Manual. Parts LOAD TRANSFER STATION. corporation. Model 40A

Transcription

1 -- TM Parts Manual LOAD TRANSFER STATON Model corporation Cascade is a Registered Trademark of Cascade Corporation. P.O. Box 360 l Springfield, Ohio l (513)

2 HOW TO USE THS MANUAL ntroduction This manual illustrates service replacement parts for the standard production Cascade Load Transfer Station. The parts manuals for stations designed by the Application Engineering Department have an A.E.D. designation on the cover of the manual. This standard manual is not interchangeable with an A.E.D. Manual since it does not reflect the special engineering of an A.E.D. station. To locate a service replacement part follow the steps below. 1. Locate Nameplate The nameplate is attached to the top of the frame near the hydraulic access panel. f the nameplate is missing, all necessary information is stamped into the frame at the same location. 2. Note the Serial Number and Additional Equipment Record the complete Serial Number and the six-digit numbers of the Additional Equipment stamped on the nameplate. See the example. 3. Refer to Serial Number ndex Locate your Serial Number in the Serial Number ndex on the following page. MPORTANT: DO NOT USE THS MANUAL TO ORDER PARTS FOR AN A.E.D. STATON. Contact Cascade Corporation to obtain the correct parts manual. You must supply the serial number and all additional equipment numbers to order the correct manual. 4. Ordering To order Service Replacement Parts Please contact: Parts Depot Cascade Corporation 2501 Sheridan Ave. Springfield, Ohio Telephone: (513) 322-l 199 Telex: For Your Convenience... we have supplied a parts ordering log located on the last page. Use this log as a permanent record of parts ordered from this manual LOAD CAPACTY PALLET SZE 4000 POUNDS 148) STRNGER x [-.-G--J DECKBOARD Cascade Corporation 1981 Litho in U.S.A. Rev. Form 5242

3 Serial Number ndex Serial Number &lode Frame Group Page nner Carriage nner Carriage Lift Group Cylinder Cylinder Cylinder Page Page Page Page Hydraulic Hydraulic , Va,ve h MPORTANT: f any of your additional equipment numbers are 300,000 numbers (example: , then the station is specially engineered. DO NOT USE THS MANUAL TO ORDER A.E.D. PARTS. Contact Cascade Corporation to obtain the correct parts manual. Please supply the serial number and all additional equipment numbers to order the correct parts manual. To order parts or service manuals contact: Technical Publications Dept. Cascade Corporation 2201 N.E. 201 Portland, Oregon Telephone: l Additional Equipment ndex Description Page Manual Controls Wheels Spares Group iii Transmitter Bracket Floor Assembly ~ Form 5242 i

4 Safety Decals / A WARNNG KEEP CLEAR QTY. PART NO. DESCRPTON Mode Decal T QTY. PART NO. DESCRPTON Warning Decal CYCLE (Manual Control Option) 1 STOP 1 1 QTY. PART NO. DESCRPTON Stop Decal QTY. PART NO. DESCRPTON Cycle Decal C QTY. PART NO. DESClilPTlON Change Oil Decal QTY. PART NO. DESCRPTON Transmitter Decal ii.-

5 Spare Parts Group QTY. PART NO. DESCRPTON WHERE USED Cvlinder Service Kit Hose lube Assembly Tube Assembly Tube Assembly Block Roller Roller Roller Bushing Bushing Washer Retaining Ring Shim Pin Weldment Pin Weldment j,i / / Spring Bumper Bushing Washer Cotter Pin All Cylinders nner Carriage Group Frame Group : Bolt Fuse - 10 amp : Tolerance Pin Fuse - 20 amo Ring L Fuse-2amo Fuse - 1 amp Fuse - 1 amp 1 Electrical Panel Assembly / Switch Solenoid Coil Heater - 460V 230V O-Ring EZ,, i : Valve Assembly Hydraulic Tank Assembly

6 1 Frame Group

7 Frame Group 1 1 ft 1 QTY. 1 PARTNO. 1 DESCRPTON 1 ri- 1 QTY. ( PART NO. 1 DESCRPTON Frame Group Roller Shim

8 nner Carriage Group DE!33?lPTlON 1 FL / DTY. ) PART NO. 1 DESCRPTON nner Carriage Group Roller 2

9 nner Cylinder 1 RN O.. 1 OTY. 1 PARTNO. 1 DESCRPTON nner Cylinder Assembly 1 ll Cotter Pin 02 1 ; Retainer Shell Wear Ring Nut Piston # l L ii; Washer Service Kit *ncluded in Service Kit

10 Carriage Cylinder PART NO. / DESCRPTON Carriage Cylinder Assembly *ncluded in Service Kit Service Kit 4

11 Lift Cylinder Lift Cylinder Assembly Wncluded in Service Kit Service Kit

12 Hydraulic Supply Group 3 REF QTY NO. - PART NO. DESCRPTON REF QTY NO. - PART NO. DESCRPTON Hydraulic Supply Group 6

13 Hydraulic Tank Assembly DESCRPTON PART NO. DESCRPTON Hydraulic Tank Assembly ; 1 ; , --,., _ Motor Pioe ;i Lockwasher, ;; 1 ; S l nc!udes Filter Element

14 Check Valve REF* QTY NO. - PART NO Check Valve 1122 Relief Valve b/l 125 Seal Kit Plug 1 Rotary Valve Check Valve 6 7 ct71,3n n,...,., o:- DESCRPTON 8

15 Electrical Panel Assembly PART NO. DESCRPTON -PART NO. DESCRPTON Electrical Panel Assy

16 10 Electrical Group

17 _ Electrical Group REF- QfY NO. - PART NO. OESCRPTON REF- QfY PART NO. NO. DkCRlPTlON Electrical Group /.-. --_-. -6lOlSl Connector Conduiet l cnnrwrtnr 821 i 5985 Nut.--- ddnrdr,. a Nut #lo NC 73 SK5 1 Ninnla --._ ] Conduit 67n447 imit Ctmit,-h n ncluded in Manual Control Group *Length as required. *See page 11 for parts breakdown. NOTE: Motor circuit is wired with 12 Gauge wire, all other wiring is 14 Gauge wire.

18 Limit Switches DESCRPTON NOTE: All quantities above are one (1) per limit switch.

19 Mobility Group PARTNO DESCRPTON Wheels Group =ncludes interns 1 through 7 only. l AS required. ( Ft / QTY. ( PARTNO. / DESCRPTON Transmitter Bracket Note: The transmitter uses a 9 Volt transistor style battery.

20 PARTS ORDERNG LOG DATE PURCHASE ORDER SERAL NUMBER PAGE REF NO QTY.. CASCADE CUSTOMER PART NO. PART NO. DESCRPTON PRCE

21 NATONAL ASSOCATON OF SERVCE Corporation 1981 Litho in U.S.A Form 5242 P/N C