KIA MOTORS K2700 (4 4) AMBULANCE AMBULANCE PARTS CATALOG

Size: px

Start display at page:

Download "KIA MOTORS K2700 (4 4) AMBULANCE AMBULANCE PARTS CATALOG"

Alaina Morgan
5 years ago
Views:

1 KIA MOTORS K2700 (4 4) AMBULANCE AMBULANCE PARTS CATALOG

2 KIA MOTORS K2700 AMBULANCE PICTORIAL INDEX

4 REAR-AIR CONDITIONER

5 REAR-AIR CONDITIONER NO PARTS NAME PART NO Q'ty DESCRIPTION 1 EVAP. CORE ASSY FRONT 2 THERMOSTAT EXPENSION V/A FRONT 4 COND & FAN SHROUD ASSY-MAIN WD 5 COMPRESSOR ASSY BKT-COMP.W/IDLE PULLEY WD 7 RECEIVER DRYER REAR COOLER ASSY DRAIN HOSE-REAR HOSE ASSY-SUC.JOINT,RW,4WD WD 11 HOSE ASSY-LIQ.RW WD 12 HOSE ASSY-SUC,REAR,4WD WD 13 HOSE ASSY-DIS.RW,4WD WD 14 HOSE ASSY-LIQ.M/COND-S/COND, WD 15 HOSE ASSY-LIQ.REAR WAY JOINT-LIQ PE-CVER,LH PE-CVER,RH

6 AMBULANCE LIGHT PARTS

7 AMBULANCE LIGHT PARTS NO PARTS NAME PART NO Q'ty DESCRIPTION 1 LED WORK LIGHT (SIDE,LH/RH) LED WORK LIGHT (BACK,LH/RH) LED WARNING LIGHT (SIDE,LH/RH) LED WARNING LIGHT (BACK,LH/RH) ROOM LAMP MOVING LIGHT DOOR LAMP (ON/OFF) REAR ASSY COMBINATION LAMP,LH E REAR ASSY COMBINATION LAMP,RH E100 1

8 AMBULANCE MAIN PARTS

9 AMBULANCE MAIN PARTS NO PARTS NAME PART NO Q'ty DESCRIPTION 1 STRETCHER BENCH SEAT (BED) ASSISTANT SEAT (FOLDING TYPE) REAR AIR CONDITIONER ASSY ROOF VENTILATOR-AUTO

10 INSTRUMENT CABINET IN ITEMS 9

11 INSTRUMENT CABINET IN ITEMS NO PARTS NAME PART NO Q'ty DESCRIPTION 1 OXYGEN TANK (10.2l) OXYGEN OUTLET MAIN SWITH ELECTRIC POWER BOARD MOVING LIGHT TRANSFUSION HANGER FOLDING EMERGENCH STRETCHER CIRCUIT BOARD AC-INVERTER MEDICAL INSTRUMENT CABINET CABINET ASSY

13 WARNING SIGNAL LIGHT CONTROLLER & AMP,MIC

14 WARNING SIGNAL LIGHT CONTROLLER & AMP,MIC NO PARTS NAME PART NO Q'ty DESCRIPTION 1 AMPLIFIER SWITH - ON/OFF ASSY 2 WARNING SWITH - ON/OFF FLASH SWITH - WORK LIGHT VOLUME MICROPHONE - ON/OFF YELP WAIL HI-LO FUSE

15 AMBULANCE CONTROL PANEL CIRCUIT DIAGRAM 50A Main Relay T Inverter 100V~220V Heater S/W LED Pilot Lamp 110V Earth Leakage Breaker 220V Earth Leakage Breaker Heater Motor Ventilaot S/W Ventilaot Move Lamp S/W LED Pilot Lamp LED Pilot Lamp LH Room Lamp S/W LH Room Lamp LED Pilot Lamp RH Room Lamp S/W RH Room Lamp LED Pilot Lamp pilot lamp Cigarette Contact Door Lamp Door S/W

16 KIA K2700 AMBULANCE INSTRUCTION MANUAL for main equipments Read this manual before you operate the Main Equipments

17 LED Warning Light Your Ambulance At-A-Glance (1) Front View LED Warning Light LED Working Light Rear View License Plate Lamp Left Side Fuel Tank-Intake Right Side Spare Tire Release Hole

18 Your Ambulance At-A-Glance (2) Aux. & Emergency Stretcher Medical Instrument Cabinet Main Switch & Elec. Power Board Transfusion Hanger Moving Light Oxygen Outlet A/C Inverter Assistant Seat Main Stretcher Oxygen Tank & Flow Meter Medical Instrument Cabinet Room Lamp "A" Type Air-Con Outlet Assistant Seat Aux. & Emergency Stretcher 3-Seater Bench with cabinet below side Main Stretcher Fire Extinguisher

Your Ambulance At-A-Glance(3) "B" Type Room Lamp Door Lamp Air-Con Outlet Moving Light Air Intake Air Intake Entrance Door(RH) See-Through Window Medical Instrument

19 Your Ambulance At-A-Glance(3) "B" Type Room Lamp Door Lamp Air-Con Outlet Moving Light Air Intake Air Intake Entrance Door(RH) See-Through Window Medical Instrument Cabinet Warning Signal Light Controler-AMP & MIC MIC & Hanger Assistant Seat Roof Ventilator Transfusion Hanger Side Entrance Door(RH) & Steps Rear Entrance Door & Step

20 Instruction for Main Equipments 1. Warning Signal Light Controler - AMP & MIC 1 AMP On - Off Switch (AMP : Amplifier) When the switch is on, the indication lamp 11 is on, and then the AMP starts operating. 2 Warning Lamp Switch When the switch is on, the indication lamp 12 is on, and at the same time, the Warning Lamp outside of the vehicle is flickering on and off. 3 Working Lamp Switch When the switch is on, the Working Lamp outside of the vehicle is on. 4 Volume Control Knob If the knob is turned to the right, it increases the volume and left, decreases the volume. 5 MIC Button (MIC : Microphone) When the button is pressed, the MIC begins to operate.

Instruction for Main Equipments 13 10 Fuse 6 YELP Button When the Button is pressed, the Police Siren is repeating in a loud-sound and low-sound.

21 Instruction for Main Equipments Fuse 6 YELP Button When the Button is pressed, the Police Siren is repeating in a loud-sound and low-sound. 7 WAIL Button When the Button is pressed, the Fire Siren is repeating in a loud-sound and low-sound. 8 HI - LO Sound Button When the Button is pressed, the Rescue Siren is repeating in a loud-sound and low-sound. 9 FUSE If the AMP is not operating, check the fuse and replace it after opening this cap.

Instruction for Main Equipments 2. Main Switch & Electric Power Board 1 2 3 4 5 1 9 8 7 6 1 ROOM LAMP Switch (LEFT) & 2 ROOM LAMP Switch (RIGHT) When the switch is on, the Room Lamp Light comes on.

22 Instruction for Main Equipments 2. Main Switch & Electric Power Board ROOM LAMP Switch (LEFT) & 2 ROOM LAMP Switch (RIGHT) When the switch is on, the Room Lamp Light comes on. 3 MOVING LAMP Switch When the switch is on, the Moving Lamp light comes on. 4 VENTILATOR Switch * EXT : In this position, the air inside the room is exhausted to outside. * CIR : In this position, the air inside the room is circulating continuously. * STOP : The Ventilator stops operating. * VENT : The Ventilator Fan is opened for natural air circulation inside & outside. * SUC : The Ventilator starts sucking fresh air from outside. 5 AC INVERTER On-Off Switch This Button converts DC12V to AC110, AC HEATER Switch * OFF : Heater Fan Motor stops operating. * Position "I" :Low Speed * Position "II" :Medium Speed * Position "III" :High Speed 7 AC 220V POWER OUTLET 8 DC 12V POWER OUTLET 9 AC 220V POWER OUTLET 10 AC 110V POWER OUTLET

23 Instruction for Main Equipments Photo Views of Main Stretcher

Instruction for Main Equipments 3. Main Stretcher for Patients Head Foot For Your Reference. * Be sure to fully read and understand following instructions before using this product.

24 Instruction for Main Equipments 3. Main Stretcher for Patients Head Foot For Your Reference. * Be sure to fully read and understand following instructions before using this product. * This product is usable in only 2 forms, i.e., vertically stretched state and horizontal state stretched on the ground and or floor. * When erecting this product in stretch, the length of stretcher may be reduced by erecting back frame and folding the upper frame downwards. * Be sure to use this product with safety belt. * In an unusual situation or loading excessive weight, it requirs additional persons/assistants to ensure safety and convenience.

Instruction for Main Equipments Information for the Function & Caution of the Main Parts. 1. Guide Handle When lifted vertically, it will be locked automatically.

* CAUTION : Do not shake the handle excessively right and left, or it may be damaged. 2.

If the required angle is acquired, unfasten the grip and lower it until locking device operates. Be sure to grip by hands until adjusting handle is safely locked and weight is positively supported.

25 Instruction for Main Equipments Information for the Function & Caution of the Main Parts. 1. Guide Handle When lifted vertically, it will be locked automatically. When a patient is on the stretcher, it must be lifted upwards without fail. If locking in 1 position is pulled, it will be opened downwards. * CAUTION : Do not shake the handle excessively right and left, or it may be damaged. 2. Adjusting the Back Frame To adjust the Back Frame, grip frame 1 by one hand and adjusting handle 2 by the other hand. If the required angle is acquired, unfasten the grip and lower it until locking device operates. Be sure to grip by hands until adjusting handle is safely locked and weight is positively supported. * CAUTION : Be sure to lift and lower the Back Frame slowly and to grip it by hands until it is completely locked. 3. Safety Device Safe locking device system is used when putting the stretcher inside. If taking it outside, lower supporter(leg) is stretched and front/rear supporters are firmly fixed. * CAUTION : Be sure to pull <Unlocking> forward only when putting stretcher inside the vehicle. If leg is stretched after taking the stretcher out of the vehicle, push to the position of <Locking>. Arrow Mark 4. Vehicle Supporter (Leg) Rack Vehicle Supportet (Leg) Rack 1 is fixing device that ensures easy transportation in the place where the stretcher cannot be moved or when ascending the stairs. "A" Type "B" Type

Instruction for Main Equipments 5. Locking Device Installed inside the vehicle, the Locking Device prevents the stretcher from moving right and left when the vehicle is running.

Operating Main Stretcher Don't move it without nurse or assistant. When transporting a patient, guide handle must be lifted and firmly fixed.

* CAUTION : When main stretcher is moving forward, safety device must be in < Locking >. Head Side 2.

26 Instruction for Main Equipments 5. Locking Device Installed inside the vehicle, the Locking Device prevents the stretcher from moving right and left when the vehicle is running. * CAUTION : Be sure to lift and lower the stretcher after adjusting the safety device by arrow mark of < Unlocking > and < Locking >. How To Use The Stretcher. "A" Type "B" Type 1. Operating Main Stretcher Don't move it without nurse or assistant. When transporting a patient, guide handle must be lifted and firmly fixed. Besides, the side where head is placed must be at the front when moving. If high obstacle(doorsill) is encountered, push the front wheel or lift it over the obstacle. * CAUTION : When main stretcher is moving forward, safety device must be in < Locking >. Head Side 2. Folding and Unfolding Main Stretcher In some cases, it is required to fold and unfold the stretcher even when a patient is on it. Be sure to inform the patient a condition of the stretcher(i.e, folded or unfolded) before moving. To fold the stretcher, the assistants must grip the frame at each end in opposite side and lift the stretcher until wheel is raised from the floor. The assistant at foot side need to firmly grip left and right adjusting handle and lower both ends forward. Then, the stretcher is firmly folded. * CAUTION : To unfold the stretcher, the assistants must grip the frame at each end in opposite side and slowly lift the stretcher until the leg(supporter) is completely stretched.

27 Instruction for Main Equipments 3. Putting the Stretcher Inside the Vehicle To put the stretcher inside the vehicle, push it toward the vehicle and put both of front wheels on the floor of the vehicle. Move the stretcher until it contacts bumper and pull the safety device upto < Unlocking > position according to the arrow mark. Then, gripping the each corner of upper frame by hands ( palm should be upwards ), push adjusting handle in the position of left and right. And then, front axis supporter is folded upto the stretcher moving inside the vehicle. * CAUTION ; After putting the stretcher inside the vehicle, be sure to fix the locking device at < Locking >. Foot Side Head Side 4. Taking The Stretcher Outside The Vehicle To take the stretcher outside the vehicle, grip each corner of the upper frame and pull the stretcher outside until supporter ( Leg) is fully stretched. Furthermore, to ensure the safety of supporter, push the safety device to < Locking > according to the arrow mark until it is fixed. * CAUTION ; Be sure to put the stretcher on the ground after confirming the front and rear legs are completely stretched. Foot Side

Instruction for Main Equipments 4. Oxygen Supply System 1.

Oxygen Valve When the Valve is turned to the left, the Oxygen Tank is opened and turned to the right, it is closed. 2.

Oxygen Outlet Adapter Humidifying Bottle is connected to this Adapter. 4.

28 Instruction for Main Equipments 4. Oxygen Supply System 1. General Specification Name & Function of Main Parts 1. Oxygen Valve When the Valve is turned to the left, the Oxygen Tank is opened and turned to the right, it is closed. 2. Oxygen Flowmeter It indicates the volume of Oxygen inside the tank. 3. Oxygen Outlet Adapter Humidifying Bottle is connected to this Adapter. 4. Humifying Bottle Fill up 150cc ~ 200cc of distilled watter in the Bottle before use. 5. Regulator Valve When you open the Valve, adjust Moving Ball in position of 3 ~ Oxygen Tank The capacity of Oxygen Tank is 10.2 liter. When the Tank is replaced, separate the Valve from the Tank with a Tool Wrench which is hanged up at the side wall. 7. Tool Wrench

29 Instruction for Main Equipments How To Operate the Oxygen Outlet. (1) Open the Cap of the humidifying bottle and fill up the distilled water upto the level marked on the surface of the bottle. (2) Close the humidifying bottle cap, and connect exactly the humidifying bottle to flowmeter, and then fasten it tightly clockwise. (3) Open the Oxygen Tank Valve. (4) Check the volume of the Oxygen in the tank when the pressure is increasing. (5) Slowly turn the flowmeter control valve to the left and control the figures of the required flowing volume. (6) After passing through the distilled water inside the humidifying bottle, the oxygen containing moisture is supplying. (7) Close the valve of the oxygen tank right after transportation of the paient. (8) Separate the humidifying bottle from the oxygen outlet adapter. (9) Dry the humidifying bottle cleanly, and then keep it in the dry place. * CAUTION ; Be careful to control the oxygen supply to the paient of which pressure is not too high.

30 KIA MOTORS K2700 (4WD) 1TON AMBULANCE

31 KIA MOTORS K2700 (4WD) 1TON AMBULANCE

32 KIA MOTORS K2700 (4WD) 1TON AMBULANCE

33 KIA MOTORS K2700 (4WD) 1TON AMBULANCE - "B" Type 1 Stretcher

34 KIA MOTORS K2700 (4WD) 1TON AMBULANCE - "B" Type 1 Stretcher PATIENT ROOM MEDICAL CABINET BENCH(BED) OXYGEN SUPPLY SYSTEM A/Con System CABINET

35 KIA MOTORS K2700 (4WD) 1TON AMBULANCE - "B" Type 1 Stretcher ASSIATANT SEAT OXYGEN TANK OXYGEN OUTLET (FOLDING TYPE) MAIN SWITCH & ELECTRIC POWER BOARD INVERTER AMPLIFIER & MICROPHONE

36 KIA MOTORS K2700 (4WD) 1TON AMBULANCE - "B" Type 1 Stretcher MAIN STRETCHER FOLDING EMERGENCY STRETCHER ROOM LAMP ROOF VENTILATOR TRANSFUSION HANGER Moving Light

37 KIA MOTORS K2700 (4WD) 1TON AMBULANCE - "B" Type 1 Stretcher OXYGEN TUBE MASK FIRST AID KIT FIRE EXTINGUISHER WRINING LIGHT (LED) SQUARE ILLUMINATOR LIGHT REAR STEP

38 KIA MOTORS K2700 (4WD) 1TON AMBULANCE - "A" Type 4 Stretcher

39 KIA MOTORS K2700 (4WD) 1TON AMBULANCE - "A" Type 4 Stretcher

AMBULANCE on TOYOTA LAND CRUISER 78 H/T AC DSL

AMBULANCE on TOYOTA LAND CRUISER 78 H/T AC DSL Type Model Code Engine Transmission Fuel Tank Capacity Suspension Brakes Tires/Wheels Dimensions (Approx.) Wheelbase Seats Special Features : Wagon : HZJ78L-RJMRSV