Parts Manual. Rotary Cutters RCR2596 & RCR2510. Copyright 2016 Printed 08/30/ P

Transcription

1 Table of Contents Part Number Index Parts Manual RCR2596 & RCR2510 Rotary Cutters Read the Operator's manual entirely. When you see this symbol, the subsequent instructions and warnings are serious - follow without exception. Your life and the lives of others depend on it! Cover illustration may show optional equipment not supplied with standard unit. Copyright 2016 Printed 08/30/ P

2 Table of Contents Table of Contents Part Number Index Section 1: Introduction...4 Using This Manual...4 Manual Replacement Information...4 Manual Revisions...4 Touch-up Paint...4 Hardware Legend...5 Replacement Hardware...5 Serial Numbers...5 Part Number Service Coding...5 Section 2: Frame Point Wheel...6 CV Trail Type Driveline...8 Deck Blade Drive...10 Deck Components & 3-Point Hitch...12 Equal Angle Pull Type Driveline...14 Hub Assembly ( K)...16 Hydraulic Lift...18 Pull Type...20 Pull Type Axle & Tires...22 Section 3: Guards...24 Guarding Chain...24 Guarding Chain...26 Guarding Rubber...28 Guarding Rubber...30 Section 4: Drivelines...32 Coupler Intermediate C & C...32 Driveline 540 RPM ( C) Eurocardan...34 Driveline 540 RPM ( C) Eurocardan...36 Driveline 540 RPM ( C) Eurocardan...38 Driveline 540 RPM ( C) Eurocardan...40 Driveline 540 RPM ( C) Eurocardan...42 Driveline CV Pull Type Cutter 540 RPM ( C) Walterscheid...44 Driveline Flex Coupler ( C) Eurocardan...46 Driveline Flex Coupler ( C) Eurocardan...48 Driveline Slip Clutch ( ) Eurocardan...50 Driveline Slip Clutch ( ) Eurocardan...52 Driveline Slip Clutch ( ) Eurocardan...54 Driveline Stub Shaft Pull Type 540 RPM ( C) Eurocardan...56 Section 5: Gearboxes...58 Gearbox ( C) Comer...58 Gearbox, T-Box 540 RPM ( C) Comer...60 Section 6: Hydraulics...62 Hydraulic Cylinder ( C) Midway...62 Hydraulic Cylinder ( C) Red Lion...64 Section 7: Decals...66 Decals...66 Part Number Index...68 Copyright 2016 All rights reserved Printed 08/30/16 Great Plains Manufacturing, Inc. provides this publication as is without warranty of any kind, either expressed or implied. While every precaution has been taken in the preparation of this manual, Great Plains Manufacturing, Inc. assumes no responsibility for errors or omissions. Neither is any liability assumed for damages resulting from the use of the information contained herein. Great Plains Manufacturing, Inc. reserves the right to revise and improve its products as it sees fit. This publication describes the state of this product at the time of its publication, and may not reflect the product in the future. Great Plains Manufacturing, Incorporated Trademarks The following are trademarks of Great Plains Mfg., Inc.: Application Systems, Ausherman, Land Pride, Great Plains All other brands and product names are trademarks or registered trademarks of their respective holders. Printed in the United States of America P /30/16

3 Table of Contents Part Number Index Alphabetized Table of Contents Selected Models 3 3-Point Wheel...6 C Coupler Intermediate C & C...32 CV Trail Type Driveline...8 D Decals...66 Deck Blade Drive...10 Deck Components & 3-Point Hitch...12 Driveline 540 RPM ( C) Eurocardan...34 Driveline 540 RPM ( C) Eurocardan...36 Driveline 540 RPM ( C) Eurocardan...38 Driveline 540 RPM ( C) Eurocardan...40 Driveline 540 RPM ( C) Eurocardan...42 Driveline CV Pull Type Cutter 540 RPM ( C) Walterscheid...44 Driveline Flex Coupler ( C) Eurocardan...46 Driveline Flex Coupler ( C) Eurocardan...48 Driveline Slip Clutch ( ) Eurocardan...50 Driveline Slip Clutch ( ) Eurocardan...52 Driveline Slip Clutch ( ) Eurocardan...54 Driveline Stub Shaft Pull Type 540 RPM ( C) Eurocardan...56 E Equal Angle Pull Type Driveline...14 G Gearbox ( C) Comer...58 Gearbox, T-Box 540 RPM ( C) Comer...60 Guarding Chain...24 Guarding Rubber...28 H Hub Assembly ( K)...16 Hydraulic Cylinder ( C) Midway...62 Hydraulic Cylinder ( C) Red Lion...64 Hydraulic Lift...18 P Pull Type...20 Pull Type Axle & Tires /30/ P

4 Table of Contents Part Number Index P /30/16

5 Table of Contents Part Number Index 08/30/ P

6 3-Point Wheel Table of Contents Part Number Index P /30/16

7 3-Point Wheel Table of Contents Part Number Index Section 2: Frame Ref. Part No. Part Description Comments Revision Dwg D D D H H C C C C C C C C C C C C C C C C C C C C C C C C C C Drawing Image Number TAILWHEEL ARM ADJUST PLATE TAILWHEEL BEAM ADJ. BRKT. TAILWHEEL BEAM MOUNTING BRKT. TAILWHEEL BEAM WLDMT SHORT TAILWHEEL BEAM WELDMENT GREASE ZERK STRAIGHT 1/4-28 GREASE ZERK 1/4-28 THD FORMING RHSNB 1/2-13X1 1/2 GR5 HUB STUD 1/2-20X1 5/8 GR5 HHCS 5/8-11X3 1/2 GR5 HHCS 3/4-10X7 1/2 GR5 HHCS 1/2-20X1 1/4 GR5 NUT LOCK 3/4-10 PLT NUT HEX WHIZ 1/2-13 PLT NUT HEX TOP LOCK 5/8-11 PLT NUT HEX 1 1/4-7(MACHINED)PLAIN NUT HEX FLG/LK 1/2-20 PLT GR G WASHER LOCK SPRING 1/2 PLT WASHER FLAT 1/2 SAE PLT WASHER MACH 2.25 X 1.50 X 14GA PIN ROLL 3/8 X 2 1/2 PLT TIRE & WHEEL LAMINATED 4.0 X 8 LAM 4X8 TR-WL-HUB-YOKE 25 SER. HUB & SPINDLE ASSY 4 BOLT HUB 4 BLT W/CUPS, ZERK & STUDS HUB 4BLT DUCTILE(USE C) OIL SEAL DBL LIP BORE BRG 1.25ID CONE BRG CUP 2.44OD BUSHING TW 1.25ODX.78IDX5 1/4 RC25 TAILWHEEL YOKE, 1.5 SHAFT RCR2596 RCR2510 RCR2596 RCR /30/ P

8 Table of Contents CV Trail Type Driveline Part Number Index (Applies to RCR2510 only) P /30/16

9 Table of Contents Part Number Index Section 2: Frame CV Trail Type Driveline (Applies to RCR2510 only) Ref. Part No. Part Description Comments Revision Dwg D C C C C C C C C Drawing Image Number PILLOW BLOCK BRG. SUPPORT GREASE ZERK 1/4-28 X 90-DEG SCREW SET 5/16-18 SKT KP X 3/8 HHCS 1/2-13X1 1/4 GR5 HHCS 1/2-13X1 3/4 GR5 NUT HEX WHIZ 1/2-13 PLT BEARING PILLOW BLOCK 1 3/8BORE PTO CV 2400 X RPM PTO W/STUB SHAFT/SC /4 08/30/ P

10 Deck Blade Drive Table of Contents Part Number Index P /30/16

11 Table of Contents Part Number Index Section 2: Frame Deck Blade Drive Ref. Part No. Part Description Comments Revision Dwg N/A H H H N/A N/A D D C C C C C C C C C C C C C C C C C C C C C C C C C C C C C A Drawing Image Number SHIELD BRACKET WELDMENT 24RND DSHPN WMT 15C/C (2.8 OS) 27RND DSHPN WMT 17C/C (2.8 OS) CCW BLADE CARRIER ASSY OUTER SHIELD RCR2596 OUTER SHIELD RCR2510 HHCS 1/2-13X1 1/4 GR5 HHCS 3/4-10X2 1/4 GR5 BLD BLT 1 1/8-12X3.44 W/.25KEY HHCS M8X1.25X20 GR8.8 NUT HEX TOP LOCK 1 1/8-12 PLT NUT HEX FLG TOP LK 3/4-10 PLT WASHER LOCK SPRING 1/2 PLT WASHER FLAT 1 HARD ASTMF436 PN WASHER SPRING LOCK M8 PLT WASHER FLAT M8 PLT GRBOX SHAFT(1 3/4OD) PROTECTOR KNOB 3/8-16 FEMALE THD 2 3/8OD CUTTER BLADE 1/2X4X20.5 CCW CUTTER BLADE 1/2X4X20.5 LL CCW CUTTER BLADE 1/2 X 4 X 25 CCW CUTTER BLADE 1/2X4X25 LL CCW CUTTER BLADE 1/2X4X20.5 CW CUTTER BLADE 1/2X4X20.5 LL CW CUTTER BLADE 1/2 X 4 X 25 CW CUTTER BLADE 1/2X4X25 LL CW DRVLN C QD CLTCH DRVLN C QD CLTCH T-BOX :1.35 GBOX 1:1.50 STD SPL. COMER VENT # COMER VENT /8MNPT DRVLN 10F FLXCPLR DRVLN 17F FLXCPLR LARGE SHAFT CONE W ACCESS DOOR BLADE BOLT KIT RCR2596 RCR2510 RCR2596 RCR2510 RCR2596 Standard RCR2596 Optional RCR2510 Standard RCR2510 Optional RCR2596 Standard RCR2596 Optional RCR2510 Standard RCR2510 Optional RCR2596 RCR2510 RCR2596 RCR2510 RCR2596 RCR /30/ P

12 Table of Contents Deck Components & 3-Point Hitch Part Number Index P /30/16

13 Table of Contents Part Number Index Section 2: Frame Deck Components & 3-Point Hitch Ref. Part No. Part Description Comments Revision Dwg S D D D H H D D D D D D D D D D D D C C C C C C C C C C C C C C C C C C C C C C C C C S C C C C C C C Drawing Image Number PIN 1 1/8 OD X 7 1/8 USABLE CAT III BUSHING TUBE RD 2 1/4ODX1 5/32IDX2 5/8 SKID SHOE RCR2596 DECK WELDMENT GREEN RCR2510 DECK WELDMENT GREEN REAR BRACE STRAIGHT SHORT BUSHING 1 1/4ODX1 1/32IDX2LG REAR BRACE SHORT REAR BRACE STRAIGHT LONG REAR BRACE STRAIGHT LONG A-FRAME RH. A-FRAME HITCH RH. A-FRAME LH. A-FRAME HITCH LH. SPCR TUBE 1.44ODX.93IDX1.50LG REAR BRACE FORMED REAR BRACE FORMED HHCS 1/4-20X1 GR5 HHCS 3/4-10X2 GR5 HHCS 1-8X4 1/2 GR5 HHCS 1-8X3 1/2 GR5 HHCS 1-8X3 GR5 HHCS 3/4-10X1 3/4 GR5 PLOW 3/8-16X1 GR5 NUT LOCK 3/4-10 PLT NUT HEX TOP LOCK 1-8 PLT NUT HEX WHIZ 3/8-16 PLT NUT HEX NYLOCK 1/4-20 WASHER FLAT 1/4 SAE PLT WASHER FLAT 3/4 SAE PLT WASHER FLAT 1 SAE PIN ROLL 1/4X1 3/4 PIN COTTER 3/16 X 2 PIN, HAIR COTTER 3/16 WIRE DIA PIN CLEVIS 1 X 3 3/16 LG PIN LINCH 7/16 X 1 3/4 PIN CLEVIS 1 X 2 PLT PIN 1 1/8 OD X 7 1/8 USABLE PIN, HITCH 3PT CAT 1&2 MANUAL STORAGE CONTAINER PLUG LP 3" ID RUBBER BUSHING 1 OD X 3/4 ID X 5/8 LG DRIVELINE HOLDER W/ HARDWARE HHCS 5/16-18X1 1/4 GR5 HHCS 5/16-18X2 1/4 GR5 NUT HEX LOCK 5/16-18 FLG. WASHER FLAT 5/16 SAE PLT SPRING TORSION DRIVELINE HLDER DRIVELINE HOOK MOUNT DRIVELINE HOOK RCR2596 RCR2510 RCR2596 RCR2510 RCR2596 RCR2510 RCR2596 RCR2510 RCR2596 RCR /30/ P

14 Table of Contents Equal Angle Pull Type Driveline Part Number Index P /30/16

15 Table of Contents Part Number Index Section 2: Frame Equal Angle Pull Type Driveline Ref. Part No. Part Description Comments Revision Dwg S D D D D C C C C C C C C C C C Drawing Image Number BEARING FLANGE ASSY. PIPE 1/2 SCH. 40 X 4 15/16 BEARING SUPPORT BEARING FLANGE TUBE 1 OD X 11/16 LG. X 5/32w SNAP RING INT HHCS 5/8-11X7 1/2 GR5 HHCS 1/2-13X7 GR5 NUT LOCK 1/2-13 PLT NUT HEX 5/8-11 PLT WASHER FLAT 5/8 SAE PLT WASHER LOCK SPRING 5/8 PLT BRG 1 3/8 B X 72MM OD W/COLLAR PTO CAT. 4 X 20.5 FIXED 540 PTO CAT. 4 JACK SHAFT 540 PTO J/S.W/4-PLATE SC CAT4 540 RCR2596 RCR2510 RCR2510 RCR /30/ P

16 Table of Contents Hub Assembly ( K) Part Number Index P /30/16

17 Table of Contents Part Number Index Section 2: Frame Hub Assembly ( K) Ref. Part No. Part Description Comments Revision Dwg D K C C C C C C C C C C C C C Image No. HUB GREASE CAP HUB 5 BOLT COMPLETE GREASE ZERK 1/4-28 THD FORMING HUB STUD 1/2-20X1.88 GR5 NUT HEX SLOTTED 7/8-14 PLT NUT HEX 1/2-20 X 5/8 HIGH WASHER SPINDLE - 7/8 PIN COTTER 5/32 X 1 3/4 LG HUB 5-BOLT W/CUPS/STUDS SEAL 1.75ID CR17617 BRG CUP LM BRG CONE 1.25ID LM BRG CUP LM BRG CONE LM HUB 5-BOLT CASTING 08/30/ P

18 Hydraulic Lift Table of Contents Part Number Index P /30/16

19 Hydraulic Lift Table of Contents Part Number Index Section 2: Frame Ref. Part No. Part Description Comments Revision Dwg A D C C C C C C C C C C C C C C Drawing Image Number HYDRAULIC LIFT COMPLETE * HOSE HOLDER BRACKET VENT PLUG - 9/16-18 PLATED HHCS 3/8-16X1 1/2 GR5 HHCS 3/4-10X1 1/2 GR5 NUT LOCK 3/8-16 PLT NUT TOP LOCK 3/4-10 PLT WASHER FLAT 3/8 SAE PLT PIN CLEVIS 1 X 2 3/4 USABLE LG PIN, HAIR COTTER 3/16 WIRE DIA SPRING HOSE LOOP CYL 2.5X8X1.12 ROD (TIE)1 PIN STRK CNTRL SPCRS TO 1.50 AD 9/16MORB 9/16MJIC CP 3/4FORB MALE QD POPPET TYPE HH3/8R /4MORB 9/16FJIC 08/30/ P

20 Pull Type Table of Contents Part Number Index P /30/16

21 Pull Type Table of Contents Part Number Index Section 2: Frame Ref. Part No. Part Description Comments Revision Dwg S H H H H H L L D H C C C C C C C C C C C C C C C C N/A C C Drawing Image Number PIN 1 1/8 OD X 7 1/8 USABLE CLEVIS WELDMENT LONG LEVEL ROD WLDMT WLDMT LEVEL ROD LONG WLDMT TONGUE LONG TONGUE WELDMENT ASSY. LEVEL ROD ASSY. LEVEL ROD TUBE 1 5/8 OD X 7/32 WL X1 LG. WLDMT. LEVEL ROD SHORT HHCS 1-8X6 1/2 GR5 HHCS 1-8X4 1/2 GR5 HHCS 1-8X2 GR5 NUT HEX JAM 7/8-9 NUT HEX TOP LOCK 1-8 PLT NUT HEX COUPLER 7/8-9 x 5 WASHER FLAT 3/4 SAE PLT WASHER FLAT 1 USS PLT WASHER FLAT 1 SAE PIN LYNCH 5/16 X 1 3/4 PIN ROLL 1/4X1 3/4 PIN COTTER 5/32 X 1 1/4 LG PIN CLEVIS 3/4 X 1 1/2 PIN, HAIR COTTER 3/16 WIRE DIA PIN 1 1/8 OD X 7 1/8 USABLE PIN, HITCH 3PT CAT 1&2 AG SAFETY CHAIN 6400 LB SCREW JACK 2000# TOP-WND RCR2510 RCR2510 RCR2596 RCR2510 RCR2596 RCR2510 RCR2596 RCR2596 RCR2510 RCR2510 RCR2510 RCR2596 RCR2510 RCR /30/ P

22 Table of Contents Pull Type Axle & Tires Part Number Index P /30/16

23 Table of Contents Part Number Index Section 2: Frame Pull Type Axle & Tires Ref. Part No. Part Description Comments Revision Dwg H H H L L D D H H H K C C C C C C C C C C C C C C C C C C C C C C C C C C C Drawing Image Number SPRING SHOCK WLDMT LONG LEVEL ROD WLDMT WLDMT LEVEL ROD LONG ASSY. LEVEL ROD ASSY. LEVEL ROD TUBE 1 OD X 12 GA X 15/16 LG. SPRING SHOCK SUPPORT AXLE WELDMENT AXLE WELDMENT WLDMT. LEVEL ROD SHORT HUB 5 BOLT COMPLETE HHCS 3/4-10X2 1/4 GR5 HHCS 1/2-13X3 1/4 GR5 BOLT WHEEL 1/2-20X1 90-DEG HHCS 3/4-10X6 1/2 GR5 HHCS 1-8X3 GR5 NUT LOCK 1/2-13 PLT NUT LOCK 3/4-10 PLT NUT HEX JAM 7/8-9 NUT HEX TOP LOCK 1-8 PLT NUT HEX COUPLER 7/8-9 x 5 WASHER FLAT 3/4 USS PLT WASHER FLAT 1 SAE PIN COTTER 5/32 X 1 1/4 LG PIN CLEVIS 3/4 X 1 1/2 PIN, HAIR COTTER 3/16 WIRE DIA PIN CLEVIS 1 X 3 3/16 LG PIN COTTER 3/16 X 1 1/2 PLT PIN CLEVIS 1 X 2 1/4 GR5 PLT SPRING COMP 1.88OD x.362w TIRE & WHEEL LAM. 6X9X21(TALL) WHEEL 15 X 5 X 4 BOLT AC TIRE 24 X 7.7 2PC 4BLT TIRE 24X ( C) RIM 2PC.4BLT 10X6 BLK( C TUBE FOR 24X ( C) SPINDLE, SINGLE BOLT-ON 7/8-14 RATCHET JACK - HEAVY DUT RCR2510 RCR2596 RCR2510 RCR2596 RCR2510 RCR2596 (spindles wellded in) RCR2510 RCR2510 RCR /30/ P

24 Guarding Chain (Applies to RCR2596 only) Table of Contents Part Number Index P /30/16

25 Guarding Chain Table of Contents Part Number Index Section 3: Guards (Applies to RCR2596 only) Ref. Part No. Part Description Comments Revision Dwg A A K K D D D D D D C C C C C Drawing Image Number 96" REAR CHAIN COMPLETE 96" FRONT CHAIN COMPLETE FRONT CHAIN GUARD ASSY. RH FRONT CHAIN GUARD ASSY. LH REAR CHAINGUARD BRACKET RPBY D ROUND ROD.25 X 59 ROD 1/4 X FRONT CHAIN GUARD RH 96 FRONT CHAIN GUARD LH RHSNB 1/2-13X1 GR5 RHSNB 1/2-13X1 1/4 GR5 NUT HEX WHIZ 1/2-13 PLT CHAIN WELD 5/16 PROOF X 5 LINK CHAIN WELD 5/16 PROOF X 4 LINK 08/30/ P

26 Guarding Chain (Applies to RCR2510 only) Table of Contents Part Number Index P /30/16

27 Guarding Chain Table of Contents Part Number Index Section 3: Guards (Applies to RCR2510 only) Ref. Part No. Part Description Comments Revision Dwg A A K K K D D D D D D C C C C Drawing Image Number 3510 REAR CHAIN COMPLETE 2510 FRONT CHAIN COMPLETE ASSY. FRONT OUTER LH. CHNGRD. ASSY. FRONT OUTER RH. CHNGRD. ASSY. FRONT CENTER CHAINGUARD FRT. CHAINGUARD BRACKET CTR. ROD 1/4 X 63 REAR CHAINGUARD BRACKET FRONT CHAINGUARD BRACKET RH FRONT CHAINGUARD BRACKET LH ROUND ROD 1/4 X 32 RHSNB 1/2-13X1 GR5 NUT HEX WHIZ 1/2-13 PLT CHAIN WELD 5/16 PROOF X 5 LINK CHAIN WELD 5/16 PROOF X 4 LINK 08/30/ P

28 Guarding Rubber (Applies to RCR2596 only) Table of Contents Part Number Index P /30/16

29 Table of Contents Part Number Index Section 3: Guards Guarding Rubber (Applies to RCR2596 only) Ref. Part No. Part Description Comments Revision Dwg A A K D D D C C C C C C C Drawing Image Number 96" REAR RUBBER COMPLETE 96" FRONT RUBBER COMPLETE FRONT RUBBER DEFLECTOR ASSY. DEFLECTOR STRAP FRONT DEFLECTOR BRACKET DEFLECTOR STRAP RHSNB 1/2-13X1 1/2 GR5 RHSNB 3/8-16X1 1/4 GR5 RHSNB 1/2-13X1 1/4 GR5 NUT HEX WHIZ 1/2-13 PLT NUT HEX WHIZ 3/8-16 PLT REAR RUBBER DEFLECTOR FRONT RUBBER DEFLECTOR Left Hand or Right Hand 08/30/ P

30 Guarding Rubber (Applies to RCR2510 only) Table of Contents Part Number Index P /30/16

31 Table of Contents Part Number Index Section 3: Guards Guarding Rubber (Applies to RCR2510 only) Ref. Part No. Part Description Comments Revision Dwg A A K K K D D D D D D C C C C C C C C Drawing Image Number 3510 REAR RUBBER COMPLETE 2510 FRONT RUBBER COMPLETE ASSY. FRT. OUTER RH DEFLECTOR ASSY. FRT. OUTER LH DEFLECTOR ASSY. FRONT CENTER DEFLECTOR FRT. DEFLECTOR BRACKET CTR. FRT.CTR.DEFLECTOR STRAP REAR DEFLECTOR STRAP FRONT DEFLECTOR BRACKET LH FRONT DEFLECTOR BRACKET RH DEFLECTOR STRAP RHSNB 1/2-13X1 1/2 GR5 RHSNB 3/8-16X1 1/4 GR5 RHSNB 1/2-13X1 1/4 GR5 NUT HEX WHIZ 1/2-13 PLT NUT HEX WHIZ 3/8-16 PLT FRT. CTR. RUBBER DEFLECTOR REAR RUBBER DEFLECTOR FRT OUTER RUBBER DEFLECTOR Includes 1 Ea #3,4 & 5 08/30/ P

32 Table of Contents Part Number Index Coupler Intermediate C & C P /30/16

33 Table of Contents Part Number Index Section 4: Drivelines Coupler Intermediate C & C Ref. Part No. Part Description Comments Revision Dwg C C C C C C Drawing Image Number CPLR, X1.38-6X10.31 FLE CPLR, X1.38-6X16.56 FLE * WASHER, FLEX COUPLER SHAPED ZERK, M8X1 GREASE BUSHING, 16MM ID COUPLER WLDMNT, DOUBLE FLEX YOKE WLDMNT, DOUBLE FLEX YOKE DISK, FLEX COUPLER RUBBER YOKE, FLEX CONNECTOR YOKE, FLEX CONNECTOR HHCS 3/8-16X1 1/4 GR5 HHCS M16X2.0X65 GR8.8 NUT HEX JAM 3/8-16 PLT NUT HEX NYLOCK M16X2.00 GRB PT RCR2596 (Complete assembly) RCR2510 (Complete assembly) For C RCR2596 For C RCR /30/ P

34 Table of Contents Part Number Index Driveline 540 RPM ( C) Eurocardan P /30/16

35 Table of Contents Part Number Index Section 4: Drivelines Driveline 540 RPM ( C) Eurocardan Ref. Part No. Part Description Comments Revision Dwg C * D D C C C Drawing Image Number PTO CAT. 4 X 20.5 FIXED 540 EC TUBE BEARING (OUTER TUBE) EC STIFFENING RING EC LONG CONE EC STOP RING EC SAFETY SLEEVE EC OUTER TUBE SHIELD EC STANDARD CONE EC CROSS ASSEMBLY EC OUTER TUBE YOKE EC 10X80-DIN-1481 O/TUBE R/PIN EC OUTER TUBE DECAL DANGER GUARD MISS PTO DECAL DANGER PTO DRIVELINE N/A EC GREASE ZERK 8X1 45 DEG. EC YOKE ASSEMBLY EC PULL COLLAR KIT EVOLUTION SHIELD KIT, C Complete assembly 08/30/ P

36 Table of Contents Part Number Index Driveline 540 RPM ( C) Eurocardan (Applies to RCR2510 only) P /30/16

37 Table of Contents Part Number Index Section 4: Drivelines Driveline 540 RPM ( C) Eurocardan (Applies to RCR2510 only) Ref. Part No. Part Description Comments Revision Dwg C * C C C Drawing Image Number PTO STD.W/4-PLATE SC CAT4 540 EC TUBE BEARING (INNER TUBE) EC STIFFENING RING EC SHORT CONE EC STOP RING EC SAFETY SLEEVE EC INNER TUBE SHEILD EC OUTER TUBE SHEILD EC STANDARD CONE EC TUBE BEARING (OUTER TUBE) EC CLUTCH FD4/6 1 3/4 20 SPL EC CROSS ASSEMBLY EC INNER TUBE YOKE EC INNER TUBE 770MM EC 10X70 ROLL PIN EC OUTER TUBE 770MM EC 10X80-DIN-1481 O/TUBE R/PIN EC OUTER TUBE YOKE EC YOKE ASSEMBLY (TRACT. END) DECAL DANGER GUARD MISS PTO DECAL DANGER PTO DRIVELINE N/A EC GREASE ZERK 8X1 45 DEG. EC TWIST COLLAR KIT (TRT. END) EC GREASE ZERK M6X1 STRAIGHT EC YOKE ASSEMBLY (TRACTOR END) EC PULL COLLAR KIT SHIELD KIT, C & C Complete assembly 08/30/ P

38 Table of Contents Part Number Index Driveline 540 RPM ( C) Eurocardan (Applies to RCR2510 only) P /30/16

39 Table of Contents Part Number Index Section 4: Drivelines Driveline 540 RPM ( C) Eurocardan (Applies to RCR2510 only) Ref. Part No. Part Description Comments Revision Dwg C N C C C Drawing Image Number PTO CAT. 4 JACK SHAFT 540 * EC TUBE BEARING (INNER TUBE) EC STIFFENING RING EC SHORT CONE EC STOP RING EC SAFETY SLEEVE EC INNER TUBE SHIELD N/A EC OUTER TUBE SHIELD EC EXTRA SHORT CONE (FOR MX) EC TUBE BEARING (OUTER TUBE) EC OUTER TUBE ASSEMBLY EC 10X70 ROLL PIN EC INNER TUBE ( ) 840MM EC INNER TUBE YOKE EC CROSS ASSEMBLY EC TORQUE LIMITER, (FD 4) DECAL DANGER PTO DRIVELINE DECAL DANGER GUARD MISS PTO EC GREASE ZERK 8X1 45 DEG. EC GREASE ZERK M6X1 EXTRA SHRT SHIELD KIT, C & C Complete assembly 08/30/ P

40 Table of Contents Part Number Index Driveline 540 RPM ( C) Eurocardan P /30/16

41 Table of Contents Part Number Index Section 4: Drivelines Driveline 540 RPM ( C) Eurocardan Ref. Part No. Part Description Comments Revision Dwg C C C C Drawing Image Number PTO STD.W/4-PLATE SC CAT4 540 * EC TUBE BEARING (INNER TUBE) EC STIFFENING RING EC SHORT CONE EC STOP RING EC SAFETY SLEEVE EC INNER TUBE SHEILD EC OUTER TUBE SHEILD EC STANDARD CONE EC TUBE BEARING (OUTER TUBE) EC CLUTCH FD4/6 1 3/4 20 SPL EC CROSS ASSEMBLY EC INNER TUBE YOKE EC INNER TUBE ( ) 620MM EC 10X70 ROLL PIN EC 840MM OUT. STOCK LENGTH TB. EC 10X80-DIN-1481 O/TUBE R/PIN EC OUTER TUBE YOKE YOKE ASSEMBLY PULL TYPE DECAL DANGER GUARD MISS PTO DECAL DANGER PTO DRIVELINE N/A EC GREASE ZERK 8X1 45 DEG. EC TWIST COLLAR KIT (TRT. END) EC GREASE ZERK M6X1 STRAIGHT EC YOKE ASSEMBLY EC PULL COLLAR KIT SHIELD KIT, C & C Complete assembly Shown 08/30/ P

42 Table of Contents Part Number Index Driveline 540 RPM ( C) Eurocardan (Applies to RCR2596 only) P /30/16

43 Table of Contents Part Number Index Section 4: Drivelines Driveline 540 RPM ( C) Eurocardan (Applies to RCR2596 only) Ref. Part No. Part Description Comments Revision Dwg C N/A N C C C Drawing Image Number PTO J/S.W/4-PLATE SC CAT4 540 EC TUBE BEARING (INNER TUBE) EC STIFFENING RING EC SHORT CONE EC STOP RING EC SAFETY SLEEVE EC INNER TUBE SHIELD EC OUTER TUBE SHIELD EC EXTRA SHORT CONE (FOR MX) EC TUBE BEARING (OUTER TUBE) EC OUTER TUBE ASSEMBLY EC 10X70 ROLL PIN EC INNER TUBE ( ) 840MM EC INNER TUBE YOKE EC CROSS ASSEMBLY EC TORQUE LIMITER, (FD 4) RPBY DECAL DANGER PTO DRIVELINE DECAL DANGER GUARD MISS PTO EC GREASE ZERK 8X1 45 DEG. EC GREASE ZERK M6X1 EXTRA SHRT SHIELD KIT, C 08/30/ P

44 Table of Contents Part Number Index Driveline CV Pull Type Cutter 540 RPM ( C) Walterscheid (Applies to RCR2510 only) P /30/16

45 Table of Contents Part Number Index Section 4: Drivelines Driveline CV Pull Type Cutter 540 RPM ( C) Walterscheid (Applies to RCR2510 only) Ref. Part No. Part Description Comments Revision Dwg C C C Drawing Image Number PTO CV 2400 X RPM * WS YOKE 1 3/8-21 SPL WS BOLT M12 X 75 WALTERSCHEID SELF-LCKG HEX NUT WS YOKE 1 3/8-6 ASGE WS GREASE ZERK WS DOUBLE YOKE WS CROSS & BEARING KIT WS INBOARD YOKE WS SPRING PIN 10 X 75 WS PROFILE & SLEEVE WS INNER PROFILE 16 GA WS INBOARD YOKE 1B DECAL DANGER GUARD MISS PTO WS SHIELD CONE 11 RIB WALTERSCHEID SCREW WS BEARING RING - SC25 N/A WS INNER SHIELD TUBE ROUND WALTERSCHEID DANGER DECAL-SHLD WS OUTER SHIELD TUBE OVL. WS SHIELD CONE 3 RIB WS CROSS BEARING KIT WS SUPPORT BEARING WS CV CONE & BEARING ASSY WS ZERK WS QUICK DISCONNECT KIT SHIELD KIT, C WS REINFORCING COLLAR Complete assembly 08/30/ P

46 Table of Contents Part Number Index Driveline Flex Coupler ( C) Eurocardan (Applies to RCR2510 only) P /30/16

47 Table of Contents Part Number Index Section 4: Drivelines Driveline Flex Coupler ( C) Eurocardan (Applies to RCR2510 only) Ref. Part No. Part Description Comments Revision Dwg C * A Drawing Image Number FLEX CPLR TO EC CONNECTION HUB EC WSH. BD. 35mm O.D/16.5mm I.D EC RUBBER DISC EC NUT EC FLANGE WELDMENT EC YOKE 1 3/8 Z6 INDUCT. HARD EC BOLT EC BOLT BUSHING EC WASHER 29.8mm O.D/17.2mm I.D CONICAL DOG KIT EC CROSS ASSEMBLY EC GREASE ZERK M6X1 STRAIGHT FLEX COUPLER KIT (ONE DISC) Complete assembly 08/30/ P

48 Table of Contents Part Number Index Driveline Flex Coupler ( C) Eurocardan (Applies to RCR2596 only) P /30/16

49 Table of Contents Part Number Index Section 4: Drivelines Driveline Flex Coupler ( C) Eurocardan (Applies to RCR2596 only) Ref. Part No. Part Description Comments Revision Dwg C A Drawing Image Number FLEX CPLR TO * EC BOLT EC CONNECTION HUB EC WSH. BD. 35mm O.D/16.5mm I.D EC BOLT BUSHING EC RUBBER DISC EC WASHER 29.8mm O.D/17.2mm I.D EC NUT EC SPIDER TUBE EC GREASE ZERK M8 STRAIGHT FLEX COUPLER KIT (ONE DISC) CONICAL DOG KIT Complete assembly 08/30/ P

50 Table of Contents Part Number Index Driveline Slip Clutch ( ) Eurocardan P /30/16

51 Table of Contents Part Number Index Section 4: Drivelines Driveline Slip Clutch ( ) Eurocardan Ref. Part No. Part Description Comments Revision Dwg A Drawing Image Number EC CLUTCH FD4/6 1 3/4 20 SPL * RPBY A EC CLUTCH YOKE W/FLANGE EC CLUTCH BUSHING EC CLUTCH LINING RING EC CLUTCH MIDDLE DISK EC INNER DISK EC HUB WITH FLANGE EC CONICAL DOG KIT REPLACEMENT EC PRESSURE DISK EC BOLT & SCREW NUT KIT REPL. SV KIT, EC SLIP CLUTCH SPRING Complete assembly 1 3/4-20 Contains 8 Springs 08/30/ P

52 Table of Contents Part Number Index Driveline Slip Clutch ( ) Eurocardan P /30/16

53 Table of Contents Part Number Index Section 4: Drivelines Driveline Slip Clutch ( ) Eurocardan Ref. Part No. Part Description Comments Revision Dwg C A Drawing Image Number EC CLUTCH FD4/6 1 3/4 20 SPL * NUT HEX M10X1.5 PLT RPBY A EC CLUTCH YOKE W/FLANGE EC CLUTCH BUSHING EC CLUTCH LINING RING EC CLUTCH MIDDLE DISK EC INNER DISK EC HUB WITH FLANGE EC BOLT (M14X80) EC SCREW NUT (M14) EC WASHER (d14) EC PRESSURE DISK EC BOLT (M10X100) SV KIT, EC SLIP CLUTCH SPRING Complete assembly Contains 8 Springs 08/30/ P

54 Table of Contents Part Number Index Driveline Slip Clutch ( ) Eurocardan P /30/16

55 Table of Contents Part Number Index Section 4: Drivelines Driveline Slip Clutch ( ) Eurocardan Ref. Part No. Part Description Comments Revision Dwg C A Drawing Image Number EC TORQUE LIMITER, (FD 4) * EC CLUTCH YOKE W/FLANGE EC HUB WITH FLANGE NUT HEX M10X1.5 PLT EC BOLT (M10X100) EC BOLT & SCREW NUT KIT REPL. SV KIT, EC SLIP CLUTCH SPRING EC PRESSURE DISK EC INNER DISK EC CLUTCH LINING RING EC CLUTCH MIDDLE DISK EC CLUTCH BUSHING EC BOLT, NUT & WASHER KIT Complete assembly 08/30/ P

56 Table of Contents Part Number Index Driveline Stub Shaft Pull Type 540 RPM ( C) Eurocardan (Applies to RCR2510 only) P /30/16

57 Table of Contents Part Number Index Section 4: Drivelines Driveline Stub Shaft Pull Type 540 RPM ( C) Eurocardan (Applies to RCR2510 only) Ref. Part No. Part Description Comments Revision Dwg C D S D C C Drawing Image Number PTO W/STUB SHAFT/SC /4 * EC TUBE BEARING (OUTER TUBE) EC STIFFENING RING EC SHORT CONE EC STOP RING EC SAFETY SLEEVE N/A EC OUTER TUBE SHEILD EC EXTRA SHORT CONE (FOR MX) EC OUTER TUBE ASSY (HRDND) EC OUTER TUBE ASSY EC 10X80-DIN-1481 O/TUBE R/PIN EC OUTER TUBE YOKE EC CROSS ASSEMBLY EC TORQUE LIMITER, (FD 4) RPBY DECAL DANGER PTO DRIVELINE DECAL DANGER GUARD MISS PTO EC GREASE ZERK 8X1 45 DEG. Complete assembly Rev. 2 Rev. 1 08/30/ P

58 Table of Contents Gearbox ( C) Comer Part Number Index P /30/16

59 Table of Contents Part Number Index Section 5: Gearboxes Gearbox ( C) Comer Ref. Part No. Part Description Comments Revision Dwg C Drawing Image Number GBOX 1:1.50 STD SPL. * REP BY A CO BOLT M8X22 HHB 8.8 CO 1/2" GAS OIL PLUG W/EMB HEX CO COVER CO CROW Z21 M5.7 REP BY C CO CASTING & MACHINING CO SNAP RING INT 72 UN17437 CO OIL SEAL 35 X 72 X 10 CO INPUT SHAFT CO NUT M30 X 1.5 CO CONIC PIGNON Z14 M5.7 CO SHIM 50.3X70.3 REP BY CO SEAL (50x90x10) CO SEAL RETAINER CO COTTER PIN B4 X 50 CO OUTPUT SHAFT CO BLANK WASHER CO CASTLE NUT M30X2 (8.8) CO PLUG 3/8 GAS REP BY C CO CAP 72 X 10 CO SHIM 44X30.3X1 CO COTTER PIN B6 X 60 CO 1/2" GAS BREATHER PLUG * Notes: Oil Type 80-90W Capacity 2.5 Pints Complete assembly 08/30/ P

60 Table of Contents Part Number Index Gearbox, T-Box 540 RPM ( C) Comer P /30/16

61 Table of Contents Part Number Index Section 5: Gearboxes Gearbox, T-Box 540 RPM ( C) Comer Ref. Part No. Part Description Comments Revision Dwg C A Drawing Image Number T-BOX :1.35 * CO CASING CO NUT LOCK M45 X 1.5 CO BOLT M10X22 HHB CO THROUGH SHAFT 1 3/4" Z20 CO SHIM 45.3X2.5 CO LABEL CO GEAR CROWN Z27 M5.7 CO GEAR PINION Z20 M5.7 CO SHIM (45.3X65.3X1) CO PARALLEL KEY B 14 X 9 X 40 CO DUST LIP 45 X 72 X 8 CO COVER CO RL BRG (45X100X27.25) CO INPUT SHAFT 1 3/4" Z20 CO EXTENSION CO BEARING CO OIL SEAL 52 X 85 X 10 CO SHIM 65.3MM RTA25 CO PLUG 3/8 GAS CO OIL FILLER PLUG 3/8 * Notes: Oil Type 80-90W Capacity 4.5 Pints Complete assembly 08/30/ P

62 Table of Contents Hydraulic Cylinder ( C) Midway Part Number Index P /30/16

63 Table of Contents Part Number Index Section 6: Hydraulics Hydraulic Cylinder ( C) Midway Ref. Part No. Part Description Comments Revision Dwg C 5M3116 2M3316 1M6006 2A0012 2A0006 7M3316 2A0012 3M3310 4M3108 4M3102 6M3126 2A0022 2A0208 2A C Drawing Image Number CYL 2.5X8X1.12 ROD (TIE)1 PIN * MW TUBE 2-1/2 X 8 X 1-1/8 ROD MW ROD MW ROD CLEVIS MW NUT CLEVIS & TIE ROD MW CAPSCREW MW TIE ROD MW NUT CLEVIS & TIE ROD MW HEAD O-RING BACK-UP WIPER SEAL O-RING MW PISTON RPBY 4M3108 MW BASE MW NUT, PISTON BACK-UP MW CLEVIS PIN MW PIN CLIP SEAL KIT MW 2.5 CYL 3A3102 Complete assembly Only found in seal kit item 19 Only found in seal kit item 19 Only found in seal kit item 19 Only found in seal kit item 19 Only found in seal kit item 19 08/30/ P

64 Table of Contents Part Number Index Hydraulic Cylinder ( C) Red Lion P /30/16

65 Table of Contents Part Number Index Section 6: Hydraulics Hydraulic Cylinder ( C) Red Lion Ref. Part No. Part Description Comments Revision Dwg C C C N/A N/A N/A N/A N/A N/A C Drawing Image Number CYL 2.5X8X1.12 ROD (TIE)1 PIN * NUT HEX 3/8-16 PLT MON PISTON NUT LION PIN MON CLEVIS PIN COTTER SCREW SET SH 3/8-16X3/8 TYPE C PLUG 9/16-18UNF MORB SOCKET HD MON ROD SEAL MON PISTON SEAL MON END CAP BACKUP WASHERS MON END CAP O-RING LION WIPER SEAL MON PISTON WEAR RING LION CYL. TUBE 2.5 X 8 LION TIE ROD 3/8, 8 CYL LION ROD CLEVIS 1 1/8-12UNF LION CLEVIS CAP 2.5, 9/16 ORB LION ROD ASAE 8 MON ROD CP /16ORB-TS MON PISTON TSS-ISO-WR MON SEAL KIT Complete assembly Only Found in Kit #20 Only Found in Kit #20 Only Found in Kit #20 Only Found in Kit #20 Only Found in Kit #20 Only Found in Kit #20 08/30/ P

66 Decals Table of Contents Part Number Index P /30/16

67 Decals Table of Contents Part Number Index Section 7: Decals Ref. Part No. Part Description Comments Revision Dwg C C C C C C C C C C C C C C C C Image No. DECAL CAUTION 540 RPM DECAL DANGER PTO DRIVELINE EN DECAL FLAG DECAL RC120 BLADE ROTATION DECAL DANGER PD GUARD MISS SML DECAL DANGER PTO DRIVELINE DECAL DANGER THROWN OBJ CUTTER DECAL DANGER ROTATING BLADES DECAL SAFETY COMBO SUNWEST DECAL 5 YEAR GEARBOX WARRANTY GREAT PLAINS - LP I.D. DECAL DECAL REFLECTOR RED 2X9 DECAL REFLECTOR AMBER 2X9 DECAL RCR2510 GREAT PLAINS DECAL RCR2596 GREAT PLAINS DECAL GREATPLAINS 25" CTR LOGO 08/30/ P

68 Table of Contents Part Number Index Part Number Index The Part Number Index is a numeric index of all part numbers included in this manual. The index shows what page(s) the part is used on. Part Number Page Part Number Page Part Number Page Part Number Page *... 19, 33, 35, 37, 39, 41, 45, 47, 49, 51, 53, 55, 57, 59, 61, 63, , , , 37, 39, 41, 43, 47, , 37, , 53, , 53, , , 37, 39, 41, 43, , 37, 39, 41, 43, , , 41, , 53, , 43, 55, D , , 53, , , 37, 41, , 39, 41, , 53, , , 53, , , 37, 39, 41, 43, , 39, 41, , 53, D D , 39, 41, 43, , 37, , 43, , 37, 39, 41, 43, D S N N M D A A A A A M S...13, D D H H A A H H H H...21, A H L...21, A...47, D H...21, A D A L...21, S D D D D H H H A A K K K K K K H H A A K K K D H D D D D D D D D D D D D D D D D D D D D D D D D D H...21, D A D D D D D D D D D D D D D H S D D A...51, 53, K...17, M M M M , , , 39, 41, , 37, 41, , , , 41, , 37, 39, 41, 43, , , , M M , P /30/16

69 Table of Contents Part Number Index Part Number Index (continued) Part Number Page Part Number Page Part Number Page Part Number Page C C C C...7, C C C C C C C...9, C C...11, C C C C...13, C C C...7, 29, C C C C...29, C C C...25, C C...25, 29, C C C C C C C...13, C C C C C C C C C...15, C C...7, 13, 19, C C... 7, 9, 25, 27, 29, C...21, C...13, 21, C C C...13, 29, C C...21, C C...53, C C C C C C C C...7, C C C C C...13, C C...13, 21, C C C C C C C C C...13, C...21, C C...21, C...13, 19, 21, C...13, C C C C C C C...13, C...13, C C C C...19, 63, C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C... 35, 37, 39, 41, 43, 45, C C... 35, 37, 39, 41, 43, 57, C C C C C C C C C C C C C C C C C C C C C C...9, C...15, C...11, C...15, C...9, C...11, C...15, C...11, C...11, C C C C C C C C C C C...11, C...11, C C C C C C C C C C C C C...25, C C...25, C C...21 A Dwg Dwg Dwg Dwg , 43 Dwg Dwg Dwg , 41 Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg N/A... 11, 21, 35, 37, 39, 41, 43, 45, 57, 65 08/30/ P

70 Great Plains Mfg., Inc E. North Street Salina, Kansas USA