This parts list is current as of the above revision date. See for the current revision.

Transcription

1 Parts List This parts list is current as of the above revision date. See for the current revision. Package Gas-Electric - Commercial

2 Table of Contents Model Explanation Page 3 Parts Numbers Drawings/Photographs Panels - Miscellaneous Page 4 Electrical Group Page 5 Fan Group Page 5 lower Group Page 6 Coil Parts Page 7 Compressor Group Page 7 Heat Exchanger-urner Group Page 8 Gas Controls Page 9 Accessories Page 10 Orifice Selection Chart Page 11 Exploded View Page 12 Top Panel Page 13 Side Panels Page 14 Top Interior Page 15 lower Assembly - elt Drive Page 16 Control ox Page 17 lower Motor Mount Assembly - elt Drive Page 18 Plate Disconnect and Receptacle Page 19 Evaporator Coil - Filter Channels Page 20 Heating Section Page 20 Heat Exchanger Assembly Page 21 urner Assembly Page 21 Condenser and Coil Pads Page 22 Compressor - Refrigeration Group Page 23 Notes Page 24 Page 2 of

3 MODEL NUMER EXPLANATION R K K N C L 1 0 E X X A TRADENAME 8 DRIVE PACKAGE L = elt Drive 2 K = ROOFTOP - COMMERCIAL M = elt Drive - High Static 3 EFFICIENCY DESIGNATION 9 HEAT CAPACITY (MH) K = ASRAE Compliant 10 = 100, = 110,000 4 DESIGN SERIES 13 = 135,000 N = (R-410A) 10 IGNITION SYSTEM 5 TECHNICAL VARIATIONS E = Electric = FIRST DESIGN SERIES 11 FACTORY INSTALLED OPTIONS 6 COOLING CAPACITY (TU/HR) = 72, ECONOMIZER OPTION A = No Economizer 7 ELECTRIC DESIGNATION F = Single Enthalpy Economizer with arometric Relief C = /3/60 G = Single Enthalpy Economizer with arometric Relief and Smoke Detector D = 460/3/50 Y = 575/3/60 N = /3/50 P = /3/50 (1) PLANT CODE (2) WEEK (DATE CODE) (3) YEAR (4) PRODUCTION NUMER SERIAL NUMER EXPLANATION F (1) (2) (3) (4) Note: For Compressor Identification Number, see Compressor Code on Rating Plate For Gas Code, see Control System Gas Code on Rating Plate Page 3 of

4 MODEL No. Notes TECHNICAL VARIATION COOLING CAPACITY PANELS, MISCELLANEOUS PARTS 1 ase Rail - Side (2) AE ase Rail - Condenser End AE ase Rail - Evaporator End AE Outdoor Coil ase Pan AS H 5 Indoor Coil ase Pan AS Condenser ulkhead (Does not include Limit affle or Tube Support Angles) AS Limit affle - Attached To Condenser ulkhead (10E Heat Capacity) AE Limit affle - Attached To Condenser ulkhead (13E Heat Capacity) AE Tube Support Angle - Attached To The Condenser. ulkhead AE lower ulkhead (Does not include Tube Support Angle, lower ExtensionS, or Insulation Retainer) AS Tube Support Angle (Small piece attached to the lower ulkhead) AE lower Extension - Front AE lower Extension - ack AE Insulation Retainer AE Wire Chase Insulation Assembly AS a Corner Post (2) AS H 12b Front Post AS H 13 Stripping (Front Post) AE Louvered Panel See Accessories 15 Louvered Panel See Accessories 16 Louvered Panel See Accessories 17a Supply Panel AS HT 17b Return Panel AS HT 18 Rear Panel (Includes Insulation, Filler Panel, and Stripping) AS H 19 Filler Panel - Return Air AS H Filler Panel Stripping AE lower/filter Access Panels (2) AS H 21 Post - Left End AS H 22 Front Panel AS H 23 Grommet a Heating Compartment Access Panel - Upper AS H 24b Heating Compartment Access Panel - Lower AS H 25 Flue Hood Assembly - Inlet and Outlet AS Mounting Panel - External Disconnect AE Control ox Access Panel AS H 27a Control ox Insert Panel AS H 27b Disconnect Plate AS H 27c Receptacle Plate AS H 27d utton Plug e Star ushing Post - Front AS H 29 Indoor Coil Top Panel Assembly AS H 30a Condenser Top Panel Assembly AS H 30b Condenser Top Support AE Wire Grille a Control ox Top AE b Control ox (w/o components) AS Page 4 of

5 MODEL TECHNICAL VARIATION No. Notes COOLING CAPACITY ELECTRICAL DESIGNATION C D Y ELECTRIC GROUP CONTROL OX COMPONENTS: 37 Capacitor - Fan Motor See Fan Group 39 Compressor Time Delay Relay See Accessories 40a Compressor Contactor See Compressor Group 40b Stk lower Contactor Relay - Inducer lower N/A N/A 42 Ground Lug a Stk Transformer b Stk Transformer - Step Down N/A N/A c Stk Integrated Furnace Control (IFC) d Low Voltage Shield AE AE AE Stk Fuse - Control oard MISCELLANEOUS: Wiring Harness - 9 pin from IFC to 9 Quick Connect terminals Wiring Harness - Economizer (12 pin) Low Ambient Control See Accessories 44 Auxilary Limit - lower Extenstion Stk Pressure Switch Stk Inducer lower Motor - Including Gasket a Tubing - Silicone Rubber AE AE AE Stk Gasket - Inducer lower Motor Low Pressure Control See Compressor Group 51 High Pressure Control See Compressor Group MODEL TECHNICAL VARIATION No. Notes COOLING CAPACITY ELECTRICAL DESIGNATION C D Y FAN GROUP 35 Stk Fan Motor Stk Fan lade Stk Capacitor - Fan Motor Page 5 of

6 MODEL TECHNICAL VARIATION No. Notes COOLING CAPACITY ELECTRICAL DESIGNATION DRIVE PACKAGE C L C M D L D M Y L Y M LOWER GROUP - ELT DRIVE 62 Stk lower Assembly (Items 63-73, Excluding Cross race) AS AS AS AS AS AS Housing AS AS AS AS AS AS earing Frame Tri-Arm (2) Stk all earing And Cushion (2) Stk lower Shaft Stk Fixed Pitch Sheave lower Support - Left AE AE AE AE AE AE Stk lower Wheel Cut-Off Tabulation AE AE AE AE AE AE MODEL TECHNICAL VARIATION No. Notes COOLING CAPACITY ELECTRICAL DESIGNATION DRIVE PACKAGE C L C M D L D M Y L Y M LOWER MOTOR MOUNTING - ELT DRIVE MOTOR MOUNTING: 71 lower racket AE AE AE AE AE AE lower racket - Drive Side AE AE AE AE AE AE a Grommet b Cross race AE AE AE AE AE AE Motor Mount Assembly AS AS AS AS AS AS MODEL TECHNICAL VARIATION No. Notes COOLING CAPACITY ELECTRICAL DESIGNATION DRIVE PACKAGE C L C M D L D M Y L Y M LOWER MOTOR GROUP - ELT DRIVE 74 lower Motor Variable Pitch Sheave elt Page 6 of

7 MODEL TECHNICAL VARIATION No. Notes COOLING CAPACITY ELECTRICAL DESIGNATION C D Y COIL GROUP 6 Filter Keeper AE AE AE EVAPORATOR COIL: 77 Stk Evaporator Coil - Coil Frame Assembly (includes Frame Sides, Angle, Frame ottom and Top Air Stop) AS AS AS Stk TXV - Sporlan Top Air Stop AE AE AE Top Coil Support AE AE AE Filter Channels (3) Center Is Two Channels ack To ack AE AE AE Indoor Coil Drain Pan CONDENSER COIL: 84 Stk Condenser Coil AS AS AS a Pad - ottom Coil (5) (5) (5) 84b Coil Filler Plate (2) AS H AS H AS H 84c Stripping Stk Filter Drier Filter - Disposable (4) MODEL TECHNICAL VARIATION No. Notes COOLING CAPACITY ELECTRICAL DESIGNATION C D Y COMPRESSOR GROUP Compressor ID: Stk Compressor S S S 40 Stk Contactor Stk Compressor Wiring Harness - Molded Plug Low Pressure Control High Pressure Control Page 7 of

8 MODEL TECHNICAL VARIATION No. Notes COOLING CAPACITY HEATING CAPACITY HEAT EXCHANGER, URNER/MANIFOLD 45 Stk Main Limit - (Condenser ulkhead) E - Electric Stk Main Limit - (Condenser ulkhead) X - NOX Main Limit Shield AS AS Stk Heat Exchanger - Includes Center Panel AS AS Turbulators AE AE (5) (6) 90 Gasket - Divider Plate Divider Plate AE AE Gasket - Collector ox Collector ox Cover AE AE Flue Duct Gasket - Flue Duct urner Shield AE AE Stk Limit (Manual Reset) (2) (2) 98 urner Compartment Floor AE AE MODEL TECHNICAL VARIATION No. Notes COOLING CAPACITY HEATING CAPACITY URNER / MANIFOLD GROUP 99 Stk, 1 urner Assembly AS AS a ushing urner Support - (Holds the urners between the urner Support rackets) AE AE urner Support racket (2) AE AE Stk Manifold Assembly (w/o Orifices) Square Head Plug - (Used on Manifold to plug extra holes) (2) (1) 104 urner Orifice - Natural Gas: 104 urner Orifice - LP: See Orifice Selection Chart 104 Number of Orifices (5) (6) 105 Stk Flame Sensor Stk Ignition Electrode and Cable Page 8 of

9 No. Notes MODEL GAS CODE GAS CONTROLS 107 Stk Gas Valve - Natural Gas Stk Gas Valve - LP See Note 1 See Note 1 See Note 1 Stk Integrated Furnace Control oard (IFC) Street Elbow Nipple Stk LP Conversion Kit EP-85H EP-85H EP-84W 2G 2U 2X Page 9 of

10 MODEL No. Notes TECHNICAL VARIATION COOLING CAPACITY OPTIONS AND ACCESSORIES Louver Panel Kit Low Ambient Control Kit Compressor Time Delay Economizer - Single Enthalpy Dual Enthalpy Upgrade Kit Carbon Dioxide Sensor Power Exhaust - "C" Voltage Power Exhaust - "D" Voltage Power Exhaust - "Y" Voltage Fresh Air Damper - Manual Fresh Air Damper - Motorized Fresh Air Damper - Motorized (Smoke Detector Compatible) AXRX-AAD01 RXRZ-A85 RXMD-04 RXRD-MCCM3 RXRX-AV02 RXRX-AR02 AXRX-GF03C AXRX-GF03D AXRX-GF03Y AXRF-FCA1 AXRF-FC1 AXRF-JH1 Page 10 of

11 PACKAGE EQUIPMENT - ORIFICE SELECTION CHART - NATURAL GAS CAUTION: Selection of the correct Natural Gas Orifice requires the following information for the specific installation: 1) Furnace Input Rating (TU/HR) 2) Number of urners 2) Altitude (ft.) For detailed information and instructions for Orifice selection, see the Gas Furnace LP Conversion Kit Index and the latest edition of the National Fuel Gas Code Handbook, or the National Standard of Canada, Natural Gas and Propane Installation Code, CAN CAUTION: This information is provided for replacement purposes only. Conversion for operation at High Altitude must be done using the kit specified on the product specification sheet for the unit. NOTE: This Orifice sizing chart is based on a Natural Gas heating value of 1075 TU/cu. ft and a pressure setting of 3.5 in. water column. NOTE: Factory installed orifices are calculated and sized based on a Natural Gas heating value of 1075 TU/cu. ft. and an elevation of ft. Canadian High Elevation (ft.) Furnace Number Altitude Derated Country Input of Input Rating (TU/HR) urners (TU/HR) U.S. U.S. U.S. U.S. Canada Canada 40,000 36, ,000 54, ,000 N/A N/A 80,000 72, ,000 N/A N/A 100,000 90, , , , , , , ,000 N/A N/A 210,000 N/A N/A 210,000 N/A N/A 225, , , , , , ,000 N/A N/A 290,000 N/A N/A 300, , ,000 N/A N/A 350, , , , PACKAGE EQUIPMENT - ORIFICE SELECTION CHART - LP CAUTION: Selection of the correct LP Orifice requires the following information for the specific installation: 1) Furnace Input Rating (TU/HR) 2) Number of urners 2) Altitude (ft.) For detailed information and instructions for Orifice selection, see the Gas Furnace LP Conversion Kit Index and the latest edition of the National Fuel Gas Code Handbook, or the National Standard of Canada, Natural Gas and Propane Installation Code, CAN CAUTION: This information is provided for replacement purposes only. Conversion to LP or for operation at High Altitude should be done using the kit(s) specified on the product specification sheet for the unit. NOTE: This Orifice sizing chart is developed using the specified pressure setting of 10 in. water column instead of the 11.0 in water column used by the NFG and CAN NOTE: Orifices supplied in the LP Conversion Kit are calculated and sized based on a heating value of 2500 TU/cu. ft. and an elevation of ft. Canadian High Elevation (ft.) Furnace Number Altitude Derated Country Input of Input Rating (TU/HR) urners (TU/HR) U.S. U.S. U.S. U.S. Canada Canada 40,000 36, ,000 54, ,000 N/A N/A 80,000 72, ,000 N/A N/A 100,000 90, , , , , , , ,000 N/A N/A 210,000 N/A N/A 210,000 N/A N/A 225, , , , , , ,000 N/A N/A 290,000 N/A N/A 300, , ,000 N/A N/A 350, , , , Page 11 of

12 Exploded View Page 12 of

13 Top Panel Page 13 of

14 Side Panels Page 14 of

15 Top Interior Page 15 of

16 lower Assembly - elt Drive Page 16 of

17 Control ox Page 17 of

18 lower Motor Mount Assembly - elt Drive Page 18 of

19 Plate Disconnect and Receptacle Page 19 of

20 Evaporator Coil - Filter Channels Heating Section Page 20 of

21 Heat Exchanger Assembly urner Assembly Page 21 of

22 Condenser and Coil Pads Page 22 of

23 Compressor - Refrigeration Group Page 23 of

24 NOTES Stk It is recommended that stock be maintained for this part. N/A Not Applicable 1 Order Gas Valve for Natural Gas along with LP Conversion Kit. P.O. ox Fort Smith, AR