DEPARTMENT OF THE ARMY TECHNICAL MANUAL

Transcription

1 DEPARTMENT OF THE ARMY TECHNICAL MANUAL DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LIST FOR QUARTZ OSCILLATOR, HEWLETT-PACKARD MODEL 105AOPTION908 (NSN ) Current as of 15 September 1976 Headquarters, Department of the Army, Washington, DC 15 November 1976 REPORTING OF ERRORS You can help improve this publication by calling attention to errors and by recommending improvements and stating your reasons for the recommendations. Your letter or DA Form 2028 (Recommended Changes to Publications and Blank Forms) should be mailed direct to Commander, US Army Missile Command, ATTN: DRSMI-MFM, Redstone Arsenal, AL A reply will be furnished direct to you. Paragraph Page SECTION I. INTRODUCTION Scope... 1 General... 2 Explanation of columns... 3 How to locate repair parts... 4 II Functional Group title Model Part group No. number 6648 Quartz oscillator 105AOPTION908 III. NATIONAL STOCK NUMBER AND PART NUMBER INDEX i

2 SECTION I INTRODUCTION 1. Scope This manual lists repair parts that are required for maintenance of Quartz Oscillator, Hewlett-Packard Model 105AOPTION908 and is applicable to Army Area Calibration Teams (AACT s). NOTE Throughout this manual, DS is used to indicate AACT. 2. General This manual is divided as follows: a. Section I. Introduction. b. Section II. Repair Parts List. A list, in alphabetical sequence, of repair parts authorized for the performance of maintenance at the AACT. c. Section III. National Stock Number and Reference Number Index. A list in ascending numerical sequence, of all National stock numbers (NSN s) appear ing in the repair parts list, followed by a list of all reference numbers in alpha-numeric sequence appearing in the list. The NSN s and reference numbers are crossreferenced to a figure number and item number in column 1. NOTE The figure and item number columns represent cross-reference numbers, since illustrations are not included in this manual. 3. Explanation of Columns Refer to section I of TM P for explanation of columns (para 3), special information (para 4, except for subparagraph 40 which is not applicable to this manual), and abbreviations (para 6). 4. How to Locate Repair Parts When NSN or reference number is unknown, use the repair parts listing and locate the item by description. When National stock number or reference number is known, use the list of NSN s or the reference numbers and locate the cross-referenced figure and item number. Locate the cross-referenced figure and item number under column 1 of the repair parts list for the complete description of the repair part. 1-1

3 GROUP 6648 QUARTZ OSCILLATOR 105AOPTION Mainframe Assembly Consisting of 1 3 PAFZZ BATTERY,STORAGE 24.0 VOLTS... EA PAFZZ BUSHING,MACHINE THREAD... EA PAFZZ BUSHING,TRANSISTOR... EA PAFZZ B-16A CABLE ASSEMBLY,POWER,ELECTRICAL... EA PAFZZ CAPACITOR ELECTRICAL... EA PAFZZ CAPACITOR,FIXED,CERAMIC DIELECTRIC. EA PAFZZ CAPACITOR,FIXED,CERAMIC DIELECTRIC. EA PAFZZ CIRCUIT CARD ASSEMBLE... EA PAFZZ CLAMP TRANSISTOR... EA PAFZZ COIL,ELECTRICAL... EA PAFZZ CONNECTOR,ELECTRICAL... EA PAFZZ CONNECTOR,MALE... EA PAFZZ CONNECTOR,ELECTRICAL... EA PAFZZ MS3106F14S5S CONNECTOR,PLUG,ELECTRICAL FSCM EA PAFZZ CRYSTAL... EA PAFZZ FUSEHOLDER,EXTRACTOR POST FSCM EA PAFZZ GUIDE,CIRCUIT CARD... EA PAFZZ BODY,HEAT SINK... EA PAFZZ INSULATOR,BUSHING... EA PAFZZ INSULATOR,PLATE... EA PAFZZ INSULATOR,PLATE... EA PAFZZ KNOB... EA PAFZZ RACK,MOUNTING... EA PAFZZ NUT,HEAT,SINK... EA PAFZZ NUT,PLAIN,HEXAGON... EA PAFZZ OVEN CHAMBER ASSMMBLY... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,VARIABLE, WIRE WOUND... EA PAFZZ RETAINER TRANSISTOR... EA PAFZZ SWITCH,SLIDE... EA PAFZZ SWITCH THERMOSTATIC... EA 1 2-1

4 1 71 PAFZZ EXTENDER,BOOARD ASSEMBLY... EA PAFZZ TERMINAL BOARD... EA PAFZZ TERMINAL,STUD... EA PAFZZ TRANSISTOR... EA PAFZZ TRANSISTOR... EA PAFZZ WAFER TRANSISTOR... EA PDFFD CIRCUIT CARD ASSEMBLY 1 MHZ DIVIDER EA 1 CONSISTING OF 2 5 PAFZZ CAPACITOR,FIXED,ELECTROLYTIC... EA PAFZZ C CAPACITOR,FIXED,CERAMIC..DIELECTRIC FSCM EA PAFZZ CAPACITOR,FIXED,MICA DIELECTRIC... EA PAFZZ RDM15F101G3C CAPACITOR,FIXED,MICA DIELECTRIC FSCM EA PAFZZ CAPACITOR,FIXED,MICA DIELECTRIC... EA PAFZZ CAPACITOR,FIXED,MICA DIELECTRIC... EA PAFZZ CAPACITOR,FIXED,MICA DIELECTRIC... EA PAFZZ CV31D CAPACITOR,VARIABLE,CERAMIC DIELECTRIC 2K FSCM EA PAFZZ CM10ED470G CAPACITOR.FIXED,MICA DIELECTRIC FSCM EA PAFZZ CAPACITOR,FIXED,MICA DIELECTRIC... EA PAFZZ CAPACITOR,FIXED,MICA DIELECTRIC... EA PAFZZ CM06FD302F CAPACITOR,FIXED,MICA DIELECTRIC FSCM EA PAFZZ CAPACITOR,FIXED,MICA DIELECTRIC... EA PAFZZ COIL,RADIO FREQUENCY... EA PAFZZ COIL,RADIO FREQUENCY... EA PAFZZ COIL,RADIO FREQUENCY... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR FIXED... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA 1 2-2

5 2 63 PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RNC55K5110FS RESISTOR,FIXED,FILM FSCM EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ SEMICONDUCTOR DEVICE,DIODE... EA PAFZZ SEMICONDUCTOR DEVICE,DIODE... EA PAFZZ TRANSFORMER... EA PAFZZ TRANSFORMER,POWER,STEP-DOWN... EA PAFZZ TRANSFORMER,ELECTRICAL... EA PAFZZ JAN2N TRANSISTOR FSCM EA PAFZZ TRANSISTOR... EA PAFZZ TRANSISTOR... EA PAFZZ TRANSISTOR... EA PDFFD CIRCUIT CARD ASSEMBLY... EA 1 CONSISTING OF 3 5 PAFZZ C CAPACITOR,FIXED,CERAMIC DIELECTRIC FSCM EA PAFZZ CAPACITOR,FIXED,CERAMIC DIELECTRIC. EA PAFZZ CAPACITOR,FIXED,CERAMIC DIELECTRIC. EA PAFZZ CAPACITOR,FIXED,MICA DIELECTRIC... EA PAFZZ CAPACITOR,FIXED,PLASTIC DIELECTRIC.. EA PAFZZ CAPACITOR,FIXED,MICA DIELECTRIC... EA PAFZZ CAPACITOR ELECTRICAL... EA PAFZZ CAPACITOR,FIXED,MICA DIELECTRIC... EA PAFZZ CAPACITOR,FIXED,MICA DIELECTRIC... EA PAFZZ CAPACITOR,FIXED,CERAMIC DIELECTRIC. EA PAFZZ CAPACITOR,FIXED,MICA DIELECTRIC... EA PAFZZ P CAPACITOR,FIXED,PLASTIC DIELECTRIC FSCM EA PAFZZ CAPACITOR,FIXED,PLASTIC DIELECTRICEA PAFZZ COIL,RADIO FREQUENCY... EA PAFZZ COIL,RADIO FREQUENCY... EA PAFZZ A-9F COIL ASSEMBLY,RADIO FREQUENCY... EA 1 2-3

6 3 37 PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RNC55K5112FS RESISTOR,FIXED,FILM FSCM EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ SEMICONDUCTOR DEVICE,DIODE... EA PAFZZ SEMICONDUCTOR DEVICE,DIODE... EA PAFZZ TRANSISTOR... EA PAFZZ TRANSISTOR... EA PAFZZ TRANSFORMER,POWER, STEP-DOWN... EA PAFZZ TRANSFORMER,RADIO FREQUENCY... EA PAFZZ A-9C TRANSFORMER,POWER... EA PAFZZ CIRCUIT CARD ASSEMBLY EFC AND 5MHZ EA 1 CONSISTING OF 4 5 PAFZZ CAPACITOR,FIXED,CERAMIC DIELECTRIC. EA PAFZZ CONNECTOR,ELECTRICAL... EA 4 2-4

7 4 9 PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ PNC55K5110FS RESISTOR,FIXED,FILM FSCM EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ SEMICONDUCTOR DEVICE,DIOOE... EA PAFZZ CIRCUIT CARD ASSEMBLY POWER SUPPLY EA 1 CONSISTING OF 5 5 PAFZZ C CAPACITOR,FIXED,CERAMIC DIELECTRIC FSCM EA 1 5 7PAFZZ P CAPACITOR,FIXED,PLASTIC DIELECTRIC FSCM EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR FIXED... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,WIPE WOUND... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ SEMICONDUCTOR DEVICE... EA PAFZZ SFMICONDUCTOR DEVICE... EA PAFZZ TRANSISTOR... EA PAFZZ TRANSISTOR... EA PAFZZ TRANSISTOR... EA PDFFD CIRCUIT CARD ASSEMBLY... EA 1 CONSISTING OF 6 5 PAFZZ CAPACITOR ELECTRICAL... EA PAFZZ CAPACITOR,FIXED,PLASTIC DIELECTRIC.. EA PAFZZ CAPACITOR,FIXED,ELECTROLYTIC... EA PAFZZ CAPACITOR,FIXED,CERAMIC DIELECTRIC. EA PAFZZ CAPACITOR,FIXED,CERAMIC DIELECTRIC. EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,VARIABLE,WIRE WOUND... EA 1 2-5

8 6 23 PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR ELECTRICAL... EA PAFZZ FUSE LINK,THERMAL... EA PAFZZ TRANSISTOR... EA PDFFD CIRCUIT CARD ASSEMBLY... EA 1 CONSISTING OF 7 5 PAFZZ CIRCUIT CARD ASSEMBLY OSCILLATOR 5 MHZ EA PAFZZ AUTOMATIC GAIN CONTROL... EA PAFZZ CAPACITOR ELECTRICAL... EA PAFZZ CAPACITOR,FIXED,CERAMIC DIELECTRIC. EA PAFZZ CAPACITOR ELECTRICAL... EA PAFZZ CAPACITOR ELECTRICAL... EA PAFZZ CM10ED330G CAPACITOR,FIXED,MICA DIELECTRIC FSCM EA PAFZZ CAPACITOR,FIXED,ELECTROLYTIC... EA PAFZZ CAPACITOR,FIXED,GLASS DIELECTRIC... EA PAFZZ CAPACITOR ELECTRICAL... EA PAFZZ CAPACITOR ELECTRICAL... EA PAFZZ CAPACITOR ELECTRICAL... EA PAFZZ CAPACITOR ELECTRICAL... EA PAFZZ CV31D CAPACITOR, VARIABLE,CERAMIC DIELEC- TRIC FSCM EA PAFZZ CM10ED330G CAPACITOR,FIXED,MICA DIELECTRIC FSCM EA PAFZZ CAPACITOR,FIXED,MICA DIELECTRIC... EA PAFZZ CM10ED390G CAPACITOR,FIXED,MICA DIELECTRIC FSCM EA PAFZZ COIL,RADIO FREQUENCY... EA PAFZZ COIL,ELECTRICAL... EA PAFZZ COIL,ELECTEICAL... EA PAFZZ CONNECTOR,RECEPTACLE,ELECTRICAL.. EA PAFZZ CRYSTAL QUARTZ... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA 1 2-6

9 7 59 PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR VARIABLE... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR VARIABLE... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ JAN1N753A SEMICONDUCTOR DEVICE FSCM EA PAFZZ SEMICONDUCTOR DEVICE... EA PAFZZ SEMICONDUCTOR DEVICE,DIODE... EA PAFZZ TERMINAL,STUD... EA PAFZZ TRANSISTOR... EA PAFZZ TRANSFORMER,ELECTRICAL... EA PAFZZ TRANSFORMER,POWER, STEP-DOWN... EA PDFFD CIRCUIT CARD ASSEMBLY... EA 1 CONSISTING OF 8 5 PAFZZ CAPACITOR,FIXED,CERAMIC DIELELCTRIC EA PAFZZ CV31D CAPACITOR,VARIABLE,CERAMIC DIELEC- TRIC FSCM EA PAFZZ M CAPACITOR,FIXED,ELECTROLYTIC FSCM EA PAFZZ CAPACITOR,FIXED,MICA DIELECTRIC... EA PAFZZ CAPACITOR ELECTRICAL... EA PAFZZ CM10ED270G CAPACITOR,FIXED,MICA DIELECTRIC FSCM EA PAFZZ CAPACITOR,FIXED,MICA DIELECTRIC... EA PAFZZ CAPACITOR,ELECTRICAL... EA PAFZZ COIL,ELECTRICAL... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RCR20G4R7JS RESISTOR,FIXED.COMP FSCM EA PAFZZ RESISTOR,FIXED,FILM... EA PAFZZ RESISTOR,VARIABLE,WIRE WOUND... EA PAFZZ RESISTOR VARIABLE... EA 1 2-7

10 8 51 PAFZZ SEMICONDUCTOR DEVICE... EA PAFZZ TRANSISTOR... EA PAFZZ TRANSISTOR... EA PAFZZ TRANSISTOR... EA PDFFD Not Assigned OSCILLATOR ASSEMBLY 5MHZ... EA 1 2-8

11 I NATIONAL STOCK NUMBER AND PART NUMBER INDEX NATIONAL STOCK NUMBER CROSS-REFERENCED TO FIGURE AND ITEM NUMBER STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM

12 I NATIONAL STOCK NUMBER CROSS-REFERENCED TO FIGURE AND ITEM NUMBER - - CONTINUED STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM PART NUMBER CROSS-REFERENCE TO FIGURE AND ITEM NUMBER PART FIG. ITEM PART FIG. ITEM NUMBER FSCM NO. NO. NUMBER FSCM NO. NO. CM06FD302F CM10ED270G CM10ED330G CM10ED330G CM10ED390G CM10ED470G CV31D CV31D CV31D JAN1N753A JAN2N MS3106F14S5S M RCR20G4R7JS RDM15F101G3C RNC55K5110FS RNC55K5110FS RNC55K5112FS

13 PART NUMBER CROSS-REFERENCE TO FIGURE AND ITEM NUMBER - - CONTINUED PART FIG. ITEM PART FIG. ITEM NUMBER FSCM NO. NO. NUMBER FSCM NO. NO A-9C A-9F B-16A P P

14 PART NUMBER CROSS-REFERENCE TO FIGURE AND ITEM NUMBER - CONTINUED PART FIG. ITEM PART FIG. ITEM NUMBER FSCM NO. NO. NUMBER FSCM NO. NO C C C

15 By Order of the Secretary of the Army: Official: PAUL T. SMITH Major General, United States Army The Adjutant General BERNARD W. ROGERS General, United States Army Chief of Staff Distribution: To be distributed in accordance with DA Form 12-34A, requirements for Calibration Procedures Publications. žu.s. GOVERNMENT PRINTING OFFICE: /63