JAH03SY FITTING INSTRUCTIONS VT, VX AND VU HOLDEN COMMODORE ARC BAR VEHICLE FRONTAL PROTECTION SYSTEM (VFPS) FOR AIR BAG & ADR COMPLIANT VEHICLES
|
|
- Malcolm Bryan
- 5 years ago
- Views:
Transcription
1 JAH03SY FITTING INSTRUCTINS REPLACES: REVISED: VT, VX AND VU HLDEN CMMDRE ARC BAR VEHICLE FRNTAL PRTECTIN SYSTEM (VFPS) FR AIR BAG & ADR CMPLIANT VEHICLES Check installation hardware before commencing. 1. Remove bumper assembly. Modify bumper retaining bracket below indicator light. See diagram Measure bumper as shown on figure 1. Using masking tape mark where cut is to occur. Check for correct alignment 3. Carefully cut bumper with air blade saw (body saw / mitre saw) using edge of masking tape as guide. NTE: Do not let blade protrude excessively though bumper whilst cutting. Check clearance of blade to avoid damage to vehicle components. 4. Check alignment of cut and refit bumper section to vehicle. 5. Connect indicator / park light wiring to original wiring located at the side of the headlights. Use cable locks (supplied). 6. Position passenger side mounting bracket (supplied) on chassis as shown in diagram 2, hard up against front face. Using bracket as a guide, mark chassis for where holes 1 and 2 are to be drilled. For hole 3 use backing plate as a guide. Ensure holes are drilled accurately to marked hole centres. Drill holes to 13mm. Blow filings clear and treat all exposed metal with a rust inhibitor. 7. Attach passenger side bracket to chassis. Use ½ x 1 ¾ bolts, flat and spring washers and backing washer plate (supplied). Check for alignment as shown in diagram 2. TIGHTEN ALL BLTS. 8. Driver s side; remove horn bracket form mounting bolt and cut where shown in diagram 3, to allow clearance for protection bar bracket to sit hard up against front face of chassis cross member shown below. 9. Hold drivers side mounting bracket on chassis as shown on diagram 2. Ensure bracket is flush against front face. Using bracket as a guide, mark chassis for where holes 1 and 2 are to be drilled. For hole 3 use backing plate as a guide. Ensure holes are drilled accurately to marked hole centres. Drill holes to 13mm. Blow filings clear and treat all exposed metal with a rust inhibitor. 10. Attach driver s side bracket to chassis. Use ½ x 1 ¾ bolts, flat and spring washers and backing washer plate (supplied). Check for alignment as shown in diagram 2. TIGHTEN ALL BLTS. NTE: Refit horn bracket and TIGHEN BLT Check the horn for correct operation. 11. Attach protection bar to brackets. Use ½ x 1 ¾ bolts, nuts, flat and spring washers (supplied). NTE: Position bolts with nuts to centre of vehicle to alloy easy access for tightening. Check for positioning of protection bar returns; ensure that returns finish with wheel arch. TIGHTEN BLTS to 92FT/LBS torque (minimum). 12. Fit Barjo LED indicator / park lights into protection bar as per instructions supplied with the LED indicator kit. NTE: Ensure park light is to outside. See figure 3.. Copyright ECB Pty Ltd
2 13. Connect indicator / park light wiring and check for correct operation. 14. Attach alloy fill in panel (supplied) to bottom of protection bar with six tek screw (supplied). Trim bottom edge of plastic inner guard if necessary and tuck into end cap of bumper on protection bar. ENSURE NUMBER PLATE IS CLEARLY VISABLE ENSURE THESE INSTRUCTINS ARE LEFT WITH VEHICLE WNER AND/R PERATR Note: When fitting/refitting the licence plate to the vehicle, ensure there is no obstruction to licence plate vision in accordance with local authorities. If required relocate licence plate to an alternate location. Further VFPS Notes: a) Do not attach VFPS to the vehicle using anchorages not intended for this purpose (e.g. engine mounting bolts). b) Do not use this product for any vehicle make or model, other than those specified by the VFPS manufacturer. c) Do not remove the plaque or label from the VFPS. d) Do not modify the structure of the VFPS in any way. e) No accessory or fitment should project forward of the VFPS forward profile. f) ENSURE THESE INSTRUCTINS ARE LEFT WITH VEHICLE WNER AND/R PERATR. IMPRTANT INFRMATIN Periodically check bolts and nuts for correct tightness, especially if travelling on rough roads FITTING KIT 1 Pair steel mounting brackets. 1 ECB LED Indicator / Park light kit 1 Pair backing plates. 6 Cable locks ¾ x ½ bolts and nuts. 1 Alloy fill in panel. 22 ½ flat washers. 6 12g x 20mm self-drilling tek screws. 12 ½ spring washers.. Copyright ECB Pty Ltd
3 Diagram 1 Cut 10mm Figure 1. Copyright ECB Pty Ltd
4 Passenger side Diagram 2 Diagram 3 Figure 2 Stainless steel self-tappers. Copyright ECB Pty Ltd
5 We value your comments Dear Fitter, Barjo would like to know how you went with the installation of this product. We value your comment and may need to contact you to clarify some details so please complete your contact details clearly. We would appreciate if you could complete as many of the following details as possible. Your Name: Product Part No. Product Description: Your contact No. Product Invoice No. Make, model, and year of vehicle: Product Work rder No. Company your from/company product purchased from: Date: / / Was the fitting hardware supplied complete? Yes No If no what was not supplied Did the installation go well? Please provide comments Please draw diagrams if you need to. Yes No Post to Fax to Reply Paid 122 (07) P Box 122 Margate QLD Copyright ECB Pty Ltd
6 . Copyright ECB Pty Ltd
7 DESPATCH CHECKLIST JAH03SY Work rder # Finish: Transport: Due Date: See other side of 1 Pair steel mounting brackets this page for 1 Pair backing plates photos of all 1 Alloy infill panel mounts 1 Bolt Kit. 1 LED ECB indicator / park light kit. 2 Barjo angled overriders Fitted to Bar Is this product the best it can be Yes / Wrapper s initials / Checker initials If N fix before continuing All parts checked and completed by: Nut and bolts: Date / / rder control: Date / / Final wrap check: Date / /. Copyright ECB Pty Ltd
8 . Copyright ECB Pty Ltd
BM141SY FITTING INSTRUCTIONS
BM141SY FITTING INSTRUCTINS REPLACES: 24.03.10 REVISED: 21.07.10. Check installation hardware before commencing. MITSUBISHI TRITN MN 08/09 on BIG TUBE PRTECTIN BAR WITH FG LIGHTS VEHICLE FRNTAL PRTECTIN
More informationEAGW10SY FITTING INSTRUCTIONS
EAGW10SY FITTING INSTRUCTINS SUPERCEEDS: EAGW04SY REVISED: 05.02.13 Check installation hardware before commencing. 1. Lift bonnet. GREAT WALL V240 03/11on AND V200 08/11on ARC BAR WITH FG LIGHTS VEHICLE
More informationBH32SY FITTING INSTRUCTIONS
BH32SY FITTING INSTRUCTINS REPLACES: 09.02.10 REVISED: 28.06.10. Check installation hardware before commencing. 1. Lift bonnet. HLDEN CAPTIVA 9/06on BIG TUBE BAR WITH FG LAMPS VEHICLE FRNTAL PRTECTIN SYSTEM
More informationBH21SY FITTING INSTRUCTIONS
BH21SY FITTING INSTRUCTINS REPLACES: 00.00.00 REVISED: 13.01.11. VE CMMDRE Series 2 MEGA AND BERLINA BIG TUBE PRTECTIN BAR WITH FG LIGHTS VEHICLE FRNTAL PRTECTIN SYSTEM (VFPS) FR AIR BAG & ADR CMPLIANT
More informationBF09SY FITTING INSTRUCTIONS
BF09SY FITTING INSTRUCTINS REPLACES: 22.02.10 REVISED: 09.07.10 FRD BA & BF FALCN & RTV BIG TUBE PRTECTIN BAR VEHICLE FRNTAL PRTECTIN SYSTEM (VFPS) FR AIR BAG AND ADR CMPLIANT VEHICLES Check installation
More informationMMA38SY/ NB6MA38SY/ NBMA38SY
MARGATE MMA38SY/ NB6MA38SY/ NBMA38SY REPLACES: 20.08.07 REVISED: 11.07.10 FITTING INSTRUCTINS MAZDA CX-7 11/06-09/09 MIDI TUBE, SERIES 2 NUDGE BAR AND 76mm NUDGE BAR VEHICLE FRNTAL PRTECTIN SYSTEM (VFPS)
More information8SZ60SY / NB6SZ60SY / NBSZ60SY FITTING INSTRUCTIONS
8SZ60SY / NB6SZ60SY / NBSZ60SY FITTING INSTRUCTIONS REPLACES: 10.03.06 REVISED: 11.07.10 SUZUKI JIMNY 8/05- T6 (VIN 003) TYPE 8, 63mm SERIES 2 NUDGE BAR and 76mm NUDGE BAR VEHICLE FRONTAL PROTECTION SYSTEM
More informationBG41SY FITTING INSTRUCTIONS
TELEPHNE: (07) 3897 5700 FAX: (07) 3283 1168 CLNTARF, BRISBANE. P.. Box 122, BG41SY FITTING INSTRUCTINS REPLACES: 10.01.06 REVISED: 08.08.10 GMC SIERRA 9/04-2500 4X4 BIG TUBE PRTECTIN BAR T SUIT 15000Lb
More informationBH13SY FITTING INSTRUCTIONS VY SS BIG TUBE PROTECTION BAR VEHICLE FRONTAL PROTECTION SYSTEM (VFPS) FOR AIR BAG AND ADR COMPLIANT VEHICLES
CLNTARF, BRISBANE. P.. Box 122, BH13SY FITTING INSTRUCTINS REPLACES: 18.02.03 REVISED: 21.08.10 Check installation hardware before commencing. NTE: Treat all drilled holes with rust inhibitor. 1. Lift
More informationMHO57SY / NB7HO57SY / NBHO57SY FITTING INSTRUCTIONS
MHO57SY / NB7HO57SY / NBHO57SY FITTING INSTRUCTIONS REPLACES: 17.06.07 REVISED: 09.07.10 HONDA CRV 2/07on MIDI TUBE, 76mm SERIES 2 NUDGE BAR & 76mm NUDGE BAR VEHICLE FRONTAL PROTECTION SYSTEM (VFPS) FOR
More informationNBMB49SY REPLACES: REVISED:
NBMB49SY REPLACES: 00.00.00 REVISED: 14.03.12 FITTING INSTRUCTIONS MERCEDES VITO 02-11 ON NUDGE BAR VEHICLE FRONTAL PROTECTION SYSTEM (VFPS) FOR AIR BAG & ADR COMPLIANT VEHICLES Check installation hardware
More informationBT180SY FITTING INSTRUCTIONS
BT180SY FITTING INSTRUCTIONS TOYOTA HIACE LWB 3-2014 ON BIG TUBE PROTECTION BAR VEHICLE FRONTAL PROTECTION SYSTEM (VFPS) FOR AIR BAG & ADR COMPLIANT VEHICLES REPLACES: 00.00.00 REVISED: 01.09.14. Check
More informationBT91S FITTING INSTRUCTIONS
BT91S FITTING INSTRUCTINS REPLACES: 27.07.04 REVISED: 22.08.10 TYTA LANDCRUSIER 70/75/78/79 SERIES BIG TUBE WITH 9000LB WARN WINCH MUNTING BRACKET PRTECTIN BAR VEHICLE FRNTAL PRTECTIN SYSTEM (VFPS) Check
More information8IZ64SY / NB7IZ64SY FITTING INSTRUCTIONS
8IZ64SY / NB7IZ64SY FITTING INSTRUCTIONS REPLACES: 09.10.12 REVISED: 27.11.12 Check installation hardware before commencing. ISUZU DMAX 6-12 on TYPE 8 AND 76MM SERIES 2 NUDGE BAR VEHICLE FRONTAL PROTECTION
More informationNB6K49SY FITTING INSTRUCTIONS KIA SORENTO 63MM STANDARD NUDGE BAR VEHICLE FRONTAL PROTECTION SYSTEM (VFPS) FOR AIR BAG & ADR COMPLIANT VEHICLES
NB6K49SY FITTING INSTRUCTIONS REPLACES: 00.00.00 REVISED: 31.05.07 Check installation hardware before commencing. 1. Lift bonnet KIA SORENTO 63MM STANDARD NUDGE BAR VEHICLE FRONTAL PROTECTION SYSTEM (VFPS)
More informationNB6MB60SY / NBMB60SY FITTING INSTRUCTIONS
NB6MB60SY / NBMB60SY FITTING INSTRUCTIONS REPLACES: 00.00.00 REVISED: 22.01.14 Check installation hardware before commencing. 1. Lift bonnet MERCEDES BENZ SPRINTER 10/13 on 63mm SERIES 2 NUDGE BAR AND
More informationBT107SY FITTING INSTRUCTIONS
TELEPHNE: (07) 3897 5700 FAX: (07) 3283 1168 CLNTARF, BRISBANE. P.. Box 122, BT107SY FITTING INSTRUCTINS REPLACES: 22.02.10 REVISED: 11.07.10. TYTA LANDCRUISER 200 SERIES 11/07 N BIG TUBE BAR (WITH FG
More information8MB48SY / NB6MB48SY FITTING INSTRUCTIONS
8MB48SY / NB6MB48SY FITTING INSTRUCTIONS REPLACES: 20.03.06 REVISED: 23.07.10 MERCEDES VITO 04/04 on TYPE 8 and 63mm SERIES 2 NUDGE BAR VEHICLE FRONTAL PROTECTION SYSTEM (VFPS) FOR AIR BAG & ADR COMPLIANT
More information8T92SY/ NB6T92SY / NBT92SY FITTING INSTRUCTIONS
8T92SY/ NB6T92SY / NBT92SY FITTING INSTRUCTIONS REPLACES: 05.05.05 REVISED: 28.06.10 TOYOTA HILUX 03/05-2WD & 4WD TYPE 8, 63mm SERIES 2 NUDGE BAR and 76mm NUDGE BAR VEHICLE FRONTAL PROTECTION SYSTEM (VFPS)
More information8H64SY / NB7H64SY / NHB64SY FITTING INSTRUCTIONS
8H64SY / NB7H64SY / NHB64SY FITTING INSTRUCTIONS REPLACES: 00.00.00 REVISED: 05.09.12 HOLDEN COLORADO RG 6-12 on TYPE 8, 76MM SERIES 2 NUDGE BAR AND 76MM NUDGE BAR VEHICLE FRONTAL PROTECTION SYSTEM (VFPS)
More informationBT72SY / AWMT13Y FITTING INSTRUCTIONS
BT72SY / AWMT13Y FITTING INSTRUCTINS REPLACES: 16.02.10 REVISED: 15.07.10 LANDCRUSIER PRAD 7/96-2/03 9000lbWARN WINCH BIG TUBE BULLBAR (RETAINS FG LIGHTS) / WINCH MUNTING BRACKET VEHICLE FRNTAL PRTECTIN
More informationBH128SY FITTING INSTRUCTIONS
BH128SY FITTING INSTRUCTIONS REPLACES: 00.00.00 REVISED: 07.10.16 HOLDEN CAPTIVA 1/16 on BIG TUBE BAR WITH FOG LIGHTS & SENSORS VEHICLE FRONTAL PROTECTION SYSTEM (VFPS) FOR AIR BAG & ADR COMPLIANT VEHICLES
More informationEAN102SY FITTING INSTRUCTIONS
MARGATE EAN102SY FITTING INSTRUCTIONS REPLACES: 00.00.00 REVISED: 27.07.10 NISSAN PATHFINDER R51 05/10on & NAVARA D40 ST-X 05/10on WINCH COMPATIBLE (UP TO XP 9.5) ARC PROTECTION BAR WITH FOG LIGHTS VEHICLE
More informationEAT116SY. 5. Remove three 10mm head bolts from inner guards and pull rearward to clear bumper side.
EAT116SY REPLACES: 30.05.12 REVISED: 22.08.12 FITTING INSTRUCTIONS TOYOTA PRADO 11/09on ARC PROTECTION BAR WITH PARKING SENSORS AND HID HEADLIGHTS VEHICLE FRONTAL PROTECTION SYSTEM (VFPS) FOR AIR BAG &
More informationNB7FI05SY / NBFI05SY FIAT DUCATO 76mm SERIES 2 NUDGE BAR and 76mm NUDGE BAR
NB7FI05SY / NBFI05SY FIAT DUCATO 76mm SERIES 2 NUDGE BAR and 76mm NUDGE BAR REPLACES: 24.07.10 REVISED: 22.01.15 To the Fitter, This instruction covers two models of this vehicle. The difference between
More informationNBM111SY FITTING INSTRUCTIONS. PAJERO SPORT 01/16-76mm NUDGE BAR VEHICLE FRONTAL PROTECTION SYSTEM (VFPS) FOR AIR BAG & ADR COMPLIANT VEHICLES
NBM111SY FITTING INSTRUCTIONS REPLACES: 00.00.00 REVISED: 6.10.16 PAJERO SPORT 01/16-76mm NUDGE BAR VEHICLE FRONTAL PROTECTION SYSTEM (VFPS) FOR AIR BAG & ADR COMPLIANT VEHICLES Check installation hardware
More informationNBT115SY / NB7T115SY FITTING INSTRUCTIONS
NBT115SY / NB7T115SY FITTING INSTRUCTIONS REPLACES: 22.12.09 REVISED: 08.07.10. TOYOTA PRADO 11/09on 76MM NUDGE BAR AND 76MM SERIES 2 NUDGE BAR VEHICLE FRONTAL PROTECTION SYSTEM (VFPS) FOR AIR BAG & ADR
More informationNBN110SY FITTING INSTRUCTIONS. NISSAN X-TRAIL 01/10 on 76mm NUDGE BAR VEHICLE FRONTAL PROTECTION SYSTEM (VFPS) FOR AIR BAG AND ADR COMPLIANT VEHICLES
NBN110SY FITTING INSTRUCTIONS REPLACES: 00.00.00 REVISED: 15.12.10 NISSAN X-TRAIL 01/10 on 76mm NUDGE BAR VEHICLE FRONTAL PROTECTION SYSTEM (VFPS) FOR AIR BAG AND ADR COMPLIANT VEHICLES Check installation
More informationEAH153SY FITTING INSTRUCTIONS
EAH153SY FITTING INSTRUCTIONS REPLACES: 15.12.16 REVISED: 16.02.17 HOLDEN COLORADO 6/16on BIG TUBE WINCH PROTECTION BAR WITH FOG LIGHTS VEHICLE FRONTAL PROTECTION SYSTEM (VFPS) FOR AIR BAG & ADR COMPLIANT
More informationEAFT01SY FITTING INSTRUCTIONS FOTON TUNLAND 03/14- ARC BAR VEHICLE FRONTAL PROTECTION SYSTEM (VFPS) FOR AIR BAG & ADR COMPLIANT VEHICLES
EAFT01SY FITTING INSTRUCTIONS REPLACES: 00.00.00 REVISED: 09.03.15 Check installation hardware before commencing. 1. Lift bonnet. FOTON TUNLAND 03/14- ARC BAR VEHICLE FRONTAL PROTECTION SYSTEM (VFPS) FOR
More informationEAF164SY FITTING INSTRUCTIONS
EAF164SY FITTING INSTRUCTIONS REPLACES: 00.00.00 REVISED: 16.08.16. FORD RANGER SERIES 2 and EVEREST ECB ARC BAR WITH FOG LIGHTS AND SONAR SYSTEM VEHICLE FRONTAL PROTECTION SYSTEM (VFPS) FOR AIR BAG &
More informationEAIZ66SY FITTING INSTRUCTIONS
EAIZ66SY FITTING INSTRUCTIONS REPLACES: 00.00.00 REVISED: 09.10.12 Check installation hardware before commencing. 1. Lift bonnet ISUZU DMAX 6-12 on ECB ARC BAR WINCH COMPATIBLE VEHICLE FRONTAL PROTECTION
More informationEAM109SY FITTING INSTRUCTIONS
EAM109SY FITTING INSTRUCTIONS REPLACES: 17.12.12 REVISED: 28.04.16 NX PAJERO MY15 11/14- ARC BAR PROTECTION BAR With fog lights VEHICLE FRONTAL PROTECTION SYSTEM (VFPS) FOR AIR BAG & ADR COMPLIANT VEHICLES
More information8H14SY FITTING INSTRUCTIONS
8H14SY FITTING INSTRUCTIONS REPLACES: 18.07.05 REVISED: 16.07.10 VY HOLDEN ADVENTRA / CROSS 8 / UTE / S / SS / EXECUTIVE / ACCLAIM VX HOLDEN EXECUTIVE / ACCLAIM and VT HOLDEN ALL MODELS TYPE 8 VEHICLE
More informationNBJ52SY / NB7J52SY. 2. Remove crash component from front of chassis. Remove tow bracket with nuts/bolts from drivers side. See figure 1.
NBJ52SY / NB7J52SY REPLACES: 06.06.05 REVISED: 08.08.10 FITTING INSTRUCTIONS JEEP CHEROKEE KJ 10/01-02/08 76mm NUDGE BAR and 76mm SERIES 2 NUDGE BAR VEHICLE FRONTAL PROTECTION SYSTEM (VFPS) FOR AIR BAG
More informationNB6R56SY FITTING INSTRUCTIONS
NB6R56SY REPLACES: 00.00.00 REVISED: 01.06.10 FITTING INSTRUCTIONS LANDROVER DISCOVERY 4 10/09on SERIES 2 NUDGE BAR VEHICLE FRONTAL PROTECTION SYSTEM (VFPS) FOR AIR BAG & ADR COMPLIANT VEHICLES Check installation
More informationNBF38SY FITTING INSTRUCTIONS. FORD TERRITORY 7/14on 76MM NUDGE BAR VEHICLE FRONTAL PROTECTION SYSTEM (VFPS) FOR AIR BAG & ADR COMPLIANT VEHICLES
NBF38SY FITTING INSTRUCTIONS COMMENCES: 280417 REVISED: 000000 Check installation hardware before commencing FORD TERRITORY 7/14on 76MM NUDGE BAR VEHICLE FRONTAL PROTECTION SYSTEM (VFPS) FOR AIR BAG &
More information8S61SY / NB6S61SY / NB6S62SY FITTING INSTRUCTIONS
8S61SY / NB6S61SY / NB6S62SY FITTING INSTRUCTIONS REPLACES: 21.07.05 REVISED: 22.07.10 SUBARU FORESTER 06/02-6/05 TYPE 8, 63mm SERIES 2 NUDGE BAR & 63mm NUDGE BAR VEHICLE FRONTAL PROTECTION SYSTEM (VFPS)
More informationNBH110SY FITTING INSTRUCTIONS. VF COMMODORE 5-13 on 76mm NUDGE BAR VEHICLE FRONTAL PROTECTION SYSTEM (VFPS) FOR AIR BAG & ADR COMPLIANT VEHICLES
NBH110SY FITTING INSTRUCTIONS REPLACES: 00.00.00 REVISED: 26.11.13. Check installation hardware before commencing. 1. Lift bonnet. VF COMMODORE 5-13 on 76mm NUDGE BAR VEHICLE FRONTAL PROTECTION SYSTEM
More informationBJ100SY FITTING INSTRUCTIONS
BJ100SY FITTING INSTRUCTIONS REPLACES: 00.00.00 REVISED: 15.07.13. Check installation hardware before commencing. Special Tools: T15 Torx bit and required drivers. 1. Lift Bonnet JEEP WRANGLER JK 08 on
More informationBJ74SY FITTING INSTRUCTIONS
BJ74SY FITTING INSTRUCTIONS REPLACES: 00.00.00 REVISED: 05.08.13. Check installation hardware before commencing. 1. Lift bonnet. JEEP GRAND CHEROKEE OVERLAND WK MY14 6/13on BIG TUBE PROTECTION BAR WITH
More informationEAT231SY FITTING INSTRUCTIONS
EAT231SY FITTING INSTRUCTIONS REPLACES: 00.00.00 REVISED: 19.04.16. Check installation hardware before commencing 1. Lift bonnet. TOYOTA FORTUNER 5-15 ON ECB WINCH COMPATIBLE BIG TUBE with fog lights VEHICLE
More informationBolt tensions Dia. (mm) Nm ft.lbs Dia. (inch) Nm ft.lbs
Product: Vehicle: FITTING INSTRUCTIONS T15 Fleet Bull Bar Nissan Pathfinder R51 / Nissan Navara D40 Part No. 070SB15F10L 070AP15F10L Australian Standards Relating to Installing Vehicle Frontal Protection
More informationSS188HF Toyota Land Cruiser Prado 150 Series KDJ150R 3.0L 4 Cyl. D-4D Diesel (1KD-FTV Engine)
SS188HF Toyota Land Cruiser Prado 150 Series KDJ150R 3.0L 4 Cyl. D-4D Diesel (1KD-FTV Engine) Parts List 8/7/2010 ITEM PART NO. DESCRIPTION QTY 1 365-133-000 BODY - SNORKEL (SS188HF) 1 2 000-135-800 3
More informationT15 Fleet Frontal Protection System Vehicle: Mazda BT50 09/08+ Part No. 070SB15X46Z
Australian Standards Relating to Installing Vehicle Frontal Protection Systems (VFPS): AS 4876.1-2002 a) Do not attach V.F.P.S. to vehicle using anchorages not intended for this purpose (e.g. engine mounting
More informationSS985HF Mazda BT-50 B32P Series 3.2L 5cylinder TDCi Diesel (P5AT Engine)
SS985HF Mazda BT-50 B32P Series 3.2L 5cylinder TDCi Diesel (P5AT Engine) Parts List 01/03/2013 ITEM PART NO. DESCRIPTION QTY 1 685-133-000 BODY - SNORKEL (SS985HF) 1 2 000-135-800 3 ½" AIR RAM ASSEMBLY
More informationWARNING. When installed in accordance with these instructions, the front protection bar does not affect operation of the SRS airbag.
Part Number: 343870 F/Kit 17557 Product Deluxe Combination Winch and Non Winch Bull Bar Description: Suited to Nissan XTERRA 05ON USA Only vehicle/s: WARNING REGARDING VEHICLES EQUIPPED WITH SRS AIRBAG;
More informationARB PRADO WINCH/NON WINCH BUMPER TO SUIT GXL, VX AND GRANDE 2003 ONWARDS.
ARB PRADO WINCH/NON WINCH BUMPER TO SUIT GXL, VX AND GRANDE 003 ONWARDS. PART No 390 500050 Top Tube Kit 50073 Buffer Kit With hole (required when fitting Top Tube) 50074 Buffer Kit With no hole FITTING
More informationT15 / T17 Frontal Protection Bar Ford Ranger / Mazda BT50 Part No. 070SB15F46Z 070AP15F46Z 074SB17N46Z
Australian Standards Relating to Installing Vehicle Frontal Protection Systems (VFPS): AS 4876.1-2002 a) Do not attach V.F.P.S. to vehicle using anchorages not intended for this purpose (e.g. engine mounting
More informationSS41HF Mitsubishi Pajero NS & NT V8/V9 Series 3.2 Litre Turbo Diesel (4M41 Engine) 3.8 Litre V6 Petrol (6G76 Engine)
SS41HF Mitsubishi Pajero NS & NT V8/V9 Series 3.2 Litre Turbo Diesel (4M41 Engine) 3.8 Litre V6 Petrol (6G76 Engine) 21/7/2010 Parts List ITEM PART NO DESCRIPTION QTY 1 570-133-200 BODY - SNORKEL (SS41HF)
More informationSS1135HF Jeep KJ Cherokee CRDI4 2.8Litre-I4 Diesel Engine
SS1135HF Jeep KJ Cherokee CRDI4 2.8Litre-I4 Diesel Engine Parts List 23/2/2010 ITEM PART NO DESCRIPTION QTY 1 965-133-000 BODY - SNORKEL (SS1130HF) 1 2 000-135-800 3 ½" AIR RAM ASSEMBLY 1 3 965-032-000
More informationCOMBAR G/BAR CHEROKEE KJ SRS 8/9 NFO
Part Number: 3450160. F/KIT: 6173660 & 6173667 Product Description: Suited to vehicle/s: Optional Fitting Kit: WARNING REGARDING VEHICLES EQUIPPED WITH SRS AIRBAG; When installed in accordance with these
More informationLAND ROVER DISCOVERY 3 ARB BULL BAR AND WINCH BAR WARNING
LAND ROVER DISCOVERY 3 ARB BULL BAR AND WINCH BAR PART No 3432150 DISCOVERY 3 WINCH BAR PART No 3232150 DISCOVERY 3 BULL BAR WARNING FOR VEHICLES EQUIPPED WITH SRS AIRBAG WHEN INSTALLED IN ACCORDANCE WITH
More informationINSTALLATION INSTRUCTIONS
Read instructions fully before commencing fitment. Left hand & Right hand components are determined as seated in the vehicle. Check for (& remove) any build up in all captive nuts fitted to the Bumper.
More informationSS15HFB Nissan GU Patrol Series 1-3 RD28-Ti, TD42T & TD42Ti Engines
SS15HFB Nissan GU Patrol Series 1-3 RD28-Ti, TD42T & TD42Ti Engines Parts List 03/12/10 ITEM PART NO DESCRIPTION QTY 1 485-133-500 BODY - SNORKEL (SS15HFB) 1 2 000-135-800 3 ½" AIR RAM ASSEMBLY 1 3 485-032-500
More informationInstruction to fit snorkel kit S065. for the Mitsubishi ML Triton 2006 onward
Instruction to fit snorkel kit S065 Airflow Vector Pty Ltd for the Mitsubishi ML Triton 2006 onward 1.0 Introduction Airflow Vector Pty Ltd thanks you for your purchase and the trust you put in our products.
More informationInstructions to fit the Snorkel Kit S002D for the Jeep Grand Cherokee WJ / WG Diesel 1.0 Introduction
Instructions to fit the Snorkel Kit S002D for the Jeep Grand Cherokee WJ / WG Diesel 1.0 Introduction Airflow Vector Pty Ltd thanks you for your purchase and the trust you put in our products. We strive
More informationBBT033/ BBC033/ BBCD033 TOYOTA HILUX 10/2011
INSTALLATION GUIDE BBT033/ BBC033/ BBCD033 TOYOTA HILUX 10/2011 Ironman 4x4 BBT/ BBC/ BBCD033 Bull Bars fit to a Toyota Hilux 10/2011 It will take about 3 hours to install. NOTE: This product has been
More informationSS730HF NISSAN D40 NAVARA DUAL CAB/R51 PATHFINDER - 2.5L YD25DDTi ENGINE
SS730HF NISSAN D40 NAVARA DUAL CAB/R51 PATHFINDER - 2.5L YD25DDTi ENGINE 27/06/06 ITEM DESCRIPTION QTY PART NO 1 BODY SNORKEL 1 430-133-000 2 3½ AIR RAM ASSEMBLY 1 000-135-650 3 BRACKET - UPPER MOUNTING
More informationSS1066HF Jeep JK Wrangler Left Hand Drive CRDI4 2.8Litre-I4 Diesel Engine and EGHV6 3.8Litre V6 Gasoline Engine
SS1066HF Jeep JK Wrangler Left Hand Drive CRDI4 2.8Litre-I4 Diesel Engine and EGHV6 3.8Litre V6 Gasoline Engine Installation Guide Safari SS1066HF Page - 1 of 12 6/10/2009 ITEM PART NO DESCRIPTION QTY
More informationSS16HFB Nissan GU Patrol Series L 4cyl Turbo Diesel (ZD30-DDTi Engine)
SS16HFB Nissan GU Patrol Series 1-3 3.0L 4cyl Turbo Diesel (ZD30-DDTi Engine) Parts List 01/06/11 ITEM PART NO DESCRIPTION QTY 1 485-133-500 BODY - SNORKEL (SS15HFB) 1 2 000-135-800 3 ½" AIR RAM ASSEMBLY
More informationFITTING KIT No s : BULL BAR WINCH ( P/No ) BULL BAR NON WINCH ( P/No )
ARB WINCH / NON WINCH BULL BAR TO SUIT LANDROVER DISCOVERY 2003 ONWARD. FITTING KIT No s :- 617 1793 BULL BAR WINCH ( P/No 343 2120 ) 617 1794 BULL BAR NON WINCH ( P/No 323 2120 ) WARNING FOR VEHICLES
More informationInstructions to fit the Snorkel Kit S018 Mazda BT on
Instructions to fit the Snorkel Kit S018 Mazda BT 50 2011 on Airflow Vector Pty Ltd 4 Collins Rd, Dromana VIC. 3936 1.0 Introduction Airflow Vector Pty Ltd thanks you for your purchase and the trust you
More informationCOMBAR G/BAR CHEROKEE KJ SRS NFO
Part Number: 3450170 F/KIT: 6173661 & 6173668 Product Description: Suited to vehicle/s: Optional Fitting Kit: WARNING REGARDING VEHICLES EQUIPPED WITH SRS AIRBAG; When installed in accordance with these
More informationSS732HF NISSAN D40 NAVARA / R51 PATHFINDER 4.0Ltr V6 Petrol (VQ40 Engine) Built: Nissan Motor Iberica, S.A.
SS732HF NISSAN D40 NAVARA / R51 PATHFINDER 4.0Ltr V6 Petrol (VQ40 Engine) Built: Nissan Motor Iberica, S.A. Parts List 31/03/2014 ITEM PART NO. DESCRIPTION QTY 1 430-133-000 BODY - SNORKEL (SS730HF) 1
More informationWH/WK JEEP GRAND CHEROKEE 2005 ON WARNING
Part Number: 3450130 F/KIT: 6172092 Product Description: Suited to vehicle/s: COMBINATION BULL BAR WH/WK JEEP GRAND CHEROKEE 2005 ON WARNING REGARDING VEHICLES EQUIPPED WITH SRS AIRBAG; When installed
More informationWARNING. When installed in accordance with these instructions, the front protection bar does not affect operation of the SRS airbag.
Part Number: 3400 Product ARB WINCH BULL BAR Description: Suited to TOYOTA 4 RUNNER YEAR MODELS 03 ON vehicle/s: WARNING REGARDING VEHICLES EQUIPPED WITH SRS AIRBAG: When installed in accordance with these
More informationFORD TERRITORY TOWBAR FITTING INSTRUCTION Part # VEHICLE YEARS OF MANUFACTURE - From May
The installation kit contains sufficient components for fitment*. Do not substitute any components. A high degree of technical competence is necessary to correctly install this product. We recommend this
More informationBULLBAR Fitting instructions to fit TUFF Range Bullbars (2-3 Post, and Aerostyle) to NISSAN NP300 NAVARA
TUFF BULLBARS AUSTRALIA sales@tuffbullbars.com.au 6 Tews Ct, (PO Box 1977) marketing@tuffbullbars.com.au TOOWOOMBA QLD 4350 feedback@tuffbullbars.com.au Phone: 1300 BE TUFF www.tuffbullbars.com.au (1300
More informationInstructions to fit the Snorkel Kit S014. for the Dodge Ram 2500 and Power Wagon (5.7L HEMI) 1.0 Introduction
Instructions to fit the Snorkel Kit S014 Airflow Vector Pty Ltd for the Dodge Ram 2500 and Power Wagon (5.7L HEMI) 1.0 Introduction Airflow Vector Pty Ltd thanks you for your purchase and the trust you
More informationSS175HF ISUZU D-MAX (June 2012 onwards) 3.0Litre, 4 Cylinder Turbo Diesel (4JJ1-TC Hi-Power Engine)
SS175HF ISUZU D-MAX (June 2012 onwards) 3.0Litre, 4 Cylinder Turbo Diesel (4JJ1-TC Hi-Power Engine) 01/09/2013 Parts List ITEM PART NO. DESCRIPTION QTY 1 740-133-000 BODY - SNORKEL (SS175HF) 1 2 000-135-800
More informationSS77HFZ Toyota Land Cruiser 70 series (Wide Nose) Suits: 4.2L 6cyl Diesel (1HZ engine) Replaces Factory Toyota Raised Air Intake (Genuine Snorkel)
SS77HFZ Toyota Land Cruiser 70 series (Wide Nose) Suits: 4.2L 6cyl Diesel (1HZ engine) Replaces Factory Toyota Raised Air Intake (Genuine Snorkel) Parts List 15/02/2011 ITEM PART NO DESCRIPTION QTY 1 330-133-700
More informationWARNING. ARB 4x4 ACCESSORIES. Corporate Head Office Garden St Tel: +61 (3) Kilsyth, Victoria Fax: +61 (3) AUSTRALIA 3137
Part Number: 3948020 Product Description: Suited to vehicle/s: Optional Fitting Kit: SAHARA BAR ISUZU DMAX 5148020 Sahara Top Tube Kit 3540050 Winch Install Kit 3500640 ARB AUX Fog Light Adaptor 3500530
More informationSAFETY SENSORS FIELD OF VIEW WILL BE ALTERED WITH USE OF THE REPLACEMENT BUMPER. Injury hazard
SAFETY Your safety and the safety of others is very important. In order to help you make informed decisions about safety, we have provided installation instructions and other information. These instructions
More informationKJ JEEP COMBINATION BULL BAR WARNING
KJ JEEP COMBINATION BULL BAR PRODUCT NUMBER FITTING KIT NUMBER 3450120 6171962 WARNING FOR VEHICLES EQUIPPED WITH SRS AIRBAG WHEN INSTALLED IN ACCORDANCE WITH THESE INSTRUCTIONS, THE FRONT PROTECTION BAR
More informationARB TOYOTA 80 SERIES REAR STEP TOW BAR
ARB TOYOTA 80 SERIES REAR STEP TOW BAR Product number: 5611010 Optional Jerry Can Carrier Optional Wheel Carrier Left Hand Side of vehicle (LHS) Rear Step Tow Bar Right Hand Side of vehicle (RHS) READ
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS PART # Product: Vehicle: 074ST17A89B FRONT BUMPER T17 Toyota TACOMA 2016 / ON (Third Gen) WARNING Read instructions completely before commencing fitment. Always use personal safety
More informationARB 4x4 ACCESSORIES Corporate Head Office
Part Number: 34500 Product Description: Suited to vehicle/s: COMBAR DODGE RAM 003-05 500 00-05 ADD BRACKET KIT# 35500 500/3500 003-05 ADD BRACKET KIT# 35500 WARNING REGARDING VEHICLES EQUIPPED WITH SRS
More informationInstructions to fit the Snorkel Kit S164. for the Holden RA Rodeo from (NO swage) 1.0 Introduction
Instructions to fit the Snorkel Kit S164 Airflow Vector Pty Ltd for the Holden RA Rodeo from 2003-2008 (NO swage) 1.0 Introduction Airflow Vector Pty Ltd thanks you for your purchase and the trust you
More informationTHANKS FOR CHOOSING TO BE TUFF!!!!!!!!!
TUFF BULLBARS AUSTRALIA, Ph: 1300 BE TUFF (1300 23 88 33) 5-7 Holt Drive, (P.O. Box 1977) Fax: 07 4633 1236 Torrington, sales@tuffbullbars.com.au Toowoomba, admin@tuffbullbars.com.au Queensland 4350, feedback@tuffbullbars.com.au
More informationInstructions to fit the Snorkel Kit S080 for the Nissan Terrano II
Instructions to fit the Snorkel Kit S080 for the Nissan Terrano II Airflow Vector Pty Ltd 1.0 Introduction Airflow Vector Pty Ltd thanks you for your purchase and the trust you put in our products. We
More informationIMPORTANT: PLEASE RETAIN THIS INSTRUCTION MANUAL FOR FUTURE REFERENCE
IMPORTANT: PLEASE RETAIN THIS INSTRUCTION MANUAL FOR FUTURE REFERENCE 2009 Toyota RAV-4 Stainless Steel Mesh Grilles L 30 G8P Fine Mesh Part #30-002-09 Quantity Description Part No. Upper Mesh Grille (includes):
More informationSS970R SAFARI R-SPEC SNORKEL Ford Ranger 3.0L Turbo Diesel Intercooled
SS970R SAFARI R-SPEC SNORKEL Ford Ranger 3.0L Turbo Diesel Intercooled 01/04/2015 ITEM DESCRIPTION QTY PART NO 1 BODY - SNORKEL 1 630-133-200R 2 3 1/2" AIR RAM ASSEMBLY 1 000-135-650 3 HOSE - AIR ENTRY
More informationWARNING. ARB 4x4 ACCESSORIES. Corporate Head Office Garden St Tel: +61 (3) Kilsyth, Victoria Fax: +61 (3) AUSTRALIA 3137
Part Number: 3440400 Product Description: Suited to vehicle/s: Winch Install Kit: DELUXE WINCH BULL BAR FORD RANGER PX 2011ON 3540050 WARNING REGARDING VEHICLES EQUIPPED WITH SRS AIRBAG; When installed
More informationARB TOYOTA 100 SERIES IFS REAR STEP TOW BAR
ARB TOYOTA 100 SERIES IFS REAR STEP TOW BAR Product number: 5613210 Optional Jerry Can Carrier Optional Wheel Carrier Left Hand Side of vehicle (LHS) Rear Step Tow Bar Right Hand Side of vehicle (RHS)
More informationISNORKEL037 VOLKSWAGEN AMAROK
INSTALLATION GUIDE ISNORKEL037 VOLKSWAGEN AMAROK Ironman 4x4 Snorkel fits to the right hand side of the Volkswagen Amarok, both flared and non-flared models. It will take about 4 hours to install. Below
More informationMahindra Pikup (2009 Production Onwards)
Mahindra Pikup (009 Production Onwards) Steel Bull Bar INSTALLATION INSTRUCTIONS Accessory Part No. BBAR07 Installation Time: 60min Approx Bull Bar Weight: 60KG! Important: Please read each step of these
More informationBBT020/ BBC020/ BBCD020 HOLDEN RODEO RA7 & ISUZU DMAX 07+ 2WD & 4WD Models
INSTALLATION GUIDE BBT020/ BBC020/ BBCD020 HOLDEN RODEO RA7 & ISUZU DMAX 07+ 2WD & 4WD Models Ironman 4x4 BBT/ BBC/ BBCD020 Bull Bars fit to a Holden Rodeo & Isuzu DMAX. It will take about 3 hours to install.
More informationSS176HF HOLDEN COLORADO RG 4WD & SUV 2.8L CTDI 4cyl Duramax Engine
SS176HF HOLDEN COLORADO RG 4WD & SUV 2.8L CTDI 4cyl Duramax Engine Parts List 01/04/2013 ITEM PART NO. DESCRIPTION QTY 1 745-133-000 BODY - SNORKEL (SS176HF) 1 2 000-135-800 3 ½" AIR RAM ASSEMBLY 1 3 745-032-000
More informationSS122HF TOYOTA HILUX (Oct 2011 onwards) 3.0L Turbo Diesel D-4D (1KD-FTV Engine)
SS122HF TOYOTA HILUX (Oct 2011 onwards) 3.0L Turbo Diesel D-4D (1KD-FTV Engine) Parts List 01/02/2014 ITEM PART NO. DESCRIPTION QTY 1 320-133-400 BODY - SNORKEL (SS122HF) 1 2 000-135-800 3 ½" AIR RAM ASSEMBLY
More informationMustang Radiator Conversion DIY. By GearHeadPeter. January 27, 2011
1964-1966 Mustang Radiator Conversion DIY By GearHeadPeter January 27, 2011 We all know that the radiators in our cars are not the best, especially if you have done any customization to the engine, which
More information4 th Gen 4 Runner Front Bumper - Installation Instructions:
www.shrockworks.com info@shrockworks.com 877-474-7625 4 th Gen 4 Runner Front Bumper - Installation Instructions: Thank you for purchasing a ShrockWorks product. We are confident you will enjoy it for
More informationBBT029/ BBC029/ BBCD029 TOYOTA PRADO 150. Ironman 4x4 BBT/ BBC/ BBCD029 Bull Bars fit to a Toyota Prado 150. It will take about 3 hours to install.
INSTALLATION GUIDE BBT029/ BBC029/ BBCD029 TOYOTA PRADO 150 Ironman 4x4 BBT/ BBC/ BBCD029 Bull Bars fit to a Toyota Prado 150. It will take about 3 hours to install. NOTE: This product has been tested
More informationFIAT 500 ABARTH FRONT MOUNTED INTERCOOLER INSTALLATION
FIAT 500 ABARTH FRONT MOUNTED INTERCOOLER INSTALLATION Tools needed: T30 screwdriver/bit 10mm socket, suitable extension and ratchet 17mm socket, suitable extension and ratchet 10mm ratchet spanner Pozidriv/Phillips
More informationBULLBAR Fitting instructions to fit TUFF Range Bullbars (2-5 Post and Aerostyle) to TOYOTA FORTUNER
BULLBARS FITTING INSTRUCTIONS FOR TOYOTA FORTUNER Last updated 9/2/16 TUFF BULLBARS AUSTRALIA sales@tuffbullbars.com.au 6 Tews Ct, (PO Box 1977) marketing@tuffbullbars.com.au TOOWOOMBA QLD 4350 feedback@tuffbullbars.com.au
More informationInstructions to fit the Snorkel Kit S073D for the D40 Navara - R51 Pathfinder Diesel 1.0 Introduction
Instructions to fit the Snorkel Kit S073D for the D40 Navara - R51 Pathfinder Diesel 1.0 Introduction thanks you for your purchase and the trust you put in our products. We strive to supply our customers
More informationRhino Track Mount System
Tools required, Track install: Power drill Drill stop 5mm (3/6 ) drill bit Vacuum Cleaner Felt tip pen Carton knife Rivet gun/pneumatic Measuring tape Masking tape Automotive Butyl Sealant Caulking gun
More informationAirtec Snorkel Assembly Vehicle: Toyota FJ Cruiser 4.0L Petrol, 04/2011+ Part No. 011SAT0185A. Read instructions fully before commencing fitment.
Read instructions fully before commencing fitment. Estimated Fitting Time: 3hrs To provide a totally sealed intake system, it will be necessary to remove all under bonnet air-cleaner plumbing & provide
More informationBBT007/ BBC007/ BBCD007 TOYOTA PRADO 90 Series
INSTALLATION GUIDE BBT007/ BBC007/ BBCD007 TOYOTA PRADO 90 Series Ironman 4x4 BBT/ BBC/ BBCD007 Bull Bars fit to a Toyota Prado 90 Series. It will take about 3 hours to install. NOTE: This product has
More informationThis SmartBar is also compatible with earlier Pajero models (01/2007+) with headlight washers LIGHT WEIGHT
Fitting Instructions - NX Pajero (09/2014+) Estimated Fitting time: 3 hrs. This SmartBar is also compatible with earlier Pajero models (01/2007+) with headlight washers FI-162 Revision: A Model No: SA162AA162
More information