Zip's Truck Equipment. 316 W. Milwaukee Street New Hampton, Iowa Phone: Fax: Visual Inspection. Order #: Comments:

Transcription

1 Zip's Truck Equipment 316 W. Milwaukee Street New Hampton, Iowa Phone: Fax: Visual Inspection Page: 1 of 7 Customer: Division: Address: Phone: Reference #: 1HTMMAAL97H Equipment Type: Car Carrier Order #: Event Performed: Car Carrier Inspection Inspected On: 12/04/14 2:47 PM CST Result: Pass Total Score: Inspected By: : Iowa Inspector Shop Car Carrier- * Year: 2007 * Make: International * Model: 4300 * Drive Type: 2 Wheel Drive * Engine Model: DT466 * Horse Power: 220 * Fuel Type: Diesel * Transmission Type: Automatic * Transmission Brand: Allison * Transmission Model: 2200 * Odometer Reading: Unknown Hour Meter Reading: Unknown * GVW: 25,000# * Body Serial Number: 21S GD07 Body Width: 96" PTO Type: Switch Panel & # Of Switches: In Cab Throttle: * Bed/Side Puller/Pylon Color ONLY: Hot Shift In Dash * Brake Type: Air Black * Suspension Type: Air Ride * Air Compressor-FOR Brake System: * Radio: Navigation System/Brand: * Driver Seat: Vinyl Air Ride High Back * GAWR Front: 8,000# * GAWR Rear: 17,500# * Rear Ratio: 4.33 Rear Vision Camera System/Brand: Remote Keyless Entry: * Cab to : 144" * Wheel-Base: 211" Wheel Type: Steel * Cab Color ONLY: Red * Body Make: Century * Body Length: 21' * Body Model: Steel Passenger Seat: Windows: Window Deflectors: Rear Sliding Window: Door Locks: Cruise Control: Tilt Steering Wheel: Air Horn: Flooring: Floor Mats: Bug Shield: Sunvisor: Vinyl 2 Man High Back Power Power Tilt Rubber or Vinyl

2 Page: 2 of 7 * Bumper: Chrome Front Tow Hooks: Engine Block Heater: Grille: Running Boards/Nerf Bars: Mirrors: Additional Mirrors: Spot Light: Fuel Tank/Where: Chrome Fuel Tank Gallons: 55 Cab Roof Marker : Power/Heated/Lighted Swing Out Convex Mirrors ne 1 Steel * Tire Size-Front: 245/70R19.5 * Tire Size-Rear : 245/70R19.5 Carrier Body Fenders: Sub-Frame Finish: Side Rails: Rub-Rails: # of Winches: 1 Winch Brand: Winch Capacity: Winch Clutch Release: Winch Work : Cable Tensioner: Cable Roller Guide: Remote Control: Pylon/Cab Guard: Work : Stop/Turn/Tail On Pylon: Bed Mounted D-Rings & #: Stake Pockets & #: Key Slots & #: Bed Floor Type: Stainless Steel 1/4 Fenders Painted Steel Removable Ramsey 8,000# Worm Type Standard Steel 6 NA 8 Key Slots 1/4" Deck Plate Toolbox System/Where: 4 Steel Toolboxes 60" Open Top Storage & Size: Dri-Dek In Toolboxes: Air Hose Reel/Mounted Where: Auxiliary Air Compressor: Snatch Blocks: V-Chain/V-Strap Assemblies: NA ne J-Chains & #: Straps/Rachets: Fire Extinguisher: Warning Triangle Kit: Tow Light System: Dual Controls: Front/Rear Safety Chains: Light Plug Ins: Hook Up : * Wheel Lift/Wheel Lift Arms: Live Air Hook Up/Where: Gas Cans/Holders/Where: Trash Cans/Holders/Where: Self Loading Dollies: Go-Jaks: ne Both CR6 Inspector Name Enter name here Justin and joe Engine Check Ability to Start Engine Blow-By Check Engine Engine ise Engine Warning Engine Water Leaks Performance Engine Mounts Other Engine tes Engine Brake Starts rmally ticeable Blow-By Issue Observed Engine sounds are normal Check Engine are on Water Leaks rmally Batteries of Cables of Batteries Load Test Pass -Installed alternator, serpentine belt and new fuel filter and now runs -Installed new batteries Cooling System Radiator Fan Fan Clutch Fan Shroud Water Hoses Fan Belt Other Cooling tes Automatic Transmission Check Transmission Other Transmission tes Conditon Transmission rmally -Replaced old one was gone

3 Page: 3 of 7 Manual Transmission Check Shifting Clutch Throw-Out Bearing Transmission ise Other Transmission tes Overall Body Overall Other Overall Body notes Cab Exterior Hood Right Fender Left Fender Grille Back of Cab Driver Side Door Passenger Side Door Roof Other Cab Exterior tes Fuel Tank Appearance Entry Steps Head-Light Doors Battery Box Driver Side Door Hinges Passenger Side Door Hinges Scratched Scratched Scratched Rusty and in Paint Bent Rusty - Needs Paint Worn - Should Be Replaced -Piece broken on inside bottom -Scratched on door -Scratched on door -Outside of tank rusty on driver side of truck - but rusty Front Bumper Factory Front Bumper Front Push Bumper Glass Windshield Driver Side Window Passenger Side Windw Back Window Other Glass tes Overall Interior Overall Other Overall Interior tes -Binding when opening door Interior Drivers Seat Passenger Seat Rear Seat Floor Mat Instrument Cluster Dash Door Panels Electric Door Locks Other Interior tes Electric Windows Needs Other Issues (see ) Fair Operate Properly -Ripped on seat cushion -Needs cleaned and put back in the truck -Radio and lower shelf need put together Interior Door Handles Air Vents Headliner Other Interior tes Door Seals Floor Mats Seat Belts or In -Ripped on driver side Windshield Wipers Wiper Arms Wiper Blades Washer Tank Washer Control Switch on driver side Heating Heater Controls Fan Motor Heater Other Heat tes Heats Appropriately Air ing Overall Air ing Controls Electrical System- Chassis Interior lights Turn Signals Head Alternator Guages Dash Cab Marker Back-Up Back-Up Alarm 4-Way Flashers Windshield Wipers Other Electrical System tes Cruise Control Engine Throttle Problem with Interior (see ) Operate rmally Head-Light Bulb Problem rmally All Gauges Perform Properly Dash Inoperative (see ) Individual are Inoperative (see Comment) Operate rmally rmally rmally Inoperative rmally rmally (te Type) on driver side replace both -Some light laying on floor needs fixed -t working on driverside Drive-Line U-Joints Rear Differential Transfer Case Other Drive-Line tes Hanger Bearings In good condition -Was missing alternator insulted new alternator -Fuel gauge don't light up and alt. gauge don't light up -Ab marker light second one in on the driverside arm and wiper blade on driverside -Fluid level needs checked

4 Page: 4 of 7 Brakes Air Compressor System Air Leaks Air Dryer Applied Brakes Brake Adjusters Air Lines Low Air Pressure Warning Front Brake Drums Brake Drums Front Brake Calipers Front Brake Linings Brake Drums Brake Linings Brake Linings Brake Drums Rear Brake Calipers Brake Linings Emergency Brake ABS Light Brake Pedal Pads Other Brake tes Air leaks -Need to find leak down -Works good but needs serviced rmally Brake apply normally rmally - from On Truck Inspection 50% or Better - on truck visual 50% or Better Worn Shock Absorbers Front Shocks Rear Front Shocks Wheels Front Nuts and Studs (2) (2) Fronts Nut and Studs Nut and Studs Nuts and Studs Wheel Simulators Front Wheel Simulators Wheel Simulators Wheel Simulators Rear Aluminum Wheels Front Aluminum Wheels Aluminum Wheels Front Aluminum Wheels Rear Wheel Wheel Wheel Hubs Front Wheel Seals Wheel Seals Wheel Seals Wheel Seals Leaking -Worn but will work for truck -Leaking on passenger side Wheel Hubs Oil Filled Hubs Front Oil Filled Hubs Oil Filled Hubs Front Oil Filled Hubs Rear Front Wheel Bearings Wheel Bearings Wheel Bearings Wheel Bearings Checked In t Checked Tires Front tes on Tires Tread is at Wear Bars or Less In Fair 50% or Better -Will check when doing wheel seal -Steer tires need replaced Exhaust Systen Manifold Exhaust Tubing Muffler DPF System Emnsions Warning Light Exhaust Shield Exhaust Stack Exhaust Mounting Bracket Conditon Showing rmal Condtiion Frame Integrity of Frame In good Suspension Air Bags Air Leaks Air Lines Spring Packs Front Spring Hangars Rear Spring Hangars Radius Arms Rear Suspension Bushings Air Leveling Valve Steering and Front Steering Pump Steering Lines Steering Sector King Pins/Ball Joints Steering Shaft Pitman Arm Drag Link Tie Rod Mounting Brackets Corroded or Cracked Air Leaks ticed In rmal rmally -One bag on passenger side rear not airing up -Just need greased

5 Page: 5 of 7 Steering and Front Toe in Check 4x4 Hubs Steering Wheel Steering Wheel Position t Checked Steering Wheel in Poor Cosmetic Steering Wheel In Correct Postion When Driven -Needs checked Fuel System Fuel Gauge Fuel Tank Fuel Fill Fuel Lines Fuel Filter Glow Plugs or Exhaust Heater Glow Plug Intake Manifold Heater Works rmally Fills rmally Replaced Glow Perform rmally Cycle rmally -Logos for cruise and controls wore off -Rusty in appearance -Replaced fuel filter Fluids Windshield Washer Engine Oil Radiator Anti-Freeze Transmission Fluid Transfer Case Oil Battery Acid Levels Hydraulic Oil Brake Fluid Power Steering Fluid Winch 1 Oil Winch 2 Oil Winch 3 (Above Cab) Oil t Checked Full Low Full Low Full t Checked t Checked -Needs topped off -Needs filled and tested -Needs checked and filled after doing wheel seal -New batteries Filters Water Filter Engine Oil Filter Transmission Oil Filter Fuel Filter Carrier Hydraulic System Engine Air Filter Chassis Lubrication Points King Pins/Ball Joints Tie-Rods Ends Steering Shaft Bearing Drag Link Clutch Linkage Throw-Out Bearing Drive-Line U-Joints S-Cam Shafts Slack Adjusters Spring Hangars Original (t replaced) Original (t replaced) Original (t replaced) Replaced t Changed Replaced Appears To have Been Well Greased -Needs checked and topped off -Needs checked and topped off Chassis Lubrication Points Door Locks and Hinges Overall Car Carrier Overall Lubrication -Needs lubed Carrier Deck Aluminum Deck Steel Deck Aluminum Deck Siderails Steel Deck Side-rails Steel Deck Side-rails Paint Aluminum Tail Section Rear Rollers Re-movable Side Rails Steel Re-movable Side Rails Aluminum Anti-Tilt Protection System Minor Scratches or Marks In Fair (See ) In Fair COndition -Paint coming off Power Take-Off PTO Warning Light Shifting Mechanism Air Leaks rmally Electrical Switch Working Properly Air Leaks Hyraulic Pump Pump Pressure Pump Flow Pump rmally Appears to Operate Bed -Needs tested rmally - t Tested -Needs tested t Tested Control Valve Control Levers and Rods Control Box Knobs Control Decals Hydraulic System Hoses Hydraulic System Leaks Winch Hoses Lift Cylinder Hoses Extension Cylinder Hoses Wheel-Lift Tilt Cylinder Hoses Wheel-Lift Extend Cylinder Hoses (2) Hydraulic Pump Hoses Hydraulic Filter Bed Lift Cylinders Extend Cylinder Wheel-Lift Tilt Cylinder pins and froze in place rmally Loose and Worn Pins and -Froze and rusty Rod Connections Bent or -Rusty and corroded Cracked or -Need replaced or in In

6 Page: 6 of 7 Hydraulic System Leaks Wheel-Lift Extend Cylinder Wheel-Lift Claw Cylinder Drivers Side Wheel-Lift Claw Cylinder Passenger Side rmally rmally Pylon Overall Bent or Dented -Bent in the center Winch Free-Wheel Mechanism Winch 1 Free-Wheel Mechanism Winch 2 Free-Wheel Mechanism Winch 3 Housing Winch 1 Housing Winch 2 Housing Winch 3 Without Load Without Load tes Test Loaded Test tes Winch 1 Cable Winch 2 Cable Winch 3 Cable Cable Tensioner rmally rmally t Performed In Poor Wheel-Lift L-Arms/Scoops L-Arm Straps L-Arm Storage Driver Side Claw Passenger Side Claw Driver Side Slide Tray Passenger Side Slide Tray Passenger Side Slide Tray Locks Driver Side Slide Tray Locks (2) Driver Side Front Stops (Vulcan) Passenger Side Front Stops (Vulcan) Driver Side L-Arm Swivel Passenger Side L-Arm Swivel (2) Center Pivot Pin and Bushing Wheel-Lift Cross-Bar Pins and Bushings Extension Tube Outer Wheel-Lift Assembly Wheel-Lift Swivel Lock Pins Wheel-Lift Swivel Lock Pins (2) Scoop Locking Pins and Chains Driver Side Claw Cylinders Broken or in Worn Excessively Worn Excessively Bent Cracked, Worn or Bent and in -Cam locks broke Wheel-Lift Wear Pads Carrier Electrical Systems Switch Panel Overall Wiring Bed Wiring Harness Junction Boxes Marker Driver Side Turn Signals Upper Passenger Side Turn Signals Upper Driver Side Turn Signals Upper Lower Passenger Side Turn Signals Lower Extra Warning Extra Clearance UpperWork Lower Work Work Mounted Near Winch Beacon Light Tow Light Plug at Tail-Board License Plate Light or In Some Inoperaive (See ) (See ) (See ) (See ) (See ) Broken or -Needs replaced -One marker light not working on passenger side front of the bed - switches - switch - switch - switch - switch - switch - switch - switch - switch sl-9 kit Tool Boxes Box Driver Side 1 Box Driver Side 2 Box Passenger Side 1 Box Passenger Side 2 Rusty but Usable in Rusty but Usable in -Rusty but missing key door key door Fenders Drivers Side Passenger Side Bent or -Bent on the edge fender Carrier Components Bed Hold-Downs Rear Bed Mounting (Pivot Pin) Driver Side Tail- Light Housing Passenger Side Tail- Light Housing (2) Rear Tail Section Body Lubrication Points Bed Pivot Pin Lift Cylinder Pins Wheel-lift Tilt Pin Wheel-Lift Pivot Pin Wheel-Lift Upper Slide Pads Wheel-Lif tlower Slide Pads Deck Slide Back Wear Pads -Dented in -Dented in -Dented

7 Page: 7 of 7 Body Lubrication Points Tool Box Door Hinges and Locks Lube Carrier Chains Front Safety Chains Rear Safety Chains V-Chains Chains V-Chains Straps Broken or Broken or Worn or -Locks need changed and lubed Mud-Flaps Mounting Brackets Mud-Flap