Zip's Truck Equipment. 316 W. Milwaukee Street New Hampton, Iowa Phone: Fax: Visual Inspection.

Transcription

1 Zip's Truck Equipment 316 W. Milwaukee Street New Hampton, Iowa Phone: Fax: Visual Inspection Page: 1 of 8 Customer: Division: Address: Phone: Reference #: 1GBJC34D26E Equipment Type: Light-Duty Tow Truck Order #: Event Performed: Light Duty Wrecker Inspection Inspected On: 01/26/15 2:17 PM CST Result: Pass Total Score: Inspected By: : Michigan Shop Service Tech 1 Light-Duty Tow Truck- * Year: 2006 * Make: Chevrolet * Model: 3500 * Engine Make: Duramax * Engine Model: 6.6L * Horse Power: 360 * Fuel Type: Diesel * Transmission Type: Automatic * Transmission Brand: Allison * Odometer Reading: Rear Vision Camera System/Brand: Remote Keyless Entry: * Cab to Axle: 84" * Wheel Base: 162 Wheel Type: Steel * Cab Color ONLY: Red * Body Make: Century * Body Model: 411 * Body Serial Number: C96 Body Width: 86" * Beacon/Lightbar Make: * Beacon/Lightbar Model: Directional Lightbar/Brand: Federal Signal JetStream Work Lights In Lightbar: PTO Type: Switch Panel & # Of Switches: In Cab Rear Throttle: Rear Throttle: Remote Controls: * Wrecker Body/Pylon Color: Clutch Pump Switch Panel - 5 Red * Brake Type: Hydraulic * Suspension Type: Spring * Air Compressor-FOR Brake System: Engine Brake: * Air ing: Air Horn: * Radio: AM/FM Navigation System/Brand: * Driver Seat: Split Vinyl w/head Rests Windows: Door Locks: Window Deflectors: Rear Sliding Window: Cruise Control: Tilt Steering Wheel: Flooring: Floor Mats: Bug Shield: Manual Crank Manual Rubber or Vinyl

2 Page: 2 of 8 Sunvisor: * Bumper: Chrome Grille: Chrome Front Tow Hooks: 2 Engine Block Heater: Extra Lights On CAB/Where: Jumper Cable Plug/Where: Jumper Cable: Running Boards/Nerf Bars: Mirrors: Vertical Exhaust Stack: Cab Roof Marker Lights: Tread Type Rear: - Front Bumper Nerf Bars Painted Swing Out Mud & Snow * Tire Size-Front: 215/85R16 Tire Depth-Front: 2/32 * Tire Size-Rear: 215/85R16 Tire Depth-Rear: 4/32 Top Hat Kit: Lug Nut Covers: * Tow Sling: Truck Bar/Hitch (Medium Duty): # of Winches: 1 Winch Brand: Winch Capacity: Winch Work Lights: Winch Clutch Release: Cable Tensioner: Cable Roller Guide: Boom Cable Wings: Pylon: Aluminum Dress Up Inside Pylon: Work Lights: Stop/Turn/Tail On Pylon: Extra Lights on WRECKER/Where: Toolbox System: Ramsey 8,000# Worm Type Mechanical Standard Steel Tunnel Toolbox/Size: 18" Lighted Toolboxes: Dri-Dek In Toolboxes: Air Hose Reel w/hose/where: LH & RH Auxiliary Air Compressor: Dri-Dek On Wrecker Top: Dual Controls: Rear Safety Chains: Light Plug Ins: Hook Up Lights: CR6 * Wheel Lift: with L-Arms Wheel Lift Style: Rear Hydraulic Stiff Legs: Live Air Hook Up/Where: Aluminum Rail Caps: Aluminum Dress Up: Wheel Lift Controls On Tailboard: Self Loading Dollies: Self Loading Dolley Mounts: GoJaks: Hand Rails: J-Chains & #: Straps/Rachets: Frame Fork Adapters: Frame Forks: Fire Extinguisher: Tow Light System: Warning Triangle Kit: Wheel Lift Spade: Gas Cans/Holders/Where: Trash Cans/Holders/Where: Trailer Hitch: Snatch Blocks: Special Equipment Storage/Where: Basic L-Arm Style ne Engine Check Ability to Start Engine Blow-By Check Engine Engine ise Engine Warning Lights Engine Water Leaks Performance Starts rmally ticeable Blow-By Issue Oil leak observed (see Engine sounds are normal Check Engine Lights are on Leaks Water (see rmally -Appears to be coming from top of engine and dripping down. Possibly turbo or intake -Signs of coolant leaking mixed in with oil leak.

3 Page: 3 of 8 Engine Check Engine Mounts Other Engine tes Engine Brake Batteries of Cables of Batteries Load Testing Do t Hold -Pass side battery bad Charge Due to Battery -Pass side battery failed Fail Cooling System Radiator Fan Fan Clutch Fan Shroud Water Hoses Fan Belt Other Cooling tes Automatic Transmission Check Transmission Operation Other Transmission tes Manual Transmission Check Shifting Clutch Operation Throw-Out Bearing Transmission ise Other Transmission tes Overall Body Overall Other Overall Body notes Transmission rmally Cab Exterior Hood Dented or Cracked Cab Exterior Passenger Side Door Roof Other Cab Exterior tes Fuel Tank Appearance Entry Steps Head-Light Doors Battery Box Driver Side Door Hinges Passenger Side Door Hinges Front bumper bent Worn - Should Be Replaced Worn - Useable -Loose Glass Windshield Driver Side Window Passenger Side Windw Back Window Other Glass tes Overall Interior Overall Other Overall Interior tes Rear view mirror separating -Mirrors rattle, rear view separating Interior Drivers Seat Needs Repair -Bottom tore up Upper seat movement inop Right Fender Left Fender Grille Back of Cab Driver Side Door In Dented -Bottom edge of door rusty dented Passenger Seat Rear Seat Floor Mat Instrument Cluster Dash Door Panels In -Drivers door missing reflector

4 Page: 4 of 8 Interior Electric Door Locks Electric Windows Other Interior tes Air Vents Door Handles Other Interior tes Manual locks Manual windows Speaker problem Headliner falling down -Pass side lock froze -Rf speaker blown LF inop -Headliner falling Windshield Wipers Wiper Arms Wiper Blades Washer Tank Washer Control Switch In Operative Heating Heater Controls Fan Motor Heater Other Heat tes Heats Appropriately Air ing Overall Air ing Controls Electrical System- Chassis Interior lights Turn Signals Head Lights Alternator Guages Dash Lights Cab Marker Lights Back-Up Lights Back-Up Alarm 4-Way Flashers Windshield Wipers Other Electrical System tes Cruise Control Engine Throttle Operating All Interior Light Operate Operate rmally Operate rmally rmally All Gauges Perform Properly Dash Lights Inoperative (see Marker Lights Perform rmally Operate rmally rmally rmally Perform rmally N/A N/A -Problem with switch, High beams stick on -Headlight switch out, middle of hvac out, RH side radio out, oil fuel speedo and tach partially out -Installed new beeper Drive-Line U-Joints Rear Differential Transfer Case Other Drive-Line tes Hangar Bearings In good condition In Brakes Air Compressor System Air Leaks Applied Brakes Brake Adjusters Air Lines Brake apply normally Brakes Low Air Pressure Warning Front Brake Drums Brake Drums Front Brake Calipers Brake Drums Front Brake Linings Rear Brake Drums Rear Brake Calipers Brake Linings Brake Linings Rear Brake Linings Emergency Brake ABS Light Brake Pedal Pads Other Brake tes Air Dryer 60 or Better - on truck visual Under 50% Doesn't Hold Properly - Needs Repair Showing rmal (t on) -Replace -Cables look chafed and rusted - Wheels Front Axle Rims/Wheels Rims/Wheels Rims/Wheels Rear Rims/Wheels Fronts Axle Nut and Studs Nut and Studs Nuts and Studs (2) (2) Rear Nuts and Studs Wheel Simulators Front Axle Wheel Simulators Wheel Simulators Wheel Simulators Rear Aluminum Wheels Front Axle Aluminum Wheels Aluminum Wheels Front Aluminum Wheels Rear Wheel Wheel -Center caps missing Wheel Hubs Front Wheel Seals Wheel Bearings Front Wheel Bearings Wheel Seals Wheel Seals Oil Filled Hubs Front Rear Wheel Seals Oil Filled Hubs Front Axle Wheel Bearings Oil Filled Hubs Oil Filled Hubs Rear Rear Wheel Bearings -Center cap missin LH nut caps missing

5 Page: 5 of 8 Tires Front Axle Rear tes on Tires Tread is at Wear Bars or Less Tread is less than 50% -Replace -4/32 replace Exhaust Systen Manifold Exhaust Tubing Muffler DPF System Emnsions Warning Light Exhaust Shield Exhaust Stack Exhaust Mounting Bracket Condtiion Frame Integrity of Frame In good Suspension Air Bags Air Leaks Air Lines Spring Packs Front Spring Hangars Rear Spring Hangars Radius Arms Rear Suspension Bushings Air Leveling Valve Steering and Front Axle Steering Pump Steering Lines Steering Sector King Pins/Ball Joints Steering Shaft Pitman Arm Drag Link Tie Rod Toe in Check 4x4 Hubs Steering Wheel rmally Leak Operating Need Replacing U-Joints Loose or Worn Loose or Worn Jointss t Checked Wheel has Cosmetic Issues -Rear overload bump stops torn up -RH bottom overload spring crooked -Line from hydro boost to pump leaking -LH upper and lower bad -Clunk noise from firewall -Small amount of movement in idler arm -RH inner and outer LH outer -Soft and deteriorating Steering and Front Axle Steering Wheel Position Wheel is Centered When Driven Fuel System Fuel Gauge Fuel Tank Fuel Fill Fuel Lines Fuel Filter Glow Plugs or Exhaust Heater Glow Plug Operation Intake Manifold Heater Works rmally Fills rmally t Replaced -Looks fairly new Fluids Windshield Washer Engine Oil Radiator Anti-Freeze Transmission Fluid Transfer Case Oil Rear Battery Acid Levels Hydraulic Oil Brake Fluid Power Steering Fluid Winch 1 Oil Winch 2 Oil Winch 3 (Above Cab) Oil Full Needs to be changed Low Full Full At Proper Level At Proper Level At Proper Level Filled to Proper Level -Change -Only good to +5F Flush system Filters Water Filter Engine Oil Filter Transmission Oil Filter Fuel Filter Carrier Hydraulic System Overall Wrecker Body Overall Wrecker Body Body Sides Body Deck Original (t replaced) Original (t replaced) Original (t replaced) t Changed Poor Surface Rust (See Rust Holes in Floor -Replace -Looks fairly new -Replace -Very rusty but seem solid

6 Page: 6 of 8 Wrecker Body Front of Body Body Side Side Rail Cap (2) Driver Side Tool Box 1 Passenger Side Tool Box 1 Tunnel Tool Box 1 Tail-Board Surface Rust (See Surface Rust in Rails (See In Fair In Fair Rusty - Minor Spots -Latches bad -Latches bad -Small bend LH taillight Power Take-Off Operation PTO Warning Light Shifting Mechanism Air Leaks Inoperative Electrical Switch Working Properly -Inop Hyraulic Pump Operation Pump Pressure Pump Flow at Pump Pump rmally Appears to Operate Equipment rmally - t Tested t Tested Controls & Valve Operation Control Levers and Rods -Pressure hose wet at pump no drips noticed during testing rmally Loose and Worn Pins and -Levers very loose Rod Connections Controls & Valve Knobs Hydraulic System Hoses Hydraulic System Leaks Winch Hoses Boom Lift Hoses Boom Extension Hoses Wheel-Lift Tilt Hoses Wheel-Lift Extend Hoses (2) Wheel-Lift Up/Down Hoses (2) Hydraulic Pump Hoses Hydraulic Filter Bed Lift s Extend Wheel-Lift Tilt Wheel-Lift Extend Wheel-Lift Claw Drivers Side Wheel-Lift Claw Passenger Side In Operating -Lettering worn down Boom Lift Boom Extend Wheel-Lift Extend Wheel-Lift Tilt Wheel-Lift Lift Wheel-Lift Lift Claw s Minor Leaks Around Shaft rmally Major Leaks at the Shaft Minor Leaks Around Shaft Minor Leaks Around Shaft Pylon Overall with Minor Scratches/Den ts Winch Free-Wheel Mechanism Winch 1 Free-Wheel Mechanism Winch 2 Free-Wheel Mechanism Winch 3 Housing Winch 1 Housing Winch 2 Housing Winch 3 Operation Without Load Operation Without Load tes Test Operation Loaded Test Operation tes Winch 1 Cable Winch 2 Cable Winch 3 Cable rmally rmally -Unable to visually see, inside of tube wet and dripping -Needs new clip Wheel-Lift L-Arms/Scoops Cracked -Rusted through from inside

7 Page: 7 of 8 Wheel-Lift L-Arm Straps Broken or Frayed Straps -One missing other frayed badly ratchet broken Wrecker Electrical Systems L-Arm Storage -ne Driver Side Claw Passenger Side Claw Driver Side Slide Tray Passenger Side Slide Tray Passenger Side Slide Tray Locks Driver Side Slide Tray Locks Driver Side Front Stops (Vulcan) Passenger Side Front Stops (Vulcan) Driver Side L-Arm Swivel Passenger Side L-Arm Swivel Center Pivot Pin and Bushing Wheel-Lift Cross-Bar Worn and in Need of Replacement Worn at Pivot Point Needs Repair -Extremely loose Bed Wiring Harness Junction Boxes Marker Lights Driver Side Turn Signals Upper Passenger Side Turn Signals Upper Driver Side Turn Signals Upper Lower Passenger Side Turn Signals Lower Extra Warning Lights Extra Clearance Lights UpperWork Lights Lower Work Lights In In In In In -Grommet ripped -Bad grommet -Installed new lights and ran new wiring Pins and Bushings Extension Tube Outer Wheel-Lift Assembly Wheel-Lift Swivel Lock Pins Wheel-Lift Swive Removeable Lock Pins Scoop Locking Pins and Chains Driver Side Claw s Main Pivot Pin for Tilting Wrecker Electrical Systems Switch Panel Overall Wiring Worn and in Need of Replacement In Fair Pin Loose or Worn In -Holes are egged out -Wear pads worn down or missing -Holes egged out Work Lights Mounted Near Winch Beacon Light 2 Beacon Light 3 Beacon Light 1 Tow Light Plug at Tail-Board In Tool Boxes Box Driver Side 1 Box Driver Side 2 Box Passenger Side 1 Box Passenger Side 2 Rusty but Usable Rusty but Usable Rusty but Usable Rusty but Usable Fenderettes Drivers Side Passenger Side Wrecker Lubrication Lift Pins Tilt Pins Wheel-lift Tilt Pin Wheel-Lift Cross-Bar Pivot Pin Upper Wheel-Lift Extension Slide Pads Lower Wheel-Lift Extension Slide Pads (2) Wheel-Lift Lift Tower Wear Pads Wheel-Lift Arm Pins and Bushings Tool Box Hinges and Latches Appears to Have Been Regularily Serviced In Need of Lubrication -Latch bad, spring assist stiff -Latch bad, spring assist stiff -Latch bad, spring assist stiff -Latch bad, spring assist stiff Chains

8 Page: 8 of 8 Chains Rear Safety Chains J-Hook Chains Broken or Broken or -Needs new clips - Tow Sling Sling Arms Sling Belts Cam Locks In Need of Repair Operating -Cam locks broken Top Lift Bar Lower Lift Bar Chassis Lubrication King Pins/Ball Joints Tie-Rod Ends Drag Link Steering Shaft Drive-Line U-Joints Spring Shackles Door Locks and HInges Wrecker Mounting System Front Bed Mounting Brackets Rear Bed Mounting Brackets (2) Appears to Have Been Regularily Serviced Appears to Have Been Regularily Serviced Lubricated Bolts are Loose or Brackets and Bolts in Shock Absorbers Front Shocks Rear Shocks -Brackets worn around bolts