Rolls-Royce Corporation T56 SERVICE INFORMATION LETTER (SIL) Technical Publications Index
|
|
- Philip Cooper
- 6 years ago
- Views:
Transcription
1 Corporation T56 SERVICE INFORMATION LETTER (SIL) Technical Publications Index November 1, 2017
2 Use of the Service Information Letter Compressor Inlet Sensing Probe Torque R Overboard Fuel Venting T56 Series III 2nd Stage Wheel Measurements T56 Series II Unexplained Oil Loss T56 Series III Unexplained Oil Loss Speed Sensitive Valve (Poppet Valve) RGB AEM s ATP and ATP Operation and Maintenance in Erosive Environments Mag Plug Inspection Tool Instructions for 4th stg. Turbine Blade ( ) R Series II 4th Stage Turbine Blades/Wheels, Inspect T56 Engine Overtorque Rear Compressor Bearing ( ), Inspect Cancelled Reduction Gearbox Main Drive Gear, Serviceability Criteria R T56 Solid State Amplifier Adjustment * Rear Carrier Bearing ( ), Inspect PPB--104, Revision Recommendations Cancelled Information Distribution to T56 Operators R* Third Stage Turbine Wheel ( ); Exhibit Request R Engine Fuel nozzle Cleaning R Compressor, Air Inlet Housing, Inspect/Rework R RGB External Oil Pressure Relief Valve--New Gasket Release Cancelled Release of New Spare Part--Prop Brake Facing ( ) Cancelled Series IV only; not available R T56 Engine Torching at High Power Settings * Scavenge Oil System Test Kit How to request and Receive Tech publications Rescinded by R Propeller Shaft Cleaning at Installation Cancelled Series IV only; not available R 5th Stage Compressor Blades (Inspect) Cancelled * Paralleling Valve; Fault Isolation, Repair and Installation Series IV only; not available Series IV only; not available Revised November 1, 2017 PAGE 1 OF 5
3 Series IV only; not available Series IV only; not available R Planet Gear and Bearing Assy. Replaceable Roller Sets Series IV only; not available Cancelled Series IV only; not available Series IV only; not available R* Fuel nozzle Bolt Lubricant R* Enhanced Reliability Gearbox--Kit release R Approved Liquid Gas Path Cleaners Series IV only; not available Cancelled * Oil Foaming * 15 Micron Pressure Oil Filter--Kit Release * LSGI * Turbine Module Installation--Kit Release * T56LFE Engines R T56/501D Series I/II/III/IV Engine Performance Calculation Trending Software and Support Equipment Release R T56/501D Series I/II/III/IV Engine Performance-- Maintenance Ground Check Procedure * Compressor Inlet Blockage R Series II to Series III Conversion Kits Release R* T56/501D Engine Models and Applications R Rolls--Royce Parts Ordering Process New 5th and 10th Stage Bleed Gaskets Cancelled TD Amplifier P/N Recall Cancelled * Minimum Torque Calculation R* T56 Thermocouple Operation and Maintenance th Stage Turbine Blade P/N Military Surplus Alert Cancelled R Allison Repaired Combustion Liner Exchange Program * Allison Repaired 1st/2nd Stage Turbine Vane Exchange Program * Extreme Overtemperature Operation Cancelled Prior to Publication Cancelled Prior to Publication R* Pinion Bearing and Shaft Fit Limits * Prop Shaft Seal Kit (P/N ) Installation & Removal Procedures Revised November 1, 2017 PAGE 2 OF 5
4 96--01* 1st and 2nd Stage Turbine Blade Color Codes R Power Section and Reduction Gearbox Oil Pressure Limitations R Conserving Turbine Life R Improved Fuel Control Start Schedule Cage Assembly, Bearing Front Turbine, Static Seal Material R Improved, Wide--Rim Thick--Bore, 1--2 Turbine Spacer R Rub Tolerant Turbine Vanes and Spacers/IN--718 Material Vane Case R Updated CIT Correction Charts R Fuel Control Speed Piston O--Ring Seal Titanium Nitride (TiN) Coated blades Cancelled Cancelled Prior to Publication Allison Access Center Cancelled * Turbine Rear Inner Exhaust Cone Loss * Rear Turbine Bearing Support Bolt Hole Cracks; Revised Acceptance Criteria Reduction Gearbox Cracking in the Eyebolt Boss and Mounting Pad Area Anti--ice Valve Seal P/N * Water Quality for Engine Wash/Rinse Alternates for ODC/EPA--17 Chemicals * Rear Compressor Bearing P/N P/N nd Stage Turbine Vane, Step In Forward Vane Slot Alternate for Acti--Thane WC--100 Paint New Spring for use in Fuel Nozzle Assemblies Micron External Scavenge Oil Filtration Reduction Gearbox (RGB) -- Main Drive Gear Bearing Failures R P/N Turbine Inlet Case Machining Condition RGB -- Planet Journal Plugs Shipment of Fuel System Components Visual Color Change of 3rd--Stage Turbine Blade, P/N Fuel Nozzle Overhaul Procedures Removal of Rear Turbine Bearing Thermal Insulation Blanket from Turbine Assembly Revised November 1, 2017 PAGE 3 OF 5
5 New Fuel Control Assembly, P/N Improved Starting Fuel Schedule and Speed Piston O--Ring Seal Replacement Engine Split Line Shield, Install Series II 4th--Stage IN901 Turbine Wheel Rear Turbine Bearing Support Cross Key Hole / Slot Repair Fuel Nozzle Upgrade Instructions Custom 450 1st--Stage Compressor Vane Assembly, P/N Series III Turbine 1st--Stage Vane, Improved Durability Part Numbers Reissue , , , and T56--A--7B Energy Absorbing Ring (EAR) New Brackets New Improved Turbine Cooling Air Baffle ( ) For T56/501D Series II Engines T56 Compressor Vane Appearance -- Custom 450 Material P/N , 4th--Stage Turbine Blade Thermocouple Assembly P/N Approval of Metco 73FNS--2 or Metco 72F Plasma Spray as Alternate Repairs for: Vane and Seal Support Internal Diameter ( ) Inner Combustion Casing Piston Ring Grooves ( ) Series II, 2nd--Stage Turbine Vane Segments P/N s and New 5th & 10th Stage Bleed Gaskets P/N s & New Fuel Nozzle Body P/N Coniflex Style Compressor Extension Shaft And Side Gear Configuration Reduction Gearbox (RGB) Carrier Oil Delivery Flange & Sun Gear Lube Tube Assembly Rework New 1st--Stage Turbine Blade P/N Visual Differences From The Original P/N Engine -- Reduction Gearbox, Main Power Train Gears Inspection and Serviceability Series II Turbine Wheel, 4th--Stage Rework Non--Destructive Testing (NDT) Requirements for Prop Control Intermediate Link Rod Assembly & Prop Control Rear Link Assembly Micron External Scavenge Oil Filtration -- Alternate Filter Element P/N s Revised November 1, 2017 PAGE 4 OF 5
6 Replacement of Narrow Rim 1st to 2nd -- Stage Turbine Spacer Assemblies, P/N s and To Clean the Engine of Bird Residue After a Bird Strike Release of Improved 1st--Stage Turbine Blade P/N Turbine Vane Case -- Add Chamfer to Inner Vane Slots Retaining Spring (P/N ) Release Inspection Required Following Metal Generating Failures Turbine Assembly -- Turbine Wheel Inspection Reduction Gearbox Assy -- Pinion Shaftgear Inspection Micron Pressure Oil Filter -- Impending Bypass Indicator Replacement Turbine Assembly -- Turbine Spacer Inspection Use of Accident -- Incident Hardware Repair of 2nd--, 3rd--, and 4th--stage Turbine Vane Inner Diameters Jet Fuel Contaminated with Fatty Acid Methyl Ester (FAME) Reduction Gearbox Assembly-- Two--Piece Starter Drive Shaft Seal Loctite Plastic Gasket 568 (Loctite 56841) Replacement New Solid State Ignition Relay Suspect External Scavenge Oil Pump Assembly P/N Replacement External Scavenge Oil Pump Assembly Inspection for End Face Clearance of Internal Gears Inspection of 1st-- and 4th--stage Turbine Wheels every 2000 Cycles Operation and Maintenance of T56 Series IV Engines in Corrosive Environments * NOTE: This SIL contains the following notice: This SIL will be rescinded five (5) years from the original publish date. This note alone does not cancel the SIL once the SIL has reached five years from the date it was published. The SIL remains in effect until a cancellation notice is issued or the SIL index notes the SIL has been Cancelled. This SIL has been reviewed and the information it contains considered to be current. This SIL will not be revised solely to remove the five (5) year statement, however if the SIL is revised the statement will be removed. Revised November 1, 2017 PAGE 5 OF 5
Rolls-Royce Corporation T56-A-15LFE COMMERCIAL SERVICE LETTER (CSL) Technical Publications Index
Corporation T56-A-15LFE COMMERCIAL SERVICE LETTER (CSL) Technical Publications Index May 1. 2018 1501 T56--A--15LFE Engine Life Limited Parts Cancelled Ref. CSL--1545 1502 Approved Lubricants -- Engine
More informationRolls-Royce Corporation 501-D22 COMMERCIAL SERVICE LETTER (CSL) Technical Publications Index
Corporation 501-D22 COMMERCIAL SERVICE LETTER (CSL) Technical Publications Index May 1. 2018 1001 T56/501D, Series II, III, Engine Life Limited Parts 12--10--65 No. 22, 08--06--15 1002 Engine Lubricants
More informationRolls-Royce Corporation T56-A-14LFE COMMERCIAL ENGINE BULLETIN (CEB) Technical Publications Index
Corporation T56-A-14LFE COMMERCIAL ENGINE BULLETIN (CEB) Technical Publications Index November 1, 2017 72-- ENGINE 72--4001 Cancelled Prior to Publication A--72--4002 Engine -- Reduction Gear, Propeller
More informationRolls-Royce Corporation 501-D22 COMMERCIAL ENGINE BULLETIN (CEB) Technical Publications Index
Corporation 501-D22 COMMERCIAL ENGINE BULLETIN (CEB) Technical Publications Index May 1. 2018 72-- ENGINE 72--1001 Engine -- Reduction Gear Prop Recommended No Later Than 11--01--66 No. 2, 11--15--68 Brake
More informationRolls-Royce Corporation 501-D13 COMMERCIAL SERVICE LETTER (CSL) Technical Publications Index
Corporation 501-D13 COMMERCIAL SERVICE LETTER (CSL) Technical Publications Index November 1, 2017 1 Initiation of The Commercial Service Letter Cancelled Ref CSL--95 2 Model 501--D13 Turbine Damage Due
More informationRolls-Royce Corporation M250-C20R COMMERCIAL ENGINE BULLETIN (CEB) Technical Publications Index
Rolls-Royce Corporation M250-C20R COMMERCIAL ENGINE BULLETIN (CEB) Technical Publications Index January 2, 2018 72-4001 Engine Conversion, 250 -C20R/2 to 250 -C20R/1 72-4002 Prior To Publication 72-4003
More informationRolls-Royce Corporation M250-B15G COMMERCIAL SERVICE LETTER (CSL) Technical Publications Index
Rolls-Royce Corporation M250-B15G COMMERCIAL SERVICE LETTER (CSL) Technical Publications Index October 1, 2018 TP 1 M250 Authorized Maintenance Centers (AMC s), Publications, Rolls-Royce Telephone Contacts,
More informationRolls-Royce Corporation 501-D13 COMMERCIAL OVERHAUL INFORMATION LETERS (COIL) Technical Publications Index
Corporation 501-D13 COMMERCIAL OVERHAUL INFORMATION LETERS (COIL) Technical Publications Index May 1. 2018 101 Metallizing of The Compressor Air Inlet Housing Cancelled * 102 Distribution of Metallizing
More informationRolls-Royce Corporation M250-C30 COMMERCIAL ENGINE BULLETIN (CEB) Technical Publications Index
Rolls-Royce Corporation M250-C30 COMMERCIAL ENGINE BULLETIN (CEB) Technical Publications Index May 1, 2018 72-3001 Engine, Compressor No. 1 Bearing Support Indexing - Add 06-19 - 79 72-3002 Gearbox, Oil
More informationRolls-Royce Corporation M250-C20R COMMERCIAL SERVICE LETTER (CSL) Technical Publications Index
Rolls-Royce Corporation M250-C20R COMMERCIAL SERVICE LETTER (CSL) Technical Publications Index February 1, 2018 4001 M250 - Authorized Maintenance Center (AMC s), Publications, Rolls-Royce Telephone Contacts,
More informationCOMMERCIAL SERVICE BULLETIN INDEX
COMMERCIAL SERVICE BULLETIN INDEX NOTE: This Service Bulletin Index, ESD 100AL dated, 07/16/2009, supersedes ESD 100AK Index dated 12/11/2007 and incorporates Service Bulletins released to date. Changes
More informationENGINE, AIRCRAFT, GAS TURBINE MODEL T63-A-720 P/N NSN
TM 55-2840-241-23 TECHNICAL MANUAL AVIATION UNIT AND AVIATION INTERMEDIATE MAINTENANCE MANUAL ENGINE, AIRCRAFT, GAS TURBINE MODEL T63-A-720 P/N6887191 NSN 2840-01-013-1339 HEADQUARTERS, DEPARTMENT OF THE
More informationRolls-Royce Corporation M250-C18 COMMERCIAL SERVICE LETTER (CSL) Technical Publications Index
Rolls-Royce Corporation M250-C18 COMMERCIAL SERVICE LETTER (CSL) Technical Publications Index November 1, 2017 1 M250 Authorized Maintenance Center (AMC s), Publications, Rolls-Royce Telephone Contacts,
More informationRolls-Royce Corporation M250-B17 COMMERCIAL SERVICE LETTER (CSL) Technical Publications Index
Rolls-Royce Corporation M250-B17 COMMERCIAL SERVICE LETTER (CSL) Technical Publications Index October 1, 2018 TP 1001 M250 Authorized Maintenance Centers (AMC s), Publications, Rolls-Royce Telephone Contacts,
More informationRolls -Royce M250--C40B OPERATION AND MAINTENANCE. Table 603. Inspection Checksheet
Table 603 Inspection Checksheet Owner Date A/C Make/Model S/N Reg. No. TSN Engine S/N TSN TSO This inspection checksheet is to be used when performing scheduled inspections. This form can be locally reproduced
More informationRolls -Royce M250--C47M OPERATION AND MAINTENANCE
TABLE 603 Inspection Checksheet Owner Date A/C Make/Model S/N Reg No. TSN Engine S/N TSN TSO This inspection checksheet is to be used when performing scheduled inspections. This form may be locally reproduced
More informationInstructions for Continued Airworthiness Extex Replacement Parts for RR250
Instructions for Continued Extex Replacement Parts for RR250 Engine Application(s): Compliance: Notes: Revisions: A B C All Rolls Royce / Allison 250 engine models. As required. Refer to OEM s published
More informationChris Ruot. October 21, APU System Update
Chris Ruot October 21, 2014 APU System Update HONEYWELL CONFIDENTIAL: This copyrighted work and all information are the property of Honeywell International, Inc., contain trade secrets and may not, in
More informationA1-F402B-MMI February 2003 Page A
1 February 2003 Page A NUMERICAL INDEX OF EFFECTIVE WORK PACKAGES/PAGES List of Current Changes Original...0...1 February 2003 (IRACs 4 thru 8 Inc.) Only those pages assigned to the manual are listed in
More informationChromalloy. Borescope and Test Report. Prepared for. Triumph Air Repair A Triumph Group Company
A Triumph Group Company Borescope and Test Report Prepared for Chromalloy Customer P.O.#: S2669 A.P.U. Model #: GTCP331-200ER A.P.U. Serial #: P-2796 A.P.U. Part #: 3800298-1 Triumph SRO #: S000013678
More informationBorescope Inspection Report MO-S-113 Taurus 70 CED Ie H
Ie H Page 1 of 14 E Thermocouple 2 nd Stage Nozzle 2 nd Stage Blades 2 nd Stage Tip Shoe Blade Retaining Pins 3 rd Stage Nozzle 3 rd Stage Tip Shoe 3 rd Stage Blades External Variable Guide Vanes IGV 00
More informationCOMPONENT IDENTIFICATION
This CFMI publication is for Training Purpose Only. The information is accurate at the time of compilation; however, no update service will be furnished to maintain accuracy. For authorized maintenance
More informationRolls-Royce Corporation M250-C28 COMMERCIAL SERVICE LETTER (CSL) Technical Publications Index
Rolls-Royce Corporation M250-C28 COMMERCIAL SERVICE LETTER (CSL) Technical Publications Index February 1, 2019 2001 M250 - Authorized Maintenance Centers (AMC s), Publications, Rolls-Royce Telephone Contacts,
More informationAl -F402A-MMI-200 Change 2-10 April 1997 Page A
Al -F4A-MMI- - 1 April 1997 Page A NUMERICAL INDEX OF EFFECTIVE WORK PACKAGES Original.... 15 November 199 (INCL previously inc IRAC 1 and RACs through 8) RAC..... 9. 15 December 1991 RAC.. 11...... 15
More informationPiston and Connecting Rod Assembly January Removal of the Piston and Connecting Rod Assembly
1 18-13 1 1 18-13 SUBJECT DATE Piston and Connecting Rod Assembly January 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Removal of the Piston and Connecting
More informationRolls -Royce M250--C47M OPERATION AND MAINTENANCE
TABLE 603 Inspection Checksheet Owner Date A/C Make/Model S/N Reg. No. TSN Engine S/N TSN TSO This inspection checksheet is to be used when performing scheduled inspections. This form can be locally reproduced
More informationPiston and Connecting Rod Assembly August Removal of the Piston and Connecting Rod Assembly
1 8 17-13 SUBJECT DATE Piston and Connecting Rod Assembly August 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Removal of the Piston DDC-SVC-MAN-0081 DD
More informationTECHNICAL MANUAL AVIATION UNIT AND AVIATION INTERMEDIATE MAINTENANCE MANUAL ENGINE, GAS TURBINE MODEL T55-L-714 NSN
TM 1-2840-252-23--2 TECHNICAL MANUAL AVIATION UNIT AND AVIATION INTERMEDIATE MAINTENANCE MANUAL ENGINE, GAS TURBINE MODEL T55-L-714 NSN 2840-01-353-7635 DISTRIBUTION STATEMENT A: Approved for public release,
More informationRolls -Royce M250--C47B OPERATION AND MAINTENANCE TABLE 603. Inspection Checksheet. A/C Make/Model S/N Reg. No. TSN
TABLE 603 Inspection Checksheet Owner Date A/C Make/Model S/N Reg. No. TSN Engine S/N TSN TSO This inspection checksheet is to be used when performing scheduled inspections. This form can be locally reproduced
More informationRolls -Royce M250--C20R SERIES OPERATION AND MAINTENANCE
C. Alternate Inspection Schedule Based on current engine configuration and the use of modern oils, operators can use this alternate inspection schedule. Prerequisites for this include: (1) The use of High
More informationAPS 2000 Shop Findings Report
APU S/N : SP-E912042 AIRCRAFT REGISTRATION: EI-CZG APU P/N : 170101-106 CUSTOMER : Air One R/O N : 78202418 EVENT N : 1379 REVISION N : 685265 TSN : 16143 TSI : 2655 DATE OF REMOVAL: 18.04.07 CSN : 15386
More informationMINI PACK BUILD SPEC. 885 ESN: FA0278 TSN: 15, CSN: 15,815 TSO: N/A CSO: N/A TSHSI: 2, CSHSI: 2,373 RGB SN. FA0278
MINI PACK ENGINE Model: BUILD SPEC. 885 ESN: PW150A FA0278 TSN: 15,012.30 CSN: 15,815 TSO: N/A CSO: N/A TSHSI: 2,056.00 CSHSI: 2,373 RGB SN. FA0278 TSN: 15,012.30 CSN: 15,815 TSO: 3,596.40 CSO: 3,863 CONTENTS:
More informationLM2500 BORESCOPE INSPECTION REPORT
LM2500 BORESCOPE INSPECTION REPORT UC DAVIS CUSTOMER UNIT NAME/NUMBER: N/A ENGINE SERIAL NUMBER: 481-743 TCT SALES ORDER NUMBER: US9010290 DATE INSPECTED:11-29-2018 SERVICEABILITY AT DATE OF INSPECTION:
More informationPT6A & JT15D. turbine engines series FOR NEW ENGINES. Excluding hbc and cessna caravan installations
PT6A & JT15D turbine engines series Excluding hbc and cessna caravan installations enhanced warranty FOR NEW ENGINES Engine Model PT6A-135A PT6A-21 PT6A-34 PT6A-35 PT6A-42 PT6A-42A PT6A-52 PT6A-60A PT6A-61
More informationRolls-Royce Corporation M250-C30 COMMERCIAL SERVICE LETTER (CSL) Technical Publications Index
Rolls-Royce Corporation M250-C30 COMMERCIAL SERVICE LETTER (CSL) Technical Publications Index February 1, 2018 3001 M250 - Authorized Maintenance Centers (AMC s), Publications, Rolls-Royce Telephone Contacts,
More informationHydraulic Angle Grinder for Underwater Use Type
M a s c h i n e n f a b r i k G m b H Hydraulic Angle Grinder for Underwater Use Type 1 1585 0010 Illustration can differ from the original Repair Manual and Spare Parts List Compiled: 18.01.13 115850010_Inst_en_Version_03
More informationAircraft Propulsion Technology
Unit 90: Aircraft Propulsion Technology Unit code: L/601/7249 QCF level: 4 Credit value: 15 Aim This unit aims to develop learners understanding of the principles and laws of aircraft propulsion and their
More informationTECHNICAL MANUAL AVIATION UNIT AND AVIATION INTERMEDIATE MAINTENANCE MANUAL ENGINE, GAS TURBINE MODEL T55-L-714 NSN
TECHNICAL MANUAL AVIATION UNIT AND AVIATION INTERMEDIATE MAINTENANCE MANUAL ENGINE, GAS TURBINE MODEL T55-L-714 NSN 2840-01-353-7635 DISTRIBUTION STATEMENT A: Approved for public release; distribution
More informationRepair Manual and Spare Parts List
Pneumatic Drive Unit Type Techn. Doc. No. 352 and Accessories for Pipe Cutting Machine Darstellung kann vom Original abweichen Repair Manual and 580027000_Inst_en_Version_02 Repair General In general,
More informationRolls -Royce M250--B17 SERIES OPERATION AND MAINTENANCE. Table 602 Inspection Checksheet Owner Date. A/C Make/Model S/N Reg No.
Table 602 Inspection Checksheet Owner Date A/C Make/Model S/N Reg No. TSN Engine S/N TSN TSO This inspection checksheet is to be used when performing scheduled inspections. This form can be locally reproduced
More informationService Manual T30-M TURBOTWIN Air Motor
Publication T3-722 Dated: April 15, 2006 Service Manual T30-M TURBOTWIN Air Motor TDI TURBOTWIN TABLE OF CONTENTS Section Subject Page 1.0 Introduction.. 1 2.0 Description of Basic Groups.. 3 3.0 Disassembly.
More informationInspection and Repair of Compressor Wheels
Subject: Applicable EXTEX Engineered Products Part Numbers: Installations: Revision History: Reason: Description: Inspection and Repair of Compressor Wheels E23057111 (Stage 1), E23057112 (Stage 2-3),
More informationLycoming AIRCRAFT ENGINES. IO-540-AC1A5 Wide Series Flange Crankcase Model Engine PARTS CATALOG PC
AIRCRAFT ENGINES IO-540-ACA5 Wide Series Flange Crankcase Model Engine PARTS CATALOG PC-5- November 008 Lycoming 5 Oliver Street Williamsport, PA 770 U.S.A. 570/33-8 IO-540-ACA5 PARTS CATALOG This illustrated
More information13A2693G190 LT-165 (2003) Page 1 of 31 Carburetor
13A2693G190 LT-165 (2003) Page 1 of 31 Carburetor 13A2693G190 LT-165 (2003) Page 2 of 31 Carburetor TC-640330 1 S Carburetor (Incl 184 of Engine Parts Lists) 1 TC-640035 1 Throttle Shaft & Lever Assembly
More informationO-540-A4B5 PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINES
INTRODUCTION This illustrated parts catalog contains a complete parts listing for the Lycoming O-540-A4B5 wide cylinder flange crankcase model aircraft engines. Major assembly and sub-assembly parts of
More informationTYPE-CERTIFICATE DATA SHEET
C28 series TYPE-CERTIFICATE DATA SHEET No. IM.E.109 for C28 series engines (see Note 1) Type Certificate Holder Rolls-Royce Corporation 450 South Meridian Street Indianapolis, Indiana 46225-1103 USA For
More informationRepair Manual and Spare Parts List
Hydraulic Drive Unit Type Techn. Doc. No. 362 and Accessories for Pipe Cutting Machine Darstellung kann vom Original abweichen Repair Manual and 580067000_Inst_en_Version_03 Repair General In general,
More informationTEXTRON Lycoming AIRCRAFT ENGINES
TEXTRON Lycoming AIRCRAFT ENGINES O-60-AP Wide Cylinder Flange Crankcase Model Engines PARTS CATALOG PC-06-6 MARCH 99 0-60-AP PARTS CATALOG This illustrated parts catalog contains a complete parts listing
More informationCFM56-7B ENGINE CAPABILITIES LIST
WGI Inc. d/b/a Westfield Gage Co Overhaul and Repair 34 Hudson Dr Southwick, MA 01077 Phone: 413-569-9444 Fax: 413-569-9369 FAA/EASA/CAAC Repair Station WNFR711K PART NUMBER E.M. SECTION REP. # REPAIR
More informationinformative only "Hawker" name change No Action Required informative of SB Publication numbering system change No Action Required
Page 1 Category: Airframe Manufacturer: Raytheon Aircraft Co. Model: MU-300 00-2001 R6 5/1/2007 Service Bulletin - General-Hawker Beechcraft Publications-What Is Available And How To Obtain It informative
More information955L Traxcavator S/n 64J, 71J & 85J Volume 1 of 2
Caterpillar Service Manual 955L Traxcavator S/n 64J, 71J & 85J Volume 1 of 2 Service Manual THIS IS A MANUAL PRODUCED BY JENSALES INC. WITHOUT THE AUTHORIZATION OF CATERPILLAR OR IT S SUCCESSORS. CATERPILLAR
More informationContents. Index. Content
s MS motor - Range... 2 MS motor - Torque module... 3 MS motor - Valving cover... 4 MS motor - Multidisc brake... 5 MS motor - Bearing support... 6 MS motor - Drum brake... 7 Forklift truck drive axle...
More informationLycoming Aircraft Engines Parts Catalog
Aircraft Engines Parts Catalog IO-0-BG Wide Cylinder Flange Crankcase Model Engine Part No. PC-0- Oliver Street Williamsport, PA 770 Aircraft Engines Parts Catalog IO-0-BG Wide Cylinder Flange Crankcase
More informationD9 & D9G Crawler S/n 66A1 to 66A3265
Caterpillar Service Manual D9 & D9G Crawler S/n 66A to 66A65 Service Manual THIS IS A MANUAL PRODUCED BY JENSALES INC. WITHOUT THE AUTHORIZATION OF CATERPILLAR OR IT S SUCCESSORS. CATERPILLAR AND IT S
More informationTCDS NUMBER E00078NE U.S. DEPARTMENT OF TRANSPORTATION REVISION: 3 DATE: April 12, 2011
TCDS NUMBER E00078NE U.S. DEPARTMENT OF TRANSPORTATION REVISION: 3 DATE: April 12, 2011 FEDERAL AVIATION ADMINISTRATION GENERAL ELECTRIC COMPANY MODELS: TYPE CERTIFICATE DATA SHEET E00078NE GEnx-1B54 GEnx-1B58
More informationEuropean Aviation Safety Agency
European Aviation Safety Agency EASA TYPE-CERTIFICATE DATA SHEET Number : IM.E.016 Issue : 07 Date : 21 May 2014 Type : Williams International Co. FJ44 Series Engines s FJ44-1A FJ44-1AP FJ44-2A FJ44-2C
More informationEuropean Aviation Safety Agency
European Aviation Safety Agency EASA TYPE-CERTIFICATE DATA SHEET Number : E.036 Issue : 04 Date : 10 September 2013 Type : Rolls-Royce plc Trent 1000 series engines Models Trent 1000-A Trent 1000-A2 Trent
More informationASSEMBLY. Transmission Automatic Transaxle/Transmission. Special Tool(s) Alignment Set, Fluid Pump 307-S039 (T74P X) Special Tool(s)
307-01-1 Automatic Transaxle/Transmission 307-01-1 ASSEMBLY Transmission Special Tool(s) Adjustment Set, Transmission Band 307-S022 (T71P-77370-A) Special Tool(s) Alignment Set, Fluid Pump 307-S039 (T74P-77103-X)
More information951B Traxcavator S/n 79H, 32F, 69H & 86J Volume 1 of 2
Caterpillar Service Manual 91B Traxcavator S/n 79H, 2F, 9H & 8J Volume 1 of 2 Service Manual THIS IS A MANUAL PRODUCED BY JENSALES INC. WITHOUT THE AUTHORIZATION OF CATERPILLAR OR IT S SUCCESSORS. CATERPILLAR
More informationO-540-F1B5 SERIES PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINES
INTRODUCTION This illustrated parts catalog contains a complete parts listing for the Lycoming O-540-F1B5 series wide cylinder flange crankcase model aircraft engines. Major assembly and sub-assembly parts
More information4.2 WATER PUMP (GEAR CASE MOUNTED AND LATER) (GCM)
SERIES 60 SERVICE MANUAL 4.2 WATER PUMP (GEAR CASE MOUNTED - 1991 AND LATER) (GCM) The centrifugal-type water pump circulates the engine coolant through the cooling system. The pump is mounted on the rear
More informationDGCANO SUBJECT REFERENCE COMPLIANCE APPLICABILITY TURBINE (IPT) AND INTERMEDIATE PRESSURE COMPRESSOR (IPC) SHAFT SPLINE FLANK WEAR
DGCA/RR RB 211-TRENT 700/800 SERIES/01 DGCA/RR RB 211-TRENT 700/800 SERIES/02 DGCA/RR RB 211-TRENT 700/800 SERIES/03 TO PREVENT THRUST REVERSER HINGE FAILURE TO PREVENT INTERMEDIATE PRESSURE TURBINE (IPT)
More informationCountry Customer Name Site Name USA Specific Reports Task Risk Assessment CSA/Invoice/Work Order Numbers Borescope Inspection YES N/A.
Country Customer Name Site Name US Specific Reports Task Risk ssessment CS/Invoice/Work Order Numbers orescope Inspection YES N/ orescope Completed y Package S/N Hours Starts S/N orescope Date PD Number
More informationLycoming Aircraft Engines Parts Catalog
Aircraft Engines Parts Catalog TIO/LTIO-540-V2AD Wide Cylinder Flange Model Part No. PC-35-2 652 Oliver Street Williamsport, PA 770 Aircraft Engines Parts Catalog TIO/LTIO-540-V2AD Wide Cylinder Flange
More informationMINI PACK N/A N/A N/A N/A FA0995 N/A
MINI PACK ENGINE MODEL: PW150 BUILD SPEC: 885 TM SN: FA0995 TSN: 4,327.60 CSN: 4,194 TSO: CSO: TSHSI: CSHSI: N/A N/A N/A N/A RGB SN: FA0995 TSN: 4,327.60 CSN: 5,194 TSO: N/A CSO: N/A CONTENTS: - TMM Transport
More informationPublication T5-703, Rev. 2 Dated: July 31, 2009 SERVICE MANUAL. T50-P TURBOTWIN Engine Air Starter AN
Publication T5-703, Rev. 2 Dated: July 31, 2009 SERVICE MANUAL T50-P TURBOTWIN Engine Air Starter AN 99-447 TABLE OF CONTENTS Section Subject Page 1.0 Introduction. 1 2.0 Description of Basic Groups. 3
More informationAirworthiness Directive Schedule
Airworthiness Directive Schedule Engines 24 November 2016 Notes 1. This AD schedule is applicable to Pratt & Whitney PT6 series engines manufactured under Transport Canada Type Certificate (TC) Numbers:
More informationASSEMBLY. Transmission Automatic Transmission 5R44E and 5R55E. Special Tool(s)
307-01-1 Automatic Transmission 5R44E and 5R55E 307-01-1 ASSEMBLY Transmission Special Tool(s) Holding Fixture, Transmission 307-262 (T93T-77002-AH) Special Tool(s) Installer, Transmission Extension Housing
More informationKatanga Mercedes 1017A Trucks, DRC
Katanga Mercedes 1017A Trucks, DRC Mercedes Benz Model 1017A Chassis N 380 113 ( 14 780087-15 2 23059 ) Engine N 353 975 10 ( 549882-999999 ) Manufactured year 1979-1990 Item Part Number Description unit
More informationEuropean Aviation Safety Agency
European Aviation Safety Agency EASA TYPE-CERTIFICATE DATA SHEET Number : IM.E.020 Issue : 1 Date : 08 June 2005 Type : Pratt and Whitney PW6000 series engines Variants PW6122A PW6124A List of effective
More informationWARNING DYNABRADE. Air Powered Abrasive Belt Machine
For Serial No.9I1001 and Higher Parts Page Reorder No. PD00 50 Effective June, 2000 Supercedes PD96 16 66402 Tool Post Grinder Instruction Manual Air Powered Abrasive Belt Machine! WARNING Always operate,
More informationRolls -Royce M250--C20R SERIES OPERATION AND MAINTENANCE. Table 602 Scheduled Inspections. Inspection Checksheet. A/C Make/Model S/N Reg. No.
Table 602 Scheduled Inspections Inspection Checksheet Owner Date A/C Make/Model S/N Reg. No. TSN Engine S/N TSN TSO This inspection checksheet is to be used when performing scheduled inspections. This
More informationLycoming Aircraft Engines Parts Catalog
Aircraft Engines Parts Catalog TIO-540 Series Standard Cylinder Flange Crankcase Models Part No. PC-35-6 652 Oliver Street Williamsport, PA 770 Reciprocating Engine Division/ Subsidiary of Textron Inc.
More information3304 Engine S/n 43V, 46V, 48V, 78P, 9Z, 7Z & 12Z
Caterpillar Service Manual 3304 Engine S/n 43V, 46V, 48V, 78P, 9Z, 7Z & 12Z Service Manual THIS IS A MANUAL PRODUCED BY JENSALES INC. WITHOUT THE AUTHORIZATION OF CATERPILLAR OR IT S SUCCESSORS. CATERPILLAR
More informationTM &P TECHNICAL MANUAL
TM 5-3895-355-14&P TECHNICAL MANUAL OPERATOR'S, ORGANIZATIONAL, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL (INCLUDING REPAIR PARTS INFORMATION AND SUPPLEMENTAL MAINTENANCE AND REPAIR PARTS INSTRUCTIONS)
More informationREPAIR PROCEDURES MANUAL
REPAIR PROCEDURES MANUAL PVX Series Vane Pumps A Design Series Step-by-Step Guide to Troubleshooting and Repairing PVX Series Vane Pumps Introduction Thank you for choosing Continental Hydraulics PVX Vane
More informationTechnician Turbocharger Guide for the L Power Stroke Engine
Technician Turbocharger Guide for the 2003.25 6.0L Power Stroke Engine Vanes VGT Actuator Piston Turbine Wheel Shaft Seal Compressor Wheel VGT Control Valve TURBOCHARGER DESCRIPTION AND BASIC OPERATION
More informationSystems Operation, Testing and Adjusting
Systems Operation, Testing and Adjusting 3176C and 3196 Engines for Caterpillar Built Machines S/N: 4SS00001-UP (Excavators 345B) S/N: 7ZR01004 (ENGINE) Use the bookmarks for navigation inside of the manual
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: October 2012 SUBJECT: REFERENCES TO THE TURBOCHARGER PURGE ROUTINE
NUMBER: 10 01 12 S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: October 2012 SUBJECT: REFERENCES TO THE TURBOCHARGER PURGE ROUTINE ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform
More informationEuropean Aviation Safety Agency
European Aviation Safety Agency EASA TYPE CERTIFICATE DATA SHEET Number: IM.E.021 Issue: 05 Date: 03 January 2013 Type: General Electric Company CF34-10E Series Engines Variants CF34-10E2A1 CF34-10E5 CF34-10E5A1
More informationINSTALLATION AND OPERATING MANUAL
Dated: May 10, 2001 INSTALLATION AND OPERATING MANUAL MODEL: T30-Y TURBOTWIN Engine Air Starter From Tech Development Inc AN96-425 6800 Poe Ave. Dayton OH 45414 Tel: (937) 898-9600 Fax: (937) 898-8431
More information2018 Capabilities International Blvd Cincinnati, OH Phone: (513) Fax: (513)
Aviation Repair & Overhaul FAA Certificate CL1R064K EASA Certificate 145.4358 CAAC Certificate F00100499 2018 Capabilities 9970 International Blvd Cincinnati, OH 45246-4898 Phone: (513) 870-6780 Fax: (513)
More informationGroup 1: Gearbox housing
1 Five-Speed gearbox crown wheel 11 Nylon socket for speed- 21 Screw 31 Tube 2 Plug 12 Cup 22 Screw 32 Deflector 3 Gearbox and clutch housing 13 Pinion f. speedometer 23 Screw 33 s 4 Front cover 14 Stop
More informationLYCOMING A Textron Company
LYCOMING AEIO-360-HB PARTS CATALOG This illustrated parts catalog contains a complete parts listing for the Lycoming AEIO-360-HB wide cylinder flange crankcase model aircraft engines. Major assembly and
More information900, 910, 1100 & 1110
Long Service Manual 900, 910, 1100 & 1110 Service Manual THIS IS A MANUAL PRODUCED BY JENSALES INC. WITHOUT THE AUTHORIZATION OF LONG OR IT S SUCCESSORS. LONG AND IT S SUCCESSORS ARE NOT RESPONSIBLE FOR
More informationPage 1 of 9 303-01C Engine 6.0L Diesel 2004 F-Super Duty 250-550/Excursion DESCRIPTION AND OPERATION Procedure revision date: 08/06/2003 Engine Printable View Engine Description The 6.0L diesel engine
More informationAutomatic Transmission Basics
Section 1 Automatic Transmission Basics Lesson Objectives 1. Describe the function of the torque converter. 2. Identify the three major components of the torque converter that contribute to the multiplication
More informationINTAKE/EXHAUST SYSTEM 7 C TURBOCHARGER
INTAKE/EXHAUST SYSTEM 7 C TURBOCHARGER Table Of Contents Page Identification.................................. 7C-1 Torque Specifications.......................... 7C-1 Sealants.....................................
More informationUNIVERSAL PUMP HANGER INSTALLATION INSTRUCTIONS
UNIVERSAL PUMP HANGER INSTALLATION INSTRUCTIONS WARNING! THESE INSTRUCTIONS MUST BE READ AND FULLY UNDERSTOOD BEFORE BEGINNING INSTALLATION. FAILURE TO FOLLOW THESE INSTRUCTIONS MAY RESULT IN POOR PERFORMANCE,
More informationGuardian Packing Rings. Vortex Shedder Seals. Turbine Components. Custom Installation. Reverse Engineering
Guardian Packing Rings Vortex Shedder Seals Turbine Components Custom Installation Reverse Engineering ADVANCED SEALING SYSTEM by Turbo Parts, LLC. Guardian Packing Rings Prevent Seal Damage While Maintaining
More information396 Series - General Parts
MTU - Product Code 31-48 - 51 396 Series - General Parts Item Description Product_ Code On Hand Qty 0000535858 VALVE STEM SEAL 31 105 0165314283 BAYONET COUPLING 31 2 0165313783 BAYONET COUPLING 31 4 0165310683
More informationTYPE-CERTIFICATE DATA SHEET
TYPE-CERTIFICATE DATA SHEET No. EASA E.047 for RB211 Trent 800 series engines Type Certificate Holder 62 Buckingham Gate Westminster London SW1E 6AT United Kingdom For Models: RB211 Trent 895-17 RB211
More informationTYPE-CERTIFICATE DATA SHEET
TYPE-CERTIFICATE DATA SHEET No. IM.E.093 for PW1100G-JM Series Engines Type Certificate Holder 400 Main Street East Hartford, CT 06118 United States of America For Models: PW1133G-JM PW1133GA-JM PW1130G-JM
More informationTOP AND CONSOLE PARTS For Models: YWED9400SW1, YWED9400SZ1, YWED9400SU1 (White/Chrome) (White/Blue) (Ultimate Silver)
TOP AND CONSOLE PARTS ELECTRIC DRYER 3 08 Litho in U.S.A. (L.T.) 1 Part No. Rev. A TOP AND CONSOLE PARTS 1 Literature Parts W10151591 Use & Care Guide W10177461 Tech Sheet W10111226 Guide, Quick Start
More information4 Stroke Diesel. Oil type SAE 15 W40/E 3
MARCH 2006 TECHNICAL DATA 2.33 GENERAL SPECIFICATIONS Cycle Air supply Injection 4 Stroke Diesel naturally aspirated direct Number of cylinders 4 in line 6 in line Bore mm 104 Stroke mm 132 Total displacement
More informationBLACKMER PISTON AIR VALVE SAFETY DATA. For Piston Air Valve Style AVC and Discontinued Style AVB TABLE OF CONTENTS SAFETY DATA...
BLACKMER PISTON AIR VALVE 960333 INSTALLATION OPERATION AND MAINTENANCE INSTRUCTIONS WITH PARTS LIST For Piston Air Valve Style AVC and Discontinued Style AVB Page 1 of 8 Section Effective Replaces INSTRUCTIONS
More informationTYPE-CERTIFICATE DATA SHEET
TYPE-CERTIFICATE DATA SHEET No. E. 103 Issue 2 for ARDIDEN 3 series engines Type Certificate Holder Avenue Joseph Szydlowski 64510 Bordes France For Models: ARDIDEN 3G ARDIDEN 3C TE.CERT.00052-001 European
More informationTHOMSON AIRWAYS LIMITED DISCREPANCY SHEET
IPC REF FIG ITEM DESCRIPTION FROM 72.35.01 01 085/220 ROTATING FAIRINGS 72.31.11 01 280 LP BLADES (22 OFF) 73.11.07 01 645/725 MAIN FUEL INLET TUBE 29.11.03 02 100 HYD. SUPPLY,RIGID TUBE 29.11.03 02 200
More informationHKS 700E. Service Manual June Ver. 2.04
HKS 700E Service Manual 009 June Ver..04 HKS CO.,LTD 78 KITAYAMA FUJINOMIYA SHIZUOKA JAPAN 48-09 TEL +8(0)544-54-78 FAX +8(0)544-54-40 hks_aviation@hks-power.co.jp http://www.hks-power.co.jp/hks_aviation/
More informationMODEL: 310A and 3108 Tractor, Loader and Backhoe Volume 1 of 2
John Deere MODEL: 310A and 3108 Tractor, Loader and Backhoe Volume 1 of 2 THIS IS A MANUAL PRODUCED BY JENSALES INC. WITHOUT THE AUTHORIZATION OF JOHN DEERE OR IT'S SUCCESSORS. JOHN DEERE AND IT'S SUCCESSORS
More information