA FIGURE 64. TRACK (SEALED AND NONLUBRICATED).

147 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1305 TRACK ASSEMBLY FIG. 64 TRACK (SEALED AND NONLUBRICATED) 1 PFOFF S404 TRACK 22 INCH GROUSER SHOE PFOFF S405 TRACK 24 INCH GROUSER SHOE PFOFF S406 TRACK 26 INCH GROUSER SHOE PFOFF S407 TRACK 28 INCH GROUSER SHOE PFOFF S410 TRACK 20 INCH GROUSER SHOE EXTREME 2 SERVICE... 1 PFOFF S411 TRACK 22 INCH GROUSER SHOE EXTREME 2 SERVICE... 1 PFOFF S412 TRACK 24 INCH GROUSER SHOE EXTREME 2 SERVICE... END OF FIGURE 64-1

148 2 3 AND 4 TA FIGURE 65. BRAKE BAND AND LINING.

149 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 14 STEERING GROUP 1403 STEERING BRAKES FIG 65 BRAKE BAND AND LINING 1 PFOZZ S7365 BRAKE BAND AND LINI... 2 END OF FIGURE 65-1

150 9 10 TA FIGURE 66. STEERING CLUTCH CONTROL LINKAGE (SIDE VIEW).

151 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1403 STEERING BRAKES FIG 66 STEERING CLUTCH CONTROL LINKAGE (SIDE VIEW) 6 PFOZZ OL0829 HANDLE, CLUTCH LEVER... 1 END OF FIGURE 66-1

152 7 8 THRU 12 TA FIGURE 67. FRONT PULL HOOK AND DRAWBAR.

153 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 15 FRAME, TOWING ATTACHMENTS, DRAWBARS, AND ARTICULATION SYSTEMS GROUP 1503 PINTLES AND TOWING ATTACHMENTS FIG 67 FRONT PULL HOCK AND DRAWBAR 1 PFOZZ B4207 NUT, PLAIN, HEXAGON PFOZZ S0115 WASHER, FLAT PFOZZ S1575 BOLT, MACHINE PFOZZ H9476 HOOK PFOZZ S6162 WASHER, FLAT PFOZZ H3390 NUT, PLAIN, HEXAGON PFOOO BS7024 BRACKET ASSEMBLY PFOZZ S7025.BRACKET RH PFOZZ B4210.NUT, PLAIN, HEXAGON PFOZZ S7023.WASHER, FLAT PFOZZ S7079.SCREW, CAP, HEXAGON H PFOZZ S7026.BRACKET LH PFOZZ NUT, SELF-LOCKING, HE PFOZZ H2168 LATCH, DRAWBAR PIN PFOZZ S1577 BOLT, MACHINE PFOZZ H2534 CLEVIS PFOZZ H4106 PIN A... 1 END OF FIGURE 67-1

154 TA FIGURE 68. SWINGING DRAWBAR.

155 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1503 PINTLES AND TOWING ATTACHMENTS FIG 68 SWINGING DRAWBAR 1 PFOZZ H4106 PIN A XDOZZ H8803 SUPPORT PFOZZ WASHER, LOCK PFOZZ H2168 LATCH, DRAWBAR PIN PFOZZ S1577 BOLT, MACHINE PFOZZ NUT, SELF-LOCKING, HE PFOZZ H33217 WEAR SHOE PFOZZ H3390 NUT, PLAIN, HEXAGON PFOZZ WASHER, FLAT XDOZZ H4217 BRACE ASSEMBLY RIGHT HAND XDOZZ H4218 BRACE ASSEMBLY LEFT HAND PFOZZ S9093 BOLT, MACHINE PFOZZ MS WASHER, LOCK XDOZZ M3331 BRACKET RIGHT HAND XDOZZ M3332 BRACKET LEFT HAND PFOZZ MS WASHER, LOCK PFOZZ B9805 SET SCREW PFOZZ B7558 CORK PFOZZ M1495 PIN XDOZZ H4213 BRACKET PFOZZ B4210 NUT, PAIN, HEXAGON PFOZZ H3328 BOLT, EXTERNALLY REL XDDZZ H3329 PLATE PFOZZ H8812 PIN ASSEMBLY PFOZZ M8732 DRAWBAR ASSEMBLY... 1 END OF FIGURE 68-1

156 TA FIGURE 69. BRUSH GUARD.

157 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 18 BODY, CAB, HOOD AND HULL GROUP 1801 BODY, CAB, HOOD AND HULL ASSEMBLIES FIG 69 BRUSH GUARD 1 XDOZZ S2467 GUARD RH XDOZZ S476 GUARD ASSEMBLY LH XDOZZ P1549 GUARD RH, TYPE XDOZZ H7353 BRACKET USE WITH TYPE XDOZZ G2144 BRACKET RH, USE WITH TYPE XDOZZ G2145 BRACKET LH, USE WITH TYPE PFOZZ MS SCREW, CAP, HEXAGON H USE WITH TYPE PFOZZ P8247 WASHER, FLAT USE WITH TYPE PFOZZ A NUT, PLAIN, HEXAGON USE WITH TYPE PFOZZ WASHER, SQUARE CONE USE WITH TYPE PFOZZ S1588 BOLT, MACHINE USE WITH TYPE PFOOO S5478 DOOR ASSEMBLY PFOZZ F2978 NUT, PLAIN, WELDING PFOZZ B4506 WASHER, LOCK PFOZZ WASHER, SQUARE CONE USE WITH TYPE PFOZZ L1351 BOLT, MACHINE PFOZZ MS WASHER, FLAT XDOOO S9691 BRACKET ASSEMBLY RH XDOOO S9692 BRACKET ASSEMBLY LH PFOZZ F2978 NUT, PLAIN, WELDING PFOZZ S7336 CLAMP, LOOP PFOZZ S7334 CLAMP, LOOP PFOZZ B4508 WASHER, LOCK PFOZZ P1076 WASHER, SHOULDERED A PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ B4205 NUT, PLAIN, HEXAGON XDOOO H7354 BRACKET ASSEMBLY PFOZZ F2978 NUT, PLAIN, WELDING PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ S1594 BOLT, MACHINE PFOZZ A NUT, PLAIN, HEXAGON XDOZZ S2469 PLATE PFOZZ S1621 BOLT, MACHINE... 4 END OF FIGURE 69-1

158 TA FIGURE 70. HEAVY DUTY CRANKCASE GUARD.

159 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1801 BODY, CAB, HOOD AND HULL ASSEMBLIES FIG 70 HEAVY DUTY CRANKCASE GUARD 1 PFOZZ L1178 BOLT, MACHINE PFOZZ MS WASHER, LOCK PFOZZ S7771 SPACER, SLEEVE PFOZZ P8829 RETAINER PFOZZ D4639 BOLT, MACHINE PFOZZ J3507 NUT, PLAIN, HEXAGON PFOZZ K5234 WASHER, FLAT XDOFF P3384 GUARD ASSEMBLY XDOFF P3382 GUARD ASSEMBLY PFOZZ F4283 BOLT, SELF-LOCKING, PFOZZ B4209 NUT, PLAIN, HEXAGON PFOFF P3061 GUARD, MECHANICAL DR PFOZZ M8659 WASHER USE ON HEAVY DUTY PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ M849 WASHER, FLAT PFOZZ B4508 WASHER, LOCK PFOZZ S9437 DOOR, ASSEMBLY PFOZZ S9434 NUT, PLAIN, RECTANGUL PFOZZ S9732 SCREW, CAP, HEXAGON H PFOZZ H5128 PIN, STRAIGHT, HEADLE PFOZZ S8673 COVER, ACCESS XDOZZ S9436 BRACKET... 2 END OF FIGURE 70-1

160 2 1 TA FIGURE 71. CRANKCASE GUARD.

161 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1801 BODY, CAB, HOOD AND HULL ASSEMBLIES FIG 71 CRANKCASE GUARD 1 XDOFF P3388 GUARD ASSEMBLY XDOZZ P3057.PLATE PFOZZ D4639 BOLT, MACHINE PFOZZ J3507 NUT, PLAIN, HEXAGON PFOZZ K5234 WASHER, FLAT PFOZZ P8829 RETAINER XDOFF P3387 GUARD ASSEMBLY PFOFF P3061 GUARD, MECHANICAL DR PFOZZ S1973 BOLT, MACHINE PFOZZ M8659 WASHER PFOZZ B3235 BOLT, MACHINE PFOZZ M849 WASHER, FLAT PFOZZ S9437 DOOR,, ASSEMBLY... 1 END OF FIGURE 71-1

162 THRU 30 TA FIGURE 72. HOOD AND DASH.

163 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1801 BODY, CAB, HOOD AND HULL ASSEMBLIES FIG 72 HOOD AND DASH 1 PFOZZ K4889 GROMMET USE WITH SERIAL RANGE V7511, 7512, 7514 TO 7520, 7522 TO 7531, 7534 TO 7537, 7553 TO 7583, 7618 TO 7620, 7622, 7624 TO 7634, 76360, 7637, 7639 TO 7645,... 2 PFOZZ S2087 SCREW, CAP, HEXAGON H USE WITH... 5 SERIAL RANGE 77V5954 THRU 77V PFOZZ P8673 COVER ASSEMBLY USE WITH SERIAL... 1 RANGE 77V5954 THRU 77V PFOZZ N1650 WASHER, FLAT USE WITH SERIAL RANGE V7511, 7512, 7514 TO 7520, 7522 TO 7531, 7534 TO 7537, 7553 TO 7583, 7618 TO 7620, 7622, 7624 TO 7634, 76360, 7637, 7639 TO 7645,... 5 PFOOO P4938 BRACKET ASSEMBLY, HO USE WITH... 2 SERIAL RANGE 77V5954 THRU 77V PFOZZ F2978 NUT, PLAIN, WELDING PFOZZ S2109 BRACKET,, ANGLE USE WITH SERIAL... 4 RANGE 77V5954 THRU 77V PFOZZ M3835 LATCH, HOOD USE WITH SERIAL RANGE V5954 THRU 77V PFOZZ P4557 CLAMP, LOOP PFOZZ L1351 BOLT, MACHINE USE WITH SERIAL RANGE V5954 TO 7510, 7513, 7521, 7532, 7533, 7538 TO 7552, 7584 TO 7617, 7621, 7623, 7635, 7638, 7646, 7656, 7660, 7664, 7665, 7672, PFOZZ L1351 BOLT, MACHINE USE WITH SERIAL RANGE V7511, 7512, 7514 TO 7520, 7522 TO 7531, 7534 TO 7537, 7553 TO 7583, 7618 TO 7620, 7622, 7624 TO 7634, 76360, 7637, 7639 TO 7645, PFOZZ B4506 WASHER, LOCK USE WITH SERIAL RANGE V5954 TO 7510, 7513, 7521, 7532, 7533, 7538 TO 7552, 7584 TO 7617, 7621, 7623, 7635, 7638, 7646, 7656, 7660, 7664, 7665, 7672, PFOZZ B4506 WASHER, LOCK USE WITH SERIAL RANGE V7511, 7512, 7514 TO 7520, 7522 TO 7531, 7534 TO 7537, 7553 TO 7583, 7618 TO 7620, 7622, 7624 TO 7634, 76360, 7637, 7639 TO 7645, PFOZZ A NUT, PLAIN, HEXAGON USE WITH SERIAL... 1 RANGE 77V5954 THRU 77V PFOZZ S7881 HOOK A USE WITH SERIAL RANGE V5954 THRU 77V PFOZZ M5795 PIN, STRAIGHT, HEADED USE WITH

164 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY SERIAL RANGE 77V5954 THRU 77V PFOZZ MS PIN, COTTER USE WITH SERIAL RANGE V5954 THRU 77V9475Y PFOZZ P9834 GRAB IRON ASSEMBLY, USE WITH SERIAL... 2 RANGE 77V7511, 7512, 7514 TO 7520, 7522 TO 7531, 7534 TO 7537, 7553 TO 7583, 7618 TO 7620, 7622, 7624 TO 7634, 7636, PFOZZ M5742 GRAB IRON USE WITH SERIAL RANGE V5954 TO 7510, 7513, 7521, 7532, 7533, 7538 TO 7552, 7584 TO 7617, 7621, 7623, 7635, 7638, 7646, 7656, 7660, 7664, 7665, 7672, PFOZZ P4503 HOOD ASSEMBLY USE WITH SERIAL... 1 RANGE 77V5954 THRU 77V PFOZZ B4508 WASHER, LOCK USE WITH SERIAL RANGE V5954 THRU 77V PFOZZ S1595 BOLT, MACHINE USE WITH SERIAL RANGE V5954 THRU 77V PFOZZ NUT, PLAIN, HEXAGON USE WITH SERIAL... 4 RANGE 77V5954 THRU 77V PFOZZ J4144 WASHER, FLAT USE WITH SERIAL RANGE V7511, 75.12, 7514 TO 7520, 7522 TO 7531, 7534 TO 7537, 7553 TO 7583, 7618 TO 7620, 7622, 7624 TO 7634, 76360, 7637, 7639 TO 7645, PFOZZ J4144 WASHER, FLAT USE WITH SERIAL RANGE V5954 TO 7510, 7513, 7521, 7532, 7533, 7538 TO 7552, 7584 TO 7617, 7621, 7623, 7635, 7638, 7646, 7656, 7660, 7664, 7665, 7672, 7674, PFOZZ MS SCREW, CAP, HEXAGON H USE WITH SERIAL RANGE 77V5954 THRU 77V PFOZZ MS WASHER, FLAT USE WITH SERIAL RANGE V5954 THRU 77V PFOZZ WASHER, LOCK USE WITH SERIAL RANGE V5954 THRU 77V PFOOO P5954 DASH ASSEMBLY USE WITH SERIAL... 1 RANGE 77V5954 THRU 77V PFOZZ F748 NUT, PLAIN, WELDING PFOZZ NUT, PLAIN, WELDING PFOZZ F2978 NUT, PLAIN, WELDING PFOZZ H6822 BEARING, SLEEVE XAOZZ F6182 BOSS PFOZZ S7113 PLATE USE WITH SERIAL RANGE V5954 THRU 77V PFOZZ P4935 PLUG USE WITH SERIAL RANGE 77V THRU 77V PFOZZ H4351 COVER, DASH USE WITH SERIAL RANGE V5954 THRU 77V PFOZZ M5839 WASHER, FLAT USE WITH SERIAL RANGE V5954 THRU 77V

165 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 35 PFOZZ K4939 BUMPER USE WITH SERIAL RANGE V5954 THRU 77V PFOZZ WASHER USE WITH SERIAL RANGE V5954 THRU 77V PFOZZ P4501 COLLAR ASSEMBLY USE WITH SERIAL... 1 RANGE 77V5954 THRU 77V PFOZZ S1587 BOLT, MACHINE USE WITH SERIAL RANGE V5954 THRU 77V PFOZZ D1649 WASHER, FLAT USE WITH SERIAL RANGE V5954 THRU 77V PFOZZ P9374 COVER RH USE WITH SERIAL RANGE V5954 THRU 77V PFOZZ P9373 COVER LH USE WITH SERIAL RANGE V5954 THRU 77V PFOZZ S1621 BOLT, MACHINE USE WITH SERIAL RANGE V5954 THRU 77V PFOZZ WASHER, FLAT USE WITH SERIAL RANGE V5954 THRU 77V PFOZZ P7631 GUARD RH USE WITH SERIAL RANGE V5954 THRU 77V PFOZZ P7632 GUARD LH USE WITH SERIAL RANGE V5954 THRU 77V END OF FIGURE 72-3

166 THRU 28 TA FIGURE 73. HOOD AND DASH (FOR USE WITH SERIAL RANGE THRU 77V5953).

167 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1801 BODY, CAB, HOOD AND HULL ASSEMBLIES FIG 73 HOOD AND DASH (FOR USE WITH SERIAL RANGE THRU 77V5953) 1 PFOZZ L1351 BOLT, MACHINE PFOZZ A NUT, PLAIN, HEXAGON PFOZZ WASHER, LOCK PFOZZ P4557 CLAMP, LOOP PFOZZ S2087 SCREW, CAP, HEXAGON H PFOZZ P2506 COVER PFOOO P4938 BRACKET ASSEMBLY HO PFOZZ F2978.NUT, PLAIN, WELDING PFOZZ BRACKET, ANGLE PFOZZ M3835 LATCH, HOOD PFOZZ S1594 BOLT, MACHINE PFOZZ S7881 HOOK A PFOZZ C56 PIN, STRAIGHT, HEADED PFOZZ MS PIN, COTTER PFOZZ M5742 GRAB IRON PFOZZ P4503 HOOD ASSEMBLY PFOZZ WASHER, LOCK PFOZZ S1595 BOLT, MACHINE PFOZZ p NUT, PLAIN, HEXAGON PFOZZ J4144 WASHER, FLAT PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ MS WASHER, FLAT PFOOO P5954 DASH ASSEMBLY PFOZZ C3477.NUT, PLAIN, WELDING PFOZZ F748.NUT, PLAIN, WELDING PFOZZ F2978.NUT, PLAIN, WELDING PFOZZ H6822.BEARING, SLEEVE XAOZZ F6182.BOSS PFOZZ P4935 PLUG PFOZZ H4351 COVER, DASH PFOZZ M5839 WASHER, FLAT PFOZZ K4939 BUMPER PFOZZ WASHER PFOZZ P4501 COLLAR ASSEMBLY PFOZZ P7631 GUARD PFOZZ P7632 GUARD LH PFOZZ WASHER, FLAT PFOZZ S1621 BOLT, MACHINE PFOZZ BOLT, MACHINE PFOZZ D1649 WASHER, FLAT PFOZZ S7113 PLATE PFOZZ P9374 COVER RH PFOZZ P9373 COVER LH... 1 END OF FIGURE 73-1

168 THRU TA FIGURE 74. RIGHT HAND FENDER.

169 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1802 FENDERS, RUNNING BOARDS WITH MOUNTING AND ATTACHING PARIS, OUTRIGGERS WINDSHIELD, GLASS, ETC. FIG 74 RIGHT HAND FENDER 1 PFOOO P3976 FENDER ASSEMBLY PFOZZ P6411.BLOCK PFOZZ S6721.SUPPORT PFOZZ P573.SUPPORT PFOZZ F5016.LUG PFOZZ F748.NUT, PLAIN, WELDING USE WITH SERIAL... 2 RANGE 77V7875 THRU 77V PFOZZ F2978.NUT, PLAIN, WELDING USE WITH SERIAL... 2 RANGE 77V7875 THRU 77V PFOZZ S3968 TREAD, ANTI SKID PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ MS WASHER, LOCK PFOOO P2336 BRACKET ASSEMBLY LH PFOZZ F748.NUT, PLAIN, WELDING PFOZZ J5169 NUT PFOZZ S1973 BOLT MACHINE PFOZZ MS NUT. PLAIN, HEXAGON PFOZZ H1031 WASHER, FLAT PFOOO P3981 SUPPORT ASSEMBLY USE WITH SERIAL... 1 RANGE 77V5006 THRU 77V PFOOO P4902 SUPPORT ASSEMBLY USE WITH SERIAL... 1 RANGE 77V5846 THRU 77V PFOZZ F748.NUT, PLAIN, WELDING PFOZZ P859 BRACKET ASSEMBLY USE WITH SERIAL... 1 RANGE 771V5006 THRU 77V6293 AND 77V6295 THRU 77V PFOZZ P5502 ANGLE ASSEMBLY USE WITH SERIAL... 1 RANGE 77V6294 AND 77V6375 THRU 77V PFOOO P2335 BRACKET ASSEMBLY RH PFOZZ F748.NUT, PLAIN, WELDING PFOZZ L2119 SPACER, RING PFOZZ L1178 BOLT, MACHINE PFOZZ S0115 WASHER, FLAT PFOZZ P6332 SUPPORT ASSEMBLY PFOZZ P773 ANGLE ASSEMBLY USE WITH SERIAL... 1 RANGE 77V5006 THRU 77V6293 AND 77V6295 THRU 77V PFOZZ P5443 ANGLE ASSEMBLY USE WITH SERIAL... 1 RANGE 77V6294 AND 77V6375 THRU 77V PFOZZ P6335 PLATE ASSEMBLY PFOZZ S1595 BOLT, MACHINE PFOZZ M849 WASHER, FLAT PFOZZ S1587 BOLT, MACHINE PFOZZ NUT, PLAIN, HEXAGON

170 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 32 PFOZZ MS SCREW, CAP, HEXAGON H USE WITH... 2 SERIAL RANGE 77V5846 THRU 77V PFOOO P4804 BRACKET ASSEMBLY USE WITH SERIAL... 1 RANGE 77V5846 THRU 77V PFOZZ F748 NUT, PLAIN, WELDING PFOZZ P9032 ANGLE PFOZZ S7663 BRACKET ASSEMBLY... 1 END OF FIGURE 74-2

171 4 5 THRU 9 TA FIGURE 75. LEFT HAND FENDER.

172 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1802 FENDERS, RUNNING BOARDS WITH MOUNTING AND ATTACHING PARTS, OUTRIGGERS, WINDSHIELD, GLASS, ETC. FIG 75 LEFT HAND FENDER 1 PFOZZ MS WASHER, LOCK PDOZZ S8025 STRIP ASSEMBLY PFOZZ S7603 BRACKET ASSEMBLY PFOOO P3985 FENDER ASSEMBLY PFOZZ F5016 LUG PFOZZ F748 NUT, PLAIN, WELDING PFOZZ P573 SUPPORT USE WITH SERIAL RANGE V5006 THRU 77V PFOZZ S6721 SUPPORT PFOZZ P6411 BLOCK PFOZZ MS SCREW, CAP, HEXAGON H USE WITH... 4 SERIAL RANGE 77V5006 THRU 77V PFOZZ NUT, PLAIN, HEXAGON USE WITH SERIAL... 4 RANGE 77V5006 THRU 77V PFOZZ M849 WASHER, FLAT USE WITH SERIAL RANGE V5006 THRU 77V PFOZZ B4488 HANDLE, BOW USE WITH SERIAL RANGE V5006 THRU 77V PFOZZ P9830 HANDLE, BOW USE WITH SERIAL RANGE V7831 THRU 77V PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ MS NUT, PLAIN, HEXAGON PFOZZ D3704 WASHER, FLAT PFOZZ P4333 COVER PFOZZ A2029 BOLT, MACHINE PFOZZ B4506 WASHER, LOCK PFOZZ J5169 NUT PFOZZ S9092 BOLT, MACHINE USE WITH SERIAL RANGE V6294 AND 77V6375 THRU 77V PFOZZ MS SCREW, CAP, HEXAGON H USE WITH... 8 SERIAL RANGE 77V5006 THRU 77V6293, 77V6295 THRU 77V6374 AND 77V7875 THRU 77V END OF FIGURE 75-1

173 THRU 3 16 TA FIGURE 76. FLOOR PLATE.

174 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1805 FLOORS, SUBFLOORS, AND RELATED COMPONENTS FIG 76 FLOOR PLATE 1 XDOOO P9566 BRACKET ASSEMBLY PFOZZ F2978.NUT, PLAIN, WELDING PFOZZ F748.NUT, PLAIN, WELDING PFOZZ B1915 BOLT PFOZZ M2894 WASHER, FLAT XDOZZ P3966 PATE XDOZZ P3968 PLATE PFOZZ S1595 BOLT, MACHINE PFOZZ B4508 WASHER, LOCK PFOZZ H156 SUPPORT XDOZZ P3972 PLATE ASSEMBLY PFOZZ M849 WASHER, FLAT XDOZZ P6383 PLATE PFOZZ MS SCREW, CAP, HEXAGON H XDOOO P9577 ANGLE ASSEMBLY PFOZZ F748.NUT, PLAIN, WELDING XDOZZ P5157 LUG... 1 END OF FIGURE 76-1

175 1 7 2 THRU 28 8 THRU 19 TA FIGURE 77. ADJUSTABLE SEAT.

176 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1806 UPHOLSTERY SEATS AND CARPETS FIG 77 ADJUSTABLE SEAT 1 PFOFF SEAT, VEHICULAR... 1 END OF FIGURE 77-1

177 THRU VIEW A TA FIGURE 78. SEAT BASE.

178 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1806 UPHOLSTERY SEATS AND CARPETS FIG 78 SEAT BASE 8 XDOFF P2959 SEAT ASSEMBLY... 1 END OF FIGURE 78-1

179 THRU THRU THRU TA FIGURE 79. SHEAVE, CABLE AND HITCH.

180 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 20 HOIST, WINCH, CAPSTAN, WINDLASS POWER CONTROL UNIT, AND POWER TAKE OFF GROUP 2001 HOIST, CAPSTAN, WINDLASS. CRANE OR WINCH ASSEMBLY FIG 79 SHEAVE, CABLE AND HITCH 1 PFOZZ ROPE, WIRE... 1 UOC: T24 2 PFOZZ J6503 HITCH... 1 UOC: T24 3 PFOOO J4039 SHEAVE... 1 UOC: T24 4 PFOOO J1881.PULLEY, GROOVE... 1 UOC: T24 5 PFOZZ J4624..BEARING, ROLLER, NEED... 1 UOC: T24 6 PFOZZ F6329.RETAINER, PULLEY SHA... 1 UOC: T24 7 PFOZZ F9401.WEDGE ASSEMBLY... 1 UOC: T24 8 PFOZZ B4508.WASHER, LOCK... 2 UOC: T24 9 PFOZZ L1329.BOLT, MACHINE... 2 UOC: T24 10 PFOZZ F4729.SPOOL, LIFT WIRE PUL... 1 UOC: T24 11 PFOZZ MS FITTING, LUBRICATION... 1 UOC: T24 12 PFOZZ MS NUT, PLAIN, HEXAGON... 1 UOC: T24 13 PFOZZ B4506.WASHER, LOCK... 1 UOC: T24 14 PFOZZ F7031.BOLT... 1 UOC: T24 15 PFOZZ H7224.PIN STRAIGHT, HEADLE... 1 UOC: T24 16 PFOOO J4038.BLOCK... 1 UOC: T24 17 PFOOO J4628..SHEAVE ASSEMBLY... 4 UOC: T24 18 PFOZZ J BEARING, ROLLER, CYLI... 1 UOC: T24 19 PFOZZ MS FITTING, LUBRICATION... 4 UOC: T24 20 PFOZZ F3556..SPACER... 8 UOC: T24 21 PFOOO J5835..BLOCK ASSEMBLY... 1 UOC: T24 22 PFOZZ F SOCKET

181 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY UOC: T24 23 PFOZZ J5668..SHAFT... 1 UOC: T24 24 PFOZZ F SCREW, CAP, HEXAGON H... 2 UOC: T24 25 PFOZZ MS NUT, PLAIN, HEXAGON... 2 UOC: T24 26 PFOZZ MS WASHER, LOCK... 2 UOC: T24 27 PFOZZ L2341..NUT, PLAIN, HEXAGON... 1 UOC: T24 28 PFOOO J4044.BLOCK... 1 UOC: T24 29 PFOZZ J5926..BOLT... 1 UOC: T24 30 PFOZZ J5940..SPACER... 1 UOC: T24 31 PFOZZ F701..NUT... 1 UOC: T24 32 PFOZZ B5328..PIN, COTTER... 1 UOC: T24 33 PFOZZ J5791..OLOCK ASSEMBLY... 1 UOC: T24 34 PFOZZ L2341..NUT, PLAIN, HEXAGON... 1 UOC: T24 35 PFOOO J4628..SHEAVE ASSEMBLY... 4 UOC: T24 36 PFOZZ J BEARING, ROLLER, CYLI... 1 UOC: T24 37 PFOZZ J5668..SHAFT... 1 UOC: T24 38 PFOZZ MS FITTING, LUBRICATION... 4 UOC: T24 END OF FIGURE 79-2

182 TA FIGURE 80. WINCH FILTER RELATED PARTS.

183 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2001 HOIST, CAPSTAN, WINDLASS CRANE OR WINCH ASSEMBLY FIG 80 WINCH FILTER RELATED PARTS 21 PFOZZ B5324 PIN, COTTER... 1 UOC: T24 22 PFOZZ J442 PIN, STRAIGHT, HEADED UOC: T24 END OF FIGURE 80-1

184 14 15 THRU 17 TA FIGURE 81. WINCH CONTROLS (FRONT VIEW).

185 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2001 HOIST, CAPSTAN, WINDLASS, CRANE OR WINCH ASSEMBLY FIG 81 WINCH CONTROLS (FRONT VIEW) 1 PFOZZ P5661 GUARD, MECHANICAL DR... 1 UOC: T24 2 PFOZZ MS SCREW, MACHINE... 4 UOC: T24 3 PFOZZ M706 KNOB... 1 UOC: T24 4 PFOZZ P6033 LEVER ASSEMBLY... 1 UOC: T24 5 PFOZZ MS PIN, SPRING... 1 UOC: T24 6 PFOZZ JM56 NUT, PLAIN, HEXAGON... 1 UOC: T24 7 PFOZZ WASHER, LOCK... 3 UOC: T24 8 PFOZZ SCREW... 1 UOC: T24 9 PFOZZ P5938 CLIP, SPRING TENSION... 1 UOC: T24 10 PFOZZ S7048 BEARING, PLAIN, ROD E... 2 UOC: T24 11 PFOZZ P16598 NUT, PLAIN, HEXAGON... 2 UOC: T24 12 PFOZZ B4506 WASHER, LOCK... 4 UOC: T24 13 PFOZZ BOLT, MACHINE... 4 UOC: T24 14 XDOOO P5204 BRACKET ASSEMBLY... 1 UOC: T24 15 PFOZZ H2400.BUSHING, SLEEVE... 2 UOC: T24 16 PFOZZ F2978.NUT, PLAIN, WELDING... 4 UOC: T24 17 PFOZZ P6008.SHAFT, STRAIGHT... 1 UOC: T24 END OF FIGURE 81-1

186 AND 5 11 TA FIGURE 82. WINCH CONTROLS (SIDE VIEW).

187 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2001 HOIST CAPSTAN, WINDLASS. CRANE OR WINCH ASSEMBLY FIG 82 WINCH CONTROLS SIDE VIEW) 1 XDOOO P6031 COVER ASSEMBLY... 1 UOC: T24 2 PFOZZ F2978.NUT, PLAIN, WELDING... 8 UOC: T24 3 PFOOO P6001 BELL CRANK ASSEMBLY... 1 UOC: T24 4 PFOZZ H2400.BUSHING, SLEEVE... 2 UOC: T24 5 PFOZZ P6009.SHAFT, SHOULDERED... 1 UOC: T24 6 PFOZZ NUT, PLAIN, HEXAGON... 2 UOC: T24 7 PFOZZ M1974 WASHER, FLAT... 3 UOC: T24 8 PFOZZ MS WASHER, LOCK... 2 UOC: T24 9 PFOZZ A9579 BOLT, MACHINE... 2 UOC: T24 10 PFOOO P6973 CLAMP ASSEMBLY... 3 UOC: T24 11 PFOZZ H1190.PIN, STRAIGHT, HEADLE... 1 UOC: T24 12 PFOZZ L8413 STRAP, TIEDOWN, ELECT... 3 UOC: T24 13 PFOZZ P4565 CABLE ASSEMBLY... 1 UOC: T24 14 PFOZZ P4564 CABLE ASSEMBLY... 1 UOC: T24 15 PFOZZ MS BOLT, MACHINE... 1 UOC: T24 16 PFOZZ P16598 NUT, PLAIN, HEXAGON... 1 UOC: T24 17 PFOZZ L7751 ROD, END... 1 UOC: T24 18 PFOZZ MS SCREW, CAP, HEXAGON H... 1 UOC: T24 19 PFOZZ Z NUT, SELF-LOCKING, HE... 1 UOC: T24 20 PFOZZ L9689 WASHER, FLAT... 1 UOC: T24 21 PFOZZ K4973 LOCKNUT... 1 UOC: T24 END OF FIGURE 82-1

188 THRU TA FIGURE 83. WINCH VALVE.

189 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2006 BULLDOZER TRIPOD, MAIN FRAME, JACK AND MOUNTING FIG 83 WINCH VALVE 1 PFOFF P3640 VALVE, LINEAR, DIRECT... 1 UOC: T24 END OF FIGURE 83-1

190 TA FIGURE 84. WINCH FAIRLEADS (USE WITH LOW SPEED AND STANDARD WINCH).

191 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2006 BULLDOZER TRIPOD, MAIN FRAME, JACK AND MOUNTING FIG 84 WINCH FAIRLEADS (USE WITH LOW SPEED AND STANDARD WINCH) 1 PFOZZ P3739 RETAINER... 2 UOC: T24 2 PFOZZ B4508 WASHER, LOCK UOC: T24 3 PFOZZ MS SCREW, CAP, HEXAGON H UOC: T24 4 PFOZZ WASHER, LOCK... 8 UOC: T24 5 PFOZZ S1588 BOLT, MACHINE... 8 UOC: T24 6 PFOZZ P3737 RETAINER... 4 UOC: T24 7 XDOOO P9303 ROLLER ASSEMBLY... 1 UOC: T24 8 PFOZZ J6250.BUSHING, SLEEVE... 2 UOC: T24 9 XDOZZ P3744 SHAFT... 1 UOC: T24 10 PFOZZ P3742 RETAINER... 2 UOC: T24 11 PFOZZ S1595 BOLT, MACHINE... 4 UOC: T24 12 XDOZZ P3738 SHAFT... 1 UOC: T24 13 XDOOO P9302 ROLLER ASSEMBLY... 1 UOC: T24 14 PFOZZ J6250.BUSHING, SLEEVE... 2 UOC: T24 15 XDOOO P3721 FRAME ASSEMBLY... 1 UOC: T24 16 XDOZZ K3656.BAR... 1 UOC: T24 17 PFOZZ B5325 PIN, COTTER... 2 UOC: T24 18 PFOZZ P7545 PIN... 2 UOC: T24 19 XDOZZ P7558 SUPPORT... 2 UOC: T24 20 XDOZZ K6413 COVER... 2 UOC: T24 21 PFOZZ B3235 BOLT, MACHINE... 4 UOC: T24 22 XDOZZ P3740 SHAFT... 2 UOC: T24 23 XDOOO P9301 ROLLER ASSEMBLY... 2 UOC: T

192 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 24 PFOZZ J6250.BUSHING, SLEEVE... 2 UOC: T24 25 PFOZZ M6900 WASHER... 4 UOC: T24 26 PFOZZ P6704 SPACER... 2 UOC: T24 END OF FIGURE 84-2

193 TA FIGURE 85. WINCH PUMP LINES.

194 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2006 BULLDOZER TRIPOD, MAIN FRAME, JACK AND MOUNTING FIG 85 WINCH PUMP LINES 1 PFOZZ MS ADAPTER STRAIGHT, TU... 2 UOC: T24 2 PFOZZ A MILP2573 PACKING, PREFORMED UOC: T24 3 PFOZZ M63248/2-920 PACKING, PREFORMED... 1 UOC: T24 4 PFOZZ ADAPTER, STRAIGHT, TU... 1 UOC: T24 5 PFOZZ D6945 WASHER, FLAT... 1 UOC: T24 6 PFOZZ MS WASHER, FLAT... 3 UOC: T24 7 PFOZZ B4506 WASHER, LOCK... 2 UOC: T24 8 PFOZZ A NUT, PLAIN, HEXAGON... 2 UOC: T24 9 PFOZZ MS SCREW, CAP, HEXAGON H... 6 UOC: T24 10 PFOZZ P6437 BRACKET ASSEMBLY... 1 UOC: T24 11 PFOZZ L1351 BOLT, MACHINE... 2 UOC: T24 12 PFOZZ L6326 CLIP, RETAINING... 1 UOC: T24 13 PFOZZ P6591 HOSE ASSEM BLY... 1 UOC: T24 14 PFOZZ S8808 CLAMP, LOOP... 1 UOC: T24 15 PFOZZ K1181 STRAP... 3 UOC: T24 16 PFOZZ J524 PACKING, PREFORMED... 1 UOC: T24 17 PFOZZ P4579 FLANGE... 2 UOC: T24 18 PFOZZ WASHER, LOCK... 4 UOC: T24 19 XDOZZ P6592 COVER... 1 UOC: T24 20 PFOZZ P6590 HOSE ASSEMBLY... 1 UOC: T24 END OF FIGURE 85-1

195 TA FIGURE 86. WINCH MOUNTING.

196 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2007 CHAIN HOIST ASSEMBLY FIG 86 WINCH MOUNTING 1 PFOZZ MS SCREW, DRIVE... 2 UOC: T24 2 PFOZZ S2113 STUD, PLAIN... 6 UOC: T24 3 PFOZZ M7423 PACKING, PREFORMED... 2 UOC: T24 4 PFOZZ K684 WASHER, FLAT... 6 UOC: T24 5 PFOZZ K7468 NUT, SELF-LOCKING, HE... 2 UOC: T24 6 PFOZZ P6694 STUD... 2 UOC: T24 7 PFOZZ H3390 NUT, PLAIN, HEXAGON... 2 UOC: T24 8 PFOZZ S6162 WASHER, FLAT... 2 UOC: T24 9 PFOZZ H7539 NUT, PLAIN, HEXAGON... 4 UOC: T24 END OF FIGURE 86-1

197 TA FIGURE 87. DATA PLATES.

198 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 22 BODY, CHASSIS, AND HULL ACCESSORY ITEMS GROUP 2210 DATA PLATES FIG 87 DATA PLATES 1 PFOZZ P4350 PLATE, WARNING FRONT IDLER PFOZZ S5927 PLATE, IDENTIFICATIO FRONT IDLER PFOZZ SCREW, DRIVE USE WITH P/N 2S PFOZZ MS SCREW, DRIVE USE WITH P/N 6P PFOZZ S8097 PLATE, IDENTIFICATIO TURBOCHARGER PFOZZ S8096 PLATE, IDENTIFICATIO TURBOCHARGER PFOZZ IT94 PLATE, NAME TORQUE CONVERTER PFOZZ M PLATE, IDENTIFICATIO TRANSMISSION PFOZZ S1604 PLATE SERIAL NUMBER, RIPPER SHANK PFOZZ Y747 PLATE SERIAL NUMBER, RIPPER SHANK PFOZZ F808 SCREW PFOZZ M SCREW, DRIVE USE WITH P/N IT94, 2 9S PFOZZ B3028 SCREW, DRIVE USE WITH P/N 5M , 2 3Y PFOZZ P9238 PLATE INDENTIFICATI TRANSMISSION 1 OIL PUMP... END OF FIGURE 87-1

199 1 9 2 THRU THRU 22 TA FIGURE 88. RIPPER SELECTOR VALVE.

200 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 24 HYDRAULIC AND FLUID SYSTEMS GROUP 2402 MANIFOLD AND CONTROL VALVES FIG 88 RIPPER SELECTOR VALVE 1 PFOFF J5398 VALVE... 1 UOC: T25 9 PFOFF J3672.VALVE SELECTOR... 1 UOC: T25 END OF-FIGURE 88-1

201 1 2 THRU 15 TA FIGURE 89. PIN PULLER CONTROL VALVE.

202 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2402 MANIFOLD AND CONTROL VALVES FIG 89 PIN PULLER CONTROL VALVE 1 PFOFF J8744 VALVE CONTROL USE WITH TYPE 1 AND 1 2 LINES... UOC: T25 1 PFOFF G9668 VALVE, CONTROL USE WITH TYPE 3 LINES... 1 UOC: T25 END OF FIGURE 89-1

203 1 7 2 AND 3 8 THRU 10 TA FIGURE 90. DUAL VALVE FOR RIPPER.

204 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2402 MANIFOLD AND CONTROL VALVES FIG 90 DUAL VALVE FOR RIPPER 1 XDOOO J43 BRACKET ASSEMBLY RIGHT HAND... 1 UOC: T25 1 XDOOO J44 BRACKET ASSEMBLY LEFT HAND... 1 UOC: T25 2 PFOZZ K4221.BAR... 1 UOC: T25 3 PFOZZ J1227 RETAINER... 3 UOC: T25 4 PFOZZ S7479 STUD, PLAIN... 8 UOC: T25 5 PFOZZ H3390 NUT, PLAIN, HEXAGON UOC: T25 6 PFOZZ WASHER, FLAT UOC: T25 7 PFOOO J8900 VALVE FOR COMPLETE REPLACEMENT USE 1 P/N 7J UOC: T25 8 PFOZZ H3472.BOLT... 4 UOC: T25 9 PFOZZ MS WASHER, LOCK... 4 UOC: T25 10 PFOZZ J522.PACKING, PREFORMED... 4 UOC: T25 END OF FIGURE 90-1

205 THRU THRU 23 FIGURE 91. SELECTOR VALVE (TYPES 1 AND 2). TA235403

206 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2402 MANIFOLD AND CONTROL VALVES FIG 91 SELECTOR VALVES (TYPES 1 AND 2) 1 PFOFF J8016 VALVE... 1 UOC: T25 END OF FIGURE 91-1

207 1 2 2 THRU 16 3 TA FIGURE 92. TILT CYLINDERS AND TILT CRANK.

208 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2404 TILT CYLINDERS AND TILT CRANK FIG 92 TILT CYLINDERS AND TILT CRANK 1 PFOFF J8682 CYLINDER ASSEMBLY, A... 1 UOC :T25 END OF FIGURE 92-1

209 THRU THRU THRU THRU 57 TA FIGURE 93. PUMP LINES, TYPE 2 (USE ON 8A BULLDOZER WITH SINGLE VALVE).

210 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2406 STRAINERS, FILTERS, LINES AND FITTINGS, ETC. FIG 93 PUMP LINES, TYPE 2 (USE ON 8A BULLDOZER WITH SINGLE VALVE) 1 PFOZZ L5359 SEAL PFOZZ P1156 TUBE ASSEMBLY AOOOO P1248 HOSE ASSEMBLY MOOZZ P HOSE MAKE FROM HOSE PIN 9S PFOZZ S6389.COUPLING ASSEMBLY PFOZZ P1711.COUPLING ASSEMBLY PFOZZ S7166.PLUNGER, DETENT PFOOO MS ADAPTER, STRAIGHT, TU PFOZZ A MILP2573.PACKING, PREFORMED PFOZZ MS51525A6 ADAPTER, STRAIGHT, TU PFOZZ PACKING, PREFORMED PFOOO P5159 HOSE ASSEMBLY, NONME MOOZZ P HOSE MAKE FROM HOSE P/N 5P XAOZZ N5560.COUPLING XAOZZ C556.FITTING PFOZZ C0194 ADAPTER, STRAIGHT, TU PFOZZ M83248/2-910 PACKING, PREFORMED PFOZZ ADAPTER, STRAIGHT, TU PFOZZ M8485 SEAL, ADAPTER, MOTOR PFOZZ P4578 FLANGE, PIPE PFOZZ H5368 BOLT, MACHINE PFOZZ B4279 WASHER, FLAT AOOOO P6956 HOSE ASSEMBLY MOOZZ HOSE MAKE FROM HOSE P/N 5P PFOZZ S7116.SLEEVE PFOZZ S571.STEM ASSEMBLY PFOZZ S8569.ELBOW, FLANGE TO HOS PFOZZ J522 PACKING, PREFORMED PFOZZ S4191 PLUG, MACHINE THREAD PFOZZ P8421 PLUG PFOZZ P6656 MANIFOLD PFOZZ S1594 BOLT, MACHINE PFOZZ B4506 WASHER, LOCK PFOZZ MS WASHER, FLAT PFOZZ B1915 BOLT PFOZZ P4576 FLANGE, PIPE PFOZZ MIL-R-83248/2 PACKING, PREFORMED PFOZZ J5914 PLUG, MACHINE THREAD PFOZZ M83248/2-920 PACKING, PREFORMED PFOZZ F8698 BOLT, MACHINE PFOZZ MS WASHER, LOCK PFOZZ [1083 4F5152 SCREW, CAP, HEXAGON H PFOZZ F3106 PACKING, P REFORMED PFOZZ MS NUT, PLAIN, HEXAGON PFOZZ MS WASHER, LOCK

211 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 46 XDOZZ P6657 MANIFOLD PFOZZ J5573 PACKING, PREFORMED XDOZZ K3979 COVER PFOZZ P3704 SEAL PFOZZ P4585 FLANGE HALF, PIPE PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ S658 WASHER, FLAT AOOOO P2896 HOSE ASSEMBLY MOOZZ P HOSE FAKE FROM HOSE P/N PFOZZ S7166.PLUNGER, DETENT PFOZZ COUPLING ASSEMBLY PFOZZ S83600.STEM PFOZZ P1154 TUBE ASSEMBLY PFOZZ HOSE PFOZZ P598 CLAMP, HOSE... 2 END OF FIGURE 93-2

212 THRU 5 11 THRU THRU THRU 55 TA FIGURE 94. PUMP LINES, TYPE 3 (USE ON 8A BULLDOZER WITH SINGLE VALVE).

213 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2406 STRAINERS, FILTERS, LINES AND FITTINGS, ETC. FIG 94 PUMP LINES, TYPE 3 (USE ON 8A BULLDOZER WITH SINGLE VALVE) 1 PFOZZ P2895 HOSE ASSEMBLY AOOOO P2898 HOSE ASSEMBLY MOOZZ P HOSE MAKE FROM HOSE P/N 9S PFOZZ COUPLING ASSEMBLY PFOZZ PLUNGER, DETENT PFOZZ MS ADAPTER, STRAIGHT, TU PFOZZ A MILP2573 PACKING, PREFORMED PFOZZ MS51525A6 ADAPTER, STRAIGHT, TU PFOZZ PACKING, PREFORMED PFOOO P5159 HOSE ASSEMBLY, NONME MOOZZ P HOSE MAKE FROM HOSE P/N 5P XAOZZ N5560.COUPLING XAOZZ FITTING PFOZZ ADAPTER, STRAIGHT, TU PFOZZ M83248/2-910 PACKING, PREFORMED PFOZZ ADAPTER, STRAIGHT, TU PFOZZ M8485 SEAL, ADAPTER, MOTOR PFOZZ P4578 FLANGE, PIPE PFOZZ H5368 BOLT, MACHINE PFOZZ B4279 WASHER, FLAT AOOOO P6956 HOSE ASSEMBLY MOOZZ C HOSE MAKE FROM HOSE P/N 5P PFOZZ S7116.SLEEVE PFOZZ S8571.STEM ASSEMBLY PFOZZ S8569.ELBOW, FLANGE TO HOS PFOZZ J522 PACKING, PREFORMED PFOZZ S4191 PLUG, MACHINE THREAD PFOZZ P8421 PLUG PFOZZ P6656 MANIFOLD PFOZZ S1594 BOLT, MACHINE PFOZZ B4506 WASHER, LOCK PFOZZ MS WASHER, FLAT PFOZZ B1915 BOLT PFOZZ P4576 FLANGE, PIPE PFOZZ MIL-R-83248/2 PACKING, PREFORMED PFOZZ J5914 PLUG, MACHINE THREAD PFOZZ M83248/2-920 PACKING, PREFORMED PFOZZ F8698 BOLT, MACHINE PFOZZ MS WASHER, LOCK PFOZZ F5192 SCREW, CAP, HEXAGON H PFOZZ F3106 PACKING, PREFORMED PFOZZ MS NUT, PLAIN, HEXAGON PFOZZ MS WASHER, LOCK XDOZZ P6657 MANIFOLD PFOZZ J5573 PACKING, PERFORMED

214 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 46 XDOZZ K3979 COVER PFOZZ P3704 SEAL PFOZZ P4585 FLANGE HALF, PIPE PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ S658 WASHER FLAT AOOOO P2896.HOSE ASSEMBLY MOOZZ P HOSE MAKE FROM HOSE P/N 9S PFOZZ S7166.PLUNGER, DETENT XDOZZ S6389.COUPLING ASSEMBLY PFOZZ S8360.STEM PFOZZ H3931 PACKING, PREFORMED... 2 END OF FIGURE 94-2

215 THRU THRU THRU THRU THRU THRU 45 TA FIGURE 95. PUMP HOSES, TYPES 1, 2 AND 3 (USE WITH DOUBLE VALVE).

216 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2406 STRAINERS. FILTERS, LINES AND FITTINGS, ETC. FIG 95 PUMP HOSES, TYPES 1, 2 AND 3 (USE WITH DOUBLE VALVE) 1 PFOZZ B1915 BOLT PFOZZ MS WASHER, FLAT PFOZZ P4576 FLANGE, PIP PFOZZ MIL-R-83248/2 PACKING, PREFORMED PFOZZ P2618 CONNECTOR PFOZZ M83248/2-905 PACKING, PREFORMED PFOZZ A NUT, PLAIN HEXAGON PFOZZ M2894 WASHER, FLAT PFOZZ M SCREW, CAP, HEXAGON H PFOZZ MS ADAPTER, STRAIGHT, TU PFOZZ A MILP2573 PACKING, PREFORMED PFOOO P5353 HOSE ASSEMBLY, NONME MOOZZ P HOSE MAKE FROM HOSE P/N 5P PFOZZ FlTTING PFOZZ D8102 COUPLING PFOZZ MS51525A6 ADAPTER, STRAIGHT, TU PFOZZ PACKING, PREFORMED PFOZZ ELBOW, TUBE AOOOO P5355 HOSE ASSEMBLY MOOZZ P HOSE MAKE FROM HOSE P/N 5P PFOZZ D8102.COUPLING PFOZZ FITTING PFOZZ M506 CONNECTOR PFOOO P5159 HOSE ASSEMBLY, NONME MOOZZ P HOSE MAKE FROM HOSE P/N 5P XAOZZ FITTING XAOZZ N5560.COUPLING PFOZZ L1352 BOLT, MACHINE PFOZZ ADAPTER, STRAIGHT, TU PFOZZ M8485 SEAL, ADAPTER, MOTOR AOOOO P1248 HOSE ASSEMBLY USE ON TYPES 2 AND AOOOO P2898 HOSE ASSEMBLY USE ON TYPE MOOZZ P HOSE MAKE FROM HOSE P/N 9S PFOZZ P1711.COUPLING ASSEMBLY USE ON TYPES 2 1 AND PFOZZ S6389.COUPLING ASSEMBLY USE ON TYPE 2 1 AND PFOZZ S6389.COUPLING ASSEMBLY USE ON TYPE PFOZZ S7166.PLUNGER, DETENT AOOOO P5354 HOSE ASSEMBLY MOOZZ P HOSE MAKE FROM HOSE P/N 5P PFOZZ S6393.ELBOW, TUBE TO HOSE PFOZZ S54.14.SLEEVE, HOSE PFOZZ P3857.COUPLING ASSEMBLY AOOOO P2896 HOSE ASSEMBLY

217 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 42 MOOZZ P HOSE MAKE FROM HOSE P/N 9S PFOZZ STEM PFOZZ S6389.COUPLING ASSEMBLY PFOZZ S7166.PLUNGER, DETENT... 2 END OF FIGURE 95-2

218 1 9 2 THRU 5 10 THRU 13 TA FIGURE 96. PUMP LINES, TYPES 1 AND 3 (USE WITH DOUBLE VALVE).

219 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2406 STRAINERS* FILTERS, LINES AND FITTINGS, ETC. FIG 96 PUMP LINES, TYPES I AND 3 (USE WITH DOUBLE VALVE) 1 PFOOO S4943 HOSE ASSEMBLY, NONME MOOZZ HOSE, NONMETALLIC MAKE FROM HOSE P/ 1 N 5P PFOZZ S4055.COUPLING ASSEMBLY STRAIGHT PFOZZ S6391.ELBOW, TUBE TO HOSE PFOZZ S8606.SLEEVE PFOZZ J522 PACKING, PREFORMED PFOZZ H5368 BOLT, MACHINE PFOZZ WASHER, FLAT AOOOO P6956 HOSE ASSEMBLY PFOZZ STEM ASSEMBLY PFOZZ S7116.SLEEVE PFOZZ S8569.ELBOW, FLANGE TO HOS 30 DEGREES PFOZZ P4585 FLANGE HALF, PIPE XDOZZ K3979 COVER PFOZZ P3704 SEAL PFOZZ PLUG PFOZZ PACKING, PREFORMED PFOZZ PLUG, MACHINE THREAD PFOZZ PACKING, PREFORMED XDOZZ P6657 MANIFOLD PFOZZ J5573 PACKING, PREFORMED PFOZZ F8698 BOLT, MACHINE PFOZZ MS WASHER, LOCK PFOZZ F5192 SCREW, CAP, HEXAGON H PFOZZ F3106 PACKING, PREFORMED PFOZZ MS NUT, PLAIN, HEXAGON PFOZZ MS WASHER, LOCK PFOZZ H3931 PACKING, PREFORMED PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ S658 WASHER, FLAT PFOZZ P2895 HOSE ASSEMBLY PFOZZ MS51525A8 ADAPTER, STRAIGHT, TU PFOZZ K360 PACKING, PREFORMED... 2 END OF FIGURE 96-1

220 1 8 2 THRU 5 9 THRU 12 TA FIGURE 97. PUMP LINES, TYPE 2 (USE WITH DOUBLE VALVE).

221 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2406 STRAINERS, FILTERS, LINES AND FITTINGS, ETC. FIG 97 PUMP LINES, TYPE 2 (USE WITH DOUBLE VALVE) 1 PFOOO S4943 HOSE ASSEMBLY, NONME MOOZZ HOSE, NONMETALLIC MAKE FROM HOSE P/ 1 N 5P PFOZZ S4055.COUPLING ASSEMBLY STRAIGHT PFOZZ S6391.ELBOW, TUBE TO HOSE 90 DEGREES PFOZZ S8606.SLEEVE PFOZZ H5368 BOLT, MACHINE PFOZZ B4279 WASHER, FLAT AOOOO P6956 HOSE ASSEMBLY PFOZZ S8571 STEM ASSEMBLY 60 DEGREES MOOZZ HOSE MAKE FROM HOSE P/N 5P PFOZZ S7116 SLEEVE PFOZZ S8569 ELBOW, FLANGE TO HOS 30 DEGREES PFOZZ P4578 FLANGE, PIPE XDOZZ K3579 COVER PFOZZ P3704 SEAL PFOZZ S5914 PLUG PFOZZ S4078 PACKING, PREFORMED PFOZZ PLUG, MACHINE THREAD PFOZZ PACKING, PREFORMED XDOZZ P6657 MANIFOLD PFOZZ J5573 PACKING, PREFORMED PFOZZ F8698 BOLT, MACHINE PFOZZ MS WASHER, LOCK PFOZZ F5192 SCREW, CAP, HEXAGON H PFOZZ F3106 PACKING, PREFORMED PFOZZ MS NUT, PLAIN, HEXAGON PFOZZ MS WASHER, LOCK PFOZZ P4585 FLANGE HALF, PIPE PFOZZ L5359 SEAL PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ S658 WASHER.FLAT PFOZZ P1154 TUBE ASSEMBLY PFOZZ P598 CLAMP, HOSE PFOZZ D5381 HOSE PFOZZ P1156 TUBE ASSEMBLY PFOZZ MS51525A8 ADAPTER, STRAIGHT, TU PFOZZ K360 PACKING, PREFORMED PFOZZ J522 PACKING, PREFORMED END OF FIGURE

222 THRU THRU THRU 38 TA FIGURE 98. RIPPER PIN PULLER LINES, TYPES 1, 2 AND 3.

223 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2406 STRAINERS, FILTERS, LINES AND FITTINGS, ETC. FIG 98 RIPPER PIN PULLER LINES, TYPES 1, 2 AND 3 1 PFOZZ ELBOW, TUBE TO BOSS... 2 UOC :T25 2 PFOZZ J7354 PACKING, PREFORMED... 2 UOC :T25 3 PFOZZ P1932 ADAPTER... 2 UOC :T25 4 PFOZZ K360 PACKING, PREFORMED UOC :T25 5 PFOZZ D6466 CLAMP, LOOP... 6 UOC :T25 6 PFOZZ S1621 BOLT, MACHINE... 2 UOC :T25 7 PFOZZ WASHER, LOCK... 2 UOC :T25 8 PFOZZ F748 NUT, PLAIN, WELDING... 2 UOC :T25 9 XDOZZ P6246 BRACKET ASSEMBLY... 1 UOC :T25 10 PFOZZ F2978 NUT, PLAIN, WELDING... 1 UOC :T25 11 PFOZZ MS SCREW, CAP, HEXAGON H... 6 UOC :T25 12 PFOZZ B4506 WASHER, LOCK... 1 UOC :T25 13 PFOZZ BOLT, MACHINE... 2 UOC :T25 14 PFOZZ JM56 NUT, PLAIN, HEXAGON... 2 UOC :T25 15 PFOZZ WASHER, LOCK... 2 UOC :T25 16 PFOZZ D679 KNOB... 1 UOC :T25 17 XDOZZ P5668 HANDLE... 1 UOC :T25 18 PFOZZ B3057 PIN, STRAIGHT, HEADED... 1 UOC :T25 19 PFOZZ MS PIN, COTTER... 1 UOC :T25 20 PFOZZ P5669 LINK... 2 UOC :T25 21 PFOZZ P3321 PIN, STRAIGHT, HEADED... 2 UOC :T25 22 PFOZZ A82-1 PIN, COTTER... 2 UOC :T25 23 PFOZZ WA1248 WASHER, FLAT... 4 UOC :T

224 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 24 AOOOO P HOSE ASSEMBLY... 1 UOC :T25 25 PFOZZ J7352.CONNECTOR, CYLINDER... 2 UOC :T PFOZZ J7354.PACKING, PREFORMED... 2 UOC :T25 27 MOOZZ P HOSE MAKE FROM HOSE P/N 3P UOC :T25 28 AOOOO HOSE ASSEMBLY... 1 UOC :T25 29 PFOZZ MS51525B4-6 ADAPTER, STRAIGHT, TU... 2 UOC :T25 30 PFOZZ PACKING, PREFORMED... 2 UOC :T25 31 MOOZZ HOSE MAKE FROM HOSE P/N 3P UOC :T25 32 PFOZZ J7303 ELBOW... 1 UOC :T25 33 PFOZZ P5905 COVER USE ON TYPE UOC :T25 33 XDOZZ G2854 COVER USE ON TYPE 2 AND UOC :T25 34 PFOZZ MS WASHER, FLAT... 6 UOC :T25 35 AOOOO P HOSE ASSEMBLY... 2 UOC :T25 36 MOOZZ P HOSE MAKE FROM HOSE P/N 3P UOC :T25 37 PFOZZ PACKING, PREFORMED... 2 UOC :T25 38 PFOZZ MS51525B4-6.ADAPTER, STRAIGHT, TU... 2 UOC :T25 END OF FIGURE 98-2

225 THRU THRU THRU 23 TA FIGURE 99. PIN PULLER LINES.

226 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2406 STRAINERS, FILTER, LINES AND FITTINGS, ETC. FIG 99 FIN PULLER LINES 1 PFOZZ S1621 BOLT, MACHINE PFOZZ WASHER, LOCK PFOZZ F2978 NUT, PLAIN, WELDING PFOZZ WASHER, LOCK PFOZZ MS SCREW, CAP, HEXAGON H XDOZZ P7948 BRACKET XDOZZ J4870 FLANGE AOOOO P HOSE ASSEMBLY MOOZZ P HOSE MAKE FROM HOSE P/N 3P PFOZZ J7352 CONNECTOR, CYLINDER PFOZZ J7354 PACKING, PREFORMED AOOOO P HOSE ASSEMBLY MOOZZ HOSE MAKE FROM HOSE P/N 3P PFOZZ J7352 CONNECTOR, CYLINDER PFOZZ J7354 PACKING, PREFORMED PFOZZ J7303 ELBOW PFOZZ P5905 COVER PFOZZ CLAMP, LOOP PFOZZ MS WASHER, FLAT AOOOO P HOSE ASSEMBLY MOOZZ P HOSE MAKE FROM HOSE P/N 3P PFOZZ J7352 CONNECTOR, CYLINDER PFOZZ J7354 PACKING, PREFORMED PFOZZ C7946 ELBOW, TUBE TO BOSS PFOZZ P1532 ADAPTER PFOZZ K360 PACKING, PREFORMED PFOZZ F748 NUT, PLAIN, WELDING... 1 END OF FIGURE 99-1

227 THRU THRU THRU 24 TA FIGURE 100. RIPPER LINES, LEFT AND RIGHT.

228 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2406 STRAINERS, FILTERS, LINES AND FITTINGS, ETC. FIG 100 RIPPER LINES, LEFT AND RIGHT 1 PFOZZ K4129 SPACER 0.38 INCH THICK... 2 UOC :T25 1 PFOZZ SPACER 1.25 INCHES THICK... 2 UOC :T25 2 PFOZZ T573 BOLT, MACHINE... 4 UOC :T25 3 PFOZZ J107 TUBE ASSEMBLY... 2 UOC :T25 4 PFOZZ P3703 PACKING, PREFORMED... 4 UOC :T25 5 PFOZZ P4577 FLANGE, PIPE UOC :T25 6 PFOZZ S1588 BOLT, MACHINE UOC :T25 7 PFOZZ MS WASHER, FLAT UOC :T25 8 PFOZZ S1619 BOLT, MACHINE... 8 UOC :T25 9 AOOOO J9618 HOSE ASSEMBLY... 2 UOC :T25 10 MOOZZ P HOSE MAKE FROM HOSE P/N 9S UOC: T25 11 PFOZZ S7166.PLUNGER, DETENT... 2 UOC :T25 12 PFOZZ P6908.STEM ASSEMBLY... 1 UOC :T25 13 PFOZZ S4591.STEM ASSEMBLY... 1 UOC :T25 14 PFOZZ J520 PACKING, PREFORMED UOC :T25 15 AOOOO J6831 HOSE ASSEMBLY... 2 UOC :T25 16 MOOZZ P HOSE MAKE FROM HOSE P/N 9S UOC :T25 17 PFOZZ S7166.PLUNGER, DETENT... 2 UOC :T25 18 PFOZZ S4591.STEM ASSEMBLY... 1 UOC: T25 19 PFOZZ S6102.STEM ASSEMBLY... 1 UOC :T25 20 AOOOO J9617 HOSE ASSEMBLY... 4 UOC :T25 21 MOOZZ P HOSE MAKE FROM HOSE P/N UOC :T25 22 PFOZZ P6908.STEM ASSEMBLY... 1 UOC :T25 23 PFOZZ S7166.PLUNGER, DETENT

229 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY UOC :T25 24 PFOZZ S4591.STEM ASSEMBLY... 1 UOC :T25 END OF FIGURE 100-2

230 THRU 8 22 THRU 25 TA FIGURE 101. BULLDOZER LINES.

231 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2406 STRAINERS, FILTERS, LINES AND FITTINGS, ETC. FIG 101 BULLDOZER LINES 1 PFOZZ J524 PACKING, PREFORMED PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ P4579 FLANGE PFOOO P2686 HOSE ASSEMBLY MOOZZ HOSE MAKE FROM HOSE P/N 5P PFOZZ S7116.SLEEVE PFOZZ S8571 STEM ASSEMBLY PFOZZ S3779 ADAPTER, STRAIGHT, FL STRAIGHT PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ P5945 CLAMP PFOZZ MS SCREW, CAP. HEXAGON H PFOZZ D3480 SPACER SHORT PFOZZ NUT, PLAIN, HEXAGON PFOZZ WASHER, LOCK PFOZZ S9846 SPACER LONG PFOZZ J522 PACKING, PREFORMED PFOZZ H5368 BOLT, MACHINE PFOZZ P4578 FLANGE, PIPE PFOZZ P6308 CLIP PFOZZ WASHER, FLAT AOOOO P2888 HOSE ASSEMBLY MOOZZ HOSE MAKE FROM HOSE P/N 5P PFOZZ S7116 SLEEVE PFOZZ S9872 STEM ASSEMBLY PFOZZ S3779 ADAPTER, STRAIGHT, FL STRAIGHT... 1 END OF FIGURE 101-1

232 1 2 THRU 5 TA FIGURE 102. BULLDOZER LINES AND FITTINGS.

233 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2406 STRAINERS, FILTERS, LINES AND FITTINGS, ETC. FIG 102 BULLDOZER LINES AND FITTINGS 1 PFOOO S5682 HOSE A PFOZZ S8358.STEM ASSEMBLY MOOZZ C HOSE MAKE FROM HOSE P/N 9S PFOZZ S7166.PLUNGER, DETENT PFOZZ S7165.STEM ASSEMBLY STRAIGHT PFOZZ MIL-R-83248/2.PACKING, PREFORMED PFOZZ P5550 TUBE ASSEMBLY PFOZZ MS SCREW, CAP, HEXAGON -H PFOZZ MS WAS HER, LOCK PFOZZ P1566 BRACKET... T 2 11 PFOZZ MS WASHER, FLAT PFOZZ S8921 CLIP TABBED PFOZZ S8920 CLIP SLOTTED PFOZZ A2029 BOLT, MACHINE PFOZZ A NUT, PLAIN, HEXAGON PFOZZ B4506 WASHER, LOCK PFOZZ P5552 TUBE ASSEMBLY PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ B4280 WASHER, FLAT PFOZZ P4579 FLANGE PFOZZ J524 PACKING, PREFORMED PFOZZ B4508 WASHER LOCK PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ P6589 MANIFOLD PFOZZ P4576 FLANGE, PIPE PFOZZ S1588 BOLT, MACHINE END OF FIGURE 102-1

234 THRU THRU THRU THRU 30 TA FIGURE 103. TILT CYLINDER HYDRAULIC LINES.

235 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2406 STRAINERS, FILTERS, LINES AND FITTINGS, ETC. FIG 103 TILT CYLINDER HYDRAULIC LINES 1 PFOZZ J7548 GUARD PFOZZ S1588 BOLT, MACHINE PFOZZ MS WASHER, FLAT PFOZZ P4576 FLANGE, PIPE PFOZZ MIL-R-83248/2 PACKING, PREFORMED PFOOO D5248 HOSE A MOOZZ HOSE NONMETALLIC - MAKE FROM HOSE P/ 1 N 5P PFOZZ S9593.ELBOW, SWIVEL FLANGE PFOZZ S8606.SLEEVE PFOZZ S4055 COUPLING ASSEMBLY PFOZZ P1325 ELBOW, TUBE PFOZZ J7550 GUARD PFOZZ D6259 BOLT, MACHINE PFOZZ WASHER, LOCK PFOZZ MS NUT, PLAIN, HEXAGON PFOOO S4936 HOSE A MOOZZ HOSE MAKE FROM HOSE P/N 5P PFOZZ SLEEVE PFOZZ COUPLING ASSEMBLY PFOZZ H3757 BOLT, MACHINE PFOZZ J9340 GUARD PFOOO J67 GUARD ASSEMBLY PFOZZ J3505.NUT, PLAIN, HEXAGON PFOZZ J8711.DOWEL PFOZZ B7560 CORK PFOZZ S1973 BOLT, MACHINE PFOOO S1690 HOSE A PFOZZ COUPLING ASSEMBLY PFOZZ S8606 SLEEVE MOOZZ HOSE MAKE FROM HOSE P/N 5P PFOZZ P1281 NIPPLE, TUBE PFOZZ F2050 NUT, LOCK... 4 END OF FIGURE 103-1

236 THRU 4 10 THRU THRU 37 TA FIGURE 104. TILT CYLINDER LINES.

237 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2406 STRAINERS, FILTERS, LINES AND FITTINGS, ETC. FIG 104 TILT CYLINDER LINES 1 AOOOO P6655 HOSE ASSEMBLY MOOZZ P HOSE MAKE FRCM HOSE P/N 5P PFOZZ S5414.SLEEVE, HOSE PFOZZ P3857.COUPLING ASSEMBLY PFOZZ MSSL525A6 ADAPTER, STRAIGHT, TU PFOZZ C PACKING, PREFORMED PFOZZ CONNECTOR PFOZZ A MILP2573 PACKING, PREFORMED AOOOO P2890 HOSE ASSEMBLY MOOZZ HOSE MAKE FRCM HOSE P/N 5P PFOZZ P8408.COUPLING A PFOZZ S8606.SLEEVE PFOZZ S6391.ELBOW, TUBE TO HOSE PFOZZ P5327 CLIP PFOZZ S9629 GUARD ASSEMBLY PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ MS WASHER, LOCK PFOZZ S658 WASHER, FLAT PFOZZ S1595 BOLT, MACHINE PFOZZ B4508 WASHER, LOCK PFOZZ B4280 WASHER, FLAT XDOZZ S9632 GUARD ASSEMBLY PFOZZ S8657 TUBE ASSEMBLY XDOZZ S8656 TUBE ASSEMBLY PFOZZ D9459 CLIP, ELECTRICAL XDOZZ S3970 BAR PFOZZ H1717 BOLT, MACHINE PFOZZ S4951 CAP, TUBE PFOZZ S1594 BOLT, MACHINE PFOZZ B4506 WASHER, LOCK PFOZZ P5588 PLATE ASSEMBLY PFOZZ F748 NUT, PLAIN, WELDING PFOZZ S1621 BOLT, MACHINE AOOOO P2900 HOSE ASSEMBLY MOOZZ HOSE MAKE FROM HOSE P/N 5P PFOZZ S6391.ELBOW, TUBE TO HESE PFOZZ S8606.SLEEVE... 2 END OF FIGURE 104-1

238 TM P TA FIGURE 105. HYDRAULIC FILTER.

239 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2406 STRAINERS, FILTERS, LINES AND FITTINGS, ETC. FIG 105 HYDRAULIC FILTER 1 PFOZZ S4191 PLUG, MACHINE THREAD PFOZZ PACKING, PREFORMED XDOZZ P3591 MANIFOLD PFOZZ F7391 PACKING, PREFORMED PFOZZ J750 FILTER ELEMENT, FLUI PFOZZ L5032 PACKING, PREFORED PFOZZ J4994 SPACER PFOZZ PACKING, PEFORMED XDOZZ J8423 COVER PFOZZ F9206 PACKING, PREFORMED PFOZZ J6309 SPACER PFOZZ J8439 BOLT, SHOULDER PFOZZ MS NUT PLAIN, HEXAGON PFOZZ INDICATOR ASSEM8LY PFOZZ B BALL, BEARING PFOZZ H5139 PLATE, PRESSURE PFOZZ H6454 GASKET PFOZZ H1447 CAP, FILLER OPENING PFOZZ D7927 STRAINER ELEMENT, SE PFOZZ H9361 RING PFOZZ J6913 RETAINER PFOZZ J8252 GLASS, LIQUID SIGHT PFOZZ J8251 GROMMET, NONMETALLIC PFOZZ J8322 RING PFOZZ J2914 SPACER PFOZZ JB443 SPRING PFOZZ JE428 TUBE ASSEMBLY PFOZZ JE424 GASKET PFOZZ JE468 VALVE PFOZZ J4862 SCREEN A PFOZZ H6488 BOLT PFOZZ NUT, PLAIN, HEXAGON PFOZZ B4508 WASHER, LOCK PFOZZ A1460 BOLT, MACHINE XDOZZ J8422 BASE PFOZZ IP3707 SEAL PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ S658 WASHER, FLAT PFOZZ P4585 FLANGE HALF, PIPE PFOZZ J8436 TUBE ASSEMBLY... 1 END OF FIGURE 105-1

240 TM P THRU 22 3 THRU 4 7 TA FIGURE 106. LIFT CYLINDERS, LEFT AND RIGHT HAND.

241 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2407 HYDRAULIC CYLINDERS FIG 106 LIFT CYLINDERS, LEFT AND RIGHT HAND 1 PFOFF G8089 CYLINDER ASSEMBLY,A LH, RH... 2 END OF FIGURE 106-1

242 TM P THRU AND 16 TA FIGURE 107. RIPPER CYLINDER, LEFT AND RIGHT.

243 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2407 HYDRAULIC CYLINDERS FIG 107 RIPPER CYLINDER, LEFT AND RIGHT 1 PFOFF J3221 CYLINDER ASSEMBLY RIGHT HAND... 1 UOC : T25 1 PFOFF J3222 CYLINDER ASSEMBLY, A LEFT HAND... 1 UOC : T25 13 PFOZZ MS FITTING, LUBRICATION... 2 UOC : T25 END OF FIGURE 107-1

244 TM P THRU 20 9 AND TA FIGURE 108. RIPPER CYLINDER, CENTER.

245 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2407 HYDRAULIC CYLINDERS FIG 108 RIPPER CYLINDER, CENTER 1 PFOFF J9129 CYLINDER ASSEMBLY... 2 UOC : T25 2 PFOZZ MS FITTING, LUBRICATIUON... 2 UOC : T25 END OF FIGURE 108-1

246 TM P TA FIGURE 109. HYDRAULIC TANK CAP PROTECTION COVER.

247 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2408 LIQUID TANKS OR RESERVOIRS FIG 109 HYDRAULIC TANK CAP PROTECTION COVER 1 PFOZZ S7949 PADLOCK GRCUP WITH KEY PFOZZ L5072 PIN PFOZZ M7394 LEVER, REMOTE CONTRO PFOZZ D1911 COVER, HYDRAULIC CAP PFOZZ J7761 RING... 1 END OF FIGURE 109-1

248 TM P TA FIGURE 110. PRESSURE GAGES.

249 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 47 GAGES, WEIGHING AND MEASURING DEVICES GROUP 4702 GAGES, MOUNTINGS LINES, AND FITTINGS FIG 110 PRESSURE GAGES 1 PFOZZ MS CLAMP, LOOP PFOZZ B6029 BUSHING RUBBER PFOZZ S0687 INDICATOR, FILTER WA PFOZZ P6886 ADAPTER PFOZZ MS SCREW, CAP, HEXAGON-H PFOZZ W WASHER, FLAT PFOZZ P2948 CONNECTOR PFOZZ BE756 INVERTED NUT, TUBE C MOOZZ TUBE MAKE FREM TUBE P/N 5P MOOZZ TUBE MAKE FROM TUBE P/N 5P PFOZZ P5334 GROMMET, NONMETALLIC MOOZZ P TUBE MAKE FROM TUBING P/N 5P PFOZZ M1065 GAGE, PRESSURE, DIAL OIL PRESSURE PFOZZ KSS79 FITTIN PFOZZ P5486 INDICATOR, ENGINE TE CONVERTER... 1 TEMPERATURE 16 PFOZZ INDICATOR, FUEL PRES PFOZZ S4914 GAGE, PRESSURE, DIAL WATER PRESSURE PFOZZ S4915 INDICATOR, TEMPERATU WATER 1 TEMPERATURE... END OF FIGUIRE 110-1

250 TM P TA FIGURE 111. SERVICE METER.

251 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 4702 GAGES, MOUNTINGS, LINES, AND FITTINGS FIG 111 SERVICE METER 1 PFOZZ MB303 PACKING, PREFORMED PFOZZ S3032 CLAMP, RIM CLENCHING PFOZZ S3033 CLAMP, RIM CLENCHING PFOZZ T416 BOLT, MACHINE PFOZZ MS WASHER, LOCK PFOZZ P1211 METER, TIME TOTALIZI... 1 END OF FIGURE 111-1

252 TM P TA FIGURE 112. PRESSURE GAGES LINES AND FITTINGS.

253 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 4702 GAGES, MOUNTINGS, LINES, AND FITTINGS FIG 112 PRESSURE GAGES LINES AND FITTINGS 1 PFOZZ NUT, THERMOCOUPLE AD PFOZZ B5721 SPACER, RING PFOZZ F244 GROMMET PFOZZ H3068 CLAMP, LOOP PFOZZ CLIP, ELECTRICAL PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ B4506 WASHER, LOCK PFOZZ S2093 STRAP AOOOO P9133 ELBOW ASSEMBLY PFOZZ P9132.ELBOW PFOZZ P6561.SLEEVE PFOZZ P8563.NUT PFOZZ M873 CLIP PFOZZ PLUG, PIPE USE WITH SERIAL RANGE 1 77V9232 THRU 77V PF-ZZ K9239 ADAPTER, STRAIGHT, PI USE WITH 1 SERIAL RANGE 77V9232 THRU 77V PFOZZ B1261 TEE, PIPE USE WITH SERIAL RANGE 1 77V9232 THRU 77V PFOZZ NIPPLE, PIPE USE WITH SERIAL RANGE 1 77V9232 THRU 77V PFOZZ K9241 FITTING USE WITH SERIAL RANGE THRU 1 771V PFOZZ B8756 INVERTED NUT, TUBE C USE WITH 2 SERIAL RANGE THRU 77V PFOZZ B CLIP, SPRING TENSION PFOZZ BUSHING, RUBBER MOOZZ TUBE MAKE FROM TUBE P/N 5P PFOZZ K9242 FITTING MOOZZ TUBE MAKE FROM TUBE P/N 5P PFOZZ K9243 ELBOW, PIPE TO TUBE... 1 END OF FIGURE 112-1

254 TM P 7 8 THRU 10 TA FIGURE 113. WATER HEATER JACKET.

255 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 60 STEAM BOILERS, WATER HEATERS, HEATING UNITS, BURNERS GROUP 6015 WATER HEATER ASSEMBLY FIG 113 WATER HEATER JACKET 1 PFOZZ B4506 WASHER, LOCK PFOZZ L1351 BOLT, MACHINE PFOZZ N83 COVER PFOZZ L5503 GASKET PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ P4622 FLANGE PFOFF P4624 HEATER PFOZZ P4621 GASKET PFOZZ K4709 WASHER PFOZZ N1604 CAP ASSEMBLY PFOZZ P4620 GASKET... 1 END OF FIGURE 113-1

256 TM P 1 2 THRU 10 TA FIGURE 114. EXTERNAL QUICK DROP VALVE.

257 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 74 CRANES, SHOVELS, AND EARTH MOVING EQUIPMENT COMPONENTS GROUP 7427 MISCELLANEOUS VALVES FIG 114 EXTERNAL QUICK DROP VALVE 1 PFOFF J608 VALVE, QUICK DUMP PFOZZ BOLT, MACHINE PFOZZ MS WASHER, LOCK... 2 END OF FIGURE 114-1

258 TM P 1 2 THRU 9 TA FIGURE 115. STRAIGHT BULLDOZER BLADE.

259 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 7435 MOLDBCARD ASSEMBLY FIG 115 STRAIGHT BULLDOZER BLADE 1 PFOFF J9027 BLADE, STRAIGHT... 1 UOC : T25 2 PFOZZ F6936.SCREW, CAP, HEXAGON H... 8 UOC : T25 3 PFOZZ J3711.RETAINER... 4 UOC : T25 4 PFOZZ J9013.CAP... 2 UOC : T25 5 PFOZZ J8118.CUTTING EDGE, MOLDBO... 3 UOC : T25 5 PFOZZ J1468.CUTTING EDGE USE WITH BULLDOZER 1 SERIAL RANGE 29V1 AND UP... UOC : T25 6 PFOZZ J9058.BOLT, SQUARE NECK UOC : T25 6 PFOZZ J9208.BOLT UOC : T25 7 PFOZZ J3507.NUT, PLAIN, HEXAGON UOC : T25 8 PFOZZ K5234.WASHER, FLAT UOC : T25 9 PFOZZ J1479.END BIT, MOLDBOARD R H... 1 UOC : T25 9 PFOZZ J1480.END BIT, MOLDBOARD L H... 1 UOC : T25 9 PFOZZ J1472.BIT, LEFT HAND USE WITH BULLDOZER 1 SERIAL RANGE 29V1 AND UP... UOC : T25 9 PFOZZ J1473.BIT, RIGHT HAND USE WITH BULLDOZER 1 SERIAL RANGE 29V1 AND UP... UOC: T25 9 PFOZZ J811L6.BIT, LEFT HAND USE WITH BULLDOZER 1 SERIAL RANGE 29V1 AND UP... UOC : T25 9 PFOZZ J8117.BIT, RIGHT HAND USE WITH BULLDOZER 1 SERIAL RANGE 29V1 AND UP... UOC: T25 END OF FIGURE 115-1

260 TM P THRU 43 5 AND THRU THRU 43 TA FIGURE 116. BULLDOZER PUSH ARM.

261 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 7436 LIFT ARMS AND PIVOT ASSEMBLIES FIG 116 BULLDOZER PUSH ARM 1 PFOFF J9196 PUSH ARM GROUP... 1 UOC: T25 3 PFOZZ MS FITTING, LUBRICATION... 2 UOC : T25 END OF FIGURE 116-1

262 TM P THRU 27 8 THRU 9 17 THRU THRU 26 TA FIGURE 117. ARM AND BRACE.

263 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 7436 LIFT ARMS AND PIVOT ASSEMBLIES FIG 117 ARM AND BRACE 1 XDOFF J218 ARM AND BRACE... 1 UOC: T24 14 PFOZZ MS FITTING, LUBRICATION... 4 UOC : T24 END OF FIGURE 117-1

264 TM P THRU 9 TA FIGURE 118. BLADE CYLINDER MOUNTING.

265 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 7436 LIFT ARMS AND PIVOT ASSEMBLIES FIG 118 BLADE CYLINDER MOUNTING 1 PFOZZ D4617 CAP SCREW PFOZZ MS WASHER, LOCK PFOOO J5283 CAP ASSEMBLY PFOZZ J5284 BEARING AOOOO J4583 TUBE ASSEMBLY PFOZZ J1335 BEARING PFOZZ F1474 PLUG, EXPANSION PFOZZ J1336 BEARING PFOZZ J4582 SUPPORT PFOZZ J3207 PIN, STRAIGHT, HEADED PFOZZ MS SCREW, CAP, HEXAGON H PFOZZ P1396 NUT PFOZZ S1322 BOLT, MACHINE PFOZZ H1031 WASHER, FLAT PFOZZ J5130 BRACKET PFOZZ J9827 PLATE PFOZZ J3505 NUT, PLAIN, HEXAGON PFOZZ MS FITTING, LUBRICATION PFOZZ J5118 PLATE PFOZZ J8004 GASKET PFOZZ S1566 BOLT, MACHINE PFOZZ MS WASHER, LOCK PFOZZ J5120 PIN PFOZZ P3864 SCREW, CAP, HEXAGCN H PFOZZ J5258 YOKE PFOZZ MS FITTING, LUBRICATION PFOZZ J1984 SEAL... 2 END OF FIGURE 118-1

266 TM P TA FIGURE 119. RIPPER LINK.

267 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 7465 ROOTERS, RIPPERS, PLOWS, HARROWS FIG 119 RIPPER LINK 2 PFOZZ MS FITTING, LUBRICATION... 4 UOC: T25 END OF FIGURE 119-1

268 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 95 GENERAL USE STANDARDIZED PARTS GROUP 9501 BULK MATERIEL FIG BULK 1 PFOZZ P 747 CABLE... V 2 PFOZZ P 695 CONDUIT... V 3 PFOZZ P182 HOSE... V 4 PFOZZ P734 HOSE... V 5 PFOZZ P735 HOSE... V 6 PFOZZ P6048 HOSE ASSEMBLY, NONME... V 1 PFOZZ P6047 HOSE ASSEMBLY, NONME... V 8 PFOZZ P6049 HOSE ASSEMBLY, NONME... V 9 PFOZZ P0179 HOSE, NONMETALLIC... V 10 PFOZZ P1263 HOSE, NONMETALLIC... V 11 PFOZZ P1442 HOSE, NONMETALLIC... V 12 PFOZZ P178 HOSE, NONMETALLIC... V 13 PFOZZ S247 HOSE, NONMETALLIC... V 14 PFOZZ P1259 HOSE, NONMETALLIC... V 15 PFOZZ P1257 HOSE, PREFORMED... V 16 PFOZZ P5633 TUBE... V 17 PFOZZ P5996 TUBE... V 18 PFOZZ P1277 TUBE... V 19 PFOZZ P1198 TUBE, METALLIC... V 20 PFOZZ P1200 TUBE, METALLIC... V 21 PFOZZ P1201 TUBE, METALLIC... V 22 PFOZZ P5628 TUBE, METALLIC... V 23 PFOZZ P5630 TUBING... V 24 PFOZZ P0385 TUBING, NONMETALLIC... V 25 PFOZZ P497 WIRE... V 26 PFOZZ P616 WIRE... V 27 PFOZZ P6642 WIRE... V 28 PFOZZ WIRE ELECTRICAL... V 29 PFOZZ M16878/1BFB2 WIRE, ELECTRICAL... V 30 PFOZZ P5632 WIRE, ELECTRICAL... V 31 PFOZZ P5621 WIRE, ELECTRICAL... V 32 PFOZZ M16878/3BMG0 WIRE, ELECTRICAL... V 33 PFOZZ P5624 WIRE, ELECTRICAL... V 34 PFOZZ M16878/1BKE0 WIRE, ELECTRICAL... V 35 PFOZZ A3626 WIRE, ELECTRICAL... V END OF FIGURE BULK-1

269 SECTION IV CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM s I-1

270 SECTION IV CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM I-2

271 SECTION IV CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM BULK I-3

272 SECTION IV CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM I-4

273 SECTION IV CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM BULK I-5

274 SECTION IV CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM C BULK I-6

275 SECTION IV CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM t I-7

276 SECTION IV CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM I-8

277 SECTION IV CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM BULK I-9

278 SECTION IV CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM BULK BULK I-10

279 SECTION IV CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM I-11

280 SECTION IV CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM S BULK [ I-12

281 SECTION IV CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM BULK s I-13

282 SECTION IV CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM BULK BULK BULK I-14

283 SECTION IV CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM l BULK BULK BULK 2 I-15

284 SECTION IV CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM BULK BULK BULK BULK BULK BULK BULK BULK I-16

285 SECTION IV CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM BULK BULK BULK BULK BULK I-17

286 SECTION IV CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM BULK BULK BULK I-18

287 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM A MILP A A A BS B C DX F02A32V15A HKP-HH/ PD5S IT JM L L L L I-19

288 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM L L L L L L L MIL-R-83248/ MS MS MS MS MS MS MS MS MS MS21044N MS I-20

289 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM MS MS MS MS MS MS MS MS MS MS MS MS MS MS I-21

290 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM MS MS MS MS MS Ill MS MS MS MS MS MS MS MS I-22

291 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM MS MS MS MS MS MS51500A MS51500A MS51504A MS51525-A MS51525A MS51525A MS MS51527A MS MS MS MS MS MS MS I-23

292 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM MS MS MS MS MS MS MS MS MS MS MS MS MS MS I-24

293 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM MS MS MS MS MS MS MS M16878/1BFB2 BULK M1687E/1BKE BULK M16878/3BMG BULK M2048F M M M M7928/ M83248/ M83248/ M83248/2-S PDM PER PER PK P P P P3C S S I-25

294 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM S S S S S S S S I-26

295 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM S S S S l S S S T T T WA W L L L I-27

296 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM MR0B A A A A A A B B B B B B B B D D D D D D I-28

297 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM D F F F F F H H H H H H H J J J J J J J J K K I-29

298 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM K K L L L L M M M M M M M M M M P P P P P P P P P P P P P P I-30

299 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM P P P P P L1083 1P P P P P P P P P P P P P P P840E P P P P P S S S S S S S S S S S S I-31

300 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM S S S S S S S S S S S S S S S S S T T Z XX A I-32

301 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM A AL BULK A A A B B B B B B B B D D D I-33

302 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM D F F F G H H H H H H393L H H H H H H J J J J J J J J J K K K K L L L L L M M I-34

303 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM M M M M M M M M M P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P I-35

304 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM P493E P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P951E R S S I-36

305 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM S S S S S S S S S S S S S S S S S S S S S I-37

306 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM S S S S S S S S S S S S W S B B I-38

307 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM B B B B B L5-00-0L B B B B B B B B B D F I-39

308 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM F F F F F F F F G G H H H H J J J J J J J J K K K K L L l I-40

309 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM L M P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P I-41

310 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM P P P L P P BULK P P P BULK P P BULK P P P P P P P P P P P P P P P P P P P P P P P R R S S I-42

311 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM S S S S S S S S S S S S S S S S S S S S S I-43

312 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM S S S S S S S S S S S S S S SS S Y F-E I-44

313 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM S B B B B B B B B B B B D D D D D D D D F F F F I-45

314 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM F H H H H H H H H H H H J J J J J J J J J J J J J K K K K I-46

315 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM L L M M M M N N N N N N N N N N N N N N N N N N S S S S S S I-47

316 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM S S S S S S B B B B D D D D F F F F H H H H H H H H H H H H I-48

317 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM H H H H H H H J J J J J K K K K K L L L L L L M M M HM M M M I-49

318 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM M M M M N P BULK P BULK P BULK P BULK P P BULK P BULK P P BULK P P P P P P P P BULK P BULK P P BULK P1277 BULK P P BULK P BULK P P P P P P P BULK P P P P P P P P I-50

319 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM P P P P BULK P P P P P P P P P P P P BULK P P BULK P P P P P P P P P P P P P P P P P P P P5624-S I-51

320 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM P BULK P P P P BULK P P BULK P BULK P P P P5996 BULK P P BULK P6642 BULK P P P P P BULK P P P BULK P P P P P P P P P S S S S S S S S S I-52

321 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM S S S S S S S S A BULK A A A B B B B954S B D D F F F F F F F H H H H H H H H H H H H H H H I-53

322 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM H H J J J J J K K K K K L L L L L L N N N N N N N N N N N N N N N N N N N N N N N N N N N N N I-54

323 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM N N N N N N N N N N N N N N N N N N N N N N P P P P P P P P P P P P P P P P P P P P P P I-55

324 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM P P P P P P P P P P P P P P P S S S B B B D F F F F F I-56

325 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM F F F F F G G G G H H H H H H H H H H H J J J J J J J J J J J J K K K L M M M M M M M I-57

326 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM M M M M N N N N L N N N N N N N S S S S S S S S S S S S S S S S S S S S S S S S I-58

327 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM C B B B D D F F F F F F F F F F F F F F F F H H H H H H H H H H H J J J J J J J J J J J I-59

328 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM J J J J J J J l J J J J J J J K t L M M M M M M M M M M M M M M M M M M M M M N N P P P P P I-60

329 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P I-61

330 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM P P P P P P S S S S S S S S S S S S S S S S S S S S S S S S S S S S S S I-62

331 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM S S S S S S S S S S S S S S S LB3-8X D D F F F F F F G I-63

332 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM H H H H H H H H H H H J J J J J J J J J J J J J J J J K K M M M M M M M M M M M M M I-64

333 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM M M M M M M M M M M M N P P P P P P P P S S S S S S BULK S S lit S S S S S S S S S S S I-65

334 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM S S S l S S S S S S I-66

335 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER BULK P 747 BULK P 695 BULK P182 BULK P734 BULK P735 BULK P6048 BULK P6047 BULK P6049 BULK P0179 BULK P1263 BULK P1442 BULK P178 BULK S247 BULK P1259 BULK P1257 BULK P5633 BULK P5996 BULK P1277 BULK P1198 BULK P1200 BULK P1201 BULK P5628 BULK P5630 BULK P0385 BULK P497 BULK P616 BULK P6642 BULK BULK M16878/1BFB2 BULK P5632 BULK P5621 BULK M16878/3BMG0 BULK P5624 BULK M16878/1BKE0 BULK A F B DX H MS A H MS51884-IC A MS B9911 I-67

336 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER H MS H B7114 I H S F M F K F MS M L XX M M M MS S B N P P P M P P M MS P M P P MS N PER MS A D F l F F F M M P H M9423 I-68

337 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER H H H H A S L P H S P S F B H N M H S MS P T P N H S S M L P S B MS MS S M P MS P P N N MS L N B L H4050 I-69

338 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER S F H F L F F F MS L T S N MS S K M M L S M S K MS51500A L P S MS B PK K H F F H C H M H F L F F H H H F L F5224 I-70

339 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER F H F F F F N N H B MS S S L N S L MS A MS H N M F S L F B F LB3-8X F F K MS M PK N B P P P M M P S8379 I-71

340 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER A N A H S J K S S MS A P M N M P T N A B P M MS P P L L P L B MS R S S M P P P L H H MS L H2663 I-72

341 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER H P A A L P MS MS MS P P M M L H H S S S S K F-E L H H P MS P L H H L A A M MS M M F-E P F M P H G D2861 I-73

342 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER P F F S A F P MS PK MS S P L H H S H L A H MS B MS S H S H MS M H S N P MS MS MS F A S S P S H PER H P P4679 I-74

343 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER P J H P MS MS M P N P F N MS N S N MS A MS M N MS S A N K F MS N S M S S S S A M N S N F P N N877 I-75

344 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER N S N N P3C H H N MS N N P N P N H P S S S P S P N H P S P S S P M S M N N S S P P N M MS F S795 I-76

345 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER P A L F N MS N S A H H MS A H S L F S M L S N M B F N MS51504A N MS M N N MS51500A S K H L N N B N M N N M N4302 I-77

346 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER M T A N M N N N N S H H P3C P L M N A N MS S MS S MS L083 7N MS N N N N N H L S N H N S M S N MS N S P S M P1132 I-78

347 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER S B S S L S MS S P S M D A H W D M S N S MS P A S M D H H H P A H N S N PD5S S MS S MS S4459 I-79

348 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER S M P S MS M S F S S H H MS P K L A H F P N F L MS MS F F H M MS P P MS PDM S MS L M L N H MS F7259 I-80

349 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER N L P MS MROB G H MS F S S S S P P P MS M MS P M M M P K M M F A B MS MS S P MS S B K P P P MS S S P8989 I-81

350 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER P J MS P A A M P L K P P B S P S A H P P P S MS P P H P L WA P M P P P MS M P P P P P P M7928/ S2093 I-82

351 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER MS MS L P P MS S S S P D N N P P L P P MS P P MS HKP-HH/ N S P MS P L A MS S P MS JM MS N S M2048F MS MS N MS MS M2048F I-83

352 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER P MS P L P P MS L S P MS P L P S JM MS MS HKP-HH/ S N P P L MS N P S MS P D S B A G P P S S S S A MS P S I-84

353 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER A L S H S P A MS L P L MS R P P S S A MS F02A32V15A S K F P S P P P S S MS L P P S L M S P MS L S H F02A32V15A P3222 I-85

354 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER P S MS P P P S MS25036-L S S P P P P S S S M M MS M M P P M M P S S MS B P P S S S3403 I-86

355 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER P M K P H S S H MS S S S H H MS J S M S S B P S MS P S S P P P S S L L L S S P P P P P I-87

356 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER P L P P P P MS P P P P P L P P P P P MS P P P P N MS S S S S P R M L MS L L P S MS S S P S S H H N P7234 I-88

357 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER P MS S S S M P B S K H P S S P MS S H H B MS MS B M F M A K P P P D S MS MD A D B H S H M MS MS B P M M8908 I-89

358 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER P S B S S S K D P S J S A MILP S H H L P P P P P S M D A S S F S S M J M M B M P B P M P F M S MS A B P7679 I-90

359 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER S M MS51527A P M MS M P P MS S B S P P P B P P M S M M P MS P B M M MS51525-A K P M S J MS21044N MS S L S S B MS F S S M M5471 I-91

360 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER D S P H F S P S P S S P H B S S S MS S B F L S P M P A A P MS S M B S P H M S M L AL S K S S M MS S F A S4551 I-92

361 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER P M MS B H S S S H MS M P MS MS P S S S F L S MS MS L P H XX A P F S F P MS B S P P P P P P P P I-93

362 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER S S S S L B S S H S b H BS S B S S S H S H H H H B H S H H S H H S MS M M MS B B M H B H H H M S S P H7353 I-94

363 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER G G MS P A S S F B L MS S S F S S B P MS B H F MS S A S S L MS S P D J K P P F B L1083 8P M MS M B S S L083 2S H S S9436 I-95

364 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER P P D J K P P P S M B M S K S P N P F S M P L L B B A S M MS M P P B S J J MS MS B P F F H F S P H M5839 I-96

365 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER K P S D P P S B P P L A B P S P P F S M S S MS M P B S J MS MS P F F H F P H M K P P P B S S D1649 I-97

366 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER S P P P P S P F F F S MS MS P F J S MS H P P F P P P F L L S P P P P S M S MS P F P S MS S S P F F P S P6411 I-98

367 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER MS M B P MS MS D P A B J MS S P F F B M P P S B H P M P MS P F P P J J J J F F L F MS MS B F H J J J4626 I-99

368 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER MS F J F J F MS MS L J J J F J L J J J MS B J P MS M P MS JM B P S P B S P H F P P F P H P S M MS A P H L8413 I-100

369 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER P P MS P L MS Z L K P P B MS B S P P J P P S P P J P K P P K P P J M P MS A MILP M833248/ D MS A MS P L L P S8808 I-101

370 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER K J P B P P MS S M K K P H S H P I S MS B IT Y S M S S F MS B P J J G J J J K J S H S J H MS J J J L P P P S6389 I-102

371 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER P S MS A MILP MS51525A P P N M83248/ S M P H B P S S S J S P P S MS P MIL-R-83248/ J M83248/ F MS F F MS MS P J K lp lp MS S P P S7166 I-103

372 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER S S P D P P P P S S MS A MI P MS51525A P P N M83248/ S M P H B P S S S J S P P S B MS B P MIL-R-83248/ J M F MS F F MS MS P J5573 I-104

373 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER K P P MS S P P S S S H B MS P MIL-R-83248/ P M83248/ A M MS MS A MILP P P D MS51525A P P D M P P N L S M P P PL P S S S P P I-105

374 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER S S P P P S S S S S S S J H B P S S S P K IP S S S P J F MS F F MS MS H MS S P MS51525A K S S S S H B P S8571 I-106

375 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER S S P K IP S S S P J F MS F F MS MS P L MS S P L083 5P D P MS51525A i1083 3K J J P K D S B F P F MS B JM D P B MS P P A82-1 I-107

376 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER WA P J J P MS J P G MS P P MS S B F B MS P J P P J J P J J J P D MS P P J J P K F K B T J P P S1588 I-108

377 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER MS S J P S P S J P S S J P P S S J MS P P S MS P MS D J H P P B P S S S S S S S MIL-R-83248/ P MS MS I-109

378 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER P MS S S A A B P MS B P J B MS P P S J S MS P MIL-R-83248/ D S S S P J D MS S S S H J J J J B S S S S P F P P I-110

379 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER S P MS51525A A MILP P P S S P S MS MS S S B B S S S D S H S S B P F S P S S S P F J L J J F J J MS I-111

380 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER H H H D H J J J J J J J J J J H A J P MS S P J G J J MS J MS S L M J I MS B S P MS W P B P P M K P5486 I-112

381 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER S S S M S S T MS P B B F H B MS B S P P P P M K B K B B B K K B L N L MS P P P K N P J MS J F J3711 I-I13

382 SECTION IV CROSS-REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER FSCM PART NUMBER J J J J J J K J J J J J J J MS J MS D MS J J J J F J J J MS P S H J J J MS J J S MS J P J MS J MS I-114

383 By Order of the Secretary of the Army: Official: CARL E. VUONO General, United States Army Chief of Staff R. L. DILWORTH Brigadier General United States Army The Adjutant General Distribution: To be distributed in accordance with DA Form 12-25A, Unit Maintenance requirements for Tractor, Full-Tracked, Low Speed, with Angle Dozer, Model D8K-8A-58, D8K-8S. U. S. GOVERNMENT PRINTING OFFICE: 1995 O

384

385 THE METRIC SYSTEM AND EQUIVALENTS

386 PIN:

387 This fine document... Was brought to you by me: Liberated Manuals -- free army and government manuals Why do I do it? I am tired of sleazy CD-ROM sellers, who take publicly available information, slap watermarks and other junk on it, and sell it. Those masters of search engine manipulation make sure that their sites that sell free information, come up first in search engines. They did not create it... They did not even scan it... Why should they get your money? Why are not letting you give those free manuals to your friends? I am setting this document FREE. This document was made by the US Government and is NOT protected by Copyright. Feel free to share, republish, sell and so on. I am not asking you for donations, fees or handouts. If you can, please provide a link to liberatedmanuals.com, so that free manuals come up first in search engines: <A HREF= Military and Government Manuals</A> Sincerely Igor Chudov Chicago Machinery Movers